2012 FORD EXPLORER Unknown Or Other Problems

The rear back up camera is now displaying a message to contact dealership. It freezes up and stops working.

My back-up camera has flipped images so the left appears on the right and the right appears on the left as well as the safety lines have disappeared. The two Ford dealerships want a diagnostic fee that doesn't even go toward the cost of the repairs.

I started receiving recall information on or before February 2024 for this recall. I finally took it in for inspection maybe 6 months ago. They broke the a-pillar trim peices on both sides so then afterwards at some point they flew off. Then i was on the highway on 6/4 & then the molding peices underneath surrounding my windshield started coming off & flapping around. Thrashing my window while driving 70mph. I had to pull the peices in & roll them up in my window before i was able to pull over & detach them fully. After the inspection as well the guy at the dealer basically laughed & said ford isnt even making these parts & they are on “indefinite back order”. Now the peices are missing as well as my windshield being exposed. All looks very unsightly as well. I dont think FORD really cares because its been almost 2 years & no parts are available yet!!!!!! I am very disappointed & frustrated.

Recall for A-pillar applique trim clip attachment. I have called local dealership and was told that it would be well over a year before they could get the parts to get it fixed however when I'm driving I can hear the piece flapping against my car in the wind. I even called Ford themselves and asked and they said we aren't making the pieces for the recall right now and dont know when we are going to be making them.

Recall A-pilars were removed creating unsafe driving conditions. Parts were flying off vehicle while driving and creating new repairs issues. The manufacturer letter states repairs will take less than half a day but are unable to provide a delivery date. This is a huge concern.

I own a 2012 Ford Explorer involved in recall 23S02 / NHTSA 24V031. The notice I received is dated February 2024. I have been in contact with two Ford dealerships and the Ford Corporation trying to find out when the repair parts for this recall will be available, and I have written to the NHTSA twice asking the same question. The only response I receive from Ford is they don't have any idea and to wait for the next letter from Ford. I have had the driver side trim blow off my vehicle while driving and fortunately I was able to grab it before it flew into a vehicle behind me. Pictures are attached. My latest contact with a dealership and Ford Corporation was February 10, 2025 and no one has a clue when the parts may be available. Can you help?

Recall data refreshed on Dec 11,2024 1 Unrepaired Recalls associated with this VIN Jan 19,2024 Manufacturer Recall Number24S02 NHTSA Recall Number24V031 After almost a year, Ford has not made a fix available for this recall

On October 31, 2020, I pulled up to the grocery store and my sunroof opened by itself. I realize it was not closing so too fast forward I found out that leaks from my sunroof had messed up my electrical wiring in my roof or filling on my car so it causes the sunroof electrical parts to stop working. Every time it rain, heavy or consistently I had a puddle of water in my front passenger seat. I’ve been able to get my sunroof closed and that hasn’t been an issue opening back up, but it does not work at this time after getting it fixed, but also I was nervous about opening it up in case it would not close because it wasn’t cheap to repair it. Now that I am living somewhere that it rains more often I am continuously getting leaks in my door frame, and it comes through my seatbelt or in my trunk. It leaks through the seatbelt or the ceiling of the back trunk. When I first had this problem, I googled it and I realize other people were having issues with the 2011 or 20 1244 and at this point I feel like it is poor construction when it comes to Feeling of the vehicle. I’m not sure how many people have reached out to discuss this but at this point is more of an issue because I am somewhere that rains a lot and I do not have anything to cover my car. If anything I wanted to still reach out to get the information out there Because I know a lot of them do have Ford Explorer. If is this something that is an issue for other people I wanted to at least be someone else to report this issue. None of these issues were due to me buying a car and this is something that was not provided when I bought the car. I am pretty sure every time it rain when I lived in IN, they had to clean out the puddle of water in passenger front floor. Although I know this is also error on dealership and I can take accountability that I was naive with buying car process I still feel like it’s something that needs to be fixed manufacturer problem as many people have had this issue.

Driving vehicle with my 15 year old daughter, noticed a smell in cabin, we both started feeling strange, getting a headache, dizzy, fearful of co2 pulled over and had it towed to dealer

The hazard lights have never worked in my vehicle and after spending months at the dealership they were not able to fix this. Also my window pillar flew off hitting another car while I was doing 75mph and the window cowl did the same thing. I've been working with a Ford dealership in Evansville, Indiana on Walnut Street and the window cowls need recalled and I was told that it will take 6 weeks to fix the pillars but the window cowl is so loose it's going to fly off in due time plus most of the vehicles the hazard lights do not work at all. Also I was able to turn the My Key feature on and I can't get it to turn off and my dealership can't figure it out. My electrical power steering unit, the steering gear box and steering knuckle also went out. And the rear end fractured on me while driving I lost steering 4 times while driving and almost hit a semi.

When backing up the the dash board (camera) screen is crossed. Items that appear on the right shows on the left on the screen. And things that appear on the left show up on the right. Some how the camera is flipped

My rear backup camera isn't working all the time. I feel this is a huge safety issue and needs to be recalled.

Front left windshield assembly came off while I was driving down the highway.

Window trim pieces have fallen off 3x. We have had them replaced multiple times. Once, the trim piece came off on the highway and caused the vehicle behind to swerve. No accidents. Currently, the drivers side trim piece is loose again, and I'm considering having it replaced, again.

While driving down the middle of a busy interstate suddenly the power steering was lost and a power steering assist warning appeared. Vehicle was almost impossible to control with no steering. After making it off the roadway and into a local business and turning the car off, when I turned it back on the warning was gone and the steering worked normally. This is definitely a life threatening failure and it happens without warning.

Power Steering stopped working. EPS Fault. Seems like it should be a safety recall issue, but it's only an extended warranty. Unfortunately we're outside the warranty. Power steering should definitely be considered a Safety Recall

When I drive especially on roads with normal speed limits gas like smell or carbon monoxide smell comes into the car.

Heavy rain causes water to leak inside vehicle. Repaired sunroof on which electrical parts was “burned” out due to water leakage. Water continues to leak inside of vehicle through driver and 3rd row (driver side) seatbelts. Googled issue and looks like many people are having this problem. There is no way that dealership was not aware of this issue as it definitely rains in Indiana where car was purchased. Just would like this to be known and fixed as this can cause not only electrical issues (sunroof went out, radio dashboard has problems) but also health issue as mold can form in vehicle.

While driving 2 hours from home, service power steering light came on, steering became impossible to turn by myself. My friend and I turned steering wheel together to get vehicle off main road. We walked to the closest auto parts store to buy power steering fluid assuming there must be a leak. Instructed that it was electrical and needed to be repaired by mechanic. Closest Ford dealer was 40 minutes away and was very honest that if I had vehicle towed to them that my car would not be looked at for close to 2 weeks. Got car to local dealership and was told that it would be $2,000 to repair. No recalls or problems were mentioned to me by dealership. Did research to find that many people are having the same problem and called dealership back. They said there was not an actual recall but that there was an extended warranty placed on the part up to 150,000 miles. Like everyone else on the complaints page, my car is over that. 165,000 miles for me. Sounds like Ford did some good negotiating and was able to keep this from going to a full recall even though so many problems. I realize I won't be spared the economic loss of $2,000 but am very glad that I did not end up in an accident to find out about the well hidden problem!!!

Ford Sync screen goes black and stays black. You cannot control rear air such as heat and or a/c. With this in mind and someone having small children that ride in the back and live in an area that sees 90 to 104 degree temperature well I am sure you can guess how hot the car is inside for them. I have been told by dealerships this is a common problem with this year of ford so why is their not a recall for this yet as children and pets are suffering and risking heat stroke due to this issue.

JUST PURCHASED THIS CAR, DECIDED TO LOOK UP ANY RECALLS AND FOUND 1 PERTAINING TO THE TOE LINKS. LOOKING THROUGHLY AT THE VEHICLE THERE ARE A LOT OF MAJOR DEFECTS. THIS IS GOING TO BE A DAILY DRIVER FOR MY DAUGHTER AND I AND I TRULY DON'T FEEL SAFE AS I'M READING ALL THE REVIEWS AND RECALLS. THE ONLY THING I CAN MENTION AT THIS MOMENT ABOUT THIS CAR WOULD BE THE BACK WASHER FLUID LEAKS INTO THE CABIN, THE HOOD OF THE CAR DOES NOT SHUT CORRECTLY-HANDLE FOR THIS AREA IS LOOSE. THE STATE OF THIS CAR IS UNKNOWN.

