2016 CHEVROLET VOLT Engine Problems

Component/System Failed: The engine of my 2016 Chevrolet Volt experienced a sudden internal crack, leading to complete engine failure. The engine is available for inspection upon request. Safety Risk: The engine failure rendered the vehicle completely inoperable, posing potential risk if it had occurred while driving. Sudden loss of engine power could have caused a crash or left me stranded in traffic, endangering myself and others. Problem Reproduction / Confirmation: The failure was confirmed by a GM dealership, which performed a full inspection and documented the engine crack. The dealership verified that the crack was sudden and not caused by negligence or improper maintenance. Inspections by Others: The vehicle has been inspected by the dealership, and all reports are available. I have also submitted the issue to GM corporate for warranty review. No police or insurance representatives have reviewed this, as this was a mechanical failure with no collision. Warning Lamps or Symptoms: No warning lights, messages, or unusual symptoms appeared prior to the failure. The engine appeared to operate normally until the sudden failure. Upon failure, low oil and low propulsion error message appeared on dash. Current no dash lights are on in the vehicle. Assessment of Cause: Based on dealership inspection and documentation, the failure appears sudden and possibly related to a defect in emissions-related engine components. No external damage or user error contributed to the failure.

While driving the car displayed “reduced propulsion power” on the dash and then I lost all drive power and could not switch the plug in hybrid from electric to gas engine mode. The vehicle had to be towed to the dealer who stated that the battery electronics control module and perhaps the battery needed to be replaced. The check engine light came on slightly before the incident.

Becm failure Car suddenly stopped driving and or starting Had to have it towed home

On [XXX] the check engine light turned on in my 2016 Chevy Volt (VIN: [XXX] miles 145,xxx). I was 2 hours from home in the freezing cold snow but thankfully the vehicle allowed me to drive home without any issues (no reduced propulsion power). When I returned to the vehicle to have a diagnostic check the error light disappeared and I was unable to check for error codes. Still no issues driving under EV/gasoline. Later that day, the car stopped going completely, no shifting out of park either. EV range was reporting 0 miles despite having full charge. I plugged in the charger but it would not work (first time this happened), " Not able to Charge" message displayed. After cycling power the EV range was full range and I was able to shift into drive again. These issues were intermittent over 3 weeks, frequently standing me temporarily. After cycling power, opening and closing the door, cycling power again, the car would function normally and I could drive under battery or gasoline power. I managed to capture these error codes while the MIL light was on: U2603, U2604, U2605, U2606, U2617, U2618, U2619, U2620, U2621, U2622, U2623, U2624 [XXX] my vehicle no longer drives or shifts out of park, "Not able to charge" message displayed, CEL light on. A class action lawsuit revealed a technical service bulletin 18-NA-261 released in 2018 (see attached) accusing GM of continuing support of the known faulty module. The result of the case was Special Coverage Bulletin N232432680 which acknowledges and addresses the above mentioned issues by replacing a faulty BECM common to ALL Chevy Volt models years 2016-2018. My VIN is EXCLUDED from coverage due to being a CARB compliant vehicle despite exhibiting the same behaviors, error codes, and sharing the same faulty BECM. Of the 60,000 Volts sold in 2016-2018, only 19,000 (~33%) qualify under the special coverage terms. 100% of the vehicles that qualify for coverage are NON-CARB compliant. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

BECM failure leaving car stranded in traffic with no ability to move under its own power.

EGR valve has failed leaving me stranded on side of the road. Problem was confirmed by a Chevrolet dealership. Engine light came on moments before it happened.

Shift to park message & audible alarm. Display while in motion pulling into home driveway. Vehicle stalled midway while in motion. Halfway in the street & half driveway. Displaying propulsion power reduced & Engine not available service soon. After 30 minutes of starting & restarting was able to move out of the street. However vehicle will NOT move. Transmission will shift, however will not move. Shift to park keeps popping up.

Mileage: 143,000

Faulty micro-switch from factory, causes power surge. Flawed microswitch in transaxle shift cable. Incomplete connection of microswitch resulting higher voltage to PCM.(power control module) This irregularity, shows a DTC code reducing power propulsion during movement. The car will loose power & ability to shift. During driving movement. Quite a safety concern. A "shift to park" error displays on driver display screen. An OBD2 scanner will clear code & after a few attempts remain operational. However intermittent & unpredictable when to expect the loss of traction power.

