2008 FORD F-150 Engine Problems

My 5.4 v8 triton motor timing came phasers are bad the truck runs fine when cold when it gets warmer up it rattles and shakes and stalls air bag light stays on I had to pull the fuse bc it beeps and warning light so it's not active

I experienced a loss in power while driving and not driving, as well as locking my keys in the vehicle once It would not unlock. The gear shifting knob stopped due to what seemed like resistance an the damaged caused by sales man to the top plunger cap just after i paid. Recently the battery and the alternator are not working and when power is ran through the vehicle, an obvious sound of a live cable buzzing in the rear cab exterior light and seemed to be spliced in a n unsafe way.

Vehicle caught on fire from the engine compartment while driving. Total loss, Fire Department responded to the scene. Two persons on board of the vehicle had to escape the fire, pulled over and jumped out.

My F150 will run great until it warms up and then it will run rough, shows low oil pressure, and stalls at stops and while driving at low speeds. I have taken it to two mechanics and have spent thousands of dollars without fixing this problem. This has been an ongoing issue and started in Sept. 2022

MY TRUCK TIMING BELTS HAVE BIN REPLACED 4 TIMES IN THE LAS 3 YRS. IT STARTS BY MAKING THE ENGINE JUMP THE RPM GO BELOW 300 AND IT SHUTS OFF AS I APPROACH A STOP SIGN OR A LIGHT. THE CHECK ENGINE LIGHT NEVER COMES ON IT JUST SHUTS OFF AND IT WONT DRIVE. *TR

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS RESTARTED AFTER SEVERAL ATTEMPTS. ON SOME OCCASIONS, THE VEHICLE HESITATED TO START. THE CONTACT BELIEVED THE FAILURE WAS DUE TO ROUSH TRANSITION TO PROPANE ON THE FORD F-150. THE VEHICLE WAS NOT TAKEN TO A LOCAL DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE AND OFFERED NO ASSISTANCE. THE CONTACT REFERENCED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 08V523000 (ENGINE AND ENGINE COOLING) HOWEVER VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 200,000.

Mileage: 200,000

MY MOTOR HAD STARTED TICKING A BIT BACK IN SEPTEMBER 2018 I ADDED SOME OIL AND IT WENT AWAY. THEN, IN JANUARY 2019 I HAD ENGINE CODES. PLUGGED MY SCAN TOOL IN AND SAID I NEEDED BOTH CAMSHAFT SENSORS, MISFIRE ON CYLINDERS 1, 3, & 7. REPLACED ALL 8 PLUGS AND COILS, MOTOR HAD 123XXX MILES. DROVE ANOTHER 4000 MILES AND THE SAME PROBLEMS PERSISTED AND GOT WORSE. I TOOK IT TO A MECHANIC FOR A DIAGNOSIS ON THE MISFIRES AND ENGINE TICK, COME TO FIND OUT IT IS A 'LIFTER TAP', SHAVINGS OF ALUMINUM IN MY OIL AND PLUGGING UP THE LIFTERS. MECHANIC SAID TO GET A NEW MOTOR, DON'T BOTH TRYING TO FIX IT. I BOUGHT IT USED WITH 119XXX AND TRUCK RAN FINE IN AUGUST OF 2018.

Mileage: 127,940

PLASTIC TIMING GUIDES ARE RIPPED FROM MOUNTING LOCATION BY TIMING CHAINS AND DROP INTO THE OIL SYSTEM, USUALLY CAUSING LOSS OF OIL PRESSURE, CONTAMINATED OIL, TRASH-FILLED MOTOR, AND ACCELERATED WEAR OF THE TIMING CHAINS, RESULTING IN ENGINE DAMAGE. USUALLY THE GUIDES BREAK OFF AT OR BEFORE 100,000 MILES AND THE CHAINS NEED REPLACING BETWEEN 120,000 AND 200,000 MILES, DEPENDING ON HOW THE TRUCK IS DRIVEN. METAL REPLACEMENT GUIDES ARE AVAILABLE AT MOST SHOPS AND ONLINE PARTS STORES.PRICES RANGE BETWEEN $10 AND $40. OCCURS IN 4.6L AND 5.4L V8 ENGINES.

