2014 FORD EXPLORER Engine Problems

Engine over heat warning while driving and I checked there is a coolant leakage.

The contact owns a 2014 Ford Explorer. The contact stated that while the vehicle was stopped, the vehicle jerked, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. In addition, the vehicle stalled. No warning light was illuminated. The contact was able to restart the vehicle. The contact stated that on a separate occasion, while driving at various speeds, the vehicle jerked and then the engine stalled. After several attempts, the vehicle was restarted. The check engine warning light was illuminated. The contact stated that on a separate occasion, when the contact was able to restart the vehicle, the failure recurred after driving a short distance. The contact stated that the failure persisted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 170,000.

Mileage: 170,000

Engine stopped working I wanna know if there is a warranty

Noticing a problem with the steering and wheel suspension that is affecting other Ford explorers between 2018 and 2025. Engine oil blow by. Causing oil to leak and ending up under the carriage and on the back of the vehicle. Rear camera problems.

Vehicle has code C0063-64ABS. Also has a problem with the restraint control module and ABS module causing the front tires to lock and make the car slide. I was about to get into a car crash on Oct 24,2024 because the cars front tires locked and just slide from one side to other the steering wheel went loose and I wasn't able to control the car I took it to ford dealership where they told me that it has the code that appears at the beginning of this message

Making a right turn I was startled by a vehicle running a red light. Front wheel passenger side cleared the curb. Right rear tire jumped the curb jolted back to ground. I looked at tire pressure gauges and no leaks were evident. Being on a single lane road I continued driving looking for a turn in place after traveling about a quarter of a mile an engine rattle developed and there was faint smell of smoke. I traveled another block and turned into a dollar general parking lot. The entrance was on an incline and the car stopped. I had just purchased a new battery a week before and had an oil change about 3 weeks before. The car refused to start. I called triple A and had it towed to dealer. They looked at car and could not come up with a rational reason and doubted car stopped because of violent rear contact with curb at right rear wheel was cause of engine seizing. I called USAA my insurance company their investigating agent agreed. My car is serviced at this dealer and I follow all of the maintenance guidelines I have the records as well as dealer. The car has 125,000 miles and has been well maintained. I am curious if there are any other reports this has happened with 2014 Ford Explorer or any other vehicle. I find it hard to accept such a violent jolt of the running engine did not cause something to fall loose on the running engine. The dealer and appraiser found the car oil full and in pristine condition. There was no frame damage.Turning the crank towards rear they hear metal falling into oil pan. Your thoughts?

The contact owns a 2014 Ford Explorer. The contact stated that the front passenger’s side door panel had started to detach from the body of the vehicle. The vehicle was taken to a dealer where the contact was informed that there were no recalls on the VIN and the contact was provided an estimate for the repair. The vehicle was not repaired. The contact stated that while driving at highway speeds, there was an abnormal whining sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where the contact was informed that the rear wheel bearing needed to be replaced. The dealer repaired the vehicle. The contact stated that the check engine warning light later was illuminated. The vehicle was taken back to the dealer where the contact was informed that the catalytic converter needed to be replaced. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN. The vehicle was not repaired. The failure mileage was approximately 100,000.

Mileage: 100,000

The contact owns a 2014 Ford Explorer. The contact stated that the security light was illuminated, and the battery was drained. The vehicle was taken to the local dealer, where it was diagnosed that the security panel needed to be replaced. The vehicle was repaired, but the failure recurred. While driving, the lights failed to turn on, and the horn was inoperable. The vehicle was taken back to the local dealer, where it was determined that the electrical system needed to be replaced. The vehicle was repaired. The contact stated that there was no longer a dinging sound when the doors were ajar. The interior lights were dim, and the horn was inoperable. The rubber trim was detaching. The moon roof failed to close. The vehicle was taken back to the local dealer, who determined that water had entered the vehicle through the sunroof and that the wires were wet. The dealer added plastic and glue to the sunroof. Additionally, the vehicle failed to start. There was an abnormal clicking sound while attempting to start the vehicle. The vehicle was taken back to the local dealer, where it was diagnosed that the compressor needed to be replaced because the compressor was clogged. The manufacturer was contacted, who opened a case. The failure mileage was approximately 127,000.

Mileage: 127,000

VEHICLE ENGINE LIGHT CAME ON. TOOK CAR INTO MECHANIC AND FOUND OUT A CODE POINTS TO A PROBLEM WITH THE TIMING CHAIN/CAM POSITION SENSOR. PRIOR TO THE ENGINE LIGHT COMING ON CAR PREVIOUSLY HAD (2) RANSOM ISSUES THAT NOW AFTER GETTING THE DIAGNOSIS MAKES SENSE WHY THE CAR WAS AT TIMES MAKING A FLUTTER SOUND WHEN STARTING ALONG WITH THE ENGINE RANDOMLY AT TIMES ACTING LIKE TO WAS GOING TO STOP RUNNING WHILE DRIVING THE VEHICLE. I TOLD FORD AND THE MECHANIC ABOUT IT PREVIOUSLY BUT THEY BOTH SAID AS LONG AS THERE'S NO ALARMS KEEP DRIVING IT. THE VEHICLE STILL DRIVES GOOD, BUT I WAS ADVISED NOT TO DRIVE IT UNTIL REPAIRS MADE. THE REPAIR IS $4,000.00 AND PUTTING THAT KIND OF MONEY INTO A VEHICLE THAT IS CURRENTLY VALUED AT $8 TO 10K WITH 136,000 BASED OFF MY RESEARCH IS NOT PRUDENT CONSIDERING OTHER THINGS THAT WILL EVENTUALLY NEED EXPENSIVE REPAIRS. I HAVE TAKEN GOOD CARE OF THE VEHICLE ALONG WITH KEEPING UP ON ALL SERVICES. DISCUSSED WITH A COUPLE EXPERIENCED FORD MECHANICS AND THIS REPAIR IS UNFORTUNATELY VERY COMMON. I BOUGHT THE EXTENDED WARRANTY WHEN THE CAR WAS NEW FOR YOUR INFORMATION. I HOPE FORD CAN STAND BEHIND THIS MECHANICAL FAILURE THAT APPARENTLY IS A KNOW ISSUE AND ACCOMMODATE ME FOR MY LOSS OF EQUITY IN A VEHICLE THAT SHOULD NOT BE HAVING THIS KIND OF WELL KNOWN BREAKDOWN. 1. VEHICLE IS AVAILABLE FOR INSPECTION 2. SAFETY AT RISK WHEN ENGINE LOSES POWER AND ALMOST STOPS RUNNING 3. YES, YESTERDAY I WAS AT THE LOCAL FORD DEALERSHIP MET THERE TOP "HEAVY END" MECHANIC WHO WAS VERY FAMILIAR WITH THE PROBLEM ALONG WITH (2) INDEPENDENT EXPERT MECHANICS FAMILIAR WITH THE DIAGNOSIS. 4. THE MANUFACTURER YESTERDAY SAW THE VEHICLE, AFTER TALKING TO THE HEAD MECHANIC, BASED OFF THE CODE AND SYSTEMS I DECIDED IT WAS NOT PRUDENT TO THROW MONEY AWAY ON GETTING AN OFFICIAL DIAGNOSIS BASED OFF MY COMFORT LEVEL FROM THE DISCUSSIONS WITH THE MECHANICS. 5. YES, THE CHECK ENGINE LIGHT CAME ON AND I HAD THE CAR PROMPTLY INSPECTED BY A MECHANIC.

The contact owns a 2014 Ford Explorer. The contact stated while approaching a stop light, the vehicle started to lose motive power and stalled. There was no warning light illuminated. The vehicle was able to be restarted, and the vehicle was towed to the residence. The dealer was not contacted; however, the vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 105,000.

Mileage: 105,000

N/A

Water is leaking from front of engine and into oil from water pump being told it will cost 1600 to over 2000 dollars to fix

Fumes are leaking into the cabin of the car. Possibly issues with an exhaust leak that is causing nausea and headaches when driving vehicle.

Car was sitting idle when a fan inside the engine compartment starting being very loud. Sound went away when car started moving. Noticed coolant was empty. Filled with coolant and made a 5 mile trip. Checked again and coolant was empty again.

My car keeps running out of coolant yet I’m leaving no puddles anywhere

I own a 2014 Ford Explorer. When driving home on November 4th the engine coolant light came on and there was white smoke coming from under the hood and the coolant was leaking under the vehicle. I had the vehicle towed to my local mechanic who said that the water pump needs to be replaced. He does not do this type of work so I'm unsure if there is additional damage since he stopped his inspection there. I have to have it towed to another place. I'm seeing this same issue with many vehicles with the same make/model and felt it should be reported. I did contact Ford and made a complaint.

Repeated catalytic converter failure. Issue was repaired at least twice. Converter failure caused both turbos to need replacement and has now caused engine damage. This appears to be a common issue with this engine model.

Water pump coolant leak. I’m experiencing this problem and have seen that Fire has known about this issue and hasn’t recalled it and it’s causing engine failure and leaving consumers to fort the 2000 bill to fix since it’s internal. Does needs to recall and fix this issue and replace the pump.

Under moderate to heavy acceleration exhaust fumes are pouring into the cabin. The harder you accelerate the more you smell. Gives me a headache every time.

The contact owns a 2014 Ford Explorer. The contact stated while driving 30 MPH, the engine coolant temperature warning light was illuminated. The contact was able to park the vehicle at a friend's residence nearby and added coolant to the engine. The contact stated that the failure recurred. The contact took the vehicle to the local dealer, where it was diagnosed with needing the radiator and the water pump to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was 132,720.

Mileage: 132,720

Every time while accelerating and RPMs reach above 2500 the cab of the vehicle fills with an odor . After doing a lot of research we have come to realize it is carbon monoxide. There are several open law suits and complaints about this already. When we purchased the vehicle in May of 2021 it was taken to the Ford dealership and they told us everything in the vehicle was fine. The car is available for inspection at any point. No warning lights or anything have come on at all!

Ever since I purchased my 2014 Ford Explorer, I noticed a foul smell inside the vehicle when accelerating. It seemed fine when driving normally, but when accelerating into traffic or whenever RPMs are increasing, it’s definitely noticeable. At first I thought it wasn’t that big of a deal, until my young step-son was in the passenger seat complaining about how he felt nauseous out of nowhere. So I decided to do a little research and found a TON of articles including the ones in these two links!: https://www.cbsnews.com/amp/news/ford-explorer-lawsuits-exhaust-leak-carbon-monoxide/ https://6abc.com/amp/ford-explorer-suv-sick-dizzy/3507986/

While driving my 2014 Ford Explorer from South Florida to Millegville Georgia the high temp Light came on and the engine slowed on I-16. Managed to get off The Interstate at Macon Ga. Almost caused accidents in traffic. Finally got to Ford dealer said water pump failed like so many others. $2600 estimate. End of my trip, had to rent car to get home car Still in shop in Georgia waiting for repairs.

UNKNOWN

Mileage: 154,421

I was driving my car stopped at a gas station went to leave and had no power steering. Replaced the power steering angle sensor still didn't fix the problem had to have the rack and pinion replaced all in cost almost $3000. Now my car is leaking coolant from the motor where the water pump is located

Ford built the motor with a water pump when it leaks leaks right into the crank case where the oil is so the motor seizes up and that’s what happened to my car now my car is shot

IN 11-2022, (NOVEMBER 2022), I NOTICED NO HEAT IN CABIN AND AFTER FURTHER INVESTIGATION, FOUND LOW COOLANT IN THE COOLANT RESERVOIR. I ADDED COOLANT BUT STARTED NOTICING COOLANT LEAKS ON DRIVEWAYS. HAD VEHICLE CHECKED BY FORD DEALER, WHERE THE VEHICLE WAS BOUGHT NEW, AND REGULARLY SERVICED; AND WAS TOLD THAT THE WATER PUMP INSIDE THE 3.5L ENGINE IS BAD WITH A COST OF $4,900 TO FIX. IT APPEARS THAT THERE ARE NUMEROUS FORD EXPLORER VEHICLES FROM 2011 - 2019 WITH THE 3.5L ENGINE WITH THIS ISSUE. REQUEST INVESTIGATION AND RECALL BY FORD.

When turning on the rear Auxililary climate control the cabin of the vehicle had a large amount of exhaust smell enter the cabin.

My ford Explorer has a 3.5L V6 motor. This motor was designed with the water pump installed in the crank shaft. As a result of this when the water pump fails and leaks coolant can leak into the motor and mix with the oil costing thousands of dollars in damages.

Water pump has a leak need to be replaced

The Exhaust manifold/catalytic converter is cracked causing excessive exhaust fumes which leak into the cabin area exposing passengers to carbon monoxide.

The contact owns a 2014 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle was stalling and while the accelerator pedal was depressed, the vehicle failed to accelerate as needed. The vehicle lost motive power and failed to restart. No warning lights were illuminated. The contact stated that she received assistance from a bystander to move the vehicle to the side of the roadway and noticed a puddle of water coming from underneath the engine. The vehicle was then towed to an independent mechanic where it was diagnosed that the engine needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that while driving up a hill, the vehicle was stalling and the parking brake was activated. The vehicle lost motive power and failed to restart. The vehicle was left on the side of the roadway to be towed; however, the contact's husband was able to restart the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 72,000.

Mileage: 72,000

Faulty water pump went out on roadtrip, hours away from home. It left me and my children stranded for 4 hours in 100° conditions. No engine light or indicators came on to warn there was a problem. Coolant mixed in with oil and engine started misfiring. I immediately turned vehicle off until a Mechanic could diagnose the problem.

Electric flickering occasionally smells like something burning. No warnings alerted. Interior lights/radio dim or go off or flash. Transmission problems, jerking, loss of power Cabin fills with exhaust fumes especially when stopped Unknown occurrence dates has been happening for at least 2yrs

The contact owns a 2014 Ford Explorer. The contact stated while driving 80 MPH, the temperature gauge indicated that the engine was overheating. The contact pulled over and had the vehicle towed to a dealer. While at the dealer, the vehicle was diagnosed with a defective water pump. The dealer acknowledged that the failure was a known issue; however, there was no recall associated with the vehicle. The manufacturer was also notified of the failure but offered no assistance. The contact was referred to the NHTSA for assistance. The vehicle was driven to the residence and remained unrepaired. The failure mileage was approximately 107,000.

Mileage: 107,000

The contact owns a 2014 Ford Explorer. The contact stated while driving approximately 35 MPH, the engine was making loud noises, and then the vehicle stalled. The contact pulled over safely to the side of the road. No warning lights illuminated on the instrument panel; however, a message was displayed to shift the vehicle into park (P). The state patrol arrived on the scene and contacted the towing company. The vehicle was towed to a local mechanic. The vehicle was diagnosed with water pump failure. The contact was also informed that the engine needed to be replaced. The vehicle was not repaired. The approximate failure mileage was 55,000.

Mileage: 55,000

Went to start my 2014 Explorer on and it struggled 3 times before turning on. It showed a "Check Brake System" light in the dashboard for a quick second but other than that the car seemed to be ok. I turned on my information panel to check the temperature gauge and it was normal. Kept it on that while driving my kids to school to make sure if I had to pull over I could. I immediately brought it to Hemborg Ford in Norco, CA. When I first brought it in and they popped my hood my coolant tank was below the recommended line and the service advisor immediately said it's most likely my water pump. They had my SUV for over 24 hours for testing and sure enough it's the water pump. Ford decided to install the water pumps INSIDE the engine rather than outside. This is a very dangerous move as the coolant and oil can mix which can cause a vehicle to shut down unexpectedly. Thankfully I trusted my intuition and took it in when I noticed something off and didn't ruin my engine or overall car. I was quoted $2900 to fix this issue. $2500 in LABOR and $400 in PARTS. This is because the job can take up to 14 hours to complete start to finish due to the location of the pump. This is ridiculous. We need something done. Soooooo many people are paying thousands of money out of pocket for something that shouldn't even be a problem. Look at all these complaints: https://www.vehiclehistory.com/articles/all-about-the-ford-explorer-water-pump-recalls

It’s a dang shame you spend thousands of dollars for a Ford Explorer and because the people that built it were not very smart the people that own them are having to pay thousands of dollars to replace the water pump. And Ford will not recall this or help with the cost. No warning lights come on and then we are stuck with the cost. I will never own another Fire in my life time.

Exhaust smell in passenger compartment while driving; similar to sulfur. Feel safety at risk due to smell causing headaches/nausea; concerned about carbon monoxide or other hazardous materials. Vehicle brought to dealer on 12/13/2021 and issue confirmed. Dealer aware of similar complaints across this vehicle type; TSB is available, so Ford is aware, however not catagorized by Ford as a safety issue. Dealer "reset" HVAC system, installed plugs on tailgate and installed tape on rear body module. Dealer stated additional repairs may be necessary as these "fixes" don't always work. No warning lamps, messages or other notifications. Issue first began November 27, 2021.

The contact owns a 2014 Ford Explorer. The contact stated that while driving the vehicle, the vehicle started to overheat. The check engine warning light was illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that there was sludge in the engine. The contact was informed that there was coolant leaking into the engine oil. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 133,553.

