2007 DODGE GRAND CARAVAN Electrical System Problems

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHEN THE CONTACT ATTEMPTED TO LOCK THE VEHICLE WITH THE POWER LOCK FUNCTION, BOTH REAR SLIDING DOORS SEIZED WITHOUT WARNING AND WOULD NOT REOPEN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 145,000.

Mileage: 145,000

WHEN TURNING ON RIGHT TURN SIGNAL IT FLASHES AND SHUTS OFF WHILE THE SWITCH IS STILL ON. WHEN I SIGNAL LEFT IT DOESN'T WORK AT TIMES, ALL THIS HAPPENS WHILE THE VEHICLE IN IN MOTION ON THE ROAD. I TRIED CONTACTING DODGE AND THEY WERE NO HELP. THIS IS A HUGE SAFETY ISSUE AND COULD LEAD ME TO GET PULLED OVER OR IN AN ACCIDENT

Mileage: 115,000

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING 60 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE FUSE BOX LOCATED UNDER THE HOOD IN THE ENGINE COMPARTMENT BECAME OVERHEATED. THE FUSES WERE EXTREMELY HOT AND SMOKING. THE VEHICLE WAS TOWED BACK TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 189,863.

Mileage: 189,863

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V373000 (AIR BAGS, ELECTRICAL SYSTEM); HOWEVER, THE PART NEEDED TO PERFORM THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

DURING PARK REAR PASSENGER DOOR WOULD NOT OPEN FROM THE INSIDE MANUALLY AND ELECTRONICALLY, SOMEONE FROM THE OUTSIDE HAS TO OPEN THE DOOR. THE UNLOCK MECHANISM IS UP BUT THE DOOR BUTTON FROM THE INSIDE WOULD NOT PUSH DOWN, THEREFORE NOT ALLOWING THE VAN DOOR TO OPEN. THIS IS BIG SAFETY PROBLEM, NO ONE CAN GET OUT MANUALLY AND ELECTRONICALLY FROM THE INSIDE. TOOK IT TO DODGE AND THEY CLAIM IT'S THE WIRE, BUT IT'S NOT BECAUSE THE WIRE IN GREAT CONDITION, BECAUSE IT'S BEEN REPLACE AND STILL HAVING THE SAME PROBLEM. IT'S NOT MOTOR BECAUSE ONCE IN A BLUE MOON IT WOULD OPEN PARTIALLY, BUT IT WOULD CLOSED AUTOMATICALLY IMMEDIATELY. I HAVE FILE NUMEROUS COMPLAINTS TO DODGE BUT NOTHING WAS DONE. I BELIEVE IT'S ELECTRONIC PROBLEM, WHICH HAS TO DO WITH ECM (ELECTRONIC CONTROL MODULAR). PLEASE CONTACT DODGE GRAND CARAVAN TO DILIGENTLY CHECK INTO THIS SAFETY ISSUE. THANK YOU. *TR

