2009 DODGE RAM 1500 Engine Problems

WHILE DRIVING MY TRUCK IT JUST SHUT OFF, DIED AND WOULD NOT START BACK UP. THIS WAS VERY DANGEROUS! GOING 65 MILES AN HOUR, IN THE CENTER LANE TRYING TO GET OVER TO THE SIDE OF THE ROAD...SAFELY! I TRIED TO START THE TRUCK...EVERYTHING CAME ON AS NORMAL, BUT WOULD NOT CRANK. I HAD TO HAVE THE TRUCK TOWED $$. THE ALTERNATOR WAS REPLACED $$. TRUCK STILL WOULD NOT START. IT WOULD NOT CRANK, YOU COULD HEAR CLICKING UNDER THE HOOD AND YOU COULD HEAR THE FUEL PUMP COME ON. I WAS TOLD IT WAS THE WIN MODULE WHICH COST ME $870.00!! (WIN MODULE AND PROGRAMMING) EVIDENTLY THIS IS A COMMON PROBLEM WITH DODGE TRUCKS. WHAT DOES IT TAKE TO HAVE A RECALL ON THIS PART?!! DOES IT TAKE A CERTAIN NUMBER OF CRASHES OR DEATHS? ALL IN ALL IT COST ME ABOUT $1500, BUT IT COULD HAVE COST ME MY LIFE, MY GIRLFRIENDS LIFE, AND POSSIBLY PEOPLE IN OTHER VEHICLES THAT WERE DRIVING AROUND ME. I HAVE RESEARCHED AND FOUND THAT OTHER DODGE VEHICLES WERE AFFECTED WITH THIS FAULTY PART AND THERE WAS A RECALL PUT OUT. THERE AGAIN, I ASK DODGE....WHAT DOES IT TAKE TO HAVE A RECALL ON THIS PART FOR RAM 1500 TRUCKS?? I HOPE THAT ALL OWNERS THAT HAD OR IS HAVING THIS PROBLEM TO FILE A REPORT! PLEASE! READ ALL THE DISCUSSIONS SIMILAR TO MINE ON DODGE FORUM. AGAIN, PLEASE REPORT THESE TYPES OF PROBLEMS, THEY WILL NOT KNOW HOW MAY VEHICLES ARE AFFECTED IF IT'S NOT REPORTED. YOU MAY SAVE SOMEONE'S LIFE.

Mileage: 157,000

EXHAUST MANIFOLD BOLTS BROKEN. CAUSES TICKING ON START UP. ITS BAD ON YOUR ENGINE AND IT WON'T PASS EMISSIONS. HOW HAS AN INVESTIGATION NOT BEEN DONE ON THIS?! SO MANY COMPLAINTS ON FORUMS, FACEBOOK, EVEN ON HERE. WITH LESS THEN 80K MILES THIS IS RIDICULOUS

Mileage: 79,000

EXHAUST MANIFOLD LEAK. BOLTS BROKE OFF

Mileage: 79,000

THE TOTAL INTEGRATED POWER MODULE FAILED AND IT'S A COMMON PROBLEM IN ALL CHRYSLER AND DODGE VEHICLES. THAT FAILS THE ENGINE RUNS ROUGH, AC, BRAKE LIGHT, TURN SIGNAL, HORN, WIPERS, STOP WORKING AND TRANSMISSION STAYS IN 1ST GEAR. THE LIGHTS ON THE DAS STAY ON: BRAKES, ABS, SEATBELT, CHECK ENGINE LIGHT AND AIR BAG... THIS IS AN SPECIALLY WHEN THE MODULE FAILS WHILE DRIVING IN THE ROAD. DEALERS KNOW IT'S A COMMON PROBLEM BUT THEY RATHER HAVE CUSTOMER PAY FOR A NEW TIPM.

ON MARCH 5, WHILE DRIVING TO WORK, I HEARD A KNOCKING SOUND FROM THE ENGINE. LATER IN THE DAY WHEN DRIVING, THE TRUCK WOULD LOSE POWER WHEN I ACCELERATED. I CALLED A DOGE DEALERSHIP AND MADE AN APPOINTMENT WITH THE SERVICE DEPARTMENT EARLY THE NEXT MORNING. THE NEXT MORNING, THE SOUND WAS LOUDER AND HAD LESS POWER THROUGH ACCELERATION WHEN DRIVING TO THE DEALERSHIP. I AGREED TO HAVE A DIAGNOSTIC AND WAS LATER CALLED AND TOLD MY FUEL PUMP NEEDED TO BE REPLACED. I WAS CHARGED $1,045. WHEN I DROVE HOME, THE TRUCK STALLED OUT ONCE BUT I MANAGED TO MAKE IT HOME. I HAD SEVERAL MECHANICS INCLUDING ONE THAT WORKED AT A DIFFERENT DODGE DEALERSHIP LISTEN TO THE KNOCKING AND EACH MECHANIC IMMEDIATELY SUSPECTED A PROBLEM WITH THE LIFTERS. ALSO, ACCORDING TO EACH MECHANIC, THIS WAS A COMMON PROBLEM WITH DOGE RAM TRUCK. I TOWED THE TRUCK TO A MECHANIC AND FOUND THAT THE 5TH CYLINDER LIFTER HAD FROZE UP AND CARVED A GROOVE INTO THE CAM. THE MECHANIC HAS ORDER THE LIFTERS AND PARTS TO REPAIR THE ENGINE AND FOUND A BACKLOG OF ORDERS FOR THE SAME PARTS. I'M CURRENTLY HAVING TO RENT A CAR. MY WORK REQUIRES ME TO SOMETIMES DRIVE ON THE HIGHWAY 100 MILES ROUND TRIP. FORTUNATELY I WAS NOT IN THAT REQUIRED SITUATION AT THE TIME OF THE BREAKDOWN.

