2009 FORD F-150 Engine Problems

The contact's son owned a 2009 Ford F-150. The contact stated that while approximately 10 MPH, he observed smoke emanating from the glove box and the check engine warning light illuminated. The contact steered the vehicle to the side of the road, and he observed a small fire by the accelerator pedal. The contact exited the vehicle and opened the hood. The contact stated that flames erupted from the engine compartment when the hood was opened, and he called 911. The fire department arrived and extinguished the fire. A police report was taken, but the info was not available at this time. The vehicle was towed to a tow lot where it was deemed totaled. There were no injuries. The manufacturer was not notified of the failure. The failure mileage was approximately 201,000.

Mileage: 201,000

My pickup truck at only 23 thousand miles in the engine, it's module went bad and brake and ABS lights came on on the dashboard. I took the car to the dealer and they said that I have to replace it and they are charging me 5,400 dollars. They said that some 2009 F150 module were bad from factory, but there's not recalls for it to be fixed by them.

The contact owns a 2009 Ford F-150. The contact stated that the engine warning light was intermittently illuminated. The contact stated while driving at undisclosed speeds and making sharp turns, the vehicle stalled. The contact was able to pull over to the side of the road and depressed the brake pedal until the vehicle responded as needed. The contact stated that the failure had been recurring while making sharp turns and while coming to a stop at traffic lights. The vehicle was taken to the dealer, and the contact was informed that the failure could not be duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 60,000.

Mileage: 60,000

The contact owns a 2009 Ford F-150. The contact stated while starting the vehicle, the engine rattled. No warning light was illuminated. The vehicle was taken to the dealer, but the dealer was unable to duplicate the failure. The failure recurred. The vehicle was then taken to an independent mechanic, who diagnosed that the cam phasers needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was approximately 115,000.

Mileage: 115,000

The contact owns a 2009 Ford F-150. The contact stated that while starting the vehicle, there was an abnormal rattling noise detected. The check engine warning light was flashing on and off. The vehicle failed to start. The vehicle was taken to the local dealer where it was diagnosed that the failure was due to a faulty cam phaser. Additionally, the contact was informed that the timing chain and engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred him to the NHTSA Hotline for assistance. The approximate failure mileage was 185,000.

Mileage: 185,000

The contact owns a 2009 Ford F-150. The contact stated while attempting to start the vehicle, it would not start. The contact stated no warning light was illuminated. The contact had the vehicle towed to an independent mechanic who diagnosed that the vehicle fuel pump had failed and determined that it needed to be replaced. The repair was made, however, the failure persisted. The independent mechanic checked the vehicle fuses and replaced a 20 AMP fuse and the vehicle was repaired. The contact stated that the failure re-occurred and he drove the vehicle to a dealer. The contact had researched that the failure was related to Manufacturer TSB Number: TSB-15-0137 and NHTSA Campaign Number: 10074713 (Engine). The manufacturer had been informed of the failure. The failure mileage was approximately 218,000.

Mileage: 218,000

WHILE IN DRIVE AT IDLE SPEED THE TRUCKS RPM JUMPED TO APPROXIMATELY 4000 RPM INSTANTLY . I HAD TO PUSH MY FOOT BRAKE AS HARD AS I COULD AND PUT SHIFTER IN NEUTRAL THEN IT WAS OK FOR A WHILE THEN THIS HAPPENED AGAIN SEVERAL WEEKS LATER TOOK TO DEALER NO CHECK ENGINE LIGHT COULD NOT FIND A PROBLEM VERY DANGEROUS SITUATION.

