2012 FORD EXPLORER Power Train Problems

The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 40-60 MPH, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. In addition, the contact stated that there was an abnormal burning odor coming from the vehicle. Upon investigation, the contact discovered NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE) and linked the failure to the recall; however, the VIN nor the year, make, or model was included. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 180,000.

Mileage: 180,000

The contact owns a 2012 Ford Explorer. The contact stated while driving 3 MPH, the power steering fault, the turn signal, advance-trac alert, and power train warning lights illuminated. The contact stated that the steering wheel became inoperable. The vehicle was taken to an independent mechanic who determined that the control modules were inoperable. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 237,000.

Mileage: 237,000

The truck has been in shop 5 times or actually 5 different dealerships. The recall has yet to be fixed but I continually pay to have the problem INVESTIGATED. The dash flashes loss of fuel pressure, service advance track soon, Battery level and mechanic wrench . I have this on video as it is constant occurrence. Each time ford takes it in they can't make the issue happen or recreate it. As told several times happens sporadic and not under any certain conditions. Over and over paying diagnostic fee and what they say will repair the issue only it happens pulling off the lot at 5 star ford Dallas Texas took it in under default to Bob Tomas Mckinney where they scanned it and found 17 communication errors left it there nothing was done but more exploration of issues going down the list of com failures and paying for each 3 anyway and it did it again leaving me stranded 3 times to count eventually leaving at Don Davis Ford Arlington Texas where it was again said repaired and is currently at Planet Ford Dallas where historically I paid $2850 and NOTHING was done as it again left me stranded and towed there where it can sit until it's fixed meaning this loss of horsepower the electric flashes and the gears in transmission ACTUALLY FUNCTION AS PER REQUESTED EACH TIME IN SERVICE

In September 2021 the tranfer case craked and also cracked the transmission. I had both replaced. I got the car back in April of 2022 3 weeks later the tranfer case cracked again no waring lights no warn or symptoms indicating it was going bad just cracked.

I was driving with my child in the car when u hear a loud noise. After that i heard grinding. So when i got home we put the car on jack stands. There seemed to be no problems. The next day i took the car to a shop and was called to come back down. The mechanic showed us that the transfer case blew a part and cracked the transmission. Not one warning lights or service engine light came on. Had the drive shaft fell out as a result it could have killed me and my child.

I was driving with my child in the car when u hear a loud noise. After that i heard grinding. So when i got home we put the car on jack stands. There seemed to be no problems. The next day i took the car to a shop and was called to come back down. The mechanic showed us that the transfer case blew a part and cracked the transmission. Not one warning lights or service engine light came on. Had the drive shaft fell out as a result it could have killed me and my child.

THE POWER STEERING, FOUR WHEEL DRIVE, AND TRACTION CONTROL COMPLETELY STOPPED WORKING EVEN AFTER I HAD IT TOWED TO THE DEALERSHIP SOME MONTHS BACK TO FIX THIS PROBLEM! ALSO,THE MYFORD TOUCH GOES BLACK AND WILL NOT WORK FOR WEEKS. WHEN THE POWER STEERING QUIT I WAS ON A PAVED SIDE ROAD NEAR MY HOME.

Mileage: 168,000

VEHICLE SHUTTING DOWN WHILE DRIVING.

Mileage: 142,000

CAR WON'T GO INTO PARK

Mileage: 118,000

PURCHASE VEHICLE 2 21 2019 AND THE TWO ENGINE LIGHTS WARNING LIGHTS BREAKING DECELERATES WHICH IS VERY DANGEROUS DRIVING ON THE HIGHWAYS. SERVICE LIGHT TRACKING LIGHT STAYS ON AND THE VEHICLE DOES ALL THIS ON IT'S ON. I HAVE CONTACTED BY CHAT THE FORD CORPORATION ABOUT THIS SERIOUS ISSUE WITH THIS MAKE AND MODEL. I WAS TOLD THEIR WAS NO SERVICE BULLETIN SO THEY COULD NOT HELP ME. THEY REFUSE TO ADDRESS THE DANGEROUS MATTER THIS MAKE AND MODEL HAS VERY DANGEROUSAND THE LIGHTS ARE STILL ON. ALSO WITH THE ENGINE LIGHTS STAYING ON ALL THE TIME THE CRUISE CONTROL DOES NOT WORK.

Mileage: 94,000

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT TOOK THE VEHICLE TO BILLY HOWELL FORD LINCOLN (1805 ATLANTA HWY, CUMMING, GA 30040, (770) 887-2311) FOR ROUTINE SERVICE. THE DEALER NOTICED THAT THE POWER TRANSFER UNIT WAS LEAKING AND NEEDED TO BE REPLACED. TWO WEEKS PRIOR, THE VEHICLE WAS REPAIRED BY THE SAME DEALER PER NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 140,000.

Mileage: 140,000

EXPERIENCING HARD SHIFTS WITH A THUD. HAPPENS WHEN THE VEHICLE IS SLOWING DOWN THEN WHEN I ACCELERAT THERE IS A DELAY THEN A THUD WHEN IT FINALLY SHODTS INTO GEAR. APPARENTLY I'M NOT THE INLY ONE FROM WHAT IVE HEARD. I WISH FORD WOULD FIX THIS ISSUE. I HAVE TAKEN IT TO GARAGE BUT THEY WERE UNABLE TO DETERMINE THE ISSUE.

Mileage: 75,000

TWICE IN 5 DAYS THE VEHICLE HAS 'AWD OFF' ERROR MESSAGE POP UP WHEN DRIVING AT 25MPH, AND HAS FORCED THE VEHICLE INTO IDLE WHILE IN TRAFFIC. ALL OF THE MECHANICS WE TALKED TO WON'T TOUCH THE VEHICLE BECAUSE THIS A KNOWN ISSUE, AND DIRECT US TO THE FORD DEALERSHIP TO HAVE IT SERVICED. THERE IS ZERO SENSE OF SAFETY WHEN DRIVING IT.

Mileage: 84,000

STEERING WHEEL LOCKS UP WHEN YOU START TRUCK AND HAVE TO TURN OFF AND RESTARTS TO GO AWAY

AT BEGINNING, VEHICLE FREQUENTLY SUDDENLY REDUCE THE SPEED WHILE DRIVING, THEN I EXPERIENCED THE DIFFICULTY TO START THE ENGINE IN THE MORNING. MISS FIRE OF THE ENGINE EXPERIENCED DURING BOTH IN DRIVING AND MORNING ENGINE START. THE VEHICLE ALSO ACCELERATE WHEN THE DRIVING SPEED AROUND 20 MPH IN CITY DRIVING, AND SUDDENLY REDUCING THE SPEED WHEN IT IS AROUND 80 MPH ON HIGHWAY. SO I DECIDED TO SEND IT TO A LOCAL REPAIR SHOP FOR FINALLY I PARKED INSIDE OF THE GARAGE AND WAITING TO DELIVERY IT DIAGNOSTIC, BUT THE REPAIR SHOP COULD DETECT ANYTHING WRONG IN MECHANIC, THEREFORE THEY RECOMMEND NE SEND IT TO FORD DEALER FOR FURTHER TESTING. AFTER STORE THIS VEHICLE IN THE GARAGE FOR FEW DAYS, THE ENGINE CAN NOT START AT ALL. I HAD TO TOW IT TO FORD DEALER FOR FURTHER TESTING. THE ONLY ERROR FORD DEALER FOUND IS THE RE-INSTALLATION OF PCM SOFTWARE. WHICH FORD HAD A RECALL ON THIS VEHICLE, THE RECALL WORK WAS PERFORMED BY THE SAME FORD DEALER ON 11-15-2016. AFTER LAST WEEK RE-INSTALL THE PCM SOFTWARE BY FORD DEALER, I STILL EXPERIENCE THE UNEVEN SHAKING WHEN THE ENGINE ACCELERATE TO 4000 RPM (NOT DRIVING CONDITION), AS WELL AS THE DIVING SPEED CLOSE TO 80 MPH ON HIGHWAY. BUY FORD DEALER CLAIMS THESE SYMPTOMS ARE VERY NORMAL OF THE FORD EXPEDITION.

