2003 FORD EXPLORER SPORT TRAC Problems, Recalls & Safety Ratings

Sep 14, 2021 Service Brakes

drivers side rear brake line developed a hole caused by the emergency brake cable rubbing against it causing all the brake fluid to leak & the brakes failed. Fortunately my husband was driving on our rural road & not out on the main highway. We have not been able to get it repaired yet.

Sep 14, 2021 Service Brakes

drivers side rear brake line developed a hole caused by the emergency brake cable rubbing against it causing all the brake fluid to leak & the brakes failed. Fortunately my husband was driving on our rural road & not out on the main highway. We have not been able to get it repaired yet.

Jun 15, 2021 Air Bags Crash

The driver was driving down the expressway and her back tire blew out causing her vehicle to spiral out of control and the vehicle then flipped and started rolling downhill, the vehicle airbags did not deploy in the vehicle at all. The driver and her mother are in critical condition. Yes, the safety...

Jun 15, 2021 Air Bags Crash

The driver was driving down the expressway and her back tire blew out causing her vehicle to spiral out of control and the vehicle then flipped and started rolling downhill, the vehicle airbags did not deploy in the vehicle at all. The driver and her mother are in critical condition. Yes, the safety...

Aug 1, 2019 Fuel/propulsion System

TAKATA RECALL .. THE SMELL OF FUEL INSIDE THE CAB AND OUTSIDE IS REALLY BAD. IT'S MAKING ME SICK AND GIVING ME HEADACHES. THE TRUCK DOESN'T RUN RIGHT AND THE MILEAGE IS AWFUL.

Aug 1, 2019 Fuel/propulsion System

TAKATA RECALL .. THE SMELL OF FUEL INSIDE THE CAB AND OUTSIDE IS REALLY BAD. IT'S MAKING ME SICK AND GIVING ME HEADACHES. THE TRUCK DOESN'T RUN RIGHT AND THE MILEAGE IS AWFUL.

Jan 23, 2018 Suspension 176,000 mi

WE HAD PURCHASED THIS VEHICLE BOUT A YEAR AGO AND WHEN WE GOT IT WE WENT TO GET TIRES AND FRONT END ALIGNMENT AND THEY ENDED UP REPLACING UPPER ND LOWER BALL JOINTS, CONTROL ARM AND SWAY BAR ON PASSENGER SIDE.THIS WAS 6/20/2017. IT WASN'T MAKING ANY NOISE UNTIL 1/3/2018. I WAS GOING DOWN CITY STREET...

Jan 23, 2018 Suspension 176,000 mi

WE HAD PURCHASED THIS VEHICLE BOUT A YEAR AGO AND WHEN WE GOT IT WE WENT TO GET TIRES AND FRONT END ALIGNMENT AND THEY ENDED UP REPLACING UPPER ND LOWER BALL JOINTS, CONTROL ARM AND SWAY BAR ON PASSENGER SIDE.THIS WAS 6/20/2017. IT WASN'T MAKING ANY NOISE UNTIL 1/3/2018. I WAS GOING DOWN CITY STREET...

Oct 16, 2017 Structure

THE CAB TO FRAME MOUNTING BOLT BUSHINGS, AND STEERING STABILIZER BUSHINGS ARE HAVE AND ARE CRUMBLING. ALL NEED TO BE REPLACED. I FEEL FORD IS AWARE OF THIS PROBLEM AND SHOULD HAVE TO FIX IT. I JUST INHERITED THIS TRUCK AND JUST FOUND OUT ABOUT THIS. THANK YOU.

Oct 16, 2017 Suspension

THE CAB TO FRAME MOUNTING BOLT BUSHINGS, AND STEERING STABILIZER BUSHINGS ARE HAVE AND ARE CRUMBLING. ALL NEED TO BE REPLACED. I FEEL FORD IS AWARE OF THIS PROBLEM AND SHOULD HAVE TO FIX IT. I JUST INHERITED THIS TRUCK AND JUST FOUND OUT ABOUT THIS. THANK YOU.

Oct 16, 2017 Structure

THE CAB TO FRAME MOUNTING BOLT BUSHINGS, AND STEERING STABILIZER BUSHINGS ARE HAVE AND ARE CRUMBLING. ALL NEED TO BE REPLACED. I FEEL FORD IS AWARE OF THIS PROBLEM AND SHOULD HAVE TO FIX IT. I JUST INHERITED THIS TRUCK AND JUST FOUND OUT ABOUT THIS. THANK YOU.

Oct 16, 2017 Suspension

THE CAB TO FRAME MOUNTING BOLT BUSHINGS, AND STEERING STABILIZER BUSHINGS ARE HAVE AND ARE CRUMBLING. ALL NEED TO BE REPLACED. I FEEL FORD IS AWARE OF THIS PROBLEM AND SHOULD HAVE TO FIX IT. I JUST INHERITED THIS TRUCK AND JUST FOUND OUT ABOUT THIS. THANK YOU.

Dec 3, 2016 Power Train 135,000 mi

TRUCK WAS RUNNING FINE. THEN ON SEVERAL OCCASIONS IT WOULD SLIP OUT OF GEAR WHILE I WAS COMING OFF OF OR ONTO EXIT RAMPS. SEEMED LIKE AS THE ENGINE DECELERATED IT WOULD SLIP INTO NEUTRAL. SOMETIMES IT WOULD EVENTUALLY FIND THE GEAR AND SOMETIMES I HAD TO COME TO A COMPLETE STOP, WHICH WAS REALLY SCA...

Dec 3, 2016 Power Train 135,000 mi

TRUCK WAS RUNNING FINE. THEN ON SEVERAL OCCASIONS IT WOULD SLIP OUT OF GEAR WHILE I WAS COMING OFF OF OR ONTO EXIT RAMPS. SEEMED LIKE AS THE ENGINE DECELERATED IT WOULD SLIP INTO NEUTRAL. SOMETIMES IT WOULD EVENTUALLY FIND THE GEAR AND SOMETIMES I HAD TO COME TO A COMPLETE STOP, WHICH WAS REALLY SCA...

Apr 4, 2015 Air Bags 153,718 mi

I WAS LEAVING THE STORE PARKING LOT. I STARTED THE CAR, PRESSED THE BREAK, PUT THE VEHICLE IN DRIVE AND THE PASSENGER SIDE AIRBAG DEPLOYED. THIS IS THE SECOND TIME THIS HAS HAPPENED SINCE THE FIRST INCIDENT IN SEPTEMBER 2014. THE VEHICLE WAS NOT HIT OR BUMPED IN ANY WAY. I WAS NOT BACKING OUT, I WAS...

Apr 4, 2015 Air Bags 153,718 mi

I WAS LEAVING THE STORE PARKING LOT. I STARTED THE CAR, PRESSED THE BREAK, PUT THE VEHICLE IN DRIVE AND THE PASSENGER SIDE AIRBAG DEPLOYED. THIS IS THE SECOND TIME THIS HAS HAPPENED SINCE THE FIRST INCIDENT IN SEPTEMBER 2014. THE VEHICLE WAS NOT HIT OR BUMPED IN ANY WAY. I WAS NOT BACKING OUT, I WAS...

Mar 31, 2015 Engine 84,292 mi

TOOK VEHICLE IN FLUID CHANGES, COMPLETE CHECK, AND TO INVESTIGATE A LEAK UNDER VEHICLE. AFTER "COMPLETE" CHECK SAID THEY FOUND BAD SERPENTINE BELT, AIR FILTER AND BUT NOTHING VALVE COVER GASKETS AS CAUSE OF LEAK. COST TO REPAIR GASKETS OVER $1000. WHILE DOING REPAIR THEY CALLED AGAIN AND SAID THEY...

Mar 31, 2015 Engine 84,292 mi

TOOK VEHICLE IN FLUID CHANGES, COMPLETE CHECK, AND TO INVESTIGATE A LEAK UNDER VEHICLE. AFTER "COMPLETE" CHECK SAID THEY FOUND BAD SERPENTINE BELT, AIR FILTER AND BUT NOTHING VALVE COVER GASKETS AS CAUSE OF LEAK. COST TO REPAIR GASKETS OVER $1000. WHILE DOING REPAIR THEY CALLED AGAIN AND SAID THEY...

