2022 FORD BRONCO Engine Problems

I purchased this vehicle in May this year and in July the manufacturer issued a safety recall notice. The manufacturer mentions in the recall that the engine may fail and can lead to crashes. I am unbale to use the vehicle for business, since I received the notice and it is causing me a lot to the verge of collapsing my business. I would like the manufacturer to look into this and issue a remedy as quickly as possible as the financial strain on my business is enormous. Thank you!

Engine started stalking and acting like it wasn’t getting enough gas about a month ago. Took to a dealership and they said u had a cracked file injector line. They supposedly fixed the issue. Today it started stalling again and shut off in the middle of the highway and wouldn’t crank back up. Tried jumping battery and it would turn over but acted like it wasn’t getting any gas when trying to give gas and take off then it would shut off again. Had to get a tow back to dealer ship.

The contact owns a 2022 Ford Bronco. The contact stated that while attempting to accelerate, the vehicle hesitated. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.

Mileage: 40,000

On 03/31/25 at approx. 12:45 AM our 2022 Ford Wild Trak was engulfed in fire while parked on our driveway. There were no occupants, and it had last been operated on 3/30/25 at approximately 1030 PM. During its last operation there was nothing abnormal to indicate the potential of a engine fire (no warning lights, messages, unusual smell or odors, performance issues, smoke, or fire). Upon observing the Ford Bronco Wild Trak for the first time the engine compartment was fully engulfed, and it was clear the fire had started in the engine compartment. The flames from the Ford Bronco Wild Trak eventually spread to a second vehicle destroying it down to the frame and causing enough damage to a third vehicle rendering it a total loss. All three vehicles were within 4 feet of our residence and the flames were hot enough it melted the garage door window frames. The Ford Bronco Wild Trak is frequently parked in our garage, and it been we would have lost our home and the lives of all four family member would have been put at risk. Researching Ford Bronco Wild Trak engine fires, we discovered that Ford Bronco Sports and Ford Escapes both have recalls due to faulty fuel injectors resulting in engine fires. The fuel injectors in Ford Bronco Wild Trak’s are similar to the fuel injectors in both the Ford Bronco Sports and Escapes. Due to the similarity between the Ford Bronco Sports and Escapes with the Wild Trak fuel Injectors we are asking for the NTSBA to initiate an investigation into Ford Bronco Wild Trak engine fires. The Ford Bronco Wild Trak can be retained for inspection if requested quickly as it is scheduled to be picked up by our insurance company and then disposed.

We were returning home from a trip. We pulled into a gas station to get gas. As we pulled up to the gas pump, we smelled smoke and then saw smoke and fire. We immediately turned the Bronco off and jumped out. Shortly after, the whole engine compartment area was on fire. Luckily, there was a tow truck in the parking lot and was able to drag it away from the gas pumps. I had gotten an oil change prior to our trip. There were no warning signals, lights, or indication of temperature or oil problems. I had intermittently smelled gas while driving during our trip, but my wife said she did not smell gas on the passenger side.

The contact owns a 2022 Ford Bronco. The contact stated while driving at various speeds, the vehicle lost motive power. The check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that a bent valve stem needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 103,000.

Mileage: 103,000

The contact owns a 2022 Ford Bronco. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the spark plugs had failed to remain connected. The spark plugs were reconnected. The next day the check engine warning light illuminated. The vehicle was returned to the dealer where it was diagnosed with the same failure. The spark plugs were replaced. The failure reoccurred and the engine sounded as if the engine was sputtering while starting the vehicle for several minutes. The vehicle was returned to the dealer where it was diagnosed as spark plug failure and that the engine was misfiring. There were no DTC codes retrieved. The vehicle was not repaired. The manufacturer had not been made aware of the failure. The failure mileage was approximately 35,000.

Mileage: 35,000

There is a major lag in the time from when you hit the pedal to when you start accelerating, almost like a pause. Hesitation, long lag or dead spot in accelerating. Failed to accelerate from a stop at least 3 times.

