2022 FORD F-150 HYBRID Problems & Recalls
Detailed safety information and owner complaints
Problem Breakdown
Compare to Other Years
Common Problems
When I started my 2022 Ford F-150 equipped with the Bang & Olufsen (B&O) sound system, a sudden extremely loud “sonic boom” noise came through the speakers without warning. The sound was so intense it caused immediate pain in my ears, and I am concerned about the possibility of permanent hearing...
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving approximately 30 MPH downhill, the vehicle stalled. The contact sh...
Mileage: 34,000
The contact owns a 2022 Ford F-150. The contact stated that the front driver’s side headlamp failed to illuminate as needed. The contact stated that the dealer had previously replaced the passenger’s side headlamp. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. T...
Mileage: 40,000
The moonroof leaks causing water to spill into the cabin thru the headliner flowing onto the dash and coming into contact with electrical equipment dome lights infotainment system and could cause a potential issue with water and electrical system!!!
I was driving down the road and heard a loud clunking noise. Then I had lost power and the rear wheels were spinning out of control. There was a grinding/spinning/whirring noise coming from beneath the vehicle, sounded like from behind. I was fortunately able to regain control of the vehicle by s...
Was stopped behind a car in line in the parking lot. The truck was in drive with the auto hold brake feature enabled. The auto hold disengaged and the car rolled forward rear ending the car in front of me. Collision alert didn't sound as expected. A similar recall came out August 6 for 2025 F150s.
Was stopped behind a car in line in the parking lot. The truck was in drive with the auto hold brake feature enabled. The auto hold disengaged and the car rolled forward rear ending the car in front of me. Collision alert didn't sound as expected. A similar recall came out August 6 for 2025 F150s.
Was stopped behind a car in line in the parking lot. The truck was in drive with the auto hold brake feature enabled. The auto hold disengaged and the car rolled forward rear ending the car in front of me. Collision alert didn't sound as expected. A similar recall came out August 6 for 2025 F150s.
On July 30, 2025, as I was pulling onto the highway, my audio system started blaring noise from all the speakers in the vehicle. This noise was unbearably loud to the point I had to pull off the road. The noise coming from the speaker system was so loud that it was visibly shaking the door panels ...
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time ...
The contact owns a 2022 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 23V896000(Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving at various undisclosed speeds, the ve...
Mileage: 33,000
The contact owns a 2022 Ford F-150. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (Fuel System, Gasoline) and 23V896000(Power Train); however, the part to do the recall repair was not yet available. The contact stated that while driving at various undisclosed speeds, the ve...
Mileage: 33,000
The vertical portion of the DRL stopped working. Looking online it looks like the LED bulb melts the light housing covering up the LED. I see many reports of this problem on forums and some have the vertical and horizontal strips do this so they lose DRL on that side of the truck.
The front daytime running lights are out and not replacable. Ford said they cannot repair the led and need to replace the entire headlight. This is a safety issue for me and my passengers as other cars might not see us especially in certain weather or lighting. Two Rivers Ford inspected the vehicle...
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The co...
Mileage: 6,795
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The co...
Mileage: 6,795
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacture...
Day time running lamps on the side of the headlight have burnt out. First time it was the passenger side that died, had it replaced under warranty. then a few month later after my warranty was up, the driver side has now died as well. The fact I have had this truck 2 and a half year and both have fa...
Day time running lamps on the side of the headlight have burnt out. First time it was the passenger side that died, had it replaced under warranty. then a few month later after my warranty was up, the driver side has now died as well. The fact I have had this truck 2 and a half year and both have fa...
At times mainly turning Right or Left you have no acceleration while pushing the gas pedal. Its like the pedal is dead and then all of sudden it kicks in and accelerates abruptly. Huge safety hazard in multiple ways.
The contact owns a 2022 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle independently accelerated, and the contact heard an abnormal sound. The contact stated that the transmission upshifted from third gear into fifth gear. The contact stated that occasionally while...
Mileage: 52,000
The contact owns a 2022 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle independently accelerated, and the contact heard an abnormal sound. The contact stated that the transmission upshifted from third gear into fifth gear. The contact stated that occasionally while...
Mileage: 52,000
The contact owns a 2022 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle independently accelerated, and the contact heard an abnormal sound. The contact stated that the transmission upshifted from third gear into fifth gear. The contact stated that occasionally while...
Mileage: 52,000
On Sunday, [XXX], my truck spontaneously burst into flames while parked in my front yard. I had just returned from doing a number of errands. The truck had been running fine with no indications of a problem. I was outside tending to my smoker when I heard a sort of popping/crackling noise. I looked ...
On Sunday, [XXX], my truck spontaneously burst into flames while parked in my front yard. I had just returned from doing a number of errands. The truck had been running fine with no indications of a problem. I was outside tending to my smoker when I heard a sort of popping/crackling noise. I looked ...
On Sunday, [XXX], my truck spontaneously burst into flames while parked in my front yard. I had just returned from doing a number of errands. The truck had been running fine with no indications of a problem. I was outside tending to my smoker when I heard a sort of popping/crackling noise. I looked ...
Vehicle started screeching at a high pitch deafening tone. It terrified me and has made my ears ring and hurt all day....went and had a hearing test done and I now have mild hearing loss...will go back in two weeks to test it again. I pulled over and turned radio and truck off....and it still keep...
Drl is half burnt out. The led is not replacable and drl is a part of a safety item that is required to be road legal. Not only has my 2022 f150 lariat with the quad led headlights have this drl led burnt out, many on the f150 forums and facebook groups for 2021-2023 are having the same exact issue....
Unbearably loud ear piercing static from speakers. Unable to turn it off or lower volume. Volume controls didn’t work. Ears in major pain from the noise. I have video of the noise but don’t seem able to upload.
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time ...
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (POWER TRAIN); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The deale...
Mileage: 15,000
Recall # 23V896 was sent to me on January 2024 and 14 months later still no parts available for the repair. Risk are the vehicle may roll in park and lose power while driving. I have already had one of the bolts break and it was replaced with a new defective bolt because replacements ( non - defecti...
After driving home from work on 12/20/24 the truck was parked at ~10pm. At ~1AM on 12/21/24, I was alerted that the truck was on fire. I found the vehicle fully engulfed in the hood and cab area. There was no prior indication of a problem or issue. The truck was fully destroyed and my home and Jeep ...
After driving home from work on 12/20/24 the truck was parked at ~10pm. At ~1AM on 12/21/24, I was alerted that the truck was on fire. I found the vehicle fully engulfed in the hood and cab area. There was no prior indication of a problem or issue. The truck was fully destroyed and my home and Jeep ...
After driving home from work on 12/20/24 the truck was parked at ~10pm. At ~1AM on 12/21/24, I was alerted that the truck was on fire. I found the vehicle fully engulfed in the hood and cab area. There was no prior indication of a problem or issue. The truck was fully destroyed and my home and Jeep ...
today is March 13, 2025. Ford Motor Co promised to make parts available to repair this truck's axle as part of Manufacturer Recall 23S65 (NHTSA Recall Number23V896) by this month, March 2025. With 17 days left in the month, I have received no information regarding any possible future repair. Please ...
The manufacturer has failed to remedy this safety recall for my F-150 vehicle in a timely manner. Ford initially identified the axle bolt fault as Customer Satisfaction Program 22B34 on Feb. 14, 2023 to a limited range of vehicles but then expanded the action as a recall notification 23S65 on Dec. ...
NHTSA states to file a complaint if there has been no remedy in reference to a safety recall in a timely manner. As of to date there is still an open recall on my truck and Ford has stated the recall is incomplete due to no remedy yet available. This recall has been in place since 12/22/23. My truck...
NHTSA states to file a complaint if there has been no remedy in reference to a safety recall in a timely manner. As of to date there is still an open recall on my truck and Ford has stated the recall is incomplete due to no remedy yet available. This recall has been in place since 12/22/23. My truck...
