2002 DODGE RAM 1500 Electrical System Problems

The heat stopped working so i replaced the blower motor and blower relay the heater switch and still have no heat. The wire gets hot to the touch. The heater only use to work on high then all of a sudden it just stopped all the way around

The contact owns a 2002 Dodge Ram 1500. The contact stated while attempting to turn on the heat in the vehicle, the HVAC system failed to operate as needed. The vehicle was taken to the dealer and the contact was informed that the instrument panel needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated there was no recall for the failure. There was no additional assistance provided. The failure mileage was 50,000.

Mileage: 50,000

WHILE DRIVING ALL OF THE GAUGES HAVE QUIT WORKING HEADLIGHTS STAY ON WILL NOT TURN OFF.

Mileage: 194,000

TL* THE CONTACT OWNS A 2002 DODGE RAM 1500. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. AN INDEPENDENT TOWING COMPANY TOWED THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE BACK TO THE INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE WIRE HARNESS CONVERTIBLE BOX HAD A LOT OF CORROSION AROUND IT AND NEEDED TO BE REPLACED. A COLLISION SHOP WAS CONTACTED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.

Mileage: 200,000

TRIED TO GET THE TRUCK STARTED AND COULD NOT GET IT TO WORK. TOOK THE KEYS OUT AND THROW THEM UP ON THE DASH AND THE TRUCK STARTED AND ALL ELECTRONICAL STUFF IN TRUCK CAME ON. THEN WHEN DRIVING HOME IT WOULD REV UP AND DOWN AND WOULD TRY TO SHUT OFF WHEN I HAD TO STOP

Mileage: 110,000

A FEW YEARS AFTER THE VEHICLE WAS PURCHASED, THE DASH BEGAN TO DEVELOP CRACKS AND HOLES. THIS HAS GOTTEN WORSE AND WORSE TO THE POINT WHERE A DASH COVER HAD TO BE PURCHASED TO AVOID THINGS FALLING DOWN BEHIND THE INSTRUMENT CLUSTER. CURRENTLY, THERE IS MORE MISSING THAN STILL IN PLACE IN THE VEHICLE. THIS IS A COMMON PROBLEM IN THIS GENERATION, AND DODGE HAS NOT ADDRESSED IT, OTHER THAN TO CLAIM IT IS STRICTLY COSMETIC. THE PLASTIC PIECES ARE EXTREMELY SHARP, AND HAVE RESULTED IN A NUMBER OF SUPERFICIAL CUTS WHEN WORKING ON THE DEFROST VENTS, OR WHEN ADJUSTING THE CARPETED DASH COVER. OTHER PIECES HAVE FALLEN INTO THE VENTS AND THEN BEEN EJECTED INTO BOTH DRIVER AND PASSENGER'S FACES WHEN THE AIR CONDITIONER/HEATER ARE TURNED ON. PIECES OF PLASTIC RATTLE BEHIND THE DASH, AND HAVE FALLEN INTO THE AIR CONDITIONER CONTROLS AND RADIO HARNESS, POSSIBLY BEING THE CAUSE OF THE FAILURE OF THE FRONT SPEAKERS (BUT NOT VERIFIED) IF THEY HAVE CUT THE WIRES. IF THE AIRBAG DEPLOYS, THE PERDON IN THE SEAT IS LIKELY TO BE BLINDED OR DISFIGURED FROM THE AMOUNT OF DANGEROUSLY SHARP SHRAPNEL, ASSUMING IT HAS NOT ALREADY BEEN CUT AND RENDERED USELESS. REPLACEMENT DASHES FROM DODGE ARE PRICED AT NEARLY $1,000, WHICH IS A RIDICULOUSLY EXORBITANT AMOUNT TO EXPECT CUSTOMERS TO PAY IN ORDER TO FIX A DEFECTIVE PRODUCT INSTALLED BY THE COMPANY. OVERLAYS OF DECENT QUALITY COST NEARLY A THIRD OF THAT.

Mileage: 30,000

INTERMITTENT TURN SIGNAL FAILURE. TURN LEFT SIGNAL ON, AND FLASH THEN RIGHT SIGNAL WILL OCCASIONALLY FLASH. SOMETIMES LEFT AND RIGHT WILL ALTERNATE. THIS IS NOT THE SAME AS EMERGENCY FLASHERS WHERE BOTH LIGHTS ARE ON AT THE SAME TIME. THIS IS DANGEROUS, I'M IN A LEFT TURN LANE WITH MY LEFT BLINKER ON BUT MY TRUCK IS TELLING OTHER DRIVERS THAT I WANT TO TURN RIGHT. THE FAILURE, ERRATIC BEHAVIOR IS RANDOM AND INTERMITTENT.

Mileage: 98,000

THE FCM AND PDC ARE EXTREMELY BAD ON THE 2002 DODGE. THEY CORRODE CAUSING YOUR BRAKE LIGHTS, BLINKERS, HEADLIGHTS AND EMERGENCY FLASHER NOT TO WORK. DODGE SHOULD HAVE BEEN MANDATED TO RECALL AND REPLACE BOTH PARTS ON EVERY TRUCK. THE CORROSION IS DO TO THE POOR DESIGN OF THE PDC "FUSE BOX" WITH HOLES IN THE BOTTOM ALLOWING WATER AND MOISTURE TO ENTER THE PDC AND START TO CORRODE. THIS IN TURN CAUSING THE FCM " FRONT CONTROL MODULE" TO SHORT OUT. THIS IS A SEVERE DANGER TO THE TRUCK OWNER AS WELL AS OTHER MOTORISTS AND PEDESTRIANS ON THE ROAD. THIS IS A VERY SERIOUS MATTER AND NEEDS TO BE LOOKED IN TO AND FIXED. I HAVE PERSONALLY EXPERIENCE THIS AND HAVE ALMOST BEEN HIT SEVERAL TIMES BY MOTORISTS BEHIND ME DO TO THE FACT MY TAILLIGHTS QUIT WORKING AND MY BLINKERS DID AS WELL. I HAVE REPLACED MY FCM AND PDC 4 TIMES ALREADY AND EACH ONE SHORTS OUT AFTER A YEAR. THAT'S $600-$1200 EACH TIME. DODGE IS RESPONSIBLE FOR THIS PROBLEM.

Mileage: 161,000

WHILE DRIVING OVER RAILROAD TRACKS LAST WEEK, THE KEY SLID OUT OF THE IGNITION. WHEN I ATTEMPTED TO PULL TO THE RIGHT SHOULDER, MY STEERING COLOMN LOCKED AND THE MOTOR FINALLY DIED AND COASTED TO A STOP.

Mileage: 222,750

TL* THE CONTACT OWNS A 2002 DODGE RAM 1500. WHILE DRIVING 75 MPH, THE HVAC BLOWER MOTOR FAILED TO OPERATE WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V078000 (STEERING). THE FAILURE MILEAGE WAS 190,000.

Mileage: 190,000

WHEN I TURN ON THE HEATER THE BLEND DOOR AND ACTUATOR MAKE A POPPING SOUND WHEN TURNED HEAT ON , BLEND DOORS BROKEN AND ACTUATOR NOT WORKING PROPERLY. IT OCCURS WHILE VEHICLE STATIONARY AND IN MOTION WHEN HEAT IS TURNED ON.

Mileage: 208,000

I WAS ON MY WAY HOME FROM PICKING UP MY PAYCHECK DRIVING ON THE HIGHWAY IN THE FAST LANE DOING AROUND 70 MPH WHEN ALL OF A SUDDEN MY TRUCK SHUT DOWN WITH NO WARNING AND THEN RESTARTED. I IMMEDIATELY GOT OFF OF THE HIGHWAY AND TOOK BACK ROADS. ABOUT 1.5 MILES FROM MY HOME AT A RED LIGHT THE TRUCK ONCE AGAIN SHUT DOWN COMPLETELY, NO ENGINE, NO ELECTRIC, NOTHING, IT WAS COMPLETELY DEAD ON A FAIRLY BUSY ROAD. I HAD TO HAVE THE TRUCK TOWED HOME AND HAVE NOT BEEN ABLE TO GET IT STARTED AT ALL. I WENT ONLINE TO SEE WHAT MIGHT BE THE CAUSE AND HAVE FOUND MANY RELATED CASES TO WHAT I AM DEALING WITH.

Mileage: 141,216

DASHBOARD CRACKED, LAMP LIGHT IS ON AND ALARM KEEPS DINGING. CHECKED ALL LIGHTS AND THEY ARE ALL WORKING.

Mileage: 157,523

ON JULY 8, 2012, THE MOTHER CARRIED HER 2 YEAR-OLD DAUGHTER TO HER HUSBAND'S PARKED 2002 DODGE RAM 1500 PICKUP EQUIPPED WITH A MANUAL TRANSMISSION. THE MOTHER OPENED THE PASSENGER DOOR, INSERTED THE IGNITION KEY INTO THE IGNITION SWITCH, TURNED THE KEY AS THE MOTHER WAS TRYING TO ACTIVATE THE AIR CONDITIONER AND COOL THE VEHICLE DOWN BEFORE HER HUSBAND CAME OUT TO DRIVE THEM HOME FROM CHURCH.THE VEHICLE WAS IN 1ST GEAR AND LURCHED FORWARD WHEN THE KEY WAS TURNED.THE SPEED OF 2 MPH AT TIME OF INCIDENT IS AN APPROXIMATION ONLY. THE MOTHER WAS STRUCK BY THE MOVING VEHICLE WHICH KNOCKED HER CHILD FROM HER ARMS TO THE PAVEMENT. THE CHILD SUFFERED SEVERE HEAD TRAUMA AND WAS REMOVED TO THE HOSPITAL BY AMBULANCE. THE CHILD LATER DIED IN THE EMERGENCY ROOM. THE ACCIDENTAL DEATH WAS CAUSED BY FAILURE OF THE CLUTCH IGNITION INTERLOCK SAFETY SWITCH, COMPRESSION SPRING, AND ATTENDANT PARTS. THIS IS THE SAME DEFECT INVOLVED IN RECALL NO.14V795000 AND IS AT LEAST THE SECOND DEATH CAUSED BY THIS SAME DEFECT. THE ONLY DIFFERENCE IS THAT RECALL NO. 14V795000 COVERS VEHICLES BACK TO ONLY 2004, AND THIS VEHICLE IS A 2002 MODEL YEAR. *TR

Mileage: 99,502

DASH BOARD HAS SHATTERED AND THE AIR CONDITION/HEATER DOES NOT BLOW. *TR

Mileage: 201,000

DASHBOARD BEGIN CRACKING AND FINALLY IN A COUPLE DAYS OF WEEKS BROKE APART COMPLETELY AS I HAD BEEN IN A CRASH.I CALLED THE COMPANY THEY SAID THE WARRANTY HAD EXPIRED.I TOLD THEM I HAVE 1992 FORD AEROSTAR WHOSE DASHBOARD WAS COMPLETELY .INTACT AND THAT IT WAS MUCH OLDER IT HAD TO BE A STRUCTURAL DEFECT. THEY OFFER TO PAY HALF WHICH MEANT I HAD TO PAY 500.00 DOLLARS, WHICH I DIDN'T HAVE. I FELT THEY SHOULD PAY ALL OF IT. ALSO THE AIRBAG LIGHT IS ON AND THE RPM ACCELERATE WITHOUT ME PUSHING THE GAS PEDAL.I TOOK MANY TIMES TO THE DEALERSHIP AND THEY SAID THEY WOULD FIX IT BUT THEY NEVER DID. *TR

Mileage: 35,000

TL* THE CONTACT OWNS A 2002 DODGE RAM 1500. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE CONTACT REPLACED THE TERMINAL BATTERY, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.

