2014 FORD EXPLORER Suspension Problems

The contact owns a 2014 Ford Explorer. The contact stated while driving at various speeds, the vehicle was driving rough. In addition, while driving at various speeds, the vehicle vibrated abnormally; however, when the vehicle shifted to neutral(N), the vibration ceased. There was no warning light illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The contact stated that recently all four tires were damaged. The vehicle was taken to Costco and all four tires were replaced. The contact had previously received notification of NHTSA Campaign number: 21V537000 (SUSPENSION) and the vehicle was repaired. The contact related the failure to the recall. The manufacturer was made aware of the failure and informed the contact that the Extended Warranty had expired. The contact attempted to have an alignment performed but was unable to find a repair facility to perform the alignment. The manufacturer was contacted and informed the contact that the vehicle was still under warranty; however, the adjustable arm needed to be upgraded at the owner’s expense to repair the vehicle. The vehicle was not repaired. The failure mileage was approximately 90,000.

Mileage: 90,000

Noticing a problem with the steering and wheel suspension that is affecting other Ford explorers between 2018 and 2025. Engine oil blow by. Causing oil to leak and ending up under the carriage and on the back of the vehicle. Rear camera problems.

I’m still waiting for the current recall to be corrected. The suspension is worn out. Replaced rear shocks, front struts, lower control arm. This is the worse automobile I’ve ever owned. If possible, I will never buy another ford. The car’s rear back up camera has been replaced and has stopped working again.

The contact owns a 2014 Ford Explorer. The contact stated that the front passenger’s side door panel had started to detach from the body of the vehicle. The vehicle was taken to a dealer where the contact was informed that there were no recalls on the VIN and the contact was provided an estimate for the repair. The vehicle was not repaired. The contact stated that while driving at highway speeds, there was an abnormal whining sound coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where the contact was informed that the rear wheel bearing needed to be replaced. The dealer repaired the vehicle. The contact stated that the check engine warning light later was illuminated. The vehicle was taken back to the dealer where the contact was informed that the catalytic converter needed to be replaced. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN. The vehicle was not repaired. The failure mileage was approximately 100,000.

Mileage: 100,000

The contact owns a 2014 Ford Explorer. The contact stated that while driving at an undisclosed speed with his 12-year-old child in the vehicle, the steering wheel tightened up, and the vehicle drove straight and crashed into a sand barrier. The air bags deployed. The driver sustained injuries to his chest, head, and shoulder. There was no injury stated for the 12-year-old child who was also in the vehicle during the crash. Medical attention was provided to the driver. A Police report was filed but was not provided to the contact. The vehicle was towed to the Police Precinct. There were no warning lights illuminated. The contact stated that prior to the crash, the vehicle was parked and rolled back and struck another vehicle. The vehicle was repaired. The contact stated that the failure was related to NHTSA Campaign Number: 21V537000 (Suspension). The contact called an unknown local dealer, but the vehicle was not diagnosed or repaired after the crash. The contact stated that the vehicle was totaled; however, the Insurance Provider had not yet rendered a decision on the vehicle. The manufacturer was not yet contacted. The failure mileage was approximately 100,000.

Mileage: 100,000

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the low tire pressure warning light illuminated. The contact also stated that when she inspected the vehicle, she became aware that the steel belts were hanging from the interior of the rear tires. The contact took the vehicle to an independent mechanic where it was diagnosed as a failure with the rear alignment. The contact was informed that the rear toe link needed to be replaced. The vehicle was not repaired. The dealer was contacted; however, the vehicle was not repaired. The manufacturer was made of the failure and the contact was referred to NHSTA Hotline for assistance. The failure mileage approximately was 120,000.

Mileage: 120,000

The contact owns a 2014 Ford Explorer. The contact stated that the sunroof motor had failed due to water intrusion. The vehicle was taken to an independent mechanic, where the sunroof motor was replaced. Additionally, the contact stated that after parking the vehicle in the independent mechanic parking lot on another occasion, he noticed a steal band underneath the rubber of the rear tires. The mechanic informed the contact that the suspension had failed, which was damaging the rear tires. The vehicle was being diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 97,745.

Mileage: 97,745

N/A

The contact owns a 2014 Ford Explorer. The contact stated the vehicle was registered from the Chicago plant and the vehicle resided in Northern Nevada, 30 minutes from Lake Tahoe. The contact stated the vehicle was susceptible to corrosion due to the weather in Northern Nevada. These vehicles may have rear toe links that received excessive electrocoating (e-coat) corrosion protection, which could cause the e-coat to become brittle and break away when contacted by road debris. The contact notified the dealer who referred the contact to the manufacturer. The contact referenced Ford Customer Satisfaction Program: [XXX] (Rear Toe Link Replacement) and NHTSA Campaign Number: [XXX] (Suspension) as a possible solution however, the VIN was not included in the recall. The manufacturer was notified of the issue and referred the contact to NHTSA Hotline. The contact had not experienced a failure. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Control arm on Ford 2014 explorer are prone to failure, causing vehicle to lose steering. Control arms rub excessively against brake components, also causing failure to both brakes, ABS, and sensors related to wheel speed. Failure is due to the manufacture. Strong action is need to prevent further road accidents if not addressed.

See attached document from complainant

under the program of 15N01 the 2014 Ford Explorer is not part of it and it should be as my vehicle is experiencing the same issues. The program currently ends for vehicles manufactured January 2014 and mine was manufactured in April of 2014. I would like this added so my vehicle can be repaired under the program. The make, model and body styling is the same as previous years and has the same parts.

The contact owns a 2014 Ford Explorer. The contact stated received notification of NHTSA Campaign Numbers: 21V537000 (Suspension) and 20V675000 (Suspension). The contact stated that the vehicle was taken to the dealer for the scheduled recall repairs, and the contact was informed that the toe links could not be replaced due to the knuckles needing to be replaced prior to completing the recall repair. The contact stated that the dealer contacted the manufacturer and the manufacturer verbally agreed to complete the recall repair by replacing both parts and scheduled the service for a later date. The vehicle was taken to the dealer for the rescheduled appointment and the contact was informed by the dealer that the manufacturer declined the recall repairs as well as replacing the knuckles. The manufacturer was not made aware of the failure. The failure mileage was unknown.

The contact owns a 2014 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle made abnormal sounds and was vibrating abnormally. Additionally, the tires experienced a loss of traction while turning. The vehicle was taken to an independent mechanic, who replaced the CV joints twice; however, the failure recurred. The vehicle was then taken to the dealer, where the steering rack and bushings were replaced, and an alignment was performed. The failure recurred, and the vehicle was taken back to the dealer, where it was determined that the CV joints needed to be replaced for the third time. The vehicle was not repaired. The manufacturer was made aware of the failure but confirmed that the VIN was not included in an unknown TSB. The failure mileage was approximately 200,000.

Mileage: 200,000

The contact owns a 2014 Ford Explorer. The contact stated that after making a left turn, the vehicle jerked in the opposite direction, and then the steering wheel became difficult to turn, and she crashed into a parked vehicle. The check engine and air bag warning lights were illuminated. The contact stated that after parking the vehicle, she noticed a fluid leak underneath. The vehicle had not yet been taken to an independent mechanic or a local dealer to be diagnosed or repaired. The VIN was included in NHTSA Campaign Number: 20V675000 (Suspension). The manufacturer was made aware of the failure. The approximate failure mileage was unknown. The contact stated that the air bags never deployed at the time of the incident. Also, it is difficult to click the seatbelt clip in. The local Ford Service Team was contacted but offered no help, stating that the accident had no correlation to the recall. They stated that they would not be covering the cost of repair for that incident.

Mileage: 171,679

Steering became very difficult, car would not track straight and turning was delayed. The dealer said teeth in the steering box had broken off. Also had a broken suspension strut - front right.

