2011 FORD F-250 SD Suspension Problems

I WAS TRAVELLING DOWN THE INTERSTATE AT APPROXIMATELY 72MPH AND THE VEHICLE STARTED SHAKING VIOLENT AND I ALMOST LOST CONTROL. MY WIFE DROVE IT AND I WAS BESIDE HER ON THE INTERSTATE AND IT HAPPENED TO HER ALMOST CAUSING HER TO WRECK THE VEHICLE. I HAD TO CALL HER TO CALM HER DOWN. PLEASE HELP FIX THIS PROBLEM BEFORE SOMEONE GETS KILLED.

Mileage: 100,000

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE 'DEATH WOBBLE' WHEN DRIVING HIGHWAY SPEEDS AND OVER UNLEVELED LAND. THE VEHICLE WAS UNSAFE TO DRIVE OVER 35 MPH DUE TO THE VIOLENT SHAKING AND VIBRATION. AN INDEPENDENT MECHANIC DIAGNOSED THE FAILURE AS THE 'DEATH WOBBLE' AND REPLACED THE TRACT BAR, BALL JOINTS, STEERING STABILIZER, STEERING DAMPER, AND PERFORMED AN ALIGNMENT; HOWEVER, THE FAILURES CONTINUED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 45,423.

Mileage: 45,423

TRUCK CONTINUES TO HAVE THE DEATH WOBBLE AS I DRIVE AT HIGHWAY SPEEDS AND HIT A SMALL PORTHOLE OR BUMP IN THE ROAD. THE WOBBLE BECOMES SO SEVERE THAT I HAVE LITTLE TO NO CONTROL OVER THE TRUCK. THIS HAS BEEN GOING ON AFTER 6MONTHS FROM PURCHASE DATE (NEW) BUT FORD SAYS THEY CAN NOT DUPLICATE. IT HAPPENS ABOUT 1-5X A WEEK AND I'VE NEARLY HIT SEVERAL OTHER VEHICLES ON THE HIGHWAY EACH TIME BY SWIRLING DURING THE WOBBLE. I LOOSE DIRECTIONAL CONTROL. I HAVE HAD A CRASH AS A RESULT OF THIS.

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING OVER UNEVEN LAND AND BUMPS IN THE ROAD, THE VEHICLE SHOOK VIOLENTLY. ALSO, THE STEERING WHEEL VIBRATED AND THERE WAS A STRONG VIBRATION FELT IN THE FRONT OF THE VEHICLE WHILE DRIVING HIGHWAY SPEEDS. GERMAIN FORD OF BEAVERCREEK (2356 HELLER DR, DAYTON, OH 45434, 1-(937) 429-1300) WAS NOTIFIED OF THE FAILURE AND COULD NOT DETERMINE THE CAUSE OF THE FAILURE WITHOUT GUIDELINES FROM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

Mileage: 58,000

FROM DAY 1 I HAVE HAD ISSUES WHERE THE FRONT END WOULD BOUNCE UNCONTROLLABLY AT HIGHWAY SPEEDS AFTER HITTING A POTHOLE OR BRIDGE EXPANSION JOINT. IT'S GETTING WORSE. THE DEALERSHIP CANNNOT FIND ANY PROBLEMS. THEY TOLD ME AT ONE TIME TO REPLACE MY TIRES BUT THAT DID NOT FIX THE ISSUE. I ALMOST RAN OFF THE ROAD 4 TIMES IN ONE TRIP BECAUSE OF THIS AS I COULD NOT MAINTAIN CONTROL. THIS WILL KILL SOMEONE IF NOT RESEARCHED AND CORRECTED BY FORD.

Mileage: 100,000

FOR THE PAST 3-4 YEARS MY TRUCK HAS EXPERIENCED THE "DEATH WOBBLE." WHEN DRIVING (STRAIGHT OR IN SLIGHT TURN) APPROXIMATELY 55 MPH OR HIGHER AND HITTING A TYPICAL BUMP IN THE ROAD, MY TRUCK BEGINS A VIOLENT SHAKING THAT STOPS WHEN I REDUCE THE SPEED ENOUGH TO REGAIN CONTROL. I HAVE ATTEMPTED REPAIRS AT TWO LOCAL FORD DEALERSHIPS AS WELL AS A LOCAL REPAIR SHOP, BUT NOTHING DONE HAS CORRECTED THE ISSUE. *TR

Mileage: 65,000

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS OVER A BUMP IN THE ROAD, THE FRONT END OF THE VEHICLE WOBBLED VERY VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER ON NUMEROUS OCCASIONS FOR A DIAGNOSTIC TESTING AND REPAIR. THE CONTACT STATED THAT THE BALL JOINTS, SHOCK ABSORBERS, AND OTHER UNKNOWN COMPONENTS WERE REPLACED OR REPAIRED BY THE DEALER, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

Mileage: 200,000

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOBBLED UNCONTROLLABLY. THE BRAKE PEDAL HAD TO BE DEPRESSED AND THE VEHICLE HAD TO ALMOST COME TO A COMPLETE STOP TO KEEP IT FROM WOBBLING. THE DEALER CONFIRMED THAT THERE WAS A WOBBLE IN THE FRONT END OF THE VEHICLE AND THAT A WOBBLE BAR WOULD NEED TO BE PLACED ON THE VEHICLE; HOWEVER, THERE WAS NO GUARANTEE THAT THE FAILURE WOULD NOT RECUR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 01/26/17*LJ UPDATED 7/12/18*JB *TR

Mileage: 90,000

WHEN TRAVELLING 45-50 MPH TWICE MY TRUCK HAS EXPERIENCED THE DEATH WOBBLE. NOW AT SPEEDS AT 62 MPH OR GREATER THE WHEELS SHIMMY BACK AND FORTH CAUSING THE STEERING WHEEL TO MOVE BACK AND FORTH ABOUT 4". IT GETS CRAZIER IF I HIT A BUMP. THIS MAKES FOR A SCARY RIDE. IT ONLY HAS 35K MILES ON IT. IT IS COMPLETELY STOCK

