2007 DODGE NITRO Fuel System, Gasoline Problems

WHIN FILLING TANK GAS BOILS OUT JUST AFTER THE AUTO SHUTOFF CLICKS.

Mileage: 48,000

THIS VEHICLE AS BOUGHT USED AT A CHEVROLET DEALERSHIP IN ARLINGTON, TX WITH ABOUT 33,800 MILES ON IT. WHEN REFUELING THIS VEHICLE FOR THE FIRST TIME THE GAS PUMP DID NOT SHUT OFF WHEN THE TANK WAS FULL, RESULTING IN GAS OVERFLOWING ONTO THE SIDE OF THE VEHICLE AND SPILLING ON THE GROUND. THIS SAME KIND OF MALFUNCTION CONTINUES TO OCCUR EVERY TIME IT IS REFUELED UNLESS THE PERSON REFUELING IT MANUALLY STOPS THE PUMP BEFORE THE TANK IS COMPLETELY FULL. SOMETIMES THE PUMP SHUTS OFF AS GAS BEGINS TO OVERFLOW, AND OTHER TIMES THE PUMP DOES NOT SHUT OFF AT ALL. THIS CONDITION IS VERY HAZARDOUS, HARMFUL TO THE VEHICLE'S PAINT, AND WASTEFUL. *TR

Mileage: 34,100

WHEN I AM FILLING GAS TANK, THE AUTOMATIC SHUT OFF DOES NOT WORK, AND FUEL POURS OUT EVERYWHERE. I HAVE BEEN COVERED IN GAS SEVERAL TIMES AS IT SUDDENLY OVERFLOWS AND ALMOST SEEMS TO SHOOT OUT. IT DOES NOT HAPPEN EVERY TIME, STARTED ABOUT TWO YEARS AGO BUT SEEMS TO BE HAPPENING MORE FREQUENTLY. *TR

Mileage: 50,000

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT WHILE REFUELING, FUEL SPRAYED OUT OF THE FILLER NECK ONTO THE GROUND. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. UPDATED 3/14/13 *CN THE MECHANIC AT THE DEALER INFORMED THE CONSUMER IT WAS THE SAME PROBLEM JEEP HAD WITH THE ROLL OVER VALVE IN THE GAS TANK BEING DEFECTIVE AND IT NEEDED TO BE REPLACED.

Mileage: 46,000

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT WHILE REFUELING, FUEL SPRAYED OUT OF THE FILLER NECK ONTO THE GROUND. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. UPDATED 3/14/13 *CN THE MECHANIC AT THE DEALER INFORMED THE CONSUMER IT WAS THE SAME PROBLEM JEEP HAD WITH THE ROLL OVER VALVE IN THE GAS TANK BEING DEFECTIVE AND IT NEEDED TO BE REPLACED.

Mileage: 46,000

WHILE ATTEMPTING TO FILL FUEL TANK, THE NOZZLE SHUT OFF AS NORMAL WHEN TANK WAS FULL, HOWEVER GASOLINE SHOT OUT OF THE FILLER NECK ALL OVER MY PANTS AND SHOES. THERE WAS PROBABLY A PINT TO A HALF GALLON OF FUEL THAT SHOT OUT OF THE TANK. I HAVE CHECKED ON LINE AND DETERMINED THIS IS A COMMON DEFECT WITH THE 2007 DODGE NITRO. THIS NOW OCCURS EACH AND EVERY TIME I FILL THE FUEL TANK. SOMEONE IS BOUND TO BE SERIOUSLY INJURED OR KILLED OVER THIS SITUATION, WHY HAS THERE NOT BEEN A RECALL ON THIS ISSUE.

Mileage: 62,450

WHILE FILLING FUEL INTO THE TRUCK THE AUTO STOP DID NOT WORK, THE FIRST TIME IT HAPPENED MY 5 YR OLD SON WAS WASHING THE WINDOWS WITH MY WIFE AND IT SPRAYED FUEL ON MY SONS LEGS AND SHOES. WE FIGURED THE PUMP HAD A PROBLEM. NOW IT SEEMS TO DO IT EVERY TIME WE FUEL THE TRUCK . AFTER SEARCHING I FOUND ITS A VENT PROBLEM WITH THE 2007 NITRO THAT THE DEALER KNOWS ABOUT, IM NOT HAPPY RIGHT NOW THE DEALER CLAIMS ONLY SOME VEHICLES ARE RECALLED ON THIS. SHOULD I BE LOOKING FOR LEGAL ACTION NEXT? *TR

GAS SPILLS OUT WHEN FILLING TANK. BY THE TIME THE AUTO SHUT OFF ON PUMP STOPS, GAS SPILLS OUT AND ON THE GROUND. HAS HAPPENED AT SEVERAL DIFFERENT GAS STATIONS. *TR

Mileage: 32,000

WHEN FILLING UP WITH FUEL THE TANK WILL OVERFLOW SPILLING OUT APPROX. A GALLON OF FUEL. THIS IS A SAFETY HAZARD. IT ALSO INDICATES THAT THE SHUT OFF VALVE ISN'T WORKING PROPERLY AND THAT THE SAFETY FEATURE OF SHUTTING OFF THE FUEL LINE WHEN IN A SERIOUS ACCIDENT WILL ALSO NOT WORK THEREFORE BEING A HUGE SAFETY CONCERN. *TR

WHILE FILLING GAS TANK, WHEN TANK BECOMES FULL IT WILL SPEW OUT GAS ALL OVER THE SIDE OF THE NITRO AND ON TO THE GROUND. NOT JUST A SMALL AMOUNT OF GAS. CLOSE TO A PINT OF GAS, IF NOT MORE. AT EACH FILLUP. TRIED DIFFERENT PUMPS AT DIFFERENT STATIONS, IN DIFFERENT STATES. ALL DO THE SAME THING. VERY HAZARDOUS TO SPILL THAT MUCH GAS ON THE GROUND EACH TIME THE NITRO IS FUELED UP. *TR

Mileage: 56,000

WHEN THE GAS TANK IS BEING FILLED UP AND THE NOZZLE AT THE PUMP SHUTS OFF INDICATING THE GAS TANK IS FULL, ABOUT A QUARTER GALLON OF GAS SPILLS OUT OF THE TANK. *TR

Mileage: 75,031

WHEN FILLING THE VEHICLE WITH GAS, FUEL WILL SPEW FROM THE FILLER PIPE AND SPILL ALL OVER THE SIDE OF THE VEHICLE AND ON THE PERSON FUELING. IT HAS COME TO OUR ATTENTION THAT THE CAUSE IS A FAULTY OVERFLOW FLAP THAT IS DESIGNED TO KEEP FUEL FROM FLOWING OUT OF THE TANK UPON FILL UP, BUT MORE IMPORTANTLY IT IS TO PREVENT FUEL FROM EXITING THE TANK IN THE CASE OF A ROLLOVER ACCIDENT. THIS FAULTY FLAP COULD MEAN LIFE OR DEATH IN A ROLLOVER IF FUEL IS ALLOWED TO LEAK FROM THE TANK AND IGNITE. *TR

