2005 FORD EXPEDITION Engine Problems

Engine Missing

The contact owns a 2005 Ford Expedition. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound. The vehicle was taken to an independent mechanic, where the contact was notified of an engine misfire. The spark plugs were replaced. Additionally, the contact stated while driving 55 MPH, the brake pedal became stiff, and the vehicle failed to immediately stop. Additionally, the vehicle made an abnormal sound and stalled. The vehicle was taken to an independent mechanic, who informed the contact that the spark plugs, and the engine needed to be replaced. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 89,000.

Mileage: 89,000

ENGINE MAKES RATTLING NOISE AND MISSING BADLY

Mileage: 30,000

MY CAR AT TIMES WILL GIVE A HARD START. TURNING, BUT NOT FULLY TURNING OVER OR GIVES OFF A SOUND THAT I CAN ONLY DESCRIBE AS AN ELEPHANT TRUMPETING. WHEN IT DOES START AT TIMES IT WILL SHUT COMPLETELY OFF JUST AS FAST. IT HESITATES TO PICK UP ADEQUATE SPEED AND WILL STUMBLE OR JERK, AND WHEN PUT IN REVERSE IT WILL COMPLETELY STALL OUT. I'VE HAD A NEW BATTERY INSTALLED, AND THE SPARK PLUGS AND BOOTS HAVE BEEN CHANGED, BUT TO NO AVAIL.

Mileage: 152,600

THE CAR TURNS OFF. I NEED TO PUT THE CAR IN PARK WAIT A FEW MINUTES THEN TURN THE CAR BACK ON AND IT WORKS. THE BAD THING IS IT CAN HAPPEN AT ANY TIME.

Mileage: 186,609

I WAS DRIVING AND ALL OF A SUDDEN STEERING WHEEL LOCKED AND MY CAR LITERALLY SHUT OFF WHILE I WAS DRIVING.. I COASTED TO THE SIDE AND I TURNED OFF CAR.. TRIED TO TURN IT BACK ON AND IT KEPT CRANKING AND I KEPT DOING IT LIKE 5 TIMES UNTIL IT STARTED BACK UP. SURE IT IS A 2005, BUT IT HAS BEEN GIVING ME PROBLEMS SINCE I GOT IT, NOW IT IS WORSE. I DON'T BELIEVE IT IS WEAR AND TEAR I ACTUALLY REPLACED THE WHOLE ENGINE 4 YEARS AFTER I BOUGHT MY CAR WHICH IS RIDICULOUS TO BEGIN WITH. IF MY CAR BURNS UP WHILE I AM DRIVING I WILL REALLY MAKE A STINK..

Mileage: 200,000

VEHICLE VIBRATES BADLY ESPECIALLY AT HIGHWAY SPEEDS. VIBRATION IS SO BAD, THE VEHICLE ROCKS SIDE-TO-SIDE WHILE DRIVING. DRIVING AT HIGHWAY TURNPIKE SPEED OF 75MPH, VEHICLE ENGINE BEGAN TO SURGE AND THEN COMPLETELY SHUT DOWN. OIL PRESSURE GAUGE INDICATED LOW OIL PRESSURE AND VEHICLE WOULD NOT START. VEHICLE STILL HAD ELECTRICAL FUNCTION BUT ENGINE NO LONGER WOULD TURN OVER. CHECKED ENGINE OIL LEVEL AND HAD ENGINE OIL. CALLED HIGHWAY PATROL AND HAD TO HAVE THE VEHICLE TOWED. *TR

Mileage: 214,200

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 30 MPH, THE VEHICLE VIBRATED ABNORMALLY AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

Mileage: 120,000

THIS CAR JUST NUMEROUS OF PROBLEM..... WHO EVER BUILT THIS CAR DID NOT HAVE A GOOD JOB OF DOING IT

MY ENGINE SAID FAIL SAFE MODE. MY SPARK PLUGS GOT STUCK IN ENGINE COSTING ME 1000 TO FIX.

Mileage: 112,000

MY 2005 EXPEDITION IS MAINTAINED NORMALLY AND SPARK PLUGS CHANGED AND THE ENGINE WILL EITHER CUT OFF OR SLOW DOWN TO ABOUT 30 MILES AN HOUR WHILE I AM ON THE HIGHWAY WITH A ERROR MESSAGE FAIL SAVE MODE. MOST TIMES WHEN I SHUT OFF THE ENGINE AND RESTART IT TURNS OVER BUT DOESN'T STAY ON. TOTALLY UNSAFE FOR ME AND MY FAMILY. PLEASE RESEARCH AND RECALL WHAT THE ISSUE IS! THIS ISSUE HAS STARTED ABOUT 4 YEARS AFTER WE PURCHASED THE VEHICLE AND HAS BEEN HAPPENING MAYBE ONE TO TWO TIMES A MONTH SINCE.