Mileage: 102,000

I HAVE A 2002 DODGE RAM 1500 QUAD CAB AND HAVE HAD TO REPLACE ALL THE HEATING AND COOLING COMPONENTS IN THIS TRUCK IN THE PAST FEW YEARS. LAST YEAR I STARTED HAVING AN ISSUE WITH THE HEAT/AC NOT WORKING UNLESS THE STEERING WHEEL WAS IN THE UP POSITION. I HAD ALL THE PARTS TO THE CONTROL BOARD BEHIND THE DASH REPLACED, ALL NEW KNOBS, ETC. STILL DIDN'T WORK. THEN WE STARTED DIVING INTO THESE SITES THAT TALK ABOUT ALL/ANY ISSUES THAT PEOPLE ARE HAVING WITH THIS MODEL TRUCK. SO WE SEE THAT WE NEED TO REPLACE THE REGISTER IN THE STEERING COLUMN. WELL THAT WORKED FOR ABOUT A WEEK AND NOW, AGAIN, IF I WANT AC/HEAT I HAVE TO RAISE THE STEERING UP AND DRIVE. NOT VERY SAFE!! ARE DEALERSHIPS HONORING RECALLS FOR THIS PART STILL? WHAT ABOUT ALL THE WIRING? DOES THAT NEED TO BE REPLACED TO STOP THE CONSTANT BLOWING UP OF THE REGISTER? THIS IS A GREAT LOOKING TRUCK BUT THE MONEY DUMPED INTO IT TO KEEP IT ON THE ROAD IS OUTRAGEOUS. I COULD HAVE PURCHASED TWO TRUCKS BY NOW. *TR

VEHICLE PROBLEM FIRST STARTED WHEN TURNING STEERING WHEEL TO THE RIGHT ENTIRELY. CURRENTLY VEHICLE AIRBAG LIGHT COMES ON AND OF THROUGH ALL RANGES OF STEERING. *JS

Mileage: 169,000

TL* THE CONTACT OWNS A 2002 DODGE RAM. THE CONTACT STATED THAT THE GEAR SHIFTER WOULD LOCK INTO ANY GEAR. ALSO, THE KEY WAS ABLE TO BE REMOVED FROM THE IGNITION KEY ALTHOUGHT THE VEHICLE WAS NOT IN PARK. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN. PAM

THE SPEEDOMETER STOPPED WORKING, ABS LIGHT ON, EBRAKE LIGHT ON, AIRBAG LIGHT ON, NO CONTROLS FOR DEFROSTER, FOUND NO POWER TO FUSES ON 32-38 SEVERAL PEOPLE ONLINE IN FORUMS HAVE THE SAME PROBLEM. *JS

Mileage: 93,000

HELLO, I HAVE JUST BOUGHT A 2002 DODGE RAM 1500 TRUCK FROM MY FATHER IN-LAW. BEFORE HE SOLD IT TO ME HE MENTIONED THAT THE AIR BLOWER FOR THE AIR CONDITIONING AND HEATER DOESN'T WORK. HE SAID IT WAS A RECALL THAT HE NEVER TOOK IN TO GET SERVICED. SO I LOOKED THE TRUCK UP ON THE WEBSITE WWW.RECALLS.GOV. AND SURE ENOUGH THERE IT WAS. A RECALL ON THE STEERING COLUMN ELECTRICAL CONNECT. NOW I REMEMBER RIDING WITH MY FATHER IN LAW AND HE WOULD BE CONSTANTLY MOVING THE STEERING WHEEL UP AND DOWN USING THE TILT WHEN THE AIR CONDITIONING WOULD CUT OFF AND THAT MADE IT TURN BACK ON. THE PROBLEM IS IS WHEN I GET ON THE DODGE SITE AND SEARCH FOR RECALLS USING THE VIN NUMBER THIS RECALL DOESN'T SHOW UP. I CALLED A DEALERSHIP AND THEY SAID IT DIDN'T SHOW UP EITHER. I FIND IT A LITTLE ODD THAT MY TRUCK DOESN'T SHOW THIS RECALL IS NEEDED WHEN IT IS VERY OBVIOUS THAT THIS STEERING COLUMN ELECTRICAL CONNECT IS THE VERY ISSUE I'M HAVING. AND I RECALL THAT MY FATHER IN LAW HAS HAD THIS ISSUE FOR A LONG TIME MAYBE NOT LONG AFTER HE BOUGHT THE TRUCK NEW. I THINK MY TRUCK SHOULD BE HONORED THIS RECALL SERVICE BEINGS IT IS A SAFETY HAZARD. THANKS FOR YOUR TIME. *JS

DASHBOARD STARTED CRACKING IN 2010 AND HAS PROGRESSIVELY GOTTEN WORSE. IT NOW HAS OPEN HOLES AND COMPLETELY CRACKED. AND SINCE THE LAST FEW MONTHS IT IS CAUSING ELECTRICAL FAILURE AND DANGEROUS TO DRIVE. THIS SITUATION I HAVE NOW FOUND OUT TO BE VERY COMMON FOR MY TRUCK AND NOW REALIZE THAT THIS IS NOT COMMON WEAR FOR THIS OR ANY OTHER VEHICLE. CHRYSLER HAS TOLD ME THEY ARE NOT EXCEPTING ANY RESPONSIBILITY FOR THE PRODUCT FAILURE AND THAT IT'S UP TO ME TO PAY FOR THE COSTLY REPAIRS. THIS IS UNACCEPTABLE AS THIS PROBLEM IS CLEARLY A PRODUCT DEFECT THAT THEY ARE AWARE OF AND SHOULD AT NO COST TO THE CONSUMER BE FIXED. *TR

Mileage: 75,000

DRIVING ON FLAT SURFACE STREET, HEARD LOUD POPPING NOISE. LATER REALIZED IT WAS THE DASH POPPING AND NOTICED MULTIPLE STRAIGHT CRACKS BEGINNING IN THE CORNERS OF DASH VENTS, GRADUALLY EXPANDING. CREATES MULTIPLE SMALL, SHARP SHARDS OF PLASTIC. POTENTIAL FOR NUMEROUS PROJECTILES OF PLASTIC IF EVER THE AIRBAGS WERE TO DEPLOY NOT TO MENTION NOW THAT THE ENTIRE DASH IS WEAKENED SMALL PARTS INTERMITTENTLY FALL INTO THE DASH AREA CAUSING ELECTRICAL PROBLEMS WITH ALL THE GAUGES, CAUSING WARNING LIGHTS TO ILLUMINATE AND POTENTIAL FOR FIRE IS OBVIOUS CONSIDERING OTHER DODGE RECALLS FOR WIRING PROBLEMS IN THIS MODEL TRUCK. *JS

Mileage: 307,000

VEHICLE HAS SEVERE DASH CRACKING. POWER WINDOWS ARE NOT WORKING AND LAMP INDICATOR WILL NOT SHUT OFF CAUSING ONGOING BEEPING. CONCERNED THAT DASH PARTS ARE STUCK INSIDE CAUSING DRIVING CONDITIONS TO BE UNSAFE. WOULD LIKE TO BE NOTIFIED IF AN INVESTIGATION HAS BEEN DONE TO REMEDY THE PROBLEMS AT DEALER COST. *TR

THERE WAS AN ELECTRICAL FAILURE IN THE WIRING SYSTEM FROM THE FUSE BLOCK THIS IS KNOWN TO BE A COMMON PROBLEM WITH THE DODGE RAMS THE ABS LIGHT, BRAKE LIGHT AND AIRBAG LIGHT AS WELL AS THE ENGINE LIGHT ALL COME ON ALSO THE ODOMETER AND SPEEDOMETER ALSO STOP WORKING. THIS STOPS THE ABS SYSTEM FROM WORKING AS WELL AS THE AIRBAGS I HAVE HAD TO CHANGE THE FUSE BLOCK AS WELL AS THE REAR SPEED SENSOR, AND THE DASH CLUSTER BECAUSE OF THIS OVER A THREE YEAR PERIOD NOW, THE FIRST TIME ALL OF MY LIGHTS STOPPED WORKING AS WELL AS THE DASH GAUGES AND DOOR LOCKS. WHY IS THIS AND ONGOING PROBLEM WITH THIS AND NOTHING SEEMS TO GET DONE ABOUT IT THE FIRST TIME I GOT A COPY OF A SERVICE BULLETIN AND DODGE TRIED TO TELL ME IT WAS ONLY GOOD FOR DIESEL MODELS AND I HAVE THE SAME ISSUES. THERE SEEMS TO BE A REAL HISTORY OF THESE PROBLEMS WITH THIS VEHICLE AND THE DEALERS ARE ALL AWARE OF THIS. *TR

Mileage: 117,320

I WAS JUST DRIVING ALONG, CRACK MY DASH CRACKED FROM FRONT END TO ALMOST THE BACK. THE CRACK CAUSED ME TO JUMP SWERVE MY TRUCK ALMOST CAUSING AN ACCIDENT. DODGE HAS BEEN NO HELP AND MY DASH HAS DETERIORATED EVEN MORE EVER SINCE, I'M GETTING VERY WORRIED IT MIGHT AFFECT THE AIR BAGS AS ALL THE DASH PIECES FALL INTO THE RECESS WHERE THE AIR BAGS ARE WHICH WOULD BE A BAD THING SHOULD THERE BE AN ACCIDENT. *TR