1ST OCCURRENCE: WHILE DRIVING ON FREEWAY ON A HOT DAY THE CAR STALLED WITHOUT WARNING. ON ATTEMPTED RESTARTS CAR WOULD FIRE FOR A COUPLE OF SECONDS AND QUIT. TRIED OTHER KEY: NO HELP. AFTER ABOUT 7 OR 8 ATTEMPTS THE CAR WOULD NOT CRANK AND SOLENOID CLICKED. TOWED HOME. CAR SET CODES P0339 AND P0344(INTERMITTENT CRANK AND CAM SENSOR). CHARGED BATTERY . REPLACED BOTH SENSORS CAR INITIALLY WOULD NOT START, THEN MYSTERIOUSLY FIRED UP AND RAN FINE. OK FOR ABOUT A MONTH. BATTERY TESTED OK CHARGING VOLTAGE GOOD WHEN RUNNING. NOT RELATED TO HAVING JUST (OVER)FILLED GAS TANK. (MUCH ON INTERNET ABOUT THIS: BAD VALVE IN TANK ALLOWS EVAP TO FLOOD) 2ND OCCURRENCE. ONCE AGAIN DRIVING ON HIGHWAY HOT DAY. ONCE AGAIN STALLED WITHOUT WARNING. SAME SYMPTOMS ON ATTEMPTED RESTART. AFTER WAITING ABOUT 15 MINUTES, CAR RESTARTED, RAN ABOUT 4 MILES AND STALLED AGAIN. ATTEMPTED FOUR OR FIVE RESTARTS, THEN BATTERY APPEARED TO RUN DOWN. HEADLIGHTS WOULD DIM ON START ATTEMPT. AFTER A WHILE THE CAR STARTED AGAIN BUT RAN ROUGHLY ON ACCELERATION. ONCE AGAIN SET SAME CODES. AT THIS POINT I NOTICED SOME ELECTRICAL ANOMALIES. UPON KEY ON, THE TEMP, FUEL, AND TACH GAUGES WOULD PEG HIGH AND THEN FALL BACK TO NORMAL. THE POWER WINDOWS BEGAN TO OPERATE WITHOUT THE KEY ON. TOW TRUCK ARRIVED AND GOT IT HOME. CAR RESTARTED IN GARAGE. REPLACED BOTH SENSORS AGAIN AND BATTERY (SUSPECTED INTERMITTENT OPEN). 3RD OCCURRENCE ON TEST DRIVE GOT ABOUT 5 MILES AND ONTO HIGHWAY. ONCE AGAIN STALLED. THIS TIME RESTARTED, TURNED AROUND AND GOT ABOUT 2 MILES THEN QUIT AGAIN. THIS TIME NO RESTART( SAME 2-3 SECONDS). THIS TIME SET CODE P0344 ONLY(CAM SENSOR INTERMITTENT). CAR RESTARTED LATER BACK IN SHOP. RESEARCH ON THE INTERNET HAS GOT ME THINKING ABOUT THE TIPM (TOTALLY INTEGRATED POWER MODULE)

Mileage: 130,000

VEHICLE STALLS INTERMITTENTLY WHILE DRIVING SHORTLY AFTER FILLING UP WITH FUEL. VEHICLE CONTINUES TO STALL PERIODICALLY WITHOUT ANY KNOWN CONSISTENCY. DURING THE STALL, THE ENGINE CUTS OUT AND THE STEERING WHEEL LOCKS UP. THIS HAS OCCURRED SEVERAL TIMES IN THE PARKING LOT AFTER FILLING UP AND WHILE ENTERING THE ROADWAY AFTER FILLING UP. THIS A VERY DANGEROUS AND SERIOUS CONCERN FOR WHEN A LOSS OF POWER OCCURS ON THE ROADWAY SERIOUS AND POTENTIALLY FATAL ACCIDENTS MAY OCCUR. *TR

Mileage: 95,000

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE VEHICLE STALLED AFTER THE VEHICLE WAS REFUELED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS NOT AVAILABLE.

Mileage: 50,000

TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH, THE VEHICLE STALLED. THE CONTACT STATED THAT THE FAILURE WAS PROGRESSING BUT THE VEHICLE WAS ABLE TO BE RESTARTED EACH TIME THE FAILURE RECURRED. THE VEHICLE WAS NOT INSPECTED OR DIAGNOSED. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V139000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,433.

