2005 FORD F-150 Engine Problems

The contact owns a 2005 Ford F-150. The contact stated that while driving at 55 MPH, while the brake pedal was depressed, the brakes failed to engage; the contact pulled the vehicle into a Home Depot parking lot, exited the vehicle, and discovered that the engine compartment was on fire. The Home Depot employees came out to the vehicle and extinguished the fire with a fire extinguisher. The Fire Department and Police Department were contacted; however, the contact was unsure if a report was filed for either department. The orgin of the fire was not confirmed however, the fire department informed that timing was critical because any longer the fire would have caused an explosion. No warning lights were illuminated. The vehicle was towed back to the residence, and the vehicle was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 360,000.

Mileage: 360,000

Spark plug blew out no check enginge lite until after coil an plugs replaced now motor has a knocking sound 5/23 not 1969 like date happended onlys puts down even if i select present day

My electrical fixtures have failed or blinks off and on, on its own.

The contact owns a 2005 Ford F-150. The contact stated while driving at an undisclosed speed, he smelled an abnormal fuel odor. Additionally, the contact stated that while the accelerator pedal was depressed, the vehicle failed to accelerate as needed. The check engine warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.

Mileage: 200,000

Pulled out of driveway and made it 50 feet and whole truck shut down right on the road. Could not make the vehical restart no click or anything dead right where it stopped. Could of caused an accident. Had to have truck taken to a shop they took a week to find out that the electrical fuel system harness had a dead short in it. So no fuel going to the feul injectors or to the key to start the vehical. Still have head lights and breaks and radio. Just no way to restart the vehical. They checked thw wires and after unplugging many wires to the fuel system and retesting it started. Left with the truck a day later the same thing happen but this time i had to jump a curb to avoid an accident and coasted into a parking lot. I got out and wiggled a few of the wires and the truck started back up. I made it back to where i was staying only 2 blocks up the road and it died in the parking lot in a stall. That has been over 3 weeks and cant find the parts to fix it even by talking to ford shops. There not able to get this harness due to they have been discontinued...truck has low miles on it and now i dont know what to DO. This is my daily driver for WORK. This shouldnt of happened with the wires being wrapped even the mechanic who has his own shop but also works for Ford as a mechanic he has seen this before and now having problems getting parts. I hope you can help with this matter. Due to its very disturbing to myself when its in good shape and was taken care of and NOW cant get parts..

I BOUGHT USED CASH TRUCK, DROVE FINE FOR FIRST DAY, SECOND DAY WHILE TRUCK WAS IN MOTION AND PUT IN REVERSE IT DIES, TOOK A COUPLE TURNS TO STARTED UP AND IT STARTED CODING THE CAMSAFT SENSORS, GOT CODES CLEARED, AND IT DROVE OK FOR 30 MINUTES COATED AGAIN STARTED TO STALL AND STUTTER A BIT. I HEARD A LOT ABOUT FORDS IN THE CAMSHAFT SENSORS DOES THAT MEAN MY TRUCK IS DONE FOR. MY TRUCK HAS TO CAMSHAFT SENSORS. 5.4

Mileage: 183,459

SPARK PLUGS AND COIL PACK CONTINUE TO EJECT THEMSELVES FROM THE CYLINDER HEAD.(F150 BLOWN OUT SPARK PLUG). THIS CONTINUES TO BE A PROBLEM AND HAS OCCURRED WHILE THE CAR IS IN MOTION ON THE HWY., TRAVELING AT A SPEED OF ABOUT 30 MPH.

Mileage: 150,000

THE ENGINE TIMING SYSTEM FAILED CAUSING THE ENGINE TO STOP WITHOUT WARNING. THIS FAILURE OCCURRED ON A CITY STREET. A FELLOW WHO HELPED PUSH THE TRUCK TO THECURB MENTIONED THE TRITON ENGINE IS 'KNOWN FOR THIS PROBLEM'.

HAD VEHICLE TOWED TO A REPAIR GARAGE TO HAVE STARTER REPLACED.ACCORDING TO REPAIR TECH.WHILE LIFTING TRUCK A LOT OF CRACKING SOUND S INSPECTION OF FRAME REVILED EXCESSIVE RUSTING AND CRACKS .THEY CALLED AND TOLD ME TRUCK WAS UN SAFE TO USE.HAVE BILLS WITH STATEMENTS MADE BY REPAIR SHOP.

Mileage: 1,150,000

MY TRUCK IS RATTLING BAD AND ITS THE TIMING CHAIN FORD SHOULD HAVE RECALLED THIS BECAUSE IT IS A KNOWN PROBLEM. THE OIL SEALS ON THE TENSIONERS START LEAKING CAUSING THEM TO NOT KEEP THE CHAIN TIGHT LIKE IT SHOULD BE AND ALSO FAILS TO PUSH OIL AROUND TO THE RIGHT SIDE CAM WHICH CAUSES IT TO FAIL. THIS SHOULD BE RECALLED IT IS DANGEROUS AND COULD CAUSE INJURIES IF THE TRUCK STALLS OUT. ALSO THE SPARK PLUGS BLOW OUT OF THE HEADS CAUSING VERY HIGH REPAIR BILLS. THIS ALSO COULD CAUSE A ACCIDENT RESULTING IN DEATH. FORD HAS KNOWN ABOUT THIS PROBLEM BUT YET HAS DONE NOTHING TO MAKE IT RIGHT. FORD SHOULD STAND BEHIND THERE MISTAKE AND MAKE IT RIGHT FIX OR REPLACE THE ENGINE NO MATTER WHAT THE MILEAGE IS BECAUSE THEY KNEW ABOUT IT. MY TRUCK REPAIRS WILL COST OVER $7000 DOLLARS TO FIX BECAUSE FORD WOULD FIX THE PROBLEM THEY KNEW ABOUT. I CHANGE MY OIL EVERY 3000 MILES WITH VAL OIL AND LUCUS OIL STABILIZER BECAUSE OF THIS ISSUE IT SEEMS TO HELP THE RATTLE ALITTLE BUT ITS JUST GOING TO GET WORSE AND I CANT AFFORD $7000 TO REPLACE AN ENGINE. *TR

Mileage: 175,000

ENGINE TAPPING WHEN WARM ONLY AT IDLE DOESN'T DO IT WHILE COLD OR WHILE DRIVING I HAD A MECHANIC LOOK AT IT AND HE SAID IT'S DUE TO A DESIGN FLAW WITH FORD 5.7 ENGINES.

Mileage: 215,000

WHILE DRIVING 75 MPH ON INTERSTATE 40, VEHICLE WENT INTO FAIL SAFE MODE (HAPPENED A COUPLE OF TIMES). SUBSEQUENTLY, ENGINE BEGAN WITH A TICKING NOISE WITH EVER INCREASING RATTLING/SHAKING TO A POINT THAT THE ENGINE HAD TO BE TURNED OFF. THIS HAPPENED NUMEROUS TIMES WHILE STOPPING OR IDLING IN CITY TRAFFIC. LOCAL FORD DEALERSHIP REPLACED ALL COILS & PLUGS, THROTTLE BODY, FUEL FILTER, ETC. VEHICLE RAN FINE FOR SIX MONTHS, HOWEVER THE RATTLING, KNOCKING, SHAKING, SURGING, STALLING HAVE RETURNED TWO FOLD. VEHICLE IS NOW EXPERIENCING A MASSIVE OIL LEAK FROM THE ENGINE. HAD IT CHECKED BY AN INDEPENDENT MECHANIC WHO COULD NOT MAKE THE REPAIRS (BUT DID COMPLETE AN OIL CHANGE). FORD MOTOR COMPANY IS TOTALLY RESPONSIBLE FOR THESE ISSUES. THESE ISSUES ARE NOT JUST INCONVENIENT AND EXPENSIVE BUT MORTALLY DANGEROUS TO THE PASSENGERS OF THE VEHICLE AS WELL AS TO ANYONE IN CLOSE PROXIMITY. STEP UP FORD!

Mileage: 170,000

1. BRAKE DOT 3 IS RUNNING OUT AFTER SEVERAL MONTHS. WHEN I APPLY THE BRAKES, THE VEHICLE KEEPS GOING. IN ORDER TO KEEP THE VEHICLE RUNNING, I MUST PUSH DOWN THE BRAKE VERY HARD TO STOP THE VEHICLE. I HAVE TO CONSTANTLY REFILL THE OIL TANK. 2. WHEN DRIVING ON THE HIGHWAY AND THE SPEED REACHES AT AROUND 45-65 MPH, THE VEHICLE AUTOMATICALLY LOSES POWER AND HIT AT 3-5 MPH BEFORE STOPPING. AFTER I COMPLETELY TURN OFF AND RESET THE BATTERY, THE VEHICLE STARTS NORMAL AGAIN. THE VEHICLE HAPPENED FROM 2009 TO CURRENT TIME, BUT THE ODB SCAN DOES NOT DETECT ANY CODE OR ERRORS.

Mileage: 75,000

TL* THE CONTACT OWNS A 2005 FORD F-150. UPON STARTING THE VEHICLE, IT IDLED AND THE CONTACT HEARD A RATTLING NOISE COMING FROM THE ENGINE. THE CONTACT ALSO STATED THAT THE VEHICLE HAD AN OIL LEAK AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC TO HAVE THE IGNITION COILS REPLACED; HOWEVER, THE FAILURES CONTINUED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 184,994.

Mileage: 184,994

LETTER FROM THE OFFICE OF THE ATTORNEY GENERAL STATE OF ILLINOIS ON BEHALF OF CONSTITUENT REGARDING HIS 2005 FORD F150 FORD TRUCK AND A FAULTY ENGINE WHICH WAS NOT DISCLOSED BY THE COMPANY. *LD *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, IT SHOOK WHILE IDLING AT A RED LIGHT AND STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WOULD NOT RESTART WHEN PROMPTED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HEAD GASKET WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000. *TT

Mileage: 94,000

VEHICLE STALLS AND OR SURGES AND HAS DEAD SPOTS. AFTER MANY ATTEMPTS TO SOLVE THE ISSUE IT STILL PERSISTS. LOOKING ON LINE IT IS A COMMON PROBLEM WITH THIS VEHICLE.2005 -2008 F 150 5.4. IT IS ESPECIALLY DANGEROUS WHEN TOWING A TRAILER MY WIFE HAS ALMOST GOT INTO ACCIDENTS A COUPLE OF TIMES WHILE TOWING A HORSE TRAILER AND IS NOW AFRAID TO DRIVE THE TRUCK. SPOKE TO FORD BUT NO REAL RESPONSE. I THINK THIS ISSUE NEEDS TO BE LOOKED AT FURTHER ESPECIALLY WHEN CONSIDERING PEOPLE DO TOW WITH THEIR TRUCKS AND IT AMPLIFIES THIS ISSUE. THANKS MARIO .

Mileage: 62,500

FORD HAD AN EXTENDED WARRANTY ON THEIR 2005 5.4L ENGINES IN THE F-150 TRUCKS. THE EXTENDED WARRANTY WAS FOR CUSTOMER SATISFACTION PROGRAM 07M08. THE EXTENDED WARRANTY COVERED FUEL INJECTOR FAILURES BUT FAILED TO COVER THE RESULT OF THOSE FAILURES. I LOST SEVERAL INJECTORS WHICH RESULTED IN "DAMAGE TO OTHER POWERTRAIN COMPONENTS." THOSE COMPONENT WERE THE CATALYTIC CONVERTERS. BOTH OF MY CATALYTIC CONVERTERS FAILED. THE VEHICLE WOULD HESITATE WHEN ACCELERATING AND FUEL CONSUMPTION INCREASED AS THE CATALYTIC CONVERTERS CONTINUED TO FAIL. EMISSION TESTING WAS NEVER PERFORMED OF THIS VEHICLE. I CAN BE ASSUMED THAT EMISSION TESTING WOULD HAVE FAILED WHILE THE VEHICLE WAS STILL UNDER THE 07M08 COVERAGE.

Mileage: 164,000

EXHAUST MANIFOLDS ARE LEAKING AND CAUSING EXHUST FUMES TO ENTER THE VEHICLE. TRUCK HAS APROX 120,000, ISSUE STARTED AT AROUND 80,000. IT'S AT THE POINT NOW WHERE IT MAKES PEOPLE IN THE TRUCK SICK AND IT WON'T PASS STATE INSPECTION. CAM PHASERS MAKE NOISES AS WELL. WO KNOW WHEN THIS ENGINE WILL FAIL. COMMON PROBLEMS WITH THE 5.4 V8 ENGINE. WELL DOCUMENTED ON THE INTERNET.

