2001 FORD F-150 Fuel System, Gasoline Problems

The contact owns a 2001 Ford F-150. The contact stated that upon entering the vehicle one day, there was an abnormal fuel odor outside the vehicle. The contact’s husband inspected underneath the vehicle and discovered that the fuel tank had detached from the subframe. The contact stated that prior to becoming aware of the failure, the low fuel warning light was occasionally illuminated. The vehicle was not taken to a local dealer. The local dealer was contacted, and the contact was informed that there were no open recalls on the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 93,000.

Mileage: 93,000

ONE OF THE STRAPS HOLDING UP MY FUEL TANK HAD RUSTED AND BROKE AWAY FROM TANK.THE OTHER STRAP IS RUSTING TOO.

Mileage: 220,000

TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE FAILED TO DECELERATE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN NOTICED A CHUNK OF ICE IN THE CARBURETOR. THE ICE WAS REMOVED AND THE VEHICLE WAS ABLE TO BE DRIVEN NORMALLY. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

2001 FORD F150 THE GAS TANK FELL & STRAP ROTTED. *MW ACCORDING TO THE REPAIR INVOICE, THE FUEL TANK AND STRAPS WERE REPLACED. *JB

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE FUEL TANK BECAME DETACHED FROM UNDER THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO REPLACED THE FUEL TANK AND THE FUEL PUMP. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 172,000.

Mileage: 172,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE FUEL TANK BECAME DETACHED FROM UNDER THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO REPLACED THE FUEL TANK AND THE FUEL PUMP. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 172,000.

Mileage: 172,000

I FILLED THE FUEL TANK WITH GAS AND DROVE ABOUT 20 MILES. WHILE PULLING INTO A RESTAURANT AT ABOUT 5 TO 10 MPH I WENT THROUGH A VERY SLIGHT DIP. I HEARD A SOFT THUNK AND HEARD SOMETHING DRAGGING ON THE GROUND. IT WAS NOT REAL LOUD SO I SLOWLY PULLED INTO THE PARKING LOT. WHEN I LOOKED UNDER MY VFORD F-150 I NOTICED THAT THE GAS TANK HAD DROPPED DUE TO BOTH STRAPS BREAKING. THE REAR OF THE TANK WAS HELD UP BY THE HOSE GOING TO THE GAS CAP AREA. FORTUNATELY, THIS DID NOT HAPPEN AT HIGH SPEED OR I MAY NOT BE AROUND TO REPORT THE INCIDENT. I CALLED FORD AND THEY STATE THAT THIS VIN NUMBER DID NOT HAVE NAY RECALLS. THE CUSTOMER RESOURCE PERSON (800.392.3673 OPTION 1, 5, 4) STATED THEY WERE NOT AWARE OF ANY GOVERNMENT NUMBER WHERE I COULD CALL IN THIS COMPLAINT. I QUICKLY DID A WEB SEARCH AND FOUND THIS NUMBER SO I FIND IT HARD TO BELIEVE THEY DID NOT KNOW ABOUT IT. THIS IS A VERY SERIOUS SAFETY ISSUE THAT COULD VERY EASILY LEAD TO SERIOUS INJURIES/DEATH TO OCCUPANTS OF THE 2001 F-150. *TR

Mileage: 152,000

2001 FORD F-150. CONSUMER WRITES IN REGARDS TO TRANSMISSION PROBLEMS. *SMD THE CONSUMER STATED DURING ROUTINE USE OF THE TRUCK, THE TRANSMISSION STOPPED FUNCTIONING. THE TRANSMISSION REPAIR SHOP, INFORMED THE CONSUMER THE CAST STEEL GEAR WITHIN THE TRANSMISSION HAD SHATTERED INTO TWO PIECES. IN OCTOBER 2009, DURING AN ANNUAL SAFETY INSPECTION, THE STRAPS HOLDING THE FUEL TANK IN PLACE WERE CORRODED AND ALMOST COMPLETELY RUSTED THROUGH. IN THE SUMMER OF 2013, FORD MOTOR COMPANY, SENT THE CONSUMER A NOTICE, INFORMING HIM THE FUEL TANK STRAP WERE BEING RECALLED. THE CONSUMER WAS NOT OVERLY CONCERNED, SINCE THEY HAD ALREADY BEEN REPLACED, FORD SENT ANOTHER RECALL. THE CONSUMER INFORMED FORD, HE HAD THE STRAPS REPLACED. FORD THEN ADVISED THE CONSUMER TO VISIT THE DEALER ABOUT REIMBURSEMENT. THE DEALER WANTED TO SEE WHAT REPAIRS HAD BEEN MADE. ONCE THE TRUCK WAS ON THE LIFT, IT WAS DISCOVERED THE ORIGINAL FAULTY TANK STRAPS HAD CAUSED A WEAKENING IN THE SKIN OF THE FUEL TAN ITSELF AND THAT IT WAS LEAKING GASOLINE THROUGH THE SKIN OF THE TANK. THE TANK WAS LEAKING FUEL AROUND THE AREA WHERE THE STRAPS RUBBED ON THE TANK. FORD WOULD ONLY HONOR THE RECALL, IF THEY REPLACED THE STRAPS. HOWEVER, THEY REFUSED TO REPLACE LEAKING FUEL TANK. *JB

I WAS DRIVING NORTHBOUND ON I-95 WHEN THE DRIVER OF AN ADJACENT VEHICLE ALERTED ME THAT THERE WAS FIRE SHOOTING OUT FROM THE AREA OF THE FUEL FILLER DOOR. I IMMEDIATELY PULLED OVER ONTO THE HIGHWAY MEDIAN AND JUMPED OUT. THE TRUCK WAS ENGULFED IN FLAMES, AND THE CAB WAS ON FIRE. I BURNED MYSELF ON THE MELTING STEERING WHEEL AND WAS SINGED BY MELTING PLASTIC. *TR

Mileage: 103,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK HAD RUSTED AND STARTED TO LEAK. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING). THE CONTACT MENTIONED THAT ALTHOUGH THE TANK WAS LEAKING AT THE TIME OF THE REPLACEMENT OF THE STRAPS THE MANUFACTURER REFUSE TO COVER THE FUEL TANK REPLACEMENT SINCE IT WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 140,000. UPDATED 02/20/13*LJ

Mileage: 140,000

NOT A NEW COMPLAINT, JUST WANTED TO SAY THANKS. FORD MOTOR COMPANY HAS REIMBURSED ME FOR 100% OF MY EXPENSES RELATED TO THE GAS TANK STRAP FAILURE. THANK YOU, AND THANK FORD MOTOR COMPANY. I COULD NOT FIND ANOTHER WAY TO EDIT MY PREVIOUS COMPLAINT. ODI # 10402810. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. WHILE THE VEHICLE WAS BEING SERVICED, THE FUEL TANK WAS FRACTURED AND BEGAN LEAKING GASOLINE. NEITHER THE DEALER NOR THE MANUFACTURER OFFERED ANY ASSISTANCE WITH THE FAILURE SINCE THE RECALL DID NOT INCLUDE REPAIRING THE FUEL TANK. THE CURRENT AND THE FAILURE MILEAGES WERE 129,400. UPDATED 02/03/12*LJ THE TANK WAS REPLACED FREE OF CHARGE ON JAN 17, 2011 AND THE PROBLEM HAS BEEN RESOLVED. UPDATED 02/10/12

Mileage: 129,400

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. WHILE THE VEHICLE WAS BEING SERVICED, THE FUEL TANK WAS FRACTURED AND BEGAN LEAKING GASOLINE. NEITHER THE DEALER NOR THE MANUFACTURER OFFERED ANY ASSISTANCE WITH THE FAILURE SINCE THE RECALL DID NOT INCLUDE REPAIRING THE FUEL TANK. THE CURRENT AND THE FAILURE MILEAGES WERE 129,400. UPDATED 02/03/12*LJ THE TANK WAS REPLACED FREE OF CHARGE ON JAN 17, 2011 AND THE PROBLEM HAS BEEN RESOLVED. UPDATED 02/10/12

Mileage: 129,400

ATTEMPTING TO PARK VEHICLE IN PARKING STALL WITH FOOT ON BRAKE STOPPING THE VEHICLE. THE VEHICLE, FOR NO APPARENT REASON, ABRUPTLY ACCELERATED FORWARD STRIKNIG THE VEHICLE ON THE OTHER SIDE OF THE PARKING STALL. THE RESULTING CRASH CAUSED DAMAGE TO THE FRONT OF THE 2011 GMC SPORT UTILITY VEHICLE AND TO THE FRONT OF THE 2001 FORD F-150. THIS IS THE SECOND TIME AN INCIDENT SIMILAR TO THIS HAS OCCURRED. THE FIRST TIME WAS IN AUGUST 2011. THE FIRST TIME THE VEHICLE DEMONSTRATED A SIMILAR PHENOMENA OCCURRED WHEN THE OWNER WAS PARKING THE VEHICLE IN A PARKING STALL. THE VEHICLE WAS STOPPED IN THE PARKING STALL, THE DRIVER'S FOOT ON THE BRAKE AND THE VEHICLE ABRUPTLY ACCELERATED, FOR NO APPARENT REASON, OVER A CONCRETE PARKING BLOCK. THE VEHICLE CONTINUED INTO THE STREET AS THE DRIVER CONTINUED TO APPLY THE BRAKE, ATTEMPTING TO STOP THE FORD F-150. THE DRIVER WAS UNABLE TO AVOID STRIKING A VEHICLE AFTER ENTERING THE STREET. *TR

Mileage: 202,534

A PLASTIC COVER OVER THE REAR PART (TOWARDS THE AXLE) OF THE GAS TANK HAS CAUSED A RUST HOLE IN THE TANK. THE PIECE IS HELD ON WITH 2 STRIPS OF DOUBLE SIDED ADHESIVE AND ATTACHES TO TWO CLIPS ON THE TANK. THE RUST DAMAGE IS UNDER THE ADHESIVE STRIP ON THE BOTTOM CAUSING A VERY SLOW LEAK. I'M NOT SURE WHAT THE FUNCTION IS FOR THIS PLASTIC PIECE AND I CAN'T IMAGINE THAT MY VEHICLE IS THE ONLY ONE AFFECTED BY THIS DESIGN FLAW? *KB

ON 11/11/11 I WAS DRIVING HOME FROM WORK IN MY 2001 FORD F150 AND WAS APPROXIMATELY 1 AND A HALF BLOCKS FROM MY HOUSE WHEN I HIT A POTHOLE AND HEARD A LOUD BANG AND THEN SOME METAL GRINDING OR DRAGGING WHICH I INITIALLY THOUGHT WAS MY EXHAUST THE WAY IT SOUNDED, SO I STOPPED THE TRUCK AND LOOKED UNDERNEATH. THIS IS WHEN I REALIZED THE MAGNITUDE OF THE SITUATION, A STRAP THAT HOLDS MY GAS TANK IN PLACE HAD BROKEN OFF FROM WHAT APPEARS TO BE RUSTED AND THE GAS TANK WAS HANGING BY ONE STRAP . AT THIS TIME I WAS ABOUT 100 FEET FROM MY HOUSE SO I HAD MY SON COME OUT AND I PUSHED THE VEHICLE TO IN FRONT OF MY HOUSE. THE TANK IS GRINDING ON SOMETHING WHEN YOU MOVE THE VEHICLE OR WHEN TURNING THE VEHICLE. *TR

Mileage: 98,890

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE NOTICED A FUEL SPILL. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AS THE REAR FUEL TANK STRAP BEING CORRODED AND CAUSED A HOLE ON THE FUEL TANK. THE FUEL TANK AND STRAPS WERE REPLACED. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE MANUFACTURER DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE BECAUSE THE FUEL TANK DID NOT DETACH. THE FAILURE MILEAGE WAS 101,340 AND THE CURRENT MILEAGE WAS 102,000.