Mileage: 70,000

HI, I READ AN ARTICLE BY CHANNEL 6 NEWS PROBLEM SOLVERS IN ORLANDO, FLORIDA. THAT DID A REPORT ON DASHBOARDS COLLAPSING IN 2002 DODGE RAM AND OTHER MODELS. IN THE ARTICLE, IT SHOWED THAT DODGE WAS REPLACING THE DASHBOARDS AT A COST OF $100 TO THE CUSTOMER. 2 YEARS AFTER I BOUGHT MY TRUCK, MY DASH STARTED CRACKING. A FRIEND OF MINE HAD A 2003 QUAD CAB AND HE WAS EXPERIENCING CRACKS IN HIS DASH IN THE EXACT SAME SPOTS. A YEAR LATER HE TRADED HIS TRUCK IN AND I STILL HAVE MINE. MY DASH IS STILL CONTINUING TO CRACK TO THIS DAY. SINCE MY DASH STARTED CRACKING, I HAVE HAD OTHER PROBLEMS WITH MY TRUCK. MY STEREO IS MESSING UP. MY A/C AND BLOWER MOTOR DON'T WORK RIGHT. MY HEATER CORE LEAKS. IN SUMMER TIME I HAVE NO A/C. IN WINTER I HAVE NO HEAT AND NO WINDOW DEFROSTER. WHEN IT RAINS, I HAVE NO DEFROSTER. THESE ARE A SAFETY ISSUE IF I CANT SEE WHERE IM DRIVING. FOR THE PAST 2 YEARS, I'VE BEEN TRYING TO GET DODGE TO REPLACE MY DASH. THEY WILL REPLACE IT ONLY AT FULL COST TO ME! WILL YOU FINALLY FORCE DODGE INTO RECALLING THESE 01-04 DODGE RAM, DAKOTA AND DURANGO DASHBOARDS???????????????????????. *TR

Mileage: 63,000

AIR CONDITIONING WORKS FINE, AS LONG AS THE VEHICLE IS MOVING. WHEN STOPPED AT TRAFFIC LIGHTS OR INTERSECTIONS, THE A/C GETS WARM, AS IF THE CONDENSER IS NOT WORKING. WHEN STARTING UP AGAIN, IT GETS COLD AFTER A BIT OF TIME. SEARCHED THE INTERNET, AND FOUND THIS IS A PROBLEM THAT OCCURS OFTEN, AND MANY SAID CHECK THE FUSE #39. ON AUG. 1, I CHECKED THE FUSE, AND FOUND THAT THE PLASTIC AND METAL PARTS OF THE FUSE HAD MELTED ONTO THE SPOT IT WAS PLUGGED INTO. ALL OF THE OTHER FUSES SEEM TO BE FINE, BUT THERE IS A TINY CHUNK OF METAL I CANNOT REMOVE FROM THE FUSEBOX TO PLUG IN ANOTHER FUSE, NOR DO I WANT TO PLUG IN ANOTHER FUSE, AS I DON'T KNOW WHY THE PREVIOUS ONE MELTED. I AM NOT SURE IF THIS IS COVERED IN ANY RECALLS. ALSO, WHEN I TRIED TO HAVE THE TRUCK INSPECTED, IT FAILED FOR THE CHECK ENGINE LIGHT, AND THERE ARE SEVERAL RECALLS LISTED IN THE POSSIBLE CAUSE LIST FOR THE CODE THAT REGISTERED IN THE INSPECTION MACHINE. *TR

Mileage: 126,932

TL* THE CONTACT OWNS A 2002 DODGE RAM 1500. THE CONTACT STATED THAT THE KEYS COULD BE EASILY REMOVED FROM THE IGNITION WHILE DRIVING OR WHEN ANY GEAR. OCCASIONALLY, THE VEHICLE COULD NOT BE SHIFTED INTO PARK, CAUSING THE VEHICLE TO ACCELERATE BACKWARD. THE DEALER WAS NOTIFIED OF THE ISSUE WHO ADVISED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 208,000.

Mileage: 208,000

VEHICLE BLOWER MOTOR FUSE WAS BLOWN ON THIS OCCASION, AND THEN LATER DATES THE AC CONDENSER FAN FUSE WAS BLOWN. THE 40 AMP FUSE FOR THE BLOWER MOTOR WAS REPLACED TO FIX THE FIRST PROBLEM. THE CONDENSER FAN FUSE WAS REPLACED AT LEAST ONCE, AND THEN THE FUSE BOX - WHERE THE CONDENSER FAN FUSE GOES - MELTED SO THAT THE FUSE COULD NOT BE REPLACED. TAKING IT TO THE DEALER TODAY. ALSO NOTICED LOTS OF DASHBOARD CRACKING COMPLAINTS. I ALSO HAVE A DASHBOARD THAT IS SERIOUSLY CRACKED. PAID TO REPLACE THE PART CLOSEST TO THE WINDOW, BUT THE DASHBOARD OVER THE INSTRUMENT PANEL WAS NOT REPLACED. ASKED DEALER TO REPLACE IT THREE TIMES, AND ALL THREE TIMES THEY SAID NONE WAS IN STOCK. ONE PERSON TOLD ME THAT THEY DON'T LIKE REPLACING THEM BECAUSE OF THE COMPLEXITY OF THE JOB. *TR

Mileage: 11,615

TL* THE CONTACT OWNS A 2002 DODGE RAM 1500 QUADCAB. WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT APPROACHED A TURN HOWEVER, THE TURN SIGNAL FAILED TO RESPOND WHEN ENGAGED. THE WINDSHIELD WIPERS, HORN AND REAR BRAKE LIGHTS BECAME INOPERABLE. IN ADDITION, BOTH TURN SIGNALS WOULD NOT FUNCTION UPON ACTIVATION. A CERTIFIED MECHANIC INSPECTED THE VEHICLE AND WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. IN ADDITION, LARGE FRAGMENTS OF MATERIAL SEPARATED THROUGHOUT THE DASHBOARD SURFACE. THERE WERE ALSO NUMEROUS CRACKS WITHIN THE DASHBOARD. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PERMANENT MALFUNCTIONS. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.

Mileage: 112,000

2002 DODGE RAM 1500 SLT 2WD 5.9 V8 (GAS) WITH 86,000 MILES. TURN SIGNALS HAVE SUDDENLY BECOME DANGEROUSLY INTERMITTENT. ALSO, OCCASIONALLY WHEN SIGNALING 'LEFT' THE RIGHT DASH INDICATOR FOR THE TURN SIGNALS WILL FLASH INSTEAD. IT HAPPENED TWICE TODAY, WE TURNED THE SIGNAL OFF THEN BACK 'ON' AND IT WORKED PROPERLY. BECAUSE THIS IS INTERMITTENT WE CANNOT DUPLICATE THE PROBLEM TO DETERMINE IF THE OUTSIDE BULBS ARE FLASHING LEFT OR RIGHT, THEREFORE WE WORRY THEY MIGHT BE INCORRECTLY SIGNALING OUR INTENTIONS TO OTHER DRIVERS. WHILE SEARCHING ON-LINE FOR A SOLUTION BEFORE WE DETERMINE A REPAIR COURSE OF ACTION, WE DISCOVERED THIS IS COMMON TO THE DODGE RAM TRUCKS FROM 2002 THROUGH AT LEAST 2008 MODEL YEAR TRUCKS, BUT THE DEALER DID NOT MENTION OR ADDRESS IT IN ADVANCE OF FAILURE. WE PAID IN ADVANCE FOR A SEVEN YEAR 100% WARRANTY WITH NO DEDUCTIBLE, WHICH HAS NOT EXPIRED. WE BELIEVE DODGE HAD PRIOR KNOWLEDGE OF THE WEAKNESS AND COULD HAVE REPAIRED IT DURING THE NO-DEDUCTIBLE WARRANTY PERIOD. THE PASSENGER DOOR WINDOW SWITCH CONTINUES TO FAIL. ITS A SIMPLE PLUG-IN MODULE AND I HAVE REPLACED IT TWICE WITH THE FACTORY PART, AND NOW ITS INTERMITTENT AGAIN AFTER LESS THAN ONE YEAR. FROM THE MILEAGE ITS CLEAR WE ARE NOT WEARING OUT SWITCHES. *TR

Mileage: 85,075

WHEN TURNING LEFT AND SIGNAL IS APPLIED, THE RIGHT BLINKER COMES ON INSIDE & OUTSIDE AND WHEN RIGHT SIGNAL IS APPLIED NOTHING HAPPENS INSIDE OR OUTSIDE. *TR

Mileage: 144,875

SEVERELY CRACKED DASH BOARD. PARTS FALLING DOWN INTO THE ELECTRICAL WIRING INCLUDING AIRBAG AREA. CONTINUES TO CRACK IN DIFFERENT AREAS. MAJOR PORTIONS OF THE DASH IS CAVING IN. COULD CAUSE GAUGE, LIGHTING, AIRBAG AND HEATING/COOLING PROBLEMS. *TR

Mileage: 111,000

ABOUT 50% OF THE TIME WHEN I TURN THE TURN SIGNAL TO THE LEFT THE RIGHT SIDE BLINKS. I HAVE TO TURN THEM OFF AND TRY AGAIN AND IT WILL WORK. THE OTHER DAY I WAS ENTERING A ON RAMP AND I SIGNALED TO THE LEFT AND NO ONE WOULD LET ME IN. I HAD TO SLOW DOWN SO I WOULDN'T GET RAN OFF THE ROAD BUT ALMOST GOT REAR ENDED. I LOOKED DOWN AND THE RIGHT SIGNAL WAS ON BUT THE LEVER WAS TO THE LEFT. I COULD HAVE DIED. I HAVE ALSO NOTICED THAT THE HAZARD BUTTON WILL NOT STAY DOWN. IT IS ALWAYS POPPED UP AND THE HAZARD FLASHERS STAY ON AND RUN THE BATTERY DOWN. I HAVE TO TAKE THE BUTTON DOWN SO THE BATTERY WONT DRAIN. *TR

