2023 CHEVROLET TAHOE Electrical System Problems

The car was parked totally normal, went into a store, then came out to start it and when it was put in drive every light on the dash came on and gave a warning for “brake system failure top speed 43 mph” “service traction control” “service esc” “service steering column lock” “service brake pad monitor” “trailer brakes disabled service required”. Shut the vehicle off and restarted with same results. Brakes were inoperable and almost hit the car parked in front of me. Let the car shut down for a couple hours came back and started it and now everything acts normal except there is a Check engine light. Haven’t read the codes yet but am making an appointment at the dealer for warranty work.

The car presented steering lock column issues with repair lights on at 50 miles. Since then, they have repaired the system numerous times and replaced that system fully twice. They also replaced the manual start system and six other pieces of the car over 18 visits to two different Chevy dealerships. The car still reduces speed and stops acceleration, has electric issues in the windows, lights and gate etc.

The engine in my vehicle has experiences major failures in valve flap adjusters, multiple valve failures, valve cover issues, and over consumption of oil by over a quarter in a week and a half of average driving. My safety was put at risk because the engine failure resulted in traction control malfunctions while going 70 mph up hill on a major interstate. This led to extreme shaking which did not stop until slowing down to below 15 mph. Luckily I was a mile from an exit and was able to coast off the road quickly; it was decent enough weather, and I was less than 5 miles from my destination so I could creep between 15-30 mph to not exacerbate traction control alarms. That slow mph did back up traffic behind me. As far as I am aware the problem was likely reproduced by the dealership service tech, which led to their recommendation to replace the whole engine. They do not consider it to be covered by any warranty anymore. The engine may be in their possession still, but I am unsure. There were zero warning lights/prompts from the vehicle that anything was going wrong prior to the shaking and loss of traction control at high speed. The dealer service team suggested that my high miles led to the engine failure. I do highway driving with it and have followed all manufacturer recommendations for oil changes, and even more frequent changes with OEM oil since about 80k miles. I do not think this engine should have failed at this amount of mileage. I made note of oil consumption around 95k miles and measured oil loss regularly. It was a little less than a quart every 2K to 3k miles which manufacturer states is within spec so I would top off oil. A year ago it had a TCM wire replaced after burning in half. 3 weeks ago I also had to replace the entire turbo. The wire rendered my car unable to go in gear. The turbo failure put me into limp mode. I think the turbo failure was a sign of a deeper issue that went undiagnosed.

On several occasions while operating the vehicle during inclement weather the windshield wipers intermittently stopped working. Restarting the vehicle several times did not remedy the problem. Once the vehicle was parked for a while the wipers started working again. This vehicle has been to the dealership regarding this issue numerous times and sent back in service with a message from the technician, could not duplicate the complaint.

On several occasions while operating the vehicle during inclement weather the windshield wipers intermittently stopped working. Restarting the vehicle several times did not remedy the problem. Once the vehicle was parked for a while the wipers started working again. This vehicle has been to the dealership regarding this issue numerous times and sent back in service with a message from the technician, could not duplicate the complaint.

At a stoplight vehicle wanted to stall out Motor was shaking

The sounds from the radio works only 10% of the time, the radio sound also is what produces the turn signal blinking sound. Additionally there is a scratching noise coming from the speakers almost like a bad signal from the tuner. This is very distracting and a safety concern, especially when the turn signal does not audible make a sound. When I call Chevy they say it will be $300 to diagnose, and if you look online this is a known issue amongst newer model Chevy.

