2015 DODGE GRAND CARAVAN Electrical System Problems

Cracking front windshield (temporarily fixed by clear tape), broken window regulator motors on both passenger and driver sides stop lifting the glasses up and down, passenger side plastic window part (vertically snapped on the upper part of passenger door) fell off, engine light sometimes on and off with unknown detected problems.

Went to roll down the window on the drivers side panel and it started to smoke and short circuit. We removed the panel because we believed of could have caught fire. Problem has not been replicated due to dealership service department being closed. There were no warning lamps or messages and had occured randomly when using the panel.

The contact owns a 2015 Dodge Grand Caravan. The contact stated that whenever the passenger’s side sliding door was opened by the fob or from inside the vehicle, there was an abnormally loud clicking sound heard. The contact stated that while inspecting the door, the contact became aware that the door had failed to close securely. The contact released the child safety lock on the door enabling the door to be locked securely; however, the clicking sound remained. The vehicle was taken to the dealer but was not diagnosed. The vehicle was not repaired. The manufacturer was made aware of the failure, and confirmed that the VIN was not under recall or Warranty. The failure mileage was 149,992.

Mileage: 149,992

There are multiple whirring and clicking noises in the walls of the cargo area, mostly in passenger side. This happens when I lock/unlock the auto, and close the doors. I also hear what sounds like a moan coming from the dash, at least 2-3 times after I've closed and locked it, from the inside. I just purchased it used, with around 98k miles on it.

The driver side passenger sliding door lock actuator is frozen, keeping the door perpetually locked. The passenger sliding door actuator will not lock at all, so the passenger sliding door is perpetually unlocked. I've been told by an auto mechanic that the passenger side sliding door is in danger of permanently locking as well. If that's the case, passengers will have to enter by the front doors (or the back hatch, which is too inconvenient). In the case of an accident, I'm concerned that exiting the vehicle will be dangerous for backseat passengers. I understand that there's an extended warranty for the 2015 Dodge Grand Caravan lock actuators, but the extended warranty only includes those manufactured after May 1, 2015. My 2015 Dodge Grand Caravan was manufactured February 2015. My family budget is really tight, and the prospect of putting $1500 to $2000 down for repairs to these doors is cost prohibitive. The doors are available for inspection. The vehicle has been inspected by a local auto service center mechanic and the actuators were confirmed as the problem by the service center. There was no warning of failure of the actuators beforehand.

I was driving on the highway and the car just turned off. this happened a few times.

The car was Driving and the blind spot module on the driver's side in the rear bumper started to smoked, because of a short in the electrical from water damage

I am inquiring about the failure of my 2015 Dodge Grand Caravan Sliding Door Power Lock Actuator. My Drivers Side passenger sliding door recently became stuck, and could not be opened from the outside or inside. This is a massive safety hazard, and could possible result in death or injury. What if there was a fire or an accident and we had to get out. There is a service bulletin 23-036.21 that covers replacing the actuators for this very reason, but my vehicle is not listed. This is a problem. Now with the door in lock position, everytime the automatic or power door lock is used, there is a really loud buzzing sound. My worry is that the door will actually come unlocked, and open on its own as i am driving down the highway, so it is a little unnerving. I want to get this fixed for our safety, but i want to know if this will be covered under the service bulletin 23-036.21, per the NHTSA this seems to be affecting more than just the 2016 RT models, and while i love our vehicle, I am now worried for my families safety.

Buzzing in side door when unlocking

transmission went totally out, sliding door makes loud buzzing noise when unlocking and locking air bag light on dash wont go off

When drive over 60mph I smell burn from front hood. I took to Dodge dealership. They said oil leaking so paid $950 , 3 weeks later car broke down like can't go over 30mph, Aqcell won't go up , I took to dealership again , he said transmission I paid $4600( October) it used transmission. After change transmission drive was uncomfortable, not smoothly like before. I took dealership he said It because differen transmission, so need takes a while to get use to it. (Idk it true or not) And engine light on over 7 times and still burning smell if drive over 60mph. Dealership kepts 3 days but they said car is fine. Im like how heck fine? If I drive 60mph now I can smell burn . Feel very uncomfortable to drive i have 3 kids always with me but can't sell car with this conditions . Any advice appreciate

Passenger sliding door faulty actuator. Five months after purchasing the car the door started buzzing every time it is unlocked.

