2006 FORD EXPLORER Engine Problems

The contact owns a 2006 Ford Explorer. The contact stated while driving at an undisclosed speed, the engine seized. The vehicle was driven to the shoulder of the road. The contact parked the vehicle and allowed the vehicle to set for a while. The vehicle was started. The contact stated that the vehicle was driven 100 yards before the failure reoccurred. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

Mileage: 150,000

Complete failure of the powertrain electrical harness. Heat degradation to wire insulation has exposed all conductors. Several other owner operators have experienced the same issue wherein the Dealer has attempted repair of existing trouble codes, by replacing sensors, modules and components. Problems range from vehicle shut-off at speed, vehicle fires, no-start and failed PCM modules due to short to power or short to ground. Based on my findings, this specifically impacts vehicles ranging from 2006-2010, Ford Explorer or Mercury Mountaineer with the 4.0L SOHC engine.

DRIVING ON SPEED LIMIT I STOPPED AT A LIGHT, CAR ENGINE WENT DEAD. I TURNED KEY OFF AND WAITED A FEW MINUTES, TURNED KEY ON, CAR STARTED AS NOTHING WAS WRONG. IT HAS HAPPENED 3 TIMES IN THE PAST YEAR. BATTERY AND ALTERNATOR ARE PRETTY NEW. DECIDED TO TAKE TO AN AUTHORIZED MECHANIC DEALER, COULDN'T FIND ANYTHING WRONG WITH THE ENGINE. REALLY? WHAT IF I WAS DRIVING IN A HIGHWAY? CERTAINLY I WOULDN'T BE ALIVE TO REPORT IT!

Mileage: 159,000

RADIATOR FLUID EXPLODED ALL OVER ENGINE AND FLOOR MASSIVE LEAK . SEARCHED IT UP ON INTERNET AND SEEMS THIS IS A COMMON PROBLEM WITH THIS VEHICLE . I STARTED VEHICLE AND FLUID STARTED GOING EVERYWHERE .I DROVE MAYBE 10 FEET AND SHUT THE CAR OFF IMMEDIATELY . *TR

Mileage: 36,300

I HAVE NOW HAD 2 PROBLEMS WITH THIS DEALERSHIP, AND PERSONALLY I BELIEVE EVERYONE DESERVES SECOND CHANCES, THE FIRST VEHICLE THE SELLER SOLD ME HAD MAJOR ISSUES WITH GAS TANK HAD A HOLE IN IT AND EXPOSED WIRES RIGHT NEXT TO IT SO THAT TRUCK WAS A TICKING TIME BOMB, NOW I HAVE A 2006 FORD EXPLORER WITH MORE ISSUES BUT AGAIN THE SELLER MAKES ITS SEEM LIKE A PRETTY RELIABLE CAR AND LIES ABOUT THE ISSUES, COVERS UP THE STORIES AND THANK GOD MY BUDDY IS A MECHANIC AND I TAKE EVERYTHING I BUY TO HIM, WHEN I FIRST RECEIVED THE CAR, (AS MANY PEOPLE NOT MANY PEOPLE KNOW ANYTHING AS SOON AS THEY HEAR A WEIRD NOISE) I TOOK IT TO HIM AND HE RIDES WITH ME AND NOTICES SOME MAJOR ISSUES, I TOOK IT FOR A DRIVE AND THE BACK SUSPENSION WAS GOING OUT (GOT THAT REPLACED) THEN THE TRANSMISSION SLIPPING , LIKE NOT ONLY WAS LIED TO BUT NOW HAVING TO PAY 2000$ JUST TO KEEP THE CAR RUNNING, NOT SUITABLE FOR ME NOR ANYONE, I FEEL BAD FOR WHOEVER THIS SELLER ALSO LIES TO. AND I AM FULLY AWARE THAT SOMEONE COULD GET THEIR LICENSE REVOKED FOR STUFF LIKE THIS, IF ANYONE WITH CLEAR EYES CAN SEE THIS SELLER SCREWS PEOPLE OVER. I TEXTED THE GUY ABOUT RETURNING THE VEHICLE AND JUST TO GET MY MONEY BACK BUT YET AGAIN NO ANSWER.

Mileage: 131,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT VARIOUS WARNING INDICATORS FLASHED AND THE VEHICLE STALLED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FLY BY WIRE PEDAL AND THE THROTTLE BODY WERE REPLACED, BUT THE FAILURE CONTINUED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Mileage: 150,000

TRANSMISSION IS SLIPPING BAD AND CAR NOT SHIFTING INTO DRIVE

I OWN A 2006 FORD EXPLORER EDDIE BAUER , BOUGHT USED IN 2011/61000K. SINCE 2012 THE CAR STARTED SHOWING PROBLEMS WITH THE POWER STEERING AND /OR ENGINE. WHEN DRIVING AT 35-40 MPH ON A HIGHWAY THE CAR STARTED TO SURGE FORWARD, THEN BACK, KEEPING SURGING UNTIL THE CAR REACHED A HIGHER SPEED OF 60. IF DRIVING ON A HILL, IT WILL LOOSE ITS SPEED. I TOOK THE CAR TO FORD DEALER AND THEY COULDN'T FIND THE PROBLEM. THE CAR NOW IS 120000K, STILL SAME PROBLEM. VERY DISAPPOINTED WITH FORD THAT WILL NOT TAKE RESPONSIBILITY FOR THE PROBLEMAS.

Mileage: 85,000

THE CAR WAS SOLD WITH LIMITED WARRANTY, USED, BUT HAD WRITTEN COLD START ISSUE. THE VEHICLE GETS WARM IF WARM OUTSIDE AND WILL JUST COMPLETELY SHUT OFF ANYWHERE AT ANYTIME. RIDING DOWN INTERSTATE, WILL LOSE POWER THEN SHUT OFF AND LEAVE YOU WITH NO POWER STEERING TO CONTROL VEHICLE GOING HIGH SPEEDS, WILL SHUT OFF IN TOWN MULTIPLE TIMES UPWARD OF A DOZEN OR MORE TIMES WHILE DRIVING, 1ST SHOP SENT TO SAID COULDN'T FIND ISSUE SECOND THEY SENT ME TOO SAID COMPUTER NEEDED REPLACING. EITHER WAY I NEVER WOULD HAVE PURCHASED IT WITHOUT IT BEING DONE HAD U KNOWN, MY FIANCE IS SMALL AND NO WAY SHE COULD HANDLE THE VEHICLE IF SHUTTING DOWN WHILE DRIVING. ITS VERY DANGEROUS AND IS GOING TO GET SOMEONE KILLED IF NOT REPAIRED AND LOOKED INTO MORE CLOSELY.

Mileage: 120,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED TWO MORE TIMES. THE VEHICLE WAS TAKEN TO TRI STAR FORD (930 OLD US HWY 22, BLAIRSVILLE, PA 15717), BUT THE DEALER WAS UNABLE TO DIAGNOSE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO ANOTHER DEALER. THE APPROXIMATE FAILURE MILEAGE WAS 37,500. THE VIN WAS UNAVAILABLE.

