2019 DODGE GRAND CARAVAN Power Train Problems

09/26/2024 Transmission had to be replaced at 47,000 miles. Without warning, the van began lurching forward at a stop light almost causing a collision and then completely stalled having to be towed to the shop. Luckily, I bought a service plan and only had to pay $100, but the parts list was $6,000+. Sliding rear doors have the electric assist option. On several occasions myself and my children have nearly been closed in the door as it malfunctions and randomly starts closing. Once I was getting my child out of the car seat when the door began closing on me, it did not stop closing as it met the resistance of my body. I have not had this issue serviced, as it is very intermittent. 10/28/2025 My driver's side headrest exploded. Thankfully no one was injured and I wasn't driving at the time. This could have caused a really dangerous situation had the vehicle been in motion. I was in the parking lot with nothing touching the headrest. Looking at the headrest there are jagged pieces of plastic that just crumbled to bits. Upon further investigation, this is a known issue with this type of vehicle, but it's not a recall. 70,000 miles. I'm waiting to see what the bill for this repair will be, but I'm concerned it is going to be replaced with the same malfunctioning equipment and I may not be so lucky next time this happens.

I have the oil changed regularly and keep all records and receipts. I've had the coolant and transmission fluid flushed, the thermostat changed twice, the coolant temperature sensor changed, the oil cooler changed and i checkmy transmission fluid regularly. My van was over heating frequently and no one could figure out why. I changed the coolant our and the temp. Sensor. It doesn't overheat now, but the heater quit working the day it was changed out. It hard shifts from 40 mph and up. Transmission fluid is good. I reset the power module by unhooking the battery for an hour. Still hard shifts . Scanner doesn't bring up any codes. 98,800 miles on it. Back sliding doors won't lock and tire sensor and radio dont work. What can I do? I cant afford a new transmission. The van was bought 2020 and for $19,000. I'm broke.

2019 Dodge Van GT when driving in about 2/3 gears(automatic trans.) was slipping and hesitating around August 2025. In July 2025 I decided to have the trans. Fluid and filter exchanged. The dealership was said it was on the schedule for it to be done. After that is when the problem started. Took back to dealership and they ran some tests and noticed the problem. The tech told me to drive it for a while that could be that the transmission needed to get use to the new fluid. It started getting worse. I took it to a transmission shop. They said the fluid was burnt and they needed to open the transmission to look closer. $1500 to check. They said they found issues. Total cost to repair/rebuild would be $6700. I thought it was a lot but it’s my main vehicle and needed it. The van has 92k miles and the transmission should not go out that soon. I’m filing a complaint because I believe the transmission should last longer than it did.

The contact owns a 2019 Dodge Grand Caravan. The contact stated that while driving at an undisclosed speed, the vehicle jerked and independently stopped. There were no warning lights illuminated. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed with rear transmission seal failure. The contact was informed that the transmission needed to be rebuilt. The vehicle was not repaired. In addition, the contact stated that the transmission was replaced in 2022, 2023, and May of 2025. The manufacturer was made aware of the failure, and a case was filed. The contact requested a buy-back; however, the request was denied. The failure mileage was approximately 67,000.

Mileage: 67,000

At 99500 the transmission went Kaputt! Repair man says metal shavings obstructed flow of fluid, through the filter, into the transmission, not allowing for running the car forward or backward. Very dangerous as we were driving down a highway when it just stopped working. Vehicle is only 6 years old. Why would this happen so soon?

Transmission had a complete failure on July 24, 2025. There were no warning signs it was operating fine until that moment. Odometer 86,948. Had van towed to my mechanics shop where he diagnosed the problem. A new factory trans was ordered and installed at a cost of $6,316.23.

My wife drove to and from a doctor's appointment. When she went to leave the vehicle did a hard jolt and would not drive anymore. There was no indication or prior warning lights about the transmission. Had it towed to a shop. Did my research and between 2016 -2018 there was a known issue with power trains on the Dodge Grand Caravan.

The contact owns a 2019 Dodge Grand Caravan. The contact stated while driving from a complete stop, the vehicle made an abnormal sound, hesitated while responding, and the transmission shifted hard. The contact stated that the failure recurred while driving at various speeds, and the vehicle felt like it was going to stall. The contact stated that while coming to a complete stop, the vehicle jerked, the transmission shifted hard and made an abnormal clunking sound. Additionally, the contact stated that the passenger's side sliding door automatic locking mechanism was inoperable, requiring the contact to manually unlock and lock the door with the interior door lever. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 120,000.