I filled my car up with gas and turned it on and it started shaking. Several warnings popped up on the dashboard screen including, Service ESC, Service traction control, And forward collision system unavailable. My cruise control was disabled I had to hold my foot at an angle to keep the speed at 45-50 mph, Causing it to take 10 hours for me to get home from Austin to Dallas. The check engine light was on the entire time and flashed for the last hour to hour and a half. I was unable to pull over at that time because it was dark And I was in the middle of nowhere by myself. The next day I turned my car on.The only thing on was the check engine light, Is , however , around 1 pm that day it Started doing the same thing. I drove it from My patient's house in allen To galleria chevrolet in Dallas. They told me my battery was too low to run diagnostics and I needed to replace it. So I bought a battery and brought it to them. They replaced the Next morning And told me there were no codes showing up so There was nothing wrong with my car and it was a fluke. Exactly one week later the same thing happened to my car. I called the dealership and they Hao it toewd to the service dept. After I repeatedly called them to check on the status of my car, they told me it was the fuel injector #1. They then were able to apply for a loaner car for me as I am a hospice nurse. These are same exact issues that the GM 6.2 L engines are having with the recall they just announced. I have a 5.3 L engine. I am afraid to put my kids in my car. Please help get GM to take responsibility for this!

While driving on the highway at high speed, my vehicle suddenly shut down and went into neutral. After a few minutes of trying to start it, it started and I was able to drive it home. The following day, on my way to the dealership for an inspection, while driving on a busy street, it shut down again. This time, it wouldn't restart, and I had to call the police and a tow truck to have it towed to the dealership. I was freaking out as I had my daughter inside the car with me. At that point, the vehicle had around 26,000 miles. The dealership inspected it and determined the engine was faulty and needed to be replaced. After the engine was replaced, the vehicle seemed fine, but recently, I've been experiencing problems again. The car struggles to start when it shuts off during stops, using the auto shut-off feature, and there's an intermittent hard shifting issue. It feels like the engine is failing again or maybe the transmission, but I've been told that unless the dealership can replicate the issue when I bring it in, they can't do anything. I'm concerned about being stranded on the road again, especially since my daughter is always with me. The vehicle’s engine and mechanical components don’t seem reliable, and I no longer feel safe driving it. However, I have no other option as it is my daily car for work and everything else. I’ve asked for an extended warranty from the dealership after the engine replacement, but I was told GMC doesn’t offer one for this issue. I’ve seen others on social media report similar problems, and I want to share my experience, as I’m just one of many customers facing this issue.

Repeated issues with the infotainment system had to be replaced 3 times to date. The motor blew at 49,000 miles 3 weeks ago. The replacement motor is on back order and it is very difficult to get a loaner vehicle, not to mention having to make a payment on the vehicle that I don’t have to use.

When we first purchased our 2023 Tahoe the engine was making a tiking noise we took it back and they told us it was because it was brand new time past engine always needs oil when we drive it u have to press gas pedal it also has electrical problems back camera turns on and off . Brake sensors don’t work . I almost had a bad car accident due to the engine that it had stop because it said reduced power while I was on a highway . I lost my son 3 yrs ago in a car wreck . I don’t want no more accidents so please help me figure some out with my Tahoe . I also went to dealership and they directed me to a manager . Manager never help never called back or nothing we bought truck at friendly Chevrolet

Traveling on the interstate late at night in the winter with my family, which includes small children, a clicking noise began but then went away. No diagnostic lamps came on, everything seemed fine, vehicle responded appropriately. Moments later, on a remote stretch of interstate, we lost power and the engine shut down. The vehicle would not turn back on. We were stranded in the dark on a freezing night.

After getting gas just outside of Pueblo Colorado on [XXX] I was entering [XXX] and luckily I was in the right lane when all of a sudden no power to the vehicle. I was able to make it by inches in the clear on the shoulder of the road. Being [XXX], I had trouble crawling over the console through the passenger side of the vehicle because I could not safely see the traffic on the interstate to exit the vehicle on the driver side. The state police could not come to assist us with any type of traffic control because of other accidents. The BNSF railroad has a mutual aid pack with them when needed in an emergency situation. They were able to come assist us with the red lights for traffic control, and the tow truck arrived and was able to flatbed the vehicle to a GM Chevy dealership. The tow truck also delivered our 26 foot travel trailer to the nearby campground. If it wouldn’t have been for the BNSF police this could’ve been horrendous accident because of the traffic. I have never been in a more scary situation as with the 2023 Tahoe built by a major corporation and being as unsafe as it is. I have been told the engine needs to be replaced because the bearings failed with metal fragments found in the oil pan. GM has been aware of this problem with the 6.2 engine for many years and has never done anything. Is it gonna take people getting killed on the highway to get something done. Sent from my iPad INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving, without warning my brake system failed and vehicle did not stop when I applied my foot on the breaks. In addition to while driving up a steep incline the engine failed as I was actively applying my foot to the gas pedal causing vehicle to roll backwards. Most importantly i do not feel confident using this vehicle any further knowing that the brakes are Not operating as they should, risking my life and my children’s life is nonnegotiable. Someone help please.

