2018 FORD ESCAPE Fuel/propulsion System Problems

coolant loss with no visible external leak, a sweet smell from the exhaust, and bubbling or gurgling in the coolant reservoir after startup. There is a KNOWN issue ongoing regarding customer satisfaction program 21N12

CEL is on -- hard time getting vehicle to start up after getting gas - once is running has a "shake to it" for a few seconds then stables Would this be a potential cover? March 30, 2018 NHTSA CAMPAIGN NUMBER: 10137114 COMPONENT: FUEL SYSTEM, GASOLINE NHTSA ID Number: 10137114 Manufacturer Communication Number: SSM 47203 Components: FUEL SYSTEM, GASOLINE

Coolant leak into the engine causing engine failure. This is a known problem with the 1.5 turbo engine in this model vehicle. Automobile is now undriveable and entire engine must be replaced.

FORD DESIGN FLAW IN 1.5 ECOBOOST ENGINE IN A 2018 ESCAPE WITH 91K MILES CAUSING WATER INTRUSION INTO CYLINDER WHICH CAUSES ENGINE TO RUN DANGEROUSLY BAD. FORD KNEW OF DESIGN FLAW BUT NEGLECTED ISSUE RECALL BUT DID ISSUE CSP 21N12 FORD WILL NOT ASSIST BECAUSE OF ENDING PROGRAM IN LATE 2022.

My 2018 Ford Escape 1.5L Ecoboost experience rough starts for about a week. Then on the highway the engine temperature gage shot all the way to hot, the check engine light began flashing, and the vehicle started rumbling. We parked and had the vehicle towed. The mechanic diagnosed the problem as coolant intrusion into the cylinder. It has cracked the engine block. This issue is known to be a problem by Ford. The dealership mechanic knew what the problem just from the make, model, and year. Ford released a letter to all dealerships to attempt a computer repair in 2022, apparently to buy time as they knew there were going to be issues as these vehicles aged. The letter suggests that Ford and the Dealers are to contact anyone who purchased these vehicles. We were not contacted. We have contacted Ford and their customer service representatives say that Ford has a Customer Satisfaction Program, 21N12, in place to fix these vehicles, but it "is not attached to our VIN" and there is nothing they can do. When you ask for a supervisor, they call from a Toll Free Number after 8:00pm and tell you the same thing. "That program isn't attached to your VIN" and there is nothing they can do about it.

We started to notice a rough idle when starting the vehicle, the check engine light came on. The rough idle continued to get worse. We took it to a Certified Mechanic to have it inspected. Based upon the check engine status, they did further diagnosis through various tests. They determined that the coolant appeared to be seeping into the #1 cylinder. They checked the Ford website for any recalls and found a TSB ( Technical Service Bulletin} # 19-2346 regarding the 2.0L Eco-Boost engine. Ford's TSP says to replace the engine block, but does not indicate at who's expense. If this is defective and Ford knows, the consumer should not be responsible to pay for this major expense. What do we do? Within the ;next couple weeks we plan to take the car into a Ford Dealership to do their own diagnosis.

Frequently (not all the time) the motor would shake after filling with the gas in tank when I start the engine and it stops pumping. So It needs to be turned back on and have to use the gas pedal to keep it running during neutral mode. Something is not right. It has to do with fuel pump system issue and engine light would be on when the problem comes.

I purchased this 2018 Ford Escape in August 2022 from Richmond Ford. Within 2 days to a week I noticed fault indicators stating check engine, failed Auto stop and start malfunctioning. I immediately reported this issue. Richmond Ford put me in a loaner for approximately 2 months to only remedy the problem with a new battery. This has happened for 3 years. I’ve had 4 batteries replaced even recently after having Extreme high heat engine failure fault while in traffic with my grand children in the car and had to be towed. My engine has faulted several times and always shuts down in the middle of traffic. This issue could have killed me and my grand children and other vehicles. Richmond Ford kept replacing the battery and charging me for other things. The technician and General Manager has claimed it’s nothing wrong but kept replacing the batteries. 4 times. My life and my grandchildren have been in danger several times while driving on the highway and local streets. Today Richmond Ford says it’s that I need a new engine because Antifreeze has intruded into the engine blowing head gaskets, mind you it was just there on June 23 of 2025 or so for engine malfunction fault extreme high temp no antifreeze and the only band aid that was offered was yet another new battery. Then today I was advised that it will cost $14,000.00 plus to replace my engine. There is definitely a problem and should recall this model 2018 Ford Escape SEL because the manufacturer has fixed the notification system and or the Faults to not warn owners of major engine failures which cost thousands to repair and is always covered up by replacing the battery. Please add this make and model to the recent recall. Thank You

Faulty purge valve control valve. Which is a common issue with the 2018 Ford Escape and there is an active recall for this issue. However my car was not included and I’m experiencing this issue.