Mileage: 37,500

GOT 2006 EDDIE BAUER W/98,000, 1 PREVIOUS OWNER (MOTHER) ALL SERVICING VIA THE SAME FORD DEALER (GENE BUTMAN), EXCEPT FOR A FEW OIL CHANGES FROM UNCLE ED'S. LATE NOV 2016 TOOK IT IN DUE TO THE HEAT WAS FLUCTUATING, WAS TOLD IT NEEDED THE THERMOSTAT AND HOUSING REPLACED (EVEN THOUGH IT HAD THE RADIATOR REPLACED A FEW YEARS EARLIER), ALSO HAD BRAKES & ROTORS DONE, THE 100,000 MILE CHECKUP SAID ALL WAS GOOD. A WEEK LATER THE EXHAUST FLUTE, ETC BROKE LOSE, GOT THAT REPAIRED & $2,000 LATER, FRIDAY 2/03/17 WRENCH LIGHT CAME ON, THEN ENGINE LIGHT, VEHICLE SEEMED TO LUNGE FORWARD, DELAY, DOESN'T ENGAGE..ACCELERATE, FEELS LIKE THE TRANSMISSION IS HANGING AND THEN SLAMS INTO GEAR. A THUD FEELING WAS ALSO REPORTED BY MY MOTHER SEVERAL TIMES IN PREVIOUS YEARS TO THE DEALER, THEY COULD NOT FIND ANYTHING WRONG, SO SHE HAD THEN DOCUMENT IT. TODAY I AM TOLD A TRANSMISSION IS NEEDED, WHICH IS A UNEXPECTED HUGE & SADDENING SURPRISE - IN 2012 AND 2013 THERE HAD ALREADY BEEN TRANSMISSION WORK ON THE VEHICLE. CHECKED AND SEE ALL REPORTS ABOUT THIS PARTICULAR MODEL HAS OCCURRED ON THIS ONE, COOLING SYSTEM/RADIATOR/THERMOSTAT AND HOUSING ISSUES, EXHAUST ISSUES AND NOW TRANSMISSION ISSUES -- THERE ARE THOUSANDS OF REPORTS FOR THIS EXACT MODEL AND OTHER EXPLORER AND FORD VEHICLES, ALL KNOWN ISSUES, MANY EXPLANATIONS WHY IT OCCURRED WITH THIS MODEL AND THAT FORD IS AWARE OF THEM AND HAS PROVIDED NO RECALLS FOR ANY OF THESE SERIOUS DEFECTIVE MATTERS, NONE - ESPECIALLY WHEN EACH ARE VERY DANGEROUS MATTERS. TODAY I AM TOLD, THAT A NEW TRANSMISSION WILL BE: $5,400, 3 YEAR WARRANTY AND A USED TRANSMISSION: $3,600 12 MOS OR 12,000 MILES. BOTH OPTIONS ARE VERY VERY EXPENSIVE. WHAT CAN NHTSA DO, WILL A RECALL EVER OCCUR? IT SEEMS FORD NEEDS TO STEP IN AND HELP WITH THESE REPAIRS. IT THERE ANY HELP WITH THESE MATTERS & COST? HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2006/ .

Mileage: 100,100

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER. IN ADDITION, THE CONTACT NOTICED STEAM COMING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE COMPRESSOR FAILED AND THE CHECK ENGINE INDICATOR WAS DISABLED. AS A RESULT, THE ELECTRONIC CONTROL MODULE CAUSED THE VEHICLE TO MALFUNCTION. THE COMPRESSOR WAS REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000.

Mileage: 109,000

CAR SHUTS OFF WHILE DRIVING. THIS HAS HAPPENED ABOUT 6 TIMES IN THE LAST TWO MONTHS. ALWAYS AT SPEEDS UNDER 40 MPH AND ALWAYS WITHIN 3 MINUTES OF TURNING THE CAR ON. THERE'S NEVER ANY WARNING OR SMELL OR SOUND. DASH GOES BLACK, RADIO CUTS OFF, POWER STEERING FAILS, AND I HAVE TO COAST TO THE SIDE OF THE ROAD. OBVIOUSLY THIS IS VERY FRIGHTENING AND I'VE BEEN VERY LUCKY THAT IT HAS NOT YET HAPPENED AT LIGHTS OR TURNS. MY CAR GUY IS REALLY GOOD AND HE'S AT A LOSS. HE THINKS MAYBE IT'S A SECURITY SYSTEM MALFUNCTION. I DRIVE WITH CHILDREN IN THE CAR AND I CAN'T AFFORD A TO BUY A NEW CAR. I'M NOT SURE WHAT MY OTHER OPTIONS ARE.

Mileage: 179,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THEENGINESTALLED WITHOUTWARNING. THE VEHICLE RESTARTED AFTER NUMEROUS ATTEMPTS. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED.THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE.THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE.

CHECK ENGINE LITE AND ORANGE WRENCH LITE WHICH SHUTS CAR DOWN NO EXCELRATION PEDAL POWER STEERING GONE AND NO BRAKE CONTROL ON FREEWAY COMING HOME. TRANS. WILL NOT SHIFT AND JUMPS WHEN WRENCH LITE IS ON VERY DANGEROUS THIS HAS BEEN GOING ON SINCE APRIL TOOK BACK TO DEALER SENT TO MECHANIC REPLACED 2 PARTS ON EXCELLERATION MODULE. STILL NOT RIGHT.

Mileage: 16,200

DOES THE CLASS ACTION LAWSUIT CONCERNING SPARK PLUGS INCLUDE THIS MODEL OF EXPLORERS? THE V8 4.6L EDDIE BAUER EDITION-IF NOT, IT SHOULD, AS WE WERE TOLD THE SAME INFO ON SPARKS PLUGS BREAKING OFF IF NOT DONE WITH A SPECIAL EXTRACTION TOOL. WE HAD DIAGNOSTICS DONE AND DEPENDING ON WHAT HAPPENED WHEN REMOVED AND CHANGED COULD COST ANYWHERE BETWEEN $600-$1500. SPECIFICALLY TOLD "DO NOT ATTEMPT YOURSELF." SERVICE WAS PERFORMED JUNE 19, 2014 BY A LOCAL FORD DEALER.

Mileage: 98,000

FIRST PROBLEM STARTED WITH THE BRAIN IN THE TRANSMISSION AREA. HESITATING, LUNGING FORWARD AND TACHOMETER JUMPING WHEN TAKING OFF AND DURING DRIVING DOWN THE ROADS/HIGHWAYS. HAD DIAGNOSTICS TESTS DONE (MARCH 3, 2016.) REPLACED BRAIN AND IT STOPPED THE HESITATION, LUNGING AND TACHOMETER JUMPING=$2700.00. NEXT PROBLEM CAME ALONG WHEN WE STARTED HEARING A TICKING SOUND WHEN IT WAS STARTED IN THE DRIVEWAY(MAY 16, 2016.) COME TO FIND OUT THE ENGINE WAS BLOWN WHICH IS NOW GOING TO COST $6700.00. WE HAVE ALWAYS MAINTAINED OUR VEHICLES WITH PROPER CARE AND ATTENTION, BUT HOW CAN ALL THESE MAJOR THINGS GO WRONG AT ONLY 108000 MILES???