PERSISTENT EXHAUST ODOR IN VEHICLE UPON START UP . WHEN THE VEHICLE CRANKS UP AND WITH A/C ON THERE IS A STRONG EXHAUST ODOR , IT ISN'T AS NOTICEABLE AT HIGHWAY SPEEDS BUT STILL THERE . THIS ISSUE STARTED A COUPLE WEEKS AGO AND HASN'T WENT AWAY

WATER IS LEAKING FROM THE ROOF THAT CAUSES ELECTRICAL ISSUES. BAD DESIGN BY FORD IN WHICH SEAL SEAMS NOT PROPERLY INSTALLED, WHICH CAUSE LEAKS INSIDE VEHICLE.

MY TRUCK BURST INTO FLAMES 🔥 AND BURN TO THE GROUND WHILE PARKED IN THE DRIVE WAY. *TR

Mileage: 140,000

MY 2012 FORD EXPLORER LEAKS FROM THE 3RD ROW SEATBELT. IT HAS RUINED THE CARPET IN THE BACK AND MOLDED IT. IT ALSO FILLED UP THE SPARE TIRE AREA WITH WATER AND RUSTED THE RIM OF THE SPARE TIRE AND THE INSIDE WHERE THE TIRE SITS. I DID NOT NOTICE THIS UNTIL MANY MONTHS AFTER I BOUGHT IT BECAUSE I WASN'T USING THE 3RD ROW AT THE TIME.

Mileage: 37,000

WHEN THE VEHICLE IS STATIONARY AND I TURN ON THE VEHICLE IT DISPLAYS THE FOLLOWING MESSAGE "POWER STEERING ASSIST FAULT" AND THE STEERING WHEEL LOCKS AND I AM UNABLE TO MOVE THE VEHICLE UNTIL I TURN IT OFF AND TURN IT BACK ON AT LEAST 2 TIMES. I AM AFRAID IF THIS FAILS WHILE I AM DRIVING I COULD KILL MYSELF OR SOMEONE ELSE.

Mileage: 120,776

MY EXPLORER SMELLS VERY STRONGLY OF EXHAUST WHEN ACCELERATING. IT MAKES ME NAUSEOUS AND PASSENGERS DO NOT WANT TO GET IN MY CAR ' I DON'T WANT TO GET IN MY CAR. FORD'S CUSTOMER SERVICE PROGRAM HAS NOT ADDRESSED THE ISSUE AND THEY HAVE NOT EVEN ACKNOWLEDGED THE ISSUE. PLUGGING UP TWO SMALL PLUGS IN THE TRUNK AND REPROGRAMMING THE AIR CONDITIONING/HEAT SYSTEM DOES NOT ADDRESS AN APPARENT EXHAUST LEAK. I HAVE SPOKEN WITH EMPLOYEES OF FORD, SEEN COUNTLESS STORIES ONLINE ' THIS ISSUE IS NOT UNKNOWN OR UNDIAGNOSABLE. I HOPE THAT THE NHTSA MAY PROVOKE FORD TO DO THE RIGHT THING BEFORE SOMEONE GET SERIOUSLY HURT.

COULD NOT FILL MY GAS TANK BECAUSE IT WAS BLOCKED BY SOME PIECE OF METAL. AT A GAS STATION. WENT TO AN AUTO REPAIR SHOP AND THE MECHANIC HAD TO USE 2 SCREWDRIVERS TO PUSH THE METAL OBSTACLE AWAY. I WAS THEN ABLE TO PUT GAS IN.

Mileage: 63,000

AS I WAS DRIVING ON THE HIGHWAY OUT OF NO WHERE I HEARD A FLAPPING NOISE COMING FROM THE DRIVERS SIDE OF THE WINDSHIELD, THE SAW A BLACK PIECE OF RUBBER IMMEDIATELY FLAPPING AROUND. I IMMEDIATELY SLOWED DOWN AND WENT TO PULL OVER TO SEE WHAT IT WAS. THEN I HEARD A LOUD 'POP" AND SAW THIS BLACK THING FLY PASS ME. WHEN I GOT OUT I REALIZED THE BLACK PILLAR MOLDING ON THE DRIVER'S SIDE OF THE WINDSHIELD HAD FLOWN OFF. SIMILARLY ENOUGH, MY ROOM MATE HAS THE SAME YEAR AND MODEL VEHICLE, ABOUT A WEEK AFTER MINE FLEW OFF, HER PASSENGER SIDE DID THE SAME THING, ONLY DRIVING ON RESIDENTIAL ROADS (SLOWER SPEED). THIS PIECE IS ABOUT 2 FEET LONG, AS A PROJECTILE FILING OFF A VEHICLE IN MOTION IT VERY EASILY COULD HAVE CAUSED AN ACCIDENT OR HIT A PEDESTRIAN.

Mileage: 116,000

THE CAR HAS WATER LEAKS, I STARTED HAVING PROBLEMS WITH ELECTRICAL FUNCTION AND FEAR OF FIRE OR CONTACT IN MY CAR .

AFTER PARKING MY VEHICLE IN MY DRIVE WAY (VEHICLE WAS IN PARK WITH EMERGENCY BRAKE APPLIED) I EXITED THE VEHICLE AND THE VEHICLE STARTED ROLLING FORWARDS DOWN MY SLOPPED DRIVEWAY. I ATTEMPTED TO CHASE THE VEHICLE HOPING TO JUMP IN AND APPLY THE BRAKE BUT WAS UNABLE TO. VEHICLE CAME TO A STOP AFTER HITTING MY FENCE, BUSHES, AND A SMALL TREE. THERE WAS BODY DAMAGE TO THE FRONT RIGHT PORTION OF THE VEHICLE.

Mileage: 50,800

TOOK MY 2012 FORD EXPLORER IN TO HAVE THE TIRES REPLACED AND THE NEXT DAY THERE WAS AN "ODOR" COMING INTO THE CAB AS WELL AS OUTSIDE OF CABIN AS I WAS DRIVING TO WORK AND WHEN I STOPPED AND GOT OUT OF THE VEHICLE.

SYNC SYSTEM DIED- NO SCREEN/NO USB POWER/NO NAVIGATION/NO HEAT/COOL CONTROL/NO RADIO/NO HAND-FREE PHONE WHILE DRIVING ON A HIGHWAY- UNABLE TO RESTART OR REBOOT.

Mileage: 710,000

SOMETIMES MY STEERING WHEEL WILL LOCK AND I CAN NOT MOVE AND I AM DRIVING WITH MY CHILDREN AND THAT SCARED ME I'VE CALLED THE TOW TRUCK TWICE TAKING IT TO THE DEALERSHIP FOR THEM TO FIND NOTHING. NOW MY VECHILE IS STARTING TO SHAKE WHEN I'M DRIVING AND I'M TIRED OF TAKING TO THE DEALERSHIP FOR NOTHING. I'VE TAKEN TO 2 DEALERSHIP AND THEY SAY THE SAME THING. IT'S ALWAYS WHEN I'M DRIVING. IT'S ALL I THE DEALERSHIP PAPERS. I'M SICK AND TIRED OF THIS . IT STARTED ABOUT 1 YEAR AFTER I GOT IT. I WOULD NOT BUY ANOTHER FORD

I AM WORRIED ABOUT THE CARBON MONOXIDE IN MY FORD EXPLORER. I WAS DRIVING A FRIEND OF MY TO LUNCH AND SHE GOT INSANELY RED AND BROKE OUT IN HIVES THE MINUTE I TURNED THE HEAT ON. I RIDE WITH THE WINDOWS OPEN BECAUSE I AM CONCERNED ABOUT THE AIR IN THE CABIN WITH MY 2 YEAR OLD WHO HAS ASTHMA. THERE IS ALWAYS A SMELL WHEN YOU TURN EITHER THE AIR OR THE HEAT ON.

YOU CAN SMELL EXHAUST FUMES IN THE CAB OF VEHICLE, AFTER ABOUT 15 MINUTES OF DRIVING I GET A HEADACHE AND DIZZY AND HAVE TO ROLL THE WINDOWS DOWN FOR THE DIZZINESS TO GO AWAY. SOUNDS LIKE A SIMPLE FIX HOWEVER WHEN ITS 8 DEGREES OUTSIDE AND YOU HAVE CHILDREN YOU CANT REALLY BE ROLLING THE WINDOWS DOWN. SINCE HAVING THIS VEHICLE I HAVE GONE TO THE HOSPITAL/DOCTORS MULTIPLE TIMES FOR FATIGUE AND HEADACHES TO WHICH I HAVE HAD TO GET TREATMENT. I USED TO SPEND MY LUNCH HOUR AT WORK IN MY VEHICLE AND NOW I CANT DO THIS BECAUSE I WILL GET NAUSEOUS AND FEEL LIKE I AM GOING TO FAINT. I AM SCARED TO BE TRANSPORTING MY CHILDREN IN MY VEHICLE DUE TO THIS NOW. AFTER LOOKING INTO WHAT WAS GOING ON WITH MY CAR I FOUND MANY MORE PEOPLE THAT HAVE HAD THESE ISSUES AND I'M CURIOUS AS TO WHY FORD HASN'T ISSUED A RECALL FOR THIS YET TO GET THIS FIXED. I AM HOPING THIS HELPS FORD REALIZE THAT SOMETHING NEEDS TO BE DONE. MOST PEOPLE WITH THESE SUVS ARE PARENTS WITH KIDS. NOT SURE HOW FORD CAN FEEL OKAY WITH THEMSELVES OVER PUTTING CHILDREN IN THE SITUATION OF INHALING CARBON MONOXIDE. IF IT WAS AN OPTION FOR US I WOULD PURCHASE A NEW VEHICLE BUT UNFORTUNATELY THAT'S NOT FINANCIALLY AN OPTION AT THIS MOMENT. I PURCHASED MY VEHICLE IN MARCH OF 2016.