The contact owns a 2014 Ford Explorer. The contact stated while inspecting the vehicle, the tech stated that the toe link needed to be replaced. The vehicle was taken to the dealer and the dealer repaired the vehicle under NHTSA Campaign Number: 21V537000 (Suspension). The vehicle was taken to the inspection center again and the tech stated that the toe link needed to be replaced once again and advised the contact to take the vehicle to the dealer for assistance. The vehicle was taken to the dealer and the dealer stated that the rear passenger’s side knuckle needed to be replaced and stated that the vehicle had exceeded the 6 marks for warranty coverage. The vehicle was not repaired. The manufacturer was contacted, and a case was filed. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was 123,000.

Mileage: 123,000

My Ford Explorer had a rear suspension toe link Recall, and in December I took my vehicle to the Ford dealership to get it fixed. At that time, they did a full vehicle inspection, fixed the part, and told me everything looked great. Shortly after the service, we had a snow storm, and my SUV would fishtail in Icy/snowy conditions. Every time it'd snow, it made me so scared to drive, because I'd essentially not have control over my vehicle. The issue wasn't present when the roads were clear. Within the two months since that service, my back tires have gone completely bald, down to the wires. I recently got in a car accident because my car wouldn't complete a turn and ended up t-boning a Tundra on a residential street. Luckily I was going slow so the damage to the other vehicle was minimal, and no obvious injuries have resulted from the accident. I was able to remove some of the plastic pieces around the fender, in order to still drive it, so I took it to the Ford dealership that originally serviced my car for an inspection. Now that the dealership has inspected my vehicle, they're claiming that it's not on their liability and that they're not responsible for any of the damage. Now the alignment is off on both the front and back, and the strut is bent (whether that's from the accident or not, we don't know). The Manager admitted that when servicing my vehicle they were only allowed to perform a rear alignment, but a front alignment was never suggested or offered to me. When aligning a vehicle (especially in the winter) the whole vehicle should be aligned, not just half. They of course claim zero liability or responsibility, even though I was having issues with it fishtailing shortly after it being serviced at their shop, for a part on the suspension, which affects alignment.

The contact owns a 2014 Ford Explorer. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 19V435000 (Suspension). The technician then became aware that the front alignment needed to be adjusted due that the rear alignment adjustment. The vehicle was not repaired. The manufacturer was contacted but declined to perform the alignment. The approximate failure mileage was 100,000.

Mileage: 100,000

The contact owns a 2014 Ford Explorer. The contact stated that while her daughter was driving approximately 15 MPH, the steering wheel became difficult to turn. The driver was able to steer the vehicle safely to a nearby parking lot. The contact was unaware if any warning lights were illuminated. The vehicle was towed to the local dealer and was diagnosed with the steering gear assembly failure. The vehicle was not repaired. The manufacturer was notified of the failure. The contact related the failure to NHTSA Campaign Number: 16V245000 (Suspension). The approximate failure mileage was 105,000.

Mileage: 105,000

The rear suspension on this vehicle stinks! I've done 2 recalls for the toe links. Now I've had to replace the rear wheel bearings. They were both bad! Niw that's done, i've a really bad(dangerous) swaying problem! The darn thing won't hardly stay on the road! I had to go to the VA for a dr appt last week in Huntington WV. On the way home i hit a downpour. I was lucky to get pulled over! The thing hydro-planed and bucked all over the road. I was only going about 40-45mph! The toe and camber are way out on the driver side rear, and the passenger side isn't much better... Those aren't the only problems. There's quite a list with this piece of junk! From the cat converters to the rear door locks, there's always been issues. I'm the second driver. I'm on disability and drive nowhere. Especially doing/driving cazy/ abusive. My dad was the other driver until he passed in 2018, and he was just an old preacher. He never hit 75mph in the thing, though he put alot of highway miles on it. I've never been above like 78 - 80mph in it... We both were/are very proactive as far as maintenence... There ought to be a lemon law...

The contact owns a 2014 Ford Explorer. The contact stated that while driving over bumps in the roadway at various speeds, a jolt could be felt from the rear end of the vehicle. The contact then received a recall notice for NHTSA Campaign Number: 21V537000 (Suspension) which she linked to the failure. The contact took the vehicle to a dealer for the repair; however, upon return of the vehicle, the contact was informed that she needed to replace a knuckle assembly on the toe link that was not covered under a recall. The contact was assured that the vehicle was safe to drive and she was referred to the manufacturer for assistance. The contact then stated that while driving 65 MPH, she drove over a bump in the roadway and the entire rear end of the vehicle slid into the opposite lane of traffic and almost caused an accident. The contact then read her service report which stated that the recall was not serviced since the assembly knuckle was not replaced. The manufacturer was notified of the failure and offered no assistance. The contact was then transferred to the NHTSA to file a complaint. The vehicle was not repaired. The failure mileage was 108,000.

Mileage: 108,000

I have been trying to get the recall done for a year and a half only to be told the parts are not available. Just got a letter from Ford that parts were available so I called for appointment. Guess what! No parts. Year and a half and still no parts. This is a real safety issue. There have been known s accidents caused by this part failure yet after all this time I'm told no parts. Crazy!!

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V537000 (Suspension) however, the part to do the recall repair was not yet available. The local dealer was contacted and an appointment was scheduled; however, the appointment was rescheduled for a later date. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2014 Ford Explorer. The contact received notification of NHTSA campaign number: 21V537000 (Suspension) however, the part to do the recall was unavailable. The contact called the local dealer who stated that the parts were not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2014 Ford Explorer. The contact stated that while turning the steering wheel there was an abnormal knocking and ticking sound detected. The maintenance warning light was illuminated. The contact called the local dealer and was provided a fee for diagnostic testing. The vehicle was not diagnosed or repaired. The contact stated the failure was related to NHTSA Campaign Number 21V537000 (Suspension). The manufacturer was contacted but no further assistance was provided. The approximate failure mileage was 122,000.

Mileage: 122,000

The contact owns a 2014 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 19V435000 (Suspension) and 21V537000 (Suspension) however, the parts to do the recall repairs were not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer and another dealer, John Kennedy Ford of Pottstown (3189 W Ridge Pike, Pottstown, PA 19464) were made aware of the issue and informed the contact that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect on NHTSA Campaign Number: 19V435000 (Suspension). VIN tool confirms parts not available on NHTSA Campaign Number: 21V537000 (suspension).

The contact owns a 2014 Ford Explorer. The contact stated that while driving at various speeds, an abnormal knocking noise would emit from the rear suspension without warning. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 21V537000 (Suspension) however, the vehicle was not included in the recall. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 125,000.

Mileage: 125,000

Hello, My car currently has an open recall that needs to be remediated it has been issued since OCT 30, 2020. This is the second recall to resolve an outstanding issue with my cars rear toe link 20S62/20V675. On three separate occasions I have attempted to get this remediated with three dealerships turning away servicing my vehicle due to lack of parts. I filed a complaint with the Ford Corporate office to report what I would consider Unfair Trade Practice and consumer right violations as these dealerships seem to be able to conduct the work however are turning away the recalls either to prioritize paying jobs. This leaves myself as a consumer with a lingering risk, exponential exposure to harm when operating my vehicle. Ford company is willfully aware of the situation and have not addressed this matter. I submitted another escalation today due to being turned away for a 3rd time. Keep in mind that I have requested to be contacted when parts have been available or if the parts can be ordered and neither of these requests have been met. I am aware that we are coming off the heels of the Covid pandemic and these dealerships might be short staffed, so they are being directed to avoid recall resolution.

