2006 FORD F-250 Engine And Engine Cooling Problems

TL*THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING AT 3 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT IT FAILED TO RESPOND. IN ADDITION, THE CONTACT NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN STATED THAT THE OIL COOLER, THE EXHAUST BACK PRESSURE SENSOR, THE TURBO AND THE EGR VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.

Mileage: 160,000

THE TRUCK WAS ON A MAJOR INTERSTATE (I-81 NEAR BLACKSBURG EXIT 118A,B,C) DRIVING UPHILL. WHILE TRYING TO MERGE INTO THE RIGHT LANE FROM THE MIDDLE LANE, WHILE LETTING OF THE ACCELERATOR THE ENGINE DIES. AT THIS POINT LOST ALL POWER INCLUDING BRAKES AND STEERING CONTROL. SINCE THERE WAS NO TRAFFIC IMMEDIATELY BEHIND THE TRUCK THEN WAS ABLE TO PULL OVER TO THE FIRST LANE AND GET OFF THE SHOULDER. THE TRUCK DIED AND FORTUNATELY DUE TO LOW TRAFFIC ABLE TO MANEUVER TO THE SHOULDER. AT THAT POINT, TRIED TO START THE TRUCK AND IT WOULD NOT START SO HAD TO REMAIN ON THE SIDE OF INTERSTATE UNTIL HELP COULD ARRIVE. STRANDED ON THE SIDE OF THE INTERSTATE. TRUCK WAS TOWED TO DEALERSHIP. FORD BLOGS INDICATE THERE IS A KNOWN PROBLEM THAT HAS GONE UNADDRESSED. *TR

Mileage: 142,000

UPON ACCELERATION, FROM STOP AT A RED LIGHT, VEHICLE HESITATED (STALLED) TO ACCELERATE. UPON ACCELERATION, AFTER SEVERAL SECONDS, THICK CLOUD OF BLACK SMOKE APPEARED FROM EXHAUST PIPE, AND WHITE SMOKE DISCHARGED FROM ENGINE OIL (FILL) TUBE. VEHICLE CONTINUED WITH DESCRIBED PROBLEM(S) FOR THE REST OF THE TRIP, WHICH WAS APPROXIMATELY TEN (10) MINUTES, AND HAS CONTINUED WITH DESCRIBED PERFORMANCE PROBLEMS FOR MANY DAYS SINCE. THIS PROBLEM AROSE AFTER SPENDING OVER $2000 TO HAVE SIMILAR ENGINE PROBLEMS FIXED, AT FORD AUTHORIZED DEALERSHIP. UPON CONTACTING FORD MOTOR COMPANY, DIRECTLY (FOR FINANCIAL ASSISTANCE ON FIXING THE PROBLEM FOR THE SECOND TIME), I WAS INFORMED THAT THERE WOULD BE NO SUCH ASSISTANCE GRANTED. PERIOD. *JS

Mileage: 127,000

2006 FORD F-250. CONSUMER STATES PROBLEM WITH EGR COOLER/EGR VALVE *TGW THE CONSUMER STATED THE PURPOSE OF THE EGR COOLER WAS TO COOL THE EXHAUST. AFTER MAKING SOME INQUIRIES, IT WAS BROUGHT TO HER ATTENTION THAT IT WAS A VERY COMMON PROBLEM. THE CONSUMER WAS INFORMED SINCE THE EGR VALVE WAS NOT MANUFACTURED PROPERLY, IT WAS GETTING PLUGGED UP WITH WET CARBON. THE CONSUMER WAS INFORMED IT WOULD COST $3,000 TO FIX THE PROBLEM. *JB

EGR AND OIL COOLER FAILURE...CAUSED ENGINE FAILURE AND HYDROLOCK SITUATION. THE ENGINE STOPPED THE TRUCK RIGHT IN THE MIDDLE OF AN INTERSECTION ALMOST CAUSING AN ACCIDENT. TOTAL COST OF REPAIRS TO MY VEHICLE $2542.42. SURE WOULD BE NICE FOR FORD TO HAVE A HAND IN THE REPAIRS DUE TO THEIR FAULTY ENGINE DESIGN. I HAVE READ 100'S OF REPORTS ONLINE ABOUT THIS AND FORD STILL WILL NOT FIX OR HELP PAY FOR THEIR ENGINE. FORD REFUSED TO HELP WITH REPAIR COST. I ONLY HAVE 98000K MILES. PLEASE LAUNCH AN INVESTIGATION INTO THESE COMPLAINTS. I BELIEVE YOU WILL FIND ENOUGH EVIDENCE TO WARRANT AN INVESTIGATION. I AM SURE THAT THE LOBBYIST AT FORD ARE DOING THEIR JOB TO KEEP THIS FROM BECOMING A RECALL SITUATION. IT IS HURTING NO ONE BUT THE OWNERS OF THIS 6.0L DIESEL ENGINE!!! WE NEED YOUR HELP! *TR

