2008 FORD F-350 SD Engine And Engine Cooling Problems

ON SEPTEMBER 30, 2014, MY WIFE WAS ON HER WAY TO COLUMBUS, OHIO IN HER 2008 FORD F350 SUPER DUTY TURBO DIESEL TRUCK WITH 44,000 MILES. SHE'S PULLING HER 2014 26 LAKOTA TWO HORSE TRAILER WITH LIVING QUARTERS WITH HER SHOW HORSE ($30,000) IN THE BACK. THE UNEXPECTED HAPPEN WHILE SHE WAS ON MD-51N NEAR CUMBERLAND, MARYLAND HEADING ACROSS A BRIDGE WITH HEAVY TRAFFIC AT 1230PM. THE CHECK ENGINE LIGHT CAME ON FOLLOWED BY A PULL OVER SAFELY' MESSAGE. TWENTY SECONDS (20 SECONDS) LATER, THE TRUCK COMPLETELY SHUT DOWN. WIFE WAS TRAVELING AT 70 MILES AN HOUR WHEN THE TRUCK SHUT DOWN, WHICH TURNED THE POWER STEERING OFF. THIS IS WHAT I CALL UNSAFE FOR ANYONE, ESPECIALLY WHEN PULLING A 26 HORSE TRAILER WITH AN EXTRA 1000LBS IN THE BACK WITH A HORSE. SHE WAS NOT ABLE TO GET COMPLETELY OFF THE ROAD BECAUSE IS SHUTDOWN ON THE BRIDGE BLOCKING THE RIGHT LANE WHICH ALMOST CAUSED A MAJOR ACCIDENT DUE TO THE VEHICLE SHUTTING DOWN ON HER. WHILE WAITING ON THE BRIDGE, HER TRAINER HAD TO TURN AROUND HIS EIGHTEEN WHEELER SO MY WIFE COULD UNLOAD HER HORSE AND LOAD IT IN HIS TRAILER. THIS COMPLETELY SHUTDOWN THE TRAFFIC ON MD-51N WHICH IS NOT SAFE UNLOADING AND LOADING A HORSE.AFTER SITTING ON THE SIDE OF THE ROAD WAITING FOR AAA TO COME TOW THE VEHICLE FOR OVER 1 HOURS, THE VEHICLE STARTED BACK UP AND SHE DROVE IT TO FORD CUMBERLAND, 10335 MT SAVAGE ROAD NW, CUMBERLAND, MD WITH THE CHECK ENGINE LIGHT STILL ON WITH A POLICE ESCORT SINCE THE SHERIFF OF CUMBERLAND SAT WITH MY WIFE ON MD-51N WAITING ON AAA. THIS IS AFTER SHE WAS ALMOST HIT BY A FEDEX EIGHTEEN WHEELER DUE TO NOT BEING ABLE TO GET TO A SAFE LOCATION FOR A TRUCK AND HORSE TRAILER DUE TO THE VEHICLE SHUTTING DOWN ON HER. THE DEALERSHIP FOUND THE PROBLEM: EXHAUST SENSOR. THEY WERE ABLE TO REPAIR IT AND SHE WAS ABLE TO CONTINUE ON WITH HER TRIP. HOW CAN THIS SENSOR GO OUT ON A TRUCK WITH ONLY 44,000 MILES ON IT? *TR

Mileage: 44,000

TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT EXHAUST FUMES EMITTED INSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE EXHAUST FILTER WAS POORLY DESIGNED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 07/03/14 MA THE CONSUMER STATED THE FUMES IN THE VEHICLE CAN CAUSE ONE TO FEEL ILL. UPDATED 07/11/2014 *JS

Mileage: 120,000

TWO 2008 FORD F-350. CONSUMER WRITES IN REGARDS TO A DESIGN FLAW IN BOTH VEHICLES CURRENT RADIATORS. *SMD FORD'S RECOMMENDATION WAS TO REPEATEDLY REPLACE THE PART AT A COST OF $ 1300. *JB

2008 FORD F350 SUPER DUTY. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO ENGINE PROBLEMS, EGR VALVES AND HIGH PRESSURE FUEL PUMPS FAILURE THAT MANUFACTURER HAS FAILED AND REFUSED TO REPAIR. *SMD

2008 FORD F350 SUPER DUTY. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO ENGINE PROBLEMS, EGR VALVES AND HIGH PRESSURE FUEL PUMPS FAILURE THAT MANUFACTURER HAS FAILED AND REFUSED TO REPAIR. *SMD