Mileage: 143,000

HAVE HAD A CRACKED DASHBOARD FOR QUITE SOME TIME NOW, I HAVE FILED A COMPLAINT BEFORE AND COULD NOT GET A RESOLUTION FROM CHRYSLER/DODGE. MY DASHBOARD HAS CRACKED TO PIECES CAUSING A SAFETY HAZARD. FINALLY MY ELECTRICAL SYSTEMS HAVE STARTED TO MALFUNCTION DUE TO THE PIECES OF MY FALLEN DASHBOARD FALLING ON ELECTRICAL COMPONENTS, THERE WAS A SMALL SHORT/FIRE THAT CAUSED MY CRUISE CONTROL TO STOP WORKING AND MY DASH LIGHTS ALSO. I FEEL IT HAS BEEN LONG ENOUGH AND SOMETHING NEEDS TO BE DONE BEFORE, SOMEONE NOT AS LUCKY AS ME, GETS REALLY HURT FROM THIS SAFETY HAZARD ISSUE THAT HAS HAUNTED US DODGE RAM OWNERS FOR A LONG TIME. WE NEED TO GET OUR DASHBOARD REPLACED ASAP. *TR

Mileage: 114,000

SIGNIFICANT CRACKS IN BOTH PRIMARY DASH AND AUXILIARY DASH SECTION BETWEEN DASH AND WINDSHIELD. EXISTING CRACKS GROWING/OPENING AND NEW ONES DEVELOPING. STARTING TO EXPERIENCE UNEXPLAINABLE ELECTRICAL ISSUES, LIKE POWER WINDOWS, AND DOOR LOCKS NOT WORKING ON OCCASION. DEALER QUOTED REPLACEMENT COST IS OUTRAGEOUS. *TR

Mileage: 65,000

OUR DODGE RAM 1500 WAS WORKING FINE ONE DAY THE NEXT DAY THE HEADLIGHTS, TURN SIGNALS, AND BRAKE LIGHTS WERE NOT FUNCTIONING. WE CHECKED FUSES AND ANYTHING ELSE OBVIOUS. THE NEXT DAY WE TOOK IT TO A MECHANIC, AFTER HALF A DAY OF CHECKING HE FOUND THAT THE FUSE AND RELAY CENTER (INTEGRATED POWER MODULE) WHICH IS LOCATED UNDER THE HOOD WAS CORRODED. THIS BOX IS NOT AIR TIGHT AND ALLOWS WATER TO GET INSIDE AND CORRODE THE INSIDES. DODGE DEALER ADVISED THEY REPLACE THE FUSE AND RELAY CENTER AND FCM (FRONT CONTROL MODULE) TOGETHER. THE FCM IS CONNECTED TO THE IPM (INTEGRATED POWER MODULE). COME TO FIND OUT THE IPM IS NOT SEALED FROM THE ELEMENTS. THE CIRCUIT BOARD IS EXPOSED FROM THE BOTTOM WHICH ALLOWS WATER TO SPLASH INTO THE MODULE THEREBY SHORTING THE FCM. I BELIEVED DODGE KNOWS THIS IS A POOR DESIGN AND IS UNSAFE BECAUSE THE NEW PARTS HAVE BEEN REDESIGNED WHICH IS SEALED FROM THE ELEMENTS. THIS IS DANGEROUS BECAUSE OF OBVIOUS REASONS. I BELIEVE THIS IS A DESIGN DEFECT AND SHOULD BE RECALLED BECAUSE THE WIRING SYSTEM PROBLEMS RESULT IN LOSS OF LIGHTING. FOR IT IS VERY DANGEROUS TO DRIVE THIS WAY. PER NHTSA INFO: WHEN IS A RECALL NECESSARY? WHEN A MOTOR VEHICLE OR ITEM OF MOTOR VEHICLE EQUIPMENT (INCLUDING TIRES) DOES NOT COMPLY WITH A FEDERAL MOTOR VEHICLE SAFETY STANDARD. WHEN THERE IS A SAFETY-RELATED DEFECT IN THE VEHICLE OR EQUIPMENT. WHAT IS A SAFETY-RELATED DEFECT? THE UNITED STATES CODE FOR MOTOR VEHICLE SAFETY (TITLE 49, CHAPTER 301). EXAMPLES OF DEFECTS CONSIDERED SAFETY-RELATED--WIRING SYSTEM PROBLEMS THAT RESULT IN A FIRE OR LOSS OF LIGHTING. *KB

Mileage: 104,000

I OWN A 2002 DODGE RAM 1500 AND MY TAILLIGHTS/RUNNING LIGHTS SUDDENLY STOPPED WORKING. I WAS NEARLY REAR ENDED BY ANOTHER VEHICLE. I CHECKED WITH A TECHNICIAN AND HE STATED THIS WAS A COMMON PROBLEM DUE TO MOISTURE IN THE FUSE BOX. IT WAS GOING TO COST ME CLOSE TO 1000.00 DOLLARS TO BE REPAIRED. THE TECH STATED THIS SHOULD NOT HAPPEN AND IT IS A MANUFACTURING DEFECT. HE STATED A REPLACEMENT COMES WITH A SHIELD TO PROTECT IT FROM SHORTING OUT. IT SOUNDS TO ME LIKE THIS IS A PROBLEM THAT DODGE SHOULD BE LIABLE FOR SINCE IT IS A "MANUFACTURING DEFECT" *KB

Mileage: 71,000

I OWN A 2002 DODGE RAM 1500 AND MY TAILLIGHTS/RUNNING LIGHTS SUDDENLY STOPPED WORKING. I WAS NEARLY REAR ENDED BY ANOTHER VEHICLE. I CHECKED WITH A TECHNICIAN AND HE STATED THIS WAS A COMMON PROBLEM DUE TO MOISTURE IN THE FUSE BOX. IT WAS GOING TO COST ME CLOSE TO 1000.00 DOLLARS TO BE REPAIRED. THE TECH STATED THIS SHOULD NOT HAPPEN AND IT IS A MANUFACTURING DEFECT. HE STATED A REPLACEMENT COMES WITH A SHIELD TO PROTECT IT FROM SHORTING OUT. IT SOUNDS TO ME LIKE THIS IS A PROBLEM THAT DODGE SHOULD BE LIABLE FOR SINCE IT IS A "MANUFACTURING DEFECT" *KB

Mileage: 71,000

TL* THE CONTACT OWNS A 2002 DODGE RAM 1500. THE CONTACT STATED THAT THE INSTRUMENT PANEL WAS CRACKED APPROXIMATELY ONE INCH STARTING FROM THE PASSENGER SIDE. OVER A TWO YEAR PERIOD, THE INSTRUMENT PANEL CAVED IN AND THE INDICATORS WERE NO LONGER CONCEALED BY THE PANEL. BOTH THE MANUFACTURER AND DEALER WERE NOTIFIED OF THE FAILURE AND DIAGNOSED THAT THE INSTRUMENT PANEL WOULD HAVE TO BE REPLACED YET THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 35,000.

Mileage: 29,000

I WAS DRIVING HOME ONE NIGHT FROM SHOPPING AT WALMART AND WAS PULLED OVER BY THE LOCAL LAW ENFORCEMENT FOR NOT HAVING ANY TAIL-LIGHTS ON MY 2002 DODGE RAM. COME TO FIND OUT , NONE OF MY PARKING LIGHTS WORKED, BUT THE SIGNAL AND BRAKE LIGHTS DID WORK. UPON FURTHER INVESTIGATION AND A VISIT TO THE LOCAL DODGE DEALER TO FIND OUT THAT THE PARKING LIGHT CIRCUIT HAD BLOWN AND I WOULD NEED A NEW FUSE BOX ($550.00) AND A FRONT CONTROL MODULE ($250.00) AND AN HOUR AND A HALF OF LABOR ($133.50) + TAX, TOTALS CLOSE TO $1000.00 TO REPAIR A DEFECT THAT CHRYSLER/DODGE KNOWS ABOUT AND HAS THE DIAGNOSTIC EQUIPMENT TO SEARCH FOR SUCH A PROBLEM. ACCORDING TO THE PARTS PERSON AT THAT SAME DODGE DEALER I WENT TO, THIS A COMMON PROBLEM WITH DODGE TRUCKS. FROM MY INVESTIGATION ON THE INTERNET, I FOUND I AM NOT THE ONLY PERSON WITH THIS PROBLEM AND THAT THIS IS NOT THE ONLY MODEL YEAR THAT HAS THIS PROBLEM. THERE SHOULD BE A RECALL ON CHRYSLER/DODGE'S PART BEFORE THIS RESULT IN AN ACCIDENT AND/OR LOSS OF LIFE ON THE ROAD DUE TO A FAULTY CIRCUIT ON A CIRCUIT BOARD. THEY ARE MAKING MONEY ON AN ITEM THAT INVOLVES PUBLIC SAFETY. *TR

Mileage: 131,000

STARTED TRUCK TURNED ON HEADLIGHT SWITCH ,WAS ON HIGH BEAM SO PULLED LEVER TO DIM AN LIGHTS WOULD NOT DIM THEN WIPERS COME ON AND WOULDNT SHUT OFF AND WIPER SPRAYER COME ON AND WOULD NOT SHUT OFF BUT IF I HELD LEVER BACK ALL WENT OFF SO HAVE TO DRIVE HOLDING LEVER BACK.WHEN I GOT HOME AND SHUT TRUCK OFF ALL OF THE PROBLEMS WOULD NOT SHUT OFF EVEN WITH KEY OUT OF IGNITION SO HAD TO TIE LEVER BACK. *TR

Mileage: 130,000

DASHBOARD CRACKING AND HOLES IN IT. ENGINE WON'T SHIFT GEARS NOW AND DASHBOARD LIGHTS GO COMPLETELY OUT AT TIMES. *TR

Mileage: 120,000

DODGE RAM GAUGE CLUSTER GOES OUT ABOUT 5 YEARS AFTER THE RECALLED WIRING HARNESS WAS FIXED. WHEN THE GAUGE CLUSTER WENT OUT I HAD TO PAY TO HAVE THAT HARNESS FIXED AGAIN BECAUSE THAT'S WHAT SHORTED IT ALL OUT. ALSO THE RAPIER SHOP WAS NOT ABLE TO PUT BACK MY MILEAGE TO 63,XXX. IT NOW SHOWS 119,XXX. THAT'S ALMOST 55,XXX MILES MORE THEN I DOVE IN TO THAT SHOP WITH. YES I HAVE ALL THE OLD PARTS. THIS IS A VERY COMMON THING FOR THIS TRUCKS. DODGE DOES NOT WANT TO MAKE IT RIGHT. *TR

Mileage: 63,000

STOPPED SEVERAL TIMES FOR NO TAILLIGHTS. WAS ADVISED THAT I COULD BE RAN OVER FOR NOT HAVING TAIL LIGHTS. LAMP OUT INDICATOR WAS NOT LIT. MECHANIC TRACED PROBLEM DOWN TO FCM (FRONT CONTROL MODULE). *TR

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. THE CONTACT STATED THAT THE EXTERIOR LIGHTS (PARKING LIGHTS) FAILED AND THEY WOULD NOT ILLUMINATE WHEN NEEDED. THE CRUISE CONTROL LIGHT ON THE STEERING WHEEL ALSO FAILED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FUSE BOX NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED BUT THE PARTS WERE ORDERED. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 101,000. THE FAILURE MILEAGE WAS APPROXIMATELY 100,980.