Mar 11, 2015 Electrical System Fire 180,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE IGNITED IN FLAMES WHILE PARKED IN THE DRIVEWAY. THE CONTACT DID NOT DISCLOSE HOW THE FIRE WAS EXTINGUISHED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AW...

Mar 11, 2015 Electrical System Fire 180,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE IGNITED IN FLAMES WHILE PARKED IN THE DRIVEWAY. THE CONTACT DID NOT DISCLOSE HOW THE FIRE WAS EXTINGUISHED. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AW...

Sep 30, 2014 Power Train 100,000 mi

MY FORD SPORT TRAC HAS FAILED TO LOCK WHEN THE GEAR SHIFT IS PUT INTO THE PARK POSITION. WHEN YOU START TO GET OUT THE VEHICLE WILL ROLL AND YOU WILL HEAR A CLICKING NOISE IN THE TRANSMISSION. IT HAS DONE THIS FOR SOME TIME AND I HAD IT FIXED ONCE BUT IT IS DOING IT AGAIN. *TR

Sep 30, 2014 Power Train 100,000 mi

MY FORD SPORT TRAC HAS FAILED TO LOCK WHEN THE GEAR SHIFT IS PUT INTO THE PARK POSITION. WHEN YOU START TO GET OUT THE VEHICLE WILL ROLL AND YOU WILL HEAR A CLICKING NOISE IN THE TRANSMISSION. IT HAS DONE THIS FOR SOME TIME AND I HAD IT FIXED ONCE BUT IT IS DOING IT AGAIN. *TR

Sep 24, 2014 Air Bags 148,745 mi

I WAS PICKING MY DAUGHTER UP FROM SCHOOL. WE GOT INTO THE CAR PUT OUR SEATBELTS ON I STARTED THE VEHICLE AND PUT IT IN GEAR. I PICKED MY FOOT UP AND MOVED TO THE GAS WHEN I NOTICED A CAR COMING UP FROM BESIDE ME AND THEN I PRESSED THE BRAKE AND THE PASSENGER SIDE AIRBAG DEPLOYED CRACKING THE WINDSHI...

Sep 24, 2014 Air Bags 148,745 mi

I WAS PICKING MY DAUGHTER UP FROM SCHOOL. WE GOT INTO THE CAR PUT OUR SEATBELTS ON I STARTED THE VEHICLE AND PUT IT IN GEAR. I PICKED MY FOOT UP AND MOVED TO THE GAS WHEN I NOTICED A CAR COMING UP FROM BESIDE ME AND THEN I PRESSED THE BRAKE AND THE PASSENGER SIDE AIRBAG DEPLOYED CRACKING THE WINDSHI...

Sep 17, 2014 Service Brakes Crash 75,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 34 MPH DOWN A MOUNTAIN, THE BRAKES WERE ENGAGED AND THE REAR END OF THE VEHICLE STARTED TO ABRUPTLY MOVE FROM SIDE TO SIDE. AS A RESULT, THE VEHICLE CRASHED INTO THE GUARD RAIL. THE DRIVER'S SID...

Sep 17, 2014 Service Brakes Crash 75,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 34 MPH DOWN A MOUNTAIN, THE BRAKES WERE ENGAGED AND THE REAR END OF THE VEHICLE STARTED TO ABRUPTLY MOVE FROM SIDE TO SIDE. AS A RESULT, THE VEHICLE CRASHED INTO THE GUARD RAIL. THE DRIVER'S SID...

Aug 11, 2014 Power Train 200,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. WHILE DRIVING ON AN INCLINE, THE TRANSMISSION SLIPPED AND THE ENGINE RPMS INCREASED ABNORMALLY. THE VEHICLE STALLED AND THE OVERDRIVE WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED APPROXIMATELY TEN TIMES AND AT VARIOUS SPEEDS. THE VEHICLE ...

Aug 11, 2014 Power Train 200,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. WHILE DRIVING ON AN INCLINE, THE TRANSMISSION SLIPPED AND THE ENGINE RPMS INCREASED ABNORMALLY. THE VEHICLE STALLED AND THE OVERDRIVE WARNING INDICATOR ILLUMINATED. THE FAILURE OCCURRED APPROXIMATELY TEN TIMES AND AT VARIOUS SPEEDS. THE VEHICLE ...

Apr 16, 2014 Steering 73,300 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE POWER STEERING FLUID LEAKED ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE POWER STEERING HIGH PRESSURE TUBE FRACTURED AS A RESULT OF RUST. THE VEHICLE WAS REPAIRED....

Apr 16, 2014 Steering 73,300 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE POWER STEERING FLUID LEAKED ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE POWER STEERING HIGH PRESSURE TUBE FRACTURED AS A RESULT OF RUST. THE VEHICLE WAS REPAIRED....

Apr 6, 2014 Structure 190,000 mi

BOTH REAR DOORS FAILED TO OPEN FROM THE INSIDE AFTER BEING USED ONLY A FEW DOZEN TIMES EACH. THE CAUSE WAS THE INTERIOR DOOR HANDLE (PLASTIC) BROKE INSIDE THE DOOR. THIS IS A BIG SAFETY ISSUE BECAUSE THIS MEANS THAT REAR SEAT PASSENGERS CANNOT EGRESS THE VEHICLE WITHOUT IT BEING OPENED BY SOMEONE ON...

Apr 6, 2014 Structure 190,000 mi

BOTH REAR DOORS FAILED TO OPEN FROM THE INSIDE AFTER BEING USED ONLY A FEW DOZEN TIMES EACH. THE CAUSE WAS THE INTERIOR DOOR HANDLE (PLASTIC) BROKE INSIDE THE DOOR. THIS IS A BIG SAFETY ISSUE BECAUSE THIS MEANS THAT REAR SEAT PASSENGERS CANNOT EGRESS THE VEHICLE WITHOUT IT BEING OPENED BY SOMEONE ON...

Mar 18, 2014 Power Train Fire 96,600 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT WAS DRIVING WITH THE VEHICLE SPEED CONTROL ENGAGED AT 68 MPH WHEN THE FAILURE OCCURRED. THE VEHICLE BEGAN TO DECELERATE AND SOME SMOKE WAS PRESENT UNDERNEATH THE VEHICLE. WHEN THE CONTACT OPENED THE HOOD THERE WAS NO EVIDENCE OF SMOKE...

Mar 18, 2014 Engine Fire 96,600 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT WAS DRIVING WITH THE VEHICLE SPEED CONTROL ENGAGED AT 68 MPH WHEN THE FAILURE OCCURRED. THE VEHICLE BEGAN TO DECELERATE AND SOME SMOKE WAS PRESENT UNDERNEATH THE VEHICLE. WHEN THE CONTACT OPENED THE HOOD THERE WAS NO EVIDENCE OF SMOKE...

Mar 18, 2014 Power Train Fire 96,600 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT WAS DRIVING WITH THE VEHICLE SPEED CONTROL ENGAGED AT 68 MPH WHEN THE FAILURE OCCURRED. THE VEHICLE BEGAN TO DECELERATE AND SOME SMOKE WAS PRESENT UNDERNEATH THE VEHICLE. WHEN THE CONTACT OPENED THE HOOD THERE WAS NO EVIDENCE OF SMOKE...

Mar 18, 2014 Engine Fire 96,600 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT WAS DRIVING WITH THE VEHICLE SPEED CONTROL ENGAGED AT 68 MPH WHEN THE FAILURE OCCURRED. THE VEHICLE BEGAN TO DECELERATE AND SOME SMOKE WAS PRESENT UNDERNEATH THE VEHICLE. WHEN THE CONTACT OPENED THE HOOD THERE WAS NO EVIDENCE OF SMOKE...