Mileage: 32,000

THE TRUCK WILL EXPERIENCE REALLY BAD WOBBLE/BOUNCE AT 35-55MPH SPEEDS. I INSTALLED A DUAL STEERING STABILIZER THINKING MAYBE IT JUST NEEDS AN UPGRADE. THE REAR END SEEMS TO BE THE PROBLEM. EVERY BUMP IS FELT. THE CAB MOVES AND ROTATES BACK AND FORTH AS IF SOMEONE IS SHAKING THE SEAT. THE TAIL BED IS VISIBLY BOUNCING UP AND DOWN THE INTERSTATE OR ANY SPEEDS OVER 40MPH. THE REAR END HAS TOO MUCH PLAY IN IT!!I BELIEVE THAT IT IS CAUSING THE FRAME TO BEND AND SUSPENSION PARTS TO GO BAD OVER TIME.

Mileage: 100,000

FOR DEATH WOBBLE

Mileage: 77,430

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING VARIOUS SPEEDS, THE FRONT END OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE VEHICLE WAS WORKING UP TO SPECIFICATIONS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.

Mileage: 100,000

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. WHILE DRIVING AT AN UNKNOWN SPEED, A LOUD CLUNKING SOUND EMITTED FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT TWO LEAF SPRINGS FRACTURED ON THE PASSENGER AND DRIVER SIDE. AS A RESULT, THE LEAF SPRINGS NEEDED TO BE REPLACED. A YEAR LATER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FIRST BROKEN SPRING $385.00 ON 12/18/15. BOTH REAR SPRINGS WERE REPLACE AT THE COST OF $1365.15. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 80,000. UPDATED 03/15/16*LJ *TR

Mileage: 80,000

WHEN DRIVING ON A FREEWAY AT 65 MPH, THE TRUCK ENCOUNTERED A SLIGHT BUMP AND THE FRONT END STARTED SHAKING VIOLENTLY, INCLUDING THE STEERING WHEEL SHAKING BACK AND FORTH VIOLENTLY. THE TRUCK WANDERED OUT OF THE LANE DUE TO LOSS OF CONTROL OF THE STEERING. THE SHAKING ONLY STOPPED AFTER SLOWING TO ABOUT 35 MPH. THE FAILURE REPEATED ITSELF A FEW MINUTES LATER BEFORE I COULD PULL OFF THE HIGHWAY. THIS OCCURRED PREVIOUSLY (6 MONTHS / 3000 MILES AGO). THE FORD DEALER SUGGESTED I TAKE THE VEHICLE TO AN INDEPENDENT SUSPENSION MECHANIC. HE INSPECTED THE TRUCK AND SAID ALL THE FRONT END COMPONENTS WERE FINE BUT HE NOTED THAT THE STEERING DAMPER HAD ABOUT A 1" DEAD ZONE. ON HIS RECOMMENDATION I REPLACED THE STEERING DAMPER AND THE FACTORY SHOCK ABSORBERS. THIS VIDEO ATTRIBUTED TO NHTSA DESCRIBES THE FAILURE PRETTY WELL: HTTPS://WWW.YOUTUBE.COM/WATCH?V=GT8CKIQSXJE

Mileage: 47,000

PURCHASED 2011 F-250 86000 MILES ON IT. GOING HOME ON THE HIGHWAY RIGHT AFTER I BOUGHT THE TRUCK WE WENT OVER A ROUGH PATCH OF ROAD AND THE TRUCK VIBRATED AND SHOOK SO BAD WE NEARLY LOST CONTROL. HAD TO STOP ON A BUSY HIGHWAY SHOULDER AND LOOK TO SEE IF WE HAD A FLAT TIRE. NOTHING OBVIOUS BUT BROUGHT IT TO OUR MECHANIC ANYWAYS A COUPLE DAYS LATER. EVERY BUMP ON THE ROAD WILL NOW CAUSE THIS REACTION AND AT HIGHWAY SPEEDS COULD BE DEVASTATING. OUR MECHANIC IS GOING TO TRY A NEW STEERING STABILIZER AND FRONT AXLE JOINTS BUT I FEAR THIS TRUCK HAS THE DREADED "DEATH WOBBLE". VERY DANGEROUS ISSUE THAT FORD WILL NOT ADDRESS.

Mileage: 86,000

WAS GETTING ON THE INTERSTATE AND WENT OVER A SEPARATION CRACK AT ABOUT 55 MPH WHEN THE TRUCK FRONT AXLE / SUSPENSION STARTED TO VIBRATE VIOLENTLY / SHAKING UNCONTROLLABLY. I STARTED TO PUT A SECURE HOLD ON THE STEERING WHEEL AND AT THE SAME TIME APPLYING THE BRAKES. AFTER SLOWING DOWN TO ABOUT 35 MPH THE TRUCK STARTED TO SMOOTH OUT, PULLED OVER TO THE SIDE OF THE EXPRESSWAY, CHECKED THE TRUCK OUT, DID NOT FIND ANY PROBLEM. I CONTINUED AT REDUCED SPEED TO HOME AND CHECKED IT OUT AGAIN, BUT DID NOT FIND ANYTHING. PRIOR TO THAT INCIDENT, I HAD COMPLAINED TO THE DEALER ABOUT WHAT I THOUGHT WAS A ROUGH RIDE, WENT WITH A MECHANIC FROM THE DEALERSHIP FOR A RIDE, AND HE SAID IT RIDES LIKE THE OTHER F250'S. AFTER THE VIBRATION INCIDENT, I DECIDED TO CHECK THE LEFT FRONT SHOCK, REMOVED IT AND THOUGHT THAT IT WAS NOT WORKING TO WELL. TOOK IT TO THE DEALERSHIP AND THEY SAID IT WAS A LITTLE BAD, AND THEY WOULD REPLACE IT, I THEN ASK THEM ABOUT THE RIGHT SHOCK, AND THEY DID NOT THINK THAT THE RIGHT SIDE WAS BAD, I THEN STATED THAT I WAS TOLD THAT THEY ARE REPLACED IN PAIRS, AND THAT THE REARS SHOULD ALSO BE REPLACED. THEY SAID NO, BUT AFTER MORE DISCUSSION, THEY DID AGREE TO REPLACE THE RIGHT SHOCK {CUSTOMER SATISFACTION}.IT DID SEEM TO RIDE BETTER. HOW EVER ON THE EVENING OF FRIDAY 7 AUGUST, THE TRUCK HAD ANOTHER EPISODE ON A DIFFERENT ROAD, LIKE IT HAD OVER A MONTH AGO. SO I DON'T THINK THAT SHOCKS ARE THE TOTAL PROBLEM.. IT IS POSSIBLE THAT UNDER DIFFERENT WEATHER CONDITIONS, THIS PROBLEM COULD INJURE OR KILL MANY PEOPLE!!! SO WHO IS TO BLAME ???? NOT ME !!! . ,