Mileage: 49,152

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THE THROTTLE BODY ASSEMBLY WAS FAULTY. WHEN THE CONTACT DEPRESSED THE ACCELERATOR PEDAL, THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT PULLED THE VEHICLE OVER AND IT STARTED SHAKING. WHEN THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, IT OPERATED NORMALLY. SAMES FORD (4721 AYERS ST, CORPUS CHRISTI, TX 78415, (361) 851-7600) DIAGNOSED THAT THE THROTTLE WAS FAULTY AND PROVIDED THE REPAIR COST. THE MANUFACTURER STATED THAT THERE WAS NO RECALL AND ADVISED THE CONTACT TO SAVE THE RECEIPTS FOR REIMBURSEMENT IF A RECALL WAS ISSUED. THE FAILURE MILEAGE WAS 58,900. *TT CONSUMER STATED CAR WOULD NOT ACCELERATE ON A BUSY ROAD. PROBLEM WAS FIXED.*JB

Mileage: 58,900

2012 FORD EXPLORER XLT 4W. THE TERRAIN MANAGEMENT SYSTEM FAULT LIGHT CAME ON AND CAR WENT IMMEDIATELY INTO LIMP MODE ON A MAJOR ROAD.THERE WAS NO WARNING AND WAS ALMOST REAR ENDED. TOOK TO DEALER OCT.1 AND THEY KEPT IT TWO DAYS. THE DEALER SAID THEY COULD NOT FIND A CODE. DEALER SAID IT IS FIXED BY UPDATING AND CALIBRATING THE ABS SYSTEM. IT WAS NOT FIXED. . OCT 13 SAME LIGHT WENT ON AND CAR IMMEDIATELY INTO LIMP MODE ON EXPRESSWAY. NEARLY CAUSED ACCIDENT BECAUSE CAR IMMEDIATELY SLOWED DOWN AND WOULD NOT GO MORE THAN 5MPH IN LIMP MODE. YOU LOOSE COMPLETE CONTROL OF THE TRANSMISSION AND THROTTLE. THERE ARE 53+ CASES WITH THIS PROBLEM ON THE INTERNET JUST THIS YEAR. HTTPS://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2016/ENGINE/WRENCH_LIGHT_ON.SHTML THIS HAPPENS SUDDENLY WHILE DRIVING AND WITHOUT WARNING. THE CAR IMMEDIATELY BEGINS TO SHUTTER AND VIBRATE AND IMMEDIATE BEGINS TO SLOW DOWN TO 5MPH. THIS IS A DANGEROUS SITUATION AND SHOULD BE INVESTIGATED. YOU HAVE NO CONTROL OVER THE SPEED OF THE CAR OR THE TRANSMISSION.. PLEASE GOOGLE (TERRAIN MANAGEMENT SYSTEM FAULT LIGHT) AND SEE THAT THERE ARE MANY MORE FORD CARS ARE AFFECTED BY THIS PROBLEM THERE ARE 3 YOUTUBES SHOWING THIS PROBLEM. THEY CARS ARE NOT SAFE TO DRIVE. ANYONE WHO HAD A TERRAIN MANAGEMENT SYSTEM LIGHT THAT GOES ON WHILE DRIVING WILL EXPERIENCE THE SAME DANGEROUS SITUATION

Mileage: 62,000

THE PROBLEM OCCURS AGAIN TWICE ON 5/23/18 THE WRENCH ICON APPEARS AGAIN, LOST POWER, NO ACCELERATION, TURN OFF THE ENGINE AND RESTART..MADE AN APPOINTMENT BACK TO COGGINS FORD AND THEY CHECKED AND STILL THERE IS NO CODE TO SEE WHAT IS WRONG WITH THE CAR. THEY SUGGEST THAT IT MIGHT BE THE ELECTRONIC THROTTLE BODY IF I WANT TO REPLACE IT BUT NOT GUARANTEE. WITH MY APPROVAL I AM TAKING MY CHANCES TO REPLACE IT BECAUSE I AM SCARED I WILL BE IN A SERIOUS ACCIDENT IF I WILL NOT DO SOMETHING ABOUT IT. I HOPE THIS WILL FIX THE PROBLEM AND ALSO HOPING THAT YOU WILL DO SOMETHING ABOUT THIS INCIDENT. THANK YOU.

Mileage: 46,778

THIS IS THE CONTINUATION OF MY 2012 FORD EXPLORER FOLLOW UP COMPLAINT ABOUT THE POWER TRAIN MALFUNCTION AND REDUCED POWER THAT HAPPEN ON 5/12/2018. AS I MENTIONED IN MY LAST COMPLAINT THAT I TOOK IT TO COGGINS FORD IN JACKSONVILLE ON 5/14/18 AND THEY CHECKED MY CAR AND THE SERVICE ADVISOR SAID THAT THEY TEST DROVED AND CHECKED BUT NO CODES SO THEY CANNOT DO ANYTHING AND HE ADVISED TO KEEP ON DRIVING UNTIL IT HAPPENS AGAIN AND TO BRING IT BACK. NOW, I AM NERVOUS DRIVING THIS CAR, IT MIGHT PUT ME AND MY PASSENGERS IN A DANGEROUS SITUATION IF SUDDENLY THIS HAPPEN AGAIN LOSS OF POWER AND STALLING WHILE DRIVING. THIS A SERIOUS SAFETY AND IT CAN LEAD TO ACCIDENTS, INJURY OR DEATH. I HOPE FORD WILL INVESTIGATE AND HAVE A RECALL ON THIS PROBLEM.

Mileage: 46,702

I WAS DRIVING ON THE HIGHWAY WITH THE SPEED OF 60 MILES PER HOUR AND SUDDENLY THE WRENCH ICON SHOWS ON THE LEFT HAND SIDE OF MY STEERING WHEEL AND MY CAR SPEED IS SLOWING DOWN. I TRIED TO PUSH MY ACCELERATOR HARDER BUT IT WILL NOT PICK UP SPEED, SO I PULL OFF THE ROAD AND TURN OFF MY ENGINE. AFTER A FEW MINUTES, I STARTED MY CAR AND IT STARTS AND DROVE HOME WITH A LOW SPEED AND MADE AN APPOINTMENT TO COGGINS FORD IN JACKSONVILLE,FL.05/14/2018. I WILL FOLLOW UP ON THE RESULT.