Mar 13, 2014 Engine

MY ENGINE WENT OUT AFTER ONLY 140000 MILES ON IT WITH NO WARNING. I KNOW SEVERAL PEOPLE THAT OWN A 2003 FORD EXPLORER AND THERE ENGINE WENT OUT AFTER ONLY WITH 100000 MILES ON IT. IT COST ME OVER 3200.00 FOR IT TO BE REPAIRED. *TR

Mar 13, 2014 Engine

MY ENGINE WENT OUT AFTER ONLY 140000 MILES ON IT WITH NO WARNING. I KNOW SEVERAL PEOPLE THAT OWN A 2003 FORD EXPLORER AND THERE ENGINE WENT OUT AFTER ONLY WITH 100000 MILES ON IT. IT COST ME OVER 3200.00 FOR IT TO BE REPAIRED. *TR

Feb 11, 2014 Electrical System

RUSTING WIRES UNDER THE DRIVERS SIDE STEP PLATE. *TR

Feb 11, 2014 Electrical System

RUSTING WIRES ON THE DRIVERS SIDE STEP PLATE. *TR

Feb 11, 2014 Electrical System

RUSTING WIRES UNDER THE DRIVERS SIDE STEP PLATE. *TR

Feb 11, 2014 Electrical System

RUSTING WIRES ON THE DRIVERS SIDE STEP PLATE. *TR

Sep 3, 2013 Fuel System, Gasoline 1,002,000 mi

I HAVE A BAD PROBLEM ( 2 ) TIMES WITH THE FUEL PUMP THE FIRST ONE WAS SPRAYING GAS OUT TOP EXTERIOR OF FUEL PUMP .MY HUSBAND WENT TO A WRECKING YARD AND PURCHASED A USED FUEL PUMP THAN 5 TO 6 MONTHS LATER DONE THE SAME THING SPRAYING OUT TOP EXTERIOR ELBOW OF FUEL PUMP. I USE MY TRUCK TO TAKE MY DA...

Sep 3, 2013 Fuel System, Gasoline 1,002,000 mi

I HAVE A BAD PROBLEM ( 2 ) TIMES WITH THE FUEL PUMP THE FIRST ONE WAS SPRAYING GAS OUT TOP EXTERIOR OF FUEL PUMP .MY HUSBAND WENT TO A WRECKING YARD AND PURCHASED A USED FUEL PUMP THAN 5 TO 6 MONTHS LATER DONE THE SAME THING SPRAYING OUT TOP EXTERIOR ELBOW OF FUEL PUMP. I USE MY TRUCK TO TAKE MY DA...

Oct 11, 2012 Vehicle Speed Control 83,000 mi

SITTING AT A STOP SIGN VEHICLE WENT INTO ACCELERATION GAS PEDDLE WENT TO FLOOR. FOOT WAS ON THE BRAKE. CHECKED NO CARPET STUCK UNDER THE GAS PEDDLE. FOOT WAS NOT TOUCHING GAS PEDDLE. IT WAS ALMOST LIKE THE CRUISE CONTROL WAS PRESSING THE GAS PEDDLE. CRUISE CONTROL WAS OFF. SHUT VEHICLE OFF THEN BACK...

Oct 11, 2012 Fuel/propulsion System 83,000 mi

SITTING AT A STOP SIGN VEHICLE WENT INTO ACCELERATION GAS PEDDLE WENT TO FLOOR. FOOT WAS ON THE BRAKE. CHECKED NO CARPET STUCK UNDER THE GAS PEDDLE. FOOT WAS NOT TOUCHING GAS PEDDLE. IT WAS ALMOST LIKE THE CRUISE CONTROL WAS PRESSING THE GAS PEDDLE. CRUISE CONTROL WAS OFF. SHUT VEHICLE OFF THEN BACK...

Oct 11, 2012 Electrical System 83,000 mi

SITTING AT A STOP SIGN VEHICLE WENT INTO ACCELERATION GAS PEDDLE WENT TO FLOOR. FOOT WAS ON THE BRAKE. CHECKED NO CARPET STUCK UNDER THE GAS PEDDLE. FOOT WAS NOT TOUCHING GAS PEDDLE. IT WAS ALMOST LIKE THE CRUISE CONTROL WAS PRESSING THE GAS PEDDLE. CRUISE CONTROL WAS OFF. SHUT VEHICLE OFF THEN BACK...

Oct 11, 2012 Vehicle Speed Control 83,000 mi

SITTING AT A STOP SIGN VEHICLE WENT INTO ACCELERATION GAS PEDDLE WENT TO FLOOR. FOOT WAS ON THE BRAKE. CHECKED NO CARPET STUCK UNDER THE GAS PEDDLE. FOOT WAS NOT TOUCHING GAS PEDDLE. IT WAS ALMOST LIKE THE CRUISE CONTROL WAS PRESSING THE GAS PEDDLE. CRUISE CONTROL WAS OFF. SHUT VEHICLE OFF THEN BACK...

Oct 11, 2012 Fuel/propulsion System 83,000 mi

SITTING AT A STOP SIGN VEHICLE WENT INTO ACCELERATION GAS PEDDLE WENT TO FLOOR. FOOT WAS ON THE BRAKE. CHECKED NO CARPET STUCK UNDER THE GAS PEDDLE. FOOT WAS NOT TOUCHING GAS PEDDLE. IT WAS ALMOST LIKE THE CRUISE CONTROL WAS PRESSING THE GAS PEDDLE. CRUISE CONTROL WAS OFF. SHUT VEHICLE OFF THEN BACK...

Oct 11, 2012 Electrical System 83,000 mi

SITTING AT A STOP SIGN VEHICLE WENT INTO ACCELERATION GAS PEDDLE WENT TO FLOOR. FOOT WAS ON THE BRAKE. CHECKED NO CARPET STUCK UNDER THE GAS PEDDLE. FOOT WAS NOT TOUCHING GAS PEDDLE. IT WAS ALMOST LIKE THE CRUISE CONTROL WAS PRESSING THE GAS PEDDLE. CRUISE CONTROL WAS OFF. SHUT VEHICLE OFF THEN BACK...

May 14, 2012 Fuel/propulsion System 78,000 mi

I HAVE HAD FUEL TANK ISSUES FOR A YEAR NOW AND THEY ARE GETTING WORSE. MY GAUGE STOPPED WORKING ABOUT 13 MONTHS AGO WHICH WAS NO BIG DEAL. NOW I AM UNABLE TO PUT MORE THEN 4-5 GALLONS OF GAS IN AT A TIME. THE SAFETY SENSOR STOPS THE PUMP FROM FILLING UP MY TANK AND IF I TRY TO DO IT A LITTLE AT A TI...

May 14, 2012 Fuel/propulsion System 78,000 mi

I HAVE HAD FUEL TANK ISSUES FOR A YEAR NOW AND THEY ARE GETTING WORSE. MY GAUGE STOPPED WORKING ABOUT 13 MONTHS AGO WHICH WAS NO BIG DEAL. NOW I AM UNABLE TO PUT MORE THEN 4-5 GALLONS OF GAS IN AT A TIME. THE SAFETY SENSOR STOPS THE PUMP FROM FILLING UP MY TANK AND IF I TRY TO DO IT A LITTLE AT A TI...

Apr 3, 2012 Electrical System Fire 182,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE ABNORMALLY DECELERATED TO 40 MPH. IN ADDITION, THERE WAS SMOKE COMING FROM THE FRONT END OF THE VEHICLE. THE CONTACT WAS INFORMED BY ANOTHER DRIVER THAT SPARKS WERE COMING FROM UNDER THE VEHICLE. TH...

Apr 3, 2012 Electrical System Fire 182,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE ABNORMALLY DECELERATED TO 40 MPH. IN ADDITION, THERE WAS SMOKE COMING FROM THE FRONT END OF THE VEHICLE. THE CONTACT WAS INFORMED BY ANOTHER DRIVER THAT SPARKS WERE COMING FROM UNDER THE VEHICLE. TH...

Mar 2, 2012 Structure 70,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE DRIVER'S SIDE REAR BODY MOUNT FRACTURED AND WAS PROTRUDING THROUGH THE BOTTOM OF THE CAB. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTA...

Mar 2, 2012 Structure 70,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE DRIVER'S SIDE REAR BODY MOUNT FRACTURED AND WAS PROTRUDING THROUGH THE BOTTOM OF THE CAB. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTA...

