2010 FORD F-350 SD Suspension Problems

Purchased truck July 1st 2023..after 2 days of owning I’ve experienced death wobble at 48-55mph. It caught me way off guard as I was hauling 40ft travel trailer and family in truck. Truck is currently back at dealership receiving the recalled parts for the newer trucks and have to pay over $3500 in repairs…within the 1200 miles I driven the truck had the death wobble 7 times. Please advise

While on highway, experienced an uncontrolled suspension vibration commonly know as the death wobble. It required me to slow down to 25mph on the highway to stop the uncontrollable vibration. This led to a chaotic situation with cars and trucks around me at the time.

The contact owns a 2010 Ford F-350 SD. The contact stated that while driving over a bump in the roadway at high speeds, the vehicle intermittently experienced the death wobble without warning. The shaking continued until the vehicle had slowed down and the contact was able to regain control of the vehicle. The contact notified the dealer and was informed that a diagnostic test needed to be performed to determine the cause of failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 70,000. The VIN was not available.

Mileage: 70,000

Truck starts Violently shaking on highway

The death wobble. It happens on the freeway. You have to almost come to a stop. A major HAZARD!!! Happen s going over train tracks, bumps on the road. It's soooo scary and dangerous! Can we ford owners file a class action lawsuit against Ford? Please help. Every time we drive it's scary and dangerous. We're always afraid to haul or drive please help us get this fixed!

WHILE DRIVING THIS TRUCK AT HIGHWAY SPEED AND HITTING A BUMP THE STEERING WHEEL WILL SHAKE UNCONTROLLABLY. THERE IS NOTHING I CAN DO BUT HOLD ON AND LET OFF THE ACCELERATOR TILL IT STOPS. THIS IS EXTREMELY DANGEROUS AS LOSS OF CONTROL AND HAVING TO SLOW DOWN MAKES IT LIKELY TO CAUSE AN ACCIDENT. PLEASE HELP!!!!

Mileage: 20,000

EXHAUST MANIFOLDS CRACKED ON BOTH SIDES OF MOTOR. DEATH WOBBLE IN FRONT SUSPENSION,FOUR WHEEL DRIVE. DRIVING ON INTERSTATE DOING 70 MPH

Mileage: 76,000

WHEN HITTING A ROUGH SPOT IN THE ROAD OR ESPECIALLY WHEN CROSSING A BRIDGE EXPANSION JOINT AT HIGHWAY SPEED, THE TRUCK DEVELOPS A TERRIFYING, VIOLENT SHAKING/VIBRATION AND THE ONLY WAY TO STOP IT IS TO SLOW DOWN TO 25 - 30MPH, WHICH IS VERY DANGEROUS WHEN DRIVING ON FREEWAYS SURROUNDED BY OTHER VEHICLES. MY WIFE REFUSES TO RIDE IN THE VEHICLE ON THE HIGHWAY AFTER EXPERIENCING THE "DEATH WOBBLE".. THE TRUCK HAS HAD VARIOUS STEERING AND SUSPENSION COMPONENTS REPLACED WITH HIGH QUALITY AFTERMARKET PARTS INCLUDING SHOCK ABSORBERS AND STEERING DAMPER WITH NO CHANGE IN WHAT HAS BEEN CALLED THE "DEATH WOBBLE". THIS IS AN INTERMITTENT PROBLEM AND DOES NOT HAPPEN EACH AND EVERY TIME WHEN HITTING A BUMP OR CROSSING A BRIDGE JOINT. MULTIPLE TECHNICIANS HAVE BEEN UNABLE TO DUPLICATE THE PROBLEM EVEN AT LOCATIONS WHERE IT HAPPENS FREQUENTLY.