DIZZINESS, NAUSEA FROM DRIVING VEHICLE IN SEPTEMBER, OCTOBER, NOVEMBER AND DECEMBER 2016. AUTO IN MOTION. WHEN DRIVING AUTO 1-30 MILES OR MORE, WHEN I GOT OUT OF CAR I WAS DIZZY AND AT TIMES HAD TO HOLD ONTO A POLE OR ANYTHING NEAR ME TO REGAIN BALANCE. I FELT TIRED ALL THE TIME. I PURCHASED A NEW 2017 FORD EXPEDITION IN JAN 02, 2017 AND I HAVE NOT BEEN DIZZY SINCE. I NOTICED CHICAGO TRIBUNE ARTICLE IN THE RIDES SECTION OF SUNDAY FEB. 4TH, 2018 ISSUE WRITTEN BY PHOEBE WALL HOWARD OF DETROIT PRESS AND IT HIT A NERVE WITH ME THAT THIS MAY HAVE BEEN THE PROBLEM. HIGH CARBON MONOXIDE LEVEL IN CAR CABIN.

MY 2012 FORD EXPLORER LIMITED EDITION HAS AN EXHAUST LEAK THAT IS PUSHING FUMES INTO THE CABIN OF THE VEHICLE. THE NOXIOUS FUMES ENTER THE CABIN AND INDUCE NAUSEA AND SEVERE HEADACHES. THE VEHICLE HAS BEEN BROUGHT TO A CERTIFIED FORD DEALERSHIP WHO HAS CONFIRMED THAT THIS LEAK IS PART OF A LARGELY KNOWN ISSUE THAT OCCURS WITH THE EXPLORERS'. I HAVE BEEN INFORMED THAT WHILE FORD RECOGNIZES THE PROBLEM, THEY HAVE YET TO PRODUCE THE PARTS REQUIRED TO FIX IT, AND I HAVE TO SIT AND WAIT FOR FORD TO DO WHAT IS NECESSARY ON THEIR PART, WHICH IS GOING TO TAKE AN UNDETERMINED AMOUNT OF TIME. IN THE MEANTIME I AM FORCED TO DRIVE AROUND WITH THESE FUMES ENTERING MY VEHICLE.

Mileage: 60,000

I SMELL EXHAUST WHEN IDLING OR WAITING AT STOP LIGHTS- EVEN WHEN DRIVING. AM I IN DANGER?? IT IS ONGOING AND HAPPENS OFTEN.

Mileage: 80,000

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING 72 MPH, THE CONTACT TURNED ON THE HEATER. APPROXIMATELY 15 MINUTES LATER, THE CONTACT BECAME TIRED AND SLEEPY. THE CONTACT ROLLED DOWN THE WINDOW AND FELT BETTER APPROXIMATELY SIX MINUTES LATER. THE CONTACT EXPERIENCED THIS ISSUE SEVERAL TIMES WITHIN THE PAST TWO YEARS, MAINLY DURING THE COOLER MONTHS DUE TO HAVING THE WINDOWS ROLLED UP. THE CONTACT STATED THAT THIS SEEMED TO BE A CARBON MONOXIDE FAILURE. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THERE WERE NO RECALLS ASSOCIATED WITH THE VIN. THE FAILURE MILEAGE WAS UNKNOWN.

I HAVE A 2012 FORD EXPLORER AND I REALLY LIKE IT BUT I'VE BEEN HAVING PROBLEMS WITH IT. SINCE NOVEMBER OF 2016 EVERY TIME IT RAINS OR SNOWS I COME IN TO THE TRUCK TO FIND A PUDDLE OF WATER ON THE FRONT PASSENGER SIDE FLOOR. LATELY WHEN IT RAINS IT'S LIKE IT IS LITERALLY RAINING INSIDE MY TRUCK. THE WATER LEAKS RIGHT THROUGH THE TOP WHERE MY LIGHT AND THE BUTTONS FOR MY SUNROOF IS. NOW MY BACK UP CAMERA DOESN'T WORK AND MY TRUCK IS STARTING TO SMELL LIKE MOLE. I'M ALSO AFRAID THAT THE WATER LEAKAGE IS GOING TO DESTROY ALL ELECTRICAL PROBLEM OR CAUSE A AN ELECTRICAL FIRE WHILE I'M IN MY TRUCK WITH MY KIDS. I ALSO DON'T WANT MY FLOOR TO RUST. CAN YOU PLEAS HELP ME IN FINDING OUT WHERE IS THE PROBLEM COMING FROM? A COWORKER OF MINE IS THE SAME PROBLEM WITH HER TRUCK AS WELL.

TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING 7 MPH, A GRINDING METAL SOUND WAS HEARD AND THE VEHICLE STOPPED. THE CONTACT SHUT OFF THE VEHICLE AND RESTARTED IT, BUT IT WOULD NOT ENGAGE INTO GEAR. THE CONTACT HAD THE VEHICLE TOWED TO HIS PERSONAL AUTO MECHANIC AND WAS INFORMED THAT THE PASSENGER SIDE AXLE MOUNT FRACTURED. THE TECHNICIAN REPLACED THE PASSENGER SIDE AXLE MOUNT. WHILE TEST DRIVING THE VEHICLE AFTER THE REPAIR, THE CONTACT NOTICED THAT THE INSTRUMENT PANEL LIGHTING, INCLUDING THE WRENCH ICON, THE SERVICE ADVANCE TRACK INDICATOR, AND THE CROSS TRAFFIC SYSTEM FAULT INDICATOR ILLUMINATED. THE MECHANIC STATED THAT THE VEHICLE WOULD HAVE TO BE TAKEN TO THE DEALER TO BE REPROGRAMMED SO THE INSTRUMENT PANEL LIGHTING WOULD DIM. THE CONTACT TOOK THE VEHICLE TO HELFMAN FORD (12220 SOUTHWEST FWY, STAFFORD, TX 77477) TO BE REPROGRAMMED. THERE WERE NO RECALL FOR THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.

Mileage: 74,000

STRONG CARBON MONOXIDE ODOR COMING THROUGH THE HVAC VENTS WHEN I WAS DRIVING TO WORK. I ROLLED DOWN MY WINDOW TO GET THE ODOR OUT OF THE VEHICLE. I HAVE NOTICED THIS ODOR IN THE PAST BUT I FIGURED THAT IT WAS COMING FROM OUTSIDE OF THE VEHICLE FROM OTHER MOTORISTS. AFTER RECEIVING NOTICE THAT THIS IS A RECALL AND IS POTENTIALLY COMING FROM MY VEHICLE, I WILL GO AHEAD AND SCHEDULE AN APPT. TO GET THIS RESOLVED. THIS IS A DANGEROUS ISSUE TO HAVE. MORE IMPORTANTLY WITH MY FAMILY IN THE VEHICLE. IF THE FORD "FIX" DOESN'T RESOLVE THE ISSUE MY QUESTION IS, WHAT AM I TO DO ABOUT THIS? THE FINAL PAYMENT FOR MY 2012 FORD EXPLORER IS DUE ON 01/15/2018. I REALLY DO NOT WANT TO HAVE TO PURCHASE ANOTHER VEHICLE AFTER PAYING $698 FOR THE PAST 6 YEARS. IF THIS ISSUE CONTINUES I'D EXPECT FORD TO DO 1 OF 2 THINGS, 1. TAKE BACK THE FORD EXPLORER AND LET ME TRADE FOR ANOTHER FORD VEHICLE OF EQUAL COST TO WHAT I PAID FOR MY EXPLORER, LESS THE INTEREST. 2. REFUND MY $46K THAT I PAID FOR MY FORD EXPLORER AS YOU HAVE SOLD ME AN UNSAFE VEHICLE. I'VE ALREADY HAD THE ISSUE OF LOSING POWER STEERING WHILE I WAS DRIVING ON MULTIPLE OCCASIONS. LUCKILY I GOT THAT ISSUE RESOLVED FROM A PREVIOUS RECALL. PLEASE HELP US NHTSA AS WE SHOULD NOT HAVE TO TOLERATE UNSAFE VEHICLES AT OUR EXPENSE. IT SEEMS LIKE THE HARD WORKING PEOPLE ARE THE ONLY ONES THAT PAY FOR MANUFACTURER'S MISTAKES. LET'S START PUNISHING THESE BIG COMPANIES SO THAT THEY DO A BETTER JOB REGARDING PEOPLE'S SAFETY. THANK YOU!