Mileage: 108,000

TAKATA RECALL

I BOUGHT A 2006 EXPLORER IN 2010 AND IN 5 YEARS I HAVE HAD A SENSOR THAT'S GOES INSIDE THE TRANSMISSION REPLACED, THEN TRANSMISSION REBUILTED, AND THE RADIATOR REPLACED TWICE. NOW THAT IT'S PAID OFF LEAKING COOLANT AGAIN MAKING IT RUN HOT. NOW IT SAYING CHECK THE CHARGING SYSTEM AND STOP ON ME ON THE FREEWAY AND NOW WON'T STAY STARTED. THOUGHT I WAS DOING EVERYTHING RIGHT WITH THE MAINTENANCE OF THE TRUCK BUT IT KEEPS BREAKING DOWN. ALSO THE WRENCH THING IS ON AND WON'T STAY STARTED EVEN WHILE PRESSING THE GAS PEDAL TO THE FLOOR ALL AFTER I JUST HAD ANOTHER SENSOR REPLACED. AND BESIDES THE RADIATOR LEAKING AGAIN THAT PLASTIC THING THEY CALL A THERMOSTAT HOUSING MAY BE CRACKED. I FEEL I'M SPENDING MORE MONEY REPAIRING THINGS ON THIS TRUCK IN 5 YEARS THAT MOST PEOPLE SPEND ON A NEW CAR. IF I HAD SEEN ALL THE PROBLEMS THIS MODEL YEAR WAS HAVING WOULD HAVE WENT A DIFFERENT BRAND.

Mileage: 190,149

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED TEN TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNDETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

DRIVING ON A HIGHWAY I-95 IN FLORIDA. THE VEHICLE STARTED TO MISS AS WE ACCELERATED. WE TOOK THE CAR INTO A FORD DEALER SERVICE FOR PLUG REPLACEMENT. THIS AUTO HAS A 4.6 LITRE V-8 ENGINE. WE WERE AMAZED TO FIND THAT IT WILL COST UPWARDS OF $1000.00 TO REPLACE 8 SPARK PLUGS. THAT COST ESCULATES IF ANY PLUGS ARE BROKEN. THE PLUGS ARE TWO PIECE CONSTRUCTION AND SEPARATE ON REMOVAL. ONLY FORD CAN REMOVE THE PLUGS AND MORE WILL BE CHARGED FOR ANY BROKEN. IT IS IMPOSSIBLE TO REMOVE THESE PLUGS WITHOUT BREAKAGE. FORD RECOMMENDS NOT CHANGING THE PLUGS UNTIL 100,000 MILES. BY THAT TIME YOU ARE OUT OF GUARANTY AND IF THEY ARE HARD TO COME OUT AT 60,000 MILES IMAGINE IF THEY ARE LEFT IN. THESE PLUGS ARE KNOWN TO BLOW OUT OF THE HEAD AND I AM SURE THERE ARE MANY ACCIDENTS. I AM A DISABLED VETERAN 83 YEARS OLD AND A MECHANICAL ENGINEER. MY WIFE AND I ARE FISHERMEN AND NEED A VEHICLE TO BRING OUR BOAT TO WATER. WE ARE AVID FORD OWNERS AND ARE GREATLY DISSAPOINTED.

Mileage: 61,000

PURCHASE THIS VEHICLE IN 2011 ONCE IT WAS HOME WITHIN 3 MONTHS BEGAN HAVING PROBLEMS, I ALSO PURCHASE THE FORD EXTENDED WARRANTY AND TOOK IT BACK TO THE DEALERSHIP. THEY EXPLAINED THEY COULD NOT FIND AN ISSUE WITH THE TRANSMISSION. IT JOLTS, LUNGES, AND SOMETIMES THE TRANSMISSION DOESN'T ENGAGE. I FEEL EXTREMELY UNSAFE TRYING TO PULL OUT AT AN INTERSECTION BECAUSE THE CAR STARTS TO JOLT AND I HAVE TO SLAM ON THE GAS IN ORDER FOR THE CAR TO GO.IT IS HORRIBLE AND I FEEL VERY UNSAFE DRIVING; ESPECIALLY WITH MY CHILDREN IN THE CAR. EVEN IF I AM DRIVING ON THE INTERSTATE I HAVE TO PUT THE CAR INTO OVERDRIVE TO STOP THE MAJORITY OF THE JOLTING, AND THAT DOES NOT EVEN GUARANTEE IT WILL STOP. IT HAS BEEN A BATTLE WITH THE DEALERSHIP. HAD IT INDEPENDENTLY CHECKED BY AAMCO AND THE TRANSMISSION REPLACED, BUT THE ISSUE STILL OCCURS. NOT SURE WHAT CAN BE DONE. THIS VEHICLE NEEDS TO BE RECALLED. *TR

Mileage: 69,364

I BOUGHT MY FIRST FORD EXPLORER ALMOST 8 YEARS AGO. I HAD ABSOLUTELY NO PROBLEMS WITH THIS VEHICLE AND FELT VERY SAFE DRIVING MY NEWBORN SON. I HAD A SECOND SON AND DECIDED TO BUY A NEW FORD EXPLORER BECAUSE IT WAS SUCH A DEPENDABLE CAR. NOW I AM REGRETTING THAT DECISION. I BOUGHT A 2006 FORD EXPLORER AT ROUND 60,000 MILES. IT NOW HAS 70,000 AND I HAVE ALREADY HAD TO GET ANOTHER TRANSMISSION AND IT STILL HAS NOT FIXED THE PROBLEM. IT JOLTS, LUNGES, AND SOMETIMES THE TRANSMISSION DOESN'T ENGAGE. I FEEL EXTREMELY UNSAFE TRYING TO PULL OUT AT AN INTERSECTION BECAUSE THE CAR STARTS TO JOLT AND I HAVE TO SLAM ON THE GAS IN ORDER FOR THE CAR TO GO.IT IS HORRIBLE AND I FEEL VERY UNSAFE DRIVING; ESPECIALLY WITH MY CHILDREN IN THE CAR. EVEN IF I AM DRIVING ON THE INTERSTATE I HAVE TO PUT THE CAR INTO OVERDRIVE TO STOP THE MAJORITY OF THE JOLTING, AND THAT DOES NOT EVEN GUARANTEE IT WILL STOP. MY HUSBAND IS IN THE MILITARY AND GONE A GREAT DEAL. HE SHOULD NOT HAVE TO WORRY ABOUT THE SAFETY OF HIS CHILDREN OR WIFE WHEN HE IS DEPLOYED OVERSEAS OR WHEN HE IS TRAINING AWAY FROM HOME. HE IS CURRENTLY AWAY FROM HOME FOR TRAINING, GETTING READY FOR DEPLOYMENT. HE IS CALLING EVERY CHANCE HE GETS TO MAKE SURE THE CAR HAS NOT BROKEN DOWN OR WE HAVE NOT BEEN IN AND ACCIDENT DUE TO THIS VERY HORRIBLE VEHICLE. IF I HAD ENOUGH MONEY I WOULD BUY ANOTHER VEHICLE AND TELL EVERYONE NOT TO EVER BUY A FORD AGAIN. I THINK I AM MORE UPSET WITH THE FACT THAT MY HUSBAND IS POSSIBLE BEING SENT OVERSEAS IN OCTOBER, AND HE CANNOT EVEN GO TO WAR WITH THE KNOWLEDGE HIS FAMILY IS SAFE. I REALLY WISH SOMEONE WOULD UNDERSTAND THAT THIS IS A HUGE PROBLEM AND MAJOR SAFETY PROBLEM. PLEASE HELP ALL OF THE FAMILIES WITH THIS DEFECT. *TR

