2001 FORD F-350 SD Electrical System Problems

AFTER THE FACT HEADS UP REGARDING POTENTIALLY CATASTROPHIC POWER LOSS. AT ABOUT 10 YEARS AND 100,000 MILES THE VEHICLE STARTED BLOWING THE #19 5AMP FUSE, DASHBOARD LIGHTS GO OUT BUT THE DANGEROUS CONSEQUENCE IS A LOSS OF POWER, CAN'T CLEAR TRAFFIC IN A LEFT TURN OR GO UP HILL, HAVE TO BACK DOWN. KNOWN PROBLEM ONLINE, SOME PEOPLE JUST REPLACE THE FUSE WITH A 10AMP, THE CAUSE IS A WIRE IN THE STEERING COLUMN WAS THROUGH IT'S INSULATION AND SHORTS. MINE HAPPENED MORE FREQUENTLY ALWAYS AFTER TURNING LEFT. FORD SERVICE IGNORED THE ONLINE INFO AND TOLD ME I NEEDED A NEW $700 FUEL PUMP. THAT DID NOT HELP AND I DEMANDED THEY OPEN THE STEERING COLUMN AND FIX THE WIRE, NO PROBLEMS SINCE, I AM ASSUMING THIS HAS NEVER BEEN REPORTED SINCE I HAD TO GOOGLE FOR THE ANSWER. I WAS LUCKY AN NEVER GOT HIT BY ANY ONCOMING OR FOLLOWING TRAFFIC, PARTICULARLY THRILLING TO BACK DOWN A NARROW STEEP STREET WITH LIMITED VISIBILITY.

Mileage: 100,000

TL*THE CONTACT OWNS A 2001 FORD F-350 DIESEL. THE CONTACT STATED THAT AFTER HAVING THE VEHICLE STORED IN A GARAGE FOR 11 MONTHS HE OBSERVED THAT IT WAS ENGULFED IN FLAMES. THE MANUFACTURER WAS CONTACTED AND REPLIED IN A LETTER ADVISING HIM THAT A RECALL NOTICE 09V399000 (VEHICLE SPEED CONTROL) WAS MAILED IN NOVEMBER 2010; HOWEVER, THE CONTACT NEVER RECEIVED THE LETTER. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 135,000.

Mileage: 135,000

I RECEIVED A "RECALL" NOTICE FROM FORD ABOUT MY F350 TRUCK, THE RECALL IS NOT LISTED ON YOUR WEB SITE???? LAST TIME I RECEIVED A "RECALL" FROM FORD I TOOK MY TRUCK TO THE LOCAL DEALER AND THEY LEFT ALL FOUR BATTERY CONNECTIONS LOOSE WHICH RUINED MY ALTERNATOR, THEY DENIED HAVING TOUCHED THE BATTERY CONNECTIONS YET THEIR OWN SERVICE REPORT HAD A CHECK MARK NEXT TO "BATTERY CONNECTIONS INSPECTED" NOW THEY SENT ME THIS RECALL ABOUT A SPEED CONTROL SENSOR AND WHEN I CALLED THE NUMBER PROVIDED THEY BASICALLY TOLD ME I HAVE NO RECOURSE IF THE LOCAL DEALER DAMAGES MY TRUCK AGAIN, AND IF I DO NOT BRING THE TRUCK IN FORD IS NOT RESPONSIBLE FOR MY INJURY OR ANY LOSS ASSOCIATED WITH THE "RECALL" HELP PLEASE! *TR

Mileage: 150,000

2001 FORD F350 SD 7.3 DIESEL AUTOMATIC TRANS. FUSE KEEPS BLOWING WHEN MANUALLY GEARING DOWN TO SECOND,SOMETIMES ALL ON ITS OWN. WHEN THIS HAPPENS, THE ENGINE GOES TO IDLE, THE THROTTLE DOESN'T RESPOND, THE GAUGES GO DEAD I'M DEAD IN THE WATER. SENSE I CAN'T PUSH THE TRUCK, I HAVE TO GET OUT AND REPLACE THE FUSE WHERE IT SETS TO GET GOING AGAIN. NOW MY OVERDRIVE LOCK OUT IS INOPERATIVE. MY MAIN CONCERN IS THAT THE TRUCK JUST STOPS MOVING, WHEN THE FUSE BLOWS RIGHT IN THE MIDDLE OF A INTERSECTION! SO HOW'S THAT FOR A SAFETY HAZARD? CAN ANYONE SPELL LAWSUIT? *TR

