2006 CHRYSLER 300 AWD Engine Problems

TL* THE CONTACT OWNS A 2006 CHRYSLER 300 AWD. WHILE AT A STOP, THE VEHICLE DID NOT ACCELERATE. THE CHECK ENGINE AND THUNDER BOLT INDICATORS ILLUMINATED. THE VEHICLE WAS TURNED OFF, RESTARTED, AND OPERATED NORMALLY. THE VEHICLE LOST ACCELERATION AGAIN. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT ALSO STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR A FUEL PUMP FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.

Mileage: 126,000

MY CAR SHUTS OFF WHEN I FILL THE TANK. IT SHUTS OF WHEN IN MOTION.

Mileage: 113,300

I HAVE READ MULTIPLE POSTS THAT FIT EXACTLY THE SAME DESCRIPTION TO WHAT HAPPENED RECENTLY WITH OUR 2006 CHRYSLER 300C 5.7L HEMI AWD - SO I THOUGHT I WOULD SHARE OUR EXPERIENCE. WE HAVE ALWAYS TAKEN VERY GOOD CARE OF OUR 300, REGULAR SERVICES ETC AND HAVE KEPT EVERY SINGLE DOCUMENTATION SINCE PURCHASED. RECENTLY, MY WIFE WAS DRIVING AT 70-75 MPH ON I-95 - ENGINE COMPLETELY CONKED OUT AND STARTED STEAMING. TOWED IT TO THE MECHANIC. ORIGINALLY THE MECHANIC SAID IT WAS JUST A CRACK/LEAK IN THE RADIATOR, WHICH WOULD COST $750. THEY WENT AHEAD AND FIXED THIS PROBLEM. HOWEVER, 2 HOURS LATER WE GET A CALL SAYING THERE WAS A SEVERE CRACK IN THE ENGINE THAT HAS CAUSED A MAJOR LEAK INTERNALLY. NOW AT THE MERCY OF THE MECHANIC, AS WE OWE THEM $750 FOR THEIR MISDIAGNOSIS. NEW DIAGNOSIS - NEED A COMPLETE ENGINE REPLACEMENT THAT WOULD COST APPROX $8000-$8500. ABSOLUTELY POINTLESS WHEN YOU TAKE INTO CONSIDERATION KBB VALUE IS BETWEEN $9,000-$10,000. AFTER DOING MY RESEARCH IT SEEMS A NEW 300 ENGINE WOULD BE BETWEEN $4,000-$5,500 AND LABOR IS APPROX $1,800-$2,500. SO I GUESS IT ISN'T A BAD DEAL FOR MECHANICS WHO CAN POSSIBLY FIX IT THEMSELVES. HOWEVER, AS USUAL THE LOYAL CUSTOMERS ALWAYS SEEM TO GET SCREWED BY CHRYSLER. WORST PART ABOUT IT IS 4 MONTHS AGO WE PURCHASED A NEW 300. MAYBE THIS WAS ONE OF THE REASONS THEY REVAMPED THE ENTIRE ENGINE OF THE NEWER CHRYSLER 300 MODEL RANGE???

Mileage: 149,000

BOTH LEFT AND RIGHT CAT PIPES HAVE FAILED. NOT THE CAT ITSELF BUT THE PIPE WHICH COULD LEAD TO EXHAUST GETTING INTO THE CAR.

