2005 FORD F-250 Suspension Problems

While driving at 65 Mph, towing a fifth wheel camper, encountered a mildly rough section of highway when entire front end began to wobble and shake violently. Slowed the vehicle, maintaining control. When going back up to speed, the same shaking occured again. Also noted a less violent shaking at 45 mph. Took vehicle to have new tires rebalanced but did not change condition much. Inspected front end components. Currently replacing steering damper and shocks in hopes of correcting issue. All other components new or nearly new (3 years) with no issues. Vehicle and components can be inspected, and all replaced parts will be kept for inspection if required. Safety of my vehicle and others on busy highway could have been compromised had I not slowed and maintained control. The problem is being dealt with by me, as I do most maintenance on vehicle. The vehicle has not been seen or inspected by others except by tire mechanic who noted no obvious issues but did re-balance all tires. There was NO advance warning of a failure or compromise.

In 2014, I got the “Ford death wobble” in the right front. VERY scary and dangerous. Trying to quickly slow down to stop it in traffic is almost as dangerous as the wobble itself. You have very little to no control with the steering when it happens. I had to repair the problem out of pocket because Ford won’t do anything about it. Now, two weeks ago, I had the same death wobble happen at 70 mph on the left front. So frightening. My passengers thought we had a blowout and we’re about to crash. I successfully slowed it down but this problem is a road hazard to me and everyone else on the road. So now, once again, it’s on me to shell out to fix a problem that should have been a recall a long time ago but Ford won’t step up and do the right thing. Please give us some relief here.

towing a trailer, traveling at 70 mph, I hit a pothole and vehicle violently shook. The episode lasted for approx 30 seconds. It was very Difficult to maintain control and I almost ran off the road. It happened several times before I took it for repairs. The stabilizer bar was replaced, however the violent shaking has still continued.

Front end suspension shimmy> My granddaughter and I were driving at 60mpa and hit a bump and could not control shaking of truck until pulling over to stop. This happened without warning. Had to drive back roads to get home.

The contact owns a 2005 Ford F-250. The contact stated while driving approximately 75 MPH, the front suspension started to bounce and vibrate, causing the vehicle to shift independently to the right lane. The contact stated no warning light was illuminated. The contact slowed the vehicle and the failure stopped. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 150,000.

Mileage: 150,000

Driving on the freeway at apps 65 miles per hour, the truck hit a numb in the road and started to shaking causing the truck to shake violently. I was able to get to the side of the road and slow down which eased the shaking. I started driving again and after reaching speeds this happened two more times, then I got off the freeway and drove backroads home under 40 miles per hour.

The steering is extremely lose and has a shimmy or “death wobble” when going over any type of bumps or other issues and at speed on the highway. Similar to recall 09L02

A SCARY AND SERIOUS WOBBLE AT 35 MPH. HAD TO CREEP HOME. ALMOST LOST CONTROL.

Mileage: 112,000

MY TRUCK VIOLENTLY SHAKE AT ANY TIME BETWEEN 30 AN 70 MPH I HAVE TO SLOW DOWN TO MAKE IT STOP WHICH COULD CAUSE A ACCIDENT IT HAPPENS IN THE CITY AN HIGHWAY