Mileage: 120,000

FOR MANY TIME THAT MY EXPEDITION HAS STALLED BECAUSE OF THE THROTTLE BODY FAILING. THE ENGINE GOES INTO SAFE MODE AND STALLS AND STOPS, THI IS VERY DANGER SITUATION

I HAVE A 2005 FORD EXPEDITION AND HAVE MAINTAINED MY VEHICLE MAINTENANCE AND ONLY HAVE 124,000 MILES ON THIS VEHICLE. IT CONTINUES TO SHUT OFF THE ENGINE AND CODE FAIL SAFE MODE ON CODE APPEAR AND WHEN I'M DRIVING ON THE HIGHWAY IT IS DANGEROUS. AFTER READING SO MANY COMPLAINTS THIS IS UNSAFE. ALSO, THE COMPUTER ISSUES WITH LOCKING DOORS, FAILURE OF THE TRANSMISSION (WHICH I HAD TO REPLACE) SUCH A DISAPPOINTMENT OF A VEHICLE. FORD SHOULD RECALL ENGINE AND COMPUTER ISSUES. I PURCHASED THIS VEHICLE BRAND NEW $50,000 + AND HAVE NOT BE ABLE TO DEPEND ON THE STABILITY SINCE I'VE HAD IT.

Mileage: 20

MY FORD EXPEDITION, WHILE DRIVING AT 40 MILES AN HOUR LOST POWER. THIS IS THE 3RD TIME IN 2 YEARS IT HAS HAPPENED. ON THE INFO CENTER IT STATED ENGINE FAIL SAFE MODE. THE THREE TIMES IT HAS HAPPENED HAS BEEN ON BACK ROADS.I CONSIDER THIS A VERY UNSAFE CONDITION . MY DEALER LOOKED AT IT THE FIRST TWO TIMES AND SAID THERE WERE NO CODES, THAT I WOULD NEED TO BRING IT IN SOONER. BUT THERE ARE NO LASTING RESULTS, AND IT STARTS RIGHT BACK UP.

Mileage: 65,000

MY 15 YEAR OLD SON AND MY LIFE WERE PLACED IN SERIOUS DANGER, BY THE GROSS NEGLIGENCE AND DECEPTIVE BUSINESS PRACTICES PROMOTED BY THE FORD MOTOR COMPANY, REGARDING SCAN CODE P2106. SINCE AS EARLY AS FEBRUARY 26, 2013 FORD MOTOR COMPANY WAS MADE AWARE OF A DANGEROUS DEFECT CONCERNING THE MECHANICAL AND ELECTRICAL COMPONENTS OF THEIR MANUFACTURED PRODUCT RELEASED TO THE CONSUMER PUBLIC FOR PROFIT. THE VEHICLES ARE FORD TRUCKS, MANUFACTURED FROM 2003 - 2008, WITH THE V8 5.4 L ENGINE. PUBLIC RECORD REVEALS CASE NO. 12-7222, JASON SCHMIDT, (PLAINTIFF) VS. FORD MOTOR COMPANY, (DEFENDANT) FILED IN THE UNITED STATES DISTRICT COURT FOR THE EASTERN DISTRICT OF PENNSYLVANIA, THAT FORD MOTOR COMPANY IS WELL AWARE OF THIS ISSUE. I BELIEVE THAT FORD MOTOR COMPANY HAS MADE NO ATTEMPTS TO INFORM FORD DEALERSHIP OWNERS, THE FORD DEALERSHIP MANAGERS OR FORD SERVICE REPAIR SHOP MANAGERS AT THE FORD DEALERSHIPS AND CONSUMERS WHO HAD ALREADY PURCHASED THEIR MANUFACTURED PRODUCT OF THE ISSUE. THIS ISSUE IS VERY DANGEROUS, I WAS TRAVELING 70 MPH, WITH MY SON IN THE TRUCK. FORD MOTOR COMPANY HAS GONE ON RECORD, VIA TELEPHONE CONVERSATION, EXPLAINING TO ME THAT; "FORD MOTOR COMPANY HAS NO CONTROL OVER HOW INDIVIDUAL DEALERSHIPS FUNCTION OR OPERATE THEIR ESTABLISHMENT PLACES OF BUSINESS, SORRY. BUT I CAN TAKE A COMPLAINT AND BE SURE THAT THE DEALERSHIP RECEIVES IT AND PROVIDE YOU WITH A COMPLAINT NUMBER". FLAMMER FORD, SPRING HILL, FL REPLACED A PART AND NEGLECTED TO TEST DRIVE THE TRUCK, RELEASED THE VEHICLE TO ME AND THE PART REPLACED WAS NOT WHAT WAS WRONG WITH THE TRUCK. I HAD MY TRUCK TOWED TO AUTONATION FORD IN BROOKSVILLE, FL FOR THE SAME ISSUE (P2106 CODE), THEY DID THE SAME THING, WITHOUT REPLACING A THING. ONLY THIS TIME, WHILE DRIVING ON A HIGHWAY, MY TRUCK AND THE LOST ALL POWER. MY TRUCK IS BACK AT AUTONATION FORD IN NEED OF A NEW TRANSMISSION.