The contact owns a 2023 Chevrolet Tahoe. The contact stated that soon after purchasing the vehicle, the vehicle's lane assist feature would be active with no other vehicles in the contact vehicle's vicinity. The contact also stated that multiple other electrical defects would occur such as the backup camera activating while in drive(D), the instrument panel intermittently going blank, and various other defects. The vehicle was taken to the dealer on multiple occasions where they failed to duplicate the failure. The contact then stated that while driving at 80 MPH, the instrument panel went blank. The contact attempted to pull the vehicle over; however, an unknown turn-off of the vehicle warning message appeared on the instrument panel as a warning chime was also emitted from the vehicle. The contact then stated that the vehicle then came to an abrupt stop where the engine and brakes seized, while traveling at 34 MPH. Due to the failure, the contact was taken to the hospital where they were treated for whiplash, inflammation in the neck and spine, 7 bulging discs in the spine, and pain in various parts of the body. The vehicle was towed to a dealer where it was diagnosed with engine failure; the vehicle's engine was replaced under warranty. Despite the repair, the contact refused to take possession of the vehicle as they did not feel safe driving the vehicle. The manufacturer was notified of the failure and a case was filed; the contact had yet to receive any assistance from the manufacturer. The failure mileage was approximately 15,000.

Mileage: 15,000

Onstar Telematics Module failure. Part is on backorder with no ETA. This module failure removes the navigation, Onstar services including safety notifications, clocks can stop working, Android auto/Apple Carplay services are not functional or intermittently working. My vehicle has stalled out at a red light. GM is refusing to cover the replacement saying it is out of the bumper to bumper to warranty but they have so many of these needing replaced they can't say when they will get the parts. Module has been confirmed dead by a mechanic at a private shop and by the dealership. GM states this is under the bumper to bumper to warranty even though it controls parts of the power train and should be covered under powertrain warranty as well.

I am writing to express my deep frustration with a recent issue I have encountered with my brand new 2023 Chevrolet Tahoe (VIN: [XXX] ). Following the expiration of my complimentary OnStar subscription, I discovered that all voice-activated and Bluetooth functions are inoperable unless I purchase a separate wireless plan at $25 / month which I cannot afford. This is a stark contrast to my previous six Chevrolets, all of which allowed hands-free phone calls and navigation functionalities via Bluetooth without requiring an additional subscription. I have contacted two Chevrolet dealerships, spoken with numerous employees, and reached out to OnStar, spending a total of nearly two hours on the phone attempting to resolve this issue. Unfortunately, no solution has been found. My primary concern is safety. Manually operating my phone while driving is unacceptable, and in some states illegal, putting myself and others at risk. Additionally, the lack of hands-free navigation significantly detracts from the convenience and value of the vehicle. While I appreciate the technological advancements in the 2023 Tahoe, the current system feels restrictive and potentially detrimental to customer safety. I understand the potential for additional revenue through data plans, but I believe the potential for unsafe driving and safety concerns outweighs this consideration. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Bought new and there was a brake pad sensor message immediately that we took it to the dealer several times for and nothing was done other than clearing the code and giving it back. Was in accident 1/24 and it was found that there was a frayed/damaged wire in the break module and break pad sensor that I feel could have led to the accident