Mileage: 100,980

NO PARKING LIGHTS. THE FUSE BOX IS NEEDED TO BE REPLACED. *TR

Mileage: 100,980

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. THE CONTACT NOTICED THAT IN MAY 2010, THERE WAS A SMALL CRACK ON THE RIGHT SIDE OF THE INSTRUMENT PANEL. AS OF AUGUST 2010, THE CRACK BECAME BIGGER FROM THE WINDSHIELD TO OVER THE GAUGES. THE INSTRUMENT PANEL WAS ALSO BEGINNING TO SEPARATE. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT HAD NOT SPOKEN WITH THE MANUFACTURER AT THE TIME OF THE COMPLAINT. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE WAS APPROXIMATELY 68,000. THE FAILURE MILEAGE WAS APPROXIMATELY 66,000.

Mileage: 66,000

RECENTLY I HAD TO REPLACE THE MAJOR FUSE BOX IN MY 2002 DODGE RAM1500. THE OLD BOX SHORTED OUT AND AS A RESULT I LOST MY PARK LIGHTS, DRIVING LIGHTS, AS WELL AS MY LICENSE PLATE LIGHTS. I WAS FIRST MADE AWARE OF IT BY THE POLICE WHEN I WAS OUT DRIVING WITH NO TAIL LIGHTS. IT WAS A GOOD THING I WAS STOPPED OR I COULD HAVE BEEN REARENDED OR IN A MAJOR ACCIDENT BEFORE I NOTICED THEY WERE NOT WORKING. I ENDED UP REPLACING THE FUSE BOX AT A COST OF 600.00. I GUESS THIS WAS A CONCERN OF DODGE BECAUSE THEY HAD FUSE BOXES ONHAND AND AVAILABLE. *TR

Mileage: 115,000

JAN. 10, 2010 A VERY LARGE CRACK APPEARED IN THE DASH ON MY 2002 DODGE 1500 PICKUP AT FIRST IT WAS JUST A COSMETIC THING ,BUT NOW ALL THE WIRING IS EXPOSED THE VEHICLE TURN INDICATORS DO NOT WORK WHEN IT IS BAD WEATHER THE WINDSHIELD WIPERS DON'T WORK AND THE DEFROSTERS WILL NOT CHANGE FROM COLD TO HOT. I WENT TO THE DEALER THEY ADVISED ME IT WAS NOT THEIR PROBLEM ,BUT I HAVE LEARNED THAT I AM NOT THE ONLY ONE THIS HAS AFFECTED AND MY PROBLEM IS A SERIOUS SAFETY ISSUE. *TR

I HAVE A 2002 DODGE RAM 1500 4DR 4WD.I JUST HAD MY TRUCK INSPECTED AND ALL LIGHTING WORKED FINE. I WAS PULLED OVER EASTER EVENING BY A NEW YORK STATE TROOPER AND NOTIFIED THAT MY REAR LIGHTS WERE OUT INCLUDING PARRKING, RUNNING, AND LICENSE PLATE LIGHTS, AS WELL AS FRONT RUNNING LIGHTS.I WAS INFORMED TO TURN 4 WAY FLASHERS ON WHILE DRIVING AT NIGHT TO MY DESTINATION. AFTER CHECKING ALL FUSES,B BULBS, RELAYS AND WIRING ARE ALL GOOD. WHEN I CHECKED FOR SIMILIAR PROBLEMS VIA INTERNET AND MY LOCAL MECHANIC AND A DODGE DEALER I WAS NOTIFIED THAT THE FUSE BOX WOULD HAVE TO BE REPLACED AND THE FRONT CONTROL MODULE. THIS IS A PART THAT SHOULD NOT GO BAD AS YOU HAVE TO CHANGE THE WHOLE BOX FOR JUST LIGHTS GOING OUT,WHICH DODGE SAYS IS AN UNSERVICEABLE PART THAT CORRODES WITHIN A SEALED BOX?AND THAT HAS TO BE CHANGED AS A WHOLE UNIT. THERE ARE NUMEROUS COMPLAINTS VIA INTERNET ETC OF THIS PROBLEM AND THAT DODGE WILL NOT BUDGE TO FIX THE PROBLEM THAT THEY ARE VERY AWARE OF OCCURING.THE CONSUMER SHOULD NOT HAVE TO PAY FOR THIS REPAIR ESTIMATES ARE ANYWHERE FROM $250 TO OVER A $1000 DOLLARS JUST TO REPLACE THE DEFECT.AND ALSO THAT DODGE HAS A BACK ORDER OF THESE BECAUSE OF THE NUMEROUS PROBLEMS WITH THEM. THE CONSEQUENCES ARE THAT THE LIGHTS WILL GO OUT WITHOUT NOTICE OR A BULB OUT LIGHT BEING SIGNALLED THEEBY CAUSING ANOTHER VEHICLE TO REAREND OR SERIOUSLY INJURE SOMEONE WITHOUT THESE LIGHTS AT NIGHT. THE TROOPER STATED ALSO THAT HE HAS SEEN THIS BEFORE ON DODGE TRUCKS. *TR

Mileage: 112,000

TL* THE CONTACT OWNS A 2002 DODGE RAM. WHILE DRIVING AT NIGHT THE HEADLIGHTS FAILED. HE STATED THAT WATER ENTERED THE POWER DISTRIBUTION CENTER BOX AND CAUSED IT TO SHORT CIRCUIT. NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 95,000.

Mileage: 95,000

DRIVING THROUGH A PUDDLE AFTER A RAIN STORM, SEVERAL SAFETY FEATURES STOPPED FUNCTIONING: WIPERS, TURN SIGNALS, HORN, HEADLIGHT CONTROL. I'M NOT SURE WHAT ELSE IS NOT FUNCTIONING BUT THESE HAVE BEEN VERIFIED. NARROWED THE PROBLEM DOWN TO THE FCM (FRONT CONTROL MODULE). THE FCM IS CONNECTED TO THE IPM (INTEGRATED POWER MODULE). COME TO FIND OUT THE IPM IS NOT SEALED FROM THE ELEMENTS. THE CIRCUIT BOARD IS EXPOSED FROM THE BOTTOM WHICH ALLOWS WATER TO SPLASH INTO THE MODULE THEREBY SHORTING THE FCM. I BELIEVED DODGE KNOWS THIS IS A POOR DESIGN AND IS UNSAFE BECAUSE I'VE READ THAT THEY'VE DESIGNED A REPLACEMENT IPM WHICH IS SEALED FROM THE ELEMENTS. THIS IS DANGEROUS BECAUSE OF OBVIOUS REASONS. *TR

Mileage: 83,000

THE HEATER / AC FAN BECAME INOPERATIVE AT ANYTHING OTHER THAN THE HIGH SPEED SETTING. WHEN I REMOVED THE FAN SPEED RESISTOR BLOCK I FOUND THE AREA TO BE PACKED WITH DRY AND BURNT LEAVES AND ACORN CAPS, CONSISTENT WITH THOSE FROM THE COAST LIVE OAK TREES ON MY PROPERTY AND IN MY COMMUNITY. THE RESISTOR BLOCK POWER SUPPLY IS EQUIPPED WITH A SPRING-LOADED SOLDER CONNECTION APPARENTLY DESIGNED TO INTERRUPT POWER IF THE CIRCUIT BECOMES HOT ENOUGH TO APPROACH THE MELTING POINT OF THE SOLDER. THE SYSTEM PARTIALLY WORKED BY CUTTING POWER UNDER EXTREME HEAT CONDITIONS. I FEEL THOUGH, THAT ALLOWING A LARGE QUANTITY OF COMBUSTIBLE MATERIALS TO ENTER AND COLLECT IN AN AREA WHERE HEAT APPROACHING THE MELTING POINT OF SOLDER IS PRESENT IS UNACCEPTABLE. I PHOTOGRAPHED AND RETAINED ALL OF THE DRY TREE MATERIAL POSSIBLE THAT WAS REMOVED FROM THE RESISTOR / FAN AREA. MUCH OF IT WAS REDUCED TO A BLACK CARBON POWDER. THE VOLUME WOULD BE APPROXIMATELY 50 CUBIC INCHES OF LOOSE MATERIAL. I RESOLDERED THE SPRING-LOADED CONNECTION AND RE-INSTALLED THE RESISTOR BLOCK. INITIAL TESTS SHOWED THAT IT WAS OPERATING CORRECTLY AND COOL TO THE TOUCH. SEVERAL HOURS OF DRIVING THIS PAST WEEKEND PRODUCED THE SAME RESULTS BUT I WOULD LIKE TO REPLACE THE RESISTOR. *TR

Mileage: 68,000

MY 2002 DODGE CARAVAN HAS NUMEROUS ELECTRICAL PROBLEMS. THE PASSENGER AND BACK WINDOWS ONLY WORK INTERMITTENTLY. THE INSIDE DOOR PANEL ON THE DRIVER'S SIDE IS ALSO BECOMING LOOSE. THE AIR CONDITIONER STARTED ONLY WORKING ON HIGH SPEED. THEN IT WOULDN'T WORK AT ALL UNLESS YOU GIGGLED THE KEY A CERTAIN WAY. NOW IT WON'T WORK AT ALL. THESE TRUCKS HAVE BEEN SUBJECT TO A RECALL FOR THIS ISSUE. "THE ELECTRICAL CONNECTOR AT THE BOTTOM OF THE STEERING COLUMN CONTAINS AN UNDER-SIZED TERMINAL FOR THE HVAC BLOWER MOTOR CIRCUIT." PER THE RECALL "'DEALERS WILL INSTALL A WIRING HARNESS OVERLAY TO CORRECT THIS CONDITION" I CONTACTED THE DEALER WHERE I BOUGHT THE MONSTROSITY AND HE WAS RUDE AND CLAIMED THIS TRUCK WAS NOT SUBJECT TO THAT RECALL. I ALSO CALLED THE NATIONAL NUMBER AND THEY REFUSED TO REPAIR THEIR DEFECTIVE VEHICLE. WE LIVE IN FLORIDA AND IT IS DANGEROUS TO HAVE TO RIDE IN A VEHICLE WITHOUT AIR CONDITIONING. OUR DODGE CARAVAN ALSO HAS A DEFECTIVE AIR CONDITIONER. I RUE THE DAY I EVER BOUGHT A DODGE. *TR

Mileage: 70,000

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. IN 2006, THE BATTERY WAS REPLACED IN THE CONTACT'S VEHICLE. WHEN HE STARTED THE VEHICLE, THE HEADLIGHTS REMAINED ILLUMINATED AND THE TURN SIGNALS, HORN, AND BRAKE LIGHTS NO LONGER WORKED. HE CALLED DAIMLER CHRYSLER AND WAS INFORMED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE CONTACT STATED THAT THE TAIL LIGHTS DID NOT WORK WHEN THE VEHICLE WAS PURCHASED. HE FEELS THESE ARE ALL SAFETY ISSUES. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS 138,844 AND FAILURE MILEAGE WAS 84,000.