Mileage: 137,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING 70 MPH, THE VEHICLE DECELERATE AND WOULD NOT EXCEED 40 MPH. THE VEHICLE VIBRATED VIOLENTLY AND THE ABS WARNING INDICATOR ILLUMINATED. AN INDEPENDENT MECHANIC REPAIRED THE MOTOR. THE DEALER WAS CONTACTED AND DID NOT ASSIST. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 185,000.

Mileage: 185,000

CHECK ENGINE LIGHT CAME ON WITH CODE FOR CYLINDER MISFIRE. DID RESEARCH ONLINE WHAT PROBLEM MIGHT BE AND SEEN THOUSANDS OF COMPLAINTS WITH EXACT SAME ISSUE. TOOK IT TO MECHANIC AND HE SAID LIFTER FAILURE. ROLLERS SEIZED UP AND TOOK LOBE OFF CAM. THIS IS THE EXACT SAME THING I SEEN ON THOUSANDS OF OTHER COMPLAINTS ONLINE.

Mileage: 90,000

SO THE HEMI 5.7 HAS NUMEROUS COMPLAINTS ON CYLINDER 5 MISFIRE AND RESULTING IN MAJOR ENGINE WORK DO TO THE MDS SYSTEM DODGE FAILED MISERABLY ENGINEERING . MY TRUCK HAS 80,000 MILES ON IT AND I GET IT MAINTAINCE REGULARLY . WHY AT CONSUMERS HAVING TO COME OUT OF POCKET AND IT NOT BE RECALLED YET FROM DODGE FOR POOR DESIGN ON THIS ENGINE .

Mileage: 80,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING 50-55 MPH, THE VEHICLE MISFIRED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT CYLINDER NUMBER FIVE WAS DEAD. THE VEHICLE WAS TAKEN TO HEBERTS TOWN AND COUNTRY CHRYSLER DODGE JEEP RAM (1155 E BERT KOUNS INDUSTRIAL LOOP, SHREVEPORT, LA 71105, (888) 881-5163) WHERE IT WAS DIAGNOSED THAT THE LIFTER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 131,049. THE VIN WAS NOT AVAILABLE.

Mileage: 131,049

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT TOOK THE VEHICLE TO AN UNKNOWN DEALER FOR ROUTINE MAINTENANCE. THE CONTACT WAS INFORMED THAT THE ALTERNATOR WAS ABOUT TO FAIL. THE CONTACT HAD THE ALTERNATOR REPLACED WITH A REBUILT ONE; HOWEVER, THE REPLACEMENT ALTERNATOR FAILED A WEEK LATER. THE CONTACT HAD THE VEHICLE TESTED FOR A NEW BATTERY AND SHE DISCOVERED THAT THE ALTERNATOR FAILED AGAIN. THE DEALER REPLACED THE ALTERNATOR AGAIN AND INFORMED THE CONTACT OF RECALLS FOR THE DODGE RAMS FROM 2007 THROUGH 2013. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 103,917. *TT*JB

Mileage: 103,917

4TH GENERATION RAM 1500 PICKUPS WITH THE 5.7L HEMI ARE BECOMING NOTORIOUS FOR PREMATURE LIFTER FAILURE RESULTING IN DAMAGE TO THE CAMSHAFT LOBE. THESE REPAIRS ARE OFTEN OCCURING JUST AFTER EXPIRY OF CCHRYSLER'S POWERTRAIN WARRANTY. THERE ARE HUNDREDS OF CASES ON ONLINE OWNER FORUMS THAT PRESENT SIMILARLY. CHRYSLER HAS NOT SOUGHT TO REMEDY THE PROBLEM WITH OWNERS. SEE THE FOLLOWING LINK FOR DOZENS OF EXAMPLES FROM THE LAST FEW YEARS: HTTPS://WWW.RAMFORUMZ.COM/SHOWTHREAD.PHP?T=188978 MAJOR POWER LOSS OCCURED AT HIGHWAY SPEEDS AND PUT THE VEHICLE IN "LIMP" MODE. THE RESULT WAS A NEAR ACCIDENT WITH A LARGE TRUCK AS POWER LOSS OCCURED WHILE PASSING ON THE HIGHWAY.