Mileage: 120,000

PURCHASED FORD F150 FROM OLD SAYBROOK FORD, FEB. 16. THE TRUCK HAS THE 5.4 ENGINE WHICH HAS NUMEROUS COMPLAINTS OF ENGINE FAILURE. DRIVING ON ROUTE 1 WHEN TRUCK ECCELORATES OR LOSES POWER. WHEN WE BOUGHT THE TRUCK THE CHAIN GUIDE WAS BROKE AND EATING THROUGH THE CASE. SPARK PLUGS GET STUCK IN ENGINE OR PROPEL THEM SELVES THROUGH THE TRUCK HOOD. DANGEROUS ENGINE TO HAVE ON ROAD. I OWE 8000.00 ON A TRUCK THAT NOW NEEDS 4-6000 WORTH OF WORK.

Mileage: 136,000

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE OPERATING THE VEHICLE, THE ODOR OF EXHAUST FUMES WAS PRESENT INSIDE THE VEHICLE. ALSO, WHEN THE ENGINE WAS STARTED, A TICKING TYPE NOISE WAS HEARD UNDER THE HOOD ON THE PASSENGER SIDE. THE CAUSE OF THE FAILURES WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND LOCAL UNKNOWN DEALER WERE NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 130,600.

Mileage: 130,600

FOLLOWING PURCHASE FROM A FORD DEALERSHIP WITH A TUNE UP AND MILAGE RELATED SERVICE COMPLETED MY 2005 FORD F150 RAN FOR LESS THAN 6000 MILES BEFORE A STUCK FUEL INJECTOR CAUSED A FAILURE OF THE ENGINE. AT THE TIME I WAS COMING TO A STOP UNDER NORMAL CONDITIONS FOLLOWING A 18 MILE COMMUTE FROM MY PREVIOUS STOP. A METALLIC SOUND WAS HEARD AND THE DRIVE BECAME SHAKY AND WEAK IN ACCELARATION. I PROCEEDED 4 BLOCKS TO THE DEALERSHIP TO ASSESS THE PROBLEM.THE FAULTY FUEL INJECTOR WHICH WAS UNDETECTED UNTIL COMPLETE FAILURE AND RESULTING DAMAGE TO ENGINE COMPONENTS. THIS PROBLEM IS WELL DOCUMENTED BY OTHER FORD OWNERS ONLINE WILL COST MY FAMILY OVER $6000 WITHOUT A RECALL ON THE PARTS KNOWN TO FAIL WIDELY IN THESE VEHICLES.

Mileage: 112,500

I AM THE SECOND OWNER OF MY 2005 FORD F-150 XLT 5.4L 3V 4X4 CREW CAB (VIN# AVAILABLE ON REQUEST) AND THERE IS A LOUD KNOCKING NOISE COMING FROM THE ENGINE. I CAN HEAR THE NOISE WHILE IDLING IN DRIVE, IDLING IN REVERSE, IDLING IN NEUTRAL, IDLING IN PARK AND TRAVELING UNDER LOW THROTTLE AND/OR POWER IN ANY GEAR(IT IS ESPECIALLY LOUD WHEN THE ECHOES BOUNCE OFF OF A HARD-SIDED BUILDING, SUCH AS A DRIVE-THROUGH RESTAURANT). THE EVENTS LEADING TO MY BREAKDOWN ON A BUSY ACCELERATION RAMP ARE AS FOLLOWS: MY VEHICLE LOST ALMOST ALL POWER ON AN ACCELERATION RAMP, SLOWING ME DOWN TO A CRAWL. IT ALSO CAUSED MASSIVE OIL LEAKING FROM THE ENGINE COMPARTMENT, WHICH RESULTED IN ROAD SPILLAGE, CAUSING UNSAFE DRIVING CONDITIONS FOR ME AND THE PEOPLE AROUND ME. I'VE DONE SOME INDEPENDENT RESEARCH AND HAVE PERSONALLY HAD THIS ISSUE FIXED ONCE. I'VE HAD IT FIXED AT A MECHANIC, THE RESULTING REPAIR COSTS ENDED UP BEING ~$3500. FULL DIAGNOSTIC AND REPAIR RECEIPT IS AVAILABLE UPON REQUEST, BUT THE MAIN ISSUES WERE THE CAM PHASER, AND TIMING CHAIN. I HAVE SEEN MULTIPLE UPON MULTIPLE COMPLAINTS ABOUT THIS ISSUE, AND I AM FORMALLY REQUESTING THE NHSTA TO INVESTIGATE AND HOLD THE FORD MOTOR COMPANY (HEREAFTER REFERRED TO AS "FORD") RESPONSIBLE FOR THIS POOR DESIGN CHOICE. I WOULD LIKE TO SEE A RECALL FOR EVERY FORD F-150 REPORTED WITH THIS ISSUE, AS WELL AS REIMBURSEMENT FOR ANY DOCUMENTED REPAIRS CONDUCTED BY MECHANICS FROM FORD. THIS MAY BE AN OUTLANDISH REQUEST THAT MAY NOT EVEN BE IN THE NHSTA'S CUMULATIVE POWER, BUT, AS A TAXPAYER, A WORKING MAN, AND MOST IMPORTANTLY, A HUSBAND, I WOULD LIKE TO SEE ACTION TAKEN BY THE PEOPLE I PUT MY FAITH IN, TO RECTIFY THIS SITUATION. THANK YOU FOR YOUR TIME, AND GOOD DAY.

Mileage: 109,000

VEHICLE WENT INTO "FAILSAFE" MODE ON TWO SEPARATE OCCASIONS WITHIN THE LAST YEAR! AND MOST RECENTLY, TWO WEEKS AGO! BOTH AT HIGHWAY SPEED ON TWO DIFFERENT INTERSTATES IN FLORIDA! VERY DANGEROUS, AND HARD TO CONTROL VEHICLE TO "LIMP" TO A SAFE PLACE TO STOP! MANY POSSIBLE CAUSES FROM ELECTRICAL, FUEL, OR ENGINE ISSUES THAT ARE WELL DOCUMENTED ON MANY INTERNET SITES AND F150 FORUMS! ALSO RUST ISSUES ON ROOF OF VEHICLE IN RAIN CHANNELS! VERY COMMON,AND VERY POOR DESIGN!

Mileage: 148,000

MY 2005 F150 XLT 4.6L ENGINE BLEW OUT THE #3 SPARK PLUG. THIS IS A TERRIBLE INCONVENIENCE AND FRIGHTENING TO THINK THAT IT COULD HAPPEN AT ANY TIME AND LEAVE YOU STRANDED IN THE MIDDLE OF "NO WHERE", A VERY DANGEROUS SITUATION, COULD EVEN BE LIFE THREATENING AND YET FORD WILL NOT OWN UP AND TAKE RESPONSIBILITY FOR THEIR INADEQUATE DESIGN. TO THINK THAT THIS COULD HAPPEN AT ANY TIME AND LEAVE ME STRANDED IN THE MIDDLE OF "NO WHERE" IS VERY FRIGHTENING AND COULD BE DANGEROUS AND LIFE THREATENING. THIS COULD PROVE VERY COSTLY AT $280 A PLUG..

Mileage: 118,000

I WAS DRIVING IN MY 2005 FORD F-150 5.4 WHEN THE ENGINE SHUT OFF ON ITS OWN. IT WAS NOT THE FIRST TIME. IT HAS HAPPENED WHILE I'M DRIVING IN THE MIDDLE OF TRAFFIC. JUST RECENTLY I WAS DRIVING WHEN I STARTED TO LOOSE POWER, BUT THIS TIME STARTED HEAR A LOUD BANGING COMING FROM THE ENGINE. I DROVE THE TRUCK WITH ALMOST NO POWER TO THE MECHANIC. THERE I WAS TOLD THAT IT A CAM SHAFT ISSUE. AS THEY UNCOVERED THE ENGINE II WAS TOLD I WOULD A NEW ENGINE AT THE COST OF $7500. AS I LATER WENT ONLINE I FOUND MANY PEOPLE COMPLAINING ABOUT THE SAME THING WITH FORD 5.4 ENGINES. IT SEEMS TO ME FORD KNOWS ABOUT THE PROBLEM BUT ARE NOT WILLING TO STAND BY THEIR PROBLEM. I HAVE KEPT UP WITH THE MAINTANANCE SINCE HAVE BEEN THE ONLY OWNER OF THE TRUCK. I LOVE THE TRUCK BUT I'M VERY DISAPPOINTED WITH FORD NOT TAKING RESPONSIBILITY FOR HAVING ENGINEERED A BAD ENGINE. I THE SINGLE PROVIDER OF MY FAMILY AND DON'T HAVE MONEY TO BE THROWING AWAY ON NEW VECHICAL. I ALSO BELIEVE THE TRUCK STALLING OUT IN THE MIDDLE OF A HIGHWAY WAS COMPLETELY DANGEROUS AND I WAS LUCKY NOT BE HIT BY ANYONE ELSE. PLEASE HELP.

Mileage: 98,000

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING VARIOUS SPEEDS OR WHILE THE VEHICLE WAS PARKED, A LOUD NOISE COULD BE HEARD COMING FROM THE ENGINE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED WITH A CAM PHASER ISSUE. THE CONTACT STATED THAT THE CAM PHASER, SOLENOID, AND TENSIONER NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED, BUT THE ISSUE PERSISTED WITH AN EVEN LOUDER NOISE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000.

Mileage: 88,000

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE LOST POWER AND MISFIRED, AND SMOKE COULD BE SEEN COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INITIALLY DIAGNOSED A FUEL LEAK FROM THE EXHAUST. UPON FURTHER INVESTIGATION, THE MECHANIC STATED THAT INJECTOR NUMBER 7 WAS NOT CLOSING CORRECTLY AND CAUSING THE FUEL TO ENTER THE CYLINDER. AS A RESULT, THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM A RECALL ON THE INJECTORS. THE RECALL DETAILS WERE NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 76,000.

Mileage: 76,000

I NEEDED A NEW TRANSMISSION LAST YEAR. JUST BLEW OUT OF NO WHERE. THIS YEAR ALONE I NEEDED NEW HUBS, ALL8 CYLINDERS HAVE A MISS FIRE MY TRUCK DROPPED FROM 60 TO TEN IN SECONDS SO SCARY

BOUGHT TRUCK NEW, HAS AN ENGINE TICKING THAT CONTINUES TO GET LOUDER. PROPERLY SERVICED AS PER OWNERS MANUAL. ENGINE NEEDS REPLACED PER MECHANIC.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE AT 65 MPH, THE VEHICLE BEGAN STALLING INTIMITTENTLY THEN THE ENGINE AND MAINTANENENCE WARNING LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO A MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR FILTER WAS OUTDATED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 108,000.

Mileage: 108,000

TRUCK WAS BOUGHT AND I REPLACED ALL SPARK PLUGS AND EVEN HAD TO REPLACE A CLINOID BECAUSE WAS TOLD THAT WAS THE PROBLEM. ITS NOT... THERE IS A BALL VALVE IN THE TRANSMISSION THAT KEEPS THE TRUCK FROM BUILDING ENOUGH PRESSURE TO BE ABLE TO SHIFT WHICH THROWS A CODE AND SAYS MISFIRE ON 6 BEEN REPLACED TWICE NOW SO CLEARLY NOT THE PROBLEM. THIS IS A MAJOR ISSUE.. TRUCK FEELS AS IF FIXING TO FIE THEN CHECK ENGINE LIGHT WILL COME ON START FLASHING BUT THROW NO CODES AND YOU CANT SPEED BACK UP BECAUSE IT FEELS LIKE YOUR TRUCK IS ABOUT TO DIE AND YOU DON'T WANT TO BLOW YOUR MOTOR.

Mileage: 130,000

BOUGHT THE TRUCK USED AT 150000 MILES. AFTER 5000 MILES THE LOUD TICKING THAT THESE TRUCKS ARE KNOWN FOR BECAME LOUDER. AT 161000 MILES THE ENGINE DIED. I STARTED IT UP IN MY DRIVEWAY ONE MORNING AND INSTEAD OF JUST TICKING, IT WAS KNOCKING 100X LOUDER. THE TRUCK BEGAN SHAKING VIOLENTLY. THEN IT JUST DIED. ALL THIS HAPPENED IN A MATTER OF MINUTES. HAD IT TOWED TO A SHOP, AND THEY SAID I NEED A WHOLE NEW ENGINE. I CAN'T HELP BUT THINK IF I WAS DRIVING AND THIS HAPPENED, WHAT THE OUTCOME WOULD BE. I HAVE READ HUNDREDS OF COMPLAINTS FROM PEOPLE ONLINE SAYING SIMILAR THINGS. FORD IS AWARE OF THE PROBLEM, BUT NO RECALL WAS ISSUED. THAT IS IRRESPONSIBLE, AND VERY DANGEROUS ON FORD'S PART.