THERE WAS A RECALL 19S17 ON THE VEHICLE. I TOOK VEHICLE TO DEALER FOR THIS 12-16-2019. THEY REPLACED THE TOE LINKS (PART DB5Z-5A972-J) AND REPORTED THAT THE LEFT SIDE TOE LINK BALL JOINT WAS LOOSE AND NEEDED REPLACEMENT. THEY WOULD HAVE TO RESCHEDULE A TIME TO DO THAT. BECAUSE THE JOINT WAS LOOSE, THEY DID NOT PERFORM THE ALIGNMENT THAT WAS SUPPOSED TO BE DONE AFTER TOE LINK REPLACEMENT. DRIVING THE VEHICLE ON SNOW COVERED ROADS AFTERWARDS REVEALED THAT THE REAR SUSPENSION WAS OUT OF ALIGNMENT BECAUSE OF VERY POOR HANDLING/WANDER. THE VEHICLE DID NOT HAVE THAT PROBLEM BEFORE THE SERVICING. THE DEALER SHOULD HAVE DONE A SIMPLE ALIGNMENT THAT WOULD HAVE PUT THE ALIGNMENT CLOSE ENOUGH INSTEAD OF SENDING THE VEHICLE OUT IN AN UNSAFE CONDITION. BECAUSE OF THE COST I WAS QUOTED, I TOOK THE VEHICLE TO AN INDEPENDENT AUTO REPAIR SHOP FOR THE JOINT REPLACEMENT, WHERE IT WAS DONE MUCH CHEAPER. I RECEIVED ANOTHER RECALL NOTICE 20V-675 DATED NOVEMBER 2020, ON THE TOE LINKS AND RETURNED THE VEHICLE TO THE DEALER ON 12-30-2020. THEY REPORTED THAT THE TOE LINKS PASSED THE INSPECTION AND THEY REPLACED THE ATTACHING BOLTS. ON 1-30-2021 I WAS DRIVING THE VEHICLE IN A 70 MPH ZONE IN THREE LANES OF TRAFFIC WHEN THE LEFT SIDE TOE LINK FRACTURED. THE VEHICLE WENT WILDLY OUT OF CONTROL, SKIDDING AND SLIDING BACK AND FORTH UNTIL I WAS ABLE TO FIGHT IT TO A STOP. LUCKILY THERE WAS NOT A COLLISION WITH NEARBY TRAFFIC. THIS WAS 30 DAYS AFTER THE TOE LINK WAS SUPPOSED TO HAVE BEEN INSPECTED. THE VEHICLE WAS TOWED TO A FORD DEALER IN THE AREA. THE DEALER REPLACED BOTH TOE LINKS. I HAVE THE BROKEN TOE LINK. FORD HAS REFUSED TO COVER ANY OF MY EXPENSE WHICH INCLUDED A RENTAL CAR. MY CONCERN IS THAT DRIVING THE CAR NOW PRESENTS A VERY SCARY SITUATION. WILL A TOE LINK BREAK AGAIN AND SEND THE VEHICLE OUT OF CONTROL CAUSING AN ACCIDENT?

Mileage: 117,550

2014 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO NHTSA SAFETY RECALL 20V-675. *LD THE CONSUMER STATED THE PARTS WERE UNAVAILABLE TO COMPLETE THE RECALL. *JS

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 40 MPH ON THE HIGHWAY, THERE WAS A LOUD ABNORMAL GRINDING SOUND COMING FROM THE REAR OF THE VEHICLE. THE REAR LOCKED UP CAUSING THE VEHICLE TO FISHTAIL IN THE MIDDLE OF THE HIGHWAY. THE CONTACT REGAINED CONTROL OF THE VEHICLE AND PULL OVER TO THE SIDE OF THE ROAD. THE CONTACT HAD THE VEHICLE TOWED TO BILL BROWN FORD (32222 PLYMOUTH RD, LIVONIA, MI 48150) WHERE THEY STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION) FOR THE REAR TOE LINK. THE VEHICLE WAS REPAIRED HOWEVER, THE CONTACT RECEIVED A NEW RECALL NOTIFICATION FOR THE SAME ISSUE. THE CONTACT STATED THAT THE RECENTLY THE STEERING WHEEL AND REAR WHEELS WOULD LOCK UP AND THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER BUT WAS NOT YET REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

Mileage: 150,000

CONTACTED FORD DEALERSHIP ABOUT RECALL EFFECTING STEERING. WAS TOLD BY DEALERSHIP THAT THE PART WOULD NOT BE IN FOR 3 TO 4 WEEKS. CONTACTED FORD MOTOR DIRECTLY AND THEY ASKED WAS I EXPERIENCING PROBLEMS AND I TOLD THEM THAT MY VEHICLE HAD FELT LIKE ITS SHIFTING SIDE TO SIDE WHEN I DRIVE. FORD REP TOLD ME THAT I WOULD NEED TO TAKE MY CAR TO PAY FOR A DIAGNOSTIC. I QUESTIONED WHY DID I NEED TO PAY FOR A DIAGNOSTIC WHEN THE FAILURE OF THE COMPANY TO HAVE THE RECALLED PART IN STOCK IS FORCING ME TO HAVE A DIAGNOSTIC DONE. IF THE PART WAS IN STOCK AND I WAS HAVING THE SAME ISSUE I WOULD HAVE MY VEHICLE CHECKED AT MY LOCAL MECHANIC SHOP THAT DOESN'T PAY CHARGE TO DIAGNOSE A VEHICLE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN: 20V675000 (SUSPENSION). THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED BOGGUS FORD HARLINGEN (2521 S EXPRESSWAY 83, HARLINGEN, TX 78550, (956) 423-2580) AND WAS INFORMED THAT PARTS WERE NOT YET AVAILABLE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. PARTS DISTRIBUTION DISCONNECT. *BF THE CONSUMER STATED THE VEHICLE WAS REPAIRED.

HI MY NAME IS [XXX]. I PURCHASED THIS 2014 FORD EXPLORER FROM A CERTIFIED FORD GARAGE MECHANIC THIS SUMMER. THE PRIVATE PARTY PURCHASE WAS IN JUNE 2020 WITH 89,XXX MILES. THE SELLER SHOWED ME EVERY REPAIR, OIL CHANGE, BRAKES ETC. WERE DONE IN A FORD GARAGE. TEN THOUSAND MILES LATER THE VEHICLE SNAPPED A TOE LINK LATERAL ARM DRIVING DOWN A SMOOTH HIGHWAY 60MPH! THE VEHICLE SWERVED AND MY WIFE AND 2 YOUNG KIDS WERE IN DANGER.. THE VEHICLE WAS TOWED, FOR THE WHEEL WAS TIPPED IN AND NOT STABLE...FLAT BED TOW $100 OUT OF POCKET... FORD OF HIBBING DEALER SAID THE VEHICLE WAS NOT RECALLED AND THEY WOULDN'T HAVE TIME TO REPAIR FOR OVER A MONTH.. THEY SOLD ME THE FACTORY FORD TOE LINK THAT WAS THE "FIX" UPGRADE... WITH ALL THE DEALERS AND LOCAL AUTO SHOPS WAY WAY BEHIND AND SHORT HANDED I HAD THE VEHICLE TOWED AGAIN FOR $100 OUT OF POCKET TO MY GARAGE.. I WENT TO TECH SCHOOL OUT OF HIGH SCHOOL FOR AUTO MECHANIC AND RECEIVED A 2 YEAR DEGREE AND PREVIOUSLY WAS A AUTO MECHANIC FOR 10 PLUS YEARS.. ANYWAYS BEYOND THAT POINT I REPLACED THE TOE LINK IN MY SHOP AND INSPECTED OTHER POINTS.. AFTER I REPLACED THE LINK I WAS ABLE TO HAVE THE VEHICLE TOWED TO A LOCAL TIRE AND ALIGNMENT SHOP IN HIBBING MN (IRON RANGE TIRE) WHICH THEY THAN PROFESSIONALLY ALIGNED AND TIGHTENED THE REAR SUSPENSION. 100 MILES LATER HAPPENS AGAIN TO MY WIFE AND KIDS DOWN THE HIGHWAY!! TOWED AGAIN $100! CURRENTLY AT LUNDGREN FORD DEALER EVELETH MN. $2800 TO REPLACE AND REPAIR SUSPENSION COMPONENTS! FILED A FORD CASE # [XXX]. FORD REFUSED TO COOPERATE OR POSSIBLY PAY FOR REPAIR! THE SERVICE DEPT MANAGER SAID THE VEHICLE WAS SERVICED REGULARLY AT THAT SHOP AND SAID SERVICE RECORDS SHOW THE COMPLETE REAR SUSPENSION WAS REPLACED IN 2019!! 20,000 MILES AGO! AND ITS ALREADY BREAKING AGAIN! ITS UNSAFE FOR MY WIFE AND 4 & 6YR OLD BOYS! PLEASE HELP! IM SERIOUSLY NOT WASTING TIME! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 100,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 15 MPH AND MAKING A TURN, IT FELT AS IF THE REAR TIRE HAD SLIPPED ON ICE WITH A LOUD ABNORMAL SOUND. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE TOE LINK DETACHED. THE CONTACT STATED THAT THE FAILURE OCCURRED TWICE. THE CONTACT STATED THAT HER HUSBAND REPLACED THE TOW LINK. FORD OF HIBBING (2627 E BELTLINE, HIBBING, MN 55746) WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT SCHEDULED AN APPOINTMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT UNDER RECALL, AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