Mileage: 101,340

TL*THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE FUEL TANK WAS LEAKING FUEL DUE TO THE CORRODED STRAPS. THE CONTACT WAS ALSO INFORMED THAT REPAIRS TO THE FUEL TANK WERE NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

Mileage: 150,000

I HAVE NOT SEEN THIS POSTED ANYWHERE. I HAVE RECEIVED THE FORD RECALL FOR THE FUEL TANK STRAPS. MY LOCAL DEALERSHIP CALLED ME WHEN I TOOK THE TRUCK IN FOR THE REPAIRS AND SAID MY FUEL TANK IS LEAKING. THE FUEL LEAK IS RIGHT BEHIND OR AROUND THE REAR TANK STRAP. I DO HAVE PICTURES IF ANYONE WANTS TO SEE IT. THE FORD DEALERSHIP DIDN'T HESITATE TO TELL ME THAT IT WAS NOT PART OF THE RECALL AND GAVE ME A QUOTE TO REPLACE IT. I FEEL IT SHOULD BE ADDED TO THE RECALL PROCEDURE. IT SURE SEEMS LIKELY THAT THE RUSTED STRAP CAUSED THE RUST AND EVENTUALLY CAUSED THE LEAK. NOW I HAVE A TRUCK THAT SHOULDN'T BE DRIVEN, WON'T PASS STATE INSPECTION AND FORD SAYS I'M ON THE HOOK FOR A NEW FUEL TANK. THEY KNOW THEY HAVE A PROBLEM AND SHOULD STEP UP TO THE PLATE AND LOOK INTO THIS SOME MORE. I'M NOT THE ONLY GUY THAT HAS THIS SAME PROBLEM. *TR

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS WERE FRACTURED AS A RESULT OF CORROSION. THE CONTACT MENTIONED THAT THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 11V385000 ( FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) . THE VEHICLE WAS TOWED TO THE DEALER WHO VERIFIED THE FAILURE AND DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE FUEL TANK WAS NOT PART OF THE RECALL. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 73,000.

Mileage: 73,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT AFTER RECEIVING NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) THE VEHICLE WAS TAKEN TO THE DEALER WHERE HE WAS INFORMED THAT THE FUEL TANK WAS CORRODED AND LEAKING SEVERELY. THE VEHICLE WAS REPAIRED FOR THE STRAPS BUT NOT THE TANK. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 77,000. THE VIN WAS UNAVAILABLE.

Mileage: 77,000

DEAR NHTSA, THIS IS REGARDS TO THE FORD RECALL ON FUEL TANK STRAPS. WE LIVE IN NORTHEAST NEBRASKA & HAVE A 2001 FORD F-150 TRUCK WHICH HAS ONE FUEL TANK STRAP THAT HAS RUSTED THROUGH AND THE OTHER IS RUSTED. WE CONTACTED FORD SERVICE STATION AND THEY SAID OUR VEHICLE WAS NOT INCLUDED IN THE FORD RECALL. WE CONTACTED FORD AND THEY SAID IT WAS NOT UNDER WARRANTY, BUT YOU MIGHT WANT TO GET IT FIXED! I ASKED HOW THEY DETERMINED WHO QUALIFIED FOR THE RECALL AND I DID NOT GET A RESPONSE TO MY QUESTION. COULD YOU PLEASE EXPLAIN WHY OUR TRUCK WAS NOT INCLUDED IN THE RECALL. IT IS OBVIOUS THAT IT SHOULD HAVE BEEN INCLUDED IN THE RECALL. WE WOULD APPRECIATE YOU LOOKING INTO THIS MATTER AND INCLUDE OUR TRUCK IN THE RECALL. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS DRIVING SLOWLY AT 25MPH DOWN A DIRT ROAD WHEN I HEARD A DRAGGING NOISE AND WHEN I PULLED OVER TO INVESTIGATE I SAW THAT MY FUEL TANK HAD FALLEN HALF OFF. WHEN I GOT SOME HELP FROM A FRIEND TO COME LOOK AT IT THEY SAID BOTH MY STRAPS SOMEHOW RUSTED AWAY AND MY TANK FELL. *TR

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT ONE OF THE FUEL TANK STRAPS FRACTURED AND DETACHED FROM THE VEHICLE. THE DEALER AND MANUFACTURER WERE NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 271,000. GAS TANK MOUNTING STRAP BROKE AND FELL OFF OF VEHICLE DUE TO RUST. UPDATED 10/19/2011 *LN *TR

Mileage: 271,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT ONE OF THE FUEL TANK STRAPS FRACTURED AND DETACHED FROM THE VEHICLE. THE DEALER AND MANUFACTURER WERE NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 271,000. GAS TANK MOUNTING STRAP BROKE AND FELL OFF OF VEHICLE DUE TO RUST. UPDATED 10/19/2011 *LN *TR

Mileage: 271,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THE VEHICLE REAR FRAME AND UNDER BODY SHIELD WAS CORRODED. THE MANUFACTURER WAS CONTACTED, BUT DENIED ASSISTANCE WITH REPAIR. THE VEHICLE HAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000 AND THE CURRENT MILEAGE WAS 110,000. THE GAS TANK AND FUEL TANK STRAPS WERE REPLACED DUE TO RUST. UPDATED 11/04/11

Mileage: 85,000

HIT BUMP, GAS TANK STRAPS BROKE AND DRAGGED TANK ON PAVEMENT, RUPTURED AND GAS SPILLED ON ROAD

Mileage: 60,000

I WANT TO KNOW WHY THE RECALL FOR THE GAS TANK STRAPS ON FORD F-150 PICKUPS 1997-2004 IS NOT IN NEBRASKA? BECAUSE NEBRASKA IS A COLD WEATHER STATE AND THEY USE CHEMICALS TO DE-ICE THE ROADS?

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS HAD BEGUN TO RUST. THE CONTACT NOTIFIED THE DEALER AND THE MANUFACTURER OF THE FAILURE, WHO ADVISED THE CONTACT OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,000 AND THE CURRENT MILEAGE WAS 115,000.

Mileage: 93,000

2001 F-150 2 DOOR 6 CYLINDER; FUEL TANK DROPPED ONTO ROADWAY DUE TO RUSTED THROUGH TANK STRAP. HAD AUTO REPAIR SHOP FIX: REPLACED FUEL TANK, FUEL TANK STRAPS, FUEL PUMP, FUEL TANK PRESSURE SENSOR, TOWING CHARGE TOTAL BILL $2,600. *KB

Mileage: 185,000

2001 F-150 2 DOOR 6 CYLINDER; FUEL TANK DROPPED ONTO ROADWAY DUE TO RUSTED THROUGH TANK STRAP. HAD AUTO REPAIR SHOP FIX: REPLACED FUEL TANK, FUEL TANK STRAPS, FUEL PUMP, FUEL TANK PRESSURE SENSOR, TOWING CHARGE TOTAL BILL $2,600. *KB

Mileage: 185,000

GAS TANK FELL OUT OF MY 2001 F-150 RUPTURING GAS IN THE STREET. COST ME $1500 TO FIX AND CLEAN UP. WHO IS GOING TO PAY FOR THIS? *KB

Mileage: 170,000

GAS TANK FELL OUT OF MY 2001 F-150 RUPTURING GAS IN THE STREET. COST ME $1500 TO FIX AND CLEAN UP. WHO IS GOING TO PAY FOR THIS? *KB

Mileage: 170,000

HIT A BUMP AND FRONT GAS TANK STRAP BROKE AND DRAGGED FOR 2 MILES LEAKING GAS,$40, WORTH. STOPPED IN PARKING LOT WITH GAS RUNNING,FIRE DEPARTMENT AND COPS ARRIVED. TRUCK TOWED TO LOT. STILL NOT ATTEMPTED REPAIRS. *KB

Mileage: 60,000

HIT A BUMP AND FRONT GAS TANK STRAP BROKE AND DRAGGED FOR 2 MILES LEAKING GAS,$40, WORTH. STOPPED IN PARKING LOT WITH GAS RUNNING,FIRE DEPARTMENT AND COPS ARRIVED. TRUCK TOWED TO LOT. STILL NOT ATTEMPTED REPAIRS. *KB

Mileage: 60,000

TL* THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING 45 MPH, THE CONTACT STATED THAT THE FUEL TANK SUDDENLY DETACHED FROM THE VEHICLE WITH A HALF TANK OF GAS. THE DEALER DID NOT OFFER ANY ASSISTANCE WHEN CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED. A PRIVATE MECHANIC REPLACED THE FUEL FILTER, STRAPS, AND THE FUEL TANK. THE CURRENT MILEAGE WAS 105,861. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

Mileage: 105,861

JUST FILLED THE GASOLINE TANK TO FULL ON SATURDAY EVENING, JULY 30, 2011. LEFT THE STATION AND DROVE ABOUT A 1/4 BLOCK AND THE FRONT PART OF THE GASOLINE TANK FELL OFF. HEARD THE DRAGGING NOISE AND STOPPED. REPAIR GARAGE STATED THEY HAVE REPAIRED MANY WITH THIS SAME PROBLEM. KNEW HOW TO HANDLE IT. CALLED BOB ALLEN FORD IN OVERLAND PARK, KS. ON MONDAY MORNING, AUGUST 1, 2011, AND THEY STATED THEY HAD NO KNOWLEDGE OF ANY TSB ON THE PROBLEM. NEVER MENTIONED THERE MAY BE A RECALL ON IT.