Mileage: 133,553

In failure while driving on highway and it was found that the issue was due to a faulty water pump

7/20/2020 and before, dashboard light came on with message "check charging system" then steering wheel locked up, turned off engine, waited 2-3 seconds, turned back on and its okay. Kept doing this once in a while, bought new battery, message kept coming on. 07/28/2021 message came on saying "something is draining the juice out of battery". This message came on after we bought a new battery. Told Ford company when getting oil change, they said my battery is charged okay. They don't know whats causing it.

Internal water pump failure. coolant mixing with oil. vehicle shut down unexpectedly while in motion.

Exhaust Manifold leaking. Causing Exhaust smell in cab.

THE ENGINE LIGHT CAME ON A GAVE A READING OF P0016, WHICH IS A CAMSHAFT POSITION SENSOR. TOOK MY EXPLORER TO FRED BEANS FORD IN MECHANICSBURG, PA. FOR INSPECTION. THEY TOLD ME THE CAM PHASERS ARE COMPUTER CONTROLLED CAMSHAFT GEARS. THE VARIABLE VALVE TIMING SYSTEM OPERATES WHEN THE ENGINE COMPUTER (PCM) SENDS OIL PRESSURE TO ONE OR THE OTHER CHAMBER OF THE PHASER VIS CAM TIMING SOLENOIDS. WHEN A CAM PHASER GOES BAD, THE VARIABLE CONTROL TIMING (VCT) SOLENOIDS WOULD BE DESTROYED, AND THE ENGINE CONTROL UNIT (ECU) WOULD NO LONGER BE ABLE TO CONTROL THE PHASERS, WHEN THIS HAPPENS, THE ENGINES TIMING WOULD BE AFFECTED. THE CHECK ENGINE CODE WAS HARD STORED IN THE VEHICLE WHICH RESULTED IN A FAILED EMMISSION TEST. THE RECOMMENDED REPAIRS WILL NEED TO BE DONE IN ORDER TO COMPLETE THE STATE EMMISSION TEST. THE TOTAL FOR ALL REPAIRS PLUS INSPECTION COMES TO A TOTAL OF $3,995,05 BEFORE TAX. TO ME THIS SHOULD BE A RECALL BECAUSE MY EXPLORER IS RUNNING GREAT. THE VEHICLE HAS ON 80,000 MILES ON IT AND OIL HAS BEEN CHANGED EVERY 6-7 THOUSAND MILES. I UNDERSTAND THE F-150 HAS A SIMILAR PROBLEM AND QUALIFIES FOR A RECALL WITH THE SAME BASIC ENGINE. TO ME, THIS IS RIDICULOUS. NOBODY WOULD BUY A FORD KNOWING THEY HAD TO DUMP $4000 INTO AT 80,000 MILES. LIKE I SAID MY VEHICLE IS RUNNING GREAT AND TO BE HIT WITH SUCH A REPAIR PRICE TAG IS VERY CONCERNING!! DON'T WANT TO SAY THIS IS A SCAM, BUT THIS SHOULD BE LOOKED INTO. I COULD DEAL WITH THE PRICE IF MY VEHICLE WAS RUNNING BAD. APPRECIATE ANY HELP ,

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED WHILE THE VEHICLE WAS GETTING TOPPED OFF WITH COOLANT, SHE NOTICED THAT COOLANT WAS LEAKING FROM THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO DON FRANKLIN FORD LONDON (388 KY-192, LONDON, KY 40741) WHERE IT WAS DIAGNOSED WITH THE WATER PUMP NEEDING TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RELATED THE ISSUE TO AN UNKNOWN RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE MANUFACTURER INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 96,000.

Mileage: 96,000

I HAD TOOK MY TRUCK TO A NEARBY FORD DEALERSHIP FOR A RECALL WITH THE TOE LINK TO BE REPAIRED AND YESTERDAY ON 01/30/2021 I WAS DRIVING AND THE ENGINE AND STEERING WHEEL STARTED SHAKING ENGINE SOUNDS LIKE IT'S ABOUT TO DROP THIS HAPPENED WHILE DRIVING ON A CITY STREET AND ONCE I HIT THE HIGHWAY AND I STARTED TO DRIVE OVER 50 MILES IT MADE IT WORST, MY TRUCK WAS DRIVING PERFECTLY FINE BEFORE I TOOK IT IN TO HAVE THAT RECALL REPAIRED.

Mileage: 153

WHEN DRIVING THE VEHICLE FOR COUPLE HOUR I BEGIN TO FEEL VERY DIZZY AND SICK AND I HAVE TO PUT OVER AND GET SOME AIR I HAVE NOICE EVERY TIME I DRIVE MY VEHICLE I GET THIS WAY I HAD THE VEHICLE FOR FIVE MONTHS NOW ALSO I HAVE FELT THIS WAS WHEN DRIVING AND IDLING TO A COMPLETE STOP I DON'T KNOW WHAT THE PROBLEM IS AND I ALSO STOPPED BY THE FIRE STATION TO GET CHECKED OUT AND I DID HAVE A SPO2 SCALE OF 90.

Mileage: 107,000

MY WIFE CONTINUES TO GET HEADACHES, DESPITE HAVING THE 'CUSTOMER SATISFACTION PROGRAM' THAT FORD PROVIDES DONE TO ELIMINATE CARBON MONOXIDE ISSUE IN HER CAR. WE BOUGHT A CARBON MONOXIDE SENSOR THAT READS DOWN TO 1PPM AND SHE IS GETTING 50-60PPM OF CARBON MONOXIDE IN THE CAB WHILE DRIVING HER VEHICLE. THE SAME SENSOR WAS PLACED IN 4 OTHER CARS (2 FORDS, 1 SUBARU; 1 TOYOTA) AND ALL 4 OTHER CARS READ 0 PPM. FORD IS NOT ACKNOWLEDGING THERE IS A PROBLEM AT ALL. WE CALLED TO MAKE AN APPOINTMENT TO HAVE IT CORRECTED AND THE SERVICE ADVISOR SIMPLY SAYS 'I'VE NEVER HEARD OF CARBON MONOXIDE IN THE CAB.' THOUGHT LESS THAN A YEAR AGO THEY WERE THE SAME DEALERSHIP TO DO THE 'CUSTOMER SATISFACTION PROGRAM' FOR THE EXACT SAME ISSUE.

Mileage: 65,000

WHILE DRIVING AT 25-30 MPH VEHICLE BEGAN TO SHAKE HARD, THEN MADE A MISFIRING/POPPING SOUNDS, AND MOTOR SHUT DOWN IN THE MIDDLE OF THE ROAD. I WAS ABLE TO COAST IT AS CLOSE TO THE EDGE AS POSSIBLE BUT I WAS STILL IN THE MIDDLE OF THE ROAD ENOUGH TO BE CONCERN FOR TRAFFIC ON A SEMI-BUSY ROAD. TRIED TO RESTART AND IT WOULD ONLY CLICK AND NOT EVEN ATTEMPT TO TURN OVER ANYMORE. HAD TO HAVE IT TOWED HOME. EXPLORER ONLY HAD JUST OVER 112,000 MILES ON IT WITH NO MECHANICAL CONCERN PRIOR TO THIS HAPPENING. MECHANIC DETERMINED MOTOR WAS SEIZED BUT COULD NOT DETERMINE A DEFINITE REASON AS TO WHY IT HAPPENED. *TR

Mileage: 112,000

CRACKED EXHAUST MANIFOLD. CAR HAS 75K MILES. $1300 REPAIR BILL FOR NEW MANIFOLD AND ATTACHED SENSORS.

THE WATER PUMP IN MY 2014 FORD EXPLORER 3.5L V6 ENGINE BEGAN LEAKING COOLANT. THE WATER PUMP HAD TO BE REPLACED AT 79,000 MILES. I BECAME AWARE OF THIS PROBLEM AFTER GETTING AN OIL CHANGE. THE COOLANT RESERVOIR HAD TO BE FILLED AND I WAS INFORMED OF A POSSIBLE COOLANT LEAK. TWO WEEKS AFTER GETTING THE COOLANT FILLED, MY RADIATOR FAN BEGAN RUNNING FAST AND LOUD. I BROUGHT IT INTO THE SHOP AND WAS TOLD I HAD A LEAKING WATER PUMP. THERE WAS ONLY ONE INCH LEFT OF COOLANT IN THE RESERVOIR AFTER JUST BEING FILLED UP. I WAS THEN TOLD IT WOULD TAKE 14-16 HOURS OF LABOR TO REPLACE THE WATER PUMP WHICH ITSELF COSTS LESS THAN $150. I WAS REFERRED BY THE SHOP TO THE DEALERSHIP BECAUSE THE WORK NEEDED WAS EXTENSIVE AND BECAUSE IT INVOLVED A FORD PART. THE DEALERSHIP REFUSED TO PAY FOR THE REPAIRS AND REFERRED ME TO FORD. THE DEALERSHIP CONFIRMED THE WATER PUMP LEAK. BASICALLY, THE ENGINE HAD TO BE TAKEN APART TO REPLACE THE WATER PUMP, BECAUSE THE PUMP IS MADE PART OF THE ENGINE ITSELF. I BELIEVE THE FORD ENGINE AND THE WATER PUMP IS DEFECTIVE. THE GASKETS OR BEARINGS IN THE WATER PUMP FAIL AND THERE ARE WEEP HOLES IN THE WATER PUMP WHICH ALLOW COOLANT TO LEAK INTO THE ENGINE AND MIX WITH THE ENGINE OIL. MY VEHICLE WAS OUT OF THE MANUFACTURER'S WARRANTY. I SPENT $1,839.82 TO FIX A SINGLE WATER PUMP! THERE SHOULD BE AN INVESTIGATION INTO THIS MANUFACTURING AND DESIGN DEFECT DUE TO THE BURDEN IT PLACES ON THE PUBLIC. THERE ARE ALSO SAFETY ISSUES CAUSED BY THIS DUE TO VEHICLES BEING SO AFFECTED BY THE COOLANT LEAKS THE ENGINES SHUT DOWN COMPLETELY WHILE IN USE. I UNDERSTAND THIS HAS HAPPENED TO MANY, MANY OTHER FORD 3.5L V6 ENGINES. I HAVE THE MY VEHICLE REPAIR RECORDS IF YOU WOULD LIKE TO REVIEW THEM.

Mileage: 79,072

WHEN YOU ACCELERATE AT HIGHER SPEEDS IE ON THE FREEWAY THE CAR IS FILLED WITH EXHAUST SMELL.

Mileage: 5,390

2014 EXPLORER CONTINUOUSLY LEAKING COOLANT NEAR FRONT PASSENGER TIRE. DEALERSHIP REFILLED COOLANT AND PERFORMED A PRESSURE TEST AND WAS UNABLE TO DUPLICATE THE PROBLEM. ONE YEAR LATER, THE VEHICLE IS STILL LEAKING COOLANT AND I HAVE TO KEEP ADDING ADDITIONAL COOLANT. I AM CONCERNED THIS IS A WATER PUMP FAILURE AND COST TO REPAIR CAR WOULD BE UPWARD OF 8K

Mileage: 91,000

I'M GETTING CEL ERROR CODE P0016. THERE IS A RATTLING NOISE ON STARTUP AND SOMETIMES DURING HIGHWAY DRIVING EVERYDAY. MY EXPLORER SPORT HAS 65,340 MILES ON IT, W AY TO SOON FOR A TIMING CHAIN. THE DEALER STATED I PROBABLY HAVE TIMING CHAIN STRETCH AND THERE NO TSB TO RESOLVED THE ISSUE IN MY TRUCK EVEN THOUGH I HAVE THE SAME ECOBOOST ENGINE AS THE F150 THAT THE TSB 17-0026 DOES APPLY TO. WHY NOT THE FORD EXPLORER THAT HAS SAME EXACT ENGINE AS F150 WITH THE SAME PROBLEM? WHY WAS THE FORD EXPLORER ECOBOOST LEFT OUT OF THE TSB? THERE'S AN ISSUE WITH THE ENGINE NOT MODEL OF TRUCK. I'M HOPEFULLY LOOKING FOR FORD TO HONER THE TSB FOR MY VEHICLE THAT HAS THE SAME ENGINE DEFECT

Mileage: 65,340

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT TOOK THE VEHICLE TO ROWE FORD AUBURN (699 CENTER ST, AUBURN, ME 04210) FOR ROUTINE MAINTENANCE AND WAS INFORMED THAT THE EXHAUST MANIFOLD WAS LEAKING AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. CONSUMER ALSO STATED EXHAUST WAS LEAKING FUMES INTO CARGO AREA, WHICH CAUSED HEADACHES AND LIGHT HEADINESS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 165,000. *CW*JB

Mileage: 165,000

THERE IS AN ODOR LEAKING INTO THE CAR FROM EITHER THE ENGINE OR THE EXHAUST . I'VE NOTICED IT MULTIPLE TIMES OVER THE LAST FEW DAYS AND WE HAVE TO PUT THE WINDOWS DOWN TO NOT FEEL SICK WHEN WE BREATHE. IT HAPPENS WHETHER I AM DRIVING OR STOPPED AT A LIGHT. I ALSO STARTED FEELING TIRED WHILE DRIVING AND ALMOST FELL ASLEEP AT THE WHEEL IN THE MIDDLE OF THE DAY. I HAVE NOW STOPPED USING THE VEHICLE. SOMETHING IS VERY WRONG.

Mileage: 55,000

WHEN ACCELERATING FROM A PARKED POSITION, THE ENGINE APPEARS TO SKIP, AND OR BUCK. IT IS NOTICEABLE, BUT THE DEALER CANNOT REMEDY IT.

Mileage: 63,000

THE ENGINE BEGAN LEAKING COOLANT CAUSED BY THE WATER PUMP SEAL FAILING. WE HAVE HAD SEVERAL OTHERS THAT ALSO HAVE HAD WATER PUMP FAILURES.

Mileage: 95,020

BELIEVE THERE IS AN ISSUE WITH CARBON MONOXIDE IN MY VEHICLE. WHILE DRIVING FOR ABOUT 4 HOURS THE CARBON MONOXIDE DETECTOR IN MY BAG BEGAN TO SOUND INDICATING THE PRESENCE OF CARBON MONOXIDE. IT DID NOT STOP UNTIL I REMOVED IT FROM THE VEHICLE. I WAS LIGHT HEADED AND EXPERIENCING NAUSEA AT THE TIME.

Mileage: 100,000

ON SUNDAY SEPTERMBER 1ST WHILE I WAS DRIVING BACK HOME A LIGHT ON MY DASHBOARD CAME ON, IT SAID "ENGINE COOLANT OVER TEMPERATURE" IN RED LIGHT. I WAS SCARE BECAUSE I WAS STUCK IN THE FREEWAY AND I WAS STILL FAR AWAY FROM HIM AND MY KIDS WERE IN THE BACK. I DROVE VERY SLOW AND MANAGED TO GET HOME. ON TUESDAY I TOOK MY CAR TO THE FORD DEALERSHIP AND THEY TOLD ME THAT I HAVE TO REPLACE MY WATER PUMP, AND IT WAS A HARD AND LONG SERVICE AND THAT IT WAS GOING TO COST ME $3,300. I AM SURPRISE OF HOW MUCH THAT COSTS, ESPECIALLY THAT IT HAPPENED ON MY 2014 FORD EXPLORER. I BOUGHT IT BRAND NEW AND I'VE BEEN TAKING IT TO FORD DEALERSHIP EVERY 7,000 MILES TO GET THE MAINTENANCE. PLUS, THE LAST TIME THAT I TOOK IT IN TO THE DEALERSHIP FOR ITS OIL CHANGE, THEY SAID THAT EVERYTHING WAS WORKING WELL. SO FOR MY SURPRISE TO HAVE THIS HAPPEN ESPECIALLY WHEN MY CAR ONLY HAS 82,316 MILES. THE LIGHT TURNS ON WHEN THE CAR IS IN MOTION. I CAN HEAR THE ENGINE WORKING EXTRA HARD TO COMPENSATE WHATEVER ELSE IS GOING ON.

Mileage: 82,316

I WAS GETTING HEADACHES WHILE DRIVING SO I PURCHASED A CARBON MONOXIDE DETECTOR FOR MY EXPLORER FOR $149.00. IT REGISTERED AROUND 18-20PPM WHEN DRIVING. JULY 2019 I HAD THE 'REPAIR' DONE AT MY LOCAL DEALER. AUGUST 2019, MORE HEADACHES AND MY VEHICLE STILL REGISTERS 18-20 PPM WHILE DRIVING. THE APPARENT FIX DID NOTHING TO CORRECT THE CARBON MONOXIDE FROM LEAKING INTO MY CABIN AREA. DRIVING WITH AIR CONDITIONER ON AND IN RECIRCULATING MODE.