Mileage: 183,000

PURCHASED VEHICLE IN NOV 2018, LESS THAN ONE YEAR THAN THE DATE OF THIS CLAIM. ON NINE DIFFERENT OCCASIONS MY VEHICLE EXPERIENCED ONE OR MORE OF THE FOLLOWING: LOSS OF ALL ELECTRICAL POWER, STEERING, ACCELERATION CONTROL, FUEL PUMP/INJECTORS, TIMING OF THE RPM, AND OTHER RELATED ISSUES LEAVING ME STRANDED IN THE MIDDLE OF NOWHERE, IMMEDIATELY AND INSTANTANEOUSLY STALLED OUT ON HIGHWAYS AND MAJOR FREEWAYS WITHOUT WARNING, SOME OF WHICH NEARLY LED TO VEHICULAR ACCIDENTS FROM SUDDEN LOSS OF ALL ELECTRONIC EQUIPMENT AND POWER OF THE TRUCK, WITH HUNDREDS OF INDIVIDUALS HAVING EXPERIENCED THE SAME OR SIMILAR ISSUES WITH THIS YEAR AND MODEL F-150. IN THE MIDST OF ALL OF THIS, I'VE SPENT OVER $3,500+ IN REPAIRS BETWEEN THE DATE OF PURCHASE TO DATE OF THIS CLAIM TO THE ECM, FUEL PUMP MODULE, FUEL INJECTOR HARNESS, BATTERY, IGNITION SWITCH, MASS FLOW AIR SENSOR, CAMSHAFT POSITION SENSORS, SERPENTINE BELT, AND NORMAL MAINTENANCE, AND HAVE BEEN INFORMED THAT I NOW NEED A NEW ENGINE, ANOTHER $5,000 ON TOP OF THE PRESENT $6,784 LIEN CURRENTLY ON THE VEHICLE. THE PHYSICAL SAFETY OF MYSELF AND OTHERS HAS NOT ONLY BEEN PLACED IN JEOPARDY, BUT THIS ISSUE AND VEHICLE HAS PLACED ME IN A SERIOUS, DELINQUENT, AND SEEMINGLY IMPOSSIBLE FINANCIAL POSITION. I CAN'T EVEN GET THE CAR TO RUN NOW, IT WILL NOT DRIVE AFTER THE ENGINE SUDDENLY STALLED OUT 15 DAYS AGO AS I LOST ALL ABILITY TO ACCELERATE ON FREEWAY; ENGINE WAS OVERHEATING AND HAD NO OIL PRESSURE. TIMING CHAINS, ROD, MAIN BEARING AND CAMSHAFTS ALL NEED REPAIR WITH NO GUARANTEE THAT I WON'T BE PLACED IN THE SAME OR SIMILAR POSITION AGAIN IF I WERE TO CORRECT, POSSIBLE BANKRUPTCY IF LEFT UNCORRECTED. FORD WANTS $400 MORE FOR INSPECTION, MAKES NO GUARANTEE ALL ISSUES WILL HE IDENTIFIED AND REFUSES TO MAKE REPAIRS OR TAKE RESPONSIBILITY FOR THEIR FAULTY 5.4L V8 TRITON ENGINE & ELECTRICAL SYSTEM THAT ARE 'BUILT FORD TOUGH.' PLEASE HELP.

Mileage: 164,000

SPARK PLUG BLOWOUT WHILE DRIVING ON A CITY STREET. COMMON PROBLEM WITH 4.6L 2V TRITON ENGINES FROM MY SEARCH RESULTS. FORD SHOULD BE RESPONSIBLE FOR FIXING THE ISSUE AS THERE IS ONLY A FEW THREADS HOLDING THE SPARK PLUG IN THE ENGINE HEADS.

Mileage: 170,000

I BOUGHT THIS VEHICLE USED WITH 151,000 MILES ON IT. IT RAN GOOD FOR A COUPLE WEEKS THEN IT STALLED WHEN I WAS GOING INTO A LEFT HAND TURN BUT RESTARTED. IT REPEATED THE PROBLEM A FEW MORE TIMES THEN WOULD NOT RESTART. I TOWED IT BACK TO THE USED CAR DEALER I BOUGHT IT FROM AND THEY REPLACEDD THE FUEL PUMP. THAT LASTED ABOUT 2 WEEKS NOW THE PROBLEM HAS RETURNED. I SEEN MANY OWNERS HAD THE SAME PROBLEM WITH THEIR TRUCKS. FORD NEED'S TO TAKE CARE OF THIS BEFORE SOMEONE GETS KILLED. THE VEHICLE STALLED UNDER ALL CONDITIONS. AT A IDLE, AT 70 MILES AN HOUR ON THE INTERSTATE, IN THE CITY AT 40 MPH

Mileage: 156,000

MY TRUCK STALLED WHILE ENTERING FREEWAY LANES. I WENT FROM 60MPH TO 10MPH AND WAS NEARLY READ ENDED. THE TRUCK FINALLY STALLED JUST AS I MADE IT TO THE SHOULDER. TWO HOURS LATER, MY TRUCK STALLED WHILE DOING 40MPH ON A SURFACE STREET. I HAD TO PULL INTO A CENTER TURN LANE TO AVOID BLOCKING TRAFFIC. FUEL WAS AT HALF A TANK. OIL LEVEL WAS GOOD.

