2006 DODGE GRAND CARAVAN Electrical System Problems

The contact owns a 2006 Dodge Grand Caravan. The contact stated while driving 5-10 MPH and pulling out of the parking lot, the vehicle stalled. The contact was able to coast into a gas station. The contact stated that the engine was running, but the vehicle failed to respond while depressing the accelerator pedal. The vehicle was towed to the residence. The contact stated that the failure occurred while driving near the residence. The contact stated that upon turning off and restarting the vehicle, the vehicle responded as needed. Additionally, the contact stated that the sliding doors had failed to close and lock automatically and sometimes opened while driving. Additionally, the contact stated that one of the windows failed to roll down. The dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000.

Mileage: 130,000

THE REAR POWER LIFT GATE ON MY 2006 DODGE GRAND CARAVAN DOES NOT STAY OPEN WHEN LOADING OR UNLOADING ITEMS BUT KEEPS CONTINUALLY CLOSING HARD AUTOMATICALLY WHEN NEEDING TO HAVE IT STAY OPEN TO ALLOW FOR LOADING OR UNLOADING. THIS HAPPEN WHETHER ONE TRIES TO OPEN THE DOOR USING THE HANDLE MANUALLY OR AUTOMATICALLY WITH THE KEY FOB. THIS HAS HAPPENED OVER THE LAST 3 OR 4 YEARS ESPECIALLY DURING WINTER BUT NOT CONFINED TO WINTER ONLY. MY GRANDSON AND MYSELF ALMOST GOT CAUGHT MORE THAN ONCE AND INJURED IN ITS UNEXPECTED DOWNWARD FREE-FALL. THIS IS VERY DANGEROUS TO ANYONE TRYING TO ACCESS THE BACK PORTION OF THE VAN AS THE HEAVY LIFT GATES CLOSES ON THEM TRAPPING THEM AND CAUSING POTENTIAL SERIOUS INJURY. THIS HAPPENS WHEN VEHICLE IS STATIONARY AND IN THE GARAGE OR STATIONARY IN A SHOPPING PARKING LOT WHEN LOADING GROCERIES OR OTHER PURCHASES. OR WHEN PUTTING THE REAR SEATS UP OR DOWN TO UTILIZE BACK PORTION OF VAN. SOMEONE CANNOT HOLD THE LIFT GATE OPEN WHEN ANOTHER IS TRYING TO ACCESS THE BACK OF THE VAN AS THE LIFT GATE FALLS HARD AND CANNOT BE STOPPED. THERE ARE CURRENTLY 93,360 MILES DRIVEN.

Mileage: 93,360

I TURNED INTO A DRIVE WAY AND THE CAR LOST CONTROL. BREAKS LOCKED AND I WOULDN'T STOP

Mileage: 230,000

TAKATA RECALL 1. THE KEY FOB, AUTOMATICALLY CONTROLLED REAR DOOR HATCH DOES NOT STAY OPEN WHEN USING THE KEY FOB OR MANUALLY OPENING THE HATCH DOOR. IT HAS CLOSED NEARLY UPON MYSELF - THE OWNER, AND OTHERS - WITHOUT WARNING WHEN STOPPED, MOTOR OFF AND LOADING OR UNLOADING ITEMS. THERE IS NO WAY TO ASSESS WHAT CAUSED THIS AS IT GETS BELOW NORMAL WEAR. SINGLE PARTY USE, NO KIDS. THIS INCIDENCE STARTED 12/12/2016 2. THE FRONT BRAKES MAKE A SCRAPING NOISE AND WOBBLING OF STEERING WHEEL UPON COMING TO A STOP. THIS WAS MENTIONED TO THE DEALER EARLIER THIS YEAR AND BRAKES, PADS AND ROTORS WERE CHECKED AT DEALER, AND IT WAS STATED THAT NOTHING WAS WRONG. NEW BRAKE PADS WERE INSTALLED IN 2013. THE CAR MILEAGE IS 85241 MILES. THE WHEELS HAVE BEEN ROTATED, ALIGNED. THE CAR HAS REGULAR, ROUTINE MAINTAINANCE, THE BRAKES STILL SCRAPES AND WOBBLES THE STEERING WHEEL. THIS HAS BEEN A RECURRING INCIDENCE.

