2002 FORD EXPLORER SPORT TRAC Engine And Engine Cooling Problems

THE BODY MOUNTS ON THE VEHICLE ARE DESINTEGRATING. I TOUCHED IT WITH MY HAND AND IT FELL APART. BODY MOUNTS SHOULD LAST MUCH LONGER. *TR

Mileage: 91,000

TL* THE CONTACT OWNS A 2002 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTOMOTIVE REPAIR SHOP WHERE A MECHANIC PERFORMED A DIAGNOSTIC TEST AND DETECTED A MALFUNCTION IN THE EMISSIONS CONTROL SYSTEM. THE MANUFACTURER HAD ISSUED A VOLUNTARY RECALL FOR THE EMISSIONS CONTROL SYSTEM HOWEVER, THE CONTACT'S VEHICLE WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 161,673.

Mileage: 161,673

I BOUGHT A 2002 FORD EXPLORER SPORT TRAC NEW. SHORTLY AFTER HAVE ELECTRIC WINDOW PROBLEMS DRIVERS DOOR BACK PASSENGER WINDOW AND NOW THE PASSENGER DOOR WINDOW, BAD BODY MOUNTS,AND IDLES BAD WHEN IN PARK OR STOPPED AT A RED LIGHT. RPM'S 500 TO 1000 BACK DOWN TO 500-400. 2002 HAD A BABY GIRL 1 1/2 YEARS AND ANOTHER ON THE WAY NEEDED A 4 DOOR AND ALSO FOR WORK. I KICK MY SELF EVERY DAY THAT I HAVE OWNED IT BUT HAD NO CHOICE MONEY WAS TIGHT AND STILL IS COULD NOT AFFORD EVERY TIME GETTING THINGS FIXED SO I LIVED WITH IT!!!! UNTIL I FOUND THIS WEB PAGE I AM FED UP I HAVE ALWAYS OWNED FORD BUT AFTER THIS IM NOT SO SURE ANYMORE! AND READING OTHER PEOPLES WITH THE SAME PROBLEMS THE SPORT TRAC IS ONE BIG LEMON!!!!!! *TR

TL*THE CONTACT OWNS A 2002 FORD EXPLORER SPORT TRAC. WHILE DRIVING 40 MPH, THE OXYGEN SENSOR CAUSED THE CHECK ENGINE LIGHT TO ILLUMINATE AND THE CRUISE CONTROL FAILED AT 40,000 MILES. THE DEALER PROMISED OVER THE PHONE TO REPAIR BOTH THE RECALL AND THE ENGINE LIGHT, BUT LATER DENIED SERVICE BECAUSE THE VEHICLE WAS 24,000 MILES OVER THE LIMIT TO REPAIR THE OXYGEN SENSOR. THE TECHNICIAN DISCONNECTED THE CRUISE CONTROL SWITCH TO PREVENT A FIRE FROM OCCURRING UNTIL THE PARTS FOR THE RECALL WERE AVAILABLE. A YEAR HAS PASSED AND THE DEALER STILL DOES NOT HAVE THE PARTS FOR THE REPAIR. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 56,000 AND FAILURE MILEAGE WAS 40,000.

Mileage: 40,000

I BOUGHT THIS TRUCK ON FEBRUARY 20TH, 2004 WITH A LITTLE OVER 20,000 MILES. ON FEBRUARY 24TH, 2004, AFTER LEAVING THE DEALERSHIP MY TRUCK DIED ON A BUSY STREET ON TWO SEPARATE OCCASIONS. THE SALESMAN TOLD ME THAT THE TRUCK HAD FLOODED. ON JUNE 10TH, AUGUST 12TH, NOVEMBER 19TH, AND AGAIN ON DECEMBER 2ND, 2004 (THE ONLY ONES I WROTE DOWN  IT DOES HAPPEN MORE OFTEN) MY TRUCK ALSO DIED WHILE DRIVING DOWN THE ROAD. THESE HAVE ALL BEEN VERY SERIOUS INCIDENTS WHERE I FELT LUCKY TO NOT ONLY BE ALIVE BUT THAT I HADNT HIT ANYTHING OR ANYONE ELSE. THE TECHNICIANS FROM THE DEALERSHIP HAVE LOOKED AT MY TRUCK ON ALL THESE OCCASIONS AND GAVE ME LITTLE OR NO EXCUSE FOR THE TRUCK TO DIE. AT THIS TIME IVE ASKED FOR A REASONABLE REFUND  WITH NO SUCCESS&&IM AT A LOSS&&&PLEASE HELP!!!!*AK