Mileage: 46,702

AFTER STARTING THE CAR WHILE PARKED THE 'SERVICE ADVANCE TRAC" WARNING CAME ON. AFTER DRIVING APPROX. 100 FEET THE WARNING WENT AWAY. THERE WAS A SLIGHT HARDNESS IN THE STEERING AT THIS TIME. THAT WENT AWAY WHEN THE WARNING WENT AWAY. THIS OCCURRED ON NOV. 10, 2017. THE SECOND PROBLEM OCCURRED ON NOV. 23, 2017. WHILE PARKED OVERNIGHT AND ALL DAY IN OUR GARAGE I STARTED THE CAR AND THE "POWER STEERING ASSIST FAULT'' WARNING CAME ON. I COULD NOT TURN THE STEERING WHEEL AT ALL. I TURNED OFF THE ENGINE AND WITHIN 10 TO 15 SECONDS I STARTED THE CAR AGAIN. NO WARNING CAME ON AND THE POWER STEERING WORKED O.K. I STARTED THE CAR AGAIN THIS MORNING AND NO WARNING OR PROBLEM.

Mileage: 100,000

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE STALLED AND THE OIL PRESSURE AND POWER TRAIN WRENCH WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS UNABLE TO START ON THE FIRST ATTEMPT. THE FAILURE RECURRED OVER THREE TIMES. THE CONTACT NOTICED THE FAILURE AFTER SHE DEPRESSED THE ACCELERATOR PEDAL AFTER A COMPLETE STOP. THE LOCAL DEALER (GULF COAST FORD, N, 3000 STATE HWY 288, ANGLETON,TX, 77515) WAS CONTACTED SCHEDULED AN APPOINTMENT FOR TWO DAYS LATER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 155,000.

Mileage: 155,000

2012 FORD EXPLORE LIMITED. WHILE DRIVING ON HIGHWAY, THE CAR SUDDENLY WITH NO WARNING DECREASED SPEED THEN A WRENCH WARNING LIGHT CAME ON IN THE LOWER LEFT DASH PANEL, AND THE CAR WAS IDLING VERY ROUGH. EVEN THOUGH I WAS PRESSING ON THE GAS PEDAL TO ACCELERATE, THERE WAS NO RESPONSE. I WAS ABLE TO LIMP IT HOME AT LITERALLY 2 MPH IN "LIMP MODE". THE CAR DID NOT RESPOND WHEN I PRESSED THE ACCELERATION PEDAL ALTHOUGH I STILL HAD POWER. I HAD TO HAVE IT TOWED TO DEALERSHIP TO BE CHECKED OUT. AFTER RESEARCHING WHAT IT COULD BE, I LEARNED IT IS POSSIBLY THE ELECTRONIC THROTTLE BODY (ETB) AND/OR PURGE VALVE. I AM PASSED EXTENDED WARRANTY NATURALLY AND PROBABLY GOING TO BE LEFT WITH A HUGE BILL. WHY IS THIS NOT A RECALL FORD????? IT IS CLEARLY A MANUFACTURED ISSUE WITH THIS MANY PEOPLE EXPERIENCING THIS SAME ISSUE.

Mileage: 91,200

GEAR SHIFT MESSAGE - 'SHIFT TO PARK' AFTER PUTTING VEHICLE IN PARK AND IGNITION IS TURNED OFF.

Mileage: 45,000

(RE)STARTING AUGUST 1, 2017, WHILE DRIVING, THE VEHICLE WOULD SUDDENLY AND WITHOUT WARNING DECELERATE, WITH NO RESPONSE FROM THE GAS PEDAL. FORD CALLS THIS THEIR "LIMP HOME MODE." THE WRENCH ICON WARNING WOULD DISPLAY AND THE ENTIRE VEHICLE WOULD SHUDDER UNTIL IT WAS PUT IN PARK AND TURNED OFF. USUALLY, IT WOULD RESUME NORMAL OPERATIONS AFTER BEING RESTARTED, HOWEVER, ON ONE OCCASION, IT TOOK THREE ATTEMPTS TO RESTART. AFTER TWO SUCH INCIDENTS OCCURRING IN LESS THAN A MILE, I DON'T FEEL SAFE DRIVING ON THE HIGHWAY (OR, REALLY, ANY OTHER PLACE) AS THERE IS NO INDICATION TO OTHER DRIVERS AND THE VEHICLE ACTIVELY DECELERATES, RATHER THAN COASTING. DURING ONE SUCH INCIDENT, THE DECELERATION WAS SO PRONOUNCED THAT PASSENGERS JERKED FORWARD IN THEIR SEATS AND A CANINE PASSENGER LOST ITS FOOTING, FALLING INTO THE BACK OF THE SEATS. WE PREVIOUSLY EXPERIENCED THIS SAME ISSUE IN 2015, LEAVING ME AND A SMALL CHILD STRANDED WHEN THE VEHICLE DID NOT RESTART AT ALL. AS PART OF A "GOODWILL" REPAIR DUE TO THE VEHICLE BEING JUST OUT OF WARRANTY, THE ETB (ELECTRONIC THROTTLE BODY) AND PURGE VALVE WERE REPLACED BY FORD. I FILED COMPLAINT 10787972 WITH THE NHTSA ON 10/25/2015. IN 5 YEARS, THIS WILL BE THE SECOND REPLACEMENT OF A PART THAT'S EXPECTED TO LAST WELL OVER 6 YEARS. FORD IS AWARE OF THE PROBLEM, IS AND HAS BEEN SUED, AND IS BEING INVESTIGATED.

Mileage: 72,000

I HAVE HAD THE CAR FOR 2 YEARS AND HAVE HAD AT LEAST 10+ INCIDENTS OF MY CAR LOSING ALL POWER FOR ACCELERATION. IT HAS HAPPENED ON THE HIGHWAY GOING 65+, IT HAS HAPPENED ACCELERATING ONTO THE HIGH WAY, IT HAS HAPPENED ON RESIDENTIAL STREETS, IT HAS HAPPENED ON STATE HIGHWAYS, IT HAS HAPPENED IN PARKING LOTS. THE CAR SUDDENLY REVS SUPER HIGH BUT PRESSING THE ACCELERATOR DOES ABSOLUTELY NOTHING. I HAVE TO LIMP TO THE SIDE OF THE ROAD, TURN THE CAR OFF AND USUALLY IT FIXES THE ISSUE. BUT SEVERAL TIMES I HAVE HAD TO TURN IT OFF AND RESTART SEVERAL TIMES BEFORE I HAVE NORMAL CONTROL OF THE CAR AGAIN. I HAVE BROUGHT IT IN SEVERAL TIMES AND EVERY TIME THEY TELL ME UNLESS IT IS HAPPENING AT THAT MOMENT THEY CAN'T FIGURE OUT THE PROBLEM. I HAVE KIDS IN MY CAR MOST OF THE TIME AND TO SUDDENLY LOSE POWER IS A TRAGEDY WAITING TO HAPPEN. TODAY DURING A ROUTINE OIL CHECK, IT WAS DISCOVERED MY PTU IS LEAKING. IN A 5 YEAR OLD CAR I WOULD NOT EXPECT THIS TO BE THE CASE.

Mileage: 55,000

FUEL AND EXHAUST FUMES OR SMELL OF BURNING OIL. PROBLEMS WITH TURBO.

