2001 FORD EXPLORER SPORT Engine And Engine Cooling Problems

TL* THE CONTACT OWNS A 2001 FORD EXPLORER SPORT. THE CONTACTED WAS DRIVING 35 MPH WHEN WHITE SMOKE EMITTED FROM THE FENDER OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND DISCOVERED FLAMES WERE COMING FROM UNDER THE HOOD. THE VEHICLE WAS DESTROYED. THE POLICE AND FIRE DEPARTMENTS WERE CONTACTED AND REPORTS WERE FILED. THE FAILURE CAUSED NO INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGES WERE 126,000.

Mileage: 126,000

AT 2100-2300 RPM ON ACCELERATION A PINGING SOUND IS HEARD THAT SOUNDS LIKE SPARK KNOCK (DETONATION). THE ACTUAL CAUSE IS FROM DEFECTIVE TIMING CHAIN GUIDES WHICH ALLOWS SLACK IN THE TIMING CHAINS (4.0 ENGINES HAS ONE IN FRONT AND ONE IN REAR) AND IS CAUSING IT TO RATTLE AND EAT AWAY AT THE GUIDES. THIS IS COMMONLY KNOWN AS THE "RATTLE OF DEATH" ON THE FORD 4.0 ENGINES BECAUSE ONCE THE PLASTIC ON THE GUIDES GETS EATEN AWAY BY THE LOOSE TIMING CHAIN, IT EATS INTO THE METAL SUPPORT AND CREATE METAL SHAVINGS THROUGHOUT THE ENGINE WHICH WILL CAUSE FAILURE, IF THE CHAIN DOES NOT FALL OFF FIRST. THIS IS A WELL KNOWN AND WELL DOCUMENTED PROBLEM DUE TO CHEAP TIMING CHAIN GUIDES. *TR

Mileage: 83,275

TL*THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING AT SPEED AT 15 MPH, THE VEHICLE LOST ELECTRICAL POWER AND THE ENGINE STALLED. THE STEERING BECAME VERY DIFFICULT TO MANEUVER AND THE CONTACT WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE. THE VEHICLE ROLLED OVER AS A RESULT OF THE FAILURE. THE POLICE ARRIVED ON THE SCENE AND THE DRIVER SUSTAINED MINOR INJURIES. THE VEHICLE WAS TAKEN TO A LOCAL BODY SHOP TO BE SERVICED. THE FAILURE RECURRED INTERMITTENTLY AND WAS THEN TAKEN TO AN AUTHORIZED DEALER FOR SERVICE. THE FAILURE CONTINUED TO RECUR INTERMITTENTLY. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 1,500 AND THE CURRENT MILEAGE WAS 40,000. UPDATED 05/21/10.*LJ THE CONSUMER STATED THE FAILURE WOULD HAPPEN WHEN FIRST STARTING TO DRIVE. UPDATED 10/14/10*JB

Mileage: 1,500

VEHICLE CAUGHT FIRE. VEHICLE WAS NOT RUNNING AT THE TIME. VEHICLE DESTROYED BY FIRE. *TR

Mileage: 110,000

THIS IS A 7 YEAR OLD VEHICLE AND IT SEEMS AS THOUGH RECALLS CONTINUE. THIS VEHICLE HAS A CHAIN GUIDE PROBLEM THAT SEEMS TO BE MAJOR. WE NOW EITHER NEED A NEW MOTOR OR WE HAVE TO HAVE IT REPLACED FOR 2,500.00 EVERYWHERE WE CHECK. MAJOR PROBLEM. NOT THAT OLD OF A VEHICLE. *TR