Mileage: 265,000

MY 2005 FORD F250 SUPER DUTY TRUCK EXHIBITS A CONDITION REFERRED TO IN FORUMS AS 'DEATH WOBBLE', IN WHICH THE TRUCK'S FRONT SUSPENSION SHAKES VIOLENTLY AT HIGHWAY SPEEDS ABOVE 50 MPH. THIS CONDITION IS GENERALLY BROUGHT ON BY EITHER OF THE FRONT WHEELS HITTING ANY DEVIATION IN THE ROAD SURFACE SUCH AS BRIDGE EXPANSION JOINTS, POTHOLES, ETC. THE CONDITION IS SO BAD THAT IMMEDIATE LOSS OF CONTROL CAN ONLY BE CONTROLLED BY JERKING OF THE STEERING WHEEL OR AN IMMEDIATE REDUCTION IN SPEED, GENERALLY TO 25 MPH. I HAVE EXPERIENCED THIS CONDITION SEVERAL TIMES OVER THE PAST 9 YEARS SINCE PURCHASING THIS VEHICLE, MOST RECENTLY ON JULY 12TH WHILE TRAVELING ON THE 57 FREEWAY IN SOUTHERN CALIFORNIA AT 65 MPH. I WAS TRAVELLING IN THE LEFT HAND LANE NEXT TO THE CARPOOL LANE (IN MODERATE TRAFFIC) WHEN I ROLLED OVER A BRIDGE EXPANSION AND THE LEFT FRONT WHEEL STARTED SHAKING VIOLENTLY AND CAUSING ME TO IMMEDIATELY APPLY MY BRAKES TO REGAIN CONTROL. THE SEVERITY SEEMS TO BE GREATLY REDUCED WHEN HAULING A SUBSTANTIAL LOAD IN THE TRUCK BED, BUT I DID EXPERIENCE THIS TWICE WHILE HAULING A 20' CARGO TRAILER ACROSS THE COUNTRY. I UNDERSTAND THAT A CLASS ACTION SUIT WAS FILED AGAINST FORD IN JUNE/2019 AND THAT FORD HAS BEEN AWARE OF THIS ISSUE WITH OTHER TRUCK OWNERS FILING COMPLAINTS REGARDING THIS CONDITION. I PERSONALLY HAVE NOT GONE TO FORD REGARDING THIS AS IT IS A WASTE OF MY TIME. THE COMPONENTS THEY REPLACE DO NOT CURE THE PROBLEM, AS MANY TRUCK OWNERS WILL ATTEST. IN MY RESEARCH, I FOUND A COMPANY IN UTAH THAT PROVIDES AN AFTERMARKET KIT THAT APPEARS TO FIX THE ISSUE. AS I AM ABOUT TO EMBARK ON ANOTHER 6000 MILE JOURNEY WITH MY WIFE AND FAMILY, I INTEND TO PURCHASE AND INSTALL THIS KIT ON MY VEHICLE. IF I FIND UPON RETURNING THAT THIS KIT HAS ALLEVIATED MY TRUCK'S ISSUE, I WILL RE-CONTACT NHTSA WITH MY RESULTS.

Mileage: 115,000

2005 FORD F250 WITH APPROXIMATELY 19,100 MILES. ORIGINAL FACTORY TIRES, SUSPENSION- NO MODIFICATIONS. TIRE PRESSURE SET TO FACTORY DOOR LABEL SPECS. ON MONDAY, 8-19-2019 WHILE ON I-95, TRAVEL SPEED AT ABOUT 60 M.P.H., I DROVE OVER A BRIDGE EXPANSION JOINT & THE ENTIRE TRUCK STARTED SHAKING VIOLENTLY. STEERING WHEEL WAS VIBRATING/SHAKING MAKING IT DIFFICULT FOR ME TO MAINTAIN CONTROL OF THE TRUCK IN MY ESTABLISHED LANE AND NEARLY TOOK OUT SEVERAL CARS IN THE ADJACENT LANES NEARLY CAUSING MULTI-VEHICLE COLLISION. WENT ON THE INTERNET & FOUND THOUSANDS OF SIMILAR COMPLAINTS REGARDING THIS SAME ISSUE I JUST EXPERIENCED. LATER FOUND OUT IT IS CALLED HARMONIC RESONANCE A.K.A. THE DEATH WOBBLE. THIS DANGEROUS SITUATION AFFECTS NOT ONLY THE DRIVER AND THE PASSENGERS IN THE DEFECTIVE VEHICLE, BUT TO OTHER UNSUSPECTING MOTORIST'S AND THEIR PASSENGERS WHOM SHARE THE SAME ROADWAYS.

Mileage: 19,100

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY VIBRATED AND PULLED TO THE LEFT. WHILE INSPECTING THE VEHICLE, THE CONTACT DISCOVERED THAT THE BRAKE CALIPERS WERE HOT TO THE TOUCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 109,000.