Mileage: 20,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 40 MPH, THE VEHICLE BACKFIRED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CRANKSHAFT AND CAM SHAFT SENSORS NEEDED TO BE REPLACED. THE CONTACT CALLED SUNRISE FORD OF FONTANA (LOCATED AT 16005 VALLEY BLVD, FONTANA, CA 92335, (888) 629-1239) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

WHEN SUDDENLY ACCELERATING TO SPEED OVER 65 MPH , EXHAUST GAS/FUMES ENTER THE MAIN CABIN, AND LINGER FOR SOMETIME, UNTIL I OPEN ALL WINDOWS TO DISSIPATE THE FUMES. THIS ISSUE ALWAYS OCCUR DURING SUDDEN ACCELERATION. I HAVE TAKEN VEHICLE TO DEALER SEVERAL TIMES AND THEY INSTALLED EXTERNAL SEALS BUT ISSUE CONTINUES, EVEN AFTER THE FIXES.

Mileage: 96,000

TIMING CHAIN AND CAM PHASERS CAUSING VEHICLE TO EXCEL ERASE AND STOP WITH NO CONTROL. POWER STEERING GOING IN AND OUT WHILE DRIVING.

IDLER PULLY WENT BAD THREW BELT..ONLY HAD 32,000 MILES ON IT...IN MOTION ON A CITY STREET.HAPPEND ON A SUNDAY WILE ON VACATION IN FLORIDA..TOOK TO FIRESTONE DEALER TO FIX..COST ME $372.00 TO FIX...

Mileage: 32,000

FUEL SMELL/FUMES ENTERING PASSENGER CABIN WHEN AC/HEAT IS ON. SOMETIMES AT A STOP OR SLOW PACE AND WINDOWS ARE OPEN FUMES OR SMELL IS APPARENT. ONCE PARKED YOU CAN SMELL FROM THE FRONT PART OF THE VEHICLE IN THE HOOD NEAR THE WIPER BLADES.

WE HAVE EXPERIENCED A CLICKING NOISE ON OUR CAR OVER THE LAST COUPLE OF WEEKS AND MY WIFE HAS BEEN COMPLAINING OF HEADACHES AND FATIGUE DURING THE SAME TIME AS WELL. WE TOOK THE CAR INTO THE SHOP AND IT HAS BEEN IDENTIFIED AS A CRACK EXHAUST MANIFOLD WHICH WOULD COST US $1,100 TO FIX. I RESEARCHED AND SAW THIS 1.3MILLION REPORTS OF THE SAMETHING. I CALLED FORD AND THEY REFUSED TO HELP WITH THE REPAIRS AS THERE IS NO RECALL ON THIS ISSUE. I AM NOT SURE HOW YOU DON'T RECALL A VERY KNOWN ISSUE THAT I NOW SEE PERSONALLY CAUSES HEALTH ISSUES THAT COULD BE FATAL - PLUS YOU GET WITH A COST THAT THEY ARE AWARE OF. NOT GOOD BUSINESS AND VERY DANGEROUS - IT IS SAD IT MAY TAKE A FATAL ACCIDENT BEFORE FORD RECALLS THIS.

Mileage: 88,000

CHAIN DRIVEN WATER PUMP FAILURE AT 85,000 MILES

Mileage: 85,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS AN OPEN THROTTLE FAILURE THAT CAUSED FUMES TO ENTER THE CABIN OF THE VEHICLE. THE FAILURE WAS SIMILAR TO THAT LISTED IN NHTSA ACTION NUMBER: EA17002 (STRUCTURE, ENGINE AND ENGINE COOLING), BUT THE VEHICLE WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

2014 FORD EXPLORER 3.5 LITER ECO-BOOST >>OIL LINES LEAK AT TURBO , CAUSING OIL TO LEAK DOWN ONTO EXHAUST. VERY BAD SMELL !! THERE IS ALREADY RECALLS FOR NEWER MODELS BUT NOT THE 2014. PEOPLE ARE GOING TO GET HURT. FORD ONLY STATED TO KEEP MY RECEIPTS FOR REIMBURSEMENT IF THERE IS EVER A RE-CALL?

WON'T TURN OFF WHEN TURN OFF BUTTON IS PUSHED TO TURN VEHICLE OFF, WE HAVE TO KEEP PRESSING BUTTON ON GEAR SHIFT AND IT HAS TAKEN 35 MINUTES TO TURN IT OFF WHICH JUST HAPPEND TODAY OCT. 30, 2018 IT HAS RAISED THE DRIVER SEAT TWICE ALL BY ITESELF WHILE THE VEHICLE HAS BEEN TURNED OFF AND NO ONE IS IN THE VEHICLE WHEN THIS HAS HAPPENED. IT MAKES ODD NOISES INSIDE THE DASH WHEN VEHICLE IS TURNED OFF

Mileage: 80,000

HEADACHES BY MY HUSBAND AND MYSELF WHILE DRIVING OR RIDING. CARBON MONOXIDE READINGS FIRST TIME READ AT 11PPM ON A 10 MINUTE TRIP. CONTINUAL MONITERING READS AT 6-9 ON NORMAL DRIVING. READINGS AT 14 ON ACCELERATION. I FEEL IT'S UNHEALTHY AND SAFETO DRIVE THIS CAR DAILY.

Mileage: 54,000

EXHAUST STARTED COMING INTO REAR OF VEHICLE. WE WERE ABLE TO SMELL IT WHEN THE CAR WAS STOPPED OR MOVING SLOWLY. PEOPLE IN THE BACKSEAT COULD SMELL IT BEFORE THOSE IN THE FRONT COULD.

Mileage: 115,000

ALL RECOMMENDED REPAIRS HAVE BEEN COMPLETED ON THE FORD EXPLORER AND EXHAUST FUMES ARE STILL PRESENT IN THE CABIN.

Mileage: 44,000

WE BROUGHT THE VEHICLE TO THE DEALER AROUND WITH ABOUT 10,000 MILES ON MAY 2018 STATING WE SMELLED EXHAUST FUMES INSIDE THE VEHICLE. THEY PUT SOME TYPE OF RUBBER PLUGS IN THE LIFT GATE REAR HATCH. THIS DIDN'T CURE THE PROBLEM. BROUGHT THE VEHICLE BACK ON AUGUST 21, 2018 WITH 13,800 MILES AND TOLD THEM WHEN WE TRIED TO ENTER A FREEWAY WHILE ACCELERATING INTO TRAFFIC WITH THE A/C ON THERE IS A VERY PROFOUND ODOR OF EXHAUST FUMES INSIDE THE VEHICLE. THEY STATED THERE WAS A TSB ISSUED FOR THIS VEHICLE BACK IN 2016 FOR THIS ISSUE. BUT UNFORTUNATELY EVEN THOUGH THE CAR ONLY HAS 13,800 MILES ON IT NOW, IT IS OVER THE 3 YEAR WARRANTY PERIOD AND THE EXTENDED WARRANTY WE PURCHASED FROM THEM FOR 50,000 OR FIVE YEARS WON'T COVER IT EITHER. DEALER WANTS TO CHARGE US 1,100 FOR THE REPAIRS. WHICH SHOULD HAVE BEEN COVERED EARLIER IF WE WERE TOLD BACK IN 2016 THERE WAS A TSB FOR THIS PROBLEM WHILE IT WAS STILL UNDER WARRANTY. THIS CAR MAY BE FIVE YEARS OLD BUT IT ONLY HAD 10,000 MILES WHEN IT WAS BROUGHT IN THE FIRST TIME. CAR IS JUST ABOUT BRAND NEW AND THEY WANT US TO PAY FOR REPAIRS ON A NEW VEHICLE THAT HAS A DEFECTIVE EXHAUST SYSTEM.

Mileage: 10,000

EXHAUST SMELL/FUMES WERE NOTICED TWICE ON A 3 HOUR TRIP. PASSENGERS IN THE VEHICLE FELT NAUSEATED AND HAD HEADACHES THAT WERE NOT PRESENT BEFORE THE TRIP AND WERE RELIEVED AFTER EXITING THE VEHICLE.

Mileage: 60,668

EXHAUST FUMES COMING IN THROUGH A/C VENT UPON RAPID ACCELERATION. HAD ALWAYS BEEN A PROBLEM SINCE FIRST PURCHASING THE VEHICLE IN 2014. FORD HAS TRIED TO REPAIR PROBLEM FOUR TIMES AND IT IS STILL NOT FIXED. IT IS A DESIGN FLAW THAT FORD HAS NOT ADDRESS SINCE 2011 WHEN THIS MODEL FIRST CAME OUT AND STILL ARE PRODUCING THE VEHICLE WITH SAME DESIGN. THE REASON WHY THE FORD EXPLORER POLICE CARS HAVE MORE ISSUES IS NOT BECAUSE OF ALTERATION WITH THE VEHICLES IT IS BECAUSE THEY DRIVE THE VEHICLES FASTER AND THE HARDER YOU PUSH THE VEHICLE THE MORE YOU WILL NOTICE THE EXHAUST FUMES. THAT'S WHY THERE HAVE BEEN MORE ISSUE'S WITH FORD EXPLORER OLICE VEHICLES. THE ISSUE HAPPENS ALL THE TIME. THE VEHICLES NEED TO BE RECALLED BEFORE MORE PEOPLE GET HURT.

Mileage: 200

UPON ACCELERATION IN PASSING GEAR THERE'S A FOUL ODOR COMING THRU THE AIR VENTS. IT SMELLS LIKE AN OVER HEATED HAIR DRYER. IT'S BAD ENOUGH THAT THE WINDOWS NEED TO BE OPENED TO LET THE ODOR OUT. MY SUV IS IN THE SHOP FOR THE 2ND TIME IN A YEAR WITH THE SAME PROBLEM. TODAY'S DATE IS 07/02/2018

Mileage: 27,782

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 55 MPH, THE STEERING WHEEL FAILED TO MOVE. THE FOLLOWING DAY, THE VEHICLE FAILED TO START AND THE OIL PRESSURE, STARTING SYSTEM FAILURE, TRACTION CONTROL, AND ENGINE COOLANT WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED A LOCAL DEALER (EXPRESSWAY FORD, 3800 HIGHWAY 62 W, MT VERNON, IN 47620, (812) 838-4366) AND WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER A WARRANTY OR RECALL. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT TO HAVE THE VEHICLE TOWED TO THE LOCAL DEALER. ADDITIONALLY, THE CONTACT WAS REFERRED TO NHTSA. THE FAILURE MILEAGE WAS 120,336.

Mileage: 120,336

VEHICLE HAS A PROBLEM WITH CAM PHASERS, CAM POSTITION SENSORS & STRETCH TIMING CHAIN

EXHAUST SMELL IN PASSENGER CABIN AFTER HARD ACLERATION!

Mileage: 34,500

DURING COMMUTES TO AND FROM WORK, TYPICALLY WITH STOP-AND-GO CONDITIONS AT SLOW SPEED, I BECOME VERY SLEEPY AND INATTENTIVE, ALMOST TO THE POINT OF PASSING OUT. THIS HAPPENED RECENTLY AFTER HAVING THE CAR SERVICED FOR OIL CHANGE AND A STANDARD 15-POINT INSPECTION.

Mileage: 67,250

STRONG EXHAUST ODOR CAN BE SMELLED IN THE CABIN SHORTLY AFTER STARTING THE VEHICLE AND WHILE DRIVING. THIS ODOR CAUSES NAUSEA AND LIGHTHEADEDNESS WHILE IN THE VEHICLE. DRIVING WITH THE WINDOWS OPEN DOES HELP TO DISSIPATE THE SMALL BUT DOES NOT TAKE IT AWAY COMPLETELY.

Mileage: 40,000

I DRIVE MY FORD EXPLORER ALMOST EVERY DAY AND I WAS BECOMING PROGRESSIVELY FATIGUED AND DIZZY ( LOSS OF NORMAL BALANCE). I COULD NOT PIN PONT THE PROBLEM AREA UNTIL I RECEIVED AN "URGENT RECALL NOTICE" FROM OUR REGULAR FORD DEALERSHIP IN BELVIDERE, ILLINOIS. MY DOCTOR ORDERED A SPECIAL BLOOD TEST WHICH CONFIRMED A HIGH LEVEL OF CARBON MONOXIDE IN MY BLOOD. THE VEHICLE WAS REPAIRED BUT I STILL HAVE SOME AMOUNT OF THE HEALTH PROBLEMS. THANKS, JIM

Mileage: 52,980

SMELL EXHAUST IN CABIN UNDER ACCELERATION WITH HVAC SYSTEM ON ESPECIALLY IN RECIRCULATE MODE. VEHICLE HAS BEEN TO DEALERSHIP 5 TIMES WITH THE CURRENT SERVICE BULLETINS PERFORMED AND CAN STILL SMELL EXHAUST IN THE CABIN. THE VEHICLE WAS UNDER WARRANTY WHEN FIRST REPORTED AND THE ISSUE NOT RESOLVED AND FORD SAYS THAT'S ALL THEY CAN DO.

Mileage: 15,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 65 MPH, THE 18-MONTH OLD CHILD, WHO WAS IN A SAFETY SEAT ON THE REAR PASSENGER SEAT, BECAME UNRESPONSIVE. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD AND THE CONTACT CALLED 911. THE CHILD WAS TAKEN TO THE EMERGENCY ROOM WHERE THE DOCTOR RAN SEVERAL TESTS, BUT WAS UNABLE TO DIAGNOSE WHAT HAPPENED TO THE CHILD. THE CHILD RECOVERED AND WAS RELEASED FROM THE EMERGENCY ROOM. THE CHILD WAS TAKEN BACK INTO THE VEHICLE AND, FIVE MINUTES INTO THE DRIVE BACK TO THE CONTACT'S RESIDENCE, THE FAILURE RECURRED. THE CHILD BECAME RESPONSIVE WHEN THE CONTACT ROLLED DOWN THE WINDOW. THE CHILD WAS TAKEN TO THE PEDIATRICIAN WHO RULED OUT THAT THE CHILD MIGHT HAVE SUFFERED A SEIZURE. BOTH THE MOTHER AND THE PEDIATRICIAN SUSPECTED THAT THE CHILD MIGHT HAVE SUFFERED FROM CARBON MONOXIDE POISONING. THE DEALER WAS CALLED (FESLER AUTO MALL IN FAIRFIELD, IOWA, 641-472-2161), BUT DID NOT CALL BACK AS PROMISED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WOULD BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000.

Mileage: 82,000

I AM WRITING TO YOU IN REGARDS TO PHYSICAL ILLNESS THAT I HAVE SUFFERED AS WELL AS MY PASSENGERS FROM MY 2014 FORD EXPLORER POLICE INTERCEPTOR PACKAGE. STARTING BACK WHEN I FIRST PURCHASED THE VEHICLE AT APPROXIMATELY 59,000 MILES, I HAVE EXPERIENCED AN EXHAUST ODOR IN THE CABIN SHORTLY AFTER ACCELERATING OVER 3,000RPMS. THIS ISSUE HAS BEEN INVESTIGATED AT MY LOCAL DEALERSHIP TWICE, WITH THE TECHNICIAN CONFIRMING THE SMELL. AFTER THIS WORK WAS PERFORMED, I STILL TO THIS DAY AM SUFFERING FROM EXHAUST FUMES AND PHYSICAL ILLNESS DIRECTLY RELATED TO MY FORD EXPLORER. ALL REPAIR ORDERS FROM INVOLVED FORD DEALERSHIPS ARE IN MY POSSESSION CONFIRMING EXHAUST FUMES ARE STILL ENTERING THE CABIN. FROM THE TIME I TOOK OWNERSHIP IN OCTOBER 2016, I HAVE EXPERIENCED PHYSICAL ILLNESS WHEN DRIVING THE VEHICLE FOR MORE THAN 1 HOUR AT A TIME. I GET EXTREMELY LIGHTHEADED AND NAUSEATED, WHICH HAS CAUSED ME TO FREQUENTLY STOP THE VEHICLE AND VOMIT. MY PASSENGERS IN THE VEHICLE HAVE ALSO EXPERIENCED SIMILAR SYMPTOMS WHEN RIDING IN THE VEHICLE. WHEN THIS HAPPENS, I STOP AT A SAFE LOCATION AND REMOVE MYSELF TO FRESH AIR, AND THE SYMPTOMS SOON PASS AND I AM ABLE TO DRIVE AGAIN. RECENTLY, I HAVE TRAVELED FROM MASSACHUSETTS TO VERMONT IN MY EXPLORER. THE MOSTLY HIGHWAY DRIVING TRIP IT WAS ME AS WELL AS MY GIRLFRIEND. AFTER AROUND AN HOUR OF DRIVING AT 60MPH, MY GIRLFRIEND AND I WERE FEELING VERY DIZZY AND BECAME NAUSEATED, SO I OPTED TO STOP AND RELAX AT A REST STOP FOR FRESH AIR PRIOR TO CONTINUING MY TRIP TO VERMONT. I HAVE INSTALLED A CARBON MONOXIDE DETECTOR IN MY VEHICLE, WHICH HAS ACTIVATED MORE THAN ONE OCCASION WHILE DRIVING. AT THIS TIME I AM NEGOTIATING WITH FORD'S OFFICE OF GENERAL COUNSEL TO PERFORM A BUYBACK OF MY EXPLORER AND REPLACE IT WITH A DIFFERENT VEHICLE.