The 7 pin trailer connecton doesn't work properly. The trailer clearance lights are on all the time. Even with the truck lights off. The electric brake controller pulses electric to the trailer brakes. Even when there is no trailer connected and the truck not running. The trailer brakes locked...
The 7 pin trailer connecton doesn't work properly. The trailer clearance lights are on all the time. Even with the truck lights off. The electric brake controller pulses electric to the trailer brakes. Even when there is no trailer connected and the truck not running. The trailer brakes locked...
1. Transmission. Auxiliary transmission fluid pump. 2. Yes. 3. No. 4. No. 5. No. Stopped at a traffic light, first inline near crosswalk. For no apparent reason, the vehicle jumped forward without any input from myself. Thought I was rear ended by someone behind me. Luckily, I always have...
The contact owns a 2022 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal sound coming from the rear end of the vehicle. The contact stated that upon inspection, the contact became aware of fluid leaking from a crack in the exhaust system caused by rust. The vehicl...
Mileage: 58,000
the blue cruise hands free driving feature does not work and has guided the vehicle off of the road. It also asks the driver to take the steering wheel, but will not register that has happened without a very hard pull on the wheel, which pulls the vehicle into other lanes of traffic. this is a very ...
the blue cruise hands free driving feature does not work and has guided the vehicle off of the road. It also asks the driver to take the steering wheel, but will not register that has happened without a very hard pull on the wheel, which pulls the vehicle into other lanes of traffic. this is a very ...
the blue cruise hands free driving feature does not work and has guided the vehicle off of the road. It also asks the driver to take the steering wheel, but will not register that has happened without a very hard pull on the wheel, which pulls the vehicle into other lanes of traffic. this is a very ...
The navigation, information, and control screen in this vehicle randomly shuts down and reboots. often when using the reverse and 360 camera system. Ford has said they will not work on these systems as they are faulty, and has promised a software revision for over 6 months. The dealers report that t...
There is a problem with the heating controls. The temperature will be set at 72 and is stable for awhile, even days, then will spontaneously heat until it's unbearably hot. This is a huge distraction while driving to having to keep messing with the controls. Safety issue! After numerous complaint...
Driving down the highway and all of a sudden the speakers made a sound like a gun going of then they all started popping at a deafening level. Was unable to focus or hear anything and almost was hit by another car before I could get safely pulled over, sat for nearly 2 hours turning on ignition peri...
The truck was involved in a major crash, but none of the airs deployed. The accident took place on 1/29/2025. A shed not tied down blew off a trailer into my truck.
While driving this past weekend 24-26 January 2025, my vehicle's tailgate dropped on its own while driving. The first two instances I discovered the tailgate down when I arrived at my destination. While I only had a few light items in my truck bed, this could have been catastrophic as I was travelin...
The contact owns a 2022 Ford F-150. The contact stated while driving at undisclosed speeds, there was an abnormal sound coming from the rear of the vehicle. The vehicle was taken to the dealer, where it was diagnosed and determined that the rear axle bolt was faulty, and the rear axles needed to be ...
Mileage: 60,000
When at a signal light with the brake pushed, we are experiencing an issue where the whole vehicle will unexpectedly lurch forward as if hit from behind after coming to a stop. This could possibly result in the truck hitting the vehicle in front of you if you are in tight traffic. Our local dealer ...
When at a signal light with the brake pushed, we are experiencing an issue where the whole vehicle will unexpectedly lurch forward as if hit from behind after coming to a stop. This could possibly result in the truck hitting the vehicle in front of you if you are in tight traffic. Our local dealer ...
When at a signal light with the brake pushed, we are experiencing an issue where the whole vehicle will unexpectedly lurch forward as if hit from behind after coming to a stop. This could possibly result in the truck hitting the vehicle in front of you if you are in tight traffic. Our local dealer ...
This is the 3rd time this has happened since purchasing this vehicle. Purchased on 7/27/24. The previous 2 times it resolved itself and the vehicle started and ran with no apparent issues afterwards.1st was on 8/05/24, 2nd was on 10/14/24. On this 3rd and current time I went to start the vehicle a...
This is the 3rd time this has happened since purchasing this vehicle. Purchased on 7/27/24. The previous 2 times it resolved itself and the vehicle started and ran with no apparent issues afterwards.1st was on 8/05/24, 2nd was on 10/14/24. On this 3rd and current time I went to start the vehicle a...
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time ...
Mileage: 30,000
on January 20, 2024 I serviced my F-150 due to a malfunction. The DTC code came back as P0A1E-00. This is for the Starter/Generator Control Module. The belt and starter were reaplaced. The code appeared again on 12/21/24 2 times, 12/25/24, 12/26/24 2 times. I brought this back to the dealer on ...
on January 20, 2024 I serviced my F-150 due to a malfunction. The DTC code came back as P0A1E-00. This is for the Starter/Generator Control Module. The belt and starter were reaplaced. The code appeared again on 12/21/24 2 times, 12/25/24, 12/26/24 2 times. I brought this back to the dealer on ...
Incredible load white noise from all speakers, unable to stop without turning truck off. Volume controls do nothing, turning off all radios and accessories does not stop it.
While driving my entire dashboard went off. No speedometer, No Tach, No fuel gauge, No odometer, nothing. Replaced appropriate fuse still out. Vehicle has just over 36,000 miles
While driving my entire dashboard went off. No speedometer, No Tach, No fuel gauge, No odometer, nothing. Replaced appropriate fuse still out. Vehicle has just over 36,000 miles
HVAC temperature does not regulate in the winter months. When the temperature is set to the 60’s the vehicle continues to blow air in the 80’s. It gets extremely hot and the only way to cool down is by setting the temperature to low, turning on the a/c, or opening a window. This is with ambient ...
Two times the wheel end hub bolt on my left rear axle broke off. The first time the car was under warranty before the recall and the dealer provided a car for me to use while the truck was in the shop. This past week no vehicle or rental car was provided. The repair will take over one week to be com...
What component or system failed or malfunctioned, and is it available for inspection upon request? The rear backup camera fails to show in the display and/or freezes. This happens inconsistently so it is not easy to reproduce. How was your safety or the safety of others put at risk? When backing u...
PASSENGER SIDE REAR AXLE BOLT BROKE. Ford says the broken bolt could result in loss of drive power putting drivers or others at risk. Local Ford dealer confirmed axle failure and asked me to not drive the vehicle until they could get a replacement axle assembly installed which could take 1-4 weeks...
The contact owns a 2022 Ford F-150. The contact stated while driving 65 MPH at midnight, there was an abnormally loud grinding and clunking sound coming from the rear of the vehicle. The contact was able to veer to the side of the road. The contact inspected the vehicle, but could not determine the ...
Mileage: 52,000
Loss of Acceleration in 2022 Ford F-150 PowerBoost Hybrid I am writing to report a safety issue with my 2022 Ford F-150 PowerBoost Hybrid, which has been experiencing acceleration lag and loss of power during regular driving conditions. Component/System that Failed: The powertrain system, specific...
Loss of Acceleration in 2022 Ford F-150 PowerBoost Hybrid I am writing to report a safety issue with my 2022 Ford F-150 PowerBoost Hybrid, which has been experiencing acceleration lag and loss of power during regular driving conditions. Component/System that Failed: The powertrain system, specific...
Loss of Acceleration in 2022 Ford F-150 PowerBoost Hybrid I am writing to report a safety issue with my 2022 Ford F-150 PowerBoost Hybrid, which has been experiencing acceleration lag and loss of power during regular driving conditions. Component/System that Failed: The powertrain system, specific...
When traveling at low speeds, 10-15 mph, and coasting (no accelerator input) then pressing the accelerator there is no response. The engine will not rev up and the truck will not accelerate for a good 6-8 seconds. It happens usually in parking lots or when making low speed turns onto street intersec...