Mileage: 26,000

WE HAVE HAD ABOUT FOUR OCCASIONS WHERE OUR TRUCK SUDDENLY BEGINS TO SHAKE AND VIBRATE, CANNOT CONTROL THE SHIMMY UNTIL YOU CAN SLOW IT DOWN UNDER 30 MPH. IT HAPPENED THREE TIMES AT ABOUT 33,000 MILES. TWO TIMES IT WAS COMING OFF BRIDGE, HITTING A STEEL CHANNEL AT THE JUNCTION AND ONE TIME A LARGE HOLE. ALL THREE TIMES IT WAS ONE WHEEL HITTING THE HOLE OR DEPRESSION BEFORE THE OTHER WHEEL HIT. WE TOOK IT TO FORD DEALERSHIP.....NO IDEAS THERE. THEY REBALANCED THE LEFT TIRE AND NO MORE PROBLEMS UNTIL TODAY WHEN IT HAPPENED AGAIN WHEN COMING OFF A BRIDGE. ABOUT 38,000 MILES AND IT WAS THE SAME THING. CANNOT CONTROL THE SHIMMY UNTIL THE VEHICLE HAS SLOWED TO ABOUT 30 MILES PER HOUR. MOST FRIGHTENING! I REFUSE TO DRIVE IT AGAIN UNTIL THIS IS FIGURED OUT! BIG, OUT-OF-CONTROL TRUCK IS NOT MY CUP OF TEA.

Mileage: 33,000

WHILE ENTERING I-40 AT ~55 MPH AFTER HITTING A SMALL BUMP THE FRONT END AND STEERING VIOLENTLY BEGAN SHAKING. STEERING CONTROL WAS NEAR ZERO. SHAKING CONTINUED WHILE BRAKING TO ~ 10 MPH THEN STOPPED. TRUCK INSPECTION FOUND NO PROBLEM. *TR

Mileage: 44,000

DEATH RUMBLE: AFTER ANY NEW SET OF TIRES GETS ABOUT 15,000 -20,000 MILES ON THEM, THE INFAMOUS "DEATH RUMBLE" OCCURS ON THIS MODEL TRUCK. WHEN TRAVELING AT SPEEDS OF 60 OR MORE AND YOU TURN OR HIT A BUMP, THE FRONT END OF THE VEHICLE STARTS SHAKING AND VIBRATING VIOLENTLY. YOU HAVE TO COME TO AN ALMOST IMMEDIATE STOP IN ORDER TO GET THE VEHICLE TO STOP THE SHAKING. IT IS SO BAD THAT YOU CANNOT CONTROL STEERING AT TIMES AND IS EVEN VISIBLE TO OTHERS NOT IN THE VEHICLE. ALL FORD DEALERS THAT I HAVE SPOKEN WITH ABOUT THIS ARE AWARE OF THE ISSUE BUT BLAME IT ON TIRES OR TIRE PRESSURE. I HAVE TRIED SEVERAL TYPES OF TIRES (AS I KNOW HAVE OVER 125,000 MILES ON MY TRUCK) AND ALWAYS INFLATE THEM AS PER MY OWNER'S MANUAL...THIS DOES NOT HELP...NOR DOES ROTATING, BALANCING, CHECKING BRAKES, BALL JOINTS, SUSPENSION, ETC. YOU CAN WATCH MANY MANY VIDEOS OF THIS PROBLEM OF YOUTUBE AND OTHER LOCATIONS, SEE WRITE-UPS IN MAGAZINES, AND AS I SAID, DEALERS EVEN KNOW ABOUT THIS ISSUE...SO WHY IS IT NOT GETTING CORRECTED??? *TR

Mileage: 15,000

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH ON UNEVEN ROAD PAVEMENT, THE VEHICLE STARTED TO VIBRATE. THE CONTACT ALSO STATED THAT HE REDUCED THE SPEED TO 10 MPH, THE VIBRATION STOPPED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT ALL FOUR TIRES NEEDED TO BE REPLACED AND BALANCED. THE TECHNICIAN ALSO ALIGNED BOTH FRONT DRIVERS AND PASSENGERS SIDE TIRES. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