Mileage: 109,000

AT ANYWHERE BETWEEN 45MPH, AND 70 THE TRUCK WILL WOBBLE AND SHAKE OUT OF CONTROL TO THE POINT WHERE YOU CAN ALMOST LOOSE CONTROL. TRUCK CAN BARELY BE DRIVEN AND IS VERY UNSAFE

Mileage: 120,000

HIT A BUMP GOING ACROSS A BRIDGE ON I-74. THE ENTIRE TRUCK BEGAN TO SHAKE VIOLENTLY FOR SEVERAL HUNDRED FEET BEFORE I REGAINED CONTROL OF THE VEHICLE. THIS IS EVIDENTLY WHAT FORD IS CALLING A " SHIMMY" . I HAD ALMOST NO CONTROL OF THE VEHICLE AT THIS POINT. IF THE SHOULDER OF THE HIGHWAY WAS ANY NARROWER I WOULD NOT BE HERE TODAY. THIS HAPPENED AGAIN TWO DAYS LATER. I WAS ALMOST REAR ENDED AT A SPEED OF 60 MPH. I DON'T KNOW WHAT TO DO, I'M STILL MAKING PAYMENTS ON A TRUCK THAT IS UNSAFE TO DRIVE. THIS "SHIMMY " IS GOING TO GET PEOPLE KILLED. *TR

Mileage: 49,000

SEVERE STEERING SHAKE AND FRONT SHIMMY AFTER GOING OVER ROUGHNESS IN ROAD. VEHICLE HAD TO BE SLOWED TO ALMOST REST TO STOP SHIMMY. HAS HAPPENED MULTIPLE TIMES. *TR

Mileage: 180,000

THIS IS THE FIRST OF FOUR TIMES THAT I HAVE HAD TO HAVE BRAKE WORK DONE ON MY TRUCK. THREE OF THE TIMES I WAS TOLD THAT THE CALIPERS HAD FROZEN AND SO CALIPERS PADS AND (EXCEPT THIS LAST TIME) ROTORS HAD TO BE REPLACED. THIS IS ABSURD FOR A TRUCK WITH LESS THAN 45,000 MILES. UNDERSTAND THIS IS EXPENSIVE!! HAVE NEVER HAD ANYTHING LIKE THIS ON ANY OTHER VEHICLE. ALSO, I HAVE EXPERIENCED THE OFT TALKED ABOUT "DEATH WOBBLE" A FEW TIMES ON THE HIGHWAY. WAS REAR BRAKES IN 2010' FRONTS IN 2011' NOW REARS AGAIN IN 2013. *TR

Mileage: 21,419

I WAS ON THE INTERSTATE DRIVING 70 MPH WHEN I HIT A SMALL BUMP IN THE ROAD WHICH CAUSED MY TRUCK TO SHAKE VIOLENTLY AND LOSE CONTROL OF STEERING WHICH TOOK ME OFF THE ROAD INTO THE CENTER MEDIAN. THIS COULD HAVE EASILY BEEN A HEAD ON COLLISION IN DIFFERENT CIRCUMSTANCES. *TR

Mileage: 36,000

DRIVING ON INTERSTATE AND RAN OFF ONTO RUMBLE STRIPS ON SIDE OF ROAD AND WHEEL SHAKE BECAME EXTREMELY VIOLENT.HAD TO BRING VEHICLE DOWN TO 30 MPH FROM 75 VERY QUICKLY AND ALMOST WAS HIT FROM BEHIND DOING SO.HAVE SEEN THIS AND HAD IT HAPPEN ON OLDER TRUCKS THAT HAD EXCESSIVE WERE IN TIE RODS AND WORN FRONT END PARTS BUT THIS TRUCK IS TIGHT SO I THOUGHT. FIRST TIME FOR THIS AND IT WAS VERY FRIGHTEN COULDN'T BELIEVE HOW VIOLENT SHAKE WAS. FORD DOES NEED TO ADDRESS THIS OR OFFER A FIX BEFORE SOMEONE DOES GET HURT. WONDER HOW MANY ARE OUT THERE THAT PEOPLE HAVE GOTTEN RID OF OR NEVER COMPLAINED ABOUT IT? *TR

Mileage: 65,000

TL* THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE WOULD SHAKE WHENEVER HE DROVE OVER A BUMP. THE FAILURE OCCURRED AT ALL SPEEDS. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE CONTACT REPLACED THE TIRES HIMSELF, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 12,000.