Mileage: 147,024

WHILE MOVING IN TRAFFIC THE VEHICLE ENGINE CUT-OFF ON ITS OWN. MESSAGE CAME UP ON DASH DISPLAY, SOMETHING ABOUT "ELECT THROTTLE CONTROL". WAS MOVING VERY SLOWLY ON AN INTERSTATE HIGHWAY BAD TRAFFIC, WITH HEATERS (FRONT AND BACK) AND THE RADIO ON. I WAS ABLE TO COAST OFF TO THE SIDE OF THE HIGHWAY. TURNED OFF RADIO, HEATERS, THEN WAS ABLE TO RESTART THE VEHICLE. BATTERY CONDITION WAS FINE (REPLACED 2 YEARS AGO), NO OTHER WARNING. VEHICLE IS WELL-MAINTAINED, NEVER DRIVEN HARD OR USED FOR TOWING. TODAY I AM TAKING IT TO A FORD DEALER FOR EVALUATION.....UPDATED 08/25/15 *BF

Mileage: 111,520

SINCE PURCHASING THE EXPEDITION IN DECEMBER 2014, I'VE HAD SEVERAL INCIDENTS OF "CHECK ENGINE THROTTLE" WARNINGS AND THE ENGINE SHUT DOWN, SUDDENLY. THIS SEEMS TO ALSO HAVE A SECONDARY ISSUE OF THE TRUCK HESITATING/SPUTTERING AROUND 40-50MPH. THE VEHICLE HAS SHUT DOWN ON ME IN CITY TRAFFIC QUITE A FEW TIMES AND ONCE ON AN EXIT RAMP OF THE HIGHWAY. THIS IS A VERY DANGEROUS SITUATION TO EXPERIENCE. THE DEALER MENTIONED POSSIBLE SPARK PLUG ISSUES. WHEN THE "CHECK ENGINE" ICON FINALLY CAME ON, I HAD IT READ BY THE DEALER AND AN INDEPENDENT MECHANIC. THE CODE IS A P2104. THE DEALER NEVER GOT BACK TO ME ON A REMEDY FOR THIS. THE MECHANIC SAYS THE ELECTRONIC THROTTLE CONTROL MUST BE REPLACED AND COULD BE THE CAUSE OF BOTH ISSUES. BOTH HAVE BEEN REPORTED TO THE DEALER BEFORE THEIR WARRANTY EXPIRED. I'M FINDING THE REPAIR COULD COST ABOUT $700. AN ISSUE OF THE ENGINE SHUTTING OFF, REGARDLESS OF SPEED, WHILE DRIVING IS VERY DANGEROUS. THE TRUCK MUST BE PLACED IN PARK, TURNED OFF, THE RE-STARTED BEFORE CONTINUING MY DRIVE. THE SCARIEST WAS UPON AN EXIT RAMP OF THE HIGHWAY AT APPROXIMATELY 30MPH. *TR

Mileage: 150,000

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE THROTTLE BODY SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 121,800.

Mileage: 121,800

THIS IS THE 4TH TIME IN 5 WEEKS THAT MY CAR HAS SHUT DOWN WHILE DRIVING AND IT SAYS "ENGINE FAIL SAFE MODE". IT HAS BEEN IN THE SHOP AFTER THE FIRST 3 INCIDENTS AND DIFFERENT THINGS HAVE BEEN DONE TO IT. I JUST GOT IT OUT OF THE SHOP AND IT HAPPENED THE 4TH TIME. SO IT'S GOING BACK TO SHOP. I HAVE BEEN FORTUNATE, AND HAVE NOT BEEN IN A ACCIDENT AS A RESULT OF IT SHUTTING DOWN. LOOKING ONLINE IT'S AMAZING HOW MANY PEOPLE HAVE EXPERIENCED THIS SAME ISSUE. WHY HAS FORD OR NHTSA NOT DONE SOMETHING ABOUT THIS? WILL IT TAKE SOMEONE GETTING KILLED BEFORE THEY TAKE ACTION? *TR

Mileage: 176,000

WHILE DRIVING ALONG AT 55 MPH ENGINE SHUT DOWN. NO POWER BRAKES, STEERING, ETC. INDICATOR MESSAGE ON DASHBOARD SAID "CHECK ELECTRONIC IGNITION". REPAIR COST $ 724.19. *TR

Mileage: 125,000

WHILE DRIVING THE VEHICLE WENT INTO A HEAVY VIBRATION FROM THE MOTOR AND THE SMELL OF RAW FUEL WAS PRESENT. AFTER TURNING OFF THE VEHICLE IT WOULD NOT START. THE VEHICLE WAS TOWED TO THE FORD DEALER AND THE DEALER STATED THAT A FUEL INJECTOR BECAME STUCK OPEN. THE INJECTOR FILLED THE CYLINDER WITH FUEL AND CAUSED THE ENGINE TO BLOW UP (SEVERE DAMAGE). IT WAS FOUND THAT THIS OCCURRED ON FORD EXPEDITIONS NUMEROUS TIMES AND FORD EXTENDED THE WARRANTY TO 11 YEARS, 120,000 MILES AND MY SCARY EXPERIENCE OCCURRED AT 129,000. I PREVIOUSLY REPLACED THE MOTOR AT MY OWN EXPENSE 2 YEARS PRIOR AND FORD DID NOT REPLACE THE INJECTORS OR NOTIFY ME OF AN INJECTOR ISSUE. FORD IS STATING THAT THEY WILL NOT HONOR THE WARRANTY AND THE ENGINE DAMAGE WAS CAUSED BY THE INJECTOR THAT WAS NOT REPLACED. IT WAS FOUND THAT FORD WAS AWARE OF THE INJECTOR ISSUE SINCE 2007. I'M NOT SURE THESE ISSUE ARE GETTING REPORTED. *TR

