2018 CHEVROLET TAHOE Engine Problems

Complete Engine failure due to the camshaft being destroyed. Dealership said it was due to the lifters.

Manufacturing problem, but not listed under recent GMC recall of April - May 2025 - 2018 Chevy Tahoe Problem: Transmission Issue - slippage

Transmission suddenly locked up while driving. Took to dealership and was advised it was a chronic issue with my vehicle. Once inspected by dealer, was advised that engine lifters also went out. My car was just out of warranty with 55k miles. Dealer did not want to honor warranty and charged me 15k in repairs. I reached out to Chevy and they provided me with some assistance by knocking off 3k. I did not get any warning lights indicating that there’s an issue with the engine or transmission. It happened suddenly. I feel that there is an engineering issue with the transmission and engine. The mechanic checked in my vehicle and said to me that this was a persistent issue with Tahoes like mines. I feel cheated by Chevrolet.

The contact owns a 2018 Chevrolet Tahoe. The contact stated while driving 35 MPH, the vehicle inadvertently lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle was restarted. The ABS and check engine warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the crankshaft push rods, resulting in damages to the engine. The contact was informed that the crankshaft and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 83,000.

Mileage: 83,000

Vehicle stopped accelerating while coming up to speed from an on ramp to the interstate while traveling from Indiana to Florida. Vehicle was towed to the nearest Chevy dealership where we were told the engine had blow and would need replaced. Vehicle has been sitting on the same dealership in Florida since early July. My families lives were put at risk as we were traveling at a low rate of speed on the interstate. As well as, sitting on the side of the interstate in a remote area waiting for a tow truck and cab. The dealer has confirmed what happened via inspection. There were not warning lamps until we lost the engine.

4100 Miles - Asked service dept. at dealership to check for noise coming from underside of vehicle. No service was completed. 4800 Miles - Asked service dept. at dealership to check again for noise on suspension. Service indicated it was a parking brake cable that was rubbing. 9800 Miles - Asked service dept. at dealership to check fluttering noise coming from engine. No service was completed. 15,000 Miles - Asked service dept. at dealership to check again for rattling noise coming from engine. Service indicated fluttering heard was exhaust pulsing through the manifold. No service was completed. 21,000 Miles- Service Dept at dealership provided multi point inspection and given clear inspection. No service was completed even though I stated there was still engine noises. 24,000- Asked service dept. at dealership to check hard shifting from transmission and poor performance. In addition, mentioned the noises again. No service was completed, service stated it was due to colder temperatures. 25,000- Asked service dept. at dealership to check hard shifting from transmission and poor performance. In addition, mentioned the noises again. Engine cooler lines were replaced. Scanned and verified clutch learn values all normal. Activated TCC and disabled TCC and found normal operation. No service completed. Now, after warranty has expired, service at dealership is telling me my camshaft and lifters need to be replaced, struts are leaking, transmission needs attention and should be flushed, and that I should NOT be driving my vehicle due to safety concerns. Although, I had taken the vehicle in multiple times during warranty period with complaints about these very items, no service was ever completed to correct them. Since then, I have read multiple articles documenting GM issues with L87 6.2L engines and transmissions. I'm filing a formal complaint with GM, as these issues should have been communicated to consumers or fixed through recalls.

The repeated failure of the fuel pumps, despite replacement three times, poses a significant safety concern as the vehicle may not start immediately, potentially leading to issues while on the road. This delay in starting could result in the vehicle not running properly, potentially shutting off unexpectedly, which poses a danger to the safety of the driver and others on the road. Additionally, the uncertainty surrounding the effects of using E85 fuel, despite the vehicle being sold as flex fuel, raises concerns about the long-term viability of the motor and overall vehicle performance. It's imperative to address this issue promptly to ensure the safety of all road users and preserve the longevity of the vehicle's components.

AC stopped blowing cold air due to a broken condenser weld issue commonly found in previous recalls 2014-2017

I was sold a vehicle from a dealer in Arizona that online says they only sell to government or law enforcement

A lifter collapsed, which in turn damaged the lobes of a piston, which then damaged the camshaft...generating a repair bill of $7,100 per the dealer. The vehicle only has 69,200 miles on it. When the lifter failed, the car shuddered at stops, lost some power and made a noticeable clanking noise. When pulling out from stops, or into traffic, the car hesitated somewhat before accelerating. This creates a very dangerous situation. Also, if more lifters or the camshaft seized up at higher speeds, a driver could experience a potentially fatal situation from an uncontrollable vehicle or a fire. Research shows that Chevy/GM knew about the lifter problem on 5.3 ltr engines with their AFM system for years and sold them anyway. They apparently have never solved the problem, and it still exists today. Several class action lawsuits have been lodged against them for the lifter failure problem. Aside from the serious potential safety issues, an expensive vehicle like my Tahoe should not be expected to incur a $7,100 repair bill when it's only 4 years old and has less then 70,000 miles on it. That's ridiculous. My wife and I are both retired. We will be tapping our retirement account to pay for this shoddy Chevy product and will worry that it just might occur again, after the fix. From a safety standpoint, a stall, loss of power, or engine seizure at speed will tax our quick response reflexes. The known lifter problem is a legitimate safety situation and needs to be addressed before someone is seriously injured or killed...if they haven't already. Thank you for listening.

The contact owns a 2018 Chevrolet Tahoe. The contact stated while driving at various speeds, the vehicle stalled with the check engine warning light illuminated on the instrument panel. Recently, the contact had the vehicle towed to a dealer where they diagnosed the vehicle with engine failure. The contact was notified of the diagnosis and the dealer recommended that the engine be replaced. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was 22,949.

Mileage: 22,949

Transmission issues on 2018 Chevy Tahoe. The vehicle stopped on the Hwy. Dealership says the transmission needs to be replaced. Is uncertain why the transmission has gone out on the vehicle since it’s only 4 years old. Error message came on my vehicle and I called the dealership. From my research it appears Chevrolet is continuing to have problems with the transmission on its Tahoes. This is unexceptionable. The consumer has to pay the price not the manufacturer. Please assist.

WHEN ACCELERATING IT SOUNDS LIKE MY VEHICLE IS STUCK IN BRAKE DEGRADING OR IS MAKING THAT DISTINGUISHING NOISE. MY VEHICLE IS IN THE SHOP FOR THE SECOND TIME TO FIX THE SAME ISSUE OF PARK ASSIST, SIDE DETECTION AND FRONT CAMERA SERVICE. WHEN EXPRESSING MY CONCERN FOR THIS PROBLEM OF THE SOUND THE DEALERSHIP SAID LET'S FIX THE SERVICE ISSUES FIRST AS EVERYTHING IS ELECTRONIC. I HOPE MY VEHICLE IS SAFE TO DRIVE.

Mileage: 41,500