2018 FORD EDGE Power Train Problems

Brought vehicle in with check engine light on and vehicle codes P0741 and P1744 appeared. Torque converter needs to be replaced along with transmission.

The problem began in early August 2025 when the check engine light came on and the vehicle misfired. A Ford mobile technician inspected it before 8/23/25, confirmed Diagnostic Code P0303 (Cylinder 3 Misfire), but said it was likely just a bad ignition coil. Based on that, I went to Midas on 8/23/25 for a tune-up and coil check. On 9/29/25, the check engine light returned and for the first time the coolant over-temperature warning illuminated. Midas confirmed coolant intrusion into Cylinder 3: borescope and pressure test showed leakage, leak-down test failed with air entering the coolant reservoir, and visible coolant loss was present. At 80,445 miles, the engine was deemed unsafe and required full replacement. Hawk Ford confirmed no warranty extensions or programs applied. The repair cost was $10,500 out of pocket. This defect matches Ford TSB [XXX] , is widely reported in EcoBoost engines, and creates a serious safety risk since the vehicle misfires, overheats, and may stall while driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Original transmission failed at 83,000km. August 2023. Replacement FORD crated transmission and new cooler installed at FORD dealership for a cost of approx $11,000 Canadian dollars failed 25 months later. Oct 2025. FORD would not honour 36 month advertised replacement parts warranty. Car was not abused and driven by retiree.

My 2018 Ford Edge (VIN [XXX] ) suffered a premature transmission failure at 105,415 miles. Just 389 miles earlier, Ford performed Customer Satisfaction Program 22N12 (flexplate/torque converter/pump replacement), for which I paid $1,669 as my 50% share. Less than two months later, the same dealer diagnosed the transmission as failed due to the forward clutch being stuck and quoted $6,955 for replacement. Ford’s maintenance schedule does not require transmission service until 150,000 miles, so this failure is premature and unreasonable. A transmission failure at highway speed could cause sudden loss of power, greatly increasing the risk of a crash. This issue appears related to Ford’s known flexplate defect (CSP 22N12) and raises concern of broader transmission reliability/safety problems in affected vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I’m having an issue where there’s a sudden loss of all power while driving at highway speeds, forcing me to slowly move to a safe spot while trying not to get hit by other cars. Once I’m safely stopped, I have to turn the vehicle off and back on, and then the power is restored—but the problem can randomly happen anytime at speeds over 65–70 mph. No codes are showing. A repair shop couldn’t find the issue, and even the dealership says everything is fine and just tells me to keep driving it. Sometimes it happens twice in one day, and other times I won’t see it for a week.

The car has been having a chemical smell when it starts. I recently was driving from San Antonio, Texas to Austin, Texas and received a warning that my car was overheating. The warning went off immediately and I continued driving it. A few days later, I got an oil change and was told that I had no coolant in the vehicle. They filled the coolant for me. I continued driving the car. This week, the car was shaking pretty violently when I turned on the ignition. I proceeded to drive it and it drove normally. The following day, a check engine light came on. I took it in to see a mechanic that day and they confirmed that I had a coolant intrusion problem caused by the 2.0L Eco boost engine which is defective and allows coolant to escape into the engine injectors. Ford is not taking any responsibility for this and says that it is not under warranty so there's no programs they can offer me. Ford should issue a recall of this defective product to avoid injuries or accidents.

The contact owns a 2018 Ford Edge. The contact stated that at start-up, there was an abnormal rattling sound coming from the engine. There was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the flex plate, flywheel, and transmission pump were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 140,000.

Mileage: 140,000

This car hesitates, engine light indicates misfire. Dealer confirms coolant leaking into the engine. I find out now this is a well known and widespread problem with Ford engines in this era. The car is unsafe to drive due to impending sudden and complete engine failure.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the ABS, the Advance Trac, the Hill Start Assist, and the Powertrain warning lights were illuminated. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000.

Mileage: 78,000

Computer error P0304 - misfiring in cylinder 4. Diagnosed with a coolant leak into the cylinder. Potential Safety Issues: Loss of Power: A misfire can cause sudden power loss, particularly during acceleration or at high speeds, increasing the risk of accidents, especially in traffic or on highways. Engine Stalling: If the misfire worsens, the engine may stall, leaving you unable to control the vehicle, which is dangerous in busy areas or intersections. Overheating Risk: Coolant intrusion into cylinder 4 (as noted in TSB 22-2229) can lead to overheating if the cooling system is compromised, potentially causing engine failure or fire hazards. Catalytic Converter Damage: Persistent misfires can overheat and damage the catalytic converter, potentially leading to a fire risk under the vehicle. Beyond this, it is my 17 year old daughter driving this car and she could be stranded some place unsafe due to not starting or in the middle of traffic while driving. It has been inspected by a mechanic to confirm the leak. Ford's issuing of a TSB on this issue (TSB 22-2229) - calls for a new engine. Ford knows they have made faulty engines in these cars and refuses to help cover the cost of replacement.