The vehicle loses power when trying to accelerate when driving in electric mode, and the gas engine kicks on after a second at which point acceleration returns. It occurs when the battery power is high or low. Sometimes a warning pops up on the dash saying speed is limited to a specific MPH.

Took the car in for service to Simi Valley Chevrolet on 8/16/2023 due to the check engine light illuminated on dashboard. They determined that the EGR valve had internally shorted so they unplugged it so as not to take down the rest of the system and placed a special order for the valve. It has now been over one year and they still don't have the replacement part. The car runs rough and occasionally stalls and sputters. I'm concerned that the car could stall while driving and is unsafe.

The Exhaust Gas Recirculation (EGR) valve failed. Confirmed by dealer, Culver City Chevrolet, 8/29/2024. Failed EGR valve causes gas engine to emit harmful smog forming emissions. This part is still covered by 10 year, 150,000 mile warranty. However, GM/Chevrolet has not made a replacement available and GM representatives have provided no estimate of when or if that replacement part will be made available.

Check engine light came on. Moran Chevrolet dealership says the code is related to the EGR cooler and EGR valve. They want me to pay $3,175.23 for these two parts - however, they can't guarantee that I will get the parts as they are on backorder, and no idea when they will get parts. This is outrageous. I asked, "What if the part doesn't come in?" The dealer's response, "Then we will refund your money, but, we will keep $250 for inspecting the car." "And what if I don't fix it?" Their response: "Eventually, your car will stop working." "What if the car is on the freeway and just stops?" Their response is unsettling for me and hopefully every driver on the road: "We haven't seen that type of failure, yet."

Car displayed a lower power mode on dashboard. Approximately 20 miles later car switched from gas mode to electrical battery mode. Fortunately there was some charge remaining in the battery that I was able to get off freeway and charge car for 3 hours to make the 30 miles home. Dealer thinks problem is a defective EGR valve and I am awaiting a part for this repair for 37 days and counting. The low power mode states it is limited to 35 KW of power but I was surprised when the engine cut off to battery mode. If I had used up the battery charge on the first portion of this trip I do not know how suddenly the car would have stopped on freeway.

The car has experienced a ‘BECM’ failure, which is very common on the Chevy volt. When it fails the car becomes undrivable and will slow down into reduced propulsion mode. It will not start and required us to have it towed to the dealer. The 2016-2019 Chevy volt BECM issue has been investigated by the nhtsa and gm. It is a common enough issue that gm has voluntarily issued ‘special coverage N232432680’. This covers the becm failure on 2016-2019 volts for free for up to 150k miles 10 years. We have a 2016 volt with 144k miles so we assumed it would be covered. The dealer said it wasn’t covered based on my vin but they didn’t know why our vin was left out of the coverage. Obviously if they thought our car didn’t have a suspect becm, they were wrong because it failed during the special coverage time. The repair is $2600 and gm will not assist us with this repair. I have attached a copy of gm special coverage and the bill. This seems to be a clerical error that our vin and maybe others were missed despite the fact our car falls right in the special coverage criteria. I believe this should be a full recall or 2016-2019 volts, especially if the becm has failed.

Mileage: 143,000

The EGR valve failed, blew up a fuse, and the internal combustion engine started to overheat and run very roughly and unsteady. I almost lost control

The EGR valve in the 2016 Chevy volt will fail blowing fuse 3 which will also take out the engine oil pressure control solenoid, the evap emission purge solenoid valve, the engine coolant thermostat heater, and the oxygen sensor 1 as they all share the same fuse. The car will tell you that the engine is unavailable and, if you are out of hybrid battery power, will leave you unable to move the vehicle. In my particular situation it left me stranded blocking one lane on a two lane s-bend road on a 5-9% grade mountainside with no cellphone reception. Thankfully the car stopped far enough away from the previous bend that people had time to see me and I didn't get rear-ended. If I had stopped 20 feet sooner that likely would not have been the case. The replacement part for the EGR valve is impossible to find as it is back ordered everywhere and places that will let you back order it will try to charge $1927 just for the part (no installation service included). If you live in a state without emission checks then you can unplug the EGR valve and replace the fuse but that means your producing more pollutants. Until GM gets their act together and offers affordable replacement parts I don't see another alternative.