Mileage: 95,000

HEAVY FUMES ARE ENTERING MY CAR CAUSING HEADACHES. RECALL WAS PERFORMED AND PROBLEM CONTINUES TO PERSIST.

THERE IS A SMELL OF GASOLINE IN AND OUTSIDE OF THE VEHICLE AT ALL TIMES. THE CHECK ENGINE LIGHT KEEPS REAPPEARING EVEN AFTER CONTINUOUS EXAMINATION.

Mileage: 65,000

GEAR SHIFT MESSAGE - 'SHIFT TO PARK' AFTER PUTTING VEHICLE IN PARK AND IGNITION IS TURNED OFF.

Mileage: 45,000

WHEN TAKIN OFF AT HIGHER SPEED LIKE TO PASS SOMEONE, A SMELL OF EXHAUST FUMES FILLS THE CAR THROUGH THE AIR SYSTEM. IT'S SO BAD WE HAVE TO ROLL THE WINDOWS DOWN TO GET IT TO GO AWAY. MY BABIES EVEN COMPLAIN OF THE HORRIBLE SMELL. THIS HAS BEEN GOING ON FOR MONTHS AND I'VE HEARD OF NOW AS A BIG PROBLEM.

Mileage: 100,000

I HAVE SMELT THE EXHAUST FUMES COMING FROM THIS VEHICLE SEVERAL TIMES. I CAN REALLY SMELL THE FUMES IF I AM GOING THROUGH A DRIVE-THRU AT A RESTAURANT AND ROLL DOWN THE WINDOW. I NEVER THOUGHT MUCH OF IT UNTIL I STARTED RESEARCHING THE COMPLAINTS FROM OTHER VEHICLE OWNERS.

Mileage: 100,000

EXHAUST LEAKING BACK INTO THE VEHICLE. AS I ACCELERATE, IT SMELLS LIKE GAS FUMES COMING FROM A/C VENTS. I NOTICED IT FROM THE DAY I BOUGHT THE VEHICLE.

Mileage: 66,000

SINCE WE PURCHASED THE SUV WE NOTICED A STRONG ODOR OF FUMES IN THE VEHICLE CABIN. IT ALWAYS OCCURS WHEN ACCELERATING, LIKE WHEN ENTERING THE HIGHWAY, AND THE SMELL STARTS AT THE REAR OF THE VEHICLE WHERE MY 2 KIDS ARE. WE HAVE HAD ALL 3 REVISIONS DONE AND STILL THE ODOR PERSIST. WE ARE OBLIGATED TO LOWER THE WINDOWS EACH TIME TO NOT FEEL NAUSEOUS AND AVOID THE STRONG HEADACHES THAT USUALLY FOLLOW. MY 9 YEAR OLD SON HAS ASTHMA AND SUFFERS GREATLY FROM IT AND CONSTANTLY COMPLAINS OF DIZZINESS AS WE ARE DAILY HIGHWAY DRIVERS. MY 4 YEAR OLD HAS HAD MULTIPLE OCCASIONS OF SUDDEN VOMITING WHILE IN THE CAR, DIZZINESS AND HEADACHES. I TOO HAVE HAD TO PULL OVER TO THE SIDE OF THE ROAD DUE TO THE INTENSITY OF THE FUMES AND FEELING FAINT. I CONTACTED THE FORD HOTLINE ON THIS ISSUE AND WAS ISSUED A CASE # YET FORD RESPONDED WITH NO SOLUTION. THEY STATE THE REPAIRS THEY HAVE AVAILABLE HAVE BEEN EXHAUSTED AND THEY HAVE NO FURTHER SOLUTION. I ASKED FOR A BUY BACK AND APPARENTLY DO NOT QUALIFY FOR THAT EITHER. I DON'T KNOW WHAT TO DO. WE HAVE BEEN DEALING WITH MULTIPLE YEARLY VISITS WITH THE SAME COMPLAINT, YEAR AFTER YEAR. WE HAVE DOCUMENTATION SHOWING HOW SINCE THE YEAR OF PURCHASE WE HAD TAKEN THE VEHICLE IN FOR THE FUMES ODOR ISSUE AND THEY HAD EITHER NO REPAIR OR PRETENDED I WAS MAKING IT UP. I'M GLAD THIS ISSUE HAS SURFACED IN THE MEDIA AS I OBVIOUSLY WAS NOT MAKING IT UP, AND IT'S A REAL PROBLEM. I WORRY MORE THAN ANYTHING ABOUT THE HEALTH OF MY CHILDREN AND THEIR SAFETY. WE HAVE BEEN AFFECTED BY THIS ISSUE LONG BEFORE MOST OF THESE COMPLAINTS EVEN APPEARED, AND WE'VE HAD TO OUT OF POCKET PAY FOR MANY OF THE REPAIRS. PLEASE HELP.

Mileage: 11

EXHAUST SMELL IN CAR

EXHAUST FUMES IN CABIN. ON A COUPLE OF OCCASIONS, AN ODOR SIMILAR TO A ROTTEN EGG SMELL HAS ENTERED THE CABIN AREA WHILE DRIVING. NOT QUITE SURE AT THIS TIME IF I WAS ACCELERATING OR IF THE AC WAS ON THE RECIRCULATION/FRESH AIR MODE WHEN THE SMELL ENTERED. I AM CONCERNED ABOUT CO2 EXPOSURE TO MY FAMILY.

Mileage: 59,500

IN 2015, FORD CHARGED ME MORE THAN $700 TO MAKE THE REPAIRS NECESSARY TO ELIMINATE EXHAUST FUMES IN THE CAR. THEY HAD A KNOWN FIX AT THAT TIME, BUT STILL CHARGED ME FOR THE REPAIR.

Mileage: 58,577

STRONG ODOR IN CABIN, MAKING OCCUPANTS ILL.

Mileage: 30,000

THE CO DETECTOR I INSTALLED (BATTERY OPERATED) SOUNDS IF I CLOSE MY WINDOWS FOR MORE THAN A FEW MOMENTS DURING A TRIP. MY 10 YEAR OLD SON CAN NOT RIDE IN MY TRUCK AS HE HAS VOMITED SEVERAL TIMES DURING TRIPS IN THE PAST. THE IDEA THAT THE VEHICLE I DRIVE IS POISONING MY SON INFURIATES ME. THE EXHAUST ODOR IS UNBEARABLE, COUPLED WITH THE NAUSEA AND HEADACHES THAT RESULT FROM THE CO LEAKS I FIND MYSELF MORE AND MORE ANGRY THAT WE SPENT $30K ON A DEATH TRAP

I AM EXPERIENCING THE EXHAUST FUMES SMELL IN MY VEHICLE WHEN ACCELERATING UP HILLS OR WHEN MERGING INTO TRAFFIC. MY FAMILY HAS SUFFERED SYMPTOMS SUCH AS HEADACHES AND LIGHTHEADEDNESS DUE TO THE SMELLS. THE SMELL IS A VERY STRONG EXHAUST FUMES SMELL AND LASTS FOR AT LEAST 30 SECONDS TO A MINUTE.

2012 FORD EXPLORER RELEASES STRONG BURNT RUBBER SMELL WHEN I ACCELERATE OR REACH 3000 RPMS. IT IS GETTING WORSE THE MORE MILES I PUT ON MY CAR. CAUSES MYSELF AND MY 2 CHILDREN TO FEEL CAR SICK OR HAVE HEADACHES. THE ONLY WAY I CAN GET THE SMELL TO GO AWAY IS TO TURN OFF THE A/C OR HEAT AND ROLL THE WINDOWS DOWN. I HAVE MENTIONED IT TO LOCAL DEALERSHIP TWICE NOW AND THEY HAVE NO IDEA WHAT IS CAUSING IT BUT I'VE TOLD THEM ABOUT THE CLASS ACTION LAWSUIT AND THEY STILL ACT LIKE THEY HAVE NEVER HEARD OF IT. THE FIRST TIME I TOOK IT TO THE DEALERSHIP FOR THE SMELL THE CAR WAS ALSO MAKING A NOISE WHEN THE A/C WAS ON SO I WAS TOLD THAT THE REPAIR THEY DID WOULD FIX WHATEVER WAS CAUSING THE NOISE AND THE SMELL. I JUST TOOK IT BACK TO THE DEALERSHIP TODAY FOR AN OIL CHANGE AND ONCE AGAIN MENTIONED THE SMELL AND THEY SAID THEY HAVE NO IDEA ABOUT A BURNING SMELL AND NOBODY HAS HAD THAT ISSUE THAT THEY KNOW OF. NOW THAT I KNOW IT IS LEGITIMATELY A CONCERN AND MY KIDS AND I AREN'T JUST ACTUALLY GETTING "CAR SICK" I AM EXTREMELY UPSET THAT I'M NOT BEING TAKEN SERIOUSLY. I AM SUPPOSED TO TAKE THE CAR BACK TO THE DEALERSHIP MONDAY TO HAVE OTHER ISSUES FIXED AND I CAN'T WAIT TO SEE WHAT THEY TELL ME NOW THAT I HAVE MADE THEM AWARE OF THE LEGITIMATE PROBLEM WITH THE EXHAUST ODOR.