Mileage: 120,000

My van has only 88,509 miles. In the middle of a snowstorm, when I was 200 miles from home, it died. It had weird noises during the day, but the engine light had not come on at all. As I was trying to get to my mother's house in blinding snow, it simply stopped on a hill on a dark road. I was terrified. I had to rent a car to get back to NJ (which cost $100). I had my van towed to a Dodge dealership in Vestal, NY where I was quoted $9000 to replace the transmission. See attached. This problem seems to be a known issue with the 2019 Grand Caravan based on research online, and I am concerned that Dodge has not adequately addressed this major transmission defect. I rejected the $9000 repair cost and had my van towed to a small town garage and I am still waiting for them to finish it. They estimated $4000. I have not gotten my van back yet so I do not know the final diagnosis/repair cost.

The contact owns a 2019 Dodge Grand Caravan. The contact stated while driving at approximately 40 MPH, while the brake pedal was depressed the vehicle violently shuddered and stalled. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the torque converter and spark plugs needed to be replaced, and the vehicle needed a software update. The vehicle was repaired; however, the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

Mileage: 100,000

The transmission failed. Yes, it is available for inspection. My safety and the safety of others were put at risk because the vehicle lost all forward propulsion as I was pulling into busy, fast moving traffic. The vehicle is pending repair at this time. There were no warning lamps or other symptoms. There was a loud pop, the rpm's immediately skyrocketed until the rev limiter was activated, and the vehicles was immediately disabled in the middle of oncoming traffic.

10/2020 - Bought this van at Findlay Honda in Henderson, relied upon Carfax report provided by the dealer that No Manufacture Recalls Reported to Carfax. Vehicle Qualifies for the Carfax Buyback Program. [XXX] - @ around 1am I was driving at [XXX] towards [XXX] when the van lose power and was forced to parked near a safety zone. Waited out for an hour and was able to arrived home safely. 02/24/24 - Called Findlay Honda about the incident but was told it was not covered by an extended warranty. Was told to call Towbin Dodge Henderson. The van was towed by Agero Towing to Towbin Dodge for diagnosis. 02/29/24 - Towbin Dodge Henderson confirmed that the Automatic Transmission failed and must be replaced and fix for $8,100+ coz it's no longer covered by a manufacturer's warranty for driving 60,298 miles. The vehicle was not inspected by the manufacturer, police, insurance representatives. [XXX] - I noticed a dashboard warning to change oil so I went to a mechanic friend for change oil that day. Went back to mechanic on 02/21/24 because the warning for change oil still popping up. Ask to check the transmission oil and showed me the oil level is proper and color is red. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Cylinder 2 misfire code p0302. I replaced the spark plugs, coil, and injector. Code still remains. Vehicle seems to run fine.

The contact owns a 2019 Dodge Grand Caravan. The contact stated that while driving at various speeds, the vehicle failed to properly accelerate while depressing the accelerator pedal. The contact stated that the vehicle lost automotive power before the vehicle stalled. The vehicle was towed to an independent mechanic who diagnosed that the transmission was faulty and needed to be replaced. The transmission was replaced, and the vehicle was repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 260,000.

Mileage: 260,000

Transmission pump failure. Same issue as previously recalled models from 2013-2017. Transmission failed while driving. Vehicle will no longer shift. Vehicle is maintained properly and up to date on all other repairs/maintenance. Code pulled at mechanic is P1790. No response from Dodge. Any interaction is either ended by their representative disconnecting or rerouting me to a department that has no clue what to do.

I had the check engine light on for an unknown amount of time, as the initially lookover of the vehicle with the dealership advised it was a gascap sensor. However, they did attempt to fix by changing the sparkplugs when it was inspected June 2024 which didn't correct the issue. Since then, it has been looked at by 2 mechanic shops due to the following problem. When I drive at 40+ mph, the car starts shaking violently. When ran with diagnostic/ testing the engine, it was found that Cylinder 2 keeps misfiring/ has a pressure issue, even after replacing the spark plugs and the fuel injector. Even after replacing those components, the cylinder misfire , lowered compression, and the shaking while driving all still persisted. They suggested fixing the issue with replacing the entire engine and avoiding driving until then, as driving it could potentially cause the engine to stop working while driving/ cause an accident. The dealership advised the engine issue would fall under the powertrain. It is available for review, as I have avoided driving it since, due to worries that the car will either stop working while I drive it, or the engine could result in an accident.