Jan 24, 2012 Engine And Engine Cooling 164,000 mi

FAULTY CYLINDER HEAD CAUSING A THROWN SPARK PLUG, AND A BROKEN COIL PACK. *TR

Jan 24, 2012 Engine And Engine Cooling 164,000 mi

FAULTY CYLINDER HEAD CAUSING A THROWN SPARK PLUG, AND A BROKEN COIL PACK. *TR

Sep 23, 2011 Structure 46,000 mi

BODY MOUNTS PREMATURELY DETERIORATING AND CRUMBLING. BODY RIDES LOOSE ON FRAME, WHICH CAN IMPACT SAFETY OF THE VEHICLE AND HANDING IN AN ACCIDENT. ALL BODY MOUNTS FOR THE CAB OF THE VEHICLE HAVE FAILED AND FALL APART TO THE TOUCH. SINCE THIS VEHICLE IS A BODY ON FRAME DESIGN, FAILED BODY MOUNTS C...

Sep 23, 2011 Structure 46,000 mi

BODY MOUNTS PREMATURELY DETERIORATING AND CRUMBLING. BODY RIDES LOOSE ON FRAME, WHICH CAN IMPACT SAFETY OF THE VEHICLE AND HANDING IN AN ACCIDENT. ALL BODY MOUNTS FOR THE CAB OF THE VEHICLE HAVE FAILED AND FALL APART TO THE TOUCH. SINCE THIS VEHICLE IS A BODY ON FRAME DESIGN, FAILED BODY MOUNTS C...

Aug 14, 2011 Engine And Engine Cooling 117,000 mi

ENGINE & MULTIPLE PARTS IN 2003 FORD ARE NOT 2003, THEY ARE 2001 & 2002. 2002 ENGINE AND EARLIER HAD A TSB FOR THE TIMING CHAIN GUIDES & OILING. EVEN THOUGH TAKEN INTO THE DEALERSHIP WITH THAT COMPLAINT, MINE WAS SUPPOSED TO BE 2003, NOT AFFECTED BY THOSE PROBLEMS, SO SERVICE DID NOT REPAIR FOR TSB....

Aug 14, 2011 Engine And Engine Cooling 117,000 mi

ENGINE & MULTIPLE PARTS IN 2003 FORD ARE NOT 2003, THEY ARE 2001 & 2002. 2002 ENGINE AND EARLIER HAD A TSB FOR THE TIMING CHAIN GUIDES & OILING. EVEN THOUGH TAKEN INTO THE DEALERSHIP WITH THAT COMPLAINT, MINE WAS SUPPOSED TO BE 2003, NOT AFFECTED BY THOSE PROBLEMS, SO SERVICE DID NOT REPAIR FOR TSB....

Aug 5, 2011 Service Brakes, Hydraulic 59,000 mi

2003 FORD EXPLORER SPORTRAC, INTERMITTENTLY BRAKE PEDAL GOES TO FLOOR, PEDAL VIBRATES, UNABLE TO STOP. NO ACCIDENT YET BUT VERY SCARY SITUATION. SCHEDULED TO HAVE DEALER INSPECT ON 8/8/2011. THIS HAS HAPPENED SEVERAL TIMES. NO ERROR CODES ON VEHICLE DIAGNOSTICS. THIS COULD CAUSE A SERIOUS ACCIDE...

Aug 5, 2011 Fuel System, Gasoline 82,500 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE CONTACT ALSO STATED THAT SHE ATTEMPTED ON SEVERAL OCCASIONS TO START THE VEHICLE WHILE DEPRESSING THE ACCELERATOR PEDAL, BUT IT WOULD NOT START. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP...

Aug 5, 2011 Service Brakes, Hydraulic 59,000 mi

2003 FORD EXPLORER SPORTRAC, INTERMITTENTLY BRAKE PEDAL GOES TO FLOOR, PEDAL VIBRATES, UNABLE TO STOP. NO ACCIDENT YET BUT VERY SCARY SITUATION. SCHEDULED TO HAVE DEALER INSPECT ON 8/8/2011. THIS HAS HAPPENED SEVERAL TIMES. NO ERROR CODES ON VEHICLE DIAGNOSTICS. THIS COULD CAUSE A SERIOUS ACCIDE...

Aug 5, 2011 Fuel System, Gasoline 82,500 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE CONTACT ALSO STATED THAT SHE ATTEMPTED ON SEVERAL OCCASIONS TO START THE VEHICLE WHILE DEPRESSING THE ACCELERATOR PEDAL, BUT IT WOULD NOT START. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP...

Feb 21, 2011 Power Train 89,100 mi

TRANSMISSION WENT OUT AT 89,000 MILES. THIS IS THE SECOND FORD I'VE HAD THAT THE TRANSMISSION WENT OUT AT 89,000. I HAVE ALSO HAD SEVERAL BRAKE ISSUES THAT FORD REFUSED TO ADDRESS AFTER EXTENDED WARRANTY EXPIRED. *TR

Feb 21, 2011 Power Train 89,100 mi

TRANSMISSION WENT OUT AT 89,000 MILES. THIS IS THE SECOND FORD I'VE HAD THAT THE TRANSMISSION WENT OUT AT 89,000. I HAVE ALSO HAD SEVERAL BRAKE ISSUES THAT FORD REFUSED TO ADDRESS AFTER EXTENDED WARRANTY EXPIRED. *TR

Nov 16, 2010 Suspension Fire 85,959 mi

IT STARTED WITH HUMMING VIBRATING NOISE IN THE FRONT END LEFT TIRE ENDING WITH FRONT WHEEL BEARING FAILURE AND SMALL FIRE TO THE WHEEL BEARING RUBBER BOOT AND HARD PULLING TO THE LEFT TOO DANGEROUS TO DRIVE THIS IS A MAJOR MECHANICAL FAILURE AFTER INSPECTING I FOUNT THAT ONLY THE ONE NUT WAS HOLDING...

Nov 16, 2010 Wheels Fire 85,959 mi

IT STARTED WITH HUMMING VIBRATING NOISE IN THE FRONT END LEFT TIRE ENDING WITH FRONT WHEEL BEARING FAILURE AND SMALL FIRE TO THE WHEEL BEARING RUBBER BOOT AND HARD PULLING TO THE LEFT TOO DANGEROUS TO DRIVE THIS IS A MAJOR MECHANICAL FAILURE AFTER INSPECTING I FOUNT THAT ONLY THE ONE NUT WAS HOLDING...

Nov 16, 2010 Suspension Fire 85,959 mi

IT STARTED WITH HUMMING VIBRATING NOISE IN THE FRONT END LEFT TIRE ENDING WITH FRONT WHEEL BEARING FAILURE AND SMALL FIRE TO THE WHEEL BEARING RUBBER BOOT AND HARD PULLING TO THE LEFT TOO DANGEROUS TO DRIVE THIS IS A MAJOR MECHANICAL FAILURE AFTER INSPECTING I FOUNT THAT ONLY THE ONE NUT WAS HOLDING...

Nov 16, 2010 Wheels Fire 85,959 mi

IT STARTED WITH HUMMING VIBRATING NOISE IN THE FRONT END LEFT TIRE ENDING WITH FRONT WHEEL BEARING FAILURE AND SMALL FIRE TO THE WHEEL BEARING RUBBER BOOT AND HARD PULLING TO THE LEFT TOO DANGEROUS TO DRIVE THIS IS A MAJOR MECHANICAL FAILURE AFTER INSPECTING I FOUNT THAT ONLY THE ONE NUT WAS HOLDING...

Nov 5, 2008 Electrical System 12 mi

WHEN I PULL DOWN MY STEERING WHEEL, THE LEFT BLINKER DOES NOT WORK NEITHER DOES THE BRAKE LIGHTS. IF THE WHEEL IS UP EVERY THING WORKS. *TR

Nov 5, 2008 Electrical System 12 mi

WHEN I PULL DOWN MY STEERING WHEEL, THE LEFT BLINKER DOES NOT WORK NEITHER DOES THE BRAKE LIGHTS. IF THE WHEEL IS UP EVERY THING WORKS. *TR

May 22, 2008 Vehicle Speed Control 221,000 mi

AFTER DRIVING SEVERAL MILES WITHOUT INCIDENT, I PULLED INTO TRAFFIC AND ACCELERATED TO ABOUT 45 MPH THEN LET UP ON PEDDLE BUT VEHICLE CONTINUED TO ACCELERATE. TO BRING IT UNDER CONTROL I HAD TO TURN THE IGNITION OFF AND AT THAT POINT, LOST POWER STEERING AND SOME BRAKES. I HAD CAR TOWED TO LOCAL DEA...