Mileage: 98,286

I HAVE A 2006 FORD F250 6.0 IT HAS BEEN TOWED 8 TIMES, I VE HAD TURBO,INJECTOR,ELECTRICAL,WHEEL,TRANS PROBLEMS SINCE DAY ONE OF PURCHASE. THERES OVER 16 PAGES OF MECHANICAL PROBLEMS THAT HAS BEEN PERFORMED AND COUNTING. I KNOW I AM NOT THE ONLY ONE THATS HAVING THESE PROBLEMS AND I CAN'T GET MUCH ASSISTANCE FROM FORD. IT GOING TO TAKE SOMEONE LIKE THIS AGENCY TO HELP US. THIS IS ALOT WHEN YOU PAY $51000.00 PLUS ADDITION REPAIRS FOR A VEHICLE WITH A EXTENTED WARR. *TT

Mileage: 139,000

TL* THE CONTACT OWNS A OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED DIFFICULTY ACCELERATING AT ALL SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT ALL OF THE SPARK PLUGS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 128,000.

Mileage: 128,000

VIOLENT SHAKING/ VIBRATIONS @ HIGHWAY SPEEDS. I PULLED OVER TO COMPLETE STOP, WAITED, STARTED UP AND VIBRATION STOPPED. THIS HAS HAPPENED ON 3 OCCASIONS SINCE. *TR

Mileage: 59,000

WHILE TRAVELING ON VACATION WITH A TRAVEL TRAILER IN TOW, THE TEMPERATURE GAUGE ON OUR 2006 FORD-F-250 (WITH A 5.4 LITER ENGINE) INDICATED THE ENGINE WAS OVERHEATING. AFTER STOPPING SEVERAL TIMES ON THE BERM OF AN INTERSTATE, THERE WAS NO INDICATION THAT THE ENGINE WAS HOT. SINCE WE WERE TRAVELING ON A HOLIDAY, THE TRUCK WAS FIRST TAKEN TO A PEP BOYS LOCATION WHERE THEIR EVALUATION SHOWED THERE WAS NO SIGN OF OVERHEATING. WE WERE ADVISED OF A SERVICE BULLETIN ISSUED ON THIS VEHICLE STATING THAT IT MIGHT EXHIBIT FALSE OVERHEATING. SO, WE CONTINUED OUR TRIP. TRUCK CONTINUED TO DISPLAY FALSE READINGS AND THE ENGINE STARTED TO DERATE. AT THIS TIME, WE HAD TO HAVE THE TRUCK TOWED TO A FORD DEALERSHIP, WHERE THEY INSTALLED AN UPDATED COOLANT CROSSOVER TUBE AND THERMOSTAT HOUSING TO CORRECT THE PROBLEM OF FALSE OVERHEATING. THIS WORK WAS DONE (PARTS & LABOR) AT A COST TO US OF $645.67 AFTER AAA DISCOUNT. THE COST TO US WAS A SURPRISE, AS THE DEALERSHIP WAS AWARE OF THE PROBLEM AND KNEW EXACTLY WHAT WAS NEEDED TO BE DONE TO RECTIFY IT. WE WERE TOLD THAT THIS KNOWN PROBLEM WAS A SERVICE BULLETIN NOT A RECALL BECAUSE IT IS NOT CONSIDERED A SAFETY ISSUE. HOWEVER, IT WAS VERY MUCH A SAFETY ISSUE FOR US AS WE WERE COMPELLED TO STOP SEVERAL TIMES ON THE SIDE OF A BUSY INTERSTATE BEFORE HAVING TO REQUEST THAT THE PICKUP AND TRAVEL TRAILER BE TOWED TO A SAFE LOCATION.

Mileage: 48,845

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE VEHICLE WAS EMITTING SMOKE FROM THE TAIL PIPE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT EGR COOLER, ENGINE COOLER, FUEL INJECTOR AND TURBO NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DID NOT OFFER ANY ASSISTANCE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WAS 63,500.

Mileage: 63,500

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH THE VEHICLE BEGAN TO ABRUPTLY DECELERATE UNTIL STOPPING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE EGR VALVE WAS STUCK IN AN OPENED POSITION. THE EGR VALVE WAS REPLACED. THE FAILURE HAD SINCE RECURRED TWICE. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE EGR COOLER AND OIL COOLER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 136,000.

