2003 CHEVROLET TAHOE Service Brakes, Hydraulic Problems

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED WHILE DRIVING 35 MPH AND ATTEMPTING TO STOP THE VEHICLE BY APPLYING THE BRAKE PEDAL THE BRAKE LINE BROKE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THERE WAS EROSION ON THE BRAKE LINES AND THEY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000. THE CURRENT MILEAGE WAS 143,050.

Mileage: 143,000

NOT SURE WHAT IS HAPPENING TO MY CAR BUT IT IS VERY SCARY WHEN IT HAPPENS. SHORTLY AFTER I START MY CAR AND IT IS WARMED UP, WHEN I AM DRIVING IT AND I PUT THE BRAKES ON TO SLOW DOWN ON A CORNER OR AT A INTERSECTION, MY CAR WILL SHUT OFF. I CAN'T STEER AND THE BRAKES ARE HARD TO PUSH. PLEASE HELP, DON'T WANT TO KILL MYSELF OR MY FAMILY. *TR

Mileage: 130,667

BRAKE LINE FAILURE ON 2003 TAHOE NEAR THE SPARE TIRE. COMPLETE LOSS OF BRAKE LINE PRESSURE. VEHICLE ONLY HAS ~ 84,000 MILES. VEHICLE OPERATED IN OHIO AND MASSACHUSETTS. REFERENCE EXISTING NHTSA ACTION NUMBER (EA11001) ON CHEVROLET VEHICLES. *TR

Mileage: 83,978

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, HE NOTICED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE BRAKE LINES WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. THE CONSUMER STATED WHEN HE BACKED UP AND APPLIED THE BRAKE PEDAL, IT WENT TO THE FLOOR. THE CONSUMER NOTICED FLUID LEAKING FROM THE DRIVER SIDE FRONT OF THE VEHICLE.

Mileage: 80,000

BRAKE LINE FAILURE, LOSS OF STOPPING, EMERGENCY BRAKE USED TO STOP VEHICLE. NEAR MISS ACCIDENT. BRAKE LINES BEHIND LEFT FRONT WHEEL RUSTED AND FAILED WITHOUT WARNING. *TR

Mileage: 126,000

TAHOE HAS 93,000 MILES ,NOT DRIVEN THAT MUCH ,LIVE IN MARYLAND -.NOT THAT MUCH SALT.TRIED TO COME TO A STOP ,BRAKE PEDAL FAILED-USED EMERG. BRAKES TO HELP STOP. GOT IT HOME LOOK AT THE LINES COMPLETE RUST JOB. ALL LINES WILL HAVE TO BE REPLACE.THIS CAN'T BE NORMAL,HAVE 95 LINCOLN NO PROBLEM-88 FORD P/U NO PROBLEM-93 CAMARO NO PROBLEM AND A 66 PONTIAC NO PROBLEM .KNOWING THE DIFFICULTY OF REPLACING THESE LINES ,GM SHOULD HAVE USED STAINLESS STEEL LINES.TO ME A ENGINEERING BLUNDER/DEFECT AND SHOULD BE UNDER RECALL IMMEDIATELY BEFORE WE HAVE ANOTHER TOYOTA PROBLEM.ANOTHER COUPLE HUNDRED DOLLARS ON $35,000 PLUS VEHICLE TO PROTECT THE OCCUPANTS IS NOT MUCH TO ASK. *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE APPLIED THE BRAKES AND THE VEHICLE WOULD NOT STOP. THE CONTACT CRASHED INTO ANOTHER VEHICLE DUE TO THE LACK OF BRAKES. THERE WERE NO INJURIES REPORTED DURING THE CRASH. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC AND THE MECHANIC STATED THAT THE BRAKE LINES WERE CORRODED. THE MECHANIC REPLACED THE BRAKE LINES. THE FAILURE MILEAGE WAS 45,000.