Mileage: 85,214

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. WHILE TRYING TO RESTART THE VEHICLE, THE CONTACT NOTICED THAT THE KEY FELL OUT OF THE IGNITION. THE CONTACT REPLACED THE KEY AND WAS ABLE TO RESTART THE VEHICLE. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 127,000.

Mileage: 127,000

TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM) EXCEEDED A REASONABLE TIME FOR REPAIR. THE CONTACT RECEIVED A RECALL NOTIFICATION IN JUNE OF 2015; HOWEVER, THE DEALER PLACED THE CONTACT ON A WAITING LIST AND STATED THAT THE PART WAS NOT AVAILABLE FOR REPAIR. THE DEALER DID NOT KNOW WHEN THE PART WOULD BE AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT IT TOOK SEVERAL ATTEMPTS TO START THE IGNITION. THE FAILURE HAS OCCURRED FOR A MONTH. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM). THE PART WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 66,114.

Mileage: 66,114

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, BOTH REAR SLIDING DOORS OPENED INDEPENDENTLY. THE CONTACT STOPPED THE VEHICLE AND MANUALLY CLOSED THE DOORS. WHILE PARKED, THE REAR SLIDING DOORS CLOSED INDEPENDENTLY AND HAD TO BE FORCED OPEN. THE VEHICLE WAS TAKEN TO A DEALER AND DIAGNOSED THE CAUSE OF FAILURE AS ELECTRICAL. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000. MA 08/11/15 THE CONSUMER STATED THE FAILURE CAUSES PHYSICAL PAIN AND ANXIETY TO OCCUPANTS. THE DOORS WOULD LOCK CHILDREN INSIDE THE VEHICLE. THE INTERIOR LIGHTS AND RADIO WOULD NOT OPERATE. THE VEHICLE WOULD ALSO SHAKE VIOLENTLY. UPDATED 8/14/15 *JS UPDATED 09/03/15*LJ UPDATED 3/29/2016 *JS THE CONSUMER STATED SHE AS WELL AS HER CHILDREN HAVE BEEN SMASHED BY THE DOORS AND HER FAMILY HAS BEEN UNDER DOCTOR'S CARE SINCE THE VEHICLE WAS PURCHASED. UPDATED 04/05/16.*JB

Mileage: 130,000

THIS VEHICLE HAS A STALK ON THE STEERING COLUMN THAT CONTROLS THE WINDSHIELD WASHER, WIPER, AS WELL AS THE VEHICLE BRIGHT LIGHTS, AND THE TURNING SIGNALS. AROUND MAY. 2014 THE WASHER BEGAN WORKING INTERMITTENTLY. SOMETIMES IT WOULD WORK, SOMETIMES NOT. WIGGLING THE STALK WOULD SOMETIMES MAKE IT WORK. BY PULLING THE STALK TOWARD THE DRIVER, THE BRIGHT LIGHTS ARE SUPPOSE TO COME ON TEMPORARILY, UNTIL RELEASED. THEY STOPPED WORKING, ALSO ABOUT MAY, 2014. IT IS STILL WORKING INTERMITTENTLY, BUT NOW THE TURNING SIGNALS ARE ALSO AFFECTED, WORKING INTERMITTENTLY, OR EVEN PUTTING ON THE LEFT TURN SIGNAL, WHEN THE SWITCH IS TURNED FOR A RIGHT TURN, OR RIGHT FOR LEFT. I AM AFRAID THAT THIS SWITCH IS DEFECTIVE, AND CAN CAUSE AN ACCIDENT IF IT DOES NOT WORK RELIABLY.

Mileage: 75,000

MY HEADLIGHTS HAVE BEEN TURNING ON BY THEMSELVES WHILE THE SWITCH IS IN THE OFF POSITION.