The passenger driver-side slide door is permanently lock and will not unlock. Door will not slide open at all. I believe the manufacture door lock actuator is the problem. The vehicle's ODM only have 36,000 miles on the it. Since the door can't be open, it is a safety issue for any passengers riding in the car. Safety issues that will put my two kids at risk since the passenger door can't be open when there is an emergency to exit the car. My two kids are the passengers in the van. As of now, I don't have the money necessary to take it to a mechanic to fix it. However, I search on the internet and found out a lot of other car owners with the same model Dodge Caravan are having the same issues with door being lock permanently. The problem just occurred without any warning. It happen about 2 months ago without any warning and the slide door will not slide open again. Please help us get the manufacturer to fix this problem. I saw today that NHTSA might be looking into this issue so that why I finally file this complain. You can email me with any questions at [XXX]. Thank you. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2015 Dodge Caravan. The contact stated while driving at an undisclosed speed, the back over prevention camera flickered on and off. Additionally, the check engine warning light remained illuminated. The contact stated that after shifting the vehicle into park and turning the ignition to the off position, the engine and electrical functions remained in operation. The contact took the vehicle to the local dealer to be diagnosed however, the mechanic was unable to duplicate the failure. The contact took the vehicle to an independent mechanic who was able diagnosed the failure as TIPM had dropped the signal causing the electrical failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximate mileage 99,000.

Mileage: 99,000

The contact owns a 2015 Dodge Caravan. The contact stated while driving at an undisclosed speed, the back over prevention camera flickered on and off. Additionally, the check engine warning light remained illuminated. The contact stated that after shifting the vehicle into park and turning the ignition to the off position, the engine and electrical functions remained in operation. The contact took the vehicle to the local dealer to be diagnosed however, the mechanic was unable to duplicate the failure. The contact took the vehicle to an independent mechanic who was able diagnosed the failure as TIPM had dropped the signal causing the electrical failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximate mileage 99,000.

Mileage: 99,000

I JUST MADE THIS SAME REPORT BUT WITH MY SON'S DODGE 06 VIN NUMBER. IGNORE THAT REPORT!! FOR MY DODGE 2015 DODGE GRAND CARAVAN HERE IS MY REPORT: PASSENGER SIDE AIR BAG EXPLODED. LUCKILY NO INJURY. VEHICLE WAS NOT MOVING. I DIDN'T EVEN KNOW IT COULD DO THAT! I'D LIKE THIS FIXED. ALSO, TWO LEAKS IN ENGINE. OIL LEAK/TRANSMISSION LEAK. IS THIS NORMAL? LEAKS ARE ONGOING. ANOTHER THING: NOTICING HEADLIGHTS GETTING SLIGHTLY DIMMER, THEN BRIGHTER, AT NIGHT AS IF SOME SORT OF ELECTRICAL PROBLEM? THIS HAPPENS DURING DRIVING AND NOT DRIVING.

Mileage: 110,000

TL* THE CONTACT OWNS A 2015 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AUTOMATIC SLIDING DOOR WAS CEASED IN THE LOCKED POSITION AND WOULD NOT UNLOCK MANUALLY. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.*DT*JB

Mileage: 78,000

DOORS MAKE A LOUD BUZZING SOUND WHEN LOCKING OR UNLOCKING. THIS SEEMS TO BE A PROBLEM WITH THESE VEHICLES. WAS ADVISED TO MAKE A COMPLAINT.

Mileage: 85,000

EVERY TIME THE DOORS ARE UNLOCKED THE VAN MAKES A WEIRD LOUD BUZZING NOISE.

THE PASSENGER SLIDING DOOR WILL NOT OPEN. BEFORE THE THE DOOR BECAME UNABLE TO OPEN A PERSISTENT SOUND WAS MADE WHEN THE POWER LOCKS WERE LOCKED AND UNLOCKED.

