2003 DODGE SPRINTER Problems & Recalls

TL* THE CONTACT OWNS A 2003 DODGE SPRINTER 2500 EQUIPPED WITH A PGW WINDSHIELD, TINT-LAMINATED, PART NUMBER DW01488GBNN. THE CONTACT STATED THAT THE WINDSHIELD WAS REPLACED BECAUSE IT WAS DAMAGED BY A STONE. THE CONTACT STATED THAT THE WINDSHIELD WAS DISTORTED AND DIFFICULT TO SEE THROUGH. THE CONTA...

TL* THE CONTACT OWNS A 2003 CHRYSLER SPRINTER 2500. ON JULY 29, 2010, THE CONTACT RECEIVED THE RECALL NOTICE, NHTSA CAMPAIGN ID NUMBER: 09V418000 - COMPONENT: ENGINE AND ENGINE COOLING:EXHAUST SYSTEM. THIS RECALL WAS FOR AN ISSUE WITH CORROSION ON THE INTAKE MANIFOLD. WHEN THE CONTACT RECEIVED TH...

CONSUMER WRITES REGARDING CHRYSLER NON-COMPLIANCE WITH SAFETY RECALL J32-DODGE SPRINTER 03 MANIFOLD/EGR *TGW THE CONSUMER STATED HE SPENT THE PAST WEEK IN REPEATED UNSUCCESSFUL EFFORTS TO ARRANGE THE NECESSARY MODIFICATIONS WITHOUT HAVING TO INCUR UNREASONABLE EXPENSES. THE CONSUMER BELIEVED CHRYS...

2003 DODGE SPRINTER. CONSUMER STATES DEFECTIVE INTAKE MANIFOLD. CONSUMER STATES THAT A NOTICE FROM CHRYSLER REGARDING ARRANGEMENTS TO REPAIR THE DEFECT HAS NOT BEEN RECEIVED *TGW

TL*THE CONTACT OWNS A 2003 DODGE SPRINTER. THE CONTACT STATED THAT THE THROTTLE PEDAL FAILED WHICH MADE IT IMPOSSIBLE TO ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES AND THEY COULD NOT FIND THE FAILURE. THE MANUFACTURER WAS CALLED AND STATED THAT THEY WERE UNABLE TO REPAIR THE FAILU...

Mileage: 50,000

I HAVE HAD 3 VALVE STEM FAILURES WHERE THE STEM GOES INTO THE RIM IN APPROX 6 WEEKS OF TIME RESULTING IN FLAT TIRES. LAST ONE WAS WHILE PARKED BUT WAS RAPID DEFLATION TOLD STEMS FROM THE FACTORY WERE NOT THE CORRECT STEMS. REPLACED BY THE DEALER FOR FREE ALL STEMS. *JB

Mileage: 49,095

I PURCHASED A 2003 DODGE INTREPID IN NOVEMBER OF 2005 AND THE CAR RUNS FINE UP UNTIL ABOUT A MONTH AND A HALF AGO. THE CHECK ENGINE LIGHT CAME ON AND THE CAR WOULD GET STUCK IN ONE GEAR AND MY RPM WOULD GO UP INTO THE RED LINE UNLESS I PULLED OVER AND RESTARTED THE CAR. OTHER TIMES IT WOULD GET STUC...

Mileage: 108,356

I PURCHASED A 2003 DODGE INTREPID IN NOVEMBER OF 2005 AND THE CAR RUNS FINE UP UNTIL ABOUT A MONTH AND A HALF AGO. THE CHECK ENGINE LIGHT CAME ON AND THE CAR WOULD GET STUCK IN ONE GEAR AND MY RPM WOULD GO UP INTO THE RED LINE UNLESS I PULLED OVER AND RESTARTED THE CAR. OTHER TIMES IT WOULD GET STUC...

Mileage: 108,356

- HAD BRAKES ON 2003 DODGE SPRINTER CHECKED BY LOCAL MECHANIC. SAID THAT THERE WAS ABOUT 40% BRAKE PAD LEFT BUT THE ROTORS WHERE EXTREMELY WORN. I AM WONDERING IF ROTOR LIFE GOES PAST THE BRAKE LIFE AND COULD BE A DANGER. DEALER SAID ROTORS ARE CHANGED EVERYTIME WITH PAD CHANGE! *NM

Mileage: 120,000

WE OPERATE 2 2003 DODGE SPRINTER PASSENGER VANS IN OUR AIRPORT SHUTTLE BUSINESS. ON THURSDAY, MAY 19TH WE HAD A VEHICLE JUST QUIT AFTER START-UP WHEN THE DRIVER STEPPED ON THE GAS. SHE RE-STARTED, DROVE A BLOCK, IT QUITS AGAIN. WE HAD 6 PASSENGERS ONBAORD TO GO TO THE AIRPORT. SHE COULD NOT MAKE TH...