Mileage: 88,870

OUR AIR BAG LIGHT COMES ON AFTER REPEATED, EXACT TURNS OF THE STEERING WHEEL. HAS TO DO WITH THE STEERING WHEEL CLOCK SPRING. IT ONLY ILLUMINATES IN TEMPS OVER 70 DEGREES OR SO. WE LIVE IN THE DESERT OF ARIZONA AND HAVE BEEN EXCLUDED IN PREVIOUS RECALLS. WE ARE AFRAID THE AIR BAGS WILL NOT WORK PROPERLY IN THE EVENT OF A CRASH. *TR

Mileage: 64,155

THE PARKING LIGHTS TURN ON AND OFF RANDOMLY WHEN THE VEHICLE IS OFF. WHEN THE VEHICLE IS RUNNING, THE PARKING LIGHTS DON'T OPERATE PROPERLY USING THE LIGHT SWITCH--E.G. THE PARKING LIGHTS STAY ON WHEN TURNED OFF. CYCLING THE SWITCH SEVERAL TIMES CAN TURN THE PARKING LIGHTS OFF. OUR CAR WAS MANUFACTURED LATE IN DECEMBER 2005 ACCORDING TO DODGE. THIS APPEARS TO BE RELATED TO NHTSA ACTION # EA11010. DODGE HAS REFUSED TO COVER THE HEADLIGHT SWITCH ASSEMBLY (HSA) UNDER WHAT SHOULD BE A LIFETIME WARRANTY. THE HSA HAS BEEN REPLACED AT OWNERS EXPENSE AND THE PROBLEM APPEARS TO BE FIXED. WE SAVED THE DEFECTIVE PART. *TR

Mileage: 135,000

PASSENGER SIDE SLIDING DOOR WILL NOT LOCK BY REMOTE KEY. DRIVER SIDE SLIDING DOOR WILL NOT OPEN OR CLOSE BY REMOTE KEY OR INTERIOR CONSOLE KEY. I BELIEVE THE SYSTEM IS DEFECTIVE AND THAT SWITCHES ARE DEFECTIVE AS WELL. *TR

Mileage: 49,500

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT ATTEMPTED TO OPEN THE PASSENGER SIDE SLIDING DOOR, BUT IT WOULD NOT OPEN WHEN THE REMOTE DOOR CONTROL WAS ACTIVATED. THE FAILURE OCCURRED FOR FOUR YEARS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

Mileage: 45,000

ELECTRIC LOCKS NO LONGER WORK FOR SIDE DOORS. CAN STILL MANUALLY LOCK/UNLOCK DOORS, BUT THIS INVOLVES REACHING AROUND FROM FRONT SEAT. THIS IS A SAFETY ISSUE BECAUSE MY CHILD CANNOT MANAGE TO MANUALLY PULL UP THE LOCK TO UNLOCK THE DOOR AND LET HERSELF OUT IN CASE OF AN EMERGENCY. SIDE DOORS ALSO NO LONGER AUTOMATICALLY LOCK WHEN REACHING DRIVING SPEEDS, WHICH IS ANOTHER SAFETY HAZARD RELATED TO CHILDREN. VARIOUS SOLUTIONS HAVE BEEN POSTED ONLINE BUT ALL ACCOUNTS STATE THESE ARE ONLY TEMPORARY FIXES AND DO NOT RESOLVE THE ISSUE LONG TERM. CANNOT OPERATE THE ELECTRONIC LOCKS FROM THE DRIVER SIDE DOOR SWITCH, EITHER, SO THIS IS NOT A KEY BATTERY ISSUE. WHATEVER ELECTRICAL SHORT IS CAUSING THIS HAS ALSO SHORTED OUT THE DOME LIGHTS INSIDE THE FRONT OF THE VAN (DRIVER AND PASSENGER SIDE). *TR

Mileage: 84,000

MY SON WAS DRIVING MY VAN ON THE INTERSTATE WHEN SUDDENLY EVERYTHING ON THE VAN SHUT OFF. LUCKILY, THERE WERE NO VEHICLES IMMEDIATELY BEHIND US .HE SAID THAT HE BUMPED THE IGNITION WITH HIS KNEE. *TR

