2000 FORD F-250 SD Engine And Engine Cooling Problems

I WAS TRAVELING ON I-90 IN ERIE,PA AND A SPARK PLUG BLEW OUT OF THE MOTOR. I LOST ALL POWER AND WAS NEARLY HIT FROM BEHIND. THE TRUCK IS A FORD F-250 WITH A TRITAN 5.4 L MOTOR. *TR

Mileage: 89,000

MY YEAR 2000 FORD F-250 TRUCK BURST INTO FLAMES IN MY DRIVEWAY TODAY AN HOUR AND A HALF AFTER I PARKED IT. IT'S A TOTAL LOSS. *TR

Mileage: 107,000

TL* THE CONTACT OWNS A 2000 FORD F-250 SD. THE CONTACT WAS DRIVING 40 MPH WHEN THE SPARK PLUGS DISCONNECTED FROM THE ENGINE. THE VEHICLE WAS INSPECTED BY THE DEALER WHO DRILLED INTO THE ENGINE AND REPLACED THE SPARK PLUGS BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THERE WERE NO FURTHER REPAIRS. THE FAILURE MILEAGE WAS 103,000 AND THE CURRENT MILEAGE WAS 103,050. THE VIN WAS UNAVAILABLE.

Mileage: 103,050

THERE WERE NO PARTICULAR EVENTS LEADING UP TO THE FAILURE. WHEN STARTING THE VEHICLE ENGINE, THE ENGINE WILL NOT KEEP RUNNING ON ITS OWN. TO KEEP THE ENGINE RUNNING LIGHT PRESSURE MUST BE APPLIED TO THE ACCELERATOR TO MAINTAIN AN 800 TO 1000 RPM. THE VEHICLE CAN BE DRIVEN, HOWEVER, THE LEFT FOOT MUST BE USED FOR BRAKING SINCE THE RIGHT FOOT MUST BE USED TO KEEP CONTINUOUS PRESSURE ON THE ACCELERATOR TO PREVENT THE ENGINE FROM STALLING. THE ACCELERATOR ISSUE WILL SOMETIMES CORRECT ITSELF AFTER THE ENGINE HAS BEEN RUNNING FOR A PERIOD OF TIME AFTER STARTUP, HOWEVER, IN MOST CASES THIS PRESENTS A DANGEROUS SITUATION. WHEN THE ENGINE IDLE CORRECTS ITSELF, THE RPMS WILL TAKE A +1000 RPM JUMP FROM THE CURRENT RPM POSITION. FOR EXAMPLE, IF YOU ARE STOPPED AT A STOP LIGHT ONLY A FEW FEET FROM THE CAR IN FRONT OF YOU WITH LIGHT PRESSURE ON THE BRAKE, THE JUMP FROM 1000 RPM TO 2000 RPM MAY SEND THE VEHICLE LURCHING FORWARD REAR-ENDING THE VEHICLE IN FRONT OF YOU IF YOU DO NOT SLAM ON THE BRAKES QUICKLY! ANOTHER SITUATION THAT HAS ALSO CAUSED A "CLOSE CALL" IS WHEN DRIVING THE VEHICLE 5 MPH AT 1000 RPM IN A PARKING LOT. THE REASON THIS SITUATION IS EVEN MORE DANGEROUS IS DUE TO THE FACT THAT THE BRAKE IS TYPICALLY NOT BEING APPLIED AT ALL, SO WHEN THE +1000 RPM JUMP TO 2000 RPMS OCCURS IT CAN SEND YOUR VEHICLE LURCHING FORWARD INTO ANOTHER VEHICLE OR PEDESTRIAN THAT IS CROSSING IN FRONT OF THE VEHICLE. I ATTEMPTED TO FIX THE FAILURE BY REMOVING THE AIR BREATHER ASSEMBLY AND CLEANING THE INTAKE THROAT WITH CARBARATOR CLEANER, HOWEVER, THIS DID NOT RESOLVE THE FAILURE. *TR

Mileage: 117,000

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

Mileage: 114,000

SPARK PLUG EJECTION IN MY 2000 FORD F250 5.4L ENGINE. THIS IS THE 3RD TIME IN 2 YEARS THIS HAS HAPPENED. IT IS MY UNDERSTANDING THIS IS COMMON WITH THESE ENGINES AND THERE ARE NO RECALLS BY FORD MOTORS. BEFORE THE SPARK PLUG IS EJECTED, THERE IS A LOUD TAPPING SOUND FOLLOWED BY THE EJECTION SHORTLY THEREAFTER. THIS IS A SERIOUS ISSUE BECAUSE FUEL ESCAPES FROM THE HOLE AND CAN BE IGNITED BY THE SPARK PLUG THAT IS STILL ATTACHED TO THE COIL PACK AND FIRING. THIS CAN CAUSE AN ENGINE FIRE AND WORSE. FORD SHOULD BACK UP THEIR PRODUCT AND FIX THIS ISSUE. *TR

Mileage: 115,000

2000 FORD F-250 6.8L ENGINE BLEW SPARK PLUG OUT OF HEAD AT 73,300 MILES. *TR

Mileage: 73,300

2000 FORD F250 V10 SPARK PLUG BLEW OUT OF HEAD, THREADS ARE STRIPPED. *TR

Mileage: 101,247

MY 2000 FORD F250 TRUCK QUIT IN THE MIDDLE OF A BUSY STREET IN MY TOWN. THERE WAS A RECALL FOR A CAM POSITION SENSOR BUT DID NOT HAVE IT REPLACED YET. I DID HAVE SPARE AND REPLACED IT MYSELF. IT DID FIX THE PROBLEM. ALSO HAD A FRIEND RESET THE CHECK ENGINE LIGHT. *TR

Mileage: 128,400

DRIVING TO WORK YESTERDAY EVENING I STOPPED TO GAS UP. AFTER FUELING THE TRUCK I STARTED THE ENGINE AND HEARD A LOUD POP FOLLOWED BY LOUD ENGINE NOISE. I SHUT DOWN THE ENGINE TO INVESTIGATE AND FOUND THE SPARK PLUG FROM THE SECOND CYLINDER ON THE PASSENGER SIDE EJECTED DESTROYING THE COIL IN THE PROCESS. I HAVE YET TO REPAIR THE PROBLEM AND HAVE CONCERNS THAT IT WILL HAPPEN AGAIN. *TR

Mileage: 99,450

LAST YEAR ABOUT SEPT 08...MY 2000 F-250 10 CYLINDER P-UP STARTED VERY ROUGH-LIKE. IT WOULD NOT DO 50 MPH ANYMORE AS OF THAT SAME DATE. I TOOK IT TO GOOD-YEAR AND TO TWO OTHER GARAGES FOR ESTIMATES AS TO WHAT WENT WRONG. THE 10TH VALVE HAD STUCK. I TOOK IT TO THE DEALER AND THEY CHARGED ME 4,000 DOLLARS TO DO A VALVE JOB. THE TRUCK ONLY HAD 49K MILES ON IT. THE ENTIRE REAR OF THE ENGINE REQUIRED ALL NEW PLUGS AND WIRES. *TR