Mileage: 125,000

WHEN THE SHIFTER IS MECHANICALLY AND SECURELY IN PARK, THE VEHICLE'S SENSOR SYSTEM DOES NOT RECOGNIZE IT IS IN PARK. THIS LEADS TO STARTING ISSUES NBECASUE OF TWO FACTORS: 1. THE BATTERY WEARS DOWN SINCE THE CAR DOES NOT COMPLETELY SHUT DOWN AND 2. STARTING THE VEHICLE REQUIRES IT TO BE IN PARK WHICH THE VEICHILE DOES NOT RECOGNIZE IT IS IN.

I ABRUPTLY ACCELERATED AROUND A CAR THAT MANEUVERED INFRONT OF ME AND MY INTERIOR CABIN WAS FILLED WITH AN NAUSEATING EXHAUST SMELL. I GOT A HEADACHE, LIGHT HEADED, AND PULLED OVER, BECAUSE I WAS STARTING TO GET DIZZY AND DEVELOP HEADACHES. THIS OCCURRED ON A HIGHWAY, AND NEARLY KILLED ME. I AM FURIOUS.

Mileage: 59,000

THERE IS A LEAK SOMEWHERE AROUND THE REAR WINDOW/ DOOR OR TOP. EVERYTIME IT RAINS, WATER ENTERS THE CAR POURING DOWN THE 3RD ROW SEATBELT. THIS HAS HAPPENED MULTIPLE TIMES.

Mileage: 50,000

FRONT STRUT BEARINGS CLUNKING/ FAILED. NEEDED REPLACED. 55,000 MILES. STRONG ODOR OF CARBON MONOXIDE WHEN ACCELERATING OR FOLLOWING LARGE TRUCKS.

Mileage: 55,000

THE DRIVER'S SIDE WINDSHIELD TRIM BLEW OFF THE CAR WHILE TRAVELING APPROXIMATELY 70 MPH ON AN INTERSTATE CREATING A DANGEROUS PROJECTILE FOR VEHICLES BEHIND ME.

Mileage: 71,630

SMELLS EXHAUST IN THE CABIN. I HAVE BEEN GETTING HEAD ACHES AND NAUSEA WHEN I DRIVE. VEHICLE IN MOTION AND AFTER BEING IN THE CAR I GET AN EXHAUST SMELL AND GET SICK.

Mileage: 100,000

EXHAUST SMELL IN CABIN, HAVE TAKEN TO DEALER 5 TIMES AND THEY PERFORMED A FIX BUT DID NOT FIX

Mileage: 15,133

THERE'S BEEN A SMELL EACH TIME I WOULD GO IN MY TRUCK AND IT WOULD GIVE ME A HEADACHE. DURING THIS TIME I WAS PREGNANT. I RECENTLY FOUND OUT THAT IT'S BEEN THE EXHAUST FUMES ENTERING THE VEHICLE. I HAVE NOT BEEN USING MY TRUCK AND I CAN'T DRIVE MY 1 MONTH OLD BABY IN THIS CAR. THIS HAS NOT BEEN THE ONLY PROBLEM WITH THE TRUCK IT HAS BEEN SHAKING AND SHUTS OFF. I'VE ALREADY TAKEN IT TO GET REPAIRED BUT IT STILL SHAKES. I'M CONCERNED ABOUT THE FUMES COMING INTO THE CAR. IT DEFINITELY IDN'T SAFE FOR ME TO HAVE MY BABY RIDE IN. I CAN'T BELIEVE I USED THIS TRUCK DURING MY PREGNANCY THINKING IT WAS JUST ME BUT SEEING IT ON THE NEWS MADE ME REALIZE SOMETHING HAS BEEN WRONG WITH THE TRUCK THE WHOLE TIME.

I PLACED A CARBON MONOXIDE DETECTOR IN MY VEHICLE AFTER READING ABOUT ISSUES. IT HAS BEEN GOING OFF DUE TO HIGH LEVELS OF CO DETECTED INSIDE MY CAR. THE DETECTOR ONLY STOPS BEEPING WHEN I OPEN ALL OF THE WINDOWS AND TURN OFF THE AIR CONDITIONER. I USE A KIDDE CO DETECTOR THAT WILL ALARM IF LEVELS ARE ABOVE 30PPM. I HAVE SMALL CHILDREN IN THE CAR MOST OF THE TIME, AND I WANT A RECALL ON THIS ISSUE TO GET IT FIXED AND PREVENT ISSUES WITH THEIR HEALTH OR AN ACCIDENT THAT CAN ENDANGER BOTH MY FAMILY AND OTHERS, AS WELL AS FIX ALL EXPLORERS WITH THE SAME ISSUE. THE DETECTOR GOES OFF WHEN THE WINDOWS ARE CLOSED AND THE AIR CONDITIONER IS ON, AND WHEN I ACCELERATE.

Mileage: 50,000

UPON HEAVY ACCELERATION (MERGING, PASSING A VEHICLE,ETC.) EXHAUST FUMES ARE DETECTED IN THE VEHICLE. IRRELEVENT AS TO WHETHER HEAT, AC OR VENT IS OPEN.

Mileage: 10,000

BAD SMELL WITH HEAT OR AC ON AT HIGHER SPEEDS HEADACHES AND LIGHTHEADEDNESS FELT AT TIMES. A SEPERATE ISSUE ALTOGETHER WINDOWS AND DOOR LOCKS HAVE FAILED TO WORK A COUPLE TIMES LEAVING ME STUCK INSIDE CAR UNTIL IT DECIDES TO WORK. DEALER HAS HAD SUPOSED PART ON BACK ORDER FOR 2 MONTHS.

Mileage: 45,000

LEAKING EXHAUST I HAVE BEEN TESTED AND HAVE HIGH LEVELS OF CARBON DIOXIDE IN MY BLOOD I NOW HAVE A BATTERY OPERATED CARBON DIOXIDE TESTER IN MY VEHICLE. I PRAY THIS PROTECTS ME. I WAS SO FATIGUED LAST SUMMER, I WENT STRAIGHT TO BED AFTER WORK. NOW I FINALLY KNOW WHY!

Mileage: 75,000

I WAS DRIVING AND FOR NO OBVIOUS MEDICAL REASON PASSED OUT AND MY CAR TRAVELED ACROSS A HIGHWAY AND OFF THE HIGHWAY AND HIT 2 TREES. I HAVE READ A NEWS REPORT OF THIS HAPPENING TO OTHER DRIVERS WITH THIS MAKE AND MODEL OF MY CARD.

Mileage: 82,000

THE SMELL OF EXHAUST IN THE CABIN. SAW THIS INTHE RECENT NATIONAL NEWS. EXACTLY WHAT I EXPERIENCED AFTER THE PURCHASE OF MY VECHICLE BUT KEEP JUST BEING DISREGARDED AS NOTHING. ALL MY ISSUES WERE NEVER RESOVED NO LETTER EVER ANSWERED. SENT A RECENT EMAIL TO FORD, UNANSWERED, CALL LOCAL DEALSHIP AND LADY IS SERVICE DEPARTMENT SAID SHE DIDNT KNOW ANYTHING ABOUT THE RECENT INVESTIGATIONS AND TO WAIT FOR A LETTER/RECALL. THIS RECORDS ARE FROM BACK WHEN I GOT MY CAR, I HAVE LEARNED TO ADAPT TO THE SMELL AND ROLL DOWN THE WINDOWS TILL IT HAS GONE.

Mileage: 30,000

SMELL WHAT SMELLS LIKE ROTTEN EGGS. FEAR MY FAMILY AND I MAY BE IN RISK FOR CARBON MONOXIDE POISONING.

WHEN I STEP ON THE GAS GOING UP A HILL OR GOING ON TO THE FREEWAY I SMELL EXHAUST IN THE VEHICLE.