May 22, 2008 Vehicle Speed Control 221,000 mi

AFTER DRIVING SEVERAL MILES WITHOUT INCIDENT, I PULLED INTO TRAFFIC AND ACCELERATED TO ABOUT 45 MPH THEN LET UP ON PEDDLE BUT VEHICLE CONTINUED TO ACCELERATE. TO BRING IT UNDER CONTROL I HAD TO TURN THE IGNITION OFF AND AT THAT POINT, LOST POWER STEERING AND SOME BRAKES. I HAD CAR TOWED TO LOCAL DEA...

Mar 18, 2008 Power Train 72,500 mi

WITH NO ADVANCE WARNING, THE O/D OFF LIGHT BEGAN FLASHING AND THE TRANSMISSION BEGAN TO SLIP. MECHANIC SAID THE TRANSMISSION IS SHOT. I HAVE NOT DONE ANY OF THE WORK YET, AS I CAN NOT AFFORD $3000 IN REPAIRS. I HAVE SINCE FOUND OUT THAT THIS PROBLEM OCCURS ON A LARGE NUMBER OF FORD EXPLORERS. *TR

Mar 18, 2008 Power Train 72,500 mi

WITH NO ADVANCE WARNING, THE O/D OFF LIGHT BEGAN FLASHING AND THE TRANSMISSION BEGAN TO SLIP. MECHANIC SAID THE TRANSMISSION IS SHOT. I HAVE NOT DONE ANY OF THE WORK YET, AS I CAN NOT AFFORD $3000 IN REPAIRS. I HAVE SINCE FOUND OUT THAT THIS PROBLEM OCCURS ON A LARGE NUMBER OF FORD EXPLORERS. *TR

Mar 6, 2008 Seat Belts 65,000 mi

SEAT BELT WON'T RETRACT. *TR

Mar 6, 2008 Seat Belts 65,000 mi

SEAT BELT WON'T RETRACT. *TR

Dec 11, 2007 Wheels

TRAVELING ON A MAJOR HIGHWAY 65-70MPH, THE RIGHT FRONT WHEEL AND TIRE CAME OFF. ALL 5 STUDS HAD SNAPPED/SHEARED OFF. WENT ON THE INTERNET, TURNS OUT THIS IS NOT AN ISOLATED INCIDENT. PLEASE HELP!!!!! MY DAUGHTER DRIVES THE EXACT VEHICLE SO DO MILLIONS OF OTHER INDIVIDUALS. *TR

Dec 11, 2007 Wheels

TRAVELING ON A MAJOR HIGHWAY 65-70MPH, THE RIGHT FRONT WHEEL AND TIRE CAME OFF. ALL 5 STUDS HAD SNAPPED/SHEARED OFF. WENT ON THE INTERNET, TURNS OUT THIS IS NOT AN ISOLATED INCIDENT. PLEASE HELP!!!!! MY DAUGHTER DRIVES THE EXACT VEHICLE SO DO MILLIONS OF OTHER INDIVIDUALS. *TR

Dec 6, 2007 Electrical System

VEHICLE ENGINE STOP WHILE DRIVING ON THE ROAD. DRIVING AS NORMAL, APPROX 30 MPH WHEN VEHICLE JUST STOPS. EXTREMELY DIFFICULT TO STEER OR BRAKE. PERFECT WEATHER, NO ENVIRONMENTAL ISSUES--NORMAL TEMPERATURE, ETC. INCIDENT OCCURRED TWICE, APPROX ONE YEAR APART. TOOK INTO REPAIR SHOP TO DIAGNOSE, N...

Dec 6, 2007 Electrical System

VEHICLE ENGINE STOP WHILE DRIVING ON THE ROAD. DRIVING AS NORMAL, APPROX 30 MPH WHEN VEHICLE JUST STOPS. EXTREMELY DIFFICULT TO STEER OR BRAKE. PERFECT WEATHER, NO ENVIRONMENTAL ISSUES--NORMAL TEMPERATURE, ETC. INCIDENT OCCURRED TWICE, APPROX ONE YEAR APART. TOOK INTO REPAIR SHOP TO DIAGNOSE, N...

Nov 4, 2007 Tires 16,000 mi

1) IMPROPER ALIGNMENT SPECIFICATIONS 2) DESTRUCTION OF ALL 4 GOODYEAR TIRES 3) FORD DENIED TO REPLACE TIRES ALTHOUGH THERE IS A TECHNICAL SERVICE BULLETIN (05-11-11) PERTAINING TO THIS ISSUE. *JB

Nov 4, 2007 Suspension 16,000 mi

1) IMPROPER ALIGNMENT SPECIFICATIONS 2) DESTRUCTION OF ALL 4 GOODYEAR TIRES 3) FORD DENIED TO REPLACE TIRES ALTHOUGH THERE IS A TECHNICAL SERVICE BULLETIN (05-11-11) PERTAINING TO THIS ISSUE. *JB

Nov 4, 2007 Tires 16,000 mi

1) IMPROPER ALIGNMENT SPECIFICATIONS 2) DESTRUCTION OF ALL 4 GOODYEAR TIRES 3) FORD DENIED TO REPLACE TIRES ALTHOUGH THERE IS A TECHNICAL SERVICE BULLETIN (05-11-11) PERTAINING TO THIS ISSUE. *JB

Nov 4, 2007 Suspension 16,000 mi

1) IMPROPER ALIGNMENT SPECIFICATIONS 2) DESTRUCTION OF ALL 4 GOODYEAR TIRES 3) FORD DENIED TO REPLACE TIRES ALTHOUGH THERE IS A TECHNICAL SERVICE BULLETIN (05-11-11) PERTAINING TO THIS ISSUE. *JB

Sep 20, 2007 Vehicle Speed Control Fire

MY SPORT TRUCK 2003 CAUGHT ON FIRE ON MARCH 26, 2007 I REPORTED COMPLAIN TO FORD AND THEY SAY THEY WERE NOT RESPONSIBLE FOR THIS. TODAY SEPTEMBER 20/07 MY FRIEND CAR HAS A RECALL FOR THE SPEED CONTROL DEACTIVATION SWITCH POSING THE RISK OF AN UNDERHOOD FIRE. THIS IS WHAT HAPPENED TO MY CAR AND FO...

Sep 20, 2007 Vehicle Speed Control Fire

MY SPORT TRUCK 2003 CAUGHT ON FIRE ON MARCH 26, 2007 I REPORTED COMPLAIN TO FORD AND THEY SAY THEY WERE NOT RESPONSIBLE FOR THIS. TODAY SEPTEMBER 20/07 MY FRIEND CAR HAS A RECALL FOR THE SPEED CONTROL DEACTIVATION SWITCH POSING THE RISK OF AN UNDERHOOD FIRE. THIS IS WHAT HAPPENED TO MY CAR AND FO...

Aug 14, 2007 Engine And Engine Cooling Fire 40 mi

I WAS GOING BACK HOME TO MIAMI AND MY CAR 2003 FORD EXPLORER SPORT TRAC CAUGHT ON FIRE AT THE EXIT OF THE MIDTOWN TUNNEL IN NEW YORK CITY. THE FIRE STARTED IN THE FRONT MOTOR AT THE PASSENGER SIDE. THE POLICE USED 3 FIRE EXTINGUISHERS BUT ALL THE EFFORT THEY DID WAS NOT ENOUGH. MY CAR WAS COMPLET...

Aug 14, 2007 Engine And Engine Cooling Fire 40 mi

I WAS GOING BACK HOME TO MIAMI AND MY CAR 2003 FORD EXPLORER SPORT TRAC CAUGHT ON FIRE AT THE EXIT OF THE MIDTOWN TUNNEL IN NEW YORK CITY. THE FIRE STARTED IN THE FRONT MOTOR AT THE PASSENGER SIDE. THE POLICE USED 3 FIRE EXTINGUISHERS BUT ALL THE EFFORT THEY DID WAS NOT ENOUGH. MY CAR WAS COMPLET...