Mileage: 30,000

THIS STARTED IN MARCH 2014. TERRIBLE STEERING WOBBLE (DEATH WOBBLE) AT HIGHWAY SPEED. LAST NIGHT IT WAS HORRIBLE AS I WAS PASSING A CAR ON I-29 ON A BRIDGE AND WE GOT THE WOBBLE AFTER GOING OVER A BRIDGE JOINT. I HAD TO STAB THE BRAKES TO SLOW DOWN AS THE TRUCK STEERING WAS OUT OF MY CONTROL. SEVERAL VEHICLES BEHIND ME ALSO HAD TO NAVIGATE AROUND ME AS I TRIED TO TURN THE VEHICLE TO THE SHOULDER. THIS TRUCK IS DANGEROUS AT HIGHWAY SPEED! THIS HAS HAPPENED SEVERAL TIMES WHILE GOING DOWN THE INTERSTATE. I'M SCARED TO DRIVE THE TRUCK ANYWHERE BUT AROUND CITY STREETS. TO MY KNOWLEDGE THIS IS A VERY COMMON PROBLEM WITH ALL SUPER DUTY TRUCKS WITH A STRAIGHT FRONT AXLE AND COIL SPRINGS. I WANT FORD TO ADMIT THERE IS A PROBLEM AND FIX THESE ISSUES. IT'S A FIXABLE ISSUE THAT THEY WON'T ADDRESS. FOR $50,000 I DON'T THINK I SHOULD HAVE TO PAY FOR THEIR ENGINEERING GEOMETRY BLUNDER. *TR

Mileage: 28,000

THE 6.7 CID DIESEL ENGINE DRIVEN VACUUM PUMP SUDDENLY BEGINS LEAKING MOTOR OIL. FAILURE OF THIS PUMP WILL AFFECT 4 WHEEL DRIVE SYSTEMS INCLUDING AUTO LOCKING HUBS AND ALL INTERIOR CLIMATE CONTROLS. LOSS OF MOTOR OIL COULD CAUSE ENGINE FAILURE. FAILURE OF 4 WHEEL DRIVE SYSTEM DURING ADVERSE WEATHER COULD RESULT IN A VEHICLE CRASH OR LOSS OF CONTROL. RESEARCH INDICATES MULTIPLE FAILURES OF THIS PART, INDICATING A SYSTEMIC FAILURE. *TR

Mileage: 78,500

WHILE DRIVING AROUND 50-60 MPH AND GOING OVER A COUPLE OF SMALL BUMPS THE TRUCK STARTED SHAKING VIOLENTLY. I HAD TO SLOW DOWN ON THE FREEWAY TO ABOUT 35 FOR THE SHAKING TO STOP. IT HAS HAPPENED TWICE IN A WEEK. AFTER READING ALL THE COMPLAINTS ON SEVERAL WEBSITES AND SEEING THE YOUTUBE VIDEO I DECIDED TO FILE THE COMPLAINT. I WILL BE GOING TO THE DEALERSHIP NEXT WEEK. *TR

Mileage: 88,000

I GET A VIOLENT SHAKE OR WOBBLE FROM FRONT END WHEN I HIT SMALL TO LARGE BUMPS IN THE ROAD. I HAVE CHECKED TIRE PRESSURE AND FRONT END PARTS. NOTHING HAS BEEN WRONG OR ABNORMAL. I RESEARCHED A BIT AND FOUND THIS TO BE A COMMON PROBLEM WITH THESE TRUCKS. *TR

Mileage: 32,600

AS I WAS DRIVING ON A ROAD AT A SPEED THAT WAS GREATER THAN 50 MPH I HIT A BUMP IN THE ROAD. THE FRONT END OF THE TRUCK AND THE STEERING WHEEL BEGAN TO SHAKE SO VIOLENTLY THAT I THOUGHT THEY WERE GOING TO FALL OFF. THIS HAD HAPPENED BEGINNING AROUND LATE NOVEMBER EARLY DECEMBER OF 2012. IT DID IT SEVERAL MORE TIMES AND I CONTACTED THE DEALER ABOUT THIS PROBLEM. THE TRUCK WAS SERVICED AND NOTHING IN THE FRONT END WAS FOUND TO BE DAMAGED AND IT WAS RECOMMENDED THAT I REPLACE THE TIRES ON THE TRUCK. THE TIRES WERE REPLACED AND THE TRUCK HAS BEEN FINE FOR THE PAST YEAR. ON 10/30/13 I AGAIN WAS DRIVING THE TRUCK AT A SPEED GREATER THAN 50 MPH AND HIT A BUMP IN THE ROAD AND THE FRONT END AGAIN BEGAN TO SHAKE VIOLENTLY. I HAVE BEEN PIN THIS SHAKING DOWN TO THE FOLLOWING CONDITIONS. IT WILL SHAKE IF YOU ARE DRIVING AT HIGHWAY SPEEDS, YOU HIT A BUMP IN THE ROAD (THIS BUMP DOES NOT HAVE TO BE BIG IT COULD BE AS SIMPLE AS DRIVING FROM THE ROADWAY ONTO A BRIDGE DECK) THE FRONT END WILL BEGIN TO SHAKE AND VERY QUICKLY GET VIOLENT. THE ONLY WAY TO STOP IT FROM SHAKING IS TO SLOW THE VEHICLE DOWN TO A SPEED THAT IS LESS THAN HIGHWAY SPEED WHICH WILL CAUSE THE VIBRATION TO STOP AND YOU CAN THEN RETURN TO HIGHWAY SPEEDS. THIS HAS HAPPENED SEVERAL TIMES AND I DO NOT HAVE THE EXACT DATES THAT IT OCCURRED PRIOR TO CHANGING THE TIRES. HOWEVER IT IS BEGINNING AGAIN AND THE FIRST TIME WAS ON THE 30TH OF OCTOBER 2013. *TR