ONLY HEAT FROM PASSENGER VENTS WHEN AC IS TURNED ON IN THE SPRING. *TR

Mileage: 31,000

THE ELECTRIC CONTROLS ARE GOING HAYWIRE WHEN VAN IS TURNED ON NOTHING WILL FUNCTION THAN THE REAR DEFROSTER COMES ON NOTHING ELSE WORKS THEN THE AIR COMES ON AND COOL AIR ON DRIVERS SIDE HEAT ON PASSENGER SIDE THEN SOME COOL THEN HEAT AND I HAVE A LIGHTING BOLT SIMBLE ON THE DASH AND VAN WAS HIT HEAD ON WHILE PARK AND THE AIR BAGS DID NOT DEPLOY

Mileage: 54,800

VEHICLE, STATIONARY, CAR DOES NOT START ON THE FIRST TRY IF IT SITS FOR OVER 4 HOURS. CRANKS THEN STALLS, OR CRANKS OVER AND OVER UNTIL EVENTUALLY CATCHING. NEW: CAR BATTERY, BATTERY TENDER/CHARGER, NEW/UPGRADED SPARK PLUGS, NEW/UPGRADED IGNITION COILS. APPEARS TO BE TIPM FAILING. HAS BEEN GETTING PROGRESSIVELY WORSE OVER THE PAST FEW WEEKS.

Mileage: 29,000

DRIVER'S SIDE DOOR TAKES TIME TO OPEN. 30 TO 45 SECONDS APPROXIMATELY TO OPEN. HAPPENS VERY OFTEN. AFRAID IT MAY STOP FUNCTIONING COMPLETELY. THE SLIDING DOORS (BOTH) OPEN ON THEIR OWN. HAVE FOUND SLIDING DOORS AND CARGO DOOR OPEN. THIS HAPPENS RANDOMLY, SOME DAYS IT MAY NOT OCCUR, BUT AFRAID TO LEAVE CAR IN THE STREET. HAVE TRIED TO SOLVE THIS ISSUE BY LOCKING DOORS MANUALLY WITH DOOR LOCK ON DRIVER'S DOOR PANEL, HOWEVER IT IS STILL MALFUNCTIONING. THE ISSUES OCCURS WHEN THE VEHICLE IS PARKED. BOUGHT THE VEHICLE IN OCTOBER 2019, HAS BEEN HAPPENING SINCE A MONTH AFTER PURCHASE ON AND OFF.

Mileage: 58,000

ON THREE SEPARATE OCCASIONS DURING DECEMBER 3019 AND JANUARY 2020 WHILE DRIVING THE VEHICLE SHUTS OFF, NO WARNING LIGHTS BEFORE IT HAPPENS OR AFTER. LOSE OF POWER AND LOSS OF BRAKING. THIS HAS HAPPEN ON THE HIGHWAY AND ON MAIN ROADS. THERE WAS A RECALL UP TO THE 2010 MODEL FOR THIS SAME REASON WHICH CONTRIBUTED TO THE IGNITION AND FOB AND TIPM. IT APPEARS DODGE HAS NOT CORRECTED THIS HAZARD. TOOK THE VEHICLE TO THE DEALERSHIP AND THEY CAN NOT DIAGNOSIS THE ISSUE. THIS ISSUE IS GOING TO GET SOMEONE SERIOUSLY INJURED OR KILLED.