Mileage: 100,000

CHECK ENGINE LIGHT ON AND RUNNING A LITTLE ROUGH IN COLD WET WEATHER. *NM

Mileage: 28,000

DT: OWNS 2001 FORD EXPLORER, BOTH DRIVER AND PASSENGER ARE PREGNANT. HAD JUST ENTERED INTERSTATE AND WAS DRIVING ABOUT 70 MPH AND TRIED TO SLOW DOWN TO ABOUT 65MPH. TRIED TO TAP BRAKE BUT HEARD ENGINE REV UP AND IT IMMEDIATELY SPED BACK UP. TAPPED BRAKE AGAIN AND KNEW SOMETHING WAS WRONG. ENGAGED HAZARD LIGHTS AND TRIED TO PULL OFF ROAD. DOWN SHIFTED TO 2ND GEAR,THEN TO 1ST, AND SLOWED TO ABOUT 50 MPH. TRIED TO ENGAGE EMERGENCY BRAKE WITH NO LUCK. WAS USING BOTH BRAKES WHILE TRAVELING IN THE GRASS UPHILL. WHEN IT SLOWED TO ABOUT 15-20 MPH PASSENGER JUMPED FROM VEHICLE. VEHICLE CONTINUED TO REV UP, DRIVER LET OFF BRAKE WHILE TRYING TO ESCAPE AND WAS SLUNG FROM VEHICLE. THE EXPLORER WENT BACK AND CROSSED 4 LANES OF TRAFFIC, ENTERED ONTO SERVICE ROAD WHERE IT STRUCK A TREE. FROM THERE THE VEHICLE ACCELERATED UP THE TREE UP-ROOTING IT. THE TIRES CAUGHT FIRE AND BYSTANDER TRIED TO PUT OUT THE FIRE WITH AN ICE CHEST AND AGAIN IT CAUGHT ON FIRE. *TT

Mileage: 80,000

WHILE DRIVING 40 MPH, THE SRS LIGHT, ABS LIGHT AND CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. SUDDENLY, THE FRONT WHEELS LOCKED AND THE VEHICLE FLIPPED OVER. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. THE CAUSE HAS NOT BEEN DETERMINED AT THIS TIME. PLEASE PROVIDE FURTHER DETAILS. *NM

PROBLEMS WITH TIRE EQUIPMENT ON 2001 EXPLORER SPORT.*MR WHILE DRIVING THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE EMISSIONS SENSOR NEEDED TO BE REPLACED. THE TECHNICIAN INDICATED THAT THE COST OF THE REPAIR WOULD BE $240.57 AND THAT THE REPLACEMENT WOULD TAKE ABOUT 45 MINUTES BECAUSE THE SENSOR WAS DIFFICULT TO GET TO. THE CONSUMER REQUESTED THAT THE OLD PART BE RETURNED TO HIM. WHEN THE CONSUME GOT HOME HE OPENED THE HOOD AND SAW THAT THE SENSOR WAS EXTREMELY ACCESSIBLE ON THE TOP RIGHT OF THE ENGINE. THE CONSUMER FELLS THE COST OF THE REPAIR WAS NOT REASONABLE. *NM

Mileage: 37,023

INTERMITTENTLY WHILE DRIVING AT 55 MPH VEHICLE STALLED AND HESITATED. A MECHANIC DETERMINED THAT THE INTAKE MANIFOLD GASKET NEEDED TO BE REPLACED. *AK

Mileage: 44,000

EGR VALVE FAILED ON MY VEHICLE 3 TIMES. ACCORDING TO AN ONLINE REPAIR FORUM, THIS COULD LEAD TO STALLING AND HESITATION IN ACCELERATION. MY EGR VALVE HAS FAILED ALL 3 TIMES DURING PERIODS OF ACCELERATION WHILE ON THE FREEWAY. THIS COULD POSE A SAFETY HAZARD SHOULD IT FAIL AND STALL WHILE ACCELERATING TO ENTER THE FREEWAY OR WHILE PASSING ANOTHER VEHICLE ON A 2 LANE ROAD.*AK

STARTING PROBLEMS WITH TEMPERATURES BELOW 40 DEGREES FAHRENHEIT ON A COLD START. VEHICLE ATTEMPTS TO START BUT WILL NOT TURN OVER WITHOUT PRESSURE BEING APPLIED TO ACCELERATOR. ONLY DUPLICATES IN COLD WEATHER. VERY WIDESPREAD PROBLEM MANY OTHER OWNERS REPORT SAME ISSUES. *LA