My coolant is leaking into the motor. Shop gave me a quote for a whole new engine. I’ve seen so many posts on forums and many friends who own the same car having the same problem. Please please make Ford issue a recall as this is my only vehicle and I got it hoping to finally not have to worry about car problems for a while. It’s been 2 months since I bought it.

When I get gas engine turns off. Need to restart it multiple times. Hesitation on acceleration afraid to be on highway. Rough idol at stop. I’ve seen it multiple people have had this issue. It turns out to be the vapor canister, purge solenoid, which I had to be replaced that fixed it. Hopefully this could help out other people. I was so scared on the highway. God bless you.

I purchased a 2018 Ford Escape in February 2024 with 80,000 miles from a dealership. The vehicle had a single owner and appeared to be in great condition at the time of purchase. However, in December 2024 it presented a critical safety issue involving the engine. While driving, the vehicle began shaking violently and lost power, almost stopping in the middle of an intersection. This placed me and others at significant risk of a collision, as I was unable to control the car properly or move it safely out of traffic. The problem was confirmed by the Ford dealership, where diagnostics initially revealed a misfire code (P0302). After further inspection, the dealership determined that the engine required a full replacement. This repair was estimated to cost $9,000—nearly the current value of the vehicle. The car is at the dealership and has not been repaired due to the prohibitive cost. Through my research, I found Technical Service Bulletin (TSB) 19-2346, which documents similar engine issues reported by other Ford Escape owners, requiring significant repairs and part replacements. Despite reaching out to Ford Customer Service, I was denied assistance and left to bear the full cost of these extensive repairs. There were no warning lamps or messages prior to the failure. The issue occurred without warning while I was driving, making the defect hazardous. Given the serious safety implications of this defect, I strongly urge this issue to be considered for recall. A vehicle with relatively low mileage should not experience catastrophic engine failure, and Ford must take responsibility for addressing this widespread and dangerous issue. My life and the safety of others on the road are far more valuable than the cost of repairs.

My engine check light came on and it said Engine Fault Service Now, with a wrench signal exposed. Then I could hardly stop the vehicle , it became very difficult to apply the brakes, using all of my body weight applied to stop the vehicle. I immediately brought it to O’Reily’s auto place and had a diagnostic test run on the vehicle. Multiple default code come up. P1016, p0365, p0299,p164D p0369,p0443,p0456,p1450. Brought it to the Ford dealership, upon inspection the diagnosis Evap system related disc on this line , tested evap system, found canister purge valve to be broken , tech notes that this is a non Oem part. Advised to replace purge valve and hose assembly. Also discovered that vacuum pump not pulling vacuum, advise to replace pump and reset. Upon removal of the vacuum pump, found pump cam lobe twisted off , vacuum pump is seized, cam replacement is seized , cam replacement will be required. Also both front axel boots are torn, spewing grease all over, recommend replacing both axels, leak p2 pinion value, left back axel leaking, both back brake rotors and pads worn 2mm in the red, coolant level low possible leak. Also is discovered that there was a non ford part purge valve that shouldn’t be there. Estimated cost is 8,500-9000 dollars could be more

Purge valve stuck open causing check engine light to come on. Same as current recall on Ford Focus 2012-2018 vehicles. Ford Escapes within the same time frame should be included in the recall. Every time I fill gas there is a hard turn on since beginning of December. Then check engine light came on and code P1450.

Total engine failure and rebuild due to faulty head gasket component from ford. Vehicle went from running good to all of a sudden having smoke when starting, engine light came on. Immediately had inspected and was told total head gasket/engine failure.

I found coolant reservoir was really low. And found a check engine light. I scanned and found a code related to misfiring. After googling it I found that is a commonly issue in this vehicles related to a bad engine design. I am in Edmonton, Alberta, Canada. And bought the car here. So I am wondering if we are covered by this vehicle complaint.

In March of 2024 warning lights for abs, hill assist, traction control came on while the car was driving. We stopped driving and had the error codes checked at a autozone who said the sparkplugs where misfiring on cylinder 3. it was changed and when we started the car it blew white smoke and the engine seized. The repairs were over $6000. We were told ford had a class action suit which closed on November of 2023. We opened a case but ford closed it and will not help with known problems with the 1.5 lt engine.