Mileage: 105,000

BAD SMELL WITH HEAT OR AC ON AT HIGHER SPEEDS HEADACHES AND LIGHTHEADEDNESS FELT AT TIMES. A SEPERATE ISSUE ALTOGETHER WINDOWS AND DOOR LOCKS HAVE FAILED TO WORK A COUPLE TIMES LEAVING ME STUCK INSIDE CAR UNTIL IT DECIDES TO WORK. DEALER HAS HAD SUPOSED PART ON BACK ORDER FOR 2 MONTHS.

Mileage: 45,000

MY 2012 FORD EXPLORER WOULD ALL OF A SUDDEN SOUND LIKE IT WAS SLIPPING OUT OF GEAR WHILE DRIVING. I WOULD LOSE ALL CONTROL OF THE ACCELERATOR & VEHICLE WOULD IDLE VERY ROUGH. THE "WRENCH" LIGHT WOULD APPEAR ON THE DASH DISPLAY. I WOULD HAVE TO DRIFT OVER TO THE SIDE OF THE ROAD, TURN THE VEHICLE OFF, & THEN RE-START THE VEHICLE. THIS HAPPENED WITHOUT WARNING & BECAME MORE FREQUENT. DEALERSHIP REPLACED THE THROTTLE BODY (AT MY COST) & EXPLAINED NO RECALL HAD BEEN DETERMINED YET, BUT EXPECTED IT TO BE ISSUED IN THE FUTURE DUE TO THE NUMBER OF COMPLAINTS. I ALSO HAD TO PAY TO HAVE MY SELECTOR LEVER ASSEMBLY REPLACED AGAIN SINCE I WAS AGAIN HAVING THE ISSUE OF VEHICLE PROBLEM OF "SHIFT TO PARK" APPEARING ONCE AGAIN. THE FIRST TIME THIS PART WAS REPLACED IT WAS COVERED UNDER TSB 15-0047, BUT THIS TIME IT WAS AT MY EXPENSE.

Mileage: 52,736

WHILE DRIVING THE VEHICLE STARTED TO MAKE A GRINDING NOISE COMING FROM THE FRONT AREA. PULL OVER AND TOW TO DEALER . THE TRANSMISSION PTO HAD A INTERNAL FAILURE. THE CAR ONLY HAS 51K MILES NORMAL DRIVING. I SEARCH ON THE INTERNET AND FOUND THAT FORD HAD SEVERAL ISSUES WITH THIS PART BREAKING IN LOW TIME. THIS COULD BE A SAFETY HAZARD. *TR

Mileage: 51,000

WHILE DRIVING THE VEHICLE SUDDENLY POWER WOULD BE LOST. WHEN APPLYING MORE PRESSURE TO THE ACCELERATOR, NO USABLE POWER WAS PRESENT AND THE VEHICLE COULD NOT EXCEED 30 MPH. AFTER THIS OCCURRED ON THE 4TH TIME ON A SUBSEQUENT DAY, THE "ENGINE" SYMBOL WAS DISPLAYED. CURRENTLY THE VEHICLE IS AT A FORD DEALERSHIP TO TROUBLESHOOT THE PROBLEM. ON TWO OCCASIONS THIS DISCREPANCY WITH ACCELERATION AND FUNCTIONALITY OF AVAILABLE POWER NEARLY CAUSED AN ACCIDENT WITH SMALL CHILDREN IN THE VEHICLE. THIS SHOULD CAUSE A MAJOR CONCERN TO OTHER OWNERS AND FORD MOTOR COMPANY AS A WHOLE DUE TO THE POTENTIAL DAMAGE, INJURY, OR DEATH THAT COULD OCCUR DUE TO COMPLETELY LOSING ACCELERATION AND/OR POWER WHILE DRIVING. *TR

Mileage: 40,000

MY 2012 FORD EXPLORE LTD. STOPS IN THE MIDDLE OF THE ROAD WHILE DRIVING. A WRENCH LIGHT COMES ON IN LOWER LEFT DASH, AND THE CAR LOSES POWER. I CAN NO LONGER ONCE THIS HAPPENS. I MUST TURN OFF THE CAR AND RESTART THE ENGINE TO GET IT GOING AGAIN. THIS HAS HAPPENED ON A HIGHWAY GOING 70 MILES PER HOUR, AND IN THE MIDDLE OF INTERSECTIONS, ON REGULAR CITY, SUBURBAN OR NEIGHBORHOOD STREETS, NOT TO MENTION IT IS NOW HAPPENING 2-3 TIMES A DAY WHILE WITH NO WARNING. IT HAPPENS WHILE DRIVING ONLY, SOMETIMES AFTER TURNING, SOMETIMES NOT, BUT THE CAR IS ALWAYS IN MOTION AT THE TIME, AT VARIOUS SPEEDS IN VARIOUS TEMPERATURES, WITH CLIMATE CONTROL EITHER OFF OR ON, SEEMS TO HAVE NO BEARING. THIS IS EXTREMELY DANGEROUS AND CAN EASILY CAUSE AN ACCIDENT, INJURY OR DEATH. APPARENTLY THE CURRENT RECALL FOR THE POWER STEERING DOES NOT ADDRESS THIS. I AM HAVING THAT WORKED ON RIGHT NOW AS I TYPE. THIS HAPPENED ONCE LAST YEAR ON THE HIGHWAY, AND ONCE ABOUT 6 MONTHS AGO AS I PULLED OUT OF A PARKING LOT. HADN'T HAPPENED AGAIN SINCE UNTIL THE MONTH OF OCTOBER IN THE 80 DEGREE WEATHER OF PLANO TX, WHETHER CAR WAS ALREADY WARMED-UP OR NOT. *TR

Mileage: 40,000

THE PTU UNIT WENT BAD AND HAD NO OIL IN IT- WHOLE UNIT NEEDS TO BE REPLACED. SHOULD HAVE OIL, SHOULD BE PERMANENT. NO REASON FOR THIS- CAR IS 4 YEARS OLD AND NOW WE ARE PAYING $2000 TO FIX. READ THAT THIS PROBLEM IS AN EPIDEMIC. SHOULD BE RECALLED FOR THIS PROBLEM. IT'S EVERYWHERE FORD HAS AWD!!

Mileage: 48,000

TRANSMISSION SHIFTS OUT OF GEAR, FROM DRIVE INTO NEUTRAL OR STALLS OUT. SAFETY HAZARD WHILE DRIVING. 6F35 TRANSMISSION. DEALER(S) REFUSE TO ACKNOWLEDGE ISSUE OR REPAIR DESPITE CUSTOMER COMPLAINT AND TRANSMISSION FAULT CODE. VEHICLE STALLS WHILE AT ALL SPEEDS ON HIGHWAY, CITY STREETS, OR WHILE IN INTERSECTIONS. TOO DANGEROUS TO DRIVE

Mileage: 38,000

REPEATED ISSUE WITH MALFUNCTIONING TCM. WENT INTO DEFAULT MODE WHILE DRIVING ON STATE HIGHWAY. REPAIRS MADE BUT HAVE SINCE TAKEN VEHICLE IN AGAIN FOR SAME SERVICE ISSUE AND IS SCHEDULED FOR A THIRD REPAIR. I KNOW THE 2012 FOCUS, FIESTA AND EXPEDITION HAVE CLASS ACTION SUITS DUE TO TCM. DEALER HAS TWICE TOLD ME VEHICLE IS SAFE TO DRIVE IN IT'S CURRENT STATE SINCE SERVICE AND CHECK ENGINE LIGHTS ARE NOT FLASHING IN DEFAULT MODE.