Mileage: 100,000

THE MANIFOLD BOLTS ON THE 5.7 HEMI BREAK SOMETIMES BREAKS OFF IN THE HEAD AND ARE NOT EASILY REMOVED. THUS CAUSING AN EXHAUST LEAK (AKA HEMI TICK). AND MY TRUCK ONLY HAS 77000 MILES ON IT. BOUGHT USED SO NO WARRANTY TO COVER THE REPAIRS.

Mileage: 77,000

IN 2018,YR 2012 DODGE RAM TRUCK, WAS RECALLED FOR THE T79 RECALL. AFTER RECALL WAS INSTALLED, NOW TRUCK STALLS-GOES DEAD WHEN BRAKE PUSHED & DIES IN REVERSE. AFTER RESEARCH, IT'S A MAJOR ISSUE W/THE 1500'S YET THERE HASNT BEEN A RECALL. THIS IS A VERY DANGEROUS SITUATION THAT DODGE HAS PUT THE OWNERS IN. SO WHEN I BRAKE FOR ANYTHING ON A HWY, IT GOES DEAD! THE DEALER CHECKS FOR AN ERROR CODE & YET THERE IS NO ERROR CODE SO THEY CANT DO ANYTHING ABOUT IT-DEPENDENT ON COMPUTERS VERSUS HANDS ON MECHANICS. DEALER SUGGESTED TO LEAVE MY TRUCK & THEY'LL DRIVE IT UNTIL IT HAPPENS WHICH IS RANDOM. IT'S RIDICULOUS THAT MECHANICS HAVE NO REAL HANDS-ON MECHANICAL ABILITY & DEPEND ON COMPUTERS TO PROVIDE ERROR CODES. AFTER THE T79 RECALL WAS DONE, WAS IT REQUIRED TO UPGRADE/UPDATE OR REFRESH THE COMPUTER SYSTEM AFTERWARDS? DEALER SAID THE RECALL DID NOT CALL FOR AN COMPUTER UPDATE AS DODGE DID NOT REQUIRE IT. PER INTERNET FORUMS, YOUTUBE, & INTERNET, THE STALLING IS A MAJOR ISSUE! GUESS I HAVE TO TAKE CHANCES W/THIS ISSUE OF STALLS/DYING ON HWY TRAVEL-DANGEROUS! ALSO, THE STEERING WHEEL HAS SOMETHING LOOSE INSIDE OF IT. IT SOUNDS LIKE THE AIRBAG HAS COME LOOSE & IS MOVING WHEN WHEEL TURNED. ANY RECALLS OR WORD ON THIS? AGAIN THE DEALER PLUGS IN HIS COMPUTER & DOESN'T SEE ANYTHING WRONG EVEN THOUGH YOU CAN HEAR IT. DODGE NEEDS TO BE ACCOUNTABLE & RESPONSIBLE FOR ALL THESE MISTAKES-ESP SINCE THIS IS A SAFETY ISSUE! ALSO, ON THE 1ST DAY OF PURCHASING MY TRUCK, THE PASS AIRBAG LIGHT REMAINED ON. DEALER KEPT NEW TRUCK FOR 6 WKS TO ATTEMPT RESOLUTION & ENDED UP CONTACTING DODGE ENGINEERING & FOUND OUT THE COLORED WIRES WERE CROSSED - THE COLORS WERE INTERCHANGED AT THE FACTORY! AMAZING & NO RECALL WAS DONE. IT'S IMPOSSIBLE TO SPEAK W/CUST SERV AT DODGE RAM- SOMEONE THAT IS KNOWLEDGEABLE.

2009 DODGE RAM 1500. WHEN THE VEHICLE WAS STARTED, A TICKING NOISE WAS HEARD FROM THE EXHAUST MANIFOLD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT BOTH SIDES OF THE ENGINE BLOCK HINGES WERE FRACTURED AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 80000

ON MY 2009 DODGE RAM 1500 HEMI I HAVE BROKEN BOLTS ON MY EXHAUST MANIFOLD, SOMETHING IS WRONG WITH MY HVAC SYSTEM IN MY TRUCK ALSO. BOTH OF WHICH I SEE ARE VERY COMMON PROBLEMS WITH THESE TRUCKS.

