2006 FORD F-150 Steering Problems

When is some one going to do something about the faulty steering column in 2006 Ford F150 pick ups and similar model years? It is all over the internet about the grinding and catching of the steering column. In some cases can't steer at all. There is tons of information on this problem. I have a 2006 Ford F150. It is starting with the problem and it only has 82,000 miles. This should not be happening some one is going to get hurt or killed !

My truck was sounding like it was going to fall apart, I brought it to my sons attention and u can see the truck sagging between front and bed of truck. We looked under vehicle and the frame is split in two all the way across. [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

THE STEERING LOWER SHAFT GETS FAULTY IN THIS YEARS TRUCK DO TO BEING CHEAP MADE AND GETS CORRODED WIN SALT FROM THE ROADS BARELY TOUCHES IT WHEN DRIVING YOU HAVE TO TURN EXTREMELY HARD TO MAKE IT STEER AND IT DOESN'T TAKE MUCH FOR IT TO BRAKE WHEN GOING DOWN A HIGHWAY ONE OF THE MOST IN SAFE DESIGNS I HAVE EVER SEEN IN A NEWER TRUCK THAN 2000 THERE WAS A RECALL ON THEM THE EXACT SAME DESIGN IN THE CROWN VICS FROM 2004 TO 2008 MINE BROKE WHEN GOING DOWN THE CITY ROAD GOING ABOUT 45MPH

Mileage: 110,000

THE U JOINT ARE FREEZING UP AND IT IS HARD TO TURN AND IT GETS WORSE

HARD STEERING ON INITIAL START UP AND DRIVING . STEERING WOULD NOT GO BACK TO CENTER BY ITSELF HAD TO MANUALLY CORRECT..STEERING GETS BETTER THE LONGER YOU DRIVE IT.

Mileage: 163,227

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE ATTEMPTING TO MAKE A TURN, THE STEERING WHEEL SEIZED. THE FAILURE PREVENTED THE VEHICLE FROM TURNING AND ALMOST DROVE OFF A BRIDGE INTO A RIVER. THE VEHICLE WAS ABLE TO BE VEERED TO SAFETY. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

WAS DRIVING MY 2006 F-150 OVER A MOUNTAIN PASS IN CANADA. THERE WAS COMPACT SNOW AND ICE ON THE ROADWAY AND I WAS TRAVELING WITH OTHER VEHICLES AROUND ME AT APPROXIMATELY 40 MPH. THE VEHICLES AHEAD OF ME BEGAN TO BRAKE, I AS WELL TRIED TO BRAKE ONLY TO FIND MY TRUCK HAD LOST POWER AND WAS NO LONGER RUNNING. I HAD LOST POWER TO MY BRAKES AND STEERING. THIS CAUSED MY TRUCK TO BEGIN SLIDING ON THE SNOW AND ICE AND I WAS UNABLE TO CONTROL MY VEHICLE. THE CARS AROUND ME WERE SLOWING AND STOPPING AND I COULD NOT. I BEGAN TO FISH TAIL IN BOTH DIRECTIONS WHILE TRYING DESPERATELY TO CONTROL MY TRUCK WITH NO BRAKES OR POWER STEERING, I EVENTUALLY DID A COMPLETE 360 DEGREE SPIN AND SOMEHOW MANAGED TO GET THE TRUCK UNDER CONTROL WITH OUT ROLLING OVER AND INTO THE DITCH OR SMASHING INTO THE OTHER VEHICLES AROUND ME. WHEN I CAME TO A STOP MY TRUCK WAS NOT RUNNING AND THE DASH LIGHTS WERE ON. I PLACED THE TRANSMISSION INTO DRIVE AND RESTARTED THE TRUCK WITHOUT ISSUE AND CONTINUED ON WITHOUT ISSUE. THIS IS THE SECOND TIME THIS HAS HAPPENED WITH THIS TRUCK, THE FIRST TIME I WAS ON A RESIDENTIAL STREET AND I WAS ABLE TO JUST COAST TO A STOP AND RESTARTED THE TRUCK. THIS LAST INCIDENT ON THE MOUNTAIN PASS HAS CONFIRMED TO ME THAT I WILL NOT OWN ANOTHER FORD AS I HAVE RESEARCHED THIS PROBLEM TO FIND THAT THIS IS A COMMON ISSUE WITH FORD TRUCKS. I AM CERTAIN THIS HAS CAUSED MAJOR ACCIDENTS IF NOT DEATHS AND THE FACT THERE ARE NO ERROR CODES LEFT BEHIND FROM THE EVENTS TO VERIFY THIS HAS HAPPENED WE MAY NEVER KNOW. THE FACT IT HAS HAPPENED TO ME TWICE AND ONCE ONLY A MIRACLE A SERIOUS ACCIDENT DIDN'T OCCUR I AM DONE WITH THE FORD MOTOR COMPANY. *TR

Mileage: 117,000

POWER STEERING HOSE RUST AND LEAKING-TRANSMISSION HOSES RUSTED AND LEAKING - SPARK PLUG BREAKING OFF WHEN HAVING THEM REPLACED

Mileage: 107,000

STEERING BECAME INTERMITTENTLY STIFF WHILE DRIVING. TRUCK HAD ABOUT 80000 MILES ON IT AND 9 YEARS OLD WHEN SYMPTOMS STARTED. STIFFNESS WOULD OCCUR SOMETIMES AT HIGHWAY SPEEDS WHEN I STARTED A LANE CHANGE, AND AT SLOW SPEEDS WHEN I WAS TURNING (FOR INSTANCE ON COMMUNITY STREETS). AS I WAS TURNING IT WOULD CYCLE FROM HARD TO REGULAR EFFORT, AS WOULD BE IF A UNIVERSAL JOINT WAS GOING BAD. MY NON-FORD MECHANIC DIAGNOSED IT AS A BAD LOWER STEERING SHAFT. I INSPECTED THE BAD SHAFT AND AGREED THAT ONE UNIVERSAL SHAFT WAS TIGHT AND THE OTHER WAS EXTREMELY TIGHT. $557 REPAIR.