Mileage: 150,000

TL* THE CONTACT OWNS A 2009 FORD F-150. WHILE DRIVING 55 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT WAS NOT ABLE TO RESTART THE VEHICLE FOR APPROXIMATELY 30 MINUTES. THE CONTACT REFERENCED TSB NUMBER: 15-0137 (CRANK NO-START, STALLING) AS A POSSIBLE CAUSE OF THE FAILURE. THE DEALER (MOSSY FORD, 858-273-7500) WAS CALLED AND STATED THAT THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED BY THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.

Mileage: 125,000

ON DECEMBER 15, 2017, WHILE DRIVING ON I35 IN HEAVY TRAFFIC IN FORT WORTH, TEXAS, THE F150 AUTONOMOUSLY ACCELERATED TO MAXIMUM RPM AND WOULD NOT SLOW DOWN. THE CRUISE CONTROL WAS NOT ON. WE WERE FORCED TO RIDE THE BREAKS HARD UNTIL WE WERE ABLE TO EXIT THE FREEWAY, PUT THE VEHICLE IN NEUTRAL AND BREAK TO A STOP. WE TURNED THE VEHICLE OFF AND RESTARTED. THE VEHICLE STILL WENT TO MAXIMUM RPMS SO WE SHUT DOWN THE VEHICLE AGAIN. FIVE MINUTES LATER WE RESTARTED THE VEHICLE AND THE ENGINE PERFORMED NORMALLY. WE DROVE IT IMMEDIATELY TO OUR LOCAL AUTO REPAIR SHOP. THE LOCAL AUTO REPAIR CENTER WAS NOT ABLE TO REPLICATE THE ISSUE AND THE VEHICLE SHOWS NO FAULT CODES. UPON SEARCHING THE INTERNET, WE DISCOVERED NO OPEN RECALLS ON THIS VEHICLE AND WE ARE NOT THE ONLY FORD CUSTOMERS TO EXPERIENCE THIS ISSUE.

Mileage: 125,000

2009 FORD F150 WITH 146,000 MILES NEEDED TO HAVE ENGINE REPLACED DUE TO SCORED CAMS. IT APPEARS THIS HAS BEEN A COMMON PROBLEM WITH THE 5.4 ENGINES. WE ARE ONE-TIME OWNERS OF THIS VEHICLE AND HAVE GREAT MAINTENANCE RECORDS. I BELIEVE A RECALL SHOULD BE MADE FOR THIS

Mileage: 146,000

AT LESS THAN 63,000 MILES, MY FORD F-150 5.4 LITER ENGINE IS FAILING. I JUST RETURNED FROM THE DEALERSHIP EARLIER TODAY WITH OVER $2800 WORTH OF REPAIR ESTIMATES; HOWEVER, THE VEHICLE SHOOK AND RATTLED WHEN IDLING AT A STOP LIGHT AND APPEARED TO BE OVERHEATING. VEHICLE IS GARAGE KEPT, GETS REGULAR OIL CHANGES AND MAINTENANCE, AND IS DRIVEN MAINLY ON HIGHWAYS. I DO NOT PULL ANYTHING (BOATS, CAMPERS, ETC.). INTERNET FORUMS ARE LOADED WITH COMPLAINS ABOUT THIS ENGINE AND ALL SURROUND THE CAM PHASERS AND LOCAL ENGINE PARTS FAILING. FORD HAS NO RECALL AND WILL DO NOTHING! I HAVE A CASE IN THEIR SYSTEM AS OF THIS EVENING AND WOULD LIKE THE GOVERNMENT TO START ISSUING GUIDANCE TO CONSUMERS AND GET A RECALL PROCESS UNDERWAY. ISSUE WAS FIRST NOTICED WHEN I TRIED TO START THE TRUCK ONE NIGHT IN MID-JUNE. I WAS FINALLY ABLE TO GET AN APPOINTMENT IN MID-JULY TO GET THIS DIAGNOSIS.