Mileage: 23,000

WHILE DRIVING ABOUT 60 MPH, SOMETIMES LESS, CHANGING PAVEMENT FROM SEMI SMOOTH TO KIND OF ROUGH, MY F250SD BEGINS SHAKING VIOLENTLY. SO SEVERE I ALMOST LOSE CONTROL. I HAVE BEEN LUCKY ENOUGH TO NOT HAVE OR CAUSE AN ACCIDENT. THIS SHAKING LAST UNTIL I LET OFF OF THE ACCELERATOR WHILE TRYING TO KEEP MY VEHICLE BETWEEN THE LINES AND HAVING TRAFFIC STAY FAR BEHIND WHEN IT FINALLY REGAINS CONTROL. THIS NOT ONLY HAPPENS AT 60 - 70 MPH BUT EVEN SOMETIMES AT 30 MPH IF YOU ARE DRIVING ON ROUGH PAVEMENT. WHEN YOU ARE DRIVING ON THE INTERSTATE AND THIS VIOLENT SHAKING STARTS, IT CAN BE EXTREMELY DANGEROUS FOR YOU AND ALL OTHER DRIVERS NEAR. I HAVE CHANGED SHOCKS, BALANCED FRONT END, TIGHTENED SUSPENSION AND ANYTHING ELSE TO DO WITH A FRONT END AND I STILL HAVE NOT SOLVED THE PROBLEM. *TR

Mileage: 60,000

MY TRUCK IS A 2011 FORD F-250 SD DIESEL. DEATH WOBBLE. THE FIRST TIME I WAS TRAVELING ON A STREET AND HIT A BUMP AT ABOUT 45 MPH. THE FRONT END STARTED TO SHIMMY TO THE POINT I HAD TO SLOW ALMOST TO A STOP TO GAIN CONTROL. THIS HAS HAPPENED AT LEAST 5 MORE TIMES ON THE HIGHWAY AT SPEEDS OF 60 MPH, I HAD TO SLOW TO AT LEAST 25-30 MPH TO GAIN CONTROL OF THE TRUCK WHILE OTHER VEHICLES ARE STILL TRAVELING AT THE POSTED HIGHWAY SPEED. I HAVE CHANGED THE STEERING STABILIZER, ALL FOUR SHOCKS AND HAD THE TIRES ROTATED AND BALANCED. I HAVE HAD TWO MECHANICS LOOK AT THE FRONT END. THEY BOTH HAVE SAID THE FRONT END IS TIGHT AND HAS NO PROBLEMS THAT THEY CAN SEE. MY TRUCK ONLY HAS 41000 MILES ON IT TO DATE. *TR

Mileage: 32,000

2011 F -250 SD4X4 HAD 08 KING RANCH NEVER A PROB IN 87K MILES.THE 11 IS DANGEROUS!!!!!!!!! THIS TRUCK WILL BE DOING FINE ON THE ROAD, HIT A BUMP OR ROUGH SPOT IN THE ROAD AND TRUCK GOES INTO (DEATH WOBBLE MODE ) THE WHOLE TRUCK STARTS BOUNCING AND SHAKING AND VILOENTLY WOBBLING. HAVE HAD IT BACK TO FORD STORE 4 TIMES. THEY REPLACED STEERING STABLIZER SHOCKS AND BALL JOINTS AT MY EXPENSE DUH!!! FIRST 3 TIMES THEY COULDNT FIND ANYTHING WRONG.IT KEPT DOIN IT . I TOOK IT BACK AND THEY DID THE REPAIRS I STATED. WELL I THOUGHT IT WAS FIXED ...WRONG, 22 MILES AFTER REPAIR IT DID IT AGAIN IN A CURVE,, I COULDNT CONTROL THE WOBBLE AND ENDED UP GOIN THRU A FENCE INTO A FIELD..HAVE TERRIBLE CUT ON LEGS AND FACE....FILED LAWSUIT YESTERDAY..WILL KEEP YOU POSTED...FORD HAS A MAJOR ENGINEERING PROB. THEY CONTINUE TO IGNORE,,,I INTEND TO GET THEIR ATTN,,,,,JC *TT

Mileage: 9,012

AFTER DRIVING OVER A SERIES OF SMALL BUMPS IN THE ROAD ON THE HIGHWAY THE FRONT END OF THE TRUCK SHOOK VIOLENTLY, SEVERE SHAKING/ VIBRATION. I HAD TO DECELERATE TO APPROXIMATELY 40-45 MPG TO STOP THE VIOLENT SHAKING. THIS HAS HAPPENED 4 TIMES SINCE THAT TIME. I HAD THE TRUCK SERVICED FOR THE PROBLEM AND IT HAS HAPPENED ONCE SINCE BEING SERVICED. *TR

Mileage: 6,000

TRAVELED OVER A MINOR ROAD IMPERFECTION IMMEDIATELY THE TRUCK BECAME UNCONTROLLABLE IT FELT AS THOUGH ALL FOUR TIRES BLEW. PULLED TO THE SIDE OF THE ROAD AND CHECKED TIRES AND SUSPENSION, NOT FINDING ANYTHING I QUESTIONED MY SANITY AND PROCEEDED UP THE ROAD WITHIN A FEW MINUTES I AGAIN TRAVELED OVER A MINOR ROAD IMPERFECTION ONCE AGAIN THE TRUCK IMMEDIATELY BECAME EXTREMELY DIFFICULT TO CONTROL. I PULLED TO THE SIDE OF THE ROAD AND CALLED FOR A TOW TRUCK. THE FORD DEALER ADVISES ME THAT THE BUSHINGS AND OTHER COMPONENTS RELATED TO THE STEERING STABILIZER NEED TO BE REPLACED AT A COST OF $700. I MADE THE TECHNICIAN AWARE THAT MY PROBLEM IS SIMILAR TO MANY OTHER INTERNET DOCUMENTED INCIDENTS INVOLVING FORD STEERING COMPONENTS AND THAT I RECENTLY RECEIVED A LETTER FROM A LEMON LAW ATTORNEY CITING THIS VERY SAME CONDITION. FORD WILL OFFER NO ASSISTANCE. *TR