Mileage: 65,000

DRIVING ON HIGHWAY APPROX 65 MPH IN RAIN. SUDDEN LOSS OF POWER STEERING, MESSAGE ON DASHBOARD INDICATING CHECK CHARGING SYSTEM, THEN HILL ASSIST FAILURE, THEN WARNING MESSAGE THAT ALL ACCESSORY POWER WAS DISABLED TO CONSERVE POWER. THEN ALL LIGHTS ON DASHBOARD LIT UP. LOSS OF POWER STEERING IN RAIN ON HIGHWAY ALMOST CAUSED VEHICLE TO LOSE CONTROL AND BE INVOLVED IN MULTIPLE CAR ACCIDENT. SERPENTINE BELT WAS FOUND TO BE IN PROPER CONDITION, AND WAS ABLE TO DRIVE HOME ALTERNATE ROUTE ALONG 35MPH ROADS. NO FURTHER PROBLEMS ASIDE FROM OCCASIONAL SQUEAK UNDER ACCELERATION. IMMEDIATELY FOLLOWED UP WITH SERVICE CALL, SERPENTINE BELL WAS IN GOOD CONDITION, BUT BELT TENSIONER SPRING HAD FAILED. VEHICLE HAS ONLY 57,000 MILES. SEEMS EXCESSIVELY EARLY FOR THIS TYPE OF PART TO FAIL.

Mileage: 57,000

STRONG EXHAUST SMELL IN THE CABIN OF THE SUV. EVERY TIME THE ACCELERATOR IS PRESSED FOR A ACCELERATION THAT IS FAST A STRONG EXHAUST SMELL IS NOTICED IN THE CABIN OF THE SUV. THIS IS THE SAME SMELL THAT COMES FROM THE EXHAUST PIPES.

Mileage: 61,000

EXHAUST LEAK INTO VEHICLE

Mileage: 454,000

EXHAUST FUMES IN CABIN WHEN ACCELERATING AT HIGHER SPEEDS, ESPECIALLY WHEN ENTERING INTERSTATE AND PASSING CARS AT HIGHER SPEEDS.

Mileage: 50,000

THIS IS A FOLLOW UP TO NHTSA ID 11019920 FILED 8/26/17. EXHAUST ODOR, SMELLS LIKE SULFUR, STRONG, PUNGENT, COMING THROUGH DAHS BOARD VENTS DURING SUSTAINED ACCELERATION AND SHORTLY AFTER. THE PROBLEM IS REPEATABLE EVERY TIME: PUT VENT SYSTEM IN RECIRCULATION MODE, SUSTAINED ACCELERATION OVER 3,000 RPM, WAIT 5 SECONDS, STRONG SULFUR ODOR COMES THROUGH DASH BOARD VENTS. I AM NOW EXPERIENCING HEADACHES ON A CONSISTENT BASIS AS I HAVE BEEN DRIVING THE VEHICLE MORE OFTEN FOR COMMUTING SINCE PURCHASING IT IN MARCH 2017 WITH 25K MILES. I AM SEEING A DOCTOR AND AM BUILDING A CASE FOR MORE SEVERE HEADACHES WITH INCREASED DRIVING IN MY EXPLORER. TODAY, I DECIDED TO LOOK UNDER THE VEHICLE - I AM INCLUDING PHOTOS OF THE EXHAUST MANIFOLD WHICH SHOWS A CRACK NEAR THE PIPE-TO-FLANGE CONNECTION. AND, NO, MY VEHICLE IS NOT A POLICE CRUISER AND IT DOES NOT HAVE AFTERMARKET PARTS INSTALLED. HOW MANY MORE COMPLAINTS DO YOU NEED? TSB 14-0130 IS FORD'S CHEAP ATTEMPT TO HIDE A VERY SERIOUS PROBLEM AND AVOID A COSTLY RECALL OF OVER 1 MILLION VEHICLES. THE EVIDENCE CONTINUES TO MOUNT, INJURIES HAVE OCCURRED, COUNTLESS EXPLORER OWNERS HAVE EXPENDED MUCH RESOURCES IN FILING COMPLAINTS, AND FORD SAYS, "THESE VEHICLES ARE SAFE. WE HAVE NOT FOUND A SAFETY ISSUE HERE". FORD HAS ISSUED TSBS WHICH DO NOT ADDRESS THE PROBLEM. THEIR LATEST INSULT TO OFFER TO "INSPECT AND REPAIR" REAR LIFT GATES AND DRAIN VALVES, AND REPROGRAM THE AIR CIRCULATION SYSTEM IS LAUGHABLE, NOTHING MORE THAN A DISTRACTION TO HIDE THE REAL PROBLEM. FORD SHOULD PUT EVERY EXPLORER ON A LIFT AND INSPECT THE EXHAUST MANIFOLDS, AND DO EXTENSIVE TESTING OF THE VACUUM SYSTEM THAT IS CONNECTED TO THE AIR CIRCULATION SYSTEM. NHTSA: WHY IS IT TAKING YOU SO LONG TO ADDRESS THIS PROBLEM? DOES SOMEONE NEED TO DIE BEFORE YOU OR FORD TAKE THIS MATTER SERIOUSLY? YOU HAVE THE EVIDENCE YOU NEED TO FORCE A RECALL, NOW! *DT*JB

Mileage: 32,256

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE ENGINE SURGED AND CAUSED THE VEHICLE TO ACCELERATE UNEXPECTEDLY. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE DRIVER WAS ABLE TO PLACE THE GEAR IN NEUTRAL AND MANEUVER TO THE SIDE OF THE ROAD TO SAFELY STOP THE VEHICLE. A COMPLAINT WAS FILED WITH THE MANUFACTURER AND THE CONTACT WAS PROVIDED CASE NUMBER: CAS-13346113-C5W0T8. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 34,000.

Mileage: 34,000

WHEN EVER I EXHILARATE I CAN SMELL EMISSIONS IN MY CABIN OF MY TRUCK TO THE POINT THAT I HAVE TO OPEN THE WINDOWS OR ILL GET DIZZY AND HEADACHES. AT LOW SPEEDS AND HIGH SPEEDS AS WELL.

Mileage: 40,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT CARBON MONOXIDE ENTERED THE VEHICLE THROUGH THE VENTS. THE CONTACT WAS ALERTED BY THE CARBON MONOXIDE DETECTOR INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO JOHN BLEAKLEY FORD IN LITHIA SPRINGS, GA 30122 (PHONE (770) 941-9000). THE DEALERSHIP REPLACED THE VENTS AND THE EXHAUST SYSTEM; HOWEVER, THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

MY 2014 EXPLORER HAS BAD FUME SMELLS IN THE CABIN WHEN ACCELERATING TO PASS VEHICLES. I HAVE TAKEN IT TO THE DEALER ONCE TO HAVE IT REPAIRED BUT IT STILL DOES IT. I HAVE ALSO HAD A FUME SMELL IN MY NOSE THAT IS THERE WHEN I AM NOT IN THE CAR. I DIDN'T KNOW WHAT IT WAS AND AM SCHEDULED FOR AN MRI BUT I HAVE RECENTLY REALIZED THE CAR CABIN SMELLS THE SAME AS THE SMELL IN MY NOSE.

Mileage: 30,000

I PURCHASED MY USED 2014 FORD EXPLORER SPORT IN JANUARY 2017. IT IS IN EXCELLENT CONDITION, HOWEVER I HAVE DISCOVERED THAT MY VEHICLE EMITS A SULPHUR "ROTTEN EGG" SMELL WHEN I ACCELERATE TO A HIGH SPEEDS. AFTER RESEARCHING THIS ISSUE, I FOUND THAT IT IS A COMMON PROBLEM WITH FORD EXPLORERS BETWEEN YEARS 2013-2017 AND MAY BE AN EXHAUST ISSUE. I HAVE A WARRANTY ON MY VEHICLE, BUT NOTICED THIS IS NOT COVERED PART AS PART OF MY WARRANTY PACKAGE AND THERE IS CURRENTLY NOT A FORD RECALL ON THIS ISSUE. THIS IS UNSAFE AND A PROBLEM FOR MANY OWNERS LIKE ME. I DO NOT FEEL SICK WHEN I DRIVE MY CAR, BUT HAVING EXHAUST CHEMICALS IN THE AIR WHEN I DRIVE CAN POSE A SERIOUS THREAT AFTER REPEATED EXPOSURE AND COULD POTENTIALLY CAUSE SERIOUS HEALTH PROBLEMS FOR ME AND OTHER PASSENGERS. IT IS AN ISSUE THAT IS CLEARLY OBVIOUS WHEN YOU ACCELERATE AND NEEDS TO FIXED BY THE FORD MANUFACTURER.

Mileage: 33,000

I HAVE THIS CAR FROM 2014 AND IS AN EXHAUST FUMES AND CARBON MONOXIDE WAFTING INTO THE CABIN, THE DEALER TRIED TO REPAIR IT SEVERAL TIMES, SEALING THE REAR END, REPLACING THE EXHAUST BUT THE PROBLEM PERSIST, THEY ARE CURRENTLY WORKING ON ANOTHER SOLUTION, I DO NOT KNOW WHAT TO DO NEXT, THEY ALWAYS TRY TO AVOID THE PROBLEM THANKS RODRIGO DIAZ

Mileage: 500

EXPERIENCING STRONG EXHAUST FUMES INSIDE CABIN WHEN RUNNING HEAT OR AC. THE SMELL IS MORE PROMINENT WHEN VEHICLE IS SITTING STATIONARY WITH ENGINE RUNNING.

Mileage: 27,000

FORD EXPLORER EXHAUST-LEAK. MY 2014 FORD EXPLORER FIRST EXHIBITED A STRONG EXHAUST LEAK SMELLS IN THE CABIN ABOUT 18 MONTHS AGO WITH APPROXIMATELY 18-20,000 MILES. THE SMELL WAS MOST NOTICEABLE AFTER COMING TO A STOP WITH THE CAR AT FULL OPERATING TEMPERATURE. AROUND TOWN IT NEVER SEEMS TO BE PRESENT. I TOOK IT TO LOVELAND FORD AND THEY INSTALLED A "KIT" WHICH SEEMED TO STOP THE PROBLEM, HOWEVER IT HAS RECENTLY COME BACK STRONGER THAN EVER. YESTERDAY, I DROVE FROM DENVER UP INTO THE ROCKIES AND THE PROBLEM WAS PARTICULARLY BAD ON THE RETURN TRIP IN STOP AND GO TRAFFIC TO THE POINT I WAS FEELING SICK BY THE TIME I GOT HOME. I HAVE HAD THIS BEFORE BUT THE CIRCUMSTANCES MADE THIS PARTICULARLY UNPLEASANT. SO THE CIRCUMSTANCE WHEN IT MOST OFTEN EXHIBITS THE STRONG "ROTTEN EGG" SMELL MIXED WITH EXHAUST IS WHEN THE VEHICLE IS AT FULL TEMPERATURE AND COMES TO A STOP.

Mileage: 20,000

I HAVE A 2014 FORD EXPLORER WITH 89K MILES. I RECENTLY BROUGHT IT TO THE DEALER FOR AN THE SMELL OF EXHAUST FUMES INSIDE THE VEHICLE. THE SMELL COMES AT HIGHER SPEEDS (ABOVE 50 MPH) AND WHEN THE VEHICLE COMES TO A FULL STOP. THE VEHICLE MUST BE AT FULL OPERATING TEMPERATURE BEFORE YOU CAN SMELL THE EXHAUST FUMES. CURRENTLY THE SOLUTION I RECEIVED FROM THE DEALER IS TO REPLACE THE MUFFLER AND THE DUAL AIR EXTRACTOR.

Mileage: 89,000

WHEN I ACCELERATE UP HILL OR TO PASS ANYONE THE EXHAUST SMELL COMES THROUGH MY AIR CONDITIONER. IT SMELLS LIKE ROTTEN EGGS. WHEN I FIRST GOT THE CAR I CALLED THE DEALER AND THEY TOLD ME IT WAS JUST BECAUSE THE CAR WAS NEW AND NOT TO WORRY ABOUT IT. BUT IT MAKES ME SICK AND DIZZY SOMETIMES WHILE DRIVING.

Mileage: 57,936

FUMES IN THE CAR AND EVEN AFTER TAKING IT TO THE DEALERSHIP IT STILL HAS NOT FIXXED THE ISSUE THEY HAVE PUT NEW REAR VENTS IN AND ADDED MORE UNDER COATING

Mileage: 40,000

PISTON ROD BROKE AND VEHICLE COMES TO AN ABRUPT STOP AND LOSES POWER. THIS HAPPENED WHILE DRIVING ON A HIGHWAY.

EXHAUST ODOR ENTERS THE CABIN WHEN UNDER HIGH ACCELERATION WHEN MERGING ONTO A FREEWAY OR UNDER SUSTAINED, HIGH RPM (ABOVE APPROXIMATELY 3,000 RPM) WHEN TRAVELING IN MOUNTAINOUS FREEWAYS WITH SUSTAINED, UPHILL GRADE. I HAVE NOTICED THIS OCCURRENCE MORE THAN SIX TIMES SINCE I PURCHASED THE VEHICLE 5 MONTHS AGO (AT THE END OF MARCH 2017 WITH 25,000 MILES). THE ODOR SMELLS LIKE SULFUR AND FILLS THE CABIN TO THE EXTENT THAT PERSONS SITTING IN THE REAR SEATS CAN SMELL THE ODOR. THE AIR CONDITIONING SYSTEM IS USUALLY ON AND IN RECIRCULATION MODE. CURRENTLY, THE VEHICLE HAS 30,000 MILES (AUGUST 26, 2017), HAS NEVER BEEN IN AN ACCIDENT, AND IS IN EXCELLENT CONDITION (EXCEPT FOR THE EXHAUST ODOR!) AND HAS NO MECHANICAL MODIFICATIONS.

Mileage: 29,800

THERE IS A STRONG EXHAUST ODOR COMING INSIDE THE VEHICLE WITH ALL OF ITS WINDOWS UP EVERY TIME AFTER A HEAVY ACCELERATION, REGARDLESS OF WHETHER OR NOT THE A/C VENTILATION IS ON OR NOT. THE STRONG EXHAUST ODOR IS INESCAPABLE AFTERWARD WHILE STILL IN MOTION ON A CITY STREET OR HIGHWAY OR WHILE STOPPING AFTER THE ACCELERATION. THIS HAS BEEN A CONSISTENTLY REPEATABLE ISSUE WITH MY VEHICLE SINCE PURCHASING IT AS BRAND NEW. MY DEALERSHIP DID NOT FIND A TSB AND OFFERED NO RESOLUTION FOR THE PROBLEM.

Mileage: 3,150

VEHICLE UNDER HARD ACCELERATION AND THE AIR IS ON RECIRCULATE, THE CABIN FILLS UP WITH EXHAUST.

Mileage: 31,000

WE ARE GETTING EXHAUST FUMES COMING THRU AC DUCTS WHILE DRIVING

EXHAUST FUMES ODOR WHILE DRIVING IS CAUSING NAUSEA AND HEADACHES TO ME AND MY WIFE MAKING IT UNBEARABLE AND UNSAFE TO DRIVE. IT STARTED OUT ONLY WHEN WE WOULD TURN ON A/C BUT NOW ITS ALL THE TIME.

Mileage: 101,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING DRIVEN ON SEVERAL OCCASIONS, EXHAUST FUMES ENTERED THE CABIN OF THE VEHICLE. THE CONTACT STATED THAT THE FAILURE OCCURRED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED WITH THE RPM'S ABOVE 3500. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

Mileage: 40,000

MY FORD EXPLORER HAS SIGNIFICANT EXHAUST SMELL IN THE VEHICLE AT TIMES, USUALLY AFTER I HAVE KICKED IT DOWN INTO PASSING GEAR, SUCH AS IN CLIMBING HILLS. WHEN I HAD IT IN FOR SERVICE, I ASKED THE DEALER I BOUGHT IT FROM TO TRY TO IDENTIFY WHAT IS CAUSING IT AND THEY CLAIMED THEY COULD NOT DISCERN ANY ODOR. I HAVE SINCE LEARNED OF THE TECHNICAL SERVICE BULLETINS THAT HAVE BEEN PUSHED OUT BY FORD FOR MY VERY PROBLEM AND HAVE ALSO LEARNED THAT THERE IS NO INDICATION ANY OF THEIR EFFORTS TO FIX THE PROBLEM ARE ACTUALLY WORKING. I CANNOT AFFORD TO PAY FORD FOR EASTER EGG HUNTS, SO I AND MY FAMILY ARE WAITING FOR A RECALL. IN THE MEANWHILE, WE ARE DRIVING THE VEHICLE WITH THE WINDOWS DOWN. WE HAVE BEEN CONTACTED BY ONE LAW FIRM SO FAR THAT IS INVOLVED IN A CLASS ACTION LAWSUIT OVER THIS ISSUE. WE WOULD RATHER HAVE FORD FIX THE PROBLEM. THE PROBLEM WAS INITIALLY NOTICED JUST AFTER WE BOUGHT IT, BUT WE THOUGHT IT WAS DUE TO SOMETHING ON THE ENGINE THAT WOULD BURN OFF IN TIME. THE PROBLEM HAS CONTINUED THE ENTIRE TIME WE HAVE HAD THE VEHICLE. THE PROBLEM DOESN'T SEEM DIRECTLY RELATED TO SPEED OF TRAVEL.

