2021 FORD ESCAPE Engine Problems

The contact owns a 2021 Ford Escape. The contact stated that while driving approximately 60 to 70 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light and the charging system service light were illuminated. The message "Vehicle Turning Off to Save Power” was displayed. In addition, there was an abnormal knocking sound coming from the engine while the vehicle was slowing down. The contact stated that the parking brake push button failed to function as intended. The contact was unable to coast to the side of the road. The vehicle was towed to Auto Zone, where the battery was checked, and the battery passed the test. The tow truck driver had difficulty attempting to tow the vehicle. The vehicle failed to restart, and the auto brake turned on independently. After a while, the vehicle was towed to the contact's mother's residence. The vehicle was later towed to the dealer. The vehicle remained at the dealer pending the results of the diagnostic test. The manufacturer was made aware of the issue; however, no assistance was offered. The vehicle was included in NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE). The contact was the second owner of the vehicle and had not received the recall notification. The failure mileage was approximately 79,000.

Mileage: 79,000

This vehicle! It eats so much gas. Something is wrong. It makes a weird noise and puts itself into modes of sports, ice/snow, eco, slippery all by itself while I am driving. My RPMs will change and car makes a different sound and it is in a different driving mode without being put in it by me. It puts itself in auto mode and shuts off at red lights and starts back up when I put on the gas and this is not a hybrid.

2021 Ford Escape. In January 2025 the turbo system failed and was replaced by a Ford dealer for about $5,903.85. Around five months later the transmission required repairs for a valve body issue, totaling roughly $3,000 in August. Two months after that repair, Firestone advised that the entire transmission now needs replacement. Each time the problem appeared, the vehicle showed violent slippage while upshifting and downshifting. When coming to a stop, the car would shake violently, slip forward several inches while my foot was still on the brake, and sometimes hesitate or lose power. Recently the vehicle will stop responding to acceleration, then suddenly surge forward without warning. These repeated transmission failures have created serious safety risks and appear consistent with ongoing problems involving the Ford 8F35 transmission used in the 2021 Escape.

NHTSA Recall 25V467 was issued in July 2025. It has been over 3 months of constant fear for under-hood fire from possible fuel injector crack. My family's safety has been at risk long enough, this needs a permanent fix please!

My engine has been misfiring since I purchased my vehicle from a Ford Dealership in Mooresville, NC. At least, I think it is misfiring. My vehicle did not pass an emissions test and I had it inspected at a Ford Dealership in Statesville, NC. They told me I have a transmission fluid leak. I went to a transmission specialist, and we stood under my car while he showed me that the transmission is not leaking in any way. This when I learned of the fuel injection recall. He wants to help in discerning what the problem actually is, but I need to address the recall issue first. I have to do something, as I need my car for my Uber side job, but I'm being told that I have no option. Please, help. I'll provide any additional information that you may need. Thank you.

Lots of owners on Facebook page 2020/2021 ford escape discussions talk about our transmissions fluttering when driving straight you can see rpm’s going from one to under one back in a straight road some have had the transitions go out. I took mine to ford at 111000 miles and was told I need to pay $500 to change fluid did that and still doing it they said everything was fine but I should look into a extended warranty because they have had a lot of issues with the transition (was told that by auto nation ford in Corpus Christi tx? We all even have issues with Rear differential going out

VEHICLE IS UNSAFE TO DRIVE. REMEDY IS NOT AVAILABLE, AND A FIRE CAN START UNDER THE HOOD. I HAVE A CAR THAT I BOUGHT THAT I CANNOT DRIVE WITHOUT THE ANXIETY OF A FIRE. FORD WILL NOT BUYBACK MY VEHICLE, AND THEY ARE IN BREACH OF THEIR WARRANTY.

I’ve visited both Ourisman Ford of Manassas, VA and Ted Britt Ford of Chantilly, VA regarding this issue and asked when a fix is expected. At both dealerships, I was informed that this is not classified as a recall but rather part of Ford’s Customer Satisfaction Program. However, when I provided the service representative with the official letter from Ford, they were unable to locate either the Manufacturer Recall Number 25S76 or the NHTSA Recall Number 25V467 in their system. I’ve also explained that my vehicle—a 2021 model with fewer than 25,000 miles—is experiencing poor fuel economy, ranging between 23–29 MPG. Additionally, I’ve noticed a troubling performance issue: when accelerating from a complete stop, the car sometimes hesitates, then suddenly lurches forward, occasionally causing the tires to squeal.

The contact owns a 2021 Ford Escape. The contact stated while driving at an undisclosed speed, the message "Service Engine Soon" was displayed. The vehicle was taken to the dealer where it was diagnosed and determined that an unknown valve needed to be replaced. The unknown valve failure was related to the fuel intake. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed with the same valve failure. The check engine warning light was illuminated. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the dealer where it was diagnosed with the same failure and the vehicle was repaired again; however, the failure reoccurred. The manufacturer was made aware of the failure and referred the contact to NHSTA Hotline for assistance. The failure mileage was unknown.

Vehicle will completely cut off when stopped at lights sometimes. And I have to turn off vehicle and restart it to get vehicle going again.

Lithia ford is Fresno worked on exhaust and replaced cat converter on September 5th 2024 for the dealer in which I purchased my vehicle. Ford did not put the support bracket that holds the exhaust and catalytic converter in place back on after the repair. I purchased the vehicle and after 1 month of driving it, the vehicle exhaust started to get really loud and began leaking exhaust fumes into the cab of the car. Car was taken to Tulare Ford to be checked when the missing bracket was discovered and work history was pulled on the vehicle showing Lithia’s direct connection to the exact missing part. Lithia ford refuses to take responsibility for their failure to properly secure the exhaust and catalytic converter which directly cause the issue at hand.