Mileage: 202,000

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE OPERATING THE VEHICLE, THE ODOR OF EXHAUST FUMES WAS PRESENT INSIDE THE CABIN OF THE VEHICLE. ALSO, WHILE IDLING, THE VEHICLE SHOOK AND RATTLED. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DISCOVERED A CRACK IN THE EXHAUST MANIFOLD. THE CAUSE OF THE CRACK WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. JOE MACHENS FORD (807 SOUTHWEST BLVD, JEFFERSON CITY, MO) WAS INFORMED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

2008 FORD F-150. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE. *LD THE CONSUMER STATED THE VEHICLE ENGINE WOULD MISFIRE AND LACKED POWER. THE ENGINE ASSEMBLY WAS REPLACED.*JS

THE ENGINE 5.4 TRITON MAKES A SOUND THAT RESEMBLES A DIESEL AND SOUNDS LIKE THE PISTON IS ABOUT READY TO COME THROUGH THE BLOCK. I FIRST EXPERIENCED THIS APPROX. 3 YEARS AGO WHILE AT A DRIVE THROUGH FAST FOOD RESTAURANT. I IMMEDIATELY TURNED OFF THE ENGINE. I THEN RESTARTED AND THE NOISE HAD STOPPED. THE MOTOR NOW STILL HAS THE SAME ISSUE, AND AFTER READING MANY FORUMS STATING THE SAME CONDITIONS, DECIDED TO CALL FORD DIRECTLY. THE RESPONSE FROM FORD WAS THEY KNOW ABOUT THE ISSUE ON THESE TYPES OF MOTORS, BUT ARE NOT ISSUING A RECALL FOR THE FIX. THE ISSUE IS APPARENTLY RELATED TO A KNOW CAM, TIMING CHAIN ISSUE THAT HAS TO HAVE THE GEARS AND TIMING CHAIN REPLACED. AT THE OWNERS EXPENSE OF APPROX. 800-1200M DOLLARS PER SIDE ON THIS TYPE OF V8 MOTOR. I RECOMMEND THAT FORD NEEDS TO DO A RECALL ON THESE, AND FIX THE KNOWN ISSUE, THUS CREATING FURTHER PURCHASES FROM CONSUMERS FOR FUTURE PURCHASES OF THEIR PRODUCT. IF YOU ARE IN DOUBT OF THIS ISSUE, JUST TYPE IN YOUR SEARCH ENGINE, 2008 FORD F150 LOUD KNOCKING NOISE WHILE IDLING, AND SIT BACK AND READ UNTIL YOU ARE TIRED OF READING. PLEASE FEEL FREE TO CONTACT ME WITH ANY QUESTIONS. THANK YOU.

Mileage: 45,000

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING AT UNKNOWN SPEEDS, THE VEHICLE HESITATED. ALSO, THE CHECK ENGINE AND ABS WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INFORMED THE CONTACT THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 200,000.

Mileage: 200,000

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING 50 MPH, THE ENGINE FAILED AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO A LOCAL DEALER (AUTO NATION OF PANAMA CITY, 1730 W 15TH ST, PANAMA CITY, FL 32401) AND WAS INFORMED THAT THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND DID NOT ASSIST. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 180,000.

Mileage: 180,000

WHEN THE BRAKE IS DEPRESSED THE ENGINE ACCELERATES (NEVER KNOW WHEN THIS IS GOING TO HAPPEN). I HAVE HAD THREE INSTANCES OVER THE TOTAL 8 YEARS (FIRST OWNER). ALL THREE TIMES THE BRAKES ARE INEFFECTIVE IN STOPPING THE VEHICLE. TWO TIMES BACKING OUT OF MY DRIVEWAY (AFRAID THAT THE TRUCK WOULD CROSS OVER MY ROAD AND HIT NEIGHBOR'S VEHICLES OR HOME. ONCE IT OCCURRED AT A ALL STOP INTERSECTION. IN MOST CASES I HAD TO TAKE THE TRUCK OUT OF DRIVE TO STOP IT. I'M AFRAID IT IS GOING TO CAUSE SERIOUS ISSUE WITH LIFE AND PROPERTY. THERE ARE NINE OTHER REPORTED CASES OF THIS HAPPENING ON 2008 F-150 VEHICLES SEE WEBSITE FOR THE NINE REPORTED CASES ( HTTP://M.CARCOMPLAINTS.COM/FORD/F-150/2008/ENGINE/UNINTENDED_ACCELERATION.SHTML). I THINK THERE IS AN ISSUE WITH THE THROTTLE BODY STICKING BUT HAVE NO IDEA. I CHECKED FORD AND THERE IS NO KNOWN RECALL FOR THIS ISSUE. SO FAR NO INJURIES OR DESTRUCTION OF PROPERTY HAS OCCURRED WITH ME BUT SOME OF THE NINE OTHER CASES HAS OCCURRED. WOULD GREATLY APPRECIATE YOUR HELP SO THERE ARE NO FATALITIES REGARDING THIS ISSUE.

Mileage: 60,693

ENGINE STUMBLES AND LOSES OF POWER ON SLIGHT INCLINE.