Mileage: 65,000

TWO TO THREE WEEKS AGO WHILE DRIVING ON THE HIGHWAY IN MY FORD F350 SRW, $WD, CREW CAB TRUCK I WENT OVER A BRIDGE. WENT I CAME OFF THE BRIDGE AND WENT OVER A LITTLE BUMP MY VEHICLE STARTED SHAKING UNCONTROLLABLY. FIRST I WAS YANKED TO THE LEFT AND THEN I WAS ABLE TO STEER IT TO THE RIGHT. I COULD NOT CONTROL THE VEHICLE UNTIL I WAS IN THE BREAKDOWN LANE. I WAS ALMOST STRUCK BY TWO TRACTOR TRAILERS WHO, BY THE GRACE OF GOD WHERE PAYING ATTENTION AND BRAKED BEFORE COLLIDING WITH ME! THE SHAKING WAS SO VIOLENT THAT MY ARMS HURT FOR TWO DAYS AFTER. IT HAS NOW HAPPENED THREE TIMES TO ME, I HAVE AN APPOINTMENT AT THE FORD DEALER WHO REALLY DOESN'T KNOW WHAT TO DO BUT "TRY" DIFFERENT THINGS.

Mileage: 135,426

THE VEHICLE SHAKES VIOLENTLY WHEN DRIVING OVER AN EVEN ROADWAY. THE SHAKING WILL NOT STOP UNTIL THE VEHICLE IS SLOWED DOWN TO ABOUT 30 MPH. THIS HAS HAPPENED NUMEROUS TIMES

Mileage: 110,000

TL* THE CONTACT OWNS A 2010 FORD F-350 SD. WHILE DRIVING 50 MPH, THE VEHICLE EXPERIENCED THE 'DEATH WOBBLE' AND SHOOK VIOLENTLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO WINSLOW FORD (LOCATED AT 840 MIKE'S PIKE ST, WINSLOW, AZ 86047, (800) 331-6698), BUT THE FAILURE COULD NOT BE DUPLICATED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.

FRONT WHEEL "DEATH WOBBLE' OCCURS BETWEEN 45 MPH AND 65+ MPH (IN TOWN STREETS AND FREEWAY) AFTER HITTING A MINOR BUMP IN THE ROAD, MOST GOING STRAIGHT BUT OCCURS IN MINOR TURNS AS WELL. FRONT WHEELS SHAKE VIOLENTLY AND TRANSMITS TO THE STEERING WHEEL AND CAB. FRONT WHEELS FEEL LIKE THEY ARE GOING TO TEAR OFF. TO STOP THE WOBBLE I HAVE TO SLOW QUICKLY TO 5 MPH TO 10 MPH. AS THE BRAKES ARE APPLIED THE WOBBLE INCREASES BECOMES EVEN MORE VIOLENT. THIS IS VERY DANGEROUS PARTICULARLY AT FREEWAY SPEEDS BECAUSE YOU HAVE TO CHANGE LANES ABRUPTLY, PULLING OVER TO STOP. THE WOBBLE STARTED AS A MINOR NUISANCE THOUGHT TO BE A WHEEL BALANCE ISSUE. NOW THE PROBLEM IS ONGOING AND PROGRESSIVE. THE VEHICLE HAS AN EXTENDED WARRANTY, IS IN REGULAR SERVICE, AND HAS APPROXIMATELY 90K MILES. THE TIRES ARE HIGH GRADE MICHELIN WITH APPROX 32K, HAVE BEEN ROTATED AND BALANCED SEVERAL TIMES (NO PROBLEMS NOTED AT AMERICA'S TIRE STORE). I HAVE A LIFETIME ALIGNMENT WITH FIRESTONE AND HAD IT ALIGNED TWICE (NO PROBLEMS NOTED AT FIRESTONE). I HAVE LOOKED ONLINE AND SEE OTHER COMPLAINTS BUT FORD DOES NOT HAVE A RECALL, SERVICE BULLETIN, OR WARNING. PEOPLE THAT HAVE SEEN IT HAPPEN HAVE PULLED OVER TO TELL ME HOW BAD IT LOOKS FROM OUTSIDE. I SEE BLOGS WITH SUGGESTIONS ON HOW TO REMEDY THE PROBLEM WITH AFTERMARKET EQUIPMENT. FORD NEEDS TO ADDRESS THE PROBLEM DIRECTLY. I AM GOING TO HAVE THE WHEELS BALANCED AGAIN AND ALIGNED THEN TAKE IT TO FORD FOR A COMPLETE DIAGNOSIS.