WE BOUGHT THIS USED FROM A USED CAR DEALERSHIP. THE VERY NEXT DAY I NOTICED WHILE DRIVING THE ENGINE JUST SHUT OFF. COUPLE MONTHS LATER THE SAME THING HAPPENED AND HAS CONTINUED TO HAPPEN OFTEN. LAST WEEK I WAS DRIVING 45 MPH ON A HIGHWAY IN THE RAIN AND LOST ALL CONTROL OF THE VEHICLE. THE BRAKES DIDN'T WORK, THE STEERING DIDN'T WORK, THE ENTIRE CAR SHUT DOWN, I HAD A PANIC ATTACK BECAUSE I WAS IN TRAFFIC AND ALMOST CAUSED A HUGE ACCIDENT WITH OTHER VEHICLES. I PUT ON THE HAZARDS AND FINALLY WAS ABLE TO DRIFT INTO A THE MIDDLE OF THE ROAD CALLED THE TURNING LANE. I CALLED THE DEALERSHIP MANY TIMES AND HAVE ONLY BEEN TOLD "WE ARE SORRY". I TRIED CALLING A LEMON LAW LAWYER BUT WAS TOLD, SORRY, IF THE TRUCK WAS A 2007 THEN I WOULD HAVE A CASE. SO, NOW WHAT DO I DO? I HAVE A 10,000 CAR LOAN FOR A VEHICLE THAT I AM FRIGHTENED TO DRIVE ANYWHERE. PLEASE HELP ME. *TR

Mileage: 88,000

I WAS DRIVING UP SMALL HILL-DRY CONDITIONS AND THE CAR SHUT DOWN. ON COMING VEHICLE SWERVED AND AVOIDED COLLISION. THIS HAS HAPPENED MANY TIMES AFTER THE TRACTION CONTROL SENSOR COMES ON. THE CAR ALSO JUMPS OUT WHEN SHIFTING GEARS AND SOMETIMES IT IS VERY HARD TO SHIFT. TRANSMISSION PROBLEM! SAFETY RECALL IMPERATIVE! *TR

Mileage: 64,863

I'VE HAD MULTIPLE PROBLEMS WITH THIS CAR. FIRST THE CAR SHIFTS HARD APPROX BETWEEN 10 MPH AND 20 MPH, THE CAR LUNGES, STALLS, THEN SHIFTS HARD INTO GEAR. WHEN IT FIRST HAPPENED, I TOOK THE CAR TO A CERTIFIED MECHANIC AND THEY DID A COMPLETE TRANSMISSION FLUSH... THE CAR RAN SMOOTH FOR ABOUT 10 DAYS, THEN IT STARTED LEAKING TRANSMISSION FLUID WHICH RESULTED IN MY RADIATOR BEING RUINED. REPLACED THE RADIATOR AND A PLUG IN THE TRANSMISSION. ($1,800) THE CAR THEN RAN FINE UP THIS PAST SUNDAY. THE CAR AS ME AND MY WIFE WERE DRIVING HOME FROM A 400 MILE TRIP WITH THE AC RUNNING, THE WRENCH LIGHT CAME ON AND THE CAR STARTED LUNGING AND SHIFTING HARD AGAIN. I EXITED OFF THE HIGHWAY AND THE CHECK ENGINE LIGHT CAME ON... THE CAR STARTED SHIFTING HARD BETWEEN 2ND AND 3RD GEAR AND MAKING A LOUD CLUNK NOISE. TOOK IT TO THE MECHANIC AND HE DID ANOTHER TRANSMISSION FLUSH ON MONDAY JUNE 16, 2014... TWO DAYS LATER AND THE CAR STILL LUNGES, STALLS, AND SHIFTS HARD. I CALLED FORD AND THEY SAID BECAUSE THE CAR IS OUT OF WARRANTY, THERE'S NOTHING THEY COULD DO. I EVEN ASKED THEM BECAUSE THERE ARE SO MANY COMPLAINTS ABOUT THE 2006 TRANSMISSION, THEY STILL COULDN'T HELP ME. THE SECOND PROBLEM IS THE CAR EVEN THOUGH IN PARK, IT TENDS TO ROLL DOWN THE DRIVEWAY INTO THE STREET IN THE MIDDLE OF THE NIGHT/ EARLY MORNING... THIS HAPPENED A COUPLE OF TIMES... TOLD FORD ABOUT THE PROBLEM, AND BECAUSE THE CAR IS OUT OF WARRANTY THERE'S NOTHING THEY COULD DO... THE LAST PROBLEM IS EVERY ONCE AND A WHILE THE CAR DOESN'T SHIFT INTO REVERSE... TOLD FORD ABOUT THE PROBLEM AND ONCE AGAIN, BECAUSE THE CAR IS OUT OF WARRANTY THERE'S NOTHING THEY COULD DO... *TR

Mileage: 100,000

TL* THE CONTACT OWNS 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT LOW SPEEDS THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE COULD NOT BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000.

Mileage: 97,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 40 MPH, THERE WAS A LOUD NOISE IN THE FRONT END AS THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT HAD ALREADY TAKEN THE VEHICLE TO AN AUTHORIZED DEALER WHO REPLACED THE RADIATOR TWICE BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE RADIATOR AND ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE MULTIPLE TIMES AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS 44,000. THE VIN WAS NOT AVAILABLE.

Mileage: 44,000

WHILE TRAVELING ON THE HIGHWAY THE VEHICLE SUDDENLY LOST POWER AS IF IT STALLED. ENGINE WAS RUNNING BUT VEHICLE HAD NO POWER. VEHICLE HAD TO BE TURNED OFF AND RESTARTED TO REGAIN POWER. ALWAYS FEARED BEING REAR ENDED OR STALLING ON RAILROAD TRACKS. DEALER DETERMINED IT WAS ELECTRONIC THROTTLE CONTROL AND REPLACED IT. THE VEHICLE HAS NOT HAD THIS MALFUNCTION SINCE THE REPAIR ABOUT 18 MONTHS AGO. *TR

Mileage: 80,000

SHIFTING OF TRANSMISSION SLAMS HARD ON A FAST TAKE OFF, THEN AT 45 OR ABOVE CYCLES GEARS AND WON'T STAY IN OVERDRIVE. *TR

Mileage: 72,000

DRIVING AT 45 MPH ,TRANSMISSION SHIFTED WITH A JERKY MOTION ,FIRST STARTED THEN.WHEN YOU FIRST TAKE OFF IT JERKS AND MAKES A NOISE. WHEN YOU BACK UP IT JERKS HARD ENOUGH IT WHIPS YOU BODY BACK. HAD IT CHECKED AT A TRANSMISSION PLACE. THEY TORE IT DOWN AND FOUND NOTHING ( $400). STILL JERKS AND SHIFTS ROUGH. DON'T KNOW HOW LONG IT'S GOING TO LAST. *TR