Mileage: 47,000

I PURCHASED MY EXPLORER IN OCTOBER 2011. I HAVE BEEN SUFFERING WITH BOUTS OF NAUSEA, VOMITING, DIZZINESS, WEAKNESS AND GENERAL INSTABILITY SINCE AUGUST 2013. I HAVE BEEN UNDER SEVERAL DOCTORS CARE WITH LITTLE IMPROVEMENT IN MY CONDITION. MOST RECENTLY I HAVE BEEN DIAGNOSED WITH VESTIBULAR PROXSYSMIA. MY MAJOR CONCERN IS THAT THESE SYMPTOMS COULD WELL HAVE BEEN CAUSED BY PERSISTENT CARBON MONIXIDE EXPOSURE. I WILL BE PURSUING THIS POSSIBILITY WITH THE MEDICAL PROFESSIONALS INVOLVED WITH MY CASE. I JUST RECENTLY TRADED IN THIS VEHICLE FOR A FORD ESCAPE SO NO LONGER OWN IT.

I HAVE THE SIMILAR PROBLEM WITH MY EXHAUST SYSTEM. ALTHOUGH, NO CHECK LIGHT IS ON, WHEN MY CAR IS IDLING OR EARLIER TODAY WHEN I WAS JUST DRIVING FOR AWHILE WITH THE HEAT ON, I SPELL A STRONG EXHAUST SMELL IN THE CAR.

ABOUT A YEAR AGO I BOUGHT 2012 FORD EXPLORER XLT WITH A 2.0 FOUR CYLINDER ECO BOOST ENGINE FROM A DEALER IN AKRON OHIO. I LIVE IN ROCHESTER, NY. DURING THE FIRST WINTER MONTHS I HAD THE CAR, WHEN I HAD THE HEAT ON I NOTICED A STRONG EXHAUST SMELL IN THE CABIN. AT FIRST I THOUGHT I WAS CRAZY BECAUSE THE CAR WAS IN SUCH GREAT SHAPE, BUT THE MORE PASSENGERS WOULD SAY THE SAME THING I STARTED TO REALIZE IT WAS A REAL ISSUE. I DID SOME SEARCHING ONLINE AND SEE THAT OTHER PEOPLE HAVE THE SAME ISSUE. WHEN I HAVE THE HEAT ON AND I PUT THE CIRCULATION IN RECYCLE MODE, IT SEEMS TO SUBSIDE THE PROBLEM A LITTLE, BUT THEN THE RECYCLE MODE SHUTS OFF AND GOES INTO FRESH AIR MODE AUTOMATICALLY AGAIN I GET BLASTED AGAIN WITH THESE HORRIBLE FUMES. THIS HAPPENS ABOUT EVERY 5 MINUTES WHILE I AM DRIVING AND I HAVE TO KEEP HITTING RECYCLE AND OPENING UP THE WINDOWS WHILE I AM DRIVING TO AIR OUT THE FUMES. WHEN I AM MOVING AT 50 OR MORE IT DOES NOT SEEM TO BE AN ISSUE, I DON'T KNOW WHY, BUT WHEN I COME TO A STOP IT IS BAD, EXHAUST FUMES SPEW INTO THE CABIN. I GET HEADACHES ALL THE TIME WHILE DRIVING. I AM AFRAID TO TAKE MY KIDS IN THE CAR BECAUSE OF THIS ISSUE. IF I START THE CAR FIRST THING IN THE MORNING AND I FORGOT TO TURN THE HEAT OFF THE NIGHT BEFORE, THE HEATER KICKS IN WHEN I START IT AND IT IS BAD. THIS MORNING IT SNOWED HERE IN ROCHESTER SO I WENT OUT AND STARTED THE CAR AND LET IT WARM UP FOR 5 MINUTES, WHEN I CAME OUT IT SMELLED SO BAD I COULDN'T EVEN GET IN. I HAD TO ROLLS DOWN THE WINDOWS AND LET IT AIR OUT, AND EVEN THEN WHEN I CAME TO WORK TODAY I HAVE HAD A HEADACHE ALL DAY AND I SMELL LIKE AN EXHAUST STACK. PLEASE HELP ME. I LOVE THE CAR, EXCEPT FOR THE FUMES ISSUE.

Mileage: 70,000

FUMES ENTERING THE CABIN MAKING THE PASSENGERS NAUSEOUS AND RESULTING IN HEADACHES. WE NOTICED THAT ONLY WHEN WE ARE IN MY HUSBAND'S CAR THAT MY CHILDREN AND I BECOME SICK WITH HEADACHES AND NAUSEA. MY HUSBAND DRIVES TO WORK IN THIS VEHICLE AND USUALLY ARRIVES TO WORK WITH A HEADACHE. HE DIDN'T REALIZE THAT THE CAR WAS MAKING HIM SICK. HE TRUSTED THE SERVICE PEOPLE WHEN THEY TOLD HIM THE CAR WAS FINE. HE TYPICALLY DIVES ON HIGHWAYS. THE FUMES ARE COMING THROUGH THE VENTS.

STRONG EXHAUST SMELL INSIDE CABIN WHEN ACCELERATING. VEHICLE HAD ABOUT 65000 MILES. MY SPEED WAS FROM 0MPH TO 65 MPH.

STRONG EXHAUST (BURNING OIL SMELL) COMING INTO CABIN UNDER MEDIUM TO HIGH ACCELERATION THROUGH VENTILATION ( AC ON) . THE SMELL PERMEATES THE CAR AND BURNS YOUR NOSTRILS. I COULD SMELL IT FOR QUITE SOME TIME EVEN AFTER EXISTING THE VEHICLE (AS THE SMELL REMAINS IN MY NOSE). EVEN FELT A BIT LIGHTHEADED AFTER EXISTING THE VEHICLE. I HAVE HAD PASSENGERS NOTICE THIS SMELL ON SEVERAL OCCASIONS ALSO.

Mileage: 95,000

EXHAUST LEAKING INTO PASSENGER CABIN ON ACCELERATION, NORMAL HIGHWAY SPEED AND WHEN A/C IS ON. STRONG SMELL OF EXHAUST DAILY. PURCHASED BATTERY POWERED CO DETECTOR AND IT HAS GONE OFF SEVERAL TIMES IN THE CABIN OF THE VEHICLE. WE HAVE TAKEN THE CAR TO THE FORD DEALER IN CUMMING , GA SEVERAL TIMES, BUT EACH TIME HAVE BEEN TOLD THERE ARE NO ISSUES. IT IS MY DAILY DRIVER AND I HAVE BEEN DIAGNOSED WITH SEVERAL HEALTH PROBLEMS SINCE PURCHASING THIS CAR. MY HUSBAND SUFFERS HEADACHES WHEN HE DRIVES IT. WE NOTICED THE PROBLEM A FEW DAYS AFTER THE PURCHASE OF THE 2012 MODEL IN SEPTEMBER OF 2011. WE HAVE STILL NOT BEEN ABLE TO GET A RESOLUTION.

FOR ABOUT THE LAST YEAR, I WOULD SMELL SOMETHING BURNING INSIDE MY VEHICLE WHEN ENTERING THE FREEWAY. I WAS NEVER ABLE TO IDENTIFY THE SOURCE OF THE SMELL, EVEN AFTER REPEATEDLY STOPPING TO SNIFF THE ENGINE COMPARTMENT AND AROUND THE TIRES AND EXHAUST. I COULD NOT DETECT THE SMELL OUTSIDE OF THE CAR, NOR DID I FIND ANY EVIDENCE OF ANYTHING BURNING (NO SMOKE, CHARRED AREAS, STUCK BRAKES, MELTED RUBBER, ETC). THERE DIDN'T APPEAR TO BE ANY PATTERN, AS I WOULD SMELL SOMETHING BURNING AT DIFFERENT POINTS IN MY COMMUTE, WITH THE ONLY TIME I CONSISTENTLY EXPERIENCED IT BEING MERGING ONTO THE FREEWAY. ON JUNE 20, 2016 AT 1:38 PM CENTRAL TIME, I SENT MY HUSBAND THE FOLLOWING TEXT: "IS THE FIRE EXTINGUISHER STILL IN THE CAR?" DUE TO THE OVERPOWERING SMELL OF SMOKE IN THE PASSENGER COMPARTMENT SHORTLY AFTER GETTING ON THE FREEWAY. I ROLLED DOWN THE WINDOWS AND EXITED THE FREEWAY, STOPPING AT THE FAR END OF A PARKING LOT. THERE WAS NO SMOKE NOR ODOR EMANATING FROM THE EXTERIOR OF THE VEHICLE. DUE TO THE HEAT, WE DRIVE WITH THE AIR RECIRCULATING MOST OF THE YEAR. MUCH OF OUR DRIVING IS IN THE CITY, WITH LIGHT ACCELERATION. TYPICALLY, THE ONLY TIME WE RAPIDLY ACCELERATE IS WHEN ENTERING THE FREEWAY. ON THIS OCCASION, I ACCELERATED MORE THAN NORMAL DUE TO A SEMI'S POSITION IN THE RIGHT LANE. AT TIMES, MY 7 YEAR OLD HAS COMPLAINED ABOUT NOT BEING ABLE TO BREATHE WITH THE WINDOWS ROLLED UP.