Mileage: 160,478

#8 CYLINDER SPARK PLUG BLEW OUT WHILE DRIVING. REPLACED ALL SPARK PLUGS AND TORQUED. FOUR DAYS LATER #8 PLUG BLEW OUT AGAIN WHILE DRIVING.

Mileage: 178,000

BRAKE BOOSTER VACUUM SUPPLY METAL STAND PIPE RUPTURED. THIS WAS WHILE DRIVING. LOSS OF VACUUM AND LOSS OF ENGINE PERFORMANCE AND BRAKES WERE SLUGGISH. HAVE TO PUSH ALL WAY TO FLOOR.

Mileage: 210,000

WHILE DRIVING 75 ON A TOLL ROAD THE ENGINE WENT INTO ENGINE FAIL SAFE MODE, I LOST ALL POWER AND ALMOST WRECKED INTO ONCOMING TRAFFIC TRYING TO GET TO THE SHOULDER, I WENT TO A MECHANIC AND THEY REPLACED THE THROTTLE BODY, 3 DAYS LATER SAME THING, I WAS TOLD THIS IS A COMMON PROBLEM ON THIS MOTOR 5.4, WHY IS THERE NOT A RECALL ON THIS ??

Mileage: 143,000

5.4 3V TRITON. WHEN THE TRUCK IS AT IDLE AT A NORMAL OPERATING TEMP, IT HAS A HORRIBLE KNOCKING NOISE ON THE PASSENGER SIDE OF THE ENGINE. FROM WHAT I AM READING THIS ENGINE HAS MAJOR PROBLEMS WITH THE CAM PHASERS AND TIMING COMPONENTS. IT SOUNDS LIKE THE TIMING CHAIN IS ABOUT TO FLY OUT OF THE ENGINE. I HOPE MY TRUCK DOESN'T GIVE OUT ON ME BECAUSE THIS IS MY ONLY TRANSPORTATION TO WORK AND CANNOT AFFORD TO HAVE IT FIXED. I BOUGHT A FORD FOR RELIABILITY, BUT UNTIL THIS IS FIXED I FEEL IT'S UNRELIABLE. I HAVE USED A FULL SYN OIL AND THE RIGHT MOTORCRAFT 820S FILTER. THIS IS A MAJOR PROBLEM AND FORD NEEDS TO PAY FOR THIS AND EVERYONE ELSE WHO HAS HAD THIS PROBLEM OVER AND OVER! RECALL THIS FORD!

TRUCK BEGAN TICKING VERY LOUDLY, THEN BEGAN A KNOCKING NOISE, AND NOW THE ENGINE SHAKES THE TRUCK WHEN IDLING. CAM PHASERS BROKE APART CAUSING DAMAGE TO THE TIMING CHAIN. SUDDEN LOSS OF POWER TO THE ENGINE AS WELL AS INABILITY TO MAINTAIN SPEED WHILE ASCENDING AN INCLINE IS FREQUENT. THE LOSS OF SPEED AND POWER HAS CAUSED US SEVERAL CLOSE-CALL ACCIDENTS. TRUCK WILL SIMPLY NOT ACCELERATE WHILE PRESSING THE GAS PEDAL. ADDITIONALLY, IT ALSO FEELS LIKE THE TRUCK CANNOT CATCH GEARS WHILE IN MOTION.

Mileage: 155,000

I WAS DRIVING THROUGH THE COUNTRY, AND SOMETHING FELT ODD. AT APPROXIMATELY 45 MPH, THE TRUCK STARTED TO SHAKE, (MORE THAN NORMAL) AND WAS THEN VANISH AFTER 55 MPH. AFTER THE NEXT FEW DAYS, THE SHAKING GOT WORSE. MY FIRST THOUGHT, "I HAVE A MISFIRE ON ONE OF MY CYLINDERS". ON MY WAY HOME FROM WORK MY TRUCK THROUGH A CHECK ENGINE LIGHT. I THEN PROCEEDED TO TAKE IT TO MY DEALER BECAUSE AT THIS POINT IT WOULD BARELY GO OVER 40 MPH. THEY CHECKED THE CODE AND TURNS OUT THAT THE TRUCK HAS A NUMBER OF PROBLEMS; THAT WHAT I HAVE SEEN ON THIS WEBSITE ARE A VERY COMMON ISSUE WITH THIS YEAR AND ENGINE TYPE (5.4L V8 TRITTON). I NEED NEW VCT SOLENOIDS, NEW CAMPHASERS, TIMING ADJUSTMENTS, AND NEW CAM SHAFT POSITION SENSORS. TO MAKE A LONG STORY SHORT, THE COMMON PROBLEM THAT HAPPENS TO THIS ENGINE, HAPPENED YET AGAIN. BAD CAM PHASERS. HAPPENED AROUND 138,4XX MILES. NOT SURE IF ANY PREVIOUS OWNER REPLACED THIS PART BEFORE OR NOT. BUT, IT SEEMS EVEN IF REPLACED, THE PROBLEM WILL STILL PERSIST IN THE FUTURE. THIS IS IN NEED OF RECALL.

Mileage: 138,400

TL* THE CONTACT OWNS A 2005 FORD F-150. THE STATED WHILE DRIVING, THERE WAS AN ABNORMAL KNOCKING NOISE COMING FROM THE ENGINE. THE CONTACT STATED HE DROVE THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CAM PHASER, THE BEARING AND THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS BACKFIRING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

Mileage: 118,000

I DRIVE A 2005 5.4 TRITON AND AFTER 110000 MILES THE ENGINE HAS DIED. THE MECHANIC STATES ITS THE CAM PHASER AND I'VE SEEN SEVERAL WEBSITES COMPLAINING THE SAME ISSUE.

Mileage: 110,000

PURCHASED MY VEHICLE USED AT THE DEALERSHIP WITH 85,000. WHICH IS TYPICALLY A GOOD BREAK-IN POINT FOR A TRUCK. WELL AFTER HAVING THE VEHICLE HOME FOR LESS THAN A MONTH I'VE NOTICED A TICKING IN THE ENGINE. A TICKING THAT I KNEW LITTLE ABOUT UNTIL FURTHER RESEARCH INTO THESE VEHICLES. SEEMS THAT ALONG WITH THOUSANDS OF OTHER PEOPLE IN THE WORLD I'VE PURCHASED A FORD LEMON. THE ENGINES RARELY MAKE IT PAST 75,000-100,000. FORD AS A WHOLE ARE AWARE OF THIS ISSUE AND DELIBERATELY FIND WAYS AROUND HAVING TO TAKE THE LIABILITY ON. THE ONLY SOLUTION TO THE TICKING IS 1,500 IN REPAIRS OF THE CAM PHASER, WHICH IN A TIMELY MANNER MELTS LIKE BUTTER OR REPLACE IT WITH A REMANUFACTURED ENGINE ONLY TO ENCOUNTER THE SAME ISSUE. WHETHER OR NOT THIS VEHICLE IS OVER 10 YEARS OLD THIS IS AN ISSUE THAT NEEDS TO BE ADDRESSED. AN ENGINE SHOULD BE ABLE TO LAST MORE THAN 100,000 MILES. I HAVE DRIVEN THIS VEHICLE LESS THAN 500 MILES AND THE PROBLEM IS EVIDENT.

MY TRUCK HAS A KNOWN ISSUE WITH THE 5.4L'S CAM PHASERS. THE TRUCK MAKES A VERY LOUD NOISE AND SHAKES. TO REPAIR THIS, IT'S AROUND $3,000 AND ALSO I HAVE A KNOWN ISSUE WITH ALL 8 COILS WHICH HAD TO BE REPLACED FOR $1,200 AND A KNOWN MISFIRE. I DO NOT UNDERSTAND WHY FORD MOTOR IS AWARE OF THE ONGOING ISSUES IN THIS YEAR TRUCK AND HAS NOT DONE ANYTHING ABOUT IT. ALSO IF THE CAM PHASERS ARE NOT REPLACED THE ENGINE WILL BLOW!

Mileage: 165,000

ENGINE STARTED TICKING ENDED UP BEING CAM PHASERS AND NEEDED NEW MOTOR FORD KNOWS ITS A WELL KNOWN PROBLEM BUT REFUSES TO STAND BEHIND THEIR PRODUCTS.WAS TOLD IT WAS NORMAL ENGINE WEAR WHICH I FIND HARD TO BELIEVE AT 100,000MILES WITH RECOMMENDED MAINTENANCE DONE TO VEHICLE CLASS ACTION LAWSUIT WOULD BE THE BEST FOR ALL INVOLVED WHEN IT COMES TO THIS PRODUCT 7000 DOLLARS TO REPLACE MOTOR.

Mileage: 100,000

KNOWN ISSUE WITH FUEL INJECTORS CAUSED PREMATURE ENGINE FAILURE AT 45K MI. TOO MUCH FUEL WHEN COMPRESSED AND IGNITED BLEW THE PISTON APART. FORD REPLACED ENGINE. 80K MILES LATER SIMILAR PROBLEMS AND RECOMMENDATION IS ANOTHER ENGINE. TWO 5.4L ENGINES WITH LESS THAN 130K OVERALL MILES IS ABSOLUTELY UNACCEPTABLE. WEB SEARCHES SAY THERE IS CURRENT LITIGATION IN PROGRESS OVER THESE 5.4L ENGINES. I'M MAKING A FORMAL COMPLAINT THAT THE BASIS OF THE LAWSUIT HAS MERIT. FORD HAS ALREADY SETTLED A SUIT OVER THE SPARK PLUGS FOR THESE 5.4L BUT THE PROBLEMS WITH THESE ENGINES GOES MUCH DEEPER. I'M THANKFUL MY ENGINE FAILURES HAPPENED WITHOUT ANY ADDITIONAL INCIDENT.

Mileage: 128,000

F-150 BEGAN WITH A TICKING NOISE AND TURNED INTO A LOUD KNOCKING NOISE, VEHICLE LOOSES POWER OR COMPLETELY SHUTS OFF WHILE DRIVING. REPLACED COIL PACKS, AND SPARK PLUGS (ONE BROKE OFF DUE TO HORRIBLE DESIGN). BASICALLY, HAD TO TAKE APART THE ENTIRE ENGINE REPLACING SEVERAL PARTS TO STILL NOT HAVE A DRIVABLE VEHICLE. MECHANIC JUST INFORMED ME THERE IS NOTHING ELSE TO DO BUT REPLACE THE ENTIRE ENGINE. THANK YOU FORD I OWE ABOUT $8000 ON THIS POS. I HAVE ALREADY SUNK $1200 INTO THE VEHICLE AND WILL NOW BE LOOKING AT OVER $5000 TO REPLACE THE ENGINE. *TR

THE PHASERS AND TUNERS ARE SHOT INTERNAL ENGINE DAMAGE IT STARTED TO MAKE NOISE WHILE MOVING

Mileage: 136,081

I PURCHASED MY 2005 F150 WITH A 5.4L TRINITRON ENGINE USED IN 2010. I COMPLETED ALL REGULAR SCHEDULED MAINTENANCE USING THE RECOMMENDED PRODUCTS, MOST OF IT DONE IN FORD DEALERSHIPS. THIS 5.4L ENGINE IS A POOR DESIGN AND SHOULD BE RECALLED. IT HAS NUMEROUS PROBLEMS. I HAD A SAFETY INSPECTION DONE AT A FORD DEALERSHIP AND IT PASSED EVEN THOUGH IT HAD A TICKING SOUND IN THE ENGINE AND I HAD HESITATION AND LOSS OF POWER. REPLACE SPARK PLUGS, I HAD ALREADY REPLACED THE TRANSMISSION AT 98,000 MILES! THIS ENGINE IS A PIECE OF JUNK! FORD NEEDS TO STAND BEHIND ITS' "BUILT FORD TOUGH" TRUCKS AND MAKE THIS RIGHT. I CANT ENJOY MY TRUCK!!!