Mileage: 40,130

DEAR SIR FIRST OF ALL , I WOULD LIKE TO STATE THAT I AM NOT A US CITIZEN , BUT , I'M A FAMILY MAN & I FEEL FOR OTHERS , I OWN A FORD EXPLORER 06 , AND RECENTLY I'VE BEEN NOTICING THAT THE TRANS HAS A MIND OF IT'S OWN , SHIFTING WRONGLY , JOLTING INTO GEAR IS NOT ENJOYABLE OR SAFE, THE OTHER DAY I WAS ABOUT TO HAVE AN ACCIDENT BECAUSE THE TRANS REFUSED TO SHIFT WHEN I TRIED TO ACCELERATE IN ORDER TO ESCAPE A SITUATION OF HITTING A CAR NEXT TO ME , I'VE LOOKED IT UP ON THE INTERNET & FOUND THAT EVERYBODY IS COMPLAINING OF THE SAME ISSUES , YOU CAN GO FOR THE BELOW SITE & CHECK HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2006/TRANSMISSION/TRANSMISSION_LUNGES_HARD_JOLT_WHEN_SHIFTING.SHTML THE PROBLEM IS THAT FORD WON'T ADMIT THAT THERE IS SOMETHING WRONG WITH THE TRANSMISSION , PUTTING PEOPLES LIFE IN DANGER FOR A FEW DOLLARS MORE PLEASE FIX THIS AS IT'S VERY CRITICAL & DANGEROUS AT THE SAME TIME [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 123,031

SINCE PURCHASING THIS VEHICLE NEW IN JANUARY 2007 THE RADIATOR HAS BEEN REPLACED TWICE. NOW, IN DECEMBER 2013 WITH 114000 MILES, THE RADIATOR IS LOSING COOLANT AND THE ENGINE SMELLS OF COOLANT AFTER DRIVING. MOST LIKELY THE RADIATOR WILL HAVE TO BE REPLACED FOR THE THIRD TIME. *TR

Mileage: 25,000

WE BOUGHT THE USED VEHICLE IN MARCH 2012 WITH A 30 DAY WARRANTY. DURING THE FIRST MONTH, NOTICED ENGINE SLIPPING (USUALLY AROUND 45 MPH). CHECKED FLUIDS, ADDED COOLANT AND NAIVELY THOUGHT THE PROBLEM WOULD GO AWAY, AND IT SEEMED TO FOR ABOUT A MONTH. HOWEVER, THE ENGINE/TRANSMISSION SLIPPAGE HAS GOTTEN MUCH WORSE SINCE THEN. WE ARE CONSTANTLY ADDING COOLANT AND DRIVING VERY CAREFULLY TO AVOID A HARD JERK IN THE TRANSMISSION AROUND 45 MPH. WHEN WE TOOK IT TO THE LOCAL FORD DEALERSHIP, THEY SAID THAT THE "TRANSMISSION WAS PROBABLY SHOT" BUT THAT THEY COULD CHANGE THE SPARK PLUGS "FOR ABOUT $250 EACH EVEN THOUGH THAT PROBABLY WOULDN'T HELP." HOW IN THE WORLD CAN A SPARK PLUG BE THIS EXPENSIVE TO CHANGE? THE DEALERSHIP CHARGED US NEARLY $200 TO RUN DIAGNOSTICS FOR A PROBLEM THAT WE NOW KNOW IS RELATED TO THIS PARTICULAR VEHICLE. THIS SHOULD HAVE LONG AGO BEEN A RECALL, AND FORD SHOULD BE ASHAMED OF ITSELF FOR NOT FIXING THE PROBLEM SOONER. *TR

Mileage: 97,000

MY SON WAS DRIVING HOME AND THE TRUCK STARTED JERKING UNCONTROLLABLY AND HE COULDN'T BACK UP SO HAD TO CALL A TOW TRUCK. ALL OF THE TRANSMISSION FLUID HAD LEAKED OUT DUE TO RADIATOR FAILURE. THE TRUCK WAS OFF WARRANTY SO HAD TO BUY A NEW RADIATOR. IN ORDER FOR THE RADIATOR TO HAVE A WARRANTY HAD TO BUY ANOTHER PART FROM THE FORD PLACE FOR 200.00. GOT THE PART AND RADIATOR. WITHIN SIX MONTHS TO A YEAR, SAME THING HAPPENED, HAD TO HAVE ANOTHER RADIATOR. HAVE HAD THREE RADIATORS AND NOW THIS YEAR 2013 LEAKING AGAIN AND THE RADIATOR THAT I PAID $600.00 FOR THE RADIATOR PLACE HAS WENT OUT OF BUSINESS SO I HAVE TO BUY ANOTHER RADIATOR. THIS IS AN ONGOING PROBLEM WITH THIS 2006 FORD EXPLORER XLT AND FORD KNOWS ABOUT IT. I AM AFRAID TO DRIVE IT HALF THE TIME, NEVER KNOW WHEN I WON'T BE ABLE TO MOVE IT IF ALL OF THE FLUID LEAKS OUT OR MAY STOP IN TRAFFIC SUDDENLY. PLEASE HELP US TO GET FORD TO RECALL THESE TRUCKS. *TR

Mileage: 19,000

BOTH OF THESE THINGS HAVE BEEN HAPPENING OVER THE LAST 2-3 YEARS BUT I CAN NOT REMEMBER EXACT DATES. FIRST MY CAR HAS BEEN RUNNING HOT CONTINUOUSLY OVER THIS PERIOD OF TIME WHICH CAUSES ME TO HAVE TO PUT COOLANT IN AT LEAST ONCE EVERY MONTH. I TOOK IT TO THE DEALERSHIP AND THEY TOLD ME THIS WAS COMMON WITH THE EXPLORERS BUT THERE HAS NOT BEEN A RECALL SO I WOULD HAVE TO PAY OUT OF POCKET. THEY FIRST TOLD ME IT WAS THE LINE TO THE RADIATOR THAT WAS LEAKING SO I HAD IT REPLACED, THEN NEXT TIME IT WAS THE THERMOSTAT AND HOUSING THAT THEY SAID WAS THE PROBLEM. SO I HAD THIS REPLACED. NOW TODAY 9/19/2013 I HAD TO REPLACE THE RADIATOR. IT DOESN'T MATTER WHAT I SEEM TO FIX THIS PROBLEM CONTINUES TO OCCUR. SECONDLY MY CAR JERKS INTO GEAR WHEN I TRY TO PUT IN GEAR. THEY ARE TELLING ME NOW I NEED A TRANSMISSION BUT I SEE THIS IS A RECURRING PROBLEMS WITH MANY EXPLORERS OWNERS AND IT DOESN'T FIX THE PROBLEM EITHER. I DON'T KNOW WHAT ELSE TO DO BECAUSE MY CAR IS JERKING WHICH CAUSES ME TO ALMOST HIT PEOPLE OR DOESN'T GO INTO GEAR FAST ENOUGH WHICH CAUSES THEM TO ALMOST HIT ME. PLEASE HELP!!! THESE PROBLEMS FIRST STARTED TO OCCUR AROUND 40000 MILES. MY PROBLEM IS RADIATOR AND TRANSMISSION. *JB

Mileage: 97,468

WHILE DRIVING AT 40 MPH CAR SPEED WENT TO 0 MPH, TRANSMISSION TOTALLY SLIPPED. SECOND TIME IT HAS HAPPENED. ONCE I SIT THERE FOR ABOUT 15 MINUTES ON SIDE OF ROAD IT WILL THEY START TO WORK AS IT SHOULD. BUT IT DOES MAKE LOUD NOISES WHILE MOTOR SHIFTS GEARS. THIS IS A KNOWN TRANSMISSION PROBLEM YET NO FORD RECALL. UNACCEPTABLE!!! *TR