Mileage: 110,000

FRACTURED REAR TOE LINK SUSPENSION. HUSBAND FIXED IT ONCE, LESS THEN A MONTH LATER AFTER REPLACING PART IT BROKE AGAIN! NOT HAPPY HAD MY KIDS IN THE VEHICLE WITH ME BOTH TIMES THANKFULLY WE WERE NOT HURT AS WE WERE NOT GOING VERY FAST WHEN THE PART COMPLETELY SNAPPED! HAPPENED WHEN I WAS TURNING THE CORNER FELT LIKE MY BACK TIRE POPPED OUT OF SOCKET!

Mileage: 110,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING ON THE HIGHWAY AT 65 MPH, THE REAR TOE LINK SPLIT IN HALF WHICH CAUSED THE VEHICLE TO LOSE CONTROL AND SLAM INTO THE GUARDRAIL ON THE DRIVER'S SIDE. THE VEHICLE BOUNCED AND SPUN 260 DEGREES AND HIT THE GUARDRAIL AGAIN AND SCRAPPED ALONG THE GUARDRAIL. AS A RESULT, THE VEHICLE DOWN TO SLOW DOWN AND COME TO A REST IN THE LEFT MEDIAN LANE. THE BRAKES FAILED AND THE CONTACT WAS ABLE TO SHUT OFF THE VEHICLE AND GET OUT AND INSPECT THE DAMAGE. THE CONTACT HAD A POLICE OFFICER DIRECT HER TO FURTHER PULL HER VEHICLE COMPLETELY OUT OF THE LANE FROM ONCOMING TRAFFIC. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A COLLISION CENTER APPROVED BY HER INSURANCE COMPANY. THE CONTACT MENTIONED THAT THE TOE LINK HAD BEEN A RECALL REPAIR FROM THE DEALER DOVI MOTORS, INC 263 TOMPKINS ST, CORTLAND, NY 13045 (607) 756-2801 BACK IN 2017. THE DEALER AND THE MANUFACTURER HAD NOT BEEN CONTACTED YET. THE FAILURE MILEAGE WAS 80,000.

Mileage: 80,000

I WAS TRAVELLING ROUGHLY 30-35 MPH ON A COUNTRY ROAD (THAT WAS DRY AND CLEAR IN THE MIDDLE OF THE AFTERNOON) WHEN I SUDDENLY LOST CONTROL OF MY VEHICLE. IT FELT LIKE THE REAR END WAS FISHTAILING ALL OVER THE PLACE. I DID NOT HEAR ANYTHING BREAK, BUT I COULD HEAR MY TIRES SQUEALING. I WAS ABLE TO REGAIN CONTROL OF THE VEHICLE BEFORE GOING INTO THE DITCH AND CAME TO A STOP ON THE RIGHT HAND SHOULDER. I EXITED MY VEHICLE, SAW THE SKID MARKS BEHIND ME ON THE ROAD AND STARTED LOOKING THE VEHICLE OVER WHEN I DISCOVERED THAT THE RIGHT REAR TIRE WAS PHYSICALLY POINTING OUT TO THE RIGHT. I THEN CHECKED UNDER THE BODY AND FOUND THAT THE RIGHT REAR SUSPENSION TOE LINK COMPLETELY SNAPPED IN TWO. I LEARNED AFTER TAKING IT TO A LOCAL DEALERSHIP THAT ON 10/22/18 THIS VEHICLE HAD ITS REAR SUSPENSION TOE LINKS REPLACED PER A RECALL (17G01), BUT THE REPLACEMENT PARTS FAILED AND THE MANUFACTURER (FORD) WILL NOT REPLACE THEM AGAIN PER A PHONE CONVERSATION THAT TOOK PLACE WITH FORD CUSTOMER CARE ON 8/11/20.

Mileage: 137,754

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT WHILE HIS DAUGHTER WAS DRIVING 75 MPH, THE REAR DRAG LINK DETACHED CAUSING THE VEHICLE TO SPIN AROUND SEVERAL TIMES AND CRASHED INTO THE CENTER RAIL AND POLE. THE VEHICLE WAS DAMAGED IN THE FRONT AND REAR. THERE WERE NO WARNING LIGHTS ILLUMINATED. THERE WERE NO REPORTED INJURIES. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TOWED TO RANDALL REED'S PLANET FORD (19000 EASTEX FWY, HUMBLE, TX 77338 866) 844-5995) WHERE IT WAS DIAGNOSED THAT THE REAR DRAG LINK FRACTURED HOWEVER THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED HOWEVER THEY DECLINED THE REPAIRS DUE TO VEHICLE DAMAGE. THE CONTACT STATED THAT A VIN SEARCH WAS DONE ON-LINE AND THEY DISCOVERED UNREPAIRED RECALLS ON THE VEHICLE. THE CONTACT REFERENCED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION). THE FAILURE MILEAGE WAS 50,000. THE VIN WAS NOT AVAILABLE.

Mileage: 50,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION) AND 19V435000 (SUSPENSION), AND THE STEERING MODULE WAS REPROGRAMMED. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE POWER STEERING ASSIST FAILED INTERMITTENTLY. THE VEHICLE WAS TAKEN BACK TO SOUTHGATE FORD LOCATED AT ((16501 FORT ST, SOUTHGATE, MI 481195), (734)282-3636), WHERE THE RECALL REPAIRS WERE PERFORMED TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING KNUCKLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. THE VIN WAS NOT AVAILABLE.