When traveling at low speeds, 10-15 mph, and coasting (no accelerator input) then pressing the accelerator there is no response. The engine will not rev up and the truck will not accelerate for a good 6-8 seconds. It happens usually in parking lots or when making low speed turns onto street intersec...
On 14 September, at approximately 11am, I rear ended another vehicle a Honda Pilot. I anticipated the vehicle in front of me pulling out into the intersection and took my eyes off that vehicle to look at vehicles approaching from my left. The vehicle in front of me stopped and I hit them moving less...
On 14 September, at approximately 11am, I rear ended another vehicle a Honda Pilot. I anticipated the vehicle in front of me pulling out into the intersection and took my eyes off that vehicle to look at vehicles approaching from my left. The vehicle in front of me stopped and I hit them moving less...
On 14 September, at approximately 11am, I rear ended another vehicle a Honda Pilot. I anticipated the vehicle in front of me pulling out into the intersection and took my eyes off that vehicle to look at vehicles approaching from my left. The vehicle in front of me stopped and I hit them moving less...
I started my 2022 F150 with B/O Audio and an extremely loud blast that sounded like a cannon shot out of the speakers. My volume dial didn't work and loud crackling and popping sounds were coming out of the tweeter speakers. This has been reported many times already. Turning the audio and the entire...
I started my 2022 F150 with B/O Audio and an extremely loud blast that sounded like a cannon shot out of the speakers. My volume dial didn't work and loud crackling and popping sounds were coming out of the tweeter speakers. This has been reported many times already. Turning the audio and the entire...
My vehicle lurches forward at low speeds which presents a collision risk. The check engine light illuminated and I received the following alert in the FordPass app: The powertrain control system has detected the transmission fluid auxiliary pump motor did not come on when commanded. The vehicle’s ...
Another Ford F150 Supercrew leak from the front cowling area into the passenger floorboards. This is a 2022 Hybrid F150 Supercrew built during COVID and purchased March 9, 2022. There are too many reports online of leaks due to lack of sealing components where large aluminum parts meet. For examp...
Another Ford F150 Supercrew leak from the front cowling area into the passenger floorboards. This is a 2022 Hybrid F150 Supercrew built during COVID and purchased March 9, 2022. There are too many reports online of leaks due to lack of sealing components where large aluminum parts meet. For examp...
Another Ford F150 Supercrew leak from the front cowling area into the passenger floorboards. This is a 2022 Hybrid F150 Supercrew built during COVID and purchased March 9, 2022. There are too many reports online of leaks due to lack of sealing components where large aluminum parts meet. For examp...
I was driving on the busiest section of interstate in my city which goes up a bit of an incline. I was in the left lane. As I was going up the incline, the RPMs on my truck jumped way up and then I lost all power. My dash lit up with a red message saying "STOP SAFELY NOW" and I had no propulsion at ...
The contact owns a 2022 Ford F-150. The contact stated while driving approximately 15 MPH, the message "Failure Trailer Brake Module" was displayed on the instrument panel. The contact stated that the turn signal was flashing constantly. The vehicle was taken to an independent mechanic where it was ...
Mileage: 42,000
The contact owns a 2022 Ford F-150. The contact stated while driving at various speeds, there was an abnormal sound coming from the transmission. The contact stated that the vehicle independently switched gear and would occasionally roll away. No warning light was illuminated. The vehicle was taken ...
Mileage: 15,000
Component: The B&O Unleashed speaker system upon turning vehicle on, put out this extremely loud pop and then extremely load crackling noise followed by extremely loud constant noise that only stopped when vehicle is turned off. Health: Ears are still ringing causing terrible headaches. Dealer: No...
Reduce power warning, instrument cluster is black, extremely loud pulse noise from radio that can not be turned off , catalytic converter issue ( ck engine light ) stalled in traffic. and horrible fuel mileage. Nothing resolved from the dealer.
Reduce power warning, instrument cluster is black, extremely loud pulse noise from radio that can not be turned off , catalytic converter issue ( ck engine light ) stalled in traffic. and horrible fuel mileage. Nothing resolved from the dealer.
Reduce power warning, instrument cluster is black, extremely loud pulse noise from radio that can not be turned off , catalytic converter issue ( ck engine light ) stalled in traffic. and horrible fuel mileage. Nothing resolved from the dealer.
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of ti...
Clicking noise began at 32,000 miles. Heard when brakes applied, then heard again when accelerating from a stop. Dealership needed the truck 4 different times to diagnose the problem. Entire differential needs to be replaced
The driver's side rear shock mounting bracket weld broke. This creates a suspension and safety problem as the rear bracket and shock are moving and could interfere with the wheel/axle. The problem was confirmed by a dealer and independent service center. An engineer from Ford Motor Co. inspected the...
I have confirmed that my passenger side rear axle bolt has sheared off and I am concerned about the safety of driving my truck. I need a remedy, I have contacted Asheville, NC Ford dealership, they said they would talk to a manager and get back to me. I am concerned about my safety with continued us...
Vehicle loss of power!! After turning occasionally I will only have enough power to remain at low low speed. Sometimes having to pull over to side of the road because I can’t gain speed and traffic is coming quickly. Problem lasts 30 seconds or more before it kicks in. Doesn’t matter if my foot...
My truck has BlueCruise technology. I have noted that the technology can be dangerous and drive me off the road, particularly in an area of an Interstate I drive often. Each time I go through that area, it will drive me off the road if I don't catch it. Always in the same place and in the same wa...
My truck has BlueCruise technology. I have noted that the technology can be dangerous and drive me off the road, particularly in an area of an Interstate I drive often. Each time I go through that area, it will drive me off the road if I don't catch it. Always in the same place and in the same wa...
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 23V896000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contac...
Mileage: 35,000
-The surround sound speaker system has produced a load popping sound as if being struck by lightning on several occasions upon starting the truck. It is extremely loud and normally goes away after a few seconds. The most recent incident occurred while I was driving and did not stop for several min...
We have been stranded twice for the recall issued in late January 2024, for the rear axle. The truck is currently at the 5th dealership since January2024. The truck is not driveable and Ford still does not have a way to fix the issue. We are having the axle replaced for the second time by a For...
We have been stranded twice for the recall issued in late January 2024, for the rear axle. The truck is currently at the 5th dealership since January2024. The truck is not driveable and Ford still does not have a way to fix the issue. We are having the axle replaced for the second time by a For...
I am having multiple electrical glitches with the vehicle. While I was in bluecruise the self driving mode the vehicle warned me to take control and when I did the vehicle was stuck in a loop on the highway with notifications alarms. I was able to take a video one of the times. I took it to the ford...
I am having multiple electrical glitches with the vehicle. While I was in bluecruise the self driving mode the vehicle warned me to take control and when I did the vehicle was stuck in a loop on the highway with notifications alarms. I was able to take a video one of the times. I took it to the ford...
I am having multiple electrical glitches with the vehicle. While I was in bluecruise the self driving mode the vehicle warned me to take control and when I did the vehicle was stuck in a loop on the highway with notifications alarms. I was able to take a video one of the times. I took it to the ford...
This 2021 F150 is equipped with Ford BlueCruise. More than one time the truck has tried to leave the road while engaged. It also has a very dangerous trait - when the BlueCruise is active and the system wants the driver to take control, THE AMOUNT OF FORCE IT TAKES TO TAKE CONTROL OF THE STEERING ...
This 2021 F150 is equipped with Ford BlueCruise. More than one time the truck has tried to leave the road while engaged. It also has a very dangerous trait - when the BlueCruise is active and the system wants the driver to take control, THE AMOUNT OF FORCE IT TAKES TO TAKE CONTROL OF THE STEERING ...
This 2021 F150 is equipped with Ford BlueCruise. More than one time the truck has tried to leave the road while engaged. It also has a very dangerous trait - when the BlueCruise is active and the system wants the driver to take control, THE AMOUNT OF FORCE IT TAKES TO TAKE CONTROL OF THE STEERING ...