I PURCHASED MY 2005 F150 WITH A 5.4L TRINITRON ENGINE NEW IN 2005. I COMPLETED ALL REGULAR SCHEDULED MAINTENANCE USING THE RECOMMENDED PRODUCTS, MOST OF IT DONE IN FORD DEALERSHIPS. THIS 5.4L ENGINE IS A POOR DESIGN AND SHOULD BE RECALLED. IT HAS NUMEROUS PROBLEMS. I HAD A SAFETY INSPECTION DONE AT A FORD DEALERSHIP AND IT PASSED EVEN THOUGH IT HAD A TICKING SOUND IN THE ENGINE AND I HAD HESITATION AND LOSS OF POWER. AT THAT POINT, I HAD ALREADY REPLACED THE TRANSMISSION AT 62,000 MILES! NOW AT 105,000 MILES THE PLASTIC CAMPHASERS BROKE APART, THE TIMING CHAIN BROKE AND THE ENGINE IS BLOWN!! THAT IS UNACCEPTABLE FOR A FORD TRUCK TO LAST THAT LONG AND HAVE THAT MANY PROBLEMS. THIS ENGINE IS A PIECE OF JUNK! FORD NEEDS TO STAND BEHIND ITS' "BUILT FORD TOUGH" TRUCKS AND MAKE THIS RIGHT. I'LL NEVER BUY ANOTHER FORD.

Mileage: 105,000

THE TRUCK HAS A TICKING SOUND INSIDE THE ENGINE. I HAVE HAD THAT NOISE SINCE I BOUGH IT. 3 YEARS AGO I HAD IT CHECKED OUT AT A FORD DEALERSHIP AND THEY SAID IT WAS NORMAL. THIS YEAR ON NOVEMBER 4, I TOOK IT AGAIN TO THE FORD DEALERSHIP AND THEY FOUND THE PROBLEM. ITS A BENT ROD. THE PROBLEM IS THAT THE EXTENDED WARRANTY THAT I HAVE WILL NOT COVER ITUNLESS THE KNOW THE CAUSE OF IT. SO FORD IS SAYING ITS A DEFECTED PART. INSURANCE WONT COVER IT AND THEY WANT ME TO PAY THOUSANDS OF DOLLARS TO REPAIR IT!! IF ITS A DEFECTED PART, DON'T YOU THINK FORD SHOULD PAY!!

Mileage: 100,000

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE LUNGED FORWARD WITHOUT WARNING. THE CONTACT STATED THAT WHEN THE VEHICLE WAS IDLE, THERE WAS A TICKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE CONSUMED EXCESSIVE OIL AT AN ACCELERATED RATE AND THE VEHICLE NEEDED AN OIL CHANGE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 144,500.

Mileage: 144,500

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT 70 MPH, THE VEHICLE SHOOK. WHILE MAKING A RIGHT TURN INTO A PARKING LOT, THE VEHICLE CRASHED INTO A MEDIAN AND A CURB. THE CONTACT SUSTAINED INJURIES TO THE SHOULDER, NECK, AND BACK, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. NO POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 93,000.

Mileage: 93,000

SPARK PLUGS ARE IMPOSSIBLE TO BE REMOVED/REPLACED. WENT TO MECHANIC TO BE REMOVED/REPLACED AND WAS EXTREMELY EXPENSIVE. MUST BE SOME DEFECT ON FORD'S PART.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE AREA AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO INDICATED THAT WHILE IDLE, THE VEHICLE WOULD SHAKE AND RATTLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE SOLENOID FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000.

Mileage: 140,000

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 20 MPH, THE VEHICLE SHOOK AND STALLED. THE CONTACT RESTARTED THE VEHICLE AND WAS ABLE TO DRIVE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE OIL PUMP WAS NOT SUPPLYING OIL TO THE TOP OF THE ENGINE AND THE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,200. UPDATED 1/12/16 *CN

Mileage: 106,200

ON HIGHWAY AT 60 MPH ENGINE STARTED TO MISS. WAS ABLE TO GET IT TO MY MECHANIC WHERE HE SAID A SPARK PLUG HAD FAILED. THE PLUG BROKE WHEN REMOVING. HE WAS ABLE TO REMOVE THE PLUG. THEN DUE TO A SQUEAL UNDER THE HOOD WHEN THE ENGINE WAS COLD, HE REMOVED THE INTAKE AND FOUND THE SEAL HAD FAILED, WHILE IT WAS APART HE NOTED 2 LEAKING FUEL INJECTORS. ALL DEFECTIVE PARTS WERE REPLACED. IN AUGUST THAT SAME YEAR I REPLACED THE OTHER 7 SPARKPLUGS, HAVING 4 MORE BRAKE OFF. THE EXTRACTOR TOOL WORKED GREAT.

Mileage: 76,000

I PURCHASED MY 2005 FORD F-150 RIGHT OUT OF THE SHOW IN 2005 AND FIRST BEGAN HAVE JERKING ISSUES 6 MONTH LATER A MECHANIC THEN TOLD ME THAT IT WAS RELATED TO THE FUEL INJECTORS. SINCE THAT TIME I HAD TO REPLACE THE TRANSMISSION TWICE IN 2008, A TIMING CHAIN AND BENT RODS IN 2014 AND CURRENTLY ANOTHER TIMING BENT RODS AND DEBRI FROM THE OIL PAN. ALL CAUSED FROM THE INITIAL FAULTY FUEL INJECTOR ISSUES CONTINUING FROM LESS THAN ONE YEAR AFTER THE ORIGINAL PURCHASE IN 2005. I'VE SENT OVER $9500 IN MECHANIC COST TO DATE.

Mileage: 185,000

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT 15 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

Mileage: 130,000

SPARK PLUG BLEW OUT OF THE ENGINE CAUSING DAMAGE AND REQUIRING ENGINE REPLACEMENT.

Mileage: 141,300

DRIVING ON INTERSTATE DOING 70 MPH (IN FAST LANE) WHEN TRUCK STOPPED/STALLED AND I GUESS FROM RESEARCH WENT INTO "LIMP MODE". I WAS UNABLE TO PRESS THE GAS PEDAL, IT JUST SHOOK THREE TIMES EACH OF WHICH SLOWED IT DOWN INCREDIBLY, THE CHECK ENGINE LIGHT WAS ON AND A WRENCH SHOWED UP, BUT THE RADIO STILL WORKED. WHILE TRYING TO PULL OVER ALMOST WRECKED (MEMORIAL DAY WEEKEND AND I WAS IN FAST LANE). FINALLY ABLE TO PULL OVER TO SIDE OF ROAD HYSTERICAL, SHUT OFF AND WAITED A MINUTE AND IT STARTED. DROVE REST OF WAY HOME *100 MILES* WITH CHECK ENGINE LIGHT ON AND ABS LIGHT ON. I AM SCARED TO DEATH TO DRIVE AGAIN. NOT FUN HAVING A VEHICLE STALL/QUIT WHATEVER ON INTERSTATE IN RUSH HOUR TRAFFIC.

Mileage: 97,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE INDEPENDENTLY DECELERATED BEFORE RAPIDLY ACCELERATING WITHOUT WARNING. THE FAILURE PERSISTED AND WOULD CAUSE THE ENGINE TO MISFIRE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUG, IGNITION COIL, AND THE NUMBER FIVE COIL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

Mileage: 125,000

UPON STARTING MY CAR THAT MORNING IT BACKFIRED AND WHITE SMOKE EXITED FROM THE EXHAUST WHICH IT HAS NEVER DONE BEFORE. ONCE IDLING I PUT THE TRUCK IN REVERSE WITH MY FOOT ON THE BRAKE AND MY TRUCK ROLLED DOWN THE DRIVEWAY. I HAD TO DEPRESS MY BRAKES WITH SIGNIFICANT FORCE TO GET IT TO STOP. UPON CHECKING THE ENGINE LATER THERE IS NO VACUUM DETECTED AT THE POWER BRAKE ASSIST. THERE IS A RECALL ON OTHER FORD TRUCKS OF THIS YEAR AND MODEL WITH THE SAME ISSUES THAT MINE WAS EXHIBITING. UPON CALLING FORD THEY SAID THAT MY VIN # WAS NOT ASSOCIATED WITH THIS RECALL. GO FIGURE! *TR

Mileage: 140,000

SPARK PLUGS BLOWING OUT. *TR

Mileage: 99,645

THIS ENGINE IS PRONE TO ENGINE FAILURE DUE TO CAM PHASERS ON 5.4 MOTOR ON A FORD F150 CAM PHASERS RESULTING IN ENGINE FAILURE WITH THE 5.4 MOTOR ## *TR

Mileage: 180,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

Mileage: 85,000

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO VEHICLE TUNE-UP ISSUES. *SMD THE CONSUMER STATED NO ONE CAN TELL HIM THE ESTIMATED COST OF A TUNE-UP BECAUSE THE SPARK PLUGS CAN BREAK OFF WHEN BEING REMOVED AND CAN COST SEVERAL HUNDRED OR EVEN THOUSANDS IF THE CYLINDER HEAD HAS TO BE REMOVED TO DEAL WITH THE BROKEN PLUG(S). *JB

EXHAUST MANIFOLD ON THE FORDS' 5.4L ENGINE APPARENTLY WERE NOT ENGINEERED CORRECTLY. I HAVE HEARD OF MANY THAT HAVE LEAKED AND HAD TO BE REPLACED. I WORRY ABOUT THE POSSIBILITY OF FIRE. I HAVE CONTACTED FORD MOTOR CO. MULTIPLE TIMES HOWEVER THEY DECLINED ANY HELP WITH THERE REPLACEMENT ON MY TRUCK. IT SEEMS TO BE A VERY COMMON PROBLEM FROM WHAT I'VE HEARD AND SEE ONLINE. SHOULD FORD HAVE A RECALL ON THESE MANIFOLDS? *TR

Mileage: 50,000

WE HAVE HAD OUR 2005 F-150 KING RANCH FOR ABOUT 10 YEARS NOW. TODAY (FEB 10,2015), MY WIFE AND OUR ONE YEAR BABE WERE HEADING TO THE POST OFFICE THE TRUCK DISPLAYED A MESSAGE READING "ENGINE FAILSAFE MODE". THE TRUCK LOST ALL POWER, NO STEERING, AND IT STALL ON THE HIGHWAY GOING ABOUT 65 MPH. LUCKILY, SHE SAID THERE WERE VEHICLES BEHIND HER AND SHE PULLED IT OVER WITH NO STEERING AND THE ENGINE DEAD. MY WIFE THEN SAT ON THE HIGHWAY FOR ABOUT 10 MINUTES AND TRIED TO START THE VEHICLE, WHICH STARTED AND THERE WERE NO "ENGINE FAILSAFE MODE" ON DISPLAY ANYMORE. KNOW WITH-IN THE LAST YEAR OUR TRUCK HAS HAD THE CHECK ENGINE LIGHT AND THE ABS LIGHT HAS COME ON AND OFF EVERY OTHER MONTH. I HAVE CHECKED THE FUSES AND HAD REPLACE A FEW BUT AT TIME IT IS NOT THE FUSE. I'VE HAD THE INTERIOR DIM IN AND OUT AND AT TIMES IT DOES NOT WORK AT ALL. BY READING THE F150.NET FORUM FOUND OUT THE A WIRE THAT SPLITS INTO TWO WIRES WAS CORRODED ON THE PASSENGER SIDE FLOOR BOARD, IT SEEMS THAT CONDENSATION OR WATER COME IN AND STAYS IN THAT POCKET WERE THAT WIRING HARNESS GOES THRU. I AM NOW TERRIFIED THAT TRUCK WILL SHUT OFF ON THE HIGHWAY AGAIN WITH MY FAMILY AND I IN IT. THIS SEEMS TO BE A LIFE THREATENING PROBLEM. I HAVE READ THRU SOME FORUMS AND IT SEEMS THAT PEOPLE HAVE CALLED THE FORD DEALERSHIP AND THE SERVICE DEPARTMENT CLAIMED THEY HAVE NEVER HEARD OF THIS PROBLEM, BUT CAN WORK ON IT IF THEY BRING IT IN. BUT THAT FORD CLAIM THAT THEY FIX THE PROBLEM AND THE PEOPLE SAYS THAT THE PROBLEM STILL EXIST. HOPE SOME ONE CAN HELP OR ASSIST US IN FIXING THIS ISSUE NOT JUST FOR OUR FAMILY BUT FOR OTHERS TOO. SINCERELY [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 170,000

