1996 FORD ECONOLINE Engine And Engine Cooling Problems

TL*THE CONTACT OWNED A 1996 FORD ECONOLINE. THE CONTACT STATED THAT THE VEHICLE CAUGHT FIRE ON JANUARY 14, 2008 WHILE PARKED IN THE DRIVEWAY. SMOKE APPEARED FROM THE ENGINE AND FRONT PASSENGER SEAT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED FORD RECALL NOTICE NUMBER 05S28 THE FIRST WEEK IN MAY OF 2008. THE CURRENT AND FAILURE MILEAGES WERE 122,000.

Mileage: 122,000

1996 FORD ECONOLINE ELECTRICAL SYSTEM REPEATEDLY CAUSED THE VAN TO BREAK DOWN. *KB THE AIR CONDITIONING COMPRESSOR SEIZED AND THE SERPENTINE BELT NEEDED TO BE REPLACED. THE IGNITION MODULE WAS REPLACED. THE TIE RODS NEEDED TO BE REPLACED WHICH FAILED WHILE THE CONSUMER WAS DRIVING. THE CRUISE CONTROL STOPPED WORKING AND THE ABS, AIR BAG AND ENGINE LIGHTS ILLUMINATED. *JB

Mileage: 20,000

ON SUNDAY MORNING AT ABOUT 6 AM THE ALARM OF OUR VAN WENT OFF. IT WOKE US UP. THE ENGINE OF THE VAN WAS ON FIRE. WE CALLED THE 911 AND THE FIRE DEPARTMENT CAME. MY HUSBAND TRIED TO USE THE FIRE EXTINGUISHER BUT HE COULD NOT OPEN THE HOOD. THE FIRE DEPARTMENT PUT OUT THE FIRE.THE LAST TIME I DROVE THE VAN WAS ABOUT 8:30 PM ON SATURDAY NIGHT. IT WAS FINE THEN WHILE IT WAS BURNING IT SOUNDED LIKE IT WAS TRYING TO START. ONE FIREMAN SAID THAT SOUND WAS FROM THE WIRES BURNING OR SOMETHING LIKE THAT. IT IS A 1996 FORD [XXX] FORD E 350 LIMITED REGENCY THE MILEAGE WAS ABOUT79362. A STICKER ON THE WINDSHIELD SAYS BUILT WITH PRIDE ECONOLINE BY LORAIND OHIO ASSEMBLY UAW 425 2000. WE ARE VERY THANKFUL FOR THE CAR ALARM. WE WERE NOT DUE TO WAKE UP UNTIL AN HOUR LATER. WE THINK IT IS TOTALED BECAUSE THE WHOLE FRONT SIDE IS BURNED AND THE WINDSHIELD BROKE. ALL THE SEATS ARE STILL IN GOOD SHAPE. THE POLICE CAME TO THE SCENE BUT WHEN WE WENT TO GET THE REPORT WE FOUND THAT THE POLICE MAN DID NOT MAKE A REPORT. HE DIDN'T EVEN SPEAK TO US. LATER WE LEARNED THAT SHIFT CHANGE HAPPENS THAT TIME OF MORNING. (A POLICE MAN WHO GOES TO OUR CHURCH TOLD US ABOUT THE SHIFT CHANGE) HE DIDN'T KNOW WHY A REPORT WAS NOT TAKEN. *NM UPDATED 07/18/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mileage: 79,362

A REOCCURRING FAILURE OF A TIMING GEAR AT 64,000 MILES. FIRST, OCCURRED AT 55,000 MILES. REPAIRED AT AN INDEPENDENT REPAIR SHOP WITH DEALER'S PART. BELIEVED NHTSA SHOULD LOOK INTO AT THIS AS A DEFECTIVE PARTS. *AK

VEHICLE STALLS DUE TO A DEFECTIVE ENGINEERING PART. DEALER HAS TOLD CONSUMER THE PART AT FAULT IS CALLED A 3-WAY TEE. IT REGULATES FUEL FUMES FROM THE GAS TANK. IT CAUSES THE MIXTURE TO BECOME TOO RICH WHICH SLOWS THE ENGINE DOWN. DEALER HAS REPAIRED THE VEHICLE.*AK VEHICLE STOPS RUNNING SUDDENLY WITHOUT WARNING AND CUSTOMER BELIEVES IT IS EXTREMELY DANGEROUS PROBLE. *YH

REPORTED TO FORD CUSTOMER SERVICE THAT THE OIL PAN IN THE VANS AND TRUCKS ARE STARTING TO RUST OUT FROM THE INSIDE. FORD WILL DO NOTHING ABOUT THE PROBLEM. THEY ADMITTED ON THE PHONE (GREG TREDWELL) IN VESTAL, NY THAT IN 96 AND 97 THEY WERE MADE OUT OF RECYCLED MATERIAL AND THAT IS WHY THEY ARE RUSTING OUT AND NEED TO BE REPLACED. WHY HASN'T THERE BEEN A RECALL ON THIS PROBLEM? *AK

DEALER CAN'T (WON'T) REPRODUCE OR FIX PROBLEM. TAKES ALL DAY, BUT DOES NOTHING. VERY FRUSTRATING. NO SAFETY DEFECT MENTIONED IN SUMMARY. *AK

WHILE PARKED ENGINE COMPARTMENT CAUGHT FIRE. VEHICLE WAS TOTALED. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. COMSUMER WANTS TO BE COMPENSATED FOR LOSSES. *AK *ML

ENGINE STALLS WHEN STOPPING DURING THE SUMMER HEAT, ESPECIALLY IN STOP AND GO TRAFFIC.

ENGINE STALLS WHILE IN STOPPED POSITION.

INTERMITTENT STALLING. *AK

EXHAUST FUMES ENTER INSIDE VEHICLE.