TL* THE CONTACT OWNS A 2009 FORD F-150. WHILE ATTEMPTING TO START THE VEHICLE, THE ENGINE TURNED OVER BUT DID NOT START. THE VEHICLE WAS INSPECTED BY TWO INDEPENDENT MECHANICS WHO REPLACED THE #27 FUSE AND RELAY, BUT WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO REPLACED THE BATTERY AND FUEL MODULE IN THE VEHICLE, BUT THE FAILURE CONTINUED. THE VEHICLE WAS NOT REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND TRANSFERRED THE CONTACT DIRECTLY TO THE NHTSA HOTLINE TO CHECK FOR RECALLS AND TO FILE A COMPLAINT. THE APPROXIMATE FAILURE MILEAGE WAS 71,000.

Mileage: 71,000

CRACKED EXHAUST MANIFOLD 2009 FORD F150 5.4 TRITON V8. I HAVE NOW CRACKED THE SECOND RIGHT SIDE ENGINE EXHAUST MANIFOLD. THIS IS IRRITATING AS EXHAUST FUMES ENTER THE PASSENGER CAB WHEN STOPPED.

Mileage: 164,702

SPARK PLUG BLOWS OUT OF HEADS AT 80774 MILES PRIOR TO FIRST TUNE UP INTERVAL. COULD OF CAUSED A ENGINE FIRE.

Mileage: 80,774

TL* THE CONTACT OWNS A 2009 FORD F-150. WHILE DRIVING 50 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND RESTARTED THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

VEHILE HAS/SHUT DOWN ON 6 OR 7 SEPARATE OCCASIONS WHILE SITTING IN A PARKING LOT OR AT A STOP LIGHTS THE STEERING ALSO LOCKED UP WHILE TRYING TO TURN LEFT . I HAVE TAKEN IT TO SEVERAL BUT THE ONLY THING THEY TELL I NEED A NEW ENGINE ,. WHICH WE CANNOT AFFORD, WE GOT IT SERVICED ON TIME AND TOOK CARE OF IT THINKING WE WOULD HAVE IT FOR MANY YEARS. NOW IT IS GARBAGE I HAVE ALWAYS DEFENDED FORD BUT NOW AM SO UPSET DON'T KNOW WHAT WE WILL DO .

Mileage: 158,000

TL* THE CONTACT OWNS A 2009 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THERE WAS AN EXHAUST LEAK AND FRACTURED BOLTS IN THE MANIFOLD. THE INDEPENDENT MECHANIC INFORMED THE CONTACT THAT THE VEHICLE SHOULD BE TAKEN TO AN AUTHORIZED DEALER FOR FURTHER DIAGNOSTIC TESTING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE CAM, TIMING SENSORS, AND GEARS FAILED AND THE ENGINE WOULD NEED TO BE REPLACED. THE FAILURE OCCURRED 24 HOURS AFTER THE VEHICLE WAS PURCHASED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,136.

Mileage: 125,136

SPARK PLUGS CAN NOT BE REMOVED DUE TO MOST BREAKING. MOST OF THE SPARK PLUGS ARE FROZEN AND BREAK WHEN YOU TRY TO REMOVE. FORD RECOMMENDS REPLACING PLUGS AT 100000 MILES.

Mileage: 105,089

SPARK PLUG EJECTION. ON 4/24/16, #3 CYLINDER EJECTED THE SPARK PLUG, RECOMMENDED REPAIR WAS TO USE/INSTALL HELI-COIL. 7/1/16, #3 CYLINDER EJECTED THE SPARK PLUG AGAIN, THIS TIME DAMAGING THE CYLINDER HEAD. NOW WAITING FOR AN ESTIMATE AND TO SEE IF THE HEAD CAN BE REPAIRED OR HAS TO BE REPLACED. BOTH TIMES, VEHICLE WAS ACCELERATING FROM A STOP WHEN TRAFFIC LIGHT CHANGED FROM RED TO GREEN.