Mileage: 12,000

TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH OVER A ROAD BUMP WHEN THE VEHICLE BEGAN TO JERK VIOLENTLY, CAUSING IT TO TRAVEL UNCONTROLLABLY ACROSS TWO LANES. THE CONTACT WAS ABLE TO REGAIN CONTROL AND RESUMED NORMALLY. THE FAILURE OCCURRED ON FOUR SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE UPPER BALL JOINTS WERE REPLACED. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIR WAS PERFORMED. THE MANUFACTURER NOTIFIED THE OWNERS THAT THE VEHICLE COULD EXPERIENCE A POTENTIAL SHIMMY AND RECOMMENDED THAT THE TIRES BE INFLATED TO THE CORRECT PRESSURE TO PREVENT THE DEFECT. THE MANUFACTURER WAS MADE AWARE OF THE RECURRING PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

Mileage: 47,000

WHEN I HIT A POT HOLE DOING 50MPH THE FRONT DRIVER SIDE STARTS TO SHAKE ON UNCONTROLLABLY PRESSURE IS OK. BRAKES ARE NEW,WHAT SHOULD I DO TO REPAIR THIS ? *TR

I JUST RECEIVED FROM FORD ANOTHER NOTICE ABOUT THE OUT OF CONTROL SHIMMING THAT TAKES PLACE CONCERNING THE 2005 F- 250 . FORD HAS DOES NOTHING TO CORRECT THIS PROBLEM OTHER THAN TO BLOW SMOKE AT EVERYONE ABOUT THE TIRE PRESSURE. SINCE I BOUGHT THIS UNIT NEW, THE TIRE HAVE ALWAYS BEEN CORRECTED TO THE PROPER AMOUNT OR THE CORRECT TIRES BEEN REPLACED. STILL THIS ISSUE TAKES PLACE . ITS AN UNBELIEVABLE TERRIFYING SHAKING THAT TAKES PLACE , AND ONLY STOPS WHEN THE TRUCK GETS TO ABOUT 20-25 MILES AN HOUR. THIS OCCURRED MOST RECENTLY, LAST THAT A CAR FOLLOWING ME , PULLED ME OVER TO TELL ME HOW IT LOOKED FROM THE REAR, TO THE POINT THE PERSON BEHIND ME WAS FEARFUL FOR THEIR SAFETY AS WELL. I REFUSE TO LET ANY MEMBER OF THE FAMILY DRIVE THIS TRUCK ,OTHER THAN MYSELF. THERE IS CERTAINLY MORE TO THIS ISSUE THAN WHAT FORD IS MAKING OUT TO BE AND ALL FORD WANTS TO DO IS BLOW SMOKE AT US ABOUT THE TIRE PRESSURE. I'VE TRIED TO SELL THIS UNIT TO NO AVAIL, AS THE DEALERS DON'T WANT TO TOUCH THIS UNIT AND OTHERS HAVE CHECKED ON LINE TO HAVE FOUND OUT ABOUT IT AND ASKED ME ABOUT IT , AND WANTING TO BE HONEST I TOLD THEM ABOUT IT. SO NOW I HAVE A TRUCK THAT I CAN'T EVEN SELL AT A DEEP DISCOUNT. THANKS FORD. *TR

Mileage: 23,000

MY FORD F250 HAS A VERY DANGEROUS WOBBLE WHEN I HIT A BUMP ON THE HIGHWAY. I HAVE CHECKED THE TIRE PRESSURE AND ALL FOUR TIRES ARE FINE. AFTER DOING SOME RESEARCH I HAD FOUND THAT THIS IS A ON GOING PROBLEM WITH THE FORD SD TRUCKS. SOMETHING HAS TO BE DONE OR SOMEONE IS GOING TO GET KILLED DUE TO A BAD ACCIDENT. EVERY DEALER THAT I TALK TO HAS NEVER HEARD OF THIS PROBLEM BUT YET I SEE IT POSTED ALL OVER THE INTERNET. I AM VERY UPSET AND I AM GOING TO TAKE LEGAL ACTION. *KB

Mileage: 129,000

CRUISING ALONG THE HIGHWAY, IF I HIT A BUMP IN THE ROAD DOING ANY SPEED OVER 55 MPH THE TRUCK BEGINS TO SHAKE VERY BADLY!! SO BAD THAT I CAN HARDLY CONTROL THE TRUCK. ONLY WAY TO MAKE IT STOP IS TO SLOW TO 40 MPH. VERY UNSAFE TO DRIVE ON ANY HIGHWAY!! THERE IS NO BAD PARTS ON THIS TRUCK...

