2004 CHRYSLER PACIFICA Steering Problems

THE FRONT CHASSIS CROSS MEMBER HAS ROTTED OUT. MY 2004 PACIFICA HAS BEEN PARKED IN MY DRIVEWAY OVER 5 YEARS BECAUSE THE CORROSION IS SO BAD I'M AFRAID TO DRIVE IT. I'VE BEEN WAITING FOR A RECALL TO FIX THIS OBVIOUS FACTORY DEFECT. THE ROTTED FRONT CROSS MEMBER WAS POINTED OUT TO ME DURING A STATE INSPECTION IN JUNE OF 2012

Mileage: 75,000

WHEN WE PURCHASED THE CAR I NOTICED WHEN I SELECTED THE SEAT SETTING IT SAID IT WAS SET. WHEN I WENT TO DRIVE THE VEHICLE AGAIN I SELECTED SEAT ONE AND IT HAD THE ERROR MESSAGES AS IN THE PICTURES.

ENGINE CRADLE SEVERELY RUSTED AND PERFORATED, CAUSING FRONT WHEEL ALIGNMENT PROBLEMS. A REPLACEMENT CRADLE IS NEEDED AS ENGINE MAY DROP..

Mileage: 68,285

I HAVE A 2004 PACIFICA TOURING EDITION...PASSENGER SIDE LOWER CONTROL, HUB, SWAY BAR ROTTED OUT. WENT TO PICK UP PARTS AND EVERY CAR I CAME ACROSS HAD THE SAME ISSUE IN THE SAME PLACE. HOW CAN FIVE DIFFERENT CARS DRIVEN BY FIVE DIFFERENT PEOPLE HAVE THE SAME PROBLEM.....TWO WORDS...CRAPPY MATERIALS. CHRYSLER SHOULD PROCEED WITH A RECALL ON THE LOWER PASSENGER SIDE CONTROL ARM FOR THESE VEHICLES, THEY ARE ROLLING DEATH TRAPS.

Mileage: 173,000

WAS DRIVING DOWN THE STREET AND HEARD A LOAD BANG WHEN DRIVERS SIDE OF CAR DROPPED DOWN ONTO FRONT TIRE. CAR ABRUPTLY SWERVED INTO LANE WITH APPROACHING TRAFFIC. VEHICLE STOPPED AGAINST THE CURB AND ONCOMING TRAFFIC STOPPED IN TIME. WE TOWED VEHICLE TO A FRIENDS BUSINESS FOR INSPECTING AND IT WAS DISCOVERED THE ENGINE CRADLE HAD ROTTED OUT FROM RUST. WE CALLED LOCAL DEALER AND WAS ASKED FOR OUR V.I.N # AND WAS TOLD OUR CAR WAS NOT PART OF RECALL BECAUSE IT WAS NOT BUILT WITHIN A FEW WEEKS WINDOW. IN SEARCHING MORE INFORMATION ONLINE WE FOUND THIS IS A HUGE ISSUE ON THESE CARS. PLEASE ADVISE

Mileage: 98,973

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING AT 40 MPH, THE TIRES SQUEALED AND THE VEHICLE VEERED TO THE RIGHT. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE WHEEL LEANED INWARDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE ENGINE CRADLE WAS CORRODED AND FRACTURED. THE TECHNICIAN DIAGNOSED THAT THE STRUT, STRUT MOUNT, TIE ROD, AND ENGINE CRADLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

Mileage: 130,000

TECHNICIAN FOUND PERFORATION ON THE FRONT SUBFRAME/CRADLE AREA ESTIMATED COST TO REPLACE $ 2,566.62.

Mileage: 118,779

MY WIFE WAS PULLING AWAY FROM A TRAFFIC LIGHT AND THE STEERING LOCKED UP. SHE WAS ABLE TO STOP BEFORE CRASHING. WHAT I FOUND WAS VERY DISTURBING. THE REAR ENGINE CRADLE MOUNTS HAD SEPARATED. CAUSING THE ENGINE CRADLE TO CONTACT THE GROUND ON ACCELERATION ALSO THE STEERING TRACK WHICH IS ATTACHED TO THIS CRADLE BECAME NON-FUNCTIONAL. THE CENTER RIPPED OUT OF BOTH REAR MOUNTS AND THERE IS NO MECHANICAL STOP TO PREVENT THE CRADLE FROM SEPARATING FROM THE BODY OF THE CAR WITH AMOUNT FAILURE. THIS CRADLE HAD BEEN REPLACED UNDER AA WARRANTY 14 MONTHS AND 11,000 MI.EARLIER. I HAD THE VEHICLE TAKEN TO A CHRYSLER DEALERSHIP, THEY INFORMED ME THAT THE FRONT CRADLE MOUNTS WERE ALSO SEPARATED AND THEY COULD NOT PUT THE CAR ON THE LIFT TO PICK IT UP DUE SAFETY REASONS AND THE ENGINE CRADLE WOULD COME OUT FROM UNDER THE CAR. I CONTACTED CHRYSLER CUSTOMER SERVICE AND AFTER ABOUT A WEEK THEY INFORMED ME THAT THEY WOULD WARRANTY THE MOUNTS AND NO LABOR AND ONLY IF THE REPAIRS ARE DONE AT THE DEALER. THE COST OF THE PARTS IS MINIMAL IN COMPARISON TO THE TOTAL COST OF THE REPAIR AND WHAT COULD VERY EASILY HAVE HAPPENED IF THE MOUNTS HAD FAILED IN A DIFFERENT SITUATION AT A MUCH HIGHER SPEED AND NOT ON A CITY STREET. *TR

Mileage: 105,000

MY STEERING WHEEL STARTED TO JERK TO THE RIGHT WHEN ACCELERATING AND IT WAS HARD TO KEEP THE CAR ON THE ROAD. IT FELT LIKE THE FRONT WHEELS WERE GOING TO FALL OFF. I TOOK THE CAR TO THE SHOP AND THEY INFORMED ME THAT THE SUB STRUCTURE CRADLE WAS RUSTED THROUGH AND HAD FAILED. THIS ALSO TOOK OUT THE TRANSMISSION MOUNT AND IDLER ARM. HAD I BEEN GOING ANY FASTER WHEN THIS FAILED IT MAY HAVE CAUSED THE CAR TO SWERVE INTO ON COMING TRAFFIC. *TR