After coasting or turning I lose all ability to accelerate for a short period of time. When trying to merge the truck fails to speed up causing a dangerous situation where traffic jams up behind you
Vehicle's engine will not start. When attempting to start, it will turn on all usual electrical components, but will immediately show an warning message to "Stop Safely Now" along with an engine light of a red outlined truck with exclamation mark. Followed by a message of accessory mode on, howeve...
Vehicle's engine will not start. When attempting to start, it will turn on all usual electrical components, but will immediately show an warning message to "Stop Safely Now" along with an engine light of a red outlined truck with exclamation mark. Followed by a message of accessory mode on, howeve...
Vehicle's engine will not start. When attempting to start, it will turn on all usual electrical components, but will immediately show an warning message to "Stop Safely Now" along with an engine light of a red outlined truck with exclamation mark. Followed by a message of accessory mode on, howeve...
While driving to work a car crossed over two lanes and pulled in front of me, I had to slam on the brakes to avoid a collision. The truck applied the brakes and that was avoided but at that moment my dash lights came on, no ABS, brake light, engine lights, and traction control all lit up. I was n...
Recently completed the safety recall for my 2022 F150 axle bolt replacement. The dealer informed me that this is a "repair" and not a solution to why the axle bolt broke leading to replacement of both the left and right axle shafts. My dealer service manager told me Ford does not have a permanent ...
Vehicle will not start. Get "Stop safely now" message. It is 16 degrees outside. What if this had happened while I was out. This would be a life threatening problem. This appears to be a known issue, but Ford has not fixed it. There are hundreds of reports on various forums of the same problem.
Vehicle will not start. Get "Stop safely now" message. It is 16 degrees outside. What if this had happened while I was out. This would be a life threatening problem. This appears to be a known issue, but Ford has not fixed it. There are hundreds of reports on various forums of the same problem.
In park changed mode to 4A and moved shifter to reverse no reverse. Truck in electric mode then engine started and reverse activated. Upon stop shifted to drive and truck would not move. Engine started then truck moved.
Loud popping coming from the pillar and roof speakers after shutting the vehicle off, it scared me to death, this can cause accidents.
Loud popping coming from the pillar and roof speakers after shutting the vehicle off, it scared me to death, this can cause accidents.
Broken bolt in passenger side rear axel. While pulling off the tire the bolt fell to the ground. It is evident it had been broken for quite some time. I think it prevents lateral movement of the axel.
AUDIO SYSTEM CREATES LOUD POPS AND STATIC NOISE, INTERMITTENT, CONTINUES WITH AUDIO OFF, DISCONTINUES WITH VEHICLE OFF. LOUD ENOUGH NOISE TO BE A HAZARD WHILE DRIVING.
Axle bolt was shredded off and making a clanking sound while driving. They replaced the axle. Should have gone ahead and replaced both sides because the other axle bolt will also break soon and is a huge liability.
The contact owns a 2022 Ford F-150. The contact stated while operating the vehicle, the air conditioner blower intermittently malfunctioned and would not blow air through the air vents. During the failure the front windshield could not be defogged or defrosted, creating a visibility hazard for the d...
Mileage: 3,000
Horrific noise made by sound system? I have the video as proof of needed? I'm glad it occured when the vehicle was parked.
My 2022 Ford F150 Powerboost Hybrid has the Max Tow Axle option. A known defect is that the LH and RH Axle bolts break early in the life of the vehicle. The failure is a tensile failure in the bolt causing the head to essentially pop off, rendering the vehicle unsafe to drive. I have had (1) of thes...
While in 4A, at a stop the vehicle lurched forward. This repeated 5 times having come to a stop with brake pedal depressed or not (autohold). Check engine light came on at some point for auxiliary transmission pump motor did not come on. Started after having truck serviced and pcm reprogrammed. Back...
When sitting at a stop light/stop sign/a complete stop, the truck will switch to electric mode... after about five to seven seconds, the truck "jumps" -- if feels like you just got rear ended. Truck currently at the dealership with no known ETA on repair.
When sitting at a stop light/stop sign/a complete stop, the truck will switch to electric mode... after about five to seven seconds, the truck "jumps" -- if feels like you just got rear ended. Truck currently at the dealership with no known ETA on repair.
When sitting at a stop light/stop sign/a complete stop, the truck will switch to electric mode... after about five to seven seconds, the truck "jumps" -- if feels like you just got rear ended. Truck currently at the dealership with no known ETA on repair.
1) The rear axle bolt failed on my Max Tow equipped truck, the bolt head and washer broke off and were rattling around in the wheel. 2) The rear axle bolt secures the axle to the knuckle/hub and transmit power from the differential to the wheels. Without this bolt the axle could fall away from the ...
Again today 12/3/23 the sync 4 screen upon startup froze in a gray screen for minutes then restated rendering the Federally Mandated Tear Camera 100% inoperable. Nothing worked for minutes a safety hazard not being able to see and move
Again today 12/3/23 the sync 4 screen upon startup froze in a gray screen for minutes then restated rendering the Federally Mandated Tear Camera 100% inoperable. Nothing worked for minutes a safety hazard not being able to see and move
This horrifyingly loud rhythmic noise came out of my speakers yesterday. I have a F-150 Platinum with B&O Stereo system. My ears felt like they were bleeding and I actually experienced pain due to how loud the noise was. It happened when my truck was parked and I went to start it and the deafening n...
This horrifyingly loud rhythmic noise came out of my speakers yesterday. I have a F-150 Platinum with B&O Stereo system. My ears felt like they were bleeding and I actually experienced pain due to how loud the noise was. It happened when my truck was parked and I went to start it and the deafening n...
Loud pop from sound system is back again, and did it so loud scared the crap out of a passenger, this is beyond dangerous, the software update didn’t work, Ford denies any issues at all exist on anything.
Loud pop from sound system is back again, and did it so loud scared the crap out of a passenger, this is beyond dangerous, the software update didn’t work, Ford denies any issues at all exist on anything.
Power train is pathetic, Ford has a software fix, that isn’t the issue. NHTSA [XXX], and force a recall if you research you will see across all platforms the 10R80 is failing, clutch blowing, Ford has known for years you morons. Power train isn’t safe, fuel economy has tanked on this truck INFOR...
Parked running boards do. Or always go up, lighting stays on for 10 min, have to go play with on/off over and over and to get it to shutoff. On the HwY BC shuts off out of nowhere, and ping pongs back and forth. Get messages saying drivetrain failure, steering failure go to the Dealer naturally. Not...
Parked running boards do. Or always go up, lighting stays on for 10 min, have to go play with on/off over and over and to get it to shutoff. On the HwY BC shuts off out of nowhere, and ping pongs back and forth. Get messages saying drivetrain failure, steering failure go to the Dealer naturally. Not...
Parked running boards do. Or always go up, lighting stays on for 10 min, have to go play with on/off over and over and to get it to shutoff. On the HwY BC shuts off out of nowhere, and ping pongs back and forth. Get messages saying drivetrain failure, steering failure go to the Dealer naturally. Not...
I had warranty work done on a trailer brake module on October 23, 2023. About 3 weeks after that it seemed like my transmission was a little rough. Then Nov. 6, I had several incidences where I was at a stop, and it felt like someone hit me from behind and lurch my truck forward a little bit. It see...
I had warranty work done on a trailer brake module on October 23, 2023. About 3 weeks after that it seemed like my transmission was a little rough. Then Nov. 6, I had several incidences where I was at a stop, and it felt like someone hit me from behind and lurch my truck forward a little bit. It see...
I had warranty work done on a trailer brake module on October 23, 2023. About 3 weeks after that it seemed like my transmission was a little rough. Then Nov. 6, I had several incidences where I was at a stop, and it felt like someone hit me from behind and lurch my truck forward a little bit. It see...
Right rear main axle bolt sheared and separated from the axle. I am concerned the wheel and hub could separate. Customer Satisfaction Program 22B34 may apply, but the dealer is not certain but is looking into it. filing this report as this seems like a serious flaw.