Jul 16, 2007 Engine And Engine Cooling

CONSTANT LOUD SQUEAL COMING FROM SERPENTINE BELT, REPLACED BY DEALERSHIP AND I HAD TO PURCHASE, STILL SQUEAL, WARRANTY AND REPLACED, STILL SQUEALED DEALERSHIP CALLED FORD, FORD SUGGESTED STRONGER BELT THAT NORMALLY DOES NOT GO IN THIS TRUCK. CURRENTLY NO SQUEAL. TOTAL BELTS: 4 *TR

Jul 16, 2007 Engine And Engine Cooling

CONSTANT LOUD SQUEAL COMING FROM SERPENTINE BELT, REPLACED BY DEALERSHIP AND I HAD TO PURCHASE, STILL SQUEAL, WARRANTY AND REPLACED, STILL SQUEALED DEALERSHIP CALLED FORD, FORD SUGGESTED STRONGER BELT THAT NORMALLY DOES NOT GO IN THIS TRUCK. CURRENTLY NO SQUEAL. TOTAL BELTS: 4 *TR

Sep 5, 2006 Engine And Engine Cooling 200,000 mi

VEHICLE SHUTS DOWN WHEN DRIVING---BOTH LOW AND HIGH SPEED--BRAKES, STEERING, ELECTRICAL, GAS--ALL QUIT. AFTER A FEW MINUTES THE CAR WILL START AGAIN. HAS HAPPENED NUMEROUS TIMES. DEALER, VISTA FORD, SAYS NOTHING WRONG/CAN'T DUPLICATE. *NM

Sep 5, 2006 Engine And Engine Cooling 200,000 mi

VEHICLE SHUTS DOWN WHEN DRIVING---BOTH LOW AND HIGH SPEED--BRAKES, STEERING, ELECTRICAL, GAS--ALL QUIT. AFTER A FEW MINUTES THE CAR WILL START AGAIN. HAS HAPPENED NUMEROUS TIMES. DEALER, VISTA FORD, SAYS NOTHING WRONG/CAN'T DUPLICATE. *NM

Jun 28, 2006 Electrical System

ANTS HAVE EATEN INTO THE COMPUTER ON MY 1994 FORD EXPLORER LAST YEAR . THIS YEAR EVEN THOUGH I PUT OUT POISON ON THE GROUND AND SPRAYED THE MOTOR AND INSIDE OF BOTH VEHICLES THEY GOT INTO THE DASH OF MY 03 AND STARTED EATING THE (LOOMS) WHAT EVER THAT IS AND THE WIRING TO MY AIR BAGS. HAS ANYONE EL...

Jun 28, 2006 Electrical System

ANTS HAVE EATEN INTO THE COMPUTER ON MY 1994 FORD EXPLORER LAST YEAR . THIS YEAR EVEN THOUGH I PUT OUT POISON ON THE GROUND AND SPRAYED THE MOTOR AND INSIDE OF BOTH VEHICLES THEY GOT INTO THE DASH OF MY 03 AND STARTED EATING THE (LOOMS) WHAT EVER THAT IS AND THE WIRING TO MY AIR BAGS. HAS ANYONE EL...

Jun 25, 2006 Tires

GOODYEAR WRANGLER RT/S TIRES HAVE 1 TO 3 INCH SPLITS APPROX. 1 INCH FROM THE RIM, I HAVE THIS ON ALL 4 TIRES. THEY ARE ON A FORD EXPLORER SPORT TRAC 2003. *NM

Jun 25, 2006 Tires

GOODYEAR WRANGLER RT/S TIRES HAVE 1 TO 3 INCH SPLITS APPROX. 1 INCH FROM THE RIM, I HAVE THIS ON ALL 4 TIRES. THEY ARE ON A FORD EXPLORER SPORT TRAC 2003. *NM

May 8, 2006 Structure 58,000 mi

DT*: THE CONTACT STATED WHILE DRIVING A RATTLING NOISE WAS HEARD. THIS OCCURRED AT VARIOUS SPEEDS. UPON INSPECTION, A FRACTURE WAS OBSERVED ON THE FRAME OF THE REAR DRIVER'S SIDE . THE FRACTURE BECAME LARGER OVER TIME. THE DEALERSHIP WAS UNABLE TO DETERMINE THE CAUSE OF THE FRACTURE, BUT RECOMM...

May 8, 2006 Structure 58,000 mi

DT*: THE CONTACT STATED WHILE DRIVING A RATTLING NOISE WAS HEARD. THIS OCCURRED AT VARIOUS SPEEDS. UPON INSPECTION, A FRACTURE WAS OBSERVED ON THE FRAME OF THE REAR DRIVER'S SIDE . THE FRACTURE BECAME LARGER OVER TIME. THE DEALERSHIP WAS UNABLE TO DETERMINE THE CAUSE OF THE FRACTURE, BUT RECOMM...

Feb 16, 2006 Suspension 37,000 mi

I HAVE HAD TO REPLACE LOWER BALL JOINTS IN MY 2003 SPORT TRAC MULTIPLE TIMES. AT 37000 AND AT 60000 MILES. *NM

Feb 16, 2006 Suspension 37,000 mi

I HAVE HAD TO REPLACE LOWER BALL JOINTS IN MY 2003 SPORT TRAC MULTIPLE TIMES. AT 37000 AND AT 60000 MILES. *NM

Jan 19, 2006 Structure

I WAS DRIVING TO WORK ON 1/12/06 AT 6:15 AM. IT WAS RUSH HOUR TRAFFIC AND ALL OF THE SUDDEN MY HOOD FLEW UP. I COULDN'T SEE A THING. I HAD TO MERGE OVER 3 LANES TO GET TO THE SHOULDER OF THE ROAD. I COULDN'T SEE ANYTHING IN FRONT OF ME BECAUSE THE HOOD OF MY TRUCK COMPLETELY COVERED MY FRONT WINDOW...

Jan 19, 2006 Structure

I WAS DRIVING TO WORK ON 1/12/06 AT 6:15 AM. IT WAS RUSH HOUR TRAFFIC AND ALL OF THE SUDDEN MY HOOD FLEW UP. I COULDN'T SEE A THING. I HAD TO MERGE OVER 3 LANES TO GET TO THE SHOULDER OF THE ROAD. I COULDN'T SEE ANYTHING IN FRONT OF ME BECAUSE THE HOOD OF MY TRUCK COMPLETELY COVERED MY FRONT WINDOW...

Jan 3, 2006 Fuel System, Gasoline

WHEN FILLING GAS TANK OF FORD SPORT TRAC, GASOLINE SUDDENLY AND WITHOUT WARNING SPRAYED OUT OF FILLER PIPE COVERING MY CLOTHS WITH GASOLINE. I TOOK VEHICLE BACK TO DEALER AND TOLD IT HAS BEEN REPAIRED. NEXT TIME I FILLED THE TANK, GASOLINE AGAIN WITHOUT WARNING ERUPTED FROM FILL PIPE AND SPRAYED ON ...

Jan 3, 2006 Fuel System, Gasoline

WHEN FILLING GAS TANK OF FORD SPORT TRAC, GASOLINE SUDDENLY AND WITHOUT WARNING SPRAYED OUT OF FILLER PIPE COVERING MY CLOTHS WITH GASOLINE. I TOOK VEHICLE BACK TO DEALER AND TOLD IT HAS BEEN REPAIRED. NEXT TIME I FILLED THE TANK, GASOLINE AGAIN WITHOUT WARNING ERUPTED FROM FILL PIPE AND SPRAYED ON ...

Oct 26, 2005 Latches/locks/linkages

DT THE PASSENGERS REAR DOOR HANDLE BROKE OFF THE VEHICLE AND THE DRIVER'S SIDE REAR DOOR HANDLE WAS STUCK. HAD TO GET OUT AND OPEN THE DOOR IN ORDER TO GET THE REAR DRIVER SIDE DOOR OPEN. NOW, ON THE DRIVER'S SIDE REAR THE HANDLE HAS BROKE OFF. STARTED NOTICING THE PROBLEM WITH THE DOOR LATCHES ON...