I was driving down the road at about 40 MPH when the transmission suddenly went out, posing a safety risk to not only myself, but other drivers on the road. It went out of gear, wouldn't go back in, and luckily enough, I was on a town road and not a highway. I had my vehicle towed and a transmission repair shop confirmed the entire transmission was completely blown out, which is ridiculous for a 5-year-old vehicle. Despite having over 150,000 miles, this still shouldn't be an issue. Besides the obvious safety risks, I'm now left with an over $5,000 repair bill.

Transmission went out

Cylinder misfire #2 Is a permanent code.the first time I got it fixed the car just stopped with no warning I couldn't get it to start unless the driver door was open. The shop had it for am entire month and had a new head rebuilt 2 weeks later the light was back on. It would go off and on for the next year, we changed filters, plug, gasket. After I got it inspected last year when the light turned off for a day that was the last time it was off. I haven't been able to get it inspected yet it's over due. 2019 was 5 years ago I've never had these problems with any other vehicles that's 10+ older. They need to do something they know what's going on it happened it 2012 and they discontinued the vans in 2020. They need to make it right. The engine is not safe it randomly loosed acceleration or occasionally gains it. I'm afraid of crashing into someone or being stranded somewhere or it dying in the middle of the road. I need this vehicle I'm still paying for it and don't really have other options to for other transportation while this one gets into a shop

May 30, 2024 To whom it may concern: This is to report a very serious matter on the 2019 Dodge Grand Caravan. The vehicle vehicle has an issue with the transmission. It shifts very rough. To make it worse, when driving on bad traffic, the minivan gets stuck on one gear after several stops and goes, the transmission seems to overheating and gets stuck on one gear.

The contact owns a 2019 Dodge Grand Caravan. The contact stated while driving 55 MPH, the vehicle shifted into neutral and stalled. The RPM increased to HIGH. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the transmission needed to be replaced. The vehicle was repaired, but the failure recurred. While driving at undisclosed speeds, there was an abnormal whistling noise detected. The manufacturer was contacted and informed the contact that there was no recall coverage for the issue. The failure mileage was approximately 75,000. The VIN was not available.

Mileage: 75,000

P1790,P0868,P083B, P0736, P0733 codes. Transmission went bad. See attached invoice for more details.

Drove it one day and it was fine, then next day I went on my lunch break and it lost power, I pull in a parking lot put it park then tried to pull it in reverse and it would only go into neutral. After a couple times it have went into reverse but found out the transmission has to be replaced. Only 110,000 miles.

hard misfire and rough idle creating issues while in traffic, almost rear ended multiple times because of loss of acceleration. inspection by mechanic says misfire in cylinder 2 couldn't be fixed. (multiple coils and spark plug replacements) mechanice made contact with a GM certified mechanic who indicated this is a common problem in the 3.6 engine used in these vehicles. Issue is deep within engine and requires complete engine replacement. It was explained to me that the engine could keep going as-is, or debris could begin breaking off inside the engine and cause total loss at any time. researched and found similar issue with 2012 engines.

My engine light came on reading stated #2 misfire. I have had spark plugs, wires, coil boot intake gaskets replaced. Now #2 misfire is reading a permanent code. I need to know why this is not a recall on my van there are reports of thousands of Dodges having this happen and has become quite costly for me. I'm afraid to drive the vehicle because it could apparently cause my valves to crack and cost a large amount of money to repair I'm [XXX] very sickly, I also still make payments on the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

the vehicle has a permanent cylinder 2 misfire. the misfire has at times produced an unexpected change in the vehicle's acceleration which could be dangerous in certain traffic conditions. The vehicle has been inspected by an independent service center who determined that the source of the misfire is either a mechanical component inside the engine or part of the valve train. I have been told that this issue could result in sudden engine lockup during operation.

Complete transmission failure at 87,447 miles. All recommended maintenance completed with local Dodge dealership. Denied any warranty help due to mileage. Transmission issues are common with this vehicle but Dodge will not offer any assistance outside of limited powertrain warranty.

64398 miles, transmission failure. Complete failure in about 5 miles from first hearing a whining type noise till barely being able to move. Dealership said not covered under warranty because we are 4398 miles over.