EGR valve failed. When switched from Battery to gas car stalled and we were stuck. Dealer said it needs a new EGR valve. But it was on back order. This was a year ago and Chevy still claims the part is on back order! Now the car is ready to renew registration. But it cannot pass inspection because it must have been driven on gas for many miles for the inspection to work! The part is obviously no longer available and Chevy has not offered a solution.

I was driving in clear weather (with my ICE engine as propulsion) when an Engine Warning Fault light appeared on my dash and the vehicle slowed to 5mph with no response from the throttle pedal. I pulled into a parking lot, had the vehicle towed to an independent service shop, and had them check the codes. There were a dozen faults stored, but they found the 'Non Walk Home' fuse had blown, and faults pointed to the EGR Valve as having faulty electronics. They could not find an EGR valve for sale so they unplugged the EGR Valve and replaced the fuse, which allowed the engine to drive normally again, but with the Check Engine Light on at all times. I called my local Chevy dealer and they told me the EGR I needed was Part Number 12691147 for $243, but they were backordered and there were dozens of people in front of me for their dealer alone. Now, 11 months later, I'm still waiting on the part, I have found hundreds of other Volt owners online with the same issue, and the Part Number has been changed by GM to 19436113, with a price increase of 1100% to $2642. And the part is still not available because of "high demand" on a car that was discontinued five years ago.

There is a propulsion warning due to faulty EGR valves. Many customers are experiencing backorders lasting for up to 6 months or more, just from what I can quickly find online. I am now on my 5-month mark. I have not been able to drive the car at all. Driving it could damage the engine and put drivers at risk. Because many of these vehicles no longer qualify for lemon laws, the manufacturer seems to not take our delay seriously or even care about our limited resources in time and money. (I purchased this used car that was in great condition and passed the inspection for about $13,000 in-full. I am not wealthy so this was an expense I was carefully saving for. I was only driving it for weeks before this happened. I am now hunting for my legal options.) Not only is their response completely unethical and inconsiderate, but some desperate drivers are suggesting to unplug the EGR then replace the fuse. This can damage engines further, disallow us to pass emission tests, and cause possible danger to the driver and others on the road. Chevy and GM need to be held accountable!

Started vehicle with > 50mi on the EV-range. Pulled out onto road, stopped at red light. Now showed 0mi and refused to move when pressing the gas (did not fail over to gas on series PHEV) Garbage truck coming up behind me had to swerve to avoid rear-ending me as I was frantically trying to start the car. Kept saying 'shift to park' (condition required to start the vehicle) Took several minutes and 20+ tries before I got it to start (GAS engine) and was able to proceed. Car keeps randomly dropping to 0mi EV range. Has refused ot start on occasion. All symptoms align with the N232432680 bulletin but GM saying my car isn't covered???

2016 Chevy volt started to not shut off with the message that car needed to shift to park. Car is just over 100,000 miles (104,000) spent a few weeks jiggling shifter to get car turned off then made an appointment at Platinum Chevy of Santa Rosa. While waiting we researched the issue to find that the Shift To Park is a known issue and the Volt has in fact been named in a class action suit. Am currently at crossroad as I cannot get GM to stand behind their product. It’s taken four calls and an escalation to management to find out that they may offer a percentage to fix the problem but because we’re out of warranty it is a customer problem. So, to cap it off, GM has sold us a vehicle with a known safety issue with no recall and will not fix their problem.

My 2016 Chevy Volt experienced a loss of propulsion power multiple times due to the EGR (Exhaust Gas Recirculation) valve failing. The malfunctioning EGR valve caused the F3 fuse to break, disabling the cooling system and forcing me to pull over immediately, which posed a safety risk, especially in high-traffic areas or on highways. The problem was reproduced when the replacement EGR valve also failed. It is not specified if the vehicle or components have been inspected by the manufacturer, police, insurance representatives, or others. Both the original and replacement EGR valves should be available for inspection upon request.