Mileage: 140,000

THERE ARE MULTIPLE OCCURRENCE BUT THE START OF THE PROBLEM WAS 1 WEEK AFTER I PURCHASED THE CAR. 5/6/14 I REPLACED THE TIRES LEFT FRONT AXLE ALONG WITH THE FRONT STRUTS AND STRUT MOUNTS, CHECK ENGINE LIGHT ON CAME OUT FOR EMISSIONS SYSTEM SMALL LEAK CHANGED THE GAS CAP. FINE TILL JUNE THEN I HAD TO REPLACE EVERYTHING OVER AGAIN CHECK ENGINE LIGHT ON AGAIN SAME CODE P0455 CHANGED PURGE SOLENOID, ALONG WITH THE RIGHT AXLE. FINE AGAIN TILL AUGUST BY THIS TIME CHECK ENGINE LIGHT IS BACK ON NOW CHANGED THE NVLD PUMP PLUS REPLACED EVERYTHING OVER AGAIN STRUTS, STRUT MOUNTS, ALONG WITH THE RACK N PINION, FRONT LOWER CONTROL ARMS BOTH SIDES, OUTTER TIE RODS. ONCE AGAIN FINE THEN OCTOBER ROLLS AROUND I TAKE IT BACK IN BECAUSE IT ACTING WEIRD STEERING WISE PLUS THE CHECK ENGINE LIGHT IS ON AGAIN SAME CODE P0455 NOW I CHANGE OUT THE CANISTER, ALONG WITH EVERYTHING OVER AGAIN BUT THE AXLES THEY ARE STILL GOOD. NOW NOVEMBER ROLLS AROUND AND EVERYTHING IS AT IT AGAIN CHECK ENGINE LIGHT IS ON P0455 THEY WANT TO REPLACE THE FUEL LINES NOW. ALSO THE 4 MOTOR MOUNTS ARE BROKE AGAIN MY ENGINE IS ALMOST READY TO FALL OUT. NOW THEY ARE FINALLY TELLING ME AFTER $3400.00 THAT THIS IS ALL CAUSED BY THE RUST AND CORROSION ON THE UNDERCARRIAGE. MY SUBFRAME AND FRAME HAVE HOLES IN IT, THE RUST IS ACTUALLY MAKING IT'S WAS INSIDE MY CAR NOW. I WENT TO FIX A FLAT TIRE AND WHEN I USED THE EMERGENCY JACK I PUMPED IT 1/4 OF THE WAY UP AND BOOM IT WENT RIGHT THRU THE FRAME. MY ALIGNMENT KEEPS THROWING IT SELF OFF BECAUSE IT CAN'T HOLD THE FRONT SUSPENSION IN PLACE. THE STRUT MOUNT HOUSING LOOKS LIKE ANOTHER FEW BUMPS AND IT WILL GO THREW. ACCIDENT: 1ST WK NOV '14 I WAS DRIVING DOWN THE FREE-WAY LUCKILY DOING 45MPH AND I WENT TO STEER MY CAR TO THE RIGHT AND IT KEPT GOING STRAIGHT AND SCRAPED THE K-RAIL. MECHANIC SAID THE THE BOLTS HE PUT BACK INTO THE SUB-FRAME KEEP FALLING OUT BECAUSE OF THE RUST. *JS

Mileage: 128,813

DEALING WITH A ROTTED K-FRAME CROSSMEMBER FOR THE FRONT ENGINE CRADLE; HAS CAUSED THE WHOLE SUSPENSION TO FAIL, EFFECTING STEERING COMPONENTS, AS WELL AS, WEARING OUT OTHER PARTS SUCH AS, ENGINE MOUNTS AND FRONT END BUSHINGS ON A CAR WITH LESS THAN 100,000 MILES ON IT. *TR

I WAS DRIVING TODAY AND IT SEEMED THAT MY STEERING WAS EXTREMELY HARD TO TURN IF I WAS MASHING THE GAS, HARDER TO TURN TO THE RIGHT SIDE OF THE CAR. IF THE CAR IS COASTING OR I AM BREAKING THE STEERING IS EASIER TO CONTROL. I HAVE STOPPED AT MY PARENTS HOUSE ON THE WAY HOME TO RESEARCH WHAT COULD BE HAPPENING WITH MY CAR AND FOUND THIS DISTURBING NEWS. UNFORTUNATELY FOR ME, THIS IS MY ONLY SOURCE OF TRANSPORTATION AND I DON'T HAVE THE FINANCES TO JUST GET ANOTHER CAR...I'M SO FRUSTRATED RIGHT NOW AND I DON'T KNOW WHAT TO DO... THE CONSUMER STATED WHILE DRIVING, SHE HAD DIFFICULTY STEERING THE VEHICLE. SHE NOTICED WHEN ACCELERATING, THE VEHICLE WAS HARD TO STEER, BUT WHEN BRAKING OR ALLOWING THE VEHICLE TO COAST IT WAS A LITTLE EASIER TO CONTROL. SHE MANAGED TO GET THE VEHICLE OFF THE ROAD. SHE DISCOVERED A PORTION OF THE SUPPORT FRAME DROPPED FROM THE VEHICLE, AND IT APPEARED THE ENGINE CRADLE WAS CORRODED WITH RUST. UPDATED 12/04/14

Mileage: 197,659

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED THAT THE STEERING WHEEL LOCKED SEVERAL TIMES WHILE DRIVING VARIOUS SPEEDS. A LOCAL MECHANIC STATED THAT THE SUBFRAME AND ENGINE CRADLE WERE CORRODED, FRACTURED, AND CONTAINED HOLES. THE VEHICLE WAS DEEMED AS UNSAFE TO DRIVE. THE MANUFACTURER STATED THAT THE ENGINE CRADLE REPLACEMENT WARRANTY HAD EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