Mileage: 91,000

2010 FORDF350 SUPER DUTY, 127,000 MILES. I HAVE THE DREADED "FORD DEATH WOBBLE", I'VE CONTACTED FORD ALL THE WAY TO CORPORATE. FORD'S RESPONSE IS WE'RE NOT AWARE IF ANY ISSUES, AND THERE IS NO RECALL ON YOUR VEHICLE. MY WIFE WON'T RIDE IN THE CAR, THAT'S HOW COOLANT THE SHAKE IS. I'VE CONTACTED FORD BOTH IN WRITING AND VERBALLY, THERE ANSWER IS OUT OF WARRANTY, YOUR PROBLEM MN. THEY ARE AWARE IF THE PROBLEM AS IT IS ALL OVER THE INTERNET. THEIR ANSWER IS YOU CAN'T BELIEVE THE INTERNET. I GUESS THEY'LL TAKE OWNERSHIP WHEN SOMEONE IS KILLED. OF COURSE IN A DEADLY CRASH, THE EVIDENCE/CAUSE OF CRASH WILL BE DESTROYED, HOW FOURTINANT FOR FORD.

Mileage: 125,000

I HAVE WHAT THE FORD DEALERSHIPS AND MASTER MECHANICS CALL THE "FORD DEATH WOBBLE". TYPE OR SURFACE OF ROAD MAKES NO DIFFERENCE, NOR DOES SPEED. HITTING A BUMP, OR EXPANSION JOINT ON THE HIGHWAY OR BRIDGE CAUSES THE FRONT END OF THE TRUCK TO SHAKE SO VILENTLY I HAVE TO SLAM ON BREAKS AND COME TO A COMPLETE STOP TO BRING THE TRUCK BACK UNDER CONTROL. I HAVE NO PHOTOS HOWEVER, SOCIAL MEDIA, UTUBE, ETC. HAS AN OVERWHELMING AMOUNT OF VIDEOS ON THIS PROBLEM. I HAVE CONTACTED FORD AND I'VE BEEN TOLD THERE HAVE BEEN NO REPORTS ON THIS ISSUE, AND THEREFORE NO RECALL. PROBLEM IS, IF THIS ISSUE CAUSES A DEADLY WRECK, ALL THE EVIDENCE OF WHAT CAUSED THE WRECK WILL BE DESTROYED IN THE WRECK. I'M 73 YEARS OLD, DRIVEN A LOT OF CARS, THIS IS THE FIRST AUTOMOBILE I'VE BEEN AFRAID TO DRIVE, AND WILL NOT LET MY WIFE DRIVE IT AT ALL. HOPEFULLY AN INVESTIGATION CONDUCTED BY YOU WILL BRING THIS PROBLEM TO FORDS ATTENTION, AND HOPEFULLY RESOLUTION. PS, THIS HAPPENS ALL THE TIME....UPDATED 02/13/17 *BF *CN

Mileage: 126,000

STEERING GEAR BOX ,OR MAIN GEAR BOX. DEATH WOBBLE ,ON SOME FORD TRUCK, NOT MY VIN# I CALL BEFORE ODI # 10908140. *TR

Mileage: 78,455

WAS ON THE FREEWAY DRIVING ABOUT 67 MPH HIT A BUMP IN THE ROAD FRONT END STARTED BOUNCING RAPIDLY UNCONTROLLABLY. I HAD TO ALMOST COME TO AN COMPLETE STOP IN ORDER TO GET IT TO STOP. *TR

