2018 FORD F-250 Engine Problems

Fuel pump faulted, engine would just cut off in middle of driving whether on highway, street, or interstate. Engine would randomly shut off. Took to ford dealership, they had to replace low pressure and high pressure fuel pumps, the dealership says this model is notorious for that, the fuel pumps tear apart and send metal into the fuel rail. This caused the truck to not get diesel and shut off. An extreme safety issue. Several times it happened while driving, and nothing prepared you for it to happen. Just saw where models I believe starting with 2020 have been recalled for same issue. Don’t understand why 18 models weren’t.

The contact owns a 2018 Ford F-250. The contact stated while driving 50 MPH, the vehicle shut off unintendedly and the contact lost control of the vehicle. The message engine power reduced was displayed. The vehicle was towed to the residence. The vehicle was taken to an independent mechanic who determined that the high-pressure fuel pump had failed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not under recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 127,460.

Mileage: 127,460

The contact owns a 2018 Ford F-250. The contact stated that the vehicle failed to start. There was no warning light illuminated before the failure. The contact was unsure if the vehicle was towed or taken to the local dealer, where it was diagnosed and determined that there was rust in the engine. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 80,000.

Mileage: 80,000

Below is what I'm experiencing with my vehicle and I want to see if there is anything I can do to get Ford to fix the problem. Is there anyway I can get my VIN on the affected list? The upper oil pan CSAT recall has affected a range of Ford F-250 models, primarily those equipped with the 6.7L Power Stroke diesel engine. While specific years can vary depending on the exact nature of the issue and the recall campaign, it's generally considered that models from 2011 to 2020 have been impacted. However, it's important to note that the best way to determine if your specific F-250 is affected by a recall is to: Check the NHTSA Recall Website: Visit the National Highway Traffic Safety Administration's website (NHTSA) and enter your vehicle's VIN to see if any recalls are active. Contact Your Local Ford Dealership: They can provide specific information on recalls and potential issues related to your vehicle's year and model. Consult the Ford Owner Website: You can often find recall information and service bulletins on the Ford Owner website. By following these steps, you can ensure that your F-250 is up-to-date with any necessary recalls and repairs.

Mileage: 127,671

The contact owns a 2018 Ford F-250. The contact stated that the vehicle hesitated while starting after multiple attempts without warning. The contact stated that in most times the vehicle would start-up; however, there were times when the vehicle would not start-up. Due to the failure, the battery had been replaced four times. The vehicle had been taken to the dealer on multiple occasions, but the mechanics were unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was also notified of the failure and acknowledged being aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was approximately 19,000.

Mileage: 19,000

The contact owns a 2018 Ford F-250. The contact stated while driving 75 MPH, the vehicle lost motive power, with the check engine warning light illuminated. The vehicle was restarted; however, the failure reoccurred. The vehicle was taken to the dealer where it was diagnosed and determined that the fuel pump had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 108,000. The VIN was not available.

Mileage: 108,000

While on vacation, driving down a major interstate, our truck suddenly lost power. The driver slowly navigated to the side of the road and by the time we stopped flames were coming out from under the engine. We quickly got ourselves and three children out of the vehicle that, within minutes, was completely engulfed in flames. It was noted by police and the wrecker company that diesel fuel was on the road behind the truck and on the trailer that we were pulling.

The contact owns a 2018 Ford F-250. The contact stated that the oil warning light illuminated, and the vehicle started to leak engine oil. The vehicle was taken to a dealer where a diagnostic test discovered that engine oil was leaking from the seals located on the upper oil pan. The manufacturer was notified of the failure and the contact was informed that there were no recalls on the VIN. The contact was then referred to the NTHSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 110,000.

Mileage: 110,000

Leaving stop sign turning right onto cross street. Touched accelerator pedal and truck lurched forward under what seemed to be full throttle. (Unintended Acceleration) Jammed on the brake pedal stopping vehicle. Engine still revs still high and rear tire started to squeal/spin on pavement. Grabbed shifter and threw into park then immediately grabbed key and turned vehicle off. Upon restart normal operation resumed. No mats in area of accelerator pedal. No ODBC error codes. Did not have foot on both pedals. Scheduled to go to dealer for investigation.

The contact owns a 2018 Ford F-250. The contact stated that while driving at approximately 65 MPH, the vehicle started shaking abnormally as if there was a blowout of one of the rear tires. The contact released the accelerator pedal and noticed there was no blowout. The contact then depressed the accelerator pedal and the shaking returned. The Engine Power Reduced message was displayed before the vehicle inadvertently shut off. The vehicle was coasted to the side of the road and started leaking fuel. The vehicle was towed to the dealer who diagnosed that the high-pressure fuel pump had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 147,000.

Mileage: 147,000

TL* THE CONTACT OWNS A 2018 FORD F-250. WHILE DRIVING DOWN A HILL IN LOW GEAR, THE VEHICLE INDEPENDENTLY ACCELERATED OUT OF CONTROL. THE VEHICLE WAS TAKEN TO EVERGREEN FORD (1500 18TH AVENUE NORTH WEST, ISSAQUAH, WASHINGTON, (425)-392-6900) WHERE THE CONTACT WAS INFORMED TO WARM UP THE VEHICLE BEFORE ATTEMPTING TO DRIVE. THE MANUFACTURER WAS CONTACTED AND STATED THAT ALL GASOLINE ENGINES WERE DESIGNED TO BE WARMED UP BEFORE ENGAGING IN LOW GEAR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 527. *DT THE CONSUMER WANTS ANOTHER COPY OF THIS EVOQ TO EDIT THE DOCUMENT. *TR

Mileage: 527

BEFORE THE V8 GASOLINE ENGINE REACHES SOME PRESCRIBED OPERATING TEMPERATURE ( BEFORE THE ENGINE IS FULLY WARMED UP ), WHEN HEADED DOWNHILL, NO LOW GEARS FUNCTION IN ANY MODE AND THE ENGINE EXPERIENCES SUDDEN UNINTENDED ACCELERATION. THE TRUCK WAS PURCHASED NEW IN 2018. THE FORD COMPANY HAS REPEATEDLY ACKNOWLEDGED THE DEFECTS, AND HOWEVER CLAIMS THAT ALL 2018 GASOLINE POWERED F250S ARE DESIGNED THAT WAY TO MEET CERTAIN STANDARDS AND THEREFORE EVERYTHING IS FINE DESPITE BEING EXTREMELY DANGEROUS IN CERTAIN CIRCUMSTANCES. PLEASE CONTACT ME FOR FURTHER ELABORATION WITH NAMES, DATES, AND PLACES. THANK YOU [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 527

2018 FORD F-250 WAS PARKED WITH ENGINE OFF WHEN FIRE STARTED UNDER THE INTERIOR CABIN. FIRE SPREAD THROUGH-OUT THE VEHICLE AND COMPLETELY ENGULFED THE TRUCK WITHIN MINUTES. COMPLETE BURN