Mileage: 110,000

IN JANUARY, THE SUSPENSION ON OUR 2004 CHRYSLER PACIFICA (PURCHASED 08/2003), SEEMED TO HAVE ISSUES. A WEB SEARCH TO INVESTIGATE, LED ME TO A MUCH MORE SERIOUS ISSUE THAT EFFECTS '04 AND '05 PACIFICAS. I HAD OUR MECHANIC INSPECT THE FRAME AND SURE ENOUGH, WE WERE ONE OF THE MANY AFFECTED. OUR MECHANIC TOLD US THE CAR WAS NO LONGER SAFE TO DRIVE, AND THAT THE COMPROMISED FRAME CAUSED THE FRONT RIGHT WHEEL TO SHIFT INWARDS. WE WERE QUOTED BETWEEN 4,000 AND 5,000 DOLLARS FOR OUR REPAIRS. THE CAR NOW SITS IN THE GARAGE AS WE HOPE FOR A RESOLUTION. AFTER IN DEPTH RESEARCH, I UNCOVERED THOUSANDS OF COMPLAINTS RELATED TO THE ISSUE, TWO NBC NEWS SEGMENTS, AND A PETITION. I ALSO DISCOVER THAT A FEW YEARS BACK, CHRYSLER EXTENDED THE WARRANTY FOR VEHICLES PRODUCED BETWEEN FEBRUARY AND MARCH OF 2004. HOWEVER, SINCE OUR VEHICLE DID NOT FALL UNDER THIS PROVISION, WE WERE NEVER INFORMED THAT WE MAY HAVE BEEN EFFECTED. I CONTACTED CHRYSLER AND OPENED A CASE. I WAS INSTRUCTED TO WRITE AN EMAIL TO THE CASE MANAGER THAT CONTAINED ALL OF THE INFORMATION WHICH I UNCOVERED ONLINE (AS IF THEY DIDN'T ALREADY KNOW THE ISSUE EXISTED). THIS PROVED TO BE A WASTE OF TIME, AS WE WERE DECLINED ANY ASSISTANCE BECAUSE OUR VEHICLE DID NOT FALL WITHIN THE EXTEND WARRANTY. WE HAVE BEEN THE ONLY OWNERS OF OUR VEHICLE, WHICH HAS 68,000 MILES, HAS BEEN GARAGE KEPT, AND HAS BEEN DRIVEN ONLY BY MY 85 YEAR OLD GRANDPARENTS. APPARENTLY, CHRYSLER HAS MADE A BUSINESS DECISION NOT TO ADDRESS THIS WIDE SPREAD ISSUE. THERE ARE THOUSANDS OF OWNERS DRIVING UNSAFE VEHICLES, MANY OF WHICH ARE COMPLETELY UNAWARE THAT THIS ISSUE EXISTS. US, AS WELL AS ALL OTHER PARTIES EFFECTED ARE DUE APPROPRIATE RECOURSE, BUT I FEAR THAT WE WILL HAVE TO CUT TIES WITH OUR VEHICLE BEFORE THERE IS A RESOLUTION. *TR

Mileage: 68,000

OUT OF NO WHERE LAST NIGHT I WENT OVER 45MPH AND MY CAR GAVE OUT ALL CONTROL OF THE STEERING WHEEL. IT WORKS FINE UNLESS I GO OVER 45MPH IT STALLS OUT. *TR

Mileage: 133,000

WAS DRIVING DOWN HIGHWAY AT 55MPH, WITH MY NIECE IN THE CAR WITH ME WHEN THE CAR STARTED TO PULL TO DRIVERS SIDE THE PULLED TO PASSENGER SIDE. I SLOWED THE VEHICLE DOWN TO UNDER 40 IT WAS STILL TRYING SWERVE AND PULL. SCARED ME AND MY NIECE. HAS BEEN CLUNKING SINCE ABOUT SIX MONTHS AFTER I BOUGHT THE VEHICLE IN 2008.. SPENT OVER A GRAND ON NEW TIE RODS, SUSPENSIONS, WHEN I TOOK IT TO DIFFERENT DEALER FOR CHRYSLER VEHICLES WHERE A TECHNICIAN TOLD ME TO STOP WASTING MY MONEY, THEY KNOW THERE IS CLUNK AND DONT KNOW HOW TO FIX IT. I EMAILED AND LEFT MESSAGE FOR CHRYSLER WITH NO RESPINSE. LOOKS LIKE THEY KNOW HOW TO FIX IT BUT CHRYSLER WONT STAND BEHIND THEIR PRODUCT AND FIX THE PROBLEM TILL SOMEONE DIES AND THE FAMILIES OF THE DECEASED HAVE TO SUE THE COMPANY, SERIOUSLY! STAND BEHIND YOUR PRODUCT, I DONT THINK I WILL EVER PURCHASE A CHRYSLER VEHICLE AGAIN AND WILL INFORM ALL FRIENDS AND FAMILY TODO THE SAME. *TR

Mileage: 196,000

MY CHRYSLER PACIFICA"S ENGINE CRADLE HAS EXTENSIVELY CORRODED WITH RUST AND HAS BECOME A DANGER TO DRIVE .THIS WAS A NATIONAL PROBLEM REPORTED ON CHICAGO TELEVISION NBC CHANNEL 5. CHRYSLER CLAIMS THAT THEY ARE INVESTIGATING..I WOULD APPRECIATE IF SOMEONE FROM YOUR ORGANIZATION CAN LOOK AT THIS CRADLE AND THE DANGER MY FAMILY HAS BEEN PUT IN. CHRYSLER ALSO CLAIMS THAT MY CAR WAS BUILT PRIOR TO THE PROBLEM METAL ON 2004/2005 . NEED FOR SOMEONE TO INSPECT THANK YOU *TR