Mileage: 62,000

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING 60 MPH, THE VEHICLE SHOOK WITHOUT WARNING. THE VEHICLE WAS TOWED TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT THE SPARKS PLUGS WERE FRACTURED AT THE BOTTOM TIP AND WENT THROUGH THE ENGINE. THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS AND ADVISED THE CONTACT TO CALL NHTSA. THE FAILURE MILEAGE WAS 140,000. UPDATED 08/29/17*LJ *CN

Mileage: 140,000

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT HEARD A LOUD NOISE COMING FROM THE MOTOR AND THE SPARK PLUG SUDDENLY BLEW OUT. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO STATED THAT THE FAILURE OCCURRED DUE TO THE ALUMINUM HEADS AND THE THREADS WERE WORN AND FRACTURED, WHICH CAUSED THEM TO DETACH. THE CONTACT HAD THE VEHICLE'S HEATING COILS THREADED IN THE HEAD COVER; HOWEVER, THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC AGAIN WHO STATED THAT THE HEATING COIL BLEW OUT AND DAMAGED THE HEAD COVER. THE MECHANIC STATED THAT THE HEAD COVER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 12284440. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

Mileage: 140,000

BOUGHT MY TRUCK WITHOUT KNOWING THAT IT HAS A COMMON IS WITH THE EXHAUST MANIFOLD LEAK. IT IS REAL BAD WHERE THE FUMES GET IN THE CAB OF TRUCK WHEN IT FIRST STARTS UP THIS ISSUE HAS LEAD TO OTHER HEALTH ISSUES FOR ME

Mileage: 131,000

WHEN THE TRUCK IS UNDER 1000RPM AND AT NORMAL OPERATING TEMPERATURE, IT BEGINS TO KNOCK LIKE A DIESEL AND SHAKE VIOLENTLY. THIS IS ONLY REMEDIED BY TURNING THE TRUCK OFF OR REVING THE ENGINE OVER 2000 RPM. THE CHECK ENGIN LIGHT NEVER COMES ON AND AT ALL OTHER TIMES THE TRUCK DRIVES NORMALLY. THIS HAD BEGUN TO HAPPEN MORE FREQUENTLY, INCLUDING AT RED LIGHTS, MY TRUCK HAS ONLY 78,000 MILES

Mileage: 78,000

WHEN THE TRUCK IS UNDER 1000RPM AND AT NORMAL OPERATING TEMPERATURE, IT BEGINS TO KNOCK LIKE A DIESEL AND SHAKE VIOLENTLY. THIS IS ONLY REMEDIED BY TURNING THE TRUCK OFF OR REVING THE ENGINE OVER 2000 RPM. THE CHECK ENGIN LIGHT NEVER COMES ON AND AT ALL OTHER TIMES THE TRUCK DRIVES NORMALLY. THIS HAD BEGUN TO HAPPEN MORE FREQUENTLY, INCLUDING AT RED LIGHTS, POSING A DANGER TO ANYONE DRIVING THE TRUCK. DIAGNOSIS HAS TAKEN THREE MECHANICS INCLUDING A FORD DEALERSHIP WHO IS STILL NOT 100% CERTAIN THE ISSUE SINCE THERE IS NO CHECK ENGIN LIGHT OR OTHER ISSUES.

Mileage: 185,000

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE COMING TO A STOP, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT PHASER FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000.

Mileage: 128,000

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE LOST OIL PRESSURE AND STALLED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND WAS ABLE TO RESTART AND RESUME DRIVING. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE LOW OIL PRESSURE CAUSED THE ENGINE TO FAIL. THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

Mileage: 120,000

RADIATOR AND THERMOSTAT - I HAVE HAD TO REPLACE 4 RADIATORS IN MY FORD F250 TRUCK AND THE VEHICLE ONLY HAS 125,000 MILES. THIS IS A KNOWN DEFECT FROM FORD AND THEY HAVE DONE NOTHING TO PROTECT THEIR CUSTOMERS. I HAVE BEEN STRANDED 3 TIMES AS A RESULT OF THIS DEFECT WITH MY CHILDREN IN THE CAR.

Mileage: 126,000

I HAVE BEEN ADVISED BY THE LOCAL PHIL LONG FORD DEALERSHIP SERVICE DEPARTMENT THAT MY TRUCK NEEDS THE CAM PHASERS REPLACED TO FIX THE PROBLEMS I AM EXPERIENCING. I HAVE SEEN THAT THIS IS A "VERY" COMMON PROBLEM WITH THE 5.4 ENGINE AND FORD HAS RETIRED THIS ENGINE FROM THEIR VEHICLES DO TO THE FAILURES AND IT HAS BEEN KNOWN BY FORD SINCE THE 2003 MODELS AND YET THEY CONTINUED TO SELL A KNOWN FAULTY ENGINE. THEY SHOULD PAY TO HAVE THESE ENGINES REPAIRED AND NOT THE CONSUMERS. THIS IS IN COLORADO SPRINGS, CO AND THE PROBLEMS IS STILL INTERMITTENT AT THIS TIME.