Mileage: 49,761

I WAS DRIVING MY FORD F250 WITH THE 5.4 TRITON V8 GAS ENGINE DOWN THE ROAD WHEN IT SOUNDED AS IF THE ENGINE HAD BLOWN. UPON INVESTIGATION AT A LOCAL REPAIR SHOP IT WAS DETERMINED THE LEFT REAR SPARK PLUG HAD BLOWN OUT OF THE CYLINDER HEAD. THE COST FOR THE REPAIR WAS QUOTED BETWEEN $300 TO $3000 PENDING ON HOW BAD THE DAMAGE WAS TO THE SPARK PLUG THREADS. IT IS CURRENTLY PARKED UNTIL THE REPAIR CAN BE MADE. *TR

Mileage: 118,000

I OWN A 2000 FORD F-250 POWERSTROKE 7.3 LITER TRUCK THAT WAS RECALLED FOR A CAMSHAFT POSITION SENSOR THAT FAILS INTERMITTENTLY. IT WILL LEAVE THE TRUCK NOT RUNNING, AND CAN RESULT IN NOT HAVING POWERSTEERING OR BRAKES. I HAD THE SENSOR REPLACED AND MY BIGGEST COMPLAINT IS THAT IT MADE MY TRUCK RUN WORSE. IT NOW HAS A MISFIRE THAT IS DIRECTLY ATTRIBUTED TO THE 'NEW' IMPROVED SENSOR. I AM NOT PLEASED AND WOULD LIKE SOME ACTION. *TR

Mileage: 105,000

OWNER OF A 2000 FORD F250 WANTS TO BE REIMBURSED FOR REPLACING THE CAMSHAFT POSITION SENSOR UNDER RECALL 07S57. *NJ THE CONSUMER STATED HE HAD TO REPLACE THE CAMSHAFT POSITION SENSOR TWICE. *JB

TL*THE CONTACT OWNS A 2000 FORD F-250 SUPERDUTY. WHILE DRIVING 40 MPH, THE ENGINE SHUT OFF AND THE VEHICLE CONTINUED TO ROLL. THE DRIVER ATTEMPTED TO DEPRESS THE BRAKE PEDAL TO STOP THE VEHICLE, BUT IT WOULD NOT STOP. THE VEHICLE FINALLY ROLLED TO A STOP IN THE GRASS WITHOUT A CRASH. THE VEHICLE WAS VERY HOT AND FLAMES WERE NOTICED COMING FROM THE FRONT OF THE VEHICLE, DIRECTLY UNDER THE ENGINE. THE FIRE DEPARTMENT ARRIVED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS BURNED FROM THE TIRES TO THE WINDSHIELD AND DASHBOARD. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V553000 (ENGINE AND ENGINE COOLING:ENGINE:DIESEL). THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 160,000. UPDATED 03/18/09. *LJ UPDATED 03/18/09.*JB

Mileage: 160,000

WHILE DRIVING 65 MPH ON THE FREEWAY, THE SPARK PLUG BLEW OUT OF THE ENGINE. NOW I AM LOOKING FOR A WAY TO REPAIR THIS. THERE IS NO WAY TO PUT AN NEW SPARK PLUG IN THE VEHICLE. I RESEARCHED THIS PROBLEM ONLINE AND SEEMS TO BE A BIG PROBLEM WITH FORD VEHICLES. *TR

Mileage: 80,001

FORD 5.4L SPARK PLUGS. I JUST EXPERIENCED MY THIRD BLOWOUT. LUCKILY, I WAS CLOSE TO HOME AND DID UNPLUG THE FUEL INJECTOR. SOMEONE LESS KNOWLEDGEABLE MAY HAVE DRIVEN THEIR VEHICLE AND WITH UNBURNED GASOLINE PUMPING ONTO A HOT ENGINE, WITH THE BLOWNOUT SPARK PLUG NEAR BY, THUS CAUSING A FIRE, OR WORSE AN EXPLOSION. IT IS MY RECOMMENDATION THAT FORD BE REQUIRED TO REPLACE THE CYLINDER HEADS ON THE DEFECTIVE VEHICLES, AT THEIR EXPENSE, WITH THEIR NEWLY REDESIGNED CYLINDER HEADS. IF THE CYLINDER HEADS WERE NOT DEFECTIVE, THEY WOULD NOT HAVE REDESIGNED THEM!!! DOES SOMEONE NEED TO DIE IN A SERIOUS AUTOMOBILE FIRE, BEFORE THEY ARE FORCED TO RECTIFY THEIR PROBLEM? IF THEY CAN ASK THE FEDERAL GOVERNMENT TO BAIL THEM OUT, THEY CAN STEP UP AND TAKE CARE OF THE MESS THEY HAVE CREATED. *TR

MY 2000 F-250 V-10 PICKUP HAS ONLY 53K MILES. IT SUDDENLY STARTED RUNNING VERY ROUGH THIS WEEK. I TOOK IT TO THREE SHOPS AND PAID FOR DIAGNOSTICS. ALL THREE GAVE ME DIFFERENT REPORTS STATING THAT THE ENGINE IS BLOWN. I CALLED THE DEALER AND FOMOCO IN DETROIT. I WAS TOLD THAT I AM UP THE CREEK...LITERALLY. THE REPAIR IS TOO COSTLY FOR ME AND I CAN'T AFFORD A NEW TRUCK AS THIS PILE COST ME ALMOST 18K INCLUDING FINANCE CHARGES. MY WARRANTY WAS UP LAST YEAR AS I BOUGHT THE 100K EXT WARR. I GOOGLED THE V-10 F-250 AND FOUND MANY COMPLAINTS INVOLVING COIL PACK PROBLEMS AS THE ROOT OF THIS ENGINE'S BLOWING. THE COIL PACKS ARE NOT THE PROBLEM, BUT INDEED CAUSE FOR US CONSUMERS TO GO TO THE DEALER WHERE THEY BILK THOUSANDS OUT OF US SINCE THESE ENGINES BLOW VERY EASILY. *TR

Mileage: 53,084

FORD 250 TRUCK 5.4L TRITON ENGINE WHILE DRIVING THE SPARK PLUG BLEW OUT OF THE ENGINE. *TR

Mileage: 164,000

ENGINE SPARK PLUG EJECTION IN 200 F250 V-10 ENGINES. DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE. DEALER ALSO NOTED A LETTER FROM FORD STATING NOT TO ATTEMPT TO REPAIR BUT REPLACE HEAD ON ENGINE. THIS IS A EXTREME PROBLEMS NOTING FORD ACKNOWLEDGES THE DESIGN FLAW AND NEEDS REPLACING WITH NEWER DESIGN THAT HAS A LONGER THREAD FOR THE SPARK PLUG. GAS SPEWS ON THE ENGINE WHEN SPARK PLUG EJECTS WHICH IN TURNS CAUSES A FIRE HAZARD. DOES IT TAKE A DEATH OR AN ENGINE TO CATCH FIRE FOR SOMEONE TO NOTICE A PROBLEM????? MY HUSBAND PULLED OVER AS SOON AS HE NOTICED THE SOUND AND THE SMELL OF GAS. IT WAS A GOOD THING THAT WE WERE NOT PULLING A TRAILER OR ON AN INTERSTATE AT THE TIME OF THE INCIDENT. *TR

