2005 FORD F-150 Power Train Problems

customer states that the frame of the vehicle has been compromised by corrosion. the vehicle only has 163,844 miles on it and it has major holes in the frame. The chassis could break in half prohibiting the use of this vehicle on the roadway due to the safety of occupants. I advised the customer of this of which they bought a frame repair kit (Pre-cut over frame c-channel steel) to weld onto the frame to support a longer lifespan. The truck is now safe for the roadway.

The contact owns a 2005 Ford F-150. The contact stated that while parking the vehicle, the vehicle rolled backwards. The contact shifted the gear shifter into park and turned off the vehicle; however, the vehicle rolled backwards again. The contact stated that while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The contact stated that upon inspecting under the hood, the contact became aware that the shifter cable had melted. The contact purchased a new shifter cable and replaced the shifter cable. The vehicle was started and driven to the residence. In addition, the contact stated that the failure had occurred at night, which was dangerous for being on the side of the road. The contact stated that the shifter cable had melted again within 12 hours. The contact stated that the failure was the result of a design flaw. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 260,000.

Mileage: 260,000

I don't even have 150,000 miles on this thing. I get it serviced regularly. I've used the 4x4 when needed, as I live in the Sierra Nv Mountains area. I don't overdo it, I don't abuse it. One day with "ZERO" Clues or indications my truck popped out of drive into neutral ON ITS OWN I put it back into drive. Then as I tried to accelerate NOTHING, I got a code/msg saying faulty transmission, my O/D kept turning off and on. I pushed it to the side if the road. I eventually got reverse back, 1st gear, but that's it. And NOBODY KNOWS WHAT IS WRONG WITH IT. Its Automatically you need a transmission. [XXX]!! You go online and this is happening to TONS of people. Are you saying WE ALL NEED NEW TRANSMISSIONS?? Kinda odd same trucks, same issues on the same part. What's the common denominator here ford??? Your [XXX] transmissions. Figure it out!!! My truck is paid off and I can't even drive the [XXX]. I'm walking because of a [XXX] transmission, on top of paying over 20,000 you want me to dish out another 3grand for your [XXX]?? Nah... Figure it the [XXX] out. Take care of your customers as you should!!! Integrity is doing the right thing when no one is looking. Come on Ford. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Issues with transmission/ over drive snap ring vehicle only has 145,000 miles. This truck has many complaints and many failures and flaws that need fixed.

I BOUGHT USED CASH TRUCK, DROVE FINE FOR FIRST DAY, SECOND DAY WHILE TRUCK WAS IN MOTION AND PUT IN REVERSE IT DIES, TOOK A COUPLE TURNS TO STARTED UP AND IT STARTED CODING THE CAMSAFT SENSORS, GOT CODES CLEARED, AND IT DROVE OK FOR 30 MINUTES COATED AGAIN STARTED TO STALL AND STUTTER A BIT. I HEARD A LOT ABOUT FORDS IN THE CAMSHAFT SENSORS DOES THAT MEAN MY TRUCK IS DONE FOR. MY TRUCK HAS TO CAMSHAFT SENSORS. 5.4

Mileage: 183,459

COMPLETE FRAME UNDER TRUNK IS RUSTED TO WHERE THE FRAME IS GETTING READY TO BREAK IN HALF I HAVE LOOKED AT SEVERAL OTHER OF THE SAME MAKE AND MODEL AND THEY HAVE THE SAME SIMILAR PROBLEMS SO I'M NOT AS BAD AS OTHERS BUT 90% OF THEM ARE NOT SAFE TO DRIVE I LIVE IN THE AREA THERE'S NOT A LOT OF SALT NORE SAND IF THIS WAS A PROBLEM WITH JUST MY VEHICLE I WOULD UNDERSTAND BUT SINCE IT IS A PROBLEM WITH A LOT OF THESE TRUCKS SOMETHING NEEDS TO BE DONE BUY FORD MANUFACTURES.

ME ENTER HOY QUE MI TRUCK TENA VARIOS RECALL Y NO HE RECIBIDO AVISO, GRACIAS POR SU ATENCION.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS CORRODED, WHICH CAUSED THE TRANSMISSION LINE TO BECOME DEFECTIVE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE TRANSMISSION LINE WAS REPLACED. THE CONTACT WAS INFORMED BY THE MECHANIC THAT, DUE TO THE CORROSION, OTHER PARTS OF THE VEHICLE COULD BECOME DEFECTIVE. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.

Mileage: 95,000

1. BRAKE DOT 3 IS RUNNING OUT AFTER SEVERAL MONTHS. WHEN I APPLY THE BRAKES, THE VEHICLE KEEPS GOING. IN ORDER TO KEEP THE VEHICLE RUNNING, I MUST PUSH DOWN THE BRAKE VERY HARD TO STOP THE VEHICLE. I HAVE TO CONSTANTLY REFILL THE OIL TANK. 2. WHEN DRIVING ON THE HIGHWAY AND THE SPEED REACHES AT AROUND 45-65 MPH, THE VEHICLE AUTOMATICALLY LOSES POWER AND HIT AT 3-5 MPH BEFORE STOPPING. AFTER I COMPLETELY TURN OFF AND RESET THE BATTERY, THE VEHICLE STARTS NORMAL AGAIN. THE VEHICLE HAPPENED FROM 2009 TO CURRENT TIME, BUT THE ODB SCAN DOES NOT DETECT ANY CODE OR ERRORS.

Mileage: 75,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO SEVERAL UNKNOWN DEALERS FOR TRANSMISSION REPAIRS. THE TRANSMISSION COLUMN SHIFT ASSEMBLY WAS REPLACED IN 2007. IN 2010, THE TRANSMISSION FLUID SPILLED AND THE GASKET, FILTERS, AND SPARK PLUGS WERE REPLACED; HOWEVER, THE REPAIR DID NOT CORRECT THE FAILURE. THE CONTACT STATED THAT THE VEHICLE DID NOT ACCELERATE OVER 40 MPH AND VIBRATED. THE CONTACT ALSO STATED THAT WHEN THE VEHICLE WAS DRIVEN UP HILL WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE DECELERATED. IN ADDITION, THE CHECK ENGINE AND TRANSMISSION FAULT INDICATORS ILLUMINATED. THE MANUFACTURER PROVIDED THE CONTACT WITH CASE NUMBER: N24150780-F193G8. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 84,000.

Mileage: 84,000

TRANSMISSION CLUNKS. TRUCK STALLS IN TRAFFIC BECAUSE OF THROTTLE BODY PROBLEMS. IT HAS BEEN AN ON GOING PROBLEM OVER THE PAST SEVERAL YEARS.

Mileage: 50,000

MY 2005 F150 HAS AN ELECTRONIC SWITCH TO ENGAGE THE 4 WHEEL DRIVE. IT HAS STOPPED WORKING ALL TOGETHER. I'VE RESEARCHED THE PROBLEM AND HAVE DISCOVERED THAT THIS IS A COMMON PROBLEM FOR THIS MODEL FROM 2004 ON UP. I NEARLY CRASHED WHILE DRIVING AFTER A SNOW STORM DUE TO THE 4 WHEEL DRIVE BEING INACTIVE.

Mileage: 193,000

WILL NOT GO IN REVERSE

Mileage: 1,001,000

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE AT A STOP, THE VEHICLE SHOOK AND DID NOT ACCELERATE. IN ADDITION, THE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO BILL KNIGHT FORD OF STILLWATER (4405 W 6TH AVE, STILLWATER, OK 74074, 405-372-7144) AND THE COMPUTER SYSTEM WAS UPDATED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

Mileage: 80,000

MY 2005 FORD F150 TRUCK HAS HAD SO MANY PROBLEMS & SOME REPLACE TWICE & IM OVER IT IM ABOUT TO HAVE A HEART ATTACK NOW IT SOUNDS LIKE MY ACULATOR AGAIN WITH THE SOUND OF METAL SCRAPING ON THE GROUND AND WHEN I SWITCH IT TO 44 THE SOUNDS STOPS .BUT IF ITS NOT IN 44 THE SOUND STAYS AND IT IS LOUD ! I HAVE SPENT SO MUCH GET MY TRUCK FIXED AND WHAT UPSETS ME IS I TAKE CARE OF MY TRUCK CHANGE OIL SPARK PLUGS EVERYTHING SINCE PURCHASED IN 2005 BRAND NEW AND IM OVER IT SOMETHING NEEDS TO DONE WITH ALL THESE PARTS DEFECTED AND IT WILL CONTINUE UNTIL SOMETHING IS DONE.

Mileage: 100,000

TRANS FAULT ERROR

Mileage: 130,000

TAKATA RECALL AT 80,000 MILES F150 TRANSMISSION WENT OUT. HAD IT REPAIRED NOW IN LESS THAN 12,000 MILES GONE AGAIN.

Mileage: 80,000

NEW TRANS NEEDED, COMMON ON MOST F150. OVERDRIVE LIGHT FLASHES AND WON'T SHIFT OUT OF FIRST GEAR

Mileage: 200,000

I NEEDED A NEW TRANSMISSION LAST YEAR. JUST BLEW OUT OF NO WHERE. THIS YEAR ALONE I NEEDED NEW HUBS, ALL8 CYLINDERS HAVE A MISS FIRE MY TRUCK DROPPED FROM 60 TO TEN IN SECONDS SO SCARY

CPSC;2005 FORD F-150 TRANSMISSION AND MOTOR WENT OUT AT 89446 MILES. A DIAGNOSTIC WAS PERFORMED. *BF THE CONSUMER STATED AFTER THE TRANSMISSION WAS REPLACED, THE VEHICLES PERFORMANCE WAS NOT INDICATIVE OF HAVING BEEN AT A REPAIR SHOP. THE CONSUMER RETURNED TO THE DEALER AND ANOTHER DIAGNOSTIC WAS PERFORMED. THE CONSUMER WAS THEN INFORMED THE ENGINE NEEDED TO BE REPLACED. IT WAS ALSO DETERMINED THE INITIAL REPAIRS WERE COMPLETED WITH SALVAGED/USED PARTS. *JB

TRUCK WAS BOUGHT AND I REPLACED ALL SPARK PLUGS AND EVEN HAD TO REPLACE A CLINOID BECAUSE WAS TOLD THAT WAS THE PROBLEM. ITS NOT... THERE IS A BALL VALVE IN THE TRANSMISSION THAT KEEPS THE TRUCK FROM BUILDING ENOUGH PRESSURE TO BE ABLE TO SHIFT WHICH THROWS A CODE AND SAYS MISFIRE ON 6 BEEN REPLACED TWICE NOW SO CLEARLY NOT THE PROBLEM. THIS IS A MAJOR ISSUE.. TRUCK FEELS AS IF FIXING TO FIE THEN CHECK ENGINE LIGHT WILL COME ON START FLASHING BUT THROW NO CODES AND YOU CANT SPEED BACK UP BECAUSE IT FEELS LIKE YOUR TRUCK IS ABOUT TO DIE AND YOU DON'T WANT TO BLOW YOUR MOTOR.

Mileage: 130,000

!. VACUUM ADVANCE CONTROL FOR FOUR WHEEL DRIVE GETS WET, LOOSES PRESSURE AND FRONT WHEELS ENGAGE SLIGHTLY, CAUSING WHEEL HUB DAMAGE. 2. STEERING BECOMES HARD, ESPECIALLY IN COLD WEATHER. HARD TO INSPECT STEERING SHAFT UNTIL IT IS DISCONNECTED FROM STEERING RACK. COMMON PROBLEM WITH MID TO LATE 2000'S FORD CROWN VIC. POLICE VEHICLES. COME ON FORD, MAN UP AND MAKE THESE PROBLEMS A RECALL.