Mileage: 87,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT HER HUSBAND WAS DRIVING AT APPROXIMATELY 5 MPH, THE DRIVER'S SIDE REAR TOE LINK FRACTURED WHICH CAUSED THE REAR DRIVER'S SIDE WHEEL TO TURN INWARD. THE VEHICLE WAS TOWED TO SPITZER FORD HARTVILLE LOCATED AT (543 W MAPLE ST, HARTVILLE, OH 44632) WHERE THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION). THE CONTACT WAS INFORMED BY THE DEALER THAT THEY WOULD BE WILLING TO PROVIDE A SECOND FREE REPAIR. THE CONTACT STATED THAT THE FAILURE RECURRED WHILE HER HUSBAND WAS DRIVING AT 67 MPH. THE VEHICLE WAS AGAIN TOWED TO SPITZER FORD WHERE IT WAS CONFIRMED THAT THE TOE LINK NEEDED TO BE REPLACED AGAIN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

Mileage: 50,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT UPON STARTING THE VEHICLE, THE VEHICLE WAS SHIFTED INTO DRIVE AND THE VEHICLE SHUDDERED AND ACCELERATED INDEPENDENTLY WITHOUT WARNING. THE VEHICLE WAS TOWED TO AUTONATION FORD VALENCIA 23920 CREEKSIDE RD, VALENCIA, CA 91355 TO BE DIAGNOSED. A DIAGNOSTIC WAS PERFORMED AND THE CONTACT WAS INFORMED THAT HER VEHICLE HAD EXPERIENCED TRANSMISSION FAILURE AND WAS GIVEN AN ESTIMATE FOR THE REPAIR. THE VEHICLE WAS INCLUDED IN NHTSA RECALL NUMBER: 19V435000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 111,000.

Mileage: 111,000

THE RECALL 19S17 (NHTSA 19V-435) AFFECT THE REAR SUSPENSION .WE BRING IN THE CAR TODAY AND THEY REPLACE THE BAD PARTS . NOW FORD SERVICE IS TELLING ME THAT IT AFFECT MY MOTOR AND TRANSMISSION MOUNTS BUT I HAVE TO PAY $900 TO REPLACE THOSE . VEHICLE IS VIBRATING AND SHAKING OVER 70MPH . THE MOUNTS ARE HERE TO MINIMISE THE VIBRATION DUE TO ROAD DEFECTED , IF THE SUSPENSION DON'T DO ITS WORK , AND IT WASN'T BECAUSE OF THE RECALL ... VEHICLE IS ONLY 90K MILES

Mileage: 89,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE REAR SUSPENSION MADE NOISES WITHOUT WARNING. THE CONTACT DROVE TO GORDIE BOUCHER FORD LINCOLN OF JANESVILLE (2727 US-14, JANESVILLE, WI 53545, 608-754-5511) WHERE IT WAS DIAGNOSED THAT THE TOE LINK WAS FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION); HOWEVER, HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 44,000.

Mileage: 44,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION) AND STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME TO REPAIR THE VEHICLE. MAC HAIK FORD PASADENA (4242 E SAM HOUSTON PKWY, S PASADENA, TX 77505) CONFIRMED THAT PARTS WERE NOT AVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. *BF CONSUMER STATED UPON FURTHER TRIES, MAC HAIK SCHEDULED THE REPAIRS AND THE REPAIR WERE COMPLETED SEPT. 2019. I HAVE NO WAY OF ENSURING THE REPAIRS WERE COMPLETED CORRECTLY BUT I HAVE NOT EXPERIENCED ANY INDICATIONS THAT WOULD CAUSE ME TO DOUBLE THE QUALITY OF THE WORK. THANK YOU FOR FOLLOWING UP WITH MY COMPLAINT THAT THE MANUFACTURER WAS ACTING UPON SUPPLYING THE DEALER. SHIP PARTS TO FIX THE FLAW IN A TIMELY MANNER.*JB

I TAKE VEHICLE TO THE DEALER FOR FAULTY DRIVER SIDE DOOR SENSOR AND I STRONGLY BELIEVE IT'S DEFECTIVE ON MANUFACTURING. THEN THE DEALER NOTIFY ABOUT REAR SUSPENSION TOE LINK REPLACEMENT AFFECTING THE STEERING CONTROL. THIS RECALL ALSO AFFECT THE REAR HUBS THE DEALER CHARGE TO ME $990.00+TAX TO FIX ISSUE. THE DEALER RECOMMENDS TO CHANGE BECAUSE OF THE SAFETY ISSUES. EACH HUBS HOLD THE WHEELS.

I RECENTLY WAS DRIVING DOWN THE HIGHWAY AT 70MPH WHEN MY CAR'S STEERING BECAME OUT OF CONTROL. IT WAS LIKE I WAS FISHTAILING ON ICE AND THE STEERING WAS LOOSE. THANKFULLY I WAS ABLE TO BRAKE AND GET INTO A GRASSY AREA OFF THE SIDE OF THE HIGHWAY. I WAS ABLE TO GET OFF THE EXIT AND DRIVE AT A SLOWER SPEED. THANKFULLY I DID NOT CRASH BUT WAS EXTREMELY CLOSE TO CRASHING.

Mileage: 77,000

ON SATURDAY, 6/29/19, I TOOK MY CAR TO BOB TOMES FORD IN MCKINNEY, TX, TO HAVE RECALL 19S17 WORK DONE AS I FEEL I HAVE LIMITED CONTROL OF MY CAR DUE TO THIS SUSPENSION TOE LINK/STEERING ISSUE. I WAS TOLD FORD SENT THE WRONG PARTS AND THAT I WOULD HAVE TO WAIT A COUPLE WEEKS FOR THE CORRECT PARTS TO COME IN. I DON'T KNOW IF THIS IS TRUE. ALL I KNOW IS, I HAVE COMPLAINED TO FORD MULTIPLE TIMES AND WAS VERY GLAD TO HEAR ABOUT THIS RECALL. NOW I HAVE TO WAIT EVEN LONGER? THIS IS THE SAME RECALL FROM 2016. WHY CAN'T FORD GET IT RIGHT? SHOULD I TRADE MY FORD IN? I JUST BOUGHT IT IN MARCH 2019. I TOLD THE GUY AT FORD, IF I CRASH MY CAR BEFORE THEY CAN FIX IT, I WILL BE TAKING FORD TO COURT. HELP

RECALL

NOISES COMING FROM FRONT AND REAR SUSPENSION

WHEN WE FIRST RECEIVED THE VEHICLE WE WENT ON A ROAD TRIP TO AZ AND THE COMPUTER COMPLETELY BLACKED OUT ON THE DASH AND THE SUSPENSION WAS SUPER WOBBLY. SO WE CALLED TO MAKE AN APPT TO BRING IT IN AS SOON AS WE GOT BACK IN TO TOWN BUT IT WAS A 2 WEEK WAIT FOR AN APPT. THEY KEPT OUR CAR FOR THREE WEEKS AND AS SOON AS WE GOT IT BACK IT WAS THE SAME PROBLEM. SO WE ASKED TO MAKE ANOTHER APPT AND THIS TIME THEY KEPT OUR CAR FOR A WHOLE MONTH AND GOT IT BACK AND THE SAME PROBLEM. ANY LITTLE BUMP OR INDENT IN THE ROAD AND THE CAR IS WOBBLY ALL OVER SOUNDS LIKE THE BEARINGS. WE HAVE YET TO GET IT FIXED AND I SEEN THERE WAS A RECALL ON 2014 FORD EXPLORERS FOR THE REAR BEARINGS. I CALLED THE NUMBER FOR RECALLS AND THEY SAID THEY DIDN'T SEE ONE FOR THIS VIN BUT IT'S THE SAME PROBLEM FROM THE RECALL IN 2016 FOR THE SAME YEAR VEHICLES.

Mileage: 70,000

RIGHT REAR TOE LINK BROKE WHILE DRIVING ON THE HIGHWAY. STEERING WAS COMPROMISED. THE LEFT REAR TOE LINK ALSO SHOWED SIGNS OF STRESS. THIS EXPLORER WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER: 16V245000 PERHAPS FORD NEEDS TO EXPAND THE NUMBER OF CARS RECALLED DUE TO THIS ISSUE.