Mileage: 84,000

1) INTERIOR BLOWER FAN: (24,000 MILES) FAN WOULD SHUT OFF AT TIMES. FIRST TOLD BY DEALER THE AIR INTAKE WAS BLOCKED WITH LEAVES AND THEY CLEANED IT OUT. TWO WEEKS LATER, I GOT THE RECALL THAT THE WIRING HARNESS FOR THE BLOWER WAS OVERHEATING. I HAD THE DEALER DO REPAIR FOR RECALL. THEY CLIPPED THE TWO LIGHTER WIRES AND REPLACED THEM WITH TWO 10 GAUGE WIRES. FAN STILL SHUTS OFF DUE TO TILTING STEERING WHEEL WITH HEAVIER WIRING NOT BEING FLEXIBLE ENOUGH. WIRES STILL GET VERY HOT. 2) RADIATOR FAN CONTROL RELAY: (90,000 MILES) CHECK ENGINE LIGHT CAME ON AND CODE WAS FOR RADIATOR FAN CONTROL RELAY CIRCUIT. RELAY WAS REPLACED. 3) ENGINE: (129,000 MILES) OIL SLUDGE CAUSED OIL NOT TO CIRCULATE PROPERLY CAUSING OIL PRESSURE GAUGE TO DROP TO ZERO AND BACK UP TO NORMAL ABOUT 4 TIMES. ENGINE OVER HEATED, WARPING HEADS AND DOING INTERIOR DAMAGE TO RODS AND BEARINGS. ENGINE HAD TO BE REPLACED WITH USED ENGINE. 4) PASSENGER WINDOW SWITCH: (FOR THE PAST 20,000 MILES) PASSENGER SIDE SWITCH WORKS INTERMITTENTLY. 5) PARKING LIGHTS: (149,000 MILES) WAS INFORMED BY ANOTHER DRIVER THAT I HAD NO TAIL LIGHTS. CHECKED FUSES AND RELAY AND EVERYTHING WAS OK. TOOK TRUCK TO GARAGE, THEY CHECKED AND COULD NOT FIND A PROBLEM. GARAGE CALLED DODGE DEALERSHIP, THEY TOLD THEM IT WOULD PROBABLY NEED THE FRONT CONTROL MODULE REPLACED. THE GARAGE DID NOT CHARGE ME AND TOLD ME THEY DID NOT WANT TO JUST START REPLACING PARTS COSTING OVER $200 TRYING TO PIN POINT A PROBLEM AND I NEEDED TO TAKE IT TO THE DEALERSHIP. THE DEALERSHIP CHECKED IT AND TOLD ME I WOULD NEED TO REPLACE THE POWER DISTRIBUTION MODULE AND THE FRONT CONTROL MODULE DUE TO BOTH HAVING AN INTERNAL SHORT. WHY BOTHER HAVING FUSES IF YOU CAN JUST HAVE CIRCUIT BOARDS COSTING OVER $200 EACH BLOW OUT? 6) IGNITION PARK LOCK: (149,000 MILES) GOT A RECALL NOTICE ABOUT IGNITION PARK LOCK NEEDING REPLACED. DEALERSHIP REPAIRED. THIS TRUCK DEFINITELY HAS ITS SHARE OFF DEFECTS, WITH THE ENGINE AND WIRING. MORE SHOULD BE DONE AS FAR AS RECALLS. *TR

I TURNED MY FAN ON TO COOL THE INSIDE OF THE TRUCK AND AFTER A FEW MINUTES, IT SHUT OFF. A WHILE LATER, I TRIED IT AGAIN AND IT WORKED, BUT SOON SHUT OFF AGAIN. I TOOK THE TRUCK TO THE DEALERSHIP AND THEY TOLD ME THEY CLEANED THE AIR INTAKE OUT AND IT WAS FULL OF LEAVES. THEY TOLD ME THAT IS WHY IT SHUT OFF. THE PROBLEM CONTINUED. A FEW WEEKS LATER, I GOT THE RECALL NOTICE ABOUT THE WIRING BEING TOO LIGHT AND IT WAS OVER HEATING. THE DEALER DID THE REPAIR. IT WORKED FINE FOR A GOOD WHILE. EVENTUALLY IT STARTED SHUTTING OFF AGAIN. SOMETIMES I COULD TILT THE STEERING WHEEL TO A DIFFERENT LOCATION AND IT WOULD COME BACK ON. I FLIPPED THE ACCESS PANEL DOWN TO FIND THE REPAIR, THEY CLIPPED THE TWO LIGHTER WIRES AND PLUGGED IN TO I BELIEVE 10 GAUGE WIRE IN THEIR PLACE. THE HEAVY WIRES ARE TOO STIFF TO FLEX AND WHEN PUSHED CERTAIN WAYS THE FAN SHUTS OFF. I ALSO NOTICED WHERE THE WIRES ARE PLUGGED IN, THE WIRES ARE SO HOT YOU CAN BARELY TOUCH THEM. I DON'T FEEL THIS WAS A VERY GOOD FIX FOR THE PROBLEM, SINCE ALTHOUGH THE FAN DOES NOT SHUT OFF DUE TO OVERHEATING, IT STILL IS HEATING UP UNDER THE DASH AND MAY CAUSE A FIRE UNDER THE DASH. *TR

Mileage: 24,000

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. THE CONTACT EXPERIENCED NUMEROUS ELECTRICAL FAILURES RANGING FROM THE FUSE BOX AND POWER LOCK:WINDOWS TO THE INTERIOR LIGHTING. SHE TOOK THE VEHICLE TO THE DEALER ON SEVERAL OCCASIONS AND A TECHNICIAN REPEATEDLY REWIRED THE ELECTRICAL SYSTEM, REPLACED THE FUSES, AND THE MOTOR FOR THE POWER WINDOW DEVICES. IMMEDIATELY AFTER THE REPAIR, THE ELECTRICAL FAILURES RECURRED. SHE RETURNED TO THE DEALER AND A TECHNICIAN STATED THAT THE WIRING HARNESS MELTED, WHICH CAUSED THE ALARM SYSTEM TO FAIL AND HAVE TO BE REPLACED. THE PARTS ARE ON BACK ORDER AND NEITHER THE MANUFACTURER NOR THE DEALER CAN PROVIDE AN ESTIMATE OF WHEN THE PARTS WILL BE AVAILABLE. SHE HAS COPIES OF DOCUMENTS PERTAINING TO THE REPAIR HISTORY OF THE ELECTRICAL SYSTEM. THE MANUFACTURER DID NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 28,000 AND CURRENT MILEAGE WAS 49,369.

Mileage: 28,000

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. THE CONTACT STATED THAT THE INSTRUMENT PANEL BEGAN TO CRACK IN JANUARY OF 2008. BY JUNE OF 2008, THE PANEL HAD CRACKED INTO SMALL PIECES AND A PIECE FELL INTO THE AIR CONDITIONING MOTOR, WHICH PREVENTED HIM FROM USING THE AIR CONDITIONER. THE DEALER WOULD NOT REPAIR THE VEHICLE FOR FREE AND IS CHARGING $800. THE MANUFACTURER PROVIDED THE CONTACT WITH REFERENCE NUMBER 17583492 AND ADVISED HIM TO CHECK WITH THE DEALER. THE CONTACT FEELS THAT THE MANUFACTURER SHOULD REPLACE THE INSTRUMENT PANEL FOR FREE. THE FAILURE MILEAGE WAS 100,000 AND CURRENT MILEAGE WAS 116,000. UPDATED 09/13/08. *LJ UPDATED 09/17/08. *JB

Mileage: 100,000

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. WHILE DRIVING VARIOUS SPEEDS AT NIGHT, THE BLOWER WOULD TURN ON AND OFF AUTOMATICALLY AND THE INSTRUMENT PANEL LIGHTS FAILED WITHOUT WARNING. THE BLOWER EVENTUALLY FAILED COMPLETELY. THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 03V078000 (STEERING:COLUMN), IN WHICH THE INSTRUMENT PANEL LIGHTS ILLUMINATED PROPERLY FOR THIRTY DAYS BEFORE FAILING AGAIN. THE VEHICLE CURRENTLY NEEDS A NEW COMPUTER. THE CURRENT MILEAGE WAS 155,000 AND FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. WHILE THE VEHICLE WAS PARKED WITHOUT THE KEY IN THE IGNITION, THE VEHICLE ROLLED DOWN A HILL. THE VEHICLE CRASHED INTO A TRAILER AND BOTH WERE DAMAGED. THERE WERE NO INJURIES. THE CONTACT RECEIVED A RECALL NOTICE FOR THE IGNITION INTERLOCK AFTER THE FAILURE OCCURRED. THE IGNITION INTERLOCK WAS REPLACED. THE PARKING BRAKE WAS NOT ENGAGED. THE APPROXIMATE FAILURE MILEAGE WAS 75,000 AND CURRENT MILEAGE WAS 80,125.