Mileage: 100,000

MY TRUCK HAS ONLY 30,000 MILES ON IT. WHILE DRIVING IT, THE 5.4 LITER ENGINE STARTED KNOCKING SEVERELY AND WOULD NOT POWER THE VEHICLE. I MANAGED TO AVOID A MAJOR ACCIDENT AND GET IT PULLED OVER TO THE SIDE OF THE FREEWAY. I HAD FORTUNATELY PURCHASED THE EXTENDED WARRANTY AND TOOK IT TO THE DEALER. WHEN I GOT IT TO THE DEALER, ALL THE SERVICE WRITERS ACKNOWLEDGED THAT THE 5.4 HAS A SERIOUS PROBLEM. THE MECHANIC EXAMINED IT AND STATED THAT IT WAS A CAM PHASER ISSUE. HERE IS THE PROBLEM: FORD KNOWS THAT THE 5.4 LITER ENGINE HAS THIS PROBLEM AND WILL NOT ACKNOWLEDGE IT BECAUSE THERE ARE 1,000S OF THESE ON THE ROAD AND THEY DO NOT WANT TO PAY TO FIX THEM. THAT IS WHY THEY DISCONTINUED THE ENGINE. WHAT IS REALLY BAD, IS THAT THE NHTSA KNOWS ABOUT IT AS WELL. FORD NEEDS TO FIX THESE TRUCKS BEFORE SOMEONE GETS HURT. I BARELY GOT THE TRUCK PULLED OVER ON THE SOUTHERN CALIFORNIA 405 FREEWAY! I WILL NEVER BUY A FORD PRODUCT AGAIN. I AM GOING BACK TO MY TRUSTED TOYOTA BRAND!

Mileage: 30,000

FORD MOTOR COMPANY HAS INSTALLED DEFECTIVE FASTENERS ON THE EXHAUST MANIFOLDS OF NUMEROUS MODULAR V8 (4.6L & 5.4L) EQUIPPED F-150S. THIS IS A WELL DOCUMENTED ISSUE AMONG SEVERAL F-150 OWNERS THROUGHOUT THE US AND CANADA FOR MANY MODEL YEARS. THE PROBLEM WITH THESE MANIFOLD FASTENERS (STUDS) IS THAT AFTER THE NORMAL HEAT CYCLES OF DRIVING AND SITTING, THEY BEGIN TO DETERIORATE AT AN EXCELLED RATE. ONCE A STUD OR STUDS HAVE FAILED, ENGINE EMISSIONS LEAVE THE EXHAUST SYSTEM PRIOR TO REACHING THE CATALYTIC CONVERTER. THE WAY TO REPAIR THIS IS BY REMOVING THE EXHAUST SYSTEM AND MANIFOLDS IN ORDER TO EXTRACT THE BROKEN STUD OR STUDS AND REPLACE THEM WITH IMPROVED PARTS, IN MANY CASES THE ENTIRE ENGINE MUST BE REMOVED FROM THE VEHICLE DUE TO CLEARANCE ISSUES. NOT ONLY IS THIS ISSUE VERY COSTLY TO THE CONSUMER AND THE ENVIRONMENT IT IS ALSO AN ARDUOUS PROCESS TO BE REPAIRED EVEN BY SOMEONE THAT IS MECHANICALLY INCLINED. MY 2009 F-150 CURRENTLY HAS THIS SAME ISSUE. EVIDENCE THAT THIS HAS BEEN A CONSISTENT PROBLEM FOR ALMOST A DECADE: SERVICE BULLETIN NO.: 17320 COMPONENT(S): ENGINE AND ENGINE COOLING NHTSA ID NUMBER: 10008169

Mileage: 113,500

EXHAUST MANIFOLD LEAK DUE TO BROKEN EXHAUST MANIFOLD TO HEAD BOLTS. ON COLD START THERE IS A MODERATELY LOUD EXHAUST LEAK THAT DIMINISHES AS THE ENGINE HEATS UP. VEHICLE WAS STATIONARY AND PARKED WHEN FIRST NOTICED.

Mileage: 81,000

TL* THE CONTACT OWNS A 2009 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED. THE FAILURE RECURRED ON ONE OTHER OCCASION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE HAD CARBON BUILD UP. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,250.

Mileage: 50,250

COMING HOME, SOMETHING LET LOSE UNDER THE HOOD AND WAS TINKING. ENDED UP HAVING IT TOWED HOME WHERE WE FOUND OUT THE SPARK PLUG EJECTED. CALLED THE DEALERSHIP AS I JUST BOUGHT MY TRUCK 2 MONTHS AGO, THEY COULDN'T DO ANYTHING. CALLED FORD CORP THEY WOULDN'T GIVE ME ANY INFORMATION. AFTER DOING RESEARCH I FOUND THIS WAS A TBS. I CALLED A FORD DEALER TO SEE WHAT TO DO. HE TOLD ME IT WOULD HAVE TO BE FIXED AT MY EXPENSE. TOOK IT TO A GARAGE WHERE THEY FIGURED THE SPARK PLUG EJECTED AND RUINED A FEW OTHER PARTS THAT NEEDED TO BE REPLACED. AFTER A WEEK LATER I HAVE MY TRUCK BACK. NOT SURE HOW MUCH IT COST YET, THE BILL IS IN THE MAIL ONCE HE FIGURES IT OUT!

