2006 FORD ESCAPE HEV Service Brakes, Hydraulic Problems

WIFE AND I WERE ENROUTE HOME FROM VERO BEACH, FL TRAVELING WEST ON FL HIWAY 60 ABOUT 10 MILES EAST OF THE FL TURNPIKE AROUND 8:30 AM. TRAVELED OVER SHORT STRETCH OF REPAVED ROAD. AT THAT TIME HEARD BEEP, NOTICED RED BRAKE LIGHT AND AMBER ABS LIGHT ON. CRUISE CONTROL ON MOVING 60 MPH. TRIED BRAKES, NOTICED EXCESSIVE BRAKE TRAVEL, BUT STILL HAD SOME BRAKES. CONTINUED ON UNTIL TURNPIKE JUNCTION. PULLED OFF ROAD, STOPPED, SHUT OFF IGNITION. UPON RESTARTING (AFTER 5 SECONDS), WARNING LIGHTS STAYED OFF, HAD GOOD BRAKES. PROCEEDED 130 MILES TO HOME W/O INCIDENT. THIS HAS OCCURRED 3 TIMES BEFORE AND HAVE HAD IT TO THE DEALER'S SERVICE DEPT. ON JULY 5TH. I AM DETAILING THIS INCIDENT BECAUSE I HAVE THE MOST INFORMATION ABOUT IT. WHEN IT OCCURRED ALL 4 TIMES, IT WAS EITHER AFTER CROSSING RAILROAD TRACKS, HITTING A POT HOLE OR IN THIS CASE AFTER A CHANGE IN ROAD SURFACE. AND IT DOESN'T HAPPEN ALL THE TIME WHEN CROSSING ROUGH SURFACES. THE DEALER (NICK NICHOLAS FORD IN INVERNESS, FL) CANNOT SEEM TO FIND AND FIX THIS. I HAVE TO GROUND THIS VEHICLE BECAUSE I CANNOT TRUST IT WITH MY WIFE DRIVING BY HERSELF. IT COULD COST UP TO 7K FOR FORD TO SWAP OUT COMPONETS TO TRY TO FIX IT - MY COST. THIS IS A SAFETY ISSUE! NOT A WEAR AND TEAR ISSUE.

Mileage: 69,292

"ABS" WARNING LIGHT ILLUMINATED AND "SERVICE BRAKE SYSTEM" APPEARED ON DISPLAY. APPLIED BRAKE PEDAL AND ANTI-LOCK ENGAGED CAUSING A "CHATTERING" SOUND FROM BRAKES AND SEVERE VIBRATION. EXTRA PRESSURE ON BRAKE PEDAL NEEDED TO BRING VEHICLE TO A SAFE STOP. *TR

Mileage: 76,152

TL*THE CONTACT OWNS A 2006 FORD ESCAPE HEV. WHILE DRIVING 60 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE; HOWEVER, THE BRAKES FAILED. THE BRAKE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND READ "SERVICE BRAKE SYSTEM". THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. HE HAS NOT TAKEN THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE OCCURRED WITHOUT WARNING. THE CURRENT AND FAILURE MILEAGES WERE 80,592. UPDATED 06/08/09 *BF THE CONSUMER WAS INFORMED THE HYDRAULIC CONTROL UNIT WAS DEFECTIVE. UPDATED 06/09/09.*JB UPDATED 6/9/09 *CN CONSUMER STATED CAR WAS TAKEN TO DREW FORD WHERE IT WAS ORIGINALLY PURCHASED, THEY TOOK A LOOK AT IT AND STATED NOTHING WAS WRONG WITH THE CAR AND THAT CONSUMER SHOULD PICK IT UP. CONSUMER EXPLAINED HE HAD FILED 20 COMPLAINTS ONLINE WITH NHTSA. FOLLOWING DAY, DEALER TESTED THE VEHICLE AGAIN AND THE BRAKES ONCE AGAIN FAILED AT THE DEALERS PARKING LOT. UPDATED 6/8/18*JB UPDATED 06/10/09.*JB

Mileage: 80,592

TL*THE CONTACT OWNS A 2006 FORD ESCAPE HEV. WHILE DRIVING 60 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE; HOWEVER, THE BRAKES FAILED. THE BRAKE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND READ "SERVICE BRAKE SYSTEM". THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. HE HAS NOT TAKEN THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE OCCURRED WITHOUT WARNING. THE CURRENT AND FAILURE MILEAGES WERE 80,592. UPDATED 06/08/09 *BF THE CONSUMER WAS INFORMED THE HYDRAULIC CONTROL UNIT WAS DEFECTIVE. UPDATED 06/09/09.*JB UPDATED 6/9/09 *CN CONSUMER STATED CAR WAS TAKEN TO DREW FORD WHERE IT WAS ORIGINALLY PURCHASED, THEY TOOK A LOOK AT IT AND STATED NOTHING WAS WRONG WITH THE CAR AND THAT CONSUMER SHOULD PICK IT UP. CONSUMER EXPLAINED HE HAD FILED 20 COMPLAINTS ONLINE WITH NHTSA. FOLLOWING DAY, DEALER TESTED THE VEHICLE AGAIN AND THE BRAKES ONCE AGAIN FAILED AT THE DEALERS PARKING LOT. UPDATED 6/8/18*JB UPDATED 06/10/09.*JB

Mileage: 80,592

NO SPECIAL CIRCUMSTANCES. UNDER DAILY DRIVING THE TONE RING A PART THE ABS BRAKING SYSTEM RELIES ON FREQUENTLY FAILS. PREVIOUSLY THIS REQUIRED THE REPLACEMENT OF THE FRONT AXLE. CURRENTLY JUST THE TONE RING IS REPLACED. *TR