BOUGHT A 2005 F150 TRITON V8 5.4L NEW IN 2005. I HAVE NOW EXPERIENCED A CAM PHASE PROBLEM WHICH WILL COST APPX 2500 TO REPAIR. TALKING TO MY MECHANIC HE SAID THAT IT WAS NO PROMISE TO FIX THE ISSUE , BECAUSE THESE MOTORS ARE KNOWN FOR THIS ISSUE. WAS TOLD IT WOULD BE EASIER TO PUT ANOTHER MOTOR IN SO I WOULDN'T HAVE TO WORRY ABOUT ,IF IT WOULD FIX THE PROBLEM. MY BROTHER HAS A 2008 FORD WITH THE SAME MOTOR AND HAD THE SAME PROBLEM ,BUT HIS MOTOR AFTER HAVING THE CAM PHASER'S REPLACED BLEW UP AND HAD TO REPLACE THE MOTOR. AFTER RESEARCHING AND TALKING TO SEVERAL ASE QUALIFIED MECHANICS THEY ALL SAID THAT THERE'S AN ISSUE WITH THE 5.4 LITER TRITON MOTOR. UPON CALLING FORD MOTOR COMPANY AS I WELL FIGURED WOULD HAPPEN THEY SAID THAT THEY WOULDN'T HELP WITH THE COST AND THAT THERE WAS NOR RECALL. CONSUMERS SHOULD BE ABLE TO GET MORE THAN 100,000 MILES OUT OF A VEHICLE THEY BUY. IF FORD WANTS TO KEEP CUSTOMERS HAPPY THEY SHOULD ADDRESS THEPROBLEM AND THE GOVERNMENT SHOULD BE MORE VIGILANT IN ASSURING THE CONSUMER IS PROTECTED FROM COMPANIES WHOSE PRODUCT DOSEN'T MEET STANDARDS. I WOULD LIKE TO SEE THE GOVERNMENT TO LOOK AT ALL COMPLAINTS THROUGH A SURVEY ON THIS MOTOR TO FIND A SOLUTION FOR THE CONSUMER. *TR

Mileage: 100,761

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE ENGINE MISFIRE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE PROBLEM RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUG WAS FRACTURED AND THAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

Mileage: 90,000

SPARK PLUG BLEW OUT OF HEAD. *TR

Mileage: 152,000

2005 F150 GOES INTO "FAIL SAFE MODE" AND SHUTS DOWN WHILE DRIVING. IT ONLY OCCURRED ONCE PER YEAR STARTING AT 65,000 MILES, BUT NOW HAPPENS EVERY 3-4 WEEKS AT 114,000 MILES. ONCE THE ENGINE SHUTS DOWN, I PUT THE TRANSMISSION INTO NEUTRAL WHILE COASTING AND IT RESTARTS EASILY. THE ENGINE LIGHT ILLUMINATES FOR 3-4 DAYS AND THEN TURNS OFF. IN RESEARCHING THE ISSUE, IT SEEMS TO BE A RATHER COMMON PROBLEM WITH THIS VEHICLE AND IS USUALLY CAUSED BY A FAULTY THROTTLE BODY. FORD STATES THAT THEY ARE AWARE OF THE PROBLEM. *TR

Mileage: 65,000

I OWN THE ABOVE MENTION VEHICLE, THERE WAS NO DISCLOSURE TO ME AT THE TIME OF PURCHASE OF A VERY SERIOUS DESIGN FLAW WITH THE SPARK PLUGS THAT COULD AND LIKELY WILL BREAK OFF IN THE ENGINE DURING REPLACEMENT AND THE EXTREME COST IN CHANGING THESE PLUGS AROUND 900 TO 1000 DOLLARS IF NO PLUGS BREAK OFF AND EVEN MORE IN THE PLUGS DO BREAK OFF OR HEADS HAVE TO REMOVED TO EXTRACT THE PLUGS EVEN WORSE PIECES OF PRSHELL COULD FALL INTO THE ENGINE CYLINDER AND CAUSE ENGINE DAMAGE TO AROUND 8000 DOLLARS NOW THAT I AWARE OF THE EXTREME COST 3 OR 4 TIMES THE AMOUNT FOR ROUTINE MAINTENANCE OF CHANGING SPARK PLUGS IN THESE FORD VEHICLES FORD IS NO HELP AT ALL SAYING ITS NOT A SAFETY ISSUE I CANT HELP IT THE DESIGN FLAW WITH THESE LONG 2 PIECE PLUGS IS SO SERIOUS AND THE PRICE GOUGING OF THE CONSUMER FOR THE COST TO CHANGE SPARK PLUGS IS SO EXPENSIVE AND SO BAD I STRONGLY FEEL THAT THE FEDERAL GOV SHOULD STEP INTO THE MATTER AND HELP THE CONSUMERS OUT AND NOT ALLOW FORD TO GET BY WITH THIS EXTREME BAD DESIGN FLAW AND THE OUTRAGEOUS COST THEY ARE CHARGING AND THE FED GOV SHOULD FORCE FORD TO RECALL ALL AFFECTED VEHICLES AND MANDATE THAT FORD EAT THE COST OF CHANGING THESE SPARK PLUGS AND PUT IN THE NEWLY DEVELOPED PLUGS THAT ARE NOT PRONE TO BECOME SEIZED TO THE ENGINE AND FORD SHALL DO SO AT NO COST TO THE CONSUMER SAFETY OR NOT IT IS JUST UNBELIEVABLE THEY CAN GET BY WITH SUCH A SERIOUS DESIGN FLAW WITH SUCH A HIGH EXPENSE TO THE CONSUMER FOR SOMETHING THAT IS SUPPOSED TO BE ROUTINE. *TR

Mileage: 85,000

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED AND THE ENGINE FAILURE SYSTEM WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED AFTER MULTIPLE ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

Mileage: 103,000

OVER THE PAST 5 YEARS I HAVE HAD MY TRUCK GO INTO FAIL SAFE MODE. MY TRUCK WILL FLASH FAIL SAFE AND I WILL LOSE ALL POWER TO THE VEHICLE. I'M ABLE TO COAST TO A STOP. I HAVE BEEN ABLE TO RE START MY VEHICLE AND CONTINUE DRIVING. *TR

Mileage: 111,000

FRONT END COLLISION INTO THE REAR OF ANOTHER TRUCK. WHOLE FRONT END DAMAGED THROUGH RADIATOR, HOOD, HEADLIGHTS, BUMPERS ETC. AIRBAG NEVER DEPLOYED AND UPON RETURN OF VEHICLE AFTER REPAIRS, I AM NOW GETTING A CODE 42 THAT THE SENSOR IS BAD AND AFTER RESEARCH FIND OUT THERE IS A RECALL ON THIS BUT FOR THE OPPOSITE REASON BUT ALSO NOW UNDERSTAND THERE ARE CORROSION ISSUES WITH THE CONNECTION OF THE SENSOR ALSO. HOPE THIS HELPS. PLEASE ADVISE WHAT TO DO, WILL FORD FIX THIS WHOLE PROBLEM AND REPLACE WITH A NEW SENSOR AND THE WIRE CHAFFING PROBLEM? THANK YOU IN ADVANCE! *TR

Mileage: 126,000

I HAVE OWNED MY FORD TRUCK FOR ALMOST 8 YEARS AND I HAVE EXPERIENCED NOTHING BUT BAD LUCK WITH THIS ENGINE AND ME AND OTHER FORD OWNERS AGREE THAT THIS ENGINE IS 1 OF THE WORST ENGINES THAT FORD HAS PRODUCED AND THEY KNOW IT. AND ARE RELUCTANT TO DO ANYTHING ABOUT IT. AND ITS COSTING ME THOUSANDS TO REPLACE SPARK PLUGS AND CAMPHASERS. MY TRUCK NOW WILL STALL WHEN PUT IN REVERSE. IT ALSO HAS A LOUD TICKING NOISE TO IT. I KNOW ITS THE CAMPHASERS AGAIN WHICH I ALREADY REPLACE ABOUT 4 YEARS AGO.THIS TRUCK IS COSTING ME MORE THAN ITS WORTH. I ONLY HAVE 85000 MILES ON IT. FORD NEEDS TO DO SOMETHING ABOUT THIS PROBLEM. ME AND OTHER FORD OWNERS OF THIS MODEL CANT KEEP SLAMMING MONEY INTO SOMETHING THAT IS A COMPLETE FAILURE FROM THE START. THIS TRUCK IS DANGEROUS AND THE PROBLEM NEEDS SOLVED. *TR

Mileage: 50,000

TRUCK SHAKES VIGOROUSLY AT SPEEDS OVER 55MPH, CANNOT EXCEL IN FAST ONCOMING TRAFFIC WITH CHILDREN IN VEHICLE! ENGINE CUTS OUT AND JERKS THE WHOLE VEHICLE. MISFIRING. CONTINUOUSLY HAVING TO GET TOWING BECAUSE THE VEHICLE FAILS TO START ALL TOGETHER! THIS COULD LEAD TO INJURY, DEATH, ACCIDENTS NOT ONLY FOR THE DRIVER/PASSENGERS BUT OTHERS ON THE ROADS AS WELL. THIS ISSUE HAS BEEN BROUGHT TO ATTENTION IN THE FORD F-150 5.4L ENGINE MORE THAN SEVERAL HUNDRED TIMES AND NO ACTION HAS BEEN TAKEN. YOU CAN FIND INFORMATION ALL OVER OF PEOPLE HAVING THE SAME ISSUES, THE FORD DEALERSHIP I TOOK IT TO TOLD ME I WOULD NEED A NEW ENGINE OR TO SPEND THOUSANDS TO FIX IT AND THEY SEE PEOPLE BACK IN THERE WITHIN THE MONTH OF SPENDING GRANDS TO FIX IT. SOMETHING NEEDS DONE ABOUT THIS BEFORE PEOPLE END UP DYING IN THESE VEHICLES. *TR

Mileage: 75,000

THE 5.4 LITER ENGINES HAVE A DESIGN PROBLEM THAT'S COSTING OWNERS A LOT OF MONEY JUST TO REPLACE THE SPARK PLUGS. THE PLUGS ARE TWISTING OFF OR BREAKING BECAUSE THE BLOCK DESIGN ALLOWS THE PLUG TO EXTEND INTO A HOLE THAT ALLOWS CARBON BUILDUP AROUND THE TIP OF THE PLUG. WHEN YOU TRY TO REMOVE THE SPARK PLUG THE BOTTOM OF THE PLUG IS SEALED TIGHT TO THE HEAD THEREFORE ALLOWING THE TOP OF THE PLUG TO TWIST AND NOT THE BOTTOM. THIS IS HAPPENING TO A LOT OF TRUCK OWNERS AND SOME DEALERS WON'T EVEN ATTEMPT TO REPLACE THE PLUGS. IF ONE BREAKS, IT COULD COST UP TO $2000 FOR THE REPAIRS. I HAVE 4 OF THEM BROKE OFF. I HAVE ORDERED THE EXTRACTOR KIT BUT THE BACK TWO CYLINDERS ARE GOING TO BE HARD TO REPAIR. I LIKE MY FORD TRUCK BUT SINCE THE EARLIER MODEL FORDS WERE BLOWING PLUGS OUT OF THE BLOCKS AND NOW WE CAN'T GET THEM OUT WITHOUT AN EXTRACTOR, TO ME THIS IS NOT GOOD ENGINEERING. I WOULD LIKE TO KNOW WHAT FORD IS DOING ABOUT THIS EXTREME COST TO ITS CUSTOMERS. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 136,000

WE BOUGHT THIS VEHICLE NEW IN 2005. CHANGE OIL AS REQUIRED AND DID REGULAR SERVICES. ENGINE STARTED KNOCKING AND RUNNING ROUGH. TOOK TO DEALER WHO STATED CAM PHASERS WENT OUT WHICH IN TURN BLEW THE ENGINE. DEALER STATES NEW ENGINE IS REQUIRED ON A 9-YEAR OLD VEHICLE WITH LESS THEN 140,000. DEALER STATES CAM PHASERS ARE VERY COMMON PROBLEM IN THIS ENGINE (5.4L TRINITRON) . CALLS TO NUMEROUS OTHER LOCAL FORD DEALERS REVEAL NUMEROUS ENGINE REPAIRS DUE TO CAM PHASERS IN THE ENGINE INTERNET RESEARCH FIND NUMEROUS ISSUES WITH THE CAM PHASERS IN THIS ENGINE CAUSING COMPLETE ENGINE FAILURE. FORD REFUSES TO ACKNOWLEDGE THE PROBLEM. DEALER QUOTE TO REPLACE THE ENGINE ON A 9-YEAR OLD VEHICLE WAS $7150.00. *TR