Mileage: 83,394

MY 2001 FORD F150 GAS TANK FELL OF MY TRUCK , NOSE FORWARD WHILE DRIVING. RESTRAINTS SEPARATED AND FUEL TANK CAME DOWN ON THE HIGHWAY. I AM VERY LUCKY, NO EXPLOSION OR FIRE ENSUED. HAD TO BE TOWED. CLEARLY THE RESTRAINTS HAD CORRODED. WHOLE SYSTEM NEEDS REPLACEMENT. *TR

Mileage: 178,000

MY WIFE WAS DRIVING HOME FROM WORK LAST EVENING AROUND 9:00 PM IN OUR 2001 FORD F-150 PICKUP TRUCK WHEN SHE HEARD A NOISE COMING FROM UNDER THE TRUCK. SHE STOPPED TO INVESTIGATE THE SOURCE OF THE NOISE TO FIND THAT THE GAS TANK HAD FALLEN ONTO THE ROAD WHICH PUT A HOLE IN THE TANK WHICH LEAKED OUT ALL THE GASOLINE. THE STRAPS WHICH SUPPORT THE TANK HAD RUSTED OUT CAUSING THE TANK TO FALL OUT. THANKFULLY SHE WAS NOT INJURED. FORD NEEDS TO ADDRESS THIS ISSUE BEFORE SOMEONE IS KILLED. *TR

Mileage: 125,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT ONE OF THE STRAPS WHICH HELD THE FUEL TANK IN PLACE BROKE OFF FROM THE FUEL TANK AND THE OTHER STRAP WAS RUSTED. NEITHER THE DEALER, NOR MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 170,000.

Mileage: 170,000

DRIVING MY 2001 FORD F-150 DOWN THE HIGHWAY AND THE GAS TANK FELL OFF AND WAS DRAGGING BENEATH THE TRUCK. IT WAS A FULL TANK OF GAS THAT WE WERE LUCKY DID NOT IGNITE. *KB

Mileage: 121,000

DRIVING MY 2001 FORD F-150 DOWN THE HIGHWAY AND THE GAS TANK FELL OFF AND WAS DRAGGING BENEATH THE TRUCK. IT WAS A FULL TANK OF GAS THAT WE WERE LUCKY DID NOT IGNITE. *KB

Mileage: 121,000

2001 FORD F-150. CONSUMER STATES PROBLEM WITH VEHICLE GAS TANK *TGW THE CONSUMER STATED WHILE DRIVING, HE HEARD A LOUD METAL NOISE. HE PULLED TO THE SIDE OF THE ROAD, EXITED THE VEHICLE AND LOOKED UNDERNEATH, ONLY TO DISCOVER THE ENTIRE GAS TANK WAS ON THE GROUND. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE GAS TANK WAS RE-INSTALLED AND THE FUEL TANK STRAPS, PRESSURE SENSOR AND FUEL FILLER NECK WERE REPLACED. *JB UPDATED 07/20/11

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING, THE FUEL TANK DETACHED FROM THE VEHICLE AND BEGAN TO LEAK FUEL. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE, BUT WERE UNABLE TO ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 166,000.

Mileage: 166,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK STRAPS FRACTURED. THE FAILURE CAUSED THE FUEL LINES TO ALSO FRACTURE AS GASOLINE SPILLED ONTO THE ROADWAY. THE VEHICLE WAS TOWED TO THE DEALER AND REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 82,513.

Mileage: 82,513

UPON LOOKING UNDER MY TRUCK I NOTICED THE FUEL TANK WAS HANGING DOWN. UPON FURTHER INSPECTION I NOTICED THE REAR STRAP HAD RUSTED AND BROKE APART. THIS LED TO THE REAR OF THE TANK DROPPING DOWN 3-4 INCHES. I REPLACED BOTH STRAPS WITH OEM STRAPS AND AM BACK ON THE ROAD. *TT

Mileage: 171,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK DETACHED FROM THE VEHICLE AS A RESULT OF THE FUEL TANK STRAPS FRACTURING. THE CONTACT STATED THAT THE TANK DID NOT HAVE TO BE REPLACED BUT THE DEALER REPLACED THE STRAPS. THE FAILURE AND CURRENT MILEAGE WAS 137,126.

Mileage: 137,126

THE FUEL TANK STRAPS ON MY 2001 FORD F150 ARE COMPLETELY RUSTED. OTHER AREAS HAVE ALSO RUSTED OUT SUCH AS THE RADIATOR SUPPORTS - RADIATOR AND SHROUD DROPPED OUT AND ARE HITTING AGAINST THE ENGINE FAN. THE PICK-UP BED OF THE TRUCK IS ALSO RUSTING OUT. UPDATED 08/11/11 *BF THE CONSUMER STATED WHEN HE INSPECTED THE STRAPS, HE FOUND ONE OF THEM COMPLETELY COVERED IN RUST, BUT STILL IN TACT. ALSO, THERE WAS UNUSUAL RUSTING ALL OVER THE UNDERSIDE OF THE VEHICLE. THE ENTIRE LOWER RADIATOR SUPPORT WAS ROTTED OUT AND THE UNDERSIDE OF THE PICK-UP BED AND OTHER SUPPORTS HAVE MAJOR RUST. UPDATED 08/12/11 THE CONSUMER STATED WHEN THE SUPPORT GAVE OUT THE RADIATOR AND RADIATOR SHROUD FELL ONTO THE FAN THAT IS MOUNTED TO THE ENGINE. ALSO, THE BALL JOINTS AND STEERING WERE WEARING PREMATURELY DUE TO LACK OF GREASE FITTINGS. UPDATED 08/30/11 *TR

Mileage: 137,805

THE FUEL TANK STRAPS ON MY 2001 FORD F150 ARE COMPLETELY RUSTED. OTHER AREAS HAVE ALSO RUSTED OUT SUCH AS THE RADIATOR SUPPORTS - RADIATOR AND SHROUD DROPPED OUT AND ARE HITTING AGAINST THE ENGINE FAN. THE PICK-UP BED OF THE TRUCK IS ALSO RUSTING OUT. UPDATED 08/11/11 *BF THE CONSUMER STATED WHEN HE INSPECTED THE STRAPS, HE FOUND ONE OF THEM COMPLETELY COVERED IN RUST, BUT STILL IN TACT. ALSO, THERE WAS UNUSUAL RUSTING ALL OVER THE UNDERSIDE OF THE VEHICLE. THE ENTIRE LOWER RADIATOR SUPPORT WAS ROTTED OUT AND THE UNDERSIDE OF THE PICK-UP BED AND OTHER SUPPORTS HAVE MAJOR RUST. UPDATED 08/12/11 THE CONSUMER STATED WHEN THE SUPPORT GAVE OUT THE RADIATOR AND RADIATOR SHROUD FELL ONTO THE FAN THAT IS MOUNTED TO THE ENGINE. ALSO, THE BALL JOINTS AND STEERING WERE WEARING PREMATURELY DUE TO LACK OF GREASE FITTINGS. UPDATED 08/30/11 *TR

Mileage: 137,805

CHECKED FUEL TANK STRAPS AFTER SEEING NEWS REPORTS. 1 STRAP BROKEN 2ND STRAP ABOUT TO BREAK. AT DEALER FOR REPLACEMENT AT MY EXPENSE. UPDATED 08/11/11 *BF THE CONSUMER STATED ONE OF THE STRAPS WAS RUSTED THROUGH AND THE OTHER STRAP WAS RUSTED CLOSE TO A COMPLETE BREAK. UPDATED 08/12/11 *TR

Mileage: 118,000

CHECKED FUEL TANK STRAPS AFTER SEEING NEWS REPORTS. 1 STRAP BROKEN 2ND STRAP ABOUT TO BREAK. AT DEALER FOR REPLACEMENT AT MY EXPENSE. UPDATED 08/11/11 *BF THE CONSUMER STATED ONE OF THE STRAPS WAS RUSTED THROUGH AND THE OTHER STRAP WAS RUSTED CLOSE TO A COMPLETE BREAK. UPDATED 08/12/11 *TR

Mileage: 118,000

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED THAT WHILE APPROACHING A TRAFFIC LIGHT, THE FUEL TANK SEPARATED FROM THE VEHICLE CAUSING GASOLINE FUEL TO SPILL OVER THE ROADWAY. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO DISCOVERED THAT THE FUEL TANK STRAPS WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE FAILURE WAS UNDER INVESTIGATION. THE FAILURE AND CURRENT MILEAGE WAS 115,000. UPDATED 08/15/11 *BF THE CONSUMER STATED BOTH STRAPS FAILED, BREAKING IN THE MIDDLE OF THE STRAP. THE TANK DID DROP TO THE GROUND AND WAS DRAGGED A SHORT DISTANCE. THERE WAS DAMAGE TO THE FUEL TANK AND IT HAD TO BE REPLACED. UPDATED 08/24/11 UPDATED 08/31/11 *BF THE VEHICLE HAS SINCE BEEM REPAIRED. UPDATED 09/01/11

Mileage: 115,000

I WAS DRIVING SOUTH ON HWY 41 IN MILWAUKEE, WI. WHEN I HEARD A DRAGGING SOUND UNDER TRUCK. I PULLED OFF HWY AND DISCOVERED MY GAS TANK WAS DRAGGING FOR APPROX. 2 MILES. WHY IT DIDN'T BLOW UP I AM NOT SURE. TWO STRAPS SNAPPED. I HAD JUST FILLED THE TANK W/ $75.00 IN GAS AND HAD TRUCK TOWED AND APPROX. COST OF GETTING TRUCK FIXED IS $700.00 PLUS THE TOW. *KB

Mileage: 236,000

I HAVE A 2001 FORD F150 REGULAR CAB LONG BED WITH 75,000 MILES. WHILE DRIVING AT APPROXIMATELY 40 MPH THE RIGHT INNER TIE ROD BROKE CAUSING THE VEHICLE TO SHUDDER SIGNIFICANTLY UNTIL I WAS ABLE TO STOP THE VEHICLE. THIS BRIEF SHUDDERING CAUSED THE REAR FUEL TANK STRAP TO SNAP IN HALF PRIMARILY DUE TO EXCESSIVE CORROSION OF THE STRAP. LOSS OF THE SUPPORTING STRAP CAUSED THE REAR OF THE TANK TO DROP ALMOST TO GROUND LEVEL WHICH ALSO BROKE THE FILLER INLET OFF OF THE TOP OF THE TANK, COMPLETELY DISCONNECTING THE FILLER TUBE AND PRESENTING A LARGE HOLE FOR FUEL TO ESCAPE. BOTH OF THESE FAILURES ARE NOT WHAT I WOULD EXPECT FROM A VEHICLE WITH ONLY 75,000 MILES ON THE ODOMETER. EITHER COULD HAVE RESULTED IN SERIOUS INJURY OR PROPERTY DAMAGE. *TR

Mileage: 75,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 TO 40 MPH HE NOTICED THE TANK HAD DETACHED FROM THE VEHICLE. WHEN HE INSPECTED THE VEHICLE HE NOTICED THAT TWO STRAPS WERE FRACTURED AND WERE SEVERELY RUSTED, BUT NO FUEL HAD SPILLED OUT OF THE FUEL TANK. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 126,000.

