2003 FORD E-250 Problems & Recalls

TIRE BRAND AND SIZE: PATHFINDER SPORT S A/T 245/75-16 PUT ON REAR OF 2003 FORD E250 EXTENDED LENGTH WORK VAN. BOUGHT NEW FROM DISCOUNT TIRE. AS SOON AS I GOT ON THE INTERSTATE I NOTICED THE VEHICLE FELT UNSTABLE. WAS WANDERING IN REAR. WHEN MAKING A LANE CHANGE IS WAS REALLY BAD AND FELT UNSAFE AS...

TL* THE CONTACT OWNS A 2003 FORD E-250. THE CONTACT STATED THAT THE ENGINE TEMPERATURE GAUGE FAILED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE INSTRUMENT PANEL WOULD NEED TO BE REPLACED. THE FAILURE PREVENTED THE CONTACT FROM KNOWING IF THE VEHICLE WAS OVERHEATING. THE VEHICLE...

Mileage: 60,000

TL* THE CONTACT OWNED A 2003 FORD E-250. THE CONTACT STATED THAT UPON STARTING, THE VEHICLE SURGED IN REVERSE AND CRASHED INTO A BUILDING. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT REPAIR SHOP. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE...

Mileage: 170,000

TL* THE CONTACT OWNS 2003 FORD E-250. THE CONTACT STATED WHILE DRIVING 2 MPH, PRESSURE WAS APPLIED TO THE BRAKE PEDAL AND IT DEPRESSED TO THE FLOOR. THE CONTACT ENGAGED THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. AN INDEPENDENT MECHANIC EXAMINED THE VEHICLE AND STATED THAT THERE WAS A SMALL P...

Mileage: 93,636

LOSS OF INSTRUMENTS IN 2003 F250 DIESEL WITH 50,153 MILES. FUSE REPLACED BY SERVICE CENTER AND INSTRUMENTS CAME ON. 3 DAYS LATER THEY WENT OFF WHILE IN 4 WHEEL LOW AND THE THE ENGINE STOPPED (BATTERY'S DEAD). I HAD NO CONTROL OVER STEERING AND WENT OFF THE ROAD. REPAIR OF DAMAGED WIRING IN STEERI...

Mileage: 50,103

LOSS OF INSTRUMENTS IN 2003 F250 DIESEL WITH 50,153 MILES. FUSE REPLACED BY SERVICE CENTER AND INSTRUMENTS CAME ON. 3 DAYS LATER THEY WENT OFF WHILE IN 4 WHEEL LOW AND THE THE ENGINE STOPPED (BATTERY'S DEAD). I HAD NO CONTROL OVER STEERING AND WENT OFF THE ROAD. REPAIR OF DAMAGED WIRING IN STEERI...

Mileage: 50,103

LOSS OF INSTRUMENTS IN 2003 F250 DIESEL WITH 50,153 MILES. FUSE REPLACED BY SERVICE CENTER AND INSTRUMENTS CAME ON. 3 DAYS LATER THEY WENT OFF WHILE IN 4 WHEEL LOW AND THE THE ENGINE STOPPED (BATTERY'S DEAD). I HAD NO CONTROL OVER STEERING AND WENT OFF THE ROAD. REPAIR OF DAMAGED WIRING IN STEERI...

Mileage: 50,103

LOSS OF INSTRUMENTS IN 2003 F250 DIESEL WITH 50,153 MILES. FUSE REPLACED BY SERVICE CENTER AND INSTRUMENTS CAME ON. 3 DAYS LATER THEY WENT OFF WHILE IN 4 WHEEL LOW AND THE THE ENGINE STOPPED (BATTERY'S DEAD). I HAD NO CONTROL OVER STEERING AND WENT OFF THE ROAD. REPAIR OF DAMAGED WIRING IN STEERI...

Mileage: 50,103

LOSS OF INSTRUMENTS IN 2003 F250 DIESEL WITH 50,153 MILES. FUSE REPLACED BY SERVICE CENTER AND INSTRUMENTS CAME ON. 3 DAYS LATER THEY WENT OFF WHILE IN 4 WHEEL LOW AND THE THE ENGINE STOPPED (BATTERY'S DEAD). I HAD NO CONTROL OVER STEERING AND WENT OFF THE ROAD. REPAIR OF DAMAGED WIRING IN STEERI...

Mileage: 50,103

TL*THE CONTACT OWNS A 2003 FORD E-250. THE CONTACT NOTICED THE ABS WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL AND THE GEARS WOULD NOT ENGAGE. THE CONTACT RESTARTED THE VEHICLE AND IT BEGAN TO FUNCTION NORMALLY; HOWEVER, THE ABS LIGHT CONTINUED TO ILLUMINATE. THE DEALER WAS CONTACTED AND S...