Mileage: 94,000

MY TRUCK HAS A KNOWN ISSUE WITH THE 5.4L'S CAM PHASERS. THE TRUCK MAKES A VERY LOUD NOISE AND SHAKES. TO REPAIR THIS, IT'S AROUND $3,000 AND ALSO I HAVE A KNOWN ISSUE WITH ALL 8 COILS WHICH HAD TO BE REPLACED FOR $1,200 AND A KNOWN MISFIRE. I DO NOT UNDERSTAND WHY FORD MOTOR IS AWARE OF THE ONGOING ISSUES IN THIS YEAR TRUCK AND HAS NOT DONE ANYTHING ABOUT IT. ALSO IF THE CAM PHASERS ARE NOT REPLACED THE ENGINE WILL BLOW!

Mileage: 165,000

REAR END SHAKING WHILE DRIVING DOWN ROAD ABOUT 60MPH. GETTING OFF GAS NOR PUTTING VEHICLE IN NEUTRAL WOULD NOT STOP SHAKING. HAD TO COME TO COMPLETE STOP BEFORE STARTING AGAIN TO MAKE VEHICLE DRIVE PROPERLY.

Mileage: 90,000

METAL SCRAPING SOUND FROM REAR END. MECHANIC HAS CHECKED AND SAYS PINION, BEARINGS, RING GEAR HAVE FAILED. LOOKS LIKE ITS A COMMON FAILURE. 9.75 RING GEAR, 3.55 RATIO

Mileage: 92,000

I WAS DRIVING AND HEARD A SOUND COME FROM MY ENGINE COMPARTMENT. I DIDN'T LOSE POWER, BUT PULLED OVER TO LOOK UNDER THE HOOD. NOT NOTICING ANYTHING OBVIOUS I CHECKED THE FLUID LEVELS AND NOTICED THAT MY TRANSMISSION FLUID WAS LOW. IT HAD BEEN CHECKED TWO MONTHS PRIOR DURING OIL CHANGE. I HAD NO VISIBLE SIGNS OF LEAKS. I FOUND A FORUM ON THE INTERNET THAT TALKED ABOUT TRANSMISSION FLUID GOING FROM THE TRANSMISSION TO THE TRANSFER CASE, BUT UNABLE TO RETURN. THEY HAD A $20 SEAL REPLACED UNDER WARRANTY. THE FORUM HAD STATED THAT THIS WAS A KNOWN CONDITION BUT NOTHING WAS BEING DONE BY FORD MOTOR COMPANY. A MECHANIC HAD SAID THAT IT ONLY EFFECTED 17-18% OF VEHICLES MANUFACTURED BETWEEN 2004-2008. I CALLED TWO LOCAL DEALERSHIPS AND THEY KNEW THE PROBLEM BUT SAID THAT THERE WAS NO RECALL ON IT. IT TAKES APPROXIMATELY 3 HOURS TO CHANGE, BY DROPPING THE TRANSFER CASE AND REPLACING THE SEAL. I CALLED FORD MOTOR COMPANY REPRESENTATIVE AND WAS TOLD THAT THERE WASN'T A RECALL AND THAT THEY COULDN'T HELP. I FEEL THAT THIS COULD RESULT IN A PREMATURE FAILURE OF THE TRANSMISSION AND POSSIBLY A CATASTROPHIC EVENT. I WAS TOLD BY FMC REP THAT SHOULD A RECALL OCCUR I COULD TAKE MY RECEIPT TO A DEALERSHIP AND THAT THEY WOULD POSSIBLY REIMBURSE ME. I DON'T FEEL THAT FORD SHOULD HAVE A KNOWN CONDITION BUT DO NOTHING TO CORRECT IT. PLEASE LOOK INTO THIS FOR ME AND OTHERS UNDER THE SAME SITUATION.

Mileage: 40,020

ON THE MORNING OF MARCH 5TH 2015 I STARTED MY TRUCK TO WARM THE INSIDE AND ALSO MELT THE SNOW OFF MY WINDSHIELD. I GOT IN THE TRUCK AND BACKED OUT AWAY FROM HOUSE. DUE TO HAVING SNOW ON THE DRIVEWAY I TURNED ON THE 4 WHEEL DRIVE IN HIGH. MY FOUR WHEEL DRIVE WOULD NOT WORK SO I TRIED TO SWICTH TO 2 WHEEL DRIVE BACK TO FOUR WHEEL DRIVE BUT THE 4 WHEEL DRIVE WOULD NOT TURN ON. I GRABBED THE GEAR SHIFT TO PUT THE TRUCK BACK IN PARK WHEN I NOTICED MY GEAR SHIFT COULD FLOAT TO PARK TO 1ST GEAR FREELY AND WOULD NOT SHIFT. AT THIS TIME I NOTICED SMOKE STARTING TO COME INSIDE CAB FROM UNDER DASH AND THRU THE VENTS. I JUMPED OUT AND OPENED THE HOOD. A 1 FOOT SECTION OF A WIRING HARNES MOUNTED TO THE FIREWALL HAD CAUGHT FIRE. I MADE ATTEMPTS TO PUT OUT THE FIRE BUT WITHIN A FEW SECONDS THE ENGINE COMPARTMENT WAS ENGULFED. IN 2 TO 3 MINUTES THE ENTIRE INSIDE OF THE CAB WAS ALSO COMPLETELY ON FIRE. MY WIFE WHO WAS WATCHING ME IMMEDIATLY CALLED 911 TO GET THE FIRE DEPARTMENT. AFTER 3 MINUTES THE TRUCK WAS ALREADY A TOTAL LOSE. DUE TO THE TRUCK BEING ONLY 60' FROM MY HOUSE AND BURNING SO HOT I WAS CONCERNED ABOUT MY HOUSE CATCHING FIRE. TWO GENTLEMAN FROM THE RESCUE SQUAD ARRIVED BUT IT WAS TOO LATE FOR ANYTHING TO BE DONE. I WAS ABLE TO GET A BACKHOE AND PUT THE FIRE OUT WITH SNOW. UNFORTUNATELY I HAD LIABILITY INSURANCE ONLY WHICH MEANT A TOTAL LOSE. I NEVER DREAMED THAT THE TRUCK WOULD BURN UP SITTING IN MY DRIVEWAY!!!! I KNOW THERE HAVE BEEN SOME RECALLS FOR F150 DUE TO FIRE HAZARDS WITH THE CRUISE CONTROL FOR OTHER YEAR MODEL CLOSE TO 2005. A VEHICLE CATCHING FIRE WHILE ITS SITTING IN A DRIVEWAY RUNNING IS TOTALLY UNACCEPTABLE. THE TRUCK WAS IN EXCELLENT SHAPE AND HAD NO AFTER MARKET PARTS OR WORK PERFORMED. I HAVE NO IDEAL WHY THE WIRING HARNESS CAUGHT FIRE.

Mileage: 175,000

I JUST WANTED TO ADD MY VEHICLE TO THE LIST OF COMPLAINTS ABOUT THE DIFFERENTIAL. MINE MAKES NOISE AND HAS MADE NOISE FOR QUITE SOME TIME. I THOUGHT IT MIGHT BE THE TIRES OR ROTORS. I FOUND OUT THAT IT WAS COMING DIRECTLY FROM THE REAR DIFFERENTIAL. BASED ON THE COMPLAINTS I HAVE HEARD, I AM PRETTY SURE THIS IS THE SAME THING. THE NOISE SOUNDS LIKE METAL RUNNING ON METAL. I BELIEVE THIS SHOULD BE SOMETHING FORD SHOULD PAY TO FIX. IF I HAVE TO PAY FOR IT, I'M DEFINITELY NOT USING FORD. I READ THAT'S MANY PEOPLE HAVE THE SAME COMPLAINTS. THIS FAILURE IS SECURITY PUBLIC PROBLEMS, BECAUSE ACCIDENTAL OR CRASH MAY OCCUR. *TR

Mileage: 97,500

2005 F150 GOES INTO "FAIL SAFE MODE" AND SHUTS DOWN WHILE DRIVING. IT ONLY OCCURRED ONCE PER YEAR STARTING AT 65,000 MILES, BUT NOW HAPPENS EVERY 3-4 WEEKS AT 114,000 MILES. ONCE THE ENGINE SHUTS DOWN, I PUT THE TRANSMISSION INTO NEUTRAL WHILE COASTING AND IT RESTARTS EASILY. THE ENGINE LIGHT ILLUMINATES FOR 3-4 DAYS AND THEN TURNS OFF. IN RESEARCHING THE ISSUE, IT SEEMS TO BE A RATHER COMMON PROBLEM WITH THIS VEHICLE AND IS USUALLY CAUSED BY A FAULTY THROTTLE BODY. FORD STATES THAT THEY ARE AWARE OF THE PROBLEM. *TR

Mileage: 65,000

I OWN THE ABOVE MENTION VEHICLE, THERE WAS NO DISCLOSURE TO ME AT THE TIME OF PURCHASE OF A VERY SERIOUS DESIGN FLAW WITH THE SPARK PLUGS THAT COULD AND LIKELY WILL BREAK OFF IN THE ENGINE DURING REPLACEMENT AND THE EXTREME COST IN CHANGING THESE PLUGS AROUND 900 TO 1000 DOLLARS IF NO PLUGS BREAK OFF AND EVEN MORE IN THE PLUGS DO BREAK OFF OR HEADS HAVE TO REMOVED TO EXTRACT THE PLUGS EVEN WORSE PIECES OF PRSHELL COULD FALL INTO THE ENGINE CYLINDER AND CAUSE ENGINE DAMAGE TO AROUND 8000 DOLLARS NOW THAT I AWARE OF THE EXTREME COST 3 OR 4 TIMES THE AMOUNT FOR ROUTINE MAINTENANCE OF CHANGING SPARK PLUGS IN THESE FORD VEHICLES FORD IS NO HELP AT ALL SAYING ITS NOT A SAFETY ISSUE I CANT HELP IT THE DESIGN FLAW WITH THESE LONG 2 PIECE PLUGS IS SO SERIOUS AND THE PRICE GOUGING OF THE CONSUMER FOR THE COST TO CHANGE SPARK PLUGS IS SO EXPENSIVE AND SO BAD I STRONGLY FEEL THAT THE FEDERAL GOV SHOULD STEP INTO THE MATTER AND HELP THE CONSUMERS OUT AND NOT ALLOW FORD TO GET BY WITH THIS EXTREME BAD DESIGN FLAW AND THE OUTRAGEOUS COST THEY ARE CHARGING AND THE FED GOV SHOULD FORCE FORD TO RECALL ALL AFFECTED VEHICLES AND MANDATE THAT FORD EAT THE COST OF CHANGING THESE SPARK PLUGS AND PUT IN THE NEWLY DEVELOPED PLUGS THAT ARE NOT PRONE TO BECOME SEIZED TO THE ENGINE AND FORD SHALL DO SO AT NO COST TO THE CONSUMER SAFETY OR NOT IT IS JUST UNBELIEVABLE THEY CAN GET BY WITH SUCH A SERIOUS DESIGN FLAW WITH SUCH A HIGH EXPENSE TO THE CONSUMER FOR SOMETHING THAT IS SUPPOSED TO BE ROUTINE. *TR

Mileage: 85,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE FOUR WHEEL DRIVE ACTIVATED INDEPENDENTLY AS A LOUD ABNORMAL NOISE EMITTED FROM THE FRONT OF THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS REPAIRED ON NUMEROUS OCCASIONS BUT THE FAILURE PERSISTED. THE REPAIR SPECIFICS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

Mileage: 58,000

FORD DESIGNED THE FACTORY SPARK PLUGS AS A TWO PIECE DESIGN. ONCE THE TRUCK REQUIRES A TUNE UP THE CURRENT SPARK PLUGS BREAK IN HALF AS THEY ARE REMOVED CAUSING AN ADDITION COST FOR EXTRA LABOR AND SPECIAL TOOLS DESIGNED TO REMOVE THESE PLUGS. I TOOK MY TRUCK TO THE FORD DEALER WHO THEN BROKE 6 OUT OF 8 PLUGS UPON REMOVAL AT AN EXTRA COST OF 80 DOLLARS A PIECE. THE TUNE UP WHICH ONLY INCLUDES THE REMOVAL OFF THE OLD AND THE INSTALLATION OF THE NEWLY DESIGNED ONE PIECE SPARK PLUGS ENDED UP COSTING ME 1000 DOLLARS. THESE SPARK PLUGS ALSO BREAK INSIDE THE ENGINE CAUSING A LOSS OF POWER AND POSSIBLE DAMAGE TO THE CATALYTIC CONVERTER. *TR