Mileage: 102,000

I HAVE A 2011 DODGE RAM. I HAD TO MARK 2009 BECAUSE MY YEAR WANT IN THE OPTIONS. I HAVE REPLACED MY FUEL PUMP TWICE TO FIND OUT I HAVE A BAD TIPM. MY FUEL PUMP WON'T SHUT OFF EVEN WHEN THE TRUCK IS OFF CAUSING A DEAD BATTERY. WINDOWS ROLL UP AND DOWN ON THEIR OWN, TRUCK LOSSES POWER OUT OF NO WHERE, AND DOOR LOCKS WON'T WORK SOMETIMES. I'VE SPENT A FEW THOUSAND TO TRY TO GET THIS FIXED JUST TO LEARN IT'S THE TIPM.YOUR OPTIONS WON'T ALLOW ME TO CHECK THE PROPER BOXES

Mileage: 99,000

I HAVE 93000 ON MY TRUCK AND THE LIFTER SEIZES I CHANGE MY OIL AS RECOMMENDED THIS IS TO LOW OF MILES TO DEAL WITH THIS PROBLEM

Mileage: 93,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART WHILE HOLDING THE KEY FOB BUT, WHEN RELEASED, THE VEHICLE LOST ALL POWER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIRELESS IGNITION SWITCH NEEDED REPALCEMENT. THE VEHICLE WAS NOT REPAIRED DUE TO THE COST. THE CONTACT FOUND NHTSA CAMPAIGN NUMBER: 10V2400000 (ELECTRICAL SYSTEM) ONLINE FOR THE 2010 RAM QUAD CAB REGARDING THE SAME FAILURE. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER FOR DIAGNOSTIC TESTING. THE CONTACT STATED THAT THE MANUFACTURER WAS NOTIFIED, BUT OFFERED NO FURTHER ASSISTANCE. THE CONTACT WAS REFERRED TO CONTACT NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 99,900.

Mileage: 99,900

DRIVING DOWN THE ROAD AND THE ENGINE SHUTS OFF.....RANDOMLY HAPPENS - EXTREMELY DANGEROUS...HAPPENS ON THE HIGHWAY TOO. NO RECALL OR ANYTHING ON THIS ISSUE........WHY IS THIS NOT A HIGH PRIORITY......A CLASS ACTION LAWSUIT WON'T DO FAMILIES ANY GOOD WHEN A LIFE OR SEVERAL LIFES ARE LOST.....PLEASE MAKE THIS A TOP PRIORITY. THANK YOU.

Mileage: 158,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT STATED THAT THE ENGINE STARTED AUTOMATICALLY WITHOUT THE KEY IN THE IGNITION. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE POWER CONTROL MODULE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.

Mileage: 37,000

2009 DODGE RAM 1500 THERE IS A MANIFOLD BOLT THAT IS INFERIOR/DEFECTIVE PART DEALERSHIP HAS ADMITTED THEY KNOW IT IS.. THEY ARE REPLACING ATLEAST ONE A WEEK. THIS BOLT CAN BREAK OFF AND CAUSE THE MOTOR TO CEASE... WARRANTY WILL NOT REPLACE AND THIS IS HAPPENING TO HUNDREDS OF PEOPLE ITS IN ALL DODGE FORUMS... $400 + TO REPLACE THIS DEFINITELY NEEDS TO BD A RECALL ONLY 50,000 MILES ON TRUCK

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE STARTING THE VEHICLE, A TICKING SOUND WAS HEARD CONSTANTLY. THE CONTACT NOTICED THAT THE ENGINE MANIFOLD BOLTS HAD FRACTURED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 53,000.

Mileage: 53,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. IT TOOK SEVERAL ATTEMPTS BEFORE THE ENGINE RESTARTED. THE MANUFACTURER WAS NOTIFIED AND NO REPAIRS WERE PERFORMED. THE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

2009 DODGE RAM 1500, 5.7 HEMI, 74000 MILES. DEVELOPED TICKING IN THE ENGINE AT IDLE AND ACCELERATION. WITHIN A COUPLE DAYS ENGINE LIGHT CAME ON WITH SHUDDERING UNDER SMALL LOAD (UP HILL HIGHWAY). TOOK TO THE LOCAL DEALERSHIP THAT DAY. THEY DISCOVERED THAT THE ROLLER LIFTER FAILED (SEIZED) AND GROUND THE CAM LOBE FLAT CAUSING THE MISFIRE IN ONE OF THE CYLINDERS. $4300 REPAIR BILL! THIS IS VERY COMMON IN THE 5.7 HEMI AND NOT JUST THE RAM, SO COMMON IN FACT THAT THE DEALERSHIP CALLED AND SAID THE REPAIR IS ON HOLD BECAUSE THE LIFTERS ARE ON BACKORDER! GOOGLE "FAILED 5.7 HEMI LIFTERS"... SOME VEHICLES DON'T MAKE IT 25000 MILES BEFORE THIS HAPPENS. CHRYSLER HAS SINCE CHANGED THE PART NUMBER OF THE LIFTER BECAUSE THEY KNOW THERE WAS A DEFECT OR DESIGN FLAW. BUT WHEN YOU ASK FOR ASSISTANCE WITH THE REPAIRS THEY DON'T ACKNOWLEDGE THERE IS A PROBLEM. THIS ISSUE NEEDS TO BE INVESTIGATED, THERE ARE TOO MANY OF THEM OUT THERE.