THE ENGINE CRADLE CROSS MEMBER OF MY VEHICLE HAS ROTTED TO THE POINT THAT THE CAR IS UNSAFE TO DRIVE. THERE IS A SERVICE NOTE FOR A SMALL WINDOW OF PACIFICAS INCLUDED ON A WARRANTY FOR THE SAME PROBLEM, BUT ONLY FOR THE CARS BUILT WITHIN A CERTAIN DATE. CHRYSLER IS AWARE OF THE PROBLEM, BUT WILL DO NOTHING TO CORRECT IT. THE CRADLE INCORPORATES THE ENGINE MOUNTS, LOWER CONTROL ARMS, AND STEERING. IF IT IS NOT REPLACED, AND BREAKS WHILE DRIVING, THERE WILL BE A COMPLETE LOSS OF CONTROL OF THE VEHICLE. I KNOW THAT MY VEHICLE IS NOT THE ONLY ONE WITH SUCH A SERIOUS ISSUE. *TR

Mileage: 64,000

THE ENGINE CRADLE CROSS MEMBER OF MY VEHICLE IS ROTTING TO THE POINT THAT I CAN NO LONGER HAVE THE CAR SAFETY INSPECTED IN PA. THERE IS A SERVICE NOTE FOR A SMALL WINDOW OF PACIFICAS INCLUDED ON A WARRANTY FOR THE SAME PROBLEM, BUT ONLY FOR THE CARS BUILT WITHIN A CERTAIN DATE. CHRYSLER IS AWARE OF THE PROBLEM, BUT WILL DO NOTHING TO CORRECT IT. THE CRADLE INCORPORATES THE ENGINE MOUNTS, LOWER CONTROL ARMS, AND STEERING. IF IT IS NOT REPLACED, AND BRAKES WHILE DRIVING, THERE WILL BE A COMPLETE LOSS OF CONTROL OF THE VEHICLE. I KNOW THAT MY VEHICLE IS NOT THE ONLY ONE WITH SUCH A SERIOUS ISSUE. *TR

Mileage: 42,000

I NOTICED SOME DIFFICULTY WITH STEERING. I PURCHASED AND USED SOME POWER STEERING FLUID. THIS DID NOT MAKE A DIFFERENCE. I WAS DRIVING ON MY OWN STREET WHEN THE STEERING COMPLETELY STOPPED WORKING. I WAS ABLE TO GET THE CAR INTO MY YARD. WHEN I HAD THE CAR LOOKED AT I WAS INFORMED THAT THE CRADLE THAT HOLDS THE ENGINE WAS COMPLETELY RUSTED AND THE ENGINE IS FALLING AND THAT IS WHAT DAMAGED THE STEERING. I HAVE BEEN INFORMED THAT THIS WILL COST MORE THAN 3000 TO REPAIR. *TR

WHILE HAVING MY VEHICLE CHECKED FOR A POWER STEERING LEAK AT AN INDEPENDENT MECHANIC, I RECEIVED CALL FROM MECHANIC THAT IF THERE WAS ANY WAY POSSIBLE THAT I CAN COME DOWN TO THE SERVICE STATION BECAUSE THE PROBLEM WAS BIGGER THAN THE LEAK. ONCE THERE HE SHOWED ME THE SERIOUS RUST THROUGH ON SUB FRAME RAILS AND ENGINE CRADLE WITH NOTICEABLE CRACKS GOING UPWARD ON SUB FRAME. HE STATED THAT THE CAUSE TO MY POWER STEERING LEAK IS DUE TO THIS SUB FRAME BEING IN THE CONDITION IT IS AND IT'S VIBRATION. HE SUGGESTED THAT I CONTACT CHRYSLER FOR A RECALL BECAUSE HE KNOWS OF THE SAME PROBLEM ON HONDA'S & TOYOTA'S THAT WERE ALREADY RECALLED. AFTER READING THE FORUMS AND SEARCHING FOR A RECALL THERE IS AN EXTENDED WARRANTY BUT UNFORTUNATELY I FALL UNDER THE STATE OF NJ WERE THIS STATE IS NOT ELIGIBLE FOR THE EXTENDED WARRANTY. THIS IS OUTRAGEOUS AND A SAFETY RECALL SHOULD BE ISSUED RIGHT AWAY. WITH SO MANY COMPLAINTS I WILL MOVE FORWARD AND START A CLASS ACTION LAW SUIT FOR NOT ISSUING A FULL SCALE RECALL TO ALL 2004 PACIFICA OWNERS IN EVERY STATE. THEY CLEARLY RECOGNIZE THE DANGER IN THEIR FAULTY DESIGN AND MANUFACTURING YET STILL REFUSE TO ISSUE A SAFETY RECALL BY ONLY PROVIDING AN EXTENDED WARRANTY TO SOME PACIFICA OWNERS. THIS IS A SERIOUS DANGER TO MY FAMILY AND A FATALITY WAITING TO HAPPEN. *TR

Mileage: 133,711

THE FRONT WHEEL STUDS ARE BREAKING OFF THE VEHICLE AND THIS IS THE SECOND TIME THIS HAS HAPPENED IN THE LAST 3 MONTHS BOTH TIME THERE HAS BEEN BRAND NEW STUDS AND BOLTS PUT ON. IT HAS CAUSED THE WHEEL TO FALL OFF THE VEHICLE AND CAUSE OTHER DAMAGES TO THE FENDER. *JS

SUB FRAME RUSTED OUT

Mileage: 84,872

I BOUGHT THIS 2004 PACIFICA FROM A DEALER ABOUT A MONTH AGO. TOOK IT TO THE SHOP TO GET MY SHOCKS LOOKED AT AND THEY TOLD ME THEY WOULDN'T DO ANY WORK ON IT BECAUSE THE SUB FRAME WAS ROTTED SO BADLY THEY ADVISED ME NOT TO DRIVE OR PUT ANY MONEY INTO THE VEHICLE BECAUSE IT IS A SAFETY ISSUE. ALSO THERE IS CLICKING COMING FROM THE STEERING WHEEL WHEN YOU TURN LEFT OR RIGHT. AND ALSO A WEEK AFTER I PURCHASED THE VEHICLE THE BLOWER MOTOR RESISTER IS BAD. *TR