Mileage: 34,769

WHEN ACCELERATING, A STRONG ODOR COMES FROM THE AIR VENTS. THE ODOR LINGERS AND SMELLS VERY STRONG, I BELIEVE THIS MAY BE EXHAUST FUMES, AS IT ONLY HAPPENS DURING ACCELERATION.

Mileage: 53,000

CARBON MINOXIDE ENTERING THE CABIN. EXHAUST FUMES ARE ENTERING THE CABIN.

SMELL OF EXHAUST FUMES PRESENT IN THE CABIN. ALL PASSENGERS COMPLAIN OF HEADACHES, DIZZYNESS, NAUSEA, AND LETHARGY. THIS OCCURS AFTER DRIVING WITH THE WINDOWS UP. SECOND OWNER OF VEHICLE. PROBLEM HAS EXISTED SINCE AT LEAST JUNE 7TH.

Mileage: 38,000

EXHAUST FUMES ENTER THE VEHICLE WHEN CAR ACCELERATES. HAPPENS MORE WITH HARDER ACCELERATION. IT HAPPENS REGULARLY AND

THERE IS AN EXHAUST SMELL OF ROTTEN EGGS, BURNT RUBBER, AND SULFUR THAT PROTRUDES FROM THE AIR VENTS INTO THE CABIN OF THE VEHICLE UPON ACCELERATION AND A SMALLER AMOUNT OF EXHAUST PROTRUSION UPON IDLE. BOTH CITY AND HIGHWAY DRIVING ARE AFFECTED. THE EXHAUST SMELL HAS CAUSED SOME PASSENGER NAUSEA.

Mileage: 43,600

EXHAUST FUMES CAN BE SMELLED WHEN WE START VEH. AND WHEN WE HAVE RAPID ACCELERATION. MENTIONED TO DEALER SEVERAL TIMES, WAS TOLD VERY FEW OTHERS HAVE HAD ISSUES AND NO RECALL FOR ITEM AS OF YET... THAT WAS LAST YEAR IN 2016. DATE BELOW ON WHEN IT HAPPENED WAS WHEN WE PURCHASED FROM DEALERSHIP NEW.

PURCHASED A 2014 FORD EXPLORER IN FEBRUARY 2014, AND WITHIN WEEKS OF OWNING THE VEHICLE I STARTED TO NOTICE A FOUL SMELL ENTERING THE CABIN IMMEDIATELY AFTER ACCELERATION. IF ACCELERATION OCCURS QUICKLY, WITH A HIGHER THEN NORMAL RPM OCCURRING, THE SMELL BECOMES WORSE. ON THREE SEPARATE OCCASIONS, I HAVE TAKEN THE VEHICLE TO MAC HAIK FORD IN HOUSTON FOR REPAIR. THE FIRST TWO VISITS WERE WERE NON-PRODUCTIVE, AS THE DEALERSHIP CLAIMED THEY COULD NOT REPRODUCE THE ISSUE. ON THE THIRD VISIT, I ASKED THAT THEY TECHNICIAN GO ON A TEST DRIVE WITH ME IN THE CAR. THIS VISIT FINALLY RESULTED IN AN ADMISSION FROM THE TECHNICIAN THAT HE COULD ALSO SMELL THE ODOR, AND THEY AGREED TO KEEP THE VEHICLE AND IDENTIFY THE SOURCE OF THE ISSUE. AFTER A FEW DAYS, I WAS TOLD THAT THE ISSUE HAD BEEN CORRECTED BY ADDING AN ADDITIONAL VENT LINE TOWARDS THE REAR OF THE VEHICLE. WITHIN HOURS OF HAVING THE VEHICLE BACK, IT HAD BECOME OBVIOUS THAT A PERMANENT FIX WAS NOT INSTALLED, AND THE ODOR INSIDE THE CABIN HAS CONTINUED TO OCCUR REGULARLY OVER THE PAST THREE YEARS.

Mileage: 100

EXHAUST SMELL IN CABIN. WE EXPERIENCE A STRONG ODOR IN THE CABIN WHEN ACCELERATING, TYPICALLY WHILE GETTING ONTO A HIGHWAY OR PASSING. IT MAKES NO DIFFERENCE IF THE WINDOWS ARE OPEN OR THE AC IS ON. WE DON'T DRIVE THIS VEHICLE VERY MUCH TO DATE WE HAVE 28000 MILES ON IT.

Mileage: 18,000

NAUSEA, HEADACHE. PROBLEMS MAY BE RELATED TO CARBON MONOXIDE ISSUE'S WITH VEHICLE'S ON-GOING INVESTIGATION.

Mileage: 106,251

WHEN THE VEHICLE IS RUNNING THE EXHAUST CAN BE SMELLED INSIDE THE CABIN. THIS HAPPENS TO A NOTICEABLE LEVEL WHEN THE VEHICLE IS EXCELERATED AT A FASTER PACE BY PRESSING THE GAS PEDAL QUICKLY TO EXCELERATE QUICKLY. THIS HAS OCCURRED MULTIPLE TIMES AND CAN BE REPRODUCED BY FAST EXCELERATION. THE CONSUMER STATED THE REAR LEFT TIRE BLEW OUT. THE PASSENGER WAS INJURED.*JS

Mileage: 55,000

OUR '14 EXPLORER HAS CONSISTENTLY ALLOWED EXHAUST GAS TO ENTER THE PASSENGER COMPARTMENT UPON 1/2 TO FULL THROTTLE ACCELERATION. STILL UNDER WARRANTY, THE DEALERSHIP SAID THEY WOULD FIX IT FOR ABOUT $800! THEY SAID IT WAS COMING FROM EXHAUST ENTERING THE REAR AC. AC ON OR OFF MAKES NO DIFFERENCE.

Mileage: 10,000

FIRST LONG TRIP IN MY SUV. MOST OF MY DRIVING IS CITY DRIVING TO AND FROM WORK. WHILE TRAVELING WITH THE FAMILY ON OUR VACATION, WE ALL NOTICED AFTER ACCELERATION (PASSING CARS OR UP INCLINES) THE CAR SMELLED LIKE SULFUR OR A WASTE TREATMENT PLANT (OTHER CLEVER WORDS USED BY MY DAUGHTERS). THIS WAS ALL HIGHWAY (TWO LANE UP TO FOUR LANE) TRAVEL. APPROXIMATELY 600 MILES EACH WAY. WITH THE FREQUENCY OF THE PROBLEM ON THIS TRIP, I REALIZED I'VE SMELLED IT BEFORE BUT JUST ASSUMED I WAS DRIVING PAST A SEWAGE PROBLEM OR TREATMENT FACILITY. I NEVER THOUGHT ABOUT AN ISSUE WITH MY CAR THAT WOULD CAUSE A SMELL LIKE THAT. UPON GOOGLING WHAT MIGHT CAUSE THE PROBLEM, I FOUND A LOT OF INFO ON THE ISSUE, INCLUDING A FORD SERVICE BULLETIN (ATTACHED), LAWSUITS AND YOUR ORGANIZATION'S INVESTIGATION OF THE ISSUE. BASED ON WHAT I READ, I FELT I SHOULD LET YOU KNOW I HAVE THE SAME ISSUE. I'VE CONTACTED THE LOCAL FORD DEALERSHIP FROM WHOM I BOUGHT THE CAR AND WHO SERVICES THE CAR AND THEY EVENTUALLY FOUND A BULLETIN THAT COVERS THE ISSUE BUT BECAUSE MY CAR IS RECENTLY OUT OF WARRANTY, SAID I NEED TO PAY FOR THE INVESTIGATION AND POSSIBLE FIX(ES). I AM NOT HAPPY ABOUT THAT EITHER AND AM NOW CONCERNED WHETHER THERE IS ACTUALLY A FIX. GIVEN THE KNOWLEDGE FORD HAS ABOUT THIS ISSUE, I WOULD EXPECT FORD TO FIX THIS AT THEIR COST . . . ASSUMING THERE IS A FIX. I'M GOING TO FOLLOW THIS WITH A CALL TO FORD MOTOR COMPANY'S CUSTOMER SERVICE DEPARTMENT TO MAKE THEM AWARE.

Mileage: 28,000

MY WIFE AND SON HAVE HAD FREQUENT HEADACHES AFTER DRIVING IN OUR VEHICLE FOR LONG PERIODS OF TIME. THIS HAS BEEN AN ISSUE FOR WELL OVER TWO YEARS. WE INITIALLY THOUGHT THEY WERE GETTING MOTION SICKNESS BUT AFTER FINDING OUT THAT THERE ARE SIGNIFICANT ISSUES WITH EXPLORERS AND EXHAUST FUMES THE PROBLEM IS LIKELY A RESULT OF EXHAUST FUMES IN THE VEHICLE. WE HAVE CONTINUOUSLY HAD A ROTTEN EGG SMELL COMING FROM THE VENT WHICH I ASSUMED THE A/C FILTERS NEEDED CHANGED. THE SMELL IS INSTANT UPON RUNNING THE A/C AND CONTINUOUS WHILE DRIVING THE VEHICLE. THE ODOR IS STRONGER AT THE BEGINNING BUT THIS COULD BE DUE TO ACCLIMATING TO THE SMELL WHILE DRIVING. I CHANGED ALL THE FILTERS IN THE VEHICLE AND SPRAYED THE VENT SYSTEM WITH AN ODOR TREATMENT BUT THE SMELL DIDN'T GO AWAY.

Mileage: 500

EXHAUST FUMES IN INTERIOR.

Mileage: 35,800

ON ACCELERATION LARGE AMOUNT OF EXHAUST FUMES IN THE CAB OF THE VEHICLE.

Mileage: 15,000

EXPERIENCING EXHAUST FUMES ENTERING PASSENGER COMPARTMENT.

Mileage: 16,500

WHEN THERE IS A HEAVY RAIN THE SERPENTINE BELT SQUEALS AT VARIOUS MOMENTS, FOR SHORT PERIODS OF TIME. THIS HAS BEEN GOING ON SINCE I PURCHASED THE VEHICLE IN 2014 , BUT DEALERSHIP SAID IT WAS A KNOWN ISSUE AND THERE WAS NOTHING THEY COULD DO ABOUT IT. THEY SAID IT WAS DUE TO THE BELT GETTING WET AND FORD DIDN'T KNOW HOW TO PREVENT IT FROM HAPPENING, AND THAT IT OCCURS ON OTHER FORD TRUCKS TOO. MY OTHER ISSUE HAS STARTED RECENTLY HAPPENING TO WHEN IT RAINS HEAVILY, THE "LOW BATTERY FEATURES TEMPOR. TURNED OFF" NOTIFICATION COMES ON AND MY STEERING WHEEL LOCKS UP BRIEFLY WHILE DRIVING. I CHECKED MY BATTERY CONNECTS AS THE MANUAL SAYS TO DO AND THEY ARE FINE. THIS ONLY OCCURS DURING HEAVY RAIN AND IT HAPPENS AT VARIOUS TIMES DURING DRIVING. IT NEVER JUST STAYS ON, BUT WILL TURN ON AND GO OFF AT DIFFERENT TIMES DURING THE DRIVE IN THE HEAVY RAIN. SEEMS LIKE SOMETHING IS GETTING WET CAUSING A SHORTAGE, BUT EITHER WAY ITS DANGEROUS WHEN MY STEERING WHEEL LOCKS UP.

Mileage: 90,000

WHEN QUICKLY ACCELERATING TO HIGHWAY SPEEDS THERE IS AN BURNING/EXHAUST SMELL IN THE CABIN. DOES NOT MATTER IF THE A/C IS ON OF OFF OR WHETHER ITS ON OUTSIDE AIR OR RECIRCULATION.

Mileage: 52,000

STRONG SMELL OF EXHAUST FUMES INSIDE PASSENGER COMPARTMENT

Mileage: 50,000

AN EXHAUST SMELL ENTERS THE CABIN OF THE VEHICLE. I FIRST STARTED TO NOTICE IT WHEN THE CAR WAS IDLING AND I THOUGHT IT WAS COMING FROM THE CAR AHEAD OF ME. THIS CONTINUED ON AND OFF FOR MONTHS UNTIL MORE RECENTLY WHEN THE SMELL WAS PRESENT EVEN AS I DROVE THE CAR. I HAVE HAD HEADACHES, DIZZINESS AND STOMACH UPSETS FOR MONTHS REALIZING THAT MY VEHICLE WAS PERHAPS NO LONGER SAFE FOR ME TO DRIVE. I BROUGHT IT IN TO MY DEALERSHIP AND THEY IMMEDIATELY ACKNOWLEDGED THE SMELL AND GAVE ME A LOANER. THEY HAVE FILED A COMPLAINT WITH FORD AND ARE CURRENTLY WAITING FOR THE REPAIR PARTS BUT THEY ARE ON BACKORDER. I WAS TOLD THAT POLICE DEPARTMENTS HAVE BEEN COMPLAINING ABOUT THE SAME THING. I JUST RECEIVED A CLASS ACTION LAWSUIT NOTICE SO I IMAGINE THIS WILL EVENTUALLY BE A RECALL. IN THE MEANTIME I CANNOT DRIVE MY OWN VEHICLE WITHOUT RISKING MY HEALTH. THE CAUSE TO ME IS UNKNOWN, I HAVE READ THAT IT IS A DEFECT IN THE ENGINEERING OF THE EXHAUST SYSTEM.

WHILE DRIVING VEHICLE, I NOTICED A VERY STRONG SMELL OF PROPANE OR NATURAL GAS. WHEN VEHICLE WAS STOPPED AND IDLING, THE SAME SMELL WAS DETECTED OUTSIDE THE CAR. THE NEXT DAY, THE VEHICLE SMELLED AGAIN WHILE DRIVING, ONLY THIS TIME IT SMELLED LIKE ROTTEN EGGS.

Mileage: 55,000

MY FORD EXPLORER HAS A BAD EXHAUST ODOR IN THE CABIN WHEN HARD ACCELERATING AND ON COLD MORNING EVEN AT IDLE IT IS IMPOSSIBLE TO NOTICE THE SMELL AND IT LINGERS IN THE CABIN IN TELL YOU OPEN A WINDOW. I CAN SMELL IT ANYTIME I GET ON THE HIGH WAY BUT THERE ARE TIMES WHEN I CAN SMELL A CHEMICAL TYPE SMELL WHEN STOPPED A LIGHTS.

Mileage: 60,000

EXHAUST SMELL INSIDE CABIN. I NOTICE A BAD EXHAUST ODOR IN THE CABIN IF I ACCELERATE OVER 3,000 RPM.

Mileage: 40,000

2014 FORD EXPLORER SPORT, STRONG SMELL OF ENGINE EXHAUST FUMES ENTERING PASSENGER CABIN. MUST DRIVE WITH WINDOWS OPEN TO VENT OUT PASSENGER CABIN. MY SAFETY AS WELL AS MY FAMILY'S SAFETY IS AT RISK FOR CARBON MONOXIDE POISONING, RESPITORY DISTRESS, ASTHMA AND POSSIBLE UNCONSCIOUSNESS WHILE DRIVING. THE OVERWHELMING ENGINE EXHAUST FUMES WITHIN THE PASSENGER CABIN AT TIMES IS UNBEARABLE.

Mileage: 25,000

WHENEVER I MAKE A HARD ACCELERATION, THERE IS A FOUL SMELL IN THE CABIN. SMELL IS SIMILAR TO ROTTEN EGG OR BAD CATALYTIC CONVERTER. I NORMALLY ALWAYS HAVE THE A/C ON AND IN RECIRCULATE. I HAVE NOTICED THIS EVER SINCE I BOUGHT THE CAR NEW. TWO DEALERSHIPS HAD NO ANSWER AND SAID THEY HAD NOT HEARD OF ANY COMPLAINTS.

Mileage: 25

MY CAR STARTED OFF WITH A PROPANE GAS SMELL WHICH WOULD COME AND GO. THEN IT TURNED INTO THIS SULFUR ODOR. WHICH HAD GOTTEN SO BAD THAT YOU COULD ONLY DRIVE THE CAR IF ALL THE WINDOWS WERE DOWN BECAUSE THE ODOR WOULD MAKE YOU SICK. THE CAR WAS IN MOTION AT ALL TIMES. YOU COULD SMELL THE ODOR WITH OR WITHOUT THE HEAT ON. THEN AT WHICH POINT THE ODOR NEVER ACTUALLY LEFT THE CABIN OF THE VEHICLE. AT WHICH I WOULD JUST LEAVE THE WINDOWS OPEN, IN HOPES THAT THE CAR WOULD EVENTUALLY AIR OUT.