Mileage: 67,000

TRUCK WENT INTO "LIMP" MODE ON START UP. VERY DIFFICULT TO GET HOME IN TRAFFIC. "FIX" WAS NEW THROTTLE BODY FROM FLECTHER FORD. $582.38. SEEMS TO BE AN ONGOING PROBLEM WITH FORD. *TR

Mileage: 69,995

I BOUGHT A 2005 FORD F 150 USED NOT KNOWING ABOUT THE ENGINE AND REAR END PROBLEMS UNTIL I HEARD THE RATTLE COMING FROM UNDER THE HOOD SO I GO ASK DEALER ABOUT THIS PROBLEM HE SAID THIS TYPE ENGINE WAS FROM FORD WAS NOT GOOD LUCKY FOR ME THEY WERE REPAIRING ONE IT HAD BLOWN A SPARK PLUG OUT AND THEY WERE REPLACE PARTS FOR THE CAM HE SAID GET RID OF THE TRUCK OR RUN IT TILL IT BLOWS UP IT HAS NO POWER IT STALLS IN THE MOST BAD PLACES I AM AFRAID I AM GOING TO HAVE A WRECK AND HURT SOME ONE FORD NEEDS TO RECALL THESE ENGINE AND FIX THE REAR END PROBLEM ALSO I DON'T HAVE 5 TO 8 GRAND TO FIX IT. *TR

Mileage: 130,000

VEHICLE WENT INTO 'FAILSAFE MODE' AND STOPPED RUNNING WITH NO WARNING. MANUAL SAID THIS WOULD ALLOW THE VEHICLE TO PROCEED SAFELY HOME. DID NOT GET FAR BEFORE IT WOULD NOT RUN. WHEN IT DID RUN, IT RAN AT ABOUT 2 MPH BEFORE FAILING TO GO ANY FARTHER. LOOKING ON THE INTERNET, LOTS OF PEOPLE HAVE HAD THIS OCCUR WITH VARIOUS FORD VEHICLES. *TR

Mileage: 125,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHENEVER HE CAME TO STOP, THE GEARS WOULD ENGAGE INDEPENDENTLY AND MAKE A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES WHERE THE TECHNICIAN DIAGNOSED THAT THE ALTERNATOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT MENTIONED THAT HE HAD TO REPLACE THE ALTERNATOR A TOTAL OF FOUR TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 175,000 AND THE CURRENT MILEAGE WAS 190,000.

Mileage: 175,000

AROUND MIDDAY WHILE DRIVING ON A CITY STREET, I HEARD A VIBRATION COMING FROM THE UNDERSIDE OF THE VEHICLE. I DROVE A FEW BLOCKS BACK TO MY OFFICE AND THE VEHICLE SAT UNTIL I LEFT TO GO HOME LATER THAT DAY. A FEW BLOCKS FROM MY OFFICE ALSO WHILE DRIVING ON A CITY STREET, I HEARD A LOUDER VIBRATION AND THIS TIME A METAL ON METAL CLANKING SOUND. I IMMEDIATELY PULLED OFF INTO A PARKING AREA AND LOOKED UNDER THE VEHICLE TO SEE THAT THE DRIVE SHAFT HAD FALLEN FROM ITS CENTER MOUNT. THE TWO PIECE DRIVE SHAFT CARRIER BEARING MOUNTING BRACKET HAD FAILED DUE TO CORROSION OF THE MOUNTING BRACKET CAUSING THE DRIVE SHAFT TO NO LONGER BE MOUNTED TO THE FRAME. FORTUNATELY, I WAS ON A CITY STREET DRIVING AND ONLY DRIVING APPROXIMATELY 20 MPH AND NOT AT HIGHWAY SPEED WHERE I COULD HAVE LOSS DRIVER CONTROL OF THE VEHICLE. LESS THAN A YEAR EARLIER, THE VEHICLE FAILED A STATE SAFETY INSPECTION DUE TO AN EXCESSIVELY CORRODED STEERING SHAFT U JOINT. THE MECHANIC SAID THIS U JOINT COULD FAIL DURING DRIVING CAUSING LOSS OF DRIVER CONTROL. EITHER OF THESE COMPONENT PART FAILURE COULD HAVE CAUSED LOSS OF VEHICLE CONTROL, AN ACCIDENT AND INJURY OR DEATH TO MYSELF, MY PASSENGERS OR OTHERS IN OTHER VEHICLES OR ON OR NEAR THE ROADWAY. I HAVE HAD MULTIPLE OTHER NON LIFE SAFETY MECHANICAL DEFECTS WITH THIS VEHICLE BUT MORE IMPORTANTLY, THIS CONDITION EXISTS WITH MANY OF THESE VEHICLES ON THE ROADS TODAY AND ANY OF THOSE DRIVERS COULD EXPERIENCE A FAILURE OF EITHER THE STEERING SHAFT OR THE DRIVE SHAFT AT ANY TIME AND BE THE CAUSE OF AN ACCIDENT. *TR

Mileage: 54,314

FIRST OFF I WANT TO SAY THAT I WORK FOR FORD AND I AM VERY DISAPPOINTED THAT THE FIRST OF THE TWO ISSUE I HAVE HASN'T BEEN RECALLED AND I'M NOT 100% SURE ABOUT THE DATES THAT THESE PROBLEMS OCCURRED ON. MY TRUCK HAS SOUNDED LIKE IT HAS A DIESEL ENGINE IN IT SINCE I BOUGHT IT BRAD NEW IN 2005 AND AFTER TALKING TO SOME GUYS AT WORK I FIND OUT THAT IT IS CAUSED BY CAM PHASERS THAT ARE IN THE 2004-07 5.4LITRE ENGINES AND IF THESE FAIL YOU HAVE TO GET A NEW MOTOR WHICH I WAS TOLD JUST A COUPLE OF MONTHS AGO WOULD BE $8900.00 WHICH IS ABSOLUTELY CRAZY. IF YOU LOOK THEM UP ONLINE YOU WILL SEE THAT THIS IS A HUGE AND COSTLY PROBLEM. MY SECOND ISSUE IS I HAVE HAD MY REAREND REBUILT TWICE SINCE I HAVE OWNED THIS VEHICLE. THE FIRST TIME WAS BEFORE IT WAS OUT OF IT 36,000 MILE FACTORY WARRANTY, THE SECOND TIME WAS BEFORE IT WAS OUT OF THE 100,000 EXTENDED WARRANTY THAT I PURCHASED SO LUCKILY THOSE TWO TIMES DID NOT COST ME ANYTHING BUT NOW IT NEEDS IT AGAIN AND THE MECHANIC TELL ME IT COULD COST $5000 SO WITH THE MOTOR ISSUE AND THE REAREND ISSUE I COULD POSSIBLY SPEND $14,000 IN REPAIRS WHICH AGAIN IS CRAZY WHEN YOU SPENT CLOSE TO $50,000.00 ON THE VEHICLE TO BEGIN WITH. *TR

Mileage: 15,000

DASH ELECTRICAL RELAY ISSUE,PAINT PEELING TAILGATE,TRANSMISSION SHUTTER GOING INTO OVERDRIVE 45 MPH. *TR

Mileage: 70,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE GEAR SHIFTER COULD NOT BE REMOVED FROM PARK UNTIL AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE SHIFT LOCK SOLENOID, BRAKE SWITCH AND BRAKE MODULE WERE REPLACED HOWEVER, THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 200.

Mileage: 200

I BOUGHT MY FORD-F 150 DIRECTLY FROM THE FORD DEALERSHIP BRAND NEW WITH ONLY 30 MILES IN AUGUST 2005. BY NOVEMBER 2005, WE BROUGHT IT IN TO THE DEALERSHIP WITH CONCERNS OF THE TRANNY SLIPPING. THE DEALERSHIP COULD NOT FIND THE PROBLEM, AND WE WENT HOME. WITH-IN 1 YR. WE HAD TO REPLACE THE POWER WINDOWS, AND WITH-IN 2 YRS, THE TRANSMISSION WENT OUT COMPLETELY. LUCKILY IT WAS UNDER WARRANTY, AND WAS REPLACED. WE HAVE REPLACED EVERY PIECE IN THAT TRUCK AT LEAST ONCE AND SOME SEVERAL TIMES. AND THE TRANSMISSION TWICE. LAST MONTH THE TRANSMISSION WENT OUT AGAIN. WE PAID $2700. TO ONLY BRING IT HOME, AND IMMEDIATELY IT WENT OUT AGAIN. THE MECHANIC IS BAFFLED. HE HAS BEEN TRYING FOR 4 WEEKS TO FIX IT, AND HAS NOW THROWN IN THE TOWEL. HERE I HAVE A GORGEOUS TRUCK, WITH A HUGE PAYMENT, AND IT'S A PIECE OF JUNK. WE HAVE MAINTAINED EVERYTHING SO PRECISELY, NEVER TOWED, NEVER LONG TRIPS, AND HAVE HAD ALL THE UP KEEP NEEDED FOR THIS TRUCK TO LAST, SO OUR SON COULD TAKE OVER WHEN HE IS OF AGE. I DON'T KNOW WHAT TO DO! *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000. *TR

Mileage: 76,000

WHEN VEHICLE'S ENGINE IS COLD, AND APPROXIMATELY 8 MINUTES INTO DRIVING, VEHICLE WILL CUT OFF WHILE IN MOTION & WRENCH LIGHT COMES ON. VEHICLE THEN HAS TO BE GUIDED TO A STOP WITH NO POWER OR CAN BE SHIFTED INTO NEUTRAL & RESTARTED WHILE STILL MOVING. FOLLOWING VEHICLE RESTART ENGINE LIGHT IS ON. CODE INDICATES TRUCK HAS BEEN PLACED IN "LIMP HOME MODE". AFTER ABOUT 2 WEEKS, ENGINE LIGHT GOES OFF. I WAS ADVISED TO REPLACE THE THROTTLE BODY IN FEB. 2010, HOWEVER THE THROTTLE BODY HAD JUST BEEN REPLACED IN APRIL 2007 WHEN THE VEHICLE WAS ONLY 2 YEARS OLD. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT HE SHIFTED INTO PARK AND EXITED THE VEHICLE HOWEVER, IT BEGAN TO ROLL AWAY IN REVERSE. THE CONTACT JUMPED BACK IN THE VEHICLE AND APPLIED THE PARKING BRAKE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 115,000.

