2024 FORD BRONCO SPORT Unknown Or Other Problems

At least 6 times now my gas guage has plummeted from 60+ miles to 6 then 2 and none in less than a mile. Thus has left me standed after midnight on the side of the highway and other various places. I had to use the road side help ford offered. It happens often and doinng deliveries this is very scary for me. I never know how much gas i have. I feel like im constantly putting in gas. I looked up the symptoms and found on reddit quite a few people experience the same. This could be very dangerous to me and other drivers constantly getting stranded on side of road or in the middle of the road. This is a new car im Paying alot of money for. And should feel as safe as possible while driving

extreme loud vibrating noise coming from sunroof while driving at or above 35 mph. it may be bad design for rubber seal and body trim for the sunroof. for example: automatic car washing - hard rolling brushes hitting the top of the vehicle during the wash process, then there is the high pressure water rinsing from different directions, followed by a high wind vortex that causes every exterior surface extreme pressure and force. so, a few trips to the car wash, now causes your sunroof seal failure which may lead to a sunroof blow out while driving at 60mph on the high way... please ALERT ALL to this danger. sunroof seal failure. sunroof blowout. sunroof vibrating.

I have contacted ford directly and they still have not gotten a remedy for the unrepaired recall. My spouse and I went on a road trip that was 20 hour trip in total. They told us to keep driving it until it catches on fire because they did not have a remedy for it yet. We had just taken it in for an oil change and had them look the vehicle over due to the rpms keep jumping up even when going at low speed. The vehicle keeps loosing power and shakes when at idle or even when it starts up. We told ford about the smell of fuel or something when we walk by the hood of the vehicle and they said there was nothing wrong with it and that they didnt notice or smell anything when they did the oil change. When we talked to ford about our concern with the vehicle and that were were afraid to drive it especially since we have a baby and that we were told to continue driving it until it catches fire. We have a 9 month old who is in the vehicle daily due to having to go daycare. i am afraid for him being in the vehicle and it catching on fire or anything and not having enough time to get him out of the vehicle. Something needs to be done pronto or a law suit will be brought up

Vehicle is having trouble with moving, when press on gas pedal it does not really want to move. When sitting at idle vehicle shakes really bad. can hear a really bad tick when driving vehicle. noticed that when driving the vehicle has been shaking really bad. Rpms have also been shooting up high when barely going up to speed.

When coming from a stop at a traffic light vehicle losses power for approximately 15-20 seconds. This puts the driver of the vehicle, passengers, and other vehicle drivers operating on the roadway in danger of a major collision, possible bodily harm or even death. We have twice taken the vehicle to our dealership, where we purchased the vehicle; in order to fix the recall and we have had no success in gaining a remedy for the issues. The vehicle was seen twice by the Chandler, Arizona Earnheart Ford service department. There were no warning signs before the incident and they started appearing soon after the purchase of the vehicle. We have notice that the hotter it is outside the more frequent the loss of power occurs.

I have cut my arm two times on the door lock while exiting the vehicle. The door lock sticks out and the point is very sharp. I have blood thinner issues and it could cause severe problems. It occurs when the door cannot be opened all the way and you turn to exit. This needs to be rounded off and the flashing from casting the part needs to be sanded off

The vehicle was bought brand new in February of this year, 2025. Was bought and has been driven by my daughter who turned [XXX] this year. She went to camp and the vehicle sat behind the house till she got back. the vehicle and front windshield face west and is exposed to the summer sun from 11:30 till 8pm. When she got back and went to drive the car on [XXX], there was a large stress crack in the middle of the windshield. (will attach pictures if possible with this online form). I had my neighbor check his security camera to see if anyone had vandalized the vehicle or if there had been any large object fall on the vehicle. after reviewing his recorded video, we both saw that no one touched the vehicle and that nothing fell on the windshield during the time it sat. I contacted Ford Motor Co. and they instructed me to take it to the dealership and have them take a look and then submit a claim if they thought it was a stress crack from the sun. I took the vehicle in to the dealership on June 26, 2025 and was told I would hear updates over the next few days. Over a week went by and I had to call the service dept at Wyatt Johnson Ford in Nashville. The Assistant service manager stated that Ford Warranty was denying the claim and stated that something else must have caused the crack. The Assistant Manager told me that the technician had written that they believed it was a stress crack from sun exposure and had submitted photos that backed up that claim. Also, on the work order, the Assistant Manager also wrote that it was a stress crack from sun exposure. There is a deep, horizontal crack in the middle of the windshield that has no origination marks or indentations which one would expect from the way that Ford Motor Warranty is denying the claim. I have asked the Assistant Manager to resubmit the claim and I sent him the photos I had taken as soon as it was first noticed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The Heritage edition of the Bronco Sport has a piece white trim on the dashboard that causes a very distracting reflection on the windshield directly in the driver's line of sight. I feel there should be a recall for this piece of trim — replacing it with the regular dark strip used on the other Bronco Sport editions. Thank you for your consideration!

I was driving down the highway, and my moonroof exploded. I thought something had exploded or someone had shot at me. No other cars were around me that could have caused something to pop up and hit the roof. I did take it to the dealership service where photos were taken and submitted for a possible claim on the warranty. I only have about 2000 miles on the vehicle. My first payment isn't even due yet. Ford warranty declined the claim. It looked like it exploded upwards leading me to think this was an installation or material issue. Glass that exploded out flew off the roof of the vehicle scratching it as it dragged along. This could have hit another driver if one had been following behind me. I am currently awaiting a callback from the insurance adjuster.

While driving on the freeway, my Ford's sunroof spontaneously shattered. There were no vehicles in front of me, I live in San Diego County and the weather was in the mid-60's and I did not have my air on. It sounded like an explosion or gunshot. I immediately pulled off on to the shoulder and saw the shattered sunroof, and since I was about to exit to my house, I continued home and called the California Highway Patrol to report a potential gunshot to my vehicle. However, when the office arrived, he believed it was an implosion from the inside of the vehicle outward. This did appear to be the correct assessment as there was no glass inside the vehicle (I had seen glass fragments falling around the outside of my vehicle and in front of my windshield at the time of the explosive sound). Also, the glass was bent out towards the top of the vehicle consistent with an inside to outside breakage. I took it to my local Ford dealership and Ford has accepted responsibility for the defect and will replace my damaged sunroof at their cost.

The steering is temporarily disabled when the vehicle is in the auto off/fuel saver mode. I had an approaching EMS vehicle that I was almost struck by because my vehicle was off due to that feature. The steering wheel was not responsive.

When I start my Bronco, daily, there a vibration even as I drive out of my garage. Once I’m on the road I don’t feel the vibration. I have taken my Bronco to the dealer 2-3 times and they tell me the Bronco doesn’t do as I stated to them. I can’t make this up, I think the mechanics are not sure what is wrong. I love my Bronco and have owned many fords over the years and have never had this issue. They did tell me, I should drive it more and the vibration should stop. At least they admitted it was happening. I drive 16 miles a day, so I’m not sure how much I should drive daily , I’ve never been told I should drive more🤪