Mileage: 50,035

DURING HIGHWAY SPEEDS AND YOU HIT A SET OF BUMPS OR A SINGLE BUMP MY TRUCK WILL VIOLENTLY SHAKE AT THE FRONT END. IT FEELS LIKE THE WHOLE FRONT END OF THE TRUCK IS COMING APART! FORD WILL NOT ADMIT ANYTHING IS WRONG.. THERE ARE COUNTLESS ENTRIES ABOUT THIS ALL OVER THE WEB.. IS SOMEBODY GOING TO DO SOMETHING?? *TR

Mileage: 60,000

MY KIDS AND I WERE DRIVING ON I-70 WEST COMING FROM CAMBRIDGE OHIO TO COLUMBUS. WE HIT A ROUGH SPOT IN THE ROAD AND THE FRONT END STARTED SHAKING VIOLENTLY FROM SIDE TO SIDE. THE WHOLE TRUCK WAS SHAKING. I LET MY FOOT OFF THE ACCELERATOR AND CHANGED LANES. THIS DID NOT STOP THE SHAKING. I WENT OFF ON THE BERM AND CONTINUED TO SLOW DOWN. AT APPROX. 35-40 MPH IT STOPPED SHAKING. I CHECKED THE TIRES AND ALL WERE FINE. WE PROCEEDED ON AND ROUGHLY 10 MILES DOWN THE ROAD IT DID IT AGAIN. I AGAIN TOOK MY FOOT OFF THE GAS AND HEADED TOWARDS THE BERM, I DID TRY HITTING THE BRAKES THIS TIME. BRAKES MADE NO DIFFERENCE. THE SHAKING DID NOT STOP UNTIL WE WERE BETWEEN 35 AND 40 MPH. I HAVE OWNED THIS TRUCK SINCE IT HAD 5,000 MILES ON IT AND HAVE TRAVELED THIS ROAD MANY TIMES. THE TRUCK HAS ALWAYS BOUNCED AROUND WHEN HITTING ROUGH ROAD SURFACES, HOWEVER, IT STOPPED ONCE PAST THE ROUGH SPOT. MY TRUCK IS ONLY USED OCCASIONALLY AND HAS ALL OF ITS ORIGINAL COMPONENTS IT LEFT THE FACTORY WITH, INCLUDING THE TIRES. I CAN NOT FIND ANY LOOSE TIE ROD ENDS. ONCE I GOT HOME I TURNED OFF THE TRUCK AND WHEN I WENT TO RESTART IT TO PULL INTO THE GARAGE THE BATTERY WAS COMPLETELY DEAD. THIS COULD OF BEEN TOTALLY COINCIDENCE, HOWEVER, I BELIEVE THE VIOLENT SHAKING CAUSED A BATTERY PLATE TO SHORT OUT. IN MY OPINION THIS IS COMPLETELY UNACCEPTABLE AND IS NOT A SAFE CONDITION FOR ANYONE TO BE IN AT HIGHWAY SPEEDS. IF MY WIFE HAD BEEN DRIVING, SHE WOULD NOT HAVE BEEN ABLE TO CONTROL THE VEHICLE. I APPRECIATE YOUR PROMPT ATTENTION TO THIS MATTER AS IT COULD HAVE VERY SERIOUS AND UNFORTUNATE CONSEQUENCES FOR OTHER OWNERS WHO COULD EXPERIENCE THIS PROBLEM, AT ANY TIME, WITHOUT WARNING.