Mileage: 190,000

WHILE DRIVING 55 MPH FRONT DRIVER/REAR PASSENGER TIRE BLEW OUT. CONSUMER PULLED OVER AND CHANGED THE TIRE. MICHELIN , P275R16. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 18,000

RECALL CAMPAIGN 04V600000 CONCERNING TIRE VALVE. WHILE DRIVING 60 MPH THE VEHICLE SWAYED SEVERELY ACROSS THE ROAD. CONSUMER WAS ABLE TO PULL THE VEHICLE OFF THE MAIN ROAD, AND NOTICED THE RIGHT REAR TIRE WAS FLAT. THEN, CONSUMER CHANGED THE TIRE, AND DROVE THE VEHICLE TO HIS BROTHER IN LAW'S HOM...

Mileage: 19,000

RECALL CAMPAIGN 04V600000 CONCERNING TIRE VALVE. WHILE DRIVING 60 MPH THE VEHICLE SWAYED SEVERELY ACROSS THE ROAD. CONSUMER WAS ABLE TO PULL THE VEHICLE OFF THE MAIN ROAD, AND NOTICED THE RIGHT REAR TIRE WAS FLAT. THEN, CONSUMER CHANGED THE TIRE, AND DROVE THE VEHICLE TO HIS BROTHER IN LAW'S HOM...

Mileage: 19,000

WHILE STOPPING FOR A RED LIGHT CONSUMER HEARD A LOUD NOISE. CFONSUMER GOT OUT OF VEHICLE AND NOTICED THAT TIRE FLAT. AAA WAS CALLED, WHO INDICATED THAT THE VALVE STEM BLEW OUT. THE NEXT DAY WHILE THE VEHICLE WAS SITTING IN THE DRIVEWAY THE VALVE STEM BLEW OUT AGAIN AT ANOTHER ANOTHER TIRE. *A...

Mileage: 28,000

I HAVE A 2003 FREIGHTLINER SPRINTER VAN, MADE BY MERCEDES, AND WHILE ON A TRIP I NOTICED A LOW TIRE AND WHEN I ATTEMPTED TO ADD AIR THE VALVE STEM THREADED BRASS PART SEPARATED FROM THE NEOPRENE. I TOOK IT TO A TIRE PLACE AND HAD THE VALVE STEM REPLACED. ABOUT A WEEK LATER, ON THE TRIP BACK TO FLORI...

Mileage: 16,500

I HAVE A 2003 FREIGHTLINER SPRINTER VAN, MADE BY MERCEDES, AND WHILE ON A TRIP I NOTICED A LOW TIRE AND WHEN I ATTEMPTED TO ADD AIR THE VALVE STEM THREADED BRASS PART SEPARATED FROM THE NEOPRENE. I TOOK IT TO A TIRE PLACE AND HAD THE VALVE STEM REPLACED. ABOUT A WEEK LATER, ON THE TRIP BACK TO FLORI...

Mileage: 16,500

TIRE VALVES SUDDENLY ALLOW AIR TO ESCAPE FROM WHEEL, A COLLISION COULD HAVE EASILY OCCURRED. FOUND THAT THE VALVE WAS FAULTY, AND FAILED DUE TO HIGH TEMPERATURES GENERATED BY DISC BRAKES.*AK PE04066_CAT

Mileage: 13,955

TIRE VALVES SUDDENLY ALLOW AIR TO ESCAPE FROM WHEEL, A COLLISION COULD HAVE EASILY OCCURRED. FOUND THAT THE VALVE WAS FAULTY, AND FAILED DUE TO HIGH TEMPERATURES GENERATED BY DISC BRAKES.*AK PE04066_CAT

Mileage: 13,955

THIS STUFF IS DANGEROUS. I'VE LOST THREE TIRE VALVES IN LESS THAN 1000 MILES AND THE LAST WAS SUDDEN AND VIOLENT. HONESTLY, I THOUGHT I'D DONE SOMETHING WRONG, BUT I'VE USED ONLY MR. CLEAN WASH SYSTEM AND A VERY DILUTE DEGREASER ON THE WHEELS. IT WAS DIFFICULT TO TRY TO REMOVE THE STEMS WITHOUT F...

Mileage: 8,945

THIS STUFF IS DANGEROUS. I'VE LOST THREE TIRE VALVES IN LESS THAN 1000 MILES AND THE LAST WAS SUDDEN AND VIOLENT. HONESTLY, I THOUGHT I'D DONE SOMETHING WRONG, BUT I'VE USED ONLY MR. CLEAN WASH SYSTEM AND A VERY DILUTE DEGREASER ON THE WHEELS. IT WAS DIFFICULT TO TRY TO REMOVE THE STEMS WITHOUT F...

Mileage: 8,945

THIS STUFF IS DANGEROUS. I'VE LOST THREE TIRE VALVES IN LESS THAN 1000 MILES AND THE LAST WAS SUDDEN AND VIOLENT. HONESTLY, I THOUGHT I'D DONE SOMETHING WRONG, BUT I'VE USED ONLY MR. CLEAN WASH SYSTEM AND A VERY DILUTE DEGREASER ON THE WHEELS. IT WAS DIFFICULT TO TRY TO REMOVE THE STEMS WITHOUT F...

Mileage: 8,945