Mileage: 73,538

WHILE DRIVING IN A PARKING LOT AT SPEED BELOW 5 MPH, THE ENGINE BEGAN TO SHAKE AND CHATTER. THE SOUND AND VIBRATION WENT AWAY AT SPEEDS ABOVE 5 MPH. I WAS ABLE TO DUPLICATE THE PROBLEM REPEATEDLY. THE LOCAL DEALER SAID IT WAS THE CAM PHASER, AND THEY NEEDED TO BE REPLACED. THIS 2009 TRUCK WAS ASSEMBLED IN NOVEMBER OF 2008. TRUCK WAS PURCHASED USED WITH 36000 MILES IN NOVEMBER OF 2014. CAM PHASERS REPLACED AT 43800 MILES.

Mileage: 43,000

PURCHASED THIS VEHICLE USED FROM A WELL KNOWN AND POPULAR DEALER IN UTAH. WE DID NOT NOTE ANY NOISES DURING THE TEST RIDE AND VEHICLE APPEARED IN GREAT CONDITION. ON THE DRIVE HOME (OF COURSE) WE STOPPED FOR DINNER. NOTICED A LOUD KNOCKING NOISE COMING FROM THE ENGINE. THIS CONTINUED AND WORSENED AND WE FEARED THE VEHICLE WOULD STALL. THE PROBLEM SUBSIDED WHEN THE RPM'S INCREASED SLIGHTLY. WE WERE ABLE TO DUPLICATE THE PROBLEM REPEATABLE IN A PARKING LOT AT LOW SPEEDS AND LOW RPMS. SPECIFICALLY WHEN TURNING LEFT AND THE PROBLEM WORSENED WHEN THE 4X4 WAS SELECTED. I VIDEO TAPED THE ENGINE NOISE AS PROOF FOR THE DEALERSHIP. DOING RESEARCH WE HAVE NOTED THAT THIS IS A COMMON PROBLEM WITH THE 2009 F150 5.4 L. RANGE OF PROBLEMS DESCRIBED AS EITHER CAM PHASER OR INTERNAL ENGINE PROBLEM. CORRECTIONS HAVE BEEN NOTED AS EITHER CAM PHASER REPLACEMENTS (NOT VERY HELPFUL) OR FULL ENGINE REPLACEMENT. TAKING THE VEHICLE BACK TO THE DEALER THIS MORNING TO RETURN.

Mileage: 87,024

2009 FORD F150 HAS BEEN SHAKING AT IDLE OR WHEN GOING SLOW WHEN VEHICLE IS NOT IN PARK. IT SHAKES AND JERKS TERRIBLY BAD. IT HAS CAUSED ME TO STALL AT A STOP LIGHT WAITING FOR THE LIGHT TO TURN GREEN AND I'VE NEARLY BEEN HIT IN THE REAR MULTIPLE TIMES AND THIS IS NOT COUNTING THE ROAD RAGE PEOPLE HAVE WHEN THIS HAPPENS. TOOK IT TO A SHOP AND WAS TOLD IT WAS A CAM PHASER. FOUND OUT THIS IS A COMMON PROBLEM WITH FORD'S 5.4 BUT FORD ISN'T DOING ANYTHING ABOUT IT. I GUESS IF YOU JUST GET RAN INTO AND NOT KILLED FROM SOMETHING THEN IT'S NOT SERIOUS ENOUGH TO OWN UP TO IT AND ISSUE A RECALL? THIS IS RIDICULOUS AND DANGEROUS!! BESIDES NOT HAVING $4K TO FIX IT I'VE ALSO BEEN TOLD THAT IT OFTEN REQUIRES YOU TO GET A NEW ENGINE. IF I DON'T HAVE $4K I DEFINITELY DON'T HAVE $8K FOR A NEW ENGINE. SOMEONE NEEDS TO HELP US PLEASE!!!