Mileage: 37,000

I BOUGHT A BRAND NEW 2014 FORD EXPLORER AND THE EXTENDED WARRANTY AT THE TIME OF PURCHASE. THE EXHAUST FUMES COMING INTO THE VEHICLE DURING ACCELERATION AT HIGHWAY SPEEDS. I TOOK THE TRUCK IN TO WHILE IT WAS UNDER THE BUMPER TO BUMPER TO BE FIXED AND WHAT WAS DONE AT THE TIME WAS REPROGRAMMING EXHAUST AND AC INTAKE. THIS DID NOT FIX THE EXHAUST PROBLEM BUT DID IMPROVE THE SMELL AND HOW OFTEN IT OCCURRED . I RECENTLY TOOK MY TRUCK INTO GET THE EXHAUST FIXED AND THEY WILL NOT FIX IT BECAUSE IT IS PASSED THE BUMPER TO BUMPER BUT THIS IS THE SAME PROBLEM TOOK IN TO BE FIX PRIOR.

Mileage: 30,000

EXHAUST FUMES LEAKING INTO CABIN CAUSING FAMILY TO BREATHE IN FUMES. IT HAS HAPPENED SINCE WE BOUGHT THE CAR NEW. IF THE VEHICLE AC IS IN RECIRCULATING MODE AND YOU ACCELERATE, FUMES FILL THE CABIN FOR A SHORT PERIOD OF TIME. WE ALWAYS HAVE TO ROLL DOWN THE WINDOWS TO LET THE FUMES OUT. IT HAPPENS ESSENTIALLY EVERY TIME YOU DRIVE THE CAR . I CALLED FORD DEALER AND THEY SAID THAT THERE ARE NO COMPLAINTS THEY HAVE SEEN. CAUSES HEADACHES AND NAUSEA.

Mileage: 200

EXHAUST SMELL IN CABIN WHILE HVAC ON AND WINDOWS UP. THIS IS MOST NOTICEABLE WHILE ACCELERATING AND AFTER COMING TO A STOP.

Mileage: 38,000

STRONG "NATURAL GAS" SMELL INSIDE CAR WHILE DRIVING AND VERY NOTICEABLE OUTSIDE OF CAR UPON EXITING INTERIOR. CAN SMELL FROM INSIDE MY HOUSE WHEN PARKED IN GARAGE. STARTED 1/26/17 WITH 63,200 MILES ON MY SUV. TOOK TO FORD FOR SERVICE ON 1/30/17 AND WAS TOLD THERE WERE NO EMISSION PROBLEMS AND THAT IT WAS DUE TO MY PTU WHICH NEEDED TO BE REPLACED ALONG WITH PTU VENT VALVE.

Mileage: 63,200

ANYTIME THE FORD EXPLORER GOES OVER 3000 RPMS THERE'S A STRONG EXHAUST SMELL IN THE CABIN OF THE CAR. PAID TO LOOK AT OUT OF POCKET AT THE DEALERSHIP AND WAS TOLD THE PROBLEM COULD NOT BE REPRODUCED.

Mileage: 46,000

WHEN ACCELERATING VEHICLE WITH THE AC ON, AND IN INTERNAL AIR MODE, THERE IS A SMELL LIKE BURNT RUBBER, OR FUMES THAT FILL THE ENTIRE CAR. I HAVE TO AVOID ACCELERATING TOO FAST, OR TURN OFF THE AC BEFORE HAND TO PREVENT FUMES FROM ENTERING CAR. THIS HAS BEEN HAPPENING SINCE I PURCHASED THE CAR IN 2013. I THOUGHT IT WAS JUST CAUSE IT WAS NEW, BUT AS IT'S STILL HAPPENING, AND OTHERS ARE HAVING THIS SAME PROBLEM, I AM REPORTING IT.

Mileage: 10

EXHAUST FUMES IN CABIN.

UPON EXCELERATION, A ROTTEN EGG TYPE ORDOR IS EVIDENT.

Mileage: 100

HAD TO REPLACE ALL 4 O2 SENSORS AT 48,000 MILES.

WHEN THE EXPLORER IS STOPPED OR IN PARK WITH THE ENGINE ON AND THE HEAT ON YOU CAN SMELL A SULFUR/ROTTEN EGG SMELL INSIDE THE CABIN. LOOKS TO BE A EXHAUST LEAK. I KNOW THIS ISSUE IS ALREADY BEING INVESTIGATED AND HAVE READ UP ABOUT THE TECHNICAL BULLETINS RELATED TO THIS ISSUE AND MOST REVIEWS COME BACK TO SAY THE BULLETINS DID NOT FIX THE ISSUE. THIS IS A SERIOUS PROBLEM CONCERNING THE SAFETY AND HEALTH OF MY FAMILY OF NOT KNOWING WHAT KIND OF GAS WE ARE BREATHING IN. COULD BE CARBON MONOXIDE OR SOMETHING ELSE. A RECALL NEEDS TO HAPPEN FOR THESE VEHICLES.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND STALLED INTERMITTENTLY. THE VEHICLE STARTED ONLY AFTER THE BATTERY WAS CHARGED. THE CONTACT ALSO STATED THAT THE HEATING SYSTEM BECAME INOPERABLE AND THE CHECK ENGINE, SERVICE TRACTION, AND BATTERY WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT WAS UNABLE TO BE STARTED OR DIAGNOSED. THE DEALER DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY FAILED. THE THROTTLE BODY WAS REPLACED AND REPROGRAMMED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 47,412. *TR

Mileage: 47,412

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE CONTINUED TO RUN AFTER THE IGNITION WAS TURNED OFF. THE FAILURE RECURRED AND DRAINED THE BATTERY. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 37,000.

Mileage: 37,000

I BOUGHT MY 2014 FORD EXPLORER IN NOVEMBER OF 2015. I NOTICED A ROTTEN EGG/ EXHAUST SMELL AS THE WEATHER BECAME WARMER. ANYTIME I WOULD ACCELERATE UP A HILL OR ACCELERATE ON A FLAT STRETCH OF ROAD DURING THE SUMMER MONTHS WAS WHEN THE SMELL IS THE WORST. I HAVE TO ROLL DOWN ALL OF THE WINDOWS. I NO LONGER ALLOW MY CHILDREN TO RIDE IN THE THIRD ROW BECAUSE THEY WOULD COMPLAIN ON THE LONGER CAR RIDES OF HAVING A HEADACHE. I HAVE TAKEN THIS TO THE DEALERSHIP ON 3 OCCASIONS NOW. THEY HAVE TOLD ME THEY HAVE TRIED TO REPRODUCE MY COMPLAINT, AND HAVE FAILED TO DO SO. I AM CURRENTLY GOING TO THAT THE SERVICE MANAGER ON A RIDE TOMORROW TO REPRODUCE THIS SMELL. THE SMELL HAS BEEN SO BAD AT TIMES THAT I PERSONALLY HAVE FELT LIKE I WAS GOING TO BE SICK. THERE IS SOMETHING SERIOUSLY WRONG WITH THE EXPLORERS HAVING THIS SMELL. SOMETHING NEEDS TO BE DONE. I AM AT THE POINT THAT I DO NOT PUT MY KIDS IN MY CAR ANYMORE THEN I HAVE TO. I HAVE HAD TO APOLOGIZE ON SEVERAL OCCASIONS TO MY FRIENDS ABOUT THE SMELL. FORD NEEDS TO FIGURE THIS OUT!! *TR

Mileage: 32,640

STRONG EXHAUST ODOR UNDER HEAVY ACCELERATION.

Mileage: 36,900

UNSAFE C02 LEVELS IN CABIN ,BAD ODORS,WHILE DRIVING VEHICLE WHILE A/C ON. *TR

Mileage: 27,000

WHEN THE VEHICLE IS ACCELERATED,A VERY STRONG ODOR OF EXHAUST COMES FROM THE AIR CONDITIONER. I HAD A REPRESENTATIVE WITH ME AND THEY NOTICED THE ODOR TOO. THIS HAPPENS NO MATTER WHAT ROAD YOU ARE DRIVING ON. *TR

Mileage: 39,000

IN JUNE 6/2016, MY WAS WAS GOING 35MPH, APPROACHING AN INTERSECTION WHEN THE WRENCH LIGHT FOLLOWED BY THE "TERRAIN MANAGEMENT FAULT" WARNING CAME ON. THE VEHICLE LOST ALL POWER. TRAFFIC COMING FROM HER RIGHT RECEIVED THE GREEN LIGHT AND SHE WAS NEARLY KILLED BY A DRIVER WHO DROVE THROUGH THE LIGHT, TIMING IT FOR WHEN IT TURNED GREEN. THE VEHICLE SPENT 14.5 DAYS AT THE PALM BAY FORD DEALERSHIP IN PALM BAY FLORIDA WERE IT WAS PURCHASED NEW. FORD DIAGNOSED THE PROBLEM AS A DEFECTIVE THROTTLE BODY. I WENT ONLINE AND SAW THE NUMBER OF THESE THROTTLE BODY FAILURES AND CONTACTED THE FORD CUSTOMER SERVICE HOTLINE. I EXPLAINED TO THEM I FELT THE VEHICLE WAS UNSAFE, THAT I HAD NO CONFIDENCE IN THE VEHICLE, AND THAT IF THERE HAD BEEN NO DESIGN CHANGE TO THE THROTTLE BODY IT WOULD HAPPEN AGAIN. I WAS GIVEN A CASE NUMBER (WHICH HAS NOW BEEN CLOSED), AND NOTES OF MY CONCERNS WERE MADE ON THE CASE. ON 10/11/2016 I AT 1530 EDT, I WAS PULLING OUT OF A GAS STATION TURNING RIGHT, WITH TRAFFIC APPROACHING FROM MY LEFT. THE WRENCH LIGHT CAME ON FOLLOWED BY THE "TERRAIN MANAGEMENT SYSTEM FAULT" ALERT. THE VEHICLE LOST ALL POWER (THROTTLE RESPONSE) AND THE APPROACHING TRAFFIC HAD TO LOCK UP THEIR BRAKES TO AVOID A BROADSIDE COLLISION!. I HAD MY WIFE, 10YR OLD DAUGHTER AND 12YR OLD SON IN THE VEHICLE WITH ME. HAD A COLLISION OCCURRED MY SON WOULD HAVE BEEN SERIOUSLY INJURED. THE VEHICLE WENT BACK TO THE PALM BAY FORD SERVICE DEPARTMENT 10/12/2016 AT 0900 EDT. THE THROTTLE BODY HAD FAILED AGAIN AS PREDICTED, THE VEHICLE IS STILL THERE. I HAVE CONTACTED THE FORD CUSTOMER SERVICE HOTLINE AND RECEIVED TWO CASE NUMBERS NOW. 1: CAS-10814941-Q8T7Z5, 2: CAS-10830198. I TRIED TO GET FORD TO TAKE THE CAR BACK AND TRADE IN ON A NEW ONE AS THIS IS AN "UNSAFE"VEHICLE. THEY WILL NOT HELP US AND THIS THROTTLE BODY ISSUE IS AN EPIDEMIC! I AM SURE THERE HAS BEEN LOSE OF LIFE FROM THESE "UNSAFE" VEHICLES?

Mileage: 41,080

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 10 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE SERVICE ENGINE AND TERRAIN MANAGEMENT SYSTEM FAULT WARNING INDICATORS ILLUMINATED. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE HESITATED TO SHIFT PROPERLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 41,000. ..UPDATED 11/17/16 *BF CONSUMER STATED PALM BAY FORD SERVICE DEPARTMENT INSTALLED A DEFECTIVE THROTTLE BODY IN HIS VEHICLE AGAINST CONSUMERS PROTEST. CONSUMER EXPRESSED CONCERNS REPEATEDLY THAT WITHOUT A DESIGN CHANGE TO THE THROTTLE BODY, IT WOULD FAIL AGAIN, WHICH IT DID. UPDATED 9/5/19*JB

Mileage: 41,000

STRONG ODOR OF EXHAUST FUMES ENTERING THE CABIN WHEN ACCELERATING. VERY CONCERNED WITH DIVER AND PASSENGERS SAFETY. THIS HAS BEEN OCCURRING SINCE IT WAS NEW. I TOOK IT TO THE DEALER OVER A YEAR AGO AND THEY PERFORMED A REPAIR THAT DID NOT RESOLVE THE ISSUE. THEY THEN TOLD ME FORD WAS WORKING ON A FIX AND SOMEONE WOULD CONTACT ME. I HAVE YET TO BE CONTACT AND VERY CONCERNED WITH CONSTANT EXPOSURE TO THE EXHAUST FUMES. THE NEED TO TAKE THIS SERIOUSLY AND GIVE IT A PRIORITY TO FIX THIS PROBLEM AS I SEE THERE IS A LOT OF PEOPLE COMPLAINING OF THE SAME ISSUE.

THERE IS AN OVERBEARING ALMOST INTOXICATING SULFUR/ROTTEN EGG SMELL COMING IN THE CABIN OF THE CAR ANY TIME ACCELERATING. I GOT THIS VEHICLE NEW IN 2014 AND IT HAS BEEN DOING IT SINCE DAY ONE. AT FIRST I WROTE IT OFF AS NEW CAR OR POSSIBLY THE TURBO. BUT NOW AFTER READING THE THOUSANDS OTHERS WITH SAME PROBLEM I AM EXTREMELY CONCERNED FOR MY FAMILY'S WELL BEING. I HAVE BEEN DRIVING MY INFANT IN THIS CAR FOR TWO YEARS AND I AM VERY UPSET THAT I COULD HAVE PUT HER HEALTH AT RISK.

Mileage: 50

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHEN THE AIR CONDITIONER CIRCULATION MODE WAS ACTIVATED OR WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, EXHAUST FUMES EMITTED INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 39,900. THE VIN WAS NOT AVAILABLE.

Mileage: 39,900

PROBLEM WITH GAS LEAK GO TO THE INTERIOR OF THE CARD.

WE HAVE A 2014 FORD EXPLORER THAT HAS A SMELL INSIDE WHILE ACCELERATING. WE HAVE TAKEN IT TO THE DEALER TO HAVE THE PROBLEM CORRECTED. OUR CONCERN IS THAT EXHAUST HAS BEEN COMING INTO THE VEHICLE. WE AREN'T SURE IF THE CURRENT SOLUTIONS IN PLACE TO FIX THE VEHICLE ARE ENOUGH. WELL KNOWING AND OUR FAMILY IS GETTING SICK FROM THIS CURRENT ISSUE WE JUST AREN'T SURE WHAT WE'RE BREATHING INSIDE THE VEHICLE IS SAFE. THE SMELL COMES WHEN YOU ACCELERATE HARD EITHER TOWING OR MERGING ONTO THE HIGHWAY OR EVEN FROM A RED LIGHT. THE SMELL IS A SULFUR SMELL OR ROTTEN EGG SMELL THAT SEEMS TO DISSIPATE QUICKLY BUT IS NOTICEABLE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE STEERING BECAME DIFFICULT TO OPERATE. THERE WERE NO WARNING INDICATORS ILLUMINATED. IN ADDITION, THERE WERE EXHAUST FUMES INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 81,590. *TR

Mileage: 81,590

EXHAUST SMELL IN MAIN CABIN WHEN RPMS EXCEED 3200. HAPPENS MOST COMMONLY WHEN CLIMBING A STEEP GRADE OR ACCELERATING ONTO A FREEWAY TO MERGE WITH TRAFFIC. THIS HAS BEEN OCCURRING FOR PAST TWO YEARS OR SO, IT CAN SMELL LIKE EXHAUST, BURNING HAIR, ETC. COMPLAINTS TO DEALER ARE GIVEN A CURSORY EXPLANATION OF EXCESS FUEL, IT IS NORMAL AND NOTHING CAN BE DONE. I'VE OWNED MANY VEHICLES OVER THE YEARS AND NEVER EXPERIENCED THIS. THIS HAPPENS EVERY TIME THERE IS A HIGHER LEVEL OF ACCELERATION OR RPMS EXCEEDING 3200.

Mileage: 45,000

I HAVE FREQUENTLY EXPERIENCED A STRONG SMELL OF EXHAUST AND/OR BURNING OIL IN THE PASSENGER COMPARTMENT. THIS OFTEN OCCURS WHEN THE A/C IS RUNNING AND/OR UNDER HEAVY ACCELERATION OR CLIMBING STEEP GRADES. I HAD MENTIONED THIS A FEW TIMES TO 2 LOCAL FORD DEALERSHIPS AND WAS ADVISED BY ONE THAT THEY ARE AWARE OF POSSIBLE ISSUES INVOLVING A CHEMICAL OR "PROPANE" SMELL, BUT NOT EXHAUST FUMES. THE OTHER HAD NO KNOWLEDGE THAT THIS WAS A FREQUENT OCCURRENCE.