I have the same complaint that many 2021-2023 Ford Bronco owners have had in regards to the 'scraping/grinding' noise in 1st and 2nd gear. I have seen this on dozens of forums and Ford acknowledged it is an issue. I was told to bring the car in when I was ready for an oil change. This is after being a second day reservation holder and waiting 2.5 years for my car to be built. The dealership told me that the transmission was bad and I needed a new transmission. It will take 10-15 weeks to get a new transmission, and in the meantime all that was offered was a less than ideal rental car (ford edge) and to wait patiently. This is a known issue that the transmissions were faulty, Ford has not been responsive in terms of getting any help/assistance otherwise, and I am not sure if this will even fix the problem. There are hundreds of other owners who have this same issue, and Ford has done nothing.

My bronco started having issues randomly when it went into limp mode one day. I brought it in to get fixed and it continued to happen. Ultimately, they told me that it needed a brand new engine.

Not exactly sure how it started to happen. Meaning there was a powertrain malfunction so my Ford computer tells me, which caused the vehicle to not restart and in addition to it not restarting, the vehicle also didn't have brakes, so it simply rolled backwards without any control until I hit a tree to stop me. On the way down, I also hit the bumper and damaged it and also hit the driver's side mirror on a rock on the way down.

Battery charge, over heated, failed power train, and failed 4x4 happened all within seconds of each other. We were on a 2 lane hwy where there was very little room to pull off the main road. It was Christmas Eve and we were about 60 miles from home. We had to pay around $400 dollars to have it towed home and it was freezing outside while we waited.

Flat towed vehicle behind motorhome. Followed Fords instructions to the letter. Transmission fried even though computer showed flat tow engaged. Ford refused to warranty this issue and blames the operator due to an internal memo. Ford dealerships have acknowledged their is an issue with their flat tow system but Ford refuses to warranty.

Driving down the road on 10/31/23, all of a sudden the entire vehicle started to shake, then the check engine light came on, then the vehicle started shaking even worse- losing power and sputtering. Pulled over and had it towed to dealer- Buckhannon WV- they checked the compression and found nothing. I am still waiting for someone to look at the vehicle's engine to determine the issue- I have not even owned this Bronco for 3 months when this happened. It only has 24000 miles on it. It left me stranded along the highway- my friend had to come and pick me up. I currently have no vehicle to get back and forth to work. Its sad that you pay such for a vehicle so you don't have to worry about getting back and forth and now it looks like I will be waiting for months- no Bronco and no one seems to be concerned.

Once the vehicle hit around 3000 miles it started making a loud clicking noise while the vehicle was running parked or driving . The noise continued to get louder. When I called New Brighton Ford where i purchased the vehicle brand new on 4/25/23 at the end of June I was told to make a service appt. The soonest they could see the vehicle was 4 weeks later. Because of the continued noise I called on about July 12 2023 they agreed they would look at it upon looking at the vehicle. It was found that the engine was in engine failure. They kept the vehicle for six weeks and had to replace to the engine.

2022 Ford Bronco loss power while driving moderate speed (35 - 55 MPH) and would not immediately restart after the first attempt. After finally restarting it would continue to stall. The car was towed to the dealership where after four weeks of investigating they found the catalytic converter to be melted. The car has now been sitting at the dealership for 7 weeks with an "indefinite lead time" on replacement parts. My Bronco only has 14,000 miles on it and no determination on what caused the catalytic converter to melt.