Mileage: 80,000

THE STEERING WHEEL FREEZES UP IN COLD WEATHER. MY MECHANIC DIAGNOSED A FAILED LOWER STEERING COLUMN THAT IS EXPOSED TO ROADWAY SPLASH AND CORROSION. THIS IS ALSO A TELESCOPING SECTION OF THE STEERING COLUMN DESIGNED TO PROTECT THE DRIVER IN CASE OF FRONTAL CRASH. SO OVERNITE IT FREEZES UP AND SLOWLY LOOSENS. WHILE DRIVING BECOMES STIF AND RESULTS IN DIFFICULT STEERING. 45,000 MILES ON ODOMETER.

Mileage: 45,000

DROVE F-150 NORMALLY DURING WEEK. ON WEEKEND MORNING WHILE PULLING OUT OF DRIVEWAY STEERING WHEEL SUDDENLY AND SPORADICALLY BEGAN RESISTING EFFORT TO TURN CAUSING TRUCK TO SWAY UNPREDICTABLY DURING TURNS. RESISTING DRIVER INPUT. WAS TOO DANGEROUS TO DRIVE. AFTER REVIEWING BLOGS ONLINE I REALIZED A LOT OF OTHER PEOPLE WHO DRIVE THIS ERA F-150 HAVE THE SAME PROBLEM. IT TURNS OUT THE LOWER STEERING COLUMN SHAFT CONTAINING THE U-JOINTS USES DEFECTIVE MATERIALS OR HAS BAD DESIGN. THE U-JOINTS ARE BINDING UP DURING DRIVING CAUSING THE DRIVER TO LOSE PARTIAL CONTROL OVER DIRECTION OF VEHICLE. TEMPORARY FIX MAY BE TO SPRAY WITH ANTI-CORROSIVE SPRAY, THEN LUBRICATING SPRAY, WHICH I DID. THIS LASTS ONLY A SHORT TIME SO THE LOWER SHAFT WITH U-JOINTS MUST BE REPLACED. FORD KNOWS OF THE DEFECT FOR THIS ERA F-150 AND HAS REDESIGNED THIS LOWER SHAFT TO ELIMINATE THE BINDING. THIS NEW DESIGN IS WHAT THEY SELL YOU AS A REPLACEMENT, NOT THE ORIGINAL DESIGN. IF YOU TRY TO BUY ONE ONLINE IT COSTS AT LEAST $245 FOR THE O.E.M. PART. IF YOU BUY ONE OF THE 2 AFTERMARKET KNOCKOFFS IT'LL SET YOU BACK APPROX $125. THE AFTERMARKET SHAFT ADVERTISING TOUTS THE FACT THAT IT HAS A DESIGN THAT WILL NOT BIND LIKE THE ORIGINAL FORD SHAFT DOES. THIS TRUCK HAD APPROX 69,700 MILES ON IT WHEN THE SHAFT BEGAN BINDING UP.

Mileage: 69,700

LAST WEEK I STARTED NOTICING MY STEERING STARTING TO GET STIFF AND THE WHEEL DOES NOT RECENTER AFTER A STEER TO THE LEFT OR RIGHT. IVE HAD TO DO SOME QUICK MUSCLING TO RECENTER THE WHEEL. I'VE JUST FINISHED RESEARCHING SOME OTHER FORD FORUMS FOR THIS VEHICLE AND MANY OWNERS HAVE REPORTED THE SAME ISSUE WITH THE U JOINTS ON THE STEERING COLUMN RUSTING OR SEIZING. I WILL TRY SPRAYING SOME ANTI SEIZE ON THE U JOINTS TOMMOROW UNTIL I CAN GET IT TO A GARAGE.MY TRUCK HAS APPROXIMATELY 103,000 MILES ON IT . THIS IS DANGEROUS AND WITH THE AMOUNT OF COMPLAINTS ON THIS IT SHOULD BE RECALLED BY FORD TO CORRECT.

Mileage: 103,000

LAST WEEK TRUCK SUDDENLY BECAME VERY HARD TO TURN GOING AROUND CORNERS. STEERING WHEEL LOCKED UP AND I ALMOST WENT OVER AN EMBANKMENT. HIT OR MISS SO I NEVER KNOW WHEN IT WILL GO OUT. THANKFULLY DID NOT HAVE MY 2 YOUNG CHILDREN! A WEEK LATER (11/29/15), TRUCK SUDDENLY STARTS TO VIOLENTLY SHAKE IF I GO OVER 50 MPH! SCARED THE DICKENS OUT OF ME! HOPING TO LIMP IT TO A DEALERSHIP AND TRADE IT IN. NOT SAFE FOR ME TO DRIVE. I HAVE PUT 20K MILES ON IT IN 2 YEARS AND HAS BEEN REGULARLY SERVICED. WHAT GIVES?!?

Mileage: 192,000

MY STEERING STARTED TO BIND WHILE DRIVING . COULD NOT MAKE FULL RIGHT OR LEFT TURNS. VERY UNSAFE. THE TRUCK HAS LEFT THAN 30,000 MILES. RARELY DRIVEN.