Vehicle has been well maintained. It has 71,xxx miles. With no warning or indication of problems, we had complete transmission failure. It worked fine, we exited highway and it was noisy. Within 2 miles, the transmission was slipping (jerking van) and then totally went out (won't accelerate at all). Still no warning lights. Towed and repair center said complete transmission failure. Looking online, this has happened to multiple people in very similar fashion (no indication of issue to being undriveable within minutes). For a vehicle with 71,xxx miles and being 3 years old, this is terrible...still a substantial loan in place :(

The contact owns a 2019 Jeep Grand Caravan. The contact stated that the vehicle inadvertently downshifted and hesitated while depressing the accelerator pedal without warning. The vehicle had been taken to the dealer and the torque converter was replaced twice and the transmission software was updated; however, the failure persisted. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 20,000.

Mileage: 20,000

While driving vehicle it began to made a horrible noise and then stalled in the middle of the road while driving. Was able to restart and move out of the way but stalled again. Car would no longer move into drive. No warning lights came on until after the car stalled for the second time. Then the check engine light came on. Previous to this occurrence the car was running perfectly fine and gave no warnings that the transmission was going out. The vehicle was towed to a mechanic where they stated the transmission blew. Upon finding this out vehicle was towed to a dodge dealership where we were informed warranty was expired. Vehicle only has 73,000 miles on it.

Transmission failed while driving on the highway without prior warning and the vehicle had to be towed home. The vehicle had limited power left to pull off the highway for safety though. What I hear when I start and rev the engine a bit is high pitched whining noise and noise of separated or lose components coming from inside the transmission. Research has shown me that this same drive train has been running in Chrysler and Dodge vehicles for about ten years now and has seen recalls on the transmission for some earlier model years like 2015, 2016, … . This is a big safety issue given that this vehicle seats seven people (families rely on this van for transportation) and therefore Chrysler should add this vehicle drive train to the recall list ASAP. After failing the the check engine light popped up and running it on the generic scan tool code P083B showed up.

Vehicle Description: 2019 DODGE GRAND CARAVAN 75,000 miles [XXX] Transmission is slipping between gears, erratic up or down shifts Transmission slams into 1st & 2nd gear. Especially at low RPM Transmission will not downshift properly Transmission Clunking into drive from park Transmission slamming into differential and drive train. Transmission passing gear is erratic into lower gears. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

I was in line at a fast food drive thru when a strange noise began coming from under my hood. When I went to drive forward, the engine revved but the vehicle didn’t move at first. It finally jerked into gear and I proceeded to exit the line and to a stop sign before driving onto the main road. I had no problem taking off from the stop sign but as I was accelerating on the main road, I got up to about 35mph and the vehicle revved again, but this time it stopped moving in the middle of the road. The car behind me blew their horn and ran off the road to a avoid rear-ending me. There was no CEL illuminated and no other warning or indication of a problem. I got off the road and turned the engine off. I turned it back on and took the back streets home and parked it. I had the transmission filter and fluid changed, and all was well for about another 200 miles. As I was driving about 60 miles an hour on a highway, I again lost forward motion and the engine revved to about 5000 rpm’s. I immediately steered off the highway to avoid a collision. Again, there no malfunction indicator light illuminated. After careful inspection by a certified technician, it was determined that the transaxle oil pump has failed. The vehicle is available for inspection at yours or your representative’s convenience.

The contact leased a rental 2019 Dodge Grand Caravan. The contact stated that while the vehicle was turned on and the gear shifter was shifted in park (P), she exited the vehicle while her three children remained inside the vehicle. The contact stated that her son went into the driver's seat and moved the gear shifter. The vehicle then rolled away and came to a complete stop in a ditch. The air bags were not deployed upon impact. The contact's son had a bruise on his head, her daughter had a bruise on her neck from the seat belt and body aches, and her other son had a cut lip upon impact. Medical attention was received for the three children. A police report was filed. The vehicle was towed to a body shop but the contact was unaware if it was deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was unknown.

Car shakes which feels like first 3 gears during acceleration. As if riding over spike strip.

Before 50K miles the transmission went out and a cylinder blew at the same time. There was no warning this would happen and when it happened we were in traffic and caused the vehicle to jump almost hitting another car. This was repaired by Dodge. At the time of pick up the technician in the shop told us that this is a common issue with these vans and he sees this all the time. Also the breaks have not worked properly since purchase. An online form shows many owners have this same issue and have determined that the break system is under rated for the size of vehicle.