Mileage: 170,000

TRUCK BEGAN STALLING OUT COMPLETELY WHILE DRIVING AFTER HAVING CPS REPLACED ON A RECALL NOTICE. TRUCK WILL RUN ABOUT 20 MINUTES AND SHUT OFF WHILE DRIVING. AFTER 15-20 MINS, TRUCK WILL RESTART. OCCURS EVERY 20-30 MINUTES WHILE DRIVING. 2 CPS HAVE BEEN REPLACED BY DEALERSHIP, 3 FUEL FILTERS REPLACED, ALL OIL AND FILTER CHANGES UP TO DATE. ONLY RECEIPTS FOR PARTS AVAILABLE, NO ACTUAL PARTS.

Mileage: 149,000

2001 F-350 SD PICK UP WAS ON FIRE 5-6 HOURS AFTER I GOT HOME AND SHUT IT OFF. *TR

Mileage: 119,000

2001 FORD F-350 CAUGHT FIRE WHILE PARKED. AUTHORITIES CALLED THE FIRE DEPARTMENT TO COME EXTINGUISH THE FIRE. *KB THE CONSUMER STATED HE PREVIOUSLY HAD SOME WIRING REPAIRS MADE TO THE FUSE BOX GOING TO THE REAR LIGHTS, BECAUSE THE WIRING HAD MELTED. (OHIO TRAFFIC CRASH REPORT # 10-0110-50)*JB SENT IN ADDITIONAL VOQ. *KB UPDATED 04/14/08. *KB THE CONSUMER ALSO STATED THE FRONT WHEEL BEARING HAD FAILED PRIOR TO THE FIRE.

Mileage: 380,000

TL*THE CONTACT OWNS A 2001 FORD F350 SUPER DUTY. WHILE DRIVING 35 MPH, THE ENGINE STALLED AND THE VEHICLE LOST ALL ELECTRICAL POWER. THE VEHICLE BECAME EXTREMELY DIFFICULT TO STOP AND STEER. THE FAILURE RESULTED IN A NEAR CRASH. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. NHTSA INITIATED AN INVESTIGATION (NHTSA ACTION NUMBER PE06011). THE VIN WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 100,000.

Mileage: 100,000

TL*THE CONTACT OWNS A 2001 FORD F350 SUPER DUTY. THE CONTACT NOTICED SMOKE RISING FROM THE HOOD WHILE THE VEHICLE WAS IDLING. HE OPENED THE HOOD AND NOTICED FLAMES COMING FROM THE WIRING HARNESS. THE DEALER STATED THAT THE SPEED CONTROL SENSOR MAY HAVE CAUSED THE FIRE. HIS VIN WAS NOT INCLUDED IN RECALL NUMBER 06V286000 FOR THE VEHICLE SPEED CONTROL BECAUSE HIS VEHICLE HAS A DIESEL ENGINE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 189,000 AND CURRENT MILEAGE WAS 193,000.

Mileage: 189,000

CPS- CAM POSITION SENSOR FAILURES. 2001 F350 7.3 POWERSTROKE. WHILE DRIVING THRU A CONSTRUCTION ZONE ON I-40 WESTBOUND, TRUCK JUST DIED. LUCKILY I WAS ABLE TO GET OFF THE ROAD WITH OUT BEING RUN OVER BY EXTREMELY HEAVY TRAFFIC. TRUCK WAS TOWED TO FORD DEALER AND THE TECHNICIAN SAID TRUCK DIED TO CPS FAILURE. 02/2005. CPS FAILURE AGAIN,04/18/2007 BUT THANK GOD THIS TIME IT WAS IN THE INTEL PARKING LOT. I HAD TRUCK TOWED HOME. 107 DOLLARS FOR CPS. REPLACED CPS AND TRUCK IS ONCE AGAIN RUNNING FINE. FORD CORPORATION IS FULLY AWARE OF THIS PROBLEM WITH THIS SENSOR AND WILL DO NOTHING ABOUT IT. THIS IS A EXTREMELY DANGEROUS PROBLEM THAT COULD HAVE ENDED TRAGICALLY FOR ME. *TR

