2021 FORD ESCAPE Electrical System Problems

The contact owns a 2021 Ford Escape. The contact stated upon taking the vehicle for the State Inspection, the contact was informed that the gateway module of the vehicle was not communicating, preventing the inspection from being performed. The vehicle was taken to the dealer, where it was determined that the gateway module needed to be reprogrammed. The contact was informed that a fee would be charged for repair. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: 22N15 (Gateway Module Reprogramming for Inspection and Maintenance (I/M) Testing); however, the manufacturer informed the contact that the vehicle was not covered under the campaign. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 45,160.

Mileage: 45,160

The contact owns a 2021 Ford Escape. The contact stated that while driving at an undisclosed speed, the fuel tank gauge decreased from 1/4th to empty almost immediately. The contact arrived at a gas station and discovered that the fuel tank was not empty. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the fuel gauge sending unit. The contact was informed that the fuel tank needed to be replaced. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 21,000. The VIN was not available.

Mileage: 21,000

Vehicle will completely cut off when stopped at lights sometimes. And I have to turn off vehicle and restart it to get vehicle going again.

I was driving my 2021 Ford Escape, that I have not yet owned for four years, that I purchased brand new from a Ford dealership. I was driving to work just as I do on a typical morning at interstate speeds, when suddenly, the car refused to upshift, slipping gears. The car became jerky. I tried to accelerate back up to speed. The car was not moving and the RPM reading shot into the red. I see a large vehicle approaching me, and I begin to feel terror that I could become the victim of a car crash, due to a faulty Ford transmission! This moment was psychologically damaging, as I feared for my life. Eventually, the car regained speed slowly and I continued on my way. Then, at stoplights, the car continued to jerk and shift gears. Once I reached my destination, the car slammed into park, throwing me toward the steering wheel. My husband towed my car home. It has been taken to a local dealership where I received a quote for a new transmission and an oil leak repair, totaling over $11,000. This car at trade-in value is worth a similar amount. The transmission fluid was tested and found to be burnt and containing traces of metal in the fluid. The dealership has been helpful in diagnosing the repair. But from Ford, this low-standard is unacceptable. I could have been killed, injured, and caused harm to others due to this faulty transmission. I have reason to believe based on a class action lawsuit that took place in March of 2024, Ford knowingly placed faulty parts and transmissions into Ford Escape models that were produced from 2009-2021. I have called Ford corporate. They offered little to no empathy, offering a small amount of assistance, which was highly disappointing.

There is an open recall that is unrepaired on the door but my problem is same as thousands of customers reporting a fuel issue to Ford. I spoke to Ford and the case manager agreed that it's so many customers calling on the Ford Escape fuel consumption issue and there should be a recall issued to fix whatever is causing it. My car had 13,000 miles on it used and I just made my second car payment. I began that week noticing something is not right. I hear a ticking at times in the engine, My MPG number on dashboard is rapidly flipping between random numbers from 99.9 MPG, down to 10 MPG and then 75 MPG and then 6 MPG and ect. I filled up and should have had 249 miles till empty and I got 147 miles before filling up again. Ford has recalls on 2021 Ford escapes for high pressured fuel injectors but only a customer satisfaction on my VIN. Now Ford said a code that alerts them my heating element is throwing a code, my USB charging ports are now throwing a code and stopped working. This is not normal. Why is this 2021 not recalled to replace injectors or whatever is the problem but other 2021 escapes are. Recall this before it breaks down and people owe like 20,000 left and no car. Thank you so much for your time and consideration. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

1. The Sunroof/Moonroof overhead fabric lining fell off the tracks when moving back, yes. 2. My safety was put at risk from the lining falling off the tracks and nearly completely covering my eyes and face while driving, which also puts the safety of others at risk. 3. I have heard numerous people and Ford Technicians noting that this is a common issue of the sunroof/moonroofs with other similar models. 4. It was completely inspected before financing at a dealership. 5. No prior symptoms or lights, I just tried to use my moonroof while driving on the highway a week ago and was nearly blinded

I have had multiple issues with the powertrain warning light illuminating. The first time it was decided to be low/dirty oil. This occurred about a month after purchasing the vehicle in 2021 with about 4000 miles. The second time it occurred about 6 months later. The dealer could not find a code nor replicate the issue. We thought I had bought bad gas. A year later it came on again, Ford dealership again couldn’t replicate the issue. Finally it came on and stayed on and throttle position sensor was replaced in July 2022. Light came on again in November 2024. Auto parts store and dealership could not find a code. This time I had no coolant. Added coolant and it has not come back on again.

I see no recalls for 2021 Ford Escape SEL AWD 2.0L. Vehicle was parked next to house under carport all day and owner smelled smoke. Looked out house window and seen front of vehicle on fire and catching house on fire. The fire department put it out but the vehicle was a total lose and house has significant damage and is unlivable until repairs can be made. There were no indications this was going to happen. These models need to have a recall.