Mileage: 92,000

ON TUESDAY, APRIL 5, 2016, WHILE DRIVING 45 MILES PER HOUR, ON A 2 LANE, BACK COUNTRY, ROAD MY FORD F150, THAT HAD 114,376 MILES BEGAN TO CLANK AND RUMBLE UP UNDER THE HOOD. THE NOISE MADE THE VEHICLE VIBRATE AS THE NOISE GOT LOUDER SO I PULLED OFF OF THE ROAD AND POPPED THE HOOD. THERE WAS SMOKE, CLICKING AND CLANKING ON TOP OF THE RIGHT SIDE OF THE ENGINE SO I TURNED THE VEHICLE OFF. I CALLED MY INSURANCE AND ASKED TO BE TOWED TO A FORD DEALERSHIP 5 MILES AWAY. THE TRUCK WAS STILL DRIVE-ABLE BUT SMOKING AND CLANKING. THE NEXT MORNING I LEARNED #2 SPARK PLUG HAD LOOSE STRIPPING THREADS IN THE CYLINDER HEAD AND THE COIL CRACKED FROM THE PLUG BLOWING OUT. THE PLUG AND BOOTS HAD TO BE REPLACED. REPLACED THE #2 COIL AND THE DEALER HAD TO EXTRACT THE BROKEN SPARK PLUG CYLINDER #2. THE PARTS, SUPPLY, AND LABOR COST WAS $1292.24. I HAVE HAD LARGE V8 ENGINE, VEHICLES ALL OF MY LIFE WITH 200,000 MILES OR MORE ON THE ENGINE BUT NEVER ANY SPARK PLUG ISSUES WITH HIGH MILEAGE ON BOTH SPARK PLUG AND OTHER VEHICLE ENGINE PARTS. IF I HAD CONTINUED TO DRIVE MY TRUCK IT SURELY WOULD HAVE IGNITED CAUSING MORE DAMAGE OR INJURY. THE SPARK PLUG ISSUES WITH FORD NEED TO BE ADDRESSED. I PURCHASED THIS TRUCK IN DECEMBER 2013 WITH 81,160 AND HAD NO PROBLEMS FOR 2 YEARS, 4 MONTHS. AT NO TIME SHOULD SPARK PLUGS BLOW UP OR OUT UNLESS THEY ARE DEFECTIVE PARTS OR PLUGS NOT SUITABLE TO BE TRANSFIXED INTO THE CYLINDER OR ENGINE. DRIVER SAFETY IS AT RISK.

Mileage: 114,376

ON APRIL 5, 2016, WHILE DRIVING MY 2008, F150, TRITON, 4.6, ABOUT 45 MPH, ON A TWO LANE, BACK COUNTRY ROAD, A SUDDEN RATTLING AND POPPING NOISE OCCURRED. I IMMEDIATELY PULLED OVER, POPPED THE HOOD, WHEREAS SMOKE AND THE RATTLING NOISE CONTINUED. I TURNED OFF THE ENGINE AND HAD THE VEHICLE TOWED TO THE FORD DEALERSHIP 5 MILES AWAY. I HAVE 113,600 MILES ON MY VEHICLE AND PURCHASED IT FROM A CARMAX DEALER IN DECEMBER 2013, WITH 81,160 MILES, HAVING EXPERIENCED (NO PROBLEMS THUS FAR). I WAS TOLD BY THE FORD DEALERSHIP THAT MY #3 SPARKPLUG HAD CAUSED THE MECHANICAL ISSUE AND ALL PLUGS NEEDED REPLACING. ADDITIONALLY REPLACEMENT OF RIGHT SIDE ENGINE ISSUES RESULTED FROM NOT HAVING DONE THE 100000 MILE TUNE UP (BULL). IT HAD BEEN TUNED UP PREVIOUS TO BEING SOLD. AFTER USING CHOICE WORDS TOWARDS THE DEALER AND ADVISING HIM OF MY OWNERSHIP OF 3, LARGER V8 ENGINES, NO SPARKPLUG EXPLOSIONS HAD EVER OCCURRED IN MY LIFE. ALL MY FORMER VEHICLES WITH THE EXCEPTION OF MY 2008 F150 HAD NEVER EXPERIENCE SUCH SPARKPLUG EXPLOSION ISSUES AND THESE VEHICLES REACHED CLOSE AND OVER 200,000 MILES. MY VEHICLE IS STILL UNDER WARRANTY BUT DOES NOT COVER THIS ISSUE, NOR WAS THE FORD MANUFACTURE HELPFUL IN ASSISTING WITH THIS MATTER. THE TOTAL COST FOR REPAIRS IS $1295.00, AND MY FIGHT WITH FORD HAS JUST BEGUN.

Mileage: 113,600

MY VEHICLE HAS A BAD MISS IN MOTOR, HAVE HAD ALL PLUGS/WIRES REPLACED TO NO AVAIL. DATA LINK STILL SAYS MISFIRE ON #3. HAVE TO DRIVE SLOW UP HILLS IF DRIVE AT NORMAL SPEED CHECK ENGINE LIGHTS UP. NO ONE SEEMS TO KNOW WHATS WRONG, EVEN MAJOR DEALERSHIPS. NEED HELP ON THIS, HAVE TALKED TO MULTIPLE PEOPLE THAT ARE HAVINT THE SAME ISSUE. I HAVE ALERTED FORD TO THIS AND THEY HAVE BEEN NO HELP AT ALL. THIS NEEDS TO BE A RECALL. IT HAPPENS MOSTLY WHEN DRIVING AT NORMAL SPEEDS GOING DOWN THE HIGHWAY. SOMETIMES IT MISSES SITTING STILL. IT IS A FX4 AS WELL.