2019 DODGE GRAND CARAVAN. 3.6 PENTASTAR ENGINE. 60K MILES. FOR OVER A YEAR IT HAS ROUGH IDLE AND ENGINE VIBRATION AT HWY SPEED. MISFIRE ON CYLINDER #2 DOES NOT GO AWAY. ALWAYS RETURNS. HAVE REPLACED COILS, PLUGS TWICE AND INJECTORS. #2 CYLINDER MISFIRE STILL THROWS ENGINE LIGHT. WENT TO AND CALLED DODGE DEALER SEVERAL TIMES ABOUT PROBLEM. THEY CLAIM THERE ARE NO KNOWN ISSUES, PROBLEMS OR RECALLS. THEY KEEP TRYING TO TELL ME IT'S BAD FUEL AND I SHOULD USE HIGHER GRADE FUEL. I'VE DONE THAT AS WELL AND THE MISFIRE ON #2 CYLINDER IS ALWAYS THERE. THE VIBRATION GETS SO BAD SOMETIMES THE ENTIRE VEHICLE SHAKES LIKE YOUR SITTING IN A MASSAGE CHAIR. MY WIFE REFUSES TO DRIVE IT ANYMORE AND I'M REALLY FRUSTRATED THAT DODGE REFUSES TO ACKNOWLEDGE THERE IS A DEFECT ON THIS ENGINE THAT IS CAUSING THIS AND SHOULD BE COVERED BY THEM. IT'S ONLY A YEAR OLD AND SHOULD NOT BE HAVING THIS PROBLEM.

Mileage: 49,000

TL* THE CONTACT OWNS A 2019 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING, THE RPM REVVED UP AND EXCEEDED 5,000 RPM. THE FAILURE RECURRED WHILE ACCELERATING WITH THE ECONOMY LIGHT DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO FELDMAN CHRYSLER DODGE JEEP LOCATED AT 23940 ALLEN RD, WOODHAVEN, 48183 HOWEVER, THE MECHANIC WAS UNABLE TO PROVIDE A CAUSE FOR THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 5,895.

Mileage: 5,895

DURING THE COURSE OF DRIVING VAN SKIPS/SLIPS THEN WILL START DECREASING SPEED BUT THEN WILL PICK BACK UP. THIS HAPPENS ON CITY STREETS OR HIGHWAYS IT DOES NOT MATTER. STARTED IN JULY TO PRESENT. *TR

Mileage: 4

TL* THE CONTACT OWNS A 2019 DODGE GRAND CARAVAN. WHILE DRIVING 20 MPH, THE VEHICLE BEGAN TO HESITATE AND THE CONTACT HEARD AN ABNORMAL NOISE. ALSO, WHEN DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE FAILED TO ACCELERATE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO NAPLETON CLERMONT CHRYSLER JEEP DODGE RAM (LOCATED AT 15859 FL-50, CLERMONT, FL 34711, (888) 359-4237) WHERE IT WAS DIAGNOSED WITH NEEDING A NEW TRANSMISSION AND BOTH CYLINDER HEADS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURES CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER MULTIPLE TIMES AND THE TRANSMISSION WAS REPLACED TWO ADDITIONAL TIMES, BUT THE FAILURES RECURRED. THE DEALER STATED THAT THEY WERE UNABLE TO DUPLICATE THE FAILURE DURING THE LAST VISITS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 10,716. *DT*JB

Mileage: 10,716

TL* THE CONTACT RENTED A 2019 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE GEAR WAS IN PARK. WHILE THE VEHICLE WAS IDLING, THE CONTACT STEPPED OUT OF THE VEHICLE. THE VEHICLE SHIFTED INTO REVERSE. AS A RESULT, THE CONTACT WAS STRUCK BY THE FRONT DRIVER'S DOOR AND DRAGGED BY THE VEHICLE. THE VEHICLE WAS STOPPED BY AN UNKNOWN PERSON. THE CONTACT SUSTAINED LEG, BACK, ARM, AND SHOULDER INJURIES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT IT WAS MISSING THE LOCK BETWEEN THE PARK AND REVERSE GATE. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO A DODGE DEALER. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 2,000.*DT THE CONSUMER STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE LOCK BETWEEN THE PARKING AND REVERSE GATE WAS MISSING. THE VEHICLE WAS RETURNED TO THE RENTAL COMPANY.

Mileage: 2,000