Mileage: 29,700

WHILE DRIVING VEHICLE STALLED. THE CONSUMER PULLED OVER AND RESTARTED THE VEHICLE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 33,000

PROBLEMS WITH VEHICLE ENGINE STALLING WHILE DRIVING. *MR THIS WAS AN INTERMITTENT PROBLEM. THERE WOULD BE NO WARNING. *SC *JB

I PURCHASED A FORD EXPLORER SPORT TRAC IN DEC. 2002. I HAVE BEEN IN AND OUT OF THE SERVICE DEPARTMENT A NUMBER OF TIMES. THE FOLLOWING IS A LIST OF ITEMS THAT I'VE HAD REPAIRED UNDER WARRANTY: 1.) FRONT BRAKES: A LOUD RUBBING/GRIDING SOUND BECAME INCREASINGLY LOUDER. THE FIRST TIME THE SERVICE DEPT. FOLKS SAID THAT IT WAS NORMAL. THE NEXT TIME I BROUGHT THE CAR IN, THEY COULD DENY THE NOISE AND THEY SUBSEQUENTLY REPLACE ONE ROTOR AND RESURFACED THE OTHER. 2.) REAR AXLE: A BROKEN SEAL ALLOWED HYDROULIC FLUID TO COVER INSIDE OF THE REAR WHEEL CAUSING DIFFICULTY IN BRAKING. THE SERVICE DEPT. REPAIRED UNDER WARRANTY 3.) THE TRANSFER CASE FOR THE 4-WHEEL DRIVE WAS LEAKING FLUID. THE SERVICE DEPT. REPAIRED UNDER WARRANTY. 4.) THE VEHICLE STALLS A NUMEROUS AMOUNTS OF TIMES (10-15 TIMES) SINCE I'VE OWNED IT. IT STALLS WHILE I'M DRIVING AT 35 MILES PER HOUR, IN REVERSE, DAY OR NIGHT. WHEN I GO FOR AN ERRAND AND PARK, THE VEHICLE WILL NOT START. AN HOUR LATER, WHEN THE TOW TRUCK IS THERE, THE VEHICLE START. IT DRIVES ME CRAZY!! THE SERVICE DEPT. SAYS THEY CANNOT DO ANYTHING BECAUSE NOTHING REGISTERS ON THE COMPUTER AND THEY CANNOT SIMULATE THE PROBLEM. THE LAST TIME IT HAPPENED (08-04-04) MERGING ON TO THE FREEWAY IT STALLED. UPON START-UP, BLACK SMOKE POURED OUT OF THE EXHAUST AND IDLING WAS EXTREMELY ROUGH. I HAD IT TOWED TO A FORD DEALERSHIP. THE SERVICE DEPT REPLACED A MASS AIRFLOW METER UNDER WARRENTY. THE VEHICLE RUNS...I'LL CROSS MY FINGERS!! MY CURRENT PROBLEM IS THAT THE FRONT TIRES ARE SEVERLY CUPPING AND THE FRONT END VIBERATES AT 60 MPH AND OVER. THE VEHICLE HAS 25K MILES AND THE TIRES HAVE BEEN ROTATED 5 TIMES ABOUT EVERY 5K MILES. I HAD THE WHEELS CHECKED FOR ALIGNMENT AND BALANCE AND IT IS TO SPECIFICATIONS. THE SERVICE DEPT SAYS ITS NORMAL AND TO CONTINUE WITH THE ROTATIONS. THE TIRES ARE WEARING UNEVENLY AND PREMATURELY. THE TIRE SHOP RECOMMENDS THAT THE SHOCKS AND STRUTS BE REPLACED. THE SERVICE DEPT DOES NOT.*AK