Mileage: 90,777

BLOWN OUT SPARK PLUG. *TR

Mileage: 142,000

MY 2000 FORD F-250 WITH A TRITON V-10 MOTOR IS BLOWING SPARK PLUGS. IT HAS BLOWN 5 SPARK PLUGS NOW OVER THE LAST 6 MONTHS OR SO, AND THIS IS ON A MOTOR INSTALLED BY FORD. SO IF THERE CLAIM OF IMPROPER TORQUE IS TRUE THEN IT WAS THEM WHO IS TO BLAME. I ALSO READ MANY CONSUMER REPORTS SAYING MANY FORD MODEL ENGINES DO THIS FROM 2000 TO 2004. IT IS VERY UNSAFE, FUEL STILL KEEPS PUMPING EVEN WHEN THE SPARK PLUG IS GONE. YOU CAN SMELL THE FULE COMING OUT VERY STRONGLY AND FIRES HAVE OCCURED UNDER THE HOOD DUE TO THIS DANGEROUS SITUATION. *CN

MY 2000 FORD F-250 WITH A TRITON V-10 MOTOR IS BLOWING SPARK PLUGS. IT HAS BLOWN 5 SPARK PLUGS NOW OVER THE LAST 6 MONTHS OR SO, AND THIS IS ON A MOTOR INSTALLED BY FORD. SO IF THERE CLAIM OF IMPROPER TORQUE IS TRUE THEN IT WAS THEM WHO IS TO BLAME. I ALSO READ MANY CONSUMER REPORTS SAYING MANY FORD MODEL ENGINES DO THIS FROM 2000 TO 2004. IT IS VERY UNSAFE, FUEL STILL KEEPS PUMPING EVEN WHEN THE SPARK PLUG IS GONE. YOU CAN SMELL THE FULE COMING OUT VERY STRONGLY AND FIRES HAVE OCCURED UNDER THE HOOD DUE TO THIS DANGEROUS SITUATION. *CN

I HAVE BEEN HAVING A STALLING ISSUE WITH MY 2000 FORD SD 7.3 SINCE I BOUGHT THE TRUCK THIS SUMMER. I HAVE BROUGHT THE TRUCK INTO THE DEALER FOR THIS PROBLEM 2 TIMES. THE RECALL WAS DONE ON THE CPS ON DEC 18TH 2007, AND IT IS STILL STALLING. AS FAR AS I CAN TELL, FORD HAS NO IDEA WHY THIS IS HAPPENING. THE TRUCK SEEMS TO RUN PERFECTLY NORMAL AND IT JUST STALLS LIKE YOU SHUT THE KEY OFF. AND SOMETIMES IT STALLS AND WILL COME BACK QUICK ENOUGH TO STAY RUNNING. WHEN THIS HAPPENS THE SES LIGHT AND THE WAIT LIGHT COME ON AND THEN GO OUT LIKE NOTHING HAPPENED. *TR

Mileage: 91,000

DRIVING AT 50 MPH TRUCK STALLED GOT OFF ROAD RESTARTED WAS OK FOR 3 WEEKS, DID SAME THING ,WAS OK FOR 1 WEEK, DID SAME THING. TOOK TRUCK TO FORD THEY REPLACED CAMSHAFT POSITION SENSOR. *TR

Mileage: 216,000

WHILE ON THE WAY HOME FROM VACATION ON 9/18/07 (TOWING MY 32 FOOT FIFTH-WHEEL) MY FORD F-250 DIESEL (7.3 LITER) STARTED ACTING AS IF THE REAR-END WAS SLIPPING. THE CHECK ENGINE LIGHT CAME ON AND THEN THE ENGINE STALLED. LUCKILY I WAS IN A CONSTRUCTION AREA AT THE TIME AND THE SPEED LIMIT WAS ONLY 35 MPH. I PULLED OVER AND HAD TO BE TOWED TO A FORD DEALER 10 MILES BACK. TRI STAR OF SOMERSET, PA ( WHICH IS A FORD DEALER) DETERMINED THE PROBLEM WAS THE CAM SHAFT SENSOR. IT COST $243.00 FOR REPAIR AND REPLACEMENT OF SENSOR (WHICH TOOK 8 DAYS DUE TO WORK LOAD BACKUP). IT COST ME $200.00 TO HAVE MY RV TOWED TO A LOCAL CAMPGROUND (WHICH I NO LONGER HAVE A RECEIPT FOR). IT COST ANOTHER $180.00 TO KEEP RV AT CAMPGROUND UNTIL REPAIRS TO TRUCK WERE COMPLETED. IN ADDITION TO THIS, IT COST $225.68 TO RENT A CAR FROM TRI STAR TO CONTINUE 200 MILES HOME TO WAIT UNTIL TRUCK WAS REPAIRED. TODAY I READ IN THE PAPER THAT THERE IS A RECALL ON 1997 THROUGH 2003 FORD SUPERDUTY TRUCKS. HOWEVER, MY F-250 IS NOT AMONG THE RECALLS (FORD/ E-SERIES, EXCURSION, F-450 SUPERDUTY, F-550 SUPERDUTY. OLD PART WAS KEPT BY TRI STAR BUT I STILL HAVE THE RECEIPTS DATED 25SEPT07. WHAT RECOURSE DO I HAVE? P.S. LUCKILY A STATE PATROL OFFICER HAPPENED BY WHEN THIS OCCURRED AND ASSISTED ME IN CONTACTING A TOW TRUCK CO. *TR

Mileage: 113,926

CAM POSITION SENSOR FAILED ON A 2000 FORD F250 W/7.3L POWERSTROKE DIESEL ENGINE. THIS IS THE 4TH CPS I'VE HAD IN THIS TRUCK. THE TRUCK HAS 60K MILES. *TR

Mileage: 60,000

CAMSHAFT POSITION SENSOR FAILURE AT HIGHWAY SPEED RESULTING IN ENGINE SHUTDOWN/ NO POWER STEERING OR POWER BRAKES/ WAS ABLE TO PULL OFF THE SIDE OF THE ROAD WITH ONLY MINOR TRAFFIC SLOW DOWN. *TR

Mileage: 202,000

I WAS TRAVELING DOWN HWY 174 IN SC AT AROUND 10:00 PM WHEN MY FORD F250 7.3L DIESEL TRUCK BEGAN TO KNOCK AND FINALLY SHUT OFF IN THE HIGHWAY. THE VEHICLE WOULD NOT RESTART, AND HAD TO BE TOWED BACK TO MY HOUSE, AND THEN TO RAVENEL FORD THE FOLLOWING DAY WHERE THEY DIAGNOSED THE FAILURE AS CAM POSITION SENSOR AND SAID THAT THIS WAS A COMMON OCCURRENCE AND RECOMMENDED THAT I KEEP A SPARE ONE IN THE GLOVE BOX. THE TOTAL REPAIR BILL WAS $453.42. *JB