Mileage: 117,108

LOSS OF CONTROL WHEN DRIVING ON BUMPY SECTION OF FREEWAY, DUE TO EXTREME SHAKING OF FRONT END. IT SEEM TO AMPLIFY IN THE SEVERITY AND VIOLENCE OF THE SHAKING UNTIL I WAS ABLE TO SLOW THE TRUCK TO UNDER 10 MILES AN HOUR ON THE SHOULDER OF THE ROAD TO REGAIN CONTROL. I HAVE HAD THE TRUCK IN SHOP AT THE DEALER 3 TO 4 TIMES FOR REPAIR FOR THIS RECURRING PROBLEM. THE FORD SERVICE TECHNICIAN ADMITTED THAT THIS WAS A COMMON PROBLEM FOR THIS MAKE AND MODEL BUT THAT NEITHER FORD OR THE DEALER WOULD TAKE RESPONSIBILITY FOR THE REPAIR. BUT, THEY DID HOWEVER HAVE A RECOMMENDED FIX, WHICH I FOUND INTERESTING FOR AN ISSUE THAT THEY SAID DIDN'T EXIST. I HAVE SPENT THOUSANDS OF DOLLARS AT THE DEALER TO FIX WHAT IS OBVIOUSLY A DESIGN AND MANUFACTURING FLAW. THIS IS A VERY DANGEROUS VEHICLE TO DRIVE. WE BOUGHT IT TO PULL A LARGE TRAVEL TRAILER BUT DO NOT HAVE CONFIDENCE IN THE TRUCK TO DO SO. SO NOT ONLY ARE WE PAYING FOR A DEFECTIVE TRUCK, WE ARE NOT ABLE TO USE THE TRUCK FOR THE PURPOSE WE INTENDED. WE COULD NOT BE MORE DISAPPOINTED IN FORD AND OUR DEALER. THESE TRUCKS WILL CAUSE FATAL CRASHES, THEY ARE NOT SAFE TO DRIVE. I CAN SEND VIDEO FROM THE CAB OF THE SHAKING THAT HAPPENED OVER THE WEEKEND. PLEASE, PLEASE TAKE ACTION TO GET THIS ISSUE FIXED. THANK YOU *TR

Mileage: 37,000

SUBMISSION FROM CONSTITUENT RE ISSUES WITH FORD F-350 TRUCK (FULL DOCUMENT NOT IMAGED). *SMD THE DEALER HAD THE CONSUMERS VEHICLE FOR 12 DAYS. THE VEHICLE WAS RETURNED TO HIM DAMAGED. WHEN HE ATTEMPTED TO START THE TRUCK, THERE WAS METALLIC ENGINE RATTLE. HE SHUT THE TRUCK OFF AND INSPECTED THE ENGINE, BUT FOUND NO PROBLEM. AS THE CONSUMER DROVE HOME, THE TRUCK STALLED SEVERAL TIMES, THE TRANSMISSION WOULD NOT SHIFT PROPERLY AND THE STEERING WHEEL STARTED TO SHAKE VIOLENTLY AT 30 MPH. THE CONSUMER ALSO STATED THE HEAD LIGHTS DID NOT PROVIDE ADEQUATE LIGHTING OF THE ROAD, THE SEAT BELTS DID NOT RETRACT PROPERLY; THEY WOULD TIGHTENED AS HE WAS DRIVING, WHICH PREVENTED HIM FROM MOVING, THERE CRUISE CONTROL DID NOT ENGAGE PROPERLY, IT WAS DIFFICULT TO MANEUVER THE STEERING WHEEL, THE FUEL GAUGE WAS NOT READING ACCURATELY, THERE WERE NOISES COMING FROM THE DRIVE TRAIN, THE EMERGENCY BRAKE WAS INOPERATIVE, THE VEHICLE SEVERELY PULLED TO THE RIGHT, THE ENGINE LACKED TORQUE AND POWER, THE SUSPENSION WAS NOT ADEQUATE FOR THE VEHICLE, EVERY TIME HE HIT A POT HOLE OR BUMP IN THE ROAD, HE WOULD LOOSE STEERING ABILITY AND THE TIRES WOULD START BOUNCING. IT WOULD TAKE TOO LONG FOR THE VEHICLE TO TAKE OFF, WHEN THE ACCELERATOR WAS APPLIED, THERE WAS AN INSTANT SHUDDER FROM THE VEHICLE, WHEN HE APPLIED THE ACCELERATOR PEDAL. *JB