Mileage: 26,000

WHILE DRIVING OUR 2014 FORD EXPLORER XLT, WE HAVE NOTICED A STRONG GAS ODOR INSIDE THE VEHICLE. THIS OCCURS WHEN THE AIR CONDITIONING IS IN RECIRCULATION MODE WHILE DRIVING AND IDLING AT A STOPLIGHT. THIS HAS HAPPENED INTERMITTENLTY DURING THE PAST YEAR.

Mileage: 47,000

WHEN ACCELERATING TO PASS ANOTHER VEHICLE, THE CAB OF MY VEHICLE FILLS WITH EXHAUST FUMES. THIS VEHICLE HAS BEEN BROUGHT TO THE DEALERSHIP FOR SERVICE REGARDING THIS ISSUE. THE DEALERSHIP WAS UNABLE TO SOLVE THE PROBLEM. THEY ALSO CLAIM THAT FORD DOES NOT KNOW HOW TO SOLVE THIS PROBLEM. I WAS ONLY TOLD TO KEEP CHECKING BACK WITH THEM TO SEE IF A SOLUTION TO THIS ISSUE HAS BECOME AVAILABLE.

Mileage: 500

WE SMELL EXHAUST GAS WHEN THE CAR IS IN FULL THROTTLE, LIKE WHEN CLIMBING A STEEP ROAD OR MERGING INTO FREEWAY RAMPS, OR JUST ANY SORT OF HARD(ISH) ACCELERATION. ODOR IS ALSO DETECTED WHEN THE AIR CONDITIONER WAS IN RECIRCULATION MODE. THIS HAS BEEN GOING ON SINCE WE BOUGHT THE VEHICLE.

Mileage: 36,000

I RECENTLY READ AN ARTICLE IN THE SFGATE.COM REGARDING COMPLAINTS TO THE NHTSA ASSOCIATED TO THE FORD EXPLORER AND FUME SMELLS COMING FROM THE ENGINE AND/OR EXHAUST INTO THE CAB OF THE CAR CREATING A HAZARD TYPE SITUATION FOR THE DRIVERS. I WOULD ALSO LIKE TO FILE A COMPLAINT TO BE ADDED TO THE OTHER EXISTING COMPLAINTS WITH THE NHSTA REGARDING THIS ISSUE. I PURCHASED A NEW 2014 FORD EXPLORER FROM THE HANSEL FORD DEALERSHIP IN PETALUMA. WITHIN A FEW MONTHS I BECAME AWARE OF A FUME TYPE ODOR WITHIN THE CAB IF THE VEHICLE. I CONTACTED THE DEALERSHIP AND STARTED TRYING TO IDENTIFY AND RESOLVE THE ISSUE. THE FUMES WERE CAUSING DIZZINESS AND NAUSEA ON LONG DRIVES. PASSENGERS ALSO COMPLAINED OF THE FUME ODOR. AFTER SEVERAL ATTEMPTS TO THE SERVICE DEPARTMENT WITH THE CAR OUT OF SERVICE AND MANY MONTHS THERE WAS NO SOLUTION. UNSATISFIED I DECIDED TO FILE A COMPLAINT WITH THE BETTER BUSINESS BUREAU IN 2014 FOR THE FUME SMELL ALONG WITH SOME UNRELATED ISSUES. I WAS FORWARDED TO ARBITRATION WHERE IT WAS JUDGED BY THE ARBITRATOR THAT NO ACTION WAS TO BE TAKEN. I CURRENTLY STILL OWN THE FORD EXPLORER AND EXPERIENCE FUME SMELLS. AS MENTIONED ABOVE I WOULD ALSO LIKE TO FILE A COMPLAINT IN REGARD TO THIS FUME ISSUE. I CAN PROVIDED SUPPORTING DOCUMENTATION IF NEEDED. PLEASE CONTACT ME DIRECTLY. THANK YOU.

Mileage: 5,000

EVERY TIME YOU STEP ON THE GAS A LITTLE MORE THAN NORMAL, IE GOING UP A HILL AND GETTING UP TO SPEED, THE INTERIOR OF THE CAR FILLS UP WITH EXHAUST/ BURNING OIL SMELL AND IS QUITE DISORIENTING. I DONT KNOW IF THERE IS AN AREA THAT DOES NOT HAVE A FILTER OR IF IT SO POTENT THAT THE CABIN AIR FILTER CANT FILTER IT ALL OUT.

Mileage: 50,000

EXPERIENCING VERY STRONG EXHAUST / SULFUR SMELL IN CABIN AREA UPON MEDIUM TO HARD ACCELERATION. BOUGHT CAR IN SPRING OF 2014 AND NOTICED IT WITHIN THE FIRST MONTH OR TWO. AT FIRST I THOUGHT IT MIGHT HAVE BEEN A CAR IN FRONT OF ME, BUT THAT IS NOT THE CASE AS I HAVE EXPERIENCED THIS NUMEROUS TIMES THIS WITH NO ONE ELSE ON THE ROAD. IT OCCURS WHEN YOU PASS SOMEONE OR GO UP A STEEP INCLINE. WHEN TOWING MY BOAT THE SMELL IS UNBEARABLE AND YOU HAVE TO HAVE THE WINDOWS ROLLED DOWN, BUT EVEN WITH THAT IT TAKES A LONG TIME TO GET THE SMELL OUT OF THE CABIN. SITUATION OCCURS WITH THE FRESH AIR VENTS ON AND/OR THE RECIRC AIR ON ' VENT SETTING DOESN'T MATTER. I'VE BEEN PUTTING OFF GETTING THIS LOOKED AT SINCE IT SOUNDS LIKE THERE IS NO DEFINITIVE FIX, BUT SINCE THE CAR NOW HAS 29,000 MILES ON IT, I WANT IT TO GET CHECKED OUT BEFORE WARRANTY IS UP. IT IS ALARMING THAT WITH ALL THE COMPLAINTS FOR THIS HAZARDOUS/DEADLY SITUATION THAT THERE HAS NOT BEEN A RECALL FOR A BETTER FIX THAN THE TSB.

Mileage: 2,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING 75 MPH, THE VEHICLE STALLED AND THE LOW OIL PRESSURE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED SEVERAL TIMES AND THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE AIR FLOW SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 15,000. MA 10/6 UPDATED 12/21/15. *JB

Mileage: 15,000

A FEW MONTHS AFTER PURCHASING OUR 2014 EXPLORER, WE NOTICED AN EXHAUST/SULFUR ORDER IN THE PASSENGER COMPARTMENT FOLLOWING A MEDIUM ACCELERATION ENTERING AN INTERSTATE HIGHWAY. WE REPORTED THE ODOR TO THE DEALERSHIP AND TURNED THE VEHICLE IN FOR REPAIR. DEALERSHIP WAS UNABLE TO RECREATE THE ORDER SO NOTHING WAS DONE. A FEW MONTHS LATER, UNDER SIMILAR CIRCUMSTANCES, THE ODOR RETURNED. ONCE AGAIN, WE TURNED THE VEHICLE IN FOR REPAIR. THE DEALER PERFORMED A REPAIR BASED ON A TSB. A FEW MONTHS LATER, THE ODOR RETURNED AND ONCE AGAIN TURNED THE VEHICLE IN FOR REPAIR. THE DEALER PERFORMED A CONTINUATION OF THE SAME TSB. A FEW MONTHS LATER, WHILE PULLING A BOAT, THE ODOR RETURNED. ONCE AGAIN, WE TURNED THE VEHICLE IN FOR REPAIR. THE DEALER OWNER AND THE SERVICE TECH DROVE THE VEHICLE FOR SEVERAL DAYS AND WERE UNABLE TO DETECT THE SMELL. THE VERY NEXT DAY WHILE PULLING THE BOAT, THE ODOR RETURNED. THE DEALER NOW SAYS THEY DON'T WANT TO PERFORM THE LAST PART OF THE TSB BECAUSE IF THEY SEND FORD A PART THAT'S NOT DEFECTIVE, FORD WILL CHARGE THEM BACK FOR THE PART....MEANWHILE I'M STUCK DRIVING A VEHICLE THAT MAY BE PUTTING SULFUR AND/OR CARBON MONOXIDE INTO THE PASSENGER COMPARTMENT. THE DEALER WANTS ME TO BRING MY BOAT AND VEHICLE IN SO THEY CAN TEST IT WHICH ISN'T GOING TO HAPPEN BECAUSE IF THEY WRECK THE VEHICLE WITH THE BOAT, MY INSURANCE HAS TO COVER IT THROUGH THE PERMISSIVE USE CLAUSE AND MY RATES WILL GO UP.

Mileage: 5,000

WHEN APPLYING FULL BRAKING AT A STOP SIGN OR RED LIGHT THE VEHICLE STOPS BUT THE ENGINE AND TRANSMISSION CONTINUE TO RACE AT FULL SPEED. THE BRAKE PULSATES LIKE THE ANTI LOCK BRAKING SYSTEM IS ENGAGED. IN ORDER TO GET THE VEHICLE BACK TO NORMAL THE ENGINE MUST BE SHUT OFF OR THE TRANSMISSION DISENGAGED. IT WILL THEN START UP NORMALLY. WE HAVE HAD 11 OCCASIONS WITHIN THE PAST 2 MONTHS WHERE THIS HAS OCCURRED, THIS HAS OCCURRED WHEN COMING DOWN FROM HIGHWAY LONG DISTANCE DRIVING AND IT HAS ALSO HAPPENED ON A PARKING LOT VERY LOW SPEED. IT IS ALL I COULD DO TO PRESS HARD ENOUGH ON THE BRAKES TO STOP. THE VEHICLE HAS BEEN RETURNED TO THE DEALERSHIP, THEIR DIAGNOSTICS SHOW NOTHING AND THE DEALERSHIP STATES THEY MUST BE ABLE TO EXPERIENCE THE PROBLEM FIRST (DUPLICATE IT). FORD MOTOR COMPANY HAS BEEN CALLED THE REGIONAL SALES MANAGER TOLD ME TO TAKE THE VEHICLE TO ANOTHER FORD DEALERSHIP TO HAVE THEM LOOK AT IT. MR. MCHALE THE MANAGER AT FMC (866-631-3788 EXT. 77713) ASSIGNED A CASE NUMBER 7644437 TO THE PROBLEM BUT HE ALSO STATED THAT THEY WOULD HAVE TO DUPLICATE THE PROBLEM BEFORE IT COULD BE RESOLVED. I TOLD HIM IF I MISJUDGE OR AM UNABLE TO BRING THE VEHICLE TO A STOP THAT I MAY BE PUSHING UP DAISIES. THEY DO NOT SEEM TO UNDERSTAND THE SEVERITY OF THE PROBLEM. IT WOULD SEEM TO ME THAT A MECHANIC WOULD LOOK FOR A SENSOR OR SWITCH THAT WOULD DISENGAGE THE TRANS MISSION WHEN THE BRAKE WAS APPLIED OR A SENSOR OR CONTROL THAT SLOWS THE ENGINE. I AM GETTING TO THE POINT I FEAR FOR MY LIFE DRIVING THIS VEHICLE UNTIL IT IS REPAIRED. I ALSO MENTIONED THAT WHEN I TURN THE VEHICLE OFF DURING THE INCIDENT THERE IS A LOT OF CLUNKING FROM THE ENGINE AND TRANSMISSION, I AM SURE DAMAGE HAS BEEN DONE TO THEM. *CN

Mileage: 9,898

A SULFUR SMELLING STENCH COMING THROUGH THE VENTILATION SYSTEM WHEN DRIVING OVER A HIGH RPM RATE. THE SMELL ENTERS THE CABIN EVEN WITH THE AC TURNED ON AND ALSO WHEN RECIRCULATION IS TURNED ON. I HAVE REPORTED TO THE DEALER AND THEY FOUND NOTHING WRONG. *TR

Mileage: 20

TWICE WHILE DRIVING (ONCE ACCELERATING TO PULL INTO TRAFFIC AND ONCE GOING UP A MOUNTAIN) AN EXHAUST SMELL ENTERED THE CABIN THROUGH THE AC SYSTEM AND RECIRCULATING MODE DID NOT IMPROVE IT. THE VEHICLE WAS ACCELERATING OVER 3500 RPMS. I HAVE TESTED THIS AGAIN AND AGAIN AND IT HAPPENS EVERY TIME UNDER THESE CONDITIONS. I AM VERY CONCERNED AS WE JUST BOUGHT THIS VEHICLE A COUPLE OF MONTHS AGO AND HAVE TWO YOUNG DAUGHTERS. I WILL BE TAKING IT TO OUR LOCAL DEALERSHIP BUT BASED ON THESE COMPLAINTS I AM NOT HOPEFULL THIS WILL BE RESOLVED. *TR

Mileage: 4,000

WHEN ACCELERATING TO PASS A DANGEROUS TRUCK (58 MPH) STRONG FUMES COMES INSIDE THE CABIN, ACCELERATION TOOK 8 SECONDS, INSTANTLY WE START COUGHING AND GET WATERY EYES, OUR YEAR OLD BABY START CRYING SHOWING SYMPTOMS OF DISTRESS, WE TELL THIS TO SALES PERSON, WHICH QUICKLY TOLD US THE STORY THAT THIS HAPPENS WITH NEW CARS.. SUPPOSEDLY NEW ENGINES SHOULD NOT BE HIGHLY ACCELERATED. NAIVELY WE BELIEVE THIS AND DECIDE TO GIVE IT A FEW DAYS? DAY BECOME MONTHS AND PROBLEM GOT WORST, AFTER FEW MONTHS WE DECIDE TO TAKE THE CAR IN FOR SERVICE, UNFORTUNATELY FORD FROM FIRST DAY TREAT US LIKE IF WE WERE INVENTING THE MATTER, AND MAKE MY WIFE LOOK LIKE IF SHE WERE CRAZY, THE WORST PART IS THAT THEY KNOW THAT CAR HAS THE DEFECT AS PREVIOUS GENERATIONS HAS THE SAME PROBLEM(FORDTECHNICAL BULLETIN CONFIRM THIS ).WE CONTINUE TO FOLLOW THE REGULAR PROCEDURE AND WENT TO THE DEALERSHIP ASKING THEM TO FIX THE PROBLEM,THEY ONLY SHOW THEY WERE CLUELESS ABOUT IT AND AFTER MORE THAN SEVEN TIMES LEAVING THE CAR THERE THEY SAY THERE??S NOTHING THEY CAN DO ABOUT IT. WE CONTACT FORD MANUFACTURER DIRECTLY,WHICH MAKE US GO THROUGH A LONG PROCESS OF VERIFYING BACK AND FORWARD, AND AT THE END AN ??ENGINEER?? SEND ESPECIALLY DIRECTLY FROM FORD TO THE DEALERSHIP TELL US PRACTICALLY THAT JUST DON??T ACCELERATE TO AVOID THIS !!!!.WE TOOK THE CAR TO SPECIALIST THAT MEASURED CO WITH A PROFESSIONAL TOOL THAT SHOW MORE THAN 140 PART PER MILLION!!!!!.THIS IS SERIOUS PROBLEM THAT FORD SHOULD BE RESPONSIBLE FOR IT, MY FAMILY HAS BEEN SICK WITH FLUE LIKE SYMPTOMS FOR A LONG TIME, MY WIFE EXPERIENCED A VERY LONG LASTING COUGH THAT ONLY START GETTING BETTER AFTER FORCEFULLY I HAVE TO GET HER ANOTHER CAR AS I COULD NO LONGER EXPOSE MY FAMILY TO MORE OF THIS DANGERS. I REQUEST TO FORD TO REPLACE THE CAR AND THEY DENIED MY REQUEST I BELIEVE NHTSA SHOULD STEP UP ON TO THIS AND PROTECT THE CONSUMERS, THANKS *TR

Mileage: 100

SINCE I'VE OWNED MY 2014 FORD EXPLORER FOR THE PAST SIX MONTHS I GET SULFUR SMELLING EXHAUST FUMES COMING FROM THE A/C VENTS WHEN QUICKLY ACCELERATING EVEN IF THE A/C IS IN RECIRC MODE AND EVEN WHEN THE FUEL TANK IS NOT FULL. IT IS DEFINITELY EXHAUST ODORS AND NOT FUEL ODORS. *TR

Mileage: 500

WHILE DRIVING ON THE FREEWAY I NEEDED TO ACCELERATE TO PASS A VEHICLE AND WHEN I DID A EXHAUST SMELL ENTERED THE CAB IT TOOK ABOUT 5-10 SECONDS AFTER ACCELERATING OVER 3500 RPMS. I HAVE TESTED THIS AGAIN AND AGAIN AND IT HAPPENS EVERY TIME UNDER THESE CONDITIONS. SITTING STILL THERE IS NO EFFECT AT ALL. FIVE STAR FORD OF PLANO TEXAS HAS TRIED A "TSB" THAT WAS ISSUED TO INSTALL A VENT ADJUSTMENT. THEY ALSO CHANGED OUT THE CABIN FILTER. STILL NO LUCK. THANK YOU *TR