Mileage: 75,000

EXCESSIVE CRACKS HAVE FORMED IN BOTH DASHBOARD PIECES. THE PLASTIC HAS BECOME VERY BRITTLE AND SHARP PIECES ARE BEGINNING TO FALL INTO THE WIRING UNDERNEATH. NOTHING PARTICULAR HAPPENED THAT CAUSED IT, THEY JUST APPEARED OVERNIGHT. CONVERSATIONS WITH THE LOCAL DODGE DEALER AND CHRYSLER CUSTOMER SERVICE YEILDED NO ASSISTANCE. I AM CONCERNED OF THE SHARP EDGES OF THE PLASTIC FALLING INTO THE DASHBOARD WIRING AND CAUSING ELECTRICAL FAILURES WHILE DRIVING OR, IN THE EVENT OF AN AIRBAG DEPLOYMENT, SHARDS OF THE SHATTERING PLASTIC IMPALING THE DRIVER OR PASSENGER. *CN

Mileage: 101,000

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. THE CONTACT STATED THAT THE INSTRUMENT PANEL IS BEGINNING TO SHATTER IN SEVERAL DIFFERENT PLACES, LEADING TO THE AIR BAG. HE STATED THAT THE AIR BAG WILL EVENTUALLY DEPLOY. THE DEALER ACCUSED HIM OF TIGHTENING THE SCREWS TOO TIGHTLY UNDERNEATH THE INSTRUMENT PANEL; HOWEVER, THE CONTACT STATED THAT HE HAS NEVER TOUCHED THE INSTRUMENT PANEL IN THAT REGARD. OTHER DEALERS HAVE STATED THAT THIS IS A COMMON OCCURRENCE WITH THIS MAKE AND MODEL. THE FAILURE MILEAGE WAS 55,000 AND CURRENT MILEAGE WAS 79,199.

Mileage: 55,000

THE DASHBOARD ON MY TRUCK CRACKED, THEN BEGAN LOSING PIECES. SOME PIECES HAVE BEEN PROPELLED AT THE DRIVER AND PASSENGERS BY THE AIR CONDITIONING AND WHEN WINDOWS ARE OPEN. WIRING PROBLEMS APPEAR TO BE DEVELOPING (I AM NOW RECEIVING "LAMP OUT" WARNINGS). I HAVE PLACED A DASH COVER TO LIMIT EXPOSURE TO THESE HAZARDS, BUT I HAVE SEEN NEWS REPORTS THAT MANY OTHER CONSUMERS ARE EXPERIENCING THESE PROBLEMS, AND THAT THEY CONTINUE TO WORSEN. *TR

TL*THE CONTACT OWNS A 2002 DODGE RAM 1500. APPROXIMATELY ONE AND A HALF YEARS AGO, THE VEHICLE'S INSTRUMENT PANEL BEGAN TO CRACK ASW WELL AS THE DASHBOARD. THE CRACK GRADUALLY SPREAD FROM THE DRIVER SIDE TO THE PASSENGER SIDE OF THE VEHICLE. IN ADDITION, THE AIR VENT DETACHED. THE CAUSE OF FAILURE HAS NOT BEEN DIAGNOSED. THE CURRENT MILEAGE IS 56,000 AND FAILURE MILEAGE WAS 42,000. UPDATED 10/18/07 *TR

Mileage: 42,000

PARKING LIGHTS AND TAIL LIGHTS DO NOT FUNCTION. LAMP OUT INDICATOR LIGHT ON DASH IS NOT ON. PROBLEM DIAGNOSED TO BE IN THE FUSE BOX CIRCUIT BOARDS ALSO KNOWN AS THE PDC (POWER DISTRIBUTION CENTER). APPARENTLY CORROSION OCCURS INSIDE THE BOX AND THE GROUND IS LOST. ORIGINAL EQUIPMENT PART NUMBER IS 56045433AE. THAT PART NUMBER IS NO LONGER AVAILABLE AND HAS BEEN REPLACED BY PART NUMBER 56045433AF. NEITHER PART IS AVAILABLE FOR PURCHASE FROM DODGE DEALERS. THERE DEPOTS ALSO SHOW NO STOCK AND THEY DO NOT KNOW WHEN THE PART WILL BE AVAILABLE. AS THE CORROSION CONTINUES OTHER ELECTRONIC COMPONENTS OF THE VEHICLE COULD BE LOST RESULTING IN A SERIOUS SAFETY ISSUE. *JB

Mileage: 55,889

DT*: THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED WHILE DRIVING 55 MPH. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, AND A COMPUTER DIAGNOSTIC IDENTIFIED A FAILURE TO THE CONDENSER FAN RELAY, DUE TO AN UNDERSIZED FUSE. A TECHNICAL SERVICE BULLETIN, # O8-002-03, WAS ISSUED BY THE MANUFACTURER, WHICH STATED THE FUSE WAS NOT LARGE ENOUGH AND THE CONDENSER FAN NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED.*AK

Mileage: 123,296

I WAS STOPPED BY POLICE DUE TO THE FACT THAT MY PARKING/RUNNING LIGHTS WERE NOT WORKING. THE SIGNALS AND STOP LIGHTS WORKED FINE. MY 2002 DODGE RAM IS AT THE GARAGE. THEY FOUND THE CIRCUIT BOARD (POWER DISTRIBUTION CENTER) UNDER THE FUSE BOX IS BURNED OUT. COST FROM DODGE, $400.00. I THINK THIS IS A SAFETY ISSUE, THERE IS NO INDICATION THAT THE LIGHT WENT OUT FROM THE CAB. THE DASH LIGHTS WORKED AND THE HEAD LIGHTS WORKED. THE GARAGE INFORMED ME THAT IS HAPPENING A LOT TO OTHER DODGE RAMS. *NM

Mileage: 65,000

THE HEATER/AC FAN WILL CONTINUE TO OPERATE WITH THE IGNITION KEY REMOVED FROM THE LOCK. SOMETIMES THE CIRCUIT IS ENERGIZED IMMEDIATELY AFTER THE KEY IS REMOVED AND AT OTHER TIMES IT ENERGIZE'S ON ITS OWN. IF NOT IDENTIFIED IN TIME THE FAN WILL DRAIN THE VEHICLE BATTERY. THE LOCAL DODGE DEALER CLAIMS THEY ARE UNABLE TO DUPLICATE THE PROBLEM. I SUSPECT THE IGNITION LOCK/SWITCH IS PROBABLY DEFECTIVE AND IS CAUSING THIS PROBLEM. *JB

Mileage: 1,200

RACK & PINION STEERING LEAKING ON LEFT SIDE. TRANSMISSION ROUGH. NO DASH LIGHTS. BLOWER MOTOR WORKS SELDOM. DANGEROUS AND EXPENSIVE REPAIRS. SEEMS LIKE THESE HAVE WIDESPREAD TRANSMISSION AND ELECTRICAL PROBLEMS. *JB

Mileage: 72,000

FIRST THE TRANSMISSION IS SLIPPING IN 3RD GEAR AT TIMES,THIS HAS BEEN AN ON GOING ISSUE THAT THE DEALER CAN'T REPRODUCE. THE LAMP OUT LIGHT GOES ON AND OFF WITH THE BELL THIS WILL DO IT INTERMITTENTLY FOR AS LONG AS 30 MIN STRAIGHT AND THIS TRUCK IS ALL OVER THE ROAD WHEN YOU HIT BUMPS AT HIGH SPEED. *JB

Mileage: 56,000

DT*: THE CONTACT STATED WHILE APPLYING PRESSURE TO THE ACCELERATOR PEDAL THE ENGINE SPUTTERED. THE CHECK ENGINE, AIRBAG, AND CHECK GAUGES LIGHTS ILLUMINATED. THE DEALERSHIP WAS ALERTED. UPDATED 03/28/06

Mileage: 78,598

DT*: THE CONTACT STATED WHILE DRIVING 70MPH ANOTHER MOTORIST ALERTED THE CONTACT THE RUNNING LIGHTS ON THE VEHICLE WERE OUT. UPON INSPECTION THE DEALERSHIP FOUND THE POWER DISTRIBUTION CENTER AND THE FCM (PART # 56045434AEA) FAILED. THERE WAS A POWER SURGE THROUGH THE PARTS THAT CAUSED THE FUSES TO BE BLOWN. AN INDEPENDENT REPAIR SHOP REPLACED THE POWER DISTRIBUTION CENTER AND THE FCM.

Mileage: 70,200

ENTIRE GAUGE CLUSTER FAILED. HEADLIGHTS AND RUNNING LIGHTS CAME ON WITH THE SWITCH IN THE OFF POSITION. TURN SIGNALS, EMERGENCY FLASHERS AND BRAKE LIGHTS DID NOT OPERATE. ELECTRIC LOCKS DID NOT OPERATE. IT HAS HAPPENED TWICE. THE FIRST TIME IT CORRECTED ITSELF AFTER CHECKING ALL OF THE FUSES. THE SECOND TIME IT WAS TAKEN TO THE DEALERSHIP. THE DEALERSHIP HAS DIAGNOSED A INTERNAL SHORT IN THE GAUGE CLUSTER WITH AN EXPECTED REPAIR COST OF $900.00. *NM

Mileage: 40,500

I HAD AN ELECTRICAL PROBLEM WITH THE INSTRUMENT CLUSTER,WHICH CAUSED ALL OF MY GAUGES TO STOP WORKING. NO SPEEDOMETER, ODOMETER, BATTERY, OIL OR TEMPERATURE GAUGE. MY TURN SIGNALS, HORN, INTERIOR LIGHTS, WIPERS, AND POWER DOOR LOCKS ALSO FAILED. I ALSO DISCOVERED THAT I HAD NO STOP/BRAKE LIGHTS OR FOG LIGHTS, BUT HAD HEADLIGHTS AND PARKING LIGHTS EVEN THOUGH THE INTERIOR SWITCH WAS IN THE OFF POSITION. EVEN THOUGH THIS TRUCK WAS PURCHASED NEW IN JANUARY OF 2002 AT JERRYS DODGE (NOW SAFFORD DODGE, AND THE THREE YEAR WARRANTY WAS JUST UP, I ONLY HAD 7,078 MILES ON THE TRUCK AT THE TIME OF THE INCIDENT. THE DEALER REPLACED THE CLUSTER BUT I HAD TO PAY. I THINK THIS CLUSTER SUDDENLY GOING OUT IS A MAJOR SAFETY HAZARD. THANK GOD MINE WENT OUT IN THE DAY TIME AND NOT AT NIGHT. I COULD HAVE BEEN REAR ENDED AS IT IS. THIS IS THE FOURTH INCIDENT OF A FAILED INSTRUMENT CLUSTER THAT I KNOW OF. I AM SURE THERE ARE MORE, AND I HAVE READ THAT CHRYSLERDAIMLER/DODGE HAS HAD CLUSTER PROBLEMS IN SOME OF THEIR OTHER VEHICLES.*JB