Mileage: 74,000

2009 DODGE RAM 1500 4X4 5.7 HEMI, MY ISSUE IS CONCERNING "THE HEMI TICK" WHICH IS ACTUALLY BROKEN EXHAUST MANIFOLD HEAD BOLTS. SEEMS LIKE EVERYBODY THAT HAS THIS YEAR MODEL HAS THE EXACT SAME PROBLEM. I HAVE 2 BROKE BOLTS ON THE PASSENGER SIDE. THE BOLTS HAPPEN TO BE THE SAME BOLTS HOLDING ON THE EXHAUST MANIFOLD SHIELD IN THE REAR OF THE MOTOR. THE COST TO FIX THE ISSUE IS MODERATELY EXPENSIVE AND IF NOT ADDRESSED COULD EASILY CAUSE MORE SERIOUS ISSUES. THE EXHAUST LEAK CAN BE IDENTIFIED BY THE TICKING SOUND (USUALLY AT START UP UNTIL MOTOR WARMS UP AND SEALS THE LEAK) AND SHOULD BE REPLACED WITH STRONGER BOLTS THAT ALLOW FOR THE TEMPERATURE CHANGES.

Mileage: 52,000

FOR THE PAST MONTH NOW MY 2009 DODGE RAM 1500 HEMI HAS STALLED OUT ON ME 4 TIMES. IT HAS HAPPENED BOTH WHILE SHIFTING FROM REVERSE TO DRIVE, SLOWING DOWN TO STOP AT A STOP SIGN, AND JUST SITTING IN DRIVE IN A PARKING GARAGE LOT. TRUCK HAS 142000 MILES ON IT BUT THIS STALLING ISSUE HAS HAPPENED BEFORE AROUND 30K. I CAN PUT THE TRUCK BACK IN NEUTRAL OR PARK AND START IT BACK UP BUT THERE'S A KNOCK EVERY TIME NOW. IT IS STARTING TO WORRY ME THAT THE TRUCK MAY STALL OUT ON THE FREEWAY. I DO NOTICE THAT IT OCCURS WHENEVER THE RPM GET LOW AROUND 500-700 RPM. THE TRUCK THEN BOGS DOWN AND STALLS WHENEVER I SHIFT FROM REVERSE TO DRIVE ON THE FEW OCCASIONS THAT IT HAPPENED. WHEN I WAS PULLING INTO A PARKING SPOT OR SLOWING DOWN TO STOP AT A STOP SIGN I ALSO NOTICED THE RPM DROP TO STALL THE TRUCK.

Mileage: 142,000

FAILED TIMING CHAIN ..... CAUSING CATASTROPHIC FAILURE TO ENGINE.

Mileage: 135,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHEN THE VEHICLE WAS STARTED, A TICKING NOISE WAS HEARD FROM THE EXHAUST MANIFOLD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT BOTH SIDES OF THE ENGINE BLOCK HINGES WERE FRACTURED AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.

Mileage: 95,000

RIGHT SIDE MANIFOLD LEAK BOLTS ARE BROKE AND NEED TO BE REPLACE BECAUSE OF WEAK BOLTS USED TO SECURE THE MANIFOLD. THIS HAPPENED WHEN TRAVELING ON THE HIGHWAY NEARLY CAUSING A ACCIDENT.

Mileage: 92,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT STATED THAT THE ENGINE BLOCK MANIFOLD BOLTS FRACTURED. WHEN THE VEHICLE WAS STARTED, THE ENGINE MADE AN ABNORMAL NOISE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE ENGINE BLOCK MANIFOLD SCREWS FRACTURED DUE TO THE HEAT. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS REPAIRED. THE CONTACT REPLACED THE ENGINE MANIFOLD BOLTS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

TICKING NOSE FROM PASSENGER SIDE OF TRUCK UNDER THE HOOD NEAR THE WHEEL. GOT UNDERNEATH TRUCK AND FOUND TWO BOLTS HAD BROKEN OFF MANIFOLD. AFTER LOOKING ON THE INTERNET FOUND THERE ARE ALOT OF OTHER OWNERS OF THIS SAME TRUCK WITH SAME ISSUE, RAM/DODGE NEEDS TO FIX THIS PROBLEM, I THINK ISSUE IS FROM TO MUCH HEAT. THE SOUND IS AT ITS BEST WHEN TRUCK IS STARTED THE FIRST TIME OF THE DAY / COLD OUT.