Mileage: 55,433

2007 DODGE GRAND CARAVAN SXT STOW N GO HAVING SEVERAL ELECTRICAL ISSUES. 1. PASSENGER POWER SLIDING DOOR FAILED, REPLACED POWER DOOR MOTOR, LOCK ACTUATOR, AND REPAIRED WIRING AS THE WIRES ACTUALLY BREAK/SNAP OVERTIME. POOR DESIGN. 2. LESS THAN TWO YEARS LATER PASSENGER POWER SLIDING DOOR HAS FAILED AGAIN, & POWER LOCKS WILL NOT WORK, & I CAN OPEN PASSENGER SLIDING DOOR AFTER LOCKING VEHICLE WITH KEY FOB AND ALARM WON'T SOUND! CANNOT GET MY CHILDREN IN AND OUT OF THIS DOOR WITHOUT REACHING IN AND PULLING UP THE LEVER FROM INSIDE (TOO STIFF, MY DAUGHTER ISN'T STRONG ENOUGH). THIS IS A SAFETY ISSUE AND RESEARCHING IT ONLINE SHOWS THAT IT IS WIDESPREAD. 3. POWER SEAT MOTOR HAS FAILED. WE HAVE STOW N GO SEATING. IN ORDER TO STOW THE 2ND ROW SEAT YOU MUST MOVE FRONT SEAT TO FULL FORWARD POSITION, THEN MOVE DRIVER SEAT BACK......DRIVER SEAT IS ALL THE WAY BACK NOW (FOR MY SPOUSE) AND I CANNOT MOVE IT FORWARD. GEARS ARE BROKEN. I CANNOT REACH THE PEDALS AND MY SEVENTH SEAT IS STOWED! I CANNOT GET MY SEAT BACK. 4. ON PASSENGER SIDE A PART BELOW DASHBOARD (I THINK IS RELATED TO HEATING AND COOLING) FELL OFF. MY FLOOR IS NOW WET EVEN AFTER REATTACHING IT. 5. LIGHT GALORE! MY VEHICLE ROTATES BETWEEN CHECK ENGINE, AND SERVICE TIRE SYSTEM WARNINGS. I'VE HAD IT CHECKED BY SEVERAL MECHANICS AND ALL SAY IT'S ELECTRICAL. *TR

Mileage: 96,000

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. WHEN THE FRONT DRIVER SIDE DOOR WAS LOCKED WITH EITHER THE KEY FOB OR MANUALLY, AN ABNORMAL NOISE EMITTED FROM THE DOOR PANEL. WHEN UNLOCKING THE DOOR FROM THE OUTSIDE, THE DOOR FAILED TO UNLOCK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 10,000. UPDATED 02/02/15*LJ UPDATED 6/8/2015 *JS

Mileage: 10,000

THE INTERIOR IN THE FRONT OF THE VEHICLE WENT OUT. WHEN I TOOK IT OUT TO REPLACE IT, AND IT WAS MELTED ON ONE SIDE. THAT HAPPENED TO ME WITH THE OTHER SIDE OF THE FRONT INTERIOR LIGHTS, AROUND 2011 AND WHEN I WENT TO THE DEALERSHIP I WAS TOLD I WOULD HAVE TO BUY THE WHOLE ASSEMBLY AT A COST OF ABOUT $150.00 I THINK. I ASKED THEN IF THERE HAD BEEN A RECALL ON THIS AND WAS TOLD NO. I ASKED WHAT WOULD CAUSE THE LIGHT TO MELT AND HE SAID HE DID NOT KNOW. I LEFT IT AS I STILL HAD THE ONE ON THE DRIVERS SIDE BUT NOW I DO NOT HAVE EITHER AND THERE ISN'T ANY LIGHT IN THE FRONT OF THE CAR WHEN OPENING THE DRIVERS OR FRONT PASSENGER DOOR. PLEASE ADVISE ME IF THIS HAS BEEN A PROBLEM AND OR WHAT CAN I DO ABOUT IT. *JS

Mileage: 86,538

VEHICLE SHUT OFF WHILE DRIVING ON INTERSTATE AT 48MPH AND INCREASING. FIRST ALL DIALS DROPPED TO 0, BRAKES WOULD NOT WORK, WHEN PRESSING ACCELERATOR ENGINE WOULD REV UP BUT NO POWER - THEN THIS STOPPED ALSO. TURNED KEY TO OFF POSITION AND WAITED A FEW MINUTES, THEN TURNED CAR BACK ON AND ALL SEEMED WELL. THIS WAS VERY SCARY WITH CARS & TRUCKS WHIPPING BY AT 50 PLUS MPH! *TR