Mileage: 500

MY 2002 FORD EXPLORER SPORT TRAC STALLS WHEN GOING DOWN THE ROAD. IT'S LIKE YOU'RE TAKING YOUR FOOT OFF THE GAS AND BACK ON IT AGAIN EXCEPT THAT ISN'T WHAT I'M DOING. TODAY IT DID THAT AND THEN WENT DEAD WHILE DRIVING DOWN THE ROAD. I TOOK IT TO THE FORD PLACE BUT THEY SAID WITH NO LIGHTS ON IT WOULDN'T DO ANY GOOD TO HOOK IT UP TO A MACHINE. THEY SAID IT COULD BE ANYTHING FROM ELECTRONICS, FUEL PUMP, ETC. MY WARRANTY RUNS OUT IN ABOUT 4,500 MILES. THIS HAS BEEN GOING ON FOR ABOUT A YEAR WITH THE STALLING OUT BUT THIS WAS THE FIRST TIME IT ACTUALLY WENT DEAD WHILE DRIVING DOWN THE ROAD. I WOULD ESTIMATE THAT OVER THE PAST YEAR THAT IT HAS STALLED AT LEAST 25 SEPARATE OCCASIONS BUT ONLY 1 TIME SO FAR DID IT GO DEAD. *NM

Mileage: 32,000

WHILE DRIVING 65 AND ATTEMPTING TO PASS ANOTHER VEHICLE CONSUMER'S VEHICLE FAILED TO GO INTO PASSING GEAR. ENGINE STALLED AND CONSUMER HAD TO COAST TO THE SIDE OF THE HIGHWAY. ONCE OFF THE ROAD CONSUMER RESTARTED THE VEHICLE AND CONTINUED DRIVING. *AK THE VEHICLE WAS TOWED TO THE DEALER BUT THE TECHNICIAN COULDN'T FIND ANYTHING WRONG. THE VEHICLE WAS TAKEN BACK TOT HE DEALER WHERE THEY REPLACED THE FUEL PUMP, GAS TANK AND AIR FLOW SENSOR. SO FAR THE VEHICLE HAS BEEN RUNNING AS IT SHOULD. THE HEAT SHIELD UNDER THE VEHICLE RATTLED. THE DEALER ADJUSTED IT. THE MULTIFUNCTION SWITCH WOULD NOT LOCK IN PLACE WHEN USING THE TURN SIGNALS. *NM

Mileage: 16,240

I BOUGHT A FORD EXPLORER SPORT TRAC IN AUG. OF 2002. EVER SINCE IT WAS A YEAR OLD I HAVE HAD NOTHING BUT PROBLEMS WITH IT. I HAD IT 6 TIMES FOR THE SAME ISSUE, THEY REPLACED THE SAME PART 4 TIMES, THAT DID NOT HELP. THEY FINALLY CALLED THE FORD HELP LINE AND FOUND OUT THEY NEEDED TO REPLACE THE WHOLE GAS TANK. MY TRUCK THE FIRST TIME LOST ALL POWER WHILE DRIVING DOWN THE ROAD, I SHUT IT OFF AND IT RESTARTED FINE. I TOOK INTO THE DEALERSHIP AND THEY HAD TO RE-PROGRAM THE MAIN COMPUTER CHIP. NEXT, MY TRUCK WOULDN'T START UNLESS HOLDING DOWN THE GAS PEDAL THEN FINALLY IT WOULD START AND THERE WOULD BE A BLACK SMOKE CLOUD THAT WOULD COME OUT OF THE TAIL PIPE EACH TIME. THE NEW GAS TANK FINALLY FIXED THIS PROBLEM! NOW I HAVE OTHER ISSUES WITH A NOISE IN THE ENGINE AND WHEN I FIRST START IT UP AND BACK OUT OF THE GARAGE OR PARKING SPACE IT SPUTTERS THEN ONCE IN DRIVE IT IS OK, ALSO WHEN SHIFTING AFTER 40MPH IT HAS A HARD SHIFT INSTEAD OF A SMOOTH ONE. STILL TRYING TO GET IT FIXED.*AK

Mileage: 11,000

WHILE DRIVING AT ANY SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *LA

Mileage: 22,288

CONSUMER COMPLAINED ABOUT A STALLING PROBLEM. VEHICLE WAS TAKEN TO DEALER. HOWEVER, THE PROBLEM HAD NOT BEEN CORRECTED. ALSO, RIGHT REAR DOOR LOCKS MALFUNCTIONED, AND DOOR COULDN'T BE OPENED EXCEPT FROM THE OUTSIDE. *AK

Mileage: 19,900

WHILE DRIVING AT ANY SPEED VEHICLE INTERMITTENTLY STALLED. CONSUMER MADE CONTACT WITH THE DEALERSHIP. THE CAUSE OF FAILURE WAS NOT IDENTIFIED AT THIS TIME. HOWEVER, FLOOR MANAGER SUGGESTED THAT FOR ANOTHER $125.00 CONSUMER COULD HAVE A NICE AND DECENT NEW CAR". *AK