Mileage: 82,000

DRIVING AROUND 40 THE VEHICLE STARTED TO SHAKE. I THOUGHT MAYBE A WHEEL BEARING OR TIE ROD WAS THE ISSUE. UPON TAKING IT TO THE SHOP TO GET CHECKED I WAS TOLD THAT THE ENGINE CRADLE WAS RUSTED TO THE POINT OF ALMOST FAILING. I AM CURRENTLY HAVING THE CRADLE REPLACED. HAD THAT OCCURRED AT A HIGHER SPEED I HAT TO THINK WHAT MAY HAVE HAPPENED. I CALLED CHRYSLER AND WAS TOLD THERE IS A REPLACEMENT PROGRAM FOR VEHICLES BUILT BETWEEN FEB 23RD AND MAR31ST 2004. BECAUSE MY VEHICLE WAS BUILT JANUARY 23RD 2004 IT WAS NOT COVERED AND I RECEIVED NO LETTER. DESPITE THE FACT I WAS DRIVING A VEHICLE WITH THE SAME PROBLEM IN A VERY DANGEROUS STATE. THERE SHOULD BE A NATIONWIDE SAFETY RECALL. *TR

Mileage: 110,000

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT NOTICED A RATTLING NOISE FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE INNER TIE ROD AND SWAY BAR LINKS FOR THE FRONT SUSPENSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 96,000.

Mileage: 96,000

SUB FRAME COMPLETELY RUSTED APART, RESULTING IN DANGEROUS FRONT END CONDITIONS AND EXPENSIVE REPAIR. FOUND SIMILAR ISSUES FOR OTHER PACIFICA OWNERS THROUGH RESEARCH AND BELIEVE THIS IS A DEFECTIVE PART AND SHOULD BE COVERED AND RECALLED BEFORE SOMEONE GETS HURT OR KILLED. *TR

Mileage: 124,000

I PURCHASED THIS VEHICLE USED WITH VERY LOW MILEAGE. IT IS IN GREAT CONDITION UNTIL I STARTED HEARING A NOISE IN THE FRONT END. I TOOK INTO THE GARAGE TO HAVE NEW TIRES AND BRAKES PUT ON IT. WHEN THE MECHANIC PUT IT ON THE RACK, HE SAID THAT THE FRAME WAS RUSTED THROUGH. SO, INSTEAD OF NEW TIRES AND BRAKES I NOW NEED A NEW FRAME. I AM JUST THANKFUL THAT I WAS NOT DRIVING WHILE THIS HAPPEN. I WAS WONDERING IF THIS PROBLEM AS AFFECTED OTHER OWNERS ALSO. *TR

Mileage: 80,000

2004 CHRYSLER PACIFICA TAKEN TO MECHANIC AFTER PURCHASING USED WITH 69,500 MILES FOR "CLUNKING" NOISE IN FRONT-END. REPLACED PARTS INCLUDED: SWAY BAR LINKAGES, TIE ROD ENDS, AND STRUTS AND MOUNTS ALL OF WHICH NEEDED REPLACING. BUT THE NOISE WAS STILL THERE. THE MECHANIC THEN USED A TOOL HE CALLED "CHASSIS EARS" TO PINPOINT THE SOURCE OF THE NOISE. HE FOUND THAT THE SUBFRAME (ENGINE CRADLE) WAS RUSTED AT THE POINT THAT IT MOUNTS TO THE BODY, JUST UNDER THE FRONT PASSENGER-SIDE FLOORBOARD. UPON FURTHER INSPECTION RUST WAS APPARENT ON THE DRIVERS-SIDE ALSO. THIS IS A MAJOR SAFETY ISSUE!!! THE ENTIRE FRONT-END OF THE VEHICLE INCLUDING: ENGINE, TRANSMISSION, AND ALL FRONT-END SUSPENSION AND STEERING IS HELD IN PLACE BY THIS SUBFRAME (ENGINE CRADLE). WHAT HAPPENS WHEN THIS TOTALLY FAILS WHILE DRIVING WITH SIX PEOPLE IN THE VEHICLE? WHY HAS THIS NOT BECOME A MANDATORY SAFETY RECALL? DOES SOMEONE HAVE TO GET KILLED BEFORE THIS GETS SOMEONES ATTENTION? THIS IS NOT AN ISOLATED INCIDENT AS CAN BE SEEN BY THIS WEBSITE. NHTSA PLEASE HELP!!! *TR

Mileage: 70,100

I OWN A CHRYSLER PACIFICA 2004 AWD. THE VEHICLE HAS HAD NUMEROUS SUSPENSION PROBLEMS, SUCH AS A CLICKING SOUND AND AN UNSTABLE VEHICLE. I BELIEVE IT MIGHT BE THE FRONT CRADLE OF THE VEHICLE BUT AM NOT SURE IF THIS IS THE EXACT CAUSE. ALSO, WHEN I BRAKE, THE CAR MAKES A HUGE THUD SOUND. I REPLACED THE BRAKES AND ROTORS AS THE DEALER HAS DONE BUT THE NOISE IS STILL THERE. PLEASE INVESTIGATE THIS MATTER AS MANY OTHER PACIFICA OWNERS HAVE ENCOUNTERED THIS. THANK YOU SO MUCH. *TR

Mileage: 50,000

TL* THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT STATED WAS DRIVING 35 MPH WHEN THE STEERING FAILED, MAKING IT VERY DIFFICULT FOR THE CONTACT TO CONTROL THE STEERING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE IT WAS DIAGNOSED. THE TECHNICIAN ADVISED THE CONTACT THAT THE ENGINE CRADLE WAS RUSTED AND FRACTURING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 83,000.