BRAKE PEDAL KICKS BACK ON OUR FOOT WHEN STOPPED BRAKES DONT WORK GOOD LOST BRAKE FLUID MUST PUMP BRAKES TO COME TO A STOP OR SLOW DOWN ON GOING FOR A YEAR NOW DEALER DROVE FOR ONLY NINE MILES THEY SAID ITS OK STILL HAVE THE PROBLEM - ENGINE HAS LOST POWER WHEN HOT - WHEN IT IS COLD ON START UP THE MOTOR RUNS ROUGH AND LACKS POWER DEALER HAS NOT LOOKED AT THE ENGINE PROBLEM YET -TURN SIGNALS WILL TURN WHEN TURNING RIGHT WHEN IT IS CANCELED IT WILL TURN THE LEFT TURN SIGNAL ON SAME THING GOING TO THE LEFT IT TURN THE RIGHT ON ON -ALL PROBLEMS ARE STILL ON GOING AS OF 10-4-2023

multiple lights on dash turned on also check engine light' loss of power and jerking of vehicle

Lost power while in drive. Car became unresponsive. No response to accelerator inputs. Engine light flashes and request to stop car, turn off, and restart. No power to get out of traffic, safely rolled of highway.

The contact owns a 2022 Ford Bronco. The contact stated while starting the vehicle, the check engine warning light illuminated. The vehicle was taken to the dealer and the dealer stated that there was low compression in cylinder #3. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 38,000.

Mileage: 38,000

I received a "Power Malfunction/ Reduced Power" notification. Then I received a notification to "Service Engine" -control system has detected the turbocharger wastegate is stuck closed. Vehicle is currently at the dealer, per service tech faulty turbo, new one ordered.

The contact owns a 2022 Ford Bronco. The contact stated while starting the vehicle he heard a rattling nosing coming from the vehicle. There was no warning light illuminated. The contact stated that after the vehicle warmed up, the sound went away. The vehicle was taken to the dealer and the mechanic confirmed the abnormal sound coming from the vehicle, but no failure was found. The manufacturer was contacted and advised the contact to reach out to the NHTSA Hotline and file a complaint. The failure mileage was 12.

Mileage: 12

Bronco has less than 43 miles. Took vehicle on highway and went to go pass a semi and the vehicle lost all power. This could of caused a wreck if there was someone behind me trying to pass the semi as well. Took back to the Dealership and the turbo failed on my brand new Bronco. Please see Bronco6G for someone who is logging a list of other members that had similar issues. https://www.bronco6g.com/forum/threads/2-3-2-7-failed-turbo-list-7-counting-slowly-working-on-list.59162/

Brand New Bronco Black Diamond Edition. Driven 1000 miles and now engine will not accelerate. Loud noises coming from engine with multiple warnings from the app: 1) powertrain / 4 wheel drive fault 2) transmission Control module / electrical fault with transmission sensor and it’s associated wiring 3)power train control module has detected one of the transmission speed sensors readings is operating outside of the expected range for the vehicle

Powertrain malfunction. Decreased power sent to powertrain. No turbocharge activation. Minimal acceleration, got up to only 45 on highway. Check engine light on, followed by Turbocharge wastegate malfunction. 6500 miles, 4 months old. 2.7L engine. Daily driver awaiting dealer service appointment. Not drivable.

Vehicle reported Anti-Brake Fault. Vehicle reported Pre-Collision Fault. Vehicle reported 4 different hill start Assist Failures. I noticed the Pre-Collison feature did not work because the breaks never activated when there was a sudden merge into my lane going 65 miles per hour. The car says that the pre-collision feature is enabled but did not respond to a vehicle that came close to causing a wreck.

The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle made abnormally loud knocking sounds. The vehicle was towed to the dealer where it was diagnosed with metal shavings in the engine oil and filter. The dealer performed an oil change and informed the contact that the two transmission pumps and the engine needed to be replaced. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 60.

Mileage: 60

Conducting the Bronco's 1st oil change at 5,003 miles at my home and the oil pan has missing or damaged pins/tabs that guide the oil plug out of and into the oil pan. When I turned the hand plug counter clockwise it did not ride out on the pans internal pins/tabs, it stayed fully seated and rotated fully to the stops. Was able to just just twist the the plug from stop to stop while fully inserted. Pulled the plug straight out and drained the oil. Once oil was drained tried feeling in the drain plug hole for any type of pin/tab that the plug is designed to guide in and out on and felt none. Did not see any damage to the plug.