Mileage: 84,000

AT 12K -13K MILES I EXPERIENCED AN ENGINE STALL IN THE EARLY MORNING. THE INSTRUMENT CLUSTER REMAINED LIT AND I WAS ABLE TO ENGAGE THE EMERGENCY FLASHER. I WAS ON A BACK ROAD AND LUCKILY I WAS ABLE TO COAST INTO A DRIVEWAY. AFTER NUMEROUS TURNS OF THE KEY FOB, THE ENGINE STARTED. THIS INCIDENT WAS REPORTED TO THE DEALERSHIP, BUT THEY SEEMED TO SHRUG IT OFF. FAST FORWARD TO 10/9/15. I HAD TROUBLE AGAIN STARTING THE TRUCK. I PROCEEDED TO THE STORE AND WAS ON A MAIN THOROUGHFARE WHEN I STARTED TO TURN ACROSS TRAFFIC INTO A PARKING LOT.THE ENGINE DIED AND LUCKILY MY MOMENTUM CARRIED ME OFF THE STREET OUT OF TRAFFIC AND INTO THE LOT. CARS HAD TO GO AROUND ME AS I TRIED TO GET THE VEHICLE STARTED. THE NEXT MONDAY 10/12/15 I HAD TROUBLE STARTING AGAIN AND I WAS ABLE TO PROCEED TO WORK. AT THE END OF MY SHIFT, IT TOOK A COUPLE DOZEN TURNS OF THE KEY FOB TO GET THE TRUCK STARTED AND I MADE IT HOME. THE TRUCK NOW SITS IN THE DRIVEWAY WAITING FOR A SERVICE APPOINTMENT ON 10/30/15. IF IT DOES NOT START, IT WILL HAVE TO BE TOWED. WHEN I INQUIRED ONLINE ABOUT THIS PROBLEM I WAS AGHAST AT HOW MANY OTHERS WERE HAVING THE SAME ISSUE AS ME AND CHRYSLER WAS DOING VERY LITTLE TO MAKE IT RIGHT. THE STALL OF AN ENGINE IN TRAFFIC IS A VERY DANGEROUS SAFETY PROBLEM. THE TRUCK HAS A BATTERY LESS THAN 2 YEARS OLD AND HAS ONLY 35200 MILES ON IT. I AM NOT GETTING ANY CHECK ENGINE LIGHTS. IT IS SERVICED ROUTINELY BY THE CHRYSLER DEALER.

Mileage: 35,200

TRUCK HAS LEFT ME STRANDED MULTIPLE TIMES BY COMPLETELY LOSING POWER ELECTRICAL AND ENGINE. DEALER CLAIMS TO HAVE "REPLACED" COMPUTER BUT CHRYSLER CORP CONFIRMS DEALER JUST "REFLASHED" COMPUTER. MULTIPLE RECALLS HAVE OCCURRED AND TRUCK WAS BROUGHT INTO DEALER BUT I KNOW THE OLD PARTS REMAIN IN PLACE! I CANNOT TRUST THIS DEALER TO DO ANYTHING THEY CLAIM TO DO, PROVEN BY COMPARING THE WRITTEN WORK ORDER WITH THE RECORDS AT CHYSLER CORPORATE. WE ARE AFRAID TO DRIVE THIS VEHICLE, MY WIFE WILL NOT STEP FOOT ON IT AND AS I AM AN AMPUTEE EVERY TIME I GET STRANDED(3 TIMES SO FAR) I CANNOT WALK TO GET HELP. SO I AM AT THE MERCY OF AVAILABLE CELL PHONE SIGNAL OR JUST PRAY. THE DEALER HAD CONTINUALLY STALLED US ON REPAIRING THESE PROBLEMS UP UNTIL THE WARRANTY RAN OUT AND THEN ALL OF A SUDDEN THEY FIGURED OUT THE "ACTUAL" PROBLEM AND COULD NOW FIX IT FOR A FEW THOUSAND!! DOLLARS. PLEASE HELP US- WE HAVE BEEN FIGHTING FOR SOME KIND OF JUSTICE FOR 6 YEARS! TRUCK HAS ONLY 24000 TOTAL,ACTUAL SCARY MILES ON IT. PAID CASH OF APPROX $50,000 AND ARE SO HURT AND DISGUSTED WITH OUR PURCHASE BUT MOST OUTRAGED BY THE TREATMENT AND LACK OF NORMAL HUMAN CONCERN FOR OUR SAFETY OR OUR LIVES FOR THAT MATTER. LAST REMARK FROM DEALER OWNER TO US: "NOT MY PROBLEM TOUGH S..T" THIS VEHICLE SHOULD BECOME CHRYSLET CORPS PROBLEM AND WE WANT THE TIMELY RETURN OF OUR MONEY ASAP PLEASE PLEASE PLEASE . THIS IS A NIGHTMARE AND HAS CAUSED US BOTH SERIOUS HEALTH ISSUES

Mileage: 1,500

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE VEHICLE WAS MAKING A LOUD TICKING AND KNOCKING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVER SIDE MANIFOLD BOLT WAS FRACTURED. THE VEHICLE WAS REPAIRED UNDER A MANUFACTURERS RECALL RELATED TO THE FAILURE HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

Mileage: 85,000

BOLTS ON EXHAUST MANIFOLD BROKE, ALLOWING EXHAUST GASES TO VENT TO ATMOSPHERE BYPASSING THE EXHAUST SYSTEM.