Mileage: 83,000

AFTER TURNING RIGHT AT STOP LIGHT AND PROCEEDING SLOWLY WITH ACCELERATION, A LOUD/SHAKING NOISE WAS HEARD FROM 2004 CHRYSLER PACIFICA (SIMILAR TO A CELL PHONE PLACED ON VIBRATE INSTEAD OF RINGING WHEN A CALL IS RECEIVED). WITHIN SECONDS, VEHICLE UNINTENTIONALLY ACCELERATED AND I WAS UNABLE TO STOP IT, EVEN AFTER PRESSING ON BRAKES. I WAS A BLOCK AWAY FROM WHERE I HAD TO TURN TO ENTER OUR SUBDIVISION, TRAVELING DOWN A TWO-LANE ROAD. THANKFULLY, NO CARS WERE TRAVELING IN OPPOSITE DIRECTION, OR COMING OUT OF OUR SUBDIVISION, SO I WAS ABLE TO TURN LEFT TO ENTER OUR SUBDIVISION. TO TRY TO SLOW CAR DOWN, I HAD TO PRESS DOWN ON BRAKES AS HARD AS I COULD WHILE TURNING THE WHEEL, WHICH CAUSED THE VEHICLE TO SWERVE, ALMOST HITTING A LIGHT POLE. AFTER TURNING AND STOPPING THE SWERVE, THE VEHICLE ACCELERATED EVEN FURTHER, REACHING THE '4' ON THE TACHOMETER (BEFORE THE TURN, IT HAD BEEN AT A '3'). AS I APPROACHED THE FOUR-WAY STOP IN OUR SUBDIVISION, I AGAIN STEPPED ON THE BRAKES AS HARD AS I COULD, BUT IT HAD NO EFFECT. THE TACHOMETER READ '4', BUT THE SPEEDOMETER SHOWED 30 MPH, REGARDLESS OF HOW HARD I PRESSED ON BRAKES. I COULD NOT BRAKE AT ALL, AND WAS LOSING THE ABILITY TO STEER AS I APPROACHED THE SIGN. THE ONLY WAY TO STOP THE VEHICLE WAS TO PLACE IT IN 'PARK'(WHICH MADE THE TACHOMETER GO EVEN HIGHER) AND REMOVE THE KEYS TO TURN OFF THE CAR AS QUICKLY AS I COULD. THIS STOPPED THE CAR RIGHT IN FRONT OF THE STOP SIGN. I WAITED ABOUT 30 SECONDS AND ATTEMPTED TO RESTART CAR, BUT AFTER IGNITION KEY WAS TURNED, TACHOMETER REVVED UP AGAIN TO '4', THOUGH SPEEDOMETER READ '0'. HUSBAND MANEUVERED CAR THE ONE BLOCK HOME BY PLACING IT IN 'NEUTRAL'. THIS IS THE FIRST INCIDENT OF THIS NATURE. CHRYSLER TO BE NOTIFIED IN MORNING, AS I CALLED AFTER BUSINESS HOURS (7:41 PM CST). MYSELF, TWO KIDS, AND TWO DOGS WERE IN THE CAR DRIVING DOWN WHAT IS NORMALLY A BUSY TWO-LANE ROAD AND INTO SUBDIVISION FULL OF PLAYING CHILDREN, TRULY A MIRACLE NO ONE WAS INJURED. *TR

Mileage: 95,000

2004 CHRYSLER PACIFICA. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE RELATED TO THE ENGINE, AIR CONDITIONER BLOWER AND ALTERNATOR *TGW THE CONSUMER STATED WHEN THE VEHICLE WAS FIRST PURCHASED, THE AIR CONDITIONER BLOWER WAS NOT WORKING PROPERLY AND HAD TO BE REPLACED. LATER THAT YEAR, THERE WAS A WHINING SOUND COMING FROM THE FRONT OF THE VEHICLE NEAR THE ENGINE, HOWEVER THE DEALER WAS UNABLE TO FIND THE SOURCE AND TO THIS DAY, THE NOISE IS STILL PRESENT. THE CONSUMER STATED THERE WAS A WHINING SOUND COMING FROM OR NEAR THE POWER STEERING PUMP WHICH WAS EVENTUALLY REPLACED, HOWEVER THE NOISE CONTINUED. THE MOTOR MOUNTS, TIE RODS AND ROCKER ARMS WERE REPLACED. *JB

2004 CHRYSLER PACIFICA. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE RELATED TO THE ENGINE, AIR CONDITIONER BLOWER AND ALTERNATOR *TGW THE CONSUMER STATED WHEN THE VEHICLE WAS FIRST PURCHASED, THE AIR CONDITIONER BLOWER WAS NOT WORKING PROPERLY AND HAD TO BE REPLACED. LATER THAT YEAR, THERE WAS A WHINING SOUND COMING FROM THE FRONT OF THE VEHICLE NEAR THE ENGINE, HOWEVER THE DEALER WAS UNABLE TO FIND THE SOURCE AND TO THIS DAY, THE NOISE IS STILL PRESENT. THE CONSUMER STATED THERE WAS A WHINING SOUND COMING FROM OR NEAR THE POWER STEERING PUMP WHICH WAS EVENTUALLY REPLACED, HOWEVER THE NOISE CONTINUED. THE MOTOR MOUNTS, TIE RODS AND ROCKER ARMS WERE REPLACED. *JB

I HAD A BAD VIBRATION IN THE FRONT . SO I TOOK IT TO THE DEALER SINCE I HAD A FACTORY EXTENDED WARRANTY BUMPER TO BUMPER., THEY SAID THE CAR NEEDED TIRES. SO I CHANGED THE TIRE IT STILL VIBRATED. GO BACK NOW IT IS THE RACK & PINION BUSHINGS ARE BAD . BUT I NEED TO REPLACE THE K FRAME BECAUSE A WELD IS BROKEN. THEY SAY I BROKE IT CAUSE THERE ARE SCRATCHES ON IT. {NOT THAT VIBRATION DID IT} SO I PAID TO HAVE A NEW ONE PUT IN . 8 MONTHS LATER THE MOTOR MOUNTS BREAK AND THE ENGINE DROPS 2" FROM THE GROUND . THANK GOD MY FAMILY WAS NOT DRIVING DOWN A HIGHWAY. SO I TAKE IT BACK AND THEY SAY BECAUSE THERE IS SCRATCHES ON IT AGAIN THAT BROKE THE BUSHINGS .ONCE AGAIN I ENDED UP PAYING TO HAVE IT FIXED. *TR

Mileage: 55,000

TL*THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT TOOK HER VEHICLE TO THE DEALER BECAUSE THE STEERING WHEEL SHAKES WHILE DRIVING 65 MPH. IN ADDITION, A NAIL WAS FOUND IN THE TIRE. THE DEALER STATED THAT INNER TIE RODS AND TIRE BALANCING WERE NEEDED. THEY FURTHER STATED THAT THE ENGINE CRADLE WAS CORRODED. THE DEALER TOOK PICTURES TO SEND TO THE MANUFACTURER SO THEY COULD BE ADVISED ON HOW TO PROCEED. THE CONTACT IS CURRENTLY WAITING ON A RETURN PHONE CALL FROM THE MANUFACTURER. THE FAILURE MILEAGE WAS 62,000.