The contact owned a 2018 Ford Edge. The contact stated that the vehicle was turned on and parked on a level ground surface while the contact was outside of the vehicle. The contact stated that the vehicle reversed independently, drove over the curb, hit the apartment complex fence, went down the alley, and hit a neighbor's fence. The contact stated that the vehicle was driven away from the scene and was parked. Additionally, the contact stated that while driving 20 MPH and depressing the brake pedal, the brake pedal was stiff, and the vehicle failed to respond and crashed into the rear of another vehicle. There was no warning light illuminated. The air bags did not deploy. The vehicle was parked near the scene, in a business parking lot. The contact sustained pain from the seat belt strap and received medical assistance. The other driver sustained unknown injuries. A police report was not filed. The vehicle was towed to the collision center, which provided an estimate of the damage. The vehicle was totaled by the insurance company. The dealer was notified of the failure. The manufacturer was notified of the failure and referred the contact to the insurance company for the brake diagnostic testing. The failure mileage was 8,200.

Mileage: 8,200

The contact owns a 2018 Ford Edge. The contact stated that the power train, wrench, and check engine warning lights were illuminated. The contact stated that the transmission was slipping once the transmission was in 5th gear. The contact stated that while the warning lights were illuminated, the vehicle hesitated before accelerating, and the vehicle was struggling to drive forward. The vehicle was taken to the dealer and was diagnosed and determined that the torque converter had failed and needed to be replaced. The vehicle was not repaired. The clutch was repaired, but not the torque converter. The contact became aware of NHTSA Campaign 18V390000 ( Power Train); however, the VIN was not included. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 118,890.

Mileage: 118,890

I am filing a formal complaint regarding a potential failed or insufficient recall repair related to NHTSA Recall 22V413 / Ford Recall 22S43 on my 2018 Ford Edge (VIN: [XXX] ). Ford replaced the shift cable bushing in Sept 2022. Within months, I experienced symptoms consistent with the original defect, including gear engagement issues, especially on inclines. One day, after shifting into reverse in a parking lot, the car rolled forward. I had to slam the brakes to avoid hitting another vehicle and feather the gas to reverse. These issues continued. Despite multiple service visits and reporting concerns, the dealership failed to document the problem. In Sept and Nov 2024, I again contacted the dealer. On Dec 18, 2024, they finally provided a loaner and inspected the vehicle. A full teardown revealed internal damage: metal debris in the solenoid body, worn sun gears, and failed clutch components—consistent with long-term gear misalignment. Ford has offered partial financial help but refuses to cover the full cost, leaving me with over $1,300 out-of-pocket despite raising concerns during the warranty window. As of June 16, 2025, the vehicle is still disassembled and remains in the dealership’s service bay with no firm repair date. I have been without my personal vehicle for six months. I respectfully request NHTSA to: Investigate whether recall 22V413 repairs are failing prematurely or inadequately prevent long-term damage. Assess whether further manufacturer responsibility is warranted for failures linked to this recall. Encourage Ford to fully cover repair costs under an extended remedy. Consider requiring a recall performance audit or extended warranty for affected vehicles. Thank you for reviewing this safety matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My engine light came on about a year ago, then went off rather quickly. This happened again about 6 months ago. At this time I connected a reader and learned that it was due to a cylinder 2 misfire. All coil packs and spark plugs were replaced thinking that would solve the problem. After it did not, I begin to search online and learned about the infamous coolant intrusion issue with my model vehicle . After reading multiple message boards regarding the issue, which appears to be directly tied to the motor design and which is very common, I confirmed that my vehicle is showing the same signs of others who have reported the issue. The last straw was when the car lost power and shut off of me in the middle of a crowded gas station parking lot where I had to sit and wait for a tow truck all while impeding traffic. At this point I am outside of my extended warranty and the only solution is a new motor at the cost of $8k. It is baffling that Ford is not being held responsible for this issue when it is so common and directly tied to the design of their motor. I am currently not able to drive a car that I am still paying a monthly payment for due to the manufacturer’s design flaw. A recall for this is well overdue and I ask you to do something about this expeditiously. Thanks.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the vehicle unexpectedly jerked with the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that there were metal shavings inside the torque converter, which caused the transmission to fail. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 79,000.

Mileage: 79,000

Coolant intrusion into cylinder 1 due to failure noted in TSB 19-2346

Fly wheel and flex plate broke causing the car to lose power. The car then stopped having use of the transmission so was unable to move the car.