Ford Escape 2018 Recall #[XXX] and #[XXX] ENGINE COOLANT LEAK Needs “New Engine” confirmed by service and available for inspection at dealer. Car was taken to Ford Dealer right when engine light came on. Dealer / Service has been only one to inspect car. On [XXX] BEFORE “Engine Coolant” Recalls were expired, car was taken to dealer for Recall #[XXX] I asked about ANY other CSP Letters or Recalls at the time of service. Ford Dealer decided on their own to ONLY preform ONE of the two Recalls that were crucial to being preformed for the safety of my vehicle. Both Recalls #[XXX] and #[XXX] should have been performed together according to letter sent to Dealers from Ford and NHTSA [XXX] Above link clearly states: “ Vehicle owners will receive one letter for both [XXX] and [XXX]. “ “Dealers should repair any affected vehicles that arrive at their dealerships, whether or not the customer has received a letter.” Ford Dealer took it upon themselves NOT to perform repair work or even discuss Recall #[XXX] at the time car was serviced [XXX] before recall expired [XXX]. Ford and Dealers knew about the “Coolant Engine Leak” problem long before and did not warn me or make me aware I was driving a dangerous car. I did not receive CSP Letters that is why I make sure to double check with Service Dept. at time of service. Ford performed Recall #[XXX] and NEVER mentioned CSP Letters sent out or that there was a second recall that needed to done #[XXX] before [XXX] Ford basically sent me on my way in a very unsafe car for myself and my passengers. I should have been made completely aware of this situation at that exact time and service (XXX). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Coolant intrusion to the cylinder bores.

Coolant intrusion into motor. Coolant leak causing multiple misfires and my vehicle to lose power while driving and not to over 30mph. I have had the spark plugs, injectors, and coil packs all changed and problem persisted. Taking my car back to mechanic a test was done and there is coolant in the pistons.

The fuel injector system needs to be replaced. Last year my vehicle had the short block replaced with the "Customer Satisfaction Program 21N12" Some of the parts that should have been inspected included the fuel injector O ring kit and tubes. A year later after my engine had been overheating and was replaced. Now, the fuel injector system needs to be replaced. There are 1 reasons why the system would need to be replaced. 1 due to contamination and 2 due to over heating of the engine. Due to Fords faulty coolant system my engine was overheating for who knows how long until the coolant was completely depleted and running into the cylinders. Now my fuel injector system is leaking due to the overheated engine and ford will not repair.

Mileage: 143,508

Gas goes fast, The canister purge valve? My engine light stays on.

Coolant injection leak, blown engine.

The car began overheating while in operation. The driver immediately pulled over and shut the car off, and the car was towed to the dealership. It was discovered that there was a crack in the gasket, allowing coolant to slowly leak into the engine over time. The engine seized and is no longer operable. This is, as confirmed by my Ford mechanic, and KNOWN and COMMON issue with this particular year/model. Ford is aware that this is a manufacturing defect and has not issued a recall at this time.

Evap purge valve issue ( well recognized by Ford itself as part of a recall with Ford focus models after 2009.). But also needs to be addressed with Ford escape models of the same period. Multiple reports noted online as well ( seeking remedy on youtube and forums). I have Ford protect warranty. They refused to address it as part of the plan!!

Entered car after work on 6/23/22, went to pull into street and car had no excelerating power, steering wheel vibrated, couldn’t go over 15-20 mph, then message on dash alert said: Engine Fault Service Now, the ford message on my app said: power train malfunction, reduced power, hill start assist warning. I messaged with Ford and they said I could drive just not over 15-20 mph. Drove home. Made arrangements to bring car to dealer service next day. They told me to drive it in like that. I was terrified when this happened, I had pulled into busy street, cars honking and trying to pass me, my car just couldn’t move. I didn’t have an immediate place to safely pull over. This was so stressful, felt grateful I wasn’t hit pulling out or from behind.

UNKNOWN The vehicle is only three years old is kept up with on a regular basis with the maintenance and is now having issues with a leaking evap system which has been an ongoing issue with a lot of Ford vehicles. I was notified by a mechanic that inspected my vehicle that the vehicle is not safe to drive and is like a ticking time bomb.