Mileage: 61,000

UPON REFUELING THE VEHICLE, THE GAS HOSE IS NOT TRIGGERED TO SHUT OFF IMMEDIATELY AND ALLOWS ABOUT A HALF OF A GALLON OF GAS TO OVERFLOW ONTO THE VEHICLE AND THE GROUND. WHETHER THE HOSE IS BEING PUMPED MANUALLY OR TRIGGERED TO STAY ON DOES NOT CHANGE THIS OUTCOME. *TR

THERE IS A VALVE IN THE GAS TANK THAT'S PREVENTS GAS SPILLAGE IN THE EVENT OF AN ACCIDENT AND THE CAR ROLLS OVER. THIS VALVE IS DEFECTIVE AND NOW MY VEHICLE SPILLS GAS WHENEVER I GAS UP AUTOMATICALLY. THIS MEANS THAT THE SAFETY VALVE IS INOP AND IF I ROLLOVER DURING AN ACCIDENT THE GAS WILL SPILL OUT. THIS HAS BEEN HAPPENING FOR A WHILE NOW AND I JUST GOOGLED THE PROBLEM AND EVERYONE THAT HAS THIS VEHICLE IS EXPERIENCING THIS PROBLEM. THERE SHOULD BE A RECALL CAUSE E EN THE DEALER TOLD ME IT IS A COMMON PROBLEM AND CHRYSLER IS AWARE OF IT. HOW CAN WE EEL SAFE DRIVING A VEHICLE WITH A POTENTIAL LIFE THREATENING MALFUNCTION. *TR

WHEN FUELING, THE FILLER NOZZLE NEVER SHUTS OFF. FUEL SPEWS OUT OF THE FILL NECK ALL OVER THE SIDE OF THE TRUCK, THE GROUND, AND YOU (IF YOU'RE STANDING TOO CLOSE). THIS HAS HAPPENS EVERY TIME I'VE FILL THE TRUCK. I'VE TRIED DIFFERENT GAS STATIONS AND IT HAPPENS AT EVERY ONE. THIS IS AN ENVIRONMENTAL PROBLEM AS WELL AS A SAFETY ISSUE. BASED ON THE RESEARCH I'VE CONDUCTED, THIS PROBLEM IS RELATED TO A "ROLLOVER" VALVE. THIS VALVE IS DESIGNED TO PREVENT FUEL FROM FLOWING OUT OF THE FILL NECK IN THE EVENT OF A ROLLOVER ACCIDENT. THIS IS A HUGE SAFETY CONCERN, AND BASED ON MY INTERNET SEARCH, THIS IS NOT AN ISOLATED PROBLEM. I BELIEVE A RECALL SHOULD BE ISSUED BEFORE SOMEONE GETS KILLED. *TR

Mileage: 28,650

APPROXIMATELY TWO YEARS AGO WHILE FILLING UP MY GAS TANK THE PUMP SHUT OFF TO INDICATE A FULL TANK AND GAS WAS GUSHING ALL OVER THE SIDE OF THE VEHICLE AND THE GROUND. AT THE TIME I THOUGHT IT MAY HAVE JUST BEEN THE GAS STATION PUMP AND DIDN'T THINK TO MUCH OF IT. THE NEXT TIME I WENT TO FILL UP IT DID THE SAME THING. THE PUMP SHUT OFF AND GAS SPILLED OUT OF THE VEHICLE. THIS HAS BEEN AN ONGOING PROBLEM EVER SINCE AND I AM NEVER ABLE TO FILL UP THE GAS TANK. AFTER LOOKING INTO SOME DODGE NITRO FORUMS I REALIZED THAT THIS IS A VEHICLE PROBLEM RELATED TO A FUEL TANK ROLL OVER VALVE STUCK OPEN WHICH COULD BE A SAFETY HAZARD. *TR

Mileage: 45,000

2007 DODGE NITRO. CONSUMER STATES PROBLEM WITH VEHICLE GAS TANK *TGW THE DEALER INFORMED THE CONSUMER THE GAS TANK WAS MOST LIKELY INSTALLED ALREADY BROKEN OR IMPROPERLY. THUS, WHEN FILLING THE TANK, THE AIR DIFFERENTIAL INSIDE THE TANK THAT FORCED THE PUMP TO SHUT OFF AUTOMATICALLY DID NOT REGISTER DUE TO THE DEFECT. THE CONSUMER STATED ON SEVERAL OCCASIONS, THE TANK HAS OVERFLOWED. THE CONSUMER WAS INFORMED, THE ENTIRE TANK WOULD HAVE TO BE REPLACED. *JB

2007 DODGE NITRO. CONSUMER STATES PROBLEM WITH VEHICLE GAS TANK *TGW THE DEALER INFORMED THE CONSUMER THE GAS TANK WAS MOST LIKELY INSTALLED ALREADY BROKEN OR IMPROPERLY. THUS, WHEN FILLING THE TANK, THE AIR DIFFERENTIAL INSIDE THE TANK THAT FORCED THE PUMP TO SHUT OFF AUTOMATICALLY DID NOT REGISTER DUE TO THE DEFECT. THE CONSUMER STATED ON SEVERAL OCCASIONS, THE TANK HAS OVERFLOWED. THE CONSUMER WAS INFORMED, THE ENTIRE TANK WOULD HAVE TO BE REPLACED. *JB