Mileage: 98,007

25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THIS FAILURE OCCURRED TWICE AFTER THE VEHICLE WAS FILED WITH FUEL. THE VEHICLE WAS TAKEN TO THE INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING, HOWEVER THEY COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. RG *TR

Mileage: 88,000

ON THREE SEPARATE OCCASIONS WHEN DRIVING THE CAR, THE IGNITION KEY SUDDENLY SHUT OFF THE ENGINE CAUSING DIFFICULTY WITH STEERING AS WELL. THIS WAS CHECKED BY THE DEALERSHIP WHO COULD FIND NO REASON FOR THE ACTION. *TR

TL-THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 15 MPH, THE ENGINE STALLED WITHOUT ANY WARNING. THE ENGINE RESTARTED AND RESUMED NORMALLY. THE FAILURE RECURRED TWO MOMENTS LATER. THE MALFUNCTION ONLY OCCURRED AFTER REFUELING. THE VEHICLE WAS CURRENTLY BEING REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILAGE WAS 81,000. JS

Mileage: 81,000

THE POWER LOCKS HAVE QUIT WORKING ON THE REAR SLIDING DOORS WHERE MY CHILDREN SIT. NO WAY TO UNLOCK DOORS FROM OUTSIDE TO REMOVE CHILDREN IN CASE OF ACCIDENT. THE DOORS WILL NOT OPEN FROM THE INSIDE UNLESS MANUALLY PULLED UP. THIS IS A VERY VERY COMMON PROBLEM WITH DODGE. ONLY ONE MANUAL KEY HOLE TO UNLOCK VAN ON DRIVERS DOOR. THIS IS VERY DANGEROUS FOR PASSENGERS ESPECIALLY CHILDREN. *TR

Mileage: 59,203

HEAD LIGHTS STOPPED WORKING. NOT SIMPLE BULB REPLACEMENT, MAJOR ELECTRICAL PROBLEM IN POWER DISTRIBUTION SYSTEM. *TR

Mileage: 87,000

INTERIOR DOME LIGHTS STOPPED WORKING. NOW, THE "MALFUNCTION LIGHT" IS LIT UP ON THE DASHBOARD AT 38,000 MILES. *TR

Mileage: 35,000

TL* THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. THE CONTACT ATTEMPTED TO START THE IGNITION THREE TIMES AND THE ENGINE IMMEDIATELY STALLED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE VEHICLE CONTINUED TO REMAIN AT THE DEALER FOR FURTHER INVESTIGATION WHERE THE CONTACT WAS AWAITING A DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS ALSO NOTIFIED OF THE PROBLEM. IN ADDITION, THE WIRING TO THE DOME LIGHT WAS FAULTY WHICH CAUSED THE DOME LIGHT TO MELT TWO YEARS PRIOR TO THE MOST RECENT FAILURE. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. ....UPDATED 08-24-12 *BF THE CONSUMER STATED WHEN THE VEHICLE'S ENGINE TURNED OFF THE INSTRUMENT CLUSTER REMAINED ILLUMINATED. THE RADIO SWITCHES STATIONS, TURNS ON THE CD PLAYER, AND SWITCHES BETWEEN AM/FM. THE DEALERSHIP ACKNOWLEDGED THERE IS AN ELECTRICAL PROBLEM BUT, CANNOT FIND THE PROBLEM. UPDATED 08/30/2012 *JS

Mileage: 50,000

AIRBAG WARNING LIGHT CAME ON AND TOOK IT TO THE DEALER. THE DEALER STATED THAT THE FRONT IMPACT SENSORS WENT BAD BECAUSE THE WIRE HARNESS CORRODED AND CAUSED THE OPEN CIRCUIT, CAUSING THE AIRBAG WARNING LIGHT TO COME ON CAUSING DAMAGE TO THE COMPONENTS. *TR