Mileage: 29,980

WHILE MY VEHICLE WAS IN THE SHOP FOR A FOUR WHEEL ALIGNMENT THE MECHANIC NOTED THAT THE U-JOINT IN INTERMEDIATE STEERING SHAFT IS GOING BAD AND THEREFORE THE REASON THERE IS SOME PLAY IN THE STEERING WHEEL. COST TO REPAIR IS GOING TO BE APPROXIMATELY $700

Mileage: 147,340

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 35 MPH AND COMING TO A COMPLETE STOP, THE REAR DRIVER SIDE TIRE SEPARATED AND ROLLED INTO TRAFFIC. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR ROTOR AND STUDS FAILED AND NEEDED TO BE TIGHTENED. THE CONTACT ALSO STATED THAT HE HAD TO ALSO REPLACE THE STEERING RACK AND PINION DUE TO THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.

Mileage: 136,000

FORD'S IWE SOLENOID HAS A TENDENCY TO MALFUNCTION DUE TO A POOR DESIGN. TSB 06-8-15 WAS ISSUED TO REPLACE THESE SOLENOIDS, BUT ONLY IF THERE WAS A PROBLEM AND ONLY IF IT WAS GIVING A PROBLEM. MY VEHICLE WAS IN STORAGE FOR 5 YEARS AND AFTER IT WAS BROUGHT OUT AND TO NY, THE WATER LEAKED ON THE SOLENOID DUE TO THE INADEQUATE DESIGN, CAUSING THE IWE'S TO MALFUNCTION. I STILL DON'T KNOW WHAT EXACTLY IT DID BUT DRIVING THE CAR DOWN THE ROAD, IT CAUSED ME TO FEEL LIKE I WAS DRIVING OVER SMALL SPEED BUMPS WITH THE FRONT DRIVERS SIDE TIRE. I'M AFRAID THAT IF THIS FAILED AT A HIGH RATE OF SPEED IT COULD CAUSE THE IWE TO ENGAGE AND POSSIBLY LOCK UP ONE OF THE FRONT TIRES. *TR

Mileage: 38,000

NOTICED STEERING WHEEL VERY HARD TO TURN. CHECKED POWER STEERING FLUID WHICH WAS OK. RESEARCHED PROBLEM ONLINE AND FOUND DOZENS OF SIMILAR COMPLAINTS REPORTED ON FORD CUSTOMER FORUMS AND ELSEWHERE ONLINE MENTIONING THAT THE U-JOINT(S) ON THE LOWER STEERING SHAFT POSSIBLY RUST AND CORRODE AND BECOME VERY STIFF. WHEN TURNING CORNERS WHEEL DOES NOT READILY RECENTER ITSELF. FEARFUL THAT STEERING JOINTS COULD FAIL, SEIZE OR BREAK RESULTING IN A COMPLETE LOSS OF STEERING AND SERIOUS INJURY OR DEATH. SAW THAT FORD REDESIGNED THE STEERING SHAFT AFTER 2006 AND THE NEW FORD PART LOOKS MUCH DIFFERENT THAN THE ORIGINAL SHAFT IN MY 2006 TRUCK. SPRAYED SOME PENETRATING OIL ON BOTH U-JOINTS YESTERDAY AND STEERING WAS NOTICEABLY MUCH EASIER WITHIN 5 MINUTES. THEN SPRAYED SOME LIQUID WRENCH LUBRICATING OIL (LIGHTWEIGHT AEROSOL OIL) ON BOTH JOINTS AND DROVE THE TRUCK. STEERING WAS LIKE NEW AND STEERING WHEEL EASY TO TURN. DO NOT KNOW HOWEVER IF THIS "OILING FIX" WILL LAST. FORD IS AWARE OF THIS ISSUE AS THEY REDESIGNED THE STEERING SHAFT/U-JOINTS AND HAD HUNDREDS OF COMPLAINTS. DEFECT IN DESIGN OF CRITICAL STEERING COMPONENT, FORD IS AWARE AND REDESIGNED STEERING SHAFT AND U-JOINTS. NOTE: OTHER CUSTOMERS WITH NON-FORD VEHICLES AND FORD VEHICLES OTHER THAN THE F-150 HAVE REPORTED NUMEROUS SIMILAR COMPLAINTS. *TR

Mileage: 74,500

FRONT END BUSHINGS DETERIORATION - REPLACEMENT COST ESTIMATE $750.00

Mileage: 43,000

MY STEERING WHEEL IS STIFF. AND HARD TO TURN THE MECHANIC SAID IT IS A RECALLED RACK AND PINION. *TR

Mileage: 103,000

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SHOOK VIOLENTLY WITHOUT WARNING. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE TIRES NEEDED TO BE REPLACED AND ALIGNED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,270.

Mileage: 92,270

AT VERY LOW MILEAGE I CANNOT UNDERSTAND WHY I WAS HEARING A WHINING NOISE THAT APPEARED FROM COMING THE REAR OF MY TRUCK. I WAS ADVISED THAT THE GEARS WERE BREAKING DOWN AND SHOULD BE REPLACED. THE GEAR AND PINION WERE REPLACED. SEEMS TO BE FIXED. AGAIN AT 57814 MILES? *TR

Mileage: 57,814

DRIVING WITH MY 2 KIDS ON US 23 I FELT THE STEERING GET TIGHT. STOPPED CHECK EVERYTHING LOOKED GOOD. STARTED BACK DRIVING AND ROAD CURVED TO LEFT AS I WAS DRIVING IT DID NOT WANT TO TURN BACK TO THE RIGHT. ALL MOST CAUSING TO HIT A VEHICLE HEAD ON. FINALLY GOT BACK TO THE HOUSE AND DONE SOME RESEARCH AND FIGURED OUT IT WAS LOWER STEERING SHAFT. *TR

Mileage: 65,000

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING SUDDENLY MALFUNCTIONED MAKING THE STEERING WHEEL DIFFICULT TO TURN AND CAUSING THE VEHICLE TO LOSE CONTROL AND DRIVE INTO ON COMING TRAFFIC NEARLY CAUSING A CRASH. THE VEHICLE WAS TAKEN TO THE DEALER AND DIAGNOSED THAT A LOWER JOINT IN THE STEERING COLUMN SHAFT SEIZED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 58,000.