Mileage: 52,000

CAR SPUTTERS AND HESITATES WHEN ORANGE WRENCH COMES ON INTERMITTENTLY WHILE IN MOTION.

Mileage: 107,000

WHILE ON FREEWAY, CAR SUDDENLY DECREASED SPEED EVEN THOUGH I WAS PRESSING ON THE PEDAL TO EXCELERATE. IT HAS HAPPENED A FEW MORE TIMES BUT LUCKILY I WAS NOT ON FREEWAY. TOOK IT IN TO MAC HAICK AND THEY SAID IT WAS THE THROTTLE BODY. MY CAR HAS LESS THAN 30,000 MILES AND I ASKED IF THIS WAS COMMON AND WAS TOLD NO. HE SAID THAT SOMETIMES IT HAPPENS WITH MORE THAT 60,000. I ASKED IF THERE WAS A RECALL AND WAS TOLD NO. I THEN CALLED FORD CUSTOMER SERVICE, THE REP SAID THAT THEY DID NOT HAVE ANY RECALLS AND GAVE ME A CASE #8559890.

Mileage: 29,500

NOVEMBER 13, 2015 CAROLINA, PUERTO RICO I'M DRIVING NORMALLY THEN A WRENCH LIGHT POPS UP ON THE DASH & SAYS "SEE SERVICE MANUAL". I THEN IMMEDIATELY WITHOUT WARNING LOOSE ALL CONTROL TO MY GAS PEDAL & THE ENGINE SHAKES AT AN IDLE. I AM FORCED TO PULL OVER. WE RETURN HOME LESS 10 MILE PER HOUR, THEN TURN THE CAR OFF. ONCE I TURN IT BACK ON IT "WARNINGS 0" IN SOME WAY & RUNS NORMALLY.

Mileage: 2

I'M DRIVING NORMALLY THEN RANDOMLY A WRENCH LIGHT POPS UP ON THE DASH & SAYS "SEE SERVICE MANUAL". I THEN IMMEDIATELY WITHOUT WARNING LOOSE ALL CONTROL TO MY GAS PEDAL & THE ENGINE SHAKES AT AN IDLE. I AM FORCED TO PULL OVER (MIND YOU WITH MY 2 KIDS IN THE CAR WHEN THIS HAS HAPPENED 3 TIMES IN 1 MONTH). THEN TURN THE CAR OFF. ONCE I TURN IT BACK ON IT "RESETS" IN SOME WAY & RUNS NORMALLY (UNTIL THIS HAPPENS AGAIN). THE FIRST TIME IT HAPPENED WAS 3 WEEKS AGO ON A WEEKEND LATE MORNING DRIVING MAYBE 45MPH, THE 2ND TIME WAS THIS PAST TUESDAY 11/2/15 IN THE EVENING AFTER WORK AT 5:15PM DRIVING MAY 35MPH. I TOOK IT TO THE DEALER THEY SAID IT WAS "FIXED" & THEY SENT ME ON MY WAY. THEN IT HAPPENED THE 3RD TIME THE NEXT MORNING ON 11/3/15 @ 7:30AM WHEN I WAS STOPPING AT A STOP SIGN SO I WASN'T GOING MORE THAN 5MPH. IT'S BEEN BACK AT FORD SINCE THEN & THEY SAID THEY "CAN'T FIX IT IF IT DOESN'T SHOW UP FOR THEM OR THE CAN'T DUPLICATE THE PROBLEM" MEANWHILE MYSELF & I HAVE NO VEHICLE TO SCHOOL & WORK. & THE WORST PART IS ALL TREE TIMES MY KIDS WERE WITH ME & THERE COULD'VE BEEN AN ACCIDENT BUT FORD WON'T DO ANYTHING.

Mileage: 27,500

ISSUE HAS OCCURRED MULTIPLE TIMES, UNDER DIFFERENT CONDITIONS. WITHOUT WARNING, THE VEHICLE LOSES ACCELERATION AND THE WRENCH ICON AND AWD ERRORS DISPLAY. THE THROTTLE BECOMES UNRESPONSIVE, BUT ALL OTHER SYSTEMS REMAIN FUNCTIONING. IF YOU LEAVE IT IN GEAR WITHOUT THE BRAKES ENGAGED, IT WILL MOVE AT IDLE SPEED ON FLAT GROUND, BUT IS UNABLE TO NAVIGATE INCLINES. WHEN SLOWING TO A STOP, THE WHOLE VEHICLE SHUDDERS. STOPPING AND RESTARTING NORMALLY RETURNS THE VEHICLE TO NORMAL OPERATION. HOWEVER, ON OCTOBER 25, IT FAILED TO START AND HAD TO BE TOWED TO THE DEALER. THERE IS NO EXTERNAL INDICATION OF THIS SUDDEN LOSS OF POWER AND IT CREATES A VERY DANGEROUS SITUATION BECAUSE IT HAPPENS WITHOUT WARNING AND YOU ARE ONLY ABLE TO STEER AND BRAKE TO CONTROL THE VEHICLE. OUR 2012 EXPLORER IS CURRENTLY AT THE DEALERSHIP, WHO HAS INDICATED THAT THE PROBLEM IS THE ELECTRONIC THROTTLE BODY (ETB) AND PURGE VALVE. FORD IS AWARE THAT THERE IS AN ISSUE WITH ETBS WITH OTHER MODELS, REFERENCE NHTSA ACTION # PE13003, AND EXPLORERS, REFERENCE NHTSA #10054323 AND 10053276, FORD TSB # TSB-13-9-8 AND TSB-13-5-29. DESCRIPTION: LINCOLN/FORD: DUE TO DIAGNOSTIC TROUBLE CODES (DTC) P0106, P0236, ENGINE ON SOME VEHICLES EXPERIENCE HESITATION, LOSS OF IDLE RPM, DIFFICULT IN STARTING, LACK OF POWER, RUNNING ROUGH AND CRANK NO START SITUATION. DESCRIPTION: FORD: DUE TO BLOCKED VAPOR PURGE LINE PORT IN AIR CLEANER OUTLET PIPE ASSEMBLY, THE MIL WOULD ILLUMINATE, WITH DTC P144C.

Mileage: 43,000

BURNING SMELL UNDER ACCELERATION.

Mileage: 10,000

WHILE DRIVING ON A 2-LANE HIGHWAY ABOUT 50 MHP, MY 2012 FORD EXPLORER SUDDENLY LOST ALL SPEED AND THE GAS PEDAL HAD NO EFFECT. AFTER DRIFTING OVER TO THE SHOULDER OUT OF HARMS WAY, THE POWER REMAINED ON AND THE DASHBOARD SAID "CHECK MANUAL" WITH A WRENCH LIT UP. WHAT HAPPENED WAS THAT IT JUST LOST ALL SPEED AND THE GAS PEDAL HAD NO EFFECT UNTIL I TURNED OFF THE POWER AND RE-STARTED. THIS WAS THE FIRST INCIDENT. THIS HAPPENED TWICE MORE IN THE FOLLOWING MONTH FOR A TOTAL OF THREE TIMES WHEN THE EXACT SAME THING HAPPENED, JUST LOST ALL SPEED. FINALLY FORD SERVICE WAS ABLE TO DIAGNOSE IT AND SAID IT WAS THE THROTTLE BODY. AFTER DOING RESEARCH, IT APPEARS THAT OTHER FORD MODELS HAVE THE SAME THROTTLE BODY PROBLEM, LOSS OF SPEED. THIS SHOULD HAVE BEEN A RECALL BUT SOMEONE DROPPED THE BALL, MAKING IT A PART OF THE CUSTOMER SATISFACTION PROGRAM (CSP 13N03) INSTEAD. THIS IS OBVIOUSLY A VERY DANGEROUS SITUATION. FORD SERVICE HAS BEEN EXTREMELY DIFFICULT WORK WITH AS THEY WILL NOT HONOR CSP 13N03 FOR MY EXPLORER.