Mileage: 126,000

BOTH FRONT AND REAR FUEL TANK STRAPS ARE BROKE. TANK IS BEING HELD UP BY FUEL LINE IN REAR. FRONT STRAP BEING HELD ON BY PLASTIC COVER ONLY. IN THE PROCESS OF REPAIRING NOW AT A FORD DEALERSHIP. PARTS COST IS APPROX. $80, LABOR IS STILL NOT CALCULATED. THE CONSUMER STATED BOTH STRAP BROKE IN THE MIDDLE DUE TO SEVERE RUST; THE REAR MORE THAN THE FRONT. THE FUEL LINE WAS STILL IN GOOD SHAPE. IT WAS SUPPORTING THE REAR TANK AFTER THE STRAP BROKE. THE TANK NEVER HIT THE GROUND. WHILE BOTH STRAPS WERE RUSTED OUT COMPLETELY IN THE MIDDLE, THERE WAS A PIECE OF PLASTIC BETWEEN THE STRAP AND THE TANK. THE PLASTIC WAS MOLDED AROUND THE STRAPS WELL ENOUGH THAT THE FRONT OF THE TANK WAS SUPPORTED BY THE PLASTIC PIECE EVEN THOUGH THE METAL STRAP HAD RUSTED AWAY. HOWEVER, THE BACK STRAP HAD RUSTED AWAY TO A POINT THAT THE STRAP FELL AND THE TANK WAS ONLY BEING SUPPORTED BY THE FUEL LINE. UPDATED 09/21/11 *TR

Mileage: 127,500

BOTH FRONT AND REAR FUEL TANK STRAPS ARE BROKE. TANK IS BEING HELD UP BY FUEL LINE IN REAR. FRONT STRAP BEING HELD ON BY PLASTIC COVER ONLY. IN THE PROCESS OF REPAIRING NOW AT A FORD DEALERSHIP. PARTS COST IS APPROX. $80, LABOR IS STILL NOT CALCULATED. THE CONSUMER STATED BOTH STRAP BROKE IN THE MIDDLE DUE TO SEVERE RUST; THE REAR MORE THAN THE FRONT. THE FUEL LINE WAS STILL IN GOOD SHAPE. IT WAS SUPPORTING THE REAR TANK AFTER THE STRAP BROKE. THE TANK NEVER HIT THE GROUND. WHILE BOTH STRAPS WERE RUSTED OUT COMPLETELY IN THE MIDDLE, THERE WAS A PIECE OF PLASTIC BETWEEN THE STRAP AND THE TANK. THE PLASTIC WAS MOLDED AROUND THE STRAPS WELL ENOUGH THAT THE FRONT OF THE TANK WAS SUPPORTED BY THE PLASTIC PIECE EVEN THOUGH THE METAL STRAP HAD RUSTED AWAY. HOWEVER, THE BACK STRAP HAD RUSTED AWAY TO A POINT THAT THE STRAP FELL AND THE TANK WAS ONLY BEING SUPPORTED BY THE FUEL LINE. UPDATED 09/21/11 *TR

Mileage: 127,500

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT ONE THE FUEL TANK STRAPS FRACTURED FROM THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 110,000.

Mileage: 110,000

TL* THE CONTACT OWNS A 2001 FORD F150. THE CONTACT STATED WHILE MAKING A RIGHT TURN AT APPROXIMATELY 10 TO 15 MPH, THE VEHICLE FUEL TANK SEPARATED AS FUEL SPILLED ONTO THE HIGHWAY. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO DIAGNOSED CORROSION OF THE FUEL TANK AND STRAPS. THE FUEL TANK AND STRAPS WERE REPLACED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THAT THE FAILURE WAS NOT RECALLED. THE FAILURE MILEAGE WAS 129,000 AND THE CURRENT MILEAGE WAS 130,000.

Mileage: 129,000

THE FRONT STRAP THAT HOLDS THE GAS TANK ON MY 2001 F-150 HAS RUSTED OFF. I READ WHERE YOU ARE INVESTIGATING THIS FAILURE. IS THERE A CURRENT RECALL? UPDATED 09/14/11 *BF THE STRAP RUSTED AWAY AND BROKE AT A PLACE WHERE THE STRAP WAS BOLTED TO THE FRAME ON THE LEFT SIDE. THE REST OF THE STRAP WAS VERY RUSTY AND CORRODED AND ALSO APPEARED TO BE READY TO FAIL. THE TANK DID NOT DROP. THE BACK STRAP SHOWED SIGNS OF HEAVY RUST. UPDATED 09/21/11 *TR

Mileage: 70,000

THE FRONT STRAP THAT HOLDS THE GAS TANK ON MY 2001 F-150 HAS RUSTED OFF. I READ WHERE YOU ARE INVESTIGATING THIS FAILURE. IS THERE A CURRENT RECALL? UPDATED 09/14/11 *BF THE STRAP RUSTED AWAY AND BROKE AT A PLACE WHERE THE STRAP WAS BOLTED TO THE FRAME ON THE LEFT SIDE. THE REST OF THE STRAP WAS VERY RUSTY AND CORRODED AND ALSO APPEARED TO BE READY TO FAIL. THE TANK DID NOT DROP. THE BACK STRAP SHOWED SIGNS OF HEAVY RUST. UPDATED 09/21/11 *TR

Mileage: 70,000

NO WARNING AT ALL. I WAS DRIVING 10-15 MPH COMING TO A STOP WHEN THE ENTIRE GAS TANK FELL OFF MY 2001 FORD F150 CREW CAB TRUCK. AN ENTIRE TANK OF GAS LEAKED ALL OF THE ROAD AND REQUIRED THE FIRE DEPARTMENT TO BE CALLED FOR SAFETY AND CLEAN UP. I HAD TO HAVE MY TRUCK TOWED TO A REPAIR SHOP, WHERE IT AWAITS DIAGNOSIS TOMORROW. IT APPEARS THAT THE STRAPS AND TANK HAD COMPLETELY RUSTED. I'M LUCKY NOTHING IGNITED SINCE I WAS ABLE TO PULL OVER AND WAS DRIVING SO SLOW. UPDATED 09/14/11 *BF UPDATED 09/16/11 *TR

Mileage: 171,000

NO WARNING AT ALL. I WAS DRIVING 10-15 MPH COMING TO A STOP WHEN THE ENTIRE GAS TANK FELL OFF MY 2001 FORD F150 CREW CAB TRUCK. AN ENTIRE TANK OF GAS LEAKED ALL OF THE ROAD AND REQUIRED THE FIRE DEPARTMENT TO BE CALLED FOR SAFETY AND CLEAN UP. I HAD TO HAVE MY TRUCK TOWED TO A REPAIR SHOP, WHERE IT AWAITS DIAGNOSIS TOMORROW. IT APPEARS THAT THE STRAPS AND TANK HAD COMPLETELY RUSTED. I'M LUCKY NOTHING IGNITED SINCE I WAS ABLE TO PULL OVER AND WAS DRIVING SO SLOW. UPDATED 09/14/11 *BF UPDATED 09/16/11 *TR

Mileage: 171,000

ON 6/10/2011. MY 18 YEAR OLD SON HAD BORROWED MY 2001 FORD F-150. HE HAD STOPPED TO FILL THE FUEL TANK AND CONTINUE ON HIS ERRAND WHEN THE GAS TANK STRAPS SUDDENLY FAILED,DROPPING THE FUEL TANK ONTO THE GROUND WHILE IN MOTION. NO INJURIES OR FIRE RESULTED FROM THE INCIDENT BUT A FULL TANK OF FUEL WAS SPILLED ONTO THE GROUND CREATING A HAZARDOUS MATERIAL SITUATION, CLOSING DOWN THE ROAD FOR A SIGNIFICANT PERIOD OF TIME TO ALLOW FOR CLEANUP. I DON'T HAVE THE FINAL COST FOR REPAIRS OR CLEANUP AND I DON'T KNOW IF AND HOW INSURANCE WOULD COVER THE COST. I WAS SURPRISED TO LEARN THAT THIS HAS HAPPENED TO OTHER SIMILAR YEAR FORD TRUCKS YET NO INFORMATIONAL WARNINGS WERE ISSUED. *TR

Mileage: 94,600

THE GAS TANK STRAP ON MY 2001 FORD F150 LARIAT SUPERCREW HAS RUSTED COMPLETELY THROUGH AND BROKE, MAKING THE GAS TANK LOOSE AND UNSTABLE. IF I WOULD NOT HAVE HEARD THE SQUEAK OF THE LOOSE TANK THAT I THOUGHT WAS MY SPARE TIRE, I WOULD HAVE EVENTUALLY LOST MY TANK WHICH COULD HAVE RESULTED IN A FIRE OR INJURY. I THINK THE STRAP SHOULD BE MADE OF A MATERIAL THAT IS NOT SO SUSCEPTIBLE TO THE ELEMENTS. *TR

Mileage: 146,996

FORD F150 SUPERCREW 4X4 - FUEL TANK STRAP BROKE. TANK JUST HANGING. LUCLILY NOTICED IT AND HAVE ORDERED NEW STRAPS. *TR

Mileage: 203,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING, THE FUEL TANK DROPPED FROM ITS HOUSING AS A RESULT OF ONE OF THE STRAPS FRACTURING. THE FUEL TANK WAS DRAGGED AND CAUSED A HOLE, WHICH CAUSED FUEL TO LEAK FROM THE TANK. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHO ADVISED THAT THE FUEL STRAPS HAD FAILED BECAUSE OF CORROSION AND THAT BOTH THE FUEL STRAPS AND THE FUEL TANK WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 240,000.