Mileage: 48,600

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED A LOCAL DEALER (MEL HAMBELTON FORD, 11771 W KELLOGG ST, WICHITA, KS 67209, (316) 462-3673) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

I DISCOVERED THAT ON EACH SIDE 1 OF THE 2 BOLTS SECURING THE SUB-FRAME STABILIZER BRACKET TO THE BODY WAS MISSING AND THE OTHER ONE WAS ALMOST OUT. IN THE ATTACHED PARTS DIAGRAM THE BOLTS ARE HS1. THE CAR HAS 104,000 MILES AND IT IS CLEAR THAT HAD I NOT NOTICED THE REMAINING 2 BOLTS WOULD HAVE FALLEN OUT LEAVING THE REAR OF THE SUB-FRAME ABLE TO MOVE AROUND. THE MAIN SUB-FRAME BOLTS WOULD THEN HAVE COME UNDER INCREASED STRAIN AND THE SUSPENSION WOULD HAVE BEEN SUBJECT TO INCREASED MOVEMENT IN UNINTENDED DIRECTIONS.

Mileage: 104,000

MY FORD EXPLORER HAS A CONSTANT EXHAUST SMELL IN THE CABIN. THE DEALERSHIP COMPLETED A RECALL WHEN I FIRST PURCHASED THE VEHICLE AND NOW THE DEALER IS TELLING ME THEY DO NOT KNOW OF ANY EXHAUST IN THE CABIN ISSUES. STRANGE NOW THE DEALERSHIP KNOWS NOTHING ABOUT A PROBLEM THEY TRIED TO FIX. THE FRONT SUSPENSION HAS BEEN REPLACED 3 TIMES NOW. ABOUT EVERY 20K MILES THE FRONT SUSPENSION START TO FAIL AND MAKES LOUD CLUNKING NOISES AND WE LOOSE ALIGNMENT IN THE FRONT END. THIS LAST TIME THE TOW IN THE FRONT TIRES CHANGED AND CAUSED FOR UNUSUAL STEERING ON THE FREEWAY. THE TURBO'S ON THE 3.5 ECOBOOST HAVE A KNOWN OIL LEAK ISSUE THAT CAUSES DAMAGE TO THE CATALYTIC CONVERTER. FORD REFUSES TO COVER THE CATALYTIC CONVERTERS EVEN IF YOU HAVE THEIR IN HOUSE EXTENDED SERVICE PLAN.

Mileage: 75,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT LOST CONTROL OF THE STEERING WHEEL AND THE BRAKES STARTED TO SQUEAK AND THEN LOCKED UP. THE VEHICLE SHIFTED INTO ONCOMING TRAFFIC, BUT NO CRASH OCCURRED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO FRANK FLETCHER FORD LINCOLN (3015 TURKEY CREEK RD, JOPLIN MO 64801, PHONE NUMBER: (417) 623-5660) WHERE IT WAS DIAGNOSED THAT THE CONTROL ARM DETACHED DUE TO THE CONTACT HITTING SOMETHING WITH THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

Mileage: 85,000

SINCE I PURCHASED THIS VEHICLE NEW IN JULY 2014, I HAVE EXPERIENCED A SULPHUR LIKE SMELL IN THE CABIN AREA OF THE VEHICLE WHEN I ACCELERATE. THE ODOR IS STRONG ENOUGH TO MAKE YOU FEEL NAUSEOUS AND LIGHT HEADED. I HAVE TAKEN THE CAR BACK TO THE DEALERSHIP WHERE IT WAS PURCHASED ON TWO SEPARATE OCCASIONS. ON ONE VISIT THEY CLAIMED THEY HAD INSTALLED ADDITIONAL VENTS TO ELIMINATE THE FUMES. THE SECOND TIME, THE EXHAUST WAS REPORTEDLY REPLACED. NEITHER REPAIR CREATED ANY IMPROVEMENT IN REGARD TO THE SMELL. ADDITIONALLY, I HAVE EXPERIENCED ISSUES WITH THE FRONT SUSPENSION/STEERING AREA. THE VEHICLE HAS BEEN TAKEN BACK TO THE DEALERSHIP ON TWO SEPARATE OCCASIONS TO ADDRESS THE ISSUE(S). THE VEHICLE HAS A LOUD POPPING SOUND THAT EMANATES FROM THE RIGHT FRONT AXLE AREA WHEN MAKING A LOW SPEED TURN. THE FIRST REPAIR WAS REPORTEDLY A LOOSE "BOOT COVER". THE SECOND REPAIR CONSISTED OF THE INSTALLATION OF A "SHIM" TO ADDRESS THE PROBLEM. NEITHER FIX TOOK CARE OF THE ISSUE LONG TERM.

Mileage: 23,000

MY VEHICLE HAS 69K MILES WITH ONLY FREEWAY DRIVING AND THE STRUTS AND BEARINGS ALREADY HAVE TO BE REPLACED. THE COST IS $900 AT THE FORD DEALERSHIP. I WAS TOLD THAT THE BEARINGS ARE WORN OUT CAUSING PROBLEMS WITH THE STRUTS. ANYTIME I WOULD DRIVE AT LOW SPEEDS YOU COULD HEAR A LOUD KNOCKING SOUND. MY NISSAN IS 12 YEARS OLD AND IT JUST NOW NEEDED SIMILAR MAINTENANCE. SOMETHING IS NOT RIGHT WITH THIS QUALITY.

Mileage: 69,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER AND DEALER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TAKATA RECALL CUANDO LO MANEJO SE MUEVE MUCHO ES DIFCIL DE CONTROLAR A 60 MILLAS PARESE UN BOTE 🚣 SE MUEVE DE LADO A LADO COMO SI PATINARA MAS EN EL FREEWAY ES MUY RIESGOSO

Mileage: 38,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

STILL WAITING FOR PARTS FOR THIS RECALL WHICH WAS ISSUED IN APRIL. THIS IS REALLY RIDICULOUS CONSIDERING THE VEHICLE IS NOT SAFE TO DRIVE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION). THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V248000 (SUSPENSION). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS INVALID. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION). THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA RECALL 16V-245 AFTER 6 MONTHS PARTS ARE STILL NOT AVAILABLE TO REPAIR WHAT COULD BE A SERIOUS SUSPENSION ISSUE. VEHICLE MAY BE UNSAFE AND IT CERTAINLY SEEMS LIKE 6 MONTHS SHOULD BE MORE THAN ENOUGH TIME TO AT LEAST START ADDRESSING THIS ISSUE. WIFE HAS BEEN AFRAID TO DRIVE THE VEHICLE.

NOTIFIED JUNE 2016 OF REAR SUSPENSION LINK THAT MAY FRACTURE WHICH MAY RESULT IN LOSS OF CONTROL. AS OF TODAY, 10/12/16 I HAVE HEARD NOTHING FROM FORD AND I AM CONCERNED ABOUT CONTINUED USE OF THE VEHICLE. HOW LONG SHOULD THIS TYPE OF REPAIR TYPICALLY TAKE?