Mileage: 136,000

THE VEHICLE BEGAN TO SMELL LIKE RAW FUEL, PARTICULARLY AT STOP SIGNS OR INTERSECTIONS. THE SMELL APPEARED TO BE COMING FROM THE ENGINE BAY. UPON DISASSEMBLY OF THE INTAKE COMPONENTS OF THE ENGINE TO EXPOSE THE FUEL INJECTION SYSTEM, IT WAS EVIDENT THAT THE FUEL RAIL HAD BEGUN LEAKING RAW FUEL INSIDE THE ENGINE BAY. THE FUEL RAIL DEVELOPED A SPECK OF CORROSION ABOUT 2-3MM IN DIAMETER ON THE TOP SURFACE OF THE RAIL. THE CORROSION EVIDENTLY PENETRATED THE ENTIRE RAIL AND BECAME A PINHOLE LEAK. RAW FUEL WAS SEEN LEAKING UP AND OUT OF THE PINHOLE. THIS HAPPENED ON THE PASSENGER SIDE FUEL RAIL, WHICH IS POSITIONED INCHES AWAY FROM THE HIGH VOLTAGE COIL PACK, AND ABOVE THE EXHAUST MANIFOLD AS WELL. CALLED FORD CUSTOMER SERVICE HOTLINE AND WAS TOLD THERE IS NO RECALL FOR IT, NO EXTENDED WARRANTY PROGRAM, NO ASSISTANCE WHATSOEVER. ORDERED A NEW FUEL RAIL THROUGH LOCAL FORD DEALER FOR $500 DOLLARS (4 TIMES WHAT A TYPICAL FUEL RAIL COSTS); PART HAS NOT BEEN SHIPPED, DEALER UNSURE IF FORD HAS ANY IN STOCK OR IS EVEN MAKING THE PART. TRUCK HAS BEEN INOPERABLE FOR OVER A WEEK WITH NO WAY TO FIX IT. *TR

Mileage: 52,863

THE NUMBER 3 SPARK PLUG BLEW LOOSE. THE FIRST TIME IT HAPPENED IT WAS JUST STARTED AND IDLING. IT GOT FIXED WITH A REPAIR KIT AND THEN IT HAPPENED AGAIN THE NEXT WEEK. IT WOULDN'T BE A HUGE CONCERN BUT THERE ARE MULTIPLE THINGS THAT COULD HAPPEN AND CAUSE SERIOUS INJURY AND OR A FATALITY. *TR

Mileage: 122,000

TRUCK WENT INTO "LIMP" MODE ON START UP. VERY DIFFICULT TO GET HOME IN TRAFFIC. "FIX" WAS NEW THROTTLE BODY FROM FLECTHER FORD. $582.38. SEEMS TO BE AN ONGOING PROBLEM WITH FORD. *TR

Mileage: 69,995

AT 58,000 MILES ENGINE MALFUNCTION DUE TO A BROKEN VALVE SPRING. AT 101,879 MILE STARTED TO MAKE A LOUD RATTLING AT STARTUP AND SUBSIDED UNTIL THE ENGINE WAS WARMED UP. THIS CONTINUED UNTIL I REACHED 273,000 MILES AND THE ENGINE JUST STOPPED DUE TO OIL STARVATION AND CAM PHASER FAILURES. OIL WAS CHANGED AS REQUIRED THROUGH OUT OWNERSHIP. *TR

Mileage: 273,000

WHILE AT IDLE MY ENGINE STARTED TO TICK,SO I TOOK IT TO THE MECHANIC AND HE TOLD ME I HAD A BAD LASH ADJUSTER,AND IT WAS VERY COMMON FOR THIS TO HAPPEN WITH THE 5,4L 3VALVE ENGINE,SO I WENT ONLINE TO SEE IF I COULD FIND ANY INFO ABOUT MY ISSUE AND IT SEAMS THAT THOUSAND OF PEOPLE ARE HAVING THE SAME ISSUE,AND HOW FORD WILL NOT RECALL THE MOTORS FOR REPAIR OF A MAJOR DEFECT TO THAT TYPE OF ENGINE,THE MECHANIC TOLD ME TO DRIVE IT UNTIL IT DIES,BECAUSE THE COST WILL BE THE SAME TO REPAIR OR REPLACE THE ENGINE,POWERTRAIN.COM SELLS THE UPGRADED ENGINE WHICH CORRECTS THE THREE MAJOR ISSUES WITH THIS ENGINE,WHICH ARE,LASH ADJUSTERS,CAM PHASERS,AND THE SPARK PLUG TREADS STRIPPING OUT OF THE HEADS,WHY HAS FORD BEEN ABLE TO HIDE THIS FOR SO LONG. *TR

Mileage: 128,000

I WAS TRAVELING SOUTH COMING TO A INTERSECTION WHEN A VEHICLE TRAVELING NORTH AND DECIDED TO TURN AND HIT ME! HE WAS TRAVEL 50 MPH. THE DRIVER RECEIVED 2 TICKETS AT CRASH SITE ALSO 1 TICKET 3 MINUTE BEFORE CRASH. I ALMOST DROVE 1/3 INTO HIS CAR. NO AIR BAG WENT OFF IN MY VEHICLE. MY HIPS HAVE BEEN HURTING EVER SINCE CRASH. ALLSTATE FORCED ME TO SETTLE THEM. I BELIEVE IF AIRBAG WENT OFF MY HIPS WOULD BE FINE! X-RAYS SHOW THEM 1" OUT OF ALIMENT AND I NEED TO CONTINUALLY SEE A CHIROPRACTOR *TR

Mileage: 181,000

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO ENGINE FAIL SAFE MODE MALFUNCTIONS CAUSES VEHICLE TO LOSE ALL POWER, BRAKES AND STEERING. CONSUMER HAS DIFFERENT VEHICLE COMPLAINT IN ARTEMIS. *SMD THE DEALER INVESTIGATED THE COMPLAINT, BUT WAS UNABLE TO IDENTIFY THE CAUSE. *JB

5.4L TRUCK ALWAYS MAINTAINED AND SERVICED AT FORD DEALERSHIPS. IT WAS RUNNING PERFECT UNTIL IT IMMEDIATELY BEGAN IDLING ROUGH AT A STOP. NO CHECK ENGINE LIGHT, WE JUST KNOW OUR TRUCK. TOOK IT IN FOR A TUNE-UP (REPLACED SPARK PLUGS, ETC.) AND OIL CHANGE. PERFECT BILL OF HEALTH - COULDN'T REPLICATE PROBLEM. ENGINE CHECKED OUT DIAGNOSTICALLY- PERFECT. THEY SUGGESTED IT COULD BE AN INTERMITTENT STICKING FUEL INJECTOR, SO WE WERE GOING TO GET AN ADDITIVE TO ADD TO THE FUEL TANK. DIDN'T MAKE IT THAT FAR. DROVE IT HOME - 35 MILES - GOT HOME AND ENGINE STALLED IN DRIVEWAY. TURNED BACK ON, ENGINE DIED AGAIN. LONG STORY SHORT - TOWED IT BACK TO FORD - THEY WERE ABLE TO REPLICATE THE PROBLEM - OIL PRESSURE DROPS SUDDENLY (INTERMITTENTLY)- POINTING TO CAM PHASER, TIMING AREA OF ENGINE - END RESULT - NEED NEW ENGINE - THIS ONE IS SHOT AT ONLY 68K MILES - ESTIMATED COST $7,400 PLUS TAX. EXTENDED WARRANTY EXPIRED. DID SOME INTERNET RESEARCH, APPEARS TO BE A COMMON PROBLEM. THESE 5.4L ENGINES ARE BREAKING DOWN LEFT AND RIGHT IN THESE TRUCKS. DON'T KNOW WHAT CHANGED. HAD A 1999 EXPEDITION WITH A 5.4L - GREAT VEHICLE. CONTACTED FORD CUSTOMER CARE - WAS TOLD TO KEEP ALL RECEIPTS IN THE EVENT OF A RECALL. AN ENGINE SHOULD NOT BLOW AT 68K MILES, ESPECIALLY A BUILT FORD TOUGH ENGINE. WE'VE OWNED FORDS SINCE HIGH SCHOOL AND THEY USED TO BE RELIABLE, LONG DRIVING VEHICLES. *TR

Mileage: 68,685

I BOUGHT A 2005 FORD F 150 USED NOT KNOWING ABOUT THE ENGINE AND REAR END PROBLEMS UNTIL I HEARD THE RATTLE COMING FROM UNDER THE HOOD SO I GO ASK DEALER ABOUT THIS PROBLEM HE SAID THIS TYPE ENGINE WAS FROM FORD WAS NOT GOOD LUCKY FOR ME THEY WERE REPAIRING ONE IT HAD BLOWN A SPARK PLUG OUT AND THEY WERE REPLACE PARTS FOR THE CAM HE SAID GET RID OF THE TRUCK OR RUN IT TILL IT BLOWS UP IT HAS NO POWER IT STALLS IN THE MOST BAD PLACES I AM AFRAID I AM GOING TO HAVE A WRECK AND HURT SOME ONE FORD NEEDS TO RECALL THESE ENGINE AND FIX THE REAR END PROBLEM ALSO I DON'T HAVE 5 TO 8 GRAND TO FIX IT. *TR

Mileage: 130,000

I HAD JUST CHANGED THE OIL AND CHECKED THE FLUIDS AND HAD TO RUN SOME ERRANDS UP TOWN ABOUT A MILE AND A HALF UP THE ROAD THE ENGINE STARTED MAKING A KNOCKING NOISE, I WAS CLOSE ENOUGH TO THE GARAGE I USE SO I PULLED IN THERE TO SEE WHAT WAS GOING ON THE OIL PAN WAS ON FIRE OIL AND WHAT LOOKED LIKE ANTI FREEZE WAS COMING OUT OF A HOLE FROM WHAT USE TO BE THE OIL PAN OR WHAT WAS LEFT OF THE PAN, THE FELLOW THAT RAN THE STATION TOLD ME IT HAD HYDRO LOCKED AND BENT A ROD AND PUSHED IT THRU THE OIL PAN, HE WENT ON TO SAY HE HAD SEEN SEVERAL OF THE 4.2 DO THIS AND IT LOOKED LIKE FORD WOULD HAVE DONE SOMETHING WHEN THEY WERE AWARE OF THE PROBLEMS WITH THE 4.2,I TALKED TO FORD ABOUT IT AND GOT THE RUN AROUND FROM THEM, JUST COULDN'T BELIEVE IT I HAD NEVER PULLED OR HAULED ANY HEAVY OBJECTS OR MISTREATED IT IN ANY WAY, DON'T UNDERSTAND WHEN THE POWERS THAT BE WERE AWARE OF THE PROBLEM WITH THIS ENGINE THE CONSUMER WAS LEFT HOLDING THE BAG TO A TUNE OF THOUSANDS OF DOLLARS IN REPAIRS, NOW GOT TO DO WITH OUT TO TRY AND SAVE THE MONEY TO GET IT FIXED, MOSTLY USED THE TRUCK TO GET MY WIFE BACK AND FORTH TO THE DR. SHE HAS M/S AND A HEART CONDITION, THE POOR ALWAYS CATCH IT IF THERE WAS ANYTHING TO FORD THEY WOULD MAKE IT GOOD AND THE SAME GOES FOR THE NHTSA THEY KNOW THE PROBLEM IS THERE JUST LOOK AT THE FORD FORMS, BUT GOD ALWAYS MAKES A WAY JUST HAVE TO WAIT AND SEE WHAT HIS PLAN ARE, ALOT OF FOLKS LIKE US HAVE NO FAMILY SO WE TAKE CARE OF OR TRUCKS, IT SURE WASN'T ABUSE THAT CAUSE THE PROBLEM. *TR