Mileage: 14,550

UPON HEAVY ACCELERATION (TO ENTER THE FREEWAY, FOR EXAMPLE) A STRONG ODOR OF EXHAUST FUMES ENTERS THE CABIN. IT IS NECESSARY TO OPEN A WINDOW IN ORDER TO BREATH AGAIN! THIS OCCURS EVERY TIME UPON ENTERING THE FREEWAY, AND IF/WHEN PASSING ANOTHER VEHICLE ON THE HIGHWAY. *TR

Mileage: 2,500

AFTER PURCHASING A NEW 2014 FORD EXPLORER LIMITED. 3.5L 4WD LESS THAN 2 HOURS PRIOR, MY WIFE AND 2 CHILDREN WERE DRIVING HOME DOWN THE FREEWAY. AFTER A HARD ACCELERATION AN AWFUL SMELL FILLED THE CABIN. MY WIFE STARTED COUGHING AND I INSTANTLY FELT NAUSEOUS. I PULLED OVER THINKING SOMETHING WAS BURNING, MY WIFE THOUGHT IT WAS BURNING WIRES. I CHECKED OF THE VEHICLE BUT FOUND NOTHING BURNING. I DID HOWEVER WALK TO THE REAR OF THE VEHICLE AND WAS OVERPOWERED BY THE SAME SMELL. I NARROWED IN DOWN TO THE EXHAUST PIPE. AFTER GETTING HOME I DID A QUICK GOOGLE SEARCH AND WAS SHOCKED TO FIND MANY OTHER PEOPLE HAVE HAD THIS PROBLEM AND THERE IS EVEN A LAWSUIT FILED AGAINST FORD OVER IT. THE DEALER MUST HAVE KNOWN ABOUT IT... I WANT TO RETURN THIS VEHICLE , FORD HAS TO HAVE KNOWN ABOUT THIS OR SHOULD HAVE. THEY PUT MY CHILDREN AT RISK AND I AM NOT HAPPY. I HAVE OWNED THIS VEHICLE FOR LESS THAN 3 HOURS AT THE TIME OF THIS WRITING. WHAT CAN I DO? *TR

Mileage: 302

EXHAUST FUMES ARE ENTERING THE VEHICLE WHEN THE CLIMATE CONTROL SYSTEM IS OPERATING. THESE FUMES ARE COMING FROM THE VEHICLE ITSELF AND NOT FROM OUTSIDE SOURCES. THE FUMES ARE WORSE WHEN THE RECIRCULATE OPTION IS OPERATING. HIGHWAY SPEEDS AND/OR MEDIUM ACCELERATION PRODUCE THE STRONGEST FUMES. HEADACHES AND NAUSEA INFLICTED ON VEHICLE OCCUPANTS. VEHICLE WAS SERVICED BY FORD, PRESENTED AS REPAIRED AND STATED TO HAVE PASSED A TEST FOR EXHAUST FUMES. VEHICLE STILL PRESENTS EXHAUST FUMES INSIDE THE VEHICLE. AFTER RESEARCHING THIS ISSUE, IT BECAME APPARENT THAT FORD AND THE NHTSA HAVE KNOWN OF THIS PROBLEM: CARBON MONOXIDE EXPOSURE AND HEALTH ISSUES SHOULD NOT BE REGULATED TO SECONDARY STATUS BY FORD NOR THE NHTSA. *TR

Mileage: 50

AT FIRST THE ONLY TIME WE WOULD NOTICE EXHAUST ENTERING THE CABIN WAS AFTER HARD ACCELERATION. NOW IT SEEMS THAT A LOWER SPEEDS EXHAUST IS ENTERING REGARDLESS OF ACCELERATION LEVELS ON AN INTERMITTENT BASIS. *TR

Mileage: 139

STRONG EXHAUST ODOR ON ACCELERATION. *TR

Mileage: 5,000

STRONG EXHAUST ODOR ON ACCELERATION. *TR

Mileage: 1,700

MY FAMILY HAS A 2013 AND 2014 FORD EXPLORER. BOTH OF THEM DELIVER A NOXIOUS ODOR INTO THE CABIN ON MEDIUM TO HARD ACCELERATION. THIS SEEMS TO BE A COMMON COMPLAINT WHEN I'VE SEARCHED FOR THE ISSUE ON THE INTERNET. *TR

Mileage: 10

ON A RECENT VACATION TO THE NORTHWOODS OF WISCONSIN, OUR 2014 EXPLORER XLT (4X4 V6) WAS RELEASING A NAUSEATING SMELL INTO THE CABIN UNDER HEAVY LOADS, HIGH RPMS, OR RAPID ACCELERATIONS. THE TRIP WAS ABOUT 6 HOURS OF SOLID DRIVING, AND BY THE 3RD HOUR MY WIFE AND I HAD POUNDING HEADACHES AND FELT UNWELL. WE IMMEDIATELY TURNED OFF THE AC AND OPENED THE WINDOWS AS I WAS ABLE TO DUPLICATE THE SMELL ON THE OPEN HIGHWAY. WE SPENT THE REMAINDER OF THE VACATION WITH LIMITED AC, OPEN WINDOWS, AND ?CAUTIOUS? DRIVING TO ENSURE THE SMELL WOULD NOT OCCUR AGAIN. WE WERE TRAVELING WITH OUR 8 MONTH OLD SON AND OLD ENGLISH BULLDOG AT THE TIME AND WANTED TO ENSURE THEY DID NOT FALL ILL. I WILL BE CONTACTING MY FORD DEALER TO ADDRESS THE ISSUE. *JS

Mileage: 17,500

MY TRANSMISSION WOULD NOT SHIFT GEARS. THIS IS THE FOURTH TIME THIS HAS HAPPENED. AS SOON AS I PUT IN DRIVE THE VEHICLE DID RUN BUT WOULD NOT SHIFT...I WAS STUCK ON A MOUNTAIN ROAD UNABLE TO PULL OVER AND MY RPM'S WERE PEGGING WITHOUT MY TRANSMISSION SHIFTING INTO 2ND GEAR. I ALMOST GOT REAR ENDED. I WAS ONLY ABLE TO GO LIKE 15 MILES PER HOUR, MY CAR STARTED SMELLING LIKE IT WAS BURNING AND THE ENGINE WAS STRESSED. WHEN I WAS ABLE TO FINALLY PULL OVER I HAD TO PUT THE CAR IN PARK TURN IT OFF, TURN IT BACK ON AND THEN IT WORKED FINE. AGAIN THIS IS THE FOURTH TIME THIS HAS HAPPENED. I CALLED THE FORD DEALER, FOR THE FOURTH TIME AND THEY SAID I COULD BRING IT IN BUT IF IT DIDN'T ACT THE SAME WAY WITH THEM THERE ISN'T MUCH THEY CAN DO. NOT THE ANSWER I WANTED. I HAVE A NEIGHBOR WHO HAS THE SAME VEHICLE AND IT HAS ALSO HAPPENED TO HER. THERE IS OBVIOUSLY A SYSTEMIC PROBLEM HERE. *TR

Mileage: 41,000

UNDER HARD ACCELERATION, WHEN TRYING TO MERGE WITH INTERSTATE TRAFFIC FOR EXAMPLE, THE CABIN IS FILLED WITH A SMELL OF BURNING OIL AND/OR EXHAUST. THIS HAS BEEN NOTICEABLE SINCE THE VEHICLE WAS PURCHASED NEW (PICKED UP WITH < 50 MILES ON THE ODOMETER) AND HAS NOT GOTTEN BETTER AFTER 4900 MILES. *TR

Mileage: 200

THE CAR REPEATEDLY FILLS WITH EXHAUST FUMES FOLLOWING HIGHER RPM'S JUST RETURNED FROM COLORADO MOUNTAINS. CLIMBING MOUNTAINS CAUSES HIGHER RPM'S AND IN THE PROCESS CAUSED THE CABIN TO FILL WITH EXHAUST FUMES. *TR

Mileage: 14,800

EVERY TIME THE SUV IS ACCELERATING OVER 3.4K RPMS FOR A DURATION OF GREATER THAN 3-5 SECONDS, THE AC SYSTEM FILLS THE CABIN WITH NAUSEATING GAS. THE SMELL HAS CHANGED OVER THE COURSE OF OWNERSHIP FROM BURNT HAIR SMELL, NOW TO A EXHAUST, ROTTEN EGG/CARBON SMELL. OCCURS WITH AC SYSTEM OFF, OR ON INDEPENDENT OF FRESH AIR OR RECIRCULATE MODE. SMELL LINGERS FOR MINUTES AFTERWARDS. TAKEN TO DEALER BUT UNABLE TO REPLICATE PROBLEM. ALSO, THEY SAID THAT THE TSB FOR THE ISSUE DID NOT APPLY TO 2014 MODELS. I AM VERY CONCERNED THAT EXHAUST (CO) IS ENTERING THE VEHICLE AT HAZARDOUS LEVELS. *TR

Mileage: 5,000

EXHAUST GAS IS GETTING INTO THE CABIN WHEN THE CAR ACCELERATES OVER 3200 TO 3500 RPM. FORD SAYS THAT THE GAS IS NOT EXHAUST GAS, BUT A STRONG ORDER THAT IS NOT HARMFUL. THEY WILL NOT TELL US WHAT CHEMICAL THE ORDER IS. WHEN I DROVE THE CAR I WAS EXPERIENCING ASTHMA AND HEART PALPITATIONS. THE DEALERSHIP FOUND THAT IT HAD THE 2013 EXPLORER PARTS IN IT AND CHANGED THEM OUT PER THE TSB 12-12-4. IT STILL DID NOT HELP. ANOTHER POST SAID THAT THEY DID USE A MONITOR IN THEIR CAR AND IT WAS EXHAUST. WHEN WE PASS A CAR OR FARM MACHINERY OR ENTER ONTO A FREEWAY, THE EXHAUST SMELL IS SUFFOCATING WHEN IT ENTERS THE CAR CABIN. MY FEAR IS THAT THE EXHAUST COULD BE COMING INTO THE CABIN ALL THE TIME, BUT WE CAN'T SMELL IT UNTIL IT GETS TO A CONCENTRATED LEVEL. FORD SAID THAT THE ENGINEERS ARE WORKING ON IT. SO I HAVE PURCHASED A $45,000 VEHICLE THAT I CAN'T DRIVE. *TR

IT WAS RAINING QUITE HEAVILY ALL DAY AND WAS RAINING WHEN THE MISFIRE OCCURRED. THE VEHICLE WOULD BUCK AND JERK WHEN I TRIED TO ACCELERATE. I HAD TO PULL OVER AND RESTART THE CAR AND THEN FINALLY THE BLINKING ENGINE WENT AWAY. THE ENGINE ON THIS CAR IS A TWIN TURBO 3.5L ECOBOOST. *JS

Mileage: 5,600

I AM PASTING FROM A PARTS OF A POST THAT I MADE ON 4/2/2014 @ 11:06AM AT WWW.BLUEOVALFORUMS.COM WITH THE TOPIC BEING: "MAJOR CONCERN/ISSUE WITH 2014 FORD EXPLORER SPORT": THIS FOR THE 2014 FORD EXPLORER SPORT WITH V6 3.5L ECOBOOST (TWIN TURBO) MOTOR. ABOUT A MONTH AFTER OWNING IT, I WAS TRAVELING ON THE HIGHWAY....I WAS TRAVELING ABOUT 60MPH ....I SIGNALED TO GET OVER AND GAVE IT GAS TO SPEED UP MODERATELY TO ABOUT 75MPH OR SO. WHEN I PRESSED ON THE GAS THE CAR BASICALLY ALMOST STALLED ON ME...IT WASN'T A TRANSMISSION TRYING TO THINK WHICH GEAR TO SHIFT INTO ISSUE, IT WAS A STRAIGHT CHOKING OF THE GAS AND STUTTERING/HESITATING UNTIL I LET OFF THE GAS 2 TIMES OR SO AND THEN PRESS DOWN ON THE GAS AGAIN AND IT TAKES OFF, BUT IT A NOTICEABLE LOSE OF POWER.THIS HAS HAPPENED NOW 4 TIMES WITH THIS PAST WEEKEND 3/30/2014 BEING THE MOST RECENT. HOWEVER THE HIGHWAY SPEED WAS THE ONLY HIGH SPEED INCIDENT. THE OTHER 3 TIMES THAT IT OCCURRED WERE ALL IN TOWN, ON ONE OF THEM I WAS MAKING A SIMPLE U-TURN FROM A STOP AND WHEN I PRESSED THE GAS (NOT HEAVILY) TO GET UP AND OUT OF THE TURN IT STALLED. THE OTHER TIME WAS PASSING TO ANOTHER LANE AND GIVING IT SOME GAS TO SPEED UP. THIS PAST SUNDAY I WAS TRAVELING ON A 2 LANE ROAD THEN CHANGES TO A 1 LANE ROAD APPROX. 100 YARDS AFTER THE STOP LIGHTS. I WAS STOPPED BEHIND A VEHICLE AND WHEN WE STARTED MOVING THE VEHICLE IN FRONT WAS ONLY GOING ABOUT 20-25MPH IN A 45MPH ZONE. SO I SIGNALED AND SAW A VAN IN THE LANE ABOUT 100 YARDS BACK SO I PRESSED ON THE GAS TO GET SOME SPEED TO PASS HIM BEFORE THE LANE ENDED AND AGAIN NOTHING CRAZY JUST TO GET UP TO 45-50MPH OR SO AND THE DARN THING STALLED ON ME AGAIN! THE BIG CONCERN I HAVE NOW IS THAT THE FAMILY AND I ARE PLANNING ON A CROSS-COUNTRY ROAD TRIP THIS SUMMER FROM MAY 24-JUNE 10, 2014. *TR

Mileage: 3,400

WITHIN 24 HRS. OF PURCHASE, DRIVING ON EVEN ROAD DRY CONDITIONS APPROX. 40 MPH ENGINE SHUT OFF WHILE IN MOTION NO HESITATION NO BUCKING JUST SHUT OFF. PULLED OFF SIDE OF ROAD RESTARTED OK TOOK TO DEALER (JACK BYRNE FORD) NO CODE NO IDEA WHAT CAUSED IT, COULD NOT GET TO REPEAT . THIS VEHICLE IS PRIMARILY DRIVEN ON THE HIGHWAY WE ARE DEATHLY AFRAID THAT THIS WILL HAPPEN AGAIN AT A HIGHER SPEED AND WILL RESULT IN A REAR END COLLISION. SPOKE TO THE SR. REGIONAL CUSTOMER SERVICE MANAGER FOR NY/NJ. SHE STATES THAT THE DEALER LOOKED VEHICLE OVER AND COULD NOT FIND PROBLEM NOR COULD THEY REPEAT IT NO CODE SHE COULD NOT STATE THE VEHICLE IS SAFE TO DRIVE JUST THAT THE DEALER COULDN'T FIND ANYTHING AND ITS READY TO BE PICKED UP AT DEALERSHIP. *TR

Mileage: 390

I BOUGHT MY FORD EXPLORER 2014 ON JULY 1ST 2013. ON AUGUST 1ST, 2013, MY CAR DID NOT MOVE FORWARD WHILE I STARTED THE CAR AND PUT IT TO 'D' (DRIVE) IN A PARKING LOT. INSTEAD, THE CAR WENT BACKWARDS WHILE I STEPPED ON GAS. I WAS VERY CONFUSED, AND THOUGHT IT WAS MY ILLUSION. SO I STEPPED ON BRAKE AND CHECKED THE DRIVE PANEL, THE LIGHT FOR 'D' IS ON. THEN I SWITCH TO 'P' AND AFTER A FEW SECONDS PUT TO 'D' AGAIN. HOWEVER, MY CAR STILL WENT BACKWARD AND MY REAR BUMP HIT THE FRONT BUMPER OF ANOTHER CAR WHICH PARK BEHIND MINE. THEN I GOT CONFIRMED THAT MY CAR WAS MALFUNCTIONING. I WAS 100% SURE THAT THE GEAR OF MY CAR WAS IN 'D', SINCE I DID NOT SEE THE BACK UP MIRROR ON FROM THE LCD DISPLAY, AND THE INDICATING LIGHT OF THE GEAR WAS 'D'. AND MY CORPORATE PARKING LOT IS VERY FLAT. AFTER THAT, I TURNED OFF MY EXPLORER, AND WENT OUT TO CHECK IF THERE IS DAMAGE TO THE CAR THAT I HIT. THEN I RESTART MY EXPLORER, PUT GEAR SHIFT IN 'D' AND IT WENT BACK TO NORMAL. I COULD NOT BELIEVE IT HAPPENED TO MY NEW CAR PURCHASED ONLY ABOUT A MONTH. THIS PROBLEM MADE ME PANIC. WHAT IF THE PROBLEM HAPPENED AGAIN IN A BUSY STREET? WHAT IF THERE ARE PEDESTRIANS IN THE PARKING LOT WHEN MY CAR WAS MOVING BACKWARD BUT IT SUPPOSES TO GO FORWARD? I HOPE SOME AUTHORITIES COULD HELP INVESTIGATE THE PROBLEM, AND ALERT THE MANUFACTURE AND OTHER OWNERS FOR SIMILAR QUESTIONS. *TR

Mileage: 1,100