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION). THE PART NEEDED TO REPAIR THE VEHICLE WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PART FOR THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

IN JUNE 2016, I RECEIVED A MANUFACTURERS RECALL LETTER FOR A 2014 FORD EXPLORER. RECALL NUMBER: 16S18. INDICATING THAT THE REAR SUSPENSION TOE LINK(S) MAY FRACTURE DUE TO AN IMPROPER WELD. RESULTING IN LOSS OF STEERING CONTROL, A DIFFICULT STEERING CONDITION, OR REAR SUSPENSION NOISE WITH AN INCREASED RISK OF A CRASH. IT STATED THAT WHEN PARTS ARE AVAILABLE, FORD WILL SEND A LETTER TO INFORM US TO CONTACT OUR DEALER TO SCHEDULE REPAIR. FOUR MONTHS HAVE GONE BY WITH NO WORD FROM FORD. I CALLED THE LOCAL FORD DEALER AND ASKED ABOUT THE TIMING ON THIS PARTICULAR RECALL. DEALER INFORMED ME THAT PARTS TO FACILITATE REPAIRS WERE NOT YET AVAILABLE AND THAT THEY ANTICIPATE A LETTER TO BE SENT OUT IN JANUARY OF 2017. MY COMPLAINT IS THAT 4 TO POSSIBLY 6 MONTHS OR MORE IS NOT A TIMELY COMPLETION OF WORK ASSOCIATED WITH A RECALL THAT INVOLVES SAFETY ISSUES AS SERIOUS AS LOSS OF STEERING CONTROL. SINCE THE RECALL REPAIRS HAVE NOT BEEN TIMELY, MY SAFETY OFFICER FOR THE COMPANY I WORK FOR HAS INFORMED ME THAT MY ASSIGNED VEHICLE CAN NO LONGER BE DRIVEN UNTIL THE RECALL WORK HAS BEEN COMPLETED. THIS HAS CAUSED A MAJOR HEADACHE IN DEALING WITH THE LOGISTICS OF MY JOB AND THE NEED TO USE THAT VEHICLE FOR MY FIELD-RELATED WORK, WHERE NO OTHER VEHICLE IS READILY AVAILABLE.

I HAVE CALLED THE DEALERSHIP NUMEROUS TIMES SINCE RECEIVING THE RECALL NOTICE AND THEY ARE UNABLE TO REPAIR THE VEHICLE FOR THE RECALL

Mileage: 11,610

SUSPENSION RECALL. THERE HAS BEEN A RECALL OUT FOR OVER 3 MONTHS WHICH CAN AFFECT THE STABILITY OF THE VEHICLE AND THERE IS STILL NO FIX AVAILABLE. I HAVEN'T BEEN ABLE TO DRIVE THE CAR AND CAN'T SELL IT BECAUSE NO ONE WILL BUY IT UNTIL RECALL DONE. I HAVEN'T HAD AN INDECENT YET, BUT, I WON'T DRIVE IT BECAUSE OF THE SAFETY RISKS TO MY FAMILY.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

FORD INITIATED RECALL ON 4/25/16 FOR A TOELINK SUSPENSION REPAIR. IT HAS BEEN LONGER THAN 60 DAYS AND I HAVE NOT BEEN OFFERED A REPAIR DUE TO LACK OF PARTS ACCORDING TO DISCUSSIONS WITH FORD CUSTOMER SERVICE AND MY LOCAL DEALER. I HAVE NOT BE OFFERED A TEMPORARY REPLACEMENT VEHICLE. I AM CONCERNED ABOUT SAFETY AS THE VEHICLE IS OUR PRIMARY FAMILY VEHICLE.

WE RECEIVED A RECALL LETTER CONCERNING THE REAR SUSPENSION TOE LINK. I HAVE NOT DRIVEN THIS VEHICLE SINCE RECEIVING THE LETTER. I DO NOT FEEL SAFE IN DRIVING A VEHICLE. WHEN CAN WE EXPECT A SOLUTION TO A FIX FOR THIS VEHICLE? IT IS VERY DISCOURAGING MAKING PAYMENTS ON A VEHICLE AND NOT FEEL SAFE IN DRIVING IT. THANK YOU FOR YOUR TIME. *TR

Mileage: 30,000

NHTSA RECALL NUMBER: 16V245, RECALL DATE: APR 25, 2016, FORD RECALL NUMBER: 16S18. RISK TO SAFETY: AN IMPROPERLY WELDED TOE LINK THAT FRACTURES WHILE DRIVING COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH. MANUFACTURER HAS EXCEEDED REASONABLE AMOUNT OF TIME TO REPAIR VEHICLE, ACCORDING TO RECALL NOTIFICATION THIS VEHICLE IS NOT SAFE TO DRIVE DO TO INCREASE RISK OF CRASH. ALSO HAVE COMPLAINED TO FORD FOR OVER A YEAR TO HAVE VEHICLE REPAIRED FOR EXHAUST FUMES ENTERING CABIN UPON HARD ACCELERATION. RECEIVED NUMEROUS EMAILS BACK FROM MANUFACTURER THAT THEY HAVE NO REPAIRS AVAILABLE AND IS UNWILLING EVEN TO ATTEMPT TO REPAIR. VEHICLE REMAINS PARKED IN GARAGE NOT WILLING TO DRIVE.

Mileage: 13,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION). THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 10/19/16*LJ UPDATED 11/03/16.*JB

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED A MANUFACTURER'S RECALL PERTAINING TO NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION). THE DEALER WAS UNABLE TO SUPPLY THE PARTS WITHIN A REASONABLE TIME FRAME. THE MANUFACTURER WAS UNABLE TO DETERMINE WHEN THE PARTS WOULD BE SUPPLIED TO THE DEALER. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION). THE MANUFACTURER WAS UNABLE TO DETERMINE WHEN THE PARTS WOULD BE SUPPLIED TO THE DEALER. THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

RECENTLY HAD TO REPLACE A FAILED POWER STEERING ISSUE, AND I AM READING THAT MANY OTHERS ARE HAVING THE SAME ISSUE. FORD HAS INDICATED THAT MY VEHICLE IS NOT CURRENTLY UNDER A RECALL, BUT OBVIOUSLY IT IS EFFECTING MORE VEHICLES THAN JUST THE ONES THEY HAVE RECALLED. MY VEHICLE LOST THE ABILITY TO STEER ON THE FREEWAY, PUTTING MYSELF AND MY CHILDRENS' LIVES AT RISK. THIS IS DISGRACEFUL THAT FORD WILL NOT RECOGNIZE THIS ISSUE FOR MORE THAN JUST THE SELECTED VEHICLES.

Mileage: 58,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION); HOWEVER, THE PARTS FOR THE RECALL REPAIR WERE NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. PARTS DISTRIBUTION DISCONNECT. UPDATED 08/05/16*LJ UPDATED 09/29/16.*JB

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS A MANUFACTURER RECALL ON THE SUSPENSION. THERE WAS NO PERMANENT REPAIR SOLUTION YET AND THE PART WAS NOT AVAILABLE FOR THE SUSPENSION RECALL. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V245000 (SUSPENSION). THE MANUFACTURER WAS UNABLE TO PROVIDE A REPAIR SOLUTION TO REFER THE CONTACT TO THE DEALER FOR INSPECTION AND REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

I AM HAVING A MAJOR CONCERN OVER THIS RECALL GIVEN THE FACT THAT NOTHING CAN BE DONE TO RESOLVE THIS ISSUE UNTIL THE THIRD QUARTER OF 2016. HOW CAN FORD ALLOW 75K+ DRIVERS TO DRIVE WILLINGLY KNOWING THERE MAY BE A POTENTIAL ISSUE WITH THEIR STEERING. THIS IS EVEN MORE SO OF A CONCERN FOR ME SINCE MY FAMILY AND I ARE SCHEDULED TO TRAVEL NORTH 16 HOURS TOMORROW. HEAVEN FORBID BUT WHO WILL BE RESPONSIBLE FOR DAMAGES TO MY VEHICLE OR MY FAMILY BECAUSE FORD WAS NOT PROACTIVELY PREPARED TO REMEDY THIS ISSUE? WHO WILL REIMBURSE ME FOR A RENTAL SINCE I CANNOT RELY ON MY VEHICLE I PAY GOOD MONEY FOR AND ON TIME EVERY MONTH? THIS IS MY VERY FIRST FORD VEHICLE I HAVE HAD FOR 6 MONTHS AND THIS IS THE 2ND STEERING ISSUE IVE ENCOUNTERED AND AM VERY DISAPPOINTED AND CONCERNED. JUST THREE WEEKS AGO I HAD TO HAVE MY STEERING RACK REPLACED. THIS IS JUST UNACCEPTABLE!