Mileage: 93,000

THE 5.4L ENGINE INSTALLED IN THE FORD F150 HAS NOTHING BUT A BAD REPUTATION FOR COSTING CONSUMERS THOUSANDS AND NEVER BEING ABLE TO FULLY FIX THE ISSUE WITHOUT REPLACING THE ENTIRE ENGINE. THE VEHICLE CUTS OUT OF POWER, SHAKES VIGOROUSLY, MISFIRES AND IS DANGEROUS ON HIGHWAYS, HILLS, OR ANY ROADWAY FOR THAT MATTER. OUR PERSONAL EXPERIENCE ALMOST GOT US REAR ENDED BY A SEMI TRUCK WITH OUR CHILDREN IN THE VEHICLE BECAUSE WE COULD NOT GET IT TO MOVE WITHOUT LOSING POWER AND SHAKING AND JERKING! THERE HAVE BEEN SEVERAL THOUSAND COMPLAINTS FILED ON THIS ENGINE I'M SURE, JUDGING BY THE FORUMS, WEBSITES, CAR COMPLAINT SITES ETC. MEANWHILE, WE TOOK OUR TRUCK INTO A FORD DEALERSHIP AND WERE TOLD THAT THEY GET HUNDREDS OF PEOPLE WHO BRING THESE VEHICLES IN AND SPEND THOUSANDS TO REPLACE THE CAM PHASERS JUST TO HAVE THE SAME ISSUE THE NEXT MONTH! BY THE TIME YOU ARE ABLE TO FIX THE PROBLEM YOU'VE PUT OUT MORE MONEY THAN THE VEHICLE IS WORTH AT THAT POINT! GET THESE ENGINES RECALLED AND GET THEM OFF THE ROADS. THEY'RE UNSAFE FOR DRIVERS, FAMILIES AND OTHERS ON THE ROADWAYS! *TR

Mileage: 80,000

FIRST OFF I WANT TO SAY THAT I WORK FOR FORD AND I AM VERY DISAPPOINTED THAT THE FIRST OF THE TWO ISSUE I HAVE HASN'T BEEN RECALLED AND I'M NOT 100% SURE ABOUT THE DATES THAT THESE PROBLEMS OCCURRED ON. MY TRUCK HAS SOUNDED LIKE IT HAS A DIESEL ENGINE IN IT SINCE I BOUGHT IT BRAD NEW IN 2005 AND AFTER TALKING TO SOME GUYS AT WORK I FIND OUT THAT IT IS CAUSED BY CAM PHASERS THAT ARE IN THE 2004-07 5.4LITRE ENGINES AND IF THESE FAIL YOU HAVE TO GET A NEW MOTOR WHICH I WAS TOLD JUST A COUPLE OF MONTHS AGO WOULD BE $8900.00 WHICH IS ABSOLUTELY CRAZY. IF YOU LOOK THEM UP ONLINE YOU WILL SEE THAT THIS IS A HUGE AND COSTLY PROBLEM. MY SECOND ISSUE IS I HAVE HAD MY REAREND REBUILT TWICE SINCE I HAVE OWNED THIS VEHICLE. THE FIRST TIME WAS BEFORE IT WAS OUT OF IT 36,000 MILE FACTORY WARRANTY, THE SECOND TIME WAS BEFORE IT WAS OUT OF THE 100,000 EXTENDED WARRANTY THAT I PURCHASED SO LUCKILY THOSE TWO TIMES DID NOT COST ME ANYTHING BUT NOW IT NEEDS IT AGAIN AND THE MECHANIC TELL ME IT COULD COST $5000 SO WITH THE MOTOR ISSUE AND THE REAREND ISSUE I COULD POSSIBLY SPEND $14,000 IN REPAIRS WHICH AGAIN IS CRAZY WHEN YOU SPENT CLOSE TO $50,000.00 ON THE VEHICLE TO BEGIN WITH. *TR

Mileage: 15,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE IDLING AT A LIGHT, HE HEARD A KNOCKING NOISE FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE CAM PHASERS AND LIFTERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. THE VIN WAS UNAVAILABLE.

Mileage: 90,000

I PURCHASES A USED 2005 FORD F150 ABOUT 5 MONTHS AGO. TODAY, FEB 28, 2014, I WAS LEAVING MY NEIGHBORHOOD AND MY TRUCKS DISPLAY FLASHED AN MESSAGE READING "ENGINE FAILSAFE MODE". MY TRUCK LOST ALL POWER, NO STEERING AND DIED. LUCKILY I WAS ON SURFACE STREETS AND PULLED IT OVER WITH NO POWER STEERING AND ENGINE DEAD. THE MECHANICS CANNOT FIND THE CAUSE AND THE ENGINE WILL START BUT CONTINUES TO TURN OFF AND THE VEHICLE'S COMPUTER SHUTS DOWN. ONLINE I READ OF THIS HAPPENING ON THE FREEWAY AT 65 MPH. IAM NOW TERRIFIED THAT MY TRUCK WILL SHUT OFF ON THE FREEWAY WITH MY CHILDREN IN THE TRUCK WITH ME. THIS SEEMS TO BE A LIFE THREATENING PROBLEM. I CALLED A FORD DEALERSHIP AND THE SERVICE DEPT CLAIMED THEY NEVER HEARD OF THIS BUT CAN WORK ON IT IF I BRING IT IN. WHAT IS MY RECOURSE? THANK YOU. *TR

Mileage: 91,000

TL- THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD TO RESTART IT. ONCE RESTARTED, THE VEHICLE FUNCTIONED PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THEY COULD NOT DETERMINE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT WAS UNABLE TO PROVIDE A REMEDY. THE FAILURE MILEAGE WAS 88,000. AP

Mileage: 88,000

I WAS DRIVING TO TOWN WHEN ENGINE STARTED MAKING A SOUND LIKE A LARGE COMPRESSOR, STOPPED TRUCK, COULD FEEL AIR COMING FROM THE TOP OF THE HEAD BY INTAKE MANIFOLD, TOOK TO A GARAGE WHERE I WAS INFORMED THAT THE PLUG CAME OUT OF THE #2 CYLINDER AND BUSTED THE COIL PAK. I KNOW THIS HAS HAPPENED TO MANY F150 TRUCK OWNERS, I KNOW OF 3 LOCALLY, AND HAVE FOUND MANY MORE COMPLAINTS WITH THE SAME PROBLEM. FORD SHOULD RECALL, THIS PROBLEM. *TR

Mileage: 136,230

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD SOUND AS IF IT WAS EQUIPPED WITH A DIESEL ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS, COILS, PULLEY AND SERPENTINE BELT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE REMEDY FAILED TO CORRECT THE FAILURE. THE DEALER THEN STATED THAT THE CAMSHAFT PHASER WAS DEFECTIVE AND AS A RESULT, THE ENGINE WOULD POSSIBLY NEED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000. UPDATED 02/11/14*LJ

Mileage: 120,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS A LOUD KNOCKING SOUND COMING FROM THE MOTOR. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 215,000. UPDATED 1/14/14*CN

Mileage: 215,000

AFTER THE TRUCK PASSED 76000 I STARTED TO NOTICE A TICK/KNOCK IN THE ENGINE. I BROUGHT IT TO FORD AND THEY TOLD ME THIS WAS NORMAL NOISE FOR THESE ENGINES, TO ME THIS WAS NO NORMAL. NOW THE TICK/KNOCK/RATTLE HAS BECOME WORSE AND I HAVE BEEN TOLD BY FORD I WOULD NEED A NEW ENGINE. THIS IS A VERY VERY COMMON SITUATION WITH THE 2004-2008 5.4L 3V ENGINES. WHAT US FORD OWNERS WOULD LIKE IS A RECALL ON THE CAM PHASERS AND VCT SOLENOIDS. FORD HAS REDESIGNED BOTH OF THESE PARTS SO THEY KNOW THIS WAS CAUSING BIG ISSUES WITH OWNERS OF THE MENTIONED MAKE/MODEL/YEAR FORDS. I DO NOT KNOW HOW A COMPANY, AN AMERICAN COMPANY, CAN GET AWAY WITH SELLING VEHICLES WHERE THE INTERNAL PARTS OF THE ENGINE, AND AMERICAN MADE ENGINE, GO FAULTY BEFORE THE ODOMETER HIT'S 100,000 MILES. THERE ARE NORMAL WEAR AND TEAR REPLACEABLE PARTS ON EVERY CAR, BUT WHEN INTERNAL ENGINE COMPONENTS FAIL WITH A VEHICLE THAT IS JUST 7 YEARS OLD THAT IS NOT ACCEPTABLE! *TR

Mileage: 78,000

THIS WOULD BE THE SECOND TIME A SPARK PLUG HAS POPPED OUT OF THE ENGINE ON MY 2005 FORD F-150 WITH THE 4.6 LITER V8 ENGINE IT. THE FIRST SPARK PLUG POPPED OUT IN AUGUST 2011 AND NOW IT HAS HAPPENED AGAIN IN SEPTEMBER 2013. I HAVE HEARD THAT I AM NOT THE ONLY PERSON THIS IS HAPPENED TO. THIS SEEMS TO BE A RECURRING PROBLEM IN NOT ONLY THE 4.6 LITER V-8 BUT THE 5.4 LITER V-8 AND THE 6.8 LITER V-10. WITH THIS PROBLEM HAPPENING OVER AND OVER AGAIN WHY HASN'T FORD DONE ANYTHING ABOUT IT. FORDPROBLEMS.COM SUGGESTS THAT FORD INSISTS THE PROBLEM IS DUE TO IMPROPER TORQUING OF NEW PLUGS OR ANY NUMBER OF OTHER REASONS. HOWEVER MANY PEOPLE HAVE HAD THE ORIGINAL FACTORY SPARK PLUGS EJECT FROM THE ENGINE, WHICH INDICATES THERE IS A DEFECT WITH THE ENGINE & CYLINDER HEAD DESIGN. THE REPAIR IS RELATIVELY EASY - DO NOT BE FOOLED BY A DEALER OFFERING TO REPAIR THE ISSUE FOR $700 OR MORE. AN INEXPENSIVE HELICOIL KIT WILL DO THE TRICK. ALSO, WE DO NOT RECOMMEND SIMPLY RE-TAPPING THE SPARK PLUG THREADS BECAUSE THE THREADS ARE PROBABLY TOO DAMAGED ALREADY & THE SPARK PLUG MAY JUST BLOW OUT AGAIN CAUSING MORE DAMAGE. SPARK PLUG EJECTION IS DANGEROUS BECAUSE FUEL VAPOR STARTS COMING OUT THE SPARK PLUG HOLE, WHICH IS CLEARLY A SERIOUS SAFETY ISSUE. THE FUEL VAPOR CAN BE IGNITED BY THE LOOSE SPARK PLUG AND IN FACT THERE HAVE BEEN A SMALL NUMBER OF CASES REPORTED OF ENGINE FIRES DUE TO SPARK PLUG EJECTION/BLOWOUT. I AS WELL AS OTHER FORD OWNERS WOULD LIKE THE NHTSA TO LOOK INTO AND FORCE A RECALL ORDER TO FORD MOTOR COMPANY TO GET THESE ISSUE FIXED, REPAIR, AND REMEMBERS ALL AFFECTED BY THIS ISSUE. *TR

Mileage: 179,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.

Mileage: 107,000

I TOOK MY VEHICLE IN FOR A SERVICE ENGINE LIGHT ISSUE. I WAS TOLD I NEED NEW SPARK PLUGS. THE ISSUE IS HUNDREDS OF 2004 -2008 FORD F-150 5.4 LITER ENGINE HAVE FAULTY SPARK PLUGS THAT BREAK OFF IN THE HEAD CREATING ADDITIONAL EXPENSE. THE PRICES ARE BETWEEN 500- 1000 TO CHANGE OUT SPARK PLUGS. THE FAULTY DESIGN OF THE PLUGS CREATED THIS ISSUE AND FORD HAD NOT ADDRESSED THIS PROBLEM. PLEASE, RESEARCH THIS ISSUE AND HELP CONSUMERS WITH THIS PROBLEM. LISLE DESIGNED A TOOL TO EXTRACT THE BROKEN PLUGS MODEL # 65600 IT IS FOR THE YEARS 2004-2008 FORD 5.4 LITER ENGINES. MANY DEALERS ARE AWARE OF THIS PROBLEM AND JUST CHARGE ADDITIONAL MONIES TO THE CUSTOMER BECAUSE OF FAULITY PART DESIGN. PLEASE, HELP. *TR

Mileage: 128,000

WHEN YOU ACCELERATE AT 40 TO 50MPH THE ENGINE STRUGGLES TO PICK UP SPEED LIKE IT IS NOT GETTING FUEL. IT HAS ALSO STALLED SEVERAL TIMES AT VARIOUS SPEEDS CAUSING ME TO PUT IT IN NEUTRAL WHILE STILL ROLLING,OR COME TO A STOP, TURN THE KEY COMPLETELY OFF AND THEN RESTART.TOOK THE VEHICLE TO THE FORD DEALER AND TO BE TOLD IT WAS THE CAM PHASERS WHICH WILL COST ABOUT $2,900.00 TO FIX WERE THE PROBLEM. HE ALSO SAID THE WORST DECISION FORD EVER MADE WAS USING THE 5.4 TRITON V8 FROM 2005-2008. YOU WOULD THINK IF A MANAGER OF A FORD MECHANIC SHOP TELLS YOU THIS, I AM NOT THE ONLY ONE HAVING THIS PROBLEM. IT ALSO HAS A CONSTANT TICKING NOISE IN THE ENGINE WHICH I WAS TOLD IS THE TENSIONER FOR THE TIMING CHAIN. THE TRUCK CURRENTLY HAS 138,000 MILES. *TR

Mileage: 110,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 20 MPH AND DECELERATING, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE ENGINE HAD FAILED. THE TIMING CHAIN, AND OIL PUMP WERE REPLACED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 175,412. UPDATED 12/23/13*LJ

Mileage: 175,412

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE BEGAN TO DECELERATE IN A JERKING MOTION. THERE WAS NO PRIOR WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT ONE SPARK PLUG FRACTURED. AN APPOINTMENT WAS SCHEDULED FOR THE VEHICLE TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 128,542.