Mileage: 41,000

I STARTED THE CAR, AND THE ABS AND BRAKE WARNING LIGHTS CAME ON. HOWEVER, THE BRAKES SEEMED TO FUNCTION NORMALLY. AFTER I DROVE 1/4 MILE, I APPROACHED A TRAFFIC LIGHT, AND THE BRAKES DID NOT WORK. I WAS ABLE TO STOP BY GETTING ONTO THE SHOULDER AND PRESSING THE BRAKE TO THE FLOOR. IT TOOK ABOUT 100 YARDS TO STOP STARTING AT 35 MPH. WHEN I RESTARTED THE CAR, THE BRAKES APPEARED TO WORK, AND I DROVE SLOWLY TO MY DESTINATION. WHEN LEAVING THE DESTINATION, I HAD THE SAME PROBLEM, BUT I REALIZED THAT THE BRAKES DID NOT WORK WHILE IN THE PARKING LOT. AFTER RESTARTING THE CAR TWICE, THE BRAKES WORKED, AND I WAS ABLE TO DRIVE IT TO THE DEALER. THE BRAKE WARNING LIGHT CAME ON WHILE DRIVING, BUT THE BRAKES SEEMED TO WORK. *TR

Mileage: 47,000

WHILE DRIVING ON THE HIGHWAY, BRAKE AND ABS WARNING LIGHTS CAME ON DASH AND BRAKES FAILED. COULD ONLY GET MINOR STOPPING POWER WHEN BRAKES DEPRESSED ALL THE WAY TO THE FLOOR. MANAGED TO STOP WITHOUT CRASH. WHEN CAR WAS TURNED OFF AND RESTARTED, THE LIGHTS WERE OFF AND THE BRAKES FUNCTIONED OKAY. DEALER CLAIMED THEY COULD FIND NO EVIDENCE OF A PROBLEM BECAUSE THE RESTART OF THE CAR CLEARED THE ERROR LOG. EXACT PROBLEM REAPPEARED 2 WEEKS LATER. BRAKE AND ABS LIGHT CAME ON DASH, BRAKES WOULD NOT STOP VEHICLE EXCEPT VERY MINOR BRAKING POWER WHEN DEPRESSED ALL THE WAY TO THE FLOOR. THIS TIME, DROVE CAR TO NEARBY DEALER WITHOUT TURNING OFF AND DEMANDED THAT THEY DRIVE IT TO WITNESS PROBLEM. AGAIN, THEY INSISTED THERE WAS NO PROBLEM UNTIL THEY ACTUALLY DROVE THE VEHICLE. REPLACED MASTER BRAKE CYLINDER AND BLED BRAKES 3 TIMES BEFORE BRAKES PASSED TEST. *TR CONSUMER STATED COMPLAINT WAS REPORTED MORE THAN 8 YEARS AGO FOR A CAR THAT CONSUMER HASN'T OWNED FOR MORE THAN 7 YEARS. UPDATED 6/8/18*JB

Mileage: 55,516

TL*THE CONTACT OWNS A 2006 FORD ESCAPE HEV. WHILE DRIVING 25 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE; HOWEVER, THE BRAKES DID NOT FUNCTION AND THE BRAKE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE IS CURRENTLY BEING DIAGNOSED BY THE DEALER. THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 3,100. UPDATED 11/17/08 *CN UPDATED 11/21/08. *JB

Mileage: 3,100

NO CRASH, NO INJURIES. ABS SYSTEM MALFUNCTIONED CAUSING BRAKES TO ENGAGE ERRATICALLY AND EVENTUALLY STALL THE VEHICLE WHEN COMING TO A STOP OR SLOWING DOWN. MULTIPLE WARNING LIGHTS FROM DASH, INCLUDING, ABS WARNING, TRACTION CONTROL WARNING AND STOP SAFELY NOW WARNING. UPDATED 12/12/07 *BF THE FRONT WHEEL SPEED SENSOR WAS MISSING. UPDATED12/12/07

Mileage: 28,800

BRAKE WARNING LIGHT AND SERVICE BRAKE SYSTEM MESSAGE FREQUENTLY DISPLAYED ON INSTRUMENT PANEL (MORE THAN A DOZEN OCCURRENCES OVER 12 MONTHS). OWNERS MANUAL DESCRIBES THIS AS A DANGEROUS CONDITION. FOUR ATTEMPTS BY FORD SERVICE TO CORRECT AND ARE UNABLE TO DETERMINE CAUSE BECAUSE CODES ARE ERASED WHEN VEHICLE IS TURNED OFF(?). *TR

Mileage: 1,950

BRAKES FAILED FOR THE SECOND TIME. THE VEHICLE WAS TAKEN IN FOR THE BRAKE REPAIR AFTER THE FIRST TIME ABOUT 4 WEEKS AGO BUT WAS TOLD BY THE FORD DEALERSHIP THAT THERE WASN'T ANYTHING WRONG WITH THE BRAKES. AFTER THE SECOND TIME THEY NOW HAVE TO ORDER PARTS WHICH ARE ON BACK ORDER IN ORDER TO MAKE THE REPAIR. *NM

Mileage: 5,980

NORMAL CITY DRIVING INITIATED FAILURE OF BRAKES TO HAVE PRESSURE. IMMEDIATELY BRAKE AND ABS LIGHTS ILLUMINATED. BRAKES MAY BE APPLIED, BUT RELEASE AFTER APPLICATION. INITIALLY, WHEN BROUGHT INTO FORD DEALERSHIP 11 DAYS AGO, PROBLEM WAS DIAGNOSED TO BE ELECTRONIC, BUT AFTER REPLACEMENT OF ELECTRONIC CONTROL SYSTEM FOR BRAKES, THE PRESSURE FAILS TO RESUME. *JB