Mileage: 100,652

I HAVE HAD TO REPLACE THE CAMSHAFT POSITION SENSOR IN MY 2000 F250 THREE TIMES NOW. THE PART COSTS OVER 140 DOLLARS AT A FORD DEALER AND I KNOW MANY MANY PEOPLE WHO HAVE HAD TO REPLACE THE SAME PART. IT IS A DESIGN FLAW AND FORD KNOWS IT. WHEN I WALKED IN THE DEALER AND SAID MY TRUCK DIED THE FIRST THING THE MECHANIC SAID WAS "OH, SOUNDS LIKE A CAMSHAFT POSITION SENSOR". THIS HAS LEFT ME STRANDED TWICE (ONCE IN THE MIDDLE OF NOWHERE ON A ROAD TRIP). *TR

Mileage: 156,000

CAMSHAFT POSITION SENSOR FAILURE CAUSED ENGINE STOP ON 2000 FORD SUPERDUTY DIESEL IN HEAVY TRAFFIC. MILEAGE WAS APPROX 125,000. REPLACEMENT OEM CPS FAILED AFTER A FURTHER 3,000 MILES! OLD PARTS ARE NOT AVAILABLE. *TR

Mileage: 125,000

CAM SHAFT POSITION SENSOR FAILED AND THE TRUCK STALLED AND HAD TO BE TOWED, NEW PART WAS REPLACED AT DEALER UNDER WARRANTY, OLD PART KEPT AT DEALER. *AK

Mileage: 22,000

WHILE ON A BACK ROAD, AT NIGHT AFTER A CAMPING TRIP WITH MY KIDS, TRUCK STUMBLED/STUTTERED. CHECK ENGINE LIGHT CAME ON. WAS ABLE TO STOP TRUCK AND THEN RESTART IT. CHECK ENGINE LIGHT WAS OFF. MADE IT HOME. NEXT DAY TRUCK WOULD TRY TO CRANK BUT WOULDN'T FIRE UP. CALLED A DIESEL MECHANIC WHO CAME OVER, PULLED CPS, WENT TO LOCAL INTERNATIONAL AND BOUGHT A NEW CPS. CHANGED OUT MINE AND TRUCK STARTED UP JUST FINE. THREW OUT THE OLD PART. *TR

Mileage: 114,000

FORD F-250 PICKUP WITH 7.3L POWERSTROKE DIESEL ENGINE. ENGINE SHUT OFF WITHOUT WARNING DUE TO FAULTY CAMSHAFT POSITIONING SENSOR (SYNCHRONIZER). ENGINE SHUT OFF CAUSED LOSS OF POWER STEERING AND BRAKES MAKING HEAVY DUTY VEHICLE DIFFICULT AND DANGEROUS TO MANEUVER IN TRAFFIC. REPLACED SENSOR TO CORRECT PROBLEM. SENSOR IS THE SAME DESIGN TO ANOTHER FAILURE IS HIGHLY POSSIBLE. *TR

Mileage: 85,937

1ST DAY OF OWNERSHIP OF 2000 F250, ENGINE INEXPLICABLY DIES, RENDERING USELESS POWER STEERING AND POWER BREAKS. TOWED TO DEALER. EXPLAINED PROBLEM TO SERVICE WRITER. WITHOUT EVEN SEEING THE VEHICLE, THE SERVICE WRITER SAYS "CAMSHAFT POSITION SENSOR." AS IT TURNS OUT, HE WAS RIGHT. PROBLEM FIXED FOR NEARLY $500 DOLLARS. *TR

Mileage: 162,000

ENGINE WOULD QUIT WHILE ON THE ROAD OR AT IDLE OUTSIDE TEMP OR ENGINE TEMP DID NOT MAKE ANY DIFFERENCE. REPLACED CAM POSITION SENSOR PROBLEM CORRECTED NEVER OCCURRED AGAIN . WHEN ENGINE QUIT WOULD RESTART. BELIEVE VERY DANGEROUS DUE TO YOU NEVER KNEW WHEN IT MIGHT QUIT. *TR

Mileage: 87,000

CAM POSITION SENSOR/SYNCHRONIZER FAILURE ON 2000 FORD F250 SUPERDUTY WITH 7.3L POWER STROKE DIESEL ENGINE @ 64477 MILES. ENGINE STOPPED RUNNING WHILE DRIVING @ 40 MILES/HOUR ON SECONDARY ROAD. LOSS OF POWER BRAKES AND STEERING. VEHICLE TOWED TO DEALER. REPLACE PART FMC F7TZ 12K073 A. TOTAL CHARGE $503.76. *JB

Mileage: 64,477

2000 FORD F-250 7.3 PSD ENGINE DIED WHILE DRIVING, LOST POWER STEERING AND BRAKING TOOK EXTRA EFFORT. PROBLEM WAS DUE TO CAMSHAFT POSITION SENSOR, REPLACED IT AT A COST OF $200 AND TRUCK IS RUNNING FINE. *JB

Mileage: 140,000

WHEN I STATED MY 2000 FORD F250 SD WITH THE 7.3 DIESEL ENGINE THE MOTOR RAN ROUGH AND WOULD NOT DEVELOP ENOUGH POWER TO MOVE. THE CHECK ENGINE LIGHT CAME ON. AFTER ALMOST AN HOUR OF IDLING THE MOTOR DEVELOPED ENOUGH POWER TO MOVE. I TOOK THE VEHICLE TO THE DEALER THE NEXT DAY AND WAS TOLD THAT THE PROBLEM WAS A DISCONNECTED/LOOSE WIRING HARNESS TO THE INJECTORS AND GLOW PLUGS. MINOR PROBLEM TILL I FOUND OUT IT WOULD TAKE ALL DAY TO FIX AND COST $675. I WAS TOLD THIS WAS A COMMON PROBLEM WITH MY TYPE VEHICLE. SO I SPENT THE MONEY AND THE DEALER INSTALLED A $17.00 PART TO LOCK THE CONNECTORS IN PLACE. THIS IS A PROBLEM THAT SHOULD NEVER HAVE HAPPENED. EVEN A FIRST YEAR ENGINEERING STUDENT OR A PERSON WITH ANY COMMON SENSE WOULD KNOW TO INSTALL A POSITIVE LOCK CONNECTOR FOR AN INTERNAL WIRING HARNESS. I'M JUST GLAD THE PROBLEM SHOWED UP WHEN STARTING AND NOT ON THE HIGHWAY GOING HIGHWAY SPEEDS WITH A HORSE TRAILER BEHIND. *NM