Mileage: 7,068

TRUCK WAS TAKEN INTO THE AUTOWEST DODGE DEALERSHIP TO FIX TAILLIGHTS THAT DIDN'T WORK. AT THE TIME THE TRUCK WAS IN THEIR POSSESSION THERE WERE 2 OPEN RECALLS AND THEY DID NOT NOTIFY ME OF EITHER. NINE MONTHS LATER THE BRAKES, CLUTCH, AND POWER STEERING WENT OUT WHILE I WAS DRIVING IT. ONCE I GOT IT TO THE SIDE OF THE ROAD THE ENGINE WAS ENGULFED IN FLAMES. TRUCK IS A TOTAL LOSS. TRUCK HAD 31,000 MILES ON IT. DAIMLERCHRYSLER HAS DENIED RESPONSIBILITY FOR THE PROBLEM. *NM

Mileage: 31,000

1) THERE WERE NO INCIDENTS LEADING UP TO THE VEHICLES FAILURES. 2) THE HEADLIGHTS WILL NOT SHUT OFF WHEN ENGINE IS ON / THE WINDSHIELD WIPERS AND PUMP ARE INOPERABLE. THEY BOTH OCCURRED AT THE SAME TIME. FAMILY WAS STUCK ON RAINY HIGHWAY FOR SEVERAL HOURS. 3) DODGE SERVICE "THINKS" THE POWER DISTRIBUTION CENTER MAY HAVE SHORTED OUT THE ELECTRONIC CONTROL MODULE AND RECOMMEND REPLACE BOTH -$750 THERE IS A BACK ORDER FOR BOTH PARTS - APPARENTLY THERE ARE MANY REQUESTS. PART #'S 56045433AF AND 56051036AD. *AK

Mileage: 41,379

THERE IS AN ELECTRICAL PROBLEM WITH THE INSTRUMENT CLUSTER,WHICH IS CAUSING THE HEAD LIGHTS, BLINKERS, AND INTERIOR LIGHTS NOT TO FUNCTION. OWNER WILL CONTACT MANUFACTURER. *NM OTHER ELECTRICAL PROBLEMS INCLUDED FOG LAMPS; WINDSHIELD WIPERS; TURN SIGNALS, BRAKE LIGHTS AND ALL CLUSTER FUNCTIONS. DEALER REPLACED A SHORTED CLUSTER. *TT

Mileage: 30,000

WIRING FOR MY 2002 DODGE RAM PICKUP 1500 QUAD CAB LIGHT BULB CONTINOUSLY BURN OUT LIKE IN A SEQUENCE ALL TAIL LIGHTS. MY BROTHER IN LAW HAS THE SAME VEHICLE AND HAD THE WIRING RE DONE WHILE TRUCK WAS UNDER WARRANTEE BECAUSE OF A SHORT. IS THERE ANY RECORD OF ANTHING LIKE THIS HAPPENING? *AK

Mileage: 63,000

PRIOR TO TAKING DELIVERY OF THE VEHICLE THE BATTERY WAS REPLACED. AFTER SEVERAL TIMES OF SERVICE FOR HEADLIGHT FAILURES, WON'T JUMP START, REPLACED BATTERY, 7 MO. LATER. AFTER SEVERAL OTHER ATTEMPTS WAS INFORMED OF NEED WIRING HARNESS DUE TO AFTER MARKET REPLACEMENT OF HEADLAMP. REPLACED HEADLAMPS TO FACTORY AND 3RD DEAD BATTERY. I HAVE INVESTED $1100 SINCE THE SECOND DEAD BATTERY. DEALER SAYS BATTERY HAS NOTHING TO DO WITH ELECTRICAL WIRING HARNESS???? MOST OCCURANCES DURING EXTENDED WARRANTY PERIOD. *AK

Mileage: 26,000

MY COMPUTER SYSTEM WENT OUT IN MY 2002 DODGE RAM 1500 TRUCK. I SPOKE WITH AN INDIVIDUAL NAMED CHRIS ON 9/15/04 REF#12633025. THE MANUFACTURER WILL NOT TAKE ANY STEPS TO RECTIFY THIS PROBLEM BECAUSE I WAS TOLD THAT THERE AREN'T ANY RECALLS ON THE COMPUTER SYSTEMS IN THESE TRUCKS. IT'S GOING TO COST ME $600.00 TO GET THIS PROBLEM WITH MY LEMON FIXED.*AK

Mileage: 49,540

INTERMITTENT WHILE DRIVING 30 MPH VEHICLE STALLED. THIS CAUSED LOSS OF STEERING AND BRAKES. DEALER REPLACED TURN SIGNAL SWITCH, BUT PROBLEM RECURRED. *AK *NM

VEHICLE STALLED WHEN MAKING LEFT TURNS AND/OR BRAKING. THIS RESULTED IN LOSES OF POWER STEERING AND BRAKES. TOOK VEHICLE TO DEALER, AND MECHANIC PERFORMED A DIAGNOSTIC TEST, BUT NO FAILURE WAS FOUND.

Mileage: 35,000

I OWN A 2002 DODGE RAM 1500 QUAD CAB 4X4. IN SEPTEMBER OF 2003, THE CHECK ENGINE LIGHT CAME ON AND IT WAS DETERMINED TO BE THE CONDENSER FAN INOPERABLE DUE TO OPEN FUSE. THE SERVICE MGR TOLD ME THAT THIS WAS A COMMON DEFECT BECAUSE OF THE DESIGN OF THE SHROUD THAT ALLOWS WATER TO COLLECT IN THE TROUGH. IT ALSO FREEZES IN THE WINTER PREVENTING THE FAN FROM TURNING. THIS IS NOT COVERED BY WARRANTY. I BELIEVE IT SHOULD BE BECAUSE IT IS DESIGN DEFECT. THIS IS QUITE COSTLY TO HAVE THIS FIXED. ACCORDING TO THE SERVICE REPRESENTATIVE, THERE HAVE BEEN SEVERAL CASES OF THIS. *LA

Mileage: 41,000

5 MINUTES AFTER PARKING VEHICLE CAUGHT ON FIRE. *AK

Mileage: 26,000

SINCE DECEMBER OF 2001 VERIZON HAS HAD (6) DODGE FULL SIZE VANS INVOLVING 1998-2001 B VANS. ALL (6) FIRES APPEAR TO HAVE STARTED UNDER THE HOOD. ALL (6) VANS ARE EQUIPPED WITH THE KELSEY HAYES EBC 325 ANTI-LOCK BRAKE SYSTEMS. THREE OF THE FIRES OCCURRED IN THE ABS CONTROLLER AREA OF THE ENGINE COMPARTMENT WITHOUT THE ENTIRE TRUCK GOING UP IN FLAMES BECAUSE THE DRIVERS WERE ABLE TO HAVE THE FIRES EXTINGUISHED BEFORE THE FIRES GOT A REAL GOOD START. THREE OF THE FIRES HAPPENED WHILE THE VEHICLES WERE UNATTENDED AND THE VEHICLES WERE TOTALLY DESTROYED. ON SEPT. 4TH, 2003 A 2002 DODGE VAN WAS REPORTED BY THE DRIVER TO HAVE THE ABS PUMP RUNNING CONTINUALY FOR OVER 2 HOURS. THE ABS PUMP WAS EXTREMELY HOT. HAD TO DISCONNECT THE BATTERY TO SHUT THE PUMP OFF. WHEN THIS VAN WAS BROUGHT INTO THE VERIZON GARAGE THE ABS LIGHT AND THE BRAKE WARNING LIGHTS WERE ILLUMINATED IN THE INSTRUMENT CLUSTER AND THE ABS PUMP WAS RUNNING CONTINUALLY. THE VAN WAS TOWED TO ROTHROCK DODGE IN ALLENTOWN, PA.,ON 9-5-03 AND LEFT WITH DANNY DAVID FOR DIAGNOSIS. WHEN THE SCAN TOOL WAS CONNECTED TO THE ABS SYSTEM THEY FOUND (2) CODES, MAIN RELAY OPEN AND PUMP MOTOR CIRCUIT OPEN. AT THIS TIME NO REPAIRS HAVE BEEN COMPLETED ON THIS VEHICLE UNTIL CHRYSLER AND A VERIZON FLEET TECH. SUPPORT SPECIALIST CAN LOOK INTO THIS CASE. CONTACT PERSONS AT VERIZON ARE AS FOLLOWS; TOM SPEZIO 732-493-9902 BOB PRINCE 410-760-8836 FRED PLETSCHER 610-264-0685. *AK

Mileage: 12,635

WHILE DRIVING AT 30MPH VEHICLE CAUGHT ON FIRE, FLAMES CAME OUT THE DASHBOARD. DEALER NOTIFIED. *AK

CONSUMER STATES VEHICLE CAUGHT ON FIRE. DEALER NOTIFIED. *AK

VEHICLE HAS LUNGED FORWARD WHILE IN DRIVE. ENGINE IDLE ELECTRONICALLY ADVANCES WHILE TRANSMISSION IN DRIVE, DRIVER MUST KEEP FOOT FIRMLY DEPRESSED ON BRAKE TO AVOID ACCIDENT. ALSO HAVING SIGNIFICANT ELECTRICAL PROBLEMS - SPECIFICALLY GAUGES DO NOT FUNCTION PROPERLY AND HORN/LIGHTS ENGAGE. PROBLEMS ARE INTERMITTENT. *NLM

Mileage: 15,000

WHILE DRIVING VEHICLE WILL STALL WITHOUT WARNING. THE VEHICLE SERVICED SEVERAL TIMES FOR THIS PROBLEM, BUT THE DEALERSHIP CAN NOT DUPLICATE, SO THEY CANNOT FIX THE PROBLEM. UPON FURTHER INSPECTION OF THE VEHICLE BY THE CONSUMER, THEY NOTICED THAT IGNITION CAN BE SWITCHED TOWARD THE ACCESSORY MODE WITHOUT MUCH FORCE. CONSUMER INFORMED DEALERSHIP AND DAIMLER CHRYSLER. TS SCC

VEHICLE WILL STALL WITHOUT WARNING WHILE DRIVING. DEALERSHIP INDICATED THAT THIS COULD BE CAUSED BY THE IGNITION. PLEASE PROVIDE MORE DETAILS.*AK

Mileage: 1,401