Mileage: 115,000

MY FUEL CONTROL MODULE SHORTED OUT WHICH CAUSED MY PCM TO BE ERASED. IT SEEMS TO BE A COMMON PROBLEM AFTER RESEARCHING IT, BUT NO RECALL HAS BEEN ISSUED. MY PREGNANT WIFE WAS DRIVING MY TRUCK AND LOST ALL POWER. THIS RESULTED IN A NEAR ACCIDENT DUE TO HAVING NO POWER STEERING AND LESS BRAKE CONTROL. IF THIS IS SUCH A COMMON PROBLEM WITH THE PLACEMENT OF THE CONTROL MODULE WHY HAS THIS NOT BEEN RECALLED. $1000 LATER I HOPE THIS DOESN'T HAPPEN AGAIN. *TR

Mileage: 62,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE SHIFTER CABLE DETACHED FROM THE CONNECTION IN THE TRANSMISSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE MECHANIC REPLACED THE SHIFTER CABLE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

THE TORQUE CONVERTER ON MY 2005 FORD F-150 HAS HAD TWO TORQUE CONVERTERS FAIL IN THE DRIVE TRAIN. ONE FAILED WITHIN THE 3 YEAR OR 36,000 MILE WARRANTY PERIOD. THE SECOND TORQUE CONVERTER FAILED AROUND 50,000 MILES. I BELIEVE THIS INFORMATION WARRANTS AN INVESTIGATION INTO THE FORD LINE OF TORQUE CONVERTERS FOR THE FORD F-150 TRUCK LINE. *TR

Mileage: 30,000

YES MY 4X4 IS NOT WORKING AND I HAVE READ OVER 300 POST EASY ABOUT THE SAME PROBLEM PEOPLE ARE HAVING. THOUSANDS OF PEOPLE ARE HAVING THE SAME PROBLEM I HAVE HAD WITH MY TRUCK. OBVIOUSLY IF THERE ARE THAT MANY PEOPLE WITH THE SAME YEAR OF TRUCK AND SAME PROBLEM WHY ISN'T FORD DOING A RECALL? THEY SAY THE PROBLEM IS THE IWE, SOLENOID, THE PROBLEM WHY IT HAPPENS IN THE FIRST PLACE IS THERE ISN'T A RAIN COVER OVER THE SOLENOID UNDERNEATH THE HOOD. I DO BELIEVE THAT THIS IS A HUGE SAFETY HAZARD AND ALMOST CAUSED ME TO BE IN AN ACCIDENT ABOUT THREE WEEKS AGO BECAUSE MY FOUR WHEEL DRIVE WENT OUT! FORD PLEASE DO A RECALL BEFORE SOMEONE GETS HURT OR EVEN DIE! I DO BELIEVE THAT FORD SHOULD BE RESPONSIBLE FOR THIS ISSUE AND HAVE A RECALL TO GET THESE VEHICLES FIXED. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE FOUR WHEEL DRIVE FEATURE MALFUNCTIONED, CAUSING THE VEHICLE TO ENGAGE THE FOUR WHEEL DRIVE SYSTEM WHILE DRIVING 60 MPH. THE FRONT END OF THE VEHICLE SHOOK VIOLENTLY WHEN THE FAILURE OCCURRED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE THE DEALER REPLACED THE FOUR WHEEL DRIVE SENSOR BECAUSE WATER HAD ENTERED THE OLD SENSOR AND CAUSED THE MALFUNCTION. THE REPLACING OF THE FOUR WHEEL DRIVE SENSOR DID NOT REMEDY THE ISSUE. THE CONTACT CALLED THE MANUFACTURER AND THEY ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER. THE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

I WAS COMING TO A STOP WHEN THE TRANSMISSION WOULD NOT RELEASE FROM GEAR AND THEN FINALLY DID WITH A LOUD CLUNK. WHEN I WENT TO DRIVE FORWARD THE ENGINE REVVED UP AND THEN JUMPED INTO GEAR JUMPING THE TRUCK FORWARD. THERE WAS NO WARNING FOR A TRANSMISSION FAILURE IT ALL OF A SUDDEN LOST ALL GEARS. THE MECHANIC AT THE FORD DEALERSHIP SAID IT WAS A KNOWN ISSUE TO THEM AND THAT ONE OF THE INTERNAL SEALS PROBABLY BROKE AND CAUSED A "CATASTROPHIC TRANSMISSION FAILURE." *TT

Mileage: 127,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE TRANSMISSION WOULD SLIP AT ANYTIME AT SPEEDS AROUND 60 MPH. THE VEHICLE HAD THE TRANSMISSION REPLACED IN MARCH OF 2011. THE FAILURE RECURRED ON SEPTEMBER 8, 2011. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED ON THE SEPTEMBER 23,2011. THE DEALER WAS IN THE PROCESS OF DIAGNOSING THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 84,855.

Mileage: 84,855

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD INTERMITTENTLY SHIFT INTO FOUR WHEEL DRIVE UNEXPECTEDLY. THE FAILURE OCCURRED WHEN DRIVING 30 MPH AND ABOVE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT WATER WAS PENETRATING THE ACTUATOR. VARIOUS REPAIRS WERE PERFORMED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 20,000.

Mileage: 20,000

LIMITED SLIP REAR DIFFERENTIAL CLUTCH PACK HAS NEEDED TO BE REPLACED THREE TIMES IN 25,000 MILES. FAILURE OF COMPONENTS CAUSES HARSH VIBRATION AND CONTROL PROBLEMS IN TURNS AND CURVES. *KB

LIMITED SLIP REAR DIFFERENTIAL CLUTCH PACK HAS NEEDED TO BE REPLACED THREE TIMES IN 25,000 MILES. FAILURE OF COMPONENTS CAUSES HARSH VIBRATION AND CONTROL PROBLEMS IN TURNS AND CURVES. *KB

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT HE ATTEMPTED TO ACCELERATE FROM A STOP, BUT THE VEHICLE WOULD NOT ACCELERATE AND A LOUD GRINDING NOISE WAS HEARD COMING FROM THE ENGINE. UPON EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT THE DRIVE SHAFT WAS CORRODED AND SPLIT IN HALF. THE VEHICLE WAS TOWED HOME AND PARKED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 96,000.

Mileage: 96,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT WAS DRIVING 60 MPH UPHILL WHEN THE ENGINE BECAME HESITANT AND THE TRANSMISSION WOULD NOT DOWNSHIFT PROPERLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 83,189.

Mileage: 83,189

1) DRIVING DOWN A PAVED ROAD GOING ABOUT 35 MPH. 2) HEARD A LOUD BANG AND THEN A METAL GRINDING SOUND. THE DRIVESHAFT FORCED ITS WAY AND BUSTED THROUGH THE CENTER CARRIER BEARING. IT ONLY NEEDS TO HAPPEN ONCE AND IT CANNOT BE FIXED. THE CENTER CARRIER BREARING IS SNAPPED. THIS PART HOLDS THE DRIVESHAFT. WITHOUT THE BEARING, THE DRIVE SHAFT WILL HANG DOWN AND GRIND AGAINST THE PAVEMENT AND THROW IT OUT OF BALANCE AND DAMAGE IT. EVENTUALLY THE DRIVESHAFT WILL BREAK IN TWO. THEN THE TRUCK WILL LOSE POWER TO THE WHEELS WHICH CAN CAUSE AN ACCIDENT. 3) THE DRIVESHAFT FROM FORD IS NONSERVICEABLE. IF ANY 1 PART FAILS YOU ARE BUYING A COMPLETE NEW DRIVESHAFT FOR UPWARDS OF $1,200.00. NONE OF THE PARTS CAN BE REPLACED. THE DRIVESHAFT FOR MY TRUCK COSTS $1200.00 FROM FORD. THE CENTER CARRIER BEARING COULD NOT BE REPLACED BECAUSE THE BEARING IS INSTALLED BEFORE TUBE WAS FRICTION WELDED (BAD) IN PLACE. THE BEARING CANNOT BE CHANGED WITHOUT CUTTING DRIVESHAFT APART, DESTROYING THE DRIVESHAFT. THIS PART IS ONLY $35.00 BUT YOU HAVE TO BUY A COMPLETE NEW DRIVESHAFT. I FOUND A COMPANY THAT SPECIALIZES IN DRIVESHAFTS AND MAKES SERVICEABLE DRIVESHAFTS FOR FORD TRUCKS. I HAVE HEARD OTHERS HAVE THIS PROBLEM SO THIS IS A COMMON DRIVESHAFT DEFECT WITH 04-05 FORD F-150 TRUCKS. I BOUGHT THE NEW DRIVESHAFT FROM HTTP://WWW.DRIVESHAFTSPECIALIST.COM F OR $725 + INSTALLATION. THIS IS LESS THAN WHAT FORD CHARGES BUT IS NOT SOMETHING I FEEL SHOULD HAVE TO BE REPLACED ON A NEWER TRUCK WITH THIS MILEAGE AND THAT IS DRIVEN VERY LIGHTLY UNLESS THERE IS A DEFECT IN DESIGN LIKE THERE IS WITH FORD F-150 DRIVE SHAFTS. THIS IS SOMETHING THIAT IS SUPPOSED TO LAST THE LIFETIME OF THE TRUCK. *KB

Mileage: 95,000

1) DRIVING DOWN A PAVED ROAD GOING ABOUT 35 MPH. 2) HEARD A LOUD BANG AND THEN A METAL GRINDING SOUND. THE DRIVESHAFT FORCED ITS WAY AND BUSTED THROUGH THE CENTER CARRIER BEARING. IT ONLY NEEDS TO HAPPEN ONCE AND IT CANNOT BE FIXED. THE CENTER CARRIER BREARING IS SNAPPED. THIS PART HOLDS THE DRIVESHAFT. WITHOUT THE BEARING, THE DRIVE SHAFT WILL HANG DOWN AND GRIND AGAINST THE PAVEMENT AND THROW IT OUT OF BALANCE AND DAMAGE IT. EVENTUALLY THE DRIVESHAFT WILL BREAK IN TWO. THEN THE TRUCK WILL LOSE POWER TO THE WHEELS WHICH CAN CAUSE AN ACCIDENT. 3) THE DRIVESHAFT FROM FORD IS NONSERVICEABLE. IF ANY 1 PART FAILS YOU ARE BUYING A COMPLETE NEW DRIVESHAFT FOR UPWARDS OF $1,200.00. NONE OF THE PARTS CAN BE REPLACED. THE DRIVESHAFT FOR MY TRUCK COSTS $1200.00 FROM FORD. THE CENTER CARRIER BEARING COULD NOT BE REPLACED BECAUSE THE BEARING IS INSTALLED BEFORE TUBE WAS FRICTION WELDED (BAD) IN PLACE. THE BEARING CANNOT BE CHANGED WITHOUT CUTTING DRIVESHAFT APART, DESTROYING THE DRIVESHAFT. THIS PART IS ONLY $35.00 BUT YOU HAVE TO BUY A COMPLETE NEW DRIVESHAFT. I FOUND A COMPANY THAT SPECIALIZES IN DRIVESHAFTS AND MAKES SERVICEABLE DRIVESHAFTS FOR FORD TRUCKS. I HAVE HEARD OTHERS HAVE THIS PROBLEM SO THIS IS A COMMON DRIVESHAFT DEFECT WITH 04-05 FORD F-150 TRUCKS. I BOUGHT THE NEW DRIVESHAFT FROM HTTP://WWW.DRIVESHAFTSPECIALIST.COM F OR $725 + INSTALLATION. THIS IS LESS THAN WHAT FORD CHARGES BUT IS NOT SOMETHING I FEEL SHOULD HAVE TO BE REPLACED ON A NEWER TRUCK WITH THIS MILEAGE AND THAT IS DRIVEN VERY LIGHTLY UNLESS THERE IS A DEFECT IN DESIGN LIKE THERE IS WITH FORD F-150 DRIVE SHAFTS. THIS IS SOMETHING THIAT IS SUPPOSED TO LAST THE LIFETIME OF THE TRUCK. *KB

Mileage: 95,000

2005 FORD F150, 139,000 MILES. TRUCK STARTED MAKING GRIND/BUZZ NOISE INTERMITTENTLY AND WOULD STOP WHEN ACCELERATOR WAS RELEASED. TOOK TO FORD DEALER AND WAS TOLD 4WD VACUUM SWITCH DAMAGED FROM WATER AND DRIVER SIDE INDEPENDENT WHEEL END NEEDED REPLACED. NEW SWITCH HAS WATER SHROUD TO PREVENT WATER DAMAGE WHICH WOULD INDICATE THIS IS A KNOWN PROBLEM. *TR

Mileage: 139,000

2005 FORD F150 TRUCK 4X4 AUTO TRANSMISSION EXPERIENCED MECHANICAL FAILURE WITH NO WARNING. LOST FORWARD LOW GEARS. ONLY HAS 57K MILES. TRUCK WAS ALWAYS DEALERSHIP SERVICED AND MAINTAINED AS RECOMMENDED. NO HARSH WEATHER CONDITIONS EXPERIENCED. NO HEAVY TOWING DONE. REPLACED WITH REBUILT TRANSMISSION. OLD PART WILL BE MADE AVAILABLE. *TR