WHILE IN MOTIION (TAKING OFF AND DURING DRIVE) THE CAR 'CUTS BACK' AND DOESN'T PICK UP SPEED CAUSING DRIVER OF VEHICLE TO COMPLETELY PRESS THE GAS PEDAL TO INCREASE SPEED(ONLY SOMEWHAT GRADUALLY AFTER ANOTHER CUTBACK). THIS HAPPENS WHILE TRAVELING ON HIGHWAYS AND ON CITY STREETS OR COUNTRY ROADS. IN ADDITION, WHEN PUTTING CAR IN REVERSE (TO PARK OR PULL OUT OF PARKING SPACE) THE CAR EITHER TURNS OFF OR DOESN'T MOVE BACK WHEN PRESSING THE GAS PEDAL.

Mileage: 105,000

ON DECEMBER 26, 2019, ANOTHER OTHER VEHICLE HIT THIS 2018 FORD ESCAPE, SPINNING IT INTO ANOTHER VEHICLE. THIS ESCAPE CAUGHT ON FIRE AND WAS TOTALLY DESTROYED. ALL INVOLVED VEHICLES (ALL FORDS) WERE IN MOTION TRAVELING ABOUT 50 MPH. THIS ESCAPE WAS TRAVELING NORTH ON ROUTE 122 NEAR BURNT CHIMNEY, VA. THE OTHER TWO FORDS WERE TRAVELING SOUTH ON THIS TWO LANE ROAD.

Mileage: 24,000

ON MARCH 3, 2018, WE PURCHASED A 2018 FORD ESCAPE FROM DUVAL FORD IN JACKSONVILLE, FL. SOON AFTER THE PURCHASE, WE EXPERIENCED ISSUES WITH THE CAR STALLING AND JERKING WHEN APPLYING GAS. ALTHOUGH THE SITUATION ONLY OCCURS ON OCCASION, IT IS A DANGEROUS PROBLEM WHEN ACCELERATING INTO TRAFFIC. THE MAIN TIME THIS HAS HAPPENED IS DURING LONG TRIPS. WITH OUR TRAVEL SCHEDULE AND FAMILY OUT OF TOWN, WE NEED A RELIABLE VEHICLE TO SAFELY TRANSPORT US TO WHATEVER LOCATION WE CHOSE. WE CALLED TO REPORT THE ISSUE AND TRIED SOME OF THE TROUBLE SHOOTING EFFORTS EXPLAINED TO US VIA PHONE. THE ISSUE PERSISTED; THEREFORE, ON MAY 8, 2018 WE RETURNED THE VEHICLE TO THE SERVICE DEPARTMENT EXPLAINING DETAILS OF THE STRUGGLES PREVIOUSLY MENTIONED. WE ASKED THEM TO CHECK THE FUEL INJECTOR AND OTHER ENGINE MISFIRES. TWO DAYS LATER, THEY RETURNED THE CAR STATING THERE WERE NO ISSUES FOUND. THIS PROCESS HAS CONTINUED SEVERAL TIMES FROM APRIL 2018 UNTIL TODAY. OUR LAST ATTEMPT TO ALLOW DUVAL FORD SERVICE DEPARTMENT TO REPAIR THE ISSUE, WAS ON DECEMBER 5, 2019. WE TOOK THE CAR INTO THE SHOP, REPORTED IN DETAIL ABOUT THE ON-GOING ISSUE AND ASKED FOR THE OIL TO BE CHANGED. THE SERVICE DEPARTMENT HAD THE VEHICLE FOR 9 DAYS, DROVE IT 31 MILES, AND REPORTED THAT NO ISSUES WERE FOUND. DURING THE 9-DAY STAY, WE CALLED TO ASK ABOUT THE STATUS OF THE VEHICLE, ONLY TO BE TOLD THAT IT WAS BEING WORKED ON. ON SATURDAY, DECEMBER 14, 2019, AFTER A 9-DAY STAY IN THE SERVICE DEPARTMENT PARKING LOT, WE WENT TO RETRIEVE OUR VEHICLE ONLY TO FIND THAT THE OIL HAD NOT BEEN CHANGED AND NO ISSUE WAS RESOLVED WITH THE PROBLEM WE REPORTED.

GETTING TERRIBLE GAS MILEAGE ONLY ABOUT 17 MILES TO THE GALLON, HAD 60 MILES ON CAR WHEN LEASED AND THEY TOLD ME TO WAIT TILL I HAD A 1000 MILES NOW HAVE 2000 MILES AND STILL GETTING LOUSY MILEAGE. ALSO, STOP/START DOES NOT SEEM TO BE WORKING. ALSO KICK PLATE ON BACK DOESN'T WORK WELL. WELL, NOW TRY TO TAKE IT IN.