Vehicle began to rough idle, and then while driving the vehicle MIL came on, as well as a "Engine overheat throttle limited" error. Pulled over and vehicle would not move. Tried to power cycle the vehicle and would not start back up. Had it towed to dealer and was told this was the long block coolant intrusion problem that leader to my engine completely failing. I was made aware of Ford TSB 19-2346, and told the repairs would be $9200. After googling around, this is a common problem on these 2018 ford ecoboost engines and Ford obviously knows there is a problem that could cause accidents or engine fires. Luckily my kids were not in the car, otherwise this could have been catastrophic due to the loss of power while driving. I called Ford support and they told me that Ford has no programs to help affected customers. There should be a Recall and Ford should be forced to replace or repair affected engines as this will get someone killed if they lose power or have an engine fire while driving.

Slips out of gear when starting up again from stop then back in gear suddenly causing jerky start

I took my vehicle in for a check engine light to the dealership. It has been diagnosed with coolant intrusion. There is a current recall but I’ve been told my vehicle isn’t in it even though this is what is wrong with my vehicle

I am told my torque converter clutch is slipping, and I am recommended to replace my torque converter and pump despite the vehicle having only 64,000 miles driven. Transmission parts are failing despite having a relatively young car. The vehicle was inspected at a Ford dealership and a diagnostic was performed to find this defect. I have investigated if there is an open recall for my VIN and none appear, although the torque converter on 2018 Ford Edge Titanium vehicles have recalls on them. Prior to the failure, a wrench icon as well as the check engine light were turning on and off between uses of the vehicle. These icons both turned off prior to bringing my vehicle to the dealership, indicating to me that there was no longer an issue present, though the dealership stated through their diagnostic that there indeed was still an issue with the transmission.

Coolant leak into cylinder causing engine to misfire, caused by warped cylinder head. Chapman Ford and CarShop have inspected and confirmed this issue and have indicated it is a common, recurring issue with Ford engines. Ford issued a service bulletin about this specific problem in 2019. In August 2019, the engine light went on, “misfire in cylinder #2”.

I have approximately 53000 miles on my vehicle. The Engine light turned on end of Aug. So I took it to a service center. They said the message code was P306 & P0316. They inspected and said the cylinder is misfiring, coolant has gotten into the cylinder, and the gasket is mush. The engine is rough running and told me to take it to Ford, I will need a new engine. In searching this problem I found a TSB 22-2229 & an NHSTA 19-2208, 19-2172. Ford can't get me in until end of September to verify. I've found several references to this problem causing an engine fire, I also found a class action suit recently filed in California for this problem. Ford has not issued a recall for this problem and I don't understand. They redesigned the engine in 2021 as they knew it was a faulty design. I didn't know that. I don't have another vehicle to drive, meanwhile I'm making car payments on it. Ford won't provide a car for me to use. I don't want to drive my car with [XXX] knowing this problem could cause harm to me, them and others. Please advise. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving the vehicle transmission shifts are radically intermittently on up shift when traveling highway speeds no problem when decreasing speed at highway speed and increasing speed sometimes the vehicle lurches or jumps then when coming to a stop when you're downshifting it seems to be third gear through first gear the transmission violently jerks as it's downshifting to the point where you can almost lose control. It seems a lot like a safety recall on the 2017 edge dealing with the torque converter

Yes, available for inspection. 2.0L Eco Boost engine leaking coolant into cylinder 1 due to a design defect 2015-2018 which has since been corrected. The only fix is a complete engine replacement. There is a recall for the Ford Fusion and Focus FOR THE SAME ISSUE; however, the Ford Edge 2.0L Eco Boost has not yet been added. There is a service bulletin addressing this issue requiring an engine block replacement: TECHNICAL SERVICE BULLETIN 2.0L EcoBoost - Coolant in Cylinders, White Exhaust Smoke And/or Illuminated MIL. An extensive internet search revealed widespread accounts of this issue, mostly after the manufacturer warranty had expired, leaving the customer responsible for engine replacement. Because this was deemed to be caused by a design defect (grooves were etched into the block to allow coolant between the cylinders which weakened the block, causing cracks, which allowed the coolant intrusion), I believe the existing recall should be expanded to include the 2015-2018 2.0L EcoBoost engine as well.

Check engine light and wrench light are both on. Checked by mechanic. Issue with power train:automatic torque converter. There is a recall on 2018 ford edge for this issue, but my VIN isn’t listed. Car has less than 60,000 miles on it.

Faulty engine design (thin wall between coolant chamber and cylinders) allows for coolant to enter the cylinders. This leads to an overheating engine (that can catch fire) and ultimately creates a blown head gasket. This is a common issue in the Ford EcoBoost engines. There is a TSB on the 1.5 liter engines, but not the 2.0 on this model. There is currently a large lawsuit happening for this reason. Vehicles with under 60k miles are getting blown engines for this problem, most people still owe several thousand dollars on their vehicle when this happens.