Mileage: 57,000

THIS PAST MARCH, DURING A HEAVY SNOW STORM I TRIED TO ENGAGE MY 4 WHEEL DRIVE ON MY 2005 F150 AND IT WOULDN'T ENGAGE. SINCE THEN, I'VE NOTICED A NOISE COMING FROM MY RIGHT FRONT WHEEL (THAT'S SINCE PROGRESSED TO MY LEFT FRONT WHEEL). FOUND A TSB #06-8-15 THAT AFFECTS THE IWE SOLENOIDS ON 04-06 F150'S. REPLACED THE SOLENOID, AND STILL HAVE NOISE. NOW BEING TOLD BY A FORD MECHANIC THAT MY ACTUATOR HUBS ARE PROBABLY SHOT FROM WATER GETTING INTO THE OLD SOLENOID AND TRAVELING DOWN THE VACUUM HOSES TO THE HUBS. *TR

Mileage: 59,000

A SPARK PLUG BLEW OUT OF THE CYLINDER HEAD, DESTROYING THE COIL ABOVE IT. NO HINT OF ANY PROBLEMS PRIOR TO BLOW OUT. *TR

Mileage: 165,822

2005 F150 STALLED WITHOUT WARNING WHILE DRIVING SOMETIMES AT HIGHSPEED ON THE HIGHWAY. IT HAPPENED VERY FREQUENTLY AND THE CHECK ENGINE LIGHT FINALLY CAME ON SO I TOOK IT TO THE DEALERSHIP FOR REPAIR. I WAS TOLD THAT THE THROTTLE BODY WOULD NEED REPLACING AT APPROX $750.00 AND WAS TOLD THAT THIS IS A TYPICAL REPAIR FOR THIS VEHICLE. I UNDERSTAND MANY OTHERS HAVE HAD THIS ISSUE. PRIOR TO REPAIRING I STALLED SEVERAL TIMES IN THE HIGH SPEED LANE AND HAD TO PULL OVER TO THE LEFT HAND OF THE 4 LANE HIGHWAY WHICH I WAS FORTUNATE NOT TO BE HIT. THIS SEEMS TO BE A VERY SERIOUS SAFETY ISSUE. *TR

Mileage: 92,000

I HAVE A 05 FORD F150 AND MY DIFFERENTIAL HAS GONE OUT AND NEEDS TO BE REBUILT I HAD THIS ISSUE WHILE UNDER WARRANTY BUT FORD ALWAYS FOUND EXCUSES AND NOW THAT ITS OUT OF WARRANTY I STARTED TO RESEARCH AND I HAVE FOUND ALOT OF COMPLAINTS WHERE PEOPLE COMPLAIN OF LOUD NOISE AND VIBRATIONS AT THE ABOVE SPEEDS OF 45MPH. *LN

Mileage: 72,000

TRUCK WOULD IDLE EXTREMELY BAD, WHEN YOU CUT IT OFF IT WOULDN'T START. THIS STARTED HAPPENING ON FRIDAY, DECEMBER 31, 2010. I TOOK THE TRUCK TO FIRESTONE AND THEY RUN A DIAGNOSTIC TEST WHICH AT THE TIME DID NOT SHOW THE THROTTLE BODY PROBLEM BECAUSE THE "CHECK ENGINE" LIGHT WAS NOT ON AT THE TIME. HOWEVER, FIRESTONE REPLACED THE FUEL FILTER, DID A TUNE UP AND REPLACED THE BATTERY AND REMOVED THE GAS TANK TO CLEAN IT BUT THIS STILL DID NOT RESOLVE THE PROBLEM AND THIS COST ME $369. THE TRUCK WAS THEN TAKEN TO A FORD DEALERSHIP AND ON THE WAY THERE THE "CHECK ENGINE" LIGHT DID COME ON. THE DEALERSHIP ADVISED US AFTER THE DIAGNOSTIC TEST THAT WE NEEDED A THROTTLE BODY AND ELECTRONIC EGR VALVE WHICH WILL COST $1330.00. *TR

Mileage: 157,000

ON CERTAIN MODEL FORD VEHICLES USING THEIR 5.4 LITER ENGINE (WHICH INCLUDES FORD/LINCOLN MODELS) THE SPARK PLUGS ARE OF A 3 PART DESIGN WHICH WILL SEPARATE AND SHOOT OUT OF THE TOP OF THE ENGINE WHILE RUNNING CAUSING SERIOUS INJURY OR EVEN DEATH AND EXTENSIVE DAMAGE TO THE ENGINE. FORD IS AWARE OF THIS PROBLEM AS I HAVE BEEN TOLD BY SEVERAL SERVICE MANAGERS BUT FORD REFUSES TO DO ANYTHING ABOUT IT BECAUSE FOR EVERY VEHICLE REPAIR IS A 1500.00 REPAIR BILL FOR THE DEALER/FORD. FOR PEOPLE WHOM DON'T HAVE 1500.00 TO REPLACE SPARK PLUGS WHICH SHOULD BE A 50.00 REPAIR, THEY REMAIN AT RISK. *TR

Mileage: 129,650

ORIGINAL FLYWHEEL BROKEN. TOLD WILL COST $1K TO $1,4K TO REPLACE THAT AND STARTER B/C FLYWHEEL 'PROBABLY' DAMAGED STARTER. TRUCK WON'T START SOMETIMES, AND GRINDS WHEN I TRY TO START IT. WAS STRANDED 2 TIMES AND HAD TO BE TOWED. *TR

Mileage: 85,000

I OWN A 2005 FORD F150 5.4 AUTOMATIC W/ 63,000. UNEXPECTED FAILURE OF TRANSMISSION CAUSED BY, AS DEALER STATED, A DEGRADATION OF A BEARING WHICH CAME LOOSE AND BECAME LODGED IN SIDE OF THE TRANSMISSION. I REPLIED TO THE FORD SERVICE MANAGER DOES THIS MEAN THAT WHAT CAUSED THE FAILURE WAS A DEFECTIVE PART, HE ANSWERED YES AND GAVE ME THE QUOTE FOR A NEW TRANSMISSION. I HAVE DONE SOME RESEARCH AND HAVE FOUND OVER 6,000 CASES OF CUSTOMERS WITH SAME ISSUE( NO TOWING, PROPER MAINTENANCE INTERVALS AND DOCUMENTATION, ETC.) YET INVESTIGATION IS BEING CONDUCTED TO FIND SOLUTION TO THE PREMATURE FAILURE. TALKED TO 3 NATIONALLY KNOWN TRANSMISSION REPAIR FACILITIES AND THEY ALSO HAVE STATED NUMEROUS PROBLEMS WITH THE 4R75W AND 4R70E/W TRANSMISSION THAT FORD IS INSTALLING IN ITS VEHICLES, PRIMARILY WITH THE EXACT SAME SYMPTOMS. *TR

Mileage: 64,000

AS I WAS DRIVING DOWN A MAJOR HIGHWAY IN SOUTH CAROLINA, I FELT LIKE MY TRANSMISSION MIGHT BE SLIPPING IN MY 2005 FORD F-150. I TOOK IT IMMEDIATELY TO A LOCAL AND REPUTABLE MECHANIC WHO TESTED THE TRANSMISSION AND SUBSEQUENTLY INFORMED ME THAT IT WAS THE ENGINE, SPECIFICALLY THE SPARK PLUGS. IN THEIR INVESTIGATION IT WAS DETERMINED THAT 4 OF MY 8 SPARK PLUGS WERE BROKEN. THEY HAD TO USE A SPECIAL TOOL, DEVELOPED BY FORD JUST FOR THIS "PROBLEM", IN ORDER TO EXTRACT THE BROKEN PLUGS. THE MECHANIC STATED THAT FORD SHOULD HAVE TO RECALL THESE OR FORCED TO REIMBURSE CONSUMERS FOR THE EXPENSIVE REPAIRS DUE TO A DESIGN ERROR. UPON RESEARCHING ON-LINE, I WAS TOTALLY AMAZED AT HOW MANY AND HOW MUCH A PROBLEM PEOPLE HAVE HAD WITH THESE PLUGS AND THE CONSUMER IS PAYING FOR THEIR DEFECT. THIS IS NOT RIGHT. THE TOTAL COST FOR THIS REPAIR FOR ME WAS $358.55. TELL ME HOW MANY OTHER CARS OR TRUCKS REQUIRE THIS TYPE OF REPAIR TO REPLACE SPARK PLUGS? I WOULD L LIKE FOR YOUR AGENCY TO INVESTIGATE THE NUMBER OF REPAIRS CONSUMERS HAVE HAD TO MAKE BECAUSE OF THIS DEFECT. [XXX] SC DRIVERS LICENSE NO. [XXX] VIN [XXX] THANK YOU FOR INVESTIGATING THIS DEFECT. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

Mileage: 116,154

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHEN ACCELERATING FROM LOW SPEEDS OF 15-25 MPH, THE VEHICLE WOULD VIBRATE EXCESSIVELY, CAUSING THE TRANSMISSION TO SHIFT HARD. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER FOR THEM TO INSPECT AND DIAGNOSE THE VEHICLE FOR REPAIRS. THE FAILURE MILEAGE WAS 64,000.

Mileage: 64,000

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD ATTEMPT TO SHIFT INTO FOUR-WHEEL DRIVE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE IT WAS FOUND THAT WATER WAS LEAKING THROUGH THE FRONT CHASSIS IN FRONT OF THE FOUR-WHEEL DRIVE AND CORRODING THE SOLENOIDS. THE DEALER ORDERED THE NECESSARY PARTS TO REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE IS 83,000. UPDATED 11/10/10

Mileage: 60,000

TRUCK ENGINE CUTTING OFF AT ANY TIME WHILE DRIVING ,LOSS OFF STEERING AND CONTROL OF TRUCK. MANY COMPLAINTS ON LINE OF SAME PROBLEM. TRUCK IS OUT OF WARRANTY. IT HAS 40,000MILES. IT HAPPENS A COUPLE TIMES A WEEK. *TR

Mileage: 39,500

FORD MOTOR COMPANY-THERE WAS A SERVICE BULLETIN PUT OUT SHOW THERE WAS A PROBLEM WITH THE CAM PHASERS AND CAM CHAIN TENSIONER CAUSING THE ENGINE TO MAKE NOISES AND THEN ENGINE FAILURE THERE HAS BEEN LOTS OF COMPLAINTSTO FORD WITH NOTHING BEING DONE IF YOU WHERE DRIVING ONTHE ROAD AND THE ENGINE BLEW COULDCAUSE A ACCIDENT I CONTACT FORD AND THEY HAVE ALL MOST ADMITTED TO IT THAT THEY NEW THERE WAS A PROBLEM I HAVE FOUND THAT THERE HAS BEEN 1092 COMPLAINTS OVER THIS PROBLEM AND NOTHING DONE. I CONTACTED FORD AND THAT'S HOW I FOUND OUT ABOUT YOU THEY KEEP SAYING THERE SENDING THE COMPLAINT TO ANOTHER DEPT..BUT THIS IS APROBLEM THAT COULD HAVE BEEN CORRECT BEFORE THE ENGINE WAS RUINED. *TR

Mileage: 74,000

FORDMOTOR COMPANY ON THE 2005 FORD F150 THERE HAS BEEN OVER 1000 COMPLAINTS ABOUT THE ACTUATOR ON THE FOUR WHEEL DRIVE THERE IS A VACUUM SWITCH THAT OPERATES THEM WATER RUNS DOWN OFF THE COWL CONTAMINATING THE VAC.LINE CAUSING THE ACTUATOR TO GO OUT THEREWAS A SERVICE BULLETIN PUT OUT SHOWING THAT THEY NEW OF THIS PROBLEM AND DID NOTHING TO CORRECT IT. THE SWITCH CONTROLS THE VAC. TO THE ACTUATOR WITH NO VAC. THE FOUR WHEEL DRIVE IS ENGAGE WHEN .TO MAKE IT SIMPLY IT TAKES VACUUM TO DISENGAGE THE FOUR WHEEL DRIVE IF YOU ARE GOING DOWN THE ROAD AND THE SWITCH FAILS WHAT'S GOING TO HAPPEN YOU WILL RUIN THE FOUR WHEEL DRIVE ACTUATORS AND COULD GET INTO OR CAUSE A ACCIDENT. *TR

Mileage: 72,000

TL*THE CONTACT OWNS A 2005 FORD F150. SHE STATED THAT WHILE DRIVING 20 MPH THE VEHICLE FISH TAILED ON AN ICY ROAD. THE BACK RIGHT TIRE HIT A CURB AND CAUSED THE AXLE TO SNAP AND THE TIRE TO FALL OFF OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE AXLE AND TIRE. THE FAILURE MILEAGE WAS 58000. THE CURRENT MILEAGE WAS 60000.