2008 FORD F350 SD. CONSUMER STATES VEHICLE BEGAN SPEWING SMOKE AND CAUGHT FIRE WHILE DRIVING *TGW THE CONSUMER ALSO STATED THE CHECK ENGINE LIGHT ILLUMINATE AND APPARENTLY A SENSOR FAILED TO OPERATE. HOWEVER, THE SERVICE CENTER INSISTED THE PROBLEM WAS NOT DUE TO A SENSOR. *JB

WHILE DRIVING MY 2008 F350 SUPERDUTY DIESEL POWERED TRUCK AT 45MPH FOR APPROX 4 MILES, RECEIVED MESSAGE "EXHAUST DRIVE COMPLETE" IMMEDIATELY FOLLOWED BY "STOP SAFELY NOW" AND COMPLETE POWERDOWN OF ENGINE. THE TRUCK DECELERATED SO FAST THAT DESPITE MY FLOORING THE THROTTLE, THE CAR BEHIND ME ALMOST COLLIDED. THE TRUCK LOST SO MUCH POWER THAT I COULD NOT SAFELY PULL OFF ROAD AND WAS IN A RURAL AREA BETWEEN TWO BLIND CURVES. THE WHOLE INCIDENT HAPPENED IN LESS THAN 30 SECONDS AND LEFT TRUCK COMPLETELY VULNERABLE TO WHATEVER TRAFFIC CONDITIONS WERE AT THE TIME OF INCIDENT. AFTER GETTING OVER TO SIDE OF ROAD, TRUCK STALLED ON SLIGHT RISE AND DID NOT HAVE THE POWER TO MOVE, HOWEVER WHEN I SHUT TRUCK DOWN, MY 5FT8IN 200LB BODY WAS ABLE TO PUSH THE 8000 LB VEHICLE OVER THE HUMP. ENGINE WOULD NOT CRANK OVER AFTER INCIDENT AND WAS NOT ALLOWED TO RESTART UNTIL AFTER THE UNIT EITHER COOLED DOWN OR TIMED OUT (DIDN'T TRY FOR 30-45 MIN LATER). BY TIME TOW TRUCK ARRIVED, UNIT WOULD RUN BUT LESS THAN FULL POWER AND CHECK ENGINE LIGHT WAS ON. TRUCK WAS IN SHOP SERVICED FOR FAULTY EGR VALVE AND HAD LATEST FORD RECALL FOR REPROGRAMMING COMPLETED LESS THAN 100 MILES PRIOR TO INCIDENT. *TR

Mileage: 23,000

I BROUGHT THIS 2008 FORD F-350SD TO THE DEALER TODAY BECAUSE OF ANTI-FREEZE LEAKING FROM BOTTOM OF RADIATOR ON THE DRIVERS SIDE. THE TRUCK HAS ABOUT 16000 MILES ON IT. DEALER SAYS THE RADIATOR MUST BE REPLACED AND NO WARRANTY SO I AM RESPONSIBLE FOR REPAIRS. I CALLED FORD AND ASKED FOR HELP AND WAS TURNED DOWN. THE FORD DEALER CONTACTED FORD AND ASKED FOR HELP AND WAS TURNED DOWN. I HAVE READ OF NUMEROUS RADIATOR FAILURES ON THIS YEARS F350 SO EVIDENTLY THERE IS A PROBLEM WITH THE DESIGN OF THEIR COOLING SYSTEM AND FORD SHOULD REIMBURSE FOR THESE FAILURES. NO RADIATOR SHOULD FAIL IN 16000 MILES.