Mileage: 58,000

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING SUDDENLY MALFUNCTIONED MAKING THE STEERING WHEEL DIFFICULT TO TURN AND CAUSING THE VEHICLE TO LOSE CONTROL AND DRIVE INTO ON COMING TRAFFIC NEARLY CAUSING A CRASH. THE VEHICLE WAS TAKEN TO THE DEALER AND DIAGNOSED THAT A LOWER JOINT IN THE STEERING COLUMN SHAFT SEIZED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 58,000.

Mileage: 58,000

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME UNSTABLE WHILE DRIVING AT AN UNKNOWN SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER MULTIPLE TIMES. THE DIAGNOSIS WAS TO REPLACE THE STEERING SHAFT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.

Mileage: 48,000

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HER RESIDENCE. THE FAILURE WAS NOT DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATELY FAILURE MILEAGE WAS 154,618.

Mileage: 154,618

MY 2006 FORD F150 FX4 HAS STALLED ON THE HIGHWAY AT TWO DIFFERENT TIMES IN THE LAST 9,000 MILES. I AM DRIVING AT NORMAL SPEEDS, WITH NORMAL WEATHER CONDITIONS, HALF TANK OF GAS, AND I WAS COASTING AS HIGHWAY SPEEDS SLOWED - AS I WENT TO HIT THE ACCELERATOR TO SPEED UP, I LOST THE ABILITY TO ACCELERATE. FIRST THE WRENCH DASH LIGHT CAME ON, THEN I NOTICED STEERING WAS SLIGHTLY DIFFICULT AND THEN THE BATTERY AND TRANSMISSION LIGHT CAME ON. I GOT THE VEHICLE TO THE SIDE OF THE ROAD, BUT I DID NOT LOSE HEADLIGHTS, RADIO, HEAT, OR POWER. I TURNED THE TRUCK OFF AND WAITED 2 MINUTES, THEN IT STARTED BACK UP - A LITTLE DIFFICULT ON THE STARTER, BUT IT WORKED. I HAVE READ NUMEROUS CHAT FORUMS ONLINE WITH USERS HAVING THIS SAME ISSUE WITH 2006 V8'S IN THE F150. WHAT IS FORD DOING ABOUT THIS? MY VEHICLE HAS BEEN METICULOUSLY MAINTAINED AND CARED FOR. FROM WHAT I READ THIS IS A FUEL PUMP CONTROL PANEL ISSUE WITH CORROSION OF DISSIMILAR METALS - WHERE IS THE RECALL? *TR

Mileage: 100,500

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING SHAFT EXHIBITED EXCESSIVE RUST, MAKING THE VEHICLE DIFFICULT TO STEER AT ALL SPEEDS. THE CONTACT CLEANED AND LUBRICATED THE STEERING SHAFT BUT THE SERVICE ONLY REMEDIED THE ISSUE TEMPORARILY. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER. THE CONTACT CALLED THE MANUFACTURER AND OFFERED THE CONTACT A NEW PART TO PURCHASE. THE CONTACT DID NOT PURCHASE THE PART. THE FAILURE MILEAGE WAS 48,000.

Mileage: 48,000

MY 2006 FORD F150 HAS THE POSITRACTION REAR END. ITS WENT OUT AROUND 25000 TO 30000 MILES, WHILE THE TRUCK WAS STILL UNDER WARRANTY AND THE DEALER FIXED IT NO CHARGE. NOW THE TRUCK HAS A LITTLE OVER 62000 MILES AND THE REAR END HAS GONE OUT AGAIN. ALMOST EXACTLY THE SAME AMOUNT OF MILES ON THE REAR END. WARRANTY WAS UP AT 60000 MILES SO ITS NO LONGER COVERED. I THINK THIS SHOULD BE LOOKED INTO AS A RECALL BECAUSE THIS IS THE SECOND TIME ITS HAPPENED ON THE SAME TRUCK. *TR

Mileage: 60,000

WHILE APPROACHING AN INTERSECTION, ABOUT TO MAKE A RIGHT AT THE LIGHT, (I WAS DRIVING ABOUT 20MPH) ON 12/24/12 (WITH MY TWO CHILDREN AND HUSBAND IN THE TRUCK) THE VEHICLE BEEPS AND IT DISPLAYS "ENGINE SAFE MODE...LOW OIL PRESSURE" THEN THE POWER STEERING CUTS OFF AND THE WHOLE VEHICLE SHUT DOWN! I AM FRANTIC AT THIS POINT BECAUSE I HAVE NO CLUE WHAT IS GOING ON! I WAS IN THE MIDDLE OF TRAFFIC AND HAD TO CUT THE CAR OFF AND CRANK IT UP AGAIN. LUCKILY I DIDN'T GET REAR ENDED OR IN AN ACCIDENT. THAT SAME DAY I WENT AND GOT MY OIL CHANGE BECAUSE IT WAS OVER DUE. WELL ON 1/4/13 THE SAME THING HAPPENS AS I AM TURNING INTO THE PARKING LOT OF MCDONALD'S. I GET THE SAME ERROR MESSAGE AS BEFORE, THE STEERING WHEEL LOCKS UP, AND TRUCK CUTS OFF! THIS SO EXTREMELY DANGEROUS. I LOOKED THIS ISSUE UP ONLINE AND SEE THAT IT APPEARS TO BE A COMMON ISSUE WITH THE 2006 F-150 AND THE EXPEDITION. MY BOTHER-IN-LAW, WHO ALSO HAS A SIMILAR F-150 TO OURS, SAID THE SAME THING HAS HAPPENED TO HIM TWICE. *TR