Mileage: 58,000

TL*THE CONTACT OWNS A 2005 FORD F150. WHILE DRIVING 2 MPH IN REVERSE THE TIRES BEGAN TO SPIN AROUND AND THE 4 WHEEL DRIVE DID NOT ACTIVATE. THE FAILURE HAS OCCURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE 4 WHEEL DRIVE WAS REPAIRED THE FIRST TIME IN JAN 2009. . THE FAILURE MILEAGE WAS 38000 AND THE CURRENT MILEAGE WAS 48000. UPDATED 4/13/10 *CN THE CONSUMER STATED THE SECOND TIME IT WAS REPAIRED WAS IN MARCH 2000. UPDATED 06/18/10

Mileage: 38,000

FRONT WHEELS DO NOT ENGAGE INTO 4-WHEEL DRIVE. INDICATOR LAMPS DISPLAY THAT SYSTEM IS ENGAGED AND FUNCTIONING PROPERLY CAUSING A FALSE SINCE OF SECURITY WHEN TRAVELING ON SNOW COVERED ROADS. MECHANIC REPLACED PART # 7LIZ-3C247-A (ACTUATOR). A COUPLE OF MECHANICS SAID IT WAS A POOR DESIGN AND THIS VACUUM SYSTEM WAS PRONE TO WATER AND DIRT AND WOULD EVENTUALLY HAVE TO BE REPLACED AGAIN. *TR

Mileage: 46,174

FOUR WHEEL DRIVE DOES NOT ENGAGE. NO INDICATOR LAMPS. FORD HAD TO REPLACE 4X4 MOTOR. 34,000 MILES BUT 38 MONTHS SO WAS NOT COVERED UNDER WARRANTY. *TR

Mileage: 34,000

TRANSMISSION FAILED WHILE DRIVING. LEAVING ME STRANDED ON THE HIGHWAY. FRONT BEARING WENT OUT ,ROOT CAUSE OF FAILURE ACCORDING TO AAMCO MECHANIC. TRUCK ONLY HAS 49,000 MILES. TRUCK HAS ALWAYS HAD A VIBRATION . LANCE CUNNINGHAM FORD ALWAYS POINTED TO TIRES, DRIVE SHAFT. I BELIEVE THAT THE TRUE PROBLEM HAS NOW CAME TO LIGHT. UNFORTUNATELY THE ORIGINAL WARRANTY WAS FOR 3 YEARS OR 36,000 MILES. *TR

Mileage: 49,000

2005 F-150 DRIVESHAFT GOES BAD PREMATURELY. THE MIDDLE JOINT IN A 2 PIECE DRIVE SHAFT IS CHEAPLY MADE AND UNSERVICEABLE. IT CAUSES DRIVETRAIN VIBRATION AND COULD FAIL CAUSING INJURY TO PASSENGERS OR OTHER DRIVERS THOUGH A ACCIDENT. THE PART FAILURE IS A COMMON OCCURRENCE IN THIS VEHICLE AND MANY HAVE BEEN ALREADY REPLACED. MY 2005 F-150 HAS 72000 MILES ON IT. THE DRIVESHAFT IS BAD AND MUST BE REPLACED. MANY OTHER TRUCKS HAVE THE SAME PROBLEM AND DO NOT KNOW WHAT IT IS. I PAID A DEALERSHIP TO DIAGNOSE THE PROBLEM. IT TOOK THEM AWHILE TO FIGURE IT OUT. UNFORTUNATELY I DID NOT HAVE THE MONEY FOR THE REPAIR. I COULD NOT SEE SPENDING 900 DOLLARS FOR THE SAME DEFECTIVE PART. I AM STILL LOOKING FOR A REASONABLE AND QUALITY REPLACEMENT. DRIVE SHAFTS HISTORICALLY LAST A LOT LONGER THAN THE ONES FORD IS PUTTING OUT . THIS IS A DANGEROUS AND EXPENSIVE DEFECT. PEOPLE ARE SPENDING MONEY TRYING TO FIX A VIBRATION AND OVERLOOKING THE DRIVESHAFT BECAUSE IT IS SO HARD TO BELIEVE THAT THE DRIVESHAFT IS BAD. SO IT IS OVERLOOKED FOR SOME BY THE TIME THEY FIGURE IT OUT IT COULD BE TOO LATE FOR THE PASSENGER OR A INNOCENT MOTORIST SHARING THE ROAD WITH THEM. DO THE RIGHT THING MAKE FORD PAY FOR OR REPLACE THESE DRIVESHAFTS. TIME IS TICKING AWAY AND THE MILES ARE CLICKING OFF ON ALL THOSE TRUCKS WITH THESE DRIVE SHAFTS. *TR

Mileage: 66,000

DRIVING ON ROAD IN SCHOOL ZONE (25 MILES PER HOUR) CHILDREN PLAYING ON SIDEWALK. CHILDREN WERE JUMPING ON OFF SIDEWALK INTO STREET. APPLIED MY BRAKES. HEARD CLUNK IN THE BACK OF THE TRUCK THEN - NO BRAKE. USED EMERGENCY BRAKE TO STOP. FAILURE OCCURRED AS AXLE BROKE, APPARENTLY LOOSE FOR LONG TIME - NOT ORIGINAL OWNER, PURCHASED FROM DEALER. C CLAMP HOLDING AXLE IN PLACE IS DISSOLVED INTO SMALL PIECES CAUSING AXEL TO COME OUT. CALIPER IS TOAST (ONLY THING HOLDING AXLE INTO PLACE) ROTOR, BRAKE PAD, ALL REAR AXLE COMPONENTS - COMPLETELY FAILED, CAUSED OVER $3,000 IN REPAIRS TO TRUCK. EXTENDED WARRANTY WON'T COVER STATING WHEN THE TIRE RUBBED AGAINST THE CURB - THEY CONSIDER THAT AS IMPACT - FORD WANTS NO PART IN FIXING - SAID NO REPORTED PROBLEMS WITH C-CLAMP (NO RECALLS) OR AXEL BREAKING OR SLIPPING AWAY. A TRUE NIGHTMARE! - YOU PAY FOR EXTENDED WARRANTY - BUT THEY DON'T PAY FOR THE REPAIR, YOU BUY A TRUCK FROM A DEALER, YET THEY DON'T CHECK SAFETY - ONLY TIRES, WIPERS AND SMALL STUFF. CONSUMER IS FORCED TO BEAR ANY DEFECTIVE PARTS ON THEIR OWN. REALLY FRUSTRATED. *TR

Mileage: 74,000

TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT SHE HEARD A GRINDING NOISE WHILE DRIVING AT ANY SPEED. THE NOISE WAS HEARD INTERMITTENLY. THE DEALER COULD NOT DUPLICATE THE FAILURE. THE VEHICLE LATER LOCKED INTO 4-WHEEL DRIVE WHILE DRIVING LESS THAN 55 MPH. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY FOUND THAT THE SOLENOID AND THE SWITCH FOR THE 4-WHEEL DRIVE WERE DEFECTIVE. THE CONTACT PAID $185 TO HAVE THE VEHICLE REPAIRED. THE DEALER WAS UNSURE IF THE REPAIR WOULD CORRECT THE FAILURE BECAUSE THE ELECTRICAL SWITCH WAS SUSCEPTIBLE TO WATER DAMAGE. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 37,217. UPDATED 08/11/09.*JB

Mileage: 37,217

WHILE DRIVING, THE VACUUM SOLENOID FOR THE 4 WHEEL DRIVE TRIES TO ENGAGE THE 4 WHEEL DRIVE - EVEN AT HIGHWAY SPEEDS- RESULTING IN A HORRIBLE SOUND. THE SOUND WAS "LIKE I HAD RUN OVER A SHOPPING CART OR HIT SOMETHING IN THE ROAD AND WAS DRAGGING IT UNDER THE TRUCK". THIS HAPPENED 5 TIMES IN TWO DAYS IN LESS THAN 30 MILES OF TOTAL DRIVING. THE NOISE IS SO LOUD AND ALARMING THAT IT MADE ME IMMEDIATELY APPLY THE BRAKES AND PULL TO THE SIDE OF THE ROAD BECAUSE I THOUGHT I HAD HIT SOMETHING/SOMEONE. AT FIRST I WONDERED IF MY MUFFLER OR DRIVE SHAFT OR SOME OTHER PART HAD FALLEN OFF OF THE TRUCK. THIS "FALSE ENGAGEMENT" OF THE 4 WHEEL DRIVE HAPPENS WITHOUT ANY WARNING IN ALL KIDS OF DRIVING CONDITIONS (SLOW, FAST, BREAKING OR ACCELERATING). A NEW, REDESIGNED (NOW HAS A COVER ON IT TO KEEP MOISTURE OUT- WHICH WAS CAUSING THE FAILURE) VACUUM SOLENOID WAS INSTALLED ON TRUCK - A $27.00 PART. DEALERSHIP KEPT OLD PART. TECH. AT DEALER TOLD ME THAT THIS PART WILL GO BAD AT SOME POINT AND NEED REPLACING ON ALL THE TRUCKS WITH THE PART. HE SAID "NOT IF BUT WHEN". FORD KNEW ABOUT THE PROBLEM - HENCE THE REDESIGNED PART. FORD HAS NOT NOTIFIED OWNERS OF THIS PART AND IT'S IMPENDING FAILURE. *TR

Mileage: 53,900

I BOUGHT THIS TRUCK WITH 48,000 MILES ON IT. IT HAD A BAD SHAKE IN THE REAR AREA. ALSO A BAD BRAKE SHIMMY. TOOK TO FORD DEALERSHIP I BOUGHT IT. COULDN'T FIND ANYTHING WRONG. TOLD NORMAL! I WORKED IN THE SERVICE DEPT OF A FORD DEALERSHIP I KNOW NORMAL. 53,000 OR SO MILES BAD CLUNKING FROM TRANSFER AREA WOULDN'T GO INTO 4 WHEEL DRIVE 1/2 THE TIME TOOK TO FORD, TOLD NOTHING WRONG AGAIN. 72,000 MILES TRANSMISSION GOES OUT. TOLD NOTHING COULD BE DONE, OUT BY 2000 MILES. I WAS A SERVICE MANAGER FOR A FORD DEALERSHIP THEY COULD DO A SUPPLEMENT ON THE WARRANTY. I ASKED FOR 1/2 OF COST TOLD NO. EVEN AFTER DOCUMENTATION OF ALL THE SERVICES AND COMPLAINTS TOLD TO BAD SO SAD. THIS TRUCK HAS HAD TRANSMISSION TROUBLES, 4 WHEEL DRIVE TROUBLE, THE POWER WINDOW SWITCH FELL APART IN THE DOOR AND A BAD BRAKE SHIMMY EVEN AFTER I HAD A 4 WHEEL BRAKE JOB DONE, ITS STILL THERE. NO HELP FROM FORD AT ALL! *TR