Oct 26, 2005 Latches/locks/linkages

DT THE PASSENGERS REAR DOOR HANDLE BROKE OFF THE VEHICLE AND THE DRIVER'S SIDE REAR DOOR HANDLE WAS STUCK. HAD TO GET OUT AND OPEN THE DOOR IN ORDER TO GET THE REAR DRIVER SIDE DOOR OPEN. NOW, ON THE DRIVER'S SIDE REAR THE HANDLE HAS BROKE OFF. STARTED NOTICING THE PROBLEM WITH THE DOOR LATCHES ON...

Sep 21, 2005 Electrical System 25,000 mi

DT: THE CONSUMER STATED THAT 2003 FORD EXPLORER SPORT TRAC SPECIAL EDITION WITH AVALANCHE ON THE BACK WAS HAVING A STALLING PROBLEM. THE ANTI-THEFT DEVICE LIGHT BLINKED ON THE DASHBOARD, AND THEN THE VEHICLE SHUT OFF THE POWER. THE CONSUMER TOOK THE TRUCK TO THE REPAIR SHOP SEVEN TO EIGHT TIM...

Sep 21, 2005 Electrical System 25,000 mi

DT: THE CONSUMER STATED THAT 2003 FORD EXPLORER SPORT TRAC SPECIAL EDITION WITH AVALANCHE ON THE BACK WAS HAVING A STALLING PROBLEM. THE ANTI-THEFT DEVICE LIGHT BLINKED ON THE DASHBOARD, AND THEN THE VEHICLE SHUT OFF THE POWER. THE CONSUMER TOOK THE TRUCK TO THE REPAIR SHOP SEVEN TO EIGHT TIM...

Apr 6, 2005 Unknown Or Other

ISSUE IS NON SAFETY RELATED. ISSUE WITH KNOWN MANUFACTURERS DEFECT COVERED UNDER WARRANTY THAT CANNOT BE REPAIRED AND WILL NOT BE REPLACED. PURCHASED VEHICLE NEW IN SEPTEMBER OF 2003. DESIRED FEATURE WAS HARD TONNEAU COVER TO KEEP BED DRY AND SECURE. COVER LEAKED. TOOK BACK TO DEALER AFTER APPR...

Apr 6, 2005 Equipment

ISSUE IS NON SAFETY RELATED. ISSUE WITH KNOWN MANUFACTURERS DEFECT COVERED UNDER WARRANTY THAT CANNOT BE REPAIRED AND WILL NOT BE REPLACED. PURCHASED VEHICLE NEW IN SEPTEMBER OF 2003. DESIRED FEATURE WAS HARD TONNEAU COVER TO KEEP BED DRY AND SECURE. COVER LEAKED. TOOK BACK TO DEALER AFTER APPR...

Apr 6, 2005 Unknown Or Other

ISSUE IS NON SAFETY RELATED. ISSUE WITH KNOWN MANUFACTURERS DEFECT COVERED UNDER WARRANTY THAT CANNOT BE REPAIRED AND WILL NOT BE REPLACED. PURCHASED VEHICLE NEW IN SEPTEMBER OF 2003. DESIRED FEATURE WAS HARD TONNEAU COVER TO KEEP BED DRY AND SECURE. COVER LEAKED. TOOK BACK TO DEALER AFTER APPR...

Apr 6, 2005 Equipment

ISSUE IS NON SAFETY RELATED. ISSUE WITH KNOWN MANUFACTURERS DEFECT COVERED UNDER WARRANTY THAT CANNOT BE REPAIRED AND WILL NOT BE REPLACED. PURCHASED VEHICLE NEW IN SEPTEMBER OF 2003. DESIRED FEATURE WAS HARD TONNEAU COVER TO KEEP BED DRY AND SECURE. COVER LEAKED. TOOK BACK TO DEALER AFTER APPR...

Mar 18, 2005 Tires

WHILE DRIVING 50 MPH DRIVER HEAR A LOUD KNOCKING NOISE COMING FROM THE REAR. SUDDENLY, THE VEHICLE VIBRATED UNCONTROLLABLY. DRIVER PULLED OVER, AND NOTICED THAT THE REAR LEFT TIRE BLEW OUT. DRIVER WILL CONTACT THE DEALER IN THE NEAR FUTURE. *AK

Mar 18, 2005 Tires

WHILE DRIVING 50 MPH DRIVER HEAR A LOUD KNOCKING NOISE COMING FROM THE REAR. SUDDENLY, THE VEHICLE VIBRATED UNCONTROLLABLY. DRIVER PULLED OVER, AND NOTICED THAT THE REAR LEFT TIRE BLEW OUT. DRIVER WILL CONTACT THE DEALER IN THE NEAR FUTURE. *AK

Feb 12, 2005 Structure Crash 15,000 mi

MY AUNT'S VEHICLE WAS INVOLVED IN AN ACCIDENT WHERE THE VEHICLE ROLLED SEVERAL TIMES. THE FRONT PILLAR ON THE DRIVER'S SIDE COLLAPSED ALLOWING THE ROOF TO COLLAPSE ALMOST DOWN TO THE LEVEL OF THE STEERING WHEEL. THERE WAS ALSO A LACK OF AVAILABILITY OF SIDE CURTAIN AIRBAGS ON THE VEHICLE. THE ACC...

Feb 12, 2005 Structure Crash 15,000 mi

MY AUNT'S VEHICLE WAS INVOLVED IN AN ACCIDENT WHERE THE VEHICLE ROLLED SEVERAL TIMES. THE FRONT PILLAR ON THE DRIVER'S SIDE COLLAPSED ALLOWING THE ROOF TO COLLAPSE ALMOST DOWN TO THE LEVEL OF THE STEERING WHEEL. THERE WAS ALSO A LACK OF AVAILABILITY OF SIDE CURTAIN AIRBAGS ON THE VEHICLE. THE ACC...

Feb 8, 2005 Vehicle Speed Control 48,600 mi

CRUISE CONTROL DOES NOT ENGAGE MOST OF THE TIME. I POWER THE SYSTEM ON, BUT WHEN PRESSING THE SET BUTTON, THE SYSTEM POWER QUICKLY BLINKS ON AND OFF. BRAKE PEDAL IS NOT DEPRESSED, IT OCCURS AT ANY SPEED.*AK

Feb 8, 2005 Service Brakes, Hydraulic 48,600 mi

CRUISE CONTROL DOES NOT ENGAGE MOST OF THE TIME. I POWER THE SYSTEM ON, BUT WHEN PRESSING THE SET BUTTON, THE SYSTEM POWER QUICKLY BLINKS ON AND OFF. BRAKE PEDAL IS NOT DEPRESSED, IT OCCURS AT ANY SPEED.*AK

Feb 8, 2005 Vehicle Speed Control 48,600 mi

CRUISE CONTROL DOES NOT ENGAGE MOST OF THE TIME. I POWER THE SYSTEM ON, BUT WHEN PRESSING THE SET BUTTON, THE SYSTEM POWER QUICKLY BLINKS ON AND OFF. BRAKE PEDAL IS NOT DEPRESSED, IT OCCURS AT ANY SPEED.*AK

Feb 8, 2005 Service Brakes, Hydraulic 48,600 mi

CRUISE CONTROL DOES NOT ENGAGE MOST OF THE TIME. I POWER THE SYSTEM ON, BUT WHEN PRESSING THE SET BUTTON, THE SYSTEM POWER QUICKLY BLINKS ON AND OFF. BRAKE PEDAL IS NOT DEPRESSED, IT OCCURS AT ANY SPEED.*AK

Oct 15, 2004 Air Bags

WHILE DRIVING, THE PASSENGER SIDE AND DRIVER SIDE AIR BAGS UNEXPECTEDLY DEPLOYED. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK THE CONSUMER RECEIVED A CALL FROM THE ENGINEERING DEPARTMENT WHO INFORMED THE CONSUMER THE AIR BAG DEPLOYED BECA...

Oct 15, 2004 Air Bags

WHILE DRIVING, THE PASSENGER SIDE AND DRIVER SIDE AIR BAGS UNEXPECTEDLY DEPLOYED. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK THE CONSUMER RECEIVED A CALL FROM THE ENGINEERING DEPARTMENT WHO INFORMED THE CONSUMER THE AIR BAG DEPLOYED BECA...