Mileage: 18,723

TL*THE CONTACT OWNS A 2005 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING 55-60 MPH OVER A BUMP IN THE ROAD, THE FRONT END BEGAN TO SHAKE VIOLENTLY. A LOCAL MECHANIC REPLACED THE SHIMMY SHOCK BUT THE FAILURE CONTINUED. THE DEALER HAD NOT INSPECTED THE VEHICLE. THE CONTACT RECEIVED A NOTICE FROM THE MANUFACTURER IN 2009 STATING ADVISING HIM TO KEEP THE TIRES INFLATED. THE CONTACT STATED THAT HE HAD TO SLOW DOWN TO 35-40 MPH TO GET THE SHAKING TO STOP. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 125 AND THE CURRENT MILEAGE WAS APPROXIMATELY 47,000.

Mileage: 125

TL*THE CONTACT OWNS A 2005 FORD F-250. WHILE TRAVELING 65 MPH OVER A BUMP OR CRACK IN THE SURFACE OF THE ROAD THE CONTACT NOTICED THAT THE FRONT END OF THE VEHICLE BEGAN TO SHAKE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PERFORMING NORMALLY. THERE WERE NO PRIOR WARNINGS. THE FAILURE MILEAGE WAS 26000 AND THE CURRENT MILEAGE WAS 28000. UPDATED 01/11/2011*LJ UPDATED 04/07/11

Mileage: 26,000

2005 FORD F 250 CREWCAB 4X4 FRONT END SHAKES UNCONTROLLABLY AFTER HITTING A BUMP AT HIGHWAY SPEEDS. THE ENTIRE VEHICLE BOUNCES AROUND TO WHERE OTHER VEHICLE ON THE ROADWAY HAVE TO SWERVE TO GET OUT OF THE WAY. ONLY WAY TO STOP IT IS TO SLOW DOWN TO ABOUT 30 MPH. I JUST RECENTLY HAD THE STEERING STABILIZER, DRAG LINK BAR AND SHOCKS ON THE TRUCK REPLACED ALONG WITH TIGHTENING THE STEERING GEAR BOX AND IT STILL CONTINUES TO DO THE SAME THING. *TR

Mileage: 87,000

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE TRAVELING AT 40 MPH, BOTH THE FRONT END OF THE VEHICLE AND THE STEERING WHEEL WILL BEGIN TO ABNORMALLY SHAKE AND VIBRATE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FRONT SHOCKS WOULD NEED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 74,000.