Mileage: 49,000

OVER THE LIFE OF VEHICLE 45MPH TO 47 MPH STARTING APPROX 6000 MILES HAS HAD A HOP OR VIBRATION THAT YOU CAN FEEL THROUGH THE FLOOR, SEAT AND STEERING. AT 35500 NEW VIBRATIONS IN STEERING WHEEL WILE GOING AROUND CORNERS AT HIGHWAY SPEEDS ALSO STEERING WHEEL SHAKING UNCONTROLLABLY WHEN HITTING SEVERAL CLOSE TOGETHER BUMPS, RIPPLES, EXPANSION JOINTS. *TR

Mileage: 35,500

TRAVELING ON A HIGHWAY AND HIT A SLIGHT BUMP AND A VIOLENT SHAKING STARTED. THE BRAKES WERE APPLIED AND I MANAGED TO PULL ONTO THE SHOULDER. THE SHAKING CONTINUED UNTIL THE TRUCK STOPPED. ALMOST LOST CONTROL OF THE VEHICLE. AFTER INSPECTING THE VEHICLE, FINDING NOTHING WRONG, I CONTINUED TO MY DESTINATION. AN INTERNET SEARCH SHOWS THIS IS A COMMON PROBLEM, AND THE REPORTS I READ MOST CONSIDER IT A VERY DANGEROUS PROBLEM. *TR

Mileage: 40,782

I DROVE OVER A BRIDGE ON AN INTERSTATE AT APPROXIMATELY 65 MPH. THE VEHICLE AND STEERING WHEEL BEGAN TO SHAKE VIOLENTLY AND UNCONTROLLABLY. IT FELT AS THOUGH ALL FOUR TIRES BLEW OUT AND I HAD NO CONTROL OVER STEERING WHATSOEVER. I HAD TO SLOW ALMOST TO A STOP AND PULL OVER ON THE SHOULDER OF THE ROAD. *TR

Mileage: 23,000

TL* THE CONTACT OWNS A 2011 FORD F-250 SD. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH OVER A ROAD BUMP WHEN THE FRONT END OF THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER THREE TIMES FOR THE FAILURE. THE STEERING STABILIZER AND FRONT END SHOCKS WERE REPLACED AT DIFFERENT TIMES. THE FAILURE RECURRED AFTER THE REPAIRS WERE PERFORMED WHENEVER DRIVING OVER A ROAD BUMP OR POTHOLE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 28,848.

Mileage: 28,848

WHILE DRIVING OVER BUMPS, ROUGH PATCHES, UNEVEN RAILROAD TRACKS THE VEHICLE STEERING WHEEL WILL START SHAKING VIOLENTLY. IMPOSSIBLE TO CONTROL UNLESS THE SPEED IS REDUCED DRAMATICALLY (BELOW 20MPH ON A FREEWAY). AFTER DOING SOME INTERNET RESEARCH IS A COMMON TROUBLE WITH THIS TYPE OF TRUCK. IS CALLED "DEATH WOBBLE". I SENT AN EMAIL TO FORD AND I HAVE NOT HEARD BACK. IT'S A DANGEROUS PROBLEM AND NEEDS TO BE FIXED. *TR

Mileage: 22,000

2011 FORD F-250 DIESEL. THE FIRST OCCURRENCE WAS DRIVING APPROXIMATELY 50 MPH ON A 2 LANE RD. AFTER HITTING A SMALL BUMP IN THE ROAD THE VEHICLE FRONT END/STEERING BEGAN TO SHAKE VIOLENTLY FROM SIDE TO SIDE. I TOOK THE VEHICLE TO A LOCAL TIRE DEALER FOR TIRE REBALANCING AND ROTATION (3RD FOR THIS VEHICLE) HE STATED THE TIRES APPEARED TO BE WEARING "FUNNY". A COUPLE WEEKS LATER ON A LONG TRIP OUT OF STATE THE VEHICLE BEGAN TO SHAKE AGAIN, WORSE THAN BEFORE. WHILE OUT OF TOWN I HAD ALIGNMENT CHECKED WITH NO ISSUE FOUND AND PURCHASED NEW TIRES. VEHICLE SEEMED REPAIRED ON RETURN TRIP AND HAS SINCE BEGUN THE VIBRATION AGAIN. I WENT TO THE DEALER TODAY WHO SENT ME TO A LOCAL FRONT END SPECIALIST. THIS GENTLEMAN KNEW THE EXACT ISSUE AND CLAIMS TO HAVE REPAIRED HUNDREDS OF THEM. HE STATED THAT FORD MOTOR COMPANY WAS AWARE OF THIS ISSUE. HIS OPINION WAS THAT I NEED TO PURCHASE A "TRACK BAR KIT" WHICH HE WOULD INSTALL AND THEN ENSURE THE VEHICLE WAS REALIGNED. AFTER ARRIVING HOME TODAY I STARTED LOOKING ON THE INTERNET FOR ANY INFORMATION I COULD FIND AND FOUND MANY ARTICLES AND VIDEOS ABOUT WHAT IS CALLED THE "DEATH WOBBLE". I HAVE A SON WHO TURNED 16 ON SUNDAY AND I VALUE HIS LIFE MORE THAN TO LET HIM DRIVE OUR NEW 2011 VEHICLE WHICH IS ABSOLUTELY RIDICULOUS AND THE REASON I AM FILING MY COMPLAINT TODAY. *TR

Mileage: 34,500

VIOLENT SHACKING OF STEERING WHEEL AND VEHICLE SLIDING TO THE RIGHT WHEN APPROCCHING A LEFT CURVE AFTER HITTING MULTIPLE IMPERFECTION ON THE ROAD (EXPANTION JOINTS, BUMPS, HOLES, ETC.) DRIVING AT 50 MPH. FORD TSB 11-6-14. *TR

TRUCK SUFFERS FROM FRONT WHEEL OSCILLATION WHEN TRAVELING OVER BROKEN/ROUGH ROAD. TRUCK SHAKES UNCONTROLLABLY UNTIL SPEED IS GREATLY REDUCED. THE SAME AS 2005-2010 TRUCKS. *TR