On [XXX], this Volt was towed to the Dealer because the Volt would not start, would not charge, and the engine light was on. The Dealer claimed that the problem was the Chevrolet Volt Battery Energy Control Module (BECM), GM Part # 24296900, which was covered under the GM hybrid VOLTEC warranty (8 years, 100,000 miles). On [XXX], 2024, this Volt (VIN [XXX] ) was towed to the Dealer again because the Volt would not start, would not charge, and the engine light was on. The Dealer claimed that the hybrid battery connectors were corroded, the disconnect relay should be replaced, and the BECM should be replaced again at a total cost of $5,005.58. On [XXX], GM issued special coverage warranty N232432680 (15 year, 150,000 miles) to cover BECM replacements for a malfunction involving the BECM. Plaintiff checked the VIN at the GM Recall and Warranty Center website. The Volt at issue is covered under special coverage warranty N232432680, according to the GM website. Plaintiff asked the Dealer and GM again after [XXX] about warranty coverage for the BECM at issue. GM responded that the bumper-to-bumper warranty expired and that they would provide no assistance. On [XXX], Plaintiff filed a complaint with the local Better Business Bureau (BBB) regarding the BECM at issue. GM responded in writing that the bumper-to-bumper warranty expired and that they would provide no assistance. Plaintiff sought arbitration, but both the local BBB and the BBB Auto Line found that Plaintiff was not eligible to arbitrate with GM due to GM’s program summary guidelines with the BBB. GM breached multiple warranties and failed to provide sufficient repairs, and this Volt has been out of service for more than 80 days. Based on GM’s warranty breaches, insufficient repairs and inconsistent statements, this Volt poses serious safety concerns. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car states the battery will not charge and cannot move the car. I connected it to a code reader with the following codes showing: P1E00 U2618 U2606 U2605 U2617 U2604

EGR valve failure. No replacement parts being made to replace failure. Engine doesn’t run smoothly and check engine light is on. Items been back ordered since August last year. No longer California compliant, cannot pass smog. Danger hazard.

I got the “propulsion power is reduced” warning at ~83.5k miles on the odometer, while visiting friends 4 hours from home. Pulled over and called 3 local dealerships and all servicing departments are closed on Sunday so knew there was nothing I could do except try to limp back to my friends house safely and reevaluate. On the 20 minute drive back, the engine cut out on the freeway and the car immediately started slowing down. I coasted to the next freeway exit safely with my hazards on. The scary part was that I had no power after the ”engine unavailable” warning popped up since the battery was completely drained already. I was able to get it towed to the closest chevy dealership and leave the keys for them. I am waiting to hear the official diagnosis from the dealership once they take a look. The cause is still unknown but this sounds like a similar series of events for BECM failure.

The contact's son owns a 2016 Chevrolet Volt. The contact stated that the vehicle was taken to the dealer due to an oil leak caused by a puncture in the oil filter. The vehicle was repaired. The contact's son had informed the dealer that he had been smelling a fuel odor inside the vehicle; however, the dealer informed the contact's son that the odor was probably a burning oil odor. The vehicle was taken to an independent mechanic, where it was diagnosed that the fuel rail was leaking and needed to be replaced. The mechanic contacted the dealer who informed him that the part was on a national backorder. The mechanic replaced the part with a used part; however, the failure persisted. The dealer was notified of the failure and informed the contact that the part was on backorder. The vehicle was not repaired. The manufacturer was notified of the failure and offered a coupon towards the purchase of a new vehicle. The failure mileage was approximately 60,000. The contact stated the Volt engine starts periodically even if it has battery power available. The engine forces itself on and can not be turned off manually.

Mileage: 60,000

My car will lose all power as I'm driving, switch between gas/ elec and almost stall, it will accelerate when I take my foot OFF the gas , it will lose power on a turn.. it's random. form what I understand it's the BECM and it happened just after 100k miles. I have 105k.

Check engine light came on reduced propulsion warning. Took to Chevrolet dealer and they diagnosed EGR value failure while on road trip. Got home Took it to my local dealership and same diagnosed no part available and emissions warranty is good and it is covered but 2 year nationwide backorder by GM. The car only shows 47000 miles without parts I will not be able to use the vehicle after it fails the emissions test for Maryland.