Mileage: 100,000

SPARK PLUG BLEW OUT IN A CROWDED STORE PARKING LOT,' BRAKING THE COIL. A FIRE COULD HAVE RESULTED IF COIL HAD NOT BROKE. THE GAS FUMES WERE STRONG. I THOUGHT IT WAS GASKET PROBLEM AND CONTINUED TO DRIVE TO MY MECHANIC'S SHOP.

Mileage: 75,000

FOR THE SECOND TIME IN LESS THAN 4 MONTHS THE #2 SPARK PLUG HAS BLOWN OUT OF THE CYLENDER HEAD. FORD HAS KNOWN ABUOT THIS PROBLEM FOR YEARS BUT WILL NOT FIX IT . THIS COULD CAUSE AN EXPLOSION & FIRE IN THE ENGINE COMPARTMENT AS THE PLUG & INJECTOR AR STILL WORKING PUMPING FUEL INTO AN OPEN HOLE.

Mileage: 52,631

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING, THE ENGINE MADE AN ABNORMAL NOISE AND THE CHECK ENGINE LIGHT ILLUMINATED. IN ADDITION, THE OIL PRESSURE WAS LOW AND THE VEHICLE SHOOK VIOLENTLY. THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE TECHNICIAN INFORMED THE CONTACT THAT THERE WAS A TSB FOR THE FAILURE (14-0114). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

Mileage: 111,000

WHILE DRIVING AT 40MPH. MY TRUCK MADE A LOUD POPPING SOUND AND I PULLED OFF THE ROAD, RAISED THE HOOD AND LEARNED THAT THE SPARKPLUG BLEW OUT. I HAVE REPLACED THE SPARK PLUG AND COIL. I LEARNED THIS IS A COMMON OCCURRENCE AND NOTHING HAS BEEN DONE TO FIX THE PROBLEM.

Mileage: 79,000

TL* THE CONTACT OWNS 2008 FORD F-150. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 55 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE AND THERE WAS A SUDDEN LOSS OF POWER WHEN ATTEMPTING TO ACCELERATE. THE CONTACT SHUT THE VEHICLE OFF AND RESTARTED IT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

Mileage: 180,000

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 182,000.

Mileage: 182,000

TRAVELLING APPROX 60 MPH ON AN INTERSTATE. THE SPARK PLUG POPPED OUT WITH A LARGE POP.

Mileage: 90,000

BROKE 4 SPARK PLUGS IN BLOCK TRYING TO REPLACE

Mileage: 99,000

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE JERKED FORWARD WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE ENGINE TEMPERATURE GAUGE REACHED HIGH LEVELS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL*THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, AN ABNORMAL NOISE EMITTED FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER MECHANIC, WHO DIAGNOSED THAT THE TIMING CHAIN, TIMING CHAIN SLIDE, TIMING CHAIN TENSIONER AND CAM PHASERS NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

ON SUNDAY 12/14/14 AT 7PM MY 2008 FORD F-150 SHUT OFF WHEN I WAS GOING 65 MPH DOWN THE NEW YORK STATE THRUWAY. I WAS STUCK ON THE SIDE OF THE ROAD FOR HOURS WAITING FOR IT TO BE TOWED. TURNS OUT THE FUEL PRESSURE MODULE (FPM) THAT IS MOUNTED IN THE BACK OF THE TRUCK ON A CROSSMEBER OF THE FRAME UP ABOVE THE SPARE TIRE WAS THE CAUSE. FORD NEEDS TO RECALL THESE 2004-2008 FORD F-150 THAT USE THIS FPM BEFORE SOMEONE GETS KILLED ON THE SIDE OF THE ROAD! *TR

Mileage: 54,000

I WAS DRIVING MY TRUCK HOME ON THANKSGIVING AND IT BLEW OUT A SPARK PLUG (SECOND INCIDENT, DIFFERENT CYLINDER). I WAS LATER TOLD THAT AN ENGINE FIRE COULD OCCUR FROM THE FUEL/FUMES COMING FROM THE OPEN CYLINDER HEAD. *JS

Mileage: 82,000

DRIVERS SIDE SEAT BELT TAKES A FEW TRIES TO GET IT TO CLICK AND SOMETIMES IT DOESN'T ENGAGE ALL THE WAY AND THE LATCH COMES OUT. A MISFIRE IN CYLINDER 1 LEAD THE DISCOVERY OF KNOWN ISSUES WITH SPARK PLUGS AND REMOVAL. 3 OF THE PLUGS WERE LOOSE. *TR