Transmission went to nurteal because it went out at 139k tow to repair shop who stated this the same transmission as escape called ford cs was told there a customer extended warranty placed on my transmission but covered it to 120k I was never notified of this ford said tuff but if it’s the same transmission as escaped they should warranty it

I have a 2018 Ford edge SEL with the 2.0 ecoboost engine in it that I just bought June 3rd, 2023. The engine light came on a couple weeks ago, so I took it to the dealership that I bought it from and found out the engine is bad because of coolant leaking into one of the cylinders. Upon further research I found that this is due to a design flaw in the engine by Ford but Ford has not recalled this engine. However Ford has recalled the 1.0 engines along with a couple others. I feel Ford should also recall the 2.0 ecoboost engine because this has been an ongoing issue for many people and the customers shouldn't have to pay for a new engine when it is a defective design that Ford even knows about but hasn't done anything

Two days after I bought this car I took it back to the dealership and told them that there was something wrong with the car. It didn't drive right and when I would put the car in reverse I felt a "flutter" feeling. After they finally got me in to have it looked at, they told me that there was nothing wrong with it. A few months later I took it back to another local Ford dealership after I got a notice in the mail about the transmission. It was not a recall. They also told me there was nothing wrong with it. At this point it would shift hard every now and again. about a month and a half ago, I was driving and a wrench light showed up on my dash. I had a mechanic hook it up to the computer and it was giving me codes P0741-00. I took it to Ford and had them run a diagnostic on it and they called me and told me that I needed a transmission overhaul. If they had fixed it the first two times I had it in to be looked at I wouldn't be without a car right now. I have been in contact with Ford Motor Co also and they are now saying that I still have to pay out over $3200 that I don't have. They were supposed to reach back with me on Fri and still have not heard from them.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the vehicle briefly jerked, after which the contact heard an abnormal sound emanating from underneath the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the torque converter. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 93,000.

Mileage: 93,000

The Ford Edge 2018 has a common issue with its transmission - it fails to start at low mileage, causing the car to lose power unexpectedly. This could lead to dangerous situations and potentially render the car completely uncontrollable. Ford dealers acknowledge that it's a common problem for this model, but they do nothing about it.

I had my 2018 Ford Edge in Gerald Jones Ford Lincoln dealership services department at Augusta, GA on [XXX] (soonest appointment schedule available) due to check engine light turning on that I detected on [XXX] According to their diagnosis, my vehicle is now in need of total engine rebuild/replace. On [XXX], 12 days prior to the check engine light turning on, my vehicle was at the dealership for its regular maintenance (oil change, tire pressure, top off fluid, etc.) that also included a multi-point inspection. There were no engine issues detected on the vehicle 12 days prior. All of a sudden, 12 days later, the vehicle's engine light turned on and now in need of serious repair. This vehicle has less than 40k mileage. I did some research and based on submitted complaints online from other vehicle owners, I became aware that there are known issues to the engine design causing misfires and coolant leaking into the combustion chamber/engine that is specific to my vehicle's make and model. Ford has not issued a recall but many have reported similar if not exact problems I am experiencing. I reached out to the dealership's General Manager on [XXX] regarding my concerns. I also called his number on [XXX] and left a voicemail message. It has been 3 business days and I have not received any email response or callback from the General Manager. At the moment, I have the vehicle in my possession while I am trying to deal with the current situation. fINFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Edge. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train). The contact stated that while driving at an undisclosed speed, the engine started to overheat. The contact was able to move the vehicle to the shoulder before taking the vehicle to the dealer. The dealer determined there was a crack in cylinder #3, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 88,000.

Mileage: 88,000

Summary: Some 2015-2018 Edge equipped with a 2.0L EcoBoost due to coolant intrusion into engine which could cause the potential for engine fires and failure, misfires, collision risk, and costly repairs. Vehicle did not exhibit a low coolant level, white exhaust smoke did not run rough. Automaker knew about the Ford EcoBoost engine defect since 2010 based on pre-production testing and complaints made by consumers to the NHSTA but didn’t address the cause of the problem. Now I have to pay $10,000 parts and labor!!! Called Ford Customer Service. No assistance unless a recall is sent.

The contact owns a 2018 Ford Edge. The contact stated while driving 45–50 MPH, the check engine warning light illuminated. While starting the vehicle, the check engine warning light illuminated, and the wrench symbol was displayed. While driving at an undisclosed speed, the vehicle was shaking and slow to accelerate. The vehicle was taken to the local dealer, where it was diagnosed that a torque replacement was needed. The vehicle was not repaired. The manufacturer was contacted and referred to the NHTSA Hotline, but no assistance was provided. The contact stated that the failure was related to NHTSA Campaign Number: 18V390000 (Power Train). The failure mileage was approximately 126,000.