Mileage: 97,027

THE CPS ON MY F-350 FORD HAS GONE OUT NOW TWO DIFFERENT TIMES. THIS IS A PART THAT SHOULDN'T BE FAILING ALL THE TIME. BOTH TIMES I WAS TOWING TRAILERS AND HAD A HARD TIME GETTING THE TRUCK TO STOP WHEN THE ENGINE TURNED OFF. *JB

Mileage: 78,000

FORD F350 SUPER DUTY XLT LARIAT 7.3L POWERSTROKE DIESEL 2001 MODEL MY TRUCK HAS A FACTORY INSTALLED ENGINE BLOCK HEATER, WHICH I HAVE TO USE TO GET IT TO START ON COLD MORNINGS. AT 7:15AM, I WAS TALKING TO MY WIFE ON OUR CORDLESS PHONE & IT WENT DEAD. AFTER SOME SEARCHING, I FOUND OUT THAT THE CIRCUIT BREAKER HAD TRIPPED. THIS CIRCUIT BREAKER POWERS THE WALL THE PHONE BASE STATION WAS PLUGGED INTO, AND THAT WALL IS SHARED WITH THE GARAGE. AFTER SOME MORE SEARCHING, I COULD NOT LOCATE THE SHORT THAT CAUSED THE TRIP AND I RESET THE BREAKER. IT TRIPPED AGAIN. I HAD TO TAKE MY DAUGHTER TO SCHOOL, SO I FIGURED I WOULD WAIT AND LOOK SOME MORE WHEN I CAME HOME. I OPENED MY GARAGE DOOR TO FIND MY TRUCK ON FIRE. THE PLUG FOR THE ENGINE BLOCK HEATER HAD SHORTED OUT, MELTED & CAUGHT FIRE....THIS CAUGHT MY TRUCK ON FIRE. THE BACK SIDE OF THE PLUG HAD MELTED AND THE WIRE HAD BURNED AND BECOME DISCONNECTED. NO OTHER PART OF THE WIRE WAS DAMAGED....ONLY THE PLUG. I CALLED FORD, AND THEY SAID THAT IT WAS NOT PART OF A RECALL & THE COULD DO NOTHING FOR ME. MY CONCERN IS THAT, OTHER THAN FEELING A LITTLE "PUT OUT" AT THE SITUATION & HOW I WAS TREATED BY FORD, WHAT IF I HAD PULLED MY TRUCK AS FAR FORWARD AS I USUALLY DO.....THERE IS AN ORNAMENTAL PINE TREE AT THE CORNER OF MY HOUSE......AND THE FLAMING MOLTEN PLASTIC FROM MY TRUCK HAD DRIPPED ON THE PINE NEEDLES & CAUGHT THE PINE TREE ON FIRE........THIS WOULD HAVE ENGAGED MY HOME. AND, WHAT IF IT HAD HAPPENED AT NIGHT & I HAD NOT PUT IT OUT RIGHT AWAY. I DON'T WANT THIS TO HAPPEN TO SOMEONE ELSE. BY THE WAY, THE PLUG ON MY ENGINE BLOCK HEATER HAS ALWAYS BEEN WARM TO THE TOUCH WHEN PLUGGED IN. I HAVE NEVER HAD A DIESEL BEFORE & ASSUMED THIS WAS NORMAL DUE TO THE AMOUNT OF ELECTRICAL CURRENT THAT THE HEATER PULLED, AND THE MECHANIC SAID THIS WAS TRUE. MY NEW ENGINE BLOCK HEATER WORKS JUST FINE & THE PLUG IS NOT WARM TO THE TOUCH. OBVIOUSLY, IT WAS DEFECTIVE FROM THE TIME I BOUGHT IT. *NM

Mileage: 41,000

(1) ON 13 DEC 06 TRUCK (APPROXIMATELY 57000 MILES ON VEHICLE) QUIT RUNNING ON MAIN ARTERY, NO LEADING SYMPTOMS (2) HAD TRUCK SERVICED AT BLACK FOREST AUTO CENTER (LOCAL) AND REPLACE CPS- CAM POSITIONING SENSOR (3) TRUCK RUNS FINE...THIS IS THE SECOND. *JB