Mileage: 50,000

WHILE DRIVING ON HIGHWAY @ 60MPH, MY 4 WHEEL DRIVE ACTIVATED WITHOUT MY TOUCHING THE DASH CONTROL. THE FRONT AXLE MADE TERRIBLE GRINDING NOISES AND THE VEHICLE SLOWED DRAMATICALLY. DEALER TOLD ME IT WAS A VACUUM LINE AND FORD REPLACED UNDER WARRANTY. *TR

Mileage: 35,000

5.4L, SUPERCREW-- ENGINE WAS REPLACED BY FORD AT 38,000 MILES (AFTER COMPLAINT TO FORD CUST SVC) DUE TO INJECTOR FAILURE AND CYLINDER HYDRA-LOCK. NOW AT 46,000 MILES, COMPLETE TRANSMISSION FAILURE. ONLY USED FOR DAILY DRIVER, NO TOWING, NEVER OFF-ROAD. TRANSMISSION FAILED ON INITIAL START ON 60 DEGREE MORNING, NO PRE-FAILURE INDICATORS. PAID $2800 FOR TRANSMISSION REBUILD. I HAVE NOTICED A FAIRLY LARGE NUMBER OF PROBLEMS REPORTED ON SUB-STANDARD FACTORY TRANSMISSION AND ENGINE PARTS ON FORD TRUCKS. *TR

Mileage: 46,475

HAVING INTERMITTENT EXTREMELY VIOLENT SHAKING ISSUES WITH OUR '05 FORD F-150. IT ONLY HAPPENS NOW AND THEN, BUT WHEN IT DOES, YOU CANNOT EVEN STEER TO GET THE TRUCK OFF THE ROAD. IT HAS NO RELATION TO SPEED OR BRAKING. WENT TO THE DEALER, THEY SAID THEY FOUND THE PROBLEM AND REPLACED ONE OF THE ARMS, BUT IT HAPPENED AGAIN. I NOTICED THERE ARE HUNDREDS OF SIMILAR COMPLAINTS WITH ALL YEARS AND NUMEROUS MAKES OF THE FORD TRUCK POSTED ONLINE UNDER "VIOLENT SHAKING". IT SEEMS THAT THIS IS A SERIOUS PROBLEM THAT FORD IS NOT LOOKING INTO, AND IT WILL CAUSE A DEATH, OR MANY IF IT IS NOT ADDRESSED. *TR

Mileage: 30,000

TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING BETWEEN 65-70 MPH, THE ENTIRE VEHICLE VIBRATES. THE DEALER IS CURRENTLY INSPECTING THE VEHICLE. THE CONTACT STATED THAT THE VEHICLE IS UNSAFE TO DRIVE. HE BELIEVED THAT THE DRIVELINE WAS THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 30,000.

Mileage: 30,000

FORD F-150 SUPER CREW WITH 57,000 MILES WILL NOT ENGAGE IN OVERDRIVE. WHILE DRIVING, THE TRANSMISSION COMPLETELY SLIPPED OUT OF GEAR. AFTER PULLING OFF THE ROAD AND TESTING IT IN REVERSE AND DRIVE, I WAS ABLE TO RESUME BUT AS SOON AS THE TRANSMISSION REACHED OVERDRIVE IT DISENGAGED COMPLETELY. DEALER CLAIMS A PIN WAS BROKEN THAT LOCKS THE TRANSMISSION IN OVERDRIVE. *TR

Mileage: 57,000

BRAKE PROBLEMS SEVERAL TIMES NOW I HAVE HAD TO HAVE CALIPERS, ROTORS, ETC REPLACED. NOW MY REAR END SEEMS TO BE SLIPPING GOING AROUND CORNERS. *TR

Mileage: 45,000

TL*THE CONTACT OWNS A 2005 FORD F150. SINCE THE VEHICLE WAS PURCHASED, THE TRANSMISSION EXPERIENCED IRREGULARITIES WHILE SHIFTING. THE VEHICLE WOULD SHIFT IN AND OUT OF GEAR. THE CONTACT HEARD A NOISE WHEN THE VEHICLE SHIFTED INTO OVERDRIVE. THE VEHICLE WAS TAKEN BACK TO THE DEALER AT 23,400 MILES AND THEY STATED THAT NOTHING WAS WRONG WITH THE VEHICLE. ROCKS WERE REMOVED FROM THE EXHAUST SHIELD. THE TECHNICIAN TEST DROVE THE VEHICLE AND STATED THAT THE NOISE WAS NORMAL. WHILE DRIVING AT 55 MPH, THE VEHICLE BEGAN JERKING AND THE TRANSMISSION FAILED WITHOUT WARNING. THE DEALER STATED THAT SOMETHING BECAME LOOSE WITHIN THE TRANSMISSION AND IT NEEDED TO BE REPLACED. FORD STATED THAT THE CONTACT WOULD HAVE TO PAY OUT OF POCKET BECAUSE THE VEHICLE WAS NOT UNDER WARRANTY. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 67,000 AND FAILURE MILEAGE WAS 8.

Mileage: 8

TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 40 MPH HE STATED THAT THE GEAR SHIFT INDICATOR DISENGAGED WHEN HE CAME TO A STOP, WHICH CAUSED THE VEHICLE TO JERK HARD. THERE WAS ALSO AN INCREASE IN THE RPM, WHICH CAUSED THE VEHICLE GEAR SHIFT INDICTOR TO ENGAGE WITHOUT WARNING. THE CONTACT STATED THE TRANSMISSIONS SLIPPED OUT OF GEAR WOULD NOT ACCELERATE. THE FAILURE MILEAGE WAS 9,000 AND THE CURRENT MILEAGE WAS 19,000.

Mileage: 9,000

UPON ACCELERATION OUR F150 EXCAB MAKES A GRINDING NOISE. ALSO, WOULD NOT DISENGAGE FROM 4HI, HAD TO STOP AND START A FEW TIMES TO GET IT TO DISENGAGE. TALKED TO FORD DEALER HERE AND HE SAID IF THE GRINDING NOISE HAPPENS AGAIN BRING IT IN WHILE IT IS HAPPENING SO A MECHANIC CAN GO FOR A RIDE. THE PROBLEM IS IT IS VERY SPORADIC AND PROBABLY WON'T HAPPEN WHEN THERE IS A MECHANIC IN THE TRUCK. *TR

Mileage: 17,000

CLUNKING/OR JEARKING WHEN SLOWING OR ACCELERATION.*AK

BRAKES, REAR, LEAKAGE OF LUBRICANT FROM REAL AXLE THROUGH SEALS TO CONTAMINATE REAR BRAKE ROTORS, CALIPERS, ETC.. THIS WAS FOUND BY TECHNICIAN AT A FORD DEALERSHIP WHILE TRUCK WAS IN FOR AN OIL CHANGE. THE ENTIRE REAR END WAS REPLACED. IT WAS A MATTER OF TIME BEFORE THE BRAKES WOULD BE INOPERATIVE. THEY COULD NOT TELL IF BRAKE FLUID MAY HAVE CAUSED THE LEAK OR A FAILURE IN THE SEALS. I HAVE ALL BILLING PAPERWORK.*AK

Mileage: 65,700

2005 F150 SUPERCREW 4X4, TRANSMISSION AT 48000 MILES BEGAN TO MIS-SHIFT INTO OVERDRIVE. WITHIN A FEW DAYS THE TRANSMISSION MISSED ALL SHIFT POINTS AND WENT INTO NEUTRAL. TRANSMISSION WAS REPLACED BY EXTENDED WARRANTY AT DEALERSHIP. NO CAUSE TO FAILURE WAS FOUND. *JB

Mileage: 48,163

VEHICLE ROLLED AWAY WITH TRANSMISSION PLACED IN PARK AND KEY REMOVED. INCIDENT HAS HAPPENED 8 TIMES AND DEALER ATTEMPTED REPAIR 4 TIMES, LAST REPAIR IS 17 NOV 2005. UNKNOWN IF IT WILL WORK. *NM

Mileage: 9,000

VEHICLE'S TRANSMISSION FAILED AFTER ONLY 18 MONTHS, 38,925 MILES. DEALER UNABLE TO DETERMINE WHY TRANSMISSION FAILED. NO LACK OF FLUID, VEHICLE IS NOT USED TO TOW. COULD ONLY STATE THAT EXCESSIVE HEAT BUILD UP IN TRANSMISSION AND RESULTED IN FAILURE. VEHICLE AND BEEN DRIVEN HOME PRIOR EVENING WITH NO ISSUES, NEXT MORNING FAILED AT START UP. MANUFACTURER WILL NOT WARRANTY DUE TO MILEAGE, REPLACED WITH A REBUILT UNIT AT A COST OF $2,800. *JB

Mileage: 38,925

PLEASE HELP A CONSUMER! I QUESTION THE SAFETY AND LONG TERM VALUE OF THE NEW FORD F150 TRUCKS MY NAME IS [XXX] AND I AM WRITING YOU AS A LAST DITCH EFFORT TO INFORM THE PUBLIC ABOUT A PRODUCTION ISSUE WITH THE FORD F150 TRUCKS THAT VIBRATE UNDER NORMAL DRIVING CONDITIONS. ABOUT THREE MONTHS AGO I PURCHASED A NEW F150 AND FROM THAT POINT I HAVE HAD A VIBRATION AND TRANSMISSION ISSUE. FORD HAS NOT BEEN ABLE TO CORRECT IT AND IN THE PROCESS I FOUND THAT THE DEALERSHIP I BOUGHT THE TRUCK FROM FORGED SOME INVOICE DOCUMENTS. I WAS SHOCKED TO FIND THIS PROBLEM ALL OVER THE COUNTRY WHEN I STARTED TO LOOK INTO IT. YOU CAN SEE FOR YOURSELF IF YOU SEARCH GOOGLE FOR TOPICS LIKE "2005 F150 VIBRATION". IF YOU WOULD LIKE, I COULD SEND YOU A LIST OF WEBSITES TO HELP. IN ALL FAIRNESS TO FORD THEY DESERVE A CHANCE TO INFORM THE PUBLIC ABOUT THIS AND I AM IN THE PROCESS OF WORKING WITH A LAWYER TO GET MY MONEY BACK. I HAVE ATTACHED A COPY OF MY NIGHTMARE TO THIS EMAIL AND JUST WANTED TO LET YOU KNOW I HAVE FOLLOWED EVERY PROTOCOL SET BY FORD. I HAVE ALSO NOTICED THAT FORD JUST LIKES TO HAVE PROBLEMS DELAYED AND EXPECT PEOPLE TO RUN OUT OF MONEY WHEN TRYING TO RECOVER THEIR ORIGINAL PURCHASE. YOU WILL ALSO FIND EMAILS ATTACHED FROM PEOPLE ACROSS THE COUNTRY WITH THE SAME PROBLEM. THIS STORY IS NOT A WASTE OF YOUR TIME. PLEASE FEEL FREE TO SEARCH THE INTERNET, YOU WILL FIND ALL THE SUPPORTING INFORMATION YOU NEED. CAN YOU PLEASE FIND THE TIME TO HELP GET THE WORD OUT AND MAKE THINGS RIGHT? I JUST WANT MY MONEY BACK AND DO NOT WANT ANYONE ELSE TO FALL INTO THIS TRAP. HELP FROM THE PRESS WOULD NOT ALLOW FORD MOTOR COMPANY TO STONEWALL PEOPLE. LETS GIVE FORD A CHANCE TO HELP THE CONSUMER. CALL ANYTIME [XXX] - I AM WILLING TO PROVIDE ALL SUPPORTING INFO INCLUDING SERVICE RECORDS, RESEARCH, AND CONTACTS FROM ACROSS THE USA. THANKS [XXX]. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 300