Mileage: 45,000

BRAKE LINE RUSTED THRU TWICE NOW. I LOST MOST OF MY BRAKING POWER SUDDENLY. I WAS TOLD BY THE LOCAL REPAIR SHOP THAT THIS IS COMMON. *TR

Mileage: 140,000

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT WAS DRIVING 20 MPH WHEN THE BRAKES WERE DEPRESSED TO THE FLOOR, BUT THE VEHICLE FAILED TO STOP PROPERLY. THE CHECK BRAKING SYSTEM FAILURE LIGHT ILLUMINATED AND THE VEHICLE WAS TAKEN THE DEALER WHERE THE DEALER CONFIRMED CORROSION ON THE BRAKE LINES. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 55,000.

Mileage: 55,000

WIFE AND 3 YEAR OLD CHILD IN VEHICLE WHEN SHE APPLIED BRAKES AND HEARD A POP, BRAKE PEDAL PRESSED COMPLETELY TO FLOOR AND VEHICLE HAD NO BRAKING POWER. VEHICLE WAS COASTED TO A PARKING LOT WHERE IT STOPPED, NO DASHBOARD WARNING LIGHTS ACTIVATED UNTIL VEHICLE WAS COMPLETELY STOPPED AND BRAKES WHERE PUMPED BY DRIVER. BRAKE LINE UNDER DRIVER SIDE OF VEHICLE BURST. SIMILAR TO NHTSA ACTION NUMBER EA11001. *TR

Mileage: 116,000

BRAKE FLUID DISCOVERED DRIPPING FROM UNDER FRONT LEFT FRAME ONTO DRIVEWAY. FOUND BRAKE LINE RUSTED AND PITTED AND WET WITH FLUID. MASTER CYLINDER WAS DOWN APPROXIMATELY 10% BELOW FULL MARK. MANY ITEMS IN LEFT SIDE ENGINE COMPARTMENT RUSTED AND CORRODED. HAVE EXPERIENCED NUMEROUS COMPONENT FAILURES RELATED TO RUST AND CORROSION UNDER LEFT SIDE HOOD AND CHASSIS, ... REAR BRAKE ROTORS, BRAKE CONTROL MODULE, BRAKE MODULATOR VALVE, CORRODED AND STUCK SPARE TIRE RELEASE CABLE, LEFT FRONT WHEEL BEARING ASSEMBLY,WIND SHIELD WIPER CONTROL MODULE REPLACED ,SPEED SENSOR REPLACED,STEERING SHAFT REPLACED.

Mileage: 107,000

ANTI LOCK BRAKES ACTIVATING AT LOW SPEED ON DRY PAVEMENT, REQUIRING HARDER BRAKING EFFORT. ALSO HEARING FOUR CHIMES WHEN TURNING AT LOW SPEEDS. *TR

Mileage: 49,000

TL*THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING APPROXIMATELY 50 MPH THE CONTACT FELT THE BRAKE PEDAL SLIGHTLY DROP. THE CONTACT PARKED THE VEHICLE AND LATER ATTEMPTED TO DRIVE THE VEHICLE WHEN THE BRAKE PEDAL FELL TO FLOOR AGAIN WHEN HE APPLIED PRESSURE TO IT IN ORDER CHANGE GEARS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO STATED THAT THE WHEEL CYLINDERS AND THE BRAKE LINE WAS CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THERE WAS AN OPEN INVESTIGATION, NHTSA ACTION NUMBER: EA1100A (SERVICE BRAKES, HYDRAULIC SERVICE BRAKES, HYDRAULIC FOUNDATION HOSES, LINES/PIPING, AND FITTINGS). THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

Mileage: 140,000

I HAD TO HAVE THE WHEEL SPEED SENSOR CLEANED 1AND 1/2 YEARS AGO ON MY CHEVY TAHOE. IT RECENTLY STARTED ACTING UP AGAIN. THEN YESTERDAY DURING A HARD BRAKE TO AVOID DEBRIS IN THE ROAD THE BRAKES FAILED COMPLETELY. I DO NOT KNOW YET WHAT FAILED BUT THERE IS VERY LITTLE BRAKE FLUID LEFT IN THE RESERVOIR. I SEE THAT THERE ARE MORE THAN 1 RECALL FOR TAHOES REGARDING BRAKES, BUT MY VEHICLE IS NOT INCLUDED? *TR