Mileage: 89,828

I TURNED THE IGNITION ON, PUT THE CAR IN REVERSE AND BACKED OUT OF A PARKING SPACE. I PUSHED ON THE BRAKES AND PUT THE CAR IN DRIVE. THE CAR BEGAN MOVING FORWARD FOR ABOUT 10 SECONDS AND THEN IT LOST ALL POWER WITH NO WARNING, JUST STALLED. THE CAR'S HEAT SENSOR GAUGE WAS NORMAL JUST BELOW HALFWAY AND I HAD A HALF TANK OF GAS. THERE WERE NO WARNING LIGHTS ON THE DASHBOARD PRIOR TO THE INCIDENT. IT DIDN'T FEEL LIKE THE BRAKES WERE WORKING EITHER. I PUT THE CAR IN PARK AND THEN STARTED IT UP AGAIN WITH NO PROBLEMS. IT DROVE TO MY DESTINATION WITHOUT ANY FURTHER PROBLEMS.

Mileage: 44,638

TL*THE CONTACT OWNS A 2007 DODGE CARAVAN. THE CONTACT STATED THAT THE POWER LOCKS HAVE MALFUNCTIONED. THE CONTACT STATED THAT THE KEYLESS ENTRY NOR THE MAIN POWER LOCK ON THE DRIVERS SIDE DOOR DOES NOT LOCK ALL OF THE DOORS. THE CONTACT HAD TO MANUALLY LOCK EACH DOOR. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO STATED THAT THE LOCKS ARE NOT COVERED BY THE WARRANTY; HOWEVER, THE CONTACT WAS RESPONSIBLE FOR THE REPAIR COST. THE CONTACT STATED THAT THE FAILURE WAS ON GOING PROBLEM WITH HIS YEAR, MAKE. AND MODEL. THE CONTACT WAS CONCERNED THAT THERE WAS NO RELATED RECALL. THE FAILURE MILEAGE WAS 62,000. UPDATED 04/06/11*LJ UPDATED 5/2/11 *CN UPDATED 05/11/11

Mileage: 62,000

AIR BAG LIGHT CAME ON AND WILL NOT GO OFF. PER OWNERS MANUAL AND OTHER SOURCES - THIS IS A FAILURE OF THE AIRBAG SENSOR. CAUSE IS LEAKAGE INTO THE SENSOR FROM ROAD SALT AND OR WATER. AIR BAG IS POSSIBLY IN A NON-WORKING CONDITION - THUS LEAVING THE POTENTIAL FOR BODILY HARM IF A CRASH SHOULD OCCUR. MANUFACTURER IS NOT OFFERING A FIX AT THIS TIME, AND ACTUALLY DENIES ANY PROBLEMS WITH SAID DEVICES.

Mileage: 72,000

THE HEADLIGHTS INTERMITTENTLY SHUTOFF OR WILL NOT TURN ON WHILE DRIVING. I HAVE REPLACED THE BULBS, CHECKED FOR A LOOSE CONNECTIONS, AND CHECKED THE FUSES MANY TIMES. THIS IS OKAY DURING THE DAY, HOWEVER I LIVE OUT IN THE COUNTRY 15 MINUTES FROM THE NEAREST TOWN. I CANNOT DRIVE AT NIGHT WITHOUT HEADLIGHTS OR WITH THE POSSIBILITY THAT THEY WILL SHUTOFF WHILE DRIVING. THIS IS EXTREMELY DANGEROUS. I HAVE BEEN LUCKY SO FAR THAT NOTHING SERIOUS HAS HAPPENED BUT THIS IS A PROBLEM THAT MUST BE FIXED! MY WIFE AND 7 MONTH OLD CHILD USE THIS VEHICLE THE MOST AND I CAN'T FATHOM THE IDEA OF THEM BEING INJURED DUE TO THIS PROBLEM. OTHERS HAVE SUGGESTED A FAULTY HEADLIGHT SWITCH. I HAVE NOT HAD THE TIME TO TAKE THE VEHICLE IN TO THE DEALERSHIP TO HAVE IT INSPECTED. *TR