Mileage: 77,180

TRANSMISSION DISENGAGED AT RED LIGHT. IT STARTED GOING BACKWARDS INSTEAD OF FORWARD. HAD TO PUT INTO PARK AND THEN BACK INTO DRIVE TO GET IT TO DRIVE. STILL GOING ON. NOW WHEN ACTUALLY ON THE ROAD IT IS GETTING OUT OF GEAR WHEN VEHICLE IS AT DRIVING SPEED. ENGINE REVS UP TO 5000RPMS, THEN DOWN TO 1000RPM. VEHICLE LUNGING. WILL GET HURT I'M SURE. *TR

Mileage: 87,000

FROM JULY 5TH TO PRESENT MY 2006 FORD EXPLORER TRUCK WAS TOED TO THE DEALERSHIP 3 TIMES. EACH TIME IT WAS FOR THE SAME PROBLEM OVERHEATING. THIS HAS BEEN A CONSTANT PROBLEM WITH THIS CAR SINCE IT WAS PURCHASED IN DECEMBER 2005. THE RADIATOR HAS BEEN REPLACE TWICE, THE TRANSMISSION ONCE, THE THROTTLE , ETC. I HAVE BEEN TOLD THAT NOW AFTER THE RADIATOR WAS A REPLACED AND THE THROTTLE, ETC. AT A COST OF $2300.00.THE CAR NOW NEEDS A NEW ENGINE AND /OR GASKETS THAT NEED REPLACING. I CANNOT UNDERSTAND WHY A CAR WITH NORMAL MILEAGE, WHICH WAS ONLY INVOLVED IN ONE MINOR FENDER BENDER.CAN NEED SO MUCH MAJOR WORK. *TR

Mileage: 70,000

I WAS DRIVING 25 MPH AND TURNING LEFT TO A SMALL STREET. I SAW AN ENGINE LIGHT SHOW ON, AND THEN THE ENGINE STOP. AT THAT POINT, I COULDN'T TURN THE WHEEL, AND ALSO IT WAS SO DIFFICULT FOR ME TO STOP THE VEHICLE. I HAD MENTION THIS PROBLEM AT THE FORD DEALER IN GREENFIELD, MA WHO FIXED MY ABS BREAK ABOUT TWO WEEKS AGO. A PERSON AT THE SERVICE RESPONDED, " THAT'S NORMAL. OUR COMPUTER DOES NOT SEE OTHER ISSUE BESIDE THE ABS." I SPEND $85 FOR DIAGNOSIS THE ABS BREAK PROBLEM AND SPEND ALMOST $500.00 TO FIX THE BREAK. I TOOK MY VEHICLE TO A SMALL BODY SHOP IN MY AREA. THIS PERSON RAN THE COMPUTER THROUGH THE VEHICLE SYSTEM, AND THE COMPUTER DID NOT SHOWN ANY PROBLEMS. THEN, I CALLED FORD CORPORATE AND TRIED TO GET SOME ADVICE FROM THE COMPANY. THE COMPANY SAID I SHOULD TAKE THE VEHICLE TO A DIFFERENT DEALER TO GET OTHER OPINION. MEANING THAT I HAVE TO PAY ANOTHER $85.00 AGAIN, AND I STILL DO NOT KNOW I WILL GET AN ANSWER OR NOT. MY CONCERN, I DO NOT WANT TO CAUSE AN ACCIDENT. *TR

Mileage: 92,500

UPON STARTING THE VEHICLE IT SUDDENLY EXCELERATES. I NOW KEEP MY FOOT ON THE BRAKE AT ALL TIMES IMMEDIATELY FOLLOWING IGNITION. IT HAS HAS HAPPENED FOUR OR FIVE TIMES IN THE LAST SEVERAL MONTHS. I HAVE OWNED THE VEHICLE SINCE 2007 WHEN I PURCHASED IT FROM OCALA LINCOLN MERCURY AS A FORD CERTIFIED VEHICLE. IT HAD APPROXIMATELY 14,000. TODAY IT HAS ONLY 54,230 MOSTLY HIGHWAY. THAT IS LESS THAN 7000 MILES PER YEAR. ITR HAS REGULAR SERVICES AT MY LOCAL FOR DEALER. ALL OF MY REPAIR RECORDS ARE OBTAINABLE THROUGH THE FORD MOTOR COMPANY.

DURING A LEFT TURN ACROSS THREE LANES OF TRAFFIC OUR EXPLORER WOULD NOT ACCELERATE. IT LURCHED TO START AND WOULD NOT GO ABOVE 10-15 MPH, NEARLY STALLING. WE WERE ABLE TO DRIVE THE CAR HOME BUT COULD NOT GET IT TO GO ABOVE 20 MPH. AT SPEEDS 10 - 20 MPH IT JERKED VIOLENTLY. THIS WAS A COMMON OCCURRENCE AT SPEEDS 45 - 60. MODERATELY ACCELERATING BETWEEN 45 - 60 MPH HAS CAUSED HARD JERKS FOR YEARS WITH THIS CAR PRIOR TO IT BEING OFF WARRANTY. WE'VE TAKEN IT TO TED BRITT FORD SEVERAL TIMES AND EACH TIME THEY SAID THERE WAS NOTHING WRONG. WE ALSO NOTED THEY ONLY PUT IT ON THE TICKET ONCE, THE OTHER TIMES TELLING US THEY TOOK IT OFF SINCE THEY DIDN'T HAVE THE ISSUE AND WOULDN'T CHARGE US FOR IT. THE TIME MENTIONED IN THIS INCIDENT THE DEALER OFFERED TO SPLIT THE COST WITH US DUE TO OUR PREVIOUS ISSUES AND THEIR INABILITY TO FIX IT. THEY ALSO DID NOT FIX THE ISSUE AS WE STILL CANNOT ACCELERATE AT SPEEDS 45 - 60 WITHOUT HARD JERKING FROM THE ENGINE OR TRANSMISSION. WE NO LONGER USE THIS CAR ON THE HIGHWAY BECAUSE IT IS DANGEROUS TRYING TO SWITCH LANES OR MERGE ON TO A HIGHWAY WHEN THE CAR VIOLENTLY SHAKES AT HIGHWAY SPEEDS. IT WOULD NOT ACCELERATE AND OFTEN LEFT US RUNNING OUT OF MERGE LANE SPACE WITHOUT THE ABILITY TO GET INTO TRAFFIC. I HAVE READ SEVERAL SUCH PROBLEMS WITH THIS CAR AND I AM SURPRISED NOTHING HAS BEEN DONE ABOUT IT. WE HAVE SPENT THOUSANDS HAVING THIS CAR LOOKED AT AND IN FAILED ATTEMPTS TO FIX IT. *TR

Mileage: 70,000

WITH ONLY 86,000 MILES OUR FORD EXPLORERS TRANSMISSION HAS FAILED ONCE AGAIN. WHEN WE HAD 23,000 MILES ON OUR VEHICLE WE NOTICED THE TRANSMISSION WAS SHIFTING RATHER HARD AND TOOK IT TO THE DEALER AND THEY FOUND NOTHING WRONG. AT 58,000 MILES THE TRANSMISSION ENGAGEMENT WAS SO ROUGH THAT WE HAD TO GET IT REPAIRED. SINCE THE WARRANTY IS ONLY UP TO 36,000 WE DECIDED OUR BEST BET IS TO NOT TAKE IT TO THE DEALER. WE HAD THE VALVE BODY REPAIRED AND IT RAN FINE UP UNTIL NOW. 86,000 MILES AND THIS VEHICLE IS ONCE AGAIN AT A REPAIR SHOP HAVING THE TRANSMISSION FULLY REBUILT. IN THE TIME I HAVE OWNED THIS VEHICLE I HAVE PAID OVER $7,000 TO KEEP IT RUNNING WITH REGULAR MAINTENANCE, TIRES, RADIATOR REPAIR, BRAKES AND NOW THE THIRD TRANSMISSION. *TR