Mileage: 44,500

MY 2011 FORD F250 DIESEL 4X4 CREW CAB 6.5' BED HAS EXPERIENCED UNEXPLAINABLE SUSPENSION VIBRATIONS AND WOBBLES OVER THE COURSE OF ITS, NOW, 13.5K MILE LIFE. THE TRUCK, NO MATTER HOW MANY TIMES THE WHEELS AND TIRES WERE BALANCE, BOUNCES AT 45-70 MPH AND BOUNCES AT A VERY DANGEROUS LEVEL AT HIGHER SPEEDS WHEN HITTING A BUMP OR UNEVEN PAVEMENT. THE PROBLEM IS ALSO WORSENED AT THE ONSET OF THE SPEED HEADING INTO A CORNER WHERE THE WHEEL IS TURNED. IT FEELS LIKE THE WHEELS GO OUT OF SYNC OR OUT OF SHAPE AND BOUNCE FORCING ME TO DECELERATE AND ON A FEW OCCASIONS, STOP ALTOGETHER. *TR

I WAS DRIVING ON HIGHWAY 55 NORTH IN IMPERIAL MISSOURI WITH MY 3 YR OLD SON IN REAR CAR SEAT WHEN I WENT OVER SOME NORMAL ROAD BUMP AND MY FRONT END STARTED SHAKING SO VIOLENTLY THAT I HAD TO COME TO A COMPLETE STOP TO CORRECT THE SHAKE. THIS ALL HAPPENED IN THE FAST LANE AS I HAD NO WAY TO MOVE TO LEFT OR RIGHT. THANK GOD I WAS NOT BEING TAILGATED! I WAS SCARED HALF TO DEATH AND MY 3YR OLD WAS CRYING SO HARD THAT HE COULDN'T BREATHE! I TOOK IT STRAIGHT TO DEALERSHIP AND THEY DID A TSB FOR A STEERING DAMPENER AND TOLD ME IT WAS FIXED. THE VERY NEXT MORNING IT DID THE VIOLENT SHAKE AGAIN. TOOK IT STRAIGHT BACK TO DEALERSHIP AND THEY HAD A FORD ENGINEER LOOK AT IT AND THEY REPLACED A TRACK BAR BALL JOINT AND SAID IT WAS GOOD NOW. I TOLD THEM THAT I WANTED TO TEST DRIVE IT BEFORE I TOOK IT THIS TIME AND THEY LET ME. STILL HAD THE PROBLEM AND WHEN I TOLD HIM THAT HE SAID THAT THE ENGINEER SAID I NEEDED TO PUT NEW TIRES ON AND A ALIGNMENT BEFORE THEY DO ANYTHING ELSE. THERE IS SOMETHING MORE THAN TIRES AND ALIGNMENT WRONG WITH MY TRUCK!!!!! MY FAMILY TRUCK HAS BECOME A DEATH TRAP!!!! PLEASE HELP WITH THIS MATTER BEFORE SOMEONE IS KILLED! IF THIS WAS YOUR CHILD IN THIS TRUCK YOU WOULD UNDERSTAND MY CONCERN!!! *TR

Mileage: 10,000

I WAS DRIVING ON A ENTRANCE RAMP TO AN INTERSTATE AT ABOUT 55-60MPH... I RECALL HITTING SOME TYPE OF ROAD BUMPS - PAVEMENT JOINT THAT STARTED THE EVENT... TYPICALLY I'M USED TO EXPERIENCING THE BACK OF MY TRUCK BOUNCE IN THE PAST CAUSING LANE CORRECTION BUT THIS TIME THE WHOLE FRONT END STARTED SHAKING SEVERELY... I WAS IN THE LEFT LANE OF 3 SO DECIDED TO BREAK AND GET INTO THE CENTER MEDIAN ASAP BASED ON APPROACHING VEHICLES FROM BEHIND... I PULLED OFF AND CHECKED THE LEFT SIDE AND THE RIGHT... ALL WAS FINE... I SHOOK THE WHEELS... ALL TIGHT... THE SHAKING OF THE VEHICLE WAS SO SEVERE I HAD A HARD TIME CONTROLLING IT AND GETTING IT SAFELY OFF THE ROADWAY... PAPERS IN MY VISORS SHOOK LOOSE... 2 GYM BAGS IN PASSENGER SEAT ENDED UP ON FLOOR.... A LARGE SCREEN TV THAT WAS TAPED AGAINST THE BACK WINDOW ON THE BACK SEAT WAS THUS SHIFTED LAYING NOW ON TOP OF THE FRONT SEATS.... I LATER REALIZED THAT THE SANDWICH I JUST BOUGHT WAS GONE FROM THE CONSOLE AND LATER FOUND ON THE FLOOR AT THE PASSENGERS DOOR!!!! BEING COMMITTED TO THE FREEWAY I SLOWLY STARTED OUT, AND NO OTHER ISSUES... AFTER ABOUT 20 MINUTES ON THE FREEWAY I KICKED IT UP TO FREEWAY SPEEDS, BUT GOT THE PUCKER FACTOR EACH TIME I HIT ROAD BUMPS ON MY TRIP.. I WORK FOR THE CITY OF ROCHESTER HILLS AND CALLED OUR FLEET MGR, AND TOLD HIM OF MY ISSUE, HE HAD NO IDEA BUT CHECKED AND FOUND TSB 11-6-14 THAT WAS VERBATIM WHAT HAPPENED TO ME.. THE DEALER ORDERED UP PARTS AND WILL ADVISE WHEN TO BRING IT IN BUT FORD CORP I FELT SHOULD HAVE NOTIFIED OF A POSSIBLE ROLL OVER ISSUE, AS IM SURE IF I WAS AT 70-80 ON THE FREEWAY OR MY KIDS DRIVING WITH LESS EXPERIENCE THERE WOULD HAVE BEEN A ROLLOVER... FORD SAID UNTIL IT HAPPENS AGAIN OR THE DEALER CAN NOT FIX IT THERE WAS NOTHING MORE THEY COULD DO!!!!! I ADVISED IT LOOKS LIKE THE NEXT CALL THEY WANT IS FROM LEGAL COUNCIL ADDING THE 0000 AFTER A FATALITY!!! *TR