Mileage: 130,475

SPARK PLUG BLOWOUT IN RUSH HOUR TRAFFIC. *TR

Mileage: 73,574

ENGINE BEGAN TO SHAKE AT 65MPH. PULLED OVER AND ENGINE WAS SHOT. POSSIBLE CAM PHASERS. *TR

Mileage: 74,985

AFTER ACCELERATING TO PASS ON THE HIGHWAY (65 MPH TO 70 MPH), THE TRUCK REMAINED GOING 70 MPH WHEN ACCELERATOR RELEASED. VEHICLE COULD BE SLOWED WITH DIFFICULTY BY APPLYING BRAKES, BUT WOULD RESUME SPEED WHEN BRAKES RELEASED. FORTUNATELY, TRAFFIC WAS LIGHT. CRUISE CONTROL WAS NOT BEING USED AT TIME OF INCIDENT. ATTEMPTED TO RESOLVE ISSUE FOR APPROXIMATELY 4 MILES/MINUTES AT HIGHWAY SPEEDS (DETERMINED ACCELERATOR NOT STUCK ON FLOOR MAT, ENGAGED AND DISENGAGED CRUISE CONTROL, BRAKED REPEATEDLY WHILE MAKING SURE I WAS ALSO NOT HITTING THE ACCELERATOR). EVENTUALLY SLOWED VEHICLE TO APPROXIMATELY 10 MPH WITH EXTREME BRAKING ON AN UPHILL INCLINE, AT WHICH POINT VEHICLE WOULD NOT SLOW ANY FURTHER. TOOK TRUCK OUT OF GEAR AND SHUT OFF ENGINE (VEHICLE STOPPED). HAD TOWED TO SERVICE DEPARTMENT OF FORD DEALER WHO "COULD NOT REPRODUCE PROBLEM" BUT REPLACED ELECTRIC THROTTLE BODY ASSEMBLY AND CLEARED/REPROGRAMMED COMPUTER. WHEN ASKED IF INCIDENTS SUCH AS THESE ARE REPORTED TO FORD FOR THEIR DATABASE, THE SERVICE REPRESENTATIVE SAID NO, THAT THEY HAD NO MEANS TO DO SO. *TR

Mileage: 153,080

TL* THE CONTACT OWNS A 2009 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS RESTARTED AFTER ONE HOUR AND OPERATED NORMALLY HOWEVER, THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS TAKEN TO A DEALER BUT THEY WERE UNABLE TO DETECT A TROUBLE CODE OR DIAGNOSE THE PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 71,000.

Mileage: 71,000

APPROACHING AN YELLOW LIGHT AT APPROXIMATELY 35 MPH I HIT THE GAS PEDAL HARD FOR PASSING GEAR. THE ACCELERATOR STUCK, THE ENGINE ROARING, I HAD TO STEP AS HARD AS POSSIBLE TO STOP THE TRUCK SO I WOULD NOT HIT THE VEHICLE IN FRONT OF ME. ENGINE WOULD NOT STOP ACCELERATING FORCING ME TO TURN OFF THE TRUCK. SHOCKED, I SAT IN TRAFFIC FOR A MOMENT BEFORE I RESTARTED THE ENGINE, BUT IT IMMEDIATELY WENT TO FULL SPEED AGAIN, FORCING ME TO AGAIN TURN OFF THE ENGINE. MY FRIEND CLIMBED OUT AND PUSHED ME OUT OF TRAFFIC. AFTER SITTING IN A PARKING LOT FOR ABOUT 5 MINUTES I AGAIN STARTED THE ENGINE AND IT STARTED NORMALLY. *JS

Mileage: 66,700

I WAS ON THE HIGHWAY AND WHEN I ATTEMPTED TO PASS A VEHICLE,WHEN I FLOORED THE GAS PEDAL THE TRUCK LOST ALL POWER FOR 3 TO 5 SECONDS ALMOST CAUSING AN ACCIDENT. IT HAS BEEN THAT WAY FROM THE DAY I BOUGHT IT UNTIL PRESENT. WHEN I QUESTIONED THE DEALER ON THE LOSE OF POWER PROBLEM I WAS TOLD NOTHING CAN BE DONE ABOUT IT BECAUSE IT IS A NORMAL ISSUE WITH FLY BY WIRE ACCELERATOR. *TR