Mileage: 72,750

CAMSHAFT POSITIONS SENSOR FAILURE NEARLY CAUSING ACCIDENT AS TRUCK QUIT RUNNING HALFWAY THROUGH INTERSECTION. FORD CPS FAILURES ARE OFTEN AND FAIL FOR NO REASON AND WITH NO WARNING. *NM

TRUCK WAS RUNNING SLUGGISH. ON NIGHT OF OCCURRENCE, TRUCK STALLED IN HIGHWAY, RESTARTED, STALLED FOR GOOD. WAITED 2 HOURS FOR TOW TRUCK ON BUSY HIGHWAY. HAD TOWED TO FORD DEALERSHIP AND THEY REPLACED THE CAM SHAFT POSITION SENSOR FOR $430.00. I DO NOT HAVE THE OLD PART. *JB

Mileage: 69,743

MY CAMSHAFT POSITIONING SENSOR WENT OUT ON MY 2000 F250 IT SHUT OFF MY MOTOR WHEN I WAS GOING 70 MPH AND I LOST ALL POWER AND WAS VERY CLOSE TO CRASHING. IT WAS FIXED EASY WITH A NEW CPS BUT THIS SHOULD OF NEVER HAPPEN. *JB

Mileage: 120,000

1. TRUCK RUNNING CORRECTLY. 2.ENGINE STOPPED, PULLED OFF ROAD, TOW REQUIRED TO FORD, ROCKLAND MAINE . 3. CPS REPLACED, ENGINE RUNNING FINE. NHTSA ACTION #: PE06011 SYNCHRONIZER OR CMP SENSOR. *NM

Mileage: 77,100

I OWN A 2000 F250 DIESEL TRUCK. ON OCTOBER 26, 2006 AT APPROXIMATELY 12 MIDNIGHT WHILE MAKING A LEFT HAND TURN FROM A DEAD STOP, CROSSING OVER THREE LANES OF TRAFFIC TRAVELING NO FASTER THEN 10 MILES PER HOUR THE TRUCK CUT OFF HALFWAY ACROSS THE ROADWAY WITHOUT ANY PRIOR WARNING. I THEN COASTED ACROSS THE ROAD WHILE CARS PROCEEDED TO GO AROUND ME. SO AS TO DEFINE WHAT I MEAN BY CUT OFF, AND NO PRIOR WARNING, THEY ARE AS FOLLOWS: CUT OFF '' ENGINE STOPPED RUNNING COMPLETELY. I HAD LOSS CONTROL OF THE STEERING TO THE EXTENT THAT IT REQUIRED THE FULL USE OF BOTH ARMS TO BE ABLE TO EVEN TURN THE STEERING WHEEL. IT WAS AS IF I HAD TURNED THE IGNITION SWITCH TO THE POSITION JUST PRIOR TO THE KEY REMOVAL POSITION. NO PRIOR WARNING '' THE TRUCK HAD NOT SHOWN ANY HESITATION OR INCLINATION TO STOP RUNNING JUST PRIOR TO IT CUTTING OFF, NOR ANY HESITATION OR INCLINATION TO STOP RUNNING FROM THE TIME I HAD BOUGHT THE TRUCK NEW TO THE TIME OF THIS INCIDENT. MY CONCERNS. THIS INCIDENT HAPPENED AT APPROXIMATELY 12 MIDNIGHT WHEN THE ROAD HAD VERY LITTLE TRAFFIC ON IT. HAD IT HAPPENED DURING THE DAYLIGHT HOURS WHEN THE ROAD IS HEAVILY TRAVELED. IT WOULD BE MORE LIKELY THEN NOT THAT EITHER I, OR OTHERS WOULD HAVE BEEN IN AN ACCIDENT AS A RESULT OF TRYING TO AVOID ME. AN EVEN WORSE IF I HAD MY TRAILER ATTACHED TO THE TRUCK, THE REASON I PURCHASED THE TRUCK, THERE WOULD BE NO DOUBT THAT AN ACCIDENT WOULD OF ACCRUED. I HAD THE TRUCK TOWED TO A FORD SERVICE CENTER. WHERE THEY REPLACED A FAULTY CAM POSITION SENSOR THE NEXT DAY. PART # F7TZ-12K073-A. I SPENT SEVERAL HOUR READING UP ON THE CPS TODAY. THIS PROBLEM SEEMS TO BE QUITE COMMON AS SHOWN ON AUTOMOTIVE INFORMATION SYSTEMS (AIS) REPORTS, AND ELSEWHERE. ALTHOUGH OFTEN THERE ARE WARNING SIGNS ( SLUGGISH PERFORMANCE UNDER LOAD, STALLING AT IDLE ) OF A FAULTY SENSOR QUITE OFTEN THEY CAN FAIL WITHOUT ANY WARNING SIGNS. IT WAS FORTUITOUS THAT THE CPS FAILURE ON MY TRUCK HAPPENED WHEN IT DID. *NM

Mileage: 62,425

DT*: THE CONTACT STATED WHILE DRIVING 35 MPH ON A CITY STREET, THERE WAS A LOUD BANGING NOISE COMING FROM THE ENGINE COMPARTMENT FOLLOWED BY THE VEHICLE OPERATING AT A REDUCED SPEED. THE CONTACT PULLED THE VEHICLE OVER FOR INSPECTION. AFTER OPENING THE HOOD, A SINGLE SPARK PLUG WAS SITTING ATOP THE ENGINE. THE VEHICLE WAS TOWED TO THE DEALER TO AWAIT FURTHER INSPECTION. THE MANUFACTURER WAS ALERTED.

Mileage: 108,000

2000 F250 SUPER DUTY...49,000 MILES #8 SPARK PLUG BLEW OUT @ 45 MPH.. LIMPED HOME....REMOVED HEAD....CRACKED....$300.00 FOR RECONDITIONED HEAD..... GASKETS, GOOP, TOOLS,BOLTS, FIXTURES..$600.00...........ABLE TO DO WORK MYSELF..LUCKY.....HELP FROM FORD..HA HA HA.... 80,000 MILES HEAD GASKET OTHER SIDE..ALREADY HAD TOOLS AND FIXTURES.... GUESS WHO GOT STUCK OUT IN THE COLD AGAIN.. *JB

Mileage: 49,990

2000 F250 SUPER DUTY...49,000 MILES #8 SPARK PLUG BLEW OUT @ 45 MPH.. LIMPED HOME....REMOVED HEAD....CRACKED....$300.00 FOR RECONDITIONED HEAD..... GASKETS, GOOP, TOOLS,BOLTS, FIXTURES..$600.00...........ABLE TO DO WORK MYSELF..LUCKY.....HELP FROM FORD..HA HA HA.... 80,000 MILES HEAD GASKET OTHER SIDE..ALREADY HAD TOOLS AND FIXTURES.... GUESS WHO GOT STUCK OUT IN THE COLD AGAIN.. *JB