Mileage: 86,000

JUST LIKE MANY OTHERS WHO HAVE REPORTED THE SAME ISSUE WITH THEIR 2006 FORD EXPLORER, WHEN BACKING OUT OF THE DRIVEWAY, I PUT THE VEHICLE IN REVERSE. THERE WAS A JERK AS THE TRANSMISSION SEEMED TO FINALLY ENGAGE. I THOUGHT THE TRANS BROKE AT THE TIME? THIS HAS HAPPENED MORE THEN ONCE. I HAVE ALSO EXPERIENCED THE SAME ISSUE AS OTHERS WITH THE DELAYED SHIFTING FROM 1ST TO 2ND GEAR. MY EXPLORER HAS JUST 88K MILES ON IT. *TR

Mileage: 87,000

THE VEHICLE WAS DRIVING AT A SPEED OF 40-45 MPH AND STALLED. THIS AGAIN HAPPENED ON MAY 25, 2012 WHILE LEAVING ON OUR VACATION. WE PARKED THE VEHICLE AND RENTED ONE TO DRIVE THE REMAINING DISTANCE. WHEN TAKEN TO A MECHANIC IT WAS FOUND THE THROTTLE BODY WAS BAD. WE HAVE REPLACED IT AND IN THE MONTH OF NOVEMBER THE VEHICLE BEGAN DOING IT AGAIN. AS YOU DRIVE IT WILL JUST COMPLETELY SHUT OFF. AS THE MECHANIC TOLD US THERE IS NO ELECTRICITY GOING TO THE ENGINE AND YOU CAN COAST TO THE SHOULDER AND RESTART THE VEHICLE. THIS WILL BE THE 2ND TIME CORRECTING THIS PROBLEM IF THIS IS THE TRUE ISSUE. IT WAS READ THERE IS A RECALL ON FORD VEHICLES FOR THAT YEAR MAKE BUT NOT FOR THE EXPLORER MODEL. I HAVE CONTACTED FORD AND THEY ALSO STATED THERE IS NO RECALL. WITH THE AGE AND LOW MILEAGE OF THE VEHICLE THERE IS NO REASON THIS SHOULD BE HAPPENING. *TR

Mileage: 72,000

WHILE DRIVING TO FLORIDA FROM MISSOURI, TO TAKE MY KIDS TO DISNEYWORLD, WITH A CAR THAT WAS WELL KEPT AND RELATIVELY NEW, ON THE HIGHWAY A FEW MILES AFTER PENSACOLA, THE VEHICLE OVERHEATED AND STALLED, SO WE HAD TO STOP ON THE SIDE OF THE HIGHWAY AT NIGHT. STEAM WAS COMING OUT FROM A CRACK ON THE TOP OF THE RADIATOR. I HAD TO CALL FOR A TOWTRUCK AND LOST A COUPLE OF DAYS OF OUR VACATION UNTIL THE CLOSEST MECHANIC WE FOUND WAS ABLE TO REPLACE THE RADIATOR WITH A NEW ONE FROM FORD. I GOT STUCK WITH A $1000 BILL SINCE THE CAR WAS OUT OF WARRANTY. BUT THAT WAS NONE OF MY WORRIES. THE ISSUE WAS THAT THE CAR BROKE DOWN IN THE MIDDLE OF NOWHERE ON A HIGHWAY AT NIGHT WITH A LOT OF SPEEDING 18WHEELERS. AT 70000 MILES THE INCIDENT HAPPENED AGAIN. THE VEHICLE OVERHEATED AND STALLED ON A SHORT 30 MILE EXCURSION TO BRANSON MISSOURI. THE HILLY HIGHWAY LEADING TO BRANSON MISSOURI IS NOT THE BEST PLACE TO BREAK DOWN. OPENED THE HOOD ONLY TO SEE THE RADIATOR STEAMING AGAIN. THE CAR WAS TOWED AGAIN AND FIXED AT A $1200 BILL. THE VEHICLE IS A LEMON AND FORD SHOULD BE FORCED TO BUY IT BACK OR AT LEAST FIX THE PROBLEM PERMANENTLY. IT CAN BREAK DOWN ANYWHERE ANYTIME, AND BECAUSE THE WAY IT BREAKS DOWN AND STALLS BECAUSE OF THE OVERHEATING IT CAN CAUSE A REALLY BAD ACCIDENT IF YOU ARE UNLUCKY ENOUGH. *TR

Mileage: 38,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN AN ABNORMAL NOISE EMITTED FROM THE ENGINE COMPARTMENT. THE CONTACT MANEUVERED TO A SAFE LOCATION AND NOTICED AN EXCESSIVE AMOUNT OF RADIATOR FLUID LEAKING ONTO THE GROUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER THREE TIMES FOR THE DEFECT AND THE RADIATOR WAS REPLACED EACH TIME. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 32,000. THE VIN WAS NOT AVAILABLE.

Mileage: 32,000

RANGE SHIFTER NEEDS TO BE REPLACED, TRUCK IS JERKING WITH ACCELERATION AND CHANGING GOING BETWEEN 1ST TO 5TH GEAR JOLTING THE VEHICLE. VERY BIG SAFETY ISSUE AS I HAVE ALMOST BEEN REAR-ENDED MULTIPLE TIMES. FORD SAYS NO RECALL ON TRANSMISSION ISSUES. MINE IS A 6R60 TRANSMISSION IN THE 2006 EDDIE BAUER EXPLORER WHICH HAS THE RANGE SHIFTER LOCATED INSIDE TRANSMISSION. WILL COST $2300 TO FIX! *TR

Mileage: 87,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS ABNORMALLY LEAKING FLUID. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC WAS PERFORMED. THE DEALER ADVISED THE CONTACT THAT THE RADIATOR PLASTIC FAILED AND CAUSED THE RADIATOR CRIMP TO LEAK. THE CONTACT STATED THAT THE FAILURE ALSO OCCURRED IN 2010 AND THE RADIATOR WAS REPLACED AT THAT TIME. THE DEALER ADVISED THAT THE RADIATOR WOULD NEED TO BE REPLACED AGAIN. THE MANUFACTURE WAS CONTACT AND ADVISED THAT THERE WERE NO RECALLS FOR THE RADIATOR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 114,000.

Mileage: 74,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHEN DRIVING APPROXIMATELY 50 MPH THE TEMPERATURE GAUGE STARTED TO RISE. A FEW MILES DOWN THE HIGHWAY HE SAW A LARGE CLOUD OF SMOKE COMING FROM HIS ENGINE. THE CONTACT WAS ABLE TO MERGED TO THE SIDE OF THE ROAD AND HAVE THE VEHICLE TOWED. AFTER DIAGNOSIS FROM THE DEALER THEY ADVISED HIM THAT THE RADIATOR FRACTURED AND STARTED TO LEAK ONTO THE ENGINE. AS A RESULT, THE ENGINE AND RADIATOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 83,000.