Mileage: 105,000

MOTOR EJECTED SPARK PLUG PASSENGER SIDE THIRD ONE BACK. SHOULD BE A RECALL BECAUSE IT IS A FAULTY DESIGN. *TR

Mileage: 168,500

VEHICLE WOULD STALL AT SLOW SPEED AND SEVERE RATTLING AND LOSS OF POWER TO VEHICLE WHICH COULD EASILY RESULT IN ACCIDENT. FORD SERVICE INDICATED THAT IT WAS CAM PHASING OR OTHERWISE KNOWN AS INTAKE CAMSHAFT POSITION TIMING OVER RETARDED PROBLEM. VERY DANGEROUS CONDITION WHICH SHOULD BE ADDRESSED VIA RECALL. *TR

Mileage: 51,200

STARTED SHAKING AND SPUTTERING IN REVERSE AT LOW RPM. TWO TRANSMISSION SHOPS SAID IT WAS THE REVERSE BAND IN TRANSMISSION AND NEEDED REBUILD. HAD TRANS REBUILT (AT COST OF 2390.00). AFTER REBUILD, MECHANIC WAS DRIVING AND IT STILL HAD PROBLEM. AFTER RESEARCHING, HE THINKS IT IS THE CAM PHASERS CAUSING PROBLEM. HE HAD REPLACED MY PLUGS BEFORE TRANSMISSION WORK TO RULE THAT OUT (ALL 8 OF THE PLUGS BROKE WHILE TAKING THEM OUT, HE HAD NEVER SEEN ALL BREAK ON A F150 BEFORE). THIS ENGINE/TRANSMISSION IS A BAD DESIGN ALL AROUND AND FORD NEEDS TO STEP UP, ADMIT IT AND FIX AND OR REIMBURSE CUSTOMERS FOR REPAIRS. YOU CAN SPEND THOUSANDS CHASING PROBLEMS IN THIS POWER TRAIN! EVEN THOUGH THE TRANSMISSION REBUILD DID NOT FIX THE INITIAL PROBLEM, THE REAR BAND WAS WORN, AND THE PLATE IN THE TRANSMISSION HAD A SMALL DENT AND HAIR LINE CRACKS, SO IT WAS GOING TO FAIL EVENTUALLY! THE TRANSMISSION SHOP SAID THIS IS COMMON IN THESE. I WANT SOMETHING DONE! *TR

Mileage: 72,000

PURCHASED USED 2008 FORD F-150 5.4L V8 GASOLINE TRUCK A COUPLE OF YEARS AGO. LAST YEAR THE TRUCK STARTED TO SOUND LIKE A DIESEL ONCE THE ENGINE WARMED UP. THE CAM PHASER SENSORS WERE REPLACED. THIS DID NOT FIX THE PROBLEM. NEXT WE WILL HAVE A CAM PHASER LOCK OUT SYSTEM INSTALLED. THE MECHANIC SAYS THAT 50% OF THE TIME IT FIXES THE PROBLEM BUT THE OTHER 50% REQUIRES A BRAND NEW ENGINE. ALSO, KEYSTONE IS THE ONLY ENGINE THAT MY MECHANIC WILL USE FOR THE REPLACEMENT DUE TO THE ORIGINAL MANUFACTURER HAVING THIS PROBLEM WITH 2004 TO 2008 MODEL YEARS. ALL SEARCHES ONLINE AND DISCUSSIONS WITH VARIOUS PEOPLE (FRIENDS, FAMILY, FORD DEALERSHIP MECHANICS, PUBLIC FORUMS) HAVE FOUND THIS TO BE A COMMON PROBLEM THAT CAN COST UP $7,000 TO FIX YET FORD HAS NOT RECALLED THE ENGINE OR OFFERED TO MODIFY THE ENGINE BY INSTALLING THE LOCK OUT KIT. NOW THE TRUCK HASN'T BEEN DRIVEN MORE THAN A COUPLE OF MILES IN THE LAST YEAR SO THE ENGINE IS NOT DESTROYED. THE MOST COMMON COURSE OF THE BREAK DOWN IN THE ENGINE IS AS FOLLOWS: CAM SENSOR FAIL, CAM PHASERS BREAK IF NOT LOCKED OUT, FRAGMENTS OF THE PHASER GETS INTO THE OIL CAUSING THE ENGINE TO BE DESTROYED. *TR