Mileage: 100,000

VEHICLE HEADLIGHTS INTERMITTENTLY TURN OFF EVEN THOUGH THE HEADLIGHT SWITCH IS IN THE ON POSITION. HEADLIGHTS ARE ABLE TO BE TURNED BACK ON BY CYCLING THE SWITCH OFF AND ON MULTIPLE TIMES. SOMETIMES HEADLIGHTS FLICKER ON AND OFF INTERMITTENTLY EVEN THOUGH THE HEADLIGHT SWITCH REMAINS IN THE ON POSITION. THIS HAS BEEN A PROBLEM ACCORDING TO A PREVIOUS INVESTIGATION BY YOUR ORGANIZATION. THE INVESTIGATION NUMBER EA11010. YOUR FINDINGS SHOWED THIS PROBLEM OCCURRING WITH THIS PARTICULAR MAKE MODEL AND YEAR OF VEHICLE. IT ALSO INDICATED THAT CHRYSLER CORPORATION WAS GOING TO INITIATE A LIFETIME WARRANTY ON THE HEADLIGHT SWITCH ASSEMBLY FOR THIS PARTICULAR VEHICLE. IT INDICATED THAT THIS WAS GOING TO START SOMETIME IN EARLY 2013. I CONTACTED CHRYSLER CORPORATION SERVICE AND THEY INDICATE THAT THERE IS NO WARRANTY OR KNOWN PROBLEM ON THAT PARTICULAR HEADLIGHT SWITCH ASSEMBLY. WHEN I REFERRED THEM TO YOUR SITE AND THE PARTICULAR INVESTIGATION AND CONCLUSION IN REGARDS TO THIS ISSUE THEY INDICATED THAT THIS WAS NOT A KNOWN PROBLEM AND JUST BECAUSE IT WAS ON THE INTERNET DOES NOT MEAN THAT IS TRUE. THE IDENTIFIED ISSUE AND PROBLEM WITH THE HEADLIGHT SWITCH ASSEMBLY WILL NOT BE TAKEN CARE OF UNDER WARRANTY ACCORDING TO CHRYSLER CORPORATION. THIS SEEMS TO BE IN DIRECT CONFLICT WITH WHAT CHRYSLER CORPORATION TOLD YOUR ORGANIZATION THAT THEY WERE GOING TO DO WHICH WAS TO PLACE THIS PART UNDER A LIFETIME WARRANTY BEGINNING SOMETIME EARLY 2013. *TR

Mileage: 106,000

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THERE WAS AN EGR AND ELECTRICAL PROBLEM THAT RECURRED. THE ENGINE LIGHT ILLUMINATED WHEN SHE WAS DRIVING ON MULTIPLE OCCASIONS. THE REAR RIGHT PASSENGER DOOR WOULD NOT LOCK OR CLOSE PROPERLY. THE LEFT BRAKE LIGHT AND LEFT TURN SIGNALS WERE REPAIRED MULTIPLE TIMES. THE FAILURE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE EGR VALVE SYSTEM, THE LEFT BRAKE LIGHT, LEFT TURN SIGNAL LIGHT, FRONT WIPERS, FRONT BRAKE PADS, AND ROTORS NEEDED TO BE REPLACE. THE VEHICLE ALSO NEEDED A MAJOR TUNE UP. ALL OF THE REPAIRS WERE MADE MINUS THE EGR VALVE SYSTEM AND THE REAR PASSENGER SIDE DOOR WHICH THE DEALER WAS UNABLE TO REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70867.

Mileage: 70,867

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE HE ATTEMPTED TO START THE ENGINE, SMOKE EMITTED UNDER THE HOOD. THE MAIN WIRING HARNESS WAS ON FIRE AND SPREAD TO THE CENTRAL COMPUTER SYSTEM AND THE WHEEL WELLS. THE MANUFACTURER INVESTIGATED THE FAILURE AND CONCLUDED THAT THE WIRING HARNESS FAILURE WAS NOT CAUSED BY A MANUFACTURING DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 162,000. UPDATED 3/31/14 *CN THE CONSUMER STATED AS OF FEB 27TH, THE INSURANCE COMPANY TOTALED THE VEHICLE, DUE TO THE EXTENSIVE REPAIRS OF $6,800. THE MAIN WIRING HARNESS AND ALL THE COMPUTERS WERE DAMAGED, ALONG WITH THE FUSE BLOCK. UPDATED 04/01/14 ..UPDATED 04-22-14 *BF UPDATED 04/23/14