Mileage: 65,000

MY CAR IS REGULARLY MAINTENANCED BY YOUR DEALERSHIP I ALSO HAVE A MAINTENANCE PLAN THAT I PURCHASED THAT YOUR DEALER REFUSED TO HONOR. I PURCHASED MY CAR FROM DODGE DEALERSHIP ON REISTERSTOWN ROAD IN OWINGS MILLS MD 21117 IN MARCH 2015 APPROXIMATELY LESS THAN 24 MONTHS I BEGAN HAVING TROUBLE WITH MY TIRES AND WAS INFORMED BY DODGE THAT MY VEHICLE WAS USED AND NOT BRAND NEW AS I WAS EXPECTING WHEN I PURCHASED IT FOR 30,0000. LESS THAN 48 YEARS MY ENGINE GAVE UP AND HAS TO BE BUILT FROM SCRATCH PUTTING MY CAR VALUE DOWN AND LEAVING ME AND MY KIDS STRANDED FOR THE HOLIDAYS AND MY GPS STOPPED WORKING COMPLETELY AND NOW I NEED 4 NEW TIRES AGAIN. YOUR DEALERSHIP SOLD ME USED TIRES AND I CONTACTED TIRE MANUFACTURER AND THEY SAID YOU NEED TO REPLACE TIRES THROUGH WARRANTY BUT YOU REFUSE TO DO IT. ALL YOU HAVE TO DO IS FILE A CLAIM BECAUSE YOKOHAMA TIRE MANUFACTURER SAID TIRES SHOULD LAST 50-60K MILES MINE ONLY LAST 30K I PURCHASED NEW BUT YOU GAVE ME USED HOW DOES THIS HAPPEN ON A BRAND NEW CAR? I TOOK MY CAR BACK TO THE DEALER FOR REPAIRS BUT, TO DATE, THE DEALER HAS BEEN UNABLE TO CORRECT THE PROBLEM. THIS PROBLEM SUBSTANTIALLY IMPAIRS BOTH THE USE AND VALUE OF MY CAR. THEREFORE, IF YOU AND/OR YOUR DEALER ARE UNABLE TO CORRECT THIS PROBLEM IN A "REASONABLE NUMBER OF ATTEMPTS" AS THAT PHRASE IS DEFINED IN MARYLAND'S AUTOMOTIVE WARRANTY ENFORCEMENT ACT (MD. CODE ANN., COM. LAW II, 14-1502 (D) ), I WILL EXPECT YOU TO [REPURCHASE OR REPLACE] THE VEHICLE PURSUANT TO 14-1502(C) OF THE ACT. TO RESOLVE THE PROBLEM, I WOULD APPRECIATE MY CAR REPLACED BY A BRAND NEW VEHICLE COMPARABLE TO THE ONE I HAVE NOW OR THE DEALERSHIP TO REPURCHASE MY CAR. THIS CAR HAS BEEN UNRELIABLE AND UNSAFE FOR ME AND MY 4 KIDS. I LOOK FORWARD TO YOUR REPLY AND A RESOLUTION TO MY PROBLEM

Mileage: 53,000

2015 DODGE CARAVAN - PASSENGER SLIDING DOOR STARTED MAKING A CLICKING NOISE WHEN LOCKING OR UNLOCKING THE DOORS.

Mileage: 62,000

NEED A RECALL ISSUED! 2015 DODGE GRAND CARAVAN WITH SLIDING DOOR ISSUES. LOCK MAKES LOUD NOISE WHEN TRYING TO UNLOCK. SOMETIMES IT WILL NOT UNLOCK OR LOCK, CAUSING THE DOOR TO WORK INCORRECTLY. THIS IS A SAFETY ISSUE THAT MULTIPLE PEOPLE HAVE ENCOUNTERED. THERE IS SHOULD BE A RECALL ON THIS LOCKING MECHANISM.

FOR ABOUT A MONTH THE VAN'S LOCK SYSTEM TO THE DOORS WOULD MAKE A BUZZING NOISE WHEN YOU UNLOCK OR LOCK THEM. SINCE FRIDAY, AUGUST 9TH 2019, THE BACK SLIDING DOOR ON THE DRIVER'S SIDE WILL NOT UNLOCK. THIS COULD CAUSE A HAZARD TO SOMEONE IN THE BACK, THAT NEEDED TO GET OUT OF VAN IN CASE OF AN EMERGENCY. THIS HAPPENS WHEN THE VAN IS STOPPED, OF COURSE I WOULD NOT TRY OPENING IT, IF VEHICLE WAS MOVING. THIS SHOULD BE AN AUTOMATIC FIX FROM THE SERVICE DEPARTMENT, BECAUSE OF SAFETY DUE TO PASSENGERS. THANK YOU!

Mileage: 96,000

ON 9-22-2018. MY 2015 DODGE GRAND CARAVAN DRIVERS REAR SLIDING DOOR CLOSED LIKE NORMAL. THEN WHEN I TRYED UNLOCKING AND OPENING THE DOOR WOULD DO ANYTHING THE LOCK MECHANISM ON IT DOESN'T DO ANYTHING TRYED MANUALLY UNLOCKING IT WOULDN'T UNLOCK. THE DOOR JUST WILL NOT OPEN...IT WAS STATIONARY IN PARK.