Engine/battery emitted smoke and sulfur odors. Causing concern of igniting or exploding

In remote area in a canyon the engine quit suddenly due to fuel starvation caused by faulty fuel pump. The engine quit on the edge of the cliff and would not start again. Check Engine light was illuminated. After being towed to the nearest dealership. I was advised that my Bronco needs a new Fuel Pump. Vehicle warnings are as follows: - Electrical Fault with the Fuel Pump. - Engine Fuel Control System cannot achieve required fuel pressure to start engine. - Engine Fuel Control Sytem is unable to control fuel system pressure.

This engine has the wrong oil dipstick does does not show he right amount of oil, this could risk engine damage by not installing enough oil at oil change

my vehicle lost power on the GW bridge in NYC. It has less than 1000 miles and the power, driving at 60 mph just died. To add insult to injury Ford (24hr roadside assistance told me that there were no tow truck available at this time). When my car was finally towed, vis a vie a 3rd party, to the nearest dealership, I was told that because I didnt buy my car there, there was nothing I could do but wait a "few weeks". Ford 24 hr road side assistance really left me out to dry. I wish and am looking for ways to sue them. Luckily, my responsible dealer at Lester Glenn Ford on Rt 35 was able to assist and is making every accommodation to help. Thank goodness for them and their restless souls for helping with this. I literally have less than 1000 miles on the Badlands 2.7 V6, and when this happened, I didnt know what to do. Disappointing. But Lester Glenn is so far amazing at the response.

Mileage: 977

During normal driving conditions, vehicle went into low power mode while on the highway but was able to navigate to side of road and then into parking lot. Numerous vehicle alerts came up on monitor including powertrain malfunction/ reduce power. Dealership mechanic put a camera into engine and can see metal pieces loose in engine cavity. Still waiting for dealership to tear down engine and officially diagnosis issue but it certainly looks similar to other issues now in the news (and on NHTSA website) with this 2.7L ecoboost engine. Dealership is taking an extraordinarily long time to give me an official answer as to what the metal is from, but the photos I saw look to be similar to the valve pieces (can see threads) others have noted on the 2021 issues.

I was driving my brand new Ford 22 Bronco South on a busy 4 lane thoroughfare duing morning rush hour and an alert sounded with the AUTOSTART sign, instructing me to shift to part and restart my car. I drove until I got to a redlight, while smelling something burning and shifted to Park and presssed Start/stop button. MY car never started again. THis is with less than 500 miles. Several near by citizens came to my rescue as I was 3 lanes from the roadside gastation. Cars were whizzing by , honking, yelling. THese gentlemen risked there lives, stopping traffic. put my car in neutral while we all pushed it to a safe location. It was towed to dealership, where they replaced my starter. 2 days later I picked up my bronco and the very next morning, the EXACT same thing happened on the exam same road on my way to work. Car was towed again and now I've been told there's an indefinite back order on the parts .

I purchased this vehicle from Portsmouth Ford in Portsmouth NH on January 27, 2022. I brought the vehicle into AutoFair Ford (Manchester, NH) on March 16, 2022 as there was a rattling in the engine (at approximately 1519 Miles). I have not seen the vehicle since. The vehicle has been inspected by the mechanics at AutoFair Ford. They attempted a repair job but the sound was still present. Apparently the engine needs to be either redone or redesigned and Ford is not really giving any good answers as to even when this may be completed. The vehicle has been sitting in the dealer lot now for 50 Days and counting. I might get it back but very concerned as to what else could be wrong with this car as it has been sitting there for so long and could easily be another 5-6 weeks before this might get repaired. very concerned for what could go wrong during this incident.

Engine comes and goes, Wastegate gets stuck

Engine failure with 25 miles on the odometer. The dealer inspected it and reported that a piston broke and it needs a new engine. A low engine oil pressure warning came on and the check engine light.

Mileage: 25