Mileage: 240,000

TL*THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING APPROXIMATELY 70 MPH, THERE WAS A LOUD NOISE AND IMMEDIATELY THE VEHICLE WAS MANEUVERED TO SIDE OF THE ROAD. THE CONTACT NOTICED THE FUEL TANK DETACHED FROM THE VEHICLE AND BOTH FUEL TANK STRAPS WERE COMPLETELY RUSTED. THE FAILURE CAUSED DAMAGE TO THE FUEL TANK AS A RESULT TO AN EXTENSIVE AMOUNT OF FUEL LEAKAGE ON THE GROUND. THE VEHICLE WAS TEMPORARILY REPAIRED AND DRIVEN TO THE RESIDENCE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THERE WAS NOT A RECALL AND PROVIDED NO FURTHER ASSISTANCE. THERE WAS AN OPEN INVESTIGATION UNDER NHTSA ACTION NUMBER EA11006 (FUEL SYSTEM, OTHER: STORAGE: TANK ASSEMBLY). THE FAILURE MILEAGE WAS 218,000. UPDATED 07/21/11 *BF THE GAS TANK STRAP BROKE,CAUSING THE TANK TO FALL WHILE DRIVING. UPDATED 07/25/11

Mileage: 218,000

TL*THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING APPROXIMATELY 70 MPH, THERE WAS A LOUD NOISE AND IMMEDIATELY THE VEHICLE WAS MANEUVERED TO SIDE OF THE ROAD. THE CONTACT NOTICED THE FUEL TANK DETACHED FROM THE VEHICLE AND BOTH FUEL TANK STRAPS WERE COMPLETELY RUSTED. THE FAILURE CAUSED DAMAGE TO THE FUEL TANK AS A RESULT TO AN EXTENSIVE AMOUNT OF FUEL LEAKAGE ON THE GROUND. THE VEHICLE WAS TEMPORARILY REPAIRED AND DRIVEN TO THE RESIDENCE. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THERE WAS NOT A RECALL AND PROVIDED NO FURTHER ASSISTANCE. THERE WAS AN OPEN INVESTIGATION UNDER NHTSA ACTION NUMBER EA11006 (FUEL SYSTEM, OTHER: STORAGE: TANK ASSEMBLY). THE FAILURE MILEAGE WAS 218,000. UPDATED 07/21/11 *BF THE GAS TANK STRAP BROKE,CAUSING THE TANK TO FALL WHILE DRIVING. UPDATED 07/25/11

Mileage: 218,000

TL* THE CONTACT OWNS A 2001 FORD F-150.THE CONTACT STATED THAT ONE OF THE FUEL TANK STRAPS WAS FRACTURED AND CAUSED THE FUEL TANK TO DETACH FROM THE VEHICLE. THE FAILURE DID NOT CAUSE A FUEL SPILL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSIS OR REPAIRS. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 210,000.

Mileage: 210,000

2001 FORD F-150. CONSUMER STATES VEHICLE CAUGHT FIRE AND THEN EXPLODED *TGW THE CONSUMER STATED SHE SAW A REPORT ON T.V. REGARDING PROBLEMS WITH FUEL TANKS AND NHTSA WAS INVESTIGATING. *JB

GAS TANK STRAPS FAILED ALLOWING GAS TANK TO DROP ONTO ROAD. *TR

Mileage: 343,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE HEARD A LOUD THUD AND METAL SCRAPING AGAINST THE GROUND. WHEN HE PULLED OVER, HE REALIZED THAT THE FUEL TANK WAS DRAGGING THE GROUND AS A RESULT OF THE FRONT FUEL TANK STRAP RUSTING AND BREAKING. A LOCAL MECHANIC REPLACED BOTH STRAPS. THE CONTACT CALLED THE MANUFACTURER WHO ADVISED THAT THERE WERE NO RELATED RECALLS AND FOR THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 150,000.

Mileage: 150,000

TL*THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH HE WAS TOLD BY A PASSERBY THAT THERE WAS A FIRE UNDERNEATH THE VEHICLE. HE DROVE TO A FIRE STATION AND THE ENTIRE CAB WAS CONSUMED WITH FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE, INSPECTED THE VEHICLE AND STATED THAT THE FIRE WAS CAUSED BY THE FUEL TANK. A FIRE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY NO LONGER HAD THE RECORDS FOR HIS VEHICLE AND COULD OFFER NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE 155,000. UPDATED 06/16/11 UPDATED 08/08/11 *BF UPDATED 08/29/11

Mileage: 155,000

AFTER HEARING ABOUT A POSSIBLE FAILURE OF THE FUEL TANK STRAPS, I INSPECTED MY STRAPS AND FOUND ONE OF THE STRAPS CORRODED TO THE POINT OF FAILURE, IT IS SPLIT AND SEPARATED. I AM NO LONGER DRIVING THIS TRUCK. I WAS GOING TO WAIT A FEW WEEKS TO SEE IF THERE IS A RECALL ON THIS PROBLEM. LUCKILY THIS INFO WAS PUBLISHED TO WARN OTHERS. *TR

Mileage: 67,896

JUST GOT OFF A HIGHWAY TRAVELING AT 60 M.P.H. AND STOPPED INTO A LOWES . UPON RETURNING TO TRUCK TO LEAVE AND BACKING FROM PARKING SPOT THE FULL GAS TANK HIT THE GROUND. NO LINES WERE BROKEN . BOTH STRAPS WERE RUSTED THROUGH.

Mileage: 111,042

TL* THE CONTACT OWNS A 2001 FORD F150 PICKUP TRUCK. THE CONTACT STATED THAT THERE WAS FUEL LEAKING FROM THE FUEL TANK ONTO THE GROUND. THE VEHICLE WAS INSPECTED AND ABNORMAL RUST SPOTS AND HOLES WERE FOUND IN THE FUEL TANK. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE FUEL TANK, STRAPS AND THE FUEL SENSOR ASSEMBLY AT A COST OF $864. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 61,000. UPDATED 10/12/11

Mileage: 61,000

TL* THE CONTACT OWNS A 2001 FORD F150 PICKUP TRUCK. THE CONTACT STATED THAT THERE WAS FUEL LEAKING FROM THE FUEL TANK ONTO THE GROUND. THE VEHICLE WAS INSPECTED AND ABNORMAL RUST SPOTS AND HOLES WERE FOUND IN THE FUEL TANK. THE VEHICLE WAS TOWED TO THE DEALER WHO REPLACED THE FUEL TANK, STRAPS AND THE FUEL SENSOR ASSEMBLY AT A COST OF $864. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 61,000. UPDATED 10/12/11

Mileage: 61,000

TL*THE CONTACT OWNS A 2001 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT HEARD A LOUD NOISE OUTSIDE OF THE VEHICLE. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD TO INSPECT THE VEHICLE AND NOTICED THAT THE FUEL TANK PARTIALLY DISENGAGED. THE VEHICLE HAD NOT BEEN TOWED. THE MANUFACTURER NOR THE DEALER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 127,997.

Mileage: 127,997

TL*THE CONTACT OWNS A 2001 FORD F-150. THE VEHICLE WAS PARKED WHEN THE CONTACT NOTICED THE FUEL TANK WAS HANGING UNDERNEATH THE VEHICLE. THE CONTACT ORDERED THE NECESSARY PARTS FROM THE MANUFACTURER AND REPAIRED THE VEHICLE. WHILE REPAIRING THE VEHICLE THE CONTACT ALSO NOTICED THE STRAPS WHICH HELD THE FUEL TANK IN PLACE WERE CORRODED. THE FAILURE MILEAGE WAS 160,000 AND THE CURRENT MILEAGE WAS 180,000.

Mileage: 160,000

TL*THE CONTACT OWNS A 2001 FORD F-150. WHILE THE CONTACT INSPECTED THE VEHICLE, HE DETECTED THAT THE FUEL TANK STRAP FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FUEL TANK STRAP WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.

Mileage: 170,000

I PULLED AWAY FROM A STOP SIGN AND HEARD A STRANGE SOUND. I STOPPED THE VEHICLE AND LOOKED UNDERNEATH AND SAW THE GAS TANK ON THE GROUND.

Mileage: 106,708

BOTH STRAPS HOLDING THE FUEL TANK ON MY 2001 F-150 BROKE ALLOWING THE GAS TANK TO FALL TO THE GROUND AND BE DRAGGED DOWN THE MASS TURNPIKE(ROUTE 90) I WAS ABLE TO EXIT THE HIGHWAY AND PULL INTO A GAS STATION. UPON EXITING THE VEHICLE I SAW THE TANK ON THE GROUND AND GAS LEAKING FROM IT. THE TRUCK WAS TOWED TO A SERVICE STATION FOR REPAIR. THEY INSTALLED A NEW GAS TANK, STRAPS AND ALL THE LINES. *TR

Mileage: 151,516

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT THE FUEL TANK WAS FILLED AND WHILE DRIVING, THE CONTACT WAS INFORMED THAT THE FUEL TANK HAD FRACTURED FROM THE VEHICLE AND GASOLINE FUEL WAS SPILLING ONTO THE HIGHWAY. THE FIRE DEPARTMENT ARRIVED TO ASSIST AND ADVISED THAT THE STRAPS OF THE FUEL TANK WERE RUSTED AND FRACTURED, CAUSING THE FUEL TANK TO FALL. THE CONTACT HAD THE VEHICLE TOWED TO A LOCAL AUTO REPAIR SHOP. THE FAILURE AND CURRENT MILEAGE WAS 138,000.

Mileage: 138,000

TL*THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THE FUEL TANK STRAP CORRODED AND FRACTURED WHEN THE DRIVER WAS DRIVING APPROXIMATELY 35-40 MPH. APPROXIMATELY TEN GALLONS OF FUEL LEAKED AS A RESULT. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND THEN TO THE CONTACT'S RESIDENCE. A MECHANIC STATED THE FUEL TANK STRAPS AND FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT DID NOT NOTIFY THE MANUFACTURER OF THE FAILURE. THE FAILURE MILEAGE WAS 155,000 AND THE CURRENT MILEAGE WAS 156,000.

Mileage: 155,000

TL*THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE DRIVING AWAY FROM REFUELING, THE FUEL TANK AND FILLER NECK FRACTURED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHERE THEY INFORMED THE FUEL TANK STRAPS AND FRAME WERE CORRODED. THE FUEL TANK, STRAPS AND FILLER NECK WERE ALL REPLACED. THE FAILURE AND THE CURRENT MILEAGES WERE 142,000.