Mileage: 31,000

DRIVING TO WORK AT THE NORMAL SPEED LIMIT 6:30 AM IN LIGHT TRAFFIC. AMBIENT TEMPERATURE WAS 65 DEGREES IN DRY CONDITIONS. SUDDENLY FELT LIKE THE TRANSMISSION HAD BEEN PLACED IN NEUTRAL. ENGINE CONTINUED TO RUN BUT NO POWER TO THE TRANSMISSION. WAS ABLE TO LET THE CAR COAST UNTIL I COULD TURN ON TO A SIDE STREET AND STOP. AN ERROR CONDITION DISPLAYED "AWD OFF" AND THEN A WRENCH ICON APPEARED. I PLACED THE TRANSMISSION IN PARK AND TURNED OFF THE ENGINE. RESTARTED THE ENGINE AND THE CAR RESUMED NORMAL DRIVING CONDITIONS. TOOK THE CAR THE NEXT DAY TO THE FORD DEALERSHIP. WAS TOLD THAT NO ERROR CODE WAS CAPTURED SO THEY COULD NOT DO ANYTHING. I ASKED HOW IT WAS THAT THE COMPUTER COULD DISPLAY THE "AWD OFF" MESSAGE AND THE WRENCH ICON WITHOUT A CODE BEING STORED. NO RESPONSE. WAS TOLD TO LEAVE CAR RUNNING NEXT TIME, CALL A TOW TRUCK AND THEN THEY COULD GET THE CODE. OF COURSE, I AM NOT ALWAYS CLOSE TO THE DEALERSHIP, IT COULD HAPPEN AFTER THEY CLOSED OR ON A WEEKEND. NOTED THAT IN MARCH 2014 FORD SETTLED A COMPLAINT ON "THROTTLE BODY" PROBLEMS IN ESCAPE, FUSION, ETC, THAT HAD A SIMILAR DESCRIPTION. EXPLORER WAS NOT INCLUDED IN THAT SETTLEMENT. *TR

Mileage: 34,000

I PARKED THE VEHICLE TO GO INTO A STORE. WHEN I RETURNED AND STARTED THE VEHICLE. I HAD THE POWER ASSIST FAULT AND SERVICE TRACK MANAGEMENT ERRORS SHOW ON THE PANEL. I HAD TO DRIVE THE CAR HOME WITHOUT POWER STEERING. I TOOK THE CAR IN FOR SERVICE YESTERDAY AND WAS TOLD THAT IT NEEDED A STEERING GEAR. I WAS UNDER THE IMPRESSION THAT THIS WOULD BE PART OF THE POWER STEERING RECALL ISSUED LAST YEAR, HOWEVER THAT IS NOT THE CASE. I WAS TOLD BY THE SERVICE TECH THAT HE TRIED TO CONTACT FORD TO SEE IF THEY WOULD WORK WITH ME ON THIS AND THEY STATED THERE WAS NOTHING THEY COULD DO. SO I BROUGHT THE CAR HOME WITHOUT REPAIR OR NEW PARTS ORDERED DUE TO THE COSTLINESS OF THIS ISSUE. IT APPEARS THAT I AM NOT THE ONLY ONE HAVING THIS POTENTIALLY DANGEROUS ISSUE WITH THEIR VEHICLE. AT THIS POINT, I AM QUITE DISAPPOINTED WITH FORD!!

I WAS DRIVING BACK FROM THE MALL ON A SINGLE LANE HIGHWAY AT 55 MPH WITH THE WHOLE FAMILY. ALL OF THE SUDDEN THE VEHICLE JUST QUIT. I TRIED TO RESTART THE VEHICLE WHILE IT WAS GLIDING WITHOUT POWER, BUT IT WOULD NOT START. I HAD TO PULL OVER TO THE SIDE OF THE ROAD UNTIL THE CAR STOPPED BY ITSELF. WHILE THE CAR WAS GLIDING TO A STOP, THERE WAS NO STEERING BRAKES OR ANYTHING AVAILABLE, SINCE THE ENGINE HAD CUT OFF AUTOMATICALLY. LUCKILY I DID NOT GET HIT BY ANYONE. I FINALLY PULLED OVER, RESTARTED THE CAR AND DROVE AGAIN. IN A COUPLE OF MINUTES THE CAR STALLED AGAIN WITH NO CONTROLS. THIS HAPPENED ABOUT 4 TIMES WITHIN A SPACE OF 15 MILES. I TOOK IT TO THE FORD DEALERSHIP THE NEXT DAY AND HAD TO SPEND $1000 FIXING IT, WHICH THEY BLAMED ON THE THROTTLE ACTIVATION OR BODY. THIS COULD HAVE RESULTED IN A FATAL SITUATION, ESPECIALLY BECAUSE THE VEHICLE HAD NO CONTROLS WHEN IT STALLED. I BELIEVE THERE HAS BEEN THE SAME ISSUE WITH OTHER FORDS AND LINCOLN VEHICLES ON THE WEB. THIS SHOULD BE CONSIDERED A SERIOUS SAFETY ISSUE, WHICH SHOULD BE FIXED AS SOON AS POSSIBLE. THIS COULD HAPPEN AGAIN TO SOMEONE AND RESULT IN SERIOUS INJURY. I FEEL LIKE FORD SHOULD BE RESPONSIBLE FOR THE FIX TO ENSURE PUBLIC SAFETY. *TR

Mileage: 37,000

WHILE I WAS DRIVING MY 2012 FORD EXPLORER XLT, IT LOST ALL POWER FOR THE 4TH TIME. WHEN I PRESSED THE THROTTLE THERE WAS NO RESPONSE. INDICATOR LIGHTS SAID AWD OFF AND DISPLAYED A WRENCH ICON. I COASTED TO THE SIDE OF THE ROAD. WHEN THIS HAPPENED THE FIRST THREE TIMES I TURNED THE CAR OFF, RESTARTED IT AND ALL WAS FINE FOR A FEW MINUTES, BEFORE THIS HAPPENED AGAIN. THIS IS QUITE A DANGEROUS SITUATION TO BE IN. I HAVE ALSO SEEN SEVERAL COMPLAINTS OF THE SAME PROBLEM FROM SEVERAL OTHER FORD AND LINCOLN OWNERS. I BELIEVE THIS IS A SERIOUS SAFETY ISSUE, SINCE STALLING IN THE MIDDLE OF ANYWHERE IS NOT SAFE AND CAN LEAD TO ACCIDENTS WITHOUT WARNING. ALSO MY CHECK ENGINE LIGHT IS NOW LIGHT AND I WILL BE TAKING IT TO THE FORD DEALER TO GET IT FIXED. IT IS GOING TO COST ME AN ARM AND LEG, BUT HOPEFULLY IT ENDS UP BEING A SAFETY RECALL AND FORD REIMBURSES DOWN THE LINE. *TR