Mileage: 64,900

STEERING BECAME VERY HARD TO TURN. WOULD NOT CENTER AFTER TURNING, WOULD LOCK ON WET ROADS. I HAD TO TURN THE STEERING WHEEL BY HAND TO GET IT BACK TO CENTER. I CHECKED TO FIND THE U JOINTS ON STEERING SHAFT WHERE RUSTED SO I LUBED WITH OIL. STEERING BECAME MUCH BETTER. I WENT TO A LOCAL FORD DEALER THEY SAID THERE WAS NO RECALLS AND KNEW OF NO PROBLEMS WITH THE STEERING ON THE F150'S. THE FORD DEALER WANTED ME TO LET THEM TAKE EVERYTHING APART BUT SAID IT COULD RUN INTO A LOT OF MONEY DEPENDING ON WHAT THEY FIND. SO FOR OVER THREE YEARS I'VE BEEN OILING THE JOINTS ON THE SHAFT AND LIVING WITH THE PROBLEM. WAITING FOR TOTAL FAILURE TO SUE FORD FOR POOR DESIGN OF THE STEERING COLUMN SHAFT JOINTS. *TR

Mileage: 40,000

TL* THE CONTACT OWNS 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE POWER STEERING FAILED AND SEIZED. THE CONTACT THEN DROVE TO HIS RESIDENCE AND ADDED POWER STEERING FLUID BUT THE FLUID LEAKED OUT OF THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THEY COULD NOT DUPLICATE THE FAILURE. THE DEALER STATED THAT THE POWER STEERING WAS REPAIRED. AFTER SEVERAL MONTHS, THE POWER STEERING FAILED AGAIN. THE VEHICLE WAS NOT COMPLETELY REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 87,000. UPDATED 07/06/12 *BF THE CONSUMER TOOK THE VEHICLE TO A REPAIR A SHOP AND A DIAGNOSIS REVEALED THE RACK AND PINION NEEDED TO BE REPLACED. ALSO, THE POWER STEERING HOSE WAS REPLACED TWICE, THE O-RING, POWER STEERING PUMP AND POWER STEERING LINE WERE REPLACED. UPDATED 08/08/12

Mileage: 70,000

TL* THE CONTACT OWNS 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE POWER STEERING FAILED AND SEIZED. THE CONTACT THEN DROVE TO HIS RESIDENCE AND ADDED POWER STEERING FLUID BUT THE FLUID LEAKED OUT OF THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THEY COULD NOT DUPLICATE THE FAILURE. THE DEALER STATED THAT THE POWER STEERING WAS REPAIRED. AFTER SEVERAL MONTHS, THE POWER STEERING FAILED AGAIN. THE VEHICLE WAS NOT COMPLETELY REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 87,000. UPDATED 07/06/12 *BF THE CONSUMER TOOK THE VEHICLE TO A REPAIR A SHOP AND A DIAGNOSIS REVEALED THE RACK AND PINION NEEDED TO BE REPLACED. ALSO, THE POWER STEERING HOSE WAS REPLACED TWICE, THE O-RING, POWER STEERING PUMP AND POWER STEERING LINE WERE REPLACED. UPDATED 08/08/12

Mileage: 70,000

THE STEERING SHAFT IS SIEZIHG CAUSING THE WHEEL NOT TO CENTER IT SELF AND STEERS HARD . IT DOES NOT SELF CENTER AFTER CORNERING. YOU CAN'T TELL IF YOUR WHEEL IS TURNED ON SLIPPERY ROADS . I CALLED FORD MOTOR COMPANY AND THEY TOLD ME IT'S NOT A SAFETY ISSUE . I'M A LICENSED MECHANIC AND THIS HARD STEERING WOULD NOT PASS A MOTOR VEHICLE SAFETY INSPECTION IN OUR SHOP.I THINK FOMOCO SHOULD FIX THIS . AS FAR AS I'M AWARE IT IS ONLY THE 2004-2008 MODEL TRUCKS.

Mileage: 25,148

WHEN DRIVING VEHICLE AT ALL DIFFERENT SPEEDS, STEERING BECOMES DIFFICULT AND WHEEL RESISTS TURNING. AFTER TURN IS MADE WHEEL DOES NOT RETURN BY ITSELF BUT NEEDS TO BE FORCED BACK WITH GREAT RESISTANCE. CONDITION WENT AWAY FOR A MONTH BUT THEN RETURNED IN OCTOBER OF 2011, AND HAS BEEN DIFFICULT SINCE. VERY DANGEROUS. *TR

Mileage: 85,000

THIS IS THE SAME THING THAT HAPPENS TO MINE AS SOMEONE ELSE HAD ALREADY POSTED.. POWER STEERING BECOMES 'HARD'. STEERING WHEEL SUDDENLY BECOMES STIFF AND DIFFICULT TO HANDLE. HARD TO TURN. CHOPPY WHILE TURNING AND SNAPS BACK IN INCREMENTS INSTEAD OF A SMOOTH, EASY RETURN TO CENTER. FEELS LIKE MANUAL STEERING THEN RETURNS TO POWER STEERING. OCCURS AT ANY SPEED, VERY DANGEROUS AT HIGHER SPEEDS. MAKES THE VEHICLE STEER 'CHOPPY' AND UNPREDICTABLE. HAVE STOPPED USING THE VEHICLE, CAUSES A DANGEROUS SITUATION WHILE DRIVING AND TRYING TO MAINTAIN CONTROL OF THE TRUCK. *TR