I HAVE A 2008 FORD F-150 KING RANCH WITH A 5.4 L ENGINE. EXHAUST STUDS HAVE SNAPPED OFF CAUSING A LEAK FROM THE EXHAUST MANIFOLD AND CARBON MONOXIDE FILLS THE CAB OF THIS VEHICLE SETTING AT IDLE. FORD HAS A PROBLEM WITH THIS ENGINE FOR USING A NON CONFORMING GRADE OF STUD. ACCORDING TO FORUMS THAT I HAVE RESEARCHED SHOWED THAT FORD HAS CHANGED THE STUDS. THEY ARE NOW USING STAINLESS STEEL STUDS. IS THERE A POSSIBILITY OF A RECALL ON THIS VEHICLES ENGINE FOR A REPAIR TO CHANGE ALL STUDS TO STAINLESS STEEL. I PURCHASED THIS VEHICLE USED AND NOTICED THE PROBLEM AFTER THE 30 DAY WARRANTY HAD EXPIRED. BUYER BEWARE! PROTECT YOUR FAMILY FROM THIS PROBLEM. *TR

Mileage: 109,000

TL* THE CONTACT OWNS A 2008 FORD F-350. THE CONTACT STATED WAS DRIVING 35 MPH AND NOTICED THAT THE ENGINE RPMS INCREASED AS SMOKE BILLOWED FROM THE EXHAUST. AFTER THE CONTACT ALLOWED THE VEHICLE TO COOL DOWN, IT WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEALS WERE LEAKING TO THE BEARINGS AND THE TURBO OF THE EMISSIONS SYSTEM HAD FAILED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 34,000.

Mileage: 34,000

MY SON WAS HAVING TROUBLE WITH ENGINE BEING SLUGGISH FOR A WEEK OR SO AND TRIED TO PASS SOMEONE AND ENGINE CUT OUT AND HE WAS ALMOST RAN OVER BY ONCOMING TRAFFIC. WE TOOK TO FORD DEALER AND THEY HAD A BULLETIN FROM FORD ABOUT FAULTY ENGINES IN 2008 F 150'S AND SAID FORD WOULD REPLACE THE ENGINE. THEY CALLED BACK NOW AND SAID THEY FOUND SOME SLUDGE IN BOTTOM OF ENGINE WHICH ONLY HAS 41,000 MILES ON IT AND SAID FORD WILL NOT COVER IT. THIS IS A FORD DEFAULT AND THEIR LIABILITY. READY TO JOIN THE CLASS ACTION AGAINST THEM ON THIS ISSUE. *TR

Mileage: 41,000

THE TRUCK STEERING COLUMN WAS HARD TO TURN. CLUNKING AND STICKING POINTS WERE NOTED DURING TURNING.FOUND LOWER STEERING SHAFT U-JOINT IN ENGINE COMPARTMENT SEIZED. THIS COINCIDES WITH LATEST FORD RECALL FOR 2005 - 2011 FORD CARS. THIS WAS DIAGNOSED AS "FROZEN" BY FORD AND REPLACED ON 06/17/13. THIS RECALL SHOULD BE EXPANDED TO INCLUDE FORD F-150 SERIES TRUCKS. THE REPAIR COST $460.00. I THOUGHT THIS SHOULD HAVE NOT HAPPEN BEING ONLY 5 YEARS OLD. ANOTHER ISSUE WITH TRUCK WAS A SPLIT IN THE RADIATOR (MAIN CORE.) WHILE DRIVING , MY FAMILY NOTICED THE SMELL OF GLYCOL. THE RADIATOR WAS LEAKING (STREAMING)IN THE MIDDLE OF RADIATOR CORE. FORD REPLACED THE RADIATOR AT A COST OF $820.83 ON 08/05/13. THERE WAS NO IMPACT DAMAGE TO RADIATOR. IT WAS DIAGNOSED AS LEAKING. *JS

Mileage: 61,917

THE #3 PASSENGER SIDE ENGINE SPARK PLUG WAS BLOWN COMPLETELY OUT OF THE ENGINE HEAD. THE BLOW-OUT STRIPED ALL THE THREADS FROM THE ENGINE HEAD. THIS DAMAGE CAUSED THE SPARK PLUG HOLE TO BE UNUSABLE. REINSTALLATION OF THE SPARK PLUG WAS NOT POSSIBLE. THE SPARK PLUG BLOWING OUT ALSO CAUSED THE COIL TO BE BROKEN LEAVING THE COIL LAYING ON THE ENGINE STILL ACTIVE WITH HIGH VOLTAGE ARCHING ACROSS THE SURFACE OF THE ENGINE POTENTIALLY CAUSING A FIRE IN THE ENGINE COMPARTMENT. THIS INCIDENT HAS NOT BEEN UNCOMMON TO FORD ALUMINUM HEAD ENGINES AND IS A PROBLEM FORD REFUSES TO ADDRESS. THE COST TO CONSUMERS IS IN THE MILLIONS OF DOLLARS TO REPAIR THIS DEFECT IN THE ENGINE HEAD. CONSUMERS ARE BEING FORCED TO REPLACE THE HEAD OR REPLACE THE ENTIRE ENGINE DUE TO THIS DEFECT. A QUICK INTERNET RESEARCH INTO THIS ANOMALY WILL REVEAL MILLIONS OF CONSUMERS WHO HAVE VICTIMIZED BY THIS DEFECT. FORD SERVICE FACILITIES ARE MAKING MILLIONS IF NOT BILLIONS OF DOLLARS AFTER THE SALE OF THE VEHICLE AS A DIRECT CONSEQUENCE OF THIS UNREVEALED DEFECT. THIS IS NOTHING LESS THAN A CASE OF DOING BUSINESS IN BAD FAITH AND SHOULD BE ADDRESSED BY THE NHTSA. *TR