Mileage: 129,000

VEHICLE CHECK ENGINE LIGHT STAYS ON. VEHICLE TURNS OFF WHEN SITTING IDLE. BROUGHT VEHICLE TO DEALERSHIP AND THEY SAID THEY FIXED IT, BUT AFTER LEAVING THE DEALERSHIP AND PAYING A LARGE BILL THE CHECK ENGINE LIGHT CAME BACK ON AND STILL CUTS OFF WHEN JUST SITTING IDLE IN "DRIVE". SCARED THAT THIS CAN CAUSE AN ACCIDENT IF SOMEONE BEHINDS ME DOESN'T REALIZE THAT MY VEHICLE CUTS OFF. *TR

Mileage: 144,239

I HAVE HAD AN ENGINE CHECK LIGHT AND NO ONE CAN FIND THE PROBLEM. SOME MECHANICS TELL ME ITS ONE THING AND THE OTHERS SOMETHING ELSE. TOOK TO A.V FORD AND QUICKLANE IN NORTH HOLLYWOOD. MY TRUCK STAYED SEVERAL DAYS AT SHOP AND STILL CANT FIND PROBLEM. MECHANIC EVEN CALLED DETROIT PLANT TO GET ADVISE. STILL NOT RESOLVED. PAID TOO MUCH JUST TRYING TO FIGURE THE PROBLEM. HAS THERE BEEN ANY ISSUES BROUGHT TO YOU ABOUT ENGINE LIGHT ON FOR FORD TRUCKS. I HAVE DOCUMENTS OF VISITS TO MECHANICS IF YOU GUYS NEED THEM. *TR

Mileage: 171,745

WHILE MOVING IN TRAFFIC THE VEHICLE ENGINE CUT-OFF ON ITS OWN. MESSAGE CAME UP ON DASH DISPLAY, SOMETHING ABOUT "ELECT THROTTLE CONTROL". WAS MOVING VERY SLOWLY ON AN INTERSTATE HIGHWAY BAD TRAFFIC, WITH HEATERS (FRONT AND BACK) AND THE RADIO ON. I WAS ABLE TO COAST OFF TO THE SIDE OF THE HIGHWAY. TURNED OFF RADIO, HEATERS, THEN WAS ABLE TO RESTART THE VEHICLE. BATTERY CONDITION WAS FINE (REPLACED 2 YEARS AGO), NO OTHER WARNING. VEHICLE IS WELL-MAINTAINED, NEVER DRIVEN HARD OR USED FOR TOWING. TODAY I AM TAKING IT TO A FORD DEALER FOR EVALUATION. *TR

Mileage: 111,520

FOR THE 3RD TIME IN THE PAST YEAR I AM DRIVING DOWN THE ROAD AT ABOUT 40 MPH - ENGINE LIGHTS COMES ON, MESSAGE "CHECK ELECTRONIC THROTTLE CONTROL" COMES ON - I HAVE NO POWER, I COAST TO THE SIDE LANE TURN ON HAZARD LIGHTS, TURN KEY TO OFF POSITION. RESTART THE CAR (TAKES A COUPLE OF TRIES) AND CONTINUE - THIS IS EXTREMELY DANGEROUS AND SHOULD BE ADDRESSED BY FORD ( I HAVE REPORTED THIS ISSUE) LOOKING ON LINE AND ON ONE SITE HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPEDITION/2005/ENGINE/VEHICLE_SPEED_CONTROL.SHTML THERE ARE 52 COMPLAINTS WITH THE SAME ISSUE. THERE ARE MANY OTHER SITES REPORTING THE SAME EXACT PROBLEM. I AM TAKING MY VEHICLE TO THE DEALER TOMORROW - WHAT ELSE SHOULD I BE DOING TO RESOLVE THIS ISSUE. - IT'S APPARENT THAT MANY OTHER PEOPLE ARE HAVING THIS SAME EXACT ISSUE- DOES IT TAKE SOMEONE DYING TO GET THE CAR MANUFACTURERS TO LISTEN TO THEIR CUSTOMERS? *TR

Mileage: 90,000

WHILE DRIVING ON THE HIGHWAY THE CAR COMPLETELY SHUT DOWN. ALL LIGHTS ON DASH LIT UP, RADIO WENT OFF. SECONDS LATER THE CAR RESTATED ITSELF AND THE RADIO WENT BACK ON. THIS HAPPENED TWICE ON 10/20/2014 AND ONCE ABOUT TWO WEEKS BEFORE THAT.. NO WARNING LIGHTS COME ON, NO BUMPS THE ROAD WAS SMOOTH, NO RAIN PUDDLES. IT JUST DIES AND RESTARTS ITSELF EACH TIME. FOR ABOUT 6 MONTHS NOW THE CAR DIES COMPLETELY WHEN I AM BACKING UP EVERY NOW AND THEN NOT EACH TIME. WE HAD 5 PEOPLE IN THE CAR AND GOT VERY SCARED. I HAVE HAD LOTS OF WORK DONE TO THE CAR AND HAVE RECEIPTS. MECHANIC SAID IT SOUNDS LIKE RAN ELECTRICS PROBLEM THAT COULD BE ONE OF A HUNDRED THINGS. PLEASE HELP WITH A SOLUTION. *TR

Mileage: 146,000

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. ADDITIONALLY AFTER RESTARTING THE VEHICLE, THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED ON TWO OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

Mileage: 103,000

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING ON AN INCLINE, THE VEHICLE STALLED AND THE ELECTRONIC THROTTLE CONTROL INDICATOR ILLUMINATED. THE ENGINE RESUMED NORMAL OPERATION AFTER THE VEHICLE WAS RESTARTED. THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 68,000.