Mileage: 49,990

VEHICLE - 2000 FORD F-250 4X4 7.3L DIESEL. CAMSHAFT POSITION SENSOR (CPS) WENT OUT CAUSING VEHICLE TO STALL AND NOT START AGAIN UNTIL PART WAS REPLACED. ENGINE TURNED OFF EXITING FREEWAY GOING APPROX 65 MPH. THIS IS THE THIRD CPS THAT HAS GONE BAD ON THIS VEHICLE. FIRST AT 38,000 MILES, SECOND AT 95,000 MILE, AND THIRD AT 159,000 MILES. *NM

2000 F250 POWER STROKE WOULD SHUT OFF ENGINE AT SPEED, USUALLY AROUND 40 MPH WHILE DRIVING. LOSS OF POWER INCLUDED POWER STEERING WHICH MADE IT DIFFICULT TO MANEUVER VEHICLE OUT OF TRAFFIC. HAPPENED SEVERAL TIMES OVER THE MONTH, ONCE DETERMINED WAS NOT BAD DIESEL FUEL, I TOOK IT TO THE FORD DEALER. THEY REPLACED THE CAMSHAFT POSITION SENSOR. RESEARCHED ON WEB ABOUT PART AND SAW A LOT OF FAILURES RELATED TO PART, AND LINK TO THIS COMPLAINT PAGE FROM FORGOTTEN.COM LINK. PART F7TZ-12K073-A NO CHECK ENGINE LIGHT EVER APPEARED DURING THE MONTH, NO WARNING INDICATION FROM VEHICLE BEFORE ENGINE IS SHUT OFF WHILE AT SPEED. *JB

Mileage: 51,000

DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS ON SEVERAL OCCASIONS THE VEHICLE STALLED. THE VEHICLE WAS MANEUVERED OFF THE ROAD WITHOUT INCIDENT AND RESTARTED AFTER A FEW MINUTES. THE VEHICLE WAS DRIVEN TO THE DEALER WHERE THE CAM POSITION SENSOR WAS REPLACED. THE PROBLEM HAS NOT REOCCURRED.

Mileage: 45,000

FAILURE OF CAMSHAFT POSITION SENSOR (CPS) CAUSED ENGINE TO STALL DURING OPERATION RESULTING IN LOSS OF STEERING AND BRAKING. FORTUNATELY, IT WAS EARLY AM AND TRAFFIC WAS LIGHT ALLOWING ME TO BRING THE VEHICLE TO A STOP WITHOUT INCIDENT. NO ADVANCE WARNING OR CHECK ENGINE LIGHT. TOWED TO DEALER, CPS REPLACED AT MY EXPENSE. *JB

Mileage: 64,000

EARLY EVENING FRIDAY, FEB 18, 2005, DRIVING 2000 F250 SD PSD 7.3-LITER DIESEL @ APPROX 50 MPH, TRUCK BUCKED A COUPLE OF TIMES THEN ENGINE DIED, LOSING ALL POWER. TRUCK WAS NOSE INTO AN INTERSECTION BEFORE I WAS ABLE TO STEER IT TO A STOP. FORTUNATELY THIS DID NOT CAUSE AN ACCIDENT, AS THE AREA WAS SUBURBAN AND PEOPLE DRIVE A BIT LESS AGGRESSIVELY THAN THEY DO IN COLUMBUS, WHERE I LIVE. I CALLED AAA, HAD THE TRUCK TOWED TO DEALER. DEALER DIAGNOSED AND REPLACED CAM SENSOR ASSEMBLY: ITEM F7TZ*12K073*A SYNCHRONIZER ASY $185.91, LABOR OF $106.32, MISC CHARGES OF $7.44; SUBTOTAL 299.67, PLUS TAX OF $20.97. GRAND TOTAL OUT OF MY POCKET $320.64 FORTUNATELY I HAD AAA DELUXE; OTHERWISE THE TOWING WOULD HAVE COST ME AN ADDITIONAL $40. *NM

Mileage: 100,125

I ALSO HAVE HAD A SPARK PLUG BLOWOUT ON MY 2000 F250 V-10 ENGINE, I HAVE CONTACTED YOUR COMPANY AND HAVE BEEN OFFERED NO HELP AT ALL, NOT EVEN TO HELP GET THE TOOL I HAD TO PAY $250 FOR TO FIX YOUR DEFECT!! THERE IS NO OTHER WAY TO DESCRIBE THIS PROBLEM!! *NM

Mileage: 78,000

OWN 2000 FORD F-250 SUPER DUTY. THE CAM POSITION SENSOR HAS FAILED 3 TIMES SINCE PURCHASE OF THIS TRUCK IN DEC 2000. VERY DANGEROUS SITUATION AS ALL POWER, BRAKES-STEERING ETC. ARE NOT FUNCTIONAL WHEN THE ENGINE STALLS. ENGINE STALL WITHOUT WARNING AT HIGH AND LOW SPEEDS CREATING HAZARDOUS SITUATIONS DUE TO ALL POWER FAILURE. DEALER REPLACED UNDER WARRANTY IN 2002 APPROXIMATELY 70,000 MILES. *JB

Mileage: 70,000

MY CPS FAILED WHILE DRIVING AND THE ENGINE STALLED LEAVING ME WITH LIMITED STEERING AND BRAKING. THE TRUCK IS A FORD F-250 WITH THE 7.3 POWERSTROKE DIESEL. THE PART WAS REPLACED UNDER WARRANTY BUT I HAD TO PAY A $100 DEDUCTIBLE. *NM

Mileage: 61,435

I HAVE TWO FORD PICKUP TRUCKS WITH THE 7.3 LITER DIESEL ENGINE. BOTH OF THESE TRUCKS HAVE HAD THE CAM POSITIONS SENSOR FAIL. THE FIRST TIME THIS HAPPENED TO ME I WAS IN THE TRUCK AND IN A BANK DRIVE THROUGH WITH THE VEHICLE RUNNING. I REPLACED THE SENSOR AT THAT TIME AND THEN HAD THE REPLACEMENT SENSOR FAIL IN THE SAME VEHICLE LESS THAN 50,000 MILES LATER WHEN I WAS DRIVING THE TRUCK DOWN THE ROAD. THIS COULD OF CAUSED AN ACCIDENT AS THERE WAS NO WARNING AND THE ENGINE QUIT RUNNING LEAVING VEHICLE WITH NO POWER. I RECENTLY HAD THE SENSOR FAIL ON MY 2ND TRUCK WITH 7.3 LITER DIESEL ENGINE. THIS TRUCK WAS UNDER THE 100,000 MILE WARRANTY SO FORD IS PAYING THE PARTS ON THIS BUT I HAD THE VEHICLE IN FOR SERVICE IN DECEMBER 2005 AND THEY HOOKED THE VEHICLE UP TO A DIAGNOSTICS MACHINE TO CHECK FOR ANY ERROR CODES AND WERE NOT ALERTED OF ANY. THE SENSOR FAILED LATE IN THE DAY AND WOULD NOT ALLOW ME TO START THE VEHICLE LEAVING ME STRANDED AND REQUIRING TO BE TOWED. *JB