Mileage: 126,000

2.0 Ecoboost complete failure Engine thermostat failure

coolant leak into engine cylinders 2018 Ford edge ecoboost engine ford dealer said vin # not under recall but know design flaw across the board with engine

My check engine light was on and my car would shake and vibrate upon staring the engine. I was running low on coolant when I shouldn’t be despite no signs of leaking on the ground. I took it to an authorized shop by Carfax, it’s Autotech in O Fallon, MO. They ran diagnostic tests and the codes were P0302 and P0316, which apparently are common issues with Ford Edges between 2015-2018. The shop owner said it’s normal for these cars even with low miles to end up needing a new engine bc of how Ford built them to where there are cylinder misfires causing coolant to leak into the engine causing engine failure. I asked why there were no recalls on this known issues and he assumed it must be bc no one died yet. I have since been reading thread after thread online of customers having this same issue and needing a new engine some even after only 25,000 and 50,000 miles. I bought my car used less than a year and a half ago with 59,000 miles on it and was not offered a warranty, which I know no why, they probably knew of the issue and the dealership didn’t want to be on the hook to cover a new engine. So now I’m stuck with an unsafe car to drive or shell out $9000 on a new engine that will fail like others who had theirs replaced only to have the same thing happen. I love my car and don’t want to give it up. How can Ford take ownership of their poor design flaw that is causing this to happen and put us at risk of being stranded or worse when our engine blows? Ford tough…how so? These cars are worthless after only 25,000 for some. For me I only got 15000 miles out of my car that I still owe $17,000 on and now I’m told I have to pay almost $10,000 to replace the engine for their design flaw that they have known for years is a major issue? There are lawsuits for this issue. There is class action in California for this issue. How can they get away with this? I’m stranded right now and I can’t afford to fix it and nor should I have to. Ford should be held accountable, not me.

Purchased a 2018 ford edge new I’m early 2019. The car has 65k miles and needs a new engine due to coolant leak into cylinder 3. This should be a recall item and Ford refuses to stand by its product. An engine with miles this low should not need replacement.

Ford Edge using coolant, temperature light turning on. Scanner indicates misfiring on cylinder #3. TSB report shows ongoing issue with a cracked cylinder, #3, causing the misfiring and coolant use. Vehicle has only 77K miles on it and maintained by dealership. This is a on going issue that apparently can only be resolved by replacing the engine.

Bought used Feb. 2023. End of March cylinder 3 misfire code pops when the check engine light comes on. Replaced all spark plugs and 1 engine coil for cylinder 3. On off until Aug. 9th when the light came back on and I took to Ford Dealership. Paid for a diagnosis and the next day they called and said the coolant is leaking into the engine and this is a “known issue” and I will need a new engine. I have barely put 3,000 miles on top of the miles it came with. Should not have to pay for a new engine with a “known issue”!

Car just hit 100000 miles. Engine light came on . Took to Barnes Crossing Ford in New Albany. After inspection was in formed coolant was leaking into engine and block needed to be replaced.The car did not overheat but the coolant leaking into engine could have ignited a fire due to other chemicals present such as oil, and other fluids needed to operate motor. TSB was already issued regarding this defect as well as multiple complaints and a recall on escapes and fusions that ended in 2022. Because of lack of investigation and safe recall this problem continues to pose a danger to myself and others. Motor has to be replaced at the nominal fee of 6500.00 . The problem continues to exist.

We were sent a recall notice from Ford (Program 22N12-Flexplate) in September 2022. Our vehicle was in the service department for an engine replacement in August of 2022. I asked my local dealer to make repair before I left for a trip from Lewisville, TX to Athens, Ga for our granddaughter's graduation. They would not because the FLEXPLATE must be broken. On our return trip home, we pulled into our hotel in Laurel, Ms. There was loud noise from the engine compartment. Went to the local dealer and he said come back in the morning and they would check it out. They found the flexplate broken and the dealer said the vehicle was unsafe to drive. Thank God it broke in town rather than on the lonely interstate at night. We believe this program should be completed immediately before you are left alone on the side of the interstate. In addition, we incurred extra expenses that Ford is not reimbursing us.