I have a engine code P0401

I had just left my house about to enter the on-ramp to Interstate 95 south when my 2016 Volt abruptly and without warning stopped. I was unable to coast or pull the car to the side of the road. I was in the middle of the lane in a dangerous place to stop a car and a dangerous place to get out of the car due to the steady traffic entering the interstate. My car would not restart and I had it towed to the Portsmouth NH Chevy dealer. As it was the beginning of the GM strike I had to wait several days for the replacement battery control sensor then I had to wait for another 4 weeks or so for a replacement transmission to be installed. The day after I got my car back, about 2 weeks ago, the transmission fluid was leaking onto the garage floor. The Chevy dealer has ordered new transmission hoses but only one has come in and I was told not to drive my car until these were replaced. The sensor pad and transmission were covered under warranty, I was told the hoses to the transmission and labor to install them are not part of the transmission and not covered. The incident has been extremely inconvenient but the way my car just abruptly stopped and wouldn’t restart was very unnerving and could have been very dangerous. I do not have paperwork at the moment but can provide a dealer invoice of the covered work so far. Please contact me with any questions.

I had BECM failure and the car suddenly stopped in the middle of the road. They need to make this a safety recall.

Driving 72mph down I5 interstate the display notified me with a check engine light with two errors, enigne propulsion reduced and engine overheating. I pulled over to the side of the road and called a tow. This was a very traumatic event. I had my partner and my 2 year old daughter in the car.I just purchased this used vehicle from a Toyota dealer the same day. It has 63k miles on it and still under powertrain warranty. I literally drove the car 45 miles. TOTAL. I have spent more time towing and fixing this car than actually driving it. This is a total lemon. I need a refund from GM and all the pain and suffering that this caused my family.

I was driving on a highway and all of a sudden I have a Check engine light and “propulsion power reduced” on my display. I took my car to the dealer and found out it was my EGR valve that had an internal failure and it was needed to be replaced. This should be a recall because I was under warranty and they stated that my warranty only covers in California or an emission state. It’s been about 2 months it’s been on back order and I cant even drive my car. This is not a rare problem every volt with a EGR valve has failed.

Component: Dealer said its the BECM. Lots of them failing, check any Chevy Volt forum. What happened: Driving on road, battery drive turns off and it switches to gas engine, "reduced propulsion" message pops up, then gas engine quits and 'shift to park' message pops up. No electric motor, no gas engine, coasting, then stuck in road, traffic piling up behind me. After half-hour or so of blocking traffic and me trying to restart the car, electric eventually 'reset' and it worked fine again, so I drove it the several miles home, and the charging system connected fine. Next morning, charging system said it was broken, and car would not start. Towed to dealer. Safety risk: Both battery drive and gas engine turned fully off while traveling on road - no power, and steering/brakes hard to use. Luckily was in slow lane on local road near corner with traffic light, so others were 'prepared' to slow down, avoided my stopped car, and were able to get around. Prior Symptoms: Within the prior week, battery drive switched to gas engine with 'reduced propulsion' popup, but then it switched back to battery drive after stopping and restarting. Several times noticed the 'battery charge' indicator would change color and the estimated mileage remaining would bounce between 0 and 47.

Our 2016 Volt was cruising at 65 mph on a major interstate highway (HOLD mode) when out of nowhere the check engine light came on followed by a warning message "Propulsion power reduced." We managed to pull off the highway, but a few minutes later navigating on local roads, we received another message that the engine had overheated and was shutting off. Fortunately, there was a chevy dealer only several miles away, and we made it there slowly under EV mode. They later traced the problem to a failed exhaust gas recirculation (ERG) valve. It was replaced under warranty. The whole experience was terrifying. We also own a 2017 Volt, and now we are afraid that it could also experience the same problem without warning.