Mileage: 40,000

I WAS DRIVING APPROX. 35MPH AND ALL OF A SUDDEN THE WRENCH LIGHT ON THE ENGINE CAME ON I LOST ALL POWER TO THE ACCELERATOR. I HAD TO COAST TO STOP, TURN OFF THE VEHICLE, START IT BACK UP AND PROCEED. IT HAS HAPPENED 4 MORE TIMES SINCE THE ORIGINAL DATE. ONE OF THOSE TIMES WAS WHEN I WAS CROSSING AN INTERSECTION AND WAS ALMOST BROADSIDED. THIS IS VERY DANGEROUS AND IS HAPPENING WITH NO WARNING OR PATTERN. I HAVE LOOKED ONLINE AND IT SEEMS TO HAVE HAPPENED WITH MANY FORD EXPLORER OWNERS. I AM READING IT HAS TO DO WITH THE POWERTRAIN CONTROL MODULE. *TR

Mileage: 34,000

THE THROTTLE BOX HAS GONE BAD. THE CAR STALLS RANDOMLY WHEN TAKING OFF FROM A START AND REQUIRES A NEW THROTTLE BODY AT ONLY 47K MILES. THIS IS PART OF THE POWERTRAIN, BUT NOT COVERED BY THE WARRANTY. FORD HAD LOTS OF PROBLEMS WITH THROTTLE BODIES IN EARLIER MODELS AND IT SEEMS THEY HAVEN'T FIXED IT YET. *TR

Mileage: 47,000

CAR HESITATES AFTER TURNS AND THEN AGAIN WHEN ACCELERATING AND ACTS LIKE IT DOESN'T HAVE ENOUGH POWER. CAR HAD TO BE TOWED ON A SEPARATE INCIDENT IN 2013 AFTER LOSING ALL POWER DURING A TURN; THE THROTTLE BODY - AIR INTAKE HAD TO BE REPLACED AT 24,457 MILES. THE PROBLEM IS ONGOING, SOMETHING IS WRONG WITH THE CAR. EVERY TIME I TAKE IT IN TO BE CHECKED, I GET THE SAME RESPONSE: CANNOT NOT RECREATE THE CONCERN, RAN THROUGH OASIS AND NO PROBLEM FOUND. I AM OVER FORD! THERE WAS A CUSTOMER SATISFACTION PROGRAM (AKA RECALL WITHOUT THE PRESS INVOLVED) (PROGRAM NUMBER 12B36) IN APRIL OF 2012 THAT HAD TO REPROGRAM THE VEHICLE'S PCM (POWERTRAIN CONTROL MODULE). THIS WAS DUE TO THE FACT THAT "INOPERATIVE ENGINE COOLING FANS COULD LEAD TO HIGH ENGINE TEMPERATURE GAUGE READINGS AND REDUCED AIR CONDITIONING PERFORMANCE. CONTINUED OPERATION OF THE VEHICLE COULD RESULT IN ILLUMINATION OF THE MALFUNCTION INDICATOR LIGHT (MIL) AND EVENTUALLY CAUSE THE ENGINE TO AUTOMATICALLY ENTER DERATE (REDUCED POWER) MODE." THIS WAS "FIXED" 14 MONTHS BEFORE THE CAR WAS TOWED.... *TR

Mileage: 7,452

ON MONDAY MARCH 10, 2014 I STARTED THE MY 2012 FORD EXPLORER AND DROVE IT TO WORK APPROXIMATELY 2 MILES AND SHUT IT OFF, AFTER 25 MINUTES I RETURNED TO THE VEHICLE AND ATTEMPTED TO START IT. THE VEHICLE STARTED AND THEN IMMEDIATELY SHUT OFF AND SAID LOW OIL PRESSURE, I PROCEEDED TO REMOVE THE KEY AND OPEN THE HOOD. I CHECKED THE OIL AND ALL WAS WITHIN RANGE, NO ISSUE IMMEDIATELY NOTED, I CLOSED THE HOOD AND ATTEMPTED TO RESTART THE CAR. UPON THE ATTEMPTED RESTART THE CAR TOOK A SUBSTANTIAL AMOUNT OF TIME TO FINALLY TURN OVER, I IMMEDIATELY SHUT THE CAR OFF AND FIGURED IT NEEDED TO REFRESH ITSELF AND WAITED A MOMENT. AFTER RESTARTING ON THE THIRD TRY I THEN ATTEMPTED TO DRIVE IT ALL INDICATORS HAD TURNED OFF. WHILE DRIVING THE VEHICLE IT REFUSED TO ACCELERATE OVER 35MPH, I IMMEDIATELY REPORTED THE ISSUE TO FORD AND THE VEHICLE HAD TO BE TOWED TO CAVALIER FORD IN GREENBRIER, VA. *TR

Mileage: 43,138

ON DEC. 2, 2013 I WAS STOPPED ON THE SIDE OF THE ROAD WITH A SLIGHT DECLINE AT A SCHOOL BUS STOP. I PUT THE VEHICLE IN PARK (WHILE STILL ON) AND GOT OUT OF THE CAR TO RETRIEVE A FORGOTTEN ITEM FROM THE BACK FOR ONE OF THE CHILDREN (AS I HAVE DONE NUMEROUS TIMES BEFORE WITHOUT INCIDENT). WHEN I EXITED THE VEHICLE, IT STARTED TO ROLL FORWARD (WHILE STILL IN PARK). IT ROLLED OFF OF THE ROAD, DOWN AN EMBANKMENT, INTO A DITCH/RAVINE, CRASHED INTO A TREE AND ROLLED ONTO THE DRIVER'S SIDE, COMING TO REST AT AN APPROXIMATE 45 DEGREE ANGLE. MY 20-MONTH-OLD CHILD WAS IN THE CAR AT THE TIME AND WAS SEATED ON THE SIDE OF THE CAR THAT WAS IN CONTACT WITH THE GROUND WHEN THE CAR CRASHED. AFTER RETRIEVING THE CHILD (PHYSICALLY UNHARMED) FROM THE CAR WITH HELP FROM A PASSERBY, I NOTICED THE CAR WAS STILL RUNNING. THE PASSERBY AND I WENT DOWN TO TURN THE CAR OFF AND REMOVE THE KEYS, AT WHICH POINT IT WAS VERIFIED THAT THE CAR WAS IN FACT STILL SHIFTED INTO THE PARK POSITION. THE TOW TRUCK COMPANY ALSO VERIFIED THAT THE CAR WAS IN PARK WHEN THEY ARRIVED. SPEED OF THE VEHICLE AT THE TIME OF IMPACT IS UNKNOWN, AS IT STARTED FROM A STOP AND INCREASED IN SPEED AS IT CONTINUED TO ROLL FORWARD AND DOWN THE EMBANKMENT. POST CRASH, THE 20-MONTH-OLD WAS PHYSICALLY FINE, BUT EXPRESSED SIGNIFICANT EMOTIONAL ANXIETY WHEN BEING PLACED IN HIS OTHER CAR SEAT FOR SUBSEQUENT CAR RIDES. SIDE AIRBAGS ON BOTH SIDES OF THE CAR DEPLOYED, FRONT DID NOT (PRESUMABLY BECAUSE NO ONE WAS SEATED IN THE FRONT OF THE VEHICLE). ONCE THE ENGINE WAS TURNED OFF AND THE KEYS WERE REMOVED, THE HORN BEGAN HONKING (PRESUMABLY A BUILT IN SAFETY FEATURE). ONCE REMOVED FROM THE CRASH SITE (TIME TO REMOVE: 2.5 HOURS USING 2 DIFFERENT TOW TRUCKS), THE CAR WAS NOT DRIVABLE AND AFTER 21 DAYS THE CAR WAS DETERMINED TO BE A TOTAL LOSS. *TR