Sep 28, 2004 Fuel System, Gasoline 8,500 mi

WHILE DRIVING ON THE FREEWAY VEHICLE DECELERATED 5 MPH BEFORE REGULATING SPEED. AFTER EXITING FREEWAY, VEHICLE DIED AT STOP LIGHT. VEHICLE TOWED TO DEALERSHIP WHERE THEY INFORMED ME THE INERTIA SWITCH, LOCATED UNDER KICK PLATE ON PASSENGER SIDE, WAS DAMAGED AND THUS CUT OFF THE FUEL PUMP. ONCE FI...

Sep 28, 2004 Fuel System, Gasoline 8,500 mi

WHILE DRIVING ON THE FREEWAY VEHICLE DECELERATED 5 MPH BEFORE REGULATING SPEED. AFTER EXITING FREEWAY, VEHICLE DIED AT STOP LIGHT. VEHICLE TOWED TO DEALERSHIP WHERE THEY INFORMED ME THE INERTIA SWITCH, LOCATED UNDER KICK PLATE ON PASSENGER SIDE, WAS DAMAGED AND THUS CUT OFF THE FUEL PUMP. ONCE FI...

Sep 16, 2004 Service Brakes, Hydraulic

WHILE APPLYING THE BRAKE PEDAL, THE VEHICLE JERKED AND VIBRATED. THE BRAKE PEDAL WENT TO THE FLOOR. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. PLEASE PROVIDE FURTHER DETAILS. *JB

Sep 16, 2004 Service Brakes, Hydraulic

WHILE APPLYING THE BRAKE PEDAL, THE VEHICLE JERKED AND VIBRATED. THE BRAKE PEDAL WENT TO THE FLOOR. THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. PLEASE PROVIDE FURTHER DETAILS. *JB

Aug 16, 2004 Structure 8,000 mi

PROBLEMS WITH TIRES ON 2003 FORD EXPLORER. *MR THERE WAS A VIBRATION IN THE FRONT END, THE TIRE WERE NOTICED WORN ON THE INSIDE, THERE WAS ALSO A PROBLEM WITH THE REAR END WHICH WAS TILTED DUE TO A BENT FRAME, THE REAR END LEAKED AS WELL. THE DEALER CLAIMED THAT THEY COULDN'T FIND ANYTHING WRON...

Aug 16, 2004 Suspension 8,000 mi

PROBLEMS WITH TIRES ON 2003 FORD EXPLORER. *MR THERE WAS A VIBRATION IN THE FRONT END, THE TIRE WERE NOTICED WORN ON THE INSIDE, THERE WAS ALSO A PROBLEM WITH THE REAR END WHICH WAS TILTED DUE TO A BENT FRAME, THE REAR END LEAKED AS WELL. THE DEALER CLAIMED THAT THEY COULDN'T FIND ANYTHING WRON...

Aug 16, 2004 Structure 8,000 mi

PROBLEMS WITH TIRES ON 2003 FORD EXPLORER. *MR THERE WAS A VIBRATION IN THE FRONT END, THE TIRE WERE NOTICED WORN ON THE INSIDE, THERE WAS ALSO A PROBLEM WITH THE REAR END WHICH WAS TILTED DUE TO A BENT FRAME, THE REAR END LEAKED AS WELL. THE DEALER CLAIMED THAT THEY COULDN'T FIND ANYTHING WRON...

Aug 16, 2004 Suspension 8,000 mi

PROBLEMS WITH TIRES ON 2003 FORD EXPLORER. *MR THERE WAS A VIBRATION IN THE FRONT END, THE TIRE WERE NOTICED WORN ON THE INSIDE, THERE WAS ALSO A PROBLEM WITH THE REAR END WHICH WAS TILTED DUE TO A BENT FRAME, THE REAR END LEAKED AS WELL. THE DEALER CLAIMED THAT THEY COULDN'T FIND ANYTHING WRON...

Aug 10, 2004 Power Train

THIS FORD EXPLORER SPORT TRACK WAS BOUGHT NEW. I PREVIOUSLY HAD A FORD EXPLORER. THE REASON I TRADED WAS BECAUSE OF THE ROLL OVER RATE. THE DEALERSHIP WHERE I PURCHASED THIS VEHICLE GAVE ME A RUN DOWN ON THE NEWLY DESIGNED EXPLORER TELLIN ME THAT THE NEW DESIGN HAD CORRECTED THE ROLL OVER PROBLEM I...

Aug 10, 2004 Steering

THIS FORD EXPLORER SPORT TRACK WAS BOUGHT NEW. I PREVIOUSLY HAD A FORD EXPLORER. THE REASON I TRADED WAS BECAUSE OF THE ROLL OVER RATE. THE DEALERSHIP WHERE I PURCHASED THIS VEHICLE GAVE ME A RUN DOWN ON THE NEWLY DESIGNED EXPLORER TELLIN ME THAT THE NEW DESIGN HAD CORRECTED THE ROLL OVER PROBLEM I...

Aug 10, 2004 Power Train

THIS FORD EXPLORER SPORT TRACK WAS BOUGHT NEW. I PREVIOUSLY HAD A FORD EXPLORER. THE REASON I TRADED WAS BECAUSE OF THE ROLL OVER RATE. THE DEALERSHIP WHERE I PURCHASED THIS VEHICLE GAVE ME A RUN DOWN ON THE NEWLY DESIGNED EXPLORER TELLIN ME THAT THE NEW DESIGN HAD CORRECTED THE ROLL OVER PROBLEM I...

Aug 10, 2004 Steering

THIS FORD EXPLORER SPORT TRACK WAS BOUGHT NEW. I PREVIOUSLY HAD A FORD EXPLORER. THE REASON I TRADED WAS BECAUSE OF THE ROLL OVER RATE. THE DEALERSHIP WHERE I PURCHASED THIS VEHICLE GAVE ME A RUN DOWN ON THE NEWLY DESIGNED EXPLORER TELLIN ME THAT THE NEW DESIGN HAD CORRECTED THE ROLL OVER PROBLEM I...

Aug 5, 2004 Service Brakes, Hydraulic 7,300 mi

WHILE DRIVING AND ATTEMPTING TO APPLY THE BRAKES THEY FAILED INTERMITTENTLY. NO IMPACT REPORTED. *AK THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN TEST DROVE THE VEHICLE BUT COULD NOT DUPLICATE THE FAILURE. THE MASTER CYLINDER WAS REPLACED BUT THE BRAKES FAILED AGAIN AFTER IT WAS REPLACED....

Aug 5, 2004 Service Brakes, Hydraulic 7,300 mi

WHILE DRIVING AND ATTEMPTING TO APPLY THE BRAKES THEY FAILED INTERMITTENTLY. NO IMPACT REPORTED. *AK THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN TEST DROVE THE VEHICLE BUT COULD NOT DUPLICATE THE FAILURE. THE MASTER CYLINDER WAS REPLACED BUT THE BRAKES FAILED AGAIN AFTER IT WAS REPLACED....

Jul 20, 2004 Fuel System, Gasoline 30 mi

VEHICLE WILL STALL AFTER SITTING OVERNIGHT AND THE ENGINE HAS NOT REACH NORMAL OPERATING TEMPERATURE, FUEL TANK FULL AND THE VEHICLE IS PROCEEDING UP AN INCLINE. WHEN VEHICLE STALLS YOU CAN START THE VEHICLE AND PROCEED. AFTER REACHING NORMAL OPERATING TEMPERATURE OR THE VEHICLE HAVE TRAVEL FORTY T...

Jul 20, 2004 Fuel System, Gasoline 30 mi

VEHICLE WILL STALL AFTER SITTING OVERNIGHT AND THE ENGINE HAS NOT REACH NORMAL OPERATING TEMPERATURE, FUEL TANK FULL AND THE VEHICLE IS PROCEEDING UP AN INCLINE. WHEN VEHICLE STALLS YOU CAN START THE VEHICLE AND PROCEED. AFTER REACHING NORMAL OPERATING TEMPERATURE OR THE VEHICLE HAVE TRAVEL FORTY T...

Jul 16, 2004 Suspension 8,000 mi