NO ACCIDENT YET. SMELLED GAS SO I LOOKED UNDER 2003 TAHOE FOR LEAKS AND NOTICED FILLER NECK PLUS FUEL LINES ALONG WITH BRAKE LINES WITH EXTREME RUST. I UNDERSTAND RUST FORMS ON ALL METALS. BUT THIS IS SOMETHING YOU SHOULD FIND ON TWENTY YEAR OR OLDER VEHICLES. I AM A LICENSED APR. AND RUN A QUALITY SHOP AND HAVE WORK ON VEHICLES FOR A LIVING FOR OVER THIRTY YEARS AND ONLY SEE THIS ON SUBSTANDARD OR LOW GRADE MATERIALS. SO WHY DO THESE LINES HAVE THIS PROBLEM? THIS IS A SAFETY ISSUE THAT REALLY SHOULD BE ADDRESSED. I'VE SEEN OTHER MANUFACTURERS RECALL MUCH LESS PROBLEMS WHY NOT THIS. IF YOU PRICE OUT THESE PIECES FOR REPLACEMENT YOU OR YOUR COSTUMER BETTER BE SITTING DOWN. PARTS ARE NORMALLY IN STOCK. WE ALL KNOW THEY ONLY STOCK WHAT'S SELLS REGULARLY. PLEASE AGAIN THIS IS SAFETY PROBLEM CHEVY SHOULD OWN UP TO. *TR

FEELS LIKE ABS BRAKES ARE TRYING TO FUNCTION AT LOW SPEEDS. TAHOE HESITATES TO STOP AT SLOW SPEEDS. *TR

Mileage: 115,000

IN NOV OF 2008 WE STARTED HAVING PROBLEMS WITH THE SPEEDOMETER. TOOK IT TO OUR DEALER AND THEY REPLACED THE IPC AND IT DID NOT FIX THE PROBLEM, AFTER WE GOT THE TAHOE BACK WE STARTED HAVING PROBLEMS WITH THE CRUISE CONTROL AS WELL. THE SPEEDOMETER BECOMES JERKY AND IF WE USE THE CRUISE THE TAHOE SPEEDS UP AND WE HAVE TO TURN CRUISE OFF TO STOP IT FROM SPEEDING OUT OF CONTROL. ALSO WHEN THE SPEEDOMETER BECOMES JERKY THE SERVICE BRAKE SYSTEM ALARM GOES OFF AFTER IT MAKES IT HARD TO STOP. (WE HAVE ALMOST REAR ENDED SOMEONE SEVERAL TIMES.)RECENTLY 12-2009 OUR SERVICE ENGINE LIGHT IS ON. WE HAVE TAKEN THE TAHOE TO OUR DEALER AND REPLACED SEVERAL PARTS AND NOTHING SEEMS TO MAKE THESE PROBLEMS GO AWAY. PLEASE HELP AS WE HAVE THREE KIDS AND ONE ON THE WAY. THE PARTS WE HAVE REPLACED ARE AS FOLLOWS: THE FRONT BRAKE SENSOR AND HUB, THE INSTRUMENT PANEL CLUSTER, EBC ELECTRONIC BRAKE CONTROL MODULE AND THE FUEL FILTER. WHICH IS EVERYTHING RECOMMENDED BY OUR DEALER. I JUST WANT IT FIXED!!!! *TR

TL*THE CONTACT OWNS 2003 CHEVROLET TAHOE. THE CONTACT WAS BACKING OUT OF A PARKING SPACE APPROXIMATELY 5 MPH. THE BRAKE PEDAL TRAVELED TO THE FLOOR WITHOUT RESISTANCE WHEN PRESSURE WAS APPLIED, FOLLOWED BY NO POWER RESPONSE. IMMEDIATELY, THE GEAR SHIFTER WAS PLACED INTO THE "PARK" POSITION AND THE VEHICLE STOPPED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR INSPECTION. THE FAILURE WAS CONTRIBUTED TO THE BRAKE LINE. THE VEHICLE WAS REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 85,808. UPDATED 02/1710 *BF UPDATED 02/19/10.*JB

Mileage: 85,808

TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING 10 MPH THE FRONT ABS BEGAN PULSATING. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE TECHNICIANS STATED THAT THE ABS HUB NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 90,700.