Mileage: 142,000

MY GAS TANK STRAP WAS HANGING BELOW VEHICLE... DEALER SAID IT HAPPENS ALL THE TIME AND ESTIMATE WAS OVER $250 TO REPLACE 2 STRAPS... UNBELIEVABLE... DEALER ALSO SAID 2ND STRAP WAS IN BAD SHAPE AND READY TO BREAK. *TR

Mileage: 172,000

2001 FORD F-150 FUEL TANK STRAPS FAILED AND DROPPED TANK ON ROAD. I WAS IN PARKING LOT BACKING OUT AND IT FELL TO GROUND. HAD TO BE STRAPPED UP AND TOWED TO A SHOP AND THE STRAPS REPLACED. UPDATED 08/04/11 *BF THE CONSUMER STATED BOTH STRAPS BROKE. THE TANK WENT COMPLETELY TO THE GROUND ON THE FRONT. THE TANK WAS AT A 45 DEGREE ANGLE WITH THE FRONT ON THE GROUND. UPDATED 08/11/11 *TR

Mileage: 131,000

TL*THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED WHILE DRIVING 70 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE, CAUSING FUEL TO LEAK. THE CONTACT WAS CONCERNED THAT A FIRE COULD HAVE OCCURRED DUE TO THE FUEL LEAK AND SPARKS. THE FIRE DEPARTMENT APPEARED ON THE SCENE TO APPLY CHEMICALS TO THE FUEL TANK. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE THE FUEL TANK, STRAPS AND FILLER NECK WERE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 157,805. UPDATED 06/01/11*LJ THE CONSUMER STATED BOTH FUEL TANK STRAPS BROKE IN THE MIDDLE DUE TO RUST. UPDATED 08/11/11 THE CONSUMER STATED BOTH GAS TANK STRAPS BROKE. THE FUEL TANK DETACHED AND DRAGGED UNDER THE VEHICLE AND CREATED A HOLE IN THE TANK. UPDATED 12/16/11

Mileage: 157,805

APPROACHING THE EXIT RAMP OFF THE FREEWAY I HEARD A DRAGGING SOUND, THOUGHT IT WAS MY MUFFLER. I PULLED OVER AND GOT OUT AND SMELLED GAS, (JUST FILLED THE TANK AT 4.19 GAL DAY BEFORE) AND SAW THE FRONT OF THE GAS TANK WAS DROPPED AND GAS WAS ALL OVER. HAD TO CALL THE FIRE DEPARTMENT TO PUT OIL DRY OR SOMETHING ON THE RAMP. I WAS FORTUNATE THAT IT DIDN'T SPARK AND THE TRUCK BLEW UP. A FEW DAYS PRIOR WE JUST GOT BACK FROM A TRIP TO SEE THE GRANDKIDS IN UPSTATE NEW YORK. WE DROVE AROUND NY WITH THESE CHILDREN IN THE TRUCK. IT GIVES ME SHIVERS TO THINK IF THIS WOULD HAVE HAPPENED AND A SPARK WE COULD HAVE LOST OUR LIVES AND OUR GRANDCHILDREN. THIS IS A VERY DANGEROUS PROBLEM AND I GUESS FORD HAS KNOWN ABOUT THIS AND WILL NOT TAKE RESPONSIBILITY. WE HAD TO HAVE THE TRUCK TOWED AND A NEW FUEL TANK, VENT VALVE, FUEL PUMP MODULE, PRESSURE SENSOR AND NEW FUEL TANK STRAPS. THE RUSTING OUT OF THE FUEL TANK STRAPS IS WHAT CAUSED THE GAS TANK TO DROP. OUR TOTAL FOR THIS REPAIR WAS 1,674.97. I WOULD THINK THIS IS A SERIOUS SAFETY ISSUE WITH THE STRAPS TO A GAS TANK RUSTING OUT. FORD DOES NOT HAVE A RECALL ON THIS AND I THINK THEY SHOULD.

Mileage: 96,897

WHILE DRIVING AT RESIDENTIAL SPEED THE GAS TANK DROPPED DOWN AND BEGAN DRAGGING ON THE GROUND SPILLING ALL THE GASOLINE CONTENTS. THERE WAS NO WARNING, I JUST HEARD A THUNK AND A DRAGGING SOUND WHICH I ABLE TO PULL OFF TO THE SIDE OF THE ROAD WITHIN A BLOCK, THIS WAS A ONETIME FAILURE. THE LOCAL VEHICLE SERVICE REPAIR SHOP ORDERED A NEW GAS TANK AND NEW TANK HOLDING STRAPS AND REPLACED THE FAILED ONES WHICH WERE RUSTED THROUGH AND HAD LET GO. *TR

Mileage: 180,000

FRONT GAS TANK STRAP RUSTED THROUGH AND BROKE IN HALF. REAR STRAP HAS RUSTED BUT NOT THROUGH YET.

Mileage: 101,000

YESTERDAY, WHILE DRIVING AT ABOUT 35 MPH I HEAR A LOUD NOISE FROM THE BOTTOM OF THE VEHICLE. I PULL OVER TO REALIZE THAT THE ENTIRE GAS TANK HAD COMPLETELY FALLEN OFF OF THE BOTTOM OF THE TRUCK, HAD PUNCTURED, AND WAS SPILLING OVER 20 GALLONS OF FUEL INTO THE ROAD. THE FIRE DEPARTMENT WAS CALLED AND SPENT TWO HOURS CONTAINING THE SPILLED FUEL AND ASSISTING THE TOW TRUCK DRIVER TO READY THE TRUCK SO THAT IT COULD BE SAFELY TOWED. THE METAL GAS TANK STRAPS HAD COMPLETELY RUSTED THROUGH AND BROKE LEAVING THE TANK HANGING ON BY ONLY A COUPLE OF SCREWS. THE TANK HAD TO BE FULLY REMOVED FROM THE TRUCK BEFORE THAT TOW TRUCK DRIVER COULD SAFELY TOW THE TRUCK TO BE REPAIRED. THIS TRUCK IS ONLY A 2001 MODEL AND ONLY HAS 75,000 MILES ON IT. THIS COULD HAVE BEEN A VERY SERIOUS SITUATION GIVEN THE AMOUNT OF FUEL THAT SPILLED AND THAT IT OCCURRED ON A BUSY INTERSECTION. THANKFULLY THERE WAS NO SPARK FROM THE TANK WHEN IT HIT THE GROUND! I THINK GIVEN THE SERIOUS NATURE OF THIS MALFUNCTION FORD REALLY NEEDS TO CONSIDER TAKING A LOOK AT THEIR TRUCKS BUILT IN THIS MODEL YEAR. ESPECIALLY SINCE THIS OCCURRED WITH SUCH A LOW MILEAGE VEHICLE GIVEN IT'S AGE. *TR

Mileage: 75,000

I WAS DRIVING ON THE FREEWAY, DID NOT HIT ANY BUMPS AND HEARD A DRAGGING NOISE FROM THE REAR OF THE VEHICLE. PULLED OFF OF THE FREEWAY AND LOOKED UNDER MY 2001 F150 TRUCK AND SAW THE FRONT OF GAS TANK SITTING ON THE ROAD. THE STRAPS ON THE GAS TANK HAD BROKEN. WAS LUCKY THAT I STOPPED OR ACCORDING TO MECHANIC, COULD HAVE WORN A HOLE IN THE GAS TANK AND CAUGHT FIRE OR EXPLODED UPDATED 08/04/11 *BF THE CONSUMER STATED BOTH GAS TANK STRAPS BROKE IN THE MIDDLE AND THERE WAS SOME RUST AND CORROSION IN THE MIDDLE OF THE STRAPS AND LESS AS THEY GO TOWARD THE BOLTS. UPDATED 08/11/11. *JB *TR

Mileage: 183,000

AFTER PURCHASING THIS USED 4WD F-150 I FILLED THE TANK AND NOTICED THE SMELL GASOLINE. INSPECTION OF THE FUEL SYSTEM REVEALED THE REAR GAS TANK SUPPORT STRAP HAD RUSTED THROUGH. THIS ALLOWED THE TANK TO DROP DOWN AND REST ON THE ROCK GUARD FOR THE TANK. OPERATION OF THE TRUCK IN THIS STATE CAUSED VIBRATIONS TO WEAR THROUGH THE TANK RESULTING IN THE FUEL LEAK. WERE IT NOT FOR THE ROCK GUARD (ON 4WD MODELS ONLY) THE TANK MAY HAVE FALLEN OFF OR AT A MINIMUM LEFT HANGING FROM THE FRONT STRAP AND THE FUEL LINE CONNECTIONS.

Mileage: 107,529

2001 F-150 XLT GAS TANK STRAP RUSTED AND BROKEN, FUEL TANK FOUND TO BE LEAKING NEAR THE TOP OF THE TANK. *TR

Mileage: 122,500

2001 FORD F150 SUPERCREW, FUEL TANK STRAP RUSTED THROUGH SAW FROM A DISTANCE SOMETHING WAS HANGING UNDER TRUCK, CRAWLED UNDER, DISCOVERED STRAP HAD RUSTED THROUGH AND WAS IN TWO PIECES, TOOK OFF PART THAT I COULD AND ATTACHED A RATCHET STRAP TO HOLD TANK IN PLACE UNTIL I CAN GET THE PARTS AND REPAIR. *TR

Mileage: 185,000

DISCOVERED REAR FUEL TANK STRAP ON 2001 FORD F150 WAS BROKEN. FRONT STRAP HEAVILY RUSTED BUT STILL HOLDING. FUEL TANK IS SAGGING BUT NOT DRAGGING. *TR

Mileage: 45,000

WHILE HAVING MY 2001 FORD F-150 4WD SUPER CAB (205,000MILES) SERVICED, IT WAS DISCOVERED THAT THE REAR FUEL TANK STRAP IS COMPLETELY RUSTED OUT AND THE FRONT STRAP IS READY TO FAIL AT ANY TIME. HAD THE DEFECT NOT BEEN NOTICED AT THIS TIME, THE TANK WOULD HAVE DROPPED FROM THE VEHICLE TO THE ROAD AT ANY TIME. REPLACEMENT STRAPS ARE BEING ORDERED. *TR

Mileage: 205,233

STRAPS THAT SECURE FUEL TANK TO VEHICLE FAILED DUE TO RUST . THIS ALLOWING FUEL TANK TO FALL FROM VEHICLE WHILE VEHICLE WAS IN MOTION . UPON CONTACT WITH THE ROAD SURFACE TANK DEVELOPED A HOLE ALLOWING ABOUT 16 GALS OF FUEL TO CONTACT THE ROAD SURFACE AND PUBLIC SEWER . FIRE DEPT WAS CALLED ALONG WITH MARYLAND DEPT OF ENVIRONMENT AND CLEAN UP BEGAN . I WAS BILLED FOR THE COST OF THE CLEAN UP .