This 2022 Ford f150 has experienced the exact failure shown in ford CSP 22B34. The right rear axle securing bolt has sheared. The CSP applies to trucks built through Sept. 30 2021. This truck was built in Dearborn, in November - BUT has had the exact failure. I am concerned Ford has under estimated ...
B&O sound system loud scary pops and static, Sync 4 screen goes blank while driving, also blank sometimes for minutes at startup, I have had it come on, watch the 360 camera begin to backup and look in the mirror the camera lags not showing the car behind me. Constant messages of steering failure, c...
B&O sound system loud scary pops and static, Sync 4 screen goes blank while driving, also blank sometimes for minutes at startup, I have had it come on, watch the 360 camera begin to backup and look in the mirror the camera lags not showing the car behind me. Constant messages of steering failure, c...
I was driving south on Interstate 5 near Stockton CA and I noticed an awful sound coming from the back of my truck. When I gave it more throttle nothing was happening, my truck was slowing down, the more throttle I gave it the louder the grinding noise got. My truck was slowing down to a crawl, and ...
I was driving south on Interstate 5 near Stockton CA and I noticed an awful sound coming from the back of my truck. When I gave it more throttle nothing was happening, my truck was slowing down, the more throttle I gave it the louder the grinding noise got. My truck was slowing down to a crawl, and ...
Fuel door seating pin fell out. With the fuel door closed getting notices that the Fuel Door is Ajar and the check engine light is on.
Auxiliary transmission pump failure code - P0C2A. Accompanied by a very hard slam and lurch forward after a complete stop. Lurch and slam coward is very abrupt and when it first happened I believed it was a rear end collision.
The contact owns a 2022 Ford F-150. The contact stated that while driving at 5 MPH, the instrument panel went black. The speakers made a loud abnormal sound which distracted the driver. No warning light was illuminated. The vehicle was taken to a dealer to be diagnosed; however, the vehicle had not ...
Mileage: 7,000
The contact owns a 2022 Ford F-150. The contact stated that while driving at 5 MPH, the instrument panel went black. The speakers made a loud abnormal sound which distracted the driver. No warning light was illuminated. The vehicle was taken to a dealer to be diagnosed; however, the vehicle had not ...
Mileage: 7,000
An axle bolt on the drivers side rear axle has sheared off rendering the truck unsafe to drive.
Sync 4 with the B&O unleashed system. Yes anytime. Extremely loud noises came from speakers upon startup of engine. It continued for several minutes accompanied by loud static as well. Ears hurt for hours after. This happened with 2700 miles on speedometer. Has happened 2 more times since. Dealer ac...
Passenger side rear axle bolt, that holds the axle shaft in place, sheared off, which could allow the axle shaft to move inside the axle housing. I'm learning that this is EXTREMELY common on 2021-2023 9.75" 3:73 MAX TOW axle.
Axle bolt holding the rear wheel assembly onto the axle have broken and the bolt head was rattling around loose inside the wheel.
Axle bolt holding the rear wheel assembly onto the axle have broken and the bolt head was rattling around loose inside the wheel.
Rear axel bolt broke, splines on axel stripped off. Truck lost ability to drive while on the highway , creating a dangerous situation. Now truck is at the dealer waiting on parts keeping me from doing my job and causing further financial hardship. For a known issue Ford should have a recall.
Rear axle retaining bolt sheered off. Issue was discovered during routine tire rotation at dealership 9/29/23. I will not have parts available as dealership keeps old parts. There were no warning indications of this issue. This is a known issue listed as Ford CSP 22B34 which instructs dealers to re...
The contact owns a 2022 Ford F-150. The contact stated while driving at slow speeds and making a left turn, the vehicle failed to accelerate as needed. The vehicle was restarted and worked as designed. The navigation system screen had frozen. While opening the sunroof, the deflector detached. While ...
Mileage: 13,696
The contact owns a 2022 Ford F-150. The contact stated while driving at slow speeds and making a left turn, the vehicle failed to accelerate as needed. The vehicle was restarted and worked as designed. The navigation system screen had frozen. While opening the sunroof, the deflector detached. While ...
Mileage: 13,696
The contact owns a 2022 Ford F-150. The contact stated while driving at slow speeds and making a left turn, the vehicle failed to accelerate as needed. The vehicle was restarted and worked as designed. The navigation system screen had frozen. While opening the sunroof, the deflector detached. While ...
Mileage: 13,696
Ford is non-responsive in fixing 3 recalls for my vehicle. I have been attempting to get a repair scheduled for over 6 months and keep getting told I will eventually get a call.
Ford is non-responsive in fixing 3 recalls for my vehicle. I have been attempting to get a repair scheduled for over 6 months and keep getting told I will eventually get a call.
Ford is non-responsive in fixing 3 recalls for my vehicle. I have been attempting to get a repair scheduled for over 6 months and keep getting told I will eventually get a call.
I have a hybrid powertrain. When the vehicle is in normal mode (hybrid mode - engine off) and I am at a stop after about 3-5 seconds sometimes the vehicle will feel like it is going to move forward even though I have my foot on the brake. When this happens the vehicle will jerk or feel like it w...
failure of wiring protection. I have pictures. Signal lights failed. The problem could have caused a fire in the vehicle or a major malfunction. Dealer made a repair at the dealership. Messages on the driver display indicated a problem. The dealer rep. advised me that the wiring harnesses are manufa...
Right side Rear axle Bolt sheared off. Dealers do not want to fix or cant fix the problem even thought there is a Customer Satisfaction Bulletin that Ford has put out to fix the vehicle. CSP 22B34 Bolt shear has been confirmed by 2 dealers and was told they could not do anything about it until ther...
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V842000 (Visibility) however, the part to do the recall repair was not yet available. The dealer was notified of the issue and confirmed that parts were not yet available. The manufacturer was notified ...
Upon pressing the start button the sound system put out an ear piercing pop and loud statis continued for 5 -10 minutes. Audio on/off and volume buttons were rendered ineffective, no response. Disconnected the negative on the battery with not effect. Static continued from all speakers. After 10 minu...
Upon pressing the start button the sound system put out an ear piercing pop and loud statis continued for 5 -10 minutes. Audio on/off and volume buttons were rendered ineffective, no response. Disconnected the negative on the battery with not effect. Static continued from all speakers. After 10 minu...
Ford is unable to correct the safety recall for the windshield wiper motor. Ford has sent out notice of recall with instructions to call them to correct on four + occasions. I have made four (4) attempts since the recall and two (2) dealerships in my area both have turned me away stating they would ...
Axle bolt connecting the rear passenger side wheel to the axle completely sheared off. Wheel starting making a terrible sound while driving and upon inspection found the sheared axle bolt.
Axle bolt connecting the rear passenger side wheel to the axle completely sheared off. Wheel starting making a terrible sound while driving and upon inspection found the sheared axle bolt.
Started the vehicle and an extremely loud popping noise came through the speaker system, then a horribly loud and terrible staticky clicking sound continued for 15 minutes or so, even after turning off the vehicle, locking it, and walking away from it.
Started the vehicle and an extremely loud popping noise came through the speaker system, then a horribly loud and terrible staticky clicking sound continued for 15 minutes or so, even after turning off the vehicle, locking it, and walking away from it.
When turning on the radio, there was a very loud pop like a gunshot or firework going off in the cab followed by sustained white noise coming from the speaker system at full volume. The volume and radio buttons did not impact the volume of the sound requiring the driver to pull over, shut the vehic...
When turning on the radio, there was a very loud pop like a gunshot or firework going off in the cab followed by sustained white noise coming from the speaker system at full volume. The volume and radio buttons did not impact the volume of the sound requiring the driver to pull over, shut the vehic...
Max Tow Package option. Rear Axle Bolt failure (broken bolt ). Torque to yield bolt design is apparently a defect they are not able to solve. This is common event as seen on forums. Ford bulletin did not list my build date but my right side axle bolt has now snapped. Ford is mishandling this issue, ...