POWER STEERING BECOMES 'HARD'. STEERING WHEEL SUDDENLY BECOMES STIFF AND DIFFICULT TO HANDLE. HARD TO TURN. CHOPPY WHILE TURNING AND SNAPS BACK IN INCREMENTS INSTEAD OF A SMOOTH, EASY RETURN TO CENTER. FEELS LIKE MANUAL STEERING THEN RETURNS TO POWER STEERING. OCCURS AT ANY SPEED, VERY DANGEROUS AT HIGHER SPEEDS. MAKES THE VEHICLE STEER 'CHOPPY' AND UNPREDICTABLE. HAVE STOPPED USING THE VEHICLE, CAUSES A DANGEROUS SITUATION WHILE DRIVING AND TRYING TO MAINTAIN CONTROL OF THE TRUCK. *TR

Mileage: 48,000

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BEGAN TO SHAKE EXCESSIVELY. THE CONTACT ALSO STATED THAT THERE WAS SMOKE COMING FROM UNDER THE HOOD. THE VEHICLE WAS SAFELY DRIVEN HOME, WHERE IT WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE STEERING SHAFT, CENTER CAPS AND THE CALIPERS NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE CENTER HUB CAP BURNT DUE TO THE CALIPERS FRACTURING AND DETACHING FROM THE VEHICLE .THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

Mileage: 68,000

POWER STEERING FAILURE, STEERING BECAME HARD AT 10 AND 2, REPLACED THE PS PUMP, PROBLEM STILL EXISTS BUT AT 9 AND 3 NOW, STEERING SO HARD WHILE TURNING THAT IT COULD CAUSE A WRECK. AFTER READING ONLINE THINKING NOW THAT IT IS IN THE STEERING SHAFT. MANY PEOPLE HAVE HAD THE SAME TROUBLE AND SAYS THEY LUBRICATED THE PART AND IT GOT BETTER. I JUST DON'T WANT TO WRECK WHILE DRIVING WITH MY 4 CHILDREN. WOULD TAKE IT TO FORD BUT AFRAID THEY WILL SAY THINGS ARE WRONG THAT ARE NOT...DON'T WANT IT TO TURN INTO A MONEY GIMMICK. EXTREMELY HARD TO TURN FROM DEAD STOP. STILL TRYING TO FIGURE THE PROBLEM OUT ONE PART AT A TIME....62,000 APPROX. *KB

Mileage: 62,000

POWER STEERING FAILURE, STEERING BECAME HARD AT 10 AND 2, REPLACED THE PS PUMP, PROBLEM STILL EXISTS BUT AT 9 AND 3 NOW, STEERING SO HARD WHILE TURNING THAT IT COULD CAUSE A WRECK. AFTER READING ONLINE THINKING NOW THAT IT IS IN THE STEERING SHAFT. MANY PEOPLE HAVE HAD THE SAME TROUBLE AND SAYS THEY LUBRICATED THE PART AND IT GOT BETTER. I JUST DON'T WANT TO WRECK WHILE DRIVING WITH MY 4 CHILDREN. WOULD TAKE IT TO FORD BUT AFRAID THEY WILL SAY THINGS ARE WRONG THAT ARE NOT...DON'T WANT IT TO TURN INTO A MONEY GIMMICK. EXTREMELY HARD TO TURN FROM DEAD STOP. STILL TRYING TO FIGURE THE PROBLEM OUT ONE PART AT A TIME....62,000 APPROX. *KB

Mileage: 62,000

STEERING SHAFT ASSEMBLY BINDING CAUSING SERIOUS SAFETY ISSUE. VEHICLE HAS 37,000 MILES CURRENTLY. I PAID FORD DEALER TO INSPECT THE VEHICLE AND THEY STATE THE STEERING SHAFT ASSEMBLY WAS "BINDING". IT WAS REPORTED THAT THE PART WAS ON A "NATIONAL BACKORDER". WHEN I CONTACTED FORD THEY WOULD NOT ASSIST WITH THE REPAIR, ONLY MAKE A NOTE IN "MY FILE". SERIOUS SAFETY ISSUE AND THE NEED FOR A RECALL NEEDS TO BE INVESTIGATED. *TR

Mileage: 35,000

SOMETIME IN FEBRUARY 2011 I NOTICED THE STEERING IN MY 2006 FORD F-150 TO BE GETTING VERY TIGHT AND EXTREMELY HARD TO STEER. SOMETIMES IT WOULD GET BETTER OTHERS IT WAS WORSE. WHEN MAKING A TURN THE STEERING WHEEL WOULD NEVER RETURN ON ITS OWN. I TOOK THE TRUCK TO THE DEALER I PURCHASED VEHICLE FOR A NEW CONTROL MODULE AND EXPLAINED MY STEERING PROBLEM THEY FLUSHED THE FLUID THE VEHICLE SEEMED BETTER FOR A WEEK AND GRADUALLY GOT WORSE. ON 05/31/2011 I AGAIN TOOK THE TRUCK TO THE DEALER. A COUPLE DAYS LATER THEY SAID IT WAS THE SOMETHING TO DO WITH STEERING SHAFT BINDING AND THE PART WOULD BE IN ON FRIDAY 06/04/2011. WHEN I SPOKE WITH THEM AGAIN THEY SAID THE PART WAS NOW ON BACKORDER AND THEY ALSO HAD 3 OTHER TRUCKS AT THE DEALER WITH THE SAME PROBLEM. COULD IT BE THAT THIS IS A WIDESPREAD PROBLEM AND THAT IS WHY THE PARTS ARE BACKORDERED OR WORSE FORD KNOWS THERE IS A PROBLEM AND IS TRYING TO FIGURE IT OUT WHILE I SIT HOME WITH NO VEHICLE. SERIOUS SAFETY ISSUE. *TR