While on a road trip, we were traveling on a rural highway at roughly 55 mph. We received a warning message on the dashboard stating that "Propulsion power was reduced" and the engine began running rough, with surging noticeable based on throttle position. We also noted that engine temperature was rising above what was typical for the vehicle. The vehicle was able to maintain highway speed, and we were able to limp the vehicle to a safe location. Based on a web search, we were able to diagnose the issue (a failed EGR valve) as well as a way to limp the vehicle to a local dealership. They made a change that allowed us to limp home safely (unplug the EGR valve's electrical connector and replace the blown fuse under the hood). The vehicle was taken to a Chevy dealership when we made it home. The failure we had diagnosed was confirmed, and the component was replaced. The repair was not covered under warranty, and cost a significant sum to repair (1139.91). Additionally, this appears to be a very, very common failure for this make and model of vehicle- to the point where there is so much demand for this repair to be performed that these components (the EGR valve specifically) are difficult to obtain from Chevy. Additionally, the failure mode is such that when the EGR valve fails, it pulls excessive currents, and blows a fuse that also controls a number of important engine cooling components, leaving engine cooling significantly compromised. If we had been going faster, or if the weather was warmer, or if the load inside the vehicle was heavier, it would have been easy to overheat the gas engine and leave us stranded. I am concerned about the incidence rate of the failure, (based on online reports) the relative small number of miles on the vehicle when the failure occurred, (~57k) and the possible knock-on effect of the failure of the gas engine's ability to cool itself due to a relatively unrelated failure.

Got a Check Engine light on Aug 26 2022 driving about 5 minutes out of my house. With that light turned on, the EV showed zero miles range (it was fully charged when I left the house), the ICE engine kicked in but it was running very harsh and when I stepped on the gas peddle, it would not accelerate and can only go about 30 mph. I immediately made a U-turn and returned home for the car is not drivable. Took the Volt to my dealership on Aug 29, 2022 and service manager diagnosed as a BECM failed and now waiting for a replacement, which they said they are not able to find one. This is going on week #7.

Vehicle suddenly experienced "reduced propulsion mode" on the highway. Multiple codes were triggered in the ECM. Root cause of the problem was the EGR valve which is on a shared circuit with multiple other components including a water pump which causes the car to overheat.

Received a Reduce Power warning with a check engine light on. OnStar e-mail notification saying there is an issue with Lithium-ion battery and to service the vehicle within 7 days. When this happened I was driving on the street not far from my house and sure enough I was not able to keep up with the speed of the traffic so I turned around and returned home. My battery was fully charged when I left home and when this happened, it showed my battery was depleted and switched to my gas engine but was not able to drive over 40 mph for the gas engine was making a weird sound as if it is not able to run smoothly.

My car, without warning, lost power while driving and then flashed an engine light. This happened on a street and I was able to coast to safety, but if it had happened in an intersection I would not have been so lucky. The problem was confirmed by a dealer as a failure of the Battery Energy Control Module, which has been happening to this car with numerous other owners, according to the Volt owner website.

THE VEHICLE ISSUES A MESSAGE TO MOVE THE GEAR SHIFTER INTO PARK (SHIFT TO PARK) MESSAGE EVEN WHEN IT IS ALREADY IN PARK. THE VEHICLE WILL NOT ENGAGE NOR WILL IT ENABLE THE DRIVER TO TURN THE VEHICLE OFF WHICH RESULTS IN UNSAFE DRIVING CIRCUMSTANCES AND STRANDS THE DRIVE IN UNTENABLE SITUATIONS. THIS IS KNOWN IN SOCIAL MEDIA AS THE "SHIFT-TO-PARK" PROBLEM WITH VOLT AND OTHER GM VEHICLES WHILE GM IS HUSH-HUSH ABOUT THE ISSUE. THERE ABSOLUTELY NEEDS TO BE A RECALL ISSUED FOR ALL AFFECTED VEHICLES AS THIS IS CLEARLY A MANUFACTURER DESIGN ISSUE GIVEN ALL OF THE PROBLEMS DRIVERS ARE HAVING. IT STARTS AS AN INTERMITTENT PROBLEM AND CONTINUES TO GET WORSE OVER TIME WITH OUT ANY WARNING.