AC suddenly stops working after 1 your driving. Happened twice after driving a week.
When getting on the road from a cold start coming out of a parking lot the vehicle will not accelerate. You mash the pedal down and it just sits there barely moving for 1 or 2 seconds and then all of a sudden it takes off. I have had the truck which I bought new for 3 months and it has happened 3 ...
Overview: Intermittent issue with audio system in vehicle making/playing EXTREMELY LOUD popping noise out of speakers randomly and with no warning. Sounds like someone is setting off explosions or a firearm inside the cabin, playing from all(?) or most of the speakers. Happens randomly and intermitt...
Overview: Intermittent issue with audio system in vehicle making/playing EXTREMELY LOUD popping noise out of speakers randomly and with no warning. Sounds like someone is setting off explosions or a firearm inside the cabin, playing from all(?) or most of the speakers. Happens randomly and intermitt...
Listed date as the date I caught issue on camera, but this has happened multiple times before and since. Numerous issues w/ infotainment system on 2022 F150 Powerboost Platinum. Backup cameras will load normally when put into reverse, but "freeze" once the vehicle starts moving. Still displays last ...
Listed date as the date I caught issue on camera, but this has happened multiple times before and since. Numerous issues w/ infotainment system on 2022 F150 Powerboost Platinum. Backup cameras will load normally when put into reverse, but "freeze" once the vehicle starts moving. Still displays last ...
Listed date as the date I caught issue on camera, but this has happened multiple times before and since. Numerous issues w/ infotainment system on 2022 F150 Powerboost Platinum. Backup cameras will load normally when put into reverse, but "freeze" once the vehicle starts moving. Still displays last ...
Axel bolt sheared off of passenger rear axel.
Sync 4 Screen will go blank while driving loosing rear camera 360 camera, all information. When starting sometimes the camera freezes makes you think a car behind you stopped when it is moving. Also, sometimes when you put on reverse. Nothing no screen, camera
Sync 4 Screen will go blank while driving loosing rear camera 360 camera, all information. When starting sometimes the camera freezes makes you think a car behind you stopped when it is moving. Also, sometimes when you put on reverse. Nothing no screen, camera
Sync 4 Screen will go blank while driving loosing rear camera 360 camera, all information. When starting sometimes the camera freezes makes you think a car behind you stopped when it is moving. Also, sometimes when you put on reverse. Nothing no screen, camera
The axle bolt has broken twice. The first time I was advised the factory torqued it too tight. The entire axle was replaced. The second time both hub assemblies were replaced. I was told there was a recall but no one could advise me why it was happening or any specifics on the recall. Both time...
I removed my wheels for standard rotation. When I removed the wheel from the passenger side rear, I found the rear axle bolt was fractured. The portion of the bolt and washer were inside the wheel. This appeared to have been chronic. Pictures available. I did not attempt to remove this bolt. Th...
Vehicle has major shifting issues with the 10 speed transmission. Shifting down or up can cause violent shifts. Extremely scary on the highway when passing semi trucks as it slams into gear. Vehicle will then show vehicle needs maintenance with a Powertrain issue. When turning the vehicle off it goe...
Stereo has made extremely loud popping sounds and now radio makes static sounds and popping sounds
Started vehicle and plugged phone im to play music/charge. Immediately, there was an incredible loud sound: it sounded almost like a gun shot. There was then a loud crackling sound which sounded like glass shattering. It scared me considerably. Thankfully I was parked. I shut the vehicle off and r...
Started vehicle and plugged phone im to play music/charge. Immediately, there was an incredible loud sound: it sounded almost like a gun shot. There was then a loud crackling sound which sounded like glass shattering. It scared me considerably. Thankfully I was parked. I shut the vehicle off and r...
The heat exchanger on my truck is faulty per the serve department at Balise Ford of Wilbraham. I had a check engine light coming on intermittently starting in October of 2022. In late December, the check engine came on steady. I made an appointment with Balise to have it checked out as well as to ...
On multiple occasions, the vehicle has exhibited, what I would call, a loss of acceleration. I first noticed this during a right-hand turn from a stop. I took my foot off the brake, initiated the turn and applied the throttle, and the vehicle took 1-2 seconds before it started to accelerate. The ...
Injury caused when power tailgate failed to slowly lower upon release. Upon release, the tailgate fell open instead of slowly opening as normal (it is a power tailgate). The force of the falling tailgate twisted my wrist and the tailgate hit my arm as I was unprepared for the tailgate to fail and...
Injury caused when power tailgate failed to slowly lower upon release. Upon release, the tailgate fell open instead of slowly opening as normal (it is a power tailgate). The force of the falling tailgate twisted my wrist and the tailgate hit my arm as I was unprepared for the tailgate to fail and...
Opened door to truck, sat down, hit the start button and immediately following was a extremely loud popping noise followed by loud static. This is a hazard to adults driving and little ones with developing ear drums. Dealers refuse to see it when it happens, so when needing to make an appointment ...
I was driving down the road when I noticed a squealing sound coming from the right rear end. Luckily, I made it home to remove the right rear tire and noticed that the axle bolt sheared off inside the axle. I checked a few different forms and this is a common occurrence with the max tow package.
While turning on my car, there was an extremely loud pop and deafening noise "exploding" in the truck cabin. If I had been driving at the time, the sudden and extreme noise would have caused me to react in a way to lose control of the vehicle. The noise was easy over 120db. It is been two hours sinc...
While turning on my car, there was an extremely loud pop and deafening noise "exploding" in the truck cabin. If I had been driving at the time, the sudden and extreme noise would have caused me to react in a way to lose control of the vehicle. The noise was easy over 120db. It is been two hours sinc...
Multiple times while driving, the tailgate has come open, allowing cargo to fall out onto the roadway. There is no notification to the driver that the tailgate has been opened or that it remains unsecured. The problem has been recognized in other F-150s but I believe it is more widespread. I am u...
Stereo has extremely loud pop and static noise. Almost blew my water drums, including wife and kids. This is a known issue and Ford is not doing anything about it. Happened 3 times now / easily cause an accident when driving not mention blowing ear drums. I had to go to doctor to get checked ou...
Vehicle B&O Unleashed sound system makes seemingly random BOOMs at full volume (>1000watt system) then a crackling and static sound as well. This is a health risk as my ears hurt 2 days afterward and were ringing no less than 2 hours. This is a safety risk as it seems like gunshots and I was pan...
Vehicle B&O Unleashed sound system makes seemingly random BOOMs at full volume (>1000watt system) then a crackling and static sound as well. This is a health risk as my ears hurt 2 days afterward and were ringing no less than 2 hours. This is a safety risk as it seems like gunshots and I was pan...
Vehicle B&O Unleashed sound system makes seemingly random BOOMs at full volume (>1000watt system) then a crackling and static sound as well. This is a health risk as my ears hurt 2 days afterward and were ringing no less than 2 hours. This is a safety risk as it seems like gunshots and I was pan...
Truck Bed camera displays a blue screen
When starting the car there was a loud audio pop that transitioned into a deafening static sound that I could not stop. I had to drive 80 minutes to the dealer with the windows down so I didn’t end up with hearing damage. The stereo could not be turned down or off. The volume knob would turn bu...
When starting the car there was a loud audio pop that transitioned into a deafening static sound that I could not stop. I had to drive 80 minutes to the dealer with the windows down so I didn’t end up with hearing damage. The stereo could not be turned down or off. The volume knob would turn bu...
The contact owns a 2022 Ford F150. The contact stated that she took her vehicle to the dealer to be serviced and the dealer informed the contact that the passenger’s side rear axle bolt had detached. The contact related the failure to NHTSA Campaign Number: 23V128000 (Power Train). The manufacture...
Mileage: 16,500
Extremely loud popping and then static noise from speakers. Loud enough to cause ear pain. Has happened twice to date.
Extremely loud popping and then static noise from speakers. Loud enough to cause ear pain. Has happened twice to date.