Mileage: 500

NO PROBLEMS UNTIL ABOUT 60,000 MILES. THEN ONE DAY, WHILE STOPPED, THE TRUCK SUDDENLY DIED, THE CHECK ENGINE LIGHT CAME ON, AND THE GAS GAUGE WOULD INDICATED A QUARTER TANK WHEN THE TANK WAS ACTUALLY FULL. ALL OF THIS HAPPENED AT THE SAME TIME. I HAD TWO OXYGEN SENSORS REPLACED (ABOUT $400) TO CLEAR THE CHECK ENGINE LIGHT AND THE FUEL PUMP REPLACED (ABOUT $700) ON THE RECOMMENDATION OF THE FORD SERVICE DEPARTMENT TO CURE THE GAS GAUGE PROBLEM. WHILE TURNING ACROSS ONCOMING TRAFFIC, THE VEHICLE HAS DIED AND WAS HARD TO STEER. ONCOMING CARS HAD TO BRAKE RAPIDLY AS I HAVE HAD A HARD TIME STEERING WITH NO POWER. THIS HAS NOW HAPPENED NUMEROUS TIMES. THE TRUCK DIES OR RUNS VERY ROUGH AND NEARLY STALLS ALMOST EVERY TIME I DRIVE IT MORE THAN A MILE OR SO. THERE IS NO CHECK ENGINE CODE AND THE DEALER STATED IT COULD NOT BE DUPLICATED WHEN I TOOK IT IN FOR EVALUATION. THIS HAS THE POTENTIAL FOR CREATING A DANGEROUS SITUATION. I WOULD FIX THIS ISSUE IF IT COULD BE IDENTIFIED. *TR

Mileage: 60,000

DROPPED OFF VEHICLE WITH FORD DEALERSHIP SERVICE ADVISER AND PROCEEDED TO WAITING AREA. VEHICLE HAD A STEADY YELLOW ENGINE LIGHT INDICATING SERVICE IS REQUIRED. FIVE MINUTES LATER, LOUD ENGINE RACING NOISE, TIRES SQUEALING AND CRASH IMPACT SOUND FROM SERVICE BAY AREA. KNOWING IT WAS MY TRUCK, I WENT OUT TO THE SERVICE BAY TO SEE IT SLAMMED THROUGH THE FAR STONE WALL, ABOUT 75 FEET FROM THE SERVICE DESK. HYDRAULIC FLUID WAS ALL OVER THE FLOOR, OUTSIDE AND INSIDE OF THE TRUCK. SERVICE ADVISER WAS STUNNED AND CRAWLED OUT OF VEHICLE CLAIMING IT SUDDENLY ACCELERATED AND HE COULD NOT PUT THE VEHICLE INTO NEUTRAL OR PARK AS THE ENGINE RACED AT FULL RPM. SERVICE ADVISER WAS SENT TO HOSPITAL. FORD SERVICE MANAGER WAS CONCERNED AND AGREED TO CHECK ENGINE CODES, HE TALKED LIKE HE'D SEEN THIS HAPPEN BEFORE. ALL SERVICE ENGINEERS WERE CONCERNED ABOUT SPONTANEOUS ACCELERATION THEY ALL WITNESSED AS THE TRUCK MIRACULOUSLY BARRELED THROUGH THE SERVICE BAYS WITHOUT HITTING ANY OF THE WORKERS. LATER IN THE DAY, I RETURNED TO CHECK STATUS AND EVERYONE AT DEALERSHIP CHANGED THEIR STORY. THEY WILL NOT TELL ME WHY THE TRUCK ACCELERATED LIKE IT DID, BUT WILL NOT ADMIT THERE WAS HUMAN ERROR EITHER. *TR

Mileage: 37,009

TL* THE CONTACT OWNS A 2009 FORD F150. THE CONTACT STATED THAT AFTER STARTING THE ENGINE, THERE WAS A LOUD, ABNORMAL NOISE EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGE WAS 59,000.

Mileage: 59,000

WHILE DRIVING THE VEHICLE ENGINE LOST ALL POWER AND WHEN I PULLED OVER TO THE SIDE OF THE ROAD THE ENGINE DIED. TRIED RESTARTING THE ENGINE MULTIPLE TIMES, AND IT WOULD START BUT ONLY RUN FOR A FEW SECONDS AND THEN DIE. HAD IT TOWED TO THE LOCAL FORD DEALER AND THEY COULD NOT REPLICATE THE PROBLEM. HAVE HAD THE SAME ISSUE 4 MORE TIMES SINCE THEN. VEHICLE ENGINE DIES BUT THE LAST FEW TIMES HAS RESTARTED. TOOK IT INTO THE LOCAL FORD DEALER AGAIN AND AGAIN THEY COULD NOT REPLICATE THE PROBLEM. *TR

Mileage: 37,000