Mileage: 68,000

ACCELERATED ENGINE TO PASS, ENGINE COUGHED AND HEAVED. THE RPM CLIMBED BUT VEHICLE ACTED LIKE IT WAS DYING. CAR EVENTUALLY DIED. TURNED CAR OFF RE- STARTED IT. CHK ENGINE LIGHT CAME ON. ENGINE RAN ROUGH WANTED TO RAMP UP IN RPMS BUT STILL ACTED LIKE IT WAS GOING TO DIE. (THIS IS NOT THE FIRST TIME, IT IS VERY INTERMITTENT) THE LAST TIME IT SEEMED SERIOUS AND CONTINUOUS THEY CHANGED THE TRANSMISSION. THE PROBLEM DID NOT LEAVE. I READ NUMEROUS POST ON THE WEB SITE AS THE PROBLEM CONTINUES TO COME BACK. NEVER SHOWING CODES. JUST RUNS LIKE CRAP. NUMEROUS IDENTICAL PROBLEMS ON THE INTERNET. BOUGHT A NEW MAF. NO HELP. REPLACED COIL PACKS NO HELP. CHECKED AND CLEANED VCT SOLENOIDS. NO HELP. REPLACED CAMSHAFT POSITION SENSOR. NO HELP. NO CHK ENG LIGHTS. WILL NOT EXCEED 3500 RPM. *TR

Mileage: 110,000

ELECTRONIC THROTTLE CONTROL HELP, I HAVE A 2005 EXPEDITION,. THE THING HAS JUST STARTED SHUTTING DOWN ON ME WHILE DRIVING. FOR NO APPARENT REASON, WHILE DRIVING ALONG, IT STOPS RUNNING, AND AFTER SHUTTING IT OFF, PLACING IT IN PARK, IT WILL START BACK UP. IT WAS SO SCARY , THANKS GOD I DIDN'T HAD ANY ACCIDENT ,THIS IS A BIG ISSUE FROM FORD *JS

Mileage: 85,000

VEHICLE DIED UNEXPECTEDLY WHILE TRAVELING DOWN HIGHWAY AT A HIGH RATE OF SPEED. THERE ARE HUNDREDS OF COMPLAINTS JUST LIKE THIS ON HERE. IF A RECALL ISN'T IN ORDER PEOPLE WILL DIE AND THE LAWSUITS WILL BEGIN. IT'S OBVIOUSLY A MAJOR MECHANICAL PROBLEM. FORD AND THE NHTSA SHOULD BE LIABLE. THIS IS SERIOUS AND READING THROUGH ALL OF THESE COMPLAINTS IT DOESN'T SEEM LIKE THE NHTSA IS DOING THEIR JOB. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE WRENCH ICON ILLUMINATED AFTER THE FAILURE OCCURRED. THE CONTACT COASTED ONTO THE SHOULDER AND WAS ABLE TO RESTART THE ENGINE. THE VEHICLE WAS LATER TAKEN TO THE DEALER, WHO PERFORMED A DIAGNOSTIC AND LOCATED THE FAILURE AT THE THROTTLE. THE THROTTLE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 117,000.

Mileage: 117,000

WHILE DRIVING 55MPH ON INTERSTATE 95 IN PHILADELPHIA, PA WITH MY WIFE AND 2 CHILDREN THE VEHICLE STOPPED RUNNING AND I WAS DANGEROUSLY STALLED IN THE MIDDLE OF INTERSTATE 95. THE CHECK ENGINE LIGHT CAME ON AND CHECK ELECTRONIC THROTTLE MESSAGE CAME ON. THIS IS A FAMILY VEHICLE AND MY WIFE AND I REFUSE TO DRIVE IT NOW IN FEAR OF THIS INCIDENT OCCURRING AGAIN RESULTING IN DEATH OR SERIOUS INJURY. BASED UPON MY RESEARCH, IT APPEARS TO BE A WELL KNOWN PROBLEM THAT OCCURRED TO THOUSANDS OF FORD EXPEDITION OWNERS. I WOULD APPRECIATE THE PROBLEM BEING ADDRESSED EXPEDITIOUSLY BEFORE PEOPLE ARE KILLED AND/OR INJURED. *TR

Mileage: 78,000

I HAVE SIX KIDS AND WHEN YOUR DRIVING AND YOUR CAR SHUTS OFF GOING 50-60 MILES AN HOURS AND GIVES YOU A MESSAGE FAIL SAFE MESSAGE, THAT'S PRETTY SCARY. I FIXED THE THROTTLE BODY SENSOR ONCE AND NOW HAVE ISSUES WITH THE SAME ISSUE. I HAVE LOOKED INTO THIS AND SURPRISED THAT THERE ARE NOT RECALLS. THIS IS ONE EXPENSIVE FIX. *TR