Mileage: 83,000

FIRST INCIDENT OCCURRED IN EARLY APRIL 2012: MY CAR WAS EMITTING A FOUL SMELL AND OVERHEATING. UPON INSPECTION, IT WAS DISCOVERED THAT MY RADIATOR WAS LEAKING. I TURNED MY VEHICLE INTO FORD AND IT WAS REPLACED. SECOND INCIDENT OCCURRED EARLY-MID OCT 2012: MY CAR WAS JERKING AND THE CHECK ENGINE LIGHT CAME ON. IT WAS TAKEN TO HAVE THE CODES CHECKED AND IT WAS INDICATED THAT I HAD 2-3 RANDOM "MISS-FIRES" TO MY SPARK PLUGS. AS THIS IS NORMALLY AN EASY AT-HOME FIX, WE WERE ABLE TO REPLACE ALL THE SPARK PLUGS. THE ISSUE WITH THIS INCIDENT WAS THAT IN THE PROCESS OF REMOVING THE SPARK PLUGS, ALL BUT ONE BROKE IN HALF. THIS IS SUCH A COMMON PROBLEM THAT FORD HAS DESIGNED AND SELLS A SPECIFIC TOOL TO REMOVE BROKEN SPARK PLUGS. ONCE THE TOOL WAS PURCHASED, I WAS ABLE TO FIX THE PROBLEM AND MY CAR NO LONGER JERKED AND THE CHECK ENGINE LIGHT WENT OFF. THIRD INCIDENT OCCURRED LATE NOV 2012: VEHICLE STARTED JOLTING AND JERKING EXCESSIVELY AND CHECK ENGINE LIGHT CAME ON. FEELS LIKE TRANSMISSION IS NOT ENGAGING GEARS PROPERLY. AFTER MUCH RESEARCH, I FOUND THAT THIS IS A COMMON AND MAJOR SAFETY ISSUE REGARDING THIS VEHICLE. A SAFETY RECALL NEEDS TO BE DONE IMMINENTLY. ANOTHER ISSUE, STARTED IN THE END OF 2011: WHEN GOING FROM PARK TO REVERSE OR DRIVE, STICK SHIFT WILL STICK AND I WILL HAVE WIGGLE AND PULL HARD TO MAKE IT MOVE. *TR

WHEN I MOVED FROM PARK TO DRIVE THE TRANSMISSION JOLTED AND SLAMMED INTO GEAR... TODAY WHILE DRIVING THE TRUCK WENT FROM 40 TO ABOUT 10 MPH AND WILL NOT GO ABOVE THIS SPEED. *TR

Mileage: 65,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT PULLED THE VEHICLE OVER AND RESTARTED IT AND IT FUNCTIONED PROPERLY. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 73,000.

Mileage: 73,000

WHILE TRYING TO STOP MY VEHICLE SUDDENLY ACCELERATED AND I HAD TO PUT IT IN NEUTRAL TO COME TO A STOP. I PULLED INTO A PARKING LOT AND SHUT THE ENGINE OFF AND THEN STARTED IT UP AGAIN AND MY ENGINE REVVED AT AROUND 4000 RPM. THE ONLY WAY I COULD DRIVE THE VEHICLE HOME WAS TO KEEP CONSTANT HEAVY PRESSURE ON THE BRAKES. IT ALWAYS WANTED TO ACCELERATE. *TR

Mileage: 80,700

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP, THE VEHICLE HESITATED. THE CONTACT WAS ABLE TO ACCELERATE INTO TRAFFIC HOWEVER WITHIN MOMENTS, FIRE EMITTED FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE AND ADVISED THAT THE FIRE ORIGINATED FROM THE RIGHT SIDE OF THE ENGINE BAY AREA. THE FIRE HAD SPREAD TO THE WINDSHIELD AND DASHBOARD AS WELL. THE VEHICLE WAS TOWED TO THE DEALER WHO DID NOT ADVISE THE CONTACT ON THE CAUSE OF THE ENGINE FAILURE THAT COULD HAVE LED TO THE FIRE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

Mileage: 50,000

ENGINE LOST POWER AND BEGAN VIBRATING. ENGINE DRIVEN TO DEALERSHIP AND ENGINE LIGHT CAME ON. DEALERSHIP STATES "SEIZED" SPARK PLUG BUT BECAUSE PART IS DEFECTIVE WANTS TO REPLACE ALL EIGHT PLUGS. UNABLE TO QUOTE COST AS PLUGS ARE KNOWN TO BREAK OFF DURING REMOVAL. PLUG REPLACEMENT RECOMMENDED ORGINALLY TO BE 100000 NOW DROPPED TO 60,000. SERVICE WRITER STATED "YOU MUST HAVE HAD SOMEONE MESSING WITH YOUR SPARK PLUGS". TOLD HIM NO ONE HAS SERVICED MY CAR BUT HIS DEALERSHIP. SPECIAL TOOL DESIGNED BY FORD TO REMOVE THESE PLUGS. COST CANNOT BE QUOTED ($946 FOR ONE PLUG CHANGEOUT PLUS FULL SERVICE FUEL SERVICE PRIOR TO REMOVAL TO "LOOSEN" UP CARBON BUILDUP WHICH THEY SAY CAUSES THE PROBLEM WITH PLUG BREAKAGE) BUT COST RUNS INTO THOUSANDS OF DOLLARS AND SHAVINGS FROM REBORING THE PLUGS FOR REPLACEMENT OF DIFFERENT DESIGN PLUG CAN CAUSE ENGINE TO BE DAMAGED. CAR PURCHASED NEW IN 2006. ONLY DRIVER. ONLY DEALER SERVICED. THIS IS A TERRIBLE PROBLEM.

Mileage: 554,000

I NOTICED A YELLOW FLUID LEAKING FROM THE THERMOSTAT HOUSING. I TOOK IT TO A MECHANIC AND HE SAID THAT THE ANTIFREEZE WAS LEAKING FROM SOMEWHERE IN THE MANIFOLD, PROBABLY THE THERMOSTAT HOUSING. WE REPLACED THE THERMOSTAT HOUSING AND BRAND NEW O-RINGS AND ADDED SILICONE SEALANT AROUND THE AFFECTED AREAS. WE ARE STILL SEEING THE LEAKING. I HAVE SEEN THIS COMPLAINT NUMEROUS TIMES AND IT IS TIME THAT FORD TAKE RESPONSIBILITY FOR THE PLASTIC PARTS THAT ARE CONNECTED TO THE ENGINE. FORD MUST USE METAL PARTS TO REPLACE THESE FOR ME BECAUSE PLASTIC WARPS IN THE HEAT OF FLORIDA. THE AFFECTED PARTS ARE THE THERMOSTAT HOUSING AND IT'S CONNECTION TO THE ENGINE. I HAVE A 2006 FORD EXPLORER EDDIE BAUER 4.0 WITH 55K MILEAGE. GOOD MAINTENANCE ALWAYS, OIL CHANGED REGULARLY, FLUIDS CHECKED AND MAINTAINED REGULARLY. FORD MUST FIX THIS! *JS

Mileage: 55,000

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE READING FROM THE TEMPERATURE GAUGE INCREASED WHEN THE RADIATOR FAILED. THE RADIATOR LEAKED COOLANT DUE TO DEFECTIVE PLASTIC. THE RADIATOR WAS REPLACED THREE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED A FOURTH. THE FAILURE MILEAGE WAS 27,000 AND THE CURRENT MILEAGE WAS 100,000.

Mileage: 27,000