2011 FORD F-250 SD Power Train Problems

WHILE TRAVELING IN THE LEFT HAND LANE ON 1-4 IN FLORIDA, WE RECEIVED A "STOP VEHICLE SAFELY NOW" WARNING AND THEN WITHIN SECONDS THE TRUCK SHUT DOWN. I WAS FORCED TO MAKE MULTIPLE, UNSAFE LANE CHANGES IN HEAVY TRAFFIC TO GET THE VEHICLE TO THE RIGHT SIDE OF THE INTERSTATE WITH WHAT POWER I HAD LEFT. MY PREGNANT WIFE AND 3 YEAR OLD SON WERE IN THE CAR WITH ME. WE WERE 3 HOURS FROM HOME AND ANY FAMILY / FRIENDS WHO COULD HELP. THE TRUCK WOULD NOT RESTART AND HAD TO BE TOWED TO A LOCAL DEALERSHIP WHICH CHARGED US $800 TO REPLACE 3 SENSORS AND GET THE TRUCK BACK ON THE ROAD. FURTHER, THEY WERE NOT ABLE TO REPAIR THE VEHICLE UNTIL THE FOLLOWING DAY, LEAVING US STRANDED IN A FOREIGN CITY. THE DEALERSHIP WAS VERY CLEAR THAT THE ISSUE WAS SIMPLY A SENSOR AND THERE IS NO REASON THE TRUCK SHOULDN'T HAVE JUST GIVEN US A CHECK ENGINE LIGHT WHICH WOULD HAVE ALLOWED US TO GET HOME. WE WERE TOLD BY THE DEALER AND SEVERAL FRIENDS WHO HAVE THE SAME MAKE AND MODEL THAT THIS IS A COMMON OCCURRENCE AND FORD HAS NO INTENTION OF FIXING THE PROBLEM. THIS COULD HAVE CAUSED AN ACCIDENT AND I AM EXTREMELY DISAPPOINTED THAT FORD WOULD KNOWINGLY PUT MY FAMILY IN DANGER. *TR

Mileage: 120,000

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT THE SPEEDOMETER FAILED TO INDICATE ACCURATE READING LEVELS. IN ADDITION, WHEN ACCELERATING FROM A STOP, THE VEHICLE JERKED. THE BRAKE PEDAL HAD TO BE DEPRESSED WITH EXCESSIVE FORCE IN ORDER TO PREVENT THE VEHICLE FROM JERKING. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE DEALER STATED THAT THE FAILURE WAS NORMAL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

I HAD A PROBLEM WITH MY 2011 F250'S TRANSMISSION. THE PROBLEM WAS COVERED UNDER TSB 11-5-19. WHEN TRYING TO ACCELERATE, THE TRANSMISSION WOULD RANDOMLY DEVELOP A PROBLEM WHICH SEEMED LIKE IT WAS TRYING TO FIND THE RIGHT GEAR. THERE WOULD BE A SEVERE LOSS OF POWER WHICH WOULD RESULT, AT TIMES, LEAVING MY VEHICLE IN TRAFFIC GOING AT A MUCH HIGHER SPEED AND CLOSING RAPIDLY FROM BEHIND. THE PROBLEM WAS RESOLVED BY DOING THE SERVICE PRESCRIBED IN THE SERVICE BULLETIN BUT I WAS NOT AWARE OF THAT BULLETIN UNTIL THE PROBLEM BECAME SEVERE. *TR

Mileage: 78,400

THE 6.7 CID DIESEL ENGINE DRIVEN VACUUM PUMP SUDDENLY BEGINS LEAKING MOTOR OIL. FAILURE OF THIS PUMP WILL AFFECT 4 WHEEL DRIVE SYSTEMS INCLUDING AUTO LOCKING HUBS AND ALL INTERIOR CLIMATE CONTROLS. LOSS OF MOTOR OIL COULD CAUSE ENGINE FAILURE. FAILURE OF 4 WHEEL DRIVE SYSTEM DURING ADVERSE WEATHER COULD RESULT IN A VEHICLE CRASH OR LOSS OF CONTROL. RESEARCH INDICATES MULTIPLE FAILURES OF THIS PART, INDICATING A SYSTEMIC FAILURE. *TR