Mileage: 90,700

RIGHT PASSENGER WHEEL HUB FAILURE ON OWNER'S 2003 CHEVROLET TAHOE WITH ABS LIGHT ILLUMINATED ON DASHBOARD WITH GRINDING NOISE FROM WHEEL. HUB REPLACED BY CHEVROLET DEALER, AND INFORMED THAT DRIVER'S WHEEL HUB NEEDS REPLACEMENT TOO. THERE IS A TECHNICAL SERVICE BULLETIN (TSB) ON THE ISSUE BY CHEVROLET, WHICH DOES NOT CONSIDER THIS A SAFETY ISSUE, EVEN THOUGH THE HUB HAS THE POTENTIAL OF SHEARING OFF AT SPEED. *TR

Mileage: 66,510

TL*THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING 5 MPH DOWNHILL AND APPROACHING A STOP, THE ANTILOCK BRAKES PUSHED BACK ON THE CONTACT'S FOOT. THE VEHICLE BECAME DIFFICULT TO STOP AND ANOTHER VEHICLE NEARLY CRASHED INTO THE CONTACT'S VEHICLE. THE DEALER REPAIRED THE BRAKES UNDER NHTSA CAMPAIGN ID NUMBER 04V045000 (SERVICE BRAKES, HYDRAULIC). WHEN THE FAILURE OCCURRED A SECOND TIME, THE DEALER HAD A TECHNICIAN INSPECT THE VEHICLE. IT WAS DISCOVERED THAT THE ANTILOCK BRAKES FAILED AND THE VEHICLE WAS REPAIRED AT THE COST OF $200. THE FAILURE MILEAGE WAS 53,000 AND CURRENT MILEAGE WAS 59,000. UPDATED 10/16/08 *BF UPDATED 10/20/08. *JB

Mileage: 53,000

2003 CHEVROLET TAHOE PROBLEM WITH BRAKES. CUSTOMER STATED THAT HE HAD TO RUN A RED LIGHT BECAUSE THE BRAKES FAILED TO STOP THE VEHICLE. MECHANIC STATED THERE WAS NOTHING WRONG WITH IT AFTER TAKING IT AROUND THE BLOCK. *KB THE CONSUMER STATED STOPPING DISTANCE WAS POOR AND THE PEDAL EVENTUALLY WENT TO THE FLOOR. THE CONSUMER LEARNED OF A RECALL 1 YEAR LATER, HOWEVER HE WAS TOLD HIS YEAR OF VEHICLE AND THE STATED HE RESIDED IN WAS NOT INCLUDED. *JB

TL*- THE CONTACT STATED WHILE DRIVING THE 2003 CHEVROLET TAHOE AT 35 MPH AND WHILE SLOWING DOWN TO A STOP SIGN WITH FOOT ON THE BRAKE PEDAL THE VEHICLE FELT AS IF IT THE BRAKES WERE BEING PUMPED. THE BRAKES WOULD ONLY SLOW THE VEHICLE, IT WOULD NOT STOP IT AT A SLOW RATE OF SPEED. THE VEHICLE WAS TAKEN TO A MECHANIC, WHO DETERMINED THAT THE ABS WAS INADVERTENTLY ACTIVATING AT A LOWER SPEED. *AK UPDATED 02/22/07. *JB

Mileage: 54,500

DT*: THE CONTACT STATED THE ABS WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL WHILE THE VEHICLE TRAVELED 40 MPH. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHO DETERMINED THE ABS HYDRAULIC BRAKE PUMP FAILED. THE MANUFACTURER WAS NOT CONTACTED.