Mileage: 2,500

ALL FOUR TIRES WERE SLIGHTLY CUPPING, AND THE BRAKES MADE A THUMPING NOISE WHEN THEY WERE DEPRESSED. DEALERSHIP REPLACED THE PADS, LUBED THE FRONT CALIPER SLIDE PIN, AND REPLACED ROTORS. *AK VEHICLE EXPERIENCING PROBLEMS WITH TIRES CUPPING. THE FOLLOWING REPAIRS WERE PERFORMED ON THE VEHICLE: ENGINE REPLACED, BRAKES, REPLACED, ALIGNMENT, BATTERY WIRING ASSEMBLY REPAIRED, DPFE SENSOR REPLACED. CONSUMER ASKED DEALER FOR A FULL REFUND ON VEHICLE.*MR

Mileage: 12,023

THE VEHICLE MUST BE DRIVEN WITH THE WINDOWS DOWN BECAUSE CHEMICAL FUMES ENTER INTO THE PASSENGER'S COMPARTMENT. THE DEALER INSPECTED THE VEHICLE SEVERAL TIMES, AND COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK THE CATALYTIC CONVERTER WAS REPLACED AND RESET BUT THE PROBLEM REMAINED THE SAME. *SCC *JB

WHILE MERGING ONTO A FREEWAY, COULDN'T GET OVER 2,000 RPM AND THUS COULDN'T GET ENOUGH SPEED TO MERGE ON AT OVER 25MPH. VEHICLE STALLED SEVERAL TIMES WHILE TRYING TO GET OFF THE FREEWAY. NEW VEHICLE HAS 10812 MILES. FORD MAINTENANCE DEPT STATED THEY COULDN'T FIND ANYTHING WRONG, IT RAN FINE FOR THEM. MY HUSBAND WENT TO PICK UP THE VEHICLE AND IN DRIVE IT RAN, IN NEUTRAL COULDN'T GET MORE THAN 2,000 RPM, MECHANIC SAID IT WAS THE GOVERNOR, NEEDLESS TO SAY, MY HUSBAND SAID FIX THE CAR. THEY STILL HAVE MY TRUCK.*AK

Mileage: 10,812

WHILE DRIVING AT VARIOUS SPEEDS BLACK SMOKE WOULD CAME FROM THE TAIL PIPE. CONSUMER COULD SMELL GAS FUMES INSIDE THE VEHICLE. .*AK DRIVERS REAR DOOR WILL NOT OPEN FROM THE INSIDE. DRIVERS SIDE SEAT MOLDING IS FALLING OFF. CENTER DUCT LOOSE ON DASH. DRIVERS SEAT CUSHION LOST ITS FORM. *TS

Mileage: 16,573

4405 MILES, 9:05 A.M., SEPTEMBER 1, 2002, CAR STALLED AGAIN. *JB

Mileage: 4,372

ENGINE STALLED AT 4683 MILES ON THE ODOMETER. DATE: 7 OCTOBER 2002. I NOTED THAT IT NOW IDLES AT 600 RPM. I DON'T KNOW WHAT THAT MEANS. *JB

Mileage: 4,683

I HAVE EXPERIENCED THE SAME PROBLEM WITH GAS SPEWING OUT OF TANK WHEN REFUELING. THIS IS MY SECOND SPORT TRAC. FORD BOUGHT BACK MY FIRST ONE BECAUSE THEY COULDN'T FIX ONGOING ENGINE PROBLEMS THAT STARTED OFF AS A ROUGH IDLE PROBLEM. THEY EVEN REPLACED THE ENGINE, AND SURPRISINGLY THAT MADE THINGS WORSE. I HAVE HAD MY NEW VEHICLE SINCE THE END OF JULY AND HAVE EXPERIENCED SIMILAR ROUGH IDLE PROBLEMS RECENTLY.*JB

NO SUMMARY. DT

BODY MOUNTS ON LEFT FRONT OF VEHICLE KEEP COMING LOOSE. VEHICLE TAKEN TO DEALER NUMEROUS TIMES, DEALER WILL TIGHTEN THE BODY MOUNTS. FORD IS BUYING VEHICLE BACK.*AK