My 2022 F-150 4x4 Platinum Supercrew Powerboost full hybrid, about 11,500 miles, had no issues until about 6:30 PM 4/11/23, when I started the truck as normal. Immediately, a very loud explosion sound occurred followed by loud "sparks and crackles". The sound was painfully loud, but after 5-10 secon...
My 2022 F-150 4x4 Platinum Supercrew Powerboost full hybrid, about 11,500 miles, had no issues until about 6:30 PM 4/11/23, when I started the truck as normal. Immediately, a very loud explosion sound occurred followed by loud "sparks and crackles". The sound was painfully loud, but after 5-10 secon...
Rear axle retaining bolt failure
I remote started the vehicle, when inside the vehicle I pressed the start button. Directly after pressing the start button, a very loud pop followed by static played through the speakers. I was not able to turn the audio volume down or off. I was forced to drive home while the loud static noise cont...
I remote started the vehicle, when inside the vehicle I pressed the start button. Directly after pressing the start button, a very loud pop followed by static played through the speakers. I was not able to turn the audio volume down or off. I was forced to drive home while the loud static noise cont...
Today I start my 2022 F150 Hybrid and I got a loud beep like something didn't work, and then the speaker started screaming at more than 100decibel. It was so loud I couldn't stay inside for more than 10s. I still feel sick after 30 min. I tried to stop / restart the car, the noise continues. I had ...
Today I start my 2022 F150 Hybrid and I got a loud beep like something didn't work, and then the speaker started screaming at more than 100decibel. It was so loud I couldn't stay inside for more than 10s. I still feel sick after 30 min. I tried to stop / restart the car, the noise continues. I had ...
Right rear axle bolt sheared. See https://www.f150forum.com/f129/2021-powerboost-rear-rotor-axle-bolt-sheared-515460
Right rear axle bolt sheared. See https://www.f150forum.com/f129/2021-powerboost-rear-rotor-axle-bolt-sheared-515460
Right rear axle bolt sheared. See https://www.f150forum.com/f129/2021-powerboost-rear-rotor-axle-bolt-sheared-515460
2022 Ford F150, PowerBoost, Platinum, 9100 miles, Bang and Olufson 18 speaker stereo system. Got in the truck today and turned the truck on and instantly heard very loud, "electric crackling" noise. It took a few seconds to realize the noise was coming out of the speakers. I was not able to turn ...
2022 Ford F150, PowerBoost, Platinum, 9100 miles, Bang and Olufson 18 speaker stereo system. Got in the truck today and turned the truck on and instantly heard very loud, "electric crackling" noise. It took a few seconds to realize the noise was coming out of the speakers. I was not able to turn ...
I went out to my vehicle in the morning and when opening the door a loud pop came from the speakers and then static there after. The pop was so loud my ears rang for quite awhile. The problem some how was gone 15 minutes later. I have young children and my worry is this happens when they are in the ...
I went out to my vehicle in the morning and when opening the door a loud pop came from the speakers and then static there after. The pop was so loud my ears rang for quite awhile. The problem some how was gone 15 minutes later. I have young children and my worry is this happens when they are in the ...
Upon starting the truck an extremely loud deafening pop was heard through the speakers and then a very loud crackling/static noise. The stereo did not work after that. This has happened twice now on March 3, 2023 & March 8, 2023 and is so loud it makes your ears ring. I called the dealership & se...
Upon starting the truck an extremely loud deafening pop was heard through the speakers and then a very loud crackling/static noise. The stereo did not work after that. This has happened twice now on March 3, 2023 & March 8, 2023 and is so loud it makes your ears ring. I called the dealership & se...
On 02/22/2023 at approximately 7:50pm I entered my vehicle. Started up normally, and pulled out from my parking spot with the stereo OFF. As I turned around I heard a deafening "Boom" followed by what sounded like hail striking my car all over. It scared the hell out of me, and it took a second for ...
The problem appears to be with the B&O Unleashed audio system, possibly the factory stereo amplifier in my new 2022 F-150 Platinum Powerboost. I was pulling up to a red light intersection, with the audio system off but connected via wireless Apple Carplay, when the audio system produced a deafening ...
All of the sudden and without any warning, an extremely loud bang followed by extremely loud buzzing and white noise sound comes from the stereo system. The bang sounded like a gun shot in my ear and the buzzing/white sound noise is louder than anything I've ever heard. It nearly caused me to run o...
All of the sudden and without any warning, an extremely loud bang followed by extremely loud buzzing and white noise sound comes from the stereo system. The bang sounded like a gun shot in my ear and the buzzing/white sound noise is louder than anything I've ever heard. It nearly caused me to run o...
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V686000 (Exterior Lighting) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manuf...
Loud pop noise from radio static no sound
Loud pop noise from radio static no sound
Vehicle lurches forward when at a stop while in electric mode. When releasing the brake, the vehicle lurches forward into a “bang”. Occurring at every stop while in electric mode. CEL for fault with auxiliary transmission oil pump
The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 22V686000 (Exterior Lighting) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Addi...
This past week, I was sitting at a red light with my foot on the brake (not the gas) and all of sudden, my truck slammed into gear hard enough that I thought I was rear ended. I actually had to look to see if a car did hit me. This happened to me twice this week. Also, several times this week, I ...
The speakers in the car all "pop" and a high static/whine pitch plays out of all speakers. It does not stop unless you turn off the car and open a door to completely turn off the car. I have videos to document the noise.
The speakers in the car all "pop" and a high static/whine pitch plays out of all speakers. It does not stop unless you turn off the car and open a door to completely turn off the car. I have videos to document the noise.
Rear axle bolt sheering off leaving the truck undrivable. Ford states the parts are on back order. Dealership does not have any loaners so I’m without a car for an unknown length of time.
The contact owns a 2022 Ford F-150. The contact stated while driving approximately 65 MPH, the contact engaged the Pre-Collision Assist with Automatic Emergency Braking (AEB). The contact stated that his vehicle kept gaining on the vehicle in front of him and was not keeping a safe distance. The con...
Mileage: 1,600
January 2, 2023 Ford Motor Company Product Claims Department 1-800-392-3673 P.O. Box 70 Dearborn, Michigan 48121 Vehicle VIN #1FTFW1ED5NFB14199 New 2022 Ford F-150 Dear Claims Department/Legal Department, On December 22, 2022 at approximately 5:00 p.m. Driver of vehicle was leaving the office to ...
I have B&O Unleashed sounds system in my 2022 F-150 Platinum. Went out to work, no issues with sound. Auto-Started the truck, & came back out to my truck after grabbing some documents from my office for an offsite meeting.. Pressed the start button when I unlocked & sat down in the drivers seat, & a...
Upon pressing the start button a loud deafening sound emits from the speakers. Followed by loud crackling and static. Happens at least once a month. Issue began about a month after I purchased the vehicle Additionally, deploy on their own while vehicle is off and key fob is not near the vehicle.
The axle retaining bolts are breaking. Ford is using the same parts to repair, but keeps happening. Being told unsafe to drive while parts are on order.
The right rear axle bolt was found to be broken when the tire was removed for rotation. The bolt appears to have been over torqued at the assembly plant. At the time of the removal of the tire, the bolt head with about 5/8" of threads left and the corresponding washer fell out and hit the floor. T...
Tonight when I started my truck there was a loud pop sound that came from the sound system. The stereo then had no volume with any source. I shut down the vehicle and restarted it. As soon as it turned on again, the sound system had incredibly loud static coming from every speaker. My ears were ring...
Tonight when I started my truck there was a loud pop sound that came from the sound system. The stereo then had no volume with any source. I shut down the vehicle and restarted it. As soon as it turned on again, the sound system had incredibly loud static coming from every speaker. My ears were ring...