Mileage: 50,000

VEHICLE'S MOTOR STALLED OUT WHEN THE ACCELERATOR WAS DEPRESSED.*MR THE CONSUMER WANTS TO PUT FORD MOTOR COMPANY ON NOTICE THAT HIS VEHICLE IS IN FACT DEFECTIVE AND HAS NOT BEEN REPAIRED AND RESPECTFULLY REQUEST THAT FORD MOTOR COMPANY WILL EXTEND THE WARRANTY ON THIS VEHICLE AND REMEDY A FUTURE FAILURE, AT NO COST, SHOULD A SIMILAR PROBLEM RECCUR AFTER THE WARRANTY EXPIRES. *CB *JB

VEHICLE RATTLES OVER 80 MPH. THE WHOLE CAR JUST SHAKES UNNECESSARILY. BAD SMELL EXISTING COMING FROM THE ENGINE. ERP(VACUUM PART $600) IS BAD AT 45000 MILES ONLY ON A 2001 FORD EXPLORER SPORT. WHAT IS THIS. *NLM

EXHAUST FUMES SEEPED INTO THE VEHICLE'S INTERIOR CABIN. DEALER WAS UNABLE TO DETERMINE CAUSE OR SOURCE OF LEAK. MANUFACTURER STATED EXHAUST FUME SMELL WAS NORMAL. *JB THE SMELL WOULD WORSEN WHEN GOING UP HILLS AND OR THE MOUNTAINS. SCC

Mileage: 23,310

AFTER REMOVING FOOT FROM GAS PEDAL AT 20 TO 25 MPH, WHEN TOUCHING THE PEDAL TO INCREASE SPEED, TRUCK SPUN AS THOUGH AT FULL THROTTLE. HAPPENED ONCE WHILE TURNING BEND ON A WET SURFACE. THEN HAPPENED AGAIN ON A STRAIGHT SNOW COVERED ROAD. DEALER COULD NOT FIND A PROBLEM, BUT REPLACED THE IDLE AIR CONTROL VALVE SINCE IT'S THE MOST COMMON COMPONENT TO CAUSE THIS PROBLEM. DT

WHILE BRAKING THE VEHICLE CONTINUED TO ACCELERATE. THIS CONDITION ALMOST CAUSED THE VEHICLE TO HIT A PARKED CAR AND A PERSON. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASION BUT THEY WERE UNABLE TO LOCATE THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *PH *NLM

WHILE IN IDLE VEHICLE WILL STALL OUT OR AT TIMES JUST START SHAKING, IDLES ROUGHLY CONSTANTLY. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK

VEHICLE IS DRIVEN VERY SLUGISH. ALSO, CONSUMER IS HAVING TROUBLE ACCELERATING. CONTACTED DEALER, AND THE DEALER STATED THAT IT COULD BE THE CONVERTER.*AK

WHEN DRIVING ON SLIGHT UPHILL ROADS AND MAKING TURNS LEFT OR RIGHT, LIKE ON RAMPS TO FREEWAY AT VERY SLOW SPEEDS, 5-10 MPH, VEHICLE IS HARD TO CONTROL. GOES ALL OVER ROAD, BRAKING MAKES IT WORSE. DEALER REPLACED STEERING GEAR AND TIRES. DID NOT REMEDY. TO DEALER 9 DAYS ONE TIME, ANOTHER 14 DAYS.*AK CONSUMER ALSO STATES ENGINE MAKES A GRINDING NOISE RIGHT AFTER START-UP.*JB

THE VEHICLE SMELLS LIKE ROTTEN EGGS ON THE INSIDE AND OUTSIDE, THERE IS ALSO A BURNING SMELL, POSSIBLY AN EXHAUST SYSTEM FAILURE, HOWEVER DEALERSHIP WAS NOT ABLE TO IDENTIFY SOURCE. NLM