Mileage: 170,000

MY MOTHER HAD MY CAR WHEN THIS OCCURRED AND THE INCIDENT AND SUBSEQUENT RESEARCH SHOWING A DANGEROUS PATTERN AND NO RECALL OF THIS ISSUE HAS ME VERY CONCERNED. WHILE AT A RED LIGHT, THE ENGINE FAILSAFE MESSAGE FLASHED ACROSS THE DASH WITH THE ENGINE LIGHT ON WHILE MAKING LOUD ALERT BEEPS. THE ENGINE WAS STILL RUNNING BUT THE CAR WOULD NOT GO. MY MOTHER PUT IT IN PARK AND SHUT THE ENGINE OFF. SHE WAS ABLE TO RESTART THE CAR AND DRIVE WITH NO ISSUES. MY CONCERN DOING RESEARCH ON THIS ISSUE IS THAT THIS CAN OCCUR WHILE IN MOTION. IF THIS HAD HAPPENED A MINUTE EARLIER OR LATER, IT COULD HAVE RESULTED IN VERY SERIOUS ACCIDENTS DURING HIGH SPEEDS OR LEFT TURNS. I AM NOW ALMOST FEARFUL FOR MYSELF AND OTHERS TO DRIVE THIS CAR. *TR

Mileage: 144,500

I WAS DRIVING WITH 4 KIDS IN THE CAR, WHEN ALL THE SUDDEN MY CAR TURNED OFF, ALL THE LIGHTS CAME ON THE DASH. LUCKILY I WAS ABLE TO MOVE OVER TO A PARKING LOT. I TURNED THE CAR OFF, TURNED BACK ON, NOTHING. TRIED AGAIN AND IT WORKED. I WAS ABLE TO DRIVE 50 MILES HOME AND AS I WAS TURNING IN MY DRIVEWAY IT HAPPENED AGAIN. *TR

Mileage: 152,000

VEHICLE STOPPED RUNNING WHILE MAKING LEFT TURN AT INTERSECTION, VEHICLE STOPPED RUNNING WHILE AT STOP LIGHT, VEHICLE STOPPED RUNNING WHILE ON INTERSTATE HWY AT HIGHWAY SPEEDS. ALL THIS HAS HAPPENED MORE THAN 20 TIMES. *TR

Mileage: 85,000

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE. THE FIRE STARTED FROM UNDER THE REAR SEAT OF THE VEHICLE. THE VEHICLE WAS DESTROYED IN THE FIRE. A POLICE REPORT WAS FILED. THE CONTACT STATED THAT HIS MECHANIC BELIEVED THAT A FAILED CATALYTIC CONVERTER COULD HAVE POTENTIALLY CAUSED THE FIRE. THE FAILURE AND THE CURRENT MILEAGE WAS 98,300. *TR

Mileage: 98,300

I WAS DRIVING ON THE FREEWAY AT 60MPH AND THE ENGINE SHUT DOWN AND SHOWED "CHECK ELECTRIC THROTTLE CONTROL". I WAS NOT ABLE TO PULL TO THE SIDE. THE TRUCK WORKED FINE AFTER I RESTARTED IT. THIS HAS HAPPENED 5 TIMES. WE WERE LUCKY THAT NOBODY HIT US ON THE FREEWAY. THROTTLE BODY NEEDS TO BE REPLACED. 3 DIFFERENT MECHANICS AND 1 ELECTRICIAN SAID THIS A DEFECT AND THEY SEE IT ALL THE TIME WITH THIS ENGINE. *TR

Mileage: 152,873

I WAS DRIVING DOWN THE HIGHWAY GOING 65 & MY TRUCK COMPLETELY SHUT DOWN WAS ALMOST HIT BY A SEMI. A WRENCH SIGN CAME ON, I PUT IT IN PARK & SHUT IT OFF & STARTED IT BACK UP. THIS HAPPENS ALL THE TIME. I BELIEVE SOMETHING SHOULD BE DONE BEFORE SOMEONE GETS KILLED,FROM WHAT IM READING ITS HAPPENS TO ALOT OF OWNERS. SO PLEASE FOR OUR SAFETY DO SOMETHING DON'T WAIT TILL ITS TO LATE. *TR

Mileage: 120,000

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED AND THE ENGINE FAIL SAFE MODE WARNING MESSAGE ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,000. *TR

Mileage: 125,000

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ENGINE SHOOK. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE VARIABLE CAM TIMING PHASER HAD FAILED AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 130,000.

Mileage: 130,000

GETTING ON FREEWAY AN AUDIBLE BIP AND A WARNING CAME ON SCREEN INDICATING TO CHECK ELECTRIC THROTTLE AND A FEW SECONDS LATER THE ENGINE DIED. EXTREMELY DANGEROUS. HAD KIDS IN CAR. THIS SHOULD BE A MATTER FOR RECALL. *TR

Mileage: 79,900

FAILURE OF CAM SHAFT AND VALVE, LIFTER PARTS ASSOCIATED WITH THE RIGHT SIDE OF THIS 5.4L ENGINE. MOST LIKELY DUE TO VARIABLE CAM TIMING UNITS. 5.4 L ENGINE IN 2005 EXPEDITION, FIRST PLACED IN SERVICE IN DECEMBER 2004. RIGHT SIDE OF ENGINE BEGAN MAKING A TICKING NOISE WITHIN 30,000 MILES. DEALER SERVICE STATED TICKING NOISE IS NORMAL, NO ISSUES. NOISE CONTINUED. NOISE RECENTLY BECAME WORSE. RIGHT SIDE OF ENGINE. MILEAGE FOR VEHICLE IS AT 142,000 MILES. INDEPENDENT MECHANIC STATES HYDRAULIC LIFTER ISSUE, CAM SHAFT IS BAD. $1,200+ REPAIR. DOING RESEARCH ON VARIOUS CAR SITES REVEALS MANY ISSUES SIMILAR TO THIS WITH THE 5.4L FORD ENGINE. ISSUES STATED DEALT WITH: DEFECTIVE CYLINDER HEADS, FAILING CAM PHASERS, CAMSHAFT BEARINGS FAILING, FAILED CAM SOLENOIDS, THRUST BEARING FAILURE, VARIABLE CAM TIMING (VCT) FAILURE AND CAM SHAFT FAILURE DUE TO OTHER PARTS. THIS DEFECT SEEMS TO BE COVERED IN A TB PUT OUT BY FORD (TSB 05-15-8), BUT DID NOT INVOLVE A RECALL. THIS ISSUE HAS AFFECTED 100'S IF NOT 10,000'S OF EXPEDITION OWNERS. INITIATE AN INVESTIGATION AND I BELIEVE THAT YOU WILL AGREE FORD SHOULD ISSUE A RECALL TO REPAIR OR REPLACE. *TR