When entering truck and apon hitting the push button start and loud pop was heard from speakers with a continus crackling afterwards.
a bolt (FoMoCo part# ML3Z19S426A) which secures the rear axle to the wheel hub sheared off. This bolt failure has happened to hundreds (thousands?) of other recent model F-150 owners as detailed in these two message board threads: https://www.f150forum.com/f129/2021-powerboost-rear-rotor-axle-bolt-s...
Passenger side rear axle retention bolt sheared off. Discovered during routine maintenance / tire rotation. Unknown how safety was at risk -- dealer told me once discovered that the vehicle would be repaired under warranty, and they could do in 24 hours, so no discussion about unsafe to drive as ot...
1. The back up brake assistant is not working. This has been defective since August 2022. It caused me to have an accident running into a post, filing an insurance claim for repairs. I have taken it to 2 different Ford dealers for service and to get the back up brake fixed. No resolve from FORD. 2....
1. The back up brake assistant is not working. This has been defective since August 2022. It caused me to have an accident running into a post, filing an insurance claim for repairs. I have taken it to 2 different Ford dealers for service and to get the back up brake fixed. No resolve from FORD. 2....
The contact owns a 2022 Ford F-150 Hybrid. The contact stated while attempting to start the vehicle, the engine failed to turn over and the engine was cranking as if the battery was drained. The contact stated that the "Stop Driving" and "Check Engine and "Check Battery" warning lights were illumina...
Mileage: 3,000
Wile driving my vehicle after a rain storm (it was not currently raining) water started to drip from the speaker above the driver. The ceiling from the middle of the driver door to the center of the windshield was soaking wet. While the vehicle does have a sunroof it is never used. I checked for blo...
As soon as I pressed the start button, an extremely loud and shrill sound came from every speaker. Horn also started blaring. All speakers continued to crackle, pop, and scream until I pressed the ignition button again and opened the drivers door. I was able to prevent it from happening again by rem...
Stereo system went to max volume with static and clicking, extremely loud. Volume control and power switch had no effect.
I took my 2021 Ford F-150 3.5L Powerboost in for it's 15k mile check up and when the driver side rear tire was removed the Rear Rotor/Axle Bolt Sheared off. Dealer informed me “unsafe” to drive and ordered new axle which is back ordered. - both dealer and ford have said truck is unsafe to drive ...
The contact owned a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, the low turbo boost and the reduced engine power warning lights were illuminated. The contact stated that he pulled over into a gas station to turn off the vehicle. After restarting the vehicle, the w...
Mileage: 5,500
I turned on the truck and heard a loud crack followed by load static originating from the front passenger area. This was from the stereo speakers. My right ear endured a lasting and substantial amount of pain. I will estimate, based on measurements of SPL I've made as an engineer, that the crack was...
Just as I left the driveway at my house, I heard what sounded like an explosion and shattering glass. My truck stereo had incredibly loud static that hurt my ears. The volume knob stopped responding and I could not make the sound stop. I turned off my ignition and then opened the driver’s door. T...
Loud pop followed by loud static from all speakers on start. Turned vehicle off and problem persisted until battery was disconnected.
Loud pop followed by loud static from all speakers on start. Turned vehicle off and problem persisted until battery was disconnected.
According to the dealer, Covert Ford in Austin, TX. A bolt on the rear axle holding the brakes to the rear axle is brittle and prone to failure. This bolt has sheared on my truck with just 10, 739.9 miles on it. The dealer says they cannot release the truck as the rear axle is damaged and the truck ...
Upon starting the vehicle an extremely loud and disorienting static popping noise started to come from every speaker in the vehicle at seemingly full volume with no way to make it stop or turn the volume down. Many attempts were made to get the sound to stop including turning the vehicle and enterta...
At startup the stereo system (my truck has the B&O unleashed option) made a very loud electrical static and buzzing sound. This came from every speaker at max volume. Attempts to make the noise stop were unsuccessful, including trying to select multiple audio inputs and turning down the volume. It j...
When I got into my truck and pressed the start button, there was an extremely loud popping noise that appeared to be coming from the sound system. It was so loud that it caused ringing in my ears. I immediately attempted to shut off the truck, but the noise continued. I opened the door to exit the v...
When I got into my truck and pressed the start button, there was an extremely loud popping noise that appeared to be coming from the sound system. It was so loud that it caused ringing in my ears. I immediately attempted to shut off the truck, but the noise continued. I opened the door to exit the v...
This has happened twice to me. The latest was about 7 days ago. There was a loud popping and static sound when driving my vehicle so loud that I had to exit the truck and my neighbors came and asked if I was ok because it was so loud. I couldn't get it to stop by shutting things off. Talked to my ...
This has happened twice to me. The latest was about 7 days ago. There was a loud popping and static sound when driving my vehicle so loud that I had to exit the truck and my neighbors came and asked if I was ok because it was so loud. I couldn't get it to stop by shutting things off. Talked to my ...
I took my 2022 f150 powerboost with max tow package to the dealer because of an audible noise coming from the rear passenger side. Ford discovered the axle bolt broke and is floating. Ford said the vehicle is “unsafe to drive” No warning lights. Just a slight squeal noise. If I hadn’t read a...
Was driving vehicle at approximately 45MPH, selected windshield sprayer to clean bugs off windshield, after a couple of full rotation of the windshield wipers, the passenger side wiper fell off and landed in spot that wipers stay while off. Upon inspection it appears that the affected wiper came ...
Rear passenger door latch failed and actually flew open in the middle of intersection while door was locked! Entered intersection from a full stop. Shut door repeatedly when we entered the truck. Seemed to have trouble shutting completely. Needed a couple tries get closed. Thankfully my kids had t...
Rear passenger door latch failed and actually flew open in the middle of intersection while door was locked! Entered intersection from a full stop. Shut door repeatedly when we entered the truck. Seemed to have trouble shutting completely. Needed a couple tries get closed. Thankfully my kids had t...
Rear passenger door latch failed and actually flew open in the middle of intersection while door was locked! Entered intersection from a full stop. Shut door repeatedly when we entered the truck. Seemed to have trouble shutting completely. Needed a couple tries get closed. Thankfully my kids had t...
After purchasing the truck new I drove it for four days and it started to leak coolant from under the middle of the truck. The truck had less then 200 miles on it and it already needed service. Once I looked up 2022 Ford F-150 Power Boost coolant leak I found out there are a lot of people experienci...
Brand New vehicle with 1000 miles on ODO, steering wheel almost completely locked up while driving and narrowly missed a head on collision. Dealership says steering gear assembly is faulty. Vehicle now inoperable and unsafe to drive
New 2022 Ford F-150 vehicle has a "Rear Brake Assist Not Available" dash warning with accompanting DTCs B1578:78, IPMA Error, and U023A, Lost Communication with Image Processing Module A. I should note my Check Engine Light never came on for either of these DTCs - I was given these codes by the deal...
I was driving about 50 mph traveling from Bethel, NC to Canton, NC and was approaching Canton so I was slowing down. The first traffic light was red so I stopped behind another car. When the light turned green I lightly pressed the accelerator and nothing happened, it was like the engine failed to...
I bought this F150 2 days ago, Vehicle drove fine in the morning to work after work I started the truck and could not get it to go into any gear the lever was stuck in park. My model has the fold flat shifter and I keep the shifter folded all the way down when It is parked. It took approximately 30 ...
This vehicle has a Powerboost Engine which is a Hybrid with a High-Voltage Battery Pack. This Battery Pack has a very sophisticated heating and cooling system which is part of the engine cooling system. A part of this cooling system is an Exhaust Heat Exchanger. It is Ford Part Number: ML3Z5A212...
1. Transmission. Stays in higher gears at stops. When starting out it barely moves in response to gas pedal increase. At about 3,000 RPMs it engages and jerks violently ahead. After this happened several times I noticed the transmission gear light was in a higher gear at stop, like 7th gear. Therefo...
There is a heat exchanger in the exhaust that leaks coolant and causes the engine to overheat. This has happened to over 500+ Powerboost Engines. Ford Case# CAS-35641317-W3Y6F0