1999 FORD F-350 SD Power Train Problems

1999 FORD F-350 SUPER DUTY P/U CLUTCH SLAVE CYLINDER FAILED W/O WARNING. TRUCK WOULDN'T COME OUT OF FORWARD GEAR. CLUTCH PEDAL INEFFECTIVE - WENT TO FLOOR AND STAYED. NARROWLY MISSED WOMAN AND TWO CHILDREN CROSSING INTERSECTION. TRUCK BRAKES WOULDN'T STOP OR HOLD THE TRUCK. FORWARD MOTION CONTINUED UNTIL IGNITION WAS SHUT OFF. THIS IS THE SECOND TIME THIS HAS HAPPENED. THE FIRST TIME TRUCK ALMOST WENT THROUGH SHOPPING CENTER WINDOWS. FORD CHARGES OVER $500 TO REPLACE THE PART, WHICH WILL AGAIN FAIL AND PROBABLY CAUSE DEATH OR SERIOUS INJURY. *TR

Mileage: 55,000

DRIVING MY 1999 F350 FORD CREW CAB LONG BOX. VEH IS A 7.3 DIESEL WITH A 6ZF 6SPD TRANSMISSION. TRAVELING 75MPH THE VEHICLE DEVELOPS A MILD VIBRATION. I PUSH IN THE CLUTCH TO PULL OUT OF TRAFFIC, THE REAR DRIVE LINE FLANGE BOLTS SHEER OFF AT THE TRANSFER CASE, THE DRIVE LINE KNOCKS A HOLE IN THE FLOOR BOARD OF THE VEHICLE CAVES IN THE CATALYTIC CONVERTER TEARS OUT THE CARRIER BEARING AND SEPARATES THE TWO PIECE DRIVE SHAFT. THE REAR SECTION OF THE DRIVE SHAFT HITS THE RIGHT REAR WHEEL SENDING THE REAR OF THE TRUCK AIRBORNE AND BREAKING THE DRIVE LINE OFF AT THE REAR AXLE. FURTHER INSPECTION I FIND THE TRANSFER CASE HAS BEEN TORN FROM THE TRANSMISSION EXTENSION HOUSING DESTROYING THE TRANSMISSION HOUSING. THIS TRUCK HAS 124000 MILES ON IT HAS NEVER HAD WORK ON THE DRIVE TRAIN. AND INSPECTION OF THE DRIVE TRAIN LESS THAN A YEAR AGO SHOWED NO SIGNS OF EXCESS WEAR. *TR

Mileage: 124,000

WHILE PULLING A TRAILER IN 4 WHEEL DRIVE (BECAUSE OF GROUND CONDITIONS) THE FRONT PINION SHAFT SNAPPED. DURING RESEARCH FOR REPAIR PART MOST PEOPLE ASSOCIATED WITH THE NEEDED REPAIR WERE AWARE THAT THE PROBLEM EXISTED. I WAS EVEN TOLD BY A DANA EMPLOYEE THAT THE PINIONS WERE NOT HEAT TREATED PROPERLY. *TR

Mileage: 115,000

TL*THE CONTACT OWNS A 1999 FORD F350 SUPER DUTY. WHEN THE CONTACT ATTEMPTED TO ACCELERATE, THE VEHICLE WOULD NOT TRANSITION FROM IDLE OR GAIN SPEED. IT WOULD TAKE MINUTES FOR HIM TO SWITCH OUT OF IDLE MODE. THE FAILURE OCCURRED AT LEAST FOUR TIMES. THE CONTACT TOOK THE VEHICLE TO THE DEALER THE FIRST TWO TIMES AND REPAIRED IT UNDER WARRANTY. DURING THE LAST TWO OCCURRENCES, HE TOOK THE VEHICLE TO A PRIVATE REPAIR SHOP ONCE AND ANOTHER TIME REPAIRED THE ISSUE HIMSELF. THE THROTTLE PEDAL ASSEMBLY WAS THE COMPONENT THAT NEEDED TO BE REPLACED. THE MANUFACTURER STATED THAT THEY WOULD NOT TAKE ANY ACTION FOR THE FAILURE. THE CURRENT MILEAGE IS 138,754 AND FAILURE MILEAGE WAS 30,573. UPDATED 11/14/08 *LJ UPDATED 11/18/08.*JB