Mileage: 162,000

MY SLIDING DOOR QUIT WORKING HALF WAY THRU CYCLE. MY POWER WENT DEAD IN DOORS AND LOCKS I TOOK IT TO THE DODGE DEALER THEY COULD NOT FIND THE PROBLEM SAID IT WAS EITHER THE ECM OR THE BCM BUT NOT SURE. THEY DID NOT WANT TO REPLACE AS THEY WOULD JUST BURN OUT AGAIN IF THIS WAS THE PROBLEM AND STILL A SHORT SOMEWHERE IT WAS SAFE TO DRIVE. I DROVE IT HOME AND NEXT DAY WENT TO START IT AND THE MAIN WIRING HARNESS UNDER THE BATTERY AND ABOVE THE DRIVERS SIDE WHEEL WELL BURST INTO FLAMES BURNING THE ENTIRE MAIN ELECTRICAL HARNESS AND ECM AND FUSE BOX UP. TOOK IT BY TOW TRUCK TO DODGE DEALER AGAIN THEY SAID LOOKS LIKE WIRING HARNESS WAS WORN THROUGH WHERE IT WAS FASTENED TO THE FRAME AT THE ASSEMBLY PLANT. CALLED DODGE AND THEY SAID THIS HAS HAPPENED BEFORE SUPPOSE TO SEND AN INSPECTOR AND NO ONE SHOWED UP IT HAS BEEN OVER A WEEK AND NO HELP FROM DODGE OR THE DEALER WHO TOLD ME IT WAS SAFE TO DRIVE. I RECEIVED A LETTER FROM CHRYSLER STATING IT WAS NOT A MANUFACTURER DEFECT YEAH RIGHT!! *TR

Mileage: 162,000

MY SLIDING DOOR QUIT WORKING HALF WAY THRU CYCLE. MY POWER WENT DEAD IN DOORS AND LOCKS I TOOK IT TO THE DODGE DEALER THEY COULD NOT FIND THE PROBLEM SAID IT WAS EITHER THE ECM OR THE BCM BUT NOT SURE. THEY DID NOT WANT TO REPLACE AS THEY WOULD JUST BURN OUT AGAIN IF THIS WAS THE PROBLEM AND STILL A SHORT SOMEWHERE IT WAS SAFE TO DRIVE. I DROVE IT HOME AND NEXT DAY WENT TO START IT AND THE MAIN WIRING HARNESS UNDER THE BATTERY AND ABOVE THE DRIVERS SIDE WHEEL WELL BURST INTO FLAMES BURNING THE ENTIRE MAIN ELECTRICAL HARNESS AND ECM AND FUSE BOX UP. TOOK IT BY TOW TRUCK TO DODGE DEALER AGAIN THEY SAID LOOKS LIKE WIRING HARNESS WAS WORN THROUGH WHERE IT WAS FASTENED TO THE FRAME AT THE ASSEMBLY PLANT. CALLED DODGE AND THEY SAID THIS HAS HAPPENED BEFORE SUPPOSE TO SEND AN INSPECTOR AND NO ONE SHOWED UP IT HAS BEEN OVER A WEEK AND NO HELP FROM DODGE OR THE DEALER WHO TOLD ME IT WAS SAFE TO DRIVE. *TR

Mileage: 154,000

VEHICLE QUITS WHILE DRIVING IN THE RAIN AND LOSES ABILITY TO STEER. *TR

Mileage: 146,000

THE AUTOMATIC DOOR LOCKS ARE JAMMED ON BOTH SIDES OF THE VEHICLE AND WILL NOT UNLOCK EVEN MANUALLY. WHILE THIS MAY SEEM LIKE A MINOR ISSUE, IF WE WERE TO END UP IN AN ACCIDENT WITH NO WAY FOR MY 5 CHILDREN TO EXIT THE VEHICLE EXCEPT THROUGH THE FRONT 2 DOORS, IT WOULD BE A HUGE SAFETY ISSUE. I UNDERSTAND THAT THE AUTOMATIC LOCKS OCCASIONAL MALFUNCTION, THERE SHOULD BE A SAFETY MECHANISM THAT AT LEAST ALLOWS FOR IT TO OPERATE MANUALLY BUT THIS IS NOT THE CASE. I RESEARCHED ONLINE AND ON MANY SITES THERE ARE OTHERS WITH THE SAME ISSUE. I CALLED CHRYSLER TO ISSUE A COMPLAINT AND THEY REFERRED ME HERE. *TR