Mileage: 40,000

EXHAUST IS GETTING INTO THE CABIN OF THE CAR THROUGH THE A/C. ON SEVERAL OCCASIONS, INCLUDING 7/30, I WILL START THE CAR AND IMMEDIATELY THERE ARE FUMES COMING FROM THE A/C. WHILE DRIVING ON 7/30 WE EXPERIENCED THIS SMELL AND EXPERIENCED HEADACHES WHILE DRIVING. ALSO, THE SMELL IS OVERPOWERING WHEN STANDING OUTSIDE OF THE RUNNING VEHICLE. MORE THAN ANY OTHER CAR I HAVE OWNED.

Mileage: 27,000

WHEN EXCELERATING ON OPEN ROAD SMELLING FUMES COMING THROUGH AIR CONDITION VENTS , AC ON! MORE RPMS THAN SLOW SPEED!

Mileage: 36,000

DRIVING AT 60 MPH ORANGE LIGHT OF DEATH CAME ON AND COMPLETELY LOST POWER STEERING AND SPEED . CAR ENTERED A LIMP HOME MODE I LET IT COME TO A STOP ON SIDE OF ROAD AND IT WAS SHAKING. I RESTARTED AND DROVE ON TO WORK, IT WORKED FINE.. LUCKILY NOONE WAS AROUND ME..THIS IS EXTREMELY DANGEROUS FOR ME AND MY KIDS. THIS IS 3RD TIME IT HAPPENED... READING POSTS ITS DEFINITELY THE ELECTRONIC THROTTLE BODY THAT IS CHEAPLY MADE..THE FUSION, ESCAPE, ETC HAVE HAD AN RECALL FOR THIS...BUT NOT THE EXPLORER..PLEASE PRAY FOR MY FAMILY.

Mileage: 77,000

EXHAUST FUMES IN CAB UPON EXCELLERATION, BEEN TO DEALER MULTIPLE TIMES , STILL HAVE PROBLEM . HAVE BOUGHT CARBON MONOXIDE TESTER TO ALARM US IF LEVEL GETS TO HIGH. FORD SEEMS TO THINK ALL'S WELL . NOT!!!!!!!!!!!! 2012 FORD EXPLORER.

Mileage: 85,000

SMELL OF EXHAUST GAS INSIDE THE VEHICLE WHILE IN MOTION OR ACCELERATION.

Mileage: 28,000

WHEN ACCELERATING TO GAIN ACCESS TO A HIGHWAY OR JUST SPEEDING UP ON A LOCAL STREET, THERE IS A GAS OR BURNT OIL SMELL THAT PERMEATES THE CABIN OF THE VEHICLE. THIS HAPPENS EVERY TIME I ACCELERATE, EVERY DAY.

Mileage: 53,000

EXHAUST SMELL ENTERING CABIN DURING MILD ACCELERATION, MANY TIMES, EASILY REPEATABLE. DEALER INSTRUCTED ME TO NOT TO COMPLETE THE MOST RECENT UP TO DATE TSB, AS IT WAS NOT GUARANTEED TO WORK IN 2015. SO WE WAIT TO SEE IF THERE IS A BETTER REPAIR.

Mileage: 50,000

SOY DE PANAMA Y TENGO EL MISMO PROBLEMA QUE DICE LOS OTROS PROPIETARIO, YA ME REALIZARON DOS CAMBIO Y AUN ASI EL OLOR ES FUERTE. TENGO TAMBIEN AMIGOS QUE TIENE LO MISMO PROBLEMA DESDE QUE LA COMPRO

EXHAUST ODORS IN THE OCCUPANT COMPARTMENT AND OIL IN THE AIR FILTER

I OWN A 2012 FORD EXPLORER XLT ECOBOOST WAS FUNCTIONING FINE TILL ONE DAY DRIVING MY FAMILY BACK FROM THE AIRPORT MY CHECK ENGINE LIGHT CAME ON AND BEGAN TO FLASH. THEN ALL OF A SUDDEN THE CAR SUV BEGAN TO SHAKE HORRIBLY AND WOULD NOT IN ACCELERATION. AFTER HAVING THE EXPLORER TOWED TO THE FORD DEALER IT WAS DETERMINED THAT THE ECOBOOST SYSTEM FAILED.

Mileage: 70,000

WHILE DRIVING TO WORK, EXHAUST FUMES IN MY CAR NEARLY PUT ME TO SLEEP. I TOOK IT TO MY FORD DEALERSHIP TO FIND THE PROBLEM, AND LEARNED THAT FORD HAS A SERVICE BULLETIN TO CORRECT THIS ISSUE, SO THEY HAVE BEEN AWARE OF THIS PROBLEM. THIS SHOULD HAVE BEEN A SAFETY RELATED RECALL, BUT INSTEAD I MUST PAY $885.00 TO REPAIR THIS KNOWN SAFETY ISSUE.

Mileage: 57,000

BURNING SMELL UNDER ACCELERATION.

Mileage: 10,000

I WAS DRIVING MY 2012 FORD EXPLORER AT A REDUCED SPEED, APPROACHING AN UNPROTECTED LEFT TURN ON GREEN WHEN MY CAR SUDDENLY JERKED AND SPUTTERED AND LOST SPEED TRIGGERING THE WRENCH ICON TO LIGHT UP ON MY PANEL. I WAS APPLYING GAS TO COMPLETE THE INTERSECTION WITH NO ACCELERATION. I CRAWLED THROUGH THE INTERSECTION AS MY CAR CONTINUED TO LOSE POWER AND IDLE LOUDLY AND SPUTTER. I WAS BARELY ABLE TO GET OFF THE ROAD AND HAD THIS BEEN A BUSIER TIME OF THE MORNING COULD HAVE BEEN IN A SIDE IMPACT CRASH. THE SERVICE CENTER CLEANED THE THROTTLE BODY AND THE PROBLEM APPEARED TO BE SOLVED UNTIL ALMOST A YEAR LATER 9/25/2015, AS I HAD JUST SHIFTED FROM REVERSE TO DRIVE AND AS I ACCELERATED AND BEGAN DRIVING, MY CAR SUDDENLY SPUTTERED AND WENT INTO THE SAME STALL DESCRIBED ABOVE. I APPLIED GAS AND TRIED TO ACCELERATE WITH NO SUCCESS. THE WRENCH LIGHT CAME ON AGAIN. I WAS TOLD TO TURN IT OFF AND THEN BACK ON WHICH ALLOWED ME TO DRIVE IT WITH CAUTION, TO THE SERVICE CENTER. AFTER DIAGNOSIS AT MY LOCAL SERVICE CENTER, IT WAS DETERMINED THAT THE ELECTRONIC THROTTLE BODY IS WORN OUT AND NEEDS REPLACED. MY VEHICLE ISN'T EVEN 5 YEARS OLD. THIS IS VERY PERPLEXING. THE INCIDENTS ARE UNSETTLING AND SHOULD IT HAPPEN ON A BUSY ROADWAY OR WHILE ACCELERATING TO MAKE TURNS OR PASS A PERSON IS AT A GREAT RISK OF BEING INJURED OR KILLED.

PAINT ON HOOD IS BLISTERING - FORD KNOWS ABOUT THIS ISSUE AND ISSUED A TSB IN 2004 TO FIX THIS ISSUE IN 2004 WHY ARE WE STILL HAVING THIS ISSUE ON A 2012 VEHICLE - DEALER SAYS FORD HQ DENIED REPAIR TO HOOD PAINT SINCE VEHICLE IS OUT OF 3 YEAR 36,000 MILE WARRANTY - WHY IS PAINT CORRODING ON 3+ YEAR OLD $34,000 VEHICLE? FORD SHOULD TAKE CARE OF THIS ISSUE SINCE IT IS KNOWN AND DEVALUES THE VEHICLE BY MANY $K.