The contact owns a 2018 Ford Edge. The contact stated while driving 65 MPH, the vehicle lost motive power. The contact was able to coast the vehicle to the side of the road. The vehicle failed to restart and was towed to an independent mechanic. The independent mechanic diagnosed that the wiring harness had become loosened and was chewed up by the idler pulley, causing a shortage in the PCM and the fuel sensors. The vehicle was repaired. Additionally, the contact stated that while driving two weeks later, the vehicle made abnormal rattling sounds. The vehicle was taken to several Pep Boys, and an independent mechanic, where it was diagnosed that the rattling was coming from the engine; however, the failure could not be duplicated. The contact received notice of Ford Campaign Number: 22N12, which she related to the failure. The dealer was contacted and informed the contact to schedule an appointment for a diagnostic test; however, the parts were not available for the repair. The vehicle was not diagnosed nor repaired. The contact stated that while starting the vehicle, the check engine warning light illuminated. The vehicle was taken back to Pep Boys, who diagnosed that cylinder #2 was misfiring. Additionally, the contact was informed that there was no coolant in the vehicle. The contact stated that she replaced the cylinder and spark plugs herself; however, the vehicle was still experiencing abnormal coolant consumption. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 73,000. The contact stated the vehicle was repaired at the owners expense of $650.

Mileage: 74,000

The contacts husband owns a 2018 Ford Edge. The contact stated that while driving various mph on multiple occasions the vehicle accelerates without the accelerator pedal being depressed. Additionally, when the vehicle was shut off the engine still sounds like its on. The check engine and powertrain malfunction safety warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified and a case number was provided. The failure mileage was 67,500.

Mileage: 67,500

The vehicle is a 2018 Ford Edge and has less than 100k miles on it. Car was leaking coolant and we took it to the dealership where they told us it was leaking coolant into cylinder 4 and was possibly a cracked head. They had an adjuster, from the warranty company, inspected the vehicle and the adjuster stated we needed a new motor on 2/20/23 then 3 days later, 2/23/23, the warranty company contacted the dealership and told them they revoked the engine swap. They stated it must be damaged by an internally lubricated part. The dealership also put in an appeal to the denial. We've been having a constant battle with the warranty since February 4th. My car was in shop for 36 consecutive days and has yet to be fixed. The vehicle can overheat due to the constant leak of coolant and catch on fire or potentially blow up the entire motor while operating. We have been in emotional distress, extreme financial distress and its attempted child endangerment. I take my vehicle to and from work and to pick up my 2 year old son from daycare. If the engine was to blow, we could crash or get stuck and it could be fatal to both my child and I and my husband if he is driving.

The contact owns a 2018 Ford Edge. The contact stated that the vehicle was serviced under an unknown recall for a flex plate; however, the failure was experienced. The contact stated that while driving at various speeds the check engine warning light illuminated. The contact stated that the vehicle would jerk while driving. The contact stated that the dealer was contacted and informed her to drive the vehicle for 3 days and if the light remained on to bring the vehicle to the dealer. The vehicle was taken back to the dealer who diagnosed the failure as coolant leaking into a valve and the engine needing to be replaced. The vehicle was not repaired as the warranty company informed her that this was a known Ford defect. The manufacturer was notified of the failure and informed the contact to call the NHTSA Hotline. The approximate failure mileage was 70,000.

Mileage: 70,000

The contact owns a 2018 Ford Edge. The contact stated that the vehicle lunged forward while being started. Additionally, the check engine warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 22V413000 (Power Train). The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 55,000.

Mileage: 55,000

The contact owns a 2018 Ford Edge. The contact stated while after a stop sign and attempting to accelerate, the vehicle failed to respond as needed. The contact stated that the vehicle jerked and then abruptly accelerated with the check engine warning light illuminated. The contact stated that the vehicle was diagnosed, and it was determined that the torque converter and clutch cylinder needed to be replaced. The vehicle was not repaired. On another occasion while attempting to accelerate, the vehicle failed to respond and started jerking. The contact pulled over on the side of the road and looked under the hood and noticed smoke coming from the transmission. The vehicle was towed to the residence. The dealer was contacted and stated that the vehicle was not included in NHTSA Campaign Number: 18V390000 (Power Train). The manufacturer was contacted and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 88,000.

Mileage: 88,000

The contact owns a 2018 Ford Edge. The contact stated while driving 40 MPH, the vehicle made an abnormal noise. The contact stated that the vehicle bucked several of times and then stopped without warning. The vehicle was towed to the dealer and the contact was informed that the transmission clutch and torque converter needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the advised the contact file a complaint with the NHTSA Hotline. The failure mileage was 70,000.

Mileage: 70,000

The contact owns a 2018 Ford Edge. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the transmission failed to shift into the intended gear, and then the vehicle lost motive power. The dealer was made aware of the failure but provided no assistance. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown. The VIN was unavailable.

My vehicle is not listed under the recall 17S16(2) this is an expansion to recall 17V-427 yet my car has been sitting for 4 months at a FORD dealership because the TORQUE CONVERTOR that is not performing IS ON BACKORDER. Why is FORD being allowed to string me the consumer along until they decide that this is a big problem? I received a Service Notice (Customer Satisfaction Program 22N12 stating that they are aware of a problem with the flexplate, transmission fluid pump and Torque convertor but no RESOLUTION. I cannot AFFORD to keep making car payments for a car I cannot drive. I am beyond frustrated and FORD will not communicate with me.