Mileage: 25,000

WE HAVE HAD THREE INCIDENTS OF UNEXPECTED ACCELERATION ON OUR FORD EXPEDITION. ONCE WITH MY DAUGHTER AND THREE GRANDCHILDREN AND TWICE WITH MYSELF. I HAVE CONTACTED FORD AND THEY SAY THERE IS NO KNOWN VEHICLE PROBLEM AND ONLY OFFERED TO HAVE IT TOWED TO A FORD DEALER AND I WILL BE RESPONSIBLE FOR THE COST OF THE REPAIR. IF FORD IS CORRECT AND THERE IS NO KNOWN PROBLEM, THEN WHY WOULD FORD BE WILLING TO PAY THE COST OF TOWING THE VEHICLE TO A DEALERSHIP? I SPOKE WITH FORD CUSTOMER SERVICE ON MARCH 5TH AND TODAY APRIL 1ST. [XXX] A FORD CUSTOMER SERVICE MANAGER STATED THE ABOVE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 125,000

THE ENGINE JUST STALLED AND THE MESSAGE "ENGINE FAIL SAFE MODE" APPEARED. LUCKILY WE WERE RIGHT AT A PARKING LOT THAT WE ROLLED INTO WITH MY HUSBAND STEERING. WE HAD JUST PULLED OFF THE INTERSTATE TRAVELING 65 MPH. IT COULD HAVE RESULTED IN INJURIES AND/OR DEATH. FORD SHOULD FIX THIS PROBLEM. *TR

Mileage: 111,920

WHILE DRIVING AT 40 MPH ENGINE STOPPED WORKING MAKING BRAKES AND STEERING FAIL. LIMPED OFF BUSY ROAD LUCKILY! ENGINE LIGHT SHOWED ELECTRONIC THROTTLE FAILURE. NOW CHECK ENGINE LIGHT IS ON. GOING TO DEALERS FOR REPAIR TODAY-SINCE THIS IS AN OBVIOUS PROBLEM FOR FORD WHY HAVEN'T THEY ADDRESSED IT! COULD BE DEADLY IF FAILS IN HEAVY TRAFFIC CONDITIONS. *TR

Mileage: 88,000

ENGINE SHUTS OFF WHILE DRIVING. *TR

Mileage: 35,000

ENGINE FAILSAFE MODE CAME ON IN THE MIDDLE OF DRIVING AND THE TRUCK JUST SHUT OFF IN THE MIDDLE OF THE ROAD. I HAD TO TURN IT OFF AND RESTART IT...IT HAPPENED THREE TIMES IN ONE TRIP. *TR

WAS DRIVING AROUND 40 MILES PER HR AND ENGINE JUST QUIT. NO POWER STEERING. WARNING LIGHT CAME ON REGARDING THROTTLE. LUCKILY WE WERE NOT ON THE INTERSTATE AND COULD PULL OVER. MY SON WILL BE TURNING 16 IN A FEW MONTHS AND HE WAS GOING TO BE DRIVING THIS. NOW WE ARE WORRIED. THERE ARE SO MANY COMPLAINTS ON LINE. FORD NEEDS TO RECALL THIS. SOMEONE WILL END UP BEING HURT OVER THIS. I HAVE SEEN THAT REPLACING THROTTLE DOES NOT FIX IT. WE TURNED CAR OFF AND RESTARTED IT AND IT WORKED FINE. YOU DO NOT KNOW WHEN THIS WILL HAPPEN. *TR

Mileage: 83,000

FIRST TIME IT OCCURRED I WAS TRAVELING TO WORK THE CAR STALLED WHILE DRIVING APPROX. 20 MPH AND THERE WAS NO CONTROL OF THE CAR - WAS ABLE TO MOVE TO SIDE OF ROAD AND RESTART. FAULT ON THE CONSOLE WAS "ELECTRONIC THROTTLE". HAS HAPPEN APPROX 4 MORE TIMES AT VARIOUS SPEEDS AND CONDITIONS WITH THREE DIFFERENT DRIVERS. NO PROBLEM EVER FOUND BY DEALER. HAS HAPPENED AT HIGH SPEED ON THE FREEWAY COMPLETE LOSS OF STEERING AND POWER OCCURS MORE CONCERNING IT CAN HAPPEN AT ANY TIME WITHOUT WARNING. I FIND THIS TO BE EXTREMELY DANGEROUS AND A DEATH TRAP WAITING TO HAPPEN. THE LAST TIME IT OCCURRED WHEN BY TEENAGE DAUGHTER WAS DRIVING SHE WAS SCARED TO DEATH REFUSING TO DRIVE IT HOME. THIS REMINDED ME OF TOYOTA PRIUS SO I TOOK IT UPON MYSELF TO REPORT MY INCIDENTS. LOOKING AT THE INTERNET I NOW FIND IT OCCURS FREQUENTLY AND IT IS NOT AN ISOLATED CASE. *TR