Mileage: 86,066

GAS TANK STRAPS CORRODED TO THE POINT OF FAILURE ON A 2001 FORD F150. THE PROBLEM WAS CAUGHT BEFORE COMPLETE RELEASE OF THE GAS TANK. NEW STRAPS WERE PUT ON IN PLACE OF THE ORIGINAL ONES. *TR

Mileage: 140,000

GAS TANK STRAPS FAILED ON MY 2001 FORD F-150. I WAS LEAVING WORK WHEN THE GAS TANK JUST FELL ON THE DRIVEWAY AS I WAS TRAVELING ABOUT 25MPH. I AM VERY FORTUNATE THAT IT HAPPENED AT THIS LOCATION AS THIS SITUATION COULD HAVE BEEN DISASTROUS, LUCKILY I WAS ABLE TO TIE IT BACK UP WITH SOME NYLON STRAPS THAT I HAD WITH SOME HELP FROM A COWORKER. I WAS ABLE TO DRIVE HOME AND REPLACED THE STRAPS WITH NEW ONES, THE OLD STRAPS APPARENTLY JUST RUSTED THROUGH AND FAILED. FORD SHOULD HAVE A RECALL ON THIS PROBLEM BEFORE SOMEONE IS SERIOUSLY HURT!!! *TR

Mileage: 94,077

MT 2001 FORD F150 BEGAN LEAKING FUEL TODAY FROM THE FUEL TANK (UNDERNEATH TRUCK). APPROXIMATELY 3-5 DRIPS PER SECOND WERE OBSERVED TO BE DRIPPING. UPON CLOSER INSPECTION, IT LOOKS AS THOUGH THE METAL STRAPS HOLDING THE FUEL TANK ON THE VEHICLE HAVE CORRODED BADLY AND WORN A HOLE IN THE UPPER PART OF THE TANK. *TR

Mileage: 158,320

2001 F150 FUEL TANK STRAPS AND FUEL TANK RUSTED THROUGH. *TR

Mileage: 54,000

WHILE DRIVING MY 2001 FORD F150 DOWN THE HIGHWAY, A SPARK PLUG BLEW OUT OF THE HEAD AND DAMAGED THE IGNITION COIL. GAS/AIR MIXTURE WAS SENT INTO THE ENGINE COMPARTMENT, AND IF THE PLUG HAD NOT DAMAGED THE COIL, IT COULD HAVE IGNITED THE GAS. THE FUEL LINE IS ALSO JUST ABOVE THE PUG, AND COULD ALSO HAVE EASILY BEEN DAMAGED. *TR

Mileage: 120,000

WHILE DRIVING ON THE HIGHWAY THE STRAPS ON THE FUEL TANK BROKE AND THE FUEL TANK FELL OFF SPILLING APPROXIMATELY 25 GALLONS OF GAS. THIS WAS CAUSED BY THE STRAPS RUSTING AWAY. *TR

Mileage: 93,800

I HAVE A 2001 FORD F150 CREWCAB TRUCK. ON MY WAY HOME FROM WORK, MY VEHICLE STARTED MAKING AN AWFUL NOISE AND THE TRUCK INSTANTLY STARTED WORKING ROUGH. I PULLED OVER AND TURNED OFF THE TRUCK. MY HUSBAND CAME TO CHECK ON ME AND WHEN WE POPPED THE HOOD AND WHEN I TURNED ON THE TRUCK HE SAW THE SPARK PLUG COMING OUT OF THE CYLINDER. I HAVE YET TO HAVE THE MECHANIC LOOK AT IT. AFTER READING UP ON THIS, I SEE THIS IS A RECURRENT PROBLEM ON FORD TRUCKS. I DO NOT UNDERSTAND WHY NOTHING HAS BEEN DONE REGARDING THIS MATTER. I SIMPLY DO NOT HAVE THE FUNDS AVAILABLE TO PAY FOR THIS IF IT IS A MAJOR REPAIR JOB NOR DO I HAVE THE MEANS TO PURCHASE ANOTHER VEHICLE DUE TO THE CURRENT ECONOMIC STATE AND WERE BARELY GETTING BY AS IT IS. I WANT SOMETHING TO BE DONE AND THIS ISSUE WITH FORD INVESTIGATED FURTHER. IT IS A DESIGN FLAW AND THIS IS GETTING RIDICULOUS. DO SOMEONE HAVE TO DIE IN ORDER FOR SOMETHING TO BE DONE. THANK GOD I DID NOT PICK MY KIDS UP YET . THANK GOD I WAS JUST STARTING OFF FROM A LIGHT AND HADN'T EVEN GOT BACK UP TO 20 MPH. THANK GOD IT HAPPENS TO ME AND NOT MY HUSBAND THAT DROVE OUT TO ORLANDO TODAY AND WAS GOING TO USE MY TRUCK. HE WOULD HAVE BEEN SEVERELY HURT OR WORSE IF THIS OCCURRED AT 70+MPH. I HAVE READ THAT THIS COULD COST IN THE THOUSANDS AND WHEN I GET AN ESTIMATE I WILL UPDATE THIS MATTER FURTHER. SOMETHING HAS TO BE DONE, THERE ARE NO MORE EXCUSES. *TR

Mileage: 178,000

WHILE DRIVING MY 2001 F-150 AT APPROX 35 MPH, THE GAS TANK SUDDENLY FELL OFF WHEN BOTH TANK STRAPS FAILED. HOSES AND FILLER NECK KEPT TANK FROM TOTALLY SEPARATING FROM TRUCK. TOWED TO GARAGE AND HAD BOTH STRAPS REPLACED. $272.91. LOOKS LIKE A FREQUENT PROBLEM AFTER LOOKING UP ON LINE. *TR UPDATED 08/01/11 *BF BOTH STRAPS WERE BROKEN WHEN THE CONSUMER CHECKED AFTER PULLING OVER. THEY APPEARED TO HAVE FAILED WHERE THEY WERE MADE TO BEND TO GO AROUND THE TANK EDGE. THERE WAS MINOR RUSTING MOSTLY AT THE BENDS. THE TANK DID IMPACT THE ROAD, BUT WAS ONLY SLIGHTLY DENTED WITH NO COMPROMISE TO THE TANK ITSELF. UPDATED 08/02/11

Mileage: 111,492

THE REAR FUEL TANK STRAP HAS RUSTED AND BROKE IN TWO. *TR

Mileage: 123,000

I FOUND ONE OF THE GAS TANK RETAINING STRAPS BROKEN ON MY 2001 FORD F-150. I AM CURRENTLY CHECKING WITH SUPPLIERS FOR REPLACEMENT FUEL TANK STRAPS AND FOUND THAT THESE STRAPS ARE BEING INVESTIGATED AS A VEHICLE DEFECT. *TR UPDATED 08/01/11 *BF THE CONSUMER STATED ONE OF THE TANKS STRAPS BROKE AND IT BROKE AT THE BEND OF THE STRAP WHERE IT WRAPS AROUND ONE OF THE BOTTOM CORNERS OF THE TANK. THERE WAS NO SPILL, SINCE THE REMAINING TANK STRAP AND WHAT REMAINED OF THE BROKEN STRAP SUPPORTED THE TANK. ASIDE FROM THE BREAK, THE TANK STRAPS APPEARED NORMAL. UPDATED 08/02/11

Mileage: 109,000

ON FRIDAY, SEPTEMBER 17, 2010 THE FUEL TANK ON MY 2001 FORD F-150 TRUCK BROKE FREE OF THE UNDERCARRIAGE AND WAS DRAGGED APPROXIMATELY 200 METERS BEFORE I COULD SAFELY STOP THE VEHICLE. AT THE TIME OF THE INCIDENT, I WAS TRAVELING 60 MPH. UPON EXITING THE VEHICLE, I SMELLED STRONG GASOLINE FUMES AND OBSERVED GASOLINE RUNNING FROM UNDERNEATH THE TRUCK. I MOVED AWAY FROM THE VEHICLE AND CALLED THE FIRE DEPARTMENT AND A TOW SERVICE. FROM A DISTANCE (APPROXIMATELY 150 FEET) THE GASOLINE TANK WAS CLEARLY RESTING ON THE ROAD SURFACE. ONCE HELP WAS ON THE SCENE, GRANULAR ABSORBENT MATERIAL WAS ADDED TO THE GASOLINE WHICH HAD SPILLED ONTO THE ROAD. THE NOW EMPTY GAS TANK WAS SECURED BY ROPE TO THE TRUCK UNDERCARRIAGE, REVEALING A LARGE HOLE IN THE GAS TANK. UPON FURTHER INVESTIGATION, IT WAS NOTED THAT THE STRAPS HOLDING THE TANK HAD BROKE. THE TRUCK WAS REMOVED FROM THE SCENE ON A FLAT-BED TRUCK. THE TOTAL COST ASSOCIATED WITH THE GAS TANK STRAPS BREAKING IS $841.00. *TR UPDATED 08/01/11 *BF THE STRAP FAILED WHERE IT ATTACHED TO THE TRUCK FRAME. THE STRAP ENDS APPEARED TO BE MORE WORN THAN THE STRAP BODY. APPROXIMATELY, 22-34 GALLONS OF FUEL WAS SPILLED. UPDATED 08/02/11

Mileage: 131,000

HELLO, I WAS DRIVING MY 2001, FORD F-150 TRUCK WITH MY SON IN THE REAR CAB ON A RAINY SATURDAY AFTERNOON IN MARCH OF THIS YEAR WHEN THE GAS TANK FELL OUT OF IT AND WAS DRAGGING ON THE GROUND FOR APPROXIMATELY A TENTH OF A MILE BEFORE I PULLED OVER AND DISCOVERED THE PROBLEM. IT WAS LEAKING GAS AND I WAS LUCKY THAT NO SPARK OCCURRED BECAUSE THE PAVEMENT WAS WET OUTSIDE. I HAD THE GAS TANK, STRAPS AND FUEL PUMP COMPLETELY REPLACED AS A RESULT. I ALSO HAVE MANY PICTURES DOCUMENTING THE INCIDENT. *TR UPDATED 08/01/11 *BF UPDATED 1/27/2012 *LN *TR

2001 F-150 FUEL TANK STRAP BROKE LAST WEEK. LUCKILY NOTICED THE TANK SITTING LOW WHEN I PULLED INTO THE DRIVE WITH MY OTHER VEHICLE. 141,000 MILES. NEIGHBOR TOLD ME OF THE INVESTIGATION HE READ IN THE PAPER THE NEXT DAY. *TR UPDATED 08/01/11 *BF THE CONSUMER STATED ONE STRAP FAILED AND THE SECOND WAS BOUND TO FAIL VERY SOON. THE STRAPS RUSTED AND FLAKED IN LAYERS IN THE MIDDLE WHERE THE PLASTIC SLEEVE WAS. THE STRAPS WERE NOT IN GOOD SHAPE. THEY WERE FLAKY. UPDATED 08/02/11

Mileage: 142,000

I HAVE A 2001 FORD 150 PICKUP AND WHILE DRIVING HOME FROM WORK ON THE BELTWAY MY GAS TANK STRAPS BROKE AND MY GAS TANK WAS DRAGGING ON THE ROAD. I DIDN'T KNOW THIS UNTIL I PULLED OVER BECAUSE I HEARD A WEIRD NOISE UNDER THE TRUCK. AFTER INSPECTING ON THE SHOULDER OF THE ROAD I NOTICED THE GAS TANK WAS LAYING ON THE GROUND, BOTH STRAPS HAD BROKE DUE TO RUST. I HAD TO STRAP UP THE TANK WITH TWO TIE DOWNS AND THEN ORDER NEW STRAPS FROM THE DEALER AND REPLACE. *TR

Mileage: 132,000

THE GAS TANK STRAP ON MY 2001 F-150 RUSTED COMPLETELY THROUGH. THE TANK HAS 2 STRAPS HOLDING THE TANK UP INSIDE THE FRAME. THE FRONT ONE WAS INTACT AND THE REAR STRAP RUSTED COMPLETELY IN TWO. MY FRIEND NOTICED MY GAS TANK WAS HANGING DOWN SLIGHTLY AND I WAS SHOCKED TO SEE THE CONDITION OF THE REAR STRAP. I DROVE HOME SLOW AVOIDING POTHOLES,ETC. AND CALLED AN AUTO PARTS STORE TO ORDER A NEW STRAP. I WANTED TO GO WITH A FORD PART BUT THEY ONLY CAME AS A SET AND COST MUCH MORE THAN THE AUTO PARTS STORE. I'M CONCERNED SOMEONE MAY NOT NOTICE THIS CONDITION UNTIL THEIR GAS TANK GOES ROLLING DOWN THE HIGHWAY. *TR

Mileage: 95,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN HE NOTICED DEBRIS COMING FROM UNDER THE VEHICLE AS WELL AS AN ABNORMAL DRAGGING SOUND. THE CONTACT DISCOVERED THAT THE FUEL TANK HAD PARTIALLY FRACTURED FROM THE VEHICLE AND BEGAN DRAGGING. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHERE THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 140,000.