I've had my 2023 Tahoe for 15 months, purchased Dec. 2023 Issue #1. Dash message on start up " Restraint System Needs Service". I noticed small lights overhead (buttons for tail gate, sun roof, reading lamps) were off. I pressed some of them, and dash message went away, and lights came on. Everything worked fine. I've narrowed it down to the passenger side reading light. When dash warning comes on, I press reading light, and whalla! all works fine. This has happened about 6 times over the last year. Issue #2. After driving many hours (9 hr drive, then a 2hr drive, then 4hr hr drive on different days/nights) in rain with wipers in auto mode, using defrost on and off as needed. Suddenly, wipers stop working as well as headlights in auto mode! Scary. Pulled over and waited with engine off. Restarted and still nothing. I was able to use headlights in full ON mode. I turned the wiper switch all the way from top-pulse to the full-on 4-6 times really quick back and forth, and like magic, everything worked again! This has happened 3 times in the last 2 months (always during several hours of rainy weather driving). Dealer says they can't fix what they can't witness. I suppose my only recourse is to video tape it and then show dealership.

While driving this rental vehicle in traffic it shutdown and came to an abrupt halt. All lights on the dash were flashing, emergency hazard lights would not turn on. Attempted to restart vehicle with no result. After 2 minutes vehicle dash lights went off and hazard lights were able to be turned on. Vehicle then restarted. While pulling vehicle off the road, brakes were not responsive.

This is a brand new vehicle with a known problem to GM yet they keep selling them and admit they cannot fix it. The audio system, including the blinker sound, is warning systems and hands free phone capabilities do not work properly, if at all. This is a distraction while driving - especially when it comes to phone use. It is deceptive and putting public safety at risk, not to mention costing consumers thousands of dollars. Their built in safety system (onstar) cannot be accessed due to lack of audio rendering it useless in a crash/emergency which is a selling point they tout. I do have video of this occurring. Dealership says they cannot repair and that consumers are just stuck with expensive vehicles they cannot rely on.

Vehicle electronics fail leaving Vehicle in a dead state with no ability to lock or unlock doors

The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving at an unknown speed, the "service safety restraint system", warning message appeared on the instrument panel. The vehicle was taken to a dealer where a diagnostic was performed; the diagnostic showed that there was a defect in the overhead module which rendered her airbag ineffective. The contact was informed that the part to repair the vehicle was on backorder and was given a time estimate of six weeks after the diagnostic was performed. The contact recently called the dealer and was informed that part was still unavailable and that there was no longer an ETA on the part. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was 15,000.

Mileage: 15,000

The contact owns a 2023 Chevrolet Tahoe. The contact stated while driving various speeds, the vehicle would shake with the check engine and several other unknown warning lights illuminated. Upon restarting the vehicle, the vehicle failed to move out of park(P) with the warning lights remaining illuminated. The contact called the dealer, and the vehicle was towed to the dealer where it remained. The manufacturer was notified of the failure and provided the contact a case number. The vehicle was not repaired. The failure mileage was approximately 8,000.

Mileage: 8,000

Intermittent loss of sound on all electrical aspects of vehicle. Can not hear music, phone calls, blinker, seat belt signal, crash detection sound. None will work. Even after turning off and turning back on issue remains unless vehicle is off for 15-30 minutes then it will reboot !

Less than four weeks after having purchased a new 2023 Chevrolet Tahoe LT the backup and 360-degree surround vision camera system completely failed. The cameras would intermittently flicker or would lose connection all together preventing the driver from being able to reverse having the benefit of the camera vision. The rearview camera screen turns black with a red triangle containing an exclamation point alongside a "no camera" circle symbol. The Chevrolet dealer has inspected the vehicle and has confirmed the camera computer is defective and cannot be fixed - a replacement module with recalibration of the cameras is necessary. The vehicle cannot be driven safely, and thus has been with the dealer now for 18 days, with no time table from either the dealer or from General Motors as to replacement of the failed component. The vehicle had been driven less than 700 miles before this failure occurred.

OVERHEAD ROOF CONSOLE INOPERATIVE/SERVICE SAFETY/ RESTRAIN SYSTEM/ SUNROOF INOPERATIVE/ DOME LIGHTS INOPERATIVE/ DTCs B1A7A and U1121