Mileage: 10,000

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND THE ENGINE FAIL SAFE MODE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AS IT RESUMED NORMAL FUNCTION. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 25,000. UPDATED 11/13/12 *CN UPDATED 11/27/2012 *JS

Mileage: 25,000

I WAS DRIVING, WHEN I TRIED TO FURTHER ACCELERATE, THE CAR DID NOT RESPOND AND A WARNING " CHECK ELECTRONIC THROTTLE CONTROL". I PULLED OVER AND WAS ABLE TO RESTART THE CAR AND CONTINUE TO DRIVE AS NORMAL. THE INTERNET INDICATES THIS IS A COMMON PROBLEM IN 2005 EXPEDITIONS. THIS IS OBVIOUS A HIGHLY DANGEROUS SITUATION TO NOT BE ABLE TO ACCELERATE WHILE ALREADY DRIVING. *TR

Mileage: 46,600

I WAS DRIVING DOWN THE CENTER LANE ON RT 41 IN PORT CHARLOTTE, WITH AN APPROXIMATE SPEED OF 45 MPH, WHEN THE ENGINE JUST SHUT DOWN. THIS IS NOT THE FIRST TIME IT HAPPENED TO ME, AND IT'S VERY DANGEROUS. I HAD TO MANEUVER CAREFULLY TO PULL OVER TO THE SIDE OF THE ROAD, WITH CARS BEEPING, AND SWERVING AROUND ME. I TRIED TO RESTART THE VEHICLE, BUT KEPT GETTING AN "ENGINE FAIL SAFE MODE" MESSAGE. I SAT FOR A WHILE ON THE SIDE OF THE ROAD FOR ABOUT 5 MINUTES, AND WHEN I TRIED RESTARTING THE TRUCK, IT MIRACULOUSLY STARTED. ON MONDAY, SEPTEMBER 17, 2012, I WENT OUT TO START MY VEHICLE SO I COULD BRING IT IN TO MY MECHANIC, AND IT WOULDN'T START. I HAD TO HAVE IT TOWED TO HIS SHOP. HE INFORMED ME THAT HE HAS SEEN THIS PROBLEM MANY TIMES WITH THIS VEHICLE. HE ALSO TOLD ME THAT PEOPLE WERE ON THE HIGHWAY WHEN THE VEHICLE SHUT DOWN ON THEM, AND HAS CAUSED ACCIDENTS. HE RESET THE CODE FOR THE THROTTLE BODY, AND THE TRUCK RAN FINE. AFTER DOING AN INTERNET SEARCH ON THIS PROBLEM, I SEE THAT THERE ARE MULTIPLE COMPLAINTS ABOUT THIS DANGEROUS PROBLEM. I ALSO CONTACTED FORD TO SEE IF THERE WAS A RECALL FOR THIS PROBLEM, AND THEY SAID THERE WASN'T. I AM AFRAID TO DRIVE THE TRUCK NOW, FOR FEAR THAT IT IS GOING TO SHUT DOWN IN A BUSY INTERSECTION. HOPEFULLY FORD WILL STEP UP TO THE PLATE AND DO A RECALL FOR THIS PROBLEM. *TR

Mileage: 116,224

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE ENGINE STALLED WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE ENGINE FAILURE MODE LIGHT ILLUMINATED AFTER THE FAILURE OCCURRED. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHO REPLACED THE FUEL FILTERS AND THE INJECTOR BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER, WHERE A DIAGNOSTIC TEST WAS PERFORMED AND LOCATED THE FAILURE AT THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 18,005 AND THE CURRENT MILEAGE WAS 119,000.

Mileage: 18,005

WARNING LIGHT SAID ELECTRONIC THROTTLE CONTROL, THIS IS THE THIRD TIME I HAVE ALMOST HAD A MAJOR ACCIDENT AND FORD TELLS ME TO CALL THEM WHEN I HAVE AN ACCIDENT OR THE CODE SHOWS BACK UP. THEY ADMIT THAT THEY ARE AWARE OF THIS ISSUE BUT IT MUST FAIL COMPLETELY BEFORE IT CAN BE REPLACED UNDER WARRANTY OR RECALL. ALSO THE TRUCK CUTS OUT AT 60MPH AND JERKS UNTIL YOU SPEED UP. THEY ADVISED THEY ARE ALSO AWARE OF THIS PROBLEM AND COME BACK WHEN IT BREAKS DOWN. *TR

Mileage: 102,000

WHILE DRIVING ON ROAD IN TRAFFIC, THE ENGINE WAS BUCKING AND TURNING OFF, CAUSING TRAFFIC TO SWERVE AROUND ME UNTIL I COULD GET OFF THE ROAD. WARNING LIGHT SAID ELECTRONIC THROTTLE CONTROL. TOOK TO DEALER FOR INSPECTION. *TR

Mileage: 97,000