Mileage: 84,000

TL*THE CONTACT OWNS A 2003 FORD E-250. THE VEHICLE HAS TRAIL KING A/S MUD N SNOW LOAD RANGE E TIRES, SIZE LT235 85 R1. THE CONTACT NOTICED PULSATION AND VIBRATION IN THE FRONT END OF HIS VEHICLE WHILE DRIVING 75 MPH. A WEEK LATER, WHILE DRIVING APPROXIMATELY 75 MPH AGAIN, THE VIBRATION WORSENED. ...

Mileage: 114,800

TL*THE CONTACT OWNS A 2003 FORD E250. WHILE DRIVING 35 MPH IN INCLEMENT WEATHER CONDITIONS, THE CONTACT CRASHED INTO A LIGHTPOLE AND SEVERAL TREES. THE VEHICLE WAS COMPLETELY DESTROYED AND NONE OF THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE T...

Mileage: 27,000

I RECEIVED A RECALL NOTICE (#05S28) FROM FORD CONCERNING A DEFECTIVE SPEED CONTROL DEACTIVATION SWITCH (CREATING A FIRE HAZARD) ON A VEHICLE I OWN. WHEN I CONTACTED DEALERSHIP SERVICE DEPARTMENTS AS INSTRUCTED (TWO DIFFERENT DEALERSHIPS) I WAS TOLD THE NECESSARY PARTS WILL NOT BE AVAILABLE UNTIL AT ...

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH AROUND A CURVE AN ACCIDENT OCCURRED TRYING TO AVOID AN ON-COMING VEHICLE. THE CONSUMER HIT A RAILROAD POST. THIS LAUNCHED THE VEHICLE INTO A CREEK. THE AIR BAGS DID NOT DEPLOY, HOWEVER THE SEAT BELTS DID RESTRAIN THE CONTACT. DUE TO THE AIR BAG'S FAIL...

Mileage: 55,000

DT: CALLER BOUGHT A USED VEHICLE FROM AN ARMORED CAR COMPANY. THE AIR CONDITIONER HAD A BAD COMPRESSOR. FORD OFFERED NO HELP BECAUSE THEY DID NOT WORK ON VAN CONVERSIONS. THE COMPANY CONSUMER BOUGHT THE VAN SENT HIM TO AN AIR CONDITIONING COMPANY. THEY SAID THE ENTIRE AIR CONDITIONER COMPRESSOR HAD...

Mileage: 3,000

THE VAN WAS PARKED AN DIT CAUGHT ON FIRE. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE. NO INJURIES REPORTED. THE VAN WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. *AK

A FORD 2003 VAN, WITH 30,000 MILES EXPERIENCES A STEERING FAILURE, WHEN THE PITMAN ARM BROKE OFF THE BOTTOM OF THE STEERING BOX. IT CLEANLY SHEARED OFF A SHAFT OF METAL WHICH IS 1 1/4 INCHES OF SOLID STEEL.*AK SINCE THE DRIVER WAS OPERATING AT LOW SPEED ON THE RAMP OF MIAMI INTERNATIONAL AIRPORT, ...

Mileage: 30,427

WHILE THE VEHICLE WAS PARKED IN THE DRIVEWAY IT CAUGHTON FIRE. ELECTRICAL/ABS SYSTEM'S WAS THE DEFECTIVE. MANUFACTURER URGED CONSUMER TO FILE A COMPLAINT. RECALL 04V444000. *AK

Mileage: 20,000

WHEN DRIVING 55 MPH OR MORE STEERING VIBRATED VIOLENTLY. *AK

Mileage: 600

WHILE DRIVING FRONT END SUSPENSION CAUSED STEERING WHEEL TO VIBRATE WHEN DRIVING AND HITTING ROUGH OR UNEVEN SURFACES. CONSUMER TOOK VEHICLE TO DEALERSHIP SEVERAL TIMES, BUT MECHANIC WAS UNABLE TO RESOLVE THE VIBRATION PROBLEM.*AK

Mileage: 30

THE FORD VAN E-250 2003 WERE PRODUCED AND SOLD WITH THE WRONG LUG WRENCH. CAN NOT CHANGE MY TIRES BECAUSE THE LUG WRENCH WILL NOT FULLY COVER THE LUG NUT BECAUSE THE WRENCH IS TO THICK AND HITS THE INER RIM. THIS IN TURN CAUSES THE WRENCH TO SLIP OFF OR STRIP THE NUT.*AK

THE FORD VAN E-250 2003 WERE PRODUCED AND SOLD WITH THE WRONG LUG WRENCH. CAN NOT CHANGE MY TIRES BECAUSE THE LUG WRENCH WILL NOT FULLY COVER THE LUG NUT BECAUSE THE WRENCH IS TO THICK AND HITS THE INER RIM. THIS IN TURN CAUSES THE WRENCH TO SLIP OFF OR STRIP THE NUT.*AK