Mileage: 62,000

TL*THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. THE CONTACT HAS BEEN TAKING HIS VEHICLE TO THE DEALER FOR AN OIL CHANGE AND SERVICE EVER SINCE IT WAS PURCHASED. THE DEALER STATED THAT THE FRAME OF HIS VEHICLE WAS RUSTED THROUGH AND FAILED. THE VEHICLE WAS UNABLE TO BE DRIVEN AND THE CONTACT MUST PAY FOR THE REPAIR COSTS. THE DEALER NEVER WARNED HIM OF ANY FAILURES. THE MANUFACTURER STATED THAT THEY COULD NOT ASSIST. THE VEHICLE IS STILL AT THE DEALER AWAITING REPAIR. THE FAILURE MILEAGE WAS 71,000. UPDATED 02/06/09 *BF THE VEHICLE PULLED TO THE LEFT. THE DEALER PERFORMED AN ALIGNMENT AND REPLACED THE TIE ROD ENDS. UPDATED 02/06/09. *JB

Mileage: 71,000

2004 CHRYLSER PACIFICA ENGINE CRADLE RUSTED OUT, TIE ROD REPLACED ABOUT ONE YR AGO. DEALER WON'T COVER COST D/T WARRANTY EXPIRED. 53,000 MILES ON CAR. MAJOR SAFETY ISSUE D/T ENGINE/TRANS COULD FALL OUT WHILE DRIVING. INSTRUCTED ONLY TO DRIVE CAR IF NECESSARY. AVOID BUMPS! HAVE FOUND MULTIPLE C/O ON INTERNET ON SAME MATTER. I SHOULD NOT HAVE TO PAY FOR POOR QUALITY OF METAL USED ON FRAME WORK. *TR

Mileage: 52,000

TL*THE CONTACT OWNS A 2004 CHRYSLER PACIFICA. WHILE DRIVING 20 MPH, THE VEHICLE BEGAN TO SHAKE AND MADE A THUMPING SOUND. THE VEHICLE ALSO TENDS TO PULL TO THE RIGHT. THE VEHICLE WAS DIAGNOSED BY THE DEALER, BUT THE FAILURE CONTINUES. THE CURRENT MILEAGE WAS 51,200 AND FAILURE MILEAGE WAS 6,000. UPDATED 6/16/08 *CN THE LEFT REAR SEATBELT WOULD NOT RETRACT, THE OUTER TIE ROD ENDS, THE BLOWER MOTOR AND RESISTOR WERE REPLACED BECAUSE THE VEHICLE DIDN'T HAVE ANY HEAT, THE BATTERY WAS STALLING. THE HEATED SEAT WERE NOT WORKING. UPDATED 06/16/08*JB

Mileage: 6,000

VEHICLE WAS IN FATAL ACCIDENT . DRIVER COMPLAINED OF HEARING CLICKING NOISES DAYS BEFORE ACCIDENT. TOOK VEHICLE TO BE SERVICED AT THE PLACE WHERE VEHICLE WAS PURCHASED. THE VEHICLE CHECKED OUT FINE. DRIVER FELT STEERING WHEEL LOCK AND WAS UNABLE TO STEER WHILE DRIVING ON INTERSTATE HE SAYS COULD NOT STEER VEHICLE AT ALL VEHICLE UNCONTROLLABLY FLIPPED 6 TIMES . NO AIR BAGS DEPLOYED . *TR

CAR FIGHTS STEERING. *TR

Mileage: 37,450

HAD TO HAVE MY 2004 PACIFICA STATE INSPECTION DONE, IT FAILED INSPECTION FOR THE FRONT RIGHT TIE ROD. THE MECHANIC SHOWED ME THAT IT WAS COMPLETELY WOREN OUT AND THE WHOLE WHEEL SHOOK BACK AND FORTH. THIS PUT MY CHILDREN IN DANGER EVERYDAY. THERE IS NO REASON FOR THIS TO HAVE WORN OUT.*AK

Mileage: 36,256

RIGHT FRONT INNER TIE ROD END WAS FOUND TO HAVE TOO MUCH PLAY TO DO AN ALIGNMENT AFTER REPLACEMENT OF TIRES. NO PARTS AVAILABLE. QUOTED $1500 FOR SERVICE BY CHRYSLER. VEHICLE HAS 53,000 MILES- NO WAY MAJOR SUSPENSION COMPONENTS SHOULD BE IN NEED OF REPLACEMENT. TIE ROD END NOT REPLACEABLE BY ITSELF- ENTIRE STEERING ARM, TIE ROD ENDS AND STEERING BOX MUST BE REPLACED AT A PARTS COST OF OVER $750! *JB

Mileage: 53,000

WHEN DRIVING AT HIGHWAY SPEEDS OR SLOWER, WHEN SLOWING DOWN CAR WOULD SHAKE BAD,TOOK TO DEALER, SAID BAD TIRES. REPLACED TIRES KEEP DOING IT, BACK TO DEALER 3 WEEKS LATER LEFT TIRE ROD WAS BAD. DEALER REPLACED BRAKES, ROTORS AT 25,000 MILES, WE NOW HAVE 53,000 WHEN ROD GOES OUT. HELP ALSO TRANSMISSION PROBLEMS RESULTING IN LOOSE BOLTS IN FRONT AXLES LOUD CLUNK BACK AGAIN. *JB

Mileage: 52,000

AT MY 3 YEAR NY STATE INSPECTION (30K MILES+/-) WE WERE INFORMED THAT THE TIE RODS WOULD NOT PASS SAFETY INSPECTION. WE LUCKILY HAD 1 MONTH LEFT ON THE WARRANTY & CHYRSLER REPLACED THE ONE SIDE IN QUESTION, BUT WOULD DO NOTHING ON THE OTHER SIDE.