Mileage: 30,000

EXTREME FRONT END WOBBLE ON MY 2005 FORD F-250. FEELS LIKE THE FRONT END IS GOING TO TEAR ITSELF APART. *TR

Mileage: 126,417

STEERING ISSUE WITH MY FORD SUPERDUTY F250. SINCE DAY 1 THE STEERING WHILE DRIVING IN A STRAIGHT LINE TENDS TO WANDER. FEELS LIKE YOU ARE DRIVING A BUMPER CAR IN TRAFFIC ONLY HOPING YOU DO NOT HIT ANYONE. FORD ENGINEER SAID IT WAS A PROBLEM THEY SUPPOSE TO HAVE FIXED. IT HELPED FOR A WHILE APROX. 21/2 YEARS BUT AS THE TRUCK GETS OLDER IT IS STARTING TO WANDER MORE. HAS ABOUT 1-1 1/2" OF PLAY IN THE STEERING WHEEL. ITS LIKE DRIVING A 1968 FORD. HAVE READ SEVERAL OTHER COMPLAINTS FROM OTHER FORD BUYERS WITH SAME ISSUE. FORD SENT A NOTIFICATION A WHILE BACK AND STATED THAT WHEN THIS WANDERING OCCURRED WHILE DRIVING TO JUST SLOW DOWN. WELL THAT'S ALL FINE AND DANDY EXCEPT MY WIFE AND I TOOK OUR 2 HORSES TO FLAGSTAFF ,AZ. A FEW WEEKS AGO FOR A TRAIL RIDE COMING UP FROM PHOENIX, AZ. WE HAD TO DRIVE UP THROUGH STEEP MOUNTAINS AND THEN COME BACK DOWN STEEP MOUNTAINS. THE SPEED LIMIT IS 75 BUT WE WERE ONLY DOING 60-65 MOST OF THE TIME. MY TRUCK IS RATED TO PULL 12500 LBS. AT ONE POINT THE TRUCK DECIDED ON ITS ON TO WANDER ABOUT 2 FT. TO THE RIGHT COMING DOWN A MOUNTAIN AT THIS POINT I WAS ONLY DOING ABOUT 60 FORTUNATELY SINCE I WAS CONSTANTLY HAVING TO WORK THE STEERING WHEEL BACK AND FORTH I WAS ABLE TO EASE OFF THE THROTTLE AND BRING IT BACK IN LINE AFTER AWHILE. AGAIN FEELING LIKE WE WERE PLAYING BUMPER CARS ONLY THIS TIME WITH 2 HORSES IN THE TRAILER WHICH THE WEIGHT WAS ONLY ABOUT 6000LBS. THE HORSES WERE NOT MOVING AROUND AS THEY WERE BEAT FROM THE DAYS PLAY. THE WHOLE ORDEAL REALLY RATTLED US.THIS HAS BEEN AN ISSUE FOR A LONG TIME AND IS ONLY GETTING WORST. I KNOW I AM OUT OF WARRANTY BUT SINCE FORD SUPPOSEDLY FIX IT BEFORE I THINK IT IS A REAL SAFETY ISSUE. IT ALL POINTS TO A BAD STEERING BOX OR BAD FRONT SUSPENSION. WE WOULD HAVE BEEN KILLED HAD I NOT GOT THIS TRUCK UNDER CONTROL AND THE HORSES WERE NOT SAFE THEN. ANY HELP WOULD BE APPRECIATED AS FORD HAS NOT BEEN MUCH HELP TO ANYONE. THEIR LITTLE NOTIFICATION TO ALL OWNERS OF THIS PROBLEM SHOULD BE A REPAIR. *TR

Mileage: 50

I EXPERIENCED A SEVERE AND VIOLENT SHAKING OF THE FRONT END OF MY 2005 FORD F-250 TRUCK WHILE TRAVELING 60 MPH OVER A SLIGHT ROUGH PATCH ON A HIGHWAY. I LOST CONTROL OF MY VEHICLE AND WAS FORCED TO SWERVE OFF THE HIGHWAY. I WAS ALMOST HIT BY THE VEHICLE DIRECTLY BEHIND ME. THIS IS THE THIRD TIME I HAVE LOST CONTROL OF THE TRUCK BECAUSE OF THIS VIOLENT SHAKING IN THE LAST MONTH. I HAVE HAD THE TRUCK TO A LOCAL INSPECTION STATION AND THEY REPLACED THE STEERING STABILIZER AND DID AN ALIGNMENT. THIS DID NOT HELP. I HAVE CALLED THE FORD DEALER I PURCHASED THE TRUCK FROM AND THEY SAID THEY NEVER HEARD OF ANYONE HAVING THIS PROBLEM WITH ANY FORD TRUCK. OBVIOUSLY, THEY ARE AWARE OF THE PROBLEM. I ONLY HOPE THERE IS A RECALL BEFORE TOO MANY PEOPLE DIE. *TR