Mileage: 44,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE LOWER CONTROL ARM FRACTURED CAUSING THE CONTACT TO CRASH INTO ANOTHER VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. NO FURTHER DETAILS WERE AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 18,500.

Mileage: 18,500

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 5 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. AS THE CONTACT APPLIED FORCE TO THE STEERING WHEEL IN ORDER TO STEER THE VEHICLE, THE VEHICLE SUDDENLY JERKED TO THE SIDE. AS A RESULT, THE CONTACT CRASHED INTO THE REAR END OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. UPON INSPECTION, THE CONTACT NOTICED THAT THE LOWER CONTROL ARM IN THE FRONT OF THE VEHICLE HAD FRACTURED. THE CONTACT SUSTAINED MINOR BRUISES AND THE REAR PASSENGER SUSTAINED MINOR NECK BRUISES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CONTROL ARM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 18,500.

Mileage: 18,500

ON SEPTEMBER 17, 2015 PICKED MY DAUGHTER UP FROM SWIM PRACTICE AT 5:50 PM THEN WE WENT TO PICK HER FRIEND UP AND WENT ON 220 TOWARDS MILL HALL TO DROP THEM OFF AT A FOOTBALL GAME, WHILE ON HIGH WAY SMELLED AN AWFUL SMELL, THOUGHT IT WAS CAR IN FRONT OF ME, WE PROCEEDED TO MILL HALL EXIT WHERE WE GOT OFF AND TOOK THEM TO CENTRAL MOUNTAIN MIDDLE SCHOOL DROPPED THEM OFF TO A FOOTBALL GAME AND PROCEEDED THROUGH PARKING LOT WHICH IS 5 MPH OR LESS AND AT APPROXIMATELY 6:16 PM MY CAR LOCKED UP SKIDDED OVER TO CURB AND HIT THAT A COUPLE TIMES AND THEN ACROSS THE PARKING LOT WHERE IT STOPPED HALF IN MIDDLE OF ROAD. I WAITED 4 HOURS FOR A TOW TRUCK WHICH AS TOWED TO FORD GARAGE, NEXT DAY STATE POLICE LOOKED AT MY CAR BEFORE ANYONE ELSE AND DEFINITELY A FAULTY LOWER CONTROL ARM WHICH SNAPPED OFF.. ON SEPTEMBER 23, 2015 FORD GARAGE CALLED SAID FORD IS NOT GOING TO PAY FOR MY CAR OR LOOK AT IT AND I NEED TO CALL INTO MY INSURANCE COMPANY. ...UPDATED 12/29/15 *BF AFTER INSPECTING THE LOWER CONTROL ARM, IT APPEARED TO BE WEAK IN THE AREA OF THE BREAK. THERE WAS DAMAGE TO THE VEHICLE AS A RESULT OF THE BREAK, BUT NO EVIDENCE TO INDICATE ANY DAMAGE PRIOR TO THE BREAK.

Mileage: 21,600

MY GRANDSON WENT OFF THE ROAD AT 70MPH INTO SOME PINE TREES AND COMPLETLE SEVERED THE PASSAGENS WHEEL OFF AND WINDSHIELD COMPLETLE DESTROYES ROOF DAMAGE AND BODY DAMAGE AND NO AIR BAGS DEPLOYED. I TALKE TO A CUSTOMER WHO ALSO HAD A 2014 EXPLORER THAT WAS INVOLVED IN A COLLISION AND THEIR AIR BAGS DIDN'T DEPLOY EITHER .THE DAMAGE TO MY VEHICLE WAS ON THE FRONT AND THE SIDE YET NO AIRBAGE DEPLOYED. SOMETHING IS WRONG !!! ITS A MIRACLE MY GRANDSON IS ALIVE I HAVE PICTURES.

Mileage: 27,700

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT AREA OF THE VEHICLE NEAR THE BUMPER. THE NOISE WAS PRESENT WHEN THE STEERING WHEEL WAS TURNED TO THE LEFT OR RIGHT. THE DEALER COULD NOT DUPLICATE THE FAILURE INITIALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER A SECOND TIME AND THEY REPLACED THE HALF SHAFT THRUST WASHER. ON A THIRD VISIT TO THE DEALER, THEY PROVIDED A TEST DRIVE, REPLACED THE PASSENGER SIDE STRUTS, AND INSPECTED THE NUTS AND BOLTS; HOWEVER, THE NOISE CONTINUED. THE VEHICLE WAS TAKEN TO THE DEALER'S BODY SHOP. THE TECHNICIAN MOVED THE FRONT BUMPER AND REPLACED THE FRONT PASSENGER SIDE BODY APRON PANEL ALONG WITH NEW BOLTS, BUT THE NOISE CONTINUED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

Mileage: 39,000

VEHICLE WAS TRAVELING APPROXIMATELY 30-35 MPH DOWN A ROAD WITH NO POT HOLES WHEN THE FRONT RIGHT LOWER CONTROL ARM BROKE IN HALF. VEHICLE LOST CONTROL AND PULLED TO THE RIGHT BRINGING THE VEHICLE INTO THE STREET CURB. DAMAGE TO THE FENDER, TIRE, WHEEL, CV JOINT, AND OTHER ASSOCIATED PARTS REPORTED. FORD DENIES WARRANTY CLAIM....05-27-15 *BF UPDATED 10/17/2017*CN

Mileage: 10,000

TL* THE CONTACT OWNS A 2014 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS OVER 50 MPH, THE VEHICLE WOULD BEGAN TO SHAKE AND VIBRATE. THE CONTACT INDICATED THAT THE VIBRATION APPEARED TO COME FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE CAUSE OF THE VIBRATION COULD NOT BE DETERMINED. THE REAR TIRES WERE BALANCED AND REPLACED, BUT THE FAILURE RECCURRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 300.

Mileage: 300

TO AVOID HITTING ANOTHER VEHICLE THAT ILLEGALLY CAME INTO THE LANE I WAS ENTERING (THEY WERE DRIVING ON THE SHOULDER), I HAD TO TAKE EVASIVE ACTION, WHICH CAUSED ME TO TURN MY VEHICLE INTO A CURB. AT THE TIME, I WAS TRAVELING 15 TO MAYBE 20 MPH. AFTER HITTING THE CURB, MY VEHICLE CAME TO A STOP AND UPON INSPECTION I DISCOVERED THAT THE LOWER CONTROL ARM HAD COMPLETELY BROKEN IN HALF. MY VEHICLE WAS TOWED TO A LOCAL DEALERSHIP, WHERE THEY SUBSEQUENTLY SERVICED THE VEHICLE, WHICH I PICKED UP ON MARCH 15, 2014. HOWEVER, WITHIN 100 MILES OF DRIVING, MULTIPLE SYSTEM ERRORS OCCURRED, AND MY STEERING WENT OUT. THE DEALERSHIP IS NOW SAYING THERE WAS APPARENTLY AN ISSUE WITH THE STEERING GEAR ASSEMBLY, AND THAT THEY WILL BE ABLE TO FURTHER DIAGNOSE UPON REPLACING THAT PART. MY CONCERN IS THE SAFETY OF THE VEHICLE AND SPECIFICALLY THAT I DO NOT THINK A CONTROL ARM SHOULD SNAP IN HALF AT THAT SPEED, PARTICULARLY IN A SUV THAT HAS AN UPGRADED SUSPENSION AS PART OF THE TRIM PACKAGE. *TR

Mileage: 5,677