Mileage: 90,000

CARS STALLS WHILE DRIVING...NO CODES ARE ON...ETC LIGHT ON WHEN STALLS AND THE CAR RESTARTS WITHOUT A PROBLEM. ALMOST IN MANY ACCIDENTS WHILE DRIVING WITH THE KIDS. CHRYSLER HAS KNOWN ABOUT THIS PROBLEM AND HAS DONE NOTHING ABOUT THIS PARTICULAR TYPE OF MODEL. TIPM IS DEFECTEDD AND THERE'S A CLASS ACTION LAWSUIT AGAINST THEM. *TR

Mileage: 104,000

MY CAR STALLED ON A STOP LIGHT TWICE LAST NOVEMBER 2014 AND JANUARY 25, 2015 AFTER I FILL UP MY CAR. I TURNED OFF THE CAR AND THEN TURNED ON THE CAR AGAIN AND IT DROVE. FOR NOW IT IS WORKING BUT I'M AFRAID IT WILL STALLED AGAIN WHILE ON THE ROAD. *TR

Mileage: 79,000

ENGINE DIED NO CHECK ENGINE NO WARNING. STARTED BACK UP AFTER A FEW MINUTES. *TR

Mileage: 134,704

WHEN I COME TO A FULLL STOP , CAR WILL DIE. ALWAYS STARTS UP AGAIN THO. IT IS SCARY. HAPPENS AT LEAST ONCE A WEEK. *TR

Mileage: 105,000

CAR STALLS RIGHT AFTER A GAS FILL UP. *TR

Mileage: 30,000

VERY SHORTLY AFTER REFUELING MY CAR (PROBABLY DRIVEN LESS THAN 1000 FEET) THE CAR SHUTTERED AND STALLED. IT RESTARTED IMMEDIATELY BUT THEN SHUT DOWN AGAIN WITHIN THE MILE. AGAIN, IT STARTED IMMEDIATELY AND I HAD NO MORE PROBLEMS UNTIL THE NEXT TIME I FILLED THE TANK AND IT STALLED AGAIN ALMOST IMMEDIATELY UPON EXITING THE GAS STATION. AGAIN, IT RESTARTED ON THE FIRST TRY AND I HAD NO MORE PROBLEMS FOR THE REST OF THE TRIP OR SINCE. HOWEVER, I HAVE NOT REFUELED SINCE; SO DON'T KNOW WHAT WILL HAPPEN WHEN I DO. I HAVE TAKEN IT TO A DEALER AND IT IS DEEMED I NEED A NEW GAS TANK. GAS TANKS SHOULD NOT WEAR OUT AND OUR CAR IS LOW MILEAGE AND IN MINT CONDITION. THIS SEEMS LIKE A FAULTY DESIGN PROBLEM. IT IS CLEARLY A SAFETY ISSUE WITH MY CAR AND I SUSPECT WITH OTHERS WHO OWN THE SAME MODEL. (I DID NOT "TOP OFF" THE TANK ON EITHER OCCASION.) *TR

Mileage: 48,000

FOR SOME TIME NOW, THERE IS A LOUD METALLIC TAPPING COMING FROM THE ENGINE. SOUNDS AS IF IT MAY BE COMING FROM THE ENGINE'S HEAD ON THE PASSENGER SIDE OF THE CAR. *TR

Mileage: 3,250

I WAS DRIVING TO A TRAFFIC LIGHT IMMEDIATELY AFTER FILLING THE GAS TANK WHEN THE CAR SUDDENLY STALLED. THERE WAS LOSS OF STEERING CONTROL. I PUT THE GEAR IN PACK AND RESTARTED THE CAR WHICH IT DID SUCCESSFULLY BUT STALLED SOON AFTER AND AGAIN RESTARTED SUCCESSFULLY. THE CAR RAN PERFECTLY TILL I REFILLED THE TANK FOUR DAYS LATER AND HAD SIMILAR OCCURRENCE. IT HAPPENED ABOUT A WEEK LATER, AGAIN AFTER ANOTHER REFILL. I TOOK THE CAR TO THE DEALER WHO INSPECTED IT AND DETERMINED THERE WAS NOTHING WRONG. THE SAME INCIDENT HAPPENED A FOURTH TIME ON 12/17/2013 AND IT WAS VERY WORRISOME AS I WAS ON THE RAMP TRYING TO MERGE INTO A HIGHWAY WHEN IT STALLED BUT I WAS ABLE TO PULL INTO THE SHOULDER. TODAY AGAIN AFTER REFILLING IT HAPPENED WHILE DRIVING FROM THE GAS STATION, AGAIN, AT LOW SPEED BUT LATER ON THE HIGHWAY, AT ABOUT 55 MILES PER HOUR IT STALLED, THE FIRST TIME IT IS STALLING AT SUCH HIGH SPEED. *TR