Mileage: 62,000

ON SEPTEMBER 15, 2010 THE REAR PASSENGER DOOR TO MY 2007 DODGE GRAND CARAVAN CAUGHT FIRE 1 FOOT FROM MY 2 YEAR OLD DAUGHTER WHO WAS STRAPPED IN A 5 POINT HARNESS CAR SEAT. I PICKED MY SON UP FROM SCHOOL AT APPROXIMATELY 5:45, WITH MY DAUGHTER IN TOW. I OPERATED THE REAR PASSENGER DOOR TO PUT HER BACK INTO HER SEAT AFTER SIGNING OUT MY SON WITH NO ISSUE. I NOTICED NOTHING WRONG WITH THE DOOR. I DROVE APPROXIMATELY 1 MILE TO MY HOUSE. HALFWAY HOME I SMELLED SOMETHING AND WHEN I PULLED INTO THE DRIVEWAY, I SAW SMOKE COMING FROM AN UNKNOWN SOURCE. I THOUGHT IT WAS MY AIR CONDITIONING UNIT AND BY TURNING THE CAR OFF I WOULD SOLVE THE PROBLEM OF THE SMOKE. I TRIED TO OPERATE THE AUTOMATIC DOORS FOR MY REAR PASSENGER DOORS BUT THEY DIDN'T WORK. I WAS ABLE TO MANUALLY OPEN MY REAR DRIVER'S SIDE DOOR BUT WAS NOT ABLE TO OPEN THE REAR PASSENGER DOOR NO MATTER HOW HARD I PULLED. I HAD NO IDEA THAT DOOR WAS ON FIRE AT THAT POINT. I NOTICED NOTHING WRONG WITH THE DOOR OTHER THAN IT WOULDN'T OPEN. I HAD TO CLIMB INTO THE BACK THROUGH THE OTHER SIDE TO GET MY DAUGHTER. I WENT IN TO THE HOUSE, STILL THINKING THAT EVERYTHING WOULD STOP SMOKING ONCE THE CAR COOLED DOWN AND LET MY DOG OUT IN THE BACK YARD. I CAME BACK AROUND TO THE FRONT OF THE HOUSE AFTER 5 MINUTES. I SAW GRAY SMOKE BILLOWING OUT OF THE REAR DRIVERS SIDE DOOR I HAD LEFT OPEN TO AIR OUT THE CAR. I WALKED AROUND TO THE PASSENGER'S SIDE AND I SAW THE PAINT BUBBLING AND MELTING AND LITTLE FLAMES LICKING THE GLASS OF THE DOOR. AT THAT POINT I CALLED THE FIRE DEPARTMENT AND MY NEIGHBOR TOOK THE HOSE TO THE CAR TO PUT OUT THE EXTERNAL FIRE. THE FIRE DEPARTMENT CAME IN 5 MINUTES AND PUT OUT THE FIRE IN THE DOOR. THEY GAVE ME THE BURNED PIECE AND SAID THEY BELIEVED THAT THE FIRE STARTED IN THE MOTOR FOR THE AUTOMATIC DOOR. I CALLED IN A COMPLAINT TO CHRYSLER/DODGE. MY REFERENCE NUMBER IS 19962230 WITH THEM. UPDATED 10/05/10 *BF PICTURES RECEIVED UPDATED 10/07/10 UPDATED 10/21/10*JB *TR