Mileage: 47,000

WE OUR PURCHASED THIS VEHICLE FROM A LOCAL FORD DEALER. OVERALL WE LOVED THE VEHICLE UNTIL WE REALIZED THIS SUV WAS NOT 4 WHEEL OR ALL WHEEL IT WAS JUST A REGULAR VEHICLE. IT HAS 20" INCH WHEELS AND WE CANNOT FIND ALL SEASON TIRES TO FIT THIS VEHICLE. IT WAS THE SCARIEST WINTER OF OUR LIVES!! WE TAKE SMALL CHILDREN TO AND FROM SCHOOL(MENNONITE) AND ALSO HAVE TWO MENTALLY CHALLENGED FOLKS WHO LIVE WITH US AND HAVE TO TRANSPORT THEM TO DR'S APPT FROM TIME TO TIME. WHY ON EARTH WOULD A VEHICLE LIKE THIS BE ORDERED TO BE SOLD IN THIS REGION EQUIPPED WITH THE TIRES IT HAD ON IT. ITS EXTREMELY DANGEROUS IN WINTER CONDITIONS. WE'RE IN OUR LATE 60'S. AND HAD TO LITERALLY PUSH THIS VEHICLE OUT OF OUR DRIVEWAY IN NOTHING BUT A DUSTING OF SNOW!!! ANY TIRE DEALER WE TRIED TO GET TIRES FROM WERE IN TOTAL DISBELIEF THAT ITS AN SUV TYPE VEHICLE WITH NO EXTRA DRIVE CAPABILITIES AND THEY CANNOT FIND TIRES FOR THE 20" RIMS.

POWER CUT OFF. (GOLDEN WRENCH OF I DONT KNOW WHAT'S WRONG CAME ON) ON 4 LANE HAD TO PULL OVER TO SHOULDER OF ROAD. CUT OFF ENGINE, RESTART, NO LIGHT DROVE TO FORD SHOP MONDAY AND LEFT CAR. SHOP TO CHECK OUT AND GET BACK WITH ME. FRIDAY HAD TO CALL AND SEE IF ANY NEWS OF WHATS WRONG. TOLD AFTER 3 HR RUNAROUND, NEEDS BATTERY AND THROTTLE BODY $ 900.00 +- OUT OF WARRANTY CONSUMER SATISFACTION PROGRAM 13N03

Mileage: 53,000

WE HAVE A 2012 FORD EXPLORER WITH 46,000 MILES AT THIS TIME. ON AUGUST 30, 2014, WE WERE DRIVING ABOUT 35 MPH WHEN THE CAR LOST ALL POWER, AND THE POWERTRAIN/WRENCH LIGHT CAME ON IN THE DISPLAY. THE CHECK ENGINE LIGHT DID NOT COME ON. I PULLED TO THE SIDE OF THE ROAD WHERE THE CAR WAS SHAKING LIKE IT WANTED TO STALL. I TURNED THE CAR OFF AND BACK ON, AND IT STARTED UP FINE, AND THE WRENCH LIGHT WENT OFF. WE DROVE ANOTHER 100 MILES WHEN IT DID THE SAME THING AGAIN ON SEPTEMBER 1 GOING ABOUT 50 MPH. I TOOK IT TO THE LOCAL SHOP WHO NOTICED THAT THE VOLTAGE WAS DROPPING FROM 14 VOLTS DOWN TO 12VOLTS AND SHUTTING DOWN THE COMPUTERS (SO THEY SAID). THEY CHANGED OUT THE ALTERNATOR- $560. EVERYTHING WAS FINE UNTIL SEPTEMBER 20 WHEN THE CAR DID THE SAME THING TWICE AGAIN, ABOUT 10 MINUTES APART, GOING 70 MPH (CAR LOST POWER, WRENCH LIGHT ON, HAD TO PULL OVER AND RESTART). I TOOK IT TO THE CLOSEST FORD DEALER WITHIN 2 DAYS; THEY DROVE THE CAR 55 MILES AND COULD NOT DUPLICATE THE PROBLEM BECAUSE IT IS INTERMITTENT. THERE WERE NO ERROR CODES PRESENT. THE CHECK ENGINE LIGHT NEVER CAME ON. THEY SAID TO COME GET THE CAR AND KEEP DRIVING IT. INTERNET RESEARCH INDICATES THAT THIS IS LIKELY A THROTTLE BODY (ETB) MALFUNCTION. I CALLED THE FORD DEALER WHERE WE BOUGHT THE CAR (NOT WHERE IT WAS NOW) AND DESCRIBED THE PROBLEM TO A SERVICE MANAGER WITH 19 YEARS EXPERIENCE. HE SAID IT WAS LIKELY THE THROTTLE BODY SINCE THE CAR WOULD RESTART. HE SAID ONLY 2 THINGS TRIGGER THE WRENCH LIGHT- THE TRANSMISSION AND THE THROTTLE BODY. SINCE MY WIFE AND DAUGHTER RIDE IN THIS CAR, I DECIDED TO HAVE THE THROTTLE BODY REPLACED AT MY EXPENSE ON SEPTEMBER 24 - $470. CONTINUING TO DRIVE THE CAR AS FORD SUGGESTED, WITH AN INTERMITTENT CUT-OFF PROBLEM, WAS NOT AN OPTION FOR ME SO I DECIDED TO MAKE AN EDUCATED GUESS/DIAGNOSIS AND THROW PARTS AT IT AND SEE. *TR

Mileage: 46,000

I WAS DRIVING ON RT44 IN MA WHEN I NOTICED ONCOMING DRIVERS YELLING AT ME. I THOUGHT I WAS DOING SOMETHING WRONG AND WHEN I CAME TO A STOP LIGHT, THE DRIVER IN FRONT OF ME GOT OUT OF HIS CAR AND YELLED THAT MY 2012 FORD EXPLORED HAD FLAMES COMING FROM THE BOTTOM OF THE VEHICLE. I IMMEDIATELY EVACUATED THE CAR WITH MY WIFE AND CHILDREN AND MY CAR WAS INDEED ON FIRE. I HAPPENED TO HAVE A FIRE EXTINGUISHER WITH ME AND WAS ABLE TO PUT OUT THE FIRE. I WAS IN FRONT OF A FORD DEALER WHEN THIS HAPPENED AND THEY CAME OUT TO INSPECT THE CAR AND I WAS TOLD THE HEAT SHIELD WAS IGNITED FROM TOUCHING THE EXHAUST. THEY REMOVED THE PLATE AND YOU CAN SEE THE BURNT DAMAGE (I HAVE PICS). THIS SITUATION COULD HAVE TURNED FATAL AND THEY SAID THEY WILL PUT A NEW ONE ON. THIS SHOULD NOT BE ABLE TO CATCH FIRE AND IF IT WASN'T FOR OTHER DRIVERS I DON'T KNOW HOW THIS COULD OF ENDED. MY WIFE AND 3 YEAR OLD SON ARE NOW TERRIFIED TO RIDE IN THE EXPLORER. THIS NEEDS TO BE INVESTIGATED IMMEDIATELY. *JS

Mileage: 51,250

AFTER NUMEROUS TRIPS TO THE DEALER TO COMPLAIN ABOUT THE WAY THIS CAR WAS DRIVING MY CAR FINALLY FAILED ON AND COMPLETELY SHIFT ITSELF OFF IN THE MIDDLE OF AN INTERSECTION WHILE MAKING A LEFT TURN. I COULD NOT STEER OR ACCELERATE. I COASTED TO THE SHOULDER. TOOK THE CAR TO THE DEALER AND THEY FINALLY SAID IT WAS THE THROTTLE BODY STICKING AND REPLACED IT. LUCKILY IT WAS UNDER WARRANTY. MY PRIOR VISITS I WAS TOLD THAT THE COMPUTER SOFTWARE NEEDED TO BE UPDATED AND THAT MAYBE THE GAS I WAS PUTTING INTO THE CAR HAD TO MUCH ETHANOL. *TR

Mileage: 22,000

OWN 2012 FORD EXPLORER,BOUGHT NEW AND A CONTRIBUTING FACTOR WAS THAT IT HAD TOW PKG. ON IT. HAD OCCASION TO USE THE TOW AND CHECKED LOCAL U-HAUL AND THEY REFUSED TO RENT A TRAILER TO ME. WAS TOLD CO. POLICY FORBID RENTAL TO ANYONE DRIVING AN EXPLORER. I WAS TOTALLY SPEECHLESS AND EVEN CALLED TWO OTHER RENTALS AND WAS REFUSED. SAID TOO MANY ACCIDENTS WITH SWAY AND ROLL-OVER. AFTER RESEARCH ON LINE I HAVE FOUND IT IS TRUE..SO NOW I OWN A VEHICLE WITH TOW ON IT,AND UNLESS I AM WILLING TO SPEND SEVERAL THOUSAND TO BUY MY OWN TRAILER, IT IS TOTALLY USELESS!WONDERING HOW FORD MOTORS IS ALLOWED TO SELL THESE VEHICLES WITH THIS SAFETY ISSUE. I CONTACTED THEM AND GOT NOWHERE. SO GUESS I'M STUCK,HOWEVER, COME NEW VEHICLE TIME THERE WILL NOT BE AN EXPLORER IN MY DRIVE. SHAME ON YOU FORD. *TR

Mileage: 20,000