Mileage: 30,573

(1) DRIVING MY 1999 FORD F-350 SUPER DUTY DIESEL HOME FROM WORK. (2) I PUSHED IN THE CLUTCH PEDAL TO SHIFT DOWN, THE CLUTCH FAILED TO RELEASE AND THE PEDAL STUCK TO THE FLOOR. I ENDED UP IN THE MIDDLE OF AN INTERSECTION AVOIDING A COLLISION. THE TRUCK IS UNDRIVEABLE, BLOCKING TRAFFIC, AND REQUIRED TOWING. (3) THE CLUTCH RELEASE FOR HAD CRACKED AND BENT ALSO CAUSING A FAILURE OF THE CLUTCH HYDRAULIC CIRCUIT. REPLACEMENT OF THE RELEASE FORK AND HYDRAULIC CIRCUIT RESTORED THE TRUCK TO OPERATION CONDITION. THE PART NUMBER OF THE NEW CLUTCH RELEASE FORK WAS DIFFERENT THAN THAT OF THE ONE REMOVED, LEADING ME TO SUSPECT A PROBLEM WITH THE STOCK RELEASE FORK. ORIGINAL RELEASE FORK PART NUMBER F61A-7515-BE. NEW INSTALLED RELEASE FORK PART NUMBER YC3Z-7515-BB. I HAVE RETAINED THE OLD RELEASE FORK AT MY HOME ADDRESS.*JB

Mileage: 34,748

I HAVE HAD 2 SUPER DUTY'S NOW A 2000 F350 AND A 1999 F350 ON THE 2000 . I HAD THE LEFT FRONT WHEEL BEARINGS FAIL AT 45K AND THE RIGHT AT 53K MILES RUNNING STOCK TIRES AND WHEELS WHEN THE RIGHT SIDE FAILED THE WHEEL ALMOST CAME OFF I HAD TO BE TOWED I SOLD THAT TRUCK THINKING I WAS NOT HAPPY ABOUT IT AND GOT THIS ONE THE 99 BOTH FRONT WHEEL BEARINGS ARE OUT. I LOOKED ON THE WEB THIS IS A HUGE PROBLEM WITH THESE TRUCKS CAN'T EVEN GREASE THEM AND THEY ARE $550 EACH. *JB

Mileage: 165,000

DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 98V303000 CONCERNING THE AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE . THIS VEHICLE EXPERIENCED THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK UPDATED 1/4/2006 - THE VEHICLE HAD A HOSE BREAK THAT WENT THROUGH THE TRANSMISSION COUPLER RESULTING IN DAMAGE TO THE TRANSMISSION. WHEN THE VEHICLE WAS TOWED OFF THE ROAD AND AT A COMPLETE STOP THE DRIVER'S AIR BAG DEPLOYED. THE TRANSMISSION HAS BEEN REPAIRED BUT THE AIR BAG HAS NOT. *NM

A RATTLING NOISE CAN BE HEARD COMING FROM THE AUTOMATIC TRANSMISSION. THE FLUIDS WERE CHANGED BUT THE NOISE CAN STILL BE HEARD. ALSO, THERE IS A TIRE COMPLAINT. THE LEFT FRONT TIRE DISINTEGRATED WHILE DRIVING 50 MPH. *AK PER RESULTS PERFORMED; THERE WERE METAL(S) UNDERLINED WERE ELEVATED EXCESSIVE WEAR. THE LEFT FRONT TIRE BLEW OUT AND CAUSED THE VEHICLE TO GO HARD TO THE LEFT, AND A FEW WEEKS LATER, THE VEHICLE BEGUN TO JUMP AND SEPARATED LIKE THE FIRST TIRE INCIDENT. A WHINE/GRINDING NOISE WOULD ALSO BE DISPLAYED WHEN THE VEHICLE WAS DRIVEN BELOW 35 MPH. *SC