Mileage: 57,340

MY F-350 SUPER DUTY DIESEL SUDDENLY SHUT DOWN WHILE DRIVING DURING RUSH HOUR WITHOUT ANY WARNING, LOSING TOTAL POWER: POWER STEERING AND BRAKES. NOT BEING ABLE TO MOVE IT DUE TO TRAFFIC AND SINCE IT WOULDN'T START POLICE WERE NOTIFIED SO THAT AN ACCIDENT WOULD NOT OCCUR. EVENTUALLY IT WAS TOWED TO A NEAR BY PARKING LOT AND THEN TOWED DIRECTLY TO THE DEALER WHERE THEY NOTIFIED ME THAT MY CAM SENSOR WAS BAD AND NEEDED TO BE REPLACED. NOT THINKING MUCH OF IT A FEW DAYS LATER SOMEONE TOLD ME THAT THEY ARE KNOWN FOR GOING BAD AND I HAD BETTER KEEP ONE IN MY GLOVE BOX AS A SPARE OR I MIGHT FIND MYSELF STRANDED AGAIN. THIS CONCERNS ME SINCE MY WIFE SOMETIMES DRIVES IT AND WE HAVE 3 CHILDREN, NOT TO MENTION THAT IT COST ME $420.00. *JB

Mileage: 49,000

CPS FAILURE. SHUTS TRUCK DOWN. BRAKES ARE BOOSTED VIA POWER STEERING. RESULTING IN LOSS OF BRAKES. *NM

Mileage: 55,000

2001 FORD F-350. ENGINE STALLING, HESITATION. ADVISED PROBLEM WAS CPS FAILURE, COMMON PROBLEM ON FORD POWERSTROKE DIESELS. AFTER MANY STALLS, OLD CPS WAS REPLACED, WAS ADVISED THAT CPS FAILURE CAN HAPPEN OFTEN, EVEN WITH A NEW UNIT. OLD CPS IS AVAILABLE. NO ACCIDENT HAS OCCURRED YET BUT I'M CONCERNED THAT ANOTHER CPS FAILURE COULD BE CATASTROPHIC. *NM

Mileage: 136,655

I HAVE A 2001 FORD F-350 WITH THE 7.3 DIESEL MOTOR. I HAVE REPLACED THE CAM SENSOR IN IT TWICE AND THERE ARE MANY PEOPLE ON THE INTERNET UPSET ABOUT THIS. WHEN THE CAM SENSOR FAIL THE TRUCK SHUTS DOWN WHICH CAUSES LOSS OF POWER STEERING, POWER BRAKES, AND ALL CONTROL OF THE TRUCK AND THERE IS NO WAY TO TELL WHEN IT IS GOING TO FAIL. FOR HAS NO RECALLS ON THIS SENSOR AND HAS HAD MANY PROBLEMS WITH IT AND NOTHING IS BEING DONE. IF THIS PROBLEM IS NOT FIXED THEN ITS IS GOING TO KILL SOMEONE IF IT HASN'T ALREADY. I TOW A 3-CAR HAULER WITH THIS TRUCK, IT'S REALLY DANGEROUS WHEN THE ENGINE SHUT DOWN WITH NO WARNING. SOMETIMES THE ENGINE MAY BE RESTARTED AND OTHER TIME I HAD TO WAIT 45 MINUTES.

Mileage: 135,000

SPARK PLUG BLOW OUT ON MY 01 FORD F-350 V-10. LOSS OF POWER UN DRIVABLE. THE TRUCK ONLY HAS 35K MILES. I CALLED COLEY FORD TO GET INFO, THEY TOLD ME TO CALL FORD CUSTOMER CARE TO SE IF THEY CAN HELP WITH THE EXPENSIVE COSTS! I WAS BASICALLY TOLD TO BAD CANT HELP, & IT ONLY HAD 35K MILES AT THE TIME IT HAPPENED BUT WAS ALMOST 4 YRS AFTER TIME OF PURCHASE. *NM

Mileage: 35,300

ELECTRONIC PROBLEM, CAUSING THE VEHICLE TO STALL, IT STALL ON THE FREEWAY CAUSING A COLLISON BETWEEEN MY VEHICLE AND A SEMI, SEMI SIDESWIPED MY VEHICLE TEARING OFF THE DRIVER'S SIDE MIRROR.*AK

Mileage: 17,000

CONSUMER STATES THAT INTERMITTENTLY THE IGNITION SWITCH BINDS/STICKS AND WILL NOT TURN TO THE LOCK POSITION, IT IS DIFFICULT TO REMOVE THE KEY. DEALER REPLACED IGNITION KEY AND SWITCH. *TT