Mileage: 78,500

TL* THE CONTACT OWNS A 2011 FORD F250 SD. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE DEF FLUID WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE NITRIC EXHAUST FILTER WAS DAMAGED AND NEEDED TO BE REPLACED. THE VEHICLE REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000. UPDATED 11/2/13*CN THE TRUCK WOULD ONLY GO TO 55 MPH AFTER 200 MILES OR SO. HE TOOK THE VEHICLE TO THE REPAIR SHOP, AND IT STOPPED ON THE WAY HOME, AFTER IT WAS REPAIRED. THE TRUCK WAS TOWED TO THE REPAIR SHOP, WHERE THEY KEPT IT FOR 10 DAYS. NOW, SMOKE EMITS FROM THE EXHAUST. THE DEALER STATED IT WAS NORMAL. UPDATED 11/5/13

Mileage: 45,000

THE 2011- CURRENT FORD F-250'S HAVE NUMEROUS KNOWN TRANSMISSION PROBLEMS WHICH CREATE SITUATIONS WHERE THE TRUCK WILL HESITATE AUTOMATIC SHIFTS BETWEEN 2ND AND 3RD GEAR. IN MY CASE IT DID SO AS I WAS PULLING ONTO A BUSY ROAD, STALLED, AND CAUSED ME TO SIT WITH NO POWER LONG ENOUGH FOR ANOTHER DRIVER TO NOT REACT QUICKLY ENOUGH AND RUN INTO ME. *TR

Mileage: 82,000

TL* THE CONTACT OWNS A 2011 FORD F-250 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE WOULD HESITATE WHEN ACCELERATING FROM A COMPLETE STOP. IN ADDITION, THE VEHICLE WOULD EXHIBIT AN ABNORMAL BUZZING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS ADVISED THAT THE PROBLEM WAS CAUSED BY UNKNOWN AFTERMARKET ADDITIONS MADE TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 22,000. UPDATED 7/9/12 *CN THE CONSUMER STATED WHEN HE NEEDED A GOOD ACCELERATION, THE ENGINE HAD A VERY BAD LAG IN ACCELERATION. THE REP AT THE DEALER STATED IT WAS PROBABLY A TURBO LOG. UPDATED 07/10/12

Mileage: 22,000

INTERMITTENTLY BETWEEN 35 MPH AND 85 MPH, THE VEHICLE WILL START TO SHUDDER FOR 5-15 SECONDS AND DURING THIS TIME, SOMETIMES WILL BE ACCOMPANIED BY LOSS OF THROTTLE. IT GENERALLY HAPPENS DURING OR SHORTLY THEREAFTER A REGEN / CLEANING EXHAUST FILTER MESSAGE APPEARS. THE "SHUDDER" COULD ALSO BE DESCRIBED AS A "LUGGING" SENSATION. AFTER CONFIRMING THIS PROBLEM WITH A VEHICLE DATA RECORDER, FORD'S RESPONSE TO MY DEALER WAS "DO NOT ATTEMPT REPAIRS AT THIS TIME, ENGINEERING IS INVESTIGATING." *TR

Mileage: 7,400

TRUCK STALLS WHEN SHIFTING FROM 2ND TO 3RD GEAR, WHEN PULLING ON TO HIGHWAY. *KB

Mileage: 204

2011 F250,CREWCAB,DIESEL, 6 SPEED AUTO TRANS - TRANSMISSION SHUDDERS AND KNOCKS, SHAKING TRUCK ,MAKES A CLUNKING SOUND WHEN TRAVELING AROUND38-40 MPH AS IF GEARS GETTING STUCK IN BETWEEN GEARS. CONCERNED THAT WHILE ON ROAD, VEHICLE MAY COME TO A COMPLETE STOP IN TRAFFIC.- ALSO TRUCK IS A SHORT BED THAT CAME WITH THE FACTORY TOWING PACKAGE ,FIFTH WHEEL /GOOSENECK SET UP. AS PER SALESMAN, TRUCK WAS READY TO TOW. CONCERNED NOW THAT THE FACTORY HITCH IS NOT A SLIDING HITCH WHICH IS REQUIRED ON SHORT BEDS FOR PROPER TURNING AND CAB CLEARANCE. CONCERNED WITH TRAILER HITTING CAB. FORD LITERATURE STATES THAT THE FIFTH WHEEL/GOOSENECK SET UP IS FOR LONG BED PICK UPS ONLY. WHY THEN WAS IT ALLOWED BY FORD TO BE INSTALLED AT FACTORY ON A SHORT BED PICKUP. *KB

Mileage: 1,423