Mileage: 142,500

FORD F250 SUPER DUTY, WITH 83,000 MILES ON THE ENGINE. TWO SPARK PLUGS BLEW OUT. THE FIRST OCCURRED ON 12/7/05 AND THE SECOND OCCURRED ON 1/9/05. THE REPAIRS ENTAILED INSTALLING STEEL SLEEVE INSERTS INTO THE SPARK PLUG HOLES IN THE ENGINE BLOCK. *JB

Mileage: 110,000

SPARK PLUG BLOWN OUT OF CYLINDER HEAD. CYLINDER HEAD IS STRIPPED. *JB

Mileage: 69,005

I HAVE EXPERIENCED THREE SPARK PLUG BLOWOUTS ON MY FORD F-250 PICKUP TRUCK WHICH HAS A 5.4 LITER ENGINE. IT IS A 2000 MODEL. THE SPARK PLUG CAN NO LONGER BE REINSERTED DUE TO DAMAGE CAUSED BY THE EJECTION. A HEAD REPLACEMENT WAS THE ONLY REMEDY OFFERED BY THE DEALERSHIP AT A RATHER SIGNIFICANT COST TO ME FOR WHAT APPEARS TO BE A PREVALENT DEFECT. *NM

Mileage: 108,000

MY COMPLAINT IS ABOUT THE CPS (CAMSHAFT POSITION SENSOR) ON THE FORD 7.3L POWER STROKE ENGINES. IT SEEMS THAT MOST/ALL VEHICLES EQUIPPED WITH THIS SENSOR HAVE EXPERIENCED FAILURE, WHICH RESULTS IN THE VEHICLE STALLING. I BELONG TO SEVERAL FORUMS AND NEARLY EVERYONE HAS HAD A PROBLEM WITH THAT SENSOR AND IT IS "RULE OF THUMB" TO CARRY ONE IN YOUR GLOVE BOX FOR WHEN IT GOES BAD. THIS HAS BECOME SUCH A PROBLEM THAT YOU CAN NOW BUY THE SENSORS ON EBAY, PEOPLE HAVE BOUGHT THESE BY THE TRUCKLOAD TO SELL SINCE THEY KNOW OF THE PROBLEM. WHY SHOULD WE CONSUMERS HAVE TO WORRY ABOUT SUCH AN IMPORTANT COMPONENT OF THE ENGINE FAILING? WE SPEND 20-30-40K DOLLARS ON THESE VEHICLES AND CAN BE LEFT STRANDED ON THE SIDE OF THE ROAD DUE TO THIS ONE PART FAILING OVER AND OVER AGAIN. PLEASE, SOMEONE DO SOMETHING ABOUT THIS!!!*JB

Mileage: 118,850

DRIVING AT 45 MPH , I HEARD A LOUD BANG AND THE ENGINE STARTED MISSING. I STOPPED ON THE SIDE OF THE ROAD AND DISCOVERED THE BOOT ASSEMBLY & SPARK PLUG WERE MISSING. THE NEXT DAY I BOUGHT A SPARK PLUG AND A BOOT AND PUT IT BACK TOGETHER (SOMEWHAT) AND WENT BACK HOME. THIS ALL HAPPENED 200 MILES FROM HOME ON A FISHING TRIP. I CONTACTED THE DEALER AND WAS INFORMED FORD WAS NOT DOING ANY OUT OF WARRANTY SERVICE, I HAD 54687 MILES ON MY 2000 F-250 5.4 L. AFTER MANY PHONE CALLS AND HEATED DISCUSSIONS WITH THE DEALER , THEY SAID FORD WOULD PAY FOR THE PARTS IF I PAID THE LABOR ,THIS COST ME $1385.26. THIS WAS THE #5 SPARK PLUG. ON AUGUST 3, 2003 AT 57646 MILES THE #2 SPARK PLUG BLEW OUT RESULTING IN THE SAME REPAIR AS BEFORE , BUT THIS TIME THE DEALER CALLED IT A "PO7 " GOODWILL WARRANTY "GIVEN" TO ME FOR $495.00. BOTH TIMES THE RESPECTIVE HEAD WAS REPLACED. I HAD NOT TAMPERED WITH ANY OF THE SPARK PLUGS, BECAUSE IN THE OWNERS MANUAL IT STATED THE SPARK PLUGS ARE GOOD FOR 100,000 MILES. THIS VEHICLE IS MY PERSONAL VEHICLE AND NOT USED FOR ANY TYPE OF COMMERCIAL USE. *NM

Mileage: 54,687

DRIVING HOME IN MY 2000 F250 V10 GAS AND SOUNDED LIKE EXHAUST HAD BROKEN CHECKED UNDER HOOD AND FOUND SPARK PLUG HAD BLOWN OUT OF PASSENGER SIDE FOURTH PLUG FROM FRONT THIS IS THE THIRD PLUG I HAVE LOST IN 194,000 MILES FIRST WAS AT ABOUT 80,000 HAD TO BE HELICOILED SECOND WAS AT ABOUT 125,000 CAME LOOSE ? AND NOW THE THIRD TIME AT 194,000 RIPPED OUT THREADS AGAIN WHAT'S GOING ON WITH THESE FORD TRUCKS IM GETTING TIRED OF PAYING FOR THEIR POOR DESIGN. *NM

Mileage: 194,000

MY VEHICLE BLOWS SPARK PLUGS OUT OF THE ENGINE WHILE DRIVING IN EXTREME HIGH TRAFFIC PUTTING ME AND MY PASSENGERS LIVES IN DANGER. *NM

Mileage: 95,000

DT: WHILE BRAKING THE VEHICLE LURCHES FORWARD AND THEN IT SHUTS DOWN, WHICH CAUSES LIMITED STEERING AND BRAKING ABILITIES. THE CONSUMER HAS TAKEN THE VEHICLE TO THE DEALER APPROXIMATELY THREE TIMES, AND WAS TOLD THAT THEY COULDN'T DO ANYTHING ABOUT IT UNLESS THE PROBLEM OCCURRED FOR THEM. ON MAY 30, 2005 THE CONSUMER WAS DRIVING THE VEHICLE AND HAD TO BRAKE BECAUSE OF THE TRAFFIC IN FRONT OF HIM, WHEN THIS OCCURRED, THE VEHICLE LURCHED FORWARD AND THE ENGINE JUST CUT OUT, LIKE IT WAS NEVER STARTED. THIS CAUSED THE CONSUMER'S VEHICLE TO REAR END THE VEHICLE IN FRONT OF HIM. THE VEHICLE WAS TAKEN TO A BODY SHOP AND IT WAS REPAIRED. THE CONSUMER SPOKE TO FORD AND WAS TOLD THAT THERE WAS NOTHING THEY COULD DO. *AK *JB *NM PER CONSUMER, NONE OF THE ABOVE IS ACCURATE. THE CONSUMER WROTE: WHILE BRAKING, THE RPM REVVED UP, THE VEHICLE LURCHED FORWARD, THEN THE RPM DROPPED AND THE ENGINE HAD SHUT DOWN. THE CHECK ENGINE LIGHT ILLUMINATED. IT WOULD TAKE SEVERAL ATTEMPTS TO START THE VEHICLE . THIS WOULD OCCUR INTERMITTENTLY. EACH TIME THE CONSUMER HAD TAKEN THE VEHICLE IN FOR REPAIRS, THE DEALER WOULD BE UNABLE TO FIND THE PROBLEM. OTHER PROBLEMS: THE CRUISE CONTROL WAS INOPERATIVE AND THE VEHICLE WOULD DIE WHEN THE BRAKES WERE APPLIED AT TIMES. FORD RECALLED THE SAME MAKE MODEL YEARS 2003-2005. THE CONSUMER FELT THAT THE RECALL STARTED WITH HIS VEHICLE'S YEAR MAKE AND MODEL. *SC *JB