Mileage: 37,000

I HAVE HAD MANY PROBLEMS WITH A VEHICLE I PURCHASED NEW IN 1999. IT HAS BEEN IN THE DEALER'S SERVICE SHOP MULITPLE TIMES AND ALSO FOR THE SAME PROBLEMS. MOST RECENTLY IS A PROBLEM I HAVE HAD THE DEALER INSPECT AND TRY TO FIX 4 TIMES AND IT IS STILL A PROBLEM. APPARENTLY THE 4X4 IS NOT FULLY DISENGAGING AND CAUSES MANY PROBLEMS WHILE IN 2-WHEEL DRIVE. I AM TAKING IT IN AGAIN FOR THE 5TH TIME FOR THIS PROBLEM ON MONDAY AND I AM AT A COMPLETE LOSS. I PAID A LOT OF MONEY FOR THIS TRUCK AND HAVE HAD NOTHING BUT PROBLEMS WITH IT AND THEY ARE ONGOING. PLEASE HELP!!!*AK

Mileage: 32,000

STANDARD 6 SPEED TRANSMISSION WOULDN'T GO INTO REVERSE OR FIRST GEAR AND WOULDN'T COME OUT OF GEAR. THIS WAS CAUSED BY A BAD CLUTCH INSTALLED AT TIME OF MANUFACTURING. *AK

Mileage: 20,000

STANDARD 6 SPEED TRANSMISSION WOULDN'T GO INTO REVERSE OR FIRST GEAR AND WOULDN'T COME OUT OF GEAR. THIS WAS CAUSED BY A BAD CLUTCH INSTALLED AT TIME OF MANUFACTURING. *AK

Mileage: 20,000

CONSUMER CALLED COMPLAINING ABOUT HAVING CLUTCH PROBLEMS. STATED THAT WHILE DRIVING AND STEPPING ON THE CLUTCH, CLUTCH WILL NOT COME OUT, AND THE VEHICLE KEEPS ON RUNNING BY ITSELF.*AK

THE TORQUE CONVERTER WENT OUT AND DESTROYED THE TRANSMISSION. HAD TO HAVE COMPLETE REPLACEMENT THAT FORD SAID WOULD NOT BE COVERED. VEHICLE HAD 75,000 MILES. *JB

TRANSMISSION "PARK" FAILURE. *JB

Mileage: 47,382

I PURCHASED A 1999 F-350 SUPER DUTY DUALLY. FROM RECORDS FROM THE PERVIOUS OWNERS PROBLEMS AND THE PROBLEMS I HAVE HAD WITH THIS TRUCK, I CAN NOT BELIVE SERVICE PROBLEMS I HAVE HAD. A COUPLE OF MONTHS AGO THE PARKING BRAKE BLEW WHEN I WAS ON ALMOST LEVEL GROUND AND NEED LEAST TO SAY THE TRUCK ROLLED AND CRASHED, LUCKY NOT ONE WAS HURT.BUT IT DID QUIT A BIT OF DAMAGE TO THE TRUCK AND MY TRAILOR. NOW I KNOW THIS IS A PROBLEM ON THESE FORDS BUT NOT YET ON MY PERTICULARE TRUCK. ALSO IN THE LAST THREE MONTHS I HAVE PUT IN A NEW CLUTCH WITCH IS EXPECTED. AND HAVE HAD CLOSE TO $ 3,000 IN BRAKE REPAIRS????? THAT WAS NOT!!!DRUMS CRACKING,HUBS EXPLOADING WITCH I UNDERSTAND IN A PROBLEM TOO BUT NOT ON MY TRUCK YET?????? PLEASE HAVE SOME ONE CONTACT ME I NEED SOME GUIDENCE, INFORMATION, HELP I HAVE HAD NO HELP FROM FORD.

Mileage: 103,000

WHILE DRIVING ON HIGHWAY TRANSMISSION/OVERDRIVE WENT OUT AND COULDN'T SHIFT INTO ANY GEARS. CONTACTED DEALER. DEALER PUT IN A NEW TRANSMISSION. 15000 MILES LATER, TRANSMISSION WENT OUT AGAIN. CONTACTED DEALER AGAIN, AND AT 26000 MILES TRANSMISSION WENT OUT ONCE MORE. THIS WAS THE 7TH TRANSMISSION REPLACED.*AK