Mileage: 33,330

THIS IS A CONTINUAL PROBLEM REPORT ONE 8/10/13 19,000 MILES: POWER STEERING LIGHT CAME ON AND POWER STEERING WENT OUT WHILE DRIVING VEHICLE <15 MPH AND BACK CEILING LIGHT CAME ON AND WOULDN'T GO OUT. FORD: 8/13/2013 SAID CEILING LIGHT SHORTENED OUT BATTERY AND CAUSED POWER STEERING TO GO OUT - ORDERED LIGHT BULB CAME BACK IN 3 DAYS TO REPLACE LIGHT BULB - THEY SAID POWER STEERING WAS FIXED. REPORT TWO 9/23/13 23,891 MILES: POWER STEERING LIGHT CAME ON WHILE PARKED. FORD: DID DIAGNOSTIC SAID THE ISSUE WAS MOST LIKELY WIRING AND SAID ISSUE WAS FIXED AND I LEFT WITH CAR REPORT THREE 10/02/13 24,280 MILES: POWER STEERING LIGHT CAME ON DASHBOARD AND POWER STEERING WENT OUT WHILE DRIVING ON A HIGHWAY 65 MPH, PULLED OFF HWY. REPORTED INCIDENT TO FORD. FORD: RAN DIAGNOSTIC, SAID ISSUE WAS MOTHERBOARD. ORDERED PART AND I RETURNED IN A FEW DAYS TO REPLACE COMPUTER BOARD. TOLD ISSUE WAS RESOLVED AND LEFT WITH MY CAR. REPORT FOUR 10/31/2013 25,295 MILES: POWER STEERING YELLOW LIGHT CAME ON DASHBOARD AS I STARTED VEHICLE IN PARKING LOT. POWER STEERING HAD NOT GONE OUT ONLY HAD WARNING LIGHT SHOWING. I DROVE A FEW MINUTES HOME WITHOUT THE STEERING GOING OUT. I STARTED CAR ABOUT AN HOUR LATER IN GARAGE AND POWER STEERING WAS COMPLETELY OUT. BRIGHT RED LIGHTS ON DASHBOARD. WARNING LIGHT SAID SOMETHING TO THE TUNE OF 'REPORT POWER STEERING IMMEDIATELY". FORD: KEPT CAR FOR 4 FULL DAYS WHILE WE DROVE RENTAL AND WAS TOLD THEY HAVE NO SOLUTION AND FORD REGIONAL'S ENGINEERS SUPPOSEDLY SAID 'THIS IS NOT AN ISSUE THEY HAVE SEEN BEFORE' (EVEN THOUGH THERE ARE ALMOST 100 REPORTS ON THE NHTSA WEBSITE ABOUT THIS EXACT ISSUE) AND TO REPORT IF HAPPENS AGAIN. REPORT FIVE 11/28/13 27,000 MILES: POWER STEERING WENT OUT WHILE STARTING VEHICLE IN GARAGE DASHBOARD LIGHT UP WITH RED WARNING SIGNS. HAVE TO WAIT UNTIL AFTER HOLIDAY TO REPORT TO SERVICE. *TR

Mileage: 25,000

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE ALL-WHEEL DRIVE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE CONTACT DID NOT TAKE THE VEHICLE FOR DIAGNOSTIC TESTING OR REPAIRS. THE FAILURE MILEAGE WAS 17,000. ...UPDATED 08-08-13 *BF

Mileage: 17,000

I WAS DRIVING IN A PARKING GARAGE AND THE TERRAIN MANAGEMENT SYSTEM AND POWER STEERING SYSTEMS BECAME DISABLED. THE CAR WAS VERY DIFFICULT TO HANDLE ONCE THE POWER STEERING WAS LOST. WHEN I PARKED THE CAR, SHUT THE CAR OFF AND RESTARTED, THE POWER STEERING APPEARED TO BE BACK BUT THE TERRAIN MANAGEMENT SYSTEM CONTINUED TO SHOW AN ERROR. I WILL BE CONTACTING THE DEALER TODAY. I HAVE SEEN SIMILAR COMPLAINTS LISTED HERE - I HOPE FORD IS ADDRESSING APPROPRIATELY. *TR

Mileage: 14,000

I WAS SLOWING DOWN AS I WAS APPROACHING A TRAFFIC SIGNAL AND HEARD A WARNING CHIME. INITIALLY, VEHICLE DID NOT SHOW ANY SIGNS OF PROBLEM, BUT GOT A WARNING MESSAGE OF POWER STEERING FAILURE (OR SOMETHING SIMILAR) AND ANOTHER ONE INDICATING TO SERVICE THE ADVANCE TRACK SYSTEM. THE ADVANCE TRACK INDICATOR LIGHT WENT OUT ON THE DIAL, TOO. AFTER A FEW HUNDRED FEET THE POWER STEERING WAS COMPLETELY GONE AND I HAD TO USE SIGNIFICANT EFFORT TO STEER THE VEHICLE INTO MY DRIVEWAY. FORTUNATELY, I WAS ONLY 2 MILES FROM HOME WITH FEW TURNS TO GET THERE. ALMOST COULDN'T MAKE THE TURN INTO MY DRIVEWAY. STARTED & RESTARTED THE VEHICLE SEVERAL TIMES AND EVENTUALLY ALL PROBLEMS AND WARNING LIGHTS DISAPPEARED. DROVE THE VEHICLE A FEW MILES AND ALL SEEMS OK. WILL UPDATE WITH ANY ADDITIONAL ISSUES AFTER 8/21/12. VEHICLE WAS PURCHASED USED ON 8/15/12 WITH 12,700 MILES. CALLED DEALER AND THEY SAID TO BRING IN IF PROBLEMS PERSIST. *TR

Mileage: 12,800

I WAS DRIVING HOME FROM A MOVIE ON PACIFIC COAST HWY IN HUNTINGTON BEACH, CA AND ALL OF SUDDEN THE POWER STEERING ASSIST FAULT WARNING CAME ON, I HADN'T LOST COMPLETE FUNCTION OF THE STEERING BUT IT WAS ABOUT A HALF A MILE DOWN THE ROAD THAT IT GOT ALMOST IMPOSSIBLE TO STEER. I CALLED THE DEALERSHIP AND THEY TOLD ME TO TOW IT TO THE DEALERSHIP AS SOON AS POSSIBLE. I DIDN'T KNOW THAT THERE WAS A SHORT TERM FIX BY TURNING OFF AND THEN TURNING BACK ON AGAIN TO MAKE THE WARNING LIGHT GO AWAY. TOMORROW TAKING IN MY CAR TO DEALER TO GET IT FIX.... NOW BEFORE IT ENDS IN CRASH OR SOMEONE KILLED.!!!!!! I HAVE THE ECOBOOST I4 CYLINDER ENGINE. *TR

Mileage: 20,038