THIS VEHICLE HAS SEVERE FRONT END WOBBLE WHICH MOSTLY OCCURS BETWEEN THE SPEEDS OF 55 - 70 MPH. THE STEERING WHEEL AND ENTIRE VEHICLE BEGINS TO VIOLENTLY WOBBLE SO MUCH THAT USUALLY THE VEHICLE HAS TO BE STOPPED ON THE SIDE OF THE ROAD TO STOP THE WOBBLE. THE COVER ON THE DASH OVER THE PASSENGER AIRBAG HAS CRACKED DUE TO THE VIOLENT SHAKING IN THE TRUCK. ALSO, FLUID HAS BEGUN TO LEAK FROM THE FRONT PASSENGER WHEEL AS A RESULT OF THE SHAKING AS WELL. BOTH FORD AND THE DEALERSHIP HAS BEEN UNABLE TO OFFER ANY REMEDY. PLEASE HELP WITH THIS SITUATION. I HAVE VIDEOS IF NEEDED. I AM AFRAID THIS IS GOING TO CAUSE AN ACCIDENT. *TR

Mileage: 70

I HAVE EXPERIENCED A VIOLENT WOBBLE IN MY FRONT END OF THE 2011 FORD 250 CREW CAB DIESEL. HAVE TAKING IT TO A FORD DEALER FOUR TIMES , THEY SAY THAT THEY CAN NOT FIND ANYTHING WRONG. AT 50+ THE TRUCK SHIMMIES SO BAD I HAVE TO SLOW DOWN TO ALMOST A STOP TO STOP THE SHIMMY. I'M AT THE POINT WHERE IT FEELS UNSAFE TO DRIVE. THANK YOU FOR YOUR TIME. *TR

Mileage: 3,600

BELOW IS A COMPLAINT LETTER THAT WAS SENT TO FORD TODAY. I PREVIOUSLY FILED A COMPLAINT WITH THE NHTSA. SO FAR THEY ARE HOLDING MY TRUCK HOSTAGE AND NOT FIXING THE PROBLEM. PLEASE DO SOMETHING. IT SEEMS THAT THERE ARE MANY TRUCK OF THIS TYPE AND MODEL THAT HAVE THE SAME PROBLEM. PLEASE SEE FORDFORUM.ORG UNDER THE HEADING OF VIOLENT FRONT END SHAKING. MY 2011 F-250 HAS BEEN AT GUS MUCHADO FORD IN PALMETTO BAY FLORIDA FOR THE PAST 4 DAYS FOR A WOBBLE IN THE FRONT END WHEN YOU HIT A BUMP. THE DEALER TELLS ME THAT THEY ARE WORKING WITH ENGINEERS AT FORD. THE PROBLEM IS THAT THE MECHANIC CAN ONLY EMAIL THE ENGINEER, HE THEN HAS TO WAIT FOR THE ENGINEER TO READ THE EMAIL AND RESPOND. THEN THE ENGINEER HAS TO WAIT FOR THE MECHANIC AND SO ON. IN THE 4 DAYS THEY HAVE HAD MY TRUCK ONLY 2 THINGS HAVE BEEN LOOKED AT. WHEN I WAS THERE THIS AFTERNOON MY TRUCK WAS PARKED OUT IN THE BACK PARKING LOT AND NOT BEING WORKED ON. WHEN I ASKED WHY IT WAS NOT BEING WORKED ON THEY RESPONDED THAT THEY WERE WAITING FOR THE ENGINEER TO TELL THEM WHAT TO DO NEXT. I DESPERATELY NEED FOR SOMEONE AT FORD TO STEP UP AND TAKE CONTROL OF THIS SITUATION. IF THIS MEANS SENDING AN ENGINEER TO THE DEALERSHIP, SO BE IT. AT THIS RATE I MIGHT NEVER SEE MY TRUCK AGAIN. BECAUSE OF THIS SLOW RESPONSE FROM THE DEALER AND FROM FORD TO REMEDY THE PROBLEM, I HAD NO CHOICE BUT TO RENT A TRUCK THIS AFTERNOON. I AM PAYING $60.00 A DAY FOR A TRUCK THAT IS NOT EVEN COMPARABLE TO MY F-250. WHEN I ASKED THE DEALER TO PICK UP THE RENTAL FOR ME DO TO THIS OBVIOUS FORD ISSUE, THE SERVICE MANAGER AUTHORIZED A VOUCHER FOR A WHOPPING $18.00. THIS WON'T EVEN PAY FOR THE GAS NEEDED TO DRIVE THE RENTAL FOR THE WEEKEND. *TR

Mileage: 27,000

THESE TRUCKS SHAKE VIOLENTLY IN THE FRONT END WHEN THEY ENCOUNTER EVEN THE SMALLEST OF BUMPS IN THE ROAD. FORD HAS FAILED TO TAKE THE RESPONSIBLE AND CORRECTIVE MATTERS TO FIX THE PROBLEMS. SOMETHING MUST BE DONE BEFORE SOMEONE GET KILLED. PLEASE SEE FORDFORUM.ORG TO SEE THAT MANY OTHERS ARE HAVING THE SAME ISSUES. *TR

Mileage: 26,925

FRONT / FRAME VIBRATION AND BOUNCING AFTER HITTING A HOLE OR AT CERTAIN SPEEDS THAT SEEM TO BE PRODUCING FRAME VIBRATION DUE TO A HARMONIC FREQUENCY GENERATED BY THE TIRES AND ROAD SPEEDS EXAGGERATING AN ENGINEERING DEFECT IN THE FRONT SUSPENSION. *TR

Mileage: 7,000