Mileage: 30,000

DT*: THE CONTACT STATED THE REAR CONTROL ARM FRACTURED. IT WAS DRIVEN ON THE FAULTY CONTROL ARM TO AN INDEPENDENT REPAIR SHOP. THE VEHICLE WAS INSPECTED BY THE MECHANIC AND REPAIRED. IT WAS TAKEN FOR STATE INSPECTION AND FAILED DUE THE INNER TIE RODS NEEDING REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS.

Mileage: 67,900

IT WAS FOUND VIA NY STATE INSPECTION AT APROX. 27,000 MILES THAT THE RIGHT FRONT TIE ROD END WAS WORN TO THE POINT OF NEAR FAILURE WHICH WOULD HAVE THE POTENTIAL TO CAUSE THE FRONT RIGHT WHEEL TO FALL OFF. I WAS ADVISED TO NOT DRIVE THE VEHICLE AT ALL. VEHICLE WAS TOWED TO CHRYSLER DEALER FOR REPAIR. *JB

Mileage: 27,000

DT: CAR WAS MAKING A NOISE, WHEN CONSUMER TURNED THE WHEEL IT FELT LIKE THE STEERING WHEEL WAS FALLING OFF AND THEN THE STEERING WENT OUT. CONSUMER HAS CALLED MANUFACTURER AND THEY WILL NOT HELP. DEALER SAID THEY ARE ONLY INVOLVED IN FIXING IT, NOT TAKING COMPLAINTS. 2000 MILES AGO, CONSUMER GOT IT FIXED AND NOW SHE FEELS THE PROBLEM IS STILL THERE. SHE STILL HEARS NOISE IN THE WHEEL. *TT

Mileage: 19,000

WHILE DRIVING FRONT TIRES SHIFTED ONE AT A TIME UPON MAKING LEFT OR RIGHT TURNS. THIS PROBLEM WAS VERY NOTICEABLE THE PROBLEM WAS REPORTED TO THE MANUFACTURER. *AK FRONT TIRES BOUNCE FROM ONE TO THE OTHER. THE CONSUMER SPOKE WITH CHRYSLER CORP ABOUT THE INCIDENT. WHILE SWITCHING LANES THE VEHICLE BEGAN BOUNCING FROM ONE TIRE TO THE OTHER THE OTHER VEHICLES SLOWED DOWN AROND THE CONSUMERS VEHICLES. *TC

FAILURE OF LEFT OUTER TIE ROD END (WORN AND EXCESSIVELY LOOSE) WAS DISCOVERED WHEN CAR WAS BEING SERVICED FOR STRANGE FRONT-END NOISES. SERVICE DEPARTMENT INDICATED THAT THE CAR WAS UNSAFE TO DRIVE LEFT OUTER TIE ROD END HAD TO BE REPLACED AFTER ONLY 18,911 MILES. *NM

Mileage: 18,911

PURCHASED CHRYSLER PACIFICA 2004 6-4-04. IMMEDIATELY AFTER PURCHASE BEGAN TO MAKE A LOUD CHIRPING/SQUEAKING NOISE. BOUGHT IN FOR REPAIR 6-10 (144 MILES). SERVICE ADVISED DEFECT HAD BEEN REPAIRED ( NEW BELT ). PICKED UP CAR ON 6-14-04 NOISE WAS STILL VERY EVIDENT/NOT FIXED. ON 6-15 REPORTED DEFECT WAS STILL NOT FIXED. 6-16-04 DROPPED OFF CAR FOR SAME DEFECT (268 MILES). 6-19 ADVISED THEY HAD CORRECTED DEFECT( REPLACED BELT AND SHIMMIED POWER STEERING PUMP). PICKED UP 6-19 NOT FIXED. DROPPED OFF THIRD TIME ON 6-22 (367 MILES). 6-24 SERVICE DEPARTMENT ADVISED FIXED CAR(FILED REP ADVISED SHIM POWER STEERING PUMP/ PULLEY). REMOVED ENGINE MOUNT AND POWER STEERING PUMP. PICKED UP CAR 6-26 STILL MAKING LOUD CHIRPING NOISE. NOISE WAS CONSTANT. BROUGHT IN MY CAR FOR 4TH TIME FOR SAME DEFECT. DROPPED OFF CAR 6-30. AS OF TODAY, DEALER IS CLAIMING THEY ARE STILL WORKING ON CAR AND CANNOT FIX DEFECT. THEY NEED MORE TIME. I AM EXTREMELY CONCERNED ABOUT THIS DEFECT AND UNDERSTAND THERE WAS A BULLETIN RELEASED (10005991) ON FEB. 17, 2004 THAT SOUNDS VERY MUCH LIKE THE DEFECT I AM REPORTING TO DEALER/SERVICE DEPARTMENT. I FEAR DRIVING THE CAR AS I DON'T KNOW WHAT THE ISSUE IS AND CANNOT UNDERSTAND WHY THE DEALER/SERVICE DEPARTMENT CANNOT FIX THIS DEFECT. SERVICE MANAGER (PETE MARTINO) FAILS TO RETURN MY CALLS AND I AM BEING COMPLETELY IGNORED (BECAUSE I AM A WOMAN). I ASKED TO PERSONALLY SPEAK TO THIS FIELD REP (JIM BERRY) YESTERDAY AS I WANTED TO UNDERSTAND THE DEFECT. PETE MARTINO REFUSED FOR ME TO SPEAK OR SEE THE FIELD REP. AT THIS POINT I FEEL LIKE I AM TRAPPED WITH A CAR THAT OBVIOUSLY HAS A DEFECT AND FEAR FOR MY SAFETY IN DRIVING THIS VEHICLE. BASICALLY THE ATTITUDE AT THIS DEALER IS TO GIVE ME THE RUN AROUND. THEY ARE JUST WAITING FOR ME TO GET A LAWYER INVOLVED PRIOR TO HAVING TO DO ANYTHING TO REMEDY THE SITUATION. IN THE MEANTIME I FEAR FOR MY SAFETY IN DRIVING A CAR WITH A DEFECT AND THE DEALER/SERVICE DEPARTMENT ARE UNABLE TO FIX. *JB

Mileage: 1