Mileage: 128,542

CONSTANT TICKING NOISE FROM ENGINE, SOUNDS LIKE A DIESEL ENGINE, REMAINS TICKING THE ENTIRE TIME./ WHEN APPLYING BRAKES EITHER ON A HARD STOP OR ROLLING OVER TRACTION IN ROAD, GRINDING FEELING IN PEDAL AND NOISE AND WILL NOT STOP IMMEDIATELY.-----WAS TOLD BY DEALERSHIP THAT THE "TICKING" WAS TYPICAL FOR FORD AND THE BRAKES WAS PART OF THE ANTILOCK SYSTEM, I DO NOT THINK SO. *TR

Mileage: 5,555

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT HE HEARD A TICKING SOUND FROM THE ENGINE THAT CAUSED THE VEHICLE TO EXHIBIT AN ABNORMAL SOUND, SIMILAR TO BREWING COFFEE. THE CONTACT PERFORMED ONLINE RESEARCH AND DETERMINED THAT THE FAILURE WAS CAUSED BY THE CAM PHASERS. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 34,000.

Mileage: 34,000

2005FORD F-150 4.6 TRITON V8 SPARK PLUG EJECTED BLOWING OUT COIL WHILE DRIVING. THIS RESULTING IN A STRIPPED HEAD AND NEEDING TO REPLACE THE ENGINE. WITH RESEARCH ON THE WEB SEEMS THIS IS A COMMON PROBLEM WITH THIS MODEL ENGINE WITH MANY COMPLAINTS THAT FORD WILL NOT ACKNOWLEDGE. *TR

Mileage: 115,000

SPARK PLUG BLEW OUT OF HEAD. CALLED FORD NO RECALL. CAN SEE WHY SO MANY SUV, TRUCKS,ECT. HAVE THIS PROBLEM. FORD SHOULD HAVE PAID. WENT TRUCK SHOPPING GOT A NEW DODGE. *TR

Mileage: 70,485

THE COIL PACKS AND PLUGS HAVE BEEN CHANGED ON DIFFERENT TIMES AND THE VEHICLE STILL HAS THE SAME PROBLEMS. FORD HAS TO FIND A BETTER SOLUTION TO FIX THESE ONGOING ISSUES SO THE CUSTOMER DOES NOT HAVE TO KEEP PAYING ALL THIS MONEY FOR THE SAME PROBLEMS OVER AND OVER AGAIN. ENGINE LOST POWER ON SEVERAL OCCASIONS AND SHAKES WHEN IDLING. PAINT ON FRONT OF VEHICLE STARTED PEELING OFF. ALL SERVICE WORK HAS BEEN CONDUCTED A T A FORD DEALERSHIP SINCE THE VEHICLE WAS PURCHASED EXCEPT FOR TODAY WITH (2) MORE COIL PACKS HAD TO BE INSTALLED AT A LOCAL GARAGE. THIS IS APPARENTLY A BIG PROBLEM AND SOMETHING HAS TO BE DONE ABOUT IT OR FORD WILL FIND GOOD CUSTOMERS GOING TO OTHER VEHICLE BRANDS. *TR

Mileage: 20,000

BOUGHT THIS FORD F150 USED WITH 95,000 MILES. I WAS TOLD THE PLUGS AND FUEL FILTER NEEDED REPLACED BY THE 100,000 RANGE. MY LOCAL GARAGE SPENT HOURS REPLACING ONE PLUG AND WHEN THEY CHECKED WITH THE LOCAL FORD DEALER ABOUT THE PROBLEM THEY WERE TOLD IT WAS A LONG ON GOING PROBLEM. THE DEALER SAID, THEY COULD REMOVE THE PLUGS BUT IT WOULD BE $500.00 DOLLARS TO START AND IF THE PLUGS BROKE OFF IN THE HEADS THE COST COULD BE AS MUCH AS $3,000.00 IF THEY HAD TO REMOVE THE HEADS. RESEARCH SHOWS ME THIS HAS BEEN GOING ON FOR EVER AND FORD REFUSES TO REPAIR OR RECALL THE F150 5.4 3V SPARK PLUG PROBLEM. BUILD UP AROUND THE BASE OF THE PLUGS FROM POOR HEAD DESIGN IS COSTING US CONSUMERS THOUSANDS. PEOPLE ARE GETTING HURT JUST TRYING TO REMOVE THESE PLUGS. I FEEL FORD SHOULD RECALL THE F150 WITH THIS ENGINE AND REPAIR OR REPLACE THE ENGINE HEADS WITH A PLUG THAT CAN BE REPLACED AT A FAIR PRICE NOT THIS STUPID THOUSANDS PEOPLE ARE SPENDING. *TR

Mileage: 96,388

ON THREE SEPARATE OCCASIONS, MY FORD 2005 F150 KING RANCH SUPERCREW 4X4 ENGINE SUDDENLY DIED WHILE DRIVING AT APPROXIMATELY 55-60MPH. ON ALL THREE OCCASIONS, I FORTUNATELY WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD WITH THE ENGINE DIED AND NO POWER STEERING. IF I HAD NOT BEEN IN THE RIGHT HAND LANE AND ABLE TO PULL OFF OF THE ROAD, THEN AN REAR ENGINE COLLISION WOULD MORE THAN LIKELY OCCURRED IF I WOULD HAVE BEEN IN AN OUTER LANE OF A MULTIPLE LANE HIGHWAY. AFTER THE THIRD OCCASION THIS PAST WEEK, I TOOK THE VEHICLE TO THE FORD DEALERSHIP IN ROCKWALL, TEXAS WHERE IT COST ME $700.00 TO HAVE THROTTLE BODY/MOTOR ASSEMBLY REPLACED. MY OBD READINGS AT HOME WERE P2104 AND P2112. IF NOT ALREADY, THIS ISSUE IS A FATALLY WAITING TO HAPPEN. LOTS OF CHATTER ON INTERNET OF SIMILAR ISSUES. *TR

Mileage: 53,000

THERE IS A OBVIOUS PROBLEM WITH THE MANIFOLDS ON THIS TRUCK. MY TRUCK IS AN FX4 AND RARELY SEEN ANY OFF ROADING. MY MANIFOLDS ARE CRACKED AND THE TRUCK HAS BEEN BABIED THIS RESULTS IN A VERY ANNOYING NOISE. ALSO THE TRANSMISSION HAD BE REPLACED AT 30,000 MILES UNDER WARRANTY, THE NEW ONE IS STILL SLIPPING. *TR

Mileage: 80,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, A LOUD NOISE EMITTED OUTSIDE OF THE VEHICLE. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD AND THEN RESUMED DRIVING. THE VEHICLE WAS INSPECTED UPON ARRIVING TO THE RESIDENCE. THE CONTACT DETECTED THE NUMBER SEVEN SPARK PLUG DISLODGED FROM THE ENGINE CYLINDER HEAD. THE DEALER WAS CONTACT WHO INFORMED HIM THAT THERE WAS NO RECALLS PERTAINING TO THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

Mileage: 115,000

THIS 5.4 LITER V8 MOTOR REQUIRED REPLACEMENT OF SPARK PLUGS (CHECK ENGINE MESSAGE FLASHED ON THE DASHBOARD). THE SPARK PLUGS HAD WELDED THEMSELVES TO THE ENGINE HEAD, ULTIMATELY REQUIRING THE REMOVEL OF THE ENGINE HEAD TO EXTRACT SPARK PLUG-COST $2,000 IN ADDITIONAL COST TO CONSUMER. INTERNET IS FULL OF SIMILAR REPORTS. MECHANICS AT FORD DEALERSHIP AND MIDAS REPORT FREQUENT ENCOUNTER WITH THIS ISSUE WITH SIMILAR RESULT. I HAVE CONTACTED FORD AND THEY CLAIM NO LIABILITY, STATING NHTSA HASN'T REQUIRED THEM TO DO A RECALL. *TR

Mileage: 119,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS BEING EXAMINED FOR ROUTINE MAINTENANCE WHEN HE WAS INFORMED THAT FOUR SPARK PLUGS WERE FRACTURED. THE CONTACT ALSO STATED THAT THE SPARK PLUGS WERE SUPPOSED TO LAST FOR APPROXIMATELY 100,000 MILES BEFORE BEING REPLACED. THE DEALER STATED THAT A CARBON BUILD UP ON THE TIPS OF THE PLUGS CAUSED THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 81,000.

Mileage: 81,000

I WAS DRIVING ON A RESIDENTIAL STREET (GRAY ST. )APPROACHING A BUSY TWO LANE STREET THAT WAS ONE WAY HEADING SOUTH (ARMENIA AVENUE) IN TAMPA, FLORIDA. AS I WAS APPROACHING THE STOP SIGN, MY FOOT WAS ON THE BRAKE. PREPARING TO STOP, BUT INSTEAD OF STOPPING THE ENGINE REVVED AND ACCELERATED INTO THE LANES OF TRAFFIC TRAVELING SOUTH. I WAS STANDING ON THE BRAKE SO HARD THAT MY LEG WAS SHAKING WHEN I FINALLY STOPPED. I STOPPED THE VEHICLE BY DEPRESSING THE EMERGENCY BRAKE AND THE RPM'S FINALLY CAME DOWN AND THE ENGINE RETURNED TO NORMAL. I WAS SO NERVOUS BECAUSE IF THERE HAD BEEN CARS COMING I WOULD HAVE BEEN HIT ON THE DRIVER'S SIDE. THE STREET IS USUALLY VERY HEAVY WITH TRAFFIC. I WAS VERY LUCKY THAT THERE WAS NO ONE CLOSE OR I MAY NOT BE WRITING THIS TODAY. A FEW DAYS LATER I CAME TO THE SAME CORNER AND A BICYCLIST CROSSED RIGHT IN FRONT OF ME. IF THIS HAD HAPPENED ON APRIL 12TH, I WOULD HAVE RUN OVER THE BICYCLIST. I DROVE AROUND THE BLOCK VERY SLOWLY CONTINUING TO STOP AND RPM'S WERE NORMAL. I REALLY THOUGHT EVERYONE WOULD THINK I WAS CRAZY FOR WHAT HAD JUST HAPPENED. WHEN THE FORD DEALERSHIP FOUND THE PROBLEM ON THE COMPUTER I WAS RELIEVED TO KNOW THAT THERE WAS A PROBLEM THAT COULD BE FIXED. IT WAS THE THROTTLE BODY. A MONTH LATER OUR OTHER FORD F-150, A 2007, HAD THE SAME PROBLEM AND THIS TIME MY HUSBAND WAS DRIVING IT. THERE WAS A REPORT ON THIS VEHICLE ALSO. FORD IS NOT RECOGNIZING THAT THERE IS A PROBLEM AND OTHER VEHICLES ARE BEING BROUGHT IN FOR THE SAME ISSUES WHICH COULD RESULT IN SERIOUS INJURY OR FATALITIES TO INNOCENT PARTIES DUE TO SOME DEFECT IN THE THROTTLE BODY'S ON THE F-150'S. MY REPORT NUMBER ON OUR 2007 F-150 IS 10459967. *TR

Mileage: 62,118