Mileage: 16,050

I BOUGHT A 2008 SUPER DUTY WITH THE 6.4 L DIESEL ENGINE IN IT. I NOTICED THAT THE RADIATOR WAS LEAKING ON THE BOTTOM DRIVER SIDE. I DECIDED TO DO SOME RESEARCH ON THE INTERNET TO SEE IF IT WERE A COMMON PROBLEM , TO MY SURPRISE IT WAS. EVERYONE THAT HAS A SUPER DUTY TRUCK WITH THE 6.4 L COMPLAINT ABOUT THE SAME PROBLEM , RADIATOR LEAKING ON THE BOTTOM DRIVER SIDE. SOME OF THE OWNERS RECORDED THAT IT WAS THEIR 3 RD RADIATOR IN THEIR TRUCK. I DID SOME RESEARCH ON CARFAX AND NOTICED THAT ATLEAST 7 TRUCKS OUT OF 20 THAT WERE FOR SALE IN THE MEMPHIS AREA HAD THEIR RADIATORS REPLACED AND SOME TRUCKS MORE THAN 3 TIMES. I WENT TO THE DEALER AND THEY LOOK AT MY RADIATOR AND TOLD ME THAT THEY WOULD REPLACE IT UNDER WARRANTY. THEY ALSO LOOKED AND MADE SURE THAT MY TRUCK HAD THE VENTURI KIT INSTALLED ON IT, THAT FORD HAD A RECALL ON THE COOLING SYSTEM BACK IN 08 , IT WAS INSTALLED. AFTER THEY REMOVED MY RADIATOR THE SERVICE MAN TOLD ME THAT IF MY THERMOSTATS WERE NOT AT FAULT THAT I HAD TO PAY FOR THE RADIATOR. MY THERMOSTATS HE SAID WERE FINE SO I WAS RESPONSIBLE TO PAY FOR A NEW RADIATOR. I STRONGLY BELIEVE FORD SHOULD BE HOLD ACCOUNTABLE FOR THESE COOLING SYSTEMS THAT IS FAILING . TO ME THEY ARE ONLY PATCHING A PROBLEM AND HOPE IT WILL LAST TILL THE WARRANTY IS OVER AND THEN IT IS THE OWNERS PROBLEM . TO MANY OWNERS OUT THERE HAS THE SAME PROBLEM FOR ME TO EXCEPT RESPONSIBILITY FOR WHAT IS CLEARLY A BAD DEFECT ON THE COOLING SYSTEM. MY TRUCK HAS ONLY 64 000 MILES ON IT, AND I DON'T EVEN TOW ANYTHING. *TR

Mileage: 64,000

TL*THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, HE WOULD HEAR A LOUD NOISE COMING FROM THE HOOD. THE VEHICLE WAS INSPECTED BY A DEALER WHO ADVISED THE CONTACT THAT HE NEEDED TO REPLACE THE ROCKER ARMS IN THE ENGINE. THE DEALER ALSO ADVISED HIM THAT IF NOT REPLACED, THEY WOULD PUNCTURE THE MOTOR CAUSING THAT TO FAIL AS WELL. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 111.

Mileage: 111

TL*THE CONTACT OWNS A 2008 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE POWER DECREASED SIGNIFICANTLY. THE CONTACT WAS ABLE TO CONTINUE IN OPERATION WITH THE POOR TURBO PERFORMANCE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE TURBOCHARGER COMPRESSOR SHAFT COMPLETELY FRACTURED AND BOTH THERMOSTATS HAD BROKEN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 94,442.

Mileage: 94,442

WHILE DRIVING IN SNOWY CONDITIONS, THE AIR FILTER WILL GET CLOGGED WITH SNOW CAUSING THE ENGINE TO STALL. ON 12/30/2010 AT 2PM I DROVE APPROXIMATELY 20 MILES (ZIP CODE 57201) AND THE AIR FILTER HAD 1/2" OF SNOW ALL AROUND AND INSIDE THE FILTER. DISCUSSED WITH LOCAL FORD DEALER AND THEY SAY THERE IS A NO FIX FOR THIS PROBLEM COULD CAUSE VEHICLE TO STALL IN ADVERSE WEATHER CONDITIONS AND CAUSE AN ACCIDENT AND OR STRAND PASSENGERS IN ADVERSE WEATHER CONDITIONS. *TR