Mileage: 37,132

TL* THE CONTACT OWNS A 2015 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE PASSENGER SIDE SLIDING DOOR DID NOT OPEN MANUALLY OR ELECTRONICALLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED CLEAR LAKE CHRYSLER JEEP DODGE AT 281-481-1000 (15711 GULF HWY, WEBSTER, TX 77598) AND WAS INFORMED THAT THE ACTUATOR MAY NEED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 71,500.

Mileage: 71,500

TL* THE CONTACT OWNS A 2015 DODGE GRAND CARAVAN. WHILE THE VEHICLE WAS STATIONARY, THE HEATER AND DEFROSTER ON THE DRIVER'S SIDE OF THE VEHICLE FAILED. LAKESHORE CHRYSLER PLYMOUTH DODGE IN MONTAGUE, MICHIGAN WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT SUGGESTED THAT TSB: R62 REGARDING THE ACTUATOR COULD BE A POSSIBLE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 11,000. *LN UPDATED 8/30/18*JB

Mileage: 11,000

2015 DODGE GRAND CARAVAN SXT AIR CONDITIONER ONLY WORKS ON ONE SIDE OTHER SIDE BLOWS OUT HOT AIR NO MATTER WHAT COLD SETTING ITS ON ONLY ONE SIDE OF THE AIR BLOWS OUT COLD AIR AND THAT'S THE DRIVERS SIDE PASSANGER SIDE IS VERY HOT

TL* THE CONTACT OWNS A 2015 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VENT CONTROL FUNCTION FAILED TO PROPERLY RELEASE THE AIR CONDITIONING OR HEATING. WHEN THE VENT, AIR CONDITIONING, OR HEATING FUNCTION WAS ACTIVATED, STRONG FUMES EMITTED INSIDE THE VEHICLE, WHICH AFFECTED THE CONTACT WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN TWICE. THE DEALER DID NOT PROVIDE ODOR TESTING AND WAS UNABLE TO REPLICATE OR DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2015 DODGE GRAND CARAVAN. WHILE PARKED, THE VEHICLE BECAME ENGULFED IN FLAMES WITHOUT WARNING. THE CONTACT WAS NOTIFIED OF THE INCIDENT BY THE FIRE MARSHALL, WHO LATER DETERMINED THAT THE FAILURE OCCURRED DUE TO A DEFECTIVE WIRING HARNESS. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO A SALVAGE YARD AND DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 4,000.

Mileage: 4,000

ONE OF MY OUTLETS IN THE CONSOLE DOES NOT WORK AND IT IS NOT DUE TO A BLOWN FUSE. THE VAN WAS BOUGHT "NEW" WITH 13 MILES ON IT. *TR

Mileage: 13

I GOT THIS CAR ON JANUARY 17, 2015, I WAS NOT TOLD IT HAS NOT AN ALARM INCLUDED, I ASSUME THAT AS AIR CONDITIONING, ALARM WAS INCLUDED, ON FEB 19 WHILE MY CAR WAS PARKED, A THIEF BROKE THE BACK WINDOW, VANDALIZING THE CAR BODY AND STEALING MY PRESCRIPTION GLASSES. ALL PEOPLE AT WORK AND FRIENDS ASKED WHAT HAPPEN WITH THE ALARM, THEN I ASKED THE DEALER (DODGE AT 321 FRONT STREET IN TORONTO) AND AFTER HESITATIONS, THEY SAID IT HAS NOT. I FEEL CHEATED, AND TODAY I AM SURE THIS IS A FLAW OF THE CAR, OTHER ISSUES IS, THOSE VENTILATION BACK WINDOWS ARE ANOTHER BIG FLAW, BEING MANUAL IN MY CAR, THEY OPEN FROM INSIDE JUST PULLING THEM, THIS IS UNBELIEVING, SO THIS CAR HAS NOT ANY SECURITY AT ALL. I DON'T UNDERSTAND HOW THE CAR SAFETY REGULATORS ALLOW THE MANUFACTURER COME WITH A CAR WITH SUCH HUGE FLAWS. *TR UPDATED 4/14/16 *JS

Mileage: 811