Mileage: 36,000

FORD 2005 F250 4X4 SUPER DUTY ,VIOLENT SHAKING. ON SAT MAY 30TH AT APPROX 11:00 AM PACIFIC STANDARD TIME, I WAS TRAVELING ON THE I 280 SOUTH FREEWAY WITH MY DAUGHTER TO A SOCCER TOURNAMENT IN MY 2005 F250 4X4 SUPER DUTY TRUCK. WE WERE IN CRUISE CONTROL GOING APPROX 55 MPH. WE DROVE OVER WHAT I BELIEVE WAS A LARGE EXPANSION JOINT ON THE FREEWAY. IMMEDIATELY AFTER WE TRAVELED OVER JOINT, THE VEHICLE START TO VIOLENTLY SHAKE AND VIBRATE. AFTER A TENSE MOMENT OF COMPLETE TERROR AS THE VEHICLE BECAME EXTREMELY DIFFICULT TO CONTROL AND CONTINUED TO SHAKE VIOLENTLY WE CAME TO A UNSAFE STOP ON THE FREEWAY. AFTER THE COMPLETE STOP, I IMMEDIATELY HAD TO SPEED UP AGAIN TO PREVENT BEING REAR ENDED IN THE MIDDLE OF THE FREEWAY. THE REST OF THE TRIP WAS SPENT WHITE KNUCKLED TRAVELING WELL BELOW FREEWAY SPEEDS FOR FEAR OF ANOTHER EPISODE OF SHAKING . EVERY BUMP IN THE ROAD WAS A SCARY REMINDER OF WHAT MIGHT HAPPEN AGAIN. MY DAUGHTER IS SCARED TO TRAVEL IN THE TRUCK AND MY WIFE HAS DEMANDED THAT THE PROBLEM BE ADDRESSED IMMEDIATELY,OR "SELL THE '!@#$% TRUCK" . THIS IS NOT AN ISOLATED INCIDENT. FORD MOTOR COMPANY SENT A NOTICE INFORMING ME OF THE PROBLEM. THEY INDICATED IT COULD BE PREVENTED WITH PROPER TIRE PRESSURE. MY TIRES WERE WELL WITHIN THE RANGE OF PRESSURE SUGGESTED. I KNOW THIS BECAUSE I CHECKED THEM IMMEDIATELY WHEN I ARRIVED HOME. THIS IS COMPLETELY UNACCEPTABLE AND PRESENTS A MAJOR RISK TO THE DRIVER OF THESE VEHICLES AS WELL AS THE SURROUNDING DRIVERS. I ALMOST LOST CONTROL OF MY TRUCK AND HAD FLASHES OF MY DAUGHTER AND I NEVER MAKING IT HOME. THERE WAS A PARENT TRAVELING BEHIND US IN A TRUCK. THEY WITNESSED THE VIOLENT SHAKING AND SAID "I THOUGHT YOUR AXLE WAS GOING TO COME UNDONE AND YOU WERE GOING TO CRASH" .THIS IS COMPLETELY UNACCEPTABLE AND I WILL BE TAKING MY DAUGHTERS AND MY EXPERIENCE TO AS MANY FORUMS AS POSSIBLE UNTIL THERE IS A FULL RECALL ON THESE TRUCKS. FORD IS COMPLETELY AWARE OF THE SITUATION, DON'T LET THEM GET AWAY THIS. *TR

Mileage: 34,341

I OWN A 2005 FORD F-250 CREW CAB 4X4 LONG BED TRUCK ALL STOCK. WHEN DRIVING AT SPEEDS ABOVE 55 MILES PER HOUR I EXPERIENCE VIOLENT SHAKING FROM THE FRONT END WHICH IS CALLED DEATH WOBBLE AFTER DOING RESEARCH. FORD SAYS THAT THERE IS NOTHING WRONG WITH THE TRUCK AND THAT IT IS FINE. THE WOBBLE ONLY STOPS WHEN MY SPEED IS DECREASED UNDER 40 MPH OR SO. WHEN THIS HAPPENS THE TRUCK IS EXTREMELY HARD TO CONTROL AND REQUIRES YOU TO SLAM ON THE BRAKES AT HIGH SPEEDS. I HAVE FOUNDS HUNDREDS OF PEOPLE ONLINE WITH THE SAME PROBLEM WITH THE 05-06 SUPER DUTY TRUCKS. THIS HAS HAPPENED TO ME DOZENS OF TIMES AND I'M TIRED OF IT. I PUT A LARGER SIZE TIRE ALL THE WAY AROUND AND IT DIDN'T HELP ANY. *TR

Mileage: 40,000

FRONT END SHAKES VIOLENTLY WHEN TRAVELING FASTER THAN 50 MPH WHEN YOU HIT A SMALL IMPERFECTION IN THE ROAD. *TR

Mileage: 30,000

TL*THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 60 MPH, THE VEHICLE SHAKES VIOLENTLY. THE FAILURE INITIALLY OCCURRED WHEN SHE HIT A SMALL BUMP IN THE ROAD. THE VEHICLE IS CURRENTLY AT THE DEALER FOR SERVICE. THE DEALER HAS NOT YET DIAGNOSED THE CAUSE OF FAILURE. THE VIN, ENGINE SIZE, AND # OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 25,000.

Mileage: 25,000