Mileage: 90,000

2006 DODGE GRAND CARAVAN SE 72900 MI. TURN STALK INOPERATIVE SIGNALLING LEFT HAND TURN THOUGH 4 WAY FLASHER WORKS; SO IT IS NOT THE FLASHER. RIGHT TURN PHASE WORKS. INTERMITTENT FAILURE. WILL REPORT TO CHRYSLER 18009921997. DEALER REFUSED TO FIX, NOT RECALLED. THIS IS THE SECOND DGC WITH A TURN STALK FAILURE I HAVE OWNED, OTHER WAS 1999 DGC. CHRY. DOES KNOW ABOUT THE HEADLIGHT SWITCH FAILURE AND REPLACED FREE. *TR

Mileage: 72,900

IT FIRST STARTED WITH THE PASSENGER SIDE SLIDING DOOR LOCK. IT WOULD NOT AUTOMATICALLY LOCK AND HAD TO BE DONE MANUALLY. NOW THE DRIVER'S SIDE DOOR LOCK WILL NOT GO UP AND DOWN AUTOMATICALLY NOR WILL IT DO IT MANUALLY. THE DOOR WILL ALSO NOT OPEN AT ALL FROM INSIDE OR OUTSIDE. THIS IS A SAFETY ISSUE BECAUSE PASSENGERS ARE NOT ABLE TO GET OUT OF THE VEHICLE FROM THAT SIDE. *TR

Mileage: 82,000

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THE VEHICLE EXHIBITED SEVERAL ELECTRICAL FAILURES. THE BRAKE LIGHTS, INSTRUMENT PANEL AND THE CLUSTER ABOVE HER HEAD ALL FAILED. THE CONTACT REPLACED SEVERAL LIGHT BULBS BUT ALL OF THE LIGHTS CONTINUED TO FAIL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE LIGHT IN THE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 165,000. ..UPDATED 12/06/12 *BF

Mileage: 165,000

TL* THE CONTACT OWNS A 2006 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE HEADLIGHTS WOULD NOT ILLUMINATE. IN ADDITION, THE HEADLIGHTS WOULD UNEXPECTEDLY STOP ILLUMINATING AT NIGHT AND WOULD NOT BEGIN FUNCTIONING AGAIN FOR A FEW HOURS. THE VEHICLE WAS TAKEN TO A DEALER AND THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000. THE CONSUMER STATED OVER THE LAST TWO YEARS THE HEADLIGHTS WOULD NOT COME ON WHEN SHE USED THE SWITCH TO TURN THEM ON. THE CONSUMER STATED WHILE DRIVING AT NIGHT, SHE NOTICED THE HEADLIGHTS WERE NOT ON, BUT WITHIN A FEW SECONDS, THEY CAME BACK ON. THE CONSUMER STATED THERE WERE SEVERAL OCCASIONS, WHERE THE HEADLIGHTS WOULD NOT COME ON AT ALL AFTER TOGGLING THE SWITCH. THE CONSUMER REFERENCED ENGINEERING ANALYSIS (EA11-010) UPDATED 03/29/12