Mileage: 26,000

WHEN SLOWLY ACCELERATING FROM A STOP I COULD HEAR A RATTLING/VIBRATION SOUND COMING FROM THE PASSENGER SIDE OF VEHICLE. THIS PROGRESSIVELY GOT WORSE UNTIL I FOUND THE HEAT SHIELD ON THE PASSENGER SIDE EXHAUST MANIFOLD WAS LOOSE DUE TO BROKEN STUD BOLTS. I DID NOT REPAIR IMMEDIATELY AS I THOUGHT THE BREAK WAS SUPERFICIAL (OUTSIDE THE MANIFOLD). OVER THE NEXT MONTH A SLIGHT EXHAUST LEAK COULD BE HEARD, WHICH HAS GOTTEN VERY LOUD NOW. THERE IS CLEARLY AT LEAST ONE BROKEN EXHAUST MANIFOLD BOLT ON PASSENGER SIDE. I AM SECOND OWNER (PURCHASED AT 19,000 MILES), SO LIFETIME WARRANTY IS NO LONGER VALID. I FEAR THIS LEAK COULD CAUSE POISONOUS CARBON MONOXIDE GAS TO FILL THE CABIN OF MY TRUCK WHILE DRIVING WITH MY WIFE AND CHILDREN. WITH THE NUMBER OF COMPLAINTS REGARDING THIS EXACT SAME ISSUE THAT I HAVE HEARD, I CANNOT BELIEVE THIS HAS NOT REACHED RECALL STATUS.

Mileage: 80,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING AT APPROXIMATELY 10 TO 15 MPH APPROCHING A TRAFFIC LIGHT, THE BRAKES WERE ENGAGED AND THE VEHICLE SUDDENLY ACCELERATED INDEPENDENTLY WITHOUT WARNING. THE CONTACT WAS ABLE TO REGAIN CONTROL OF THE VEHICLE AND CONTINUE DRIVING; HOWEVER, THE VEHICLE STALLED SHORTLY AFTERWARDS. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000.

Mileage: 89,000

PURCHASED THE TRUCK USED. ENGINE BEGAN MAKING A TAPPING SOUND SEVERAL MONTHS AFTER PURCHASE. DEALER INFORMED ME THAT BOTH EXHAUST MANIFOLDS WERE LEAKING DUE TO BROKEN BOLTS. THE DEALER STATED A RECALL WAS ESTABLISHED TO REMEDY THIS ISSUE BUT MY VEHICLE WAS NOT INCLUDED. ON 07/01/2014 I HAD THE MANIFOLD BOLTS AND GASKETS REPLACED BY A LOCAL AUTO REPAIR SHOP. ON 01/01/2015 THE TAPPING STARTED AGAIN.

Mileage: 36,000

IT GOT COLD ON THIS MORNING WENT OUT TO START TRUCK. STARTED FINE LIKE ALWAYS DROVE MY WIFE TO WORK SOON AS I PUT TRUCK IN REVERSE MY ABS LIGHT TRACTION CONTROL AND EMERGENCY BRAKE LIGHTS ALL FLASHED ON AT ONCE. TOOK INTO GET BRAKES CHECKED THEY SAID THEY WERE FINE. ALSO HAVE FOUR EXHAUST MANIFOLD BOLTS BROKE FLUSH OFF ON THE BLOCK KINDA BEEN READING A LOT OF PEOPLE HAVE TOO. IS THIS GOING TO BE A RECALL? *JS

Mileage: 107,900

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART AND RESUMED NORMAL OPERATION. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 46,000.

Mileage: 46,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED INTERMITTENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES. THE TECHNICIAN WAS NOT ABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 62,500. UPDATED 10/23/14*CN UPDATED 7/8/2015*JS

Mileage: 62,500

TRANSMISSION STICKS IN 4TH GEAR HAVE TO PULL OVER, TURN OFF TRUCK FOR 5 SECONDS AND RESTART. MOTOR USES NUMBER OF QUARTS OF OIL A DAY WITH NO SIGN OF LEAK. *TR

UPON START-UP OF THE VEHICLE A TICKING NOISE IS HEARD (POSSIBLE EXHAUST LEAK). THE SOUND BECOMES LESS NOTICEABLE AS THE ENGINE WARMS TO NORMAL OPERATING TEMPERATURE. SIMILAR CASES HAVE BEEN SEEN IN 2009 MODELS CAUSED BY BROKEN OR LOOSE EXHAUST MANIFOLD BOLTS FOR CYLINDERS 7 AND 8. CONTACTED THE DEALER BUT THEY STATED MY VEHICLE WAS NOT AFFECTED BY THAT RECALL EVEN THOUGH IT IS THE SAME YEAR AND ENGINE TYPE. *JS