Mileage: 136,000

I PURCHASED A 2006 FORD F 250 WITH THE TRITON 54 . I HAD IT FOR 2 DAYS WHEN THE MOTOR STARTED TICKING. I'M TOLD THAT IT'S A SPARK PLUG ISSUE AND NO ONE IS WILLING TO WORK ON IT DUE TO THE HIGH COST OF FIXING THE PROBLEM WHEN THE PLUGS BREAK OFF IN THE HEAD AND THEY ALSO SAID IT WILL PROBABLY BLOW A SPARKPLUG OUT . THIS WILL COST APROX. $3000 TO FIX . *TR

Mileage: 58,000

DURING REPLACEMENT OF SPARKPLUGS IN A 2006 FORD F-250, 5 PLUGS HAD TO BE BORED OUT DUE THE PLUGS DISINTEGRATING UPON ATTEMPTS TO REMOVE THEM. THE REPAIR COSTS ARE $600-800 TO REMOVE THE REMAINDER OF THE PLUGS AND INSTALL NEW PLUGS. WHEN THE FORD SERVICE REPRESENTATIVE WAS ASKED WHAT CAUSED THIS PROBLEM AND IF IT WOULD OCCUR AGAIN THE FOLLOWING ANSWER WAS PROVIDED. DURING PRODUCT ASSEMBLY AT THE FACTORY , NO LUBRICANT WAS PLACED ON THE SPARKPLUG THREADS IN "SOME MODELS", CAUSING THE BASE TO WELD ITSELF TO THE ENGINE. THIS CAUSED WHAT SHOULD BE A $300 REPAIR TO MORE THAN DOUBLE IN COST. FORD SHOULD HAVE TO BEAR REPAIR COSTS TO BORE OUT THE PLUGS, NOT THE CAR OWNER. THIS PROBLEM IS WIDELY KNOWN, BUT THE CONSUMER HAS NO COURSE OF ACTION EXCEPT A COSTLY LEGAL REMEDY. I WILL NO LONGER PURCHASE FORD PRODUCTS BASED ON MY RECENT PROBLEMS WITH THEIR PRODUCTS. *TR

Mileage: 70,000

TL*THE CONTACT OWNS A 2006 FORD F-250. WHEN THE CONTACT WOULD ATTEMPT TO START HIS VEHICLE HE NOTICED THAT THE KEY WOULD TURN INSIDE THE IGNITION BUT THE ENGINE WOULD NOT START. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC SHOP WHERE THE CONTACT WAS INFORMED THAT THE INJECTOR DRIVING MODULE WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 160000.

Mileage: 160,000

NO PSI FOR TURBO, AND TURBO BLEW OUT. *AK

Mileage: 24,000

TL* THE CONTACT OWNS A 2006 FORD F 250. THE TRANSMISSION WAS SLIPPING. ALSO, THE ENGINE AND THE 3RD CYLINDER FAILED. THE FAILURE MILEAGE WAS 28,000. THE CONTACT STATED THAT DUE TO THE YEAR OF THIS VEHICLE THE ENGINE AND TRANSMISSION SHOULD BE OPERATING NORMALLY. THE VEHICLE WAS REPAIRED. THE CURRENT MILEAGE WAS 34,000. *AK

Mileage: 28,000

F 250 2006 HD 4X4 LESS THAN 2000 MILES - DRIVING VEHICLE, WHILE TURNING AND GOING DOWN A HILL, STALLED OUT COMPLETELY:DASH BOARD LIGHTS ALL CAME ON. NO BRAKES OR STEERING. WENT OFF THE ROAD, INTO FRONT YARD OF HOME WHICH WAS FOR SALE, HIT FOR SALE SIGN, NICKED A TREE IN FRONT YARD AND INTO HANDICAP VAN IN DRIVEWAY, PUSHED VAN INTO NEIGHBORS YARD. HEAVY FRONT END DAMAGE SUSTAINED AND SIGHTED BY POLICE FOR "FAILURE TO CONTROL VEHICLE"!!! PURCHASING DEALER COULD FIND NO ISSUES. FIRST TIME THIS OCCURRED WAS 3 WEEKS AFTER NOV. 2005 PURCHASE. VEHICLE HAS BEEN REPAIRED, BUT DID IT AGAIN ON 2-3-2006. DEALER HAS BEEN NOTIFIED OF THIS AGAIN. STILL NO SOLUTION. OVER $10,000.00 DAMAGE TO BRAND NEW VEHICLE. FREE LOANER VEHICLE PROMISED WHEN PURCHASED "DOESNT APPLY TO BODY SHOP" OUT OF WORK WITH NO VEHICLE FOR 2.5 WEEKS. *JB

Mileage: 2,000