Mileage: 45,558

WHEN ATTEMPTING TO TURN OFF THE CAR IT SAYS "ACTION REQUIRED: SHIFT TO PARK" AND WILL PROCEED AS BEING LEFT ON, DESPITE BEING IN PARK. THIS OCCURS ABOUT 70% OF THE TIME THE CAR IS DRIVEN AND TAKES SEVERAL TRIES OF TURNING ON THE CAR, MOVING, PARKING, AND TURNING BACK OFF BEFORE THE ENGINE SHUTS OFF WITHOUT THIS WARNING.

Mileage: 40,000

UNABLE TO TURN OFF POWER TO CAR WITH ERROR ON DASHBOARD SAYING SHIFT TO PARK. HAVE TO POWER ON AND OFF SEVERAL TIMES WHILE MOVING THE SHIFTER IN AND OUT OF PARK TO GET THE CAR TO TURN OFF.

Mileage: 29,368

TL* THE CONTACT OWNS A 2016 CHEVROLET VOLT. THE CONTACT STATED THAT THE BACK-UP CAMERA WAS MALFUNCTIONING AND THE FRONT CONSOLE WOULD NOT WORK IF OTHER SERVICES WERE BEING USED. THE CONTACT HAD TO TURN OFF AND RESTART THE VEHICLE TO GET THE CONSOLE TO WORK AGAIN. THE VEHICLE WAS TAKEN TO RELIABLE CHEVROLET (800 N CENTRAL EXPY, RICHARDSON, TX 75080, (972) 201-9240) WHERE THEY RE-FLASHED THE MODULE AND CHANGED THE CAMERA; HOWEVER, THE FAILURE RECURRED AND THE VEHICLE WOULD SHUT OFF WHEN PARKED. THE VEHICLE WAS A HYBRID AND THE BATTERY WAS DEPLETED. THE CONTACT WAS CONCERNED ABOUT THE CARBON MONOXIDE LEVEL IN HER GARAGE. THE VEHICLE WAS GETTING MORE AND MORE DIFFICULT TO SHUT OFF AND THE CONTACT HAD TO WAIT SEVERAL MINUTES TO MAKE SURE IT FINALLY SHUT OFF. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY STATED THAT THEY WOULD CONTACT THE MANUFACTURER AND CALL BACK. THE FAILURE MILEAGE WAS 5,000. *TT *JB *TT THE CONSUMER STATED UNRESPONSIVE DISPLAY GOES BLANK WHEN STARTING THE VEHICLE. THE CONSUMER FURTHER STATES WHEN A VEHICLE IS TURNED OFF HAVING ERRORS NOT RECOGNIZING THE VEHICLE IS IN PARK. *TR

Mileage: 5,000

IN REGARD TO RECALL 16055 REPROGRAM HYBRID POWERTRAIN CONTROL; MODULE 2. I HAD THIS RECALL DONE ON JANUARY 5, 2017. THIS SERVICE CHANGES SOME SETTINGS WITHOUT NOTIFICATION TO THE OWNER. CRITICALLY IMPORTANT IT CHANGES THE ENGINE RUN ON REMOTE START FROM OFF TO ON. IF THE OWNER STARTS THEIR CAR TO WARM UP IN THE GARAGE THE ENGINE WILL RUN UNKNOWING TO THE OWNER. THIS COULD BE A VERY DANGEROUS SITUATION FOR THE BUILDUP OF CARBON MONOXIDE IN THE GARAGE.

Mileage: 7,400

2016 CHEVY VOLT WOULDN'T START, LESS THAN A YEAR OLD, CURRENT ON MAINTENANCE. TOWED IT TO DEALER, THEY SAID THERE WERE SOME RECALLS - BUT COULDN'T TELL ME WHAT WAS WRONG. GOT IT BACK AFTER 2 DAYS, WAS FINE - THEN ON 9/22/16 WOULDN'T START AGAIN - I WAS STRANDED IN THE DARK, GOT IT JUMP STARTED. TOOK IT TO THE DEALER, SINCE IT WAS RUNNING FINE HE DIDN'T TAKE IT IN. TOLD ME NEXT TIME IT HAPPENS TO GET IT TOWED IN. WOULDN'T START AGAIN YESTERDAY, UNRELIABLE CAR. PLEASE INVESTIGATE.

Mileage: 14,000