Mileage: 73,000

08 F350 WITH 70,000MILES ON IT. WE TOW A TRAILER DAILY WITH THIS VEHICLE. APPROXIMATELY 10 TIMES PER DAY IT STATES "CLEANING THE EXHAUST FILTER". ON SEPT. 29, 2010, IT SAID "CLEANING EXHAUST FILTER AND STOP SAFELY NOW" AND SHUT OFF IMMEDIATELY. WHILE I WAS IN THE MIDDLE OF ROAD. LUCKILY A FRIEND WAS DRIVING BY AND TOWED ME OUT OF THE LANE OF TRAFFIC. PRIOR TO THIS OUR VEHICLE HAD FOUR RADIATORS PUT INTO VEHICLE BECAUSE PLASTIC PARTS KEPT BREAKING. THE EXHAUST SENSOR WAS REPLACED PRIOR TO THIS INCIDENT. THE CODE FOR THIS WAS THE EXHAUST SENSOR. IF I WAS ON FOUR LANE HIGHWAY WHEN THE VEHICLE SHUT DOWN I'D BE DEAD. I DIDN'T HAVE ANY TIME TO PULL OFF ROAD. SOMETHING MUST BE DONE ABOUT THIS. FORD IS NOT STANDING BEHIND THIS. TRUCK IS STILL AT DEALER. I'VE BEEN WITHOUT VEHICLE SINCE SEPT. 29, 2010. THEY REFUSE TO PUT TRUCK BACK TOGETHER. THEY STATED THAT THIS WOULD BE WARRANTY BUT FORD WON'T WARRANTY AND I WON'T PAY WHAT THEY ARE ASKING FOR SOMETHING THAT IS A FREQUENT OCCURRENCE. *TR

Mileage: 70,000

LOSES POWER WHILE DRIVING CAN NOT GET ANY SPEED ALMOST GOT HIT ON INTERSTATE SINCE IT DROPPED SPEED FROM 70 TO 40 FUEL PUMP REPLACED STILL AT DEALERS HAS BEEN THERE FOR 3 WEEKS HAD IT IN THE SHOP A FEW MONTHS AGO FOR COOLING SYSTEM THIS IS SUPPOSED TO BE A HEAVY DUTY TRUCK THERE IS A NUMBER OF PROBLEMS WITH THESE TRUCKS . WITH 73 BULLETINS ON THEM I THINK IT IS A SAFETY ISSUE !!!!!!!!! *TR

Mileage: 73,000

LOSES POWER WHILE DRIVING CAN NOT GET ANY SPEED ALMOST GOT HIT ON INTERSTATE SINCE IT DROPPED SPEED FROM 70 TO 40 FUEL PUMP REPLACED STILL AT DEALERS HAS BEEN THERE FOR 3 WEEKS HAD IT IN THE SHOP A FEW MONTHS AGO FOR COOLING SYSTEM THIS IS SUPPOSED TO BE A HEAVY DUTY TRUCK THERE IS A NUMBER OF PROBLEMS WITH THESE TRUCKS . WITH 73 BULLETINS ON THEM I THINK IT IS A SAFETY ISSUE !!!!!!!!! *TR

Mileage: 73,000

TL* THE CONTACT OWNS A 2008 FORD F350 SUPER DUTY TRUCK PURCHASED NEW. HE STATED AFTER HAVING A REGULAR OIL CHANGE, HE NOTICED A LARGE OIL SPILLAGE COMING FROM UNDER THE VEHICLE. THE DEALER ADVISED REPLACING THE HIGH PRESSURE FUEL PUMP. THE REPAIR CAUSED THE OIL TO LEAK WORSE. WITHIN JUST UNDER A YEAR OF THE INITIAL FAILURE, THE DEALER REPLACED THE HIGH PRESSURE FUEL PUMP A SECOND TIME. SEVERAL MONTHS LATER, THE CONTACT BEGAN TO NOTICE THE OIL LEAK AGAIN. THE HIGH PRESSURE FUEL PUMP WAS REPLACED A THIRD TIME. HE ALSO STATED THE BULBS IN THE EXTERIOR LIGHTING ELEMENTS, INCLUDING HEADLIGHTS, TAIL LIGHTS AND TURN SIGNALS CONTINUED TO BLOW. THE DEALER COULD NOT IDENTIFY THE REASON WHY THEY CONTINUED TO FAIL. WHILE AT A STOP, WHILE ATTEMPTING TO ACCELERATE, THE VEHICLE WOULD NOT SHIFT INTO GEARS PROPERLY. THE VEHICLE WOULD STAY IN HIGH GEAR AND WOULD NOT DOWN SHIFT PROPERLY. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. NO FURTHER REPAIRS WERE MADE TO DATE. THERE WERE NO RECALLS ON HIS VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE UNDER 28,000.