Mileage: 137,000

FOR THE 5TH TIME IN 12 MONTHS, MY 2006 CHRYSLER 300C STALLED AFTER FILLING UP AT A GAS STATION, NEARLY CAUSING AN ACCIDENT. I PREVIOUSLY BROUGHT IT TO A MECHANIC WHO DID A TUNE UP, NEW SPARK PLUGS, AND EVEN REPLACED VALVE LIFTERS TO TRY TO RESOLVE THIS ISSUE, TO NO AVAIL. I FINALLY DID A GOOGLE SEARCH AND SEE THAT MANY OTHER PEOPLE HAVE THIS PROBLEM. IT IS RIDICULOUS TO ME THAT THIS HAS NOT BEEN A RECALL, AS IT IS VERY DANGEROUS TO STALL WHEN PULLING OUT INTO TRAFFIC AFTER FILLING UP THE TANK WITH GAS. *TR

Mileage: 78,000

MY VEHICLE STALLED WHILE TRAVELING ON HIGHWAY AFTER FILLING FUEL TANK. THIS PROBLEM HAS HAPPENED AT LEAST 3 TIMES IN THE PAST AND IS VERY DANGEROUS. THANK GOD IT WAS A SUNDAY AFTERNOON AND TRAFFIC WAS LIGHT. I HAVE READ ON LINE THIS IS A FAMILIAR ISSUE. WHY ISN'T ANYTHING BEING DONE ABOUT THIS??? *TR

Mileage: 89,300

AFTER REFILLING THE GAS TANK OF MY 2006 300C CHRYSLER, IT STUMBLES AS THOUGH IT IS NO LONGER GETTING ENOUGH FUEL. THERE IS A DEFINITE AND SERIOUS LOSS OF POWER, WITH CONCERN FOR OUR SAFETY AS WE EXIT THE GAS STATION AND REENTER TRAFFIC. THERE IS A SENSE THAT THE ENGINE IS STRUGGLING AND WOULD STALL. THE LOSS OF POWER REPEATS SEVERAL MORE TIMES AS WE DRIVE FURTHER FROM THE GAS STATION. THIS PROBLEM HAS PRESENTED ITSELF ALMOST EVERY TIME WE REFUEL AND IS CAUSE FOR REAL CONCERN FOR OUR SAFETY. BASED ON ADVICE FROM OTHER 300C OWNERS, WE PLAN TO NO LONGER FILL THE TANK, BUT STOP AT ABOUT THE 3/4 MARK. THIS DOES NOT SEEM TO BE A VERY EFFECTIVE SOLUTION TO A GENUINE SAFETY ISSUE. *TR

Mileage: 102,000

WHEN I FILL MY GAS TANK, THE CAR HESITATES AND STALLS FOR THE FIRST 5 TO 20 MILES ON LOCAL STREETS. IT HAPPENS WHETHER I FILL TO THE AUTOMATIC SHUT OFF OR THE STATION "TOPS OFF" THE TANK. AFTER THIS HAPPENED 4 OR 5 TIMES, I STARTED TO FILL THE TANK TO 75% AND NOW IT DOES NOT HAPPEN. IT WAS VERY SCARY AND UNSAFE TO STALL LIKE THAT. I SAW THE INVESTIGATION INTO THE OTHER 2006 CHRYSLER PRODUCTS AND MY PROBLEM IS IDENTICAL. MY DEALER HAD NO IDEA WHAT WAS WRONG WITH THE CAR AND THEY SUGGESTED FILLING IT TO 75%. *TR

Mileage: 35,000