Mileage: 51,000

TL*THE CONTACT OWNS A 2007 DODGE GRAND CARAVAN. FROM SEPTEMBER OF 2007 UNTIL MAY OF 2008, THE VEHICLE WAS TAKEN TO THE DEALER THREE TIMES FOR TRANSMISSION FAILURE. WHILE ATTEMPTING TO ACCELERATE FROM A RED LIGHT, THE TRANSMISSION FEELS AS IF IT WILL DROP TO THE GROUND WHEN SHIFTING FROM FIRST TO SECOND GEAR. ON MAY 14, 2008, THE TRANSMISSION WAS FINALLY REPAIRED UNDER WARRANTY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BECAUSE PAINT WAS PEELING FROM THE REAR PASSENGER SIDE QUARTER PANEL. THE DEALER STATED THAT TAR ADHERED TO THE PAINT; THEREFORE, THEY WASHED THE QUARTER PANEL AND SCRAPED OFF THE PAINT. WHEN THE VEHICLE AND HEADLIGHTS ARE TURNED OFF, THE INSTRUMENT PANEL LIGHTS, FOG LIGHTS, AND HEADLIGHTS WOULD REMAIN ILLUMINATED, EVEN THOUGH THE SWITCH WAS IN THE OFF POSITION. WHILE THE VEHICLE WAS PARKED, THE EXTERIOR LIGHTS WOULD ILLUMINATE AUTOMATICALLY, WHICH DRAINED THE BATTERY. THE DEALER STATED THAT THE HEADLAMP SWITCH SHORTED OUT. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT STATED THAT THE SWITCH ON THE PANEL TO SHUT THE VEHICLE DOORS DID NOT WORK FOR TWO DAYS. IT HAS BEGUN TO WORK AGAIN, BUT THE CONTACT BELIEVES IT IS ONLY A MATTER OF TIME BEFORE THE SWITCH FAILS AGAIN. THE CURRENT MILEAGE WAS 7,000 AND FAILURE MILEAGE WAS 2,500. UPDATED 07/10/08. *LJ UPDATED

Mileage: 2,500

WHEN SLOWING DOWN AFTER DRIVING IN OVERDRIVE AND PRIOR TO ENGINE REACHING NORMAL OPERATING TEMPERATURE ALL LIGHTS (HEAD, TAIL, DASH, DOME, ETC) DIM TO A NEARLY OFF BRIGHTNESS AND COME RIGHT BACK TO NORMAL BRIGHTNESS AT THE 3/2 DOWN SHIFT. THIS HAS OCCURRED SINCE THE VEHICLE WAS NEW AND THE DEALER ADVISES THAT EVERYTHING IS WORKING AS DESIGNED. I DON'T THINK CHRYSLER DESIGNED THE LIGHTS TO FLASH OFF AND ON WHEN SLOWING DOWN. ALSO, AT 7 MONTHS (15696 MILES) THE BATTERY FAILED AND HAD TO BE REPLACED. *TR

Mileage: 15,000

WHEN SLOWING DOWN AFTER DRIVING IN OVERDRIVE AND PRIOR TO ENGINE REACHING NORMAL OPERATING TEMPERATURE ALL LIGHTS (HEAD, TAIL, DASH, DOME, ETC) DIM TO A NEARLY OFF BRIGHTNESS AND COME RIGHT BACK TO NORMAL BRIGHTNESS AT THE 3/2 DOWN SHIFT. THIS HAS OCCURRED SINCE THE VEHICLE WAS NEW AND THE DEALER ADVISES THAT EVERYTHING IS WORKING AS DESIGNED. I DON'T THINK CHRYSLER DESIGNED THE LIGHTS TO FLASH OFF AND ON WHEN SLOWING DOWN. ALSO, AT 7 MONTHS (15696 MILES) THE BATTERY FAILED AND HAD TO BE REPLACED. *TR