When I change gears to reverse, it’s hard to put in gear and studders as well. I am not sure what the issue here is with it.

Every time I get gas my engine stalls out citing an issue with the evap system — evap purge valve. This is not safe as it stalls out directly after filling the car up. The smell of gas is very prominent leading me to believe there could be a fire hazard associated with this as well.

2021 Ford Escape 1.5L 19,502 miles Coolant loss with no visible leaks

On or about [XXX] I was driving on the highway and the traffic was slowed down. Once the traffic speed picked back up I noticed the maintenance symbol light up. I could not go any faster than 50 mph. I immediately went and got and oil change. Once I paid for the service the technician told me that I had a stripped oil pan. He said that I needed to check it out. The Ford Escape drove without a problem for about 2 weeks then the check engine light came on [XXX]. I made and appointment with Pep boys. The next morning 1/19 as I started the car the check engine light was on. I took the car to pep boys and parked to wait for appointment time. I turned the car off and waited for about 5 minutes and started the car back up and the check engine light did not come back on. I told the technician that my check engine light was on but now it is not. So he could not do a diagnostic on it. He told me that my oil pan would be in until the next day 1/20. 1/20/25 the next morning I took my Ford Escape to get the oil pan changed. While on the way the check engine light was still off. So as I get to the pep boys I tell them that my check engine light is back on. They did the repair for the change of the oil pan and diagnosed a DTC p3402 ( Cylinders 1 Deactivation/ intake valve. It was recommended for me to take my Ford Escape to the authorized dealer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I see no recalls for 2021 Ford Escape SEL AWD 2.0L. Vehicle was parked next to house under carport all day and owner smelled smoke. Looked out house window and seen front of vehicle on fire and catching house on fire. The fire department put it out but the vehicle was a total lose and house has significant damage and is unlivable until repairs can be made. There were no indications this was going to happen. These models need to have a recall.

While accelerating at a stop light I heard a thud in the hood of my car and then it started to smoke so I pulled off the road and turned off vehicle but the car caught fire and the entire front end burned.

My coolant exploded while in the middle of the road, engine stopped accelerating. Warning light turned on right as acceleration was reduced to nothing. No prior warning & temp gauge was normal it’s I lost acceleration. Had to turn on hazards to warn cars behind me as it was sudden. No warning lamps prior to the coolant leak besides the low tire pressure.

My 2021 Ford Escape SE is loosing coolant, but no leaks.

The contact owns a 2021 Ford Escape. The contact stated while driving at various speeds, the vehicle was veering to the right independently. The vehicle was taken to the dealer, where both the rear shock absorbers and the front passenger's side tie rod were replaced. Additionally, the contact stated while driving 60 MPH and at higher speeds, the front end of the vehicle was vibrating. The contact stated that upon inspecting the vehicle while parked, she opened the hood and noticed that the engine was vibrating significantly while running. The contact stated that she also noticed a black stain on the engine. The vehicle was taken to a second dealer Casco Bay Ford1 (213 US-1, Yarmouth, ME 04096), and to a third dealer Rowe Ford Sales (91 Main St, Westbrook, ME 04092), where the contact was informed that the engine was operating as designed. The vehicle was not diagnosed or repaired. The failure mileage was approximately 14,000.

Mileage: 14,000

Front windshield is prone to crack. I have had to replace 5 windshields since I first purchased the vehicle. It is a known documented issue. Assuming aerodynamics is the issue and can cause more than the reasonable amount of cracked windshields. Valve body and transmission went out at 100,243 miles. All requested/required regular maintenance was completed.

Mileage: 100,243

No incident, but complaint regarding Ford's untimely correction of safety recall 22S73, NHTSA Recall 22V859. Recall notice sent in January 2023; thus far Ford (Woody Anderson Ford, Huntsville, AL) is totally noncommittal in terms of a likely correction date. Based upon data from this Ford dealership, corrective action could be as late as Fall/Winter 2023. Ford should be responsible for allotting adequate resources to this safety issue.

The vehicle still has not been serviced due to the dealerships informing me that they do not have the parts even though I received notice that the parts were in stock.

FORD ESCAPE. CONSUMER WRITES IN REGARD TO PARTS BEING UNAVAILABLE TO PERFORM SAFETY RECALL.

While driving on the interstate a fire started under the hood and shortly after smoke entered the driver cabin. Luckily I was able to pull over and get out of the vehicle before the fire reached the driver cabin. It is going to be investigated by a company hired by AAA, the appraiser from the insurance company was not able to find a cause due to the fire damage being too bad. The first warning message was engine coolant overtemperature and a couple of others followed.

The contact owns a 2021 Ford Escape. The contact stated while driving 65 MPH, the vehicle began vibrating and the contact heard an abnormal noise. The contact stated no warning light was illuminated. The contact was able to drive to his destination. The contact took the vehicle to local dealer and was informed that there was no remedy for the failure. The vehicle was not repaired but was pending repairs. The manufacturer had been informed of the failure. The failure mileage was approximately 700.

Mileage: 700

The contact’s daughter owned a 2021 Ford Escape. The contact stated that while her daughter was driving at an unknown speed, the coolant warning light illuminated. As the contact's daughter began to pull over, she began to lose control of the vehicle as a black smoke started coming from the engine. The vehicle caught on fire once the contact's daughter had exited the vehicle. The fire department arrived at the scene and was able to extinguish the fire. A fire report was filed. There was no injury reported. Due to the failure, the vehicle was initially towed to a tow yard however, the current location of the vehicle was unknown. The contact's daughter notified the dealer of the failure and a week later and she was informed that an investigation would be started. The manufacturer was not notified of the failure. The vehicle was destroyed. The failure mileage was unknown.