Mileage: 27,999

DIESEL PERTICULATE FILTERS. *TR

Mileage: 19,000

2MONTHS INTO MY "NEW" VEHICLE THE RADIATOR CRACKED AND OVER HEATED ; THE BACK GLASS LEAKS WITH WATER EVERY TIME IT RAINS , MOTOR REVES UP OUT OF CONTROL , NOW MOTOR HAS BLOWN OIL INTO RADIATOR AND ALL OVER DRIVEWAY DEEMING VEHICLE UNDRIVEABLE. *TR

TL*THE CONTACT OWNS A 2008 FORD F-350 SD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR REGULAR MAINTENANCE. THE TECHNICIAN OBSERVED AN EXCESSIVE OIL LEAK AND STATED THAT THE FAILURE WAS RELATED TO THE FRONT MAIN SEAL. THE VEHICLE WAS REPAIRED. ON NINE SEPARATE OCCASIONS, THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR IDENTICAL FAILURES; HOWEVER, THERE WERE NO RESOLUTIONS. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE CONTACT HAS NOTIFIED THE MANUFACTURER. THE FAILURE MILEAGE WAS 20,000 AND CURRENT MILEAGE WAS 53,000.

Mileage: 20,000

REGARDLESS OF SPEED, EXCESSIVE WHITE SMOKE BLOWING OUT OF EXHAUST COMPLETELY OBSTRUCTING OWN REAR SIGHT AS WELL AS BLINDING FOLLOWING VEHICLES. IT HAS HAPPENED 4 TIMES, VEHICLE CURRENTLY AT 36, 000 KM. PERSONAL BELIEF IS THAT THIS HAS LED TO ENGINE NEEDING TO BE REPLACED WHICH FORD WILL NOT WARRANTY. NOTHING HAS BEEN DONE AS FORD REPORTS THEY CANNOT FIND THE PROBLEM. *TR

Mileage: 9,000

I LEASED A 2008 F350 6.4 LITER IT WAS SMOKING OUT OF THE TAILPIPE OFTEN SO I CALLED THE DEALER AND THEY SAID IT WAS NORMAL OVER THE NEXT FEW MONTHS IT GOT WORSE THEN I HAD THE OIL CHANGED AT THE DEALER AND THE SMOKE CHECKED THEY SAID IN THE PAPER WORK IT WAS UNDETERMINED 1 MONTH LATER I LOST ALL POWER AND THE TRUCK DIED THE OIL CAP WAS NOT PUT ON AND THERE WAS OIL EVERYWHERE SINCE THEN THE SMOKE HAS GOTTEN WORSE SO I STARTED TO GO TO A SMALL MECHANIC THAT WORKS ON MY OTHER TRUCKS WELL SINCE THIS INCIDENT THE SMOKE IS MORE OFTEN LIKE TWO TIMES A WEEK FOR 10 MIN SON I BROUGHT IT TO THE DEALER TWO WEEKS AGO THEY HAD IT FOR 3 DAYS AND THEN THEY CALLED ME AND SAID I HAD TO PROVE THAT I HAD THE OIL CHANGES DONE TO IT I OWN FOUR TRUCKS AND THEY ALL GET OIL CHANGES SO I BROUGHT THE RECITES AND THEY SAID BECAUSE I PAID CASH FOR THE OIL CHANGES THE RECEIPT FORM THE MECHANIC WHERE FAKE AND IT WAS A MAINTENANCE ISSUE SO I DROVE IT DOWN THE STREET TO ANOTHER PLACE SINCE THEN ITS UN DRIVABLE IT SMOKES THE HOLE TIME ITS RUNNING WHAT DO I DO? *TR

Mileage: 31,000

FOR TWENTY FIVE THOUSAND MILES THE VEHICLE HAS HAD AN INTERMITTENT ENGINE MISS. THEY HAVE WORKED ON THIS NUMEROUS TIMES TO NO AVAIL. THE VEHICLE FINALLY QUIT ON I-70 JUST BEFORE THE HOLIDAYS. THEY HAVE HAD NUMEROUS PROBLEMS WITH THESE TRUCKS THAT NEED TO BE ADDRESSED BY SOMEONE THAT CARES ABOUT THE SAFETY OF US ,THE CONSUMERS. THANK YOU FOR YOUR TIME. *TR

Mileage: 36,000

TL*-THE CONTACT OWNS A 2008 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT THE MORE PRESSURE HE APPLIED TO THE BRAKES, THE MORE THE VEHICLE LOST CONTROL AND ACCELERATED TO FULL THROTTLE. THE FAILURE OCCURRED WHILE DRIVING 65 MPH. THE TACHOMETER WAS ABOVE 3,000 RPM. THE CURRENT MILEAGE WAS 2,000 AND FAILURE MILEAGE WAS 1,450.

Mileage: 1,450