Mileage: 66,581

DRIVING HOME AT ABOUT 55MPH NOTICED A VERY BAD HESITATION IN 5.4L ENGINE AND APPARENT MISFIRE. AFTER PULLING OVER AND SHUTTING ENGINE OFF, NOTICED # 3 COIL BROKEN AND SPARKPLUG LAYING BY FUEL RAIL. SPARK PLUG SHOT OUT OF CYLINDER HEAD DUE TO POOR ENGINEERING BY FORD. 1999-2002 F250 5.4L HEADS ONLY HAVE 4 THREADS THAT HOLD SPARK PLUGS.*AK

STARTED ENGINE, HEARD POP SOUND, ENGINE SUDDENLY RAN BAD. MECHANIC SAID SPARK PLUG BLEW OUT (STRIPPED). MECHANIC SAID THIS IS COMMON FORD PROBLEM, A DEFECT, AND EXPENSIVE. *NM

Mileage: 90,000

2000 FORD F250 5.4L 3RD FROM FRONT PASSENGER SIDE SPARK PLUG SHOT OUT. STRANDED HAD TO HAVE VEHICLE TOWED. HELICOIL INSTALLED AND IS HOLDING, BUT FOR HOW LONG?*AK

Mileage: 80,250

ON MY WAY HOME FROM WORK I HEARD AN UNUSUAL NOISE EMINATING FROM UNDER THE HOOD OF MY 2000 FORD F-250 SUPER DUTY, 6.8 (V-10) TRUCK. I THOUGHT IT WAS AN XHAUST MANIFOLD LEAK. I PULLED ONTO A GRAVEL ROAD, LIFTED THE HOOD AND CLIMBED UP TO LOOK TO SEE WHAT I COULD FIND. IMAGINE MY SUPRISE TO SEE A LEFT BANK SPARK PLUG, #8 CYLINDER, LYING AGAINST THE FUEL RAIL AND THE COIL FIRING AGAINST THE HEAD. I LIMPED HOME, WONDERING ALL THE WHILE HOW MUCH FUEL WAS POURING INTO THE OIL PAN! I USED A STRONG FLASH LIGHT TO PEER INTO THE SPARK PLUG HOLE AND FOUND TO MY SUPRISE, VERY LITTLE IF ANY THREADS TO CONTIAN THE SPARK PLUG. I THEN USED A 90 DEG. PICK TO "FEEL" THE THREADS. NONE. I CALLED JOE MACHENS FORD IN COLUMBIA, MO. TO SEE IF THIS MIGHT BE A COMMON PROBLEM. THEY INFORMED ME THEY SEE QUITE A FEW OF THE 5.4 LITER CYLINDER HEADS IN FOR REPAIR AND HAD HAD ONE 6.8. THEY INFORMED ME THAT FORD HAD ISSUED A TSB FOR THE LIGHTNING WITH THE 5.4 ( I CAN SEE WHY, A COMPRESSOR ON TOP OF THE ENGINE CAN CREATE PROBLEMS) OTHER THAN THE AFORMENTIONED TSB, NO OTHERS EXIST AND FORD HAS YET TO ACKNOWLEDGE THE PROBLEM. I CHECKED FOR INFO VIA THE GOOGLE SEARCH ENGINE AND WASN'T ABLE TO FIND MUCH INFORMATION. I PROBABLY USED THE INCORRECT TERMINOLOGY. WHO KNOWS HOW MUCH OF THE ALUMNIUM THREADS WERE INGESTED INTO THE CYLINDER, WHICH IN TURN WILL CAUSE SCARRING AND OIL CONTROL PROBLEMS. I DO KNOW HOWEVER, DUE TO WHAT I WAS TOLD BY THE PERSON AT JOE MACHENS FORD IN COLUMBIA, MO., IT SEEMS AS THOUGH FORD HAS NOT PRACTICED DUE DILIGENCE AS TO FINDING A SUITABLE COST EFECTIVE REPAIR OR REPLACEMENT FOR THIS PROBLEM.*AK

Mileage: 99,500

FORD SUPER DUTY DIESEL F-250 : ENGINE CUTS OUT AND/OR DIES DURING ALL LOAD CONDITIONS. ESPECIALLY DANGEROUS WHEN PASSING CARS OR ON FREEWAY. DEALER IS UNABLE TO LOCATE PROBLEM AND "NOTHING REGISTERS ON THE COMPUTER" BEGAN IN MARCH 2003 AND CONTINUES DAILY TO THIS DAY.

FORD SUPER DUTY DIESEL F-250 : ENGINE CUTS OUT AND/OR DIES DURING ALL LOAD CONDITIONS. SERVICE ENGINE SOON LIGHT COMES ON UNDER MOST SEVERE CUT-OUTS. FORD SERVICE HAS REPEATEDLY (8 TIMES IN 2 YEARS) WORKED ON THE ISSUE ON MY TRUCK AS WELL AS OTHER OWNERS TRUCKS WITH WHOM I AM ACQUAINTED. THIS ENGINE FAILURE OCCURS APPROXIMATELY ONCE EVERY 10 MILES, AND IS VERY DANGEROUS WHEN TRYING TO ENTER A FREEWAY OR PASS ON A FM ROAD. I BELIEVE FORD DAMAGED THE ENGINE CONTROL UNIT WHEN THEY INSTALLED THEIR FORD AUTHORIZED POWER CHIP. THEY SEEM TO KEEP REPLACING LESS COSTLY COMPONENTS AND GIVING ME THE TRUCK BACK. I FEEL THEY ARE WAITING FOR MY TRUCK TO GET OUT OF THE WARRANTY PERIOD BEFORE THE REAL STORY IS TOLD. THAT WAY, I WILL BE OUT THE MONEY FOR WHAT EVER IS REALLY WRONG WITH THIS VEHICLES. OTHERS THAT I HAVE TALKED TO HAVE THE SAME ISSUE. PERHAPS ITS THE DEALERSHIP COVERING UP, BUT I WOULD NOT PUT IT PAST FORD TO BE BEHIND THIS. *JB

Mileage: 11,000

A BROKEN CLAMP ON THE LOWER HOSE CAUSED A COOLANT LEAK ON TWO OCCASIONS. NLM