Mileage: 70,000

STEERING WHEEL SHIMMIES AT 50-70MPH. HAVE HAD TIRES ROTATED, TIRES REPLACED, FRONT END ALIGNED, BRAKE ROTORS REPLACED STILL THE SHIMMY IS THERE AND HAVE BEEN TOLD THAT THE BIG TIRES 18"RIMS 235/75 MAY PARTIALLY BEEN THE PROBLEM. WHAT? WHY WOULD FORD USE A TIRE THAT IS TOO BIG? AND CAUSE THE STEERING WHEEL TO SHAKE AND SHIMMY. HAVE HAD AN INDEPENDENT SHOP LOOK AT TRUCK AND CAN FIND NOTHING WRONG, BUT I HAVE NEVER HAD A VEHICLE HAVE SUCH A NOTICEABLE SHIMMY IN THE STEERING WHEEL. VERY UNSETTLING FEELING. *TR

Mileage: 15,000

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING APPROXIMATELY 10-15 MPH THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN AND THE VEHICLE WAS ALSO DIFFICULT TO DRIVE. THE FAILURE HAD OCCURRED FOR APPROXIMATELY 2 WEEKS. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER OR A LOCAL MECHANIC. HE CALLED THE MANUFACTURER AND WAS ADVISED THAT THERE WERE NO RECALLS AND THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 58,345 AND THE CURRENT MILEAGE WAS 58,622.

Mileage: 58,345

TL. THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THE POWER STEERING MALFUNCTIONED CAUSING DAMAGE TO THE RACK AND PINION. THE CONTACT STATED WHILE DRIVING AT 15 MPH THE VEHICLE BECOMES DIFFICULT TO TURN. THE CONTACT CALLED THE MANUFACTURER AND THEY INFORMED THE CONTACT THAT THE VEHICLE IS OUT OF WARRANTY SO THERE IS NOTHING THEY CAN DO. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER AT THIS. THE CONTACT STATED THE MANUFACTURER SHOULD ISSUE A RECALL BECAUSE THIS IS A MAJOR SAFETY ISSUE. THE FAILURE MILEAGE WAS 47,052. JO

Mileage: 47,052

LOSS OF POWER STEERING. *TR

Mileage: 56,000

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING APPROXIMATELY 20 TO 25 MPH ON NORMAL ROAD CONDITIONS A LOUD NOISE EXPELLED FROM THE STEERING WHEEL. THE DRIVER EXERTED HIGHER EFFORT TO TURN THE STEERING WHEEL AND WAS ABLE TO CONTINUE DRIVING WITH CAUTION. THERE WERE NO WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT HE WOULD PERFORM THE REPAIRS ON THE VEHICLE. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 62,000. UPDATED 10/13/09. *LJ THE CONSUMER STATED A POWER STEERING PUMP SHOULD FAIL ON A 3 YEAR OLD VEHICLE. UPDATED 10/15/09

Mileage: 62,000

STEERING GOT HARD, WOULDN'T RETURN TO CENTER, NEARLY PUT TRUCK INTO DITCH AFTER TURNING OUT OF DRIVEWAY.....THOUGHT POWER STEERING WAS INOP...SEEMS THE COUPLI NG WAS SEIZED UP....DEALER SAID IT HAPPENS ALL THE TIME...I BELIEVE THIS IS A SERIOUS SAFETY DEFECT...IT WAS COVERED UNDER AN EXTENDED WARRANTY, BUT STILL COST ME THE DEDUCTIBLE ,PLUS AS IT WAS FAILING , MY DRIVING PROBABLY SEEMED ERRATIC TO ANYONE VIEWING THE STRUGGLE TO GET VEHICLE STRAIGHTENED OUT AFTER A TURN....I BELIEVE THIS IS A RECALLABLE ITEM.... STEERING DEFECTIVE. *TR

Mileage: 35,000

2006 FORD F-150, WHEN MAKING A TURN WHILE DRIVING, THE STEERING WHEEL GETS VERY STIFF, THEN LOOSENS UP EVERY HALF TURN, OCCASIONALLY BINDING UP TO THE POINT OF NOT BEING ABLE TO STEER AT ALL. UPON INSPECTION, FOUND THE STEER SHAFT UNIVERSAL BINDS UP. HAS BEEN GREASED SEVERAL TIMES, WORKS FINE FOR A WEEK, AND THEN STARTS BINDING UP AGAIN. REQUIRES GREAT FORCE TO TURN AND AVOID ACCIDENTS IN TURNS. IF UNIVERSAL BREAKS, ALL STEERING CONTROL WILL BE LOST WHILE TURNING. *TR

Mileage: 85,000

TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 50-70 MPH, THE STEERING WHEEL BEGAN TO SHAKE. THE DEALER RECOMMENDED THAT THE TIRES BE REPLACED. THE CONTACT CHANGED THE TIRES, BUT THE FAILURE CONTINUED. HE FEELS THAT THE VEHICLE IS VERY UNSAFE AND DIFFICULT TO DRIVE. THE CURRENT MILEAGE WAS 29,190 AND FAILURE MILEAGE WAS 23,000. UPDATED 01/05/2009 LJ THE CONSUMER STATED OVER THE PAST 5 MONTHS HE HAS EXPERIENCED AN ONGOING PROBLEM WITH A SHAKING AND SHIMMY OF THE VEHICLE AT SPEEDS OF 50 MPH. THE DEALER REPLACED THE FRONT ROTORS WHICH STOPPED THE FRONT OF THE VEHICLE FROM SHAKING. UPDATED 01/05/09. *JB

Mileage: 16,000

MODERATE TO SEVERE WHEEL VIBRATION IN STEERING SINCE 2006. IT REMAINS UNREPAIRED AFTER SEVERAL ATTEMPTS BY THE DEALERSHIP WHERE VEHICLE WAS PURCHASED. I'M NOW BEING TOLD TO "LIVE" WITH THE SHIMMY AND IT SHOULD BE "EXPECTED". *TR