Mileage: 77,143

THE BRAKES FAILED TO STOP THE TRUCK WHEN DEPRESSED BETWEEN 10-15 MPH UPON APPROACHING A TRAFFIC LIGHT. THIS RESULTED IN THE TRUCK REAR ENDING ANOTHER VEHICLE. ALL THE DASHBOARD WARNING LIGHTS AND THE CHECK ENGINE LIGHT STARTED FLASHING AN HOUR BEFORE THE BRAKE FAILURE. ALSO, THERE WAS A RATTLING/THUMPING NOISE IN THE STEERING WHEEL WHEN TURNING. THE TRUCK WAS TOWED TO THE DEALERSHIP, WHO TOGETHER WITH INSURANCE COMPANY HAD TO INSPECT THE TRUCK TO DETERMINE THE CAUSE OF THE BRAKE FAILURE.*AK

Mileage: 18,000

ANTI LOCK BRAKE CONCERN: EARLY THIS SUMMER I HAD TO SUDDENLY STOP ON THE FREEWAY. IT WAS DRY PAVEMENT ON A COMPLETELY CLEAR STRAIGHTAWAY. THE ANTI LOCK BRAKES WENT INTO PLAY AND THE TAHOE WAS SOMEHOW PULLED US TO THE SIDE. MY WIFE SAID "WHAT THE HELL WAS THAT" "WHY". I FELT THE SAME WAY. HAD WE BEEN ON ICE OR A WET SURFACE THIS COULD HAVE CAUSED US TO LOOSE CONTROL COMPLETELY. IT ALMOST FELT LIKE WE WERE GOING TO LOOSE CONTROL. THERE IS NO PULLING OR CONCERNS HOWEVER DURING NORMAL BRAKING. DATE BELOW IS APPROXIMATELY. *AK

Mileage: 20,000

PARKING BRAKE PREMATURE WEARING RESULTS IN VEHICLE THAT CAN ROLL DOWN A HILL AND CAUSE INJURY OR ACCIDENT. WITH 28,000 MILES ON MY 2001 CHEVY TAHOE, THE PARKING BRAKE WILL NOT HOLD. AFTER PAYING THE DEALER TO LOOK AT THE PROBLEM I WAS TOLD THAT THE BRAKE SHOES WERE WORN. I WAS INFORMED THAT OTHER NEWER MODEL TRUCKS HAVE THE SAME CONDITION. THE SERVICE TECH SAID, "DRIVING JUST 10 FEET WILL WEAR THEM OUT." I INFORMED I DO NOT DRIVE WITH THE BRAKE ON. ON PERHAPS 2-3 OCASSIONS DID I MOVE WITH THE BRAKE ON AND ONCE THE CHIME SOUNDED IT WAS TAKEN OFF. DRIVING 10 FEET IS HARDLY ACCEPTABLE. I CONTACTED CHEVROLET ABOUT THIS BUILT-IIN REQUIREMENT FOR SERVICE THAT MAKES THE DEALER HAPPY AND CAUSES A MAJOR SAFETY ISSUE. THEY WERE NOT WILLING TO MAKE ANY "GOODWILL" GESTURES, CITING THIS WAS A WEAR ISSUE. *LA

Mileage: 28,887

WHILE DRIVING ABOUT 55 MPH ON THE HIGHWAY DRIVER APPLIED THE BRAKES AND PEDAL WENT ALL THE WAY DOWN TO THE FLOOR, AND VEHICLE CRASHED INTO A GUARD RAIL. *AK

WHILE SLOWING DOWN, CONSUMER STATES" VEHICLE SUDDENLY ACCELERATED ENGINE WAS RACING, WHICH RESULTED IN CONSUMER CRASHING VEHICLE INTO A CONCRETE WALL. CONSUMER STATES FOOT WAS PRESSED TO THE FLOOR ON BRAKE PEDAL, AFTER HITTING WALL ENGINE WAS STILL RACING LIKE WALL WAS STOPPING IT FROM TAKING OFF. PLEASE DESCRIBE FURTHER. TS