Mileage: 36,678

ON A DAILY BASIS THE ENGINE ON MY 09 DODGE RAM CREW CAB WILL DIE AT LEAST 3-4 TIMES A DAY WHILE DRIVING AROUND 20-30 MPH. I HAVE TAKEN MY TRUCK TO MY LOCAL DEALERSHIP 5 TIMES TO GET THE ISSUE FIXED. THEY HAVE REPLACED THE COMPUTER 3 TIMES. THE ISSUE STILL HAPPENS ON A DAILY OCCURRENCE. I HAVE DUPLICATED THE ISSUE MULTIPLE TIMES TO THE SERVICE AGENT, BUT MAGICALLY WHEN THEY HAVE MY TRUCK FOR TWO WEEKS AT A TIME THE VEHICLE STALLING DOES NOT OCCUR AND THEY CANNOT "RECREATE" THE ISSUE. I HAVE HAD SEVERAL CLOSE ACCIDENTS DUE TO THIS ISSUE AND SOMETHING NEEDS TO BE DONE. THIS ISSUE DOES NOT PULL ANY CODES WHEN HOOKED UP AND HAS BEEN DIAGNOSED BY THE DEALERSHIP AS A "PHANTOM" PROBLEM. THIS IS A SERIOUS ISSUE THAT NEEDS TO BE FIXED BEFORE MY FAMILY GETS SERIOUSLY INJURED!! *TR

Mileage: 14,000

UPON START-UP OF THE VEHICLE A TICKING NOISE IS HEARD. THIS SOUND IS LESS NOTICEABLE AS THE ENGINE WARMS TO NORMAL OPERATING TEMPERATURE. SIMILAR CASES HAVE BEEN SEEN IN 2009 MODELS CAUSED BY BROKEN OR LOOSE EXHAUST MANIFOLD BOLTS FOR CYLINDERS 7 AND 8. CONTACTED THE DEALER BUT THEY STATED MY VEHICLE WAS NOT AFFECTED BY THAT RECALL EVEN THOUGH IT IS THE SAME YEAR AND ENGINE TYPE. *TR

Mileage: 30,000

I PULLED INTO WORK AND SHUT MY TRUCK OFF, BUT THE ENGINE DID NOT TURN OFF. THE TRUCK WAS IN PARK AND THE KEY TO THE TRUCK WAS IN MY HAND AND THE ENGINE CONTINUED TO RUN. I PULLED THE BATTERY TERMINALS OFF THE BATTERY AND THE TRUCK CONTINUED TO RUN. THE TRUCK RAN WHILE I WAS IN WORK WITHOUT THE KEY IN THE IGNITION AND THE BATTERY TERMINALS DISCONNECTED. WHEN I WAS DONE AT WORK THE TRUCK WAS STILL RUNNING IN THE PARKING LOT. I DROVE THE TRUCK HOME DISCONNECTED THE BATTERY TERMINALS AGAIN AND BEGAN PULLING FUSES OUT OF THE FUSE BOX ONE BY ONE UNTIL THE TRUCK FINALLY SHUT OFF. *TR

Mileage: 43,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT STATED THAT WHILE DRIVING 75 MPH HE BEGAN TO BECOME VERY SLEEPY. THE CONTACT HAD TO PULL OVER AND TAKE A WALK TO WAKE HIMSELF UP. THE CONTACT SMELLED EXHAUST FUMES WHEN HE RE-ENTERED THE VEHICLE. THE DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THAT THE BOLTS ON THE MANIFOLD HAD BROKEN AND THE FAILURE WAS COMMON. AS A PRECAUTION, THE CONTACT CONSULTED WITH ANOTHER DEALER AND WAS GIVEN THE SAME ANSWER. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 40,000.

Mileage: 40,000

EXHAUST MANIFOLD BOLTS (AS NOW KNOWN UNDER DODGE TSB SAME SUBJECT) ARE DEFECTIVE AND OF WRONG MATERIAL TYPE AS PER TSB. BOLTS MAY FAIL CAUSING EXHAUST LEAK AT MANIFOLD TO ENGINE GASKET, ALLOWING EXHAUST FUMES TO ENTER THE CABIN. NOXIOUS FUMES IN CABIN MAY CAUSE DRIVER TO BECOME POISONED OVER LONG TRIP TIMES RESULTING IN LOSS OF CONSCIOUSNESS AND VEHICLE CONTROL OR SITUATIONAL AWARENESS. FAILURE OF BOLTS ALSO ALLOWS RELEASE OF PRE-CATALYST EXHAUST TO BE DISCHARGED INTO THE ATMOSPHERE. CONTACT:[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 41,000

TL* THE CONTACT OWNS A 2009 DODGE RAM 1500. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP, THERE WAS A CLICKING NOISE COMING FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY STATED THAT IT WAS THE EXHAUST MANIFOLD BOLTS THAT WERE FRACTURED AND CAUSING THE NOISE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 31,000.

Mileage: 31,000