BAD VIBRATION FROM REAR OF TRUCK 55-60 MPH INTERMITTENT. FORD STATE IT IS AFTERMARKET TIRES. HAD TRUCK IN 2 TIMES WITH FACTORY TIRES AND 3 TIMES WITH NEW TIRES FOR SAME VIBRATION. PINION ANGLE CHANGED TWICE ON TRUCK CAUSING MORE VIBRATIONS THAT FORD WON'T FIX. NOW TRUCK IS LEAKING ENGINE OIL FROM REAR MAIN. I AM AFRAID TO TAKE TRUCK ON LONG TRIPS FOR FEAR OF DRIVELINE FAILURE. NUMEROUS COMPLAINTS ON WEB OF SAME PROBLEM. WHY IS FORD NOT MADE TO FIX THIS ISSUE?TRUCK HAS 6,200 MILES ON IT AND ALMOST A YEAR OLD. THIS COULD BE A BIG SAFETY CONCERN IF DRIVELINE FAILURE OCCURS AT HIGHWAY SPEEDS. I HAVE BEEN AN AUTO MECHANIC FOR 18 YEARS AT DEALERSHIPS AND I KNOW A TIRE VIBRATION FROM A DRIVELINE VIBRATION. *JB

THE AUTOMATIC TRANSMISSION IN THE CONSUMER'S 2005 FORD F150 FAILED. *NM

JERKING AND BUMPING NOISE IN DRIVE LINE AT LIGHT ACCELERATION JUST BEFORE OR JUST AFTER TRANSMISSION SHIFTS TO THE NEXT GEAR. DEALER ADDED A GEAR FLUID ADDITIVE THAT THEY SAID WAS LEFT OUT AT FACTORY. THIS DID NOT FIX THE PROBLEM. *NM

POPPING FROM REAR-END AT SLOW SPEEDS AND SHUTTERING AT DOWN SHIFT ON HIGHWAY. LOCAL DEALER SAID REAR PINION GEAR OUT OF ALIGNMENT, AND CLUTCH PACKS WERE BAD THEY HAD TO ORDER PARTS TO FIX THE PROBLEMS. *NM

Mileage: 17,000

MY PAINT JOB WAS DEFECTIVE AND THIN, MY WINDSHIELD WAS NOT SEALED PROPERLY, THERE ARE TICKING NOISES FROM UNDER THE DASHBOARD, THE FRONT END IS TOO HEAVY FOR THE ADDED WEIGHT TO THE TRUCK, THE TRANSMISSION STALLS THE TRUCK WHEN IT ROLLS BACKWARDS IN DRIVE, THE TRUCK SHAKES AT HIGH SPEEDS AND HAS EXCESSIVE TIRE WEAR, WHICH IS THE ONLY THING THAT FORD HAS ALL BUT ADMITTED TO BY EXTENDING THE EXCESSIVE TIRE WEAR/RIDE HARSHNESS WARRANTY FROM 1YR/12,000 MILES TO 3YRS/36,000 MILES. HAVE YOU EVER HEARD OF A CAR COMPANY GIVING AWAY SOMETHING UNLESS THERE WAS A SERIOUS PROBLEM WITH THIS VEHICLE. *NM

AUTOMATIC TRANSMISSION ON 2005 FORD 150, GOES INTO NUTERAL WHEN YOU STOP ON A HILL AND WILL ROLL BACKWARDS EVEN THOUGH THE TRUCK IS IN DRIVE OR THE TRUCK WILL ROLL FORWARD EVEN WITH THE TRUCK IN REVERSE. THE TRUCK ALSO GOES INTO NUTERAL WHEN GOING DOWN A HILL AND YOU TAKE YOUR FOOT OFF THE GAS . TRANSMISSION THEN CLUNKS WHEN GOES BACK INTO GEAR. ALSO WHEN TUCK DOWN SHIFTS WHEN GOING UP HILL IT SEEMS TO HIT A DEAD SPACE IN THE TRANSMISSION. WAS TOLD THIS IS ALL NORMAL BY FORD REPS. *NM

Mileage: 13,000

I CURRENTLY OWN A 2005 FORD F-150 4X4 SUPERCREW TRUCK AND HAVE STARTED EXPERIENCING SOME GRINDING/ PULLING IN THE TRANSMISSION. I FIRST THOUGHT IT WOULD PROBABLY JUST GO AWAY AND NOW IT JUST GETS WORSE EACH TIME. THE PROBLEM CREATES A RATHER LOUD NOISE AND HAS GREATLY CONCERNED ME. I CONTACTED THE DEALERSHIP WHERE I PURCHASED THE TRUCK, RIVERTOWN FORD/ COLUMBUS,GA, AND I DISCOVERED THAT THIS PROBLEM SEEMS TO BE WIDE SPREAD WITH THE F-150. I AM IN PROCESS OF TRYING TO SOLVE THIS PROBLEM NOW. FORD MOTOR CO. NEEDS TO ISSUE A RECALL FOR THIS ISSUE. *NM

Mileage: 12,110

DT: THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATES THAT THE AUTOMATIC TRANSMISSION IS NOT WORKING PROPERLY. WHILE DRIVING UP A HILL THE VEHICLE WILL ROLL BACK. ALSO, WHEN DRIVING DOWN A HILL THE VEHICLE WILL ROLL BACK AS WELL. IN ADDITION, TRANSMISSION IS MAKING A CLANKING NOISE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOUR TIMES, AND THEY WOULD LIKE TO FIX THE VEHICLE, BUT THEY CONTACTED FORD. THE DEALERSHIP SPOKE WITH THE REGIONAL FORD REPRESENTATIVE, WHO TOLD THEM THIS WAS NORMAL FOR THE VEHICLE ALTHOUGH NONE OF THE OTHER TRUCKS HAD A SIMILAR PROBLEM. THE CONTACT TEST DROVE A 1999 MODEL AND DROVE IT THE SAME PLACES WHERE SHE EXPERIENCED THE PROBLEM ,AND THAT VEHICLE DID NOT EXPERIENCE THE SAME PROBLEM. THE DEALERSHIP WAS GOING TO TEAR THE VEHICLE APART TO SEE WHAT WAS WRONG WITH IT BECAUSE THEY TEST DROVE IT AS WELL AND NOTICED THE PROBLEM. THIS PROBLEM IS INTERMITTENT AND GETS WORSE.*AK *NM

I HAVE A NEW 2005 F150 SUPER CREW 4X4 W/ 5.4L. ESPECIALLY NOTICEABLE IN CITY TRAFFIC, WHENEVER I SLOW DOWN AND THEN ACCELERATE, THERE IS A AT LEAST ONE OR MORE BUMPS OR JERKS SEEMING TO COME FROM THE TRANSMISSION OR DRIVE TRAIN. FORD WON'T DO ANYTHING ABOUT IT. THIS IS TOO MAJOR OF A BUMP TO NOT CAUSE DAMAGE OR PROBLEMS LATER ON. *NM

EVER SINCE DELIVERY OF VEHICLE (2005 FORD F150 LARIAT 4WD), VEHICLE "SHUTTERS" OR "JERKS" ON ACCELERATION FROM A COMPLETE STOP. INITIALLY THERE WAS ALSO SOME "POPPING" ON TURNING AND ACCELERATION, WHICH WAS FIXED BY THE DEALERSHIP. THE SHUTTERING HAS BEEN FIXED, BUT AFTER 3 REPAIR ATTEMPS, THE TRUCK CONTINUES TO JUMP/JERK ON ACCELERATION FROM A COMPLETE STOP. THE DEALERSHIP STATES THIS IS NORMAL, BUT THE DRIVELINE ONLY JERKS WHEN IN 2WD MODE - IT DOES NOT JERK IN 4WD. TO GET THE SHUTTERING TO STOP, FORD INSTALLED A SHIM KIT TO ALIGN THE DRIVELINE, WHICH THEY STATE IS A PROBLEM THEY FINALLY FOUND. *JB

I PURCHASED F150 LARIAT FROM LEIF JOHNSON FORD IN AUSTIN OCT 2004. I HAVE BEEN EXPERIENCING TROUBLE WITH THE TRUCK NOT WANTING TO COME OUT OF PARK. YOU CAN PUT YOUR FOOT ON THE BRAKE ALL DAY LONG AND TRY TO PUSH THE BUTTON IN TO MOVE THE GEAR AND NOTHING HAPPENS. I HAVE BEEN TO THE DEALERSHIP 4 TIMES IN THE PAST MONTH TRYING TO RESOLVE THE PROBLEM. LAST FRIDAY 8-05-05 THEY CHANGED OUT THE COMPLETE GEAR SHIFT THINKING THAT WAS THE PROBLEM AND HAVE THE SAME PROBLEM ON THAT SATURDAY 8-06-05 AND AGAIN 8-07-05,8-08-05 IN WHICH I RETURNED TO FORD.*JB

DT: THE CONSUMER STATED 2005 FORD F150 SURGED FORWARD. IT FELT LIKE CRUISE CONTROL KICKED IN. HE TOOK THE VEHICLE TO DEALER, AND DEALERSHIP CALLED FORD, AND THEY HAD THE ACCELERATOR CHIP REALIGNED. AFTER THE VEHICLE WAS FIXED THE SURGING CONTINUED. HE CONTINUED TO CONTACT THE DEALERSHIP AND FORD. ACCORDING TO CUSTOMER SERVICE THE ENGINEERS SAID THEY COULD NOT FIND ANYTHING WRONG WITH IT. CONSUMER WAS CURRENTLY AFRAID TO DRIVE THE VEHICLE, SO WAS SITTING IN THE DRIVEWAY. THE VEHICLE WAS TAKEN IN LAST WEEK, AND THEY KEPT IT FOR A WEEK, AND THEY STATED THEY COULD NOT FIND ANYTHING WRONG WITH IT. ON THE WAY HOME TRANSMISSION SLIPPED AND SURGED FORWARD. DEALERSHIP AND THE MANUFACTURER KEPT TELLING HIM TO CALL THE OTHER. CONSUMER STATED VEHICLE HAS BEEN AT DEALERSHIP AT LEAST FIVE TIMES, AND GOT A DIFFERENT SERVICE MANAGER EVERY TIME. THE PROBLEM STARTED THE NIGHT HE PURCHASED THE VEHICLE. *AK

Mileage: 5

I HAVE A 2003 F-150 WITH A 5.4 ENGINE. THERE IS SLACK IN THE TRANSMISSION AROUND THE TORQUE CONVERTER. WHWNEVER YOU SLOW DOWN THE GENTLY BUMP THE ACCELERATOR YOU HEAR A BUMPING NOISE. IS THIS NORMAL

DT: THERE IS A LOUD CLANKING NOISE IN THE REAR END WHEN TAKING OFF AND WHEN SHIFTING GEARS. IT JUMPS SO BAD SOMETIMES YOU HAVE TO STOP THE VEHICLE AND LET IT COOL OFF BEFORE RESUMING RIDE. IT'S BEING HAVING THIS PROBLEM FOR THE PAST 2000 MILES. HAVE TAKEN TO THE MANUFACTOR AND THE DEALER. IT'S BEEN AT THE DEALER 3 TIMES FOR THIS PROBLEM ALONE. NO PARTS HAVE BEEN REPLACED. THE DEALER TOLD CONSUMER THAT IF THERE WAS NO RECALL THEY COULDN'T FIX IT BECAUSE ALL THE TRUCKS 2005 F150 REGULAR CABS HAVE THE SAME PROBLEM.*AK

Mileage: 3,000

WHILE SHIFTING THE VEHICLE INTO PARK AND GETTING OUT OF THE VEHICLE, THE VEHICLE WENT INTO REVERSE. THE CONSUMER WAS ABLE TO GET BACK INTO THE VEHICLE AND STOPPED THE VEHICLE. THE TRUCK WAS TOWED TO THE DEALER. THE DEALER HAD TO REPLACE THE TRANSMISSION LEVEL LINKAGE. *SC *JB

Mileage: 35,000