Mileage: 60,000

THE SLIDING PASSENGER DOOR LOCKS NO LONGER LOCK AUTOMATICALLY LOCK WHILE DRIVING. THEY HAVE TO BE LOCKED MANUALLY. THIS IS A SAFETY ISSUE. WITH CHILDREN IN THE BACK SEAT, THEY CAN NOW OPEN THE DOORS WHILE THE CAR IS MOVING IF AN ADULT FORGETS TO LOCK THEM. THE LIFT GATE IN THE BACK NO LONGER CHIMES WHEN OPENING. THIS IS A SAFETY ISSUE. SOMEONE CAN GET WHACKED WITH THE DOOR, NOT KNOWING THAT IT IS ABOUT TO OPEN. THE PARKING LIGHTS STAY ON OR COME ON SPONTANEOUSLY AFTER THE HEADLIGHTS HAVE BEEN TURNED OFF. THIS IS A PROBLEM. VERY EASY FOR THE OWNER TO COME OUT IN THE MORNING TO A DEAD BATTERY AND A CAR THAT WON'T START. SOME OWNERS HAVE REPORTED THE HEADLIGHTS CUTTING OUT WHILE DRIVING, A SERIOUS SAFETY ISSUE. *TR

Mileage: 78,000

DRIVER SIDE PASSENGER DOOR AUTOMATIC LOCK DOES NOT WORK. *TR

ON 6/27/11 THE AIR BAGS DEPLOYED IN OUR 2006 DODGE GRAND CARAVAN FOR NO REASON WHILE THE VEHICLE WAS BEING DRIVEN AT ABOUT 25 MPH. THE DRIVER HAD MINOR INJURIES. CHRYSLER HAS REFUSED TO REPAIR THE VEHICLE AT THEIR COST AND HAVE GIVEN US A REPAIR QUOTE OF ABOUT $4000.00. CHRYSLER TOLD US THAT THE AIRBAG WARNING LIGHT WAS ON FOR 250 DRIVING HOURS BEFORE THE INCIDENT, BUT THAT IS COMPLETELY FALSE. THEY WILL NOT RELEASE THE REPORT TO US. AT THIS POINT, THE VEHICLE HAS NOT YET BEEN REPAIRED. AFTER THE INCIDENT, WE WERE TOLD ABOUT A PREVIOUS AIRBAG RECALL ON SOME 2006 GRAND CARAVANS. AFTER THE INCIDENT, THE 2008 GRAND CARAVANS WERE ALSO RECALLED FOR UNEXPECTED AIRBAG DEPLOYMENT. ALSO THE STEERING GEAR WAS LEAKING AND HAD TO BE REPLACED. ALSO, THE BATTERY WAS REPLACED. UPDATED 10/25/11 *TR

Mileage: 55,000

WE OWN A 2006 DODGE GRAND CARAVAN , THE PROBLEMS STARTED WITH THE TURN INDICATOR NOT WORK CORRECTLY , IT FLASHES ON THE WRONG SIDE , IF YOU CLICK IT TO TURN RIGHT THE LIGHTS WORK FOR THE LEFT SIDE , SOME TIME IT WILL NOT WORK AT ALL. NOW THE KEY LESS ENTRY DOESN'T WORK THE FIRST TIME YOU PRESS IT UNLOCKS THE DRIVERS SIDE ONLY PRESS IT TWO TIMES RAPIDLY AND IT WILL UNLOCK THE REAR HATCH AND PASSENGERS SIDE. THIS MODEL VAN HAS MASSIVE ELECTRICAL PROBLEMS I KEEP SMELLING BURNING WIRES BUT I HAVE TO DRIVE IT BECAUSE ITS OUR ONLY VEHICLE AND I HAVE 4 CHILDREN SO IM ALWAYS WORRIED ABOUT THERE SAFETY IN THIS VAN. WE HAVE OWNED IT SINCE NEW SO THERE HAS BEEN NOTHING CHANGED BYE ANYONE BESIDES THE DODGE DEALER. BTW TOOK IT TO DODGE THEY NEVER HAVE FIGURED IT OUT AND THE WARRANTY IS EXPIRED NOW SO I AM STUCK WITH IT. *TR

Mileage: 31,051

2006 DODGE GRAND CARAVAN - DOOR DOES NOT FULLY CLOSE OR OPEN WITH AUTOMATIC BUTTON - WIRE IN DOOR TRACK WAS SEVERED FROM MULTIPLE OPENINGS AND CLOSINGS - HAVE SEEN ON THE INTERNET THAT IT HAS HAPPENED TO A LOT OF OTHER VANS. *TR