Mileage: 156,216

MY 16 YEAR OLD SON WAS DRIVING OUR TRUCK AND THE ENGINE STARTED TO KNOCK AND THEN PROCEEDED TO DIE. IT STARTED BACK UP BUT IT WILL DIE WHEN YOU START TO SLOW DOWN FOR AN INTERSECTION OR TO PARK. OUR TRUCK IS ONLY 5 YEARS OLD, ONLY HAS 121,000 MILES, AND HAS HAD ITS OIL CHANGES REGULARLY. THERE IS NO REASON WE SHOULD BE HAVING A PROBLEM LIKE THIS WITH THE TRUCK. WHEN I TALKED TO OUR LOCAL AUTO MECHANIC HE INFORMED ME THAT HE HAS REPLACED THE CAM PHASERS IN 7 F-150'S IN THE PAST MONTH. THIS SEEMS TO BE A PROBLEM THAT SHOULD BE LOOKED AT BY FORD. THE REPAIR IS NOT CHEAP AND I BELIEVE FORD HAS A RESPONSIBILITY TO LOOK INTO THIS CONSIDERING THE DANGER OF THE VEHICLE DYING WHENEVER IT WANTS WITH NO WARNING. I THOUGHT I WAS GIVING MY SON A RELIABLE TRUCK TO DRIVE BUT AS IT TURNS OUT HE CANNOT DRIVE IT BECAUSE I FEEL IT IS TO DANGEROUS FOR HIM WITH THE ENGINE DYING. *TR

Mileage: 119,000

AT IDLE THE ENGINE KNOCKS LOUDLY VEHICLE STALLS ENGINE FAILS. NOT ABLE TO DRIVE. I HAVE BEEN TOLD BY FORD TECHS AND DEALERSHIP TO REPLACE ENGINE. *TR

Mileage: 50,000

I BOUGHT MY FORD TRUCK USED IN APRIL 2012 WITH 33000 MILES. ABOUT A MONTH LATER I NOTICED THAT WHEN I APPLIED THE BRAKES TO STOP, THE ENGINE WOULD REV UP. IT HAS SINCE GOTTEN ALOT WORSE. NOW THE ENGINE HAS STARTED TO OVERPOWER THE BRAKES. I FIND THAT WHEN THE ENGINE STARTS TO REV, IF I LET OFF THE BRAKE AND REBRAKE IT WILL DROP THE RPM'S BACK DOWN. IT'S DANGEROUS TO HAVE TO LET OFF THE BRAKE ESPECIALLY IN TRAFFIC! IT'S SUCH A SAFETY ISSUE. IN RESEARCHING THIS FOR A RECALL, I'VE COME ACROSS OTHER COMPLAINTS LIKE THIS. *TR

Mileage: 34,250

HAD A P/M CHECK DONE ON MY VEHICLE BY MY MECHANIC. DURING THE CHECK, HE INFORMED ME THAT THE IGNITION COIL FOR CYLINDER 5 WAS GOING OUT. HE ADVISED THAT THIS WAS COMMON. HE ALSO ADV THAT HE NEEDED TO REPLACE THE SPARK PLUG BUT HE DID NOT WANT TO UNTIL I CHECK INFO ON THE 9/16 PLUG ON-LINE. THIS PLUG HAS HISTORY OF BREAKING (DESIGN FLAW- CARBON FUSING/REPLACEMENT MC PLUGS HAVE BEEN REDESIGNED) BASED ON INFO IN VARIOUS FORUMS. THE PLUG DID BREAK DURING EXTRACTION REQUIRING ADDITIONAL WORK/EXPENSE. CALLED A LOCAL FORD DEALER SERVICE MGR WHO ADVISED HE WAS UNAWARE OF THAT HAPPENING BEFORE 80K MLS. AN EMAIL TO FORD REVEALED THAT THEY ARE UNAWARE OF ANY PROBLEMS/RECALLS OR TSB (WHICH DO EXIST). IN OTHER WORDS, THEY WILL NOT DO ANYTHING. I AM NOW WORRIED ABOUT PLUGS BREAKING DURING SCHEDULED TUNE RESULTING IN ADDITIONAL EXPENSE EVEN AT FORD DEALER .(AS PER COMMENTS ON LINE FORUM) THIS IS CLEARLY A DESIGN FLAW W/ MOTORCRAFT PLUGS AND THEY KNOW IT (TSB'S) CAN YOU HELP? *JS

Mileage: 60,000