The contact owns a 2021 Ford Escape. The contact stated that upon having the A/C unit serviced, the service technician shocked and burned himself on the wiring harness. The contact was informed that the vehicle was unsafe to drive due to the issue. The contact was informed that the wiring harness needed to be replaced; however, the part was on backorder. The manufacturer was also notified of the failure but offered no assistance. The vehicle was not repaired and remained with the dealer. The failure mileage was approximately 39,000.

Mileage: 39,000

Left Driver door making popping sound when opening or closing due to spot welds failing. Left Driver door has no catch when opening until door is completely open. Left Driver door electronics affected due to spot welds failing this includes window up/down function and locking/unlocking. Claim filed with Ford customer concern and spoke to dealer. Ford wants $2600.00 to repair and will contribute $900.00 because vehicle is out of warranty.

The contact owns a 2021 Ford Escape. The contact stated that while in the reverse(R) position, the vehicle independently increased in speed without warning. The contact made multiple attempts to stop the vehicle by depressing the brake pedal; however, the brakes failed to operate as needed. The contact crashed into a fire hydrant but the air bags did not deploy upon impact. The contact suffered pain in her stomach and neck but did not seek immediate medical attention. The fire hydrant was damaged as a result of the failure. A police report was filed. The vehicle was towed to an independent mechanic where it was repaired. Since the repair, the contact stated that the vehicle would shake when driving over 30 MPH without warning. She also mentioned that a loud, squeaking noise would emit from the vehicle while in reverse. The contact took the vehicle to a dealer where they were unable to diagnose the failure. The manufacturer had been notified of the failure but offered no assistance. The vehicle had yet to be repaired. The failure mileage was approximately 3,000.

Mileage: 3,000

Speed is telling me the limit is 80 when there is no speed limit like that in the area and the speed limit actually is 45. Steering wheel keeps telling me to put my hands on the wheel when both hands are on the wheel.

I just had it in the shop. The car acts like there is going to be a collision when nothing is in front of it. Also try’s to pull me off the road. Been computer and electrical issues since I bought the vehicle.

In September 2021 the car had 2 incidents of not being able to stop with the brakes while backing down my drive. The auto stop shut down was on. In the first instant I almost hit a senior with a walker. He fell but only scraped his hand and was not hit by the car. The second time, May 2022, the car crashed into the neighbor's front porch and took down a fence, I got out of the car and then fell in the street and broke my pelvis. The third time I was going down the steep drive and was able to steer the car until it stopped. The 4th time< May 6, 2022, I was backing out of a parking space, May and did not turn off the engine stop button and the car went into reverse don the lot. I managed to avoid hitting a row of cars and 1 man before I got the car to stop.

The contact owns a 2021 Ford Escape. The contact stated while driving approximately 15 MPH to enter the freeway, the Auto Start/Stop feature inadvertently stopped the vehicle. There were no warning lights on the instrument panel. The vehicle had to be manually disabled. The vehicle was taken to an independent mechanic who was unable to determine the cause of the failure. The manufacturer was notified of the failure. The approximate failure mileage was 7,000.

Mileage: 7,000

I rented this Ford Escape from Avis this month and ran into what could have been an incredibly dangerous safety issue due to a massive oversight in the car's design. I installed a small booster seat in the passenger side back seat for my 10 year-old son. He got in the seat and attached his seat belt, which he has done hundreds of times before in our own car. About 1 hour into a 2-hour freeway trip, a notification went off on the dashboard, telling me that a seat belt in the back had come undone. My son tried frantically to reattach the buckle but was unable. I had to exit the freeway and park on the side of the road. When I tried to reattach the buckle, I saw why there was a problem: He had inserted the buckle into the CENTER receptacle, not the passenger-side one. The receptacle didn't click, as it was probably designed not to do, but because the metal of the buckle has a slight angle to it, there was enough tension for it to temporarily hold. However even a minor accident could have been fatal because my son wasn't property strapped in. There are several issues here. First, the dash indicator should have been designed to tell me that there was weight on the right rear seat but no buckle was attached to that receptacle. Second, the center receptacle did not immediately reject the right-most buckle; instead, the bent angle of the buckle's metal temporarily held it in place and made my 10 year-old believe he was strapped in. Finally, the receptacles themselves have no play from side-to-side. This, plus the angle of the buckle's metal, means that when a booster seat is installed, there is not enough room to fully attach the buckle into the receptacle without exerting a LOT of force to push the receptacle to the left. I can't imagine the buckle can be attached at all with a larger child seat. The image I attached shows why this is; attaching a car seat requires exerting enough force to bend the metal holding the receptacle in order to attach the buckle.