Mileage: 15,000

WHEN SLOWING DOWN AFTER DRIVING IN OVERDRIVE AND PRIOR TO ENGINE REACHING NORMAL OPERATING TEMPERATURE ALL LIGHTS (HEAD, TAIL, DASH, DOME, ETC) DIM TO A NEARLY OFF BRIGHTNESS AND COME RIGHT BACK TO NORMAL BRIGHTNESS AT THE 3/2 DOWN SHIFT. THIS HAS OCCURRED SINCE THE VEHICLE WAS NEW AND THE DEALER ADVISES THAT EVERYTHING IS WORKING AS DESIGNED. I DON'T THINK CHRYSLER DESIGNED THE LIGHTS TO FLASH OFF AND ON WHEN SLOWING DOWN. ALSO, AT 7 MONTHS (15696 MILES) THE BATTERY FAILED AND HAD TO BE REPLACED. *TR

Mileage: 15,000

ON 8/22/07 I PURCHASED A 2007 DODGE GRAND CARAVAN FROM ED NAPLETON DODGE IN OAKLAWN, ILLINOIS. ON 10/5/07 WHILE DRIVING MY VEHICLE, IT OVERHEATED AND THE STEERING WENT OUT OF CONTROL CAUSING THE VEHICLE TO BE HARD TO STEER. LOOKING UNDER THE HOOD THE ALTERNATOR BELT WAS IN SHREDS. IT WAS LEARNED THAT THE POWER STEERING PUMP WENT OUT. *JB

Mileage: 2,138

WE PURCHASED AN 07' DODGE GRAND CARAVAN JUNE 07 AND HAVE HAD NOTHING BUT PROBLEMS W/ IT SINCE SHORTLY AFTER THE PURCHASE. IT HAS BEEN IN THE SHOP TWICE FOR THE SAME ISSUE AND IS CONTINUING TO HAVE THE PROBLEM. WHEN WE HAD IT IN THE LAST TIME WE WERE TOLD CHRYSLER WAS WORKING ON THE PROBLEM AND WOULD HAVE SOMETHING DURING THE MONTH OF AUGUST ... WELL I PHONED SEPT 11 12:15 PM AND WAS TOLD AT THAT TIME THEY STILL HAD HEARD NOTHING IN REGARDS TO THE ISSUE. IT STARTED OUT THAT THE VAN WOULD NOT SHIFT INTO GEAR WHEN COMING TO A STOP ... FEELS LIKE THE TRANSMISSION IS GOING TO DROP OUT AT TIMES. IT THEN MOVED TO DOING THIS WHILE IN MOTION AS WELL ... THE DEALER ASSURED US THAT NOTHING IS GOING TO HAPPEN IT IS A COMPUTER PROBLEM THAT CHRYSLER IS WORKING ON. THERE ARE OTHER KNOWN CUSTOMERS W/ THE SAME PROBLEM. WHEN WE HAD IT IN THE SHOP THE FIRST TIME A DX WAS RAN ON THE COMPUTER TO RESET EVERYTHING ... DIDN'T HELP AT ALL. HAD IT BACK IN A WEEK LATER FOR 9+DAYS AND AT THAT TIME THEY DROPPED THE TRANSMISSION OUT AND REPLACED THE CLUTCHES AND SOMETHING ELSE TOO. AS SOON AS WE DROVE IT OFF THE LOT IT WAS BACK TO SQUARE ONE. MY KEY HAS GOTTEN STUCK IN THE IGNITION ONCE SO FAR ... DIDN'T TAKE IT IN BUT DID PHONE TO LET THEM KNOW ABOUT THE ISSUE. THAT HAPPENED DURING THE MONTH OF JULY .... NOW MY BACK AUTOMATIC DOORS WILL NOT OPEN FROM THE INSIDE SWITCH LOCATED NEAR THE DOORS, AND MY PASSENGER SIDE WINDOW WAS ROLLED DOWN YESTERDAY (09/15/07) AND DIDN'T WANT TO GO BACK UP. I DID FINALLY GET IT UP BUT SCARED TO TRY AND ROLL IT DOWN AGAIN. *JB