Mileage: 140,000

TL* THE CONTACT OWNS A 2001 FORD F150. WHILE DRIVING APPROXIMATELY 60-65 MPH, THERE WAS AN ABNORMAL DRAGGING COMING FROM UNDER THE VEHICLE. THE CONTACT DISCOVERED THAT THE FUEL TANK WAS SEMI-FRACTURED FROM THE VEHICLE. BOTH STRAPS WERE FRACTURED AND THE FUEL TANK WAS HANGING FROM THE VEHICLE BY THE FUEL LINE. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS TOWED TO HIS PLACE OF RESIDENCE. THE MANUFACTURER WAS CONTACTED BUT WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 191,000.

Mileage: 191,000

WHILE DRIVING ON THE FREEWAY, I HEARD A LOUD POP FROM THE ENGINE COMPARTMENT FOLLOWED BY THE ENGINE RUNNING ROUGHLY AND ACCOMPANIED BY POPPING SOUNDS. WITHIN 10 SECONDS, THE SMELL OF GASOLINE WAS NOTICED. I PULLED OFF AT THE NEXT EXIT, APPROXIMATELY 30 SECONDS LATER, AND CAME TO A STOP. AS I CAME TO A STOP, FLAMES ERUPTED FROM THE HOOD AND THE ENTIRE ENGINE COMPARTMENT WAS ENGULFED IN FLAMES. A FIRE TRUCK ARRIVED WITHIN A FEW MINUTES AND EXTINGUISHED THE FIRE, BUT NOT BEFORE THE FIRE HAD BURNED THROUGH THE FIREWALL INTO THE PASSENGER COMPARTMENT. THE VEHICLE WAS A TOTAL LOSS. UPON FURTHER INSPECTION, IT WAS DISCOVERED THAT THE #8 CYLINDER SPARK PLUG HAD EJECTED FROM THE CYLINDER (THE INITIAL POP SOUND) WITH SUCH FORCE THAT IT RUPTURED THE RUBBER FUEL LINE IMMEDIATELY ABOVE IT AND AFT OF THE STAINLESS FUEL INJECTOR BAR. WITH FUEL SPRAYING FROM THE HOSE, IT WAS THEN IGNITED BY THE COIL WHICH WAS STILL ATTACHED TO THE ENGINE AND EMITTING SPARKS. IT HAS BEEN DOCUMENTED THAT THE CYLINDER HEAD DESIGN IN THIS VEHICLE HAS HAD A HISTORY OF PROBLEMS WITH EJECTING SPARK PLUGS DUE TO A LACK OF ADEQUATE THREADS IN THE SPARK PLUG HOLES. I BELIEVE THIS DEFECT CONTRIBUTED DIRECTLY TO THIS FIRE AND IS A SAFETY HAZARD. *TR

Mileage: 116,000

TL* THE CONTACT OWNS A 2001 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING AT SPEEDS OF 60 MPH, THE FUEL TANK FRACTURED FROM UNDER THE VEHICLE AND ONTO THE ROADWAY. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHO ADVISED THE CONTACT THAT THE TWO STRAPS HOLDING THE FUEL TANK HAD BROKEN. THE FAILURE AND CURRENT MILEAGES WERE 162,852. UPDATED 11/23/10 *CN UPDATED 11/30/10 UPDATED 08/01/11 *BF UPDATED 1/27/2012 *LN

Mileage: 162,852

TL* THE CONTACT OWNS A 2001 FORD F150. WHILE DRIVING AT SPEEDS OF 70MPH THE FUEL TANK FELL FROM THE VEHICLE. THERE WAS A LARGE QUANTITY OF GASOLINE SPRAYING FROM UNDER THE VEHICLE AND ONTO THE HIGHWAY. THE CONTACT WAS ABLE TO MOVE THE VEHICLE OFF THE ROADWAY WITHOUT FURTHER INCIDENT. THE VEHICLE WAS TOWED TO HIS RESIDENCE WHERE THE CONTACT MADE REPAIRS TO THE VEHICLE. THE FUEL TANK STRAPS HAD FRACTURED CAUSING THE FUEL TANK TO FALL FROM PLACE. THE DEALER WAS UNABLE TO PROVIDE ANY ASSISTANCE. THE MANUFACTURE WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 103,000.

Mileage: 103,000

THROTTLE STICKS AFTER STEADY DRIVING IN COLD/SNOW BECAUSE OF FORD'S POOR DESIGN, THEY EVEN STATE IT IN FORD ARTICLE NO. 01-21-5. HAS HAPPENED MAY TIMES TO ME. I JUST FINALLY GOT AN ANSWER TO THE PROBLEM. THE FIX IS OVER 500.00, AND I DON'T HAVE THE MONEY. IT IS THEIR POOR DESIGN, THIS JUST DOES NOT SEEM FAIR. I HAVE HAD SEVERAL CLOSE CALLS DUE TO THIS PROBLEM, THERE REALLY SHOULD BE A RECALL ON THIS. *TR

Mileage: 85,000

FIRE IN ENGINE COMPARTMENT CNG VEHICLE. *BF THE PROBLEM WAS DUE TO THE BI-FUEL CNG AND GASOLINE VEHICLE IN THE CONSUMERS GOVERNMENT FLEET. THE VEHICLE WAS PARKED AND WHEN THE CONSUMER RETURNED HE FOUND SMOKE. THE FIRE SPREAD THROUGH THE ENGINE COMPARTMENT AND CAUSED THE VEHICLE TO BE A TOTAL LOSS. *SC

Mileage: 10,000

FUEL LINES WERE LEAKING BEHIND ENGINE. *MR THERE WAS A GAS SMELL. IT WAS DISCOVERED THE GAS LINES WERE INSTALLED BETWEEN THE FRAME AND THE BED OF THE TRUCK. THE HOLE EVENTUALLY WAS CREATED BY THE FRICTION. *SCC *JB

2001 FORD F-150 CRANK NO START CONDITION.BETWEEN JUNE AND AUGUST OF 2003 MY FORD F-150 HAS BEEN TOWED IN THREE TIMES AND NOT STARTED AT LEAST TWO DOZEN TIMES. THE FIRST DEALER REPLACED THE MAIN FUEL RELAY. THE SECOND TIME IT WAS TOWED TO ANOTHER DEALER AND AFTER FIVE DAYS COULD NOT REPRODUCE THE PROBLEM, AND I PICKED THE TRUCK UP. TWO DAYS LATER THE SAME THING, THIS TIME I HAD THE TRUCK TOWED TO MY HOUSE. A FEW HOURS LATER IT STARTED. AT THIS POINT I'M GETTING VERY IRRITATED. AFTER GOING BACK THRU THIS WHOLE THING I STARTED THINKING IT HAD TO BE THIS MAIN FUEL RELAY AND DECIDED TO DO SOME TESTING ON MY OWN. I WORK IN ELECTRONICS AND SO I GOT A COUPLE TYCO RELAYS AND A CAN OF FREEZE SPRAY. THE NEXT TIME THIS HAPPENED I PULLED THE FORD RELAY AND REPLACED IT WITH A NEW ONE - THE TRUCK STARTED RIGHT UP. THE NEXT TIME I GET THE CAN OF FREEZE SPRAY OUT AND COOL THE RELAY AND THE TRUCK STARTS UP. IM FINDING THIS TO BE WARM WEATHER RELATED AND EVERY TIME IT GET HOT OUTSIDE I CAN PLAN ON THE TRUCK NOT STARTING AFTER DRIVING A SHORT TIME AND THEN SHUTTING OFF. IF THE TRUCK SITS BY ITSELF LONG ENOUGH FOR THE RELAY TO COOL DOWN IT WILL START I THINK FORD SHOULD COME UP WILL A LONG TERM FIX FOR THIS PROBLEM INSTEAD OF REPLACING RELAYS.*AK

WHILE DRIVING THE CONSUMER NOTICED THAT THE FUEL GAUGE INDICATED THE VEHICLE HAD A HALF TANK OF GAS YET THE VEHICLE RAN OUT OF GASOLINE. *NLM

I HAVE HAD NOTHING BUT PROBLEMS WITH THE FUEL INJECTION SYSTEM. THE DEAL DID FIX THE FIRST PROBLEM BUT IGNORED COMPLAINTS THAT THE PROBLEM WAS STILL NOT FIXED. AT 36000 MILES THE DRIVE BELT WENT OUT AND STILL THERE WAS PROBLEMS W/ INJECTORS . NOW DEALERS WILL NOT HONOR WARRANTY BECASUE CURRENT MILEAGE IS 36900 EVEN THOUGH THEY PUT THE FIRST 1,234 WHEN THE TRUCK WAS BOUGHT NEW.*AK

WHILE REFUELING THE GASOLINE TANK, THE NOZZLE CAUGHT FIRE AND BURNED THE SIDE OF THE TRUCK. THE VEHICLE WAS OFF, DRIVER DOES NOT SMOKE AND THERE WAS NO IMMEDIATE KNOWN REASON FOR THE FIRE TO START. NO CELL PHONE USEAGE. KEYS WERE NOT IN THE IGNITION. POSSIBLE STATIC ELECTRICITY.*AK

I TOOK MY 2001 F150 TRUCK IN FOR SERVICE AND I WAS TOLD THE FUEL PUMP NEEDED TO BE REPLACED THE NEXT CALL I GOT WAS TO TELL ME MY TRUCK HAD CAUGHT ON FIRE DURING THE TEST DRIVE AND BURNT TO THE GROUND NEITHER AC COLLINS FORD OR FORD MOTOR COMPANY WILL CLAIM RESPONSIBILITY FOR THIS THEY BOTH SAY IT WAS NOT THEIR FAULT BUT FORD NEVER SENT AN INSPECTOR. *AK