EVERY TIME I FILL THE GAS TANK OF MY 2007 DODGE NITRO THERE IS A LARGE AMOUNT OF GASOLINE THAT "BURPS" BACK OUT OF THE TANK ONTO THE CAR, THE GROUND AND ANYONE (UNSUSPECTING THAT THIS WOULD HAPPEN) STANDING NEAR BY. IT MAY BE AS MUCH AS A GALLON OF GASOLINE. CHRYSLER HAS ADMITTED THIS IS DUE TO A MANUFACTURING DEFECT OF A VALVE IN THE GAS TANK. THIS VALVE IS THERE TO PREVENT THE POSSIBILITY OF AN EXPLOSION IN THE EVENT OF A ROLLOVER ACCIDENT. IF THIS VALVE IS DEFECTIVE IT WOULD SEEM IT WILL NOT PREVENT AN EXPLOSION IN A ROLLOVER ACCIDENT. RECENTLY MY DAUGHTER BORROWED THE CAR. I NEGLECTED TO TELL HER ABOUT THIS PROBLEM. SHE FILLED THE CAR AND STOOD THERE AS GASOLINE COVERED HER SHOES AND THE BOTTOM OF A GOOD PAIR OF SLACKS. YOU CAN IMAGINE HER HORROR AS SHE STOOD THERE COVERED IN FRESH GASOLINE. CHRYSLERS SOLUTION AT THIS TIME IS FOR ME TO PAY A DEALERSHIP TO REPLACE THE GAS TANK. TO AVOID HAVING TO PAY FOR THIS REPAIR (WITH MONEY I DON'T HAVE) AS THE TANK FILLS I SLOW THE FUEL FLOW INTO THE TANK TO THE SLOWEST FLOW RATE ON THE PUMP HANDLE. THERE IS STILL A "BURP" BACK AT FULL. JUST NOT VERY MUCH FUEL. THIS DEFECTIVE VALVE IS GOING TO CAUSE HORRIBLE DEATHS OR DISFIGURING BURNS TO SOMEONE. A GASOLINE FIRE WOULD BE AN AWFUL THING, THE FACT THAT IT IS PREVENTABLE WOULD MAKE IT UNIMAGINABLE. KNOWING THIS PROBLEM EXISTS WITH MY VEHICLE I CANNOT EVEN SELL IT IN GOOD CONSCIENCE. *TR

Mileage: 56,000

THE GAS TANK VALVE INSIDE THE TANK FOR SAFETY IS BROKEN. WITH OUT THIS VALVE GAS WILL BE RELEASED IN ANY ACCIDENT. IT ALSO CAUSES THE GAS TANK TO OVER FILL WHEN FILLING UP. *TR

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, GAS SPEWED BACK OUT OF THE FILLER NECK. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE ROLL OVER VALVE WITHIN THE FUEL TANK WAS DEFECTIVE AND AS A RESULT, THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 72,000.

Mileage: 70,000

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT GASOLINE WOULD SPILL OUT OF THE FUEL TANK WHEN THE CONTACT WAS REFUELING. THE CONTACT SPOKE WITH THE DEALER BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 59,000.

Mileage: 45,000

WHEN FILLING THE GAS TANK WITH AN AUTOMATIC CUT OFF NOZZLE, THERE IS SEVERE SPLASH BACK AS THE NOZZLE SHUTS OFF THE GAS SUPPLY. GAS SPOUTS OUT OF THE FILLER PIPE UNDER PRESSURE. THIS IS REAL FIRE HAZARD PLUS QUITE A MESS IF IT GETS ON THE DRIVER/GAS PUMP USER. REPEATED SURGES WILL LIKELY TAKE THE PAINT OFF THE LEFT REAR FENDER. *TR

Mileage: 65,000

WHEN FILLING THE GAS TANK WITH AN AUTOMATIC CUT OFF NOZZLE, THERE IS SEVERE SPLASH BACK AS THE NOZZLE SHUTS OFF THE GAS SUPPLY. GAS SPUTS OUT OF THE FILLER PIPE UNDER PRESSURE. THIS IS A REAL FIRE HAZARD PLUS QUITE A MESS IF IT GETS ON THE DRIVER/GAS PUMP USER. REPEATED SURGES WILL LIKELY TAKE THE PAINT OFF THE LEFT REAR FENDER. IF I ESTIMATE THAT THE TANK WILL TAKE ABOUT 14 GALLONS, I STOP THE DELIVERY AT 11 GALLONS, REMOVE THE NOZZLE AND SHAKE THE VEHICLE. THEN I REINSERT THE NOZZLE AND STOP AT EACH GALLON UNTIL FULL. EVEN WITH THIS TECHNIQUE, THERE MAY BE A MILD SPLASH BACK. THIS TECHNIQUE MAKES FUELING THE VEHICLE A REAL CHORE WHICH IS AN AGGRAVATION! *KB

Mileage: 65,000

WHEN FILLING THE VEHICLE WITH GASOLINE, THE AUTO SHUT OFF DOES NOT WORK. THIS IS VERY DANGEROUS, AS IT OVERFILLS AND FUEL SPILLS OUT ALL OVER THE VEHICLE AND THE SURROUNDING AREA. I HAVE LEARNED THAT THIS HAS SOMETHING TO DO WITH THE VAPOR VALVE IN THE FUEL TANK, AND IS EVEN A BIGGER PROBLEM IF THE VEHICLE WAS INVOLVED IN A ROLLOVER, AS THE FUEL WOULD COME SPILLING OUT OF THE TANK. TOOK IT TO THE DEALERSHIP AND THEY TOLD ME THAT I WOULD BE RESPONSIBLE FOR REPLACING THE FUEL TANK. THIS SHOULD BE A RECALL, AS DODGE HAS HAD THIS HAPPEN BEFORE ON OTHER MODELS. *TR

Mileage: 20,000

WHEN I FILL MY TANK UP GASOLINE WILL OVERFLOW AND SPILL ONTO THE SIDE OF MY CAR AND ONTO THE FLOOR. *TR

EVERY TIME GAS TANK IS FILLED COMPLETELY AND NOZZLE SHUTS OFF, GAS SPILLS OUT OF THE TANK ALL OVER THE CAR AND ONTO THE GROUND. SEVERE FIRE HAZARD. CAR IS NOT BEING TOPPED OFF. HAPPENS ONLY WHEN TANK IS ALLOWED TO BE COMPLETELY FULL. HAS TO DO WITH THE VEHICLE AND NOT THE GAS STATIONS PUMPS. DODGE INCORPORATED A SHUT OFF SYSTEM IN SUVS TO PREVENT FIRE DURING A ROLL OVER ACCIDENT BUT THIS IS THE PART THAT IS FAILING IN THE GAS TANK. IS A SEVERE SAFETY RISK. *TR

Mileage: 40,000

WHEN FILLING THE GAS TANK, GAS BACKS UP AND POURS OUT OF THE TANK SPOUT. THIS ISN'T EXCLUSIVE TO FILLING UP THE TANK ENTIRELY. THIS CAUSES A CONCERN AS IT SPRAYS FUEL ON THE INDIVIDUAL PUMPING THE GAS AND LEAVES A SPILL AT THE GAS PUMP. *TR

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT FUEL SPILLED OUT FROM THE FILLER NECK WHILE REFUELING AND SPILLED ONTO HERSELF AS WELL AS THE EXTERIOR OF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE CONTACT RESEARCHED THE FUEL SYSTEM MALFUNCTION ONLINE AND DISCOVERED THAT THIS WAS A COMMON FAILURE. THE CONTACT NOTIFIED THE MANUFACTURER AND FILED A COMPLAINT. THE FAILURE MILEAGE WAS 72,000. ..UPDATED 12/07/11 *BF UPDATED 06/04/12