Mileage: 60,000

AUTOMATIC PASSENGER SLIDING DOOR WILL NOT OPEN OR SHUT COMPLETELY WITH EITHER BUTTONS OR FOB. WHEN THE DOOR IS CLOSED MANUALLY THE DOOR CYCLES TO "PULL" ITSELF SHUT. MY CHILDREN NOTICED THIS ALSO STARTING ON DRIVER SIDE DOOR AS WELL. WE BELIEVE A WIRE IN THE PLASTIC BLACK CASING HAS SHORTED OR BEEN SEVERED. *TR

Mileage: 60,043

2006 DODGE GRAND CARAVAN ALL OF SUDDEN DID NOT START. THE FAILURE ENGINE CONTROL MODULE A COMPUTER THAT WAS PUT ON BY DODGE AND CHRYSLER ,THAT IS MALFUNCTION ON ITS VEHICLE.THE PRICE TO REPLACE THIS COMPUTER IS AROUND 700.00. IT HAS ALSO FAILED IN THE TOWN AND COUNTRY MINI VAN AND THE DODGE DURANGO. *TR

Mileage: 93,000

DOOR LOCK FAILURE ON 2006 DODGE GRAND CARAVAN. SLIDING DOOR IS LOCKED AND WILL NOT OPEN MANUALLY OR WITH ELETRONIC BUTTONS. BIG SAFETY ISSUE IF A CHILD OR PASSENGER IS IN THE BACK OF VAN AND YOU COULD NOT GET THE DOOR OPEN TO GET CHILD OR PEOPLE OUT IF AN ACCIDENT WAS TO HAPPEN!!! VEHICLE IS NO LONGER UNDER WARRANTY AND I CANNOT AFFORD AN $100 CHARGE TO A DEALERSHIP JUST TO LOOK AT THE CAR. *TR

2006 DODGE GRAND CARAVAN ELECTRIC PASSENGER DOOR STOPS 6" AFTER OPENING, WHEN CLOSING STOPS IN THE SAME PLACE. 82,000 MILES - SEEMS LIKE A VERY COMMON PROBLEM WITH OTHERS AFTER DOING RESEARCH. *TR

Mileage: 82,000

HEADLIGHTS ON MY 2006 DODGE GRAND CARAVAN HAVE BEEN INTERMITTENT ON VARIOUS OCCASIONS. WHEN YOU TURN THE SWITCH ON, HEADLIGHTS DO NOT ALWAYS ACTIVATE. NO INJURIES, NO ACCIDENTS, BUT COULD CAUSE A POTENTIAL ACCIDENT BY NOT BEING ABLE TO SEE, OR TO BE SEEN. ONCE THE PROBLEM WAS RECOGNIZED, IN EACH INSTANCE, BY PLAYING WITH THE SWITCH, THE LIGHTS EVENTUALLY WOULD COME ON. FIRST INSTANCE WAS PROBABLY IN 2007, LATEST IN 2009 ON A COUPLE OF DIFFERENT OCCASIONS. *TR

Mileage: 19,000

MULTIPLE ELECTRICAL PROBLEMS RESULTING IN MANY SENSOR AND PART REPLACEMENTS. FIRST SURGE IN MILEAGE GAUAGE RESULTED IN REPLACEMENT OF FRIED RADIO. SECOND SURGE RESULTED IN AIR BAG SENSOR REPLACEMENT. THIRD SURGE RESULTED IN NO PROBLEM FOUND. FOURTH SURGE RESULTED IN ABS SENSOR NEEDING TO BE REPLACED. THE FIFTH SURGE RESULTED IN DRIVER SEAT CONTROL MOTOR GOING BAD, BUT BEING REPAIRABLE. THE SIXTH SUGRE RESULTED IN DRIVERS SEAT MOTOR HAVING TO BE REPLACED DUE TO COMPLETE BURN OUT. SINCE THE FIRST SURGE I HAVE BEEN UNABLE TO OPEN THE SLIDING DOORS WITH EITHER THE CONSOLE OR THE BUTTONS BESIDE THE DOORS MOST OFTEN. AFTER ONE OF THESE SURGES, ONLY THE KEY REMOTE WILL OPEN THE SLIDING DOORS. *AK

Mileage: 20,435