Mileage: 3,206

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE MAKING A TURN AT 10 MPH, THE VEHICLE SLID FORWARD. THE MOMENTUM OF THE VEHICLE PUSHED FORWARD, BUT THE FRONT WHEEL LOCKED UP AND PREVENTED IT FROM TURNING. THE DEALER STATED THAT THIS WAS A NORMAL OCCURRENCE. THE CURRENT MILEAGE WAS 23,000 AND FAILURE MILEAGE WAS 21,500. UPDATED 02-14-08. *KB

Mileage: 21,500

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT AT 395 MILES, THE PASSENGER SIDE FRONT BUMPER WAS BENT AND THE BED WAS ALIGNED IMPROPERLY. THE FORD DEALER REPAIRED THE VEHICLE FOR FREE. THE INSIDE OF THE FRONT TIRES HAD SEVERE EDGE WEAR BECAUSE OF AN ISSUE WITH THE ALIGNMENT ONCE AGAIN AT 4,076 MILES. THE DEALER PERFORMED A 4-WHEEL ROTATION AND ALIGNED THE VEHICLE. THE CONTACT TOOK THE VEHICLE BACK AT 11,000 MILES FOR THE SAME FAILURE. HE ALSO STATED THAT THE STEERING WHEEL VIBRATED WHEN DRIVING 70 MPH. THE DEALER CHANGED THE DRIVER SIDE FRONT TIRE, FRONT SHOCK ABSORBER, AND PERFORMED ANOTHER WHEEL ALIGNMENT. THE CONTACT TOOK THE VEHICLE BACK AND THE DEALER CALLED FORD MOTOR COMPANY. THE CONTACT WAS ADVISED TO TAKE THE VEHICLE TO MISSION VALLEY FORD FOR A WHEEL ALIGNMENT. THEY PERFORMED A WHEEL ALIGNMENT AND INFORMED HIM TO COME BACK FOR A FOLLOW-UP VISIT AFTER 1,000 MILES. THE CONTACT OBEYED AND THE VEHICLE WAS FOUND TO BE OUT OF ALIGNMENT ONCE AGAIN. MISSION VALLEY FORD CALLED FORD MOTOR COMPANY AND THE CONTACT WAS THEN ADVISED TO TAKE THE VEHICLE TO SUNNYVILLE FORD. FORD AUTHORIZED FOUR NEW TIRES AND AN ALIGNMENT AT 18,456 MILES. HE WAS ADVISED ONCE AGAIN TO TAKE THE VEHICLE BACK AFTER 1,000 MILES FOR A FOLLOW-UP VISIT. THE FRONT TIRES WERE FOUND TO HAVE INSIDE EDGE WEAR AND THE DEALER ROTATED THEM AND PERFORMED ANOTHER ALIGNMENT. THE CONTACT TOOK THE VEHICLE BACK AT 19,640 MILES AND THEY ROTATED THE TIRES ONCE MORE. THE CONTACT TOOK THE VEHICLE BACK AFTER 1,000 MILES. AFTER THAT, HE WAS INFORMED THAT NOTHING ELSE COULD BE DONE. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 21,056 AND FAILURE MILEAGE WAS 4,076.

Mileage: 4,076

DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE SHOOK VIOLENTLY, AND PULLED TO BOTH THE LEFT AND RIGHT. EXCESSIVE FORCE WAS REQUIRED TO KEEP THE VEHICLE MOVING STRAIGHT. THE VEHICLE WAS TAKEN TO A SERVICE DEALER ON 3 DIFFERENT OCCASIONS, WHERE THE DEALER WAS UNABLE TO DETERMINE THE PROBLEM.

Mileage: 3,500

WHILE DRIVING I HEARD A POP AND THE TRUCK JERKED TO THE RIGHT. I HAD NO CONTROL OF THE STEERING. I HIT A LARGE TREE STUMP. IT CAUSED SEVERAL THOUSAND DOLLARS OF DAMAGE. WHILE THE INSURANCE APPRAISER AND BODY SHOP OWNER WERE LOOKING AT THE TRUCK THEY DISCOVERED THAT THE SCREW FROM THE TIE ROD INTO THE RACK AND PINION STEERING WAS STRIPPED. IT FELL APART TAKING AWAY ALL MY CONTROL OF STEERING THE TRUCK. FORD REFUSES TO EVEN LOOK AT THE TRUCK. *NM

Mileage: 6,000

2006 F-150 4X4 SUPER CREW TILT LEVER FALLS OUT WHILE DRIVING, HAS BEEN REPLACED 5 TIMES. *KB ***NAR*** *JB

WHILE DRIVING I NOTICED THAT THE STEERING SEEMED SLOPPY AND UNRESPONSIVE. DIFFICULT TO KEEP THE VEHICLE IN THE LANES ESPECIALLY GOING INTO OR OUT OF CURVES. UPON REACHING MY DESTINATION I ASKED MY ASSOCIATE TO OBSERVE THE STEERING COMPONENTS WHILE I TURNED THE WHEEL WITH THE ENGINE OFF. HE IMMEDIATELY NOTICED THE ENTIRE RACK AND PINION ASSEMBLY SHIFTING BACK AND FORTH. UPON FURTHER INSPECTION I FOUND THAT OF THE TWO BOLTS THAT HOLD THE UNIT TO THE CHASSIS ONE HAD A LOOSE NUT AND THE OTHER HAD NO NUT AT ALL. THE THREADS ON THE BOLT W/O THE NUT APPEARED TO NEVER HAVE EVEN HAD A NUT BUT I CAN NOT BE SURE OF THIS. NEEDLESS TO SAY I WAS A LITTLE MORE THAN UPSET THAT I HAD PUT MYSELF AND OTHERS AT GREAT RISK OVER POOR ASSEMBLY QUALITY CONTROL. *JB

Mileage: 400