My vehicle only has 77K miles on it and is already needing an entirely new engine due to coolant intrusion into the cylinder. We discovered this after replacing all the spark plugs in the vehicle and the check engine light not disengaging. You should not have to replace an entire engine with only 77K miles. This is a known issue with FORD referencing two bulletin's - the first bulletin #19-2346 and now with bulletin #22-2133. They are refusing to cover the repairs 100% and expecting the consumer to pay 40% of the cost of their known issue of a $10K repair ticket. It also clearly states in the recent bulletin that the MIL may or may not engage with this issue. If we had know that this was an issue with this vehicle inside the 5 year/60K mile powertrain warraty which would have covered the repairs 100% we would have taken care of it then. The MIL was never engaged and provided any indication that this was going on. It was discovered after the MIL engaged at 77K miles and we took it in for service and had all spark plugs replaced costing almost $300 in repairs just to discover that did not resolve the check engine light to stop illuminating. This vehicle has been maticulously maintained since taking ownership of it in 2018. All service records are available if needed.

2018 FORD EDGE. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALL 22V-413. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR.

The contact owns a 2018 Ford Edge. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

2018 FORD EDGE. CONSUMER WRITES IN REGARD TO PARTS BEING UNAVAILABLE TO PERFORM SAFETY RECALL. THE CONSUMER REFCERENCED SAFETY RECALL 22S43/22V413. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR.

2018 FORD EDGE. CONSUMER WRITES IN REGARD TO PARTS BEING UNAVAILABLE TO PERFORM SAFETY RECALL. THE CONSUMER REFCERENCED SAFETY RECALL 22S43/22V413. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR.

2018 FORD EDGE. CONSUMER WRITES IN REGARD TO PARTS BEING UNAVAILABLE TO PERFORM SAFETY RECALL. THE CONSUMER REFCERENCED SAFETY RECALL 22S43/22V413. THE CONSUMER STATED THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME COMPLETING THE RECALL REPAIR.

2018 FORD EDGE. CONSUMER WRITES IN REGARD TO NHTSA SAFETY RECALL 22V-413.

The contact owns a 2018 Ford Edge. The contact stated while driving at various speeds, the accelerator pedal was depressed but the vehicle hesitated and stalled on several occasions. The vehicle was taken to the local dealer where the transmission was repaired. However, the failure reoccurred. No further information was available. The vehicle was taken back to the dealer where it was diagnosed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 20,000.

Mileage: 20,000

The contact owns a 2018 Ford Edge. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train ) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Vin tool confirms parts not available

Car rolled out of drivewayacross road and hit tree in neighbors yard which kept it from hitting house. 10,000 in damages to rear of car. While car being repaired heard about recall. Body shop told us about it. Took @ 3 months to get car repaired. No one in car at time of rollaway

I've bought a 2018 Ford Edge SEL July of 2021 at Zech Ford (Kansas), it had just a little over 50k miles, within the first month of ownership, engine light comes on (code P0301), I took to the dealership and they replaced the oxygen sensor, everything seemed fine since. This last May, the flex plate cracked, I took to Greenway Ford dealership (Florida) and paid $3,085.36 for the repair, within just an hour of having the car back, engine light comes on (P0301), I immediately took the car back, they kept the car for the weekend, replaced the stream O2 sensor and charged me $105.24, they only charged me for the part, they waived the labor fee since I just had a $3k repair. Now, 2 months later, engine light comes on again for the same code P0301, but this time I can hear liquid running through the dashboard and a lot of white smoke coming out of the exhausts, I popped the hood and see that the coolant container is virtually empty, so I’ve bought some and added to it, I took it back to Greenway Ford, left the car there and couple hours later they called me to let me know that the coolant leaked into the cylinder and tells me that my only option is to have the engine replaced at a cost of $8400! This is my only car, I still owe $22,700 and I do not have $8k to get it repaired! And the car has about 94k miles now,

The contact owns a 2018 Ford Edge. The contact stated while driving 35 MPH, the contact heard a clicking noise coming from the engine compartment which resulted in the vehicle losing power. The contact stated no warning light was illuminated. The vehicle was able to be pulled over but was not restarted. The vehicle was towed to a local mechanic where it was diagnosed with needing the torque converter replaced. The vehicle was repaired but recall was not covered. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V390000 (Power Train) however, the VIN was not included. The manufacturer was informed of the failure and informed the contact that the VIN was not included. The failure mileage was approximately 80,000.

