2024 FORD BRONCO SPORT Electrical System Problems

Powertrain malfunctions have occurred on 12/17/24, 4/11/25 and 10/5/25. Powertrain malfunction and yes. The car would not accelerate and someone could of ran into me, I could of been killed or badly injured and same for any other occupants in the either vehicle. Yes. Yes. The messages appeared on 12/17/24, 4/11/25 and 10/5/25.

I reached out to ford due to my 2024 bronco sport overheating and running hot. During the time of that complaint I was advised that my bronco currently has a recall that the fuel tank needs to be replaced but it is currently being deemed as non safety and will only be addressed if the vehicle is in for service. I was also advised that due to this recall it is currently a part of fords customer satisfaction program. Anything fuel related should be deemed as a safety recall considering fuel is a flammable chemical. I have requested a buy back as I no longer feel safe operating the vehicle or comfortable transporting my daughter in the vehicle as it aligns too closely with the known fuel safety recall currently present on some 2021-2024 bronco sports.

The contact owns a 2024 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle vibrated, and the contact stated that there was an abnormal white noise coming from the rear of the vehicle. No warning lights were illuminated. The contact stated that on another occasion, while driving 60 MPH, there was smoke coming from under the hood. The contact pulled over to the side of the road and shifted in park(P). The contact opened the hood and noticed that the engine had overheated. No warning lights were illuminated. The contact waited for the engine temperature to lower. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that the failure persisted. On another occasion, while driving 65 MPH in the rain, the steering wheel pulled to the right. The contact was able to control the steering wheel and continued to drive at a slower speed. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. Most recently, the contact stated that there was an abnormal static sound coming from the electronics inside the vehicle. The contact stated that the abnormal sound was also heard with the engine turned off. The contact stated that the magnetic vibrations and potential unauthorized electronic interference affected her health. The contact used the PHYPHOX App to get the magnetic and electronic interference readings. The contact stated that while the vehicle was being diagnosed, a rental was provided. The rental was a 2024 Ford Bronco Sport, and the contact experienced the same failure. The manufacturer was made aware of the failure. The failure mileage was approximately 1,000.

Mileage: 1,000

When coming from a stop at a traffic light vehicle losses power for approximately 15-20 seconds. This puts the driver of the vehicle, passengers, and other vehicle drivers operating on the roadway in danger of a major collision, possible bodily harm or even death. We have twice taken the vehicle to our dealership, where we purchased the vehicle; in order to fix the recall and we have had no success in gaining a remedy for the issues. The vehicle was seen twice by the Chandler, Arizona Earnheart Ford service department. There were no warning signs before the incident and they started appearing soon after the purchase of the vehicle. We have notice that the hotter it is outside the more frequent the loss of power occurs.

My backup camera one two separate occasions has not operated properly. First time it never showed a vehicle had come up behind me. Didn’t go off with any notice. I backed into a car. Second time a man with a cart walk behind as I was backing out no notice. There is a recall on review camera but not on my vin.

The contact owns a 2024 Ford Bronco Sport. The contact stated that the engine knock sensor and the oil pressure sensor failure warning lights were illuminated; however, the vehicle had not displayed any failures. The vehicle was taken to the dealer who diagnosed the vehicle and determined that the wires underneath the vehicle were defective due to bite marks. The contact stated that after the wires were repaired, the contact attempted to start the vehicle, but the vehicle failed to start. The vehicle was towed back to the dealer who determined that there were bite marks on the wires again. The contact was informed that the insulation on the wires were soy-based, and squirrels were chewing on the insulation. The wires were replaced again. The manufacturer was not informed of the failure. The failure mileage was approximately 6,031.

Mileage: 6,031

The contact owns a 2024 Ford Bronco Sport. The contact stated that while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to the dealer, and it was determined that there were bite marks on the electrical wires under the vehicle. The contact was informed that the insulation of the wires underneath the vehicle were soy-based and was being chewed on by squirrels. The wires were replaced. The manufacturer was not informed of the failure. The failure mileage was unknown.

Vechicle is again in Battery saver Mode. Vechicle not safe to drive.

Vechicle battery will not hold a charge, longer than a few days. Ford can see the BCM Faults on there end.

Battery will not hold a charge longer than a few days. Ford can see the BCM Faults, on their end.

Battery / 12V system failure. Vehicle will not start, requires jump start to start vehicle. Battery does not sufficiently re-charge while vehicle is running and requires jump start next time vehicle is needs to be started. This issue has left me stranded on multiple occasions. The dealer has not reviewed the vehicle yet and no parts have been inspected. Problem first occurred two weeks into ownership / 400miles. There are no official indicators of issue, however I did notice that the auto stop/start feature does not function when driving as an early tell that the 12V system does not have sufficient charge.

Bought car June 27 and now being July 15 the car is completely dead and battery is dead. Charged the battery up works now. But battery will need to be replaced. Picture attached of battery after charging for 3 hours.

On [XXX], my 2024 Ford Bronco Sport spontaneously burst into flames while driven by my [XXX] son. Per a local bystander, there was smoke and fire observed around the undercarriage as he drove down the road. Multiple vehicles began honking while stopped at a red light. A driver alerted my son of the fire. He was able to evacuate along with his [XXX] sister. As they were fleeing to the median of an active highway, the vehicle burst into flames. After several explosions the vehicle continued to burn and melt until the fire dept extinguished the flames. Prior to spontaneous combustion, there were no symptoms of gas leaks or error messages. Nor were there any fluid leaks. There were no error messages or signs of vehicle distress even while my children were driving & engulfed in flames. If bystanders had not flagged down my son, my children may have still been inside the vehicle when the fire & explosions consumed them. The fire department ultimately inspected the vehicle for damage. I am still awaiting their report. Initial conversations on the scene indicated an engine fire. On June 11th, my insurer commissioned an engineer to inspect the vehicle for causation. No report currently available. The vehicle was brand new; purchased just 6 weeks ago. At the time we purchased, 2022 & 2023 models had an open safety recall for fire risk due to a fuel injection defect. There were no reported design updates for the 2024 model. Nor were the recall fixes recommended in Feb 2024 installed on my Bronco purchased late April. It is my position that both Ford & the dealership knew or should have known the 2024 models would have the same defect and fire risk. Disturbing they sold their defective vehicle to my family. The dealership claims no responsibility or obligation to disclose risks. Ford refuses to speak with me given total loss status. My only recourse now is through my insurance. My children remain traumatized by their near death experience. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC

The contact owns a 2024 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number 24V267000 (Electrical System, Power Train) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.