Mileage: 72,000

IT APPEARS THERE IS A PROBLEM WITH THE GAS TANK WHICH SEEMS TO SPILL FUEL EVERY TIME DURING REFUELING. *TR

Mileage: 50,000

GAS OVERFLOW WHEN FILLING. REPORTS OF "ROLLOVER VALVE IN TANK NOT SEALING" HAVE BEEN SUBMITTED TO DODGE BUT NO RECALL AS OF YET. "THE FUEL TANK ROLLOVER VALVE CAN ALLOW FUEL TO PASS INTO THE VAPOR CANISTER RESULTING IN THE POTENTIAL FOR FUEL LEAKAGE. " *TR

Mileage: 28,000

ABOUT 2 MONTHS AGO WHEN FILLING MY VEHICLE WITH GAS WHEN THE PUMP SHUT OFF IT SPLASHED OUT QUITE A BIT OF FUEL. I THOUGHT OK ONE TIME. MY VEHICLE CONTINUES TO DO THIS NOW. BECAUSE OF THIS I JUST PUT IN SO MANY GALLONS OF FUEL AND TURN OFF MYSELF. I CALLED THE DEALERSHIP AND THEY SAID WOULD HAVE TO BRING IN AND PAY TO HAVE IT TESTED. I HAVE SEEN ONLINE THAT SEVERAL PEOPLE ARE HAVING THE SAME PROBLEM WITH THE NITRO. THIS IS DANGEROUS AS IT COULD SPLASH IN EYES, ETC. IF YOU ARE NOT AWARE. I WOULD THINK THERE WOULD BE A RECALL BY NOW. I HAVE LEFT 3 MESSAGES FOR THE DEALERSHIP TO CALL ME TO DISCUSS THIS BUT NO ONE RETURNS MY CALLS. *TR

Mileage: 33,500

ABOUT 2 MONTHS AGO WHEN FILLING MY VEHICLE WITH GAS WHEN THE PUMP SHUT OFF IT SPLASHED OUT QUITE A BIT OF FUEL. I THOUGHT OK ONE TIME. MY VEHICLE CONTINUES TO DO THIS NOW. BECAUSE OF THIS I JUST PUT IN SO MANY GALLONS OF FUEL AND TURN OFF MYSELF. I CALLED THE DEALERSHIP AND THEY SAID WOULD HAVE TO BRING IN AND PAY TO HAVE IT TESTED. I HAVE SEEN ONLINE THAT SEVERAL PEOPLE ARE HAVING THE SAME PROBLEM WITH THE NITRO. THIS IS DANGEROUS AS IT COULD SPLASH IN EYES, ETC. IF YOU ARE NOT AWARE OF THE PROBLEM. I WOULD THINK THERE WOULD B A RECALL BY NOW. I HAVE LEFT 3 MESSAGES FOR THE DEALERSHIP TO CALL ME TO DISCUSS THIS BUT NO ONE RETURNS MY CALLS. *TR

Mileage: 33,500

WHILE FUELING THE VEHICLE THE FUEL OVERFLOWS ONCE FULL AND GOES ALL OVER THE GROUND AND VEHICLE. THE PUMP SHUTS OFF BUT FUEL JUST COMES BACK UP THROUGH THE TANK FILL SPOUT. *TR

Mileage: 33,000

FUEL COMES RUSHING OUT ALL OVER VEHICLE AND ALL OVER PERSONS FILLING THE GAS TANK. THIS HAPPENS EVERYTIME IT IS FILLED UP. *TR

Mileage: 73,000

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT GASOLINE WOULD SPILL FROM THE FUEL TANK WHEN THE VEHICLE WAS REFUELED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THERE WAS A FAILURE WITH THE FILLER CAP. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 59,000. POST SCRIPT: CHRYSLER DID A WARRANTY REPAIR WITH A DEDUCTIBLE $150.00. GAS TANK WAS REPLACED 9/01/2011. THE ACTION FIXED THE PROBLEM ABOVE. UPDATED 09/29/2011 *LN *TR

Mileage: 58,000

WHEN FILLING UP 2007 DODGE NITRO SXT 92,000 MILES, GASOLINE SPRAYS BACK AFTER FUEL PUMP SHUTS OFF. *TR

Mileage: 92,500

WHEN REFUELING, AFTER THE PUMP NOZZLE SHUTS OFF, THERE IS A BACK SPLASH OF GASOLINE FROM THE TANK FILLER TUBE. SUSPECT THE FUEL TANK ROLL OVER VALVE IS STUCK OPEN. THIS CREATES A FIRE HAZARD UPON REFUELING AND WOULD ALLOW FUEL LEAKAGE UPON ROLL OVER, THE EXACT EVENT THE VALVE IS SUPPOSED TO PREVENT. THIS HAS BEEN CONSISTENT SINCE NOVEMBER 2010.

Mileage: 24,000

A SUBSTANTIAL AMOUNT OF FUEL SPILLS OUT OF THE FILLER TUBE WHEN FILLING THE FUEL TANK. THIS HAPPENS EVERY TIME THE TANK IS FILLED. THIS HAS BEEN HAPPENING FOR ABOUT 7 MONTHS NOW. *TR

Mileage: 55,000

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED WHILE ADDING FUEL TO THE VEHICLE IT WOULD SPILL OUT OF THE FUEL TANK ONTO THE CONTACT AND THE VEHICLE. THE CONTACT CALLED THE MANUFACTURER REGARDING THE FUEL TANK AND THEY STATED THERE WAS NO RECALL. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAS ONLY ABLE TO ADD A HALF TANK OF GASOLINE TO THE FUEL TANK BECAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 71,000.

Mileage: 71,000

AFTER FILLING UP MY 2007 DODGE NITRO GAS SPEW OUT WITH FORCE ON MYSELF AND THE SIDE OF THE SUV. WHEN UNLOCKING OR LOCKING MY VEHICLE SOMETIME THE COOLING FAN AND RADIO WILL TURN ON. BOTH OF MY BACK WINDOWS DON'T NOT WORK. *TR

2007 DODGE NITRO, FUEL SYSTEM GASOLINE. DURING FILL-UP THE FUEL SPILLS OUT OF THE FILLER NECK DUE TO A BAD FUEL TANK ROLLOVER VALVE. VEHICLE HAS 38K MILES WHEN PROBLEM STARTED. *TR

Mileage: 38,000

2007 DODGE NITRO, SLT, 3.7 LITRE. FUEL TANK OVERFLOWS EVERY TIME I FILL MY GAS TANK, DOES NOT MATTER IF I USE GAS PUMP NOZZLE FULL OPEN OR BARELY OPEN. *TR

AFTER FILLING THE FUEL TANK TO CAPACITY, ABOUT A QUART OF FUEL SPEWS OUT. THIS HAPPENS EVERY TIME THE VEHICLE IS REFUELED AT ANY GAS STATION. THE PROBLEM STARTED AROUND 15,000 MILES. *TR

Mileage: 15,000

HTTP://WWW.NITROFORUMZ.COM/SHOWTHREAD.PHP?T=700 GO TO THAT WEB ADDRESS AND YOU WILL SEE WELL OVER 30 PLUS PEOPLE EFFECTED BY THIS. I DRIVE A DODGE NITRO SLT 07', THE GAS TANK VALVE WAS MESSED UP AND EVERYTIME I FILLED MY TANK THE GAS WOULD GUSH OUT. EVERY TIME. THE DEALERSHIP SAID IT WAS NOT A KNOWN PROBLEM AND WOULD BE 100% OUT OF POCKET. *TR

Mileage: 35,000

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT AFTER DISPENSING FUEL TO THE FULL CAPACITY LEVEL, THE FUEL WOULD SPEW OUT ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND THEY INFORMED THE CONTACT THAT THE FUEL TANK WOULD NEED TO BE REPLACED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

Mileage: 36,000

WHEN PUMPING FUEL INTO OUR FAMILYS 2007 DODGE NITRO, A LARGE AMOUNT OF GASOLINE SPILLS ALL OVER THE PERSON, THE CAR, AND THE GROUND AT THE GAS STATION. THIS HAPPENS NO MATTER WHAT GAS STATION IS USED. IT IS A SAFETY DEFECT FULLY KNOWN TO CHRYSLER-DODGE, AND MAY BE CAUSED BY A PART SUPPLIER DEFECT. THE ALLEGEDLY DEFECTIVE PART IS A FUEL CHECK VALVE THAT IS BUILT INTO THE FUEL TANK. THE FUEL TANK HAS TO BE REPLACED IN ORDER TO FIX THE DEFECTIVE PART SO IT IS A MAJOR REPAIR. THIS DEFECTIVE PART IS APPARENTLY INVOLVED IN PREVENTING TANK EXPLOSIONS SHOULD THE VEHICLE ROLL OVER. SINCE THIS DEFECTIVE PART IS LIKELY INSTALLED IN MANY THOUSANDS OF VEHICLES, THERE IS CONCERN THIS DEFECT COULD LEAD TO FUEL TANK DETONATIONS IN NITROS AND JEEP LIBERTIES INVOLVED IN ACCIDENTS. IN ADDITION, THIS DEFECT WILL LIKELY LEAD TO FUTURE EXPLOSIONS AT FUELING STATIONS SINCE GASOLINE POURS UNCONTROLLABLY AND PROFUSELY OUT OF THE GAS TANK. CHRYSLER DODGE INFORMED ME DIRECTLY THEY HAVE ISSUED EXTENDED WARRANTIES TO CERTAIN CHRYSLER VEHICLES (IN LIEU OF A RECALL) BECAUSE, AS A DODGE RECALL REPRESENTATIVE TOLD ME BY TELEPHONE ON 3/28/11, THEY HAD ISSUES WITH THE SAME FUEL TANK INLET CHECK VALVE FOR OTHER CHRYSLER VEHICLES. BUT, DESPITE HAVING THE EXACT SAME SAFETY DEFECT WITH MY 2007 DODGE NITRO, CHRYSLER-DODGE HAS NOT YET ISSUED A RECALL OR AN EXTENDED WARRANTY FOR THIS VEHICLE. DOES A FAMILY HAVE TO DIE TRAGICALLY BEFORE CHRYSLER DODGE ISSUES A GENUINE RECALL FOR A SERIOUS SAFETY DEFECT THAT IS FULL KNOWN TO THEIR COMPANY?

Mileage: 40,900

MY 2007 DODGE NITRO SPILLS GASOLINE EVERY TIME I PUMP GAS. THE PUMP FAILS TO SHUT OFF AND GASOLINE SPEWES OUT OF THE FILL TUBE ONTO THE SIDE OF THE VEHICLE, THE PAVEMENT AND ON A COUPLE OF OCCASIONS MY LEGS AND SHOES. THIS HAS OCCURRED AT MANY DIFFERENT GAS STATIONS AND PUMPS AND ONLY STARTED RECENTLY AFTER THE WARRANTY EXPIRED. INTERNET RESEARCH INDICATES THAT THIS PROBLEM IS CAUSED BY A FAULTY VENT VALVE INSIDE THE TANK THAT MUST BE REPLACED. IN ADDITION THE FAULTY VALVE IS DESIGNED TO PREVENT EXPLOSIONS IN CASE THE VEHICLE ROLLS OVER. IF THIS VALVE IS FAULTY THIS IS A SERIOUS SAFETY ISSUE FOR NITRO OWNERS. *TR

Mileage: 62,000

FUEL SPILLS OUT WHEN GAS TANK BECOMES CLOSE TO FULL. HALF A GALLON OR SO VERY STRONGLY IS SPRAYED ALL OVER THE SIDE OF THE VEHICLE AND ANYTHING WITHIN A 1-2FT DISTANCE FROM THE VEHICLE. THIS HAPPENS REGARDLESS OF THE GAS STATION USED. *TR

Mileage: 35,000

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT WHEN REFUELING THE VEHICLE, AT LEAST ONE QUART OF GASOLINE WOULD SPEW BACK OUT FROM THE FILLER NECK AND WOULD OCCUR WHENEVER THE CONTACT WOULD REFUEL THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS TOLD THAT THEY WOULD NEED TO REPLACE THE FUEL TANK BECAUSE THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. THE FAILURE MILEAGE WAS 33,000 AND THE CURRENT MILEAGE WAS 34,000.

Mileage: 33,000

GAS SPILLING OUT OF FILLER NECK ON MY 2007 DODGE NITRO WHEN IT HAS FINISHED FILLING. I PLACED THE NOZZLE FULLY INTO THE TANK AND CLICK THE AUTOMATIC FILLER IN PLACE AND ONCE THE NOZZLE CLICKS INDICATING IT IS FULL 1-2 CUPS OF GAS SPILLS OUT AND SPRAYS EVERYWHERE ON ME, THE GROUND, AND THE CAR CREATING A HUGE SAFETY HAZARD. THIS HAS HAPPENED SEVERAL TIMES AT NUMEROUS GAS STATIONS. I HAVE FOUND OUT RECENTLY THAT THE NITRO, ALONG WITH JEEP'S LIBERTY, IS PRONE TO THIS. THERE NEEDS TO BE A RECALL ON THIS ISSUE AND DODGE NEEDS TO TAKE CARE OF THIS IMMEDIATELY. *TR

TL*THE CONTACT OWNS A 2007 DODGE NITRO. WHILE ADDING FUEL TO THE VEHICLE WHEN IT WAS ALSO MOST FULL GASOLINE SPILLED BACK OUT OF THE FUEL TANK. THE CONTACT STATED THAT PREVIOUSLY WHEN THE FAILURE OCCURRED SHE HAD TO GO BACK HOME AND CHANGE CLOTHES. THE FAILURE ALSO OCCURRED TO ANOTHER DRIVER OF THE VEHICLE. THE FAILURE HAD BEEN ON GOING FOR FOUR TO SIX WEEKS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE DEALER WAS REPLACED THE FUEL TANK. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 16,500 AND THE CURRENT MILEAGE WAS 16,900. UPDATED 03/21/11

Mileage: 16,500

GAS HAZARD!!!! MY 2007 DODGE NITRO SPITS GAS BACK AT YOU ONCE IT HAS FINISHED FILLING. I PLACED THE NOZZLE FULLY INTO THE TANK AND CLICK THE AUTOMATIC FILLER IN PLACE AND ONCE THE NOZZLE CLICKS INDICATING IT IS FULL 1-2 CUPS OF GAS "BURPS" BACK UP SPRAYING EVERYWHERE ON ME, THE GROUND, THE CAR MAKING A GIANT MESS AND HUGE SAFETY HAZARD. THIS HAS HAPPENED NUMEROUS TIMES AT MORE THAN A COUPLE DIFFERENT LOCATIONS AND I HAVE FOUND OUT RECENTLY THAT THE NITRO IS PRONE TO THIS. THERE NEEDS TO BE A RECALL ON THIS ISSUE AND DODGE NEEDS TO TAKE CARE OF THIS IMMEDIATELY.

Mileage: 47,758

FUEL TANK BURPS BACK AFTER PUMP CLICKS OFF SPILLING APPROX. A QUART OF GAS ON THE SIDE OF VEHICLE AND THE GROUND. 2007 DODGE NITRO 4X4. *TR

Mileage: 40,136

FIRST REPAIR: VEHICLE WOULD JERK (AS IF IT WAS SHIFTING TOO HARD) WHEN GOING OVER BUMPS IN THE ROAD AND WOULD STOP (RPM GAUGE DROPS TO 0, LOSE POWER STEERING, WOULD HAVE TO COAST TO SHOULDER AND RE-START VEHICLE). FUEL INJECTOR WAS REPLACED. SECOND REPAIR: VEHICLE WOULD NOT START WITHOUT SEVERAL ATTEMPTS, ONCE IT STARTED IT WOULD STOP DRIVING (RPM GAUGE DROPS TO 0, LOSE POWER STEERING, WOULD HAVE TO COAST TO SHOULDER AND RE-START VEHICLE). RELAY WAS REPLACED. THIRD REPAIR (ABOUT TO GO BACK TO SHOP TOMORROW)- CAR STARTED NORMALLY AND THEN STOPPED WHILE DRIVING (RPM GAUGE DROPS TO 0, LOSE POWER STEERING, WOULD HAVE TO COAST TO SHOULDER AND RE-START VEHICLE). THIS IS THE THIRD TIME IN 2 WEEKS THAT THE CAR HAS BEEN IN FOR SERVICING FOR THE SAME PROBLEM, AND THE MANUFACTURER'S DEALERSHIP CANNOT FIGURE OUT WHAT IS WRONG WITH THE VEHICLE. THIS HAS BECOME A MAJOR SAFETY CONCERN, AS I DO NOT KNOW WHEN THE VEHICLE WILL STOP UNEXPECTEDLY WHILE DRIVING. I HAVE RENTED A CAR UNTIL I CAN HAVE MY CAR REPAIRED AGAIN, BECAUSE I AM AFRAID TO DRIVE MY CAR. *TR

Mileage: 39,000

GAS COMES SHOOTING OUT OF FUEL FILLER NECK WHEN FILLING UP AT NUMEROUS GAS STATIONS. *TR

MY 2007 DODGE NITRO SPITS GAS BACK AT YOU ONCE IT HAS FINISHED FILLING. I PLACE THE NOZZLE FULLY INTO THE TANK AND CLICK THE AUTOMATIC FILLER IN PLACE (AS I HAVE DONE WHEN FILLING ANY OTHER CAR IN MY LIFE) AND ONCE THE NOZZLE CLICKS INDICATING IT IS FULL 1-2 CUPS OF GAS "BURPS" BACK UP SPRAYING EVERYWHERE ON ME, THE GROUND, THE CAR MAKING A GIANT MESS AND HUGE SAFETY HAZARD. THIS HAS HAPPENED NUMEROUS TIMES AT MORE THAN A COUPLE DIFFERENT LOCATIONS AND I HAVE FOUND OUT RECENTLY THAT THE NITRO IS PRONE TO THIS. THERE NEEDS TO BE A RECALL ON THIS ISSUE AND DODGE NEEDS TO TAKE CARE OF THIS IMMEDIATELY. *TR

Mileage: 50,000

I OWN A 2007 DODGE NITRO 3.7 V6. I HAVE BEEN EXPERIENCING FOR OVER THE LAST MONTH WHEN I FILL UP THE GAS TANK IT WILL CLICK OFF AT THE NOZZLE BUT THEN I GET GAS SPEWING BACK OUT! SCARY AND A SAFETY HAZARD. I AM TOLD THIS IS A PROBLEM WITH THE ROLLOVER VALVE. THE VALVE IS DEFECTIVE, AND THUS THE GAS SPILLS OUT, AND THE CAR COULD POSSIBLY EXPLODE IN A ROLLOVER ACCIDENT. I HAVE READ THAT THIS IS A MANUFACTURING DEFECT, AND CHRYSLER/DODGE KNOWS ABOUT IT. I AM OUT OF WARRANTY FOR MY VEHICLE BUT I KNOW I AM NOT ALONE IN THIS. THE ONLY FIX I KNOW OF IS REPLACING THE GAS TANK AT MY EXPENSE. I FEEL CHRYSLER/DODGE SHOULD DO THIS AT THEIR EXPENSE SINCE THEY KNOW IT IS A COMMON PROBLEM!

Mileage: 40,000

TL* THE CONTACT OWNS A 2007 DODGE NITRO. THE CONTACT STATED THAT WHEN ADDING GASOLINE TO THE FUEL TANK IT WOULD SPEW BACK OUT FROM THE FILLER TANK. THE FAILURE WOULD OCCUR ON AN INTERMITTENT BASIS FOR A PERIOD OF ONE YEAR. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 64,200.

Mileage: 64,200

I HAVE AN 07 DODGE NITRO R/T. EVERY TIME I FILL UP THE GAS TANK, IT OVERFLOWS AND POURS OUT. IT IS A COMMON OCCURRENCE WITH THESE VEHICLES AND CLEARLY NEEDS TO BE RECALLED. APPARENTLY THIS IS DUE TO A BROKEN GAUGE IN THE GAS TANK FILLER NECK. *TR

Mileage: 30,000

WHEN FUELING, AS SOON AS THE FUEL NOZZLE AUTOMATICALLY TURNS OFF, A SIGNIFICANT AMOUNT OF GASOLINE "BURPS" OUT OF THE FILLER NECK SPILLING OUT WITH ENOUGH PRESSURE TO COVER THE ENTIRE SIDE OF THE VEHICLE AND FUEL NOZZLE HANDLE. *TR

Mileage: 23,952

EVERY TIME I FILL THE GAS TANK OF MY 2007 DODGE NITRO R/T, THE GAS BACK FLOWS OUT OF THE FILLER NECK OPENING ONCE THE GAS NOZZLE CLICKS AS THE TANK BECOMES FULL. THIS BACK FLOW POURS GAS OUT OF THE FILLER NECK, ONTO THE SIDE OF THE VEHICLE, ONTO THE GROUND AND, MOST TIMES, ON ME. I HAVE NOT APPROACHED DODGE ABOUT FIXING THIS ISSUE. OF COURSE MY WARRANTY IS GONE. NHTSA: FORCE DODGE TO DO A RECALL ON THIS ISSUE. WHAT IS IT GOING TO TAKE, SOMEONE CATCHING ON FIRE FROM GAS POURING ON THEM? *TR

Mileage: 62,913

I OWN A 2007 DODGE NITRO 3.7 V6. I HAVE BEEN EXPERIENCING FOR OVER THE LAST YEAR WHEN I FILL UP THE GAS TANK IT WILL CLICK OFF AT THE NOZZLE BUT THEN I GET GAS SPEWING BACK OUT! VERY SCARY AND A SAFETY HAZARD. I AM OUT OF WARRANTY FOR MY VEHICLE BUT I KNOW I AM NOT ALONE IN THIS. THE ONLY FIX I KNOW OF IS REPLACING THE GAS TANK AT MY EXPENSE. I FEEL DODGE SHOULD DO THIS AT THEIR EXPENSE SINCE THEY KNOW IT IS A COMMON PROBLEM! *TR

Mileage: 30,000

FUEL OVERFLOWS ALMOST EVERY TIME I FILL UP. I HAVE NOTICED THAT THE LITTLE FLAP IS NOW MISSING FROM THE TOP OF THE FILLER TUBE. *TR

Mileage: 30,000

AFTER FUELING UP THE VEHICLE, THE GAS TANK "BURPS" OUT ABOUT A GALLON AND A HALF OF GAS ALL OVER THE PERSON PUMPING GAS, THE TRUCK AND THE GROUND AROUND THE VEHICLE.

Mileage: 60,500

GAS FILLER PIPES SPIT OUT GAS WHEN FUELING RESULTING IN SPILLAGE ON VEHICLE, GROUND AND PERSON PUMPING GAS. *TR

Mileage: 50,000

WHEN FILLING TANK ON OUR 2007 DODGE NITRO, FUEL WILL POUR OUT OF FUEL FILL DOWN THE SIDE OF CAR AND ALL OVER THE FLOOR. PUMP WILL SHUT OFF AND FUEL WILL BURP OUT OF FILLER. *TR

Mileage: 33,045

WHEN FILLING WITH GAS THE TRUCK WILL NOT SIGNAL THE GAS PUMP TO "CLICK' AND SHUT OFF WHEN THE TANK IS FULL THUS CAUSING GAS TO OVERFLOW DOWN THE SIDE OF THE TRUCK. *TR

Mileage: 19,950

GASOLINE OVERFLOWS ONTO SIDE OF TRUCK AND GROUND WHEN FILLING TANK. *TR

Mileage: 30,220

GAS OVERFLOW ON THE 2007 DODGE NITRO. PURCHASED NITRO TWO WEEKS AGO AND THE LAST TWO TIMES OUT OF THREE WHEN I PUT GAS IN IT OVERFLOWED WHEN TAKING THE GAS PUMP OUT OF TANK. FIRST TIME THE PUMPED STOPPED ON IT'S OWN AND SECOND TIME I STOPPED THE PUMP MANUALLY BECAUSE I THOUGHT TOO MUCH GAS WAS GOING IN. *TR

Mileage: 29,000

WHILE FUELING MY 2007 DODGE NITRO R/T AS THE FUEL REACHES FULL AND THE GAS PUMP CLICKS OFF, SOME FUEL BURPS UP AND SPILLS TO GROUND/ON TO SIDE OF VEHICLE. THIS OCCURS EACH TIME I FILL UP THE FUEL. *TR

Mileage: 41,800

2007 DODGE NITRO OVERFILLS GAS TANK. VALVE IN GAS TANK IS NOT WORKING. POTENTIAL FIRE HAZARD. HAPPENS AT EVERY FILL UP. *TR

Mileage: 25,000

WHEN FILLING THE SUV WITH GAS. WHEN THE GAS AUTO-SHUTOFF CLICKS, GAS COMES ERUPTING OUT OF THE GAS TANK FILLER NECK. *TR

GAS OVERFLOW FROM TANK, UPON AUTOMATIC SHUTOFF. HAPPENS ON ALL FILLUPS. WILL RETURN TO DEALER FOR INSPECTION. *TR

Mileage: 5,000

SPLASH BACK OF GASOLINE WHEN FILLING UP FUEL TANK. INCIDENT OCCURS JUST ABOUT EVERY TIME TANK IS FILLED AND THE CONSEQUENCES ARE THAT A LARGE AMOUNT OF GASOLINE SHOOTS BACK OUT OF THE FILLING NOZZLE ALL OVER THE PAINTED SURFACE OF THE VEHICLE AND ON TO THE SURFACE OF THE AREA IN WHICH PARKED. IN ADDITION TO AGGRAVATION, ENVIRONMENTAL DAMAGE, PAINT DAMAGE, THERE ARE EXTREMELY DANGEROUS CONSEQUENCES THAT COULD OCCUR IF SOME SORT OF AN IGNITION SOURCE OCCURRED AT THE TIME IT HAPPENED. CONTROLLING THE FLOW/SPEED OF GASOLINE FROM THE GAS PUMP THROUGH THE NOZZLE INTO THE TANK FILLER TUBE DOES NOT LESSEN THE PROBLEM. I AM GOING TO DISCUSS THIS MATTER WITH MY DODGE SERVICE DEPARTMENT ON 18 FEB, 2010 TO FIND OUT WHAT THEY HAVE TO SAY ABOUT THE MATTER. *TR

Mileage: 43,691

GAS OVERFLOWS FROM THE TANK WHEN FILLING WITH GASOLINE. *TR

Mileage: 28,000

GAS OVERFLOWS WHEN FILLING THE GAS TANK ON THE DODGE NITRO. *TR

Mileage: 40,000

I HAVE A 2007 DODGE NITRO AND AFTER FILLING UP MY GAS TANK THE NOZZLE CLICKED AND THERE COMES FUEL GUSHING OUT ALL OVER THE PLACE. IT HAPPENS EVERY SINGLE TIME I FILL MY TANK WITH GAS. *TR

Mileage: 46,346

GAS SPILLING OUT OF GAS TANK WHEN FILLING FROM GAS PUMP. I TOOK MY NITRO IN THIS MORNING AND THEY HAD DONE AND READY TO GO BY NOON. INVOICE READS AS FOLLOWS: 78240 CONFIRM GAS OVERFLOW WHEN FILLING, TEST VENT HOSES, GOOD. FOUND ROLLOVER VALVE IN TANK NOT SEALING. REPLACED FUEL TANK AND SEAL. 1-68034783AA TANK REPLACE CHARCOAL CANISTER & O-RING. 1 4891757AC CANISTER 1 55366298AA O-RING-FUEL PUMP AND LEVEL COST TO ME WAS $425.00. *TR

Mileage: 78,500

WHILE REFUELING GAS WILL OVERFLOW ONTO THE TRUCK AND GROUND. THIS HAPPENS EVERY TIME I REFUEL NOW. IT DOES NOT MATTER HOW MUCH GAS IS IN THE TANK, WHAT GAS STATION, TIME OF DAY, WINTER OR SUMMER, THE RESULT IS THE SAME FUEL OVERFLOW. THIS STARTED ABOUT 52,000 MILES AND I HAVE 60,086 MILES NOW. *TR

Mileage: 52,000

TL*THE CONTACT OWNS 2007 DODGE NITRO SXT. THE CONTACT OBSERVED FUEL SPRAYING OUT OF THE FUEL TANK WHENEVER SHE WAS REFUELING THE VEHICLE. AN AUTHORIZED DEALER STATED THAT THE FAILURE WAS CONTRIBUTED TO THE CHECK VALVE IN THE FUEL TANK. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT HAS CONCERNS OF THE POTENTIAL SAFETY HAZARD. THE FAILURE MILEAGE WAS 35,000 AND THE CURRENT MILEAGE WAS 40,000. UPDATED 12/8/09 *CN THE CONSUMER ALSO STATED THE VEHICLE HAD A TRANSMISSION LEAK. UPDATED 12/09/09.*JB

Mileage: 35,000

TL*THE CONTACT OWNS A 2007 DODGE NITRO. WHILE ADDING FUEL TO THE VEHICLE THERE WAS A CLICKING NOISE PRESENT. WHENEVER THE FUEL BEING ADDED WAS NEAR IT'S CAPACITY IT RAPIDLY BEGAN LEAKING ON THE FLOOR. THE FAILURE OCCURRED APPROXIMATELY 7 TO 8 TIMES. THE DEALER HAS BEEN NOTIFIED. THE FUEL LEAK WILL BE REPAIRED PER THE WARRANTY. THE FAILURE MILEAGE WAS 39000 AND THE CURRENT MILEAGE WAS 40000. UPDATED 11/06/09. *LJ THE DEALER REPLACED THE ENTIRE GAS TANK. UPDATED 11/09/09

Mileage: 39,000

AS YOU ARE PUTTING GAS INTO THE FUEL TANK IT WILL OVERFLOW FROM FILLER SPOUT AND SPILL OUT CAUSING A HAZARDOUS CONDITION AND ENVIRONMENTAL PROBLEM. THIS WILL HAPPEN NOT MATTER THE AMOUNT OF FUEL IN TANK. I WAS TOLD BY DEALER THAT THE HOLE INTO THE GAS TANK IS SMALLER THAN THE FILL LINE AND CAUSES BACK UP. IF YOU TRY TO FILL VERY SLOW THE SENSOR IN THE PUMP DOES NOT DETECT AND IT OVERFLOWS. DEALER HAS REPLACED GAS TANK BUT DID NOT HELP THE PROBLEM. *TR

Mileage: 50

UNCONTROLLED ACCELLERATION OF 2007 DODGE NITRO, W/3.7 LITRE, HAS HAPPENED 5 TIMES IN SIX MONTHS OF OWNING . CANT BE FIXED BY DEALER CAUSE DOESN'T SHOW CODE OR ABLE TO DUPLICATE WHEN THEY HAVE IT , ONLY WAY TO STOP IT IS TO PUT IN NEUTRAL AND KILL ENGINE . HAVE HAD OTHER PROBLEMS LIKE IDLE ROUGH AND SURGING , AND LIKE SOMEONE TURNING KEY OFF AND ON FOR SPLIT SECOND WHILE DRIVING AT HIGHWAY SPEEDS. THERE HAS NOT BEEN ANY PATTERN TO WHEN SUDDEN ACEL HAPPENS , IT HAS BEEN RANDOM AND CAN SEEMINGLY HAPPEN W/OUT NOTICE. THE DEALER KEEPS TELLING ME TO KEEP DRIVING IT TILL IT DOES IT AGAIN SO THEY CAN TRY TO GET CODES OR SOMETHING TO TROUBLE SHOOT IT. BUT THIS IS VERY DANGEROUS AS YOU WOULD THINK. IM AT A LOSS TO WHAT TO DO , I HAVE CONTACTED DODGE COMPLAINT LINE AND THEY DON'T SEEM TO WORRIED ABOUT MY SAFETY AS IT WOULD SEEM , DO TO THEM WANTING ME TO KEEP BRINGING IT BACK TO DEALER . ALSO NO PARTS HAVE BEEN CHANGED IN ORDER TO TRY TO CORRECT ,ONLY HOOK UP SCANNER AND DRIVE AROUND BLOCK AND FLASH PROGRAMS AT IT WHICH HAS SEEMINGLY HAD ILL AFFECT ON IT AS IN MY FUEL MILEAGE HAS WENT 23-24 HIGHWAY TO ABOUT 15-18 NOW, AND THEY CANT GET IT BACK WHERE IT WAS, NOW IT IS PARKED IN DRIVEWAY AND FAMILY WONT DRIVE BECAUSE SCARED OF IT, AND I M STILL PAYING ON VEHICLE THAT IS UNSAFE AND NO IDEA HOW TO FIX , OR DODGE I SHOULD SAY, CANT FIX. *TR

Mileage: 17,000