Mileage: 80,000

HAD OIL CHANGED AT DEALERSHIP IN DEC 2020AND ADVISED OF LOW COOLANT. TECH CHECKED NO LEAKS FOUND. MARCH 2021 CHECK ENGINE LIGHT CAME ON CODE P0301, MISFIRE IN CYL 1. HAD NEW SPARK PLUGS PUT IN. DROVE 500 MILES, CODE CAME BACK. SWAPPED COIL PACK FROM CYL 1 AND 2, DROVE ANOTHER 450 MILES CODE CAME BACK. HAD INJECTORS CHECKED, ALL OK. CAR STARTED HAVING A SLOW SLUGGISH START TO IT. NOTICED COOLANT WAS EMPTY. REFILLED, WITHIN A DAY EMPTY. TOOK TO SHOP AND COOLANT IN CYLINDERS

Mileage: 78,000

MY 2018 EDGE WITH ECOBOOST HAS LESS THAN 62K MILES. NOTICED A RATTLING NOISE WHEN I WAS IDLED OR NOT ACCELERATING. NOISE GOT LOUDER AND WORSE, SEEMED TO HAVE ISSUES CHANGING GEARS, BEGAN SOUNDING LIKE A DIESEL WHEN I WAS IDLE. TOOK IT IN FOR DIAGNOSTICS TODAY AND NOTICED THE CHECK ENGINE LIGHT CAME ON TODAY. RESULTS CAME BACK WITH RANDOM MISFIRE CODE. TURNS OUT THERE IS A CRACK IN THE FLYWHEEL...WHICH FROM WHAT I CAN TELL BY RESEARCH IS DUE TO MANUFACTURER ISSUES WITH THE TORQUE CONVERTER. WHY IS THERE NO RECALL FOR THIS? IT IS DANGEROUS AND THE CAR IS NOT OLD OR WORN OUT ENOUGH TO HAVE THESE KIND OF ISSUES. COST TO CORRECT IS ASTRONOMICAL. PLEASE HELP RAISE AWARENESS AND GET THE HELP CONSUMERS DESERVE.

THERE IS AN ELECTRICAL ISSUE WITH THIS VEHICLE - STARTED AT 24000+/- AND DRAINED BATTERIES - AFTER REPLACING 4 BATTERIES - CHECK ENGINE LIGHT CAME ON - DEALER DID PRESSURE CHECK AND ENGINE HAD TO BE REPLACED! AFTER REPLACEMENT, BATTERY WAS AGAIN DEAD. THEY CANNOT FIND REASON FOR DRAINED BATTERY. THIS VEHICLE IS UNSAFE AND POTENTIALLY A FIRE HAZARD. I CANNOT GET RELIEF FROM FORD MOTOR - REFUSED TO BUY BACK. VEHICLE WAS PARKED EVERY TIME BATTERY WAS DRAINED.

VEHICLE POWERTRAIN EQUIPMENT FAILURE AT 34K MILES CONSISTENT WITH NHTSA CAMPAIGN # 18V390000 AND FORD RECALL 17S16. NO ACCIDENTS OR INJURY RESULTING FROM THE FAILURE. REQUIRED REPLACEMENT OF ENGINE AND TRANSMISSION COMPONENTS INCLUDING THE TORQUE CONVERTER. REPAIRS TOOK ALMOST SIX WEEKS TO COMPLETE DUE TO PARTS AVAILABILITY.

Mileage: 34,000

LOSS OF TRANSMISSION POWER, LIKE AS IF THE TRANSMISSION CANT DECIDE WHICH GEAR TO BE IN, THEN WHEN IT SELECTS THE GEAR IT SLAMS INTO GEAR SO HARD THAT IT FEELS LIKE YOU HAVE BEEN HIT FROM BEHIND BY A TRUCK. THIS HAS HAPPENED WHILE DRIVING IN STOP AND GO TRAFFIC, WHEN DRIVING THRU A DIP IN THE ROAD,AND MOST DISTURBINGLY WHILE DRIVING UP A LONG STEEP HILL.

Mileage: 9,000

WHEN AT HIGHWAY SPEEDS AND TRY TO SPEED UP TO CHANGE LANES STEP ON GAS PEDAL AND NOTHING HAPPENS CAR JUST SLOWS DOWN TILL I LET OFF THE GAS PEDAL

Mileage: 4,000

THE FRONT AXLE, (KNOWN AS THE HALF SHAFT) BLEW OUT ALL THE GREASE IN THE RUBBER BOOT. THE INSIDE FRONT , DRIVER'S SIDE TIRE, SUSPENSION AND BRAKES WERE COVERED WITH GREASE. CAME FROM THE DEALERSHIP